Professional Documents
Culture Documents
D. Rehle/T. Pillmeier 24/04/09 Index 1.2 The information contained in this document is proprietary to THOMSON and should not be disclosed by the recipient to third persons without the written permission of THOMSON.
Table of content
1. 2. 3. Introduction....................................................................................................... 3 Evaluation kit content ...................................................................................... 4 Software installation......................................................................................... 5
4. Operation........................................................................................................... 7 4.1 ISDB-T mode ...................................................................................................... 7 4.2 Analogue TV mode ............................................................................................. 9 5. Software features............................................................................................ 10 5.1 ISDB-T demodulator control ............................................................................. 10 5.1.1 IQ, BER, MER Setting .................................................................................. 12 5.1.2 TS Output Setting ......................................................................................... 12 5.2 Tuner control..................................................................................................... 13 5.2.1 Tuner standard mode ................................................................................... 13 5.2.2 Tuner expert mode ....................................................................................... 14 5.3 IC interface ...................................................................................................... 14 6. 7. Contacts .......................................................................................................... 15 History ............................................................................................................. 16
Page 2 / 16
1.
Introduction
The NI386X is an ISDB-T NIM. It is intended for the Brazil market. With the evaluation kit it is possible to demonstrate the function and the performance of the NI386X for ISDB-T reception. An additional test board option is an analogue demodulator to demonstrate the function and the performance in analogue TV mode. First the evaluation software must be installed. After that the hardware can be connected.
Page 3 / 16
2.
Page 4 / 16
3.
Software installation
Double click the file setup.exe in the path NI386Xv1_4\cvidistkit.NI386X_v1_5 of your CD ROM drive. Follow the next steps:
Press Next
Page 5 / 16
Press Next
Press Finish
Ni3862v1_0
This shortcut appears at your desktop and in the Start menu Programs NuTune NI3862v1_0
Page 6 / 16
4.
Operation
11 1 10 2
3 9 8 4 5 6 7
Test board with NI386X for ISDB-T with option for analogue TV reception
Page 7 / 16
Page 8 / 16
Page 9 / 16
5.
Software features
Lock: Green color indicates that an ISDB-T signal has been detected Demod Address: The demodulator IC address can be selected depending on the ADR0 (Pin 30) and ADR1 (Pin 31) Mode: FFT size, Mode 3 = 8k FFT, Mode 2 = 4k FFT and Mode 1 = 2k FFT Guard: Detected guard interval Emergency: Becomes red when emergency signal is detected Reset emergency: Press this button to reset the XIRQ output into non emergency state. Otherwise the XIRQ output remains in emergency state Transmission parameters: Modulation, Code rate, Time interleaver mode, Number of segments for each layer BER: Bit error rate pre Viterbi, after Viterbi and detected packet errors SNR: Signal to noise estimator By clicking in the Post Viterby field Layer A , B or C a additional window comes up and show the post viterby and package error over time in a display
Page 10 / 16
Thin blue line: Show post viterby errors over the time.
Fat orange line: limit for post viterby errors. Could be changed through the numeric control in the panel)
Page 11 / 16
5.1.1
Application Digital Demodulator IQ, BER, MER Setting IQ: Switches between normal mode and spectrum inversion RS: Reed Solomon decoder state Segment: Switches between different 1 and 13 segment reception BER Monitor Timer Setting: Number of data for BER calculation
5.1.2
TS Output Setting
Application Digital Demodulator TS Output Setting Sets the parameters for the digital transport stream interface
Page 12 / 16
Page 13 / 16
5.2.2
Application Tuner Expert These settings should be changed only by experienced users. It can deteriorate the tuner performance. In the expert mode the charge pumps will not be set automatically.
Charge pump: Manual charge pump control Band / Standby: Manual band switch and tuner stand by AGC Decay Current: Changes the time constant of the RF-AGC (Only for ISDB-T reception)
5.3 IC interface
IC Status: No indicator should be red. The IC speed can be changed with the slider. I/O Port: The parallel port address (LPT-Port) can be selected. In most cases 0x378 is the right value.
Page 14 / 16
6.
Contacts
NuTune Europe / USA Gerd Siegel VRF-Lab Villingen Tel. (49) 7721 85 2263 Fax (49) 7721 85 2230 E-mail gerd.siegel@nutune.com NuTune Asia Joke Tin Goh SLH-Lab Singapore Tel. (65) 63791404 Fax (65) 6371775 E-mail Joke-Tin.GOH@nutune.com
Page 15 / 16
History Date of Changes 31-07-08 07-08-08 27-11-08 11-12-08 24-04-09 Index 0 1 1.1 1.1 1.2 Modification Creation Contacts added Change name and logo Change image Update from NI3860 to NI3862 Pages
all 6 all
Page 16 / 16