Professional Documents
Culture Documents
analysis software, and how to achieve powerful combination makes it possible to use HYPERMESH meshing model, and then imported into the ANSYS WORKBENCH analysis, attracted the attention of many CAE engineers. But no matter the network media, or from the published literature, but also do not see a relevant example. In view of this, the author of this question to explore, to find a suitable way. Starting from an example below, a step-by-step description of how to use the two co-simulation. The examples are as follows. The two cantilever beams A and B, one above In addition, a slight gap between.Uniform load applied to the left of the cantilever down to study when the the load collector degree gradually increase, the cantilever is how oppression below the cantilever, resulting in its deformed.
The major steps of the operation of the two co-simulation are as follows: Two three-dimensional cantilever as shown below. Created in a three-dimensional software (SOLIDWORKS) and saved as a *. Stp format files.
3. Defined in the Component Manager in HYPERMESH unit type, material, and set the Component Manager.
A 4. Finite element model derived in HYPERMESH to the ANSYS. Get a practics.CDB file. This file can be read into the ANSYS classic interface.
Open ANSYS classic interface, use the FILE> the READ the INPUT FROM reads the file.
6. Use the export function of the document model in ANSYS classic interface to write to the file, here write for file.cdb file.
Open the main interface of ANSYS WORKBENCH and dragged into a Finite Element Modeler component.
The three-dimensional model as well as in front of the finite element model can use the the WORKBENCH other applications. Below followed by demonstrations in the MECHANICAL use. 11 in WORKBENCH create a static analysis.
12. Finite Element Modeler model cell onto the static structural model cell, and build relationships.
Thus, the problem solving end. Seen, the use of the above-described manner, the advantages of both can be combined with the efficient simulation, which can be a complex problem. In fact, the purpose of the general problem, using ANSYS WORKBENCH enough, do not need to spend HYPERMESH Dajia mesh. Just for a very complex model, the quality of the grid for the results before they need for such operations.