PeRTY OF
. OVERNMENT
Handbook of Biomass
Downdraft Gasifier
Engine Systems
serusp-271-3022 SOLAR ENERGY RESEARCH INS
DESS001135 TECHNICAL LIBRARY
March 1988
UC Category: 245 OCT 1988
GOUDEN, COLORADO, 80401
sa
This handbook has been prepared by the Solar Energy Research Institute under the t
Department of Energy Solar Technical Information Program. It is intended as a guide
to the design, testing, operation, and manufacture of small-scale {less than 200 kW
(270 hp)] gasifiers. A great deal of the information will be useful for all levels of biomass
gasification.
The handbook is meant to be a practical guide to gasifier systems, and a minimum
amount of space is devoted to questions of more theoretical interest.
We apologize in advance for mixing English and Scientifique Internationale (SI) units.
Whenever possible, we have used SI units, with the corresponding English units fol-
lowing in parentheses. Unfortunately, many of the figures use English units, and it
would have been too difficult to convert all of these figures to both units. We have sup-
plied a conversion chart in the Appendix to make these conversions easier for the
reader.
Mr. Bill Nostrand, one of our very helpful reviewers, died in May 1985. Bill was num-
ber one in the ranks of those who became interested in gasification because of its poten-
tial for supplying clean, renewable energy. We all will miss him. The improvement of
gasification systems will be noticeably slowed by his death
We dedicate this book to the Bill Nostrands of this world who will bri
to the level of safety, cleanlin
Thanks, Bill
‘T. B. Reed and A. Das
Golden, Colorado
gasifier systems
ind reliability required to realize their full potential.
avoddctotne O2'76 SEI#
Solar Technical Information Program A Division of Midwest Research institute
Solar Energy Research Institute Operated for the
1617 Cole Boulevard, Golden, Colorado 80401-3393 U.S. Department of EnergyAcknowledgments
Since it is impossible for one or two authors to realistically comprehend a subject from all viewpoints, we ha
solicited input from leading workers in the field. Early versions were sent to a number of investigators, and each
‘was invited to comment on and supplement our effort. We therefore express our heartfelt thanks to the following,
reviewers for greatly enhancing the quality of the final product:
Dr. Thomas Milne, Solar Energy Research Institute Dr. Bjorn Kjellstrom, The Boijor Institute, Sweden
Dr. Thomas McGowan, Georgia Instituto of Technology Dr. Hubert Stassen, Twente University, The Netherlands
Mr. Matthew Mendis, World Bank Prof. Ibarra Cruz, University of Manila, The Philippines
Mr. Bill Nostrand, New England Gasification Associates
‘Wo take final responsibility for the contents and omissions, and extend our apologies to those workers whose work
we may have unknowingly omitted.
Organization and Use
A gasifier converts solid fuel to gascous fuel. A gasifier system includes the gasification reactor itself, along with
the auxiliary equipment necessary to handle the solids, gases, and effluents going into or coming from the gasifier.
The figure below shows the major components of a gasifier system and the chapters in which they are discussed,
2
8
JIN 3
Flare
Gas Ch. 9, 12
Gasifier measurement
Ch. 4.5.6 and
cleaning
Ch. 7,8
Engine
(or combustor)
Chott
————————E—E—E——
Ch.9, 10
Notice
This report was prepared as an account of work sponsored by an agony of tho United States government, Neithor the United States govern:
‘ment nor any agency thervo, nor any of their employees, makes any warranties, express or implied, or assumes any legal liability or respon:
sibility forthe accuracy, completeness, or usefulness of any information, apparatus, product or process disclosed, of represents that is use
‘would not intinge privately owned rights, Reference herein to any specific commercial prodic, process, of service by tate name, trademark.
‘manufacturer or athrwise doesnot necessarily constitute or imply its endorsement, recommendation, or favoring by tho United Stalos govern
‘mentor any agency thereof. The views and opinions af authors expressed herein do nol necessarily stale or reflect thove of the United States
‘overnment oF any agency thereof
Printed in the United States of America
“Avalable from:
Superintendent of Documents
USiGovornmont Printing Office
Washinglon, DC: 20402
National Technical Information Service
US. Department of Commerce
5285 Port Royal Road
Springfield, VA 22101,
rice: Microfiche A03
Printed Copy AO7
Codes are used for pricing all publications. The code is determined by tho numberof pages inthe publication. Information pertaining to the
pricing codes can be found inthe current ssue ofthe following publications which are generally available in most libraries. Energy Research
‘Abstracts (ERA): Gaveriment Reports Announcements and Index (GRA and 1): Scientific nd Technical Abstract Reports (STAR). and publica
tion NTIS-PR 260 available from NTIS at the above address,Other Fuel Parameter
3.1 Particle Size and Shape
3.3.2 Charcoal and Char Properties
3.3.3 Biomass Ash Content and Effects
3.3.4 Biomass Moisture Content and Effects
3.3.5 Biomass Heating Value
Benoficiation of Biomass Fuels
3.4.1 Densifying Biomass Fuels
4.2 Drying Biomas
3.5 Biomass Fuel Emissior
4.0 Principles of Gasification
4.1 Introduction
4.2 Biomass Thermal Conversion
4.2.1 Introduction
4.2.2 Biomass Pyrolysis
4.2.3 Combustion of Biomass
4.2.4 Chomistry of Biomass
4.2.5 Thermodynamics of Gasification
sification
Contents