STARLET ELECTRICAL WIRING DIAGRAM-1983 Model (Page 1 to Page 2)
Starting1G-2
IGNITION SYSTEM — Precautions, Troubleshooting
PRECAUTIONS
1. Do not keep the ignition switch ON for more than 10
minutes if the engine will not start.
2. When a tachometer is connected to the system, con-
nect the tachometer positive (+) terminal to the igi
tion coil negative (—) terminal.
‘As some tachometers are not compatible with this
ignition system, it is recommended that you consult
with the manufacturer.
4. NEVER allow the ignition coil terminals to touch
ground as it could result in damage to the igniter and/
or ignition coil.
Do not disconnect the battery when the engine is run-
ning.
6. Make sure that the igniter is properly grounded to the
body.
TROUBLESHOOTING
Problem Possible caure 1 Remedy Pave
Engine will not strt/ | Incorrect ignition timing Reset timing 16-15
Hard to start Ignition coil faulty Inspect coil IG-5
(cranks ok) Igniter faulty Inspect igniter 16-5
Distributor faulty Inspect distributor ice
High tension cord faulty Inspect high tension cord i6-3
Spark plugs foulty Inspect plugs 3
ia" Ignition wiring disconnected or broken | Inspect wring
Rough ide or sta | Spark plugs feuty Inspect plugs 163
Ignition wing fulty Inspect viting
Incorrect ignition timing Reset timing
Ignition coil faulty Inspect coi
Igniter faulty Inspect igniter
Distributor faulty Inspect distibutor
High tension cord faulty Inspect high tension cord _
Engine hesitetes/ Spark pluge foulty Inspect plugs
Poor acceleration Ignition wiring faulty Inspect wiring
Incorret ignition timing Reset ting
Mutter explosion | Incorrect ignition timing Reset timing
lafter fire) all the time
Engine backfires Incorrect ignition timing Reset timing
Poor gasoline mileage} Spark plugs faulty Inspect plugs
Incorrect ignition timing eset timing
Engine overheats
Incorrect ignition timing
Reset timingIGNITION SYSTEM — Distributor 116-9
DISTRIBUTOR,
COMPONENTS
Igniter Dust Cover
Signal Generator
Dust Cover
Dstrintor Cap t f
Signal
Wilgniter type|
‘Generator as Mn
Rotor —____4 > Igniter y
' | Signal Geonerotor
: (oat
{ 1
Peas Toate
i |
! | Dust Cover
|
Breaker Plate —_& aT
Grease Stopper- eG taniter type
overor Spng— En,
Signal Rotor
Governor Weight
Governor Shatt—
Thrust Washer ———
Dustproot Packing
Distributor Housing
Vacuum Advance
Diephragr
O-Ring.
Plate Washer——______
=
Gear——_—__ a] 5