CONCORDIA UNIVERSITY Faculty of Engineering and Computer Science
Department of Mechanical and Industrial Engineering
Engineering Metrology and Measurement Systems MECH 6491 2014-2015 Assignment #2
Due date: Thursday 12 th June, 2014
Instructions: This assignment represents a significant part of your requirements in the course. This assignment requires individual work only. Produce the completed assignment before the deadline in hard copy typed. Any assignment submitted after the due date or copied will not be given marks.
For questions 1 & 2, you need to do a literature survey. Restrict your work to a short paragraph of 10 lines per question (include at least 1 reference per question). If you answer more than 10 lines, marks will not be given for anything more than the 10 th line. For questions 3 & 4 you need to study geometric tolerances to complete.
Question 1 What is Hariharan algorithm for phase shifting, what problem does it solve when compared to others?
Question 2 If you cut a small piece out a recorded hologram plate, and use this piece in the reconstruction, what would you see and why?
Question 3 In the following figure, add the largest equal coordinate tolerances so that if two parts are assemble with edges aligned, the distance between their hole centers could never be more that that shown as a note in the figure.
Question 4 In the following figure, add the tolerance zone and limits of size for both parts. You only need to draw the portion of the part that has geometric tolerance specified. You need not reproduce the whole part.