You are on page 1of 62

i

2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual
\














METROLOGIC INSTRUMENTS, INC.

MS7600 Series Horizon
Laser Scanner


























SERVICE MANUAL

2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


ii






This page has been intentionally left blank.
iii
2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual
\

TABLE OF CONTENTS

SUBJECT PAGE #

COPYRIGHT INFORMATION................................................................................................ V
PRELIMINARY INFORMATION............................................................................................. 7
INFORMATION & SAFETY...................................................................................................................................7
EUROPEAN STANDARD.......................................................................................................................................8
GENERAL PRECAUTIONS....................................................................................................................................9
Product ESD Information......................................................................................................................................9
Laser Safety Information .......................................................................................................................................9
Laser Classes.........................................................................................................................................................9
HOW TO HANDLE THE MS7600.........................................................................................................................10
INTRODUCTION....................................................................................................................... 11
APPLICATIONS AND PROTOCOLS ...................................................................................................................12
7600 SCANNER REVISION HISTORY................................................................................................................13
THEORY & OPERATION........................................................................................................ 15
BASIC OPERATION OF A LASER BARCODE SCANNER...............................................................................15
IR ACTIVATION SCANNING AREA..................................................................................................................16
SCAN VOLUME SPECIFICATIONS....................................................................................................................17
DEPTH OF FIELD BY MINIMUM BAR CODE ELEMENT WIDTH.................................................................18
TROUBLESHOOTING............................................................................................................. 19
AUDIBLE & VISUAL FAILURE MODES ...........................................................................................................19
Audible Indicators ...............................................................................................................................................19
Failure Modes......................................................................................................................................................20
Visual Indicators..................................................................................................................................................21
MS7600 TROUBLESHOOTING GUIDE ..............................................................................................................22
All Interfaces........................................................................................................................................................22
Keyboard Wedge Only.........................................................................................................................................24
RS-232 Only.........................................................................................................................................................25
Aux Port Operation with any Interface................................................................................................................26
USB Only.............................................................................................................................................................26
RS-232 Demonstration Program.........................................................................................................................27
SERVICING & MAINTENANCE PROCEDURES ............................................................... 29
GENERAL CLEANINESS OF SCANNER............................................................................................................29
CASE ASSEMBLY/DISASSEMBLY PROCEDURE ...........................................................................................31
Case Disassembly Procedure ..............................................................................................................................31
Case Assembly Procedure ...................................................................................................................................32
DECODE BOARD REMOVAL/INSTALLATION PROCEDURES.....................................................................33
Decode Board Removal Procedure .....................................................................................................................33
Decode Board Install Procedure .........................................................................................................................33
SIGNAL PROCESSOR BOARD REMOVAL/INSTALLATION PROCEDURES ..............................................34
Signal Processor Board Removal Procedure ......................................................................................................34
Installing new Signal Processor PCB Procedure................................................................................................34
MOTOR REPLACEMENT/INSTALLATION PROCEDURE ..............................................................................35
Motor Replacement Procedure............................................................................................................................35
Motor Installation Procedure..............................................................................................................................35
VLD REPLACEMENT/INSTALLATION PROCEDURES ..................................................................................36
VLD Removal Procedure.....................................................................................................................................36
VLD Installation Procedure ................................................................................................................................36
OPTICS BENCH / VLD ALIGNMENT PROCEDURE ........................................................................................37

2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


iv
PCB SPECIFICATIONS ........................................................................................................... 39
33717B SCAN BOARD LAYOUT.........................................................................................................................39
33717B Scan Board Top Side Drawing...............................................................................................................39
33717B Scan Board Bottom Side Drawing..........................................................................................................40
37717B Scan Board Connector Pin-outs:............................................................................................................40
33737C RS232 / OCIA / IBM DECODE INTERFACE PCB LAYOUT................................................................41
33737C Decode Interface Board Connector Pin-outs:........................................................................................42
SERVICING DIAGRAMS, PARTS & PINOUTS .................................................................. 43
SCANNER PARTS.................................................................................................................................................43
SCANNER INSTALLATION.................................................................................................................................44
Keyboard Wedge Interface Installation...............................................................................................................44
SCANNER PINOUT CONNECTIONS: .................................................................................................................46
Cable Connector Configurations (Host End) ......................................................................................................48
Cable Connector Configuration ..........................................................................................................................49
MS6720 SCANNER SPECIFICATIONS & DETAILS..........................................................................................50
Physical Characteristics......................................................................................................................................50
Overall Dimensions .............................................................................................................................................50
Electrical Characteristics....................................................................................................................................51
Manufacturers Recommendation........................................................................................................................51
APPLICATIONS AND PROTOCOLS...................................................................................................................52
SCANNER LABEL.................................................................................................................................................53
ORDERING PARTS & SERVICING INFORMATION........................................................ 55
REPLACEMENT PARTS AVAILABLE...............................................................................................................55
WARRANTY AND DISCLAIMER.......................................................................................................................56
METROLOGIC WORLDWIDE OFFICE LOCATIONS.......................................................................................57
PATENTS................................................................................................................................................................58
NOTES: .....................................................................................................................................................................59









2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


v

COPYRIGHT INFORMATION






Copyright 2004 by Metrologic Instruments, Inc. All
rights reserved. No part of this publication may be
reproduced, in any form or by any means for any
commercial purposes.




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


vi





This page has been intentionally left blank.



2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


7
PRELIMINARY INFORMATION


INFORMATION & SAFETY


NOTICE

This equipment has been tested and found to comply with limits for a Class A digital device,
pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable
protection against harmful interference when the equipment is operated in a commercial
environment. This equipment generates, uses and can radiate radio frequency energy and, if
not installed and used in accordance with the instruction manual, may cause harmful
interference to radio communications. Operation of this equipment in a residential area is likely
to cause harmful interference, in which case the user will be required to correct the interference
at his own expense. Any unauthorized changes or modifications to this equipment could void
the users authority to operate this device. This device complies with Part 15 of the FCC Rules.
Operation is subject to the following two conditions:

1) This device may not cause harmful interference.
2) This device must accept any interference received, including interference that may
cause undesired operation.


NOTICE

This Class A digital apparatus complies with Canadian ICES-003.


Remarque
Cet appareil numrique de la classe A est conforme la norme NMB-003 du Canada.



Caution
Use of controls or adjustments or performance of procedures other than those specified herein
may result in hazardous laser light exposure. Under no circumstances should the customer
attempt to service the laser scanner. Never attempt to look at the laser beam, even if the
scanner appears to be nonfunctional. Never open the scanner in an attempt to look into the
device. Doing so could result in hazardous laser light exposure. The use of optical instruments
with the laser equipment will increase eye hazard.

Atencin
La modificacin de los procedimientos, o la utilizacin de controles o ajustes distintos de los
especificados aqu, pueden provocar una luz de lser peligrosa. Bajo ninguna circunstancia el
usuario deber realizar el mantenimiento del lser del escner. Ni intentar mirar al haz del lser
incluso cuando este no est operativo. Tampoco deber abrir el escner para examinar el
aparato. El hacerlo puede conllevar una exposicin peligrosa a la luz de lser. El uso de
instrumentos pticos con el equipo lser puede incrementar el riesgo para la vista.



2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


8
PRELIMINARY INFORMATION


ATTENTION
L'emploi de commandes, rglages ou procds autres que ceux dcrits ici peut entraner de
graves irradiations. Le client ne doit en aucun cas essayer d'entretenir lui-mme le scanner ou
le laser. Ne regardez jamais directement le rayon laser, mme si vous croyez que le scanner
est inactif. N'ouvrez jamais le scanner pour regarder dans l'appareil. Ce faisant, vous vous
exposez une rayonnement laser q st hazardous. L'emploi d'appareils optiques avec cet
quipement laser augmente le risque d'endommagement de la vision.

ACHTUNG
Die Verwendung anderer als der hier beschriebenen Steuerungen, Einstellungen oder
Verfahren kann eine gefhrliche Laserstrahlung hervorrufen. Der Kunde sollte unter keinen
Umstnden versuchen, den Laser-Scanner selbst zu warten. Sehen Sie niemals in den
Laserstrahl, selbst wenn Sie glauben, da der Scanner nicht aktiv ist. ffnen Sie niemals den
Scanner, um in das Gert hineinzusehen. Wenn Sie dies tun, knnen Sie sich einer
gefhrlichen Laserstrahlung aussetzen. Der Einsatz optischer Gerte mit dieser
Laserausrstung erhht das Risiko einer Sehschdigung.

ATTENZIONE
Lutilizzo di sistemi di controllo, di regolazioni o di procedimenti diversi da quelli descritti nel
presente Manuale pu provocare delle esposizioni a raggi laser rischiose. Il cliente non deve
assolutamente tentare di riparare egli stesso lo scanner laser. Non guardate mai il raggio laser,
anche se credete che lo scanner non sia attivo. Non aprite mai lo scanner per guardare dentro
lapparecchio. Facendolo potete esporVi ad una esposizione laser rischiosa. Luso di
apparecchi ottici, equipaggiati con raggi laser, aumenta il rischio di danni alla vista.

EUROPEAN STANDARD

Warning
This is a class A product. In a domestic environment this product may cause radio interference
in which case the user may be required to take adequate measures.

Funkstreigenschaften nach EN 55022:1998

Warnung!
Dies ist eine Einrichtung der Klasse A. Diese Einrichtung kann im Wohnbereich Funkstrungen
verursachen; in diesem fall kann vom Betrieber verlangt werden, angemessene Manahmen
durchfhren.

STANDARD EUROPEO

Attenzione
Questo e un prodotto di classe A. Se usato in vicinanza di residenze private potrebbe causare
interferenze radio che potrebbero richiedere allutilizzatore opportune misure.

Attention
Ce produit est de classe A. Dans un environnement domestique, ce produit peut tre la cause
dinterfrences radio. Dans ce cas lutiliseteur peut tre amen predre les mesures
adquates.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


9
PRELIMINARY INFORMATION


GENERAL PRECAUTIONS


** ESD PREVENTION STEPS MUST BE USED DURING ANY MODIFICATIONS AND/OR
REPAIRS TO THIS UNIT! **


Product ESD Information

This product contains ESD sensitive components, or Electrostatic Discharge sensitive
electronic parts. The Electrostatic discharge is defined as the transfer of charge between
bodies at different electrical potentials.

Electrostatic discharge has the ability to modify the electrical characteristics of a
semiconductor device, possibly degrading or even destroying it. Electrostatic discharge also
may upset the normal operation of an electronic system, causing equipment malfunction or
failure.



Laser Safety Information

Use of controls or adjustments or performance of procedures other than those specified
herein may result in hazardous radiation exposure. Under no circumstances should the
customer attempt to service the scanner. Never attempt to look at the laser beam, even if the
scanner appears to be nonfunctional. Doing so could result in hazardous radiation exposure.

The MS7600 Unit is rated as a CLASS I laser product, as defined by The U.S. Federal Laser
Product Performance Standard (FLPPS): Title 21 of the Code of Federal Regulations; Part
1000; [Parts 1040.10 and 1040.11].


Laser Classes

CLASS I, II, and IIA lasers are defined as:

CLASS I: cannot emit laser radiation at known hazard levels (typically continuous (CW):
0.4microwatts at visible wavelengths). Users of a Class I laser products are generally
exempt from radiation hazard controls during operation and maintenance (but not
necessarily during service).

CLASS II: low power visible lasers, which emit above Class I levels but emitting a radiant
power not above 1mW. The concept is that the human aversion reaction to bright light will
protect a person.

CLASS IIA is a special designation that is based upon a 1000 second exposure and applies
only to lasers that are "not intended for viewing" such as a supermarket laser scanner.
These laser are emitting light in the visible wavelengths (0.4 to 0.7 mm) with power not
above 1mW.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


10
PRELIMINARY INFORMATION


HOW TO HANDLE THE MS7600

When mounting or handling the MS7600, or
when replacing the Top Plate:


DO NOT TURN the MS7600
upside down!








DO NOT PRESS down on the
window!





ALWAYS LIFT the Top Plate
straight up to remove.

NOTE: There is no hardware required
when removing or replacing the
top cover.

There are two installation tabs under the
top cover that can be used to place the
unit into the counter top mounting hole.






DO NOT PRESS on the
window in the replacement Top
plate.






2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


11
INTRODUCTION


The MS7600 Horizon series is Metrologics next generation in-counter laser bar code
scanner. This compact, hands-free scanner is designed with a dense 20-line omnidirectional
scan pattern that helps provide fast, efficient throughput with a high first pass read rate.

The MS7600 is equipped with a multitude of standard features including:

Durable die-cast construction
Available with either a stainless steel (MS7625) or a high-impact plastic (MS7620) top
plate
Firmware updates via Flash ROM
Field replaceable window
EAS deactivation antenna is standard
Supports commonly used interfaces including USB and Keyboard Wedge
Custom Edit bar code data
PowerLink, user replaceable cables
RS232 auxiliary port for adding peripherals
Programmable depth of field
OPOS and JPOS system compatible
Sunrise 2005 Compliant

























2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


12
INTRODUCTION


APPLICATIONS AND PROTOCOLS


The model number on each scanner includes the scanner number and factory default
communications protocol.
SCANNER VERSION












The MS7600 with Built-in PC Keyboard Wedge Interface is designed to be used for keyboard
emulation only. Many RS-232 programmable functions available in other Metrologic scanners
are also available as keyboard wedge functions.

The following are the most important selectable options specific to the keyboard wedge.


Keyboard Type:
** AT (includes IBM PS2 models 50, 55, 60, 80)
XT
IBM PS2 (includes models 30, 70, 8556)


Keyboard Country Type:
** USA German Spanish
Belgium Italian Swiss
French Japan United Kingdom








2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


13
INTRODUCTION


7600 SCANNER REVISION HISTORY


MS7600 PROTOTYPE
February 2002

MS7600 A
March 2002

Inception of finalized product.
MS7600 B
May 2003

VLD was changed to SANYO VLD for longer life




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


14





This page has been intentionally left blank.



2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


15
THEORY & OPERATION


BASIC OPERATION OF A LASER BARCODE SCANNER



























Basic Data Decoding Sectional Summaries:

Photodiode (Detector) Summary
Receives the optical signal reflected off the bar code.
Converts into electrical signal (current) of about 100nanoamps.

Pre-Amplifier Sectional Summary
Part of the Signal processor board, usually contained in a shielded area of the PCB with the
Photodiode.
Converts the electrical current to a voltage signal.
Voltage signal is amplified by a factor of 1000.
Ambient light noise is filtered out. Resultant signal is routed to the motherboard to primary signal
processing circuitry.

Signal Processor Section Summary
Converts analog waveform into a digital signal that can be used by the microprocessor.

Decoder Section Summary
Decoding algorithm decodes digital signals into ASCII characters.



VLD LASER AND BARCODE DATA PATHS


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


16
THEORY & OPERATION


IR ACTIVATION SCANNING AREA

















































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


17
THEORY & OPERATION


SCAN VOLUME SPECIFICATIONS




















































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


18

THEORY & OPERATION


DEPTH OF FIELD BY MINIMUM BAR CODE ELEMENT WIDTH










































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


19
TROUBLESHOOTING


AUDIBLE & VISUAL FAILURE MODES

Audible Indicators

When the MS7600 scanner is in operation, it provides audible feedback. These sounds indicate
the status of the scanner. Eight settings are available for the tone of the beep (normal, 6
alternate tones and no tone) plus three volume settings.



One Beep
When the scanner first receives power, the amber LED will turn on, the
red LED will flash and the scanner will beep once. (The red LED will
remain on for the duration of the beep.) The scanner is now ready to
scan.

When the scanner successfully reads a bar code, the red LED will flash
and the scanner will beep once (if programmed to do so). If the scanner
does not beep once and the red light does not flash, then the bar code
has not been successfully read.


Razzberry Tone
This is a failure indicator. Refer to failure modes page 24.


Three Beeps - During Operation
When placing the scanner in program mode, the red LED will flash while
the scanner simultaneously beeps three times. The red and amber LEDs
will continue to flash until the unit exits program mode. Upon exiting
program mode, the scanner will beep three times and the red LED will
stop flashing.

When configured, 3 beeps can also indicate a communications timeout
during normal scanning mode.

When using one-code-programming, the scanner will beep three times
(the current selected tone), followed by a short pause, a high tone and a
low tone. This tells the user that the single configuration bar code has
successfully configured the scanner.


Three Beeps - On Power Up
This is a failure indicator. Refer to failure modes page 24.








2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


20
TROUBLESHOOTING


Failure Modes

There is a red LED and amber LED on the
front of the MS7600. When the scanner is
on, the flashing or constant illumination of
the LEDs indicates the status of the current
scan and the scanner.





Flashing Amber and One Razzberry Tone
This indicates the scanner has experienced a laser
subsystem failure. Return the unit for repair at an
authorized service center.





Flashing Red and Amber and Two Razzberry Tones
This indicates the scanner has experienced a motor failure.
Return the unit for repair at an authorized service center.





Continuous Razzberry Tone with both LEDs off
If, upon power up, the scanner emits a continuous
razzberry tone, then the scanner has an electronic failure.
Return the unit for repair at an authorized service center.





Three Beeps - on power up
If the scanner beeps 3 times on power up then, the
nonvolatile memory that holds the scanner configuration
has failed. Return the unit for repair at an authorized
service center.






2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


21
TROUBLESHOOTING


Visual Indicators

There is a red LED and amber LED on the
front of the MS7600. When the scanner is
on, the flashing or constant illumination of
the LEDs indicates the status of the current
scan and the scanner.


No Red or Amber LED
The LEDs will not be illuminated if the scanner is not
receiving power from the host or transformer.


Steady Amber
When the laser is active, the amber LED is illuminated.
The amber LED will remain illuminated until the laser is
deactivated.


Steady Amber and Single Red Flash
When the scanner successfully reads a bar code, the red
LED will flash and the scanner will beep once. If the red
LED does not flash or the scanner does not beep once,
then the bar code has not been successfully read.


Steady Amber and Steady Red
After a successful scan, the scanner transmits the data to
the host device. Some communication modes require that
the host inform the scanner when data is ready to be
received. If the host is not ready to accept the information,
the scanners red LED will remain on until the data can be
transmitted.


Flashing Amber then Flashing Red
This indicates the scanner is in program mode. A razzberry
tone indicates that an invalid bar code has been scanned
in this mode.
-Or-
If the unit is in sleep mode, each LED will flash once every
15 seconds.


Steady Red, Amber off
This indicates the scanner may be waiting for
communication from the host.




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


22
TROUBLESHOOTING


MS7600 TROUBLESHOOTING GUIDE


MS7600 Series Troubleshooting Guide
SYMPTOMS POSSIBLE CAUSE(S) SOLUTION
All Interfaces
No LEDs, beep or motor
spin.
No power is being supplied to the
scanner.
Check transformer, outlet and power
strip. Make sure the cable is plugged
into the scanner.

No LEDs, beep.
No power is being supplied to the
scanner from host.
Some host systems cannot supply
enough current to power MS7600
series scanner. Use the power supply
included with the scanner.

3 beeps on power up. Non-volatile RAM failure.
Contact a Metrologic Representative,
if the unit will not hold the
programmed configuration.

Continuous razz tone on
power up.
RAM or ROM failure.
Contact a Metrologic Representative,
if the unit will not function.

Razz tone and amber LED
flash at power up.
VLD failure. Contact a Metrologic Representative.

Razz tone and both LEDs
flash at power up.
Scanner motor failure. Contact a Metrologic Representative.

Multiple scans upon
presentation of code.
Same symbol timeout set to short.
Adjust same symbol timeout for a
longer time.

The unit powers up, but
does not beep.
Beeper disabled.
No volume is selected.
No tone is selected.
Enable Beeper.
Select Volume Level.
Select tone.

The following guide is for reference purposes only. Contact a Metrologic
representative at 1-800-ID-METRO or 1-800-436-3876 to preserve the limited
warranty terms.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


23
TROUBLESHOOTING


MS7600 TROUBLESHOOTING GUIDE

SYMPTOMS POSSIBLE CAUSE(S) SOLUTION
All Interfaces Continued
Scanning a particular symbology
that is not enabled.
UPC/EAN, Code 39, Interleaved 2 of
5, Code 93, Code 128, and Cobabar
are enabled by default. Verify that the
type of bar code being read has been
selected.
The unit powers up, but
does no scan and/or beep.
The scanner has been
programmed for a character length
lock, or a minimum length and bar
code being scanned does not
satisfy the programmed criteria.
Verify that the bar code that is being
scanned falls into the criteria. (Typical
of Non-UPC/EAN codes. The scanner
defaults to a minimum of 4 character
bar code.)

The unit scans a bar code,
but locks up after the first
scan (red LED stays on).
The scanner is configured to
support some form of host
handshaking but is not receiving
the signal.
If the scanner is setup to support
ACK/NAK, RTS/CTS, XON/XOFF or
D/E, verify that the host cable and
host are supporting the handshaking
properly.

The unit scans, but the
data transmitted to the
host is incorrect.
The scanners data format does
not match the host system
requirements.
Verify that the scanners data format
matches that required by the host.
Make sure that the scanner is
connected to the proper host port.

The print quality of the bar code is
suspect.
Also check character length lock.
Scanner beeps at some
bar codes and NOT for
other of the same bar code
symbology.
The aspect ratio of the bar code is
out of tolerance.
Check print mode. The type of printer
could be the problem. Change printer
settings. For example change to
econo mode or high speed.





2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


24
TROUBLESHOOTING


MS7600 TROUBLESHOOTING GUIDE

SYMPTOMS POSSIBLE CAUSE(S) SOLUTION
All Interfaces Continued
The bar code may have been
printed incorrectly.
Check if it is a check digit/character/or
border problem.
he scanner is not configured
correctly for this type of bar code.
Check if check digits are set properly.
Scanner beeps at some
bar codes and NOT for
others of the same bar
code symbology.
The minimum symbol length
setting does not work with the car
code.
Check if the correct minimum symbol
length is set.
Keyboard Wedge Only
The unit scans, but the
data transmitted to the
host is incorrect.
The scanner is configured to
support some form of host
handshaking but is not receiving
the signal.
If the scanner is setup to support
ACK/NAK, RTS/CTS, XON/XOFF or
D/E, verify that the host cable and
host are supporting the handshaking
properly.

The unit scans but the
data is not correct.
Configuration is not correct.
Make sure that the proper PC
type AT, PS2 or XT is selected.
Verify correct country code and
data formatting are selected.
Adjust inter-character delay,

The unit is transmitting
each character
Configuration is not correct.
Increase the interscan code delay
setting.
Adjust whether the F0 break is
transmitted.
* It may be necessary to try this in
both settings.

Alpha characters show as
lower case.
Computer is in Caps Lock mode.
Enable Caps Lock detect setting of
the scanner to detect whether the PC
is operating in Caps Lock.






2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


25
TROUBLESHOOTING


MS7600 TROUBLESHOOTING GUIDE

SYMPTOMS POSSIBLE CAUSE(S) SOLUTION
Keyboard Wedge Only Continued
Everything works except
for a couple of characters.
These characters may not be
supported by that countrys key
look up table.
Try operating the scanner in Alt Mode.
RS-232 Only
The unit is transmitting
each character.
Configuration is not correct.
Increase the interscan code delay
setting.
Adjust whether the F0 break is
transmitted.
* It may be necessary to try this in
both settings.

Alpha characters show as
lower case.
Computer is in Caps Lock mode.
Enable Caps Lock detect setting of
the scanner to detect whether the PC
is operating in Caps Lock.

Everything works except
for a couple of characters.
These characters may not be
supported by that countrys key
look up table.
Try operating the scanner in Alt Mode.

Com port at the host is not working
or configured properly.
Cable not connected to the proper
com port.
Power-up OK and scans
OK but does not
communicate properly to
the host.
Com port not operating properly.
Check to make sure that the baud rate
and parity of the scanner and the
communication port match and the
program is looking for RS-232 data.

The host is receiving data
but the data does not look
correct.
The scanner and the host may not
be configured for the same
interface.
Check that the scanner and the host
are configured for the same interface.






2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


26
TROUBLESHOOTING


MS7600 TROUBLESHOOTING GUIDE


SYMPTOMS POSSIBLE CAUSE(S) SOLUTION
RS-232 Only Continued
Characters are being
dropped.
Intercharacter delay needs to be
added to the transmitted output.
Add some intercharacter delay to the
transmitted output by using the
MetroSelect Programming Guide
(MLPN 00-02407).
Aux Port Operation with any Interface
Trouble with Secondary
Scanner.

Refer to the users guide provided with
the secondary scanner.

Cable [MLPN 54-54667] may not
be connected to the proper port.
Ensure Secondary Scanner is
connected to the MS7600 com port
marked Aux port.
The MS7600 must be programmed to
enable the Aux port.
Secondary Scanner
powers up but data is not
relayed to the host.
The Aux com port may not be
operating properly.
The auxiliary input ports data format
must match the main output format of
the secondary scanner.
Use MetroSet
For the Auxiliary interface, choose HoloTrak Decode.
All remaining parameters will be automatically chosen.
USB Only
Check that the scanner is
programmed for USB operation.
The scanner Powers up
OK, scans OK but does no
communicate.
The USB Port is not operating
correctly.
Check that the hosts USB port is
enabled.

Unplug & plug USB cable at host end.
When configured as USB
scanner razz tone & 3 LED
flashes occur.
The USB Port is not operating
correctly.
Contact a Metrologic representative if
error continues.





2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


27
TROUBLESHOOTING


RS-232 Demonstration Program

RS-232 Demonstration Program

If an RS-232 scanner is not communicating with your IBM compatible PC, key in the following
BASIC program to test that the communication port and scanner are working. This program is
for demonstration purposes only. It is only intended to prove that cabling is correct, the com
port is working, and the scanner is working. If the bar code data displays on the screen while
using this program, it only demonstrates that the hardware interface and scanner are working.
At this point, investigate whether the application software and the scanner configuration
match. If the application does not support RS-232 scanners, a software wedge program that
will take RS-232 data and place it into a keyboard buffer may be needed. This program tells
the PC to ignore RTS-CTS, Data Set Ready (DSR) and Data Carrier Detect (DCD) signals. If
the demonstration program works and yours still does not, jumper RTS to CTS and Data
Terminal Reading (DTR) to DCD and DSR on the back of your PC.


10 CLS
20 ON ERROR GOTO 100
30 OPEN COM1:9600,S,7,1,CS0,DS0,CD0,LF AS #1
35 PRINT SCAN A FEW BAR CODES
40 LINE INPUT #1, BARCODE$
50 PRINT BARCODE$
60 K$ = INKEY$: IF K$ = CHR$(27) THEN GOTO 32766
70 GOTO 40
100 PRINT ERROR NO.; ERR; PRESS ANY KEY TO TERMINATE.
110 K$ = INKEY$: IF K$ = THAN GOTO 110
32766 CLOSE: SYSTEM
32767 END






2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


28





This page has been intentionally left blank.




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


29
SERVICING & MAINTENANCE PROCEDURES


GENERAL CLEANINESS OF SCANNER

Smudges and dirt can interfere with the proper scanning of a bar code. Therefore, the output
window will need occasional cleaning.

For the MS7600 glass window:
1. Spray glass cleaner onto a lint free, non-abrasive cleaning cloth.
2. Gently wipe the scanner window.

For the MS7600 red window:
1. Use mild soap and water with lint free, non-abrasive cleaning cloth.
2. Gently wipe the scanner window.




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


30
SERVICING & MAINTENANCE PROCEDURES



CAUTION!


ESD PREVENTION STEPS MUST BE
USED DURING ANY MODIFICATIONS
AND/OR REPAIRS TO THIS UNIT!




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


31
EAS Wire is the single
black colored wire running
around the inside perimeter
of the scanner.
SERVICING & MAINTENANCE PROCEDURES


CASE ASSEMBLY/DISASSEMBLY
PROCEDURE

Case Disassembly Procedure

1. Remove the outer cover to reveal the
inner cover by lifting up on the edges of
the cover.

2. Remove the four (4) Torx screws that
hold the inner cover on. (Refer to Figure
1 A)

3. Left the inner cover off by using the
straps provided. (Refer to Figure 1 B).

4. Using a Philips head screwdriver
remove the screw and washer from the
center of the optics bench. (Refer to
Figure 2).

5. Carefully lift the optics bench from the
unit.

6. While the optics bench is part way out
from the case, unplug the flex cable
from the signal processor and the motor
from the decode board.

7. Remove the optics bench from the case
trying not to disturb the EAS wire. (Refer
to Figure 3)





















A A
A A
B B
FIGURE 1
Inner Cover View
FIGURE 2
Optics Bench Mounting Screw
FIGURE 3
EAS Wire Shown


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


32

A
B
Decode PCB
SERVICING & MAINTENANCE PROCEDURES



Case Assembly Procedure


1. Acquire the replacement Optics bench
assembly (46-46802).

2. Plug motor JST cable into J7 of the decode
board. (Refer to Figure 4-A)

3. Make sure ribbon cable connection on
Decode board is tight. (Refer to Figure 4-B)

4. Insert ribbon cable into ZIF connector J1 on
the S/P board. Make sure the connectors
are completely closed.








5. Lower optics bench into case bottom and
onto the center post collector end first,
capturing the ribbon cable under the bench
and to the right of the front post. Dress the
motor cable to the right of the cluster. (Refer
to figure 5)

6. Using an electric screwdriver (set@26 in-
oz.), fasten bench to case with the washer
and screw previously taken out. If an electric
screwdriver is not available, tighten screw
until gasket in center starts to compress.

7. Using ionized air, blow out the bottom case
and the inner cover.

8. Install inner top cover by lowering speaker
side first, then opposite side to properly
compress speaker gasket. (Refer to Figure
6)

9. Fasten the inner cover to the bottom case
using the four (4) Torx screws removed
during disassembly.

10. Using ionized air, blow out the inner cover
and the outer cover.

11. Reinstall the outer cover onto the unit.


ZIF CONNECTORS OF RIBBON
AND VLD FLEX CABLES MUST
BE COMPLETELY CLOSED ON
BOTH SIDES
FIGURE 4
Decode PCB
FIGURE 5
Optics Bench Mounting Pins
FIGURE 6
Speaker Mounting


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


33
SERVICING & MAINTENANCE PROCEDURES


DECODE BOARD REMOVAL/INSTALLATION PROCEDURES

Decode Board Removal Procedure

1. Gain access to the Decode Board by first
completing the Case Disassembly
Procedure, located on page 31.

2. If optics bench has not been removed from
inside the scanner chassis, perform steps 4
7 of the Case Disassembly Procedure,
located on page 31 of this manual.

3. Disconnect the speaker connector from J4
on the Decode Board. (Refer to Figure 7)

4. Carefully move the EAS wire up and over to
allow the decode board to be removed with.
(Refer to Figure 8)

5. Make sure all the interface ports are closed
on the exterior of the unit. (Refer to Figure 9)

6. Carefully pull up on the decode board until it
is free. (Refer to Figure 10)

7. Remove the rubber interface


Decode Board Install Procedure

1. Follow the Decode Board Removal
Procedure in reverse, beginning with step 7.















FIGURE 7
J4 (Speaker)

FIGURE 8
EAS Loop Wire
FIGURE 9
Exterior Interface Ports
FIGURE 10
Decode board Removal


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


34
The remaining steps require the use of
the 7600 Collector & Joystick Alignment
Test Fixture Set.
SERVICING & MAINTENANCE PROCEDURES


SIGNAL PROCESSOR BOARD REMOVAL/INSTALLATION
PROCEDURES

Signal Processor Board Removal Procedure

1. Disassemble case to gain access to the
Signal Processor Board area. Refer to the
Case Disassembly Procedure located on
page 31 of this manual.

* Please note that the full Optics Bench does
not need to be removed from the scanner
chassis.

2. Remove the two (2) screws that hold the
signal processor to the optic module.(Shown
in Figure 11.)

3. Detach the VLD and the ribbon cable from
the signal processor.(Shown in Figure 12.)



Installing new Signal Processor PCB
Procedure

1. To install, read what resistors have been
put on the old board for VLD (R71) and IR
(R69) and solder those values into the new
board.

2. Attach the VLD and ribbon cable to the
signal processor. (Shown in Figure 12.)

3. Loosely secure the signal processor in place
using the two (2) screws previously
removed. (Shown in Figure 11.)







4. Power up the unit.

5. Place a piece a reflective material above the
unit so that it reflects the pattern back as a
signal return.

6. Look into the number three (3) mirror at the
photocell of the signal processor. The return
signal should be visible.

7. Adjust the signal processor until the return
signal is in the middle of the photocell. Lock
in place.

8. Close the unit.

FIGURE 11
FIGURE 12


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


35
The remaining steps require the use of
the 7600 Alignment Fixture Set.
The following procedure uses the 7600 Collector & Joystick Alignment Test Fixture Set.
Anyone performing this procedure must be familiar with the 7600 Alignment Set!
SERVICING & MAINTENANCE PROCEDURES

MOTOR REPLACEMENT/INSTALLATION PROCEDURE
Motor Replacement Procedure

1. Disassemble case to gain access to the
Signal Processor Board/Motor area. Refer to
the Case Disassembly Procedure located on
page 31 of this manual. Complete the entire
Case Disassembly Procedure, including the
final Optics Bench Removal Steps.

2. Remove the two (2) screws that hold the
signal processor to the optic module. (Refer
to Figure 13)

3. Remove the three (3) screws that hold the
motor down.


Motor Installation Procedure

1. Place the motor on the optic module and
secure in place using the three (3) screws
previously removed.

2. Loosely secure the signal processor in place
using the two (2) screws previously used.

3. Install the optics module into the unit
chassis. (As described in the Case
Assembly Procedure found on page 32 of
this manual.)




4. Power up the unit.

5. Place a piece a reflective material above the
unit so that it reflects the pattern back as a
signal return.

6. Look into the number three (3) mirror at the
photocell of the signal processor. The return
signal should be visible.

7. Adjust the signal processor until the return
signal is in the middle of the photocell. Lock
in place.

8. Close the unit.


FIGURE 13
Signal Processor Screws
FIGURE 14
Motor Screws Access


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


36
The following procedure uses the 7600 Collector & Joystick Alignment Test Fixture Set.
Anyone performing this procedure must be familiar with the 7600 Alignment Set!
SERVICING & MAINTENANCE PROCEDURES

VLD REPLACEMENT/INSTALLATION PROCEDURES

VLD Removal Procedure

1. Disassemble case to gain access to the
Signal Processor Board/Motor area. Refer to
the Case Disassembly Procedure located on
page 31 of this manual. Complete the entire
Case Disassembly Procedure, including the
final Optics Bench Removal Steps.

2. Remove the two (2) screws that hold the
signal processor to the optic module. (Refer
to Figure 13 on previous page.)

3. Detach the VLD and the ribbon cable from
the signal processor.

4. With a pair of pliers remove the VLD from
the optic bench using a twisting motion to
break it free. (Refer to figure 15.)

5. Carefully remove the collector / folding
mirror from the optic bench. (Refer to Figure
16)

6. Clean left over adhesive from the plastic
optic bench.


VLD Installation Procedure

1. Acquire a VLD assembly and collector.

2. Install the collector into the 'goal posts' of
the optic bench using firm pressure until it
clicks in. Be careful of over pressing the
collector because damage may occur to the
optic bench.

3. Using an ESD safe soldering iron, remove
the VLD SBT from R71 of the signal
processor.

4. Insert a target pin into the collector hole.

5. Plug the VLD into the MA022 targeting box.

6. Insert the joystick manipulator onto the end
of the VLD.

7. Turn on the targeting box and insert the VLD
into the optic bench.

8. Target the beam onto the center of the
target pin.

9. Apply a liberal amount of LOCTITE 406
followed by a few drops of LOCTITE 712 &
let cure (Glue will turn white in color when
dry.).

10. Use the MA022 to determine the SBT
needed and solder at location R71 using an
ESD safe soldering iron.

11. Connect flex cable to the signal processor.

12. Follow the alignment procedure to complete
the unit.


Adhesive
Grip with
pliers
FIGURE 15
Optics Bench VLD
FIGURE 16
Collector Folding Mirror


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


37
The following procedure uses the 7600 Collector & Joystick Alignment Test Fixture Set.
Anyone performing this procedure must be familiar with the 7600 Alignment Set!
SERVICING & MAINTENANCE PROCEDURES


OPTICS BENCH / VLD ALIGNMENT PROCEDURE


1. Plug motor JST cable and ribbon cable into
target VLD power box TE259 Set optic
bench assembly into alignment fixture and
fasten with washer and an M3 screw using a
torque driver set at 26 in/ozs.

2. Plug JST connector cable from auto power
box into JST receptacle on the scan board.

3. Flip toggle switch to power up VLD and
motor.

4. Position cluster mirror target on mirror #2 as
shown.

Note: Make sure raster is between the lines
on the cluster target.

5. Slide the bar/space pattern in place over the
unit.

6. Push back and forth on the collector tabs to
adjust the angle of the collector until the
signals on the scope is maximized. Verify
that the return signal is within the photocell
using the manual reflective tool.

7. When signal is at maximum amplitude, place
2 drops of LOCTITE 406 on each pivot point
on the collector/bench.

8. Place 2 drops of LOCTITE 712 Accelerator
over the LOCTITE 406 applied in step 7.
Glue will turn white once dry.

9. Obtain the joystick assembly. Verify the
folding mirror is clean and straight.

10. Insert joystick into the hole in the collector
so the folding mirror is at the front of the
collector and the key of the joystick is
pointing down. Align mirror to make sure it
is straight up and down. DO NOT TOUCH
THE FACE OF THE FOLDING MIRROR
OR THE COLLECTOR. CLEAN IF
NECESSARY.

11. Adjust the folding mirror/joystick to align the
raster into the cluster mirror target lines.

12. Slide the bar/space pattern to the right so
pattern can be seen in the red window
template.

13. Adjust the folding mirror/joystick so the
raster lines are centered in the cluster mirror
target lines and the outside lines of mirrors
#1 & #5 are even with each other.

14. When the pattern is within specifications,
apply 3-4 drops of LOCTITE 406 to the
joystick in back of the collector where it exits
the hole. Do Not touch the joystick, But let
the glue run into the hole and onto the ball of
the joystick. Apply 3-4 drops of LOCTITE
712 Accelerator to the same spot.

15. Recheck the pattern alignments.

16. Slide the bar/space pattern in place over the
unit. Observe signal strength on scope for
the (4) sets of (4) field signals.

17. Signal return for fields 1& 5 should be equal
in height. If not, loosen Signal Processor
Board screws and slide board left or right to
make fields 1 & 5 equal. Securely tighten
screws.

18. Unplug cables from unit. Remove unit from
fixture.

19. Follow the assembly procedure to re-
assemble the unit.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


38





This page has been intentionally left blank.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


39
PCB SPECIFICATIONS


33717B SCAN BOARD LAYOUT

33717B Scan Board Top Side Drawing













































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


40
PCB SPECIFICATIONS

33717B Scan Board Bottom Side Drawing




























37717B Scan Board Connector Pin-outs:

















J1 12 PIN ZIF to
DECODE BOARD

1 TO OBJECT DETECT
2 SCAN ENABLE
3 VLD STATUS
4 VLD ENABLE
5 FIRST DERIVATIVE
6 GROUND
7 DATA SET
8 DATA OUT
9 GROUND
10 +5VDC
11 +5VDC
12 +12VDC

J2 - VLD

1 VLD DRIVE
2 +5VDC
3 MONITOR CURRENT



2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


41
PCB SPECIFICATIONS


33737C RS232 / OCIA / IBM DECODE INTERFACE PCB LAYOUT









































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


42
PCB SPECIFICATIONS


33737C Decode Interface Board Connector Pin-outs:















































J1 12 PIN ZIF to
SCAN BOARD

1 +12VDC
2 +5VDC
3 +5VDC
4 GROUND
5 DATA OUT
6 DATA SET
7 GROUND
8 1
ST
DERIVATIVE
9 VLD ENABLE
10 VLD STATUS
11 SCAN/MOT ENABLE
12 OBJECT DETECT

J2 - SPEAKER

1 SPEAKER +
2 SPEAKER

J3 IBM
INTERFACE

1 GROUND
2 TRANSMIT
3 RECEIVE
4 READY-TO-SEND
5 CLEAR-TO-SEND
6 DTR
7 B-
8 A+
9 +5VDC
10 NO CONNECTION


J4 - OCIA
INTERFACE

1 GROUND
2 NO CONNECTION
3 NO CONNECTION
4 RDATA
5 RDATA RETURN
6 CLOCK IN
7 CLOCK OUT
8 CLOCK IN RETURN
9 +5VDC
10 SHIELD GROUND


J5 AUX PORT

1 GROUND
2 RECEIVE
3 TRANSMIT
4 READY-TO-SEND
5 CLEAR-TO-SEND
6 NO CONNECTION
7 EAS2
8 EAS2
9 EAS1
10 EAS1



J6 PSD934

1 TMS
2 TCK
3 TSTAT
4 TERR
5 VCC
6 TDI
7 TDO
8 RST
9 GROUND
10 GROUND



J7 - MOTOR

1 MOTOR +
2 HALL SW GROUND
3 HALL SW OUT
4 HALL SW +5VDC

J8- EAS

1 EAS1
2 NO CONNECTION
3 EAS2




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


43
SERVICING DIAGRAMS, PARTS & PINOUTS


SCANNER PARTS





















2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


44
SERVICING DIAGRAMS, PARTS & PINOUTS


SCANNER INSTALLATION

Keyboard Wedge Interface Installation

1. Turn off the host system.

2. Disconnect the keyboard from the host.

3. Connect the PowerLink cable to the 2nd
jack from the top of the MS7600.

4. Connect the Y end of the PowerLink
cable to the keyboard and the keyboard
port on the host. If necessary use the
male/female adapter cable supplied with
the scanner for proper connections.

Before continuing, verify that the
PowerLink cable is connected to the
appropriate interface jack on the
scanner. An incorrect cable
connection can cause
communication problems or potential
damage to the scanner.

5. Connect the external power supply to
the power jack on the PowerLink cable.

6. Check the AC input requirements of the
power supply to make sure the voltage
matches the AC outlet.

7. Connect AC power to the transformer.
The outlet should be near the equipment
and easily accessible.

8. Scan the Load Keyboard Wedge
Defaults bar code to configure the
MS7600 for Keyboard Wedge
communication.

9. Turn on the host system.




Caution:
To maintain compliance with applicable standards, all circuits connected to the scanner must meet the requirements for
SELV (Safety Extra Low Voltage) according to EN 60950.

To maintain compliance with standard CSA C22.2 No. 60950-00/UL 60950 and norm EN 60950, the power source should
meet applicable performance requirements for a limited power source.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


45
SERVICING DIAGRAMS, PARTS & PINOUTS


1. Turn off the host system.

2. Disconnect the keyboard from the host.


3. Connect the PowerLink cable to the 2
nd

jack from the top of the MS7600.

4. Connect the other end of the PowerLink
cable to the keyboard port on the host.

5. Before continuing verify that the
PowerLink cable is connected to the
appropriate interface jack on the
scanner. An incorrect cable connection
can cause communication problems or
potential damage to the scanner.

6. Connect the external power supply to
the power jack on the PowerLink cable.

7. Check the AC input requirements of the
power supply to make sure the voltage
matches the AC outlet.

8. Connect AC power to the transformer.
The outlet should be near the equipment
and easily accessible.


9. Scan the Load Keyboard Wedge
Defaults bar code then the Enable
Stand Alone Keyboard bar code to
configure the MS7600 for Stand-Alone
Keyboard communication.

10. Note: When scanning the bar codes,
cover the code not being scanned to
ensure the codes are read in the proper
sequence.

11. Turn on the host system.








2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


46
SERVICING DIAGRAMS, PARTS & PINOUTS


SCANNER PINOUT CONNECTIONS:

The MS7600 scanner interfaces terminate to 10-pin modular jacks located on the back
of the unit. The serial # label indicates the model number of the scanner.














































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


47
SERVICING DIAGRAMS, PARTS & PINOUTS


Scanner Pinout Connections Continued:

















































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


48
SERVICING DIAGRAMS, PARTS & PINOUTS


Cable Connector Configurations (Host End)









































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


49
SERVICING DIAGRAMS, PARTS & PINOUTS


Cable Connector Configuration

The PowerLink cable is terminated with a 5-pin DIN female connector on one end, and
a 6-pin mini DIN male on the other.








Metrologic will supply an adapter cable with a 5-pin DIN male connector on one end and
a 6-pin mini DIN female connector on the other.









According to the termination required, connect the appropriate end of the adapter cable
to the PowerLink cable, leaving the necessary termination exposed for connecting to the
keyboard and the keyboard port on the PC. The pin assignments are as follows:





















2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


50
SERVICING DIAGRAMS, PARTS & PINOUTS


MS6720 SCANNER SPECIFICATIONS & DETAILS

Physical Characteristics
OPERATIONAL































Overall Dimensions









2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


51
SERVICING DIAGRAMS, PARTS & PINOUTS


Electrical Characteristics




















Manufacturers Recommendation





2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


52
SERVICING DIAGRAMS, PARTS & PINOUTS


APPLICATIONS AND PROTOCOLS

The model number on each scanner includes the scanner number and factory default
communications protocol.













The MS7600 with Built-in PC Keyboard Wedge Interface is designed to be used for
keyboard emulation only. Many RS-232 programmable functions available in other
Metrologic scanners are also available as keyboard wedge functions.


The following are the most important selectable options specific to the keyboard wedge.



Keyboard Type

** AT (includes IBM PS2 models 50, 55, 60, 80)
XT
IBM PS2 (includes models 30, 70, 8556)





Keyboard Country Type

** USA German Spanish
Belgium Italian Swiss
French Japan United Kingdom


Refer to the MetroSelect Programming Guide (MLPN 00-02407) or MetroSet 2s help
files for information on how to change the default settings.







2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


53
SERVICING DIAGRAMS, PARTS & PINOUTS


SCANNER LABEL

Each scanner has a label on the bottom of the unit. The label contains information such
as the model number, date of manufacture, serial number, and caution information. An
additional caution label is located under the top plate. The following are examples of
these labels.
















































2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


54





This page has been intentionally left blank.




2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


55
ORDERING PARTS & SERVICING INFORMATION


** To order replacement parts, contact the dealer, distributor or call Metrologics
Customer Service Department at 1-800-ID-METRO or 1-800-436-3876. **

REPLACEMENT PARTS AVAILABLE


Metrologic
Part Number
Part / Item Description
46-46648 SCAN BOARD
46-46646 DEC w/232/ocia/ibm[7600]
46-46647 DEC w/kb/usb/lp/232
46-46654 COLLECTOR,DRILLED &
46-46586 RPL,JOYSTICK ASSY,7600
46-46652 MOTOR/POLYGON 7600
46-46649 7620 VLD ASSY
46-46650 RPL,CABLE,ZIFF,SCAN BOARD
46-46651 SPEAKER CABLE,7600
46-46651 RPL,SPEAKER ASSY,7600
46-46653 RPL,INT EAS CABLE Assy,
46-46655 RPL,Cover,Inner Window,
46-46602 7600 SS Top Cover w/ SAPHIRE
46-46603 RP STAINLESS STEEL TOP with DIAMONEX
46-46604 RP,Stnls Steel Top WITH STANDARD WINDOW
46-46605 High Impact Plastic WITH SAPHIRE
46-46606 Rp,High Impact Plastic WITH DIAMONEX
46-46607 Rp,High Impact Plastic WITH STANDARD
46-46802 76xx Aligned Optics Assy

* This parts listing is current as of July 1
st
, 2004. More additional parts maybe available from Metrologic Instruments,
Inc. For a complete up to date listing please contact Metrologic Instruments or visit Metrologics website at
http://www.metrologic.com/.


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


56
ORDERING PARTS AND SERVICING INFORMATION

WARRANTY AND DISCLAIMER

Limited Warranty

All MS7600 scanners are manufactured by Metrologic at its Blackwood, New Jersey, U.S.A. facility. The
MS7600 scanners have a two (2) year limited warranty from the date of manufacture. Metrologic
warrants and represents that all scanners are free of all defects in material, workmanship and design, and
have been produced and labeled in compliance with all applicable U.S. Federal, state and local laws,
regulations and ordinances pertaining to their production and labeling.

This warranty is limited to repair, replacement of Product or refund of Product price at the sole discretion
of Metrologic. Faulty equipment must be returned to the Metrologic facility in Blackwood, New Jersey,
U.S.A. or Puchheim, Germany. To do this, contact Metrologics Customer Service/Repair Department to
obtain a Returned Material Authorization (RMA) number.

In the event that it is determined the equipment failure is covered under this warranty, Metrologic shall,
at its sole option, repair the Product or replace the Product with a functionally equivalent unit and return
such repaired or replaced Product without charge for service or return freight, whether distributor,
dealer/reseller, or retail consumer, or refund an amount equal to the original purchase price.

This limited warranty does not extend to any Product which, in the sole judgement of Metrologic, has
been subjected to abuse, misuse, neglect, improper installation, or accident, nor any damage due to
use or misuse produced from integration of the Product into any mechanical, electrical or computer
system. The warranty is void if the case of Product is opened by anyone other than Metrologics repair
department or authorized repair centers.

THIS LIMITED WARRANTY, EXCEPT AS TO TITLE, IS IN LIEU OF ALL OTHER WARRANTIES OR
GUARANTEES, EITHER EXPRESS OR IMPLIED, AND SPECIFICALLY EXCLUDES, WITHOUT
LIMITATION, WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE UNDER THE UNIFORM COMMERCIAL CODE, OR ARISING OUT OF CUSTOM OR
CONDUCT. THE RIGHTS AND REMEDIES PROVIDED HEREIN ARE EXCLUSIVE AND IN LIEU OF
ANY OTHER RIGHTS OR REMEDIES. IN NO EVENT SHALL METROLOGIC BE LIABLE FOR ANY
INDIRECT OR CONSEQUENTIAL DAMAGES, INCIDENTAL DAMAGES, DAMAGES TO PERSON OR
PROPERTY, OR EFFECT ON BUSINESS OR PROPERTY, OR OTHER DAMAGES OR EXPENSES
DUE DIRECTLY OR INDIRECTLY TO THE PRODUCT, EXCEPT AS STATED IN THIS WARRANTY.
IN NO EVENT SHALL ANY LIABILITY OF METROLOGIC EXCEED THE ACTUAL AMOUNT PAID TO
METROLOGIC FOR THE PRODUCT. METROLOGIC RESERVES THE RIGHT TO MAKE ANY
CHANGES TO THE PRODUCT DESCRIBED HEREIN.












Metrologic Instruments GmbH
Dornierstrasse 2
82178 Puchheim b
Munich, Germany
TEL: 49-89-89019-0
FAX: 49-89-89019-200
Metrologic Instruments, Inc.
90 Coles Road
Blackwood, NJ 08012-4683
Customer Service Department:
1-800-ID-METRO (1-800-436-3876)
TEL: 856-228-8100
FAX: 856-228-6673


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


57
ORDERING PARTS & SERVICING INFORMATION

METROLOGIC WORLDWIDE OFFICE LOCATIONS

Corporate Headquarters

North America Metrologic Instruments, Inc. Customer Service: 1-800-ID-METRO
90 Coles Road Tel: 856-228-8100
Blackwood, NJ 08012-4683 Fax: 856-228-6673
Email: info@metrologic.com
Internet: www.metrologic.com
European Headquarters

Germany, Metrologic Instruments GmbH Tel: +49 89 89019 0
Middle East and Africa Dornierstrasse 2 Fax: +49 89 89019 200
82178 Puchheim b. Email: info@europe.metrologic.com
Munich, Germany Germany Email: info@de.metrologic.com

Spain Metrologic Eria lbrica SL Tel: +34 913 272 400
Julin Camarillo 29, D-1 Fax: +34 913 273 829
Edificio Diapasn Email: info@es.metrologic.com
28037 Madrid

Italy Metrologic Instruments Italia srl Tel: +39 0 51 6511978
Via Emilia 70 Fax: +39 0 51 6521337
40064 Ozzano dellEmilia (BO) Email: info@it.metrologic.com

France Metrologic Eria France SA Tel: +33 (0) 1 48.63.78.78
69 Rue de la Belle Etoile Fax: +33 (0) 1 48.63.24.94
ZI Paris Nord II, BP 50057 Email: info@fr.metrologic.com
95947 ROISSY CDG CEDEX

United Kingdom Metrologic Instruments UK Limited Tel: +44 (0) 1256 365900
58 Tempus Business Centre Fax: +44 (0) 1256 365955
Kingsclere Road, Basingstoke Email: info@uk.metrologic.com
Hampshire RG21 6XG
Asia

Singapore Metrologic Asia (Pte) Ltd Tel: 65-6842-7155
No. 8 Kaki Bukit Place Fax: 65-6842-7166
4
th
Floor Email: info@sg.metrologic.com
Singapore 416186

China Metro (Suzhou) Technologies Co., Ltd. Tel: 86-512-62572511
221 Xing Hai Street Fax: 86-512-62571517
Suzhou Industrial Park Email: info@cn.metrologic.com
Suzhou, China
215021

Japan Metrologic Japan Co., Ltd. Tel: 81-03-3839-8511
Matsunoya Building, 6 Floor Fax: 81-03-3839-8519
3-14-8 Higashiueno Email: info@jp.metrologic.com
Taitou-Ku, Tokyo 110-0015 Japan
South America


Brazil Metrologic do Brasil Ltda. Tel: 55-11-5182-8226
Rua da Paz 2059 Fax: 55-11-5182-8315
CEP 04713-002 Email: info@br.metrologic.com
Chcara Santo Antnio
So Paulo, SP, Brasil

Outside Brazil Metrologic South America Tel: 55-11-5182-7273
Rua da Paz 2059 Fax: 55-11-5182-7198
CEP 04713-002 Email: info@sa.metrologic.com
Chcara Santo Antnio


2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


58
ORDERING PARTS AND SERVICING INFORMATION


PATENTS

*Patent Information

This METROLOGIC product may be covered by one or more of the following U.S. Patents:

U.S. Patent No.; 4,360,798; 4,369,361; 4,387,297; 4,460,120; 4,496,831; 4,593,186; 4,607,156;
4,673,805; 4,736,095; 4,758,717; 4,816,660; 4,845,350; 4,896,026; 4,923,281; 4,933,538;
4,960,985; 4,992,717; 5,015,833; 5,017,765; 5,059,779; 5,081,342; 5,117,098; 5,124,539;
5,130,520; 5,132,525; 5,140,144; 5,149,950; 5,180,904; 5,200,599; 5,216,232; 5,229,591;
5,247,162; 5,250,790; 5,250,791; 5,250,792; 5,260,553; 5,262,628; 5,280,162; 5,280,164;
5,304,788; 5,321,246; 5,324,924; 5,340,971; 5,340,973; 5,396,053; 5,396,055; 5,408,081;
5,410,139; 5,424,525; 5,436,440; 5,449,891; 5,468,949; 5,468,951; 5,479,000; 5,484,992;
5,525,789; 5,528,024; 5,532,469; 5,545,889; 5,557,093; 5,570,093; 5,591,953; 5,616,908;
5,627,359; 5,637,852; 5,661,292; 5,767,501; 5,777,315; 5,789,730; 5,789,731; 5,796,091;
5,811,780; 5,825,012; 5,828,048; 5,844,227; 5,883,375; 5,886,337; 5,895,907; 5,925,870;
5,925,871; 5,939,698; 5,942,743; 6,029,894; D385,265;


No license right or sublicense is granted, either expressly or by implication, estoppel, or
otherwise, under any METROLOGIC or third party intellectual property rights (whether or not
such third party rights are licensed to METROLOGIC), including any third party patent listed
above, except for an implied license only for the normal intended use of the specific equipment,
circuits, and devices represented by or contained in the METROLOGIC products that are
physically transferred to the user, and only to the extent of METROLOGICs license rights and
subject to any conditions, covenants and restrictions therein.


Other worldwide patents pending.













2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


59
Notes:























2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


60
Notes:























2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


61
Notes:























2004 Metrologic Instruments, Inc. All rights reserved MS7600 Service Manual


62

You might also like