Wavelength =375 mm Parasitic elements contacting a square section metal boom 25.00 mm across. Folded dipole mounted same as directors and reflector Director/reflector square section =6 mm Radiator diam =6 mm REFLECTOR 200 mm long at boom position =30 mm (IT =87.5 mm) RADIATOR Single dipole 173 mm tip to tip, spaced 75 mm from reflector at boom posn 105 mm (IT =74.0 mm) Folded dipole 196 mm tip to tip, spaced 75 mm from reflector at boom posn 105 mm (IT =85.5 mm) DIRECTORS Dir Length SpacedBoom position IT Gain Gain (no.) (mm) (mm) (mm) (mm) (dBd) (dBi) 1 173 28 133 74.0 3.6 5.8 2 171 67 201 73.0 5.8 8.0 3 169 81 281 72.0 7.4 9.5 4 167 94 375 71.0 8.6 10.7 5 165 105 480 70.0 9.5 11.7 6 164 112 592 69.5 10.3 12.5 7 162 118 710 68.5 11.0 13.2 8 161 124 834 68.0 11.6 13.8 COMMENTS The abbreviation "IT" means "Insert To", it is the construction distance from the element tip to the edge of the boom for through boom mounting Spacings measured centre to centre from previous element Tolerance for element lengths is +/- 1 mm Boom position is the mounting point for each element as measured from the rear of the boom and includes the 30 mm overhang.T he total boom length is 864 mm including two overhangs of 30 mm The beam's estimated 3dB beamwidth is 42 deg FOLDED DIPOLE CONSTRUCTION Measurements are taken from the inside of bends Folded dipole length measured tip to tip =196mm Total rod length =422mm Centre of rod=211mm Distance HI=GF=76mm Distance HA=GE=103mm Distance HB=GD=131mm Distance HC=GC=211mm Gap at HG=10mm Bend diameter BI=DF=35mm If the folded dipole is considered as a flat plane (see ARRL Antenna Handbook) then its resonant frequency is less than the flat plane algorithm's range of 10:1 B C D /--------------|-------------\ A E \-------------| |-------------/ I H G F