Professional Documents
Culture Documents
shtml
Close Window
Assessment System
Take Assessment - ESwitching Chapter 3 - CCNA Exploration: LAN Switching and Wireless (Version 4.0)
1 Switch-A and Switch-B are both configured with ports in the Marketing, Sales, Accounting, and Admin VLANs. Each VLAN contains 12
users. How many different subnetworks will be needed to enable routed connectivity between the VLANs?
j1
k
l
m
n
i4
j
k
l
m
n
j 12
k
l
m
n
j 48
k
l
m
n
Refer to the exhibit. The network administrator has just added VLAN 50 to Switch1 and Switch2 and assigned hosts on the IP addresses of the
VLAN in the 10.1.50.0/24 subnet range. Host A can communicate with Host B, but not with Host C or Host D. What is the most likely cause of
this problem?
j There is a native VLAN mismatch.
k
l
m
n
i The link between Switch1 and Switch2 is up but not trunked.
j
k
l
m
n
j The router is not properly configured for inter-VLAN routing.
k
l
m
n
j VLAN filtering is preventing VLAN 50 from entering the trunk between Switch1 and Switch2.
k
l
m
n
3 Switch port fa0/1 was manually configured as a trunk, but now it will be used to connect a host to the network. How should the network
administrator reconfigure switch port fa0/1?
j Remove the multiple VLANs that the port carried in global configuration mode.
k
l
m
n
j Enter the switchport nonegotiate command in interface configuration mode.
k
l
m
n
j Administratively shut down and re-enable the interface to return it to default.
k
l
m
n
i Enter the no switchport mode trunk command in interface configuration mode.
j
k
l
m
n
j Disable DTP.
k
l
m
n
j Enter the switchport mode access command in interface configuration mode.
k
l
m
n
Refer to the exhibit. The two switches that are shown will not form a trunk. What is the most likely cause of this problem?
j The native VLANs are improperly configured.
k
l
m
n
j All the hosts are on the same VLAN and a trunk is not needed.
k
l
m
n
i Both ports are set to dynamic auto.
j
k
l
m
n
j The trunk should be configured using the switchport mode access command.
k
l
m
n
5 A network administrator is removing several VLANs from a switch. When the administrator enters the no vlan 1 command, an error is
received. Why did this command generate an error?
j VLANs can only be deleted by the user who created them.
k
l
m
n
j VLAN 1 can not be deleted until another VLAN has been assigned its responsibilities.
k
l
m
n
j The command was not entered properly, which caused a syntax error to occur.
k
l
m
n
j VLAN 1 can not be deleted until all ports have been removed from it.
k
l
m
n
i VLAN 1 is the management VLAN by default and can not be deleted.
j
k
l
m
n
Refer to the exhibit. Interface Fa0/1 on switch SW1 is configured in trunk mode. Which statement is true about the trunk link between the
switches SW1 and SW2?
i Interface Fa0/2 on switch SW2 will negotiate to become a trunk link if it supports DTP.
j
k
l
m
n
j Interface Fa0/1 converts the neighboring link on the adjacent switch into a trunk link automatically with no consideration of the
k
l
m
n
configuration on the neighboring interface.
j Interface Fa0/1 converts the neighboring link on the adjacent switch into a trunk link if the neighboring interface is configured in
k
l
m
n
nonegotiate mode.
j Interface Fa0/2 on switch SW2 can only become a trunk link if statically configured in that mode.
k
l
m
n
Refer to the exhibit. Host B is on the same VLAN as Host D, but they are unable to communicate. What is the most likely cause of this
problem?
j The link between the switches is up but not trunked.
k
l
m
n
j VLAN filtering is not allowing VLAN 3 to enter the trunk between the switches.
k
l
m
n
j The router is not properly configured to route traffic between the VLANs.
k
l
m
n
i Host D does not have a proper address for the VLAN 3 address space.
j
k
l
m
n
9 What are three characteristics of VLAN1 in a default switch configuration? (Choose three.)
b CDP messages are only sent on VLAN1.
c
d
e
f
g
g VLAN1 is reserved for links between switches.
b
c
d
e
f
g All switch ports are members of VLAN1.
b
c
d
e
f
g VLAN1 must be created before ports can be assigned to it.
c
d
e
f
c Only switch port 0/1 is assigned to VLAN1.
d
e
f
g
c An IP address configured on the switch will only apply to ports on VLAN1.
d
e
f
g
10
Refer to the exhibit. Which two conclusions can be drawn regarding the switch that produced the output shown? (Choose two.)
c The network administrator configured VLANs 1002-1005.
d
e
f
g
g The VLANs are in the active state and are in the process of negotiating configuration parameters.
b
c
d
e
f
c A FDDI trunk has been configured on this switch.
d
e
f
g
g The command switchport access vlan 20 was entered in interface configuration mode for Fast Ethernet interface 0/1.
c
d
e
f
g Devices attached to ports fa0/5 through fa0/8 cannot communicate with devices attached to ports fa0/9 through fa0/12 without the
b
c
d
e
f
use of a Layer 3 device.
11
Refer to the exhibit. The network administrator has added the configuration shown to a Catalyst switch without receiving any error or
information messages from the switch. What statement is true regarding Fast Ethernet port 0/2?
j Data from multiple VLANs travels on interface Fast Ethernet 0/2.
k
l
m
n
j No data can travel on interface Fast Ethernet 0/2 until the network administrator assigns it an IP address in the range of VLAN2.
k
l
m
n
j For Host A to be able to communicate with Host B and Host C, VLAN3 and VLAN4 must also be configured on interface Fast
k
l
m
n
Ethernet 0/2.
i The network administrator has already entered the command vlan 2 in global configuration mode.
j
k
l
m
n
j The network administrator has already named VLAN2.
k
l
m
n
13 What must the network administrator do to remove Fast Ethernet port fa0/1 from VLAN 2 and assign it to VLAN 3?
j Enter the no vlan 2 and the vlan 3 commands in global configuration mode.
k
l
m
n
j Enter the no switchport access vlan 2 command in interface configuration mode and then configure the port for VLAN 3.
k
l
m
n
i Enter the switchport access vlan 3 command in interface configuration mode.
j
k
l
m
n
j Administratively shut down the interface to return it to the default configuration and then configure the port for VLAN 3.
k
l
m
n
15 Which two statements describe how devices on VLANs communicate? (Choose two.)
c Devices on different VLANs communicate through VTP.
d
e
f
g
b Devices on different VLANs communicate through routers.
c
d
e
f
g
g Data for multiple VLANs is carried over an access link that connects two switches.
c
d
e
f
g Devices on the same VLAN communicate through a router.
c
d
e
f
g Devices on the same VLAN communicate through Layer 2 switches.
b
c
d
e
f
Close Window
All content copyright 1992-2007 Cisco Systems, Inc. Privacy Statement and Trademarks.
Close Window
Assessment System
Take Assessment - ESwitching Chapter 3 - CCNA Exploration: LAN Switching and Wireless (Version 4.0)
16
Refer to the exhibit. How far is a broadcast frame that is sent by host A propagated in the LAN domain?
i Only hosts in VLAN10 receive the broadcast frame.
j
k
l
m
n
j All hosts that are connected to SW1 receive the broadcast frame.
k
l
m
n
j All hosts that are connected to SW2 and SW3 receive the broadcast frame.
k
l
m
n
j All hosts in VLAN 20 and VLAN 30 receive the broadcast frame.
k
l
m
n
j Hosts that are connected to all switches receive the broadcast frame.
k
l
m
n
18 What port assignment mode should be used on the switch to provide connectivity for traffic coming from voice and data VLANs?
j static VLAN port membership, as long as all VLANs are enabled on the port
k
l
m
n
j static VLAN port membership, as long as voice and data VLANs are enabled on the port
k
l
m
n
i voice VLAN port membership, which automatically provides connectivity for both VLANs
j
k
l
m
n
j dynamic VLAN port membership, which dynamically switches the traffic coming from voice and data VLANs
k
l
m
n
19
Refer to the exhibit. Host A sends a frame to host B. On which links along the path between hosts A and B will a VLAN ID tag be included
with the frame?
i C, E
j
k
l
m
n
j A, C, E
k
l
m
n
j C, E, F
k
l
m
n
j A, C, D, E
k
l
m
n
j A, B, C, D, E
k
l
m
n
j A, B, C, D, E, F, G
k
l
m
n
20 What happens to the member ports of a VLAN when the VLAN is deleted?
i They become inactive.
j
k
l
m
n
j They default back to the management VLAN.
k
l
m
n
j They automatically become a part of VLAN1.
k
l
m
n
j They must be assigned to another VLAN before the original VLAN can be deleted.
k
l
m
n
j They remain a part of that VLAN until the switch is rebooted. They then become members of the management VLAN.
k
l
m
n
21 The network administrator wants to separate hosts in Building A into two VLANs numbered 20 and 30. Which two statements are true
concerning VLAN configuration? (Choose two.)
b The VLANs may be named.
c
d
e
f
g
c VLAN information is saved in the startup configuration.
d
e
f
g
c Non-default VLANs created manually must use the extended range VLAN numbers.
d
e
f
g
b The network administrator may create the VLANs in either global configuration mode or VLAN database mode.
c
d
e
f
g
c Both VLANs may be named BUILDING_A to distinguish them from other VLANs in different geographical locations.
d
e
f
g
22
23
24
25 What information does frame tagging add to each frame to allow delivery of frames across a switched trunk?
j the destination MAC address
k
l
m
n
j the switch MAC address
k
l
m
n
i the VLAN ID
j
k
l
m
n
j the BID
k
l
m
n
Maximum
2 2 2 3 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 51 100
Score
Your
1 1 2 0 1 0 0 0 0 37 72.5
Score
Legend
(I.I) Interactivate Items
(T/F) True/False
(*) Regraded