CANOPY WORKS CONSTRUCTION METHOD of STATEMENT Specification Sheet. Number of columns will be 6 columns. Columns will be fixed to the foundation by using steel plate and bolts not welding. All around the canopy will be covered ; 40cm to 50 cm height and 1mm to 1. Mm thickness steel plate.
Original Description:
Original Title
Car Wash Construction Works Method of Statement[1]
CANOPY WORKS CONSTRUCTION METHOD of STATEMENT Specification Sheet. Number of columns will be 6 columns. Columns will be fixed to the foundation by using steel plate and bolts not welding. All around the canopy will be covered ; 40cm to 50 cm height and 1mm to 1. Mm thickness steel plate.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOC, PDF, TXT or read online from Scribd
CANOPY WORKS CONSTRUCTION METHOD of STATEMENT Specification Sheet. Number of columns will be 6 columns. Columns will be fixed to the foundation by using steel plate and bolts not welding. All around the canopy will be covered ; 40cm to 50 cm height and 1mm to 1. Mm thickness steel plate.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOC, PDF, TXT or read online from Scribd
WORKS METHOD OF STATEMENT Specification Sheet A ) CANOPY WORKS 1 ) Dimension of the Canopy will be : 5 mt x 10 mt. 2) Sandwich Roof 3 ) Colomns will be made by using Min. 2 mm thickness steel profile or steel plate and dimensions will be 200mm x 200mm x 3 meters (clear height ) . number of columns will be 6 columns. Columns will be fixed to the foundation by using steel plate and bolts not welding. 4 ) Column Foundation dimentions : (50cmx50cmx50cm) 5) Trusses will be prepared using min 50mm to 60mm steel angles or according to calculations by Construction Company. 6 ) Roof will be 3 cm or 4 cm or 5 cm thickness sandwich panel. 7 ) All around the canopy will be covered ; 40cm to 50 cm height and 1mm to 1.5 mm thickness steel plate 8 ) Drainage Channel for roof ; 10 mt length 20 cm x 20 cm dimension and 1 mm to 1.5 mm tickness steel plate will be used (PVC half pipe may be used ). Plastic pipe will be installed for 2 columns as 100 mm diameter for drainage on one side . 9 ) Lights ; two Spot lights will be fixed , one at each corner of the canopy. 10 ) All the Canopy will be painted by anti rust primer and then by company colors. B ) FOUNDATION CONSTRUCTION WORKS 1 ) It will be a concrete area Under the Canopy . Dimension of the concrete area ; 5 mt x 10 mt x 0.20 mt height. Min. 5 mm diameter steel mesh will be used. The slope will be adjusted towards to drainage system channel place 2 ) Surface of the concrete should be smooth and the concrete sides shoud be of sharp edges 90 degrees angles. 3 ) Drainage Channel : Constructed both sides entrance and exit at the point where the car wash rails end , it should be 2.5 to 3 meters mt length and 25 to 30 cm width and 20 to 30 cm depth , the drainage channel should be covered with strong steel mesh to allow water drainage. The drainage cover should be made of steel angles bottom and top, not less than 40mm and steel bars mesh not less than 14 mm diameter .