Professional Documents
Culture Documents
TECHNICAL MANUAL
Table of Contents
Illus
Page Figure
SECTION I. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
II. Repair parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Group 00 Antenna Loop AT-784/PRC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1
01 Antenna AT-1082/PRC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 2-6
02 Cable Assemblies CG-3344/PRC, CG-2840A/U . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 7
SECTION III. Special tools list (not applicable)
IV. National stock number and part number index. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
★ This manual supersedes so much of TM 11-5985-284-15, 3 February 1967, as pertains to repair parts and
special tools lists.
i
*TM 11-5985-284-24P
SECTION I
INTRODUCTION
1. Scope NOTE
This manual lists spares and repair parts; special tools, Cannibalization or salvage maybe used as a
special test, measurement, and diagnostic equipment source of supply for any items source coded
(TMDE), and other special support equipment required above except those coded XA and aircraft
for performance of organizational, direct support, and support items as restricted by AR 700-42.
general support maintenance of the AT-784/PRC. (2) Maintenance code. Maintenance codes are as-
It authorizes the requisitioning and issue of spares and signed to indicate the levels of maintenance authorized
repair parts as indicated by the source and mainte- to USE and REPAIR support items. The maintenance
nance codes. codes are entered in the third and fourth positions of
the Uniform SMR Code format as follows:
2. General (a) The maintenance code entered in the third
This Repair Parts and SpeciaI Tools List is divided into position will indicate the lowest maintenance level au-
the following sections: thorized to remove, replace, and use the support item.
a. Section II. Repair Parts List. A list of spares and The maintenance code entered in the third position
repair parts authorized for use in the performance of will indicate one of the following levels of mainte-
maintenance. The list also includes parts which must nance.
Code Application/Explanation
be removed for replacement of the authorized parts.
Parts lists are composed of functional groups in nu- O—Support item is removed, replaced, used at the or-
ganizational level.
meric sequence, with the parts in each group listed in
figure and item number sequence. F—Support item is removed, replaced, used at the di-
rect support level.
b. Section III. Special Tools List. Not applicable.
c. Section IV. National Stock Number and Part H—Support item is removed, replaced, used at the
Number Index. A list, in National item identification general support level.
number (NIIN) sequence, of all National stock num- (b) The maintenance code entered in the fourth
position indicates whether the item is to be repaired
bers (NSN) appearing in the listings, followed by a list,
in alphameric sequence, of all part numbers appearing and identifies the lowest maintenance level with the
in the listings. National stock numbers and part num- capability to perform complete repair (i.e., all author-
ized maintenance functions). This position will contain
bers are cross-referenced to each illustration figure
and item number appearance. one of the following maintenance codes:
code Application/Explanatwn
3. Explanation of Columns F—The lowest maintenance level capable of complete.
a. Illustration. This column is divided as follows: repair of the support item is the direct support
(1) Figure number. Indicates the figure number of level.
the illustration on which the item is shown. H—The lowest maintenance level capable of complete
(2) Item number. The number used to identify repair of the support item is the general support
item called out in the illustration. level.
b. Source, Maintenance, and Recoverability (SMR) Z—Nonreparable. No repair is authorized.
Codes. (3) Recoverbility code. Recoverability codes are
(1) Source code. Source codes indicate the manner assigned to support items to indicate the disposition
of acquiring support items for maintenance, repair, or action on unserviceable items. The recoverability code
overhaul of end items. Source codes are entered in the is entered in the fifth position of the Uniform SMR
first and second positions of the Uniform SMR Code Code format as follows:
format as follows: Recoverbility
Code Definition code 8 Definition
PA—Item procured and stocked for anticipated or Z—Nonreparable item. When unserviceable, condemn
known usage. and dispose at the level indicated in position 3.
XD—A support item that is not stocked. When re- F—Reparable item. When uneconomically reparable,
quired, item will be procured through normal condemn and dispose at the direct support level.
supply channels. H—Reparable item. When uneconomically reparable,
1
★ TM 11-5985-284-24P
2
TM 11-5985-284-24P
EL2MQOOI
Figure 1. Antenna, Loop AT-784/PRC
4
TM11-5985-284-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
5/(6 BLANK)
TM 11-5985-284-24P
EL2MQ002
EL2MQ003
9
TM 11-5985-284-24P
10
TM11-5985-284-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
11
TM 11-5895-284-24P
EL2MQ005
13
TM 11-5895-284-24P
EL2MQ006
Figure 5. Antenna AT-1082/PRC, RF Tuning and Attenuator Assembly,
Band Switch and Attenuator Assemblies.
14
TM11-5985-284-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
15
TM 11-5895-284-24P
EL2QM007
Figure 6. Antenna AT-1082/PRC, Housing Assembly.
16
TM11-5985-284-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
17
TM 11-5895-284-24P
18
TM11-5985-284-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO NO CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
CG-2840A/U
19
SECTION IV TM11-5985-284-24P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT END OF INDEX
5310-00-054-1830 2 6 5310-00-722-5998 2 11
5310-00-058-3599 3 6 5320-00-753-3942 7 8
5320-00-081-7418 4 3 5930-00-823-0482 2 25
5905-00-111-4736 5 8 5310-00-929-6395 2 10
5930-00-933-8369 3 4
5930-00-933-8371 5 13
5305-00-253-5603 2 3 5930-00-933-8372 5 2
5305-00-253-5604 2 22 5820-00-933-8396 2 21
5905-00-279-1758 5 14 5820-00-933-8398 2 7
5340-00-291-5322 7 11 5820-00-933-8406 2 4
5905-00-299-1541 5 9 5910-00-933-8514 3 3
5305-00-543-2192 2 5 5910-00-933-8515 3 9
5905-00-935-8544 5 11
5935-00-577-2281 7 3 5820-00-936-5479 3 1
5355-00-616-9659 2 23 5820-00-937-1671 2 13
5320-00-952-7864 4 4
MS35183-912A 96906 2 14
MS35223-12 96906 3 7
MS35223-41 96906 2 5
MS35233-26 96906 2 24
MS35335-57 96906 3 6 SMD447766 80063 3 5
MS35337-79 96906 2 10 SMD508824 80063 2 20
MS35338-80 96906 2 6 SMD508825 80063 6 3
MS8241-159 96906 2 12 SMD508826 80063 2 13
MS91525-1 96906 2 23 SMD508836 80063 5 2
SMD508837 80063 3 10
RC20GF101J 81349 5 10 SMD508838 80063 5 3
RC20GF151J 81349 5 9 SMD508839 80063 5 6
RC20GF161J 81349 5 8 SMD508840 80063 5 13
RC20GF181J 81349 5 11 SMD508841 80063 5 7
RC20GF680J 81349 5 12 SMD508842 80063 5 16
RC20GF750J 81349 5 14 SMD508845 80063 2 18
RG-55B/U 81349 7 1 SMD508846 80063 2 8
RG-55B/U 81349 7 4 SMD508864 80063 2 21
SMB447725 8063 2 17 SMD508870 80063 2 1
SMB508828-2 80063 6 4 SMD508873 80063 2 26
SMB508856 80063 4 2 SMD508876 80063 3 2
SMB508879 80063 7 6 SMD508877 80063 3 4
SMC508827 80063 2 25 SMD508883 80063 6 6
SMC508830 80063 6 1
SMC508834 80063 3 3 UG-890/U 80058 7 3
20
SECTION IV NATIONAL STOCK NUMBER AND PART NUMBER INDEX TM11-5985-284-24P
21/(22 BLANK)
By Order of the Secretary of the Army:
E. C. MEYER
General, United States Army
Official: Chief of Staff
J. C. PENNINGTON
Major General, United States Army
The Adjutant General
Distribution:
To be distributed in accordance with DA Form 12-51 Organizational requirements for AT-784/PRC.
PIN : 044622-000