Jarol cannot accept responsibility for the finished garment if any yarn other than the recommended yarn is used. Instructions are given for 26 in or 66 cm size, larger sizes in square brackets. Where only one set of figures is given, this applies to all sizes.
Jarol cannot accept responsibility for the finished garment if any yarn other than the recommended yarn is used. Instructions are given for 26 in or 66 cm size, larger sizes in square brackets. Where only one set of figures is given, this applies to all sizes.
Jarol cannot accept responsibility for the finished garment if any yarn other than the recommended yarn is used. Instructions are given for 26 in or 66 cm size, larger sizes in square brackets. Where only one set of figures is given, this applies to all sizes.
Wrap over with Long or Short Sleeves and an Optional Lace Edging MEASUREMENTS AND MATERIALS
To fit chest/bust sizes 26 28 30 32 34 36 38 40 in
66 71 76 81 86 91 97 102 cm
Garment measurement 28112 30'/2 . 32 34 36114 38 40112 42'/2 in
72 77 81 86 92 97 103 108 cm
Length from centre back neck 13 14'12 16 18 18112 19 19112 20 in
33 37 41 46 47 48 50 51 cm
Length of long sleeves 12 13112 15 16 16112 17 17112 17314 in
30 34 38 41 42 43 44 45 cm
Length of short sleeves 3 3 3112 3112 4 4 4112 4112 in
7 -, 5 7.5 9 9 10 10 11.5 11.5 cm
JAROL SUNSHINE OK
Wrapover with Long Sleeves 5 5 5 6 6 7 7 8 50g balls
Wrapover with Short Sleeves and Lace Edging 5 5 5 6 6 7 7 8
1 pair size 3114 mm (UK10-USA3) and 1 pair size 4 mm (UK8-USA6) knitting needles or the size of needles to give correct tension. IMPORTANT
These yarn amounts are based on average requirements and are therefore approximate.
Jarol cannot accept responsibility for the finished garment if any yarn other than the recommended yarn is used.
NOTES
Instructions are given for 26 in or 66 cm size, larger sizes in square brackets.
Where only one set of figures is given, this applies to all sizes. We suggest that you underline all the figures for the size you require before knitting.
TENSION
22 sts and 30 rows to 4 in or 10 cm measured over st st on size 4 mm needles or the size of needles to give correct tension.
It is important to check your tension before commencing the garment, therefore knit a tension square.
If there are less sts or rows to 4 in or 10 cm than stated, change to thinner needles.
If there are more sts or rows to 4 in or 10 cm than stated, change to thicker needles.
ABBREVIATIONS
Beg = beginning; em =
Page 2 (E806)
centimetres; K = knit; inc = increase; in = inch(es); M1 = pick up the bar between st just worked and next st on left-hand needle and work into back of it; mm = millimetres; P = purl; patt = pattern; P550 = pass slipped st over; rep = repeat; skpo = slip 1, knit 1, pass slipped st over; 51 = slip; st st = stocking stitch (K 1 row, P 1 row); 5t(5) = stitch(es}; tog = together; yf = yarn forward; yfon = yarn forward and over needle.
LEFT FRONT
** Using 31/4 mm needles cast on 71 [77 : 81 : 87 : 93 : 99 :
105 : 111] sts.
15t rib row (Right side): K2, P1, * K1, P1, rep from * to last 2 sts, K2.
2nd rib row: K1, * P1, K1, rep from * to end.
Rep these 2 rows for 2.5 [2.5 : 2.5: 4 : 4: 4 : 4 : 4] cm, ending with a 2nd rib row.
Change to 4 mm needles. Proceeding in st st, work 4 rows, so ending with a Prow. **
time(s) more. - 68 [74 : 75 : 78 : 87 : 96 : 103 : 108] sts. Next row: K to last 5 sts, K2tog, K3.
Next row: P.
Rep last 2 rows until 50 [55 : 57 : 63 : 66 : 69 : 73 : 77] sts remain, so ending with a Prow.
Shape Raglan
Next row: Cast off 3 [4 : 4 : 4 : 5 : 6 : 6 : 6] sts, K to last 5 sts, K2tog, K3.
Next row: P.
Next row: K3, skpo, K to last 5 sts, K2tog, K3.
Next row: P.
Rep last 2 rows until 8sts remain, so ending with a Prow. Next row: K3, 51 1, K2tog, psso, K2.
Next row: P6.
Next row: K3, 51 1, K2tog, psso. Next row: P4.
Next row: K1, s11, K2tog, psso. Next row: P2.
K2tog and fasten off.
RIGHT FRONT
Work as for Left Front from ** to **.
Shape Front Edge
Next row: K3, skpo, K to end. Work 1 [3 : 3 : 3 : 3 : 3 : 3 : 1] row(s) straight.
Rep last 2 [4: 4: 4: 4: 4: 4: 2] rows 2 [2 : 5 : 8 : 5 : 2 : 1 : 2] time(s) more. - 68 [74: 75 : 78 : 87 : 96 : 1 03 : 108] sts. Next row: K3, skpo, K to end.
Next row: P.
Rep last 2 rows until 50 [55 : 57: 63: 66 : 69 : 73 : 77] sts remain, so ending with a Prow. Next row: K3, skpo, K to end.
Shape Raglan
Next row: Cast off 3 [4: 4: 4: 5: 6 : 6 : 6] sts, P to end.
Next row: K3, skpo, K to last 5 sts, K2tog, K3.
Next row: P.
Rep last 2 rows until 8 sts remain, so ending with a Prow. Next row: K2, K3tog, K3. Next row: P6.
Next row: K3tog, K3. Next row: P4.
Next row: K3tog, K1. Next row: P2.
K2tog and fasten off.
BACK
Using31f4 mm needles cast on 79 [85 : 89 : 95 : 101 : 107 : 113 : 119] sts.
Beg with a 1 st rib row, work in rib for 2.5 [2.5 : 2.5 : 4: 4: 4: 4 : 4] cm, ending with a 2nd rib row.
Change to 4 mm needles. Proceed in st st until back is same length as fronts up to beg of raglan shaping, ending with a Prow.
Shape Raglan
Cast off 3 [4: 4 : 4: 5 : 6 : 6 : 6] sts at beg of next 2 rows.
Next row: K3, skpo, K to last 5 sts, K2tog, K3.
Next row: P.
Rep last 2 rows until 29 [29 : 31 :31 :33:35:37:39]sts remain, ending with a Prow. Cast off.
LONG SLEEVES
Using 3% mm needles cast on 33[35:39:43:45:47:49: 51] sts.
Beg with a 1 st rib row, work in rib for 4 [4 : 4 : 6 : 6 : 6 : 6 : 6] cm, ending with a 2nd rib row. Change to 4 mm needles.
Proceed in st st but inc 1 st at each end of 5th and every following 4th row to 45 [47 : 43: 47: 51 : 55 : 61 : 65] sts, then at each end of every following 6th row until there are 59 [65 : 69 : 75 : 79 : 83 : 87: 91] sts.
Work straight until sleeve measures 30 [34: 38 : 41 : 42 : 43: 44 : 45] cm from cast-on edge, ending with a Prow.
Shape Raglan
*** Cast off 3 [4: 4 : 4 : 5 : 6 :
6 : 6] sts at beg of next 2 rows. Next row: K3, skpo, K to last 5 sts, K2tog, K3.
Next row: P.
Rep last 2 rows until 9 [9: 11 : 11 : 11 : 11 : 11 : 11] sts remain, so ending with a P row. Cast off. ***
SHORT SLEEVES
Using 3114 mm needles cast on 51 [55:57:63:65:69:71: 75] sts.
Beg with a 1 st rib row, work in rib for 2.5 cm, ending with a 1st rib row.
Change to 4 mm needles. Proceed in st st but inc 1 st at each end of 5th and every following 4th row until there are 59 [65 : 69 : 75 : 79 : 83 : 87 : 91] sts.
Work straight until sleeve measures 7.5 [7.5: 9: 9: 10: 10: 11.5: 11.5] cm from east-on edge, ending with a Prow.
Shape Raglan
Work as for Long Sleeves from *** to ***.
THE BORDER Join raglan seams.
Left Front and Back Neck Border
With right side facing, join on yarn at centre back neck and using a 3114 mm needle, pick up and K 105 [115 : 125: 137 : 141 : 145: 153 : 157] sts evenly across back neck and down left front to cast-on edge. Beg with a 2nd rib row, rib 5
[5 : 5 : 7 : 7 : 7 : 7 : 7] rows.
Cast off loosely in rib.
Right Front and Back Neck Border
With right side facing, join on yarn at east-on edge of right front and using a 3% mm needle, pick up and K 105 [115 : 125 : 137 : 141 : 145 : 153 : 157] sts evenly up front and round to centre back neck.
Now complete as for Left Front and Back Neck Border.
TIES (Make 2)
Using 3% mm needles cast on 9 sts.
Work in rib as for Left Front until tie measures 60 [60: 70 : 70: 80 : 80 : 90 : 90] cm long. Cast off in rib.
LACE EDGING (Optional)
Lap right front over left front and place a marker on the edge of the left front border approximately 5 cm under the overlap.
15th row: SI 1, K 1, K2tog, yf, K2, K2tog, (yf, K2tog) twice, K1. - 12 sts.
16th row: Yfon, K2tog, K 10. These 16 rows form the patt. Rep them until straight edge fits from east-on edge of right front, up right front, round back neck and down left front to marker, ending with a 16th row.
Cast off.
TO MAKEUP
See ball band for pressing and washing instructions.
Join right side seam leaving approximately 2.5 cm open at top of rib, then join sleeve seam. Join left side and sleeve seam. Join border at centre back neck.
Sew a tie onto each front edge at top of rib.
Thread tie on left front through opening on right front side seam to tie round waist. Sew Lace Edging to cast-off edge of border, then turn to right side and slipstitch cast-on and cast-off edges in position.
This pattern is protected by copyright, reproduction in any form, including photostat, is strictly forbidden. Any infringement wdllead to prosecution.
We shall be pleased to deal With any query providinq a ball band of the varn specified and a stamped self-addressed envelope accompanies your correspondence.
JAROL LTD.
WHITE ROSE MILLS, CAPE STREET, CANAL ROAD, BRADFORD BDl 4RN.
Page 4 (E8061
Designed and produced by DUD Dssiqn. Printed by Coltcc Parker, Keighley.