Professional Documents
Culture Documents
Sr. RF-Optimization in 3G network at Ericsson Telecom India Pvt.Ltd at Ericsson Telecom India Pvt.Ltd
Past
y y y
Sr. RF-ENGINEER in 2G & 3G Network at ZTE TELECOM INDIA PVT.LTD Sr. RF- Planning & Optimization at HUAWEI TELECOMMUNICATION INDIA PVT.LTD. RF- ENGINEER at ADACELL WORKS LTD.
Education
y
(Telecommunications industry) July 2010 Present (6 months) Monitoring daily BO reports and RNC KPI reports. Traffic Analysis InterferenceAnalysis,CapacityAnalysis,AntennaConfiguration. Monitoring performance of cell site and take corrective measures for improving the network performance. HSPDA , 3G drive , Analysis of drive test data, identify weak coverage/quality areas, call related issues (CS/PS setup time, Pilot pollution , interference Ec/Io , missing neighbor , call drops, RAB establishment issues, less throughput), rectification of the same. Handling optimization of new sites and handled problems like RAB Speech drop, interference, IRAT handover failure, handover reversion, in-building problem, antenna tilting, competitive Drive Test. Optimizing RF Related Parameters such as Neighbor list, DN, IRAT Relation(3G to 3G, 3G to 2G and 2G to 3G), Antenna E Tilt , SC(Scrambling Code) and change other parameter values such as RSCP and Ec/No. By adding and deleting Neighbors for reduce Pilot Pollution, interference, addition of missing Neighbors & SC changes in order to enhance main routes performance. Responsible for call drop reduction, RRC connection & RAB established success rate, IRAT handover and soft handover improvement for CS ,video, R99 and HS data. Network tuning for good RSCP, Ec/No and less pilot pollution. UTRAN cell parameter, PS and HSDPA parameter definitions for Node-B and RNC parameter definitions. Performance engineering (Analyzing traffic data for drops, congestion, accessibility, traffic growth etc.) based on the KPIs on daily basis. Analyzing in 3G(WCDMA) Interference, Call Drops, Handoff failures, IRAT Handover failures, Common Pilot Channel Received Signal Code Power , Common Pilot Channel Interference Ec/No, Scrambling Code and defining Neighbors(3G AND 2G BOTH), Check relation b/w 3G and 2G etc. Responsible for Call Test(Voice and Video), Data(HSDPA) Test and Submitting the coverage plot report.
y
UTRAN Cell parameters, PS and HSDPA parameter definitions for Node-B and RNC parameter definitions. Cluster planning and drive route definitions for tuning Network tuning for good RSCP, Ec/No and less pilot pollution Tested and demonstrated HSDPA speed up to 3.4 Mbps Responsible for call drop reduction, RRC connection & RAB establishment success rate, IRAT handover and soft hander improvement for CS, Video, R99 and HS data. Parameter inconsistency check for Node-B and RNC. Ensure Frequency Planning, Neighbors Planning, Parameter Optimization of the Network. Handle All EDGE/GPRS Parameter for best data quality. Maintaining KPIs(CSSR/CDR/HOSR/TASR/PSR/SBR/TBR). Daily Analysis Network performance statistics (KPI) e.g. Handover Statistics, Drop Statistics, Neighboring list optimization, their reasons and take necessary action. Daily monitoring of OMCR reports to analyze the Radio network performance to verify the Radio utilization, blocking (TCH/SDCCH), assign failures etc. & take corrective steps to achieve the optimum KPI. To find the causes of the call drops, blocked calls, handover failures, excessive handovers, poor quality, poor C/I, interferences etc. Coordinate with Drive test teams to suggest changes in Antenna orientations, Antenna height, tilts etc. New site planning in Existing sites depending on Drive test results, Customer Complaints and capacity. Monitor the data KPI and work on the worst cells affected. Nominal Planning, Lac planning, BSIC Planning, HSN Planning through mapinfo. New site planning in Existing sites depending on Drive test results, Customer Complaints and capacity. Network optimization based on traffic analysis. Analysis EDGE/GPRS parameter.
y
Do the trouble shooting according to project requirement. Do the network detail planning such as frequency planning, neighbor planning. Network optimization based on traffic analysis. Monitor the KPI by daily wise and improve the KPI. Network optimization based on traffic analysis. Maintaining KPIs(CSSR/CDR/HOSR/TASR/PSR/SBR/TBR). Daily Analysis Network performance statistics (KPI) e.g. Handover Statistics, Drop Statistics, Neighboring list optimization, their reasons and take necessary action. Daily monitoring of OMCR reports to analyze the Radio network performance to verify the Radio utilization, blocking (TCH/SDCCH), assign failures etc. & take corrective steps to achieve the optimum KPI. Do the trouble shooting according to project requirement. Coordinate with Drive test teams to suggest changes in Antenna orientations, Antenna height, tilts etc. New site planning in Existing sites depending on Drive test results, Customer Complaints and capacity. To provide all RF details as Antenna Orientation, Height of the GSM antenna etc. Monitor the data KPI and work on the worst cells affected.
y
RF- ENGINEER
ADACELL WORKS LTD. (Telecommunications industry) July 2006 December 2007 (1 year 6 months) Daily performance monitoring and worst cells optimization. Optimization of network based on coverage and capacity requirement of customer for new and existing sites Post processing drive test data. Using TEMS and NEMO Outdoor Cluster network optimization by detailed analysis of call events (drop call, call setup success fail) parameters & neighbor list. Recommendation to change parameters. Maintaining KPIs ( BLOCKING /TRAFFIC CHANNEL/HOSR/CALL DROP,TASR). Monitoring KPIs ND111,Daily Report 153,154,232,196,208 ,etc. Analysis of Drive Test log files by using TEMS ANALYSER to resolve the problem. Analysis of Drive Test files for taking care of External and Internal Interference in the Network, which involves analysis of Rx quality, Rx Level etc, re-planning of RF parameters in problematic areas accordingly. Co-channel (C/I) and Adjacent channel (C/A) Interference analysis Suggest required physical changes and changes in parameter in OMC. Raised all the CRF related to BTS and BSC level parameter. To find the causes of the call drops blocked calls, handover failures, excessive handovers, poor quality, poor C/I, interferences etc. Analyzing interface, call drops, Hanover failures, Rx. level, Rx. quality etc.
Responsible for drive test ( before swap, after swap, short call, long call & moc) etc. Responsible for Antenna Azimuth, Height, Tilt planning & cable routing.
Additional Information
Ramji Guptas Groups:
y y y y y y y y y y y y y
Telecom Professionals Radio Planning and Optimization Engineer Telecoms Operators in APAC GTL - Global Group Enterprise Radio Network Planning and Optimization Telecom Tigers - Innovative Networking for Telecom Professionals RF wireless jobs AIRCOM International Alumni Group of ZTE and Huawei 3G-LTE RF Optimisation Engineers RF Engineers Jobs@Ranop Project Managers Telecoms NetworkersMSB Telecoms (RF, Transmission, PS/CS Core, BTS, BSC, RNC, RAN) Radio Network Optimization - Africa Telecom professional (RF,CS,PS,NSS,BSS,NSS,OSS)
y y
y y
career opportunities consulting offers new ventures job inquiries expertise requests business deals reference requests getting back in touch