Professional Documents
Culture Documents
A: To set up Call Termination on the MP-1xx FXO, use the following 5 methods supported by the MP-1xx FXO: 1 2 3 4 5 Detection of polarity reversal / current disconnect (Go to) Detection of Reorder / Busy tones (Go to) Detection of silence (Go to) Interruption of RTP stream (Go to) Protocol-based termination of the call from the IP side (Go to)
Note: Note that the disconnection methods used by the MP-1xx must be supported by the CO or PBX.
Detection of Silence
The call is disconnected after silence is detected on both call directions for a specific (configurable) amount of time. The call isnt disconnected immediately; therefore, this method should only be used as a backup. Relevant ini file parameters: EnableSilenceDisconnect and FarEndDisconnectPeriod (with DSP templates number 2 or 3).