Professional Documents
Culture Documents
Tools
This procedure requires the following tools: Phillips #2
Part Location
Preliminary Steps
Before you begin, do the following: Place the computer face down on an ESD mat Remove the user access door Remove the feet Remove the rear housing Discharge the CRT Remove the Faraday plate
Bluetooth
Procedure
1. Remove the two screws on the Bluetooth board.
2. With two ngers, gently wiggle the Bluetooth board off the connector on the logic board.
Bluetooth
3. Turn the Bluetooth board over and carefully disconnect the Bluetooth antenna cable from the board.
4. To remove the Bluetooth antenna cable, pull the cable through the hole in the chassis.
Bluetooth
5. WIth the nylon tool (922-5065), pry the antenna xture off the front bezel. The antenna is attached to the front bezel with double-stick tape.
Bluetooth