You are on page 1of 7

Minolta CF2001 X3e Fiery Controller Win-2K Network Printer Instructions

Go To Start, Settings, Printers.

Select Add Printer

At the Welcome to the Add Printer Wizard Select Next

At Local or Network Printer Select Local

At Select the Printer Port Select Create a new Port In Type Select Standard TCP/IP Port

At Add a Standard TCP/IP Printer Port Wizard Select Next

At Printer Name or IP Address: Enter the IP Address of the Printer At Port Name Enter a Name for the port Select Next

At Additional Port Information Required Select Custom and Settings

At Protocol Select LPR At LPR Settings Queue Name: = Print Select LPR Byte Counting Enabled Select OK

At Additional Port Information Required Select Next...

At Completing the Add Standard TCP/IP Printer Port Wizard Select Finish

At Add Printer Wizard Select Have Disk

At Install from Disk Select Browse

At Locate File Browse to the location that you downloaded the file to

NOTE: Depending on the device you are installing, you may see different Drivers then the ones listed here. Select your driver from the List

NOTE: the eu following the driver name refers to European installations Select Your Device from the List

At Printer Name Select a Recognizable Name for your device

At Printer Sharing Select Do not share this printer

At Print Test Page Select Yes

NOTE: This screen may have different values depending on the driver you installed At Completing the Add Printer Wizard Select Finish

Note: You may not see this Screen At Digital Signature Not Found Select Yes

Select OK when the test page has completed

Any further instruction on the installation of this driver please refer to your Fiery User Guide

You might also like