You are on page 1of 1

12

P OFF ON

29
OFF RUN

17
OFF ON

4
HI LO

25
OFF ON

40
L LN N PUSH RN R

32

Note 10 Note 7 L N R

32

Note 5

66

65

22

36

35

27

Note 4

Note 1

Note 3

28

45
PUSH FREE

Note 3

Note 5 Note 7 Note 5 Note 3

Wiring Diagram Component Key


6 7 8

38 9 10 51
Note 4 Note 6

52
Note 6

60
Note 6 Note 7

58

Note 6

64 62 55(56)

46
Note 5

57

Note 4

Note 4

NOTES
1 = NOT MODELS G, H, LH & RJ 2= NOT MODEL RJ Note 6

53 61

3 = SINGLE CONNECTORS ON MODELS RJ & J 4 = SINGLE CONNECTION ON Note 7 Note 5 MODELS G, H & LH 5 = MODELS J & RJ ONLY 6 = MODEL J ONLY 7 = MODELS G, H & LH ONLY 8 = MODEL RJ ONLY Note 5 9 = MODELS G, H, LH & J ONLY 10 = Add-on or Modifications

H. 12242

Note 8 Note 8

13

13

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Battery Starter Motor Starter Solenoid Starter Switch Starter Circuit Cut-off Relay Fuse Box Fuse -- Main Fuse -- Headlight Fuse -- Signal Fuse -- Ignition Fuse -- In line Main Switch Ignition Coil TCI Unit Pickup Coil Spart Plugs Engin Kill Switch Alternator Rectifier/Regulator Light Switch Headlamp Headlamp Relay Auxiliary Lamp Auxiliary Lamp Switch Dip Switch Passing Switch Tail/Stop Lamp Licence Plate Lamp Front Stop Lamp Switch Rear Stop Lamp Switch Indicator Relay Indicator Switch Cancelling Unit

34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Front Indicators Rear Indicators Diode Block Diode Clutch Switch Horn(s) Horn Switch Neutral Switch Fuel Level sender Brake Fluid Switch Oil Level Switch Side-Stand Switch Side-Stand Relay Check Switch Warning Control Switch Parking Lamp Computerized Monirot Tachometer Lamp Tachometer Speedometer Lamp Indicator Indicator Warning Lamp RH Indicator Warning Lamp LH Indicator Warning Lamp Neutral Indicator Lamp Warning Control Indicator Lamp High Beam Warning Lamp Distance Sensor Oil Level Warning Lamp Battery Condition Sensor Fram Main Earth (Ground) LM7805 Voltage Regulator (mod) 5volt USB plug for GPS (mod)

21 39 34
Note 9

Note 8

18 44 19 31 30 41 15 14 16 16

33

Wiring Diagram -- XJ 650 G, H, LH, J and RJ Models

You might also like