You are on page 1of 16

Pin/bolt design fy fup gM0 gM2 gM6,ser fb,Ed,ser fv,Ed MEd d d0 t A Wet,i a sh,Ed fh,Rd sh,Ed fv,Ed fv,Rd

fb,Ed fb,Rd MEd MRd (MEd/MRd)^2+(Fv,Ed/Fv,Rd)^2 (MEd/MRd)^2+(Fv,Ed/Fv,Rd)^2 fv,Ed*gM0/(2*t*fy)+2*d0/3 fv,Ed*gM0/(2*t*fy)+2*d0/3

= = = = = = = = = = = = = = = = = = = = = a 1 MRd fb,Rd fv,Rd

355 Mpa 460 MPa 1.15 1.3 1 150 kN 195 kN 19.5 150 154 15 5104 4.84E+05 150 fh,Rd 785 361 kNm mm mm mm mm^2 mm^3 mm

the lower of the design strengths of the pin and the connected part; the ultimate tensile strength of the pin;

is the design value of the force to be transferred in bearing, under the the design shear force per bolt for the ultimate limit state; the design moment per bolt for the ultimate limit state; the diameter of the pin; is the diameter of the pin hole; the thickness of the connected part; the cross-sectional area of a pin. the elastic section modulus of member i (i = 0, 1, 2 or 3); Distance between hole and BG edge the design value of the Hertz pressure use gM6,ser = Norsok gM,ser * gM2 / gM0 = 1.0 * 1.3 / 1.15

the design shear resistance per bolt; 1084 kN the design bearing resistance per bolt 1042 Bending resistance of the pin 224

0.04

Combined shear and bending resistance of the pin

124

Geometrical requirements for pin ended members

engths of the pin and the connected part;

orce to be transferred in bearing, under the characteristic load combination for serviceability limit states.

bolt for the ultimate limit state;

lt for the ultimate limit state;

s of member i (i = 0, 1, 2 or 3);

ser * gM2 / gM0 = 1.0 * 1.3 / 1.15

ing resistance of the pin

for pin ended members

You might also like