Professional Documents
Culture Documents
KNUCKLE LINE
Fault category
Streaking
Alternative terms
Description
When light falls on the part from a certain angle, a line or shimmer can clearly be seen on its surface, frequently at weld lines, ribs, abrupt changes in section thickness or splits
Possible Causes 1. Elastic deformation of sliding cores 2. Glass fibres perpendicular to flow direction at weld lines 3. Abrupt changes in stiffness at ribs or where section thickness changes
Remedial Actions Improve slide supports or increase mould rigidity Alter position of weld lines, if necessary by changing location or number of gates Avoid abrupt changes in wall thickness in favour of gradual transitions