Brave of Contents
Table of Contents 1
Quick Start 4
Appearance...
PC Configuration Requirements.
Installation...
Managing your router...
Ending your Intemet session
Restoring the Factory Defaults
Using the Management Page 6
‘Management Page Overview
Viewing Configuration info
Configuring Your Computer 8
Wireless Configuration ..
Configuring the PC Network...
Advanced Settings 10
‘Overview .. :
System Management ‘
Broadband SIM Settings... mat
Configuring te Moe for ‘Searching Network
bobeeoe
am
Duce Settings
WLAN Settings...
Security Settings (Optional 7
Firewall Switch
LAN MAC Filter...
LAN IP Filter
Virtual Server...
DMZ Settings...
UPnP Settings.
Remote Management ..
Troubleshooting 21
Safety Information 22
Abbreviations 25Helou ick Start
EE
Signal + Steady on and in green: Slat strength
+ Steady on and in yellow: Signal strength
{is good
+ Steady on and in red: Signal strength is
tow
+ Fast blinking in ed: The broadband SIM
‘card does not exst or the PIN code is not
verified
Mode + Double blinking in green: Searching for
the network
+ Steady on and in blue: HSPA data
service connected
8933 WiFi Series Router
re Statu
uration Requirements
ane ed ea ee The recommended PC configurations for using the
a ee z router are as follows:
WLAN + Steady on and in green: The WLAN is Bane! 1: sie mia
+ Memory: 128 MB RAM or above
‘+ Hard disk: 100 MB or above available space
+ Operating System: Windows 2000, Windows XP, or
Windows Vista, MAC OS
+ LCD resolution: 800°600 pixel or above, recommended
1024*768 pixel
* Interface: standard USB interface
+ Blinking: Data is being transmittedInstallation
* Internet Browser: Internet Explorer 6.0 oF above,
Firefox 1.5 or above, Netscape 8.0 or above
installation
*@ Step 1: Insert the Broadband SIM card
Before inserting or removing the broadband
SIM card, you must disconnect the router from
fning the power adapter.
Insert the broadband SIM card into the slot
completely, by pushing the broadband SIM card
gently until if clicks into place, as shown in the
following figure.
‘To remove the broadband SIM card, push it
‘gently then pull out the card,
a
& Step 2: Connect to the power adapter
Use a power adapter that is compatible with the
‘outer; otherwise, the router may be damaged.
‘Mako sure the power indicator is steady on and
in yellow. ress and hold the power
button,
‘® Step 3: Connect toa PC
pption 1: Via Ethernet cable-connect one of the cable
{0 the ethemet port of the router and the other end to
the LAN port of your PC.