You are on page 1of 2

Technical QUIZ

1. The supply terminals for a dc shunt motor are reserved. What


will be the effect on motor?
a. it will run as a dc generator
b. it will run in reverse direction
c. it will stop
d. it will burn
2. Which single phase motor has relatively high power factor?
a. universal motor b. split phase motor
c. repulsion motor d. synchonous motor
3. Isolators are used to disconnect a circuit when
a.line is on full load
b.line is energized
c.circuit breaker is not open
d.there is no current in the line
4.A device that does not exhibit negative resistance
characteristics is
a.FET b.UJT
c.tunnel diode c.SCR
5.To save the energy during braking
a.dynamic braking is used
b.plugging is used
c.regenerative braking is used
d.mechanical braking is used
6.Most commonly used AC motor is
a.slip ring induction motor
b.synchronous motor
c.squirrel cage induction motor
d.ac commutator induction motor
7. According to Indian electricity rules, extra high voltage implies
voltage exceeding
a.440V b.66kV
c.33kV d.110kV
8.In order to make SCR OFF it is necessary to make
a.anode voltage<breakdown voltage
b.gate current zero
c.anode current<holding current
d.gate current=latch current
9. The effect of adding poles and zeros can be determined by
A. Nicholar chart B. Nyquist plot
C. Bode plot D. Root locus

10. Feedback control systems are


A. low pass filter B. high pass filter
C. band pass filter D. none of the above

11. Selysn is trade name of


A. Stepper motor B. Rotating transformer
C. Resolver D. Synchro

12. Hydraulic torque transmission is analog of


A. RC parallel circuit B. Amplidyne test
C. Motor generator set D. none

13. Op-amp in an electronic ohmmeter is used for


A. Differentiator B. Integrator
C. Buffer amplifierD. none

14. Triangular waveform is obtained by


A. Integrating a sine wave B.Integrating a square wave
C. Differentiating a sine wave D. Differentiating a square wave

15. An oscilloscope indicates


A. DC value of a voltage B. RMS value of an ac voltage
C. Average value of an ac voltage D. Peak to peak value of an ac
voltage

16. Power required by an LCD


A. 20 mw B. 20 micro W
C. 20W D. none

You might also like