You are on page 1of 2

XPose !

Distanzsensor Justieren

256065792.doc

Adjustment of Distance Sensor


Before the distance sensor is into operation, a focus test with the zero point switch
(73 = 0 / Focus distance sensor 0= OFF/ 1=ON) must be created and a plate be exposed.
All Settings must be correctly adjusted:
In the Plates input the current thickness of the plate, for 0.3mm plates = 0,28mm.
The focus value must be correctly entered in the SupportTool
e.g. 1.16mm Reference Position with reference switch
The value is again necessary if with the reference switch a problem appears.

adjust distance
sensor Baumer up or
down

zero point
switch

XPose !

Distanzsensor Justieren

256065792.doc

Important : The Xpose must be always switched on with the whole procedure!!
Note: First a job must be exposed (that the optics is in focus):
then the distance sensor must be switched on,
wf 73
1
#Focus Distance Sensor
[1=OFF / 0 = ON]
Switch on the vacuum to hold a plate (CTRL + 1)

Move the optics over the Plate


TE 608: On the keyboard press the Hand button and select Fokus.
TE 613: On the keyboard press the Setup button and select Fokus.

Distanz to the plate e.g.. =


0.789 mm

The sensor must be fixed now on the correct height until the value of approx. 750 (0.75mm) is
displayed. The value 750 is the average value between 0.4... 1,1 mm
wf 79

0.74

#Reference position with distance sensor

After fixing the sensor e.g. 0,74, this value must be transferred to the SupportTool. The value should
between 0.65 - 0.85mm.
Now the reference value (wf79) must be tested. A focus test must be created, in steps off 0.02mm.
Beginnings with 0,10 mm below like reference position.
Important !!
The value should be between 0.65-0.85mm, it would be possible 0.40-1.10mm, you loses at the
measuring range if the value is at the end of the measuring range (0,4 or 1.1mm).The sensor notices
that its at of the end of the area, it displays for both ends 255 (0.255mm), even if he is too hight !!
Attention:

If wf 73 = 0, then the reference position in wf 89 = e.g. 1.16 for zero point switches
If wf 73 = 1, then the reference position in wf 79 = e.g. 0.74 for distance sensor
wf 83
150
#Adjust position[mm]
Position measured from the front, where the focus in the automatic mode is adjusted (only with
distance Sensor).

You might also like