Page 1 of 1
Accessories}
Chart
General Booms & | Truck
Data
Information Hibs Specs
National
Series
300B
Load oad Radius | Winch
Ratings
Crane
Maximum Capacity: 16,000 Pounds (7.3
Metric Tons) ;
‘Maximum Vertical Reach: 61 Feet (18.6
Meters)
Product brochure in printable format: ito download right click and choose "Save File As.” or "Save Link As.”).
a = 300B pdf
hittp://www.nationalerane.com/products.nsf/0/561b751f2c2296e786256b9900470ab170p... 11/18/2004Load
General Booms & | Truck
Ratings
Information Jibs Spees
National Series 300B Telescoping Crane
Load Radius | Winch
Chart Data
3288: 12% fL-28 It. three section
—
3878: 1516 ft.-37 tt three section
—
3378; 1515 11-37 ft tree section
3468: 18% f1.-46 {1 three section
———
Page 1 of 1
Accessories|
Product brochure in printable format: to download right click and choose "Save File As.." or "Save Link As."
(8) «soos sar
hittp://www.nationalerane.com/products.nsf/0/561b75 1f2c2a96e786256b9900470ab1 ?0p...
11/18/2004Page 1 of 3
General Booms & | Truck | Load | LoadRadius | Winch ;
Information | | Spees | Ratings Chart Data |; Asvessorics|
National Series 300B Telescoping Crane
[Mounting Configurations
[The versatility of the Series Coen Configuration 2
1300B can be enhanced by ‘onfiguration with Heavy Duty Subbase
the mounting with Subspacer
configurations described at
ithe right. The configurations
lare based on a Series 300B
lwith an 85% stability
actor. The complete unit
Imust be installed in
laccordance with factory
lrequirements and a test
lperformed to determine
[in most cases, ifthe turck is
[purchased to minimum
lspecifications, this
configuration allows 360-degree
stability without counterweight
lor rear stabilizers. Since the
Ifront tires are used as a
stabilizing base, lifting over the
litont is recommended only for
[The advantages of a rear-
imounted eries 300B are: (1)
lit allows the operator to
leffectively use the close-in
lworking area to lift heavier
loads, and (2) 360-degree
stability at full-rated load.
[Counterweight may be
equired on a minimum truck.|
{50,000 PST
factual stability and_ loccasional use. If loads are tobe _|With this configuration, a
{counterweight requirements ||ontinually lifted around the Ipayload of approximately
fance sndivadual truck, liront of the vehicle, front 17,000 pounds (3,175 kg) can
chassis vary. |sabilizers are recommended to. _ [be hauled on a minimum
lgive the unit a firm base. With ltruck. Rear mounts require
Iihis configuration, a payload of either "behind the cab"
lapproximately 9,000 pounds stabilizers (ASHBC) or
(4,028 kg) can be hauled on a lcross-frame outriggers and
Iminimum truck. Most trucks Ineavy-duty subbase.
Iwill be equipped with an 18,500 —_||Underframe stabilizers
pound GAWR rear axle and will |fbehind the cab may interfere
hhaul a payload of approximately _|jwith the drive line or cause
{3,000 pounds. leround clearance problems. I
so, contact the factory for
lalternatives.
[Stable 360 degrees 360 degrees
[Gross Axle Weight Rating 9,000 Ibs. Contact factory
|(GAWR), front
[Gross Axle Weight Rating 17,500 Ibs. 17,500 Ibs.
|(GAWR), rear
[Wheelbase (WB) 184 inches on Models 328B, 202 inches
337B
202 inches on Model 346B
[Cab to axle/trunnion 120 inches on Models 328B, 138 inches
(CA/CT) 337B
138 inches on Model 346B
[Frame Section Modulus
(SM) under crane: 15.0 cu. inch 13 cu. inch
http://www.nationalcrane.com/products.nsf/0/561b751f2c2a96e786256b9900470ab1 20p..
11/18/2004Page 2 of 3
lor
110,000 PST 10 cu. inch 10 cu. inch
[Frame Section Modulus
is) ilizers: 10 cu. inch 13 cu. inch
[50,000 PSI
r
110,000 PST
[Stability Weight, Front** 4,800 Ibs. minimum 4,800 Ibs. minimum
\(See note 6) 5,600 Ibs. maximum
[Stability Weight, Rear** 4,600 Ibs. 5,500 Ibs.
stimated Average Final 19,500 Ibs. 22,500 Ibs.
Weight
|(No options included)
NOTES:
((1) GAWR means Gross
lAxle Weight Rating and is
(dependent on all
‘components of the vehicle
lsuch as axles, tires, springs, ggaseue —anocus
iframe, etc. meeting =
manufacturer's ~
recommendations. Always
specify GAWR when
[purchasing trucks.
(2) Minimum axle | ee
Irequirements may increase one ate
Iwith use of longer
wheelbase, service bodies,
diesel engines or front
stabilizers.
(3) Tandem axle trucks must}
Ibe used for hauling larger
[payloads.
(4) Diesel engines require
|variable speed governor and
lenergize-to-run fuel
solenoid for smooth crane
peration.
\(5) On trucks shorter than
120 CA, additional weight
lmay be required at the rear
jaxle for 360-degree *May use shorter CA with all boom lengths, depending upon
stability. bed length
|(6) On trucks with front axle] +*—stimated axle scale weights prior to installation of crane,
weight of 5,200 Ibs. or stabilizers and subbase if required for 85% stability.
lereater, a 9,000-Ib. GAWR
10 cu. inch 10 cu, inch
http:/www.nationalerane.com/products.nsf/0/561b75 1{2c2a96e786256b9900470ab1 2p... 11/18/2004Page 3 of 3
| Front) will not be adequate
lif front-mounted stabilizers
lare used for continuous
lifting over the front axle.
Product brochure in printable format: to download right click and choose "Save File As." or "Save Link As..").
fh ~300B.pdf
‘http://www.nationalcrane.com/products.nsf/0/561b7511£2c2a96e786256b9900470ab1 ?0p... 11/18/2004Page | of 1
General Booms & | Truck | Load | LoadRadius | Winch | 4 ceccories
Information Jibs Specs Ratings Chart Data
National Series 300B Telescoping Crane
Series 337B with 15-ft jib
LOAD ||LOADED] 16FT |[LOADED]| 26FT |[LOADED] 37Fr || [LOADED], 15FT
rapius | Boom || Boom || Boom || Boom || Boom || noom | | Boom | mB
@EED) || ANGLE || ps) [Lance |_@ss) |Lancue ||_@xs) || || anoue || op
4 7 16,00) a0" 3,000
6 702 10200]| 7 5950 70 1,900
5 @ 6200) 74 7.050]|_80° 00] _|_ 60" 1,400
a 6,600]|_ | 5850) 76 5300) _4s" 1,000
izes ears 5,700] 65" 5050]|_ 75° 4500) 30° 709
WL o00)[__59° 4350)[ 710" 2.009 cod
16 se 3,500]|_ 66" 3.400
8 a 3,500) 62 3.109
20 a 3.150] 60° 2,900
25 a 2,350)[ 50° 2,409
30 3 7,900
35 21° 1,500
Product brochure in printable format: o download right click and choose "Save File As.." or "Save Link As.)
fh = 300B.pdf
http://www nationalerane.com/products.nsf/0/561b751£2c2a96e786256b99004 70ab1 2p...
11/18/2004Page 1 of 1
General Booms & | Truck Load | Load Radius | Winch
Information Specs | Ratings Chart Data
National Series 300B Telescoping Crane
70
on '—-| SERIES 3978
i as'Fr wires 60
fr 18FT JIB
EB 50
= a7 5
eS u
g i
Ff ma)
ap es) =
= E
3 ao
a * icy
=
20
10
0
G1 10) 20) 60. 40 co. a0)
RADIUS IN FEET
Produet brochure in printable format: o download righ click and choose "Save File As." or "Save Link As.)
tH - 300B.pdf
hittp://www-nationalcrane.com/products.nsf/0/561b751f2c2a96e786256b9900470ab1?0p...__ 11/18/2004Page 1 of I
General Booms & | Truck Winch | 4 cessori
Information Jibs Spees Data seal
National Series 300B Telescoping Crane
‘National Series 3008 Winch Data 1 Past Line 2 Part Line 3 Part Line
Caution:
+ Do not deadhead lineblock against
boom tip when extending boom,
+ Keep atleast three wraps of|
Joad line on the drum at all imes,
+ Use only the specified cable on this
machine. ¥
“Average ;
Cable Lift and Lift and Lift and
winch || sirpica | Beating | "Specs Speed Speed
Standard
a nee | 29,200 tbs. |] 5,840 tbs. (2,650 kg) | 11,680 tbs. (5,300 kg) ] 17,520 tbs. (7,950 ke)
Standard || rotation resistant {13-250 Ka) || 184 fom (56 mimin) |] 92 fpm 28 m/min) || 61 fpm (19 m/min)
Planetary | Optional
Winch 1/2" diameter |} 23,000 Ibs. |) 5,840 Ibs. (2,650 kg) || 11,680 Ibs. (5,300 kg) | 17,520 Ibs. (7,950 kz)
6x19 or 6x25 | (10,436 ke) |] 184 fpm (56 m/min) |] 92 fpm 28 m/min) || 61 fpm (19 m/min)
IWRC
‘Standard
9/16" diameter
pina rotons
pul
Planetary || Optional
Winch |] 9/16" diameter |} 29,750 Ibs. | 8,400 Ibs. (3,811 ke) | 16,800 Ibs. (7,622 ke) |] 20,000 Tbs. (9,075 ke)
6X19 oF 625 |] (13,500 kg) || 100 fpm (31 m/min) || 50 pm (15 m/min) || 33 fpm (10 m/min)
IWRC
‘Above winch pulls and speeds are shown on the third layer. Winch pulls would increase on the first and second layers.
‘Winch line speeds would decrease on the first and second layers. Winch line pulls may be limited by the winch capacity
or the ANSI 5 to 1 or 35 to one safety factor. These are shown below.
37,000 Ibs. |} 7,400 Ibs. (3,357 kg) || 14,800 Ibs. (6,715 kg) |} 20,000 Ibs. (9,075 kg)
(16,788 kg) |] 100 fpm (31 m/min) |} 50 fpm (15 m/min) |} 33 fpm (10 m/min)
Standard Optional
Winch Winch Limited Cable Limited Cable Limited
Standard Planetary 6,835 Ibs. (3,101 kg) 5,840 Ibs. (2,650 kg) 5,840 Ibs. (2,650 ke)
Optional Planetary 10,200 Ibs. (4,628 kg) 7,400 lbs. (3,357 kg) 8,400 Ibs. (3,811 ke),
Product brochure in printable format:
ih = 300B.pdf
10 download right click and choose "Save File As." or "Save Link As.)
http://www-nationalerane.com/products.nsf/0/561b75 1£2c2a96e786256b9900470ab1 20p... 11/18/2004Page 1 of 1
Winch
Data
Load
Ratings
Load Radius
Chart
General Booms & | Truck
Information ibs Specs
National Series 300B Telescoping Crane
Accesoria|
Every Series 300B is part of the National Lifting System, a select choice of accessories that add
versatility to your crane, With National accessories you can tailor your crane to handle your specific
job requirements. In many instances, a truck-mounted crane equipped with accessories can
eliminate your need for other specialized equipment.
Because your Series 300B affords such versatility, you save time, money, and manpower. You can
do more, faster with less equipment. National accessories are, thus, cost-efficient options.
Click on the link in the navigation bar to the left to view the full line of National Crane accessories.
Sec how easy efficiency can be!
Note: Weights of all accessories attached to the boom or loadline of the crane must be deducted
from the effective lifting capacity. Consult your National dealer for specific accessory availability.
Some accessories cannot be used in combination with other accessories and/or certain boom/jib
combinations.
Product brochure in printable format: «0 download right click and choose "Save File As." or "Save Link As.
(8 oo
http://www .nationalcrane.com/products.nsf/0/561b7511f2c2a96e786256b9900470ab120p..._ 11/18/2004