For the following signals, the brake closing time is not taken into account: OFF2 command For fail-safe applications, in addition, after "Safe Torque Off" (STO) After these control commands, the signal to close the motor holding brake is immediately output independent of the motor speed. The inverter does not monitor the motor speed until the brake closes. 0RWRUVZLWFKHGRQ
21 2))672
0RWRUPDJQHWL]HG U 2SHUDWLRQ U
S
W 6SHHGVHWSRLQW
U W
2SHQEUDNH U W
S %UDNHRSHQHG 0
0 W
Figure 8-28
Controlling the motor holding brake after an OFF2 command or STO
Frequency converter with CU240B-2 and CU240E-2 Control Units
Operating Instructions, 04/2012, FW V4.5, A5E02299792B AC