Professional Documents
Culture Documents
UO
TYPICAL APPLICATI
Quiescent Supply Current vs Temperature
600
1 16 TEST CONDITION: VCC = 3.3V
VCC = 3.3V
0.1µF 3 2 500
QUIESCENT CURRENT (µA)
4 LTC1386 6 0.1µF
10 7
LOGIC INPUT 562 OUTPUT 100
12 13
LOGIC OUTPUT 562 INPUT
5k 0
–20 0 20 40 60 80
TEMPERATURE (°C)
9 8
LOGIC OUTPUT 562 INPUT LTC1386 • TA02
5k
15
LTC1386 • TA01
1
LTC1386
W W W U U W U
ABSOLUTE AXI U RATI GS PACKAGE/ORDER I FOR ATIO
Supply Voltage (VCC) ................................................ 5V
Input Voltage TOP VIEW
ORDER PART
Driver ....................................... – 0.3V to V CC + 0.3V NUMBER
C1+ 1 16 VCC
Receiver ............................................... – 25V to 25V V+ 2 15 GND
LTC1386CN
Digital Input ............................... – 0.3V to VCC + 0.3V C1– 3 14 TR1 OUT
LTC1386CS
Output Voltage C2+ 4 13 RX1 IN
2
LTC1386
AC CHARACTERISTICS VCC = 3.3V, C1 = C2 = C3 = C4 = 0.1µF, unless otherwise noted.
PARAMETER CONDITIONS MIN TYP MAX UNITS
Slew Rate RL = 3k, CL = 51pF 8 30 V/µs
RL = 3k, CL = 1000pF 3 5 V/µs
Driver Propagation Delay t HLD (Figure 1) ● 2 3.5 µs
(TTL to EIA/TIA562) t LHD (Figure 1) ● 2 3.5 µs
Receiver Propagation Delay t HLR (Figure 2) ● 0.3 0.8 µs
(EIA/TIA562 to TTL ) t LHR (Figure 2) ● 0.3 0.8 µs
The ● denotes specifications which apply over the operating temperature Note 2: Supply current is measured with driver and receiver outputs
range of 0°C ≤ TA ≤ 70°C. unloaded.
Note 1: Absolute maximum ratings are those values beyond which the life
of the device may be impaired.
U W
TYPICAL PERFORMANCE CHARACTERISTICS
Driver Output Voltage Receiver Input Thresholds
vs Temperature vs Temperature Supply Current vs Data Rate
5 2.2 20
VCC = 3.3V
4 OUTPUT HIGH
RL = 3k
VCC = 3.3V 2.0 CL = 2500pF
DRIVER OUTPUT VOLTAGE (V)
3
THRESHOLD VOLTAGE (V)
RL = 3k CL = 51pF
3.0 DRIVER
OUTPUT
2.5 RL = 3k
2.0 1 DRIVER LOADED
RL = 3k INPUT
1.5 INPUT
1.0
LTC1386 • TPC05 LTC1386 • TPC06
0.5
0
0 10 20 30 40 50 60 70
TEMPERATURE (°C)
LTC1386 • TPC04
3
LTC1386
U U U
PI FU CTIO S
VCC: 3.3V Input Supply Pin. This pin should be decoupled charge pump efficiency, the capacitor’s effective series
with a 0.1µF ceramic capacitor. resistance should be less than 2Ω.
GND: Ground Pin. TR IN: EIA/TIA562 Driver Input Pins. Inputs are TTL/
V +:Positive Supply Output (EIA/TIA562 Drivers). ≅ V+ CMOS compatible. The inputs of unused drivers can be left
2VCC – 1V. This pin requires an external capacitor C = unconnected since 300k input pull-up resistors to VCC are
0.1µF for charge storage. The capacitor may be tied to included on chip.
ground or VCC. With multiple devices, the V + and V – pins TR OUT: Driver Outputs at EIA/TIA562 Voltage Levels.
may share a common capacitor. For large numbers of The driver outputs are protected against ESD to ±10kV for
devices, increasing the size of the shared common storage human body model discharges.
capacitors is recommended to reduce ripple. RX IN: Receiver Inputs. These pins can be forced to ±25V
V –: Negative Supply Output (RS232 Drivers). V – ≅ – (2VCC without damage. The receiver inputs are protected against
– 1.3V). This pin requires an external capacitor C = 0.1µF ESD to ±10kV for human body model discharges. Each
for charge storage. receiver provides 0.4V of hysteresis for noise immunity.
C1+, C1–, C2+, C2–: Commutating Capacitor Inputs. These RX OUT: Receiver Outputs with TTL/CMOS Voltage
pins require two external capacitors C = 0.1µF: one from Levels.
C1+ to C1– and another from C2+ to C2 –. To maintain
U W W
SWITCHI G TI E WAVEFOR S
VCC VCC
DRIVER RX 1.7V
INPUT 1.4V 1.4V INPUT 1.3V
0V 0V
V+ VCC
DRIVER RX 2.4V
0V 0V
OUTPUT OUTPUT 0.8V
V– 0V
t LHD t HLD t LHR t HLR
LTC1386 • F01 LTC1386 • F02
Figure 1. Driver Propagation Delay Timing Figure 2. Receiver Propagation Delay Timing
4
LTC1386
TEST CIRCUITS
Driver Timing Test Load Receiver Timing Test Load
DRIVER RX
OUTPUT OUTPUT
DRIVER RX INPUT
DRIVER RX
INPUT
51pF 3k 51pF
LTC1386 • TA04
LTC1386 • TA03
1 16
LTC1386 VCC
0.1µF 3 2
4 6
0.1µF 5 VCC 0.1µF 0.1µF
300k
11 14
LOGIC INPUT 562 OUTPUT
VCC
300k
10 7 RS562
LOGIC INPUT 562 OUTPUT LINE PINS
12 13 PROTECTED
LOGIC OUTPUT 562 INPUT TO ±10kV
5k
9 8
LOGIC OUTPUT 562 INPUT
5k
15
1386 TA05
5
LTC1386
U
TYPICAL APPLICATIONS N
Paralleling Power Supply Generator
with Common Storage Capacitors
1 16 1 16
VCC = 3.3V VCC = 3.3V
0.1µF 3 2 0.1µF 3 2
9 8 9 8
LOGIC OUTPUT 562 INPUT LOGIC OUTPUT 562 INPUT
5k 5k
15 15
LTC1386 • TA06
6
LTC1386
U
PACKAGE DESCRIPTION Dimensions in inches (millimeters) unless otherwise noted.
N Package
16-Lead Plastic DIP
0.770
(19.558)
MAX
16 15 14 13 12 11 10 9
0.260 ± 0.010
(6.604 ± 0.254)
1 2 3 4 5 6 7 8
0.015
(0.381)
MIN 0.065
0.009 – 0.015 (1.651)
(0.229 – 0.381) TYP
+0.025
0.325 –0.015
( )
0.125 0.045 ± 0.015
+0.635 0.018 ± 0.003
8.255 (3.175) (1.143 ± 0.381)
–0.381 MIN (0.457 ± 0.076)
0.100 ± 0.010
(2.540 ± 0.254) N16 0492
S Package
16-Lead Plastic SOIC
0.386 – 0.394*
(9.804 – 10.008)
16 15 14 13 12 11 10 9
1 2 3 4 5 6 7 8
0.010 – 0.020
× 45° 0.053 – 0.069
(0.254 – 0.508)
(1.346 – 1.752)
0.008 – 0.010 0.004 – 0.010
(0.203 – 0.254) 0° – 8° TYP (0.101 – 0.254)
7
Information furnished by Linear Technology Corporation is believed to be accurate and reliable.
However, no responsibility is assumed for its use. Linear Technology Corporation makes no represen-
tation that the interconnection of its circuits as described herein will not infringe on existing patent rights.
LTC1386
U.S. Area Sales Offices
FRANCE KOREA
Linear Technology S.A.R.L. Linear Technology Korea Branch TAIWAN
Immeuble "Le Quartz" Namsong Building, #505 Linear Technology Corporation
58 Chemin de la Justice Itaewon-Dong 260-199 Rm. 801, No. 46, Sec. 2
92290 Chatenay Malabry Yongsan-Ku, Seoul Chung Shan N. Rd.
France Korea Taipei, Taiwan, R.O.C.
Phone: 33-1-41079555 Phone: 82-2-792-1617 Phone: 886-2-521-7575
FAX: 33-1-46314613 FAX: 82-2-792-1619 FAX: 886-2-562-2285
JAPAN
Linear Technology KK
5F YZ Bldg.
4-4-12 Iidabashi, Chiyoda-Ku
Tokyo, 102 Japan
Phone: 81-3-3237-7891
FAX: 81-3-3237-8010
World Headquarters