You are on page 1of 3

Phast and Phast Risk

Manual Installation Notes for Version 6.7


For all Product modes

DNV SOFTWARE
Palace House, 3 Cathedral Street, London SE19DE, UK
www.dnvsoftware.com

Copyright Det Norske Veritas. All Rights Reserved.


No reproduction or broadcast of this material is permitted without the express written consent of DNV.
Contact software.support@dnv.com for more information

Phast and Phast Risk v6.7 Manual Installation Notes

Phast and Phast Risk 6.7 Manual Installation Notes


Contents
Assumptions and Recommendations........................................................................................................3

Phast and Phast Risk v6.7 Manual Installation Notes

Phast Risk 6.7 Manual process

Assumptions and Recommendations


This document is in extract from the manual installation processes when the provided setup.exe cannot
be used or fails to run as expected.
Due to the large difference between Phast 6.7 and Phast Risk 6.7 installation procedures, specific
processes are provided.
It is assumed that:

Phast and Phast Risk 6.7 release DVD is accessed from the drive letter E:. If not please adjust
all stated paths. If you have downloaded the installation, please take account of your drive
letter and path when following these instructions.

The operating system has all its basic components installed. For example, the MSI version on
Windows XP is at least 3.0 or that Windows7 is at least 4.5.

The reader of this document is a software engineer or at least the person has good operating
system understanding who feels comfortable running low level operating system commands.
For example editing the registry whilst avoiding damage to the operating system, rebooting,
etc.

The user running the manual installation process must have full local administrator rights.

The relevant Phast Installation Notes and Phast Risk Installation Notes have been read and
understood, especially the section Requirements and Known issues.

Most steps have a condition, failure to check the condition may cause unwanted outcomes
such as removing a piece of software instead of installing it. Few have no condition, in this
case it is assumed that the Control Panels Add/Remove program is used to check whether the
software is installed or not.

DNV software Helpdesk (Software.Support@dnv.com) is contacted for the complete


document.

The installation processes described in the full document can be the foundation for automated
deployment in a corporate environment using technology like Active directory, SMS, SCCM or
similar technology where users have no administrator rights or Phast or Phast Risk are to be installed
on many machines.

You might also like