You are on page 1of 2

EL 2

EL 2 point to point PDH radio system, working in the 1.35 to 2.7 GHz band, has been designed as a low/medium capacity digital link, with tributaries rate from 2 to 34 Mb/s (or Nx2 Mb/s). All indoor installation.

EL 2

RT22G

TRANSCEIVER UNIT
Software programmability of major RF parameters (RF Frequency, TX power, Spectrum occupancy, RX threshold alarms, etc.) Excellent short and long term frequency stability Frequency agility (with tiny frequency steps) Excellent interference rejection Compact, lightweight design

POINT TO POINT

EasyLink Family

BASEBAND UNIT

ily EasyLink fam

rowave Advanced micgy technolo Full Softwarety ili programmab gain s High sy tem h a Integr ted hig nnas ante performance bility Excellent Relia nge Frequency ra GHz 38 fom 2 up to ommonality c le u d o m h Hig

The Baseband carries the main traffic plus auxiliary channels 2, 2x2, 4x2, 8x2, 16x2, 2x8, 34 Mbit/s baseband interfaces High spectral efficiency (4 QAM and 16 QAM modulation) Laptop and hand held terminal interfaces for setting radio link configuration, parameters, monitoring, alarms, etc. Full range of Management solutions for all kind/any dimension of Network Forward Error Correction (FEC) Hitless (Error Free) 1+1 switch EOW and data service interfaces 19" mechanical arrangement Configurable Relay contacts and user inputs Choice of traffic connectors type and impedance Front (or optionally rear) traffic connections Software programming of system parameters (RF Frequency, TX power, Spectrum occupancy, RX threshold, Transmission capacity, Alarm threshold, Alarm mapping, etc.) Software command and control (local and remote loopbacks, local and remote TX and RX switches)

siae microelettronica

s.p.a.

Website www.siaemic.it

Via M. Buonarroti, 21 20093 Cologno Monzese, Milano, Italy Phone +(39)0227325.1 Fax +(39)0225391585 e-mail siaemi@siaemic.it

All rights reserved SIAE Microelettronica

EasyLink Family
Excellent radio electrical performances Easy capacity/configuration upgrading Fast installation and commissioning Integrated G.821/G.826 Performance Monitoring, RX power data registration, Alarm history Low cost O&M (high reliability plus fast restoring of replaceable units) Full range of O&M SW Tools: Manual forcing of changeover switches, TX switch off, BB/IF loopbacks, selectable time duration of commands

TECHNICAL SPECIFICATIONS
Frequency range TX/RX spacing (Go return) Modulation Demodulation Adjacent channel separation Capacity (Mbit/s) Frequency channel spacing (MHz) Output power at point CI 16 QAM: 1 1.75 3.5 7 14 4 QAM: 31 dBm 16 QAM: 26.5 dBm Receiver sensitivity for BER 10-3 at point C (1+0 conf, RF filter losses included) Mbit/s 2 2x2 4x2 8x2/2x8 16x2/34 4 QAM: dBm -95.5 -92.5 -89.5 -86.5 -83.5 16 QAM: dBm -91.5 -88.5 -85.5 -82.5 -79.5 Frequency stability 5 ppm Frequency agility software programmable 250 KHz steps RF tuning range 23 MHz (28 MHz in 2.0 2.7 GHz band) RF channel identification 255 settable number link identification Spurious emissions according to ETSI standards Spurious response rejection according to ETSI standards Transmitter power attenuation software programmable, up to 20 dB Service channels EOW, V.11/V.28, RS 232C, G.703 64 Kbit/s Mechanical Dimensions 1+0 config. (W x H x D) 480 x 647 x 260 1+1 config. (W x H x D) 480 x 712 x 260 Environmental performance Temperature range -10C to +55C Supply voltage Nominal battery -24/-48/-60 VDC (positive, negative grounded or floating) Power consumption from 55 to 65 W (unprotected) from 110 to 120 W (protected) 1.35 to 1.55 GHz or 2.0 to 2.7 GHz 65.5 or 52 or 74 or 94 or 119 or 175 MHz (depending on frequency sub-bands) 4 QAM / 16 QAM coherent 2 1.75 2x2 3.5 4x2 7 8x2/2x8 16x2/34 14 28

4 QAM:

POINT TO POINT

www.italgraf.it

EL2E.001 Data subject to change without notice

EL 2
siae microelettronica s.p.a.
Via Michelangelo Buonarroti, 21 20093 Cologno Monzese, Milano, Italy Phone +(39)0227325.1 Fax +(39)0225391585 e-mail siaemi@siaemic.it Website www.siaemic.it
RT22G

PDH Digital Radio

EL 2

RT22G

You might also like