SM HSCU-300 E1 9968615010-00e PDF

HD CAMERA CONTROL UNIT
HSCU-300
MAINTENANCE MANUAL
1st Edition
Serial No. 10001 and Higher: HSCU-300 (UC)
Serial No. 30001 and Higher: HSCU-300 (J)
Serial No. 40001 and Higher: HSCU-300 (CE)
! WARNING
This manual is intended for qualified service personnel only.
To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that
contained in the operating instructions unless you are qualified to do so. Refer all servicing to
qualified service personnel.
! WARNUNG
Die Anleitung ist nur fr qualifiziertes Fachpersonal bestimmt.
Alle Wartungsarbeiten drfen nur von qualifiziertem Fachpersonal ausgefhrt werden. Um die
Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei
Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben
Wartungsarbeiten drfen nur von Personen ausgefhrt werden, die eine spezielle Befhigung
dazu besitzen.
! AVERTISSEMENT
Ce manual est destin uniquement aux personnes comptentes en charge de lentretien. Afin
de rduire les risques de dcharge lectrique, dincendie ou de blessure neffectuer que les
rparations indiques dans le mode demploi moins dtre qualifi pour en effectuer dautres.
Pour toute rparation faire appel une personne comptente uniquement.
: LAN
For safety, do not connect the connector for peripheral

device wiring that might have excessive voltage to the
following port(s).
: LAN connector
Follow the instructions for the ports(s).
HSCU-300
FRSIKTIGHET!
Fara fr explosion vid felaktigt placerat batteri.

Byt endast mot samma eller likvrdig typ av batteri,
enligt tillverkarens rekommendationer.
Nr du kasserar batteriet ska du flja rdande lagar
fr regionen eller landet.
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type recommended by the manufacturer.
When you dispose of the battery, you must obey the
law in the relative area or country.
PAS P
Fare for eksplosion, hvis batteriet ikke udskiftes
korrekt.
Udskift kun med et batteri af samme eller tilsvarende
type, som er anbefalet af fabrikanten.
Nr du bortskaffer batteriet, skal du flge
lovgivningen i det pgldende omrde eller land.
ATTENTION
Il y a danger dexplosion sil y a remplacement incorrect de la batterie. Remplacer uniquement avec
une batterie du mme type ou dun type quivalent
recommand par le constructeur.
Lorsque vous mettez la batterie au rebut, vous devez
respecter la lgislation en vigueur dans le pays ou la
rgion o vous vous trouvez.
HUOMIO
Rjhdysvaara, jos akku vaihdetaan virheellisesti.
Vaihda vain samanlaiseen tai vastaavantyyppiseen,
valmistajan suosittelemaan akkuun.
Noudata akun hvittmisess oman maasi tai
alueesi lakeja.
FORSIKTIG
VORSICHT
Explosionsgefahr bei Verwendung falscher Batterien.
Batterien nur durch den vom Hersteller empfohlenen
oder einen gleichwertigen Typ ersetzen.
Wenn Sie die Batterie entsorgen, mssen Sie die
Gesetze der jeweiligen Region und des jeweiligen
Landes befolgen.
Eksplosjonsfare hvis feil type batteri settes i.

Bytt ut kun med samme type eller tilsvarende
anbefalt av produsenten.
Kasser batteriet i henhold til gjeldende avfallsregler.
For kundene i Norge

Dette utstyret kan kobles til et IT-strmfordelingssystem.
HSCU-300
1 (P)
Attention-when the product is installed in Rack:

1. Prevention against overloading of branch circuit
When this product is installed in a rack and is supplied
power from an outlet on the rack, please make sure
that the rack does not overload the supply circuit.
2. Providing protective earth
When this product is installed in a rack and is supplied
power from an outlet on the rack, please confirm that
the outlet is provided with a suitable protective earth
connection.
3. Internal air ambient temperature of the rack
When this product is installed in a rack, please make
sure that the internal air ambient temperature of the
rack is within the specified limit of this product.
4. Prevention against achieving hazardous condition
due to uneven mechanical loading
When this product is installed in a rack, please make
sure that the rack does not achieve hazardous condition due to uneven mechanical loading.
5. Install the equipment while taking the operating
temperature of the equipment into consideration
For the operating temperature of the equipment, refer
to the specifications of the Operation Manual.
6. When performing the installation, keep the following space away from walls in order to obtain proper
exhaust and radiation of heat.
Rear: 10 cm (4 inches) or more
Right, Left: 4 cm (1.6 inches) or more
Top: 4 cm (1.6 inches) or more
2 (P)
HSCU-300
Table of Contents
Manual Structure
3. System Setup
Purpose of this manual ............................................................ 3 (E)
3-1.
Related manuals ...................................................................... 3 (E)

Trademarks.............................................................................. 3 (E)
3-2. Audio System ............................................................3-2 (E)

3-2-1.
Intercom System Setting ..................................3-2 (E)
3-2-2.
Microphone Setting..........................................3-6 (E)
1. Installation
3-3. System Settings .........................................................3-7 (E)

3-3-1.
Tally System Setting ........................................3-7 (E)
3-3-2.
Camera Number Setting...................................3-7 (E)
1-1. Connectors and Cables ..............................................1-1 (E)

1-1-1.
Connector Input/Output Signals ......................1-1 (E)
1-1-2.
Wiring Diagrams for Cables ............................1-5 (E)
1-1-3.
Connection Connectors/Cables ........................1-5 (E)
1-2.
Location of Printed Circuit Boards ...........................1-6 (E)
1-3.
Outside Dimensions ..................................................1-6 (E)
1-4.
Description of Onboard LED Indicators ...................1-7 (E)
1-5.
Switch Settings .........................................................1-9 (E)
1-6.
Potentiometer Functions......................................... 1-11 (E)
1-7.
Mounting the Unit in a 19-Inch Rack......................1-12 (E)
System Connection....................................................3-1 (E)
3-4. Video Signal System .................................................3-8 (E)

3-4-1.
Input/Output Signal Selection..........................3-8 (E)
3-4-2.
Signal Phase Adjustment .................................3-8 (E)
3-4-3.
Aspect Ratio Setting for Down-Conversion ....3-9 (E)
3-4-4.
VBS Signal Level Adjustment ....................... 3-11 (E)
3-4-5.
Waveform Monitor Signal Level Adjustment ... 3-11 (E)
3-4-6.
Stair Case Signal Adjustment Procedure .......3-14 (E)
3-4-7.
Picture Monitor Signal Level Adjustment .....3-15 (E)
3-4-8.
RETURN Input Signal ...................................3-16 (E)
4. Maintenance Mode
2. Service Overview
2-1. Service Information ...................................................2-1 (E)
2-1-1.
Tools.................................................................2-1 (E)
2-1-2.
Note on Replacement of Lithium Battery ........2-1 (E)
2-2.
Connecting/Disconnecting the Flexible Card Wire...2-2 (E)
2-3. Upgrading the Software Programs ............................2-3 (E)

2-3-1.
Upgrading the Main Program ..........................2-3 (E)
2-3-2.
Upgrading the Boot Program ...........................2-4 (E)
2-4.
Writing and Rewriting the PLD Internal Data ..........2-5 (E)
2-5.
Periodic Replacement Parts.......................................2-6 (E)
2-6. Notes on Replacement of Circuit Board ...................2-6 (E)

2-6-1.
EEPROM Data.................................................2-6 (E)
2-6-2.
Actions to Be Taken during Board Replacement
and after Board Replacement/Repair ................2-6 (E)
2-7.
Circuit Protective Devices.........................................2-7 (E)
2-8. How to Extend Boards ..............................................2-8 (E)

2-8-1.
Horizontal Extension .......................................2-8 (E)
2-8-2.
Vertical Extension .......................................... 2-11 (E)
2-9.
Circuit Description ..................................................2-14 (E)
2-10. Notes on Repair Parts ..............................................2-19 (E)

2-11. Unleaded Solder ......................................................2-19 (E)
HSCU-300
4-1. Preparations ...............................................................4-1 (E)

4-1-1.
Starting/Exiting the Maintenance Mode ..........4-1 (E)
4-1-2.
Memory Stick ..................................................4-1 (E)
4-2.
VE OPERATION Menu ............................................4-2 (E)
4-3.
MAINTENANCE Menu .........................................4-12 (E)
5. Replacement of Main Parts

5-1.
Removing/Installing the Front assembly...................5-1 (E)
5-2.
Replacing the DC Fan ...............................................5-1 (E)
5-3.
Removing/Installing the Rear Panel Assembly .........5-2 (E)
5-4.
Replacing the TRIAX connector assembly ...............5-3 (E)
5-5. Replacing Boards ......................................................5-4 (E)

5-5-1.
AU-321 Board/CN-3083 Board .......................5-4 (E)
5-5-2.
CN-3080B Board .............................................5-5 (E)
5-5-3.
CN-3081B Board .............................................5-6 (E)
5-5-4.
CN-3082 Board ................................................5-7 (E)
5-5-5.
CT-257 Board...................................................5-7 (E)
5-5-6.
DPR-300 Board ...............................................5-8 (E)
5-5-7.
DY-23 Board ....................................................5-9 (E)
5-5-8.
ENC-112 Board ...............................................5-9 (E)
1 (E)
5-5-9.
5-5-10.
5-5-11.
5-5-12.
5-5-13.
5-5-14.
FL-349 Board.................................................5-10 (E)

MB-1124 Board .............................................5-12 (E)
PS-739 Board .................................................5-13 (E)
SDI-97B Board ..............................................5-14 (E)
SY-364 Board.................................................5-14 (E)
VIF-39 Board .................................................5-15 (E)
6. Electrical Alignment
6-1. Preparations ...............................................................6-1 (E)
6-1-1.
Equipment Required ........................................6-1 (E)
6-1-2.
Precautions on Adjustments .............................6-1 (E)
6-1-3.
Connection of Equipment ................................6-2 (E)
6-1-4.
Initial Settings ..................................................6-2 (E)
8. Block Diagrams
Overall ............................................................................. 8-2
9. Schematic Diagrams
AU-321 ............................................................................ 9-2
CN-3080B ....................................................................... 9-3
CN-3081B ....................................................................... 9-4
CN-3082 .......................................................................... 9-6
CN-3083 .......................................................................... 9-6
DPR-300 .......................................................................... 9-7
DY-23 ........................................................................... 9-43
6-2. Audio System Adjustment.........................................6-3 (E)

6-2-1.
RTS Intercom Adjustment Check ....................6-3 (E)
ENC-112........................................................................ 9-48
6-3. Video/Reference Signal System Adjustment.............6-5 (E)

6-3-1.
27 MHz VCO Free-Running Adjustment ........6-5 (E)
6-3-2.
STAIR CASE Adjustment ...............................6-5 (E)
MB-1124 ....................................................................... 9-51
6-4. SD Signal System Adjustment ..................................6-6 (E)

6-4-1.
VBS Output Level Adjustment ........................6-6 (E)
6-4-2.
PIX Output Level Adjustment .........................6-6 (E)
6-4-3.
WF Output Level Adjustment ..........................6-7 (E)
6-4-4.
Y/R-Y/B-Y Output Level Adjustment (SD) ....6-8 (E)
VIF-39 ........................................................................... 9-74
6-5. HD Signal System Adjustment..................................6-9 (E)

6-5-1.
Y/R-Y/B-Y Output Level Adjustment (HD)....6-9 (E)
6-5-2.
RGB Output Level Adjustment......................6-10 (E)
6-6. TRIAX Transmission System Adjustment .............. 6-11 (E)
6-6-1.
1.0-MHz Modulation Circuit Adjustment...... 6-11 (E)
6-6-2.
1.4-MHz Demodulation Circuit Adjustment ...6-12 (E)
6-6-3.
Tone Detection Frequency Adjustment..........6-13 (E)
FL-349 ........................................................................... 9-50

SDI-97B ........................................................................ 9-54
SY-364 ........................................................................... 9-56
Frame Wiring................................................................. 9-75
10. Board Layouts

AU-321 .......................................................................... 10-2
CN-3080B ..................................................................... 10-3
CN-3081B ..................................................................... 10-4
CN-3082 ........................................................................ 10-5
CN-3083 ........................................................................ 10-5
DPR-300 ........................................................................ 10-6
DY-23 .......................................................................... 10-11
7. Spare Parts
ENC-112...................................................................... 10-11
FL-349 ......................................................................... 10-12
7-1.
Notes on Repair Parts ...................................................... 7-1
MB-1124 ..................................................................... 10-12
7-2.
Exploded Views............................................................... 7-2
SDI-97B ...................................................................... 10-13
7-3.
Electrical Parts List ......................................................... 7-6
SY-364 ......................................................................... 10-14
7-4.
Supplied Accessories ..................................................... 7-79
VIF-39 ......................................................................... 10-18
7-5.
Optional Fixtures ........................................................... 7-79
2 (E)
HSCU-300
Manual Structure
Purpose of this manual
This manual is the maintenance manual for HD Camera Control Unit HSCU-300.
This manual describes the information items that premise the service based on the
components parts such as main parts replacement, electrical alignment, schematic
diagrams, board layouts and detailed parts list assuming use of system and service
engineers.
Related manuals
Besides this maintenance manual the following manual is available for this unit.
. HSCU-300 Operation Manual (Supplied with HSCU-300)
This manual is necessary for application and operation of HSCU-300.
Part number: 4-140-408-0X (Japanese)
Part number: 4-140-409-0X (English)
. HSCU-300 Operation Manual CD-ROM (Supplied with HSCU-300)
This manual is necessary for application and operation of HSCU-300.
The CD-ROM contains the English, French, German, Italian, and Spanish operation
manual (PDF).
Part number: 4-140-417-0X
. Semiconductor Pin Assignments CD-ROM (Available on request)
This Semiconductor Pin Assignments CD-ROM allows you to search for semiconductors used in Broadcast and Professional equipment.
This manual contains a complete list of semiconductors and their ID Nos., and thus
should be used together with the CD-ROM.
Part number: 9-968-546-06
Trademarks
Trademarks and registered trademarks used in this manual are follows.
. FRAM is a registered trademark of Ramtron International Corporation.
HSCU-300
3 (E)
Section 1
Installation
1-1. Connectors and Cables
1-1-1. Connector Input/Output Signals
Input/Output Signals (TRIAX)
Name
Description
CAMERA
VIDEO, RET VIDEO, INCOM, MIC, COMMAND, PROMPTER, PGM, TRUNK, TONE,
POWER
Input Signals (BNC)

Name
Description
PROMPTER 1, 2
Analog composite signals: 1.0 V p-p, 75 Z
REFERENCE
HD or SD
HD: SMPTE 274M, tri-level sync, 0.6 V p-p, 75 Z
SD: Black burst signal
NTSC: 0.286 V p-p, 75 Z
PAL: 0.3 V p-p, 75 Z
RETURN INPUT
SDI 1/3, SDI 2/4
HD SDI or SD SDI
HD SDI: SMPTE 292M, 0.8 V p-p, 75 Z , 1.485 Gbps/1.4835 Gbps
BTA-S004B compliant
SD SDI: SMPTE 259M, 270 Mbps
Component serial signal
RETURN INPUT
VBS 1/3, VBS 2/4
Analog composite signals: 1.0 V p-p, 75 Z
Output Signals (BNC)

Name
Description
PIX
1.0 V p-p, 75 Z
Pr/R/R-Y, Y/G/Y,
Pb/B/B-Y
. HD component video
Y/Pb/Pr: 0.7 V p-p, 75 Z
. HD RGB video
R/G/B: 0.7 V p-p, 75 Z
. SD RGB video
R/G/B: 0.7 V p-p, 75 Z
. SD component video (NTSC, 75 % color-bar)
Y: 1.0 V p-p (VIDEO:0.714 V, SYNC:0.286 V), 75 Z
R-Y/B-Y: 0.756 V p-p, 75 Z (J)
0.7 V p-p, 75 Z (UC)
. SD component(PAL, 75 % color-bar)
Y: 1.0 V p-p (VIDEO:0.7 V, SYNC:0.3 V), 75 Z
R-Y/B-Y: 0.525 V p-p, 75 Z
SDI OUTPUT
1 to 4
HD SDI: SMPTE 292M, 0.8 V p-p, 75 Z, 1.485 Gbps/1.4835 Gbps

BTA-S004B compliant
SD SDI: SMPTE 259M, 0.8 V p-p, 75 Z, 270 Mbps
Component serial signal
HD SDI or SD SDI selectable
SYNC
HD: BTA-S001A, tri-level sync, 0.6 V p-p, 75 Z

SD: composite sync, 0.3 V p-p, 75 Z
HD SYNC/SD SYNC selectable
VBS OUTPUT 1, 2
1.0 V p-p, 75 Z
WF
0.714 V p-p, 75 Z (NTSC)

0.7 V p-p, 75 Z (PAL)
ENC : 1.0 V p-p, 75 Z
HSCU-300
1-1 (E)
INTERCOM (XLR 5P, Female)
INTERCOM/TALLY/PGM (D-sub 25P, Female)

13
5
4 3 2
25
- EXT VIEW (0 dBu = 0.775 Vrms)
14
No.
Signal
Specifications
No.
Signal
Specifications
ENG (R) (X) OUT
INTERCOM MIC IN (Y)
ENG (R) (Y) OUT
ENG SYSTEM RECEIVE

0 dBu BALANCED
INTERCOM MIC IN (X)
_20 dBu
(CARBON UNBALANCE)
_40 dBu
(ECM, UNBALANCE)
_60 dBu (DYNAMIC,
BALANCE/UNBALANCE)
ENG (G)
GND for ENG
ENG (T) (X) IN
ENG (T) (Y) IN
ENG SYSTEM TALK

0 dBu BALANCED
PGM1 (X) IN
PGM1 (Y) IN
PGM1 (G) IN
GND
10
AUX3
11
R TALLY (X) IN
12
R TALLY (Y) IN
ON:24 Vdc, TTL (H), SHORT

OFF:0 Vdc, TTL (L), OPEN
13
GND
CHASSIS GND
14
PROD (R) (X) OUT
GND
GND for INTERCOM
INTERCOM L OUT
8 dBu (VR Max, 250 Z

Load)
8 dBu (VR Max, 250 Z

Load)
INTERCOM R OUT
LAN (8P, RJ-45, 10Base-T/100Base-TX)
_20 dBu/0 dBu/+ 4 dBu

(Selectable with CCU Menu)
GND for AUX
15
PROD (R) (Y) OUT
PROD SYSTEM RECEIVE

0 dBu BALANCED
16
PROD (G)
GND for PROD
17
PROD (T) (X) IN
18
PROD (T) (Y) IN
PROD SYSTEM TALK

0 dBu BALANCED
19
PGM2 (X) IN
20
PGM2 (Y) IN
21
PGM2 (G) IN
22
EML* PIX/WF
OUTPUT
Active:GND
THROUGH (OFF):OPEN
23
EML Enable
Enable:GND
Normal (Disable) :OPEN
24
G TALLY (X) IN
25
G TALLY (Y) IN
ON:24 Vdc, TTL (H), SHORT

OFF:0 Vdc, TTL (L), OPEN
_20 dBu/0 dBu/+ 4 dBu

*: Easy Monitor Link function
MIC OUT 1, 2 (XLR 3P, Male)
- EXT VIEW No.
Signal
Specifications
TX (+)
Transmitted Data (+)
TX (_)
Transmitted Data (_)
2
3
RX (+)
Received Data (+)
NC
No connection
NC
No connection
No.
Signal
Specifications
RX (_)
Received Data (_)
MIC OUT (G)
NC
No connection
MIC OUT (X)
0 dBu/_ 20 dBu
NC
No connection
MIC OUT (Y)
1-2 (E)
HSCU-300
MIC REMOTE (D-sub 15P, Female)

8
1
15
- EXT VIEW No.
Signal
Specifications
+ 5.5 V OUT
Max. 250 mA
TALLY GND
GND for TALLY
G TALLY OUT
ON (GND) : Max. 30 mA IN
R TALLY OUT
CAM MIC AMP GAIN CTRL2 IN
CTRL 0
CTRL 1
CTRL 2
CAM MIC AMP GAIN
60 dB
50 dB
40 dB
30 dB
20 dB
MIC1 GAIN CTRL ON/OFF IN

8pin
15pin
MIC GAIN CTRL
MIC 1 and 2 ON
MIC 1 ON
MIC 2 ON
INTERNAL set
GND
GND for +5.5 V
10
TALLY OUT
R/G TALLY OUT

11
PREVIEW OUT
ON (GND) : OPEN COLLECTOR
12
ASPECT REMOTE ON/OFF IN
L : REMOTE
13
ASPECT CTRL1 IN
14
ASPECT CTRL2 IN
15
HSCU-300
CTRL1
CTRL2
ASPECT
SQ (16:9)
EC (4:3)
INTERNAL set
LB
MIC2 GAIN CTRL ON/OFF IN

8pin
15pin
MIC GAIN CTRL
MIC 1 and 2 ON
MIC 1 ON
MIC 2 ON
INTERNAL set
1-3 (E)
REMOTE (8P, Female)
TRUNK (D-sub 9P, Female, RS-422A)

1
1
2
7
3 8 6
4 5
- EXT VIEW -
- EXT VIEW No.
Signal
Specifications
TX (+)
SERIAL DATA OUT
TX (_)
RX (+)
RX (_)
TX GND
GND for TX
POWER (+) OUT
RCP POWER, +30 V
POWER (_) OUT
GND for POWER
VIDEO (X)
75 , 1.0 V p-p
CHASSIS GND
CHASSIS GND
SERIAL DATA IN
No.
Signal
GND
Specifications
RX (_)
TRUNK Data in
TX (+)
TRUNK Data out
GND
GND
GND
RX (+)
TRUNK Data in
TX (_)
TRUNK Data out
GND
WF REMOTE (D-sub 15P, Female)
WF MODE (4P, Female)
8
4
1
15
- EXT VIEW -
- EXT VIEW -
No.
Signal
Specifications
No.
Signal
Specifications
SEQ CTRL OUT (G)
NC
No connection
SEQ CTRL OUT (X)
OPEN COLLECTOR
+(PNP)/_(NPN)
(Selectable with S2801/
DPR-300board)
NC
No connection
NC
No connection
STAIR CASE OUT (X)
*1
NC
No connection
STAIR CASE OUT (G)
GND for STAIR CASE
RECALL2 (G)
LOW ACTIVE
RECALL3 (B)
RECALL1 (R)
RECALL4 (SEQ)
*1 : Stair Case signal
12
1
A6
1-4 (E)
DC 0 r 2 V
GND
10
NC
11
NC
No connection
12
RECALL5 (ENC)
LOW ACTIVE
13
RECALL6 (R+B)
14
RECALL7 (R+G)
15
RECALL8 (G+B)
No connection
HSCU-300
1-1-2. Wiring Diagrams for Cables
INTERCOM MIC Cable

(1) Balance (BALANCE in MIC TYPE menu)
CCA-5 Cable (for REMOTE connector)

Black
White
G
Orange
White
X
Y
Brown
INTERCOM
MIC
(2) Unbalance (UNBALANCE in MIC TYPE menu)

Red
White
Red
Brown
Brown
8P CONNECTOR (MALE)
(WIRING SIDE)
X
Y
INTERCOM
MIC
1-1-3. Connection Connectors/Cables

Connection made with the connector panels during installation or service, should be made with the connectors/complete
cable assemblies specified in the following list, or equivalent parts.
Connector Name
Connector/Cable
CAMERA (TRIAX)
. KINGS TRIAX (UC) connector

. Tajimi Electronics TRIAX (J) connector
. FISCHER TRIAX (CE) connector
PROMPTER 1, 2
REFERENCE, SYNC
VBS OUTPUT 1, 2
PIX, WF
Pr/R/R-Y, Y/G/Y, Pb/B/B-Y
RETURN INPUT VBS 1/3, 2/4
(BNC)
1-564-742-11 PLUG, BNC or B-B Cable assembly (1.5 m, optional)
SDI OUTPUT 1 to 4
RETURN INPUT SDI 1/3, 2/4
(BNC)
1-569-370-12 PLUG, BNC or 5C-FB coaxial cable (Fujikura products recommended)
MIC OUT 1, 2 (3P, Male)
1-508-083-00 XLR 3P Female or CANNON XLR-3-11C equivalent
WF REMOTE (D-sub 15P, Female)

MIC REMOTE (D-sub 15P, Female)
1-506-582-11 D-sub 15P, Male or JAE DA-15PF-N equivalent

(Available shell: JAE DA-C1-J10-R equivalent)
INTERCOM/TALLY/PGM
(D-sub 25P, Female)
1-766-367-11 D-sub 25P, Male JAE DB-25PF-N equivalent

(Available shell: JAE DB-C2-J9-R equivalent)
WF MODE (4P, Female)
1-560-155-00 PLUG, 4P Male (accessory)
REMOTE (8P, Female)
1-766-848-11 PLUG, 8P Male or CCA CABLE ASSY (optional) CCA-5-10 (10 m),
CCA-5-3 (3 m)
INTERCOM (5P, Female)
1-508-370-11 XLR 5P, Male or CANNON XLR-5-12C equivalent
TRUNK (D-sub 9P, Female)
1-568-182-11 D-sub 9P, Male or JAE DE-9PF-N equivalent

(Available shell: JAE DE-C1-J6-R equivalent)
LAN (8P, RJ-45)
LAN cable (commercially available, shield type, category 5 or higher)
HSCU-300
1-5 (E)
1-2. Location of Printed Circuit Boards

FL-349
CN-3082
CT-257
CN-3080B
PS-739
SDI-97B
VIF-39
AU-321
CN-3083
CN-3081B
DPR-300
MB-1124
DY-23
SY-364
ENC-112
DY-23
1-3. Outside Dimensions
66
395
424
482
Unit: mm
1-6 (E)
HSCU-300
1-4. Description of Onboard LED Indicators

DPR-300 Board
G
A
1
D406
D701
5
6
DPR-300 Board (SIDE A)

Ref.No.
Name
Color
Description
Normal state
D406
PWR
Green
Lights when all power voltages on the DPR-300 board are

normal.
Lit
D701
CONF
Red
Lights when there is a problem with the configuration of any

FPGA (IC700, IC1700, IC2000, or IC2400) on the DPR-300
board.
Off
DY-23 Board
D102
1
2
B
DY-23 Board (SIDE B)

Ref.No.
Name
Color
Description
Normal state
D102
D7
Green
Blinks slowly when IC201 on the DY-23 board functions

correctly.
Blinking
HSCU-300
1-7 (E)
ENC-112 Board
B
D100
D101
D102
A
1
ENC-112 Board (SIDE B)

Ref.No.
Name
Color
Description
Normal state
D100-102
Green
Blinks when IC100 on the ENC-112 board functions

correctly.
Blinking
SY-364 Board
9
8
D808
6
5
3
2
1
L
SY-364 Board (SIDE A)

Ref.No.
Name
Color
Description
Normal state
D808
MS-LED
Red/Green
Indicates state of access to the memory stick

Lit red:
Access to the memory stick in progress. Do
not remove the memory stick.
Lit green: The inserted memory stick can be removed.
1-8 (E)
HSCU-300
1-5.
Switch Settings
n
Do not change the settings of unused switches.
DPR-300 Board
G
A
1
S2801
S2001
3
5
6

Ref.No.
Name
Bit
Description
Factory setting
S2001
CLEAN
Enables or disables the SDI monitor output (3, 4) character mixing function.
OFF: Normal SDI monitor output
ON:
SDI monitor output (3, 4) character and marker
are always OFF (Clean).
OFF
Not used
OFF
Not used
OFF
Not used
OFF
SEQ
Switched according to the waveform monitor used.

_ (NPN): NPN open-collector output
+ (PNP): PNP open-collector output
_ (NPN)
S2801
HSCU-300
1-9 (E)
SY-364 Board
9
S801
6
5
S730
S731
S733
S734
S531
S530
1
L

Ref.No.
Name
Bit
Description
Factory setting
S530
PROD SEL
Select an intercom system for the producer line.

4W:
4-wire system
RTS (CC): RTS or Clear-Com is selectable with
the CCU menu.
4W
S531
ENG SEL
Select an intercom system for the engineer line.

4W:
4-wire system
RTS (CC): RTS or Clear-Com is selectable with
the CCU menu.
4W
S730
R-TALLY
(POWER/CONTACT)
CONTACT
S733
R-TALLY
(POWER/TTL)
Set these switches in accordance with the specifications for the R TALLY signal that is input to the
INTERCOM/TALLY/PGM connector on the rear
panel. For relationship of the signal and switch
settings, refer to the table below.
S731
G-TALLY
(POWER/CONTACT)
S734
G-TALLY
(POWER/ TTL)
S801
TTL
Set these switches in accordance with the specifications for the G TALLY signal that is input to the
INTERCOM/TALLY/PGM connector on the rear
panel. For relationship of the signal and switch
settings, refer to the table below.
CONTACT
TTL
PROTECT
Used to protect data write to IC801.
ON
VerUp
Used to enable software upgrade using a memory

stick.
OFF
NORMAL/DEBUG
Not used
OFF
NORMAL/DEBUG
Not used
OFF
Tally System Settings

Ref.No.
Red tally
S730
(POWER/ CONTACT)
S733
(POWER/TTL)
Green tally
S731
(POWER/ CONTACT)
S734
(POWER/TTL)
Contact supply
CONTACT
CONTACT
24 V supply
POWER
POWER
POWER
POWER
5 V supply
POWER
TTL
POWER
TTL
1-10 (E)
HSCU-300
1-6.
Potentiometer Functions
DPR-300 Board
G
A
1
RV2602 1 2
RV2601 1
3
LV1501 11 RV1501
RV1502 1 1 LV1502
RV1503 1 1 LV1503
Ref.No.
Name
Description
RV1501
DEV ADJ
Adjusts modulation degree of standby INCOM (CCU to CAM) FM-modulated wave

output.
RV1502
ST INCOM LEV ADJ
Adjusts waveform level of standby INCOM (CAM to CCU) demodulation output.
RV1503
TONE ADJ.
Adjusts free-running oscillation frequency of the TONE signal detection circuit.
RV2601
DC (Position)
Adjusts lateral display position of tri-waveform display on the waveform monitor.
RV2602
LEVEL (Interval)
Adjusts display position interval of tri-waveform display on the waveform monitor.
LV1501
1.0M FREQ ADJ
Adjusts modulation frequency of standby INCOM (CCU to CAM) FM-modulated

wave.
LV1502
TUNE 1
Adjusts operating point of the standby INCOM (CAM to CCU) demodulation circuit.
LV1503
TUNE 2
Adjusts output distortion of the standby INCOM (CAM to CCU) demodulation circuit.
SY-364 Board
9
8
RV531 1 5
RV530 1
4
3
2
RV1
1
L
1
E

Ref.No.
Name
Description
RV1
27M FREQ
Adjusts free-running oscillation frequency of 27M-VCO (X1) for readjustment required

when it is replaced.
RV530
PROD RTS CANCEL
Adjusts sidetone cancellation amount of the producer line when RTS or Clear-Com
is connected.
RV531
ENG RTS CANCEL
Adjusts sidetone cancellation amount of the engineer line when RTS or Clear-Com
is connected.
HSCU-300
1-11 (E)
1-7. Mounting the Unit in a 19-Inch Rack

This unit can be mounted in a 19-inch EIA standard rack (height: 1.5U).
w
. Secure the rack to the floor.
If the rack falls due to the weight of equipment, it may result in death or serious injury.
Secure the rack to the floor without fail to prevent it from falling or moving.
. Do not mount the unit at a floor height of more than 1 m.
Fall of the rack may result in death or serious injury.
Mount the unit in the rack that is secured to the floor at a floor height within about 1 m.
Preparations
c
Be sure to use specified rack-mount rails.
If unspecified rack-mount rails are used, the equipment in the rack may fall due to insufficient strength,
which may result in injury.
[Part]
. Slide rail
Accuride Japan Model 305A-18 (457 mm)
. Front bracket
Sony Part No.: 2-142-214-01
. Rear bracket
Sony Part No.:2-142-215-01
. Screw (B4 x 8)
. Screw (B5 x 8)
. Screw (PWH4 x 20)
. Nut
. Plate nut
Sony Part No.: 3-651-812-00
. Rack mount rail screw (PSW5 x 25):
[Quantity]
[1 set]
[2]
[2]
[14]
[8]
[2]
[2]
[2]
[4]
Manufacturer: Accuride Japan
1-12 (E)
HSCU-300
Mounting the Unit in the Rack

This unit is mounted in the rack by attaching the inner rails at the upper or lower part 1U of height 1.5U.
The rail attaching position varies depending on the unit mounting height in the rack.
When mounting this unit under other equipment,
install the inner rail at the upper part (1U) of the
unit.
Inner rail
Inner rail
1U
Other equipment
0.5U
1.5U
HSCU-300
1.5U
HSCU-300
0.5U
Other equipment
1U
When mounting this unit above other equipment,

install the inner rail at the lower part (1U) of the
unit.
1. Pull out the inner rail while pressing the rail

stopper.
Outer rail
Stopper
Inner rail
2. Install the inner rail to the unit with six

screws (B4 x 8).
n
This figure shows attaching the inner rails at
the upper part.
The same method applies for attaching the
inner rails at the lower part.
Inner rail
B4 x 8
Inner rail
B4 x 8
HSCU-300
1-13 (E)
3. Attach the front and rear brackets to the outer

rail with eight screws (B4 x 8).
m
. When attaching the front bracket, slide the
middle member to the position where the
screw hole in the cabinet member is visible
from the hole in the middle member shown
in the figure.
. When attaching the rear bracket, adjust the
bracket position according to the depth of
the rack.
Plate nut
Rear bracket
B4 x 8
Front bracket
Cabinet member
Mid member
B4 x 8
Front bracket
Mid member
B4 x 8
1-14 (E)
HSCU-300
4. Attach the front bracket to the inside of the rack

mount position with two screws (PWH4 x 20).
Nut
Front bracket
Rack (front)
Outer rail
PWH4 x 20
12.7
31.75
12.7
31.75
Unit: mm
When the inner rail is installed at the upper part (1U) of the
unit, attach the front bracket at this position.
Inner rail
31.75
12.7
31.75
12.7
31.75
Inner rail
When the inner rail is installed at the lower part (1U) of the
unit, attach the front bracket at this position.
5. Attach the rear bracket to the outside of the

rack mount position with four screws (B5 x 8).
Rack (rear)
Outer rail
B5 x 8
31.75
B5 x 8
Rear bracket
Unit: mm
HSCU-300
1-15 (E)
6. Set the unit in the rack while pressing the

inner rail stopper into the outer rail as far as it
will go.
m
. This rack mounting work must be done by
two or more workers so as not to hurt the
worker s waist.
. Failure to tighten the rack angle screws
may cause the unit to slide and fall from the
rack, resulting in injury. After the unit has
been mounted, be sure to tighten all the
screws.
. When setting and drawing the mounted
unit, be careful not to catch your fingers by
the rails.
. If balance is lost when mounting and
removing the unit, it may fall, resulting in
injury. Mount or remove the unit carefully
maintaining a stable posture.
Rack
Stopper
PSW5 x 25
Stopper
Inner rail
PSW5 x 25
7. After the unit has been set in the rack, secure the
unit to the rack with four screws (PSW5 x 25).
1-16 (E)
HSCU-300
Section 2
Service Overview
2-1. Service Information
2-1-1. Tools
Sony Part No.
Name
Use
A-1727-365-A
Extended board EX-1121
Front/rear-side vertical extended board (long size)
A-1727-367-A
Front-side horizontal extended board
A-1727-368-A
Front/rear-side vertical extended board (short size)
A-1727-369-A
Rear-side horizontal extended board
A-8326-017-A
ROM-28 board
For boot program upgrade
J-7120-220-A
PLD download tool
PLD data download cable (USB)
2-1-2. Note on Replacement of Lithium Battery

A lithium battery is mounted on the SY-364 board to back up the real time clock (RTC). If a battery comes
to the lifetime, then RTC stops. Therefore, replace the battery and re-set DATE/TIME on the C13 DATE
page of the CCU menu. (Refer to Setup Menu in the Operation Manual.)
SY-364 board/CR2032: Sony Part No. (! 1-528-174-11)
c
In replacing, ensure that the battery is installed with + and _ poles connected to the correct terminals.
Improper connection may cause an explosion or leakage of fluid.
HSCU-300
2-1 (E)
2-2. Connecting/Disconnecting the

Flexible Card Wire
The flexible card wires are used to connect between the
boards in this unit. Life of flexible card wire will be significantly shortened if it is bent. Be very careful not to bend
the flexible card wire.
Three types of different-shaped connectors are used in this
unit. (Type A to type C)
Because the direction of the flexible card wire is different
depending on the shape of the connector, be careful when
connecting the flexible card wire.
Type A
Isolation surface
(blue)
A
Disconnecting
1. Turn off the power.
2. Raise the portion A in the direction of the arrow to
unlock and pull out the flexible card wire.
Connector
Type B
A
Isolation surface (blue)
Connecting
m
. Do not insert the flexible card wire sideways.
. Confirm that there is no stain or dust on the contact
surface of the flexible card wire.
. When connecting the flexible card wire, check the connector shape, and great care should be taken for the
direction of the contact surface or isolation surface
(blue).
(Refer to illustration of the type A to type C.)
1. Raise the portion A in the direction of the arrow and
securely insert the flexible card wire into the deep end
of the connector.
2. Return the portion A to its original position and lock
the connector.
2-2 (E)
Connector
Type C
Isolation surface (blue)
Connector
HSCU-300
2-3. Upgrading the Software Programs

The ROM (IC812 and IC813 on the SY-364 board) version can be upgraded using a Memory Stick.
For upgrading the software programs, follow the procedures below.
2-3-1. Upgrading the Main Program

Tool
Memory Stick
Check
Check the current main program version with ROM Version of status display. (Refer to the Operation
Manual.)
Preparation
Copy the upgrading program to the Memory Stick in the following steps.
n
To get the upgrading program (program files hscu300.rom and boot.rom), contact your local Sony
Sales Office/Service Center.
(1) Make the following directory on the Memory Stick.
\MSSONY\PRO\CAMERA\HSCU300
(2) Copy the program files hscu300.rom and boot.rom to the directory made in step (1).
Procedure
1. Remove the front panel. (Refer to Section 5-1.)
2. Set the switch S801-2 on the SY-364 board to ON.
3. Insert the Memory Stick that contains the upgrading program into the connector CN804 on the
SY-364 board.
4. Turn on the power.
The diode D808 on the SY-364 board blinks green and red during upgrade, and lights green upon
completion of the upgrade.
5. Turn off the power and re-set S801-2 on the SY-364 board to OFF.
6. Remove the Memory Stick.
7. Attach the front panel.
8. When the unit is turned on, the main program is upgraded and runs.
9. Check that the main program has been upgraded with ROM Version of status display. (Refer to the
Operation Manual.)
HSCU-300
2-3 (E)
2-3-2. Upgrading the Boot Program

Tools
. Memory Stick
. ROM-28 board: (Sony Part No.: A-8326-017-A)
Check
Check the current boot program version with FIRMWARE UPDATE of the MAINTENANCE menu.
(Refer to Section 4-3.)
Preparation
1. Copy the upgrading program to the Memory Stick in the following steps.
n
To get the upgrading program (program files hscu300.rom and boot.rom), contact your local Sony
(1) Make the following directory on the Memory Stick.
\MSSONY\PRO\CAMERA\HSCU300
(2) Copy the program files hscu300.rom and boot.rom to the directory made in step (1).
2. Save the upgrading boot program in the ROMs H (IC2) and L (IC3) on the ROM-28 board.
n
For details of saving the upgrading program, contact your local Sony Sales Office/Service Center.
2-4 (E)
ROM-28 board
CN1
DOWN
LOAD
Procedure
1. Remove the front panel.
2. Draw the SY-364 board.
(Refer to Section 5-5-13.)
3. Insert the Memory Stick that contains the
upgrading program into the connector CN804
on the SY-364 board.
4. Connect the connector CN1 on the ROM-28
board to the connector CN805 on the SY-364
board.
5. Set the switch S1 on the ROM-28 board to
the DOWNLOAD side.
6. Insert the SY-364 board and turn on the power.
The diode D808 on the SY-364 board blinks
green and red during upgrade, and lights
green upon completion of the upgrade.
7. Turn off the power, and remove the ROM-28
board from the SY-364 board.
8. Remove the Memory Stick.
9. Insert the SY-364 board, and attach the front
panel.
10. When the unit is turned on, the boot program
is upgraded and runs.
11. Check that the boot program has been upgraded with FIRMWARE UPDATE of the MAINTENANCE menu. (Refer to Section 4-3.)
S1
SY-364 board
CN805
HSCU-300
2-4. Writing and Rewriting the PLD Internal Data

This unit uses the PLD (Programmable Logic Device) that supports the e-Production (EPR) system to
write and rewrite the internal data.
If the parts listed below needs to be replaced or if PLD needs to be upgraded, contact your local Sony
n
The part number of PLD (or ROM for PLD) in which data is not written yet, is shown in Spare Parts.
Therefore, if part replacement is required, write the data by the following procedure.
In the case of the PLD type that runs on the program stored in external ROM, the PLD has only to be
replaced and data needs not to be written only.
e-Production system has the advantages shown below.
. To write/rewrite the PLD internal data:
1. The standard fixture (cable) can be used.
2. The standard software (PLD Download Tool) can be used.
. The PLD internal data is controlled in the Sony Database Server under the name Project file
(E_xxx_xxx_xx_xx).
. The printed circuit board is equipped with the standard connector (EPR2 connector) to write the PLD
internal data. The indication EPR2 is shown on the printed circuit board.
Corresponding PLDs
Board name
PLD/ROM
EPR2 connector
Project file No.
SY-364
IC800, IC857*1, IC900
CN806
E_000_004_61_xx
DPR-300
IC700, IC701*2, IC1700, IC2000, IC2400
CN702
E_000_004_62_xx
*1 : IC857/SY-364 is a ROM for IC800, IC900/SY-364.

*2 : IC701/DPR-300 is a ROM for IC700, IC1700, IC2000, IC2400/DPR-300.
Equipment required
. PLD download tool (USB)
The cable to connect PC to this unit.
. PC
A PC having USB port.
A PC in which the PLD Download Tool software is already installed.
For the applicable OS and the operating environment, refer to Download Tool Operating Instruction
for Device Programming.
HSCU-300
2-5 (E)
Data writing procedure

Data writing procedure in the PLD (or ROM for PLD) is outlined below.
For details of data writing procedure, refer to Download Tool Operating Instruction for Device Programming, which is available in the same site where the PLD Download Tool software is available.
1. Prepare the Project file.
n
Download the Project file from the Sony Database Server.
2. Turn off the power of this unit.
Connect the PC USB port to the EPR2 connector of the target board using the PLD download tool
(cable).
3. Turn on the power of this unit.
Start the PLD Download Tool software and read the Project file.
4. Program the PLD (or ROM for PLD) with the PLD Download Tool software.
5. Upon completion of programming, check that error message is not displayed. Turn off the power of
this unit and back on.
2-5. Periodic Replacement Parts

This table does not describe the guarantee period of part.
The replacement period of each part depends on the environment and condition. Refer to Section 5
Replacement of Main Parts for the replacement method of parts.
Part name
Sony Part No.
Check/replacement period
FAN, DC (60 SQUARE)
! 1-787-419-12
Replace every two years *
*: When used for eight hours a day.
2-6. Notes on Replacement of Circuit Board

2-6-1. EEPROM Data
The table below lists data retained in the EEPROM on respective boards.
n
The part number listed in Spare Parts is for EEPROM which is not programmed. Therefore, program a
new EEPROM after replacement. For details, contact your local Sony Sales Office/Service Center.
Board
Ref No.
Stored data
DPR-300
IC2402
Board adjustment data
SY-364
IC801
Serial number, etc.
2-6-2. Actions to Be Taken during Board Replacement and after Board Replacement/Repair
Board
Action
DPR-300
SD Signal System Adjustment (Refer to Section 6-4.)

HD Signal System Adjustment (Refer to Section 6-5.)
TRIAX Transmission System Adjustment (Refer to Section 6-6.) only for repair *
Setting of the cable length calculation reference value only when IC2402 is replaced (Refer to Section 4-3.) *
SY-364
Re-setting of serial number, model name, and destination (Refer to Section 4-3.)
*: Not necessary when the DPR-300 board is replaced.
2-6 (E)
HSCU-300
2-7. Circuit Protective Devices

Thermistor
This unit is provided with positive thermistors for power circuit. If an overcurrent flows in a positive
thermistor or it heats up to a certain degree with the increase of the ambient temperature, its internal
resistance increases sharply to limit the current flowing in the circuit. When a thermistor is activated, turn
off the power and check the circuit of the unit. After the cause of the problem is removed and the device
cools down, turn on the power again. The unit will work normally. It takes about one minute for the
device to cool down after power-off.
Board
CN-3081B
DPR-300
SDI-97B
SY-364
HSCU-300
Ref. No.
THP21
THP61
THP101
THP102
THP281
THP282
THP301
THP302
THP303
THP304
THP305
THP306
THP307
THP308
THP401
THP402
THP403
THP404
THP405
THP406
THP407
THP408
THP409
THP410
THP411
THP412
THP1
THP2
THP801
THP950
THP951
THP952
THP953
THP954
THP955
THP956
THP957
THP958
THP959
THP960
THP961
THP962
THP963
THP964
THP965
THP966
THP967
THP968
THP969
Address
F1 (Side A)
D1 (Side A)
C2 (Side A)
A2 (Side A)
F4 (Side A)
F4 (Side B)
G3 (Side A)
G6 (Side B)
G6 (Side A)
G6 (Side A)
F6 (Side B)
F6 (Side B)
G6 (Side A)
F6 (Side B)
G3 (Side B)
G4 (Side B)
F2 (Side B)
C3 (Side B)
C3 (Side B)
D2 (Side A)
B2 (Side B)
B2 (Side A)
B2 (Side B)
B2 (Side B)
F2 (Side B)
C2 (Side A)
A2 (Side B)
B2 (Side B)
B8 (Side A)
H7 (Side A)
K7 (Side A)
K7 (Side A)
J7 (Side A)
K6 (Side A)
K3 (Side A)
K4 (Side A)
J4 (Side A)
J3 (Side A)
J2 (Side A)
J3 (Side A)
K2 (Side A)
H1 (Side A)
A3 (Side A)
K6 (Side A)
A2 (Side A)
A3 (Side A)
K4 (Side B)
L4 (Side A)
L3 (Side A)
Sony part No.

! 1-803-615-21
! 1-803-615-21
! 1-803-615-21
! 1-803-615-21
1-804-616-21
1-804-458-21
! 1-804-458-21
! 1-804-987-21
! 1-804-458-21
! 1-804-616-21
! 1-804-616-21
! 1-804-458-21
! 1-804-458-21
! 1-804-616-21
! 1-804-987-21
! 1-804-458-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-458-21
! 1-804-616-21
! 1-804-458-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-802-108-11
! 1-803-615-21
! 1-803-615-21
! 1-804-616-21
! 1-804-616-21
! 1-803-615-21
! 1-803-615-21
! 1-804-616-21
! 1-804-616-21
! 1-804-616-21
! 1-802-108-11
! 1-804-616-21
! 1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
2-7 (E)
2-8. How to Extend Boards

There are the following four extended boards used for checking and adjusting boards.
Use the following extended boards in combination to extend boards according to each situation.
Sony Part No.
Extended Board Name
Use
A-1727-365-A
EX-1121*2
A-1727-367-A
EX-1098*1
A-1727-368-A
EX-1099*2
A-1727-369-A
EX-1100
*1: A coaxial cable and a 30-wire flexible card wire are supplied.
*2: A coaxial cable and a 30-wire flexible card wire are not supplied.
When the flexible card wire is not connected to the connector CN1 on the SY-364 board, any operation with the switches and
potentiometers on the AU-321 board is disabled. Only the indicators on the AU-321 board function.
The following components are necessary for vertical extension of the DPR-300 board.
. BNC cable (commercially available)
. Coaxial connector converter: 2 units
Sony Part No.: 1-774-157-11
. Coaxial cable supplied with the extended board EX-1098
Sony Part No.: 1-836-794-11
2-8-1. Horizontal Extension

Front boards and rear boards can be extended
horizontally with the extended boards EX-1098
and EX-1100, respectively.
n
Before starting this work, be sure to turn off the
power and disconnect the power cord.
Extending the CN-3081B/SDI-97B/VIF-39 Boards
1. Remove the board to be extended.
. CN-3081B board (Refer to Section 5-5-3.)
. SDI-97B board (Refer to Section 5-5-12.)
. VIF-39 board (Refer to Section 5-5-14.)
2. Connect the extended board EX-1100 to the
MB-1124 board.
3. Connect the board to be extended to the
EX-1100 board.
MB-1124 board
CN-3081B board
SDI-97B board
VIF-39 board
2-8 (E)
HSCU-300
Extending the DPR-300 Board

1. Disconnect the coaxial cable from the connector CN3901 on the DPR-300 board.
n
Be sure to hold the plug when disconnecting
the coaxial cable. Do not pull the cable.
2. Draw the DPR-300 board out of the chassis.
MB-1124 board.
4. Connect the DPR-300 board to the extended
board EX-1098.
5. Disconnect the coaxial cable from the connector CN5 on the EX-1098 board, and
connect the coaxial cable to the connector
CN3901 on the DPR-300 board.
n
6. Connect the coaxial cable (disconnected in
step 1) to the connector CN5 on the EX-1098
board.
OK Hold the plug to remove.
NG Do not attempt to remove

by pulling the cable.
MB-1124 board
Coaxial cable
(Supplied)
CCU
CN5
CN3901
DPR-300 board
HSCU-300
2-9 (E)
Extending the SY-364 Board

1. Disconnect the flexible card wire from the
connector CN1 on the SY-364 board.
n
Be careful not to bend the flexible card wire.
This shortens the wire life.
2. Draw the SY-364 board out of the chassis.
MB-1124 board.
4. Connect the SY-364 board to the EX-1098
board.
connector CN3 on the AU-321 board.
n
6. Connect the connector CN1 on the SY-364
board to the connector CN3 on the AU-321
board using the flexible card wire supplied
with the EX-1098 board.
2-10 (E)
MB-1124 board
AU-321 board
CN3
Flexible card wire
(Supplied)

CN1
SY-364 board
HSCU-300
2-8-2. Vertical Extension

Each plug-in board can be extended vertically
using the extended board EX-1099 or EX-1121.
n
Before starting work, be sure to turn off the power
and disconnect the power cord.
Extending the CN-3081B/SDI-97B/VIF-39 Boards
1. Remove the top cover. (Refer to Section 5-2.)
2. Remove the board to be extended.
. CN-3081B board (Refer to Section 5-5-3.)
. SDI-97B board (Refer to Section 5-5-12.)
. VIF-39 board (Refer to Section 5-5-14.)
3. Connect the extended boards EX-1099 and
EX-1121 to the MB-1124 board.
4. Connect the boards to be extended to the
EX-1099 and EX-1121 boards.
CN-3081B board
SDI-97B board
VIF-39 board
MB-1124 board

(Short size)
CN-3081B board
SDI-97B board
VIF-39 board
MB-1124 board

(Long size)
HSCU-300
2-11 (E)
Extending the DPR-300 Board

1. Remove the top cover (Refer to Section 5-2.)
2. Disconnect the coaxial cable from the connector CN3901 on the DPR-300 board.
n
MB-1124 board.
5. Connect the DPR-300 board to the EX-1099
board.
6. Extend the coaxial cable disconnected in step
2 using the coaxial connector converters and
cables.
7. Connect the extended coaxial cable to the
connector CN3901 on the DPR-300 board.
Coaxial connector converter

Coaxial cable
(Supplied with the extended board EX-1098)
DPR-300 board
BNC cable
CN3901
MB-1124 board
CCU
Coaxial connector
converter
(Short size)
Coaxial cable
2-12 (E)
HSCU-300
Extending the SY-364 Board

1. Remove the top cover (Refer to Section 5-2.)
n
4. Draw the SY-364 board out of the chassis.
MB-1124 board.
6. Connect the SY-364 board to the EX-1121
board.
n
8. Connect the connector CN1 on the SY-364
board and the connector CN3 on the AU-321
board with the flexible card wire supplied
with the extended board EX-1098.
n
Without this connection, any operation with
the switches and potentiometers on the
AU-321 board is disabled. Only the indicators
on the AU-321 board function.
HSCU-300
Flexible card wire

(Supplied)
AU-321 board
CN3
SY-364 board
CN1
MB-1124 board

(Long size)
2-13 (E)
2-9. Circuit Description

SY-364 Board
The SY-364 board that contains a microcomputer SH2-DSP (IC808) controls the internal boards and
power supply, and performs settings for the system including camera. It also performs command communication with the camera, RCP, and MSU.
Furthermore, this board enables LAN connection by the LAN controller that incorporates a microcomputer.
This board has an HD/SD signal generator and performs genlock with the external reference and between
HD and SD signals. Thus it controls entire video signal phases. It also can select HD tri-level sync signal
or SD sync signal and output it.
[Audio Signal and Tally Processing]
. D/A-converts and outputs the MIC signal sent from the DPR-300 board.
. Selects and D/A-converts the intercom signals sent from the DPR-300 board, and sends them to external circuits.
. A/D-converts the intercom signals and the PGM signal that are input to the unit, and sends them to the
DPR-300 board.
. R/G tally signal interface
[Return Signal Processing]
The SY-364 board can handle return signals HD-SDI, SD-SDI, and VBS, and converts them to the specified signals and sends them back to the camera.
. The HD-SDI signal phase is adjusted.
. The SD-SDI signal is up-converted to the pseudo-HD signal and its signal phase is adjusted.
. The VBS signal is digitized to a signal equivalent to the SD digital component signal, and is processed
in the same way as the SD-SDI signal.
2-14 (E)
HSCU-300
DPR-300 Board
The DPR-300 board has two blocks: one is for digital triax transmission and the other is for video signal
processing.
[Digital Triax Transmission Circuit]
The transmission circuit consists of an FM signal transmitter/receiver for the standby intercom/tone/sync
signals, and an OFDM signal transmitter/receiver for the video/audio/trunk signals and commands. This
circuit has a function to monitor the receiver operation status for the OFDM signal transmitter/receiver
control and a function to detect the length of the connected triax cable.
. In the FM receiver, the FM signal (carrier frequency 1.4 MHz) is extracted from the RF signal sent from
the camera by the MPX filter and BPF, and is demodulated by IC1502. The demodulated signal is
separated into standby intercom signal (CAM to CCU) and tone signal (16.38 kHz) by the LPF (7 kHz)
and HPF (14 kHz). The tone signal is used to control the main power supply (180 VDC) to the camera.
In the FM transmitter, the standby intercom signal (CCU to CAM) and the sync signal are switched, and
the selected signal is FM-modulated with a carrier frequency of 1.0 MHz and is then sent to the CCU.
The standby intercom signal (CCU to CAM) is transmitted during the standby state, and the sync signal
is transmitted while the main power is turned on.
. The OFDM signal receiver circuit consists of two blocks: one is for the F1/F2/F3 low bands and the
other is for F4/F5/F6 mid bands to support six waves F1 to F6 for transmission of video/sub video/MIC/
INCOM/command signals.
The low-band receiver circuit removes low-frequency noise from F1 to F3 signals that are output from
the LPF side of the MPX filter by the HPF (0.9 MHz), and amplifies the signals by the low-noise amplifier, and selects them for each band by the BPF for individual processing.
The levels of the selected F2 and F3 signals are regulated by the step gain amplifier (that automatically
switches amplifier gain to four steps according to input signal level) and the AGC amplifier. Then the
signals are converted to signals with a center frequency of 36 MHz by the mixer circuit.
Since the AGC amplifier does not function in the F1 band, the F1 signal processing circuit configuration
is different from that for F2/F3 signals. In the F1 signal processing circuit, the F1 signal is input to the
step gain amplifier (IC3402) and then to the mixer circuit. The F1 signal is converted to a signal with a
center frequency of 36 MHz, and the signal level is regulated by the AGC amplifier.
The converted OFDM signals F1, F2, and F3 (36 MHz center frequency) are converted to TS data by
the demodulator ICs (IC3404, IC3504, and IC3604), and the serial TS data is output to the video signal
processing circuit.
The mid-band receiver circuit amplifies the F4 to F6 signals that are output from the BPF side of the
MPX filter by the low-noise amplifier, and selects them for each band by the BPF for individual processing. Since attenuation in the cable transmission becomes large in the mid signal band, this circuit
has a function to switch the low-noise amplifier gain to two steps according to the transmission distance.
The selected F4 to F6 signals are processed in the same circuit configuration as for the F2 and F3 signals.
. The OFDM signal transmitter circuit consists of two blocks: one is for F7 + F9 bands and the other is
for F8 band to support three waves F7 to F9 for transmission of return video/prompter video/ INCOM/
PGM/command signals.
The video signal processing circuit generates OFDM signals with D/A conversion. However, because
the clock frequency is 183 MHz, this circuit generates OFDM signals with low frequencies (26 + 46
MHz and 36 MHz) but not with direct (F7 + F9) and F8 frequencies, and then converts them to signals
with (F7 + F9) and F8 frequencies by the mixer circuit. Then the converted OFDM signals are mixed
by the respective output drivers and are output to the camera. Since attenuation in the cable transmission becomes large in the F7 to F9 signal bands, this circuit has a function to switch the output signal
level to four levels by the gain control amplifier and ATT according to the transmission distance.
This digital triax transmission circuit is provided with a transmission cable length detection function for
transmission distance-based control, a mixer circuit, and a 4MHz clock generator for the OFDM signal
demodulation IC.
HSCU-300
2-15 (E)
[Video Signal Processing Circuit]

The DPR-300 board has two circuits for the main-line system and the return system. In the main-line
system circuit, the OFDM-modulated signal from the camera is demodulated, and the demodulated signal
is down-converted and processed. Then video signals of each system are transferred to the rear boards. In
the return system circuit, the return video signals from the SY-364 board and the VBS prompter signal
from the rear boards are encoded, OFDM-modulated, and are then sent back to the camera.
In the main-line system circuit, the stream signal demodulated from the signal sent from the transmission
block is separated into video signals, audio signals, command signal, and trunk signal.
. The video signals are sent to the DY-23 board to be decoded to baseband video signals.
. Some audio signals are sent to the SY-364 board to be output to the CCU, and others are embedded in
the SDI output.
. The command signal is sent to the SY-364 board.
. The trunk signal is sent to the rear boards to be output.
The video signals decoded to baseband video signals on the DY-23 board are down-converted, if necessary, by the video signal processing IC according to the output format. The audio signal and sync signal
are mixed with the signal for SDI output by the next-stage IC, and the mixed signal is converted to HDSDI or SD-SDI serial signal, and the converted signal is sent to the rear boards.
The analog component output signal HD-YPbPr or SD-Ycd from the video signal processing IC is converted to RGB signals by the converter IC according to the output format. The converted RGB signals are
D/A-converted for each channel and are sent to the rear boards.
The VBS-format SD-Ycd output from the video signal processing IC is converted to VBS signal by the
encoder IC. The converted VBS signal is D/A-converted to WF, PIX, and VBS output signals, and these
signals are sent to the rear boards. This circuit has a function to align the subcarrier component phase with
the reference signal input to the CCU for VBS system output.
In the return system circuit, the return video signal from the SY-364 board is sent to the DY-23 board to
be encoded, and is then sent to the OFDM modulation IC. The VBS prompter signal from the rear boards
is decoded by the VBS decoder IC, and is then sent to the ENC-112 board to be encoded. The encoded
signal is sent to the OFDM modulation IC. When the SDI prompter is selected, the video signal to be sent
to the ENC-112 board becomes the SDI signal from the SY-364 board.
The OFDM modulation IC multiplexes the return/prompter signals, the command signal sent to the camera, and the audio signal for the intercom to generate two-system signals (F7 + F9 and F8 waves),
D/A-converts the multiplexed signal, and then sends it to the transmission circuit.
In addition to these circuits for the main-line and return signal processing systems, the DPR-300 board
contains a character generator for CCU menu output, a WFM stair case signal generator, and an EEPROM
that retains signals for the component/VBS video level adjustment data/cable length determination adjustment data.
ENC-112 Board
This small board located on the DPR-300 board functions as a CODEC of video signals for the prompter.
The ICs on this board have MPEG2 encoding/decoding functions, and the CCU side uses the encoding
function.
DY-23 Board
This small board located on the DPR-300 board functions as a CODEC of main-line video signals and
return video signals.
The ICs on this board have encoding/decoding functions for digital triax transmission. Those for mainline signals use the decoding function, and those for return video signals uses the encoding function.
2-16 (E)
HSCU-300
PS-739 Board
This board generates 38 VDC/180 VDC for camera, 28 VDC for RCP, and 15 VDC for the internal CCU
power from the AC line power input, and supplies them. Commercial power source 100 to 240 VAC is
supplied from the rear AC inlet through the front AC switch. This board supplies 28 V for RCP and 15 V
for the internal CCU power by the internal LV converter. Then this board converts them to CAM38 V and
180 V by the internal HV converter and outputs 38 V first, and then outputs 180 V upon receiving CAM
POWER ON from the CCU. Since this board checks the connection to the camera, it does not output 180
V while the camera is not connected.
CT-257 Board
This small board located on the PS-739 board contains an internal protective circuit, a PLD circuit for
CHU output control, and a 28 V output regulator for RCP.
AU-321 Board
This board contains tally (red/green) and status indicator LEDs, menu operation switches, intercom
switches, and a microphone amplifier. The power, tally, status indicator LEDs (CABLE OPEN/SHORT,
MAIN POWER, CAM POWER, and NETWORK signals) are connected to the rear CN-3081B board.
The switches and potentiometers for the intercom, menu operation switches, MENU LEDs, and the rotary
encoder are connected to the SY-364 board.
Selection of the microphone amplifier gain, BIAS power on/off, and balance/unbalance is set by the CCU
menu.
CN-3080B Board
This board, connected to the SDI-97B board with a flexible card wire, outputs SD analog signals (PIX and
WF signals), HD/SD component signals, and HD/SD SYNC signals to external devices.
This board also outputs the stair case signal used for monitoring signals in the sequential mode on the
waveform monitor. Furthermore, this board inputs two-system prompter signal from external devices, and
interfaces with the RCP, MSU, and CNU through the connector. A relay to enable the easy monitoring
function is provided on this board, which is switched by the status signal sent form the DPR-300 board.
CN-3081B Board
This board contains the INCOM/TALLY/PGM, MIC REMOTE, WF REMOTE, and TRUNK connectors
for the interface with external devices.
This board supplies the front boards with 15 V as the CCU power supply generated by the PS-739 board,
and supplies the CN-3080B board with 28 V for RCP.
In addition, this board has a circuit to generate fan power voltage 12 V from 15 V as the CCU power
supply, and sends the fan power voltage to the fan.
HSCU-300
2-17 (E)
CN-3082 Board
This board provides two channels of MIC signal output.
CN-3083 Board
This board contains an intercom connector (XLR-5, female).
FL-349 Board
This board handles the RF signal and DC power voltage for CAM, which are sent to the camera with the
TRIAX cable.
This board contains a TRIAX connector and connectors for connection to the PS-739 and DPR-300
boards.
SDI-97B Board
This board outputs four systems of the HD/SD-SDI signal to external devices and outputs two systems of
the VBS signal.
This board interfaces the following signals between the DPR-300 board and the CN-3080B board.
PIX signal, WF signal, HD/SD component signals, HD/SD sync signals, stair case signal, prompter signal,
and RCP/MSU/CNU control signals
VIF-39 Board
This board contains a reference input connector for external synchronization. It inputs two systems of the
HD/SD-SDI return signal from external devices and inputs two systems of the composite analog return
signal.
This board interfaces the MIC signal between the SY-364 board and the CN-3082 board. In addition, this
board contains a LAN connector for communication with external devices, and interfaces with the SY-364
board.
MB-1124 Board
This board is the motherboard of this unit. It only contains connectors for plug-in boards for interface
wiring between them.
2-18 (E)
HSCU-300
2-10. Notes on Repair Parts

1. Safety Related Components Warning
w
Components marked ! are critical to safe operation. Therefore, specified parts should be used in the
case of replacement.
2. Standardization of Parts
Some repair parts supplied by Sony differ from those used for the unit. These are because of parts
commonality and improvement.
3. Stock of Parts
Parts marked with o at SP (Supply Code) column of the spare parts list may not be stocked. Therefore, the delivery date will be delayed.
4. Harness
Harnesses with no part number are not registered as spare parts.
2-11. Unleaded Solder

Boards requiring use of lead-free solder are printed with a lead free mark (LF) indicating the solder
contains no lead.
(Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular
size.)
: LEAD FREE MARK
m
. Be sure to use the lead-free solder for the printed circuit board printed with the lead free mark.
. The lead-free solder melts at a temperature about 40 dC higher than the ordinary solder, therefore, it is
recommended to use the soldering iron having a temperature regulator.
. The ordinary soldering iron can be used but the iron tip has to be applied to the solder joint for a slightly
longer time. The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so
be careful.
HSCU-300
2-19 (E)
Section 3
System Setup
3-1. System Connection
HD SDI/SD SDI
VBS
COMPONENT
(HD/SD)
SD analog
monitor
SD analog
waveform monitor
HSC-300*2
SYNC
VIDEO
PROMPTER (VBS)
TRIAX cable
HSCU-300
REFERENCE
(HD/SD)
RETURN VIDEO
RETURN VIDEO
RCP-700/900 series
HD SDI/SD SDI
HSC-300*2
HDLA1500 series
*1
VBS
LAN cable
HD SDI/SD SDI
VBS
COMPONENT
(HD/SD)
SD analog
monitor
SD analog
waveform monitor
SYNC
VIDEO
PROMPTER
(VBS)
TRIAX cable
HSCU-300
RCP-700/900 series
RETURN VIDEO
RETURN VIDEO
HD SDI/SD SDI*1
VBS
Hub
LAN cable
NEXT
HSCU-300
MSU-900/950
NEXT
HSCU-300
*1: The PROMPTER signals (HD SDI and SD SDI) can be input instead of the RETURN VIDEO signals (HD SDI and SD SDI) by the CCU menu setting.
*2: When the CCU is connected, the local power supply (EXT DC) on the camera side cannot be used. Be sure to use the CCU power supply.
HSCU-300
3-1 (E)
3-2. Audio System

3-2-1. Intercom System Setting
Two independent intercom lines (producer line and engineer line) are selectable and available in this unit.
This unit supports 4-wire, RTS, and Clear-Com (CC) intercom systems. Make settings of the internal
switches and menus according to the system to be used.
Selecting Intercom System
Select an intercom system (4W, RTS, or CC) for each of the engineer line and producer line according to
the system to be used.
n
When switches S530 and S531 are set to RTS (CC), be sure to connect the unit to the RTS or Clear-Com
system. Failure to do so will cause the output to oscillate and adversely affect the surrounding circuit.
Selecting Producer Line
1. Set S530 (PROD SEL) on the SY-364 board according to the system.
4-wire:
4W (factory setting)
RTS/Clear-Com: RTS (CC)
2. When RTS (CC) is selected, select RTS or Clear-Com with C06:SYSTEM INTERFACE of the CCU
menu.
Selecting Engineer Line
1. Set S531 (ENG SEL) on the SY-364 board according to the system.
4-wire:
4W (factory setting)
RTS/Clear-Com: RTS (CC)
2. When RTS (CC) is selected, select RTS or Clear-Com with C06:SYSTEM INTERFACE of the CCU
menu.
9
8
RTS (CC) 4W
4W
S531
RTS (CC)
S530
3
2
1
L
SY-364 BOARD (SIDE A)
3-2 (E)
HSCU-300
Adjusting RTS Cancellation (RTS/Clear-Com)

When the RTS or Clear-Com system is used, adjust the sidetone cancellation amount using the following
procedure.
1. Set the C07:SIDE TONE value of the CCU menu to 0.
2. Set the INCOM switch on the front panel to PROD.
3. While speaking to the headset microphone, adjust potentiometer RV530 (PROD RTS CANCEL) on
the SY-364 board so that the voice heard from the headset becomes minimum.
4. Set the INCOM switch on the front panel to ENG.
5. While speaking to the headset microphone, adjust potentiometer RV531 (ENG RTS CANCEL) on the
SY-364 board so that the voice heard from the headset becomes minimum.
6. Re-set the C07:SIDE TONE value of the CCU menu to the previous value or a desired value.
9
8
RV531 1 5
RV530 1
4
3
2
1
L
Setting PGM Audio Signal Input Level

Set the PGM audio signals (PGM1 and PGM2) with C06:PGM1, 2 LEVEL according to each signal level.
_20 dBu, 0 dBu, or +4 dBu (factory setting: 0 dBu)
Setting Headset Microphone
1. Set C07:INCOM MIC of the CCU menu according to the microphone type of the headset to be
connected to the front INTERCOM connector.
Carbon microphone:
CARBON (_20 dBu, power supplied)
Condenser microphone: ECM (_40 dBu, power supplied)
Dynamic microphone: DYNAMIC (_60 dB, no power supplied) (factory setting)
2. Set C07:MIC TYPE of the CCU menu according to the microphone of the headset to be connected to
the front INTERCOM connector.
BALANCE:
Balanced microphone
UNBALANCE: Unbalanced microphone (factory setting)
Adjusting Sidetone Volume (4-Wire)
Adjust the sidetone volume of the headset connected to the front INTERCOM connector with C07:SIDE
TONE of the CCU menu according to the headset to be used. Too high volume of the sidetone may cause
howling.
HSCU-300
3-3 (E)
Selecting PGM Audio Signal

Select the PGM audio signal of the headset connected to the front INTERCOM connector to a desired
level with C07: PGM SEL of the CCU menu.
To select PGM1:
PGM1 (factory setting)
To select PGM2:
PGM 2
To select PGM1 and PGM2 mixed: PGM1+PGM2
Headset output selection
C07:PGM MIX (CCU menu)
INCOM + PGM
ON
MIC/PGM switch
OFF
PGM
Intercom + PGM
OFF
L-INCOM/R-PGM
Intercom
Left: Intercom
Right: PGM
PGM
Adjusting PGM Audio Signal Mixing Volume

Adjust the PGM audio signal mixing volume of the headset connected to the front INTERCOM connector
to a desired level with C07:PGM1 LVL, PGM2 LVL of the CCU menu.
Selecting Intercom Line to Be Connected to the INTERCOM Connector
Select the intercom line to be connected to the front INTERCOM connector as follows with the INTERCOM switch.
Producer line:
PROD
Engineer line:
ENG
Communication only between CCU and camera: PRIV
3-4 (E)
HSCU-300
Intercom Signal Flow

INTERCOM/TALLY/
PGM connector
Producer line
Talk
Receive
X !'
Y !,
X !]
Y !\
G !;
SY-364 board
S530
PROD
Talk
Receive
X4
Y5
X1
Y2
G3
S531
ENG
4W/RTS (CC)
PROD
PRIV
4W/RTS (CC)
SY-364 board
Engineer line
Front panel
INTERCOM switch
Front panel
INTERCOM switch
ENG
PRIV
CCU menu
C06: PGM1 LEVEL
Program line 1
X6
Y7
G8
PGM1
-20/0/+4dBu
CCU menu
Program line 2
X !.
Y @/
G @-
C06: PGM2 LEVEL

PGM2
-20/0/+4dBu
CCU menu
C07: PGM SEL
CCU menu
C07: PGM1, 2 LVL
INTERCOM connector
HSCU-300
3-5 (E)
3-2-2. Microphone Setting

This unit can receive two independent microphone lines (MIC1 and MIC2) from the camera and output
them.
Remote Controlling Microphone Input Amplifier Gain
Remote Control Using the CCU Menu
When the MIC REMOTE connector on the rear panel is open or pins 8 and 15 of the MIC REMOTE
connector are at a high level, set the gain with C05:CAM MIC GAIN of the CCU menu.
20 dB, 30 dB, 40 dB, 50 dB, or 60 dB (factory setting: 60 dB)
Remote Control from the MIC REMOTE Connector
The microphone input amplifier gain control is enabled or disabled by pins 8 and 15 of the MIC REMOTE
connector on the rear panel. The microphone input amplifier gain can be set by pins 5 to 7 of the MIC
REMOTE connector.
Pin
8
15
Connector
MIC IN CH-1
MIC IN CH-2
ON
ON
ON
OFF
OFF
ON
Set with C05:CAM MIC GAIN
Pin
7
60 dB
50 dB
40 dB
30 dB
20 dB
Gain
H: +5V or open
L: GND
Input resistance: 100 kZ (+5 V pull-up)
Adjusting MIC Phase

Adjust the microphone signal phase with C05:MIC OUT DELAY of the CCU menu according to the
system to be used.
0 to 3328 FS (factory setting: 0 FS)
Setting MIC Output Level
Set the MIC outputs (MIC1 and MIC2) with C05:MIC1, 2 LEVEL according to each signal level.
_20 dB, or 0 dB (factory setting: 0 dB)
3-6 (E)
HSCU-300
3-3. System Settings

3-3-1. Tally System Setting
This unit supports red tally and green tally systems, and also supports contact supply and power voltage
supply (24 V/TTL). Set the switches on the SY-364 board according to the tally system to be used.
9
R-TALLY
S730 S733
POWER
TTL
CONTACT
POWER
6
S731 S734
G-TALLY
3
2
1
L

Switch
Red tally
S730
S733
Green tally
S731
S734
Contact supply (factory setting)
CONTACT
CONTACT
24 V supply
POWER
POWER
POWER
POWER
5 V supply
POWER
TTL
POWER
TTL
3-3-2. Camera Number Setting

Systems that do not use CNU-700
Set the camera number with N03:CCU NO of the NETWORK SETTINGS menu.
Systems that use CNU-700
The number of the CCU connector on the CNU-700 rear panel is the camera number.
For example, the camera of the CCU connected to the CCU1 connector is camera number 1.
1 HSC-300
1 HSCU-300
CNU-700
REMOTE
CCU1
CCU2
RCP1
2 HSC-300
HDLA1500 series
RCP2
CCU/CNU
CCU/CNU
2 HSCU-300
REMOTE
1 RCP-700/900
series
HSCU-300
2 RCP-700/900
series
3-7 (E)
3-4. Video Signal System

Video signals of this unit and the equipment used for a camera system were adjusted to the specified
levels in the factory shipping process.
Before starting operation, check the signal levels between equipment and adjust them, if necessary.
3-4-1. Input/Output Signal Selection

Select a signal of the input/output connector on the rear panel according to the video system to be implemented.
3-4-2. Signal Phase Adjustment

Adjust signal phases of the unit.
Before starting this adjustment, input the following sync signals to the unit and equipment used.
REFERENCE connector
Input the HD tri-level sync signal or black burst signal.
HD tri-level sync signal: 0.6 Vp-p
Black burst signal:
40 IRE (0.3 Vp-p)
Adjusting Sync Signal Phase
Adjust the sync signal phase with S02:GENLOCK PHASE of the SYSTEM OPERATION menu so that
the output signal phase matches the phase of the reference signal. The phase can also be adjusted using
the maintenance menu of MSU-900/950.
3-8 (E)
HSCU-300
3-4-3. Aspect Ratio Setting for Down-Conversion

With this unit or MSU-900/950, this system enables switching of aspect ratio in accordance with various
systems for the HD-SD down-conversion.
Set the aspect ratio with the MIC REMOTE connector on the rear panel or with S05:SD ASPECT of the
SYSTEM OPERATION menu. It can also be set using the maintenance menu of MSU-900/950.
The following four aspect ratio modes are selectable in this system.
Squeeze
Converts the HD video signal to SD signal with an aspect ratio of 16 : 9 unchanged (16 : 9)
Edge crop
Crops 4 : 3 video part from the HD video signal and converts it to SD signal (4 : 3)
Letterbox
Fits the HD video signal with an aspect ratio of 16 : 9 into a 4 : 3 monitor frame and converts it to SD signal (4 : 3)
(Black level is inserted above and below the picture.)
Semi-letterbox
Crops 15 : 9 (or 14 : 9 or 13 : 9) video part from the HD video signal, fits it into a 4 : 3
monitor frame, and then converts it to SD signal (4 : 3)
(Black level is inserted above and below the picture.)
Setting Aspect Ratio with the MIC REMOTE Connector

1. Set pin 12 of the MIC REMOTE connector on the rear panel to low level.
2. Set pins 13 and 14 of the MIC REMOTE connector according to the aspect ratio to be converted.
Pin 13
(ASPECT CTRL1)
Pin 14
(ASPECT CTRL2)
Aspect ratio
Squeeze (16 : 9)
Edge crop (4 : 3)
Set with S05:SD ASPECT of the SYSTEM OPERATION menu.
Letterbox (4 : 3)
HSCU-300
3-9 (E)
Examples of display
16 : 9 picture (picture from camera)
Letter box (16 : 9)

The 16 : 9 ratio picture is inserted into
the 4 : 3 ratio picture without changing
the ratio and is output in the SD format.
Horizontal cutting position of 16 : 9
Horizontal cutting position of
4 : 3 (12 : 9)
Picture whose aspect ratio is converted (SD output)
Semi-letter box (15 : 9)

The picture that is cut out with the
aspect ratio of 15 : 9, is inserted into
the 4 : 3 ratio picture and is output in
the SD format.
Edge-crop
CROP POSITION can be changed.
the SD format.
Squeeze
The 16 : 9 ratio picture is output in the
SD format without changing the ratio.

the SD format.
3-10 (E)
HSCU-300
3-4-4. VBS Signal Level Adjustment

Adjust the VBS signal level that is output from this unit using the color-bar signal.
Adjustment Procedure
Adjust the VBS signal level with VBS LEVEL of M05:ANALOG VIDEO2 in the MAINTENANCE
menu.
Equipment:
SD waveform monitor
Test Point:
VBS connector/SDI-97B board
Specification: A = 140 ?1 IRE (75 Z termination)
B = 1000 ?7 mV p-p (75 Z termination)
NTSC
PAL
3-4-5. Waveform Monitor Signal Level Adjustment

The video output signal of the unit can be checked using the waveform monitor connected to the WF
connector. Adjust the WF output signal level using the color-bar signal.
In a system using VCS-700, MSU-900/950 or CNU-700, the video output signal of the unit can also be
checked using the waveform/vector monitor connected to VCS-700.
WF Output Signal Level Adjustment Procedure
Adjust the WF output signal level with WF LEVEL of M05:ANALOG VIDEO2 in the MAINTENANCE
menu.
Equipment:
SD waveform monitor
Test Point:
WF connector/CN-3080B board
NTSC
PAL
HSCU-300
3-11 (E)
Adjustment Procedure Using VCS-700

In a system using VCS-700, MSU-900/950 or CNU-700, the video output signal of the unit can be
checked using the waveform/vector monitor connected to the WF A OUTPUT and WF B OUTPUT
connectors of VCS-700.
Connect this unit to VCS-700 as follows and adjust the video output signal using the color-bar signal.
HSCU-300
WF
WF1
PIX
PIX1
WF A
VCS-700
WF B
Waveform monitor
Vector monitor
1. Press the BARS button of the MSU-900/950 or RCP-750/751.

2. Press the ENC button of the WAVEFORM MONITOR button or MONITOR SELECT button to
display color-bars on the waveform/vector monitor.
3. Set the CONTROL switch of VCS-700 to RESET.
4. Adjust the color-bar signal level with the WFM 1 LEVEL and WFM 1 CHROMA controls of
VCS-700 so that the signal level falls within the specified range.
Test Point:
WF A, and WF B connectors/VCS-700
Specification: A = 140 ?1 IRE (WFM 1 LEVEL control)
B = 1000 ?7 mV p-p (WFM 1 LEVEL control)
NTSC
PAL
Each illuminated spot on the vector monitor shall fall within . (WFM 1 CHROMA control)
NTSC
PAL
MG
MG
YL
YL
B
G
3-12 (E)
CY
B
G
CY
HSCU-300
Adjustment Procedure Using MSU-900/950

The color-bar signal level can be adjusted using MSU-900/950 instead of the controls of VCS-700.
1. Press the MAINTENANCE button in the MODE area of MSU-900/950 to light the button.
The MAINTENANCE menu appears.
Maintenance Menu
Adjusting
CAM SW
Setting
Lens
Adjusting
VCS
Adjusting
Exit
Auto
Setup
SD
SuperMotion
Adjusting Setting
2. Press [VCS|Adjusting].
The VCS monitor level adjustment items are displayed.
Clear
Home
1
1
Monitor
Level
VCS Monitor Level
Low
Middle
High
100%
Character on
WF Level WF Chroma
3. Adjust the color-bar signal level with WF Level and WF Chroma so that the color-bar signal falls
within the specified range.
Test Point:
WF A, and WF B connectors/VCS-700
Specification: A = 140 ?1 IRE (WF Level)
B = 1000 ?7 mV p-p (WF Level)
NTSC
PAL
Each illuminated spot on the vector monitor shall fall within . (WF CHROMA)
NTSC
PAL
MG
MG
YL
YL
B
G
HSCU-300
CY
B
G
CY
3-13 (E)
3-4-6. Stair Case Signal Adjustment Procedure

Adjust the stair case signal to display signals in the sequential mode on the waveform monitor. Make this
adjustment when signals in the sequential mode are not displayed correctly on the waveform monitor.
When the waveform monitor is connected to the unit, adjust the stair case signal with potentiometers
RV2601 and RV2602 on the DPR-300 board. When the unit is connected to VCS-700, refer to the
VCS-700 maintenance manual.
G
A
1
LEVEL (Interval)
RV2602 1 2
RV2601 1
DC (Position) 3
5
6
DPR-300 BOARD (SIDE A)
1. Press the SEQ button of the WAVEFORM MONITOR button or MONITOR SELECT button of
MSU-900/950, RCP-750/751, etc.
2. Adjust the position of the signal to be displayed with potentiometer RV2601 on the DPR-300 board.
3. Adjust intervals A and B (shown in the figure below) of the signal to be displayed with potentiometer
RV2602 on the DPR-300 board, so that A and B are nearly equal.
When the SEQ button of the WAVEFORM MONITOR button or MONITOR SELECT button of
MSU-900/950, RCP-750/751, etc. is pressed, the waveform monitor control signal of the unit is output in
synchronization with the WF connector output signal.
3-14 (E)
HSCU-300
n
The sequential mode control varies with the waveform monitor used. Change the polarity of control by
the S2801 (SEQ) setting on the DPR-300 board as required.
If the stair case signal cannot be adjusted properly even by changing the polarity of control, adjust it on
the waveform monitor side.
G
A
1
PNP
NPN
3
S2801
4
5
6
3-4-7. Picture Monitor Signal Level Adjustment

The video output signal of the unit can be checked using the waveform monitor connected to the PIX
connector. Adjust the PIX output signal level using the color-bar signal.
In a system using VCS-700, MSU-900/950 or CNU-700, the video signal of the unit can be checked using
the waveform/vector monitor connected to VCS-700.
PIX Output Signal Level Adjustment Procedure
Adjust the PIX output signal level with WF LEVEL of M05:ANALOG VIDEO2 in the MAINTENANCE
menu.
Equipment:
SD waveform monitor
Test Point:
PIX connector/CN-3080B board
NTSC
PAL
HSCU-300
3-15 (E)
Adjustment Procedure Using VCS-700

In a system using VCS-700, MSU-900/950 or CNU-700, the video output signal of the unit can be
checked using the waveform/vector monitor connected to the PIX A OUTPUT and PIX B OUTPUT
connectors of VCS-700.
Connect this unit to VCS-700 as follows and adjust the video output signal using the color-bar signal.
HSCU-300
PIX A
VCS-700
PIX
PIX1
PIX B
Waveform monitor
Vector monitor
1. Press the BARS button of the MSU-900/950 or RCP-750/751.

2. Press the ENC button of the WAVEFORM MONITOR button or MONITOR SELECT button to
display color-bars on the waveform/vector monitor.
3. Set the CONTROL switch of VCS-700 to RESET.
4. Adjust the color-bar signal level with the PIX 1 LEVEL and PIX 1 CHROMA controls of VCS-700
so that the signal level falls within the specified range.
Test Point:
PIX A, and PIX B connectors/VCS-700
Specification: A = 140 ?1 IRE (PIX 1 LEVEL control)
B = 1000 ?7 mV p-p (PIX 1 LEVEL control)
NTSC
PAL
Each illuminated spot on the vector monitor shall fall within . (PIX 1 CHROMA control)
NTSC
PAL
MG
MG
YL
YL
B
G
CY
B
G
CY
3-4-8. RETURN Input Signal

Set the format of the return signal to be input to the RETURN INPUT connector (SDI 1/3, 2/4 and VBS
1/3, 2/4) using the maintenance menu of MSU-900/950 or S06:RETURN FORMAT in the SYSTEM
OPERATION menu of the unit.
3-16 (E)
HSCU-300
Section 4
Maintenance Mode
This unit can display the status of this unit and entire system on the video monitor connected to the PIX
connector to check and change settings
4-1. Preparations
4-1-1. Starting/Exiting the Maintenance Mode
Starting
1. When the status screen or menu screen is displayed, hide the screen.
. When the status screen is displayed, turn the DISP/MENU lever to the DISP side once.
. When the menu screen is displayed, turn the DISP/MENU lever to the MENU side once.
2. While pressing the CONTROL knob, turn the CANCEL/ENTER lever quickly to the ENTER side twice.
3. Turn the DISP/MENU lever to the MENU side within two seconds.
DISP/MENU lever
CANCEL/ENTER lever
CONTROL knob
(Rotary encoder)
4. Check that the following screen appears. If it does not appear, repeat steps 1 to 3.
$ $ 6 .&/6
D 4:45&.01&3"5*0/
$ $ 6 $ 0/'*(63"5*0/
/ & 5 8 0 3,4&55*/(4
7 & 0 1 &3"5*0/
. " * / 5 &/"/$&
Exiting
1. When the status screen or menu screen is displayed, hide the screen.
2. Turn the CANCEL/ENTER lever quickly to the CANCEL side twice.
Changing Setting Values
To enter:
To cancel:
Press the CONTROL knob.

Turn the CANCEL/ENTER lever to the CANCEL side before pressing the CONTROL
knob. The setting of the selected item is restored.
To suspend: Turn the DISP/MENU lever to the MENU. The menu disappears.
To restart the setting operation, turn the DISP/MENU lever again to the MENU side.
4-1-2. Memory Stick

The following types of Memory Stick are available for this unit.
. Memory Stick
. Memory Stick PRO (Up to 2 GB)
HSCU-300
4-1 (E)
4-2. VE OPERATION Menu

V01: REFERENCE
Menu screen
<REFERENCE>
V01
TOP
STORE FILE
STANDARD
ALL PRESET
READ (MS CAM)
WRITE(CAMMS )
M.S FORMAT
FILE ID :
CAM CODE:
DATE
Item
Description
STORE FILE
Registers the current values of the VE OPERATION menu and MAINTENANCE menu as
reference.
STANDARD
Calls the registered standard state.
ALL PRESET
Restores the factory settings.
READ (MSCAM)
Reads the reference file from the memory stick

and transfers it to the camera.
WRITE (CAMMS)
Writes the reference file stored in the camera

to the memory stick.
M.S FORMAT
Formats the memory stick.
FILE ID
Displays and edits the comment information of

the reference file stored in the memory stick.
CAM CODE
Model name information of the reference file

stored in the memory stick.
DATA
Reference file save date information stored in

the memory stick.
Item
Description
STORE FILE
Registers the current adjustment values as a

lens file selected with No. (1 to 16).
No.
Selects a file corresponding to the mounted

lens from the lens file (16 types).
NAME
Displays and edits the lens name selected with

No. (1 to 16).
Item
Description
STORE FILE
Registers the current adjustment values as an

OHB file.
V02: LENS FILE

Menu screen
<LENS FILE>
V02
TOP
STORE FILE
No. :
1
NAME: A10x4.8
V03: OHB FILE

Menu screen
<OHB FILE>
STORE FILE
4-2 (E)
V03
TOP
HSCU-300
V04: SCENE FILE

Menu screen
<SCENE FILE>
1
V04
TOP
Item
Description
1 to 5, STORE
When STORE operation is not used:

Call the relevant scene file using the file
number selection menu.
After that, the indication of STORE is
highlighted.
To cancel the call, select the file number
again.
When STORE operation is used:
Place the cursor at STORE and turn the
CANCEL/ENTER lever to the ENTER side.
A message STORE NO? appears and the
indication of STORE is highlighted.
Save the relevant scene file using the file
number selection menu.
STANDARD
Calls the registered reference file.
READ (MSCAM)
Reads the scene file from the memory stick

and transfers it to the camera.
WRITE (CAMMS)
Acquires the scene file stored in the camera

using the file transfer, and writes it to the
memory stick.
FILE ID
Comment information of the reference file

It can be edited from the menu.
CAM CODE
Model name information of the scene file

DATE
Scene file save date information stored in the

memory stick.
Item
Setting
WHITE R/G/B
?99
BLACK R/G/B/M
?99
FLARE R/G/B
?99
GAMMA R/G/B/M
?99
V MOD R/G/B/M
?99
FLARE
ON/OFF
STORE
STANDARD
MEMORY STICK
READ (MS CAM)
WRITE(CAMMS )
FILE ID:
CAM CODE
DATE
V05: VIDEO LEVEL

Menu screen
<VIDEO LEVEL>
WHITE
BLACK
FLARE
GAMMA
V MOD
FLARE
V MOD
TEST
HSCU-300
:
:
:
:
:
V05
TOP
[R] [G] [B] [M]

0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
:
ON
:
ON D.SHAD: OFF
: OFF
V MOD
ON/OFF
D.SHAD
ON/OFF
TEST
OFF/1/2
4-3 (E)
V06: GAMMA
Menu screen
Item
<GAMMA>
LEVEL
V06
TOP
[R] [G] [B] [M]

:
0
0
0
0
COARSE
: 0.45
GAMMA TYPE: 5
: BVW-400
GAMMA
TEST
Setting
LEVEL R/G/B/M
?99
COARSE
0.90 to 0.35
GAMMA TYPE
0 to 8
:
ON
: OFF
Type
Name
----
x3.5
x4.5
CAMCORDER
x5.0
BVW-400
SMPTE-240M
ITU-R709
FILM
GAMMA
ON/OFF
TEST
OFF/1/2
Item
Setting
LEVEL
?99
RANGE
LOW/MID L/MID H/HIGH

ON/OFF
Item
Setting
K POINT R/G/B/M
?99
K SLOPE R/G/B/M
?99
KNEE
ON/OFF
KNEE MAX
ON/OFF
KNEE SAT
?99
ON/OFF
V07: BLACK GAMMA

Menu screen
<BLACK GAMMA>
LEVEL
RANGE
V07
TOP
:
0
: HIGH
: OFF
V08: KNEE
Menu screen
<KNEE>
K POINT:
K SLOPE:
KNEE
KNEE MAX
KNEE SAT
V08
[R] [G] [B] [M]

0
0
0
0
0
0
0
0
:
ON
: OFF
:
0 : OFF
AUTO KNEE
: OFF
POINT LIMIT:
0
SLOPE
:
0
4-4 (E)
TOP
AUTO KNEE
OFF/AUTO
POINT LIMIT
?99
SLOPE
?99
HSCU-300
V09: WHITE CLIP

Menu screen
<WHITE CLIP>
V09
TOP
Item
Setting
W-CLIP R/G/B/M
?99
ON/OFF
Item
Setting
MATRIX R-G/R-B
?99
MATRIX G-R/G-B
?99
MATRIX B-R/B-G
?99
[R] [G] [B] [M]

W-CLIP :
0
0
0
0
:
ON
V10: USER MATRIX

Menu screen
<USER MATRIX>
R
G
B
:
:
:
[-R]
-0
0
V10
[-G]
0
-0
TOP
[-B]
0
0
--
MATRIX
: OFF
PRESET
: --USER MATRIX : ---
MATRIX
ON/OFF
PRESET
ON/OFF
USER MATRIX
ON/OFF
V11: MULTI MATRIX

Menu screen
<MULTI MATRIX>
PHASE :
HUE
:
SAT
:
V11
TOP
Item
Setting
Description
PHASE
0, 23, 45, 68, 90, 113,

135, 158, 180, 203,
225, 248, 270, 293,
315, 338
Selects an angle (from 16

angles) that varies the
multi-matrix correction
function.
HUE
?99
Adjusts the multi-matrix

correction value of hue for
each PHASE (16 angles).
SAT
?99
Adjusts the multi-matrix

correction value of saturation for each PHASE (16
angles).
0
0
0
ALL CLEAR
MATRIX
: OFF
PRESET
: --MULTI MATRIX: ---
ALL CLEAR
HSCU-300
Clears HUE and SAT of all

16 angles to 0.
MATRIX
ON/OFF
PRESET
ON/OFF
MULTI MATRIX
ON/OFF
4-5 (E)
V12: DETAIL 1
Menu screen
<DETAIL 1>
V12
DETAIL
LEVEL
:
LIMITER [M] :
[WHT]:
[BLK]:
CRISP
:
LVL DEP
:
TOP
Item
Setting
DETAIL
ON/OFF
?99
LEVEL
ON
LIMITER
0
0
0
0
0
0 :
ON
[M]
?99
[WHT]
?99
[BLK]
?99
CRISP
?99
LEVEL DEP
?99
ON/OFF
Item
Setting
H/V RATIO
?99
FREQ
?99
MIX RATIO
?99
FINE DTL
?99
ON/OFF
KNEE APT
?99
ON/OFF
DTL COMB
?99
V13: DETAIL 2
Menu screen
<DETAIL 2>
H/V RATIO
FREQ
MIX RATIO
FINE DTL
KNEE APT
DTL COMB
V13
:
:
:
:
:
:
TOP
0
0
0
0 : OFF
0 : OFF
0
V14: SKIN DETAIL

This unit controls only channel [1].
Menu screen
<SKIN DETAIL>
V14
TOP
SKIN DTL : OFF

SKIN GATE: OFF
CH SW
HUE
PHASE
WIDTH
SAT
LEVEL
4-6 (E)
:
:
:
:
:
:
[1]
(ON)
AUTO
0
29
-89
0
[2]
OFF
AUTO
0
29
-89
0
[3]
OFF
AUTO
0
29
-89
0
Item
Setting
SKIN DTL
ON/OFF
SKIN GATE
ON/OFF
CH SW 1/2/3
ON/OFF
HUE 1/2/3
Description
Place the cursor at AUTO and

turn the CANCEL/ENTER lever
to the ENTER side. A message
AUTO HUE1:STANDBY appears and the cursor changes to
?. When the CANCEL/ENTER
lever is turned to the ENTER side
again, AUTO HUE is executed.
PHASE 1/2/3
0, 359 to 270 to
180 to 90
WIDTH 1/2/3
?99
SAT 1/2/3
?99
LEVEL 1/2/3
?99
The setting value decreases

when the rotary encoder is
rotated clockwise.
HSCU-300
V15: SHUTTER
Menu screen
<SHUTTER>
V15
TOP
SHUTTER : OFF
: 1/100
ECS FREQ: 60.00Hz
EVS
Item
Setting
SHUTTER
(SPEED)
ON/OFF
1/100 1/125 ... 1/2000 ECS 1/100
ECS FREQ
EVS
: OFF
ON/OFF
V16: LOW KEY SAT

Menu screen
<LOW KEY SAT>
LEVEL
RANGE
TEST
V16
TOP
:
0
: HIGH
: OFF
Item
Setting
LEVEL
?99
RANGE
LOW/MID L/MID H/HIGH

ON/OFF
TEST
OFF/1/2
Item
Setting
SUPPRESSION
?99
ON/OFF
Item
Setting
M-GAMMA
?99
PEDESTAL R/G/B
?99
: OFF
V17: CROSS COLOR

Menu screen
<CROSS COLOR>
V17
TOP
SUPPRESSION :
0
: OFF
V18: SD GAMMA
Menu screen
<SD GAMMA>
M-GAMMA :
V18
[R]
PEDESTAL:
0
HSCU-300
TOP
0
[G]
0
[B]
0
4-7 (E)
V19: SD DETAIL 1
Menu screen
<SD DETAIL 1>
DETAIL
LEVEL
V19
:
:
ON
0
LIMITER[MST]:
[WHT]:
[BLK]:
0
0
0
CRISP
TOP
Item
Setting
DETAIL
ON/OFF
?99
LEVEL
LIMITER
[MST]
?99
[WHT]
?99
[BLK]
?99
CRISP
?99
Item
Setting
H-DETAIL FREQ
?99
H/V RATIO
?99
V-DTL MODE
H/V, V ONLY
DTL COMB
?99
LEVEL DEP
?99
LEVEL DEP GAIN
?99
Item
Setting
CCR
ON/OFF
CCR LEVEL
?99
CCR CORING
?99
Item
Setting
R-G/R-B
?99
G-R/G-B
?99
B-R/B-G
?99
MATRIX
ON/OFF
PRESET MATRIX
ON/OFF
USER MATRIX
ON/OFF
V20: SD DETAIL 2
Menu screen
<SD DETAIL 2>
V20
H-DETAIL FREQ
H/V RATIO
V-DTL MODE
DTL COMB
:
0
:
0
: H/V
:
0
LEVEL DEP
LEVEL DEP GAIN:
TOP
V21: SD CROSS COLOR

Menu screen
<SD CROSS COLOR>V21 TOP
CCR
: OFF
CCR LEVEL :
0
CCR CORING:
0
V22: SD USER MATRIX

Menu screen
<SD USER MATRIX>V22 TOP
[-R]
[-G]
[-B]
[R] : --- :
0 :
0
[G] :
0 : --- :
0
[B] :
0 :
0 : --MATRIX
: OFF
PRESET MATRIX: ON
USER MATRIX
: OFF
4-8 (E)
HSCU-300
V23: SD MULTI MATRIX

Menu screen
<SD MULT MATRIX>V23 TOP
PHASE
:
HUE
:
SATURATION :
Item
Setting
Description
PHASE
0, 23, 45, 68, 90,

113, 135, 158, 180,
203, 225, 248, 270,
293, 315, 338

angles) that varies the SD
multi-matrix correction
function.
HUE
?99
Adjusts the SD multi-matrix

correction value of hue for
each PHASE (16 angles).
SATURATION
?99
Adjusts the SD multi-matrix

correction value of saturation for each PHASE (16
angles).
0( 0)
0
0
ALL PRESET
MATRIX
: OFF
PRESET MATRIX: ON
MULTI MATRIX : OFF
ALL PRESET
MATRIX
ON/OFF
PRESET MATRIX
ON/OFF
MULTI MATRIX
ON/OFF
V24: BLACK SHADING

Menu screen
<BLACK SHADING> V24 TOP
[R] [G] [B] [M]
V SAW
:
0
0
0
V PARA :
0
0
0
H SAW
:
0
0
0
H PARA :
0
0
0
BLK SET:
0
0
0
BLACK
:
0
0
0
0
MASTER GAIN:
0dB
AUTO BLACK SHADING
GAIN BOUNCE: OFF
Item
Setting
V SAW R/G/B
?99
V PARA R/G/B
?99
H SAW R/G/B
?99
H PARA R/G/B
?99
BLK SET R/G/B
?99
BLACK R/G/B/M
?99
MASTER GAIN
_3dB to +12dB
AUTO BLACK
SHADING
Description
To execute:
Place the cursor at AUTO
BLACK SHADING, and turn
the CANCEL/ENTER lever to
the ENTER side.
To cancel:
Turn the CANCEL/ENTER
lever to the ENTER side
during execution.
GAIN BOUNCE
HSCU-300
ON/OFF
4-9 (E)
V25: WHITE SHADING

Menu screen
<WHITE SHADING> V25 TOP
V SAW
V PARA
H SAW
H PARA
WHITE
:
:
:
:
:
[R] [G] [B]

0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
AUTO WHITE SHADING

WHITE SHAD MODE: RGB
Item
Setting
V SAW R/G/B
?99
V PARA R/G/B
?99
H SAW R/G/B
?99
H PARA R/G/B
?99
WHITE R/G/B
?99
AUTO WHITE
SHADING
Description
To execute:
Place the cursor at AUTO
WHITE SHADING and turn
the CANCEL/ENTER lever to
the ENTER side.
To cancel:
Turn the CANCEL/ENTER
lever to the ENTER side
during execution.
WHITE SHAD
MODE
RB/RGB
V26: AUTO IRIS

Menu screen
Item
<AUTO IRIS>
WINDOW
V26
TOP
: 1
IRIS LEVEL:
APL RATIO :
IRIS GAIN :
0
65
0
Setting
WINDOW
1 to 6
IRIS LEVEL
?99
APL RATIO
?99
IRIS GAIN
?99
AUTO IRIS
ON/OFF
AUTO IRIS : OFF
V27: OHB MATRIX

Menu screen
<OHB MATRIX>
R
G
B
:
:
:
[-R]
-0
0
PHASE :
HUE
:
SAT
:
V27
[-G]
0
-0
0
0
0
TOP
[-B]
0
0
--
Item
Setting
R-G/R-B
?99
G-R/G-B
?99
B-R/B-G
?99
PHASE
0, 23, 45, 68, 90, 113,

135, 158, 180, 203,
225, 248, 270, 293,
315, 338

angles) that varies the
OHB matrix correction
function.
HUE
?99
Adjust the OHB multimatrix correction value of

hue for each PHASE (16
angles).
SAT
?99
Adjusts the OHB multimatrix correction value of

saturation for each PHASE
(16 angles).
OHB MATRIX
ON/OFF
OHB MATRIX: OFF
4-10 (E)
Description
HSCU-300
V28: OTHERS
Menu screen
<OTHERS>
V28
V DTL CREATION
DTL H/V MODE
: Y
: H/V
TOP
WHITE SETUP MODE: A.LVL

WHITE GAMMA RGB : OFF
Item
Setting
V DTL CREATION
NAM/G/R+G/Y
DTL H/V MODE
H/V, V ONLY
WHITE SETUP MODE
A.LVL/RGB
WHITE GAMMA RGB
ON/OFF
V29: AUTO SETUP

Menu screen
Item
<AUTO SETUP>
V29 TOP
Auto Message
AUTO BLACK
AUTO WHITE
AUTO LEVEL
AUTO WHITE SHADING
AUTO BLACK SHADING
TEST
: OFF
Setting
AUTO BLACK
To execute:
Place the cursor at the item to
be adjusted.
Turn the CANCEL/ENTER lever
to the ENTER side.
To cancel:
Turn the CANCEL/ENTER lever
to the ENTER side during
execution.
AUTO WHITE
AUTO LEVEL
AUTO WHITE
SHADING
AUTO BLACK
SHADING
TEST
Description
OFF/1/2
The following messages are displayed in the shaded Auto Message.

Adjustment
item
Preparation
for execution
During execution
Normal end
Abnormal end
Cancel
AUTO BLACK _
ABB:EXECUTING
ABB:OK
ABB:NG
ABB:BREAK
AUTO WHITE
AWB:EXECUTING
AWB:OK
AWB:NG
AWB:BREAK
AUTO LEVEL
LEVEL AUTO:EXECUTING LEVEL AUTO:OK LEVELAUTO:NG LEVEL AUTO:BREAK
AUTO WHITE
SHADING
AWS:EXECUTING
AWS:OK
AWS:NG
AWS:BREAK
AUTO BLACK _
SHADING
ABS:EXECUTING
ABS:OK
ABS:NG
ABS:BREAK
V30: CCU VIDEO

Menu screen
<CCU VIDEO>
VBS CHROMA :
V30
ON
MONO COLOR : OFF

PHASE
:
0
SATURATION:
0
HSCU-300
TOP
Item
Setting
VBS CHROMA
ON/OFF
MONO COLOR
ON/OFF
PHASE
0, 359 to 270 to 180

to 90
SATURATION
?99
Description
The setting value decreases when the rotary encoder

is rotated clockwise.
4-11 (E)
4-3. MAINTENANCE Menu

M01: SERIAL NO SET
Menu screen
<SERIAL NO SET> M01 TOP
SERIAL NO:00000000
NAME: HSCU-300
DEST: SYL
WRITE
EDIT CANCEL
Item
Setting
Description
SERIAL NO
00000000 to
99999999
NAME
HSCU-300
DEST
SYL Common
J
Japan
CN China
UC United States
CE Europe
The setup information is stored in

the EEPROM (IC801) on the
SY-364 board.
To change the setup information,
set S801-1 (PROTECT) on the
SY-364 board to OFF.
TIMER-RESET
FACTORY-RECALL
WRITE
Writes the above setup information to

the EEPROM.
Place the cursor at WRITE and turn
the CANCEL/ENTER lever to the
ENTER side.
A message SERIAL NO WRITE OK?
appears.
Turn the CANCEL/ENTER lever to the
ENTER side again to perform the
processing.
EDIT CANCEL
Restores the setup information

during editing to the previous
information before editing.
Place the cursor at EDIT-CANCEL
and turn the CANCEL/ENTER lever
to the ENTER side.
A message EDIT DATA CANCEL
OK? appears.
Turn the CANCEL/ENTER lever to
the ENTER side again to perform
the processing.
TIMER-RESET
Resets the timer for displaying

power-on hours.
FACTORYRECALL
Resets all the setting values except

the following items to the factory
settings
. Media access control (MAC)
address
. Serial number
. Power-on hours display timer
. Setting values stored in the
EEPROM on the DPR-300 board
through the PLD.
Processing result indication

SettingItem
Normal end
Abnormal end
Description
WRITE
SERIAL NO WRITE OK
EEPROM WRITE PROTECTED
S801-1 (PROTECT) on the

SY-364 board is set to ON.
MODEL NAME IS WRONG
The NAME (model name) setting

is not correct.
DEST NAME IS WRONG
The DEST (destination) setting

is not correct.
SERIAL NO WRITE NG
Data cannot be written to the

EEPROM.
EDIT-CANCEL
4-12 (E)
EDIT DATA CANCEL OK
HSCU-300
M02: FIRMWARE UPDATE

Menu screen
Item
Description
<FirmwareUpdate>M02 TOP
BOOT
BOOT version information
BOOT
VERSION UP EXEC
Place the cursor at VERSION UP EXEC and

turn the CANCEL/ENTER lever to the ENTER
side.
A message UPDATE BOOT BLOCK ?
appears.
Turn the CANCEL/ENTER lever to the ENTER
side again to perform the processing.
LOADER
LOADER version information
MAIN
MAIN version information
VERSION UP EXEC
Place the cursor at VERSION UP EXEC and

turn the CANCEL/ENTER lever to the ENTER
side.
A message UPDATE MAIN BLOCK ? appears.
Turn the CANCEL/ENTER lever to the ENTER
side again to perform the processing.
:HSCU-300_BOOT
1.00
07.12.24
VERSION UP EXEC
LOADER:HSCU-300_LOADER
1.00
07.12.24
MAIN
:HSCU-300
1.00
07.12.24
VERSION UP EXEC
If an error is detected during memory stick read operation, any of the following messages is displayed.
. MS NOT FOUND:
Memory stick is not inserted.
. MS-FILE NOT FOUND: The target file is not found in the memory stick.
. MS-FILE SIZE ERR:
File size is not correct.
. MS-FILE READ ERR: Memory stick read error
M03: OTHERS
Menu screen
<OTHERS>
M03
TOP
GRAY LINE: OFF

DATE ON BARS
MIX OFF
V
1 H CENTER
RX WARNING
: ACTIVE
AUDIO 1KHz
: OFF
HSCU-300
Item
Setting
GRAY LINE
ON/OFF
DATE ON BARS MIX
ON/OFF
DATE ON BARS V
1 to 12
DATE ON BARS H
LEFT/CENTER/RIGHT
RX WARNING
ACTIVE/NON ACTIVE
AUDIO 1KHz
ON/OFF
4-13 (E)
M04: ANALOG VIDEO1

Analog component connector output cropping level adjustment. The setting values are stored in the
EEPROM on the DPR-300 board.
Menu screen
<ANALOG VIDEO1> M04 TOP
TRIM
Y/G-HD/SD :XX
B-HD/SD :XX
PB-HD/PAL:XX
PB-NTSC
:XX
R-HD/SD :XX
PR-HD/PAL:XX
PR-NTSC
:XX
ADJ
(80)
(80)
(80)
WRITE CLEAR
Item
Setting
Y/G-HD/SD TRIM
00h to FFh
Description
B-HD/SD TRIM
PB-HD/PAL TRIM
PB-NTSC TRIM
R-HD/SD TRIM
PR-HD/PAL TRIM
PR-NTSC TRIM
Y/G-HD/SD ADJ
00h to FFh
Only display
B-HD/SD ADJ
R-HD/SD ADJ
4-14 (E)
WRITE
Writes the above cropping setting

values to the EEPROM.
CLEAR
Clears the above adjustment values.
HSCU-300
M05: ANALOG VIDEO2

VBS/PIX/WF connector output cropping level adjustment. The setting values are stored in the EEPROM on
the DPR-300 board.
Menu screen
<ANALOG VIDEO2> M05 TOP
TRIM
VBS LEVEL :XX
PIX LEVEL :XX
WF
LEVEL :XX
ADJ
(80)
(80)
(80)
OFFSET ADJ:XX
F3 RSSI
:(1.900V)
WRITE CLEAR
Item
Setting
VBS LEVEL TRIM
00h to FFh
Description
PIX LEVEL TRIM

WF LEVEL TRIM
VBS LEVEL ADJ
00h to FFh
Only display
00h to FFh
Sets the cable length calculation

reference value (F3 RSSI).*
n
Do not usually change this value.
PIX LEVEL ADJ

WF LEVEL ADJ
OFFSET ADJ
F3 RSSI
Displays the cable length calculation

reference value (F3 RSSI).
WRITE
Writes the above setting values to the

EEPROM.
CLEAR
Clears the above adjustment values.
*: Setting the cable length calculation reference value (F3 RSSI)

n
Change this setting only when IC2402 on the DPR-300 is replaced.
Preparation
Connect the unit to the camera with the TRIAX cable.
Use either one of the following TRIAX cables.
. A 500-meter Fujikura 8.5 mm cable
. Cable with attenuation characteristics of 18.5 ?1 dB (at 26 MHz)
. Cable with attenuation characteristics of 38.5 ?2 dB (at 100 MHz)
Setting Procedure
1. Turn on the unit and the camera.
2. Open M05:ANALOG VIDEO2 of the MAINTENANCE menu.
3. Adjust the OFFSET ADJ value so that the F3 RSSI value becomes 1.900V.
4. Place the cursor at WRITE and write the adjustment value to the EEPROM.
HSCU-300
4-15 (E)
M06: OFDM MONITOR

Menu screen
<OFDM MONITOR>
F RSS STP AGC
1 2.6 U_L 0.66
2 2.6 U_L 0.66
3 2.6 Low 0.66
4 2.6 Mid 0.66
5 2.6 Hi
0.66
6 2.6 Hi
0.66
M_Gain:Low
R_Lev :-11dBm
Cable : 900m
4-16 (E)
M06
TOP
SNR
VITB
26.6 0210
26.6 0210
26.6 0210
26.6 0210
26.6 0210
26.6 0210
STEP:AUTO
RF:
DET
TEMP:47.7
Item
Description
F1
6 MHz
F2
16 MHz
F3
26 MHz
F4
46 MHz
F5
56 MHz
F6
66 MHz
RSS of F1 to F6
0.0 V to 3.3 V: Receive signal tuning output voltage
STP of F1 to F6
U_L/Low/Mid/Hi: Step gain amplifier operating status
AGC of F1 to F6
0.20 V to 3.27 V: AGC amplifier control voltage
SNR of F1 to F6
SN measurement value of the OFDM demodulation IC

input signal
VITB of F1 to F6
OFDM signal reception status
M_Gain
Low/Hi: Receiver amplifier gain of F4 to F6
STEP
AUTO (HOLD): Step gain switching operation setting

status of the step gain
amplifier(CXA3793R)
R_Lev
+10dBm/0dBm/_11dBm/_22dBm:
OFDM output level of F7 to F9
RF
NO/DET: RF signal detection status
Cable
Cable length (Fujikura 8.5-mm cable conversion

value)
TEMP
RF signal drive circuit ambient temperature
HSCU-300
Section 5
Replacement of Main Parts
5-1. Removing/Installing the
Front assembly
1. Loosen the five screws with stopper to
remove the front assembly.
Screws with stopper

Front assembly
2. Install the front assembly by reversing the

step above.
Screws with stopper
5-2. Replacing the DC Fan

PSW3 x 6
1. Remove the front assembly.

2. Remove the four screws of the rear panel
and the 11 screws of the top cover to detach
the top cover.
n
All these 15 screws are marked with .
PSW3 x 6
PSW3 x 6
Top cover
PSW3 x 6
HSCU-300
5-1 (E)
3. Disconnect the harness from the connector

CN9 on the CN-3081B board.
4. Remove the UL tape and release the harness from the harness clamp.
5. Remove the three screws and remove the
fan duct.
6. Remove the DC fan from the fan duct.
7. Remove the fan cushion from the DC fan.
DC fan
Label side
Fan cushion
PSW3 x 6
UL tape
Fan duct
8. Install a new DC fan by reversing the steps

above.
n
Carefully install the new DC fan confirming the orientation of the label side and the
harness shown in the figure.
Harness clamp
CN-3081B board
CN9
5-3. Removing/Installing the

Rear Panel Assembly
2 Remove the top cover.
3. Remove all the screws marked with on
the rear panel assembly.
. Screw (PSW3 x 6) x13
. Screw (P2.6 x 5) x6
. Hexagon screw x8
connector CN10 on the SDI-97B board.
n
Be careful not to bend the flexible card
wire. This shortens the wire life.
CN-3082 board
CN-3081B
board
CN8
CN10

CN3 on the CN-3082 board.
CN8 on the CN-3081B board, and remove
the rear panel assembly.
7. Install the removed parts by reversing the
steps above.
5-2 (E)
SDI-97B board
CN3
Rear panel assembly

Remove all the screws marked with
.
HSCU-300
5-4. Replacing the TRIAX connector assembly

2. Remove the top cover.
CN9 on the CN-3081B board, and release
the harness from the harness clamp.
OK
NG
PSW3 x 6
FL cover
4. Remove the three screws to detach the FL

cover.
CN1 on the FL-349 board.
6. Remove the four screws to remove the
TRIAX connector assembly.
7. Install a new TRIAX connector assembly
by reversing the steps above.
m
. When installing the new TRIAX connector assembly, be careful of the orientation
of the capacitor.
. Attach two claws to the FL cover as
shown in the figure.
HSCU-300
Capacitor
CN1
PSW3 x 6
FL-349 board
TRIAX connector assembly
PSW3 x 6
5-3 (E)
5-5. Replacing Boards

5-5-1. AU-321 Board/CN-3083 Board
n
4. Remove the two screws and draw the
intercom assembly in the arrow direction.
n
Do not pull the harness (AC IN) and the
flexible card wire strongly.
PSW3 x 6
Harness (AC IN)
Intercom assembly
CN1
SY-364 board

n
CN-3083 board
PSW3 x 6
CN2
PSW3 x 6
CN2
6. Remove the two screws (BVTP3 x 12) to

remove the CN-3083 board.
CN2 on the CN-3083 board.
8. Remove the four screws (PSW3 x 6) to
remove the AU-321 board.
CN2 on the AU-321 board.
n
5-4 (E)
AU-321 board
CN1
Flexible card wire
CN3
Incom panel
BVTP3 x 12
HSCU-300
11. Remove the screw to remove the tally

reflector.
12. Detach the rotary encoder knob.
PSW3 x 6
AU-321 board
Tally reflector
13. Install a new AU-321 board by reversing

the steps above.
Rotary encoder knob
5-5-2. CN-3080B Board

3. Remove the rear panel assembly.
4. Remove the two screws to remove the
CN-3080B board.
connector CN12 on the CN-3080B board.
n
Flexible card wire
CN-3080B board
CN12
PSW3 x 6
HSCU-300
5-5 (E)
6. Loosen the cable clamp and disconnect the

harnesses from the connectors CN3 and
CN5 on the CN-3080B board.
7. Remove the nut and disconnect the harness
(WF-REMOTE).
CN-3080B board
CN5
CN3
Cable clamp
Harness
(WF-REMOTE)
8. Install a new CN-3080B board by reversing

the steps above.
Nut
5-5-3. CN-3081B Board

4. Remove the SDI-97B board.
5. Remove the VIF-39 board.
6. Disconnect the harnesses from the connectors CN5, CN6, CN9, and CN10 on the
CN-3081B board.
connector CN7 on the CN-3081B board.
n
MB-1124 board
CN6
CN7
CN5
CN5
Remove the CN-3081B board from the

connector CN5 on the MB-1124 board.
9. Install a new CN-3081B board by reversing

the steps above.
5-6 (E)
CN10
CN9
CN-3081B board
HSCU-300
5-5-4. CN-3082 Board

CN-3082 board.
CN-3082 board
BVTP3 x 12
Rear panel assembly
5. Install a new CN-3082 board by reversing

the steps above.
5-5-5. CT-257 Board

The CT-257 board is not a spare part.
When replacing this board, replace the PS-739
board together with the CT-257 board.
HSCU-300
5-7 (E)
5-5-6. DPR-300 Board

2. Open the board lever and draw the
DPR-300 board by about 10 cm.
3. Disconnect the coaxial cable from the
connector CN3901 on the DPR-300 board.
n
Be sure to hold the plug when disconnecting the coaxial cable. Do not pull the cable.
4. Remove the DPR-300 board from the
chassis.
Coaxial cable
Board lever
CN3901
DPR-300 board
5. Remove the four screws to remove the two

DY-23 boards.
ENC-112 board.
NG Do not attempt to remove

by pulling the cable.
PSW2 x 5
DY-23 board
PSW2 x 5
DY-23 board
DPR-300 board
CN1800 CN900
PSW2 x 5
ENC-112
board
OK Hold the portion near
the connector and
remove the board
straight.
5-8 (E)
CN701
NG Do not remove
the board obliquely.
HSCU-300
7. Install a new DPR-300 board by reversing

the steps above.
m
. When installing the board, be careful not
to catch the coaxial cable.
. Arrange the route of the coaxial cable so
that it passes on the heatsink as shown in
the figure.
. Hold the plug of the coaxial cable, and
connect it perpendicularly to the connector.
Push the plug into the connector while
turning it clockwise and counterclockwise several times.
Coaxial cable route
Heatsink
Hold the plug to connect.
Connecting
connector
5-5-7. DY-23 Board

For how to replace the DY-23 board, refer to the
procedure in Section 5-5-6 DPR-300 Board.
5-5-8. ENC-112 Board

For how to replace the ENC-112 board, refer to
the procedure in Section 5-5-6 DPR-300
Board.
HSCU-300
5-9 (E)
5-5-9. FL-349 Board

CN9 on the CN-3081B board, and release
the harness from the harness clamp.
4. Remove the three screws to detach the FL
cover. (Refer to Section 5-4.)
5. Remove the two screws to detach the PS
cover.
n
When installing the PS cover, attach 10
claws to the PS cover as shown in the
figure.
CN2002 on the PS-739 board.
7. Unlock the two wire holders.
OK
NG
PSW3 x 6
FL cover
PS cover
PSW3 x 6
CN2002
PS-739 board
5-10 (E)
Wire holders
HSCU-300
8. Remove the clamp filter 1 from the FL

shield.
9. Disconnect the coaxial cable from the
connector CN2 on the FL-349 board, and
pull it out of the hole in the FL shield.
n
Be sure to hold the plug when disconnecting the coaxial cable. Do not pull the cable.
PSW3 x 6
FL-349 board
CN2
Clamp filter 2
FL shield
Coaxial cable
Clamp filter 1
10. Remove the TRIAX connector assembly.

11. Remove the three screws to remove the
FL-349 board.
12. Remove the clamp filter 2.
13. Install a new FL-349 board by reversing the

steps above.
n
Hold the plug of the coaxial cable, and
connect it perpendicularly to the connector.
Push the plug into the connector while turning it clockwise and counterclockwise
several times.
HSCU-300
NG Do not attempt to remove by

pulling the cable.
Hold the plug to connect.
Connecting
connector
5-11 (E)
5-5-10. MB-1124 Board

2. Remove the DPR-300 board.
3. Remove the SY-364 board.
6. Remove the SDI-97B board.
7. Remove the VIF-39 board.
8. Remove the CN-3081B board.
9. Remove the four screws to remove the
MB-1124 board.
MB-1124 board
PSW3 x 6
PSW3 x 6
Claws on the chassis
10. Install a new MB-1124 board by reversing

the steps above.
n
When installing the new MB-1124 board,
set it between the claws on the chassis and
tighten the screws.
5-12 (E)
HSCU-300
5-5-11. PS-739 Board

3. Remove the two screws to detach the PS
cover. (Refer to Section 5-5-9.)
4. Disconnect the harnesses from the connectors CN5006 and CN5007 on the CT-257
board.
5. Disconnect the harnesses from the connectors CN1, CN1004, and CN2002 on the
PS-739 board.
6. Unlock the three wire holders.
7. Remove the five screws to remove the
PS-739 board.
CN2002
PSW3 x 6
CN5006
PSW3 x 6
CN5007
CN1004
CT-257 board
Wire holders
PS-739
board
8. Install a new PS-739 board by reversing the

steps above.
HSCU-300
CN1
Wire holder
5-13 (E)
5-5-12. SDI-97B Board

4. Remove the SDI-97B board from the
connector CN1 on the MB-1124 board.
MB-1124 board
CN1
SDI-97B board
5. Install a new SDI-97B board by reversing

the steps above.
5-5-13. SY-364 Board

n
3. Open the board lever and draw the SY-364
board.
4. Install a new SY-364 board by reversing the
steps above.
m
. When installing the board, be careful not
to catch the flexible card wire.
. When the DPR-300 board was removed
and is installed, be careful not to catch
the coaxial cable.
5-14 (E)
Board lever
CN1
Flexible card wire
SY-364 board
HSCU-300
5-5-14. VIF-39 Board

4. Remove the VIF-39 board from connector
CN3 on the MB-1124 board.
CN4 on the VIF-39 board.
MB-1124 board
Harness
CN3
CN4
VIF-39 board
6. Install a new VIF-39 board by reversing the

steps above.
HSCU-300
5-15 (E)
Section 6
Electrical Alignment
6-1. Preparations
6-1-1. Equipment Required
.
.
.
.
.
.
.
SD waveform/vector monitor
Analog HD waveform monitor
Oscilloscope:
Tektronix TDS460A or equivalent
Frequency counter: Advantest TR5821AK or equivalent
Audio oscillator:
Tektronix SG-5010 or equivalent
Audio analyzer
FM signal generator: ROHDE & SCHWARZ SMHU58 or equivalent
Related equipment
. HD color camera HSC-300
. Master setup unit MSU-900/950
Tools
Sony Part No.
Name
Use
A-1727-365-A
A-1727-367-A
A-1727-368-A
A-1727-369-A
6-1-2. Precautions on Adjustments

.
.
.
.
.
Warm up the unit for about 10 minutes before starting adjustments.

All measuring equipment must have been calibrated.
Section 6-1-4. Initial Settings must have been completed.
Adjustments for HSC-300 must have been completed.
Adjustments of this unit are made by extended connection of each plug-in board. Be sure to turn off the
power before disconnecting the board.
HSCU-300
6-1 (E)
6-1-3. Connection of Equipment

Audio
oscillator
HD color camera
HSC-300
TRIAX cable *
HD camera control unit

HSCU-300
REFERENCE
/VIF-39
Signal
generator
Waveform
monitor
CCA-5 cable
(max. 200 m)
WF/PIX
/CN-3080B
75
Master setup unit

MSU-900/950
75
*: Transmittable cable attenuation: 3.6 to 64 dB (100 MHz)

n
When Fujikura 8.5 mm cable is used 50 to 900 m
6-1-4. Initial Settings

Make the following settings before starting adjustments.
After each adjustment is completed, be sure to restore the previous settings.
. CCU menu
C07: INCOM MIC
CARBON
. Front panel
INTERCOM switch
PROD
. SY-364 board
S530
RTS (CC)
S531
RTS (CC)
Except for these settings, do not change the switch settings made when the unit was shipped. (Refer to Section 1-5.)
6-2 (E)
HSCU-300
6-2. Audio System Adjustment

6-2-1. RTS Intercom Adjustment Check
Precautions
. This adjustment is described on condition that the audio oscillator output impedance is 600 Z.
. Potentiometers RV530 and RV531 on the SY-364 board have been adjusted according to the customers system. Check
this adjustment only when the system intercom output is repaired.
Preparation
. Extend the SY-364 board using an extended board.
. SY-364 board setting
S530
RTS (CC)
S531
RTS (CC)
. CCU menu setting
C06: ENGINEER
RTS
PRODUCER RTS
C07: INCOM MIC CARBON
9
8
RV531 1
RV530 1
TP530
TP531
S531
S530
1
L
Check (PROD CANCEL)

1. Set the INTERCOM switch on the front panel to
PROD.
2. Connect a 200-ohm resistor between pin e11 (CN1
side) and pin C10 of the extended board.
3. Input a sine wave (1 kHz, 220 mV p-p (_20 dBu)) to
pin 2 (X), pin 1 (Y), and pin 3 (G) of the INTERCOM
connector from the audio oscillator.
INTERCOM connector
(Front panel)
1
5
4
Audio oscillator
600
GND
4. PROD CANCEL check

Equipment:
Oscilloscope
Test Point:
TP531 (C-4) /SY364 board
Adjusting Point: 1RV530 (PROD RTS CANSEL)/
SY-364 board
Specification:
There must be a point where A becomes the minimum within the range (60 degrees) shown in the
figure.
HSCU-300
60
30 30
A
SY-364 board
6-3 (E)
Check (ENG CANCEL)

1. Set the INTERCOM switch on the front panel to ENG.
2. Connect a 200-ohm resistor between pin e10 (CN1
side) and pin C10 of the extended board.
3. Input a sine wave (1 kHz, 220 mV p-p (_20 dBu)) to
pin 2 (X), pin 1 (Y), and pin 3 (G) of the INTERCOM
connector from the audio oscillator.
INTERCOM connector
(Front panel)
1
5
4
Audio oscillator
600
GND
4. ENG CANCEL check

Equipment:
Oscilloscope
Test Point:
TP530 (C-4)/SY364 board
Adjusting Point: 1RV531 (ENG RTS CANSEL)/
SY-364 board
Specification:
There must be a point where B becomes the
minimum within the range (60 degrees) shown in
the figure.
60
30 30
B
SY-364 board
Setting after Adjustment

After this adjustment is completed, set the switch and CCU
menu to the previous state.
6-4 (E)
HSCU-300
6-3. Video/Reference Signal System

Adjustment
6-3-1. 27 MHz VCO Free-Running Adjustment
Preparation
. SYSTEM OPERATION menu
S02:GENLOCK
SD
. Extend the SY-364 board using an extended board.
. Disconnect the cable from the REFERENCE INPUT
connector on the rear panel.
. Connect the measuring equipment as shown in the figure.
. Start this adjustment after 10 minutes have elapsed from
power-on.
CH2
IN
Probe
CH2
OUT
IN
Frequency
counter
Oscilloscope
9
8
Adjustment
Equipment:
Test Point:
Adjusting Point:
Specification:
Frequency counter/Oscilloscope
TP4 (G-1)/SY-364 board
1RV1 (F-1)/SY-364 board
27,000,000 ?50 Hz
6
5
Setting after Adjustment
TP4 RV1
1
After this adjustment is completed, set the switch to the

previous state and reconnect the disconnected cable.
1
E
6-3-2. STAIR CASE Adjustment

Precautions
A
1
This adjustment is used tentatively when a repair is made.

This adjustment must be made again according to the
waveform monitor characteristics at the system setup.
RV2602 1 2
RV2601 1
TP262 3
Preparation
Extend the DPR-300 board using an extended board.

5
6
Adjustment
Equipment:
Oscilloscope
Test Point:
TP262 (A-3)/DPR-300 board
Adjusting Point: 1RV2602 (E-4)/DPR-300 board
1RV2601 (E-4) /DPR-300 board
Specification:
A = 4.0 ?0.5 V p-p (1RV2602)
B = 0 ?0.5 V dc (1RV2601)
HSCU-300
B
A
GND
6-5 (E)
6-4. SD Signal System Adjustment

6-4-1. VBS Output Level Adjustment
Preparation
CCU menu
C01: SD BAR
NTSC100% (NTSC)
PAL100% (PAL)
C10: VBS LEVEL
0
CHROMA 0
Adjustment
Equipment:
SD waveform monitor
Test Point:
VBS connector/SDI-97B board
Adjusting Point: MAINTENANCE menu
M05: VBS LEVEL
Specification:
A = 140 ?1 IRE (75 Z termination)
B = 1000 ?7 mV (75 Z termination)
NTSC
PAL
6-4-2. PIX Output Level Adjustment

Preparation
CCU menu
C01: SD BAR
C10:PIX LEVEL
CHROMA
NTSC100% (NTSC)
PAL100% (PAL)
0
0
Adjustment
Equipment:
SD waveform monitor
Test Point:
PIX connector/CN-3080B board
M05: PIX LEVEL
Specification:
6-6 (E)
NTSC
PAL
HSCU-300
6-4-3. WF Output Level Adjustment

Preparation
CCU menu
C01: SD BAR
NTSC100% (NTSC)
PAL100% (PAL)
C10:WF LEVEL
0
CHROMA 0
Adjustment
NTSC
Equipment:
SD waveform monitor
Test Point:
WF connector/CN-3080B board
M05: WF LEVEL
Specification:
HSCU-300
PAL
6-7 (E)
6-4-4. Y/R-Y/B-Y Output Level Adjustment

(SD)
Precautions
The Y/R-Y/B-Y output level adjustment (HD) must have
been completed. (Refer to Section 6-5-1.)
Preparation
S04: COMPONENT
SD YCD
. CCU menu
C01: SD BAR
FULL
C10: R/R-Y LEVEL
0
B/B-Y LEVEL
0
Adjustment
1. R-Y signal level adjustment
Equipment:
SD waveform monitor (NTSC)
Test Point:
R-Y connector/CN-3080B board
M04: PR-NTSC TRIM
Specification:
A = 756 ?5 mV (SET UP: OFF) (75 Z termination)
A = 700 ?5 mV (SET UP: ON) (75 Z termination)
2. B-Y signal level adjustment
Equipment:
SD waveform monitor (NTSC)
Test Point:
B-Y connector/CN-3080B board
M04: PB-NTSC TRIM
Specification:
B = 756 ?5 mV (SET UP: OFF) (75 Z termination)
B = 700 ?5 mV (SET UP: ON) (75 Z termination)
3. After these adjustments are completed, select WRITE

to store the setting values.
6-8 (E)
HSCU-300
6-5. HD Signal System Adjustment

6-5-1. Y/R-Y/B-Y Output Level Adjustment
(HD)
Preparation
S04: COMPONENT
HD YPbPr
. CCU menu
C01: HD BAR
BAR 16:9 (100%)
C10: G/Y LEVEL
0
R/R-Y LEVEL
0
B/B-Y LEVEL
0
Adjustment
1. Y signal level adjustment
Equipment:
Test Point:
Y connector/CN-3080B board
M04: Y/G-HD/SD TRIM
Specification:
A = 700 ?5 mV (75 Z termination)
2. R-Y signal level adjustment

Equipment:
Test Point:
Pr connector/CN-3080B board
M04: PR-HD/PAL TRIM
Specification:
3. B-Y signal level adjustment
Equipment:
Test Point:
Pb connector/CN-3080B board
M04: PB-HD/PAL TRIM
Specification:
C = 700 ?5 mV (75 Z termination)

HSCU-300
6-9 (E)
6-5-2. RGB Output Level Adjustment

Precaution
The Y/R-Y/B-Y output level adjustment (HD) must have
been completed. (Refer to Section 6-5-1.)
Preparation
S04: COMPONENT
HD RGB
. CCU menu
C10: R/R-Y LEVEL
0
B/B-Y LEVEL
0
Adjustment
1. R signal level adjustment
Equipment:
Test Point:
R connector/CN-3080B board
M04: R-HD/SD TRIM
Specification:
A = 700 ?5 mV p-p (75 Z termination)
(when 100% color-bar is used)
2. B signal level adjustment
Equipment:
Test Point:
B connector/CN-3080B board
M04: PB-HD/PAL TRIM
Specification:
(when 100% color-bar is used)

6-10 (E)
HSCU-300
6-6.
TRIAX Transmission System Adjustment
6-6-1. 1.0-MHz Modulation Circuit Adjustment

Frequency Adjustment
Preparation
. Disconnect the camera.
. If the camera is connected, turn off the CAMERA POWER switch on the inside panel.
Adjustment
Equipment:
Test Point:
Frequency counter
TP1501 (F-6)/DPR-300 board
GND: E1501 (F-6)/DPR-300 board
Adjusting Point: 1LV1501 (F-6)/DPR-300 board
Specification:
1000 ?5 kHz
Probe
CH2
IN
CH2
OUT
Oscilloscope
IN
Frequency
counter
Dev Adjustment
n
Before starting this adjustment, check that the TRIAX
transmission system adjustment of the camera has been
completed.
Preparation
. Connect the CCU to the camera with the TRIAX cable.
. Turn off the CAMERA POWER switch.
. CCU MAINTENANCE menu setting
M03: AUDIO 1 KHz ON
Adjustment
Equipment:
Test Point:
Oscilloscope
TP2 (A-3)/TX-126 board
(On the camera)
GND: E2 (A-2)/TX-126 board
(On the camera)
Adjusting Point: 1RV1501 (F-6)/TX-126 board
(On the camera)
Specification:
A = 220 ?10 mV p-p
HSCU-300
6-11 (E)
6-6-2. 1.4-MHz Demodulation Circuit Adjustment

Preparation
. Disconnect the coaxial cable from the connector CN3901
on the DPR-300 board, and then connect the FM signal
generator to CN3901.
. FM signal generator settings
Carrier frequency: 1.4 MHz
AF frequency:
1 kHz
Output level:
_15 dBm
Dev:
?3 kHz
Tuning Adjustment
1. Equipment:
Test Point:
Oscilloscope
TP1502 (E-6)/DPR-300 board
Adjusting Point: 1LV1502 (E-6)/DPR-300 board
Specification:
A = 1.3 ?0.2 V
A=1.3 ? 0.2 V
GND
2. Equipment:
Audio analyzer
(Unbalanced, high-impedance,
HPF: 400 Hz, LPF: 20 kHz)
Test Point:
Specification:
Minimize the distortion.
3. Equipment:
Audio analyzer
(Unbalanced, high-impedance,
HPF: 400 Hz, LPF: 20 kHz)
Test Point:
Specification:
Minimize the distortion.
4. Repeat steps 2 and 3 to minimize the output carrier

level.
Check that the distortion is 0.4% or less.
5. Check that the DC level A of terminal TP1502 on
the DPR-300 board is 1.3 ?1.0 V.
6-12 (E)
HSCU-300
Output Level Adjustment

n
Before starting this adjustment, check that the 1.4-MHz
demodulation circuit adjustment has been completed.
Adjustment
Equipment:
Test Point:
Oscilloscope
Specification:
B = 220 ?10 mV p-p
After the adjustment, disconnect the cable between connector CN3901 on the DPR-300 board and the FM signal
generator, and then connect the coaxial cable of the unit to
CN3901.
6-6-3. Tone Detection Frequency Adjustment

Frequency Adjustment
Preparation
. Disconnect the coaxial cable from the connector CN3901
(RF) on the DPR-300 board.
Adjustment
Probe
CH2
IN
CH2
OUT
Oscilloscope
IN
Frequency
counter
1. Equipment:
Test Point:
Frequency counter
TP1505 (F-6)/DPR-300 board
Specification:
16.38 ?0.10 kHz
2. After the adjustment, connect the coaxial cable to the

connector CN3901 (RF) on the DPR-300 board.
HSCU-300
6-13 (E)
Section 7
Spare Parts
7-1. Notes on Repair Parts
7-1.
1. Safety Related Components Warning

w
Components marked ! are critical to safe operation.
Therefore, specified parts should be used in the case of
replacement.
1.
!
!
2. Standardization of Parts
Some repair parts supplied by Sony differ from those
used for the unit. These are because of parts commonality and improvement.
Parts list has the present standardized repair parts.
2.
3. Stock of Parts
Parts marked with o at SP (Supply Code) column of
the spare parts list may not be stocked. Therefore, the
delivery date will be delayed.
4. Harness
Harnesses with no part number are not registered as
spare parts.
HSCU-300
3.
SPSupply code o
4.
7-1
Front Panel
7-2. Exploded Views
8
8
PSW3 x 10
2
8
7
4
BTP3 x 6
BTP3 x 6
PSW3 x 10
PSW3 x 6
No.
Part No.
SP Description
1
2
3
4
5
A-1729-094-A
A-1729-095-A
2-139-192-01
2-139-193-02
2-249-353-01
6
7
8
3-682-057-11 s SPACER (SMALL)

4-139-240-01 s FILTER
4-382-854-51 s SCREW (M3X6), P, SW (+)
s
s
s
s
s
FRONT PANEL ASSY(B)

RACK BRACKET ASSY 1.5U(B)
FRAME, INDICATOR WINDOW
WINDOW, INDICATOR
COVER, LAMP
7-682-947-01 s SCREW +PSW 3X6

7-682-949-01 s SCREW +PSW 3X10
7-685-545-14 s SCREW +BTP 3X6 TYPE2 N-S
7-2
HSCU-300
Front Boards
BVTP3 x 12
112
112
104
102
a
g
HARNESS
(INCOM)
BVTP3 x 12
111
b
109
112
112
110
103
110
103
106
110
101
112
105
112
108
107
No.
Part No.
101
102
103
104
105
A-1707-190-A
A-1707-198-A
A-1707-199-A
A-1707-203-A
A-1707-917-A
s
s
s
s
s
MOUNTED
MOUNTED
MOUNTED
MOUNTED
MOUNTED
A-1708-255-A
1-528-174-11
1-831-106-11
1-836-687-11
2-640-315-02
s
s
s
s
o
MOUNTED CIRCUIT BOARD, DPR-300

BATTERY, LITHIUM (CR2032 TYPE)
CABLE, FLEXIBLE FLAT (30 CORE)
CABLE, CONNECTOR WITH COAXIAL
SCREW (M2X5), SMALL, +P, SW
106
107
108
109
110
111
112
!
!
SP Description
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
BOARD,
BOARD,
BOARD,
BOARD,
BOARD,
SY-364
AU-321
DY-23
CN-3083
ENC-112
4-139-232-01 s KNOB, ROTARY ENCODER

4-382-854-51 s SCREW (M3X6), P, SW (+)
7-685-648-91 s SCREW +BVTP 3X12 TYPE2 TT(B)
HSCU-300
7-3
PS-739 Board, TRIAX Connector

216
216
216
j
h i
201
CT-257
BOARD
f
c b
210
216
205
213
d
HARNESS (PS)
216
216
208
216
213
213
216
214
216
UC
206
207
PSW4 x 8
215
209
216
HARNESS
(F-GND)
211
203
PSW
3 x 10
216
c
e
202
209
f
212
CE
204
209
No.
Part No.
201
202
203
204
205
A-1706-471-A
A-1707-005-A
A-1707-006-A
A-1707-007-A
A-1707-204-A
s
s
s
s
s
MOUNTED CIRCUIT BOARD, PS-739

TRIAX(UC)ASSY
TRIAX(J)ASSY
TRIAX(CE)ASSY
MOUNTED CIRCUIT BOARD, FL-349
211
212
213
214
215
1-251-378-12
1-469-241-11
1-481-530-31
1-500-082-21
1-500-459-11
s
s
s
s
s
INLET (WITH NOISE FILTER)

CORE, FERRITE (RFC-8 BK)
FILTER, CLAMP (FERRITE CORE)
CLAMP, SLEEVE FERRITE
FILTER, CLAMP (FERRITE CORE)
216
206
207
208
209
210
7-4
SP Description
No.
Part No.
!
!
1-787-419-12
1-966-632-11
2-433-598-01
2-990-241-02
4-139-239-01
SP Description
s
s
s
s
s
FAN, DC (60 SQUARE)

SUB HARNESS (AC IN)
HOLDER (LT-11U), WIRE
HOLDER (A), PLUG
FAN CUSHION
4-382-854-51 s SCREW (M3X6), P, SW (+)

7-682-949-01 s SCREW +PSW 3X10
7-682-961-01 s SCREW +PSW 4X8
HSCU-300
Rear Panel
301
HARNESS
(MIC)
307
310
HARNESS
(WF-REMOTE)
302
310
304
310
BVTP3 x 12
306
310
310
309
310
303
308
309
HARNESS (RCP)
h
HARNESS (UNREG)
i
k
HARNESS
(RCP-POWER)
HARNESS (CONTROL)
e
305
Note
1: These screws are accessories of
the connectors.
No.
Part No.
301
302
303
304
305
A-1707-195-A
A-1707-202-A
A-1707-206-A
A-1707-214-A
A-1707-215-A
s
s
s
s
s
MOUNTED
MOUNTED
MOUNTED
MOUNTED
MOUNTED
A-1707-216-A
1-833-470-21
1-836-690-11
3-637-901-02
4-382-854-51
s
s
s
s
s
MOUNTED CIRCUIT BOARD, SDI-97B

CABLE, FLEXIBLE FLAT (33P)
CABLE, FLEXIBLE FLAT (15 CORE)
SCREW M2.6X5
SCREW (M3X6), P, SW (+)
306
307
308
309
310
!
!
SP Description
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
BOARD,
BOARD,
BOARD,
BOARD,
BOARD,
MB-1124
CN-3082
VIF-39
CN-3080B
CN-3081B
7-685-648-91 s SCREW +BVTP 3X12 TYPE2 TT(B)
HSCU-300
7-5
7-3. Electrical Parts List

-----------AU-321 BOARD
-----------Ref. No.
or Qty Part No.
(AU-321 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
D2
D3
D4
D5
D6
6-502-598-01
6-502-598-01
6-501-358-01
6-501-358-01
6-501-358-01
s
s
s
s
s
DI SML-D12U8WT86
DI SML-D12U8WT86
DIODE CL-197HG5-CD-T
D7
D8
D10
D14
D18
6-501-358-01
6-501-358-01
6-502-598-01
6-502-598-01
6-502-197-01
s
s
s
s
s
DI SML-D12U8WT86
DI SML-D12U8WT86
DI SML-D12M8WT86SM
D20
6-502-197-01 s DI SML-D12M8WT86SM
CAP,CHIP CERAMIC 0.01MF B 1005

CAP, CHIP ELECT 22MF(6.3X5.7)
CAP, CERAMIC 0.1MF C (1005)
CAP, CHIP ELECT 47MF (6.3X5.7)
EN1
1-480-630-11 s ENCODER, ROTARY
FB1
FB2
FB3
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-469-094-21 s FERRITE, EMI (SMD) (1608)
1-469-094-21 s FERRITE, EMI (SMD) (1608)
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
IC1
IC3
8-759-422-21 s IC NJM4580V(TE2)
6-709-213-01 s IC NJM2387ADL3(TE2)
L1
1-457-217-21 o COMMON MODE CHOKE COIL
1-112-692-81
1-100-567-81
1-117-142-21
1-117-142-21
1-100-567-81
s
s
s
s
s
CAP,CHIP CERAMIC1000PF CH 1005

CAP, ELECT 0.22MF
CAP, ELECT 0.22MF
Q1
Q2
Q3
Q4
Q5
8-729-928-91
8-729-928-91
8-729-928-91
8-729-928-91
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
C27
C28
C29
C30
C31
1-126-396-21
1-100-567-81
1-100-567-81
1-126-396-21
1-100-567-81
s
s
s
s
s

Q7
Q8
Q9
Q11
Q12
8-729-928-91
8-729-928-25
8-729-928-05
8-729-928-91
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EE-TL
2SA1774TL-QR
2SC4617TL-QR
DTC114EE-TL
DTC114EE-TL
C32
C33
C34
C35
C36
1-100-567-81
1-100-567-81
1-100-567-81
1-114-214-81
1-114-214-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
Q13
Q14
Q15
Q16
Q17
8-729-928-05
8-729-928-91
8-729-231-96
8-729-231-96
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
DTC114EE-TL
2SK880GR-TE85L
2SK880GR-TE85L
DTC114EE-TL
C37
C38
C39
C40
C41
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
1-112-298-91
s
s
s
s
o
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1MF
Q18
Q19
8-729-928-91 s TRANSISTOR DTC114EE-TL

8-729-928-91 s TRANSISTOR DTC114EE-TL
C42
C43
C44
C45
C46
1-112-298-91
1-112-692-81
1-112-298-91
1-112-692-81
1-100-567-81
o
s
o
s
s
CAP, CERAMIC 1MF B (1608)

R1
R2
R3
R5
R8
1-208-879-81
1-208-895-81
1-208-879-81
1-208-895-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
2.2K (1005)
470 (1005)
2.2K (1005)
1.5K (1005)
C47
C51
C52
C53
C54
1-100-505-91
1-100-505-91
1-100-567-81
1-100-567-81
1-100-505-91
s
s
s
s
s

R9
R11
R12
R15
R16
1-208-895-81
1-208-891-81
1-208-891-81
1-208-891-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K
1.5K
1.5K
1.5K
1.5K
C55
C56
1-100-505-91 s CAP, CERAMIC 0.1MF C (1005)

1-100-505-91 s CAP, CERAMIC 0.1MF C (1005)
R17
R18
R24
R25
R26
1-208-891-81
1-208-891-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
1.5K (1005)
220 (1005)
220 (1005)
220 (1005)
CN1
CN2
CN3
1-785-840-31 s CONNECTOR, FFC/FPC(ZIF) AN 15P

1-770-625-21 s PIN, CONNECTOR 8P
D1
6-502-598-01 s DI SML-D12U8WT86
R27
R28
R29
R33
R34
1-208-935-81
1-208-935-81
1-208-919-81
1-208-863-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100K (1005)
22K (1005)
100 (1005)
2.2K (1005)
1pc
A-1707-198-A s MOUNTED CIRCUIT BOARD, AU-321
C1
C2
C3
C4
C5
1-100-567-81
1-100-567-81
1-112-298-91
1-100-567-81
1-100-567-81
s
s
o
s
s
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1MF
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
C6
C7
C8
C10
C11
1-100-505-91
1-100-505-91
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s

C12
C13
C14
C15
C16
1-100-567-81
1-126-400-21
1-100-567-81
1-100-505-91
1-126-396-21
s
s
s
s
s
C17
C18
C19
C20
C21
1-100-581-81
1-100-581-81
1-100-581-81
1-112-692-81
1-100-581-81
C22
C23
C24
C25
C26
7-6
0.01MF B
0.01MF B
B (1608)
0.01MF B
0.01MF B
1005
1005
1005
1005
CERAMIC0.0047MF B1005
CERAMIC1000PF CH 1005
CERAMIC 0.01MF B 1005

CERAMIC470PF CH1005
CERAMIC470PF CH1005
0.01MF B
0.01MF B
0.01MF B
0.01MF B
B (1608)
1005
1005
1005
1005
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
-------------CN-3080B BOARD
-------------Ref. No.
or Qty Part No.
(AU-321 BOARD)
Ref. No.
or Qty Part No.
SP Description
R35
R36
R37
R38
R39
1-208-919-81
1-208-895-81
1-208-895-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
2.2K (1005)
2.2K (1005)
22K (1005)
22K (1005)
R40
R41
R42
R44
R45
1-208-919-81
1-208-919-81
1-208-895-81
1-208-879-81
1-208-879-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
22K (1005)
2.2K (1005)
470 (1005)
470 (1005)
R46
R47
R48
R52
R53
1-208-879-81
1-208-879-81
1-208-895-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
470 (1005)
2.2K (1005)
10K (1005)
10K (1005)
R54
R55
R56
R57
R58
1-208-879-81
1-208-879-81
1-208-879-81
1-208-879-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
470 (1005)
470 (1005)
470 (1005)
100K (1005)
R59
R60
R61
R62
R63
1-208-935-81
1-208-871-81
1-208-871-81
1-220-882-81
1-220-882-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
220 (1005)
220 (1005)
33 (1005)
33 (1005)
R64
R65
R66
R67
R68
1-208-879-81
1-208-891-81
1-208-891-81
1-208-891-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
1.5K (1005)
1.5K (1005)
1.5K (1005)
1.5K (1005)
R69
R70
R71
R72
R73
1-208-891-81
1-208-891-81
1-208-863-81
1-208-879-81
1-220-882-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
1.5K (1005)
100 (1005)
470 (1005)
33 (1005)
R74
R75
R76
R77
R78
1-208-895-81
1-208-895-81
1-208-895-81
1-243-975-81
1-243-975-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K
2.2K
2.2K
4.7M
4.7M
R79
R80
R81
R82
R83
1-243-975-81
1-220-882-81
1-218-990-81
1-208-919-81
1-220-882-81
s
s
s
s
s
RES, CHIP 4.7M (1005)

RES, CHIP 33 (1005)
CONDUCTOR, CHIP (1005)
RES, CHIP 22K (1005)
RES, CHIP 33 (1005)
R84
R85
R86
1-208-891-81 s RES, CHIP 1.5K (1005)

1-208-879-81 s RES, CHIP 470 (1005)
1-208-911-81 s RES, CHIP 10K (1005)
RB1
RB2
1-234-374-21 s RES, NETWORK 470 (1005X4)

1-234-374-21 s RES, NETWORK 470 (1005X4)
RV1
1-238-255-21 s RES, VAR, CARBON 10K
S1
S2
S3
S4
1-762-531-21
1-762-531-21
1-762-123-21
1-762-123-21
HSCU-300
s
s
s
s
SWITCH,
SWITCH,
SWITCH,
SWITCH,
(1005)
(1005)
(1005)
(1005)
(1005)
SP Description
1pc
2pcs
A-1707-214-A s MOUNTED CIRCUIT BOARD, CN-3080B

4-674-315-01 s SCREW (M2.6X6)
C1
C2
C3
1-165-875-91 s CAP, CHIP CERAMIC 10MF B 3216

1-112-692-81 s CAP,CHIP CERAMIC1000PF CH 1005
CN1
CN2
CN3
CN4
CN5
1-561-336-41
1-561-336-41
1-770-160-21
1-766-696-11
1-764-089-21
s
s
s
o
o
CONNECTOR, COAXIAL
CONNECTOR, COAXIAL
PIN, CONNECTOR (PC BOARD) 2P
CONNECTOR, ROUND TYPE 8P
CN6
CN7
CN8
CN9
CN10
1-561-336-41
1-561-336-41
1-561-336-41
1-561-336-41
1-561-336-41
s
s
s
s
s
CONNECTOR,
CONNECTOR,
CONNECTOR,
CONNECTOR,
CONNECTOR,
CN11
CN12
1-561-336-41 s CONNECTOR, COAXIAL

1-820-785-11 s CONNECTOR, FFC/FPC (ZIF) 33P
D1
8-719-989-04 s DIODE DAN222-TL
FB1
1-469-094-21 s FERRITE, EMI (SMD) (1608)
FL1
FL2
FL3
FL4
FL5
1-239-897-31
1-239-897-31
1-239-897-31
1-239-897-31
1-239-897-31
L1
1-414-398-41 s INDUCTOR (SMD) 10.0UH
Q1
Q2
Q3
8-729-928-05 s TRANSISTOR 2SC4617TL-QR

8-729-928-25 s TRANSISTOR 2SA1774TL-QR
R1
R2
R3
R4
R5
1-216-864-91
1-208-927-81
1-208-927-81
1-208-927-81
1-220-870-81
s
s
s
s
s

RES, CHIP 10 (1005)
R6
R7
R8
R9
R12
1-220-870-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R13
1-208-927-81 s RES, CHIP 47K (1005)
RY1
1-755-380-21 s RELAY
s
s
s
s
s
FILTER,
FILTER,
FILTER,
FILTER,
FILTER,
COAXIAL
COAXIAL
COAXIAL
COAXIAL
COAXIAL
EMI
EMI
EMI
EMI
EMI
CHIP
CHIP
CHIP
CHIP
CHIP
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10 (1005)
47K (1005)
47K (1005)
47K (1005)
4.7K (1005)
TOGGLE
TOGGLE
TOGGLE
TOGGLE
7-7
-------------CN-3081B BOARD
-------------Ref. No.
or Qty Part No.
(CN-3081B BOARD)
Ref. No.
or Qty Part No.
SP Description
1pc
A-1707-215-A s MOUNTED CIRCUIT BOARD, CN-3081B
C1
C2
C3
C4
C5
1-112-692-81
1-164-939-81
1-164-939-81
1-112-692-81
1-114-214-81
s
s
s
s
s

CAP, CHIPCERAMIC 2200PF B 1005
CAP,CHIP CERAMIC470PF CH1005
C6
C7
C8
C9
C10
1-114-214-81
1-114-214-81
1-114-214-81
1-112-692-81
1-164-939-81
s
s
s
s
s

C11
C12
C13
C14
C15
1-164-939-81
1-112-692-81
1-164-939-81
1-164-939-81
1-164-939-81
s
s
s
s
s
CAP, CHIPCERAMIC 2200PF B

CAP,CHIP CERAMIC1000PF CH
1005
1005
1005
1005
1005
C21
C22
C23
C24
C25
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
2200PF
2200PF
2200PF
2200PF
2200PF
B
B
B
B
B
1005
1005
1005
1005
1005
C26
C27
C28
C29
C30
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
2200PF
2200PF
2200PF
2200PF
2200PF
B
B
B
B
B
1005
1005
1005
1005
1005
C31
C32
C33
C34
C41
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
2200PF
2200PF
2200PF
2200PF
2200PF
B
B
B
B
B
1005
1005
1005
1005
1005
C42
C43
C44
C45
C46
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
CHIPCERAMIC
2200PF
2200PF
2200PF
2200PF
2200PF
B
B
B
B
B
1005
1005
1005
1005
1005
C47
C48
C49
C61
C62
1-164-939-81
1-164-939-81
1-164-939-81
1-165-875-91
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC 2200PF B 1005

CHIP CERAMIC 10MF B 3216
C63
C64
C105
C106
C107
1-165-875-91
1-165-875-91
1-100-567-81
1-126-400-21
1-100-505-91
s
s
s
s
s
CAP, CHIP CERAMIC 10MF B 3216

C108
C109
C110
C111
C112
1-126-396-21
1-135-960-91
1-135-960-91
1-100-567-81
1-126-400-21
s
s
s
s
s

CAP, CHIP CERAMIC 10MF B(3225)
C113
C114
C115
C116
C117
1-135-960-91
1-100-567-81
1-115-339-91
1-100-567-81
1-100-567-81
s
s
s
s
s

CAP, CERAMIC 0.1MF B (2012)
C118
C119
1-100-567-81 s CAP,CHIP CERAMIC 0.01MF B 1005

1-100-567-81 s CAP,CHIP CERAMIC 0.01MF B 1005
7-8
SP Description
C120
C121
C122
C123
C124
1-100-567-81
1-100-567-81
1-100-505-91
1-165-875-91
1-165-875-91
s
s
s
s
s

CN1
CN2
CN3
CN4
CN5
1-750-890-11
1-750-889-11
1-750-889-11
1-573-566-11
1-779-992-21
s
s
s
s
s
CONNECTOR,D-SUB(ANGLE TYPE)25P
CONNECTOR, D-SUB(ANGLE TYPE)9P
PIN, CONNECTOR (PWB) 8P
CN6
CN7
CN8
CN9
CN10
1-794-509-21
1-778-647-31
1-770-469-21
1-560-357-11
1-770-468-21
s
s
s
o
s
PIN, CONNECTOR (PC BOARD) (3P)

CONNECTOR, FFC/FPC(ZIF) ST 15P
CONNECTOR POST HEADER,ILG (3P)
D101
8-719-046-86 s DIODE F1J6TP
E1
1-535-877-22 s CHIP, CHECKER
FB1
FB2
FB3
FB4
FB101
1-414-445-21
1-414-445-21
1-414-445-21
1-414-445-21
1-469-094-21
FB102
FB103
FB104
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-469-094-21 s FERRITE, EMI (SMD) (1608)
1-469-094-21 s FERRITE, EMI (SMD) (1608)
FL61
FL62
FL63
FL64
1-239-896-31
1-239-896-31
1-239-896-31
1-239-896-31
IC1
IC2
IC101
6-712-135-01 o IC R1173H001D-T1-F
6-701-904-01 s IC SN75179BPSR
6-709-213-01 s IC NJM2387ADL3(TE2)
JC21
1-216-864-91 s CONDUCTOR, CHIP (1608)
L1
L2
L3
L4
L61
1-457-217-21
1-457-217-21
1-457-217-21
1-457-217-21
1-414-398-41
o
o
o
o
s
COMMON MODE CHOKE COIL

INDUCTOR (SMD) 10.0UH
L101
L102
L103
L104
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
Q101
Q102

R61
R62
R63
R64
R65
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
R66
R67
R68
R69
R70
1-220-870-81
1-220-870-81
1-208-863-81
1-208-895-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
100 (1005)
2.2K (1005)
2.2K (1005)
R71
1-208-919-81 s RES, CHIP 22K (1005)
s
s
s
s
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FILTER,
FILTER,
FILTER,
FILTER,
EMI
EMI
EMI
EMI
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
------------CN-3082 BOARD
------------Ref. No.
or Qty Part No.
(CN-3081B BOARD)
Ref. No.
or Qty Part No.
SP Description
R72
R73
R102
R103
R104
1-208-919-81
1-208-863-81
1-208-903-81
1-208-891-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
100 (1005)
4.7K (1005)
1.5K (1005)
220 (1005)
R105
R106
R108
R109
R110
1-208-911-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
R111
R112
R113
R114
R115
1-208-887-81
1-208-903-81
1-208-887-81
1-208-887-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
4.7K (1005)
1.0K (1005)
1.0K (1005)
22K (1005)
R116
R117
R118
R119
R120
1-208-863-81
1-216-864-91
1-208-935-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 100K (1005)
R121
R201
1-216-864-91 s CONDUCTOR, CHIP (1608)

1-208-863-81 s RES, CHIP 100 (1005)
RB101
RB102
1-234-374-21 s RES, NETWORK 470 (1005X4)

1-234-374-21 s RES, NETWORK 470 (1005X4)
THP21
THP61
THP101
THP102
HSCU-300
!
!
!
!
1-803-615-21
1-803-615-21
1-803-615-21
1-803-615-21
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
SP Description
1pc
A-1707-202-A s MOUNTED CIRCUIT BOARD, CN-3082
C1
C2
C3
C4
C5
1-112-692-81
1-112-692-81
1-112-692-81
1-112-692-81
1-112-692-81
C6
CN1
CN3
1-816-669-11 s CONNECTOR (RECEPTACLE), XLR

FB1
FB2
FB3
FB4
FB5
1-414-445-21
1-414-445-21
1-414-445-21
1-414-445-21
1-414-445-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB6
FB7
FB10
FB11
FB14
1-414-445-21
1-414-445-21
1-414-445-21
1-414-445-21
1-414-445-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
------------CN-3083 BOARD
------------Ref. No.
or Qty Part No.
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CERAMIC1000PF
CERAMIC1000PF
CERAMIC1000PF
CERAMIC1000PF
CERAMIC1000PF
CH
CH
CH
CH
CH
1005
1005
1005
1005
1005
SP Description
1pc
A-1707-203-A s MOUNTED CIRCUIT BOARD, CN-3083
C1
C2
C3
1-114-214-81 s CAP,CHIP CERAMIC470PF CH1005

CN1
CN2
1-817-940-11 s CONNECTOR, ROUND TYPE 5P

FB1
FB2
FB3
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-414-445-21 s FERRITE, EMI (SMD) (1608)
1-414-445-21 s FERRITE, EMI (SMD) (1608)
L1
1-457-217-21 o COMMON MODE CHOKE COIL
7-9
------------DPR-300 BOARD
------------Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
1pc
6pcs
1pc
6pcs
A-1708-255-A
2-640-315-02
3-179-085-01
4-382-854-51
s
o
s
s
MOUNTED CIRCUIT BOARD, DPR-300

SCREW (M2X5), SMALL, +P, SW
LEVER (L), PC BOARD
SCREW (M3X6), P, SW (+)
C21
C22
C201
C202
C203
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-164-845-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C204
C205
C206
C207
C208
1-164-874-81
1-164-935-81
1-164-850-81
1-164-846-81
1-125-777-81
s
s
s
s
s
CAP,CHIP CERAMIC 100PF CH 1005

CAP, CHIP CERAMIC 470PF B 1005
CAP, CHIP CERAMIC 10PF CH 1005
CAP, CHIP CERAMIC 0.1MF B 1005
C209
C210
C211
C212
C213
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C214
C215
C216
C217
C218
1-162-919-91
1-162-919-91
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s
CAP, CERAMIC 22PF CH 1608

C219
C220
C221
C222
C223
1-125-777-81
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s
CAP, CHIP CERAMIC 0.1MF

CAP,CHIP CERAMIC 0.01MF
C224
C225
C226
C227
C228
1-125-777-81
1-100-567-81
1-100-567-81
1-164-874-81
1-127-692-91
s
s
s
s
s

C229
C230
C231
C232
C233
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C234
C235
C236
C237
C238
1-100-567-81
1-100-567-81
1-165-989-91
1-112-021-91
1-100-567-81
s
s
s
s
s

CAP, CERAMIC 10MF (2012)
C239
C240
C242
C244
C245
1-100-567-81
1-112-692-81
1-164-882-81
1-100-567-81
1-164-858-81
s
s
s
s
s
CAP,CHIP CERAMIC 0.01MF B

CAP,CHIP CERAMIC 220PF CH
CAP, CHIP CERAMIC 22PF CH
C246
C247
C248
C249
C250
1-100-567-81
1-165-989-91
1-164-846-81
1-164-848-81
1-100-567-81
s
s
s
s
s

C252
C254
C255
C256
C257
1-112-692-81
1-112-692-81
1-100-567-81
1-100-567-81
1-164-842-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
7-10
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF B 1005
0.1MF B 1005
(2012)
0.1MF B 1005
5PF CH 1005
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
B
B
B
B
B
CERAMIC1000PF CH
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC1000PF CH
CERAMIC1000PF CH
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 2.0PF CK
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
SP Description
C259
C261
C262
C263
C264
1-164-858-81
1-164-874-81
1-164-844-81
1-125-777-81
1-125-777-81
s
s
s
s
s

C265
C266
C267
C268
C269
1-100-567-81
1-100-567-81
1-100-567-81
1-112-692-81
1-165-989-91
s
s
s
s
s

1005
1005
1005
1005
C270
C271
C272
C273
C274
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C275
C276
C277
C278
C279
1-125-777-81
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C280
C281
C282
C283
C284
1-125-777-81
1-100-567-81
1-100-567-81
1-164-874-81
1-127-692-91
s
s
s
s
s

C285
C286
C287
C288
C289
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CERAMIC1000PF CH
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
1005
1005
1005
1005
1005
C290
C291
C292
C293
C294
1-100-567-81
1-100-567-81
1-165-989-91
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
C295
C296
C297
C299
C301
1-100-567-81
1-165-989-91
1-100-567-81
1-112-692-81
1-100-671-91
s
s
s
s
s

C302
C303
C304
C305
C306
1-100-567-81
1-100-567-81
1-115-339-91
1-114-236-21
1-114-236-21
s
s
s
s
s

C307
C308
C309
C310
C311
1-114-236-21
1-114-236-21
1-100-505-91
1-114-214-81
1-164-874-81
s
s
s
s
s

C313
C314
C315
C316
C317
1-100-505-91
1-100-505-91
1-165-875-91
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 0.1MF C (1005)

C318
C319
C320
C321
1-112-015-91
1-112-015-91
1-112-015-91
1-112-015-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
47MF
47MF
47MF
47MF
B
B
B
B
1005
1005
3225
3225
3225
3225
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C381
C382
C383
C384
C385
1-100-505-91
1-115-339-91
1-100-505-91
1-100-881-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC

CAP, CHIP CERAMIC 1MF B
C386
C387
C388
C389
C390
1-112-815-91
1-100-881-91
1-135-960-91
1-100-165-21
1-135-960-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF C (1608)

CHIP CERAMIC 10MF B(3225)
ELECT 47MF (8X7)
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC 470PF B 1005

C391
C392
C393
C394
C395
1-112-746-91
1-100-505-91
1-100-881-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1-165-875-91
1-164-936-81
1-112-015-91
1-165-875-91
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
10MF B 3216
680PF B 1005
47MF B 3225
10MF B 3216
10MF B 3216
C396
C397
C398
C399
C401
1-135-960-91
1-100-567-81
1-100-505-91
1-100-505-91
1-100-671-91
s
s
s
s
s

C342
C343
C344
C345
C346
1-112-015-91
1-100-881-91
1-100-881-91
1-125-777-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP CERAMIC 0.1MF B 1005
C402
C403
C404
C405
C406
1-100-567-81
1-100-567-81
1-114-236-21
1-114-236-21
1-114-236-21
s
s
s
s
s

C347
C348
C349
C350
C351
1-100-881-91
1-100-505-91
1-164-858-81
1-164-936-81
1-164-874-81
s
s
s
s
s
CAP, CERAMIC 47MF C (3216)

C407
C408
C409
C410
C412
1-114-236-21
1-100-505-91
1-114-214-81
1-164-874-81
1-100-505-91
s
s
s
s
s

C352
C353
C354
C355
C356
1-114-214-81
1-100-505-91
1-112-015-91
1-100-505-91
1-112-015-91
s
s
s
s
s

C413
C414
C415
C416
C417
1-100-505-91
1-165-875-91
1-100-505-91
1-100-505-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C357
C358
C359
C360
C361
1-164-874-81
1-164-874-81
1-100-505-91
1-100-505-91
1-164-874-81
s
s
s
s
s

C418
C419
C420
C421
C422
1-112-015-91
1-112-015-91
1-112-015-91
1-112-015-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C362
C363
C364
C365
C366
1-112-717-91
1-100-505-91
1-100-505-91
1-112-015-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 1UF B (1005)

C423
C424
C425
C426
C427
1-100-505-91
1-100-505-91
1-100-566-91
1-125-777-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C367
C368
C369
C370
C371
1-114-236-21
1-112-746-91
1-100-505-91
1-100-881-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C428
C429
C430
C431
C432
1-164-936-81
1-164-874-81
1-114-214-81
1-165-875-91
1-165-875-91
s
s
s
s
s

C372
C373
C374
C375
C376
1-112-815-91
1-100-881-91
1-112-746-91
1-115-339-91
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 4.7MF B (1608)
C433
C434
C435
C436
C437
1-112-015-91
1-164-936-81
1-100-505-91
1-165-875-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C377
C378
C379
C380
1-125-827-91
1-164-935-81
1-164-933-81
1-112-015-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
C438
C439
C440
C441
1-100-881-91
1-100-881-91
1-112-015-91
1-100-505-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,

C322
C323
C324
C325
C326
1-112-015-91
1-100-505-91
1-100-505-91
1-100-505-91
1-115-339-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C327
C328
C329
C330
C331
1-114-236-21
1-114-236-21
1-100-567-81
1-165-875-91
1-125-827-91
s
s
s
s
s
C332
C333
C334
C335
C336
1-164-935-81
1-164-933-81
1-112-015-91
1-100-505-91
1-112-015-91
C337
C338
C339
C340
C341
HSCU-300

CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
22MF B (3225)
4.7MF B (1608)
0.1MF C (1005)
47MF C (3216)
10MF C (1608)
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1MF B
470PF B 1005
220PF B 1005
47MF B 3225
0.1MF C (1005)
0.1MF B (2012)
0.1MF C (1005)
47MF C (3216)
10MF C (1608)
4.7MF B (1608)
0.1MF C (1005)
47MF C (3216)
10MF C (1608)
10MF C (1608)
7-11
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
C442
C443
C444
C445
C446
1-100-881-91
1-112-015-91
1-100-505-91
1-100-505-91
1-164-874-81
s
s
s
s
s

C502
C503
C504
C506
C507
1-125-777-81
1-112-717-91
1-112-815-91
1-125-777-81
1-100-881-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C447
C448
C449
C450
C451
1-164-936-81
1-114-214-81
1-164-858-81
1-165-875-91
1-164-936-81
s
s
s
s
s

C508
C509
C510
C511
C512
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C452
C453
C454
C455
C456
1-165-875-91
1-112-015-91
1-100-505-91
1-165-875-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C513
C514
C515
C516
C517
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C457
C458
C459
C460
C461
1-100-881-91
1-100-881-91
1-100-881-91
1-112-015-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C518
C519
C520
C521
C522
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C462
C463
C464
C465
C466
1-100-505-91
1-164-858-81
1-114-214-81
1-164-936-81
1-164-874-81
s
s
s
s
s

C523
C526
C527
C528
C529
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C467
C468
C469
C470
C471
1-165-875-91
1-165-875-91
1-112-015-91
1-164-936-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C530
C531
C533
C534
C535
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C472
C473
C474
C475
C476
1-165-875-91
1-112-015-91
1-100-881-91
1-100-881-91
1-100-881-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 47MF
CERAMIC 47MF
CERAMIC 47MF
C536
C537
C540
C541
C601
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
C477
C478
C479
C480
C481
1-112-692-81
1-164-850-81
1-164-866-81
1-100-505-91
1-164-936-81
s
s
s
s
s

C602
C604
C605
C606
C607
1-112-815-91
1-112-717-91
1-100-611-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C482
C483
C484
C485
C486
1-164-858-81
1-165-875-91
1-100-055-21
1-125-777-81
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
22PF CH 1005
10MF B 3216
22MF B 3225
0.1MF B 1005
10MF B 3216
C608
C609
C610
C611
C612
1-125-777-81
1-125-777-81
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
0.1MF B 1005
C487
C488
C489
C490
C491
1-100-881-91
1-100-611-91
1-100-055-21
1-100-881-91
1-100-611-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 47MF
CERAMIC 22MF
CHIP CERAMIC
CERAMIC 47MF
CERAMIC 22MF
C (3216)
C (2012)
22MF B 3225
C (3216)
C (2012)
C613
C614
C615
C616
C617
1-125-777-81
1-125-777-81
1-125-777-81
1-100-611-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (2012)
0.1MF B 1005
C492
C493
C494
C495
C496
1-112-692-81
1-164-850-81
1-100-881-91
1-112-746-91
1-112-746-91
s
s
s
s
s

C618
C619
C620
C621
C622
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
C (1608)
C497
C498
C499
C501
1-100-881-91
1-115-339-91
1-100-567-81
1-125-777-81
s
s
s
s

C624
C625
C626
C627
1-112-717-91
1-100-611-91
1-125-777-81
1-112-815-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,

7-12
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF B 3216
47MF B 3225
C (3216)
C (3216)
C (3216)
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
HSCU-300
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
C628
C629
C630
C631
C632
1-125-777-81
1-125-777-81
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
0.1MF B 1005
C806
C807
C808
C809
C810
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C633
C634
C635
C636
C637
1-125-777-81
1-125-777-81
1-125-777-81
1-100-611-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (2012)
0.1MF B 1005
C811
C812
C900
C901
C902
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C638
C639
C640
C701
C702
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
C903
C904
C905
C906
C907
1-112-717-91
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C703
C704
C705
C706
C707
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C908
C909
C910
C1101
C1102
1-112-815-91
1-125-777-81
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C708
C709
C710
C711
C712
1-125-777-81
1-125-777-81
1-112-717-91
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1103
C1104
C1105
C1106
C1107
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
C713
C714
C715
C716
C717
1-125-777-81
1-112-717-91
1-125-777-81
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1108
C1109
C1110
C1111
C1112
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
C718
C719
C720
C721
C722
1-125-777-81
1-125-777-81
1-112-717-91
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1113
C1114
C1115
C1116
C1117
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C723
C724
C725
C726
C727
1-125-777-81
1-112-717-91
1-125-777-81
1-112-717-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1118
C1119
C1120
C1121
C1122
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C728
C729
C730
C731
C732
1-112-717-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP CERAMIC 0.1MF B
1005
1005
1005
1005
C1123
C1124
C1125
C1126
C1127
1-125-777-81
1-112-815-91
1-112-815-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C733
C734
C735
C736
C737
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
C (1608)
C (1608)
C (1608)
0.1MF B 1005
C1128
C1129
C1130
C1131
C1132
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
C738
C739
C740
C741
C801
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
C1133
C1134
C1135
C1136
C1137
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
C802
C803
C804
C805
1-125-777-81
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
C1138
C1139
C1140
C1141
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
HSCU-300
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
1005
1005
1005
1005
1005
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
1005
1005
1005
1005
7-13
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
C1142
C1143
C1144
C1145
C1146
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
B
B
B
B
B
1005
1005
1005
1005
1005
C1219
C1220
C1221
C1222
C1223
1-100-567-81
1-100-567-81
1-100-567-81
1-165-989-91
1-125-777-81
s
s
s
s
s

CAP, CHIP CERAMIC 0.1MF B
1005
1005
1005
C1147
C1148
C1149
C1150
C1151
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1005
1005
1005
1005
C1224
C1225
C1226
C1227
C1228
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
1005
1005
1005
1005
1005
C1152
C1153
C1156
C1157
C1158
1-125-777-81
1-164-850-81
1-112-815-91
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
10PF CH 1005
C (1608)
C (1608)
0.1MF B 1005
C1229
C1230
C1231
C1232
C1233
1-112-298-91
1-112-298-91
1-164-848-81
1-164-850-81
1-164-842-81
o
o
s
s
s

CAP,CHIP CERAMIC 2.0PF CK 1005
C1159
C1160
C1161
C1162
C1163
1-125-777-81
1-112-815-91
1-125-777-81
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
C (1608)
0.1MF B 1005
0.1MF B 1005
C (1608)
C1234
C1235
C1236
C1239
C1240
1-164-850-81
1-164-850-81
1-164-842-81
1-208-887-81
1-208-887-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
C1164
C1165
C1170
C1171
C1172
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
C1241
C1242
C1243
C1244
C1245
1-164-840-81
1-164-840-81
1-164-840-81
1-164-840-81
1-164-840-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C1173
C1174
C1175
C1176
C1177
1-125-777-81
1-112-717-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1005
1005
1005
C1247
C1248
C1249
C1250
C1251
1-164-858-81
1-164-858-81
1-164-842-81
1-125-777-81
1-125-777-81
s
s
s
s
s

CAP,CHIP CERAMIC 2.0PF CK
C1178
C1179
C1180
C1181
C1183
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
C (1608)
0.1MF B 1005
0.1MF B 1005
C1252
C1255
C1256
C1258
C1259
1-165-989-91
1-125-777-81
1-164-849-81
1-112-692-81
1-112-692-81
s
s
s
s
s

C1184
C1185
C1186
C1187
C1188
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
C1260
C1500
C1501
C1502
C1503
1-112-692-81
1-112-717-91
1-125-777-81
1-164-840-81
1-100-567-81
s
s
s
s
s

CAP, CERAMIC 1UF B (1005)
CAP, CHIP CERAMIC 1PF CK 1005
C1189
C1190
C1200
C1201
C1202
1-112-815-91
1-125-777-81
1-164-842-81
1-100-567-81
1-100-567-81
s
s
s
s
s

C1504
C1505
C1506
C1507
C1508
1-165-989-91
1-100-567-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
C1203
C1205
C1207
C1208
C1209
1-164-844-81
1-164-858-81
1-164-843-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C1509
C1510
C1511
C1512
C1513
1-165-989-91
1-164-940-81
1-164-935-81
1-164-874-81
1-125-777-81
s
s
s
s
s

CAP,CHIP CERAMIC 3300PF B
CAP, CHIP CERAMIC 470PF B
1005
1005
1005
1005
C1210
C1211
C1212
C1213
C1214
1-100-567-81
1-100-567-81
1-100-567-81
1-112-692-81
1-165-989-91
s
s
s
s
s

1005
1005
1005
1005
C1514
C1515
C1517
C1518
C1519
1-125-777-81
1-164-874-81
1-164-862-81
1-164-874-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1215
C1216
C1217
C1218
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
1005
1005
1005
1005
C1520
C1521
C1522
C1523
1-164-870-81
1-125-777-81
1-100-881-91
1-112-021-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
7-14
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
SP Description
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1005
4PF CH 1005
22PF CH 1005
3PF CJ 1005
0.1MF B 1005
0.1MF B 1005
0.01MF
0.01MF
0.01MF
0.01MF
B
B
B
B
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
1PF
1PF
1PF
1PF
1PF
B
B
B
B
B
1005
CK
CK
CK
CK
CK
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
CHIP CERAMIC 68PF CH 1005

HSCU-300
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
C1524
C1525
C1526
C1527
C1528
1-164-936-81
1-164-936-81
1-164-690-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 2200PF CH (2012)
C1529
C1530
C1531
C1532
C1533
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
C1534
C1535
C1536
C1537
C1538
1-100-567-81
1-164-870-81
1-112-692-81
1-164-882-81
1-164-936-81
s
s
s
s
s
C1539
C1540
C1542
C1543
C1545
1-165-989-91
1-100-159-91
1-125-777-81
1-125-777-81
1-164-940-81
C1546
C1547
C1548
C1549
C1550
SP Description
C1587
C1588
C1589
C1590
C1591
1-164-690-91
1-164-690-91
1-114-386-11
1-125-777-81
1-112-300-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
1005
1005
1005
1005
1005
C1592
C1593
C1594
C1595
C1596
1-112-298-91
1-100-567-81
1-100-159-91
1-100-567-81
1-107-819-81
o
s
s
s
s

CAP, CERAMIC 22MF B (SMD) 3216
CAP,CHIP CERAMIC 22000PF B1005

1005
1005
1005
1005
1005
C1597
C1598
C1599
C1600
C1601
1-112-298-91
1-127-692-91
1-125-777-81
1-127-692-91
1-100-567-81
o
s
s
s
s

s
s
s
s
s

CAP, CERAMIC 22MF B (SMD)
CAP,CHIP CERAMIC 3300PF B
3216
1005
1005
1005
C1602
C1603
C1604
C1605
C1606
1-100-567-81
1-125-777-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
1-125-777-81
1-125-777-81
1-164-882-81
1-164-858-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1607
C1608
C1609
C1610
C1611
1-125-777-81
1-100-567-81
1-165-989-91
1-125-777-81
1-100-567-81
s
s
s
s
s

1005
1005
C1551
C1552
C1553
C1554
C1555
1-100-159-91
1-100-159-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF
CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
3216
3216
1005
1005
1005
C1612
C1613
C1614
C1615
C1616
1-125-777-81
1-125-777-81
1-165-989-91
1-100-567-81
1-100-055-21
s
s
s
s
s

C1556
C1557
C1558
C1559
C1560
1-164-858-81
1-114-386-11
1-112-298-91
1-112-298-91
1-125-777-81
s
s
o
o
s
CAP,
CAP,
CAP,
CAP,
CAP,

NIOBIUM ELECT 100MF 105
CERAMIC 1MF B (1608)
C1617
C1618
C1619
C1620
C1621
1-125-777-81
1-125-777-81
1-100-567-81
1-125-777-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C1561
C1562
C1563
C1564
C1565
1-112-746-91
1-164-935-81
1-100-567-81
1-100-567-81
1-164-935-81
s
s
s
s
s

C1622
C1623
C1624
C1625
C1627
1-100-567-81
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C1568
C1569
C1570
C1571
C1572
1-164-874-81
1-100-567-81
1-100-567-81
1-100-567-81
1-107-819-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C1628
C1629
C1630
C1631
C1632
1-125-777-81
1-165-989-91
1-100-567-81
1-100-567-81
1-165-989-91
s
s
s
s
s

C1573
C1574
C1575
C1576
C1577
1-164-934-81
1-164-882-81
1-164-882-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1633
C1634
C1635
C1636
C1637
1-100-567-81
1-125-777-81
1-100-567-81
1-125-777-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C1578
C1579
C1580
C1581
C1582
1-125-777-81
1-112-692-81
1-112-692-81
1-112-692-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1638
C1639
C1640
C1641
C1642
1-125-777-81
1-100-567-81
1-125-777-81
1-100-567-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C1583
C1584
C1585
C1586
1-100-567-81
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s

1005
1005
3216
1005
C1643
C1644
C1645
C1646
1-125-777-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s

B
B
B
B
1005
1005
1005
1005
HSCU-300
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B (SMD)
B (SMD)
0.1MF B
0.1MF B
0.1MF B
100PF CH 1005
0.01MF B 1005
0.01MF B 1005
0.01MF B 1005
22000PF B1005

NIOBIUM ELECT 100MF 105
1005
1005
7-15
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
C1647
C1650
C1651
C1692
C1693
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
1-165-875-91
s
s
s
s
s

C2019
C2020
C2021
C2022
C2023
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
B
B
B
B
B
1005
1005
1005
1005
1005
C1694
C1695
C1701
C1702
C1703
1-164-940-81
1-112-692-81
1-112-815-91
1-112-815-91
1-112-717-91
s
s
s
s
s
CAP,CHIP CERAMIC 3300PF B 1005

C2024
C2025
C2027
C2028
C2029
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1005
1005
1005
C1704
C1705
C1706
C1707
C1708
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C2030
C2101
C2102
C2103
C2104
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
C (1608)
C (1608)
C (1608)
C (1608)
C1709
C1710
C1711
C1712
C1713
1-112-717-91
1-112-717-91
1-112-717-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2105
C2106
C2107
C2108
C2109
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1714
C1715
C1716
C1717
C1718
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C2110
C2111
C2112
C2113
C2114
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1719
C1720
C1721
C1722
C1723
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C2115
C2116
C2117
C2118
C2119
1-125-777-81
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
C (1608)
C (1608)
C (1608)
C1724
C1725
C1800
C1801
C1802
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1005
1005
1005
1005
C2120
C2121
C2122
C2123
C2124
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C1804
C1805
C1806
C1807
C1808
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2125
C2126
C2127
C2128
C2129
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
C1809
C2001
C2002
C2003
C2004
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
10MF C (1608)
10MF C (1608)
10MF C (1608)
1UF B (1005)
C2130
C2131
C2132
C2201
C2202
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2005
C2006
C2007
C2008
C2009
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
C2203
C2204
C2205
C2206
C2207
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C2010
C2011
C2012
C2013
C2014
1-112-717-91
1-112-717-91
1-112-717-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2208
C2209
C2210
C2211
C2212
1-112-717-91
1-112-717-91
1-112-717-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2015
C2016
C2017
C2018
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
C2213
C2214
C2215
C2216
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
7-16
1UF
1UF
1UF
1UF
1UF
B
B
B
B
B
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
1005
1005
1005
1005
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
B
B
B
B
B
1005
1005
1005
1005
1005
1005
(1005)
(1005)
(1005)
(1005)
(1005)
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
1005
1005
1005
1005
HSCU-300
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
C2217
C2218
C2219
C2220
C2221
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C2222
C2223
C2224
C2225
C2226
1-100-159-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C2227
C2228
C2229
C2230
C2231
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
C2232
C2233
C2234
C2235
C2236
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
C2237
C2238
C2239
C2240
C2241
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
1005
1005
1005
1005
1005
C2316
C2317
C2318
C2319
C2320
1-112-717-91
1-112-815-91
1-112-717-91
1-112-815-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF B (1005)
10MF C (1608)
1UF B (1005)
10MF C (1608)
4.7MF B (1608)
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
22MF B (SMD) 3216

1UF B (1005)
1UF B (1005)
1UF B (1005)
1UF B (1005)
C2321
C2322
C2323
C2324
C2325
1-112-746-91
1-112-717-91
1-112-717-91
1-112-717-91
1-119-923-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4.7MF B (1608)
1UF B (1005)
1UF B (1005)
1UF B (1005)
0.047MF B 1005
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
C2327
C2328
C2329
C2330
C2331
1-112-717-91
1-112-717-91
1-112-746-91
1-112-746-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF B
1UF B
4.7MF
4.7MF
1UF B
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
C2242
C2243
C2244
C2245
C2246
1-112-717-91
1-112-717-91
1-112-717-91
1-112-815-91
1-125-777-81
s
s
s
s
s
C2247
C2248
C2249
C2250
C2251
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
C2252
C2253
C2257
C2258
C2259
(1005)
(1005)
(1005)
(1005)
(1005)
1005
1005
1005
1005
1005
C2332
C2333
C2334
C2335
C2336
1-125-777-81
1-112-746-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

0.1MF B
0.1MF B
0.1MF B
0.1MF B
B (SMD)
1005
1005
1005
1005
3216
C2337
C2338
C2339
C2340
C2341
1-112-815-91
1-112-717-91
1-112-815-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
1UF B (1005)
10MF C (1608)
4.7MF B (1608)
4.7MF B (1608)
CAP,
CAP,
CAP,
CAP,
CAP,

C2342
C2343
C2344
C2345
C2347
1-112-717-91
1-112-717-91
1-112-717-91
1-119-923-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF B (1005)
1UF B (1005)
1UF B (1005)
0.047MF B 1005
1UF B (1005)
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
1005
1005
1005
1005
1005
C2348
C2349
C2350
C2351
C2352
1-112-717-91
1-112-746-91
1-112-746-91
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1-100-159-91
1-100-505-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF B (SMD) 3216

C2353
C2354
C2355
C2356
C2357
1-112-717-91
1-112-815-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C2260
C2261
C2262
C2263
C2301
1-125-777-81
1-125-777-81
1-112-815-91
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
C (1608)
C (1608)
0.1MF B 1005
C2358
C2359
C2360
C2361
C2362
1-112-717-91
1-112-746-91
1-112-746-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2302
C2303
C2304
C2305
C2306
1-125-777-81
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
0.1MF B 1005
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C2365
C2366
C2367
C2368
C2369
1-112-746-91
1-112-746-91
1-112-746-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2307
C2308
C2309
C2310
C2311
1-125-777-81
1-125-777-81
1-112-717-91
1-112-815-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2370
C2371
C2372
C2373
C2374
1-112-815-91
1-112-746-91
1-125-777-81
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2312
C2313
C2314
C2315
1-125-777-81
1-112-746-91
1-112-717-91
1-112-717-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,

C2375
C2400
C2401
C2402
1-112-815-91
1-112-717-91
1-112-815-91
1-112-815-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
(1005)
(1005)
B (1608)
B (1608)
(1005)
B
B
B
B
B
HSCU-300
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
B
B
B
B
B
SP Description
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1UF B (1005)
10MF C (1608)
1UF B (1005)
1UF B (1005)
1UF B (1005)
10MF C (1608)
1UF B (1005)
10MF C (1608)
10MF C (1608)
7-17
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C2403
C2404
C2405
C2406
C2407
1-112-815-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
1UF B (1005)
1UF B (1005)
1UF B (1005)
1UF B (1005)
C2616
C2617
C2618
C2619
C2620
1-100-505-91
1-112-298-91
1-112-015-91
1-112-298-91
1-112-015-91
s
o
s
o
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2408
C2409
C2410
C2411
C2412
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
1UF
1UF
1UF
1UF
1UF
C2621
C2622
C2623
C2624
C2625
1-112-298-91
1-125-777-81
1-100-505-91
1-112-815-91
1-100-505-91
o
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2413
C2414
C2415
C2416
C2417
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C2626
C2627
C2628
C2629
C2630
1-100-505-91
1-112-815-91
1-100-505-91
1-162-923-91
1-162-915-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C2418
C2419
C2420
C2421
C2422
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C2631
C2632
C2633
C2634
C2635
1-162-919-91
1-115-416-91
1-112-815-91
1-100-505-91
1-127-954-21
s
s
s
s
s

CAP, CHIP FILM 0.047MF (3216)
C2423
C2424
C2425
C2426
C2427
1-100-505-91
1-100-505-91
1-125-777-81
1-125-777-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2636
C2637
C2638
C2639
C2640
1-115-416-91
1-112-815-91
1-100-505-91
1-100-505-91
1-112-815-91
s
s
s
s
s

C2501
C2502
C2503
C2504
C2505
1-125-777-81
1-125-777-81
1-100-881-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 47MF
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
C (3216)
C (1608)
C (1608)
C2641
C2642
C2643
C2644
C2645
1-112-815-91
1-100-505-91
1-100-505-91
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
0.1MF C (1005)
0.1MF C (1005)
0.1MF C (1005)
0.1MF C (1005)
C2506
C2507
C2508
C2509
C2510
1-112-815-91
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C2646
C2647
C2648
C2649
C2650
1-100-505-91
1-112-815-91
1-100-505-91
1-100-505-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF C (1005)
10MF C (1608)
0.1MF C (1005)
0.1MF C (1005)
10MF C (1608)
C2511
C2512
C2513
C2514
C2515
1-125-777-81
1-125-777-81
1-112-815-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
C (1608)
C2651
C2652
C2653
C2701
C2702
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C2516
C2517
C2518
C2519
C2601
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2703
C2704
C2705
C2706
C2707
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
C (1608)
C2602
C2603
C2604
C2605
C2606
1-100-881-91
1-100-505-91
1-100-505-91
1-112-815-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
47MF C (3216)
0.1MF C (1005)
0.1MF C (1005)
10MF C (1608)
0.1MF C (1005)
C2708
C2709
C2710
C2711
C2712
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C2607
C2608
C2609
C2610
C2611
1-112-815-91
1-112-815-91
1-100-505-91
1-112-815-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
10MF C (1608)
0.1MF C (1005)
10MF C (1608)
0.1MF C (1005)
C2713
C2714
C2715
C2716
C2717
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
C2612
C2613
C2614
C2615
1-112-815-91
1-100-505-91
1-112-815-91
1-100-505-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF C (1608)
0.1MF C (1005)
10MF C (1608)
0.1MF C (1005)
C2718
C2719
C2720
C2721
1-125-777-81
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
7-18
B
B
B
B
B
(1005)
(1005)
(1005)
(1005)
(1005)
0.1MF C (1005)
10MF C (1608)
0.1MF C (1005)
47PF CH 1608
10PF CH 1608
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
1005
1005
1005
1005
1005
0.1MF B
0.1MF B
0.1MF B
B (SMD)
1005
1005
1005
3216
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C2722
C2723
C2724
C2725
C2726
1-100-159-91
1-100-159-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF
CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
B (SMD)
B (SMD)
0.1MF B
0.1MF B
0.1MF B
3216
3216
1005
1005
1005
C2805
C2806
C2807
C2808
C2809
1-100-505-91
1-100-505-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C2727
C2728
C2729
C2730
C2731
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C2810
C2811
C2812
C2813
C2814
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
C (1608)
C (1608)
C (1608)
0.1MF B 1005
0.1MF B 1005
C2732
C2733
C2734
C2735
C2736
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-164-850-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF B
0.1MF B
0.1MF B
0.1MF B
10PF CH
1005
1005
1005
1005
1005
C2815
C2816
C2817
C2818
C2819
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
C2737
C2738
C2739
C2740
C2741
1-164-850-81
1-164-850-81
1-164-843-81
1-164-845-81
1-164-843-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10PF CH 1005
10PF CH 1005
3PF CJ 1005
5PF CH 1005
3PF CJ 1005
C2820
C2821
C2822
C2823
C2824
1-125-777-81
1-125-777-81
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
C (1608)
C (1608)
C (1608)
C2742
C2743
C2744
C2745
C2746
1-164-845-81
1-164-843-81
1-164-845-81
1-164-852-81
1-164-852-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
5PF CH 1005
3PF CJ 1005
5PF CH 1005
12PF CH 1005
12PF CH 1005
C2825
C2826
C2827
C2828
C2829
1-125-777-81
1-125-777-81
1-125-777-81
1-162-923-91
1-162-923-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 47PF
CERAMIC 47PF
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
CH 1608
CH 1608
C2747
C2748
C2749
C2750
C2751
1-164-852-81
1-125-777-81
1-112-815-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
12PF CH 1005
0.1MF B 1005
C (1608)
0.1MF B 1005
C (1608)
C2830
C2831
C2832
C2833
C2834
1-162-923-91
1-162-910-91
1-162-915-91
1-162-910-91
1-162-915-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
47PF CH 1608
5.0PF CH 1608
10PF CH 1608
5.0PF CH 1608
10PF CH 1608
C2752
C2753
C2754
C2755
C2756
1-125-777-81
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
C (1608)
0.1MF B 1005
C (1608)
0.1MF B 1005
C2835
C2836
C2837
C2838
C2839
1-162-910-91
1-162-915-91
1-162-923-91
1-162-923-91
1-162-923-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
5.0PF CH 1608
10PF CH 1608
47PF CH 1608
47PF CH 1608
47PF CH 1608
C2757
C2758
C2759
C2760
C2761
1-112-815-91
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
C (1608)
C (1608)
0.1MF B 1005
C (1608)
0.1MF B 1005
C2840
C2841
C2842
C2843
C2844
1-125-777-81
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
C (1608)
0.1MF B 1005
C (1608)
0.1MF B 1005
C2762
C2763
C2764
C2766
C2768
1-112-815-91
1-125-777-81
1-164-846-81
1-164-846-81
1-164-846-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C (1608)
0.1MF B 1005
6PF CH 1005
6PF CH 1005
6PF CH 1005
C2845
C2846
C2847
C2848
C2849
1-112-815-91
1-112-815-91
1-125-777-81
1-112-815-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
C (1608)
C (1608)
0.1MF B 1005
C (1608)
0.1MF B 1005
C2770
C2771
C2772
C2773
C2774
1-125-777-81
1-112-815-91
1-112-815-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
C (1608)
C (1608)
0.1MF B 1005
C (1608)
C2850
C2851
C2852
C2853
C2854
1-112-815-91
1-125-777-81
1-162-915-91
1-162-913-91
1-162-915-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10PF CH 1608
CERAMIC 8.0PF CH 1608
C2775
C2776
C2777
C2778
C2779
1-125-777-81
1-112-815-91
1-112-815-91
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
0.1MF B 1005
C (1608)
C (1608)
0.1MF B 1005
C (1608)
C2855
C2856
C2857
C2858
C2859
1-162-913-91
1-162-915-91
1-162-913-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C2801
C2802
C2803
C2804
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
C2860
C2861
C2862
C2863
1-165-875-91
1-112-015-91
1-112-015-91
1-164-874-81
s
s
s
s
CAP, CHIP CERAMIC 10MF

CAP,CHIP CERAMIC 100PF
HSCU-300
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
1005
1005
1005
1005
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
1005
1005
1005
1005
1005
8.0PF CH 1608
10PF CH 1608
8.0PF CH 1608
10MF C (1608)
10MF C (1608)
B 3216
B 3225
B 3225
CH 1005
7-19
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C2864
C2865
C2866
C2867
C2868
1-112-746-91
1-125-827-91
1-164-935-81
1-164-933-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP CERAMIC 1MF B
C3445
C3446
C3447
C3448
C3449
1-100-567-81
1-100-567-81
1-100-567-81
1-165-989-91
1-112-692-81
s
s
s
s
s

1005
1005
1005
C2869
C2870
C2871
C2872
C2873
1-112-717-91
1-100-505-91
1-112-015-91
1-100-505-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C3450
C3451
C3452
C3453
C3454
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s
1005
1005
1005
1005
1005
C2874
C2875
C3001
C3002
C3003
1-112-015-91
1-112-015-91
1-114-214-81
1-165-875-91
1-100-567-81
s
s
s
s
s

C3455
C3456
C3457
C3458
C3459
1-125-777-81
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B
0.1MF B
0.1MF B
(2012)
0.1MF B
1005
1005
1005
C3005
C3006
C3007
C3008
C3009
1-112-015-91
1-112-015-91
1-100-505-91
1-114-236-21
1-114-236-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C3460
C3461
C3462
C3463
C3464
1-125-777-81
1-125-891-91
1-125-777-81
1-165-989-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP CERAMIC0.47MF B
CERAMIC 10MF (2012)
1005
1608
1005
C3010
C3401
C3402
C3403
C3404
1-104-760-91
1-165-989-91
1-165-989-91
1-112-021-91
1-112-692-81
s
s
s
s
s
CAP, CERAMIC 47000PF B (2012)

C3465
C3466
C3467
C3468
C3469
1-165-989-91
1-125-777-81
1-125-777-81
1-125-777-81
1-164-845-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C3405
C3406
C3407
C3408
C3409
1-164-840-81
1-100-567-81
1-100-567-81
1-125-777-81
1-125-777-81
s
s
s
s
s

C3470
C3471
C3472
C3478
C3479
1-164-854-81
1-164-866-81
1-164-866-81
1-100-567-81
1-112-717-91
s
s
s
s
s

C3410
C3411
C3412
C3413
C3414
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
1-112-692-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3489
C3490
C3491
C3501
C3502
1-112-692-81
1-112-692-81
1-112-692-81
1-165-989-91
1-165-989-91
s
s
s
s
s

C3415
C3417
C3419
C3420
C3421
1-112-300-91
1-112-692-81
1-165-989-91
1-112-692-81
1-112-692-81
s
s
s
s
s

C3503
C3504
C3505
C3506
C3507
1-112-021-91
1-112-692-81
1-164-842-81
1-100-567-81
1-100-567-81
s
s
s
s
s

C3422
C3424
C3426
C3427
C3428
1-100-567-81
1-164-858-81
1-100-567-81
1-100-567-81
1-164-856-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3508
C3509
C3510
C3511
C3512
1-125-777-81
1-114-214-81
1-114-214-81
1-125-777-81
1-100-567-81
s
s
s
s
s

C3429
C3430
C3431
C3432
C3433
1-164-856-81
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3513
C3514
C3515
C3517
C3519
1-100-567-81
1-112-692-81
1-112-300-91
1-112-692-81
1-165-989-91
s
s
s
s
s

C3434
C3435
C3436
C3437
C3438
1-164-866-81
1-164-848-81
1-100-567-81
1-100-567-81
1-164-846-81
s
s
s
s
s

C3520
C3521
C3522
C3524
C3526
1-112-692-81
1-112-692-81
1-100-567-81
1-164-858-81
1-100-567-81
s
s
s
s
s
1005
1005
1005
1005
1005
C3439
C3441
C3442
C3444
1-164-862-81
1-164-874-81
1-112-692-81
1-100-567-81
s
s
s
s

C3527
C3528
C3529
C3530
1-100-567-81
1-164-856-81
1-164-856-81
1-125-777-81
s
s
s
s

1005
1005
1005
1005
7-20

1005
1005
1005
1005
1005
1005
1005
(2012)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
5PF CH 1005
1005
1005
1005
1005
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C3531
C3532
C3533
C3534
C3535
1-125-777-81
1-100-567-81
1-100-567-81
1-164-866-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3617
C3618
C3619
C3620
C3622
1-100-567-81
1-100-567-81
1-112-692-81
1-112-300-91
1-112-692-81
s
s
s
s
s

C3536
C3537
C3538
C3539
C3540
1-100-567-81
1-164-846-81
1-164-862-81
1-164-843-81
1-164-874-81
s
s
s
s
s

CAP, CHIP CERAMIC 3PF CJ 1005
C3624
C3625
C3626
C3627
C3629
1-165-989-91
1-112-692-81
1-112-692-81
1-100-567-81
1-164-858-81
s
s
s
s
s

1005
1005
1005
1005
C3541
C3543
C3544
C3545
C3546
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CERAMIC1000PF CH
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
1005
1005
1005
1005
1005
C3631
C3632
C3633
C3634
C3635
1-100-567-81
1-100-567-81
1-164-856-81
1-164-856-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3547
C3548
C3549
C3550
C3551
1-165-989-91
1-112-692-81
1-112-692-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
C3636
C3637
C3638
C3639
C3640
1-125-777-81
1-100-567-81
1-100-567-81
1-164-848-81
1-100-567-81
s
s
s
s
s

C3552
C3553
C3554
C3555
C3556
1-100-567-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C3641
C3642
C3643
C3645
C3646
1-100-567-81
1-164-846-81
1-164-862-81
1-164-874-81
1-112-692-81
s
s
s
s
s

C3557
C3558
C3559
C3560
C3561
1-165-989-91
1-125-777-81
1-125-777-81
1-125-891-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

1005
1005
1608
1005
C3648
C3649
C3650
C3651
C3652
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
1-165-989-91
s
s
s
s
s

1005
1005
1005
1005
C3562
C3563
C3564
C3565
C3566
1-165-989-91
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
(2012)
0.1MF B 1005
(2012)
0.1MF B 1005
0.1MF B 1005
C3653
C3654
C3655
C3656
C3658
1-112-692-81
1-112-692-81
1-100-567-81
1-100-567-81
1-165-989-91
s
s
s
s
s
1005
1005
1005
1005
C3567
C3568
C3569
C3577
C3578
1-125-777-81
1-164-866-81
1-164-866-81
1-165-989-91
1-100-567-81
s
s
s
s
s

1005
C3659
C3660
C3661
C3662
C3663
1-164-936-81
1-112-692-81
1-100-567-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3579
C3589
C3590
C3601
C3602
1-112-717-91
1-112-692-81
1-112-692-81
1-165-989-91
1-165-989-91
s
s
s
s
s

C3664
C3665
C3666
C3667
C3668
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
1005
1005
C3603
C3604
C3605
C3606
C3607
1-125-777-81
1-164-842-81
1-112-021-91
1-100-567-81
1-100-567-81
s
s
s
s
s

C3669
C3670
C3671
C3672
C3673
1-125-891-91
1-125-777-81
1-165-989-91
1-125-777-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC0.47MF B 1608

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C3608
C3609
C3610
C3611
C3612
1-112-692-81
1-112-692-81
1-164-842-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
1005
1005
1005
1005
1005
C3674
C3675
C3676
C3677
C3678
1-125-777-81
1-125-777-81
1-125-777-81
1-165-989-91
1-100-567-81
s
s
s
s
s

C3613
C3614
C3615
C3616
1-125-777-81
1-114-214-81
1-114-214-81
1-125-777-81
s
s
s
s

C3679
C3680
C3681
C3683
1-112-717-91
1-164-866-81
1-164-866-81
1-100-581-81
s
s
s
s

CAP,CHIP CERAMIC0.0047MF B1005
HSCU-300
CERAMIC1000PF CH
CERAMIC1000PF CH
CERAMIC 2.0PF CK
CERAMIC 0.01MF B
CERAMIC 0.01MF B
1005
1005
1005
0.1MF B
0.1MF B
(2012)
0.1MF B
0.1MF B
1005
1005
1005
1005
1005
1005
7-21
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C3684
C3685
C3686
C3687
C3688
1-112-692-81
1-100-567-81
1-100-581-81
1-114-214-81
1-112-692-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CERAMIC470PF CH1005
C3759
C3760
C3761
C3762
C3763
1-125-777-81
1-125-891-91
1-125-777-81
1-165-989-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
C3689
C3690
C3701
C3702
C3703
1-112-692-81
1-112-692-81
1-165-989-91
1-165-989-91
1-112-021-91
s
s
s
s
s

C3764
C3765
C3766
C3767
C3769
1-165-989-91
1-125-777-81
1-125-777-81
1-125-777-81
1-164-866-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
(2012)
0.1MF B
0.1MF B
0.1MF B
47PF CH
1005
1005
1005
1005
C3704
C3705
C3706
C3707
C3708
1-112-692-81
1-164-840-81
1-100-567-81
1-100-567-81
1-125-777-81
s
s
s
s
s

C3770
C3778
C3779
C3782
C3784
1-164-866-81
1-112-692-81
1-112-692-81
1-100-567-81
1-112-717-91
s
s
s
s
s

1005
1005
1005
1005
C3709
C3710
C3711
C3712
C3713
1-164-874-81
1-164-874-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3788
C3801
C3802
C3803
C3804
1-165-989-91
1-165-989-91
1-165-989-91
1-112-021-91
1-112-692-81
s
s
s
s
s

C3714
C3715
C3717
C3719
C3720
1-112-692-81
1-112-300-91
1-112-692-81
1-165-989-91
1-112-692-81
s
s
s
s
s

C3805
C3806
C3807
C3808
C3809
1-164-840-81
1-100-567-81
1-100-567-81
1-125-777-81
1-164-874-81
s
s
s
s
s

C3721
C3722
C3726
C3727
C3728
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-164-856-81
s
s
s
s
s
1005
1005
1005
1005
1005
C3810
C3811
C3812
C3813
C3814
1-164-874-81
1-125-777-81
1-100-567-81
1-100-567-81
1-112-692-81
s
s
s
s
s

C3729
C3730
C3731
C3732
C3733
1-164-856-81
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3815
C3817
C3819
C3820
C3821
1-112-300-91
1-112-692-81
1-165-989-91
1-112-692-81
1-112-692-81
s
s
s
s
s

C3734
C3735
C3736
C3737
C3738
1-164-848-81
1-100-567-81
1-100-567-81
1-164-846-81
1-164-862-81
s
s
s
s
s

C3822
C3826
C3827
C3828
C3829
1-100-567-81
1-100-567-81
1-100-567-81
1-164-856-81
1-164-856-81
s
s
s
s
s

C3739
C3740
C3741
C3743
C3744
1-164-840-81
1-164-874-81
1-112-692-81
1-100-567-81
1-100-567-81
s
s
s
s
s

C3830
C3831
C3832
C3833
C3834
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
1-164-848-81
s
s
s
s
s

C3745
C3746
C3747
C3748
C3749
1-100-567-81
1-100-567-81
1-165-989-91
1-112-692-81
1-112-692-81
s
s
s
s
s

1005
1005
1005
1005
C3835
C3836
C3837
C3838
C3840
1-100-567-81
1-100-567-81
1-164-846-81
1-164-862-81
1-164-874-81
s
s
s
s
s

C3750
C3751
C3752
C3753
C3754
1-100-567-81
1-100-567-81
1-125-777-81
1-125-777-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3841
C3843
C3844
C3845
C3846
1-112-692-81
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C3755
C3756
C3757
C3758
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
0.1MF B 1005
0.1MF B 1005
(2012)
0.1MF B 1005
C3847
C3848
C3849
C3850
1-165-989-91
1-112-692-81
1-112-692-81
1-100-567-81
s
s
s
s

7-22
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
B
B
B
B
B
CERAMIC1000PF CH
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
CERAMIC 0.01MF B
1005
1608
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
B
B
B
B
B
1005
1005
1005
1005
1005
C3938
C3939
C3940
C3941
C3942
1-164-856-81
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
1005
1005
1005
1608
C3943
C3944
C3945
C3946
C3947
1-164-848-81
1-100-567-81
1-100-567-81
1-164-846-81
1-164-862-81
s
s
s
s
s

s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
(2012)
0.1MF B 1005
(2012)
0.1MF B 1005
C3948
C3949
C3950
C3952
C3953
1-164-840-81
1-164-874-81
1-112-692-81
1-100-567-81
1-100-567-81
s
s
s
s
s

1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C3954
C3955
C3956
C3957
C3958
1-100-567-81
1-100-567-81
1-165-989-91
1-112-692-81
1-112-692-81
s
s
s
s
s

1005
1005
C3872
C3873
C3874
C3878
C3882
1-100-567-81
1-164-866-81
1-164-866-81
1-112-692-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C3959
C3960
C3961
C3962
C3963
1-100-567-81
1-100-567-81
1-125-777-81
1-125-777-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C3884
C3888
C3901
C3902
C3903
1-112-717-91
1-165-989-91
1-165-989-91
1-112-692-81
1-125-777-81
s
s
s
s
s

C3964
C3965
C3966
C3967
C3968
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B
0.1MF B
(2012)
0.1MF B
0.1MF B
1005
1005
C3904
C3905
C3906
C3907
C3908
1-112-692-81
1-100-567-81
1-164-840-81
1-165-989-91
1-112-692-81
s
s
s
s
s

C3969
C3970
C3971
C3972
C3973
1-125-891-91
1-125-777-81
1-165-989-91
1-125-777-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC0.47MF B 1608

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C3909
C3910
C3911
C3912
C3913
1-100-567-81
1-100-567-81
1-164-874-81
1-112-021-91
1-112-692-81
s
s
s
s
s

C3974
C3975
C3976
C3978
C3982
1-125-777-81
1-125-777-81
1-125-777-81
1-112-692-81
1-100-567-81
s
s
s
s
s

C3914
C3915
C3916
C3917
C3918
1-164-840-81
1-100-567-81
1-100-567-81
1-125-777-81
1-164-874-81
s
s
s
s
s

C3983
C3984
C3985
C3986
C3988
1-165-989-91
1-112-717-91
1-164-866-81
1-164-866-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

CERAMIC 10MF (2012)
C3919
C3920
C3921
C3922
C3923
1-164-874-81
1-125-777-81
1-100-567-81
1-100-567-81
1-112-692-81
s
s
s
s
s

1005
1005
1005
1005
1005
C4001
C4002
C4003
C4004
C4005
1-100-505-91
1-164-866-81
1-100-505-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C3924
C3926
C3928
C3929
C3930
1-112-300-91
1-112-692-81
1-165-989-91
1-112-692-81
1-112-692-81
s
s
s
s
s

C4006
C4007
C4008
C4009
C4010
1-112-815-91
1-164-858-81
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
C (1608)
22PF CH 1005
C (1608)
C (1608)
C (1608)
C3931
C3935
C3936
C3937
1-100-567-81
1-100-567-81
1-100-567-81
1-164-856-81
s
s
s
s

C4011
C4012
C4013
C4014
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C
C
C
C
C3851
C3852
C3853
C3854
C3855
1-100-567-81
1-125-777-81
1-125-777-81
1-100-567-81
1-125-777-81
s
s
s
s
s

C3856
C3857
C3858
C3859
C3860
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
1-125-891-91
s
s
s
s
s
C3861
C3862
C3863
C3864
C3865
1-125-777-81
1-165-989-91
1-125-777-81
1-165-989-91
1-125-777-81
C3866
C3867
C3869
C3870
C3871
HSCU-300
1005
1005
1005
1005
10MF
10MF
10MF
10MF
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
1005
(1608)
(1608)
(1608)
(1608)
7-23
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
D401
D402
D403
D404
D405
8-719-048-98
8-719-070-20
6-501-123-01
8-719-083-60
8-719-083-60
s
s
s
s
s
DIODE RB160L-40TE25
DIODE RB706F-40
DIODE RB160M-60TR
DI UDZSUSTE-174.7B
DI UDZSUSTE-174.7B

D406
D407
D701
D1503
D1504
6-502-197-01
8-719-083-60
6-502-598-01
8-719-989-01
8-719-041-40
s
s
s
s
s
DI SML-D12M8WT86SM
DI UDZSUSTE-174.7B
DI SML-D12U8WT86
DIODE DA221-TL
DIODE KV1470TL00-G
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

D1505
D1506
D1507
D1508
D1509
8-719-989-01
6-500-695-01
6-500-695-01
8-719-069-99
8-719-069-99
s
s
s
s
s
DIODE DA221-TL
DI UDZSUSTE-172.7B
DI UDZSUSTE-172.7B
DIODE 1SS375-TL-E
DIODE 1SS375-TL-E
1-164-874-81
1-112-717-91
1-100-505-91
1-112-015-91
1-100-505-91
s
s
s
s
s

D1602
D2201
D2801
D2802
D3401
8-719-989-04
8-719-082-45
8-719-083-60
6-501-123-01
8-719-083-90
s
s
s
s
s
DIODE DAN222-TL
DIODE RB715W-TL
DI UDZSUSTE-174.7B
DIODE RB160M-60TR
DIODE HVU363ATRU
C4035
C4036
C4037
C4038
C4039
1-112-015-91
1-100-505-91
1-100-505-91
1-112-015-91
1-164-936-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

D3501
D3601
D3602
D3603
D3701
8-719-083-90
8-719-069-28
8-719-069-28
8-719-083-90
8-719-083-90
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
HVU363ATRU
1SS400TE-61
1SS400TE-61
HVU363ATRU
HVU363ATRU
C4041
C4042
C4043
C4044
C4045
1-165-875-91
1-100-567-81
1-164-858-81
1-165-875-91
1-100-055-21
s
s
s
s
s

D3801
D3902
D3904
D3905
8-719-083-90
8-719-083-90
8-719-075-48
8-719-075-48
s
s
s
s
DIODE
DIODE
DIODE
DIODE
HVU363ATRU
HVU363ATRU
1SS390-TE61
1SS390-TE61
C4046
C4047
C4048
C4049
C4050
1-125-777-81
1-165-875-91
1-100-881-91
1-100-611-91
1-100-055-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
E1
E2
E4
E5
E7
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
C4051
C4052
C4053
C4054
C4055
1-100-881-91
1-100-611-91
1-125-777-81
1-100-567-81
1-107-819-81
s
s
s
s
s

E8
E9
E14
E201
E271
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
C4057
C4058
C4059
C4060
C4061
1-112-015-91
1-112-015-91
1-114-236-21
1-114-236-21
1-104-760-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
E272
E1501

CN702
CN3901

1-750-880-11 s RECEPTACLE, COAXIAL CONNECTOR
FB21
FB22
FB301
FB302
FB303
1-469-094-21
1-469-094-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D201
D202
D203
D301
D302
8-719-083-90
8-719-989-04
8-719-989-01
8-719-048-98
8-719-070-20
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
FB304
FB305
FB306
FB307
FB308
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D303
D304
D305
D306
D307
6-501-123-01
8-719-083-60
8-719-083-60
6-501-124-01
6-501-123-01
s
s
s
s
s
DIODE RB160M-60TR
DI UDZSUSTE-174.7B
DI UDZSUSTE-174.7B
DIODE RSX101VA-30TR
DIODE RB160M-60TR
FB309
FB310
FB311
FB312
FB313
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D308
6-501-124-01 s DIODE RSX101VA-30TR
FB314
FB315
1-414-864-21 s FERRITE, EMI (SMD) (1608)

1-414-864-21 s FERRITE, EMI (SMD) (1608)
C4015
C4016
C4017
C4018
C4019
1-112-815-91
1-165-875-91
1-100-505-91
1-100-505-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C4020
C4021
C4022
C4023
C4024
1-112-015-91
1-125-827-91
1-164-935-81
1-164-874-81
1-164-874-81
s
s
s
s
s
C4025
C4026
C4027
C4028
C4029
1-164-933-81
1-100-505-91
1-112-015-91
1-100-505-91
1-100-505-91
C4030
C4031
C4032
C4033
C4034
7-24

CHIP CERAMIC
CHIP CERAMIC
CERAMIC 47MF
CERAMIC 22MF
CHIP CERAMIC
0.1MF B 1005
10MF B 3216
C (3216)
C (2012)
22MF B 3225

CERAMIC 47000PF B (2012)
HVU363ATRU
DAN222-TL
DA221-TL
RB160L-40TE25
RB706F-40
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
FB316
FB317
FB318
FB319
FB320
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB502
FB503
FB504
FB505
FB506
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB321
FB322
FB323
FB324
FB325
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB507
FB701
FB702
FB703
FB704
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB326
FB401
FB402
FB403
FB404
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB705
FB706
FB707
FB708
FB801
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB405
FB406
FB407
FB408
FB409
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB802
FB803
FB900
FB901
FB902
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB410
FB411
FB412
FB413
FB414
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB903
FB906
FB907
FB908
FB911
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB415
FB416
FB417
FB418
FB419
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1101
FB1102
FB1103
FB1104
FB1105
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB420
FB421
FB422
FB423
FB424
1-414-864-21
1-414-864-21
1-469-094-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1106
FB1107
FB1108
FB1109
FB1110
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB425
FB426
FB427
FB428
FB429
1-414-864-21
1-414-864-21
1-469-094-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1111
FB1800
FB1801
FB1804
FB1805
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB430
FB431
FB432
FB433
FB434
1-414-864-21
1-414-864-21
1-469-094-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1808
FB1812
FB2001
FB2301
FB2302
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB435
FB436
FB437
FB438
FB439
1-414-864-21
1-414-864-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB2303
FB2304
FB2305
FB2306
FB2307
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB440
FB441
FB442
FB443
FB444
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB2308
FB2309
FB2310
FB2311
FB2312
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB445
FB446
FB447
FB501
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
FB2313
FB2314
FB2316
FB2317
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
HSCU-300
7-25
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
FB2319
FB2401
FB2402
FB2403
FB2601
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FL3601
FL3701
FL3801
FL3901
FL3902
1-200-089-11
1-200-083-11
1-200-084-11
1-200-090-11
1-200-085-11
s
s
s
s
s
FILTER,
FILTER,
FILTER,
FILTER,
FILTER,
FB2602
FB2701
FB2702
FB2706
FB2801
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC21
IC22
IC201
IC202
IC203
6-706-487-01
6-706-487-01
8-753-321-14
8-753-321-15
6-712-077-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SH08FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
CXA3792Q-T4
CXA3793R-T4
LMH6550MAX
FB2802
FB2806
FB2807
FB2808
FB3402
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC204
IC205
IC206
IC207
IC208
6-712-077-01
8-753-321-14
8-753-321-15
6-712-077-01
6-712-077-01
s
s
s
s
s
IC
IC
IC
IC
IC
LMH6550MAX
CXA3792Q-T4
CXA3793R-T4
LMH6550MAX
LMH6550MAX
FB3403
FB3404
FB3406
FB3407
FB3408
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC209
IC210
IC211
IC212
IC213
6-706-482-01
6-706-482-01
6-706-487-01
6-706-489-01
6-706-482-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SH00FU(T5RSOYJF)
TC7SH00FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
TC7SH32FU(T5RSOYJF)
TC7SH00FU(T5RSOYJF)
FB3409
FB3502
FB3503
FB3504
FB3506
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC215
IC216
IC217
IC301
IC302
6-706-906-01
8-759-346-27
6-712-383-01
6-701-549-01
6-700-655-01
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2732RB1(TE2)
LM45BIM3X
TC74VHC4051AFT(EK)
LTC1778EGN
LT1963ES8#TR
FB3507
FB3602
FB3603
FB3604
FB3606
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC303
IC304
IC305
IC306
IC307
6-705-481-01
6-706-136-01
8-759-327-01
6-704-976-01
6-712-135-01
s
s
s
s
o
IC
IC
IC
IC
IC
LT1931ES5#TR
LTC3412EFE#TR
NJM062V(TE2)
ADR381ARTZ-REEL7
R1173H001D-T1-F
FB3607
FB3608
FB3609
FB3702
FB3703
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC308
IC309
IC310
IC311
IC312
6-712-135-01
6-705-481-01
6-712-135-01
8-759-338-95
6-706-482-01
o
s
o
s
s
IC
IC
IC
IC
IC
R1173H001D-T1-F
LT1931ES5#TR
R1173H001D-T1-F
NJM2903V(TE2)
TC7SH00FU(T5RSOYJF)
FB3704
FB3706
FB3707
FB3708
FB3709
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC401
IC402
IC403
IC404
IC405
6-701-549-01
6-706-136-01
6-706-136-01
6-706-136-01
6-706-220-01
s
s
s
s
s
IC
IC
IC
IC
IC
LTC1778EGN
LTC3412EFE#TR
LTC3412EFE#TR
LTC3412EFE#TR
LTC3411EMS#TR
FB3802
FB3803
FB3804
FB3806
FB3807
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC406
IC407
IC408
IC409
IC410
6-706-482-01
6-706-220-01
6-704-976-01
6-712-135-01
6-700-655-01
s
s
s
o
s
IC
IC
IC
IC
IC
TC7SH00FU(T5RSOYJF)
LTC3411EMS#TR
ADR381ARTZ-REEL7
R1173H001D-T1-F
LT1963ES8#TR
FB3808
FB3809
FB3902
FB3903
FB3904
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
IC411
IC412
IC414
IC415
IC416
8-759-327-01
6-705-481-01
6-706-482-01
6-702-879-01
6-702-879-01
s
s
s
s
s
IC
IC
IC
IC
IC
NJM062V(TE2)
LT1931ES5#TR
TC7SH00FU(T5RSOYJF)
R3112N281A-TR-FA
R3112N281A-TR-FA
FB3906
FB3907
1-414-864-21 s FERRITE, EMI (SMD) (1608)

1-414-864-21 s FERRITE, EMI (SMD) (1608)
FL201
FL202
FL1501
FL1502
FL3401
1-200-086-11
1-200-081-11
1-200-078-11
1-200-079-11
1-200-087-11
IC417
IC418
IC501
IC502
IC503
8-759-338-95
6-706-482-01
6-708-538-01
8-759-592-47
6-703-875-01
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2903V(TE2)
TC7SH00FU(T5RSOYJF)
CDCVF2510APWR
TC7SZ08FU(TE85R)
CDCVF2505PWR
FL3501
1-200-088-11 s FILTER, BAND PASS (16MHZ)
IC504
IC505
IC506
IC507
6-708-538-01
6-707-875-01
6-706-478-01
6-707-875-01
s
s
s
s
IC
IC
IC
IC
CDCVF2510APWR
TC74VHC245FT(EKJ)
TC7SET08FU(T5RSOJF)
TC74VHC245FT(EKJ)
7-26
s
s
s
s
s
FILTER,
FILTER,
FILTER,
FILTER,
FILTER,
BAND
BAND
BAND
BAND
BAND
PASS
PASS
PASS
PASS
PASS
(82-110MHZ)
(96MHZ)
(1.0MHZ)
(1.4MHZ)
(6MHZ)
BAND PASS
BAND PASS
BAND PASS
MULTIPLEX
BAND PASS
(26MHZ)
(46MHZ)
(56MHZ)
(66MHZ)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
IC508
IC509
IC510
IC511
IC513
6-707-875-01
8-759-592-47
6-707-875-01
6-707-845-01
6-702-879-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC74VHC245FT(EKJ)
TC7SZ08FU(TE85R)
TC74VHC245FT(EKJ)
TC74LCX138FT(EKJ)
R3112N281A-TR-FA
IC1612
IC1613
IC1614
IC1615
IC1616
8-759-337-40
8-759-337-40
6-712-383-01
8-759-337-40
8-759-278-58
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2904V(TE2)
NJM2904V(TE2)
TC74VHC4051AFT(EK)
NJM2904V(TE2)
NJM4558V-TE2
IC514
IC515
IC517
IC518
IC519
8-759-592-47
8-759-592-47
8-759-592-47
8-759-592-47
8-759-592-47
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
IC1617
IC1618
IC1701
IC1800
IC1801
8-759-278-58
6-710-944-01
6-706-487-01
6-708-637-01
8-759-592-47
s
s
s
s
s
IC
IC
IC
IC
IC
NJM4558V-TE2
TC74VHC573FK(EL,K)
TC7SH08FU(T5RSOYJF)
NJM2871BF33-TE2
TC7SZ08FU(TE85R)
IC520
IC523
IC524
IC601
IC602
6-708-637-01
8-759-592-47
8-759-592-47
6-708-506-01
6-708-506-01
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2871BF33-TE2
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
ML86V7666TBZ03A
ML86V7666TBZ03A
IC2002
IC2003
IC2005
IC2101
IC2102
6-701-874-01
6-707-856-01
8-759-592-47
6-713-495-01
6-713-495-01
s
s
s
s
s
IC
IC
IC
IC
IC
IDT71V016SA15PHG-TL
TC74LCX74FT(EKJ)
TC7SZ08FU(TE85R)
W9864G2GH-6-W-ER10
W9864G2GH-6-W-ER10
IC701
IC702
IC703
IC704
IC705
6-712-922-01
8-759-592-49
8-759-592-49
6-707-856-01
6-706-487-01
s
s
s
s
s
IC
IC
IC
IC
IC
EPCS16SI8N
TC7SZ125FU(TE85R)
TC7SZ125FU(TE85R)
TC74LCX74FT(EKJ)
TC7SH08FU(T5RSOYJF)
IC2103
IC2104
IC2201
IC2202
IC2203
6-713-495-01
6-713-495-01
6-702-787-01
6-702-787-01
6-702-787-01
s
s
s
s
s
IC
IC
IC
IC
IC
W9864G2GH-6-W-ER10
W9864G2GH-6-W-ER10
UPD6467GR-525-E2
UPD6467GR-525-E2
UPD6467GR-525-E2
IC706
IC707
IC708
IC709
IC710
6-707-856-01
6-707-855-01
6-707-855-01
8-759-592-47
8-759-592-47
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX74FT(EKJ)
TC74LCX574FT(EKJ)
TC74LCX574FT(EKJ)
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
IC2204
IC2205
IC2301
IC2302
IC2303
8-759-592-47
6-706-478-01
6-706-484-01
8-759-592-49
6-706-484-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ08FU(TE85R)
TC7SET08FU(T5RSOJF)
TC7SH04FU(T5RSOYJF)
TC7SZ125FU(TE85R)
TC7SH04FU(T5RSOYJF)
IC711
IC713
IC900
IC901
IC902
8-759-592-47
6-707-842-01
6-707-855-01
6-708-637-01
6-707-855-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ08FU(TE85R)
TC74LCX08FT(EKJ)
TC74LCX574FT(EKJ)
NJM2871BF33-TE2
TC74LCX574FT(EKJ)
IC2304
IC2305
IC2306
IC2307
IC2310
8-759-592-49
6-708-637-01
8-759-592-49
8-759-592-49
6-708-637-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ125FU(TE85R)
NJM2871BF33-TE2
TC7SZ125FU(TE85R)
TC7SZ125FU(TE85R)
NJM2871BF33-TE2
IC903
IC1102
IC1103
IC1104
IC1109
8-759-592-47
6-708-637-01
6-713-512-01
6-713-512-01
6-708-637-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ08FU(TE85R)
NJM2871BF33-TE2
AD9744ACPZ
AD9744ACPZ
NJM2871BF33-TE2
IC2311
IC2312
IC2402
IC2501
IC2601
6-712-135-01
6-712-135-01
8-759-672-76
6-707-557-01
6-702-787-01
o
o
s
s
s
IC
IC
IC
IC
IC
R1173H001D-T1-F
R1173H001D-T1-F
AK9813BF-E2
CXD9186R
UPD6467GR-525-E2
IC1501
IC1502
IC1503
IC1504
IC1505
6-706-863-01
6-713-713-01
8-759-278-58
8-759-083-42
8-759-278-58
s
s
s
s
s
IC
IC
IC
IC
IC
LMH6732MFX/NOPB
LA1235M-TLM-E
NJM4558V-TE2
TC4W53FU(TE12R)
NJM4558V-TE2
IC2602
IC2603
IC2604
IC2605
IC2606
6-707-556-01
6-706-474-01
8-759-422-21
8-752-371-56
6-706-484-01
s
s
s
s
s
IC
IC
IC
IC
IC
CXD9184R
TC7SET00FU(T5RSOJF)
NJM4580V(TE2)
CXD1171M-TH
TC7SH04FU(T5RSOYJF)
IC1506
IC1507
IC1508
IC1509
IC1510
8-759-278-58
6-706-487-01
8-759-083-42
8-759-278-58
8-759-278-58
s
s
s
s
s
IC
IC
IC
IC
IC
NJM4558V-TE2
TC7SH08FU(T5RSOYJF)
TC4W53FU(TE12R)
NJM4558V-TE2
NJM4558V-TE2
IC2608
IC2609
IC2610
IC2611
IC2612
8-759-276-25
6-706-474-01
8-752-349-19
6-707-855-01
6-702-787-01
s
s
s
s
s
IC
IC
IC
IC
IC
TLC272CPSR
TC7SET00FU(T5RSOJF)
CXD1176Q-T4
TC74LCX574FT(EKJ)
UPD6467GR-525-E2
IC1511
IC1512
IC1513
IC1514
IC1515
6-713-784-01
8-759-144-73
6-706-487-01
8-759-422-21
6-706-487-01
s
s
s
s
s
IC
IC
IC
IC
IC
NJM567M(TE2)
UPC393G2-E2
TC7SH08FU(T5RSOYJF)
NJM4580V(TE2)
TC7SH08FU(T5RSOYJF)
IC2613
IC2614
IC2615
IC2701
IC2702
8-759-592-47
8-759-592-47
6-706-474-01
6-706-478-01
6-706-478-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ08FU(TE85R)
TC7SZ08FU(TE85R)
TC7SET00FU(T5RSOJF)
TC7SET08FU(T5RSOJF)
TC7SET08FU(T5RSOJF)
IC1601
IC1602
IC1603
IC1604
IC1605
8-759-337-40
8-759-337-40
8-759-337-40
8-759-337-40
8-759-337-40
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2904V(TE2)
NJM2904V(TE2)
NJM2904V(TE2)
NJM2904V(TE2)
NJM2904V(TE2)
IC2703
IC2704
IC2705
IC2706
IC2707
8-752-391-99
8-752-391-99
8-752-391-99
6-712-382-01
8-759-561-46
s
s
s
s
s
IC
IC
IC
IC
IC
CXD2315Q-T4
CXD2315Q-T4
CXD2315Q-T4
TC74VHC4053AFT(EK)
AD8014ARTZ-REEL7
IC1606
IC1607
IC1609
IC1611
8-759-337-40
8-759-337-40
6-706-487-01
8-759-337-40
s
s
s
s
IC
IC
IC
IC
NJM2904V(TE2)
NJM2904V(TE2)
TC7SH08FU(T5RSOYJF)
NJM2904V(TE2)
IC2708
IC2709
IC2710
IC2711
8-759-561-46
6-712-382-01
8-759-561-46
6-712-135-01
s
s
s
o
IC
IC
IC
IC
AD8014ARTZ-REEL7
TC74VHC4053AFT(EK)
AD8014ARTZ-REEL7
R1173H001D-T1-F
HSCU-300
7-27
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
IC2801
IC2802
IC2803
IC2804
IC2805
6-706-478-01
6-706-478-01
8-759-327-01
6-712-135-01
6-706-471-01
s
s
s
o
s
IC
IC
IC
IC
IC
TC7SET08FU(T5RSOJF)
TC7SET08FU(T5RSOJF)
NJM062V(TE2)
R1173H001D-T1-F
THS5661AIPWR
L307
L308
L401
L402
L403
1-416-344-21
1-416-344-21
1-419-630-21
1-481-180-21
1-457-372-21
s
s
s
s
s
COIL, CHOKE 10UH

COIL, CHOKE 10UH
COIL, CHOKE 4.7UH
INDUCTOR 10UH
COIL, CHOKE 1UH
IC2806
IC2807
IC2808
IC2809
IC2810
6-706-471-01
6-706-471-01
8-759-561-46
8-759-561-46
8-759-561-46
s
s
s
s
s
IC
IC
IC
IC
IC
THS5661AIPWR
THS5661AIPWR
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
L404
L405
L406
L407
L408
1-457-372-21
1-457-372-21
1-419-630-21
1-416-344-21
1-416-344-21
s
s
s
s
s
COIL,
COIL,
COIL,
COIL,
COIL,
IC2811
IC3401
IC3402
IC3403
IC3404
6-705-481-01
8-753-321-15
8-753-321-14
8-753-321-15
8-753-276-53
s
s
s
s
s
IC
IC
IC
IC
IC
LT1931ES5#TR
CXA3793R-T4
CXA3792Q-T4
CXA3793R-T4
CXD1968AR-T6
L501
L601
L602
L603
L604
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC3405
IC3501
IC3502
IC3504
IC3505
8-759-561-46
8-753-321-15
8-753-321-14
8-753-276-53
8-759-561-46
s
s
s
s
s
IC
IC
IC
IC
IC
AD8014ARTZ-REEL7
CXA3793R-T4
CXA3792Q-T4
CXD1968AR-T6
AD8014ARTZ-REEL7
L605
L606
L607
L608
L609
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC3601
IC3602
IC3604
IC3605
IC3606
8-753-321-15
8-753-321-14
8-753-276-53
8-759-561-46
6-713-951-01
s
s
s
s
s
IC
IC
IC
IC
IC
CXA3793R-T4
CXA3792Q-T4
CXD1968AR-T6
AD8014ARTZ-REEL7
LMH6624MFX
L610
L611
L612
L701
L702
1-414-398-41
1-414-398-41
1-414-398-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
1.0UH
1.0UH
IC3701
IC3702
IC3704
IC3705
IC3801
8-753-321-15
8-753-321-14
8-753-276-53
6-713-951-01
8-753-321-15
s
s
s
s
s
IC
IC
IC
IC
IC
CXA3793R-T4
CXA3792Q-T4
CXD1968AR-T6
LMH6624MFX
CXA3793R-T4
L703
L704
L1101
L1102
L1103
1-414-392-41
1-414-398-41
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
10.0UH
1.0UH
1.0UH
1.0UH
IC3802
IC3804
IC3805
IC3806
IC3901
8-753-321-14
8-753-276-53
6-713-951-01
6-706-863-01
8-753-321-15
s
s
s
s
s
IC
IC
IC
IC
IC
CXA3792Q-T4
CXD1968AR-T6
LMH6624MFX
LMH6732MFX/NOPB
CXA3793R-T4
L1104
L1105
L1106
L1501
L1502
1-414-398-41
1-414-398-41
1-414-463-41
1-414-398-41
1-414-404-41
s
s
s
s
s
INDUCTOR (SMD)
INDUCTOR (SMD)
INDUCTOR, CHIP
INDUCTOR (SMD)
INDUCTOR (SMD)
10.0UH
10.0UH
(J) 10NH
10.0UH
100.0UH
IC3902
IC3904
IC3905
IC3906
IC3907
8-753-321-14
8-753-276-53
6-713-951-01
6-713-951-01
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
CXA3792Q-T4
CXD1968AR-T6
LMH6624MFX
LMH6624MFX
TC7W53FK(TE85R)
L1503
L1504
L1505
L1506
L1507
1-414-398-41
1-414-402-41
1-400-542-11
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
330UH
(SMD)
(SMD)
10.0UH
47.0UH
L201
L202
L203
L204
L205
1-414-398-41
1-412-935-21
1-412-935-21
1-456-901-11
1-481-612-11
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD) 10.0UH
0.47UH (2520)
0.47UH (2520)
82NH
120NH
L1508
L1509
L1601
L1602
L1603
1-414-398-41
1-414-400-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
22.0UH
10.0UH
10.0UH
10.0UH
L206
L207
L208
L209
L210
1-481-612-11
1-412-935-21
1-412-935-21
1-481-612-11
1-481-612-11
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
120NH
0.47UH (2520)
0.47UH (2520)
120NH
120NH
L1701
L1702
L1703
L2001
L2002
1-414-392-41
1-414-392-41
1-414-398-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
10.0UH
1.0UH
1.0UH
L211
L212
L213
L214
L301
1-414-398-41
1-412-935-21
1-469-549-21
1-412-975-41
1-416-344-21
s
s
s
s
s

INDUCTOR 0.47UH (2520)
INDUCTOR, CHIP 1.0UH (LB2016)
INDUCTOR, SMALL TYPE 0.47UH
COIL, CHOKE 10UH
L2003
L2004
L2101
L2102
L2103
1-414-392-41
1-414-398-41
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
10.0UH
1.0UH
1.0UH
1.0UH
L303
L304
L305
L306
1-481-180-21
1-416-344-21
1-416-344-21
1-416-344-21
s
s
s
s
INDUCTOR 10UH
COIL, CHOKE 10UH
COIL, CHOKE 10UH
COIL, CHOKE 10UH
L2104
L2201
L2202
L2203
1-414-392-41
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
1.0UH
1.0UH
7-28
CHOKE
CHOKE
CHOKE
CHOKE
CHOKE
1UH
1UH
4.7UH
10UH
10UH
10.0UH
10.0UH
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
L2204
L2205
L2207
L2301
L2302
1-414-392-41
1-414-392-41
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
1.0UH
1.0UH
1.0UH
L3403
L3404
L3405
L3406
L3407
1-412-939-21
1-412-939-21
1-481-608-11
1-481-608-11
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1.0UH (2520)
1.0UH (2520)
330NH
330NH
(SMD) 1.0UH
L2401
L2402
L2403
L2405
L2501
1-414-392-41
1-414-392-41
1-414-392-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
1.0UH
10.0UH
10.0UH
L3408
L3409
L3501
L3502
L3503
1-456-906-11
1-414-392-41
1-414-392-41
1-414-392-41
1-412-939-21
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
820NH
(SMD)
(SMD)
(SMD)
1.0UH
L2502
L2601
L2602
L2603
L2604
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
L3504
L3505
L3507
L3508
L3509
1-412-939-21
1-456-902-11
1-414-392-41
1-456-906-11
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1.0UH (2520)
220NH
(SMD) 1.0UH
820NH
(SMD) 1.0UH
L2605
L2606
L2607
L2608
L2609
1-412-947-21
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
4.7UH
(SMD)
(SMD)
(SMD)
(SMD)
(2520)
10.0UH
10.0UH
10.0UH
10.0UH
L3510
L3601
L3602
L3603
L3604
1-414-392-41
1-414-392-41
1-414-392-41
1-412-939-21
1-412-939-21
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
L2610
L2611
L2612
L2701
L2702
1-416-344-21
1-416-344-21
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
COIL, CHOKE 10UH

COIL, CHOKE 10UH
L3605
L3606
L3607
L3608
L3609
1-481-608-11
1-400-657-21
1-414-392-41
1-456-906-11
1-414-392-41
s
s
s
s
s
INDUCTOR 330NH
INDUCTOR, CHIP 15UH (2520)
INDUCTOR 820NH
L2703
L2704
L2705
L2706
L2707
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-412-939-21
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
10.0UH
10.0UH
10.0UH
10.0UH
(2520)
L3610
L3611
L3701
L3702
L3703
1-414-392-41
1-400-197-21
1-414-392-41
1-414-392-41
1-412-939-21
s
s
s
s
s
INDUCTOR (SMD)
INDUCTOR, CHIP
INDUCTOR (SMD)
INDUCTOR (SMD)
INDUCTOR 1.0UH
1.0UH
12UH (2520)
1.0UH
1.0UH
(2520)
L2708
L2709
L2710
L2712
L2713
1-412-939-21
1-412-939-21
1-414-392-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1.0UH
1.0UH
(SMD)
(SMD)
(SMD)
(2520)
(2520)
1.0UH
10.0UH
10.0UH
L3704
L3706
L3707
L3708
L3709
1-412-939-21
1-456-906-11
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1.0UH
820NH
(SMD)
(SMD)
(SMD)
(2520)
L2714
L2715
L2716
L2717
L2718
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
1.0UH
L3801
L3802
L3803
L3804
L3805
1-414-392-41
1-414-392-41
1-412-939-21
1-412-939-21
1-481-611-11
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
1.0UH
1.0UH
150NH
1.0UH
1.0UH
(2520)
(2520)
L2801
L2802
L2803
L2804
L2805
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
L3806
L3807
L3808
L3809
L3901
1-456-906-11
1-414-392-41
1-414-392-41
1-414-392-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
820NH
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
1.0UH
1.0UH
L2806
L2807
L2808
L2809
L2810
1-414-398-41
1-412-947-21
1-412-947-21
1-412-947-21
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
4.7UH
4.7UH
4.7UH
(SMD)
10.0UH
(2520)
(2520)
(2520)
10.0UH
L3902
L3903
L3904
L3905
L3906
1-414-392-41
1-412-939-21
1-412-939-21
1-481-610-11
1-456-906-11
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD) 1.0UH
1.0UH (2520)
1.0UH (2520)
110NH
820NH
L2811
L2812
L2813
L2814
L2815
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
L3907
L3908
L3909
1-414-392-41 s INDUCTOR (SMD) 1.0UH

L2816
L2817
L3401
L3402
1-414-398-41
1-414-398-41
1-414-392-41
1-414-392-41
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
1.0UH
1.0UH
LV1501
LV1502
LV1503
1-457-738-11 s COIL, VARIABLE (150UH)

1-457-740-11 s COIL, VARIABLE (1.4MHZ)
1-457-739-11 s COIL, VARIABLE (1.4MHZ)
Q201
Q202
8-729-144-81 s TRANSISTOR 2SC4176T1B33B34B35

8-729-144-81 s TRANSISTOR 2SC4176T1B33B34B35
HSCU-300
1.0UH
1.0UH
1.0UH
(2520)
1.0UH
1.0UH
1.0UH
(2520)
(2520)
1.0UH
1.0UH
1.0UH
7-29
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
Q203
Q204
Q205
Q206
Q207
8-729-144-81
8-729-144-81
8-729-144-81
8-729-111-97
8-729-111-97
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4176T1B33B34B35
2SC4176T1B33B34B35
2SC4176T1B33B34B35
2SC3356-T1K
2SC3356-T1K
R23
R24
R25
R26
R201
1-208-863-81
1-208-863-81
1-208-911-81
1-208-911-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
10K
10K
15K
Q208
Q209
Q210
Q211
Q212
8-729-111-97
8-729-111-97
8-729-111-97
8-729-111-97
8-729-144-81
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3356-T1K
2SC3356-T1K
2SC3356-T1K
2SC3356-T1K
2SC4176T1B33B34B35
R203
R204
R205
R206
R207
1-208-911-81
1-208-887-81
1-208-903-81
1-218-947-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
1.0K (1005)
4.7K (1005)
330
330 (1005)
Q213
Q214
Q215
Q301
Q302
8-729-144-81
8-729-144-81
8-729-144-81
8-729-054-35
8-729-054-35
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4176T1B33B34B35
2SC4176T1B33B34B35
2SC4176T1B33B34B35
HAT2070R-EL
HAT2070R-EL
R208
R209
R210
R211
R212
1-208-907-81
1-208-907-81
1-208-907-81
1-208-879-81
1-208-879-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
6.8K (1005)
6.8K (1005)
6.8K (1005)
470 (1005)
470 (1005)
Q303
Q304
Q305
Q306
Q307
8-729-035-99
6-550-632-01
8-729-928-05
8-729-928-05
8-729-928-82
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1615-Z-E2
2SC4672-T100-Q
2SC4617TL-QR
2SC4617TL-QR
DTC144EE-TL
R213
R214
R215
R216
R217
1-218-947-81
1-208-875-81
1-208-907-81
1-208-907-81
1-208-907-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330
330 (1005)
6.8K (1005)
6.8K (1005)
6.8K (1005)
Q308
Q309
Q310
Q401
Q402
8-729-928-82
8-729-928-82
8-729-928-82
8-729-054-35
8-729-054-35
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144EE-TL
DTC144EE-TL
DTC144EE-TL
HAT2070R-EL
HAT2070R-EL
R218
R219
R220
R221
R222
1-208-879-81
1-208-879-81
1-220-874-81
1-220-874-81
1-220-874-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
470 (1005)
15 (1005)
15 (1005)
15 (1005)
Q403
Q404
Q405
Q406
Q407
8-729-928-05
6-550-631-01
6-550-632-01
8-729-928-05
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SA1797-T100-Q
2SC4672-T100-Q
2SC4617TL-QR
2SA1774TL-QR
R223
R224
R225
R226
R227
1-220-874-81
1-208-879-81
1-208-879-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15 (1005)
470 (1005)
470 (1005)
220 (1005)
220 (1005)
Q408
Q409
Q410
Q411
Q412
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-82
8-729-928-82
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
DTC144EE-TL
DTC144EE-TL
R228
R229
R230
R231
R232
1-208-883-81
1-208-883-81
1-208-860-81
1-208-860-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
680 (1005)
75 (1005)
75 (1005)
10 (1005)
Q413
Q414
Q415
Q601
Q602
8-729-928-82
8-729-928-82
8-729-928-05
8-729-928-25
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144EE-TL
DTC144EE-TL
2SC4617TL-QR
2SA1774TL-QR
2SA1774TL-QR
R233
R234
R235
R236
R237
1-208-915-81
1-208-911-81
1-208-895-81
1-208-915-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
10K (1005)
2.2K (1005)
15K (1005)
10 (1005)
Q701
Q1501
Q1502
Q1503
Q1504
8-729-928-28
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-05
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA144EE-TL
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
R238
R239
R240
R241
R242
1-208-911-81
1-208-875-81
1-208-875-81
1-208-895-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
330 (1005)
330 (1005)
2.2K (1005)
10K (1005)
Q1505
Q1601
Q1602
Q1603
Q1604
8-729-928-25
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-05
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1774TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
R243
R244
R245
R246
R248
1-208-927-81
1-220-882-81
1-208-879-81
1-208-879-81
1-208-879-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
33 (1005)
470 (1005)
470 (1005)
470 (1005)
Q1605
Q2801
Q2802
Q2803
Q2804
8-729-928-05
8-729-928-25
8-729-928-05
8-729-928-25
8-729-928-82
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SA1774TL-QR
2SC4617TL-QR
2SA1774TL-QR
DTC144EE-TL
R249
R250
R251
R252
R253
1-208-875-81
1-208-875-81
1-220-874-81
1-220-874-81
1-220-874-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330 (1005)
330 (1005)
15 (1005)
15 (1005)
15 (1005)
Q2805
6-550-632-01 s TRANSISTOR 2SC4672-T100-Q
R21
R22
1-208-863-81 s RES, CHIP 100 (1005)

1-208-863-81 s RES, CHIP 100 (1005)
R254
R255
R256
R257
1-220-874-81
1-208-879-81
1-208-879-81
1-208-871-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
15 (1005)
470 (1005)
470 (1005)
220 (1005)
7-30
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R258
R259
R260
R261
R262
1-208-871-81
1-208-883-81
1-208-883-81
1-208-860-81
1-208-860-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
680 (1005)
680 (1005)
75 (1005)
75 (1005)
R320
R321
R322
R323
R324
1-208-919-81
1-208-911-81
1-208-899-81
1-208-943-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R263
R264
R265
R266
R267
1-220-870-81
1-208-915-81
1-208-911-81
1-208-895-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
15K (1005)
10K (1005)
2.2K (1005)
15K (1005)
R325
R326
R327
R328
R329
1-243-975-81
1-218-990-81
1-208-871-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES, CHIP 4.7M (1005)

RES, CHIP 220 (1005)
R268
R269
R270
R271
R272
1-220-870-81
1-208-911-81
1-208-875-81
1-208-875-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10K (1005)
330 (1005)
330 (1005)
2.2K (1005)
R330
R331
R332
R333
R334
1-208-927-81
1-208-871-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R273
R274
R275
R276
R277
1-208-879-81
1-208-879-81
1-208-875-81
1-208-875-81
1-218-990-81
s
s
s
s
s
RES, CHIP 470 (1005)

RES, CHIP 470 (1005)
RES, CHIP 330 (1005)
RES, CHIP 330 (1005)
R335
R336
R337
R338
R339
1-208-911-81
1-208-871-81
1-208-927-81
1-220-234-91
1-208-895-81
s
s
s
s
s

RES, CHIP 220 (1005)
RES,SQUARE TYPE CHIP 4.7(3225)
RES, CHIP 2.2K (1005)
R278
R279
R280
R281
R282
1-218-990-81
1-220-870-81
1-218-990-81
1-208-899-81
1-218-990-81
s
s
s
s
s

RES, CHIP 10 (1005)
RES, CHIP 3.3K (1005)
R340
R341
R342
R343
R344
1-208-911-81
1-208-919-81
1-208-895-81
1-208-911-81
1-220-230-91
s
s
s
s
s

RES, CHIP 2.2K (1005)
R283
R284
R285
R286
R287
1-208-887-81
1-208-899-81
1-218-990-81
1-208-923-81
1-208-915-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 3.3K (1005)
R345
R346
R347
R348
R349
1-208-919-81
1-208-887-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
1.0K (1005)
10K (1005)
10K (1005)
10K (1005)
R288
R289
R290
R292
R293
1-208-919-81
1-208-927-81
1-208-911-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
10K
47K
47K
R350
R351
R352
R353
R354
1-208-919-81
1-208-919-81
1-218-823-91
1-218-823-91
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
100
100
22K
R294
R295
R297
R298
R299
1-208-911-81
1-208-935-81
1-208-923-81
1-208-899-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100K (1005)
33K (1005)
3.3K (1005)
33K (1005)
R355
R356
R357
R358
R359
1-208-935-81
1-208-899-81
1-208-875-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
3.3K (1005)
330 (1005)
47K (1005)
10K (1005)
R301
R302
R303
R304
R305
1-208-927-81
1-208-923-81
1-208-911-81
1-208-927-81
1-208-913-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
33K
10K
47K
12K
R360
R361
R362
R363
R364
1-220-234-91
1-208-895-81
1-208-911-81
1-208-919-81
1-208-895-81
s
s
s
s
s

RES, CHIP 2.2K (1005)
RES, CHIP 2.2K (1005)
R306
R307
R308
R309
R310
1-208-951-81
1-208-939-81
1-218-236-91
1-220-230-91
1-220-230-91
s
s
s
s
s
RES, CHIP 470K (1005)

RES, CHIP 150K (1005)
R365
R366
R367
R369
R370
1-208-911-81
1-208-863-81
1-208-935-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R311
R312
R313
R314
R315
1-208-919-81
1-208-887-81
1-208-911-81
1-208-911-81
1-220-230-91
s
s
s
s
s

RES, CHIP 1.0K (1005)
R371
R372
R373
R374
R375
1-218-990-81
1-208-911-81
1-208-959-81
1-208-959-81
1-208-863-81
s
s
s
s
s

RES, CHIP 1M (1005)
RES, CHIP 1M (1005)
RES, CHIP 100 (1005)
R316
R317
R318
R319
1-208-899-81
1-208-927-81
1-243-975-81
1-208-919-81
s
s
s
s
RES,
RES,
RES,
RES,
R377
R378
R401
R402
1-208-951-81
1-208-935-81
1-208-927-81
1-208-923-81
s
s
s
s
RES,
RES,
RES,
RES,
HSCU-300
CHIP
CHIP
CHIP
CHIP
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
3.3K (1005)
47K (1005)
4.7M (1005)
22K (1005)
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
10K (1005)
3.3K (1005)
220K (1005)
22K (1005)
47K
220
47K
47K
47K
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1608)
(1608)
(1005)
10K (1005)
100 (1005)
100K (1005)
22K (1005)
22K (1005)
470K (1005)
100K (1005)
47K (1005)
33K (1005)
7-31
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
R403
R404
R405
R406
R407
1-208-911-81
1-208-927-81
1-208-913-81
1-208-951-81
1-208-939-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
10K (1005)
47K (1005)
12K (1005)
470K (1005)
150K (1005)
R466
R467
R468
R469
R470
1-208-871-81
1-208-911-81
1-208-919-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R408
R409
R410
R411
R412
1-218-236-91
1-220-230-91
1-208-919-81
1-208-951-81
1-208-863-81
s
s
s
s
s

RES, CHIP 470K (1005)
RES, CHIP 100 (1005)
R471
R472
R474
R475
R476
1-211-899-91
1-208-863-81
1-208-919-81
1-208-911-81
1-208-927-81
s
s
s
s
s
RES,SQUARE TYPE CHIP 0.22 3225

RES, CHIP 100 (1005)
R414
R415
R416
R417
R418
1-208-959-81
1-243-975-81
1-208-919-81
1-208-919-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
4.7M (1005)
22K (1005)
22K (1005)
15K (1005)
R477
R478
R479
R480
R481
1-208-911-81
1-208-907-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R419
R420
R421
R422
R423
1-208-891-81
1-208-943-81
1-208-919-81
1-243-975-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
220K (1005)
22K (1005)
4.7M (1005)
3.3K (1005)
R482
R483
R484
R485
R486
1-208-863-81
1-208-863-81
1-220-870-81
1-208-911-81
1-220-230-91
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 100 (1005)
RES, CHIP 10 (1005)
R424
R425
R426
R427
R428
1-208-927-81
1-220-230-91
1-208-959-81
1-243-975-81
1-243-975-81
s
s
s
s
s

RES, CHIP 1M (1005)
RES, CHIP 4.7M (1005)
RES, CHIP 4.7M (1005)
R487
R488
R489
R490
R491
1-208-871-81
1-208-871-81
1-208-919-81
1-208-887-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
22K (1005)
1.0K (1005)
10K (1005)
R429
R430
R431
R432
R433
1-208-919-81
1-208-919-81
1-208-915-81
1-208-883-81
1-208-943-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
22K (1005)
15K (1005)
680 (1005)
220K (1005)
R492
R493
R494
R495
R496
1-208-911-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
47K
47K
47K
47K
R434
R435
R436
R437
R438
1-208-935-81
1-208-959-81
1-208-959-81
1-208-887-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
1M (1005)
1M (1005)
1.0K (1005)
33K (1005)
R497
R498
R499
R501
R502
1-208-927-81
1-208-911-81
1-208-911-81
1-208-919-81
1-211-969-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
10K (1005)
10K (1005)
22K (1005)
10 (1608)
R439
R440
R441
R442
R443
1-220-230-91
1-208-919-81
1-208-891-81
1-208-915-81
1-243-975-81
s
s
s
s
s

RES, CHIP 1.5K (1005)
RES, CHIP 4.7M (1005)
R503
R504
R505
R509
R510
1-211-969-91
1-220-878-81
1-220-878-81
1-220-878-81
1-218-990-81
s
s
s
s
s
RES, CHIP 10 (1608)

RES, CHIP 22 (1005)
RES, CHIP 22 (1005)
RES, CHIP 22 (1005)
R444
R445
R446
R447
R448
1-243-975-81
1-208-919-81
1-208-915-81
1-208-899-81
1-208-943-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
4.7M (1005)
22K (1005)
15K (1005)
3.3K (1005)
220K (1005)
R511
R513
R514
R518
R519
1-208-895-81
1-208-879-81
1-220-878-81
1-208-863-81
1-218-990-81
s
s
s
s
s
RES, CHIP 2.2K (1005)

RES, CHIP 470 (1005)
RES, CHIP 22 (1005)
RES, CHIP 100 (1005)
R449
R450
R452
R454
R455
1-208-935-81
1-208-935-81
1-220-230-91
1-208-919-81
1-208-911-81
s
s
s
s
s
RES, CHIP 100K (1005)

RES, CHIP 100K (1005)
R520
R521
R523
R524
R525
1-220-878-81
1-208-911-81
1-208-879-81
1-208-863-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
10K (1005)
470 (1005)
100 (1005)
22 (1005)
R456
R457
R458
R459
R460
1-208-935-81
1-208-911-81
1-208-943-81
1-243-975-81
1-220-230-91
s
s
s
s
s
RES, CHIP 100K (1005)

RES, CHIP 220K (1005)
RES, CHIP 4.7M (1005)
R526
R527
R528
R529
R530
1-220-878-81
1-220-878-81
1-220-878-81
1-220-878-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
22
22
22
10
R461
R462
R463
R465
1-208-911-81
1-218-990-81
1-220-878-81
1-208-919-81
s
s
s
s

RES, CHIP 22 (1005)
R531
R532
R533
R534
1-208-895-81
1-220-878-81
1-220-870-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
22 (1005)
10 (1005)
10 (1005)
7-32
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
220
10K
22K
10K
22K
(1005)
(1005)
(1005)
(1005)
(1005)
10K (1005)
6.8K (1005)
100 (1005)
100 (1005)
100 (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R535
R537
R538
R539
R540
1-208-911-81
1-208-927-81
1-208-855-81
1-208-863-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
47K (1005)
47 (1005)
100 (1005)
47K (1005)
R648
R652
R653
R654
R655
1-208-911-81
1-208-911-81
1-208-911-81
1-208-863-81
1-218-990-81
s
s
s
s
s

RES, CHIP 100 (1005)
R541
R542
R543
R544
R546
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-218-871-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
10K
(1005)
(1005)
(1005)
(1005)
(1608)
R656
R657
R659
R661
R662
1-220-870-81
1-220-878-81
1-208-863-81
1-208-863-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
22 (1005)
100 (1005)
100 (1005)
10K (1005)
R547
R548
R549
R550
R553
1-220-870-81
1-220-870-81
1-208-863-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
100 (1005)
22 (1005)
22 (1005)
R663
R664
R665
R666
R667
1-208-911-81
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10 (1005)
10 (1005)
10 (1005)
10 (1005)
R554
R555
R556
R558
R559
1-218-990-81
1-208-895-81
1-220-870-81
1-208-927-81
1-208-855-81
s
s
s
s
s

RES, CHIP 2.2K (1005)
RES, CHIP 10 (1005)
RES, CHIP 47 (1005)
R668
R669
R670
R671
R672
1-208-927-81
1-218-990-81
1-218-990-81
1-220-870-81
1-218-990-81
s
s
s
s
s

RES, CHIP 10 (1005)
R560
R561
R562
R563
R564
1-220-878-81
1-220-870-81
1-220-870-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
10
10
22
22
R673
R701
R702
R703
R704
1-218-990-81
1-208-855-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s

RES, CHIP 47 (1005)
R565
R566
R567
R572
R573
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
1-218-871-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
10 (1005)
10 (1005)
10K (1608)
R705
R706
R707
R708
R709
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10K (1005)
47 (1005)
R574
R575
R576
R601
R602
1-208-927-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
100
100
100
330
R710
R711
R712
R714
R715
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
47
47
47
47
R603
R604
R605
R614
R618
1-218-990-81
1-208-891-81
1-218-990-81
1-208-911-81
1-208-911-81
s
s
s
s
s

RES, CHIP 1.5K (1005)
R716
R719
R720
R721
R722
1-218-990-81
1-208-855-81
1-208-863-81
1-208-863-81
1-208-855-81
s
s
s
s
s

RES, CHIP 47 (1005)
RES, CHIP 100 (1005)
RES, CHIP 100 (1005)
RES, CHIP 47 (1005)
R619
R620
R621
R622
R624
1-208-863-81
1-218-990-81
1-220-870-81
1-220-878-81
1-208-863-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 10 (1005)
RES, CHIP 22 (1005)
RES, CHIP 100 (1005)
R723
R724
R725
R726
R727
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
220
220
100
R626
R627
R628
R629
R630
1-208-863-81
1-208-911-81
1-208-911-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R728
R729
R732
R733
R734
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
100 (1005)
100 (1005)
10 (1005)
R631
R632
R633
R634
R635
1-220-870-81
1-218-990-81
1-218-990-81
1-208-927-81
1-208-863-81
s
s
s
s
s
RES, CHIP 10 (1005)

RES, CHIP 100 (1005)
R735
R736
R737
R738
R739
1-220-870-81
1-208-863-81
1-208-871-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
100 (1005)
220 (1005)
100 (1005)
100 (1005)
R636
R637
R638
R639
1-208-875-81
1-218-990-81
1-208-891-81
1-218-990-81
s
s
s
s
RES, CHIP 330 (1005)

RES, CHIP 1.5K (1005)
R740
R741
R742
R745
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47
47
47
47
HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
100 (1005)
10K (1005)
10K (1005)
10 (1005)
10 (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-33
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1102
R1103
R1104
R1106
R1110
1-218-990-81
1-208-911-81
1-220-870-81
1-208-855-81
1-211-969-91
s
s
s
s
s

RES, CHIP 10 (1005)
RES, CHIP 47 (1005)
RES, CHIP 10 (1608)
100 (1005)
100 (1005)
47 (1005)
47 (1005)
100 (1005)
R1111
R1112
R1113
R1114
R1115
1-208-927-81
1-208-887-81
1-208-863-81
1-208-887-81
1-218-937-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
47 (1005)
100 (1005)
47 (1005)
R1116
R1117
R1118
R1119
R1120
1-208-887-81
1-220-878-81
1-208-887-81
1-208-887-81
1-218-990-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 22 (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
47K
10K
R1121
R1122
R1123
R1125
R1126
1-208-887-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
47 (1005)
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
10K (1005)
2.2K (1005)
47 (1005)
47 (1005)
R1127
R1128
R1129
R1130
R1131
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-218-937-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
47
47
47
47
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
47
47
47
47
(1005)
(1005)
(1005)
(1005)
(1005)
R1132
R1133
R1134
R1135
R1136
1-218-937-81
1-218-937-81
1-208-855-81
1-218-990-81
1-208-899-81
s
s
s
s
s
RES, CHIP 47
RES, CHIP 47
RES, CHIP 47 (1005)
RES, CHIP 3.3K (1005)
R777
R778
R779
R801
R802
1-208-911-81
1-220-870-81
1-220-870-81
1-208-855-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10 (1005)
10 (1005)
47 (1005)
4.7K (1005)
R1137
R1138
R1140
R1141
R1142
1-208-899-81
1-208-899-81
1-208-863-81
1-208-871-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R900
R901
R902
R903
R904
1-208-855-81
1-208-895-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
2.2K (1005)
47 (1005)
47 (1005)
47 (1005)
R1143
R1144
R1145
R1151
R1152
1-208-863-81
1-208-863-81
1-218-990-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 100 (1005)
RES, CHIP 22 (1005)
RES, CHIP 22 (1005)
R905
R906
R907
R908
R913
1-208-871-81
1-208-871-81
1-208-871-81
1-220-878-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
220 (1005)
22 (1005)
220 (1005)
R1153
R1155
R1156
R1158
R1159
1-208-927-81
1-208-899-81
1-208-899-81
1-208-887-81
1-218-990-81
s
s
s
s
s

RES, CHIP 3.3K (1005)
RES, CHIP 3.3K (1005)
RES, CHIP 1.0K (1005)
R916
R917
R920
R921
R927
1-208-863-81
1-218-933-81
1-208-871-81
1-208-855-81
1-218-933-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
22
220 (1005)
47 (1005)
22
R1160
R1161
R1163
R1164
R1165
1-208-887-81
1-208-887-81
1-218-990-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 22 (1005)
RES, CHIP 22 (1005)
R928
R929
R930
R931
R932
1-218-933-81
1-218-933-81
1-220-878-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
22
22 (1005)
10K (1005)
47 (1005)
R1167
R1168
R1170
R1171
R1172
1-208-899-81
1-208-899-81
1-208-887-81
1-218-990-81
1-208-887-81
s
s
s
s
s
RES, CHIP 3.3K (1005)

RES, CHIP 3.3K (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
R933
R934
R935
R1101
1-208-855-81
1-208-855-81
1-208-855-81
1-218-990-81
s
s
s
s
RES, CHIP 47 (1005)

RES, CHIP 47 (1005)
RES, CHIP 47 (1005)
R1173
R1175
R1176
R1177
1-208-887-81
1-218-990-81
1-208-863-81
1-208-859-81
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 100 (1005)
RES, CHIP 68 (1005)
R746
R747
R748
R749
R750
1-208-855-81
1-220-870-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
10
47
47
47
R751
R752
R753
R754
R755
1-208-863-81
1-208-863-81
1-208-855-81
1-208-855-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
R756
R757
R758
R759
R760
1-208-855-81
1-208-855-81
1-208-855-81
1-208-863-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R761
R762
R763
R764
R765
1-208-863-81
1-208-863-81
1-208-863-81
1-208-927-81
1-208-911-81
s
s
s
s
s
R766
R767
R769
R770
R771
1-208-927-81
1-208-911-81
1-208-895-81
1-208-855-81
1-208-855-81
R772
R773
R774
R775
R776
7-34
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
1.0K (1005)
100 (1005)
1.0K (1005)
47
(1005)
(1005)
(1005)
(1005)
3.3K (1005)
3.3K (1005)
100 (1005)
220 (1005)
1.0K (1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1178
R1179
R1180
R1181
R1183
1-208-859-81
1-208-863-81
1-218-990-81
1-218-990-81
1-208-859-81
s
s
s
s
s
RES, CHIP 68 (1005)

RES, CHIP 100 (1005)
RES, CHIP 68 (1005)
R1523
R1524
R1525
R1526
R1527
1-208-915-81
1-208-911-81
1-208-935-81
1-208-935-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1184
R1186
R1187
R1200
R1201
1-208-859-81
1-218-990-81
1-218-990-81
1-208-919-81
1-208-911-81
s
s
s
s
s
RES, CHIP 68 (1005)

R1528
R1529
R1530
R1531
R1532
1-208-931-81
1-208-919-81
1-208-895-81
1-218-990-81
1-208-935-81
s
s
s
s
s

RES, CHIP 2.2K (1005)
RES, CHIP 100K (1005)
R1202
R1203
R1204
R1206
R1207
1-208-911-81
1-208-935-81
1-208-887-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100K (1005)
1.0K (1005)
100 (1005)
100 (1005)
R1534
R1535
R1536
R1537
R1538
1-208-887-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
10K (1005)
10K (1005)
10K (1005)
R1208
R1209
R1210
R1211
R1212
1-208-863-81
1-208-863-81
1-208-887-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
R1539
R1540
R1541
R1542
R1543
1-208-935-81
1-208-887-81
1-208-875-81
1-208-899-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
1.0K (1005)
330 (1005)
3.3K (1005)
2.2K (1005)
R1213
R1218
R1219
R1220
R1221
1-208-879-81
1-208-895-81
1-208-891-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
2.2K (1005)
1.5K (1005)
10K (1005)
10K (1005)
R1544
R1545
R1546
R1547
R1548
1-208-919-81
1-208-915-81
1-208-911-81
1-208-863-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
15K
10K
100
22K
R1222
R1223
R1224
R1225
R1226
1-208-875-81
1-208-875-81
1-208-863-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330
330
100
10K
10K
R1549
R1550
R1551
R1552
R1553
1-208-875-81
1-208-891-81
1-208-899-81
1-208-915-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330 (1005)
1.5K (1005)
3.3K (1005)
15K (1005)
2.2K (1005)
R1227
R1228
R1229
R1230
R1231
1-208-879-81
1-208-895-81
1-208-871-81
1-208-875-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
2.2K (1005)
220 (1005)
330 (1005)
330 (1005)
R1554
R1555
R1556
R1557
R1558
1-208-927-81
1-208-935-81
1-208-863-81
1-208-935-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
100K (1005)
100 (1005)
100K (1005)
2.2K (1005)
R1232
R1233
R1234
R1235
R1501
1-208-875-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330
330
330
330
100
R1559
R1560
R1561
R1562
R1563
1-208-903-81
1-208-891-81
1-208-923-81
1-208-923-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
1.5K (1005)
33K (1005)
33K (1005)
1.5K (1005)
R1502
R1503
R1504
R1505
R1506
1-208-863-81
1-208-863-81
1-208-907-81
1-208-935-81
1-208-943-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
6.8K (1005)
100K (1005)
220K (1005)
R1564
R1565
R1567
R1568
R1569
1-208-891-81
1-208-899-81
1-208-919-81
1-208-935-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
3.3K (1005)
22K (1005)
100K (1005)
3.3K (1005)
R1507
R1508
R1509
R1510
R1511
1-218-990-81
1-208-863-81
1-208-891-81
1-208-891-81
1-208-895-81
s
s
s
s
s

RES, CHIP 100 (1005)
RES, CHIP 1.5K (1005)
RES, CHIP 1.5K (1005)
RES, CHIP 2.2K (1005)
R1570
R1572
R1574
R1576
R1577
1-208-915-81
1-208-911-81
1-208-919-81
1-208-903-81
1-208-931-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
10K (1005)
22K (1005)
4.7K (1005)
68K (1005)
R1512
R1513
R1515
R1516
R1517
1-208-907-81
1-208-899-81
1-208-919-81
1-208-935-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
6.8K (1005)
3.3K (1005)
22K (1005)
100K (1005)
2.2K (1005)
R1579
R1580
R1581
R1582
R1583
1-208-927-81
1-218-990-81
1-208-903-81
1-208-923-81
1-208-939-81
s
s
s
s
s

RES, CHIP 4.7K (1005)
RES, CHIP 150K (1005)
R1518
R1520
R1521
R1522
1-208-915-81
1-208-919-81
1-208-919-81
1-208-911-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
15K
22K
22K
10K
R1584
R1585
R1586
R1587
1-218-990-81
1-208-903-81
1-218-990-81
1-208-911-81
s
s
s
s

RES, CHIP 4.7K (1005)
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
10K (1005)
100K (1005)
100K (1005)
4.7K (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-35
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1649
R1650
R1651
R1652
R1653
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10
10
10
10
10
10K (1005)
10 (1005)
68K (1005)
22K (1005)
100K (1005)
R1654
R1655
R1656
R1657
R1658
1-208-911-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
47K (1005)
47K (1005)
47K (1005)
100K (1005)
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
R1659
R1660
R1661
R1662
R1663
1-208-911-81
1-208-919-81
1-208-919-81
1-208-919-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
22K (1005)
22K (1005)
22K (1005)
10 (1005)
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
1.0K (1005)
R1665
R1666
R1667
R1668
R1669
1-208-887-81
1-208-899-81
1-208-915-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
3.3K (1005)
15K (1005)
10K (1005)
10K (1005)
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
22K (1005)
22K (1005)
1.0K (1005)
R1670
R1671
R1672
R1673
R1674
1-208-927-81
1-208-943-81
1-208-947-81
1-208-947-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
220K (1005)
330K (1005)
330K (1005)
33K (1005)
1-208-887-81
1-208-887-81
1-208-863-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
1.0K (1005)
1.0K (1005)
R1675
R1676
R1677
R1678
R1679
1-208-879-81
1-208-919-81
1-208-911-81
1-208-875-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
22K (1005)
10K (1005)
330 (1005)
1.0K (1005)
R1620
R1621
R1622
R1623
R1624
1-208-887-81
1-208-863-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100 (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
R1680
R1681
R1682
R1683
R1684
1-208-911-81
1-208-911-81
1-208-927-81
1-208-923-81
1-208-947-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
47K (1005)
33K (1005)
330K (1005)
R1625
R1626
R1627
R1628
R1629
1-208-919-81
1-208-919-81
1-208-911-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
10K
47K
10K
R1685
R1686
R1687
R1688
R1689
1-208-947-81
1-208-923-81
1-208-883-81
1-208-891-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330K (1005)
33K (1005)
680 (1005)
1.5K (1005)
15K (1005)
R1630
R1631
R1632
R1633
R1634
1-208-927-81
1-208-931-81
1-208-947-81
1-208-927-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
68K (1005)
330K (1005)
47K (1005)
100 (1005)
R1690
R1691
R1692
R1693
R1694
1-208-911-81
1-208-911-81
1-208-911-81
1-208-927-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
47K (1005)
100K (1005)
R1635
R1636
R1637
R1638
R1639
1-208-951-81
1-208-919-81
1-208-927-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470K (1005)
22K (1005)
47K (1005)
4.7K (1005)
10K (1005)
R1695
R1696
R1697
R1698
R1699
1-208-947-81
1-208-923-81
1-208-891-81
1-208-903-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330K (1005)
33K (1005)
1.5K (1005)
4.7K (1005)
15K (1005)
R1640
R1641
R1642
R1643
R1644
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
R1700
R1705
R1707
R1708
R1729
1-208-911-81
1-208-855-81
1-208-855-81
1-208-863-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
47 (1005)
47 (1005)
100 (1005)
47 (1005)
R1645
R1646
R1647
R1648
1-208-947-81
1-208-923-81
1-220-870-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
330K (1005)
33K (1005)
10 (1005)
10 (1005)
R1730
R1732
R1733
R1734
1-220-878-81
1-220-878-81
1-208-855-81
1-220-878-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
22
22
47
22
R1588
R1589
R1590
R1591
R1592
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
R1593
R1594
R1596
R1597
R1598
1-208-911-81
1-220-870-81
1-208-931-81
1-208-919-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
R1599
R1601
R1602
R1603
R1604
1-208-903-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1605
R1606
R1607
R1608
R1609
1-208-887-81
1-208-887-81
1-208-887-81
1-208-863-81
1-208-887-81
s
s
s
s
s
R1610
R1611
R1612
R1613
R1614
1-208-887-81
1-208-887-81
1-208-919-81
1-208-919-81
1-208-887-81
R1615
R1616
R1617
R1618
R1619
7-36
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1910
R1911
R1912
R1913
R1914
1-208-911-81
1-220-870-81
1-208-903-81
1-208-867-81
1-208-883-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10 (1005)
4.7K (1005)
150 (1005)
680 (1005)
47 (1005)
47 (1005)
22 (1005)
220 (1005)
47 (1005)
R1915
R1916
R1917
R1918
R1919
1-208-859-81
1-208-939-81
1-208-927-81
1-208-899-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
68 (1005)
150K (1005)
47K (1005)
3.3K (1005)
22K (1005)
22
47
47
47
22
R1920
R1921
R1922
R1923
R1924
1-208-919-81
1-208-923-81
1-220-870-81
1-208-931-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
33K (1005)
10 (1005)
68K (1005)
22K (1005)
RES, CHIP 47 (1005)

RES, CHIP 22 (1005)
RES, CHIP 100 (1005)
RES, CHIP 47 (1005)
R1925
R1926
R1927
R1928
R1929
1-208-919-81
1-208-927-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
10K
10K
22K
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 47 (1005)
R1930
R1931
R1932
R1933
R1934
1-208-875-81
1-208-903-81
1-218-990-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES, CHIP 330 (1005)

RES, CHIP 4.7K (1005)
RES, CHIP 4.7K (1005)
1-208-919-81
1-208-919-81
1-208-895-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
22K (1005)
2.2K (1005)
220 (1005)
220 (1005)
R1935
R1936
R1937
R1938
R1940
1-208-919-81
1-208-919-81
1-208-863-81
1-208-863-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
100
100
10K
R1803
R1804
R1806
R1807
R1808
1-208-871-81
1-220-870-81
1-220-878-81
1-220-878-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
10 (1005)
22 (1005)
22 (1005)
47 (1005)
R1941
R1942
R1943
R1944
R1945
1-208-871-81
1-208-935-81
1-208-903-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
100K (1005)
4.7K (1005)
10K (1005)
10K (1005)
R1809
R1810
R1811
R1814
R1816
1-208-855-81
1-218-933-81
1-208-863-81
1-208-871-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
22
100 (1005)
220 (1005)
22 (1005)
R1946
R1947
R1948
R1949
R2005
1-208-911-81
1-208-911-81
1-208-911-81
1-208-947-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
330K (1005)
47 (1005)
R1818
R1819
R1820
R1822
R1823
1-218-933-81
1-218-933-81
1-218-933-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
22
22
10K (1005)
47 (1005)
R2006
R2007
R2008
R2009
R2010
1-208-871-81
1-208-863-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
100
220
220
220
R1824
R1825
R1826
R1827
R1828
1-208-855-81
1-208-855-81
1-208-855-81
1-218-990-81
1-218-990-81
s
s
s
s
s
RES, CHIP 47 (1005)

RES, CHIP 47 (1005)
RES, CHIP 47 (1005)
R2011
R2012
R2013
R2014
R2015
1-208-863-81
1-208-863-81
1-208-863-81
1-208-855-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
100 (1005)
47 (1005)
10K (1005)
R1829
R1901
R1902
R1903
R1905
1-208-863-81
1-208-923-81
1-220-804-81
1-208-911-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
33K (1005)
2.2M
10K (1005)
33K (1005)
R2016
R2017
R2018
R2019
R2020
1-208-879-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
100 (1005)
100 (1005)
100 (1005)
100K (1005)
R1906
R1907
R1908
R1909
1-220-870-81
1-220-870-81
1-208-927-81
1-208-919-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
47K (1005)
22K (1005)
R2021
R2022
R2023
R2024
1-208-871-81
1-208-855-81
1-208-911-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
220 (1005)
47 (1005)
10K (1005)
1.0K (1005)
R1735
R1736
R1737
R1738
R1739
1-220-878-81
1-220-878-81
1-220-878-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
22
22
47
47
R1740
R1741
R1742
R1743
R1745
1-208-855-81
1-208-855-81
1-220-878-81
1-208-871-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
R1746
R1747
R1748
R1749
R1750
1-220-878-81
1-208-855-81
1-208-855-81
1-208-855-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
R1751
R1752
R1753
R1754
R1770
1-208-855-81
1-220-878-81
1-208-863-81
1-218-990-81
1-208-855-81
s
s
s
s
s
R1771
R1772
R1774
R1775
R1776
1-208-887-81
1-208-887-81
1-208-855-81
1-218-990-81
1-208-919-81
R1777
R1778
R1800
R1801
R1802
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-37
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R2027
R2028
R2029
R2030
R2031
1-208-911-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
47 (1005)
47 (1005)
47 (1005)
100 (1005)
R2235
R2236
R2237
R2238
R2239
1-220-870-81
1-220-870-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
100 (1005)
100 (1005)
100 (1005)
R2032
R2033
R2034
R2035
R2036
1-208-863-81
1-208-871-81
1-208-855-81
1-208-855-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
220 (1005)
47 (1005)
47 (1005)
220 (1005)
R2240
R2241
R2242
R2243
R2244
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2037
R2038
R2039
R2040
R2041
1-208-871-81
1-208-871-81
1-208-871-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
220
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2245
R2247
R2249
R2250
R2251
1-208-863-81
1-208-863-81
1-208-863-81
1-208-927-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
47K
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2042
R2043
R2044
R2045
R2046
1-208-855-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
100 (1005)
100 (1005)
100 (1005)
100 (1005)
R2252
R2253
R2254
R2255
R2256
1-208-863-81
1-208-903-81
1-208-903-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
4.7K (1005)
4.7K (1005)
1.0K (1005)
100 (1005)
R2047
R2048
R2052
R2053
R2054
1-208-911-81
1-208-863-81
1-208-935-81
1-208-935-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
100K (1005)
100K (1005)
100K (1005)
R2257
R2259
R2260
R2261
R2301
1-208-927-81
1-220-882-81
1-220-882-81
1-208-863-81
1-211-969-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
33 (1005)
33 (1005)
100 (1005)
10 (1608)
R2101
R2102
R2201
R2202
R2203
1-208-911-81
1-208-911-81
1-208-863-81
1-208-911-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
100 (1005)
10K (1005)
10 (1005)
R2302
R2303
R2304
R2305
R2308
1-208-919-81
1-208-895-81
1-208-915-81
1-208-907-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
2.2K (1005)
15K (1005)
6.8K (1005)
10 (1005)
R2204
R2206
R2207
R2208
R2210
1-220-870-81
1-208-927-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
47K (1005)
100 (1005)
100 (1005)
100 (1005)
R2309
R2310
R2311
R2312
R2313
1-220-870-81
1-220-870-81
1-220-870-81
1-216-864-91
1-216-864-91
s
s
s
s
s
RES, CHIP 10 (1005)

RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
R2211
R2212
R2213
R2214
R2215
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2314
R2315
R2316
R2317
R2318
1-220-870-81
1-208-871-81
1-208-915-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R2216
R2217
R2218
R2219
R2220
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2320
R2321
R2322
R2323
R2324
1-208-887-81
1-208-887-81
1-208-895-81
1-208-887-81
1-218-990-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 2.2K (1005)
RES, CHIP 1.0K (1005)
R2221
R2222
R2223
R2224
R2225
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2325
R2326
R2327
R2328
R2329
1-208-883-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
47K (1005)
R2226
R2227
R2228
R2229
R2230
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2330
R2331
R2332
R2333
R2334
1-208-887-81
1-208-887-81
1-208-887-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
47K (1005)
47K (1005)
R2231
R2232
R2233
R2234
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10
10
10
10
R2335
R2336
R2337
R2338
1-208-927-81
1-208-927-81
1-208-927-81
1-208-856-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47K (1005)
47K (1005)
47K (1005)
51 (1005)
7-38
(1005)
(1005)
(1005)
(1005)
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
220 (1005)
15K (1005)
10K (1005)
47 (1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R2422
R2423
R2424
R2425
R2429
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
220

RES, CHIP 10 (1005)
R2433
R2434
R2435
R2436
R2437
1-208-871-81
1-208-871-81
1-208-855-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
47 (1005)
10K (1005)
47 (1005)
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R2438
R2439
R2501
R2502
R2503
1-208-855-81
1-208-855-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
100 (1005)
100 (1005)
100 (1005)
1-208-887-81
1-208-871-81
1-208-887-81
1-218-990-81
1-208-883-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 220 (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 680 (1005)
R2504
R2505
R2510
R2518
R2519
1-208-871-81
1-208-855-81
1-208-863-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
47 (1005)
100 (1005)
10K (1005)
47 (1005)
R2360
R2361
R2362
R2363
R2364
1-208-887-81
1-208-887-81
1-208-887-81
1-208-927-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
47K (1005)
1.0K (1005)
R2520
R2601
R2602
R2603
R2604
1-208-863-81
1-220-870-81
1-208-863-81
1-208-855-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
10 (1005)
100 (1005)
47 (1005)
2.2K (1005)
R2365
R2366
R2367
R2368
R2369
1-208-887-81
1-208-887-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
47K (1005)
47K (1005)
47K (1005)
R2605
R2606
R2607
R2608
R2610
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
1-218-990-81
s
s
s
s
s
RES, CHIP 220 (1005)

RES, CHIP 220 (1005)
RES, CHIP 220 (1005)
RES, CHIP 220 (1005)
R2370
R2371
R2372
R2373
R2374
1-208-927-81
1-208-927-81
1-218-990-81
1-218-990-81
1-208-919-81
s
s
s
s
s

R2613
R2614
R2617
R2620
R2621
1-218-990-81
1-218-990-81
1-208-871-81
1-208-911-81
1-218-990-81
s
s
s
s
s

RES, CHIP 220 (1005)
R2375
R2376
R2377
R2378
R2379
1-211-969-91
1-208-856-81
1-208-856-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1608)
51 (1005)
51 (1005)
1.0K (1005)
1.0K (1005)
R2622
R2623
R2624
R2625
R2626
1-208-911-81
1-218-990-81
1-208-911-81
1-208-871-81
1-220-870-81
s
s
s
s
s

RES, CHIP 220 (1005)
RES, CHIP 10 (1005)
R2380
R2381
R2382
R2402
R2403
1-208-887-81
1-208-887-81
1-208-915-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
15K (1005)
47 (1005)
47 (1005)
R2627
R2628
R2629
R2630
R2631
1-208-911-81
1-208-887-81
1-208-887-81
1-208-911-81
1-218-990-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
R2404
R2405
R2406
R2407
R2410
1-208-871-81
1-208-871-81
1-208-911-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
10K (1005)
1.0K (1005)
100 (1005)
R2632
R2633
R2634
R2635
R2636
1-220-870-81
1-208-911-81
1-208-911-81
1-208-911-81
1-218-990-81
s
s
s
s
s
RES, CHIP 10 (1005)

R2411
R2412
R2413
R2414
R2415
1-208-863-81
1-208-911-81
1-208-855-81
1-218-990-81
1-218-990-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 47 (1005)
R2637
R2638
R2639
R2640
R2641
1-208-911-81
1-208-899-81
1-208-903-81
1-208-923-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
3.3K (1005)
4.7K (1005)
33K (1005)
33K (1005)
R2418
R2419
R2420
R2421
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
R2642
R2643
R2644
R2646
1-208-871-81
1-208-863-81
1-208-863-81
1-208-879-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
220
100
100
470
R2339
R2340
R2341
R2342
R2343
1-208-856-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R2344
R2345
R2346
R2347
R2348
1-218-990-81
1-218-990-81
1-216-864-91
1-216-864-91
1-220-870-81
s
s
s
s
s
R2349
R2350
R2351
R2352
R2354
1-208-915-81
1-208-907-81
1-208-911-81
1-208-855-81
1-208-887-81
R2355
R2356
R2357
R2358
R2359
HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
51 (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
15K (1005)
6.8K (1005)
10K (1005)
47 (1005)
1.0K (1005)
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-39
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R2647
R2648
R2649
R2650
R2651
1-208-895-81
1-218-990-81
1-208-923-81
1-208-919-81
1-208-887-81
s
s
s
s
s
RES, CHIP 2.2K (1005)

RES, CHIP 1.0K (1005)
R2724
R2725
R2726
R2727
R2728
1-208-899-81
1-208-895-81
1-208-871-81
1-208-895-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
3.3K (1005)
2.2K (1005)
220 (1005)
2.2K (1005)
1.0K (1005)
R2652
R2653
R2654
R2655
R2656
1-208-879-81
1-208-879-81
1-208-935-81
1-208-871-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
470 (1005)
100K (1005)
220 (1005)
10 (1005)
R2729
R2730
R2731
R2732
R2733
1-208-895-81
1-208-911-81
1-208-895-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
10K (1005)
2.2K (1005)
100 (1005)
100 (1005)
R2657
R2658
R2659
R2665
R2668
1-220-870-81
1-208-895-81
1-208-895-81
1-208-911-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
2.2K (1005)
2.2K (1005)
10K (1005)
330 (1005)
R2734
R2735
R2736
R2737
R2738
1-208-915-81
1-208-915-81
1-208-863-81
1-208-915-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K
15K
100
15K
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2669
R2670
R2671
R2672
R2673
1-208-891-81
1-208-919-81
1-208-863-81
1-208-863-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
22K (1005)
100 (1005)
100 (1005)
47 (1005)
R2739
R2740
R2741
R2742
R2743
1-208-863-81
1-208-863-81
1-208-863-81
1-208-867-81
1-208-867-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
150
150
(1005)
(1005)
(1005)
(1005)
(1005)
R2674
R2675
R2676
R2677
R2678
1-208-863-81
1-220-870-81
1-218-990-81
1-218-990-81
1-220-870-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
R2744
R2745
R2746
R2747
R2748
1-208-867-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
150
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2679
R2680
R2682
R2683
R2684
1-220-870-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R2749
R2750
R2751
R2752
R2753
1-208-863-81
1-208-871-81
1-208-871-81
1-208-871-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
220
220
220
15K
(1005)
(1005)
(1005)
(1005)
(1005)
R2685
R2686
R2687
R2688
R2689
1-208-911-81
1-208-911-81
1-208-911-81
1-208-883-81
1-218-990-81
s
s
s
s
s

RES, CHIP 680 (1005)
R2754
R2755
R2756
R2757
R2758
1-208-863-81
1-208-871-81
1-208-883-81
1-218-990-81
1-208-915-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 220 (1005)
RES, CHIP 680 (1005)
R2691
R2701
R2702
R2703
R2704
1-208-863-81
1-208-863-81
1-208-863-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R2759
R2760
R2761
R2762
R2763
1-208-871-81
1-208-867-81
1-208-883-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
150
680
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2705
R2706
R2707
R2708
R2709
1-208-863-81
1-208-863-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
47 (1005)
47 (1005)
47 (1005)
R2764
R2765
R2766
R2767
R2768
1-208-863-81
1-208-883-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
680
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2710
R2711
R2712
R2713
R2714
1-208-863-81
1-208-899-81
1-208-899-81
1-208-899-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
3.3K (1005)
3.3K (1005)
3.3K (1005)
330 (1005)
R2769
R2770
R2771
R2772
R2773
1-208-919-81
1-208-919-81
1-208-883-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
680
22K
22K
(1005)
(1005)
(1005)
(1005)
(1005)
R2715
R2716
R2717
R2718
R2719
1-208-919-81
1-208-875-81
1-208-923-81
1-208-875-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
330
33K
330
100
R2774
R2775
R2776
R2777
R2778
1-208-883-81
1-208-891-81
1-208-911-81
1-208-883-81
1-208-867-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
1.5K (1005)
10K (1005)
680 (1005)
150 (1005)
R2720
R2721
R2722
R2723
1-208-871-81
1-208-895-81
1-208-887-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
220 (1005)
2.2K (1005)
1.0K (1005)
1.0K (1005)
R2779
R2780
R2781
R2782
1-208-883-81
1-208-867-81
1-208-867-81
1-208-883-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
680
150
150
680
7-40
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10K (1005)
10K (1005)
10K (1005)
10K (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R2784
R2787
R2788
R2789
R2791
1-208-883-81
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680
220
220
220
220
(1005)
(1005)
(1005)
(1005)
(1005)
R2848
R2849
R2850
R2851
R2852
1-208-923-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33K
330
330
330
100
R2793
R2794
R2795
R2796
R2797
1-208-871-81
1-208-871-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R2853
R2854
R2855
R2856
R2857
1-208-879-81
1-208-887-81
1-208-863-81
1-208-879-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
1.0K (1005)
100 (1005)
470 (1005)
1.0K (1005)
R2798
R2799
R2801
R2802
R2803
1-208-863-81
1-218-990-81
1-208-863-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 100 (1005)
RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
R2858
R2859
R2860
R2861
R2862
1-208-863-81
1-208-887-81
1-208-879-81
1-208-883-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
1.0K (1005)
470 (1005)
680 (1005)
10K (1005)
R2804
R2805
R2806
R2807
R2808
1-208-923-81
1-208-927-81
1-208-911-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33K
47K
10K
22K
22K
R2863
R2864
R2865
R2866
R2867
1-208-883-81
1-208-883-81
1-208-911-81
1-208-883-81
1-208-883-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680
680
10K
680
680
(1005)
(1005)
(1005)
(1005)
(1005)
R2809
R2810
R2811
R2812
R2813
1-208-911-81
1-208-863-81
1-208-919-81
1-208-895-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
22K (1005)
2.2K (1005)
220 (1005)
R2868
R2869
R2870
R2871
R2872
1-208-911-81
1-208-883-81
1-208-867-81
1-208-867-81
1-208-867-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
680
150
150
150
(1005)
(1005)
(1005)
(1005)
(1005)
R2814
R2815
R2816
R2817
R2818
1-208-955-81
1-220-230-91
1-208-955-81
1-208-919-81
1-208-955-81
s
s
s
s
s
RES, CHIP 680K (1005)

RES, CHIP 680K (1005)
RES, CHIP 680K (1005)
R2873
R2874
R2875
R2876
R2877
1-208-883-81
1-208-883-81
1-208-883-81
1-208-923-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680
680
680
33K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R2819
R2820
R2821
R2822
R2823
1-208-927-81
1-208-927-81
1-208-927-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
47K
100
100
R2878
R2879
R2880
R2881
R2882
1-208-927-81
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
220
220
220
220
(1005)
(1005)
(1005)
(1005)
(1005)
R2824
R2825
R2826
R2827
R2828
1-208-863-81
1-208-867-81
1-208-867-81
1-208-867-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
150 (1005)
150 (1005)
150 (1005)
3.3K (1005)
R2883
R2884
R2885
R2886
R2887
1-208-871-81
1-208-871-81
1-208-903-81
1-218-990-81
1-218-990-81
s
s
s
s
s
RES, CHIP 220 (1005)

RES, CHIP 220 (1005)
RES, CHIP 4.7K (1005)
R2829
R2830
R2831
R2832
R2833
1-208-899-81
1-208-899-81
1-208-899-81
1-208-899-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
3.3K
3.3K
3.3K
3.3K
3.3K
R2888
R2889
R3401
R3402
R3403
1-218-990-81
1-208-927-81
1-208-887-81
1-208-887-81
1-208-863-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 100 (1005)
R2834
R2835
R2836
R2837
R2838
1-208-915-81
1-208-915-81
1-208-915-81
1-208-875-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K
15K
15K
330
330
(1005)
(1005)
(1005)
(1005)
(1005)
R3404
R3406
R3412
R3413
R3414
1-208-907-81
1-208-935-81
1-218-990-81
1-218-990-81
1-220-882-81
s
s
s
s
s
RES, CHIP 6.8K (1005)

RES, CHIP 100K (1005)
RES, CHIP 33 (1005)
R2839
R2840
R2841
R2842
R2843
1-208-875-81
1-208-883-81
1-208-883-81
1-208-883-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
330
680
680
680
100
(1005)
(1005)
(1005)
(1005)
(1005)
R3415
R3416
R3417
R3418
R3419
1-208-911-81
1-208-931-81
1-208-863-81
1-208-863-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
68K (1005)
100 (1005)
100 (1005)
1.0K (1005)
R2844
R2845
R2846
R2847
1-208-899-81
1-208-863-81
1-208-855-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
3.3K (1005)
100 (1005)
47 (1005)
100 (1005)
R3420
R3421
R3422
R3423
1-208-871-81
1-208-959-81
1-208-959-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
220 (1005)
1M (1005)
1M (1005)
1.0K (1005)
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-41
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R3424
R3425
R3429
R3430
R3431
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10K (1005)
22 (1005)
R3539
R3540
R3541
R3543
R3551
1-208-907-81
1-208-911-81
1-208-923-81
1-218-990-81
1-208-903-81
s
s
s
s
s
RES, CHIP 6.8K (1005)

RES, CHIP 4.7K (1005)
R3432
R3433
R3434
R3435
R3436
1-220-878-81
1-208-911-81
1-208-911-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
10K (1005)
10K (1005)
47 (1005)
47 (1005)
R3552
R3553
R3554
R3555
R3556
1-208-895-81
1-208-951-81
1-208-907-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
470K (1005)
6.8K (1005)
1.0K (1005)
100 (1005)
R3437
R3440
R3441
R3443
R3451
1-208-907-81
1-218-990-81
1-218-990-81
1-208-891-81
1-208-891-81
s
s
s
s
s
RES, CHIP 6.8K (1005)

RES, CHIP 1.5K (1005)
RES, CHIP 1.5K (1005)
R3557
R3559
R3560
R3561
R3570
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
330
330
330
220
(1005)
(1005)
(1005)
(1005)
(1005)
R3452
R3453
R3454
R3455
R3456
1-208-895-81
1-208-939-81
1-208-907-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
150K (1005)
6.8K (1005)
1.0K (1005)
100 (1005)
R3571
R3574
R3601
R3602
R3603
1-208-871-81
1-208-927-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
47K
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R3457
R3459
R3460
R3461
R3470
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
330
330
330
220
R3604
R3605
R3606
R3607
R3608
1-208-863-81
1-208-879-81
1-208-863-81
1-208-875-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
470 (1005)
100 (1005)
330 (1005)
1.0K (1005)
R3471
R3501
R3502
R3503
R3504
1-208-871-81
1-208-887-81
1-208-887-81
1-208-863-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
2.2K (1005)
R3609
R3610
R3611
R3612
R3613
1-208-887-81
1-208-863-81
1-208-895-81
1-208-931-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100 (1005)
2.2K (1005)
68K (1005)
4.7K (1005)
R3505
R3506
R3507
R3508
R3509
1-208-887-81
1-208-927-81
1-208-903-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
47K (1005)
4.7K (1005)
4.7K (1005)
10K (1005)
R3614
R3615
R3616
R3618
R3619
1-208-903-81
1-208-915-81
1-208-919-81
1-218-990-81
1-218-990-81
s
s
s
s
s
RES, CHIP 4.7K (1005)

R3510
R3512
R3513
R3514
R3515
1-208-923-81
1-218-990-81
1-218-990-81
1-220-882-81
1-208-911-81
s
s
s
s
s

RES, CHIP 33 (1005)
R3620
R3621
R3622
R3623
R3624
1-220-882-81
1-208-911-81
1-208-931-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33 (1005)
10K (1005)
68K (1005)
100 (1005)
100 (1005)
R3516
R3517
R3518
R3520
R3521
1-208-931-81
1-208-863-81
1-208-863-81
1-208-871-81
1-208-959-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
68K (1005)
100 (1005)
100 (1005)
220 (1005)
1M (1005)
R3625
R3627
R3630
R3631
R3632
1-208-887-81
1-208-923-81
1-208-871-81
1-208-959-81
1-208-959-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
33K (1005)
220 (1005)
1M (1005)
1M (1005)
R3522
R3523
R3524
R3525
R3529
1-208-959-81
1-208-887-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
1.0K (1005)
10K (1005)
10K (1005)
10K (1005)
R3633
R3634
R3635
R3639
R3640
1-208-887-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
10K (1005)
10K (1005)
10K (1005)
R3530
R3531
R3532
R3533
R3534
1-208-911-81
1-220-878-81
1-220-878-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
22 (1005)
22 (1005)
10K (1005)
10K (1005)
R3641
R3642
R3643
R3644
R3645
1-220-878-81
1-220-878-81
1-208-911-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
22 (1005)
10K (1005)
10K (1005)
47 (1005)
R3535
R3536
R3537
R3538
1-208-855-81
1-208-855-81
1-218-990-81
1-218-990-81
s
s
s
s
RES, CHIP 47 (1005)

RES, CHIP 47 (1005)
R3646
R3647
R3648
R3649
1-208-855-81
1-208-895-81
1-208-911-81
1-208-919-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47 (1005)
2.2K (1005)
10K (1005)
22K (1005)
7-42
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R3652
R3653
R3654
R3655
R3656
1-208-915-81
1-208-947-81
1-208-907-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
330K (1005)
6.8K (1005)
1.0K (1005)
100 (1005)
R3805
R3806
R3807
R3808
R3809
1-208-887-81
1-208-931-81
1-208-903-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R3657
R3659
R3660
R3661
R3670
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
330
330
330
220
R3810
R3812
R3813
R3814
R3815
1-208-907-81
1-218-990-81
1-218-990-81
1-220-882-81
1-208-911-81
s
s
s
s
s
RES, CHIP 6.8K (1005)

RES, CHIP 33 (1005)
R3671
R3701
R3702
R3703
R3704
1-208-871-81
1-208-879-81
1-208-879-81
1-208-863-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
470 (1005)
470 (1005)
100 (1005)
3.3K (1005)
R3816
R3817
R3818
R3819
R3820
1-208-931-81
1-208-863-81
1-208-863-81
1-208-919-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
68K
100
100
22K
220
R3705
R3706
R3707
R3708
R3709
1-208-927-81
1-208-907-81
1-208-903-81
1-208-907-81
1-208-907-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
6.8K (1005)
4.7K (1005)
6.8K (1005)
6.8K (1005)
R3821
R3822
R3823
R3824
R3825
1-208-959-81
1-208-959-81
1-208-887-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
1M (1005)
1.0K (1005)
10K (1005)
10K (1005)
R3711
R3712
R3713
R3714
R3715
1-218-990-81
1-218-990-81
1-220-882-81
1-208-911-81
1-208-931-81
s
s
s
s
s

RES, CHIP 33 (1005)
R3829
R3830
R3831
R3832
R3833
1-208-911-81
1-208-911-81
1-220-878-81
1-220-878-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
22 (1005)
22 (1005)
10K (1005)
R3716
R3717
R3718
R3719
R3720
1-208-863-81
1-208-863-81
1-208-887-81
1-208-871-81
1-208-959-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
1.0K (1005)
220 (1005)
1M (1005)
R3834
R3835
R3836
R3837
R3838
1-208-911-81
1-208-855-81
1-208-855-81
1-218-990-81
1-218-990-81
s
s
s
s
s

RES, CHIP 47 (1005)
RES, CHIP 47 (1005)
R3721
R3722
R3723
R3724
R3728
1-208-959-81
1-208-887-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
1.0K (1005)
10K (1005)
10K (1005)
10K (1005)
R3839
R3840
R3841
R3842
R3843
1-208-911-81
1-208-923-81
1-208-923-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
33K
33K
10K
10K
R3729
R3730
R3731
R3732
R3733
1-208-911-81
1-220-878-81
1-220-878-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
22 (1005)
22 (1005)
10K (1005)
10K (1005)
R3844
R3845
R3846
R3847
R3850
1-208-935-81
1-208-907-81
1-208-871-81
1-208-871-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
6.8K (1005)
220 (1005)
220 (1005)
100K (1005)
R3734
R3735
R3736
R3739
R3746
1-208-855-81
1-208-855-81
1-208-907-81
1-208-923-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
6.8K (1005)
33K (1005)
220 (1005)
R3857
R3858
R3859
R3860
R3862
1-208-895-81
1-208-947-81
1-208-907-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
330K (1005)
6.8K (1005)
1.0K (1005)
100 (1005)
R3747
R3757
R3758
R3759
R3760
1-208-871-81
1-208-895-81
1-208-951-81
1-208-907-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
2.2K (1005)
470K (1005)
6.8K (1005)
1.0K (1005)
R3863
R3865
R3866
R3867
R3901
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
330
330
330
100
R3762
R3763
R3765
R3766
R3767
1-208-863-81
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
330
330
330
R3902
R3903
R3904
R3905
R3906
1-208-883-81
1-208-883-81
1-220-878-81
1-208-899-81
1-208-883-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
680 (1005)
22 (1005)
3.3K (1005)
680 (1005)
R3801
R3802
R3803
R3804
1-208-879-81
1-208-879-81
1-208-863-81
1-208-899-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
470 (1005)
470 (1005)
100 (1005)
3.3K (1005)
R3907
R3908
R3909
R3910
1-208-863-81
1-208-883-81
1-208-887-81
1-208-879-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100 (1005)
680 (1005)
1.0K (1005)
470 (1005)
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
68K (1005)
4.7K (1005)
4.7K (1005)
10K (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-43
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R4015
R4016
R4017
R4018
R4019
1-208-911-81
1-208-959-81
1-208-935-81
1-208-915-81
1-208-943-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
RES, CHIP 4.7K (1005)

R4020
R4021
R4022
R4023
R4024
1-208-959-81
1-220-230-91
1-208-911-81
1-218-990-81
1-208-919-81
s
s
s
s
s
RES, CHIP 1M (1005)

s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33 (1005)
10K (1005)
68K (1005)
100 (1005)
100 (1005)
R4025
R4026
1-208-887-81 s RES, CHIP 1.0K (1005)

1-208-919-81 s RES, CHIP 22K (1005)
1-208-887-81
1-208-871-81
1-208-959-81
1-208-959-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
220 (1005)
1M (1005)
1M (1005)
1.0K (1005)
RB501
RB502
RB503
RB504
RB505
1-234-370-21
1-234-370-21
1-234-373-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22 (1005X4)
22 (1005X4)
220 (1005X4)
220 (1005X4)
47 (1005X4)
R3932
R3933
R3937
R3938
R3939
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10K (1005)
22 (1005)
RB506
RB507
RB508
RB509
RB510
1-234-371-21
1-234-381-21
1-234-381-21
1-234-381-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47 (1005X4)
100K (1005X4)
100K (1005X4)
100K (1005X4)
220 (1005X4)
R3940
R3941
R3942
R3943
R3944
1-220-878-81
1-208-911-81
1-208-911-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
10K (1005)
10K (1005)
47 (1005)
47 (1005)
RB511
RB512
RB513
RB514
RB515
1-234-373-21
1-234-381-21
1-234-373-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
100K (1005X4)
220 (1005X4)
220 (1005X4)
47 (1005X4)
R3946
R3947
R3948
R3953
R3955
1-208-871-81
1-208-907-81
1-208-911-81
1-208-915-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
6.8K (1005)
10K (1005)
15K (1005)
220 (1005)
RB516
RB517
RB518
RB519
RB520
1-234-371-21
1-234-371-21
1-234-371-21
1-234-381-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47 (1005X4)
47 (1005X4)
47 (1005X4)
100K (1005X4)
220 (1005X4)
R3957
R3958
R3959
R3960
R3961
1-208-895-81
1-208-935-81
1-208-907-81
1-208-887-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K
100K
6.8K
1.0K
100K
RB521
RB522
RB523
RB701
RB702
1-234-371-21
1-234-381-21
1-234-381-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47 (1005X4)
100K (1005X4)
100K (1005X4)
220 (1005X4)
220 (1005X4)
R3962
R3963
R3965
R3966
R3967
1-208-863-81
1-208-863-81
1-208-875-81
1-208-875-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
330
330
330
(1005)
(1005)
(1005)
(1005)
(1005)
RB703
RB704
RB705
RB706
RB707
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
R4001
R4002
R4003
R4004
R4005
1-208-919-81
1-208-919-81
1-208-919-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
22K
47K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
RB708
RB709
RB710
RB711
RB712
1-234-373-21
1-234-373-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
R4006
R4007
R4008
R4009
R4010
1-208-911-81
1-208-895-81
1-208-863-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
2.2K (1005)
100 (1005)
10K (1005)
10K (1005)
RB713
RB714
RB715
RB716
RB717
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
R4011
R4012
R4013
R4014
1-208-911-81
1-208-899-81
1-208-919-81
1-218-990-81
s
s
s
s

RES, CHIP 3.3K (1005)
RB718
RB719
RB720
RB722
RB723
1-234-371-21
1-234-371-21
1-234-372-21
1-234-372-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47 (1005X4)
47 (1005X4)
100 (1005X4)
100 (1005X4)
47 (1005X4)
RB724
1-234-371-21 s RES, NETWORK 47 (1005X4)
R3911
R3912
R3913
R3914
R3915
1-208-879-81
1-208-863-81
1-208-899-81
1-208-935-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R3916
R3917
R3918
R3920
R3921
1-208-903-81
1-208-915-81
1-208-911-81
1-218-990-81
1-218-990-81
s
s
s
s
s
R3922
R3923
R3924
R3925
R3926
1-220-882-81
1-208-911-81
1-208-931-81
1-208-863-81
1-208-863-81
R3927
R3928
R3929
R3930
R3931
7-44
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
100 (1005)
3.3K (1005)
100K (1005)
4.7K (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
1M (1005)
100K (1005)
15K (1005)
220K (1005)
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
RB725
RB726
RB728
RB729
RB730
1-234-372-21
1-234-372-21
1-234-372-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
220 (1005X4)
47 (1005X4)
RB1705
RB1706
RB1707
RB1708
RB1709
1-234-379-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22K
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB801
RB802
RB803
RB804
RB805
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1710
RB1711
RB1712
RB1713
RB1714
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB806
RB807
RB808
RB809
RB810
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1715
RB1716
RB1717
RB1718
RB1719
1-234-373-21
1-234-373-21
1-234-379-21
1-234-379-21
1-234-379-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
22K
22K
22K
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB811
RB812
RB813
RB814
RB900
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1720
RB1721
RB1722
RB1723
RB1724
1-234-379-21
1-234-379-21
1-234-379-21
1-234-379-21
1-234-378-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22K
22K
22K
22K
10K
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB901
RB902
RB903
RB904
RB905
1-234-372-21
1-234-372-21
1-234-372-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
47 (1005X4)
47 (1005X4)
RB1800
RB1801
RB1802
RB1803
RB1804
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB906
RB907
RB908
RB909
RB910
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
22
22
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1805
RB1806
RB1807
RB1808
RB1809
1-234-370-21
1-234-370-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB911
RB912
RB913
RB914
RB915
1-234-371-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
22
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1810
RB1811
RB1812
RB1813
RB2001
1-234-371-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
22
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1101
RB1102
RB1103
RB1105
RB1106
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2002
RB2003
RB2004
RB2005
RB2006
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1107
RB1108
RB1109
RB1110
RB1111
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2007
RB2008
RB2009
RB2010
RB2011
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1112
RB1113
RB1114
RB1115
RB1116
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2012
RB2013
RB2014
RB2015
RB2016
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1117
RB1118
RB1119
RB1120
RB1121
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2017
RB2018
RB2019
RB2020
RB2021
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1701
RB1702
RB1703
RB1704
1-234-379-21
1-234-379-21
1-234-379-21
1-234-379-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
22K
22K
22K
22K
RB2022
RB2024
RB2025
RB2026
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
HSCU-300
(1005X4)
(1005X4)
(1005X4)
(1005X4)
7-45
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
RB2027
RB2028
RB2029
RB2030
RB2031
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
220 (1005X4)
220 (1005X4)
220 (1005X4)
47 (1005X4)
RB2152
RB2201
RB2202
RB2203
RB2204
1-234-372-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
220 (1005X4)
220 (1005X4)
220 (1005X4)
47 (1005X4)
RB2032
RB2033
RB2034
RB2101
RB2102
1-234-373-21
1-234-373-21
1-234-379-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
22K
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2205
RB2301
RB2302
RB2303
RB2304
1-234-372-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2103
RB2104
RB2105
RB2106
RB2107
1-234-372-21
1-234-372-21
1-234-371-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
47 (1005X4)
100 (1005X4)
100 (1005X4)
RB2305
RB2306
RB2307
RB2308
RB2309
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2108
RB2109
RB2110
RB2111
RB2112
1-234-372-21
1-234-372-21
1-234-371-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
47 (1005X4)
100 (1005X4)
100 (1005X4)
RB2310
RB2401
RB2402
RB2403
RB2404
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2113
RB2114
RB2115
RB2116
RB2117
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2405
RB2406
RB2407
RB2408
RB2409
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2118
RB2119
RB2120
RB2121
RB2122
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2410
RB2411
RB2412
RB2413
RB2414
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2123
RB2124
RB2125
RB2126
RB2127
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2415
RB2416
RB2417
RB2418
RB2419
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2128
RB2129
RB2130
RB2131
RB2132
1-234-372-21
1-234-372-21
1-234-372-21
1-234-371-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
47 (1005X4)
100 (1005X4)
RB2420
RB2421
RB2422
RB2423
RB2424
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2133
RB2134
RB2135
RB2136
RB2137
1-234-372-21
1-234-372-21
1-234-372-21
1-234-371-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
100 (1005X4)
100 (1005X4)
47 (1005X4)
100 (1005X4)
RB2426
RB2427
RB2428
RB2501
RB2502
1-234-373-21
1-234-372-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
100
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2138
RB2139
RB2140
RB2141
RB2142
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2503
RB2504
RB2506
RB2507
RB2508
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2143
RB2144
RB2145
RB2146
RB2147
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2509
RB2510
RB2511
RB2512
RB2513
1-234-373-21
1-234-373-21
1-234-372-21
1-234-378-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
100
10K
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2148
RB2149
RB2150
RB2151
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB2601
RB2602
RB2603
RB2604
1-234-379-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
22K
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
7-46
HSCU-300
(DPR-300 BOARD)
(DPR-300 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
RB2605
RB2606
RB2607
RB2608
RB2609
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
THP301
THP302
THP303
THP304
THP305
!
!
!
!
!
1-804-458-21
1-804-987-21
1-804-458-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
RB2610
RB2611
RB2612
RB2613
RB2614
1-234-373-21
1-234-373-21
1-234-371-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
220 (1005X4)
47 (1005X4)
220 (1005X4)
220 (1005X4)
THP306
THP307
THP308
THP401
THP402
!
!
!
!
!
1-804-458-21
1-804-458-21
1-804-616-21
1-804-987-21
1-804-458-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
RB2616
RB2617
RB2618
RB2619
RB2701
1-234-373-21
1-234-373-21
1-234-381-21
1-234-381-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
220 (1005X4)
100K (1005X4)
100K (1005X4)
220 (1005X4)
THP403
THP404
THP405
THP406
THP407
!
!
!
!
!
1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
RB2702
RB2703
RB2704
RB2705
RB2706
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
THP408
THP409
THP410
THP411
THP412
!
!
!
!
!
1-804-458-21
1-804-616-21
1-804-458-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
RB2707
RB2708
RB2709
RB2801
RB2802
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
TP261
TP262
TP501
TP502
TP601
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
RB2803
RB2804
RB2805
RB2806
RB2807
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
TP602
TP1100
TP1501
TP1502
TP1503
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
RB2808
RB2809
RB3401
RB3501
RB3601
1-234-373-21
1-234-373-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
220 (1005X4)
47 (1005X4)
47 (1005X4)
47 (1005X4)
TP1505
TP1800
TP2001
TP2002
TP2003
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
RB3701
RB3801
RB3901
1-234-371-21 s RES, NETWORK 47 (1005X4)

1-234-371-21 s RES, NETWORK 47 (1005X4)
1-234-371-21 s RES, NETWORK 47 (1005X4)
RV1501
RV1502
RV1503
RV2601
RV2602
1-225-792-21
1-225-793-21
1-225-791-21
1-241-263-41
1-241-264-41
TP2004
TP2200
TP2201
TP2701
TP2702
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
S2001
S2801
1-692-270-41 s SWITCH, SLIDE

TP2703
TP2801
TP2802
TP2803
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
SWF1
SWF2
SWF3
SWF4
SWF5
1-813-413-11
1-813-413-11
1-813-413-11
1-813-413-11
1-813-413-11
X201
X1101
X2301
X2302
1-579-477-21
1-814-223-11
1-814-162-11
1-814-162-11
s
s
s
s
VIBRATOR, CRYSTAL (4 MHz)

OSCILLATOR, CRYSTAL
OSCILLATOR (VCO)
OSCILLATOR (VCO)
SWF6
1-813-413-11 s FILTER, SAW
T201
T202
T203
T204
1-445-612-11
1-445-611-11
1-445-612-11
1-445-611-11
THP281
THP282
1-804-616-21 s THERMISTOR, POSITIVE

HSCU-300
s
s
s
s
s
s
s
s
s
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
ADJ,
ADJ,
ADJ,
ADJ,
ADJ,
FILTER,
FILTER,
FILTER,
FILTER,
FILTER,
CERMET
CERMET
CERMET
CERMET
CERMET
10K
20K
5K
5K
10K
SAW
SAW
SAW
SAW
SAW
TRANSFORMER,
TRANSFORMER,
TRANSFORMER,
TRANSFORMER,
BALUN
BALUN
BALUN
BALUN
7-47
----------DY-23 BOARD
----------Ref. No.
or Qty Part No.
(DY-23 BOARD)
Ref. No.
or Qty Part No.
SP Description
1pc
A-1707-199-A s MOUNTED CIRCUIT BOARD, DY-23
C101
C102
C103
C104
C105
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF
10MF
10MF
10MF
10MF
C
C
C
C
C
(1608)
(1608)
(1608)
(1608)
(1608)
C106
C107
C108
C109
C112
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF
10MF
10MF
10MF
10MF
C
C
C
C
C
(1608)
(1608)
(1608)
(1608)
(1608)
C113
C114
C115
C301
C302
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C303
C304
C305
C306
C307
1-100-881-91
1-125-777-81
1-125-777-81
1-125-777-81
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 47MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
C (3216)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C (1608)
C308
C309
C311
C312
C313
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
C (1608)
C (1608)
C (1608)
0.1MF B 1005
0.1MF B 1005
C314
C315
C316
C317
C318
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C319
C320
C321
C322
C323
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C324
C325
C326
C327
C328
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C329
C330
C331
C332
C333
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C334
C335
C336
C337
C338
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C339
C340
C341
C342
C343
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C344
C345
1-125-777-81 s CAP, CHIP CERAMIC 0.1MF B 1005

7-48
SP Description
C346
C347
C401
C402
C403
1-112-815-91
1-112-815-91
1-112-815-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
C (1608)
C (1608)
C (1608)
0.1MF B 1005
0.1MF B 1005
C404
C405
C406
C407
C408
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
C409
C410
C411
C412
C413
1-112-717-91
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C414
C415
C416
C417
C418
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CN102
CN103

D102
D103
6-502-197-01 s DI SML-D12M8WT86SM
8-719-820-42 s DIODE 1SS302-TE85L
FB101
FB301
FB304
FB305
FB401
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
FB402
FB403
FB404
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-469-094-21 s FERRITE, EMI (SMD) (1608)
1-469-094-21 s FERRITE, EMI (SMD) (1608)
IC101
IC301
6-712-135-01 o IC R1173H001D-T1-F
6-712-135-01 o IC R1173H001D-T1-F
L301
L302
L303

R101
R102
R104
R105
R107
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
47 (1005)
47 (1005)
4.7K (1005)
R108
R109
R110
R111
R112
1-208-871-81
1-208-919-81
1-208-911-81
1-208-911-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
22K (1005)
10K (1005)
10K (1005)
2.2K (1005)
R114
R205
R206
R207
R208
1-218-990-81
1-220-870-81
1-208-887-81
1-208-887-81
1-218-990-81
s
s
s
s
s

RES, CHIP 10 (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
R209
R210
R301
R302
R303
1-220-878-81
1-220-878-81
1-208-911-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CHIP
CHIP
CHIP
CHIP
CHIP
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
B
B
B
B
B
1005
1005
1005
1005
1005
1005
1005
1005
1005
(1608)
(1608)
(1608)
(1608)
(1608)
22 (1005)
22 (1005)
10K (1005)
22 (1005)
22 (1005)
HSCU-300
(DY-23 BOARD)
(DY-23 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
R304
R305
R306
R307
R308
1-208-863-81
1-208-855-81
1-208-887-81
1-220-870-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R309
R310
R311
R406
R407
1-208-887-81
1-208-911-81
1-218-990-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 47 (1005)
RES, CHIP 47 (1005)
R408
R409
R410
R411
R412
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
47
47
47
47
(1005)
(1005)
(1005)
(1005)
(1005)
R413
R414
R415
R416
R417
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
47
47
47
47
(1005)
(1005)
(1005)
(1005)
(1005)
R418
R419
R420
R421
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47
47
47
47
(1005)
(1005)
(1005)
(1005)
RB201
RB202
RB203
RB204
RB205
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10
10
10
10
10
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB206
RB207
RB208
RB209
RB210
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10
10
10
10
10
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB211
RB212
RB213
RB214
RB215
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
1-234-369-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10
10
10
10
10
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB216
RB217
RB218
RB219
RB220
1-234-369-21
1-234-369-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10
10
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB221
RB222
RB301
RB401
RB402
1-234-370-21
1-234-370-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB403
RB404
RB405
RB406
RB407
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB408
RB409
RB410
RB411
RB412
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
47 (1005)
1.0K (1005)
10 (1005)
1.0K (1005)
SP Description
RB413
RB414
RB415
RB416
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
47
47
47
47
(1005X4)
(1005X4)
(1005X4)
(1005X4)
X301
1-813-480-11 s OSCILLATOR, CRYSTAL
7-49
------------ENC-112 BOARD
------------Ref. No.
or Qty Part No.
(ENC-112 BOARD)
Ref. No.
or Qty Part No.
SP Description
1pc
A-1707-917-A s MOUNTED CIRCUIT BOARD, ENC-112
C100
C101
C102
C103
C104
1-112-815-91
1-125-777-81
1-112-298-91
1-100-567-81
1-125-777-81
s
s
o
s
s

C105
C106
C107
C108
C109
1-112-298-91
1-100-567-81
1-125-777-81
1-112-298-91
1-100-567-81
o
s
s
o
s

C110
C111
C112
C113
C114
1-125-777-81
1-112-298-91
1-100-567-81
1-125-777-81
1-112-815-91
s
o
s
s
s

C115
C116
C117
C118
C119
1-125-777-81
1-125-777-81
1-125-777-81
1-112-298-91
1-100-567-81
s
s
s
o
s

1005
1005
1005
C120
C121
C122
C123
C124
1-125-777-81
1-125-777-81
1-125-777-81
1-112-298-91
1-100-567-81
s
s
s
o
s

1005
1005
1005
C125
C126
C127
C128
C129
1-125-777-81
1-125-777-81
1-125-777-81
1-100-567-81
1-112-815-91
s
s
s
s
s

C130
C131
C132
C133
C134
1-125-777-81
1-112-298-91
1-100-567-81
1-125-777-81
1-112-298-91
s
o
s
s
o

C135
C136
C137
C138
C139
1-100-567-81
1-125-777-81
1-112-298-91
1-100-567-81
1-125-777-81
s
s
o
s
s

C140
C141
C142
C143
C144
1-112-298-91
1-100-567-81
1-125-777-81
1-112-298-91
1-100-567-81
o
s
s
o
s

C145
C146
C147
C148
C149
1-125-777-81
1-112-298-91
1-100-567-81
1-125-777-81
1-112-815-91
s
o
s
s
s

C150
C151
C152
C153
C154
1-112-815-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C155
C156

7-50
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
1005
1005
1005
1005
1005
1005
C (1608)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
SP Description
C157
C158
C159
C160
C161
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C162
C163
C164
C165
C166
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C167
C168
C169
C170
C171
1-165-989-91
1-165-989-91
1-165-989-91
1-112-815-91
1-112-815-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
D100
D101
D102
6-502-197-01 s DI SML-D12M8WT86SM
6-502-197-01 s DI SML-D12M8WT86SM
6-502-197-01 s DI SML-D12M8WT86SM
FB100
FB101
FB102
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-469-094-21 s FERRITE, EMI (SMD) (1608)
1-469-094-21 s FERRITE, EMI (SMD) (1608)
IC100
8-753-276-37 o IC CXD3195AGG-T6
R100
R101
R102
R103
R104
1-220-878-81
1-218-990-81
1-218-990-81
1-218-990-81
1-220-878-81
s
s
s
s
s
RES, CHIP 22 (1005)

RES, CHIP 22 (1005)
R105
R106
R107
R108
R109
1-220-878-81
1-208-911-81
1-220-878-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R110
R111
R112
R113
R114
1-208-911-81
1-208-911-81
1-218-990-81
1-208-887-81
1-208-887-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
R115
R118
R119
R120
R121
1-208-911-81
1-220-878-81
1-220-878-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
RB101
RB102
RB103
RB105
RB108
1-234-378-21
1-234-378-21
1-234-378-21
1-234-376-21
1-234-378-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10K (1005X4)
10K (1005X4)
10K (1005X4)
2.2K (1005X4)
10K (1005X4)
RB109
RB110
RB111
RB112
RB113
1-234-378-21
1-234-378-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10K (1005X4)
10K (1005X4)
22 (1005X4)
22 (1005X4)
22 (1005X4)
RB114
RB115
RB116
RB117
RB118
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
22
22
22
CHIP
CHIP
CHIP
CHIP
CHIP
10MF
10MF
10MF
10MF
10MF
(2012)
(2012)
(2012)
C (1608)
C (1608)
22 (1005)
10K (1005)
22 (1005)
10K (1005)
10K (1005)
10K (1005)
22 (1005)
22 (1005)
22 (1005)
22 (1005)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
HSCU-300
-----------PS-739 BOARD
-----------Ref. No.
or Qty Part No.
(ENC-112 BOARD)
Ref. No.
or Qty Part No.
SP Description
RB119
RB120
RB121
RB122
RB123
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
1-234-370-21
RB124
RB125
RB126
1-234-370-21 s RES, NETWORK 22 (1005X4)

1-234-370-21 s RES, NETWORK 22 (1005X4)
1-234-370-21 s RES, NETWORK 22 (1005X4)
-----------FL-349 BOARD
-----------Ref. No.
or Qty Part No.
1pc
1pc
2pcs
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
22
22
22
22
22
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
! 1-523-066-11 s FUSE (TIME-LAG TYPE) 10A
A-1707-204-A s MOUNTED CIRCUIT BOARD, FL-349

1-562-211-11 o HOUSING, CONNECTOR 3P
3-315-760-01 s SPACER (B)
!
!
!
!
!
1-136-206-11
1-136-206-11
1-136-200-11
1-136-191-11
1-136-191-11
C21
C22
!
!
1-113-925-51 s CAP, CERAMIC 10000PF F

1-113-925-51 s CAP, CERAMIC 10000PF F
CN1
CN2
1-691-291-11 o PIN, CONNECTOR (PC BOARD) 5P

1-750-880-11 s RECEPTACLE, COAXIAL CONNECTOR
s
s
s
s
s
METALIZED
METALIZED
METALIZED
METALIZED
METALIZED
INDUCTOR,
INDUCTOR,
INDUCTOR,
INDUCTOR,
INDUCTOR,
FILM
FILM
FILM
FILM
FILM
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0.033MF
0.033MF
0.15MF
0.22MF
0.22MF
1-469-979-21
1-469-979-21
1-469-979-21
1-469-979-21
1-469-979-21
FB13
FB14
1-469-979-21 s INDUCTOR, FERRITE BEAD

1-469-979-21 s INDUCTOR, FERRITE BEAD
L1
L2
L3
L4
L5
1-410-283-11
1-410-283-11
1-416-831-11
1-416-831-11
1-416-831-11
s
s
s
s
s
INDUCTOR (WITH CORE)

INDUCTOR (WITH CORE)
COIL, CHOKE 100UH
COIL, CHOKE 100UH
COIL, CHOKE 100UH
L11
L13
L14
L21
L22
1-416-831-11
1-416-831-11
1-416-831-11
1-412-963-21
1-412-963-21
s
s
s
s
s
COIL, CHOKE 100UH

COIL, CHOKE 100UH
COIL, CHOKE 100UH
INDUCTOR 100UH (2520)
INDUCTOR 100UH (2520)
------------MB-1124 BOARD
------------Ref. No.
or Qty Part No.
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
FB2
FB3
FB4
FB5
FB11
HSCU-300
F1
A-1706-471-A s MOUNTED CIRCUIT BOARD, PS-739
SP Description
C3
C4
C5
C11
C13
1pc
1pc
SP Description
BEAD
BEAD
BEAD
BEAD
BEAD
SP Description
A-1707-195-A s MOUNTED CIRCUIT BOARD, MB-1124
7-51
------------SDI-97B BOARD
------------Ref. No.
or Qty Part No.
(SDI-97B BOARD)
Ref. No.
or Qty Part No.
SP Description
C263
C303
C304
C305
C306
1-100-505-91
1-112-746-91
1-100-505-91
1-100-505-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
4.7MF
0.1MF
0.1MF
4.7MF
C
B
C
C
B
(1005)
(1608)
(1005)
(1005)
(1608)
C322
C323
C324
C325
C341
1-112-746-91
1-100-505-91
1-100-505-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4.7MF
0.1MF
0.1MF
4.7MF
4.7MF
B
C
C
B
B
(1608)
(1005)
(1005)
(1608)
(1608)
C342
C346
C347
C503
C504
1-100-505-91
1-100-505-91
1-112-746-91
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
4.7MF
0.1MF
0.1MF
C
C
B
C
C
(1005)
(1005)
(1608)
(1005)
(1005)
C523
C524
1-100-505-91 s CAP, CERAMIC 0.1MF C (1005)

1-100-505-91 s CAP, CERAMIC 0.1MF C (1005)
CN1
CN2
CN3
CN10
1-819-993-11
1-819-993-11
1-819-993-11
1-820-786-11
D1
D2
D28
8-719-083-60 s DI UDZSUSTE-174.7B
8-719-083-60 s DI UDZSUSTE-174.7B
8-719-070-20 s DIODE RB706F-40
E1
E2

(1608)
(1608)
(1608)
(1608)
(1608)
FB1
FB101
FB102
FB103
FB104
1-414-554-21
1-414-554-21
1-414-554-21
1-414-554-21
1-414-554-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
(1608)
(1608)
(1608)
(1608)
(1608)
FL201
FL221
FL241
FL301
FL321
1-813-544-11
1-813-544-11
1-813-544-11
1-813-437-11
1-813-437-11
s
s
s
s
s
FILTER,
FILTER,
FILTER,
FILTER,
FILTER,
FL341
1-813-437-11 s FILTER, LOW PASS (10MHZ)
IC1
IC2
IC3
IC11
IC101
8-759-327-01
6-704-976-01
6-712-135-01
8-759-598-43
6-709-619-01
s
s
o
s
s
IC
IC
IC
IC
IC
NJM062V(TE2)
ADR381ARTZ-REEL7
R1173H001D-T1-F
TC7WH04FK(TE85R)
GS1578ACNE3
IC102
IC121
IC141
IC201
IC221
6-709-619-01
8-759-256-45
8-759-092-83
8-759-561-46
8-759-561-46
s
s
s
s
s
IC
IC
IC
IC
IC
GS1578ACNE3
NJM4560M-TE2
SN75158PSR
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
IC241
IC261
IC301
IC302
IC321
8-759-561-46
8-759-561-46
8-759-561-46
8-759-561-46
8-759-561-46
s
s
s
s
s
IC
IC
IC
IC
IC
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
IC341
IC342
IC501
IC521
8-759-561-46
8-759-561-46
8-759-561-46
8-759-561-46
s
s
s
s
IC
IC
IC
IC
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
1pc
3pcs
A-1707-216-A s MOUNTED CIRCUIT BOARD, SDI-97B

3-637-901-02 s SCREW M2.6X5
C1
C2
C3
C4
C5
1-165-585-21
1-100-505-91
1-100-505-91
1-112-015-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C6
C7
C8
C9
C10
1-164-874-81
1-164-874-81
1-164-874-81
1-164-874-81
1-112-746-91
s
s
s
s
s

C11
C12
C13
C14
C15
1-112-746-91
1-100-055-21
1-100-055-21
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C16
C17
C21
C23
C24
1-112-015-91
1-100-055-21
1-100-505-91
1-100-505-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C27
C28
C29
C101
C102
1-100-055-21
1-100-055-21
1-100-055-21
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C103
C104
C105
C106
C107
1-112-746-91
1-112-746-91
1-112-746-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4.7MF
4.7MF
4.7MF
4.7MF
4.7MF
B
B
B
B
B
C108
C109
C110
C111
C112
1-112-746-91
1-112-746-91
1-112-746-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4.7MF
4.7MF
4.7MF
4.7MF
4.7MF
B
B
B
B
B
C113
C114
C151
C152
C153
1-112-746-91
1-112-746-91
1-112-746-91
1-164-862-81
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C154
C156
C157
C201
C202
1-100-505-91
1-100-505-91
1-112-746-91
1-100-505-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
4.7MF
0.1MF
4.7MF
C
C
B
C
B
(1005)
(1005)
(1608)
(1005)
(1608)
C203
C204
C221
C222
C223
1-112-746-91
1-100-505-91
1-100-505-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4.7MF
0.1MF
0.1MF
4.7MF
4.7MF
B
C
C
B
B
(1608)
(1005)
(1005)
(1608)
(1608)
C224
C241
C242
C243
C244
1-100-505-91
1-100-505-91
1-112-746-91
1-112-746-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
4.7MF
4.7MF
0.1MF
C
C
B
B
C
(1005)
(1005)
(1608)
(1608)
(1005)
C262
1-100-505-91 s CAP, CERAMIC 0.1MF C (1005)
7-52
SP Description
CHIP ELECT 47MF

s
s
s
s
CONNECTOR,
CONNECTOR,
CONNECTOR,
CONNECTOR,
COAXIAL(BNC DOUBLE)
COAXIAL(BNC DOUBLE)
COAXIAL(BNC DOUBLE)
FFC/FPC (ZIF) 33P
EMI
EMI
EMI
EMI
EMI
LOW
LOW
LOW
LOW
LOW
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
PASS
PASS
PASS
PASS (10MHZ)
PASS (10MHZ)
HSCU-300
(SDI-97B BOARD)
(SDI-97B BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
L1
L2
L11
L101
L102
1-414-398-41
1-416-344-21
1-414-398-41
1-414-459-21
1-414-459-21
s
s
s
s
s

COIL, CHOKE 10UH
INDUCTOR, CHIP (S) 4.7NH
INDUCTOR, CHIP (S) 4.7NH
R104
R105
R106
R107
R108
1-211-986-91
1-208-863-81
1-208-863-81
1-211-986-91
1-211-986-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
51 (1608)
100 (1005)
100 (1005)
51 (1608)
51 (1608)
L103
L104
L151
L152
L201
1-414-459-21
1-414-459-21
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR, CHIP
INDUCTOR, CHIP
INDUCTOR (SMD)
INDUCTOR (SMD)
INDUCTOR (SMD)
(S) 4.7NH
(S) 4.7NH
10.0UH
10.0UH
10.0UH
R109
R110
R111
R112
R113
1-208-855-81
1-208-927-81
1-208-855-81
1-208-927-81
1-208-883-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47K (1005)
47 (1005)
47K (1005)
680 (1005)
L202
L221
L222
L241
L242
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
R114
R115
R116
R117
R118
1-208-883-81
1-211-990-91
1-211-990-91
1-211-990-91
1-211-990-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
75 (1608)
75 (1608)
75 (1608)
75 (1608)
L261
L262
L301
L302
L321
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
R119
R120
R121
R122
R127
1-208-859-81
1-208-859-81
1-208-859-81
1-208-859-81
1-218-990-81
s
s
s
s
s
RES, CHIP 68 (1005)

RES, CHIP 68 (1005)
RES, CHIP 68 (1005)
RES, CHIP 68 (1005)
L322
L341
L343
L501
L502
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
R128
R129
R130
R151
R152
1-218-990-81
1-218-990-81
1-218-990-81
1-208-863-81
1-208-927-81
s
s
s
s
s

RES, CHIP 100 (1005)
L521
L522
1-414-398-41 s INDUCTOR (SMD) 10.0UH

1-414-398-41 s INDUCTOR (SMD) 10.0UH
PH141
8-749-014-35 s IC HCPL-0630-500
Q1
Q2
Q3
6-550-631-01 s TRANSISTOR 2SA1797-T100-Q

6-550-632-01 s TRANSISTOR 2SC4672-T100-Q
R153
R154
R155
R156
R157
1-208-903-81
1-208-907-81
1-208-875-81
1-208-907-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
6.8K (1005)
330 (1005)
6.8K (1005)
10K (1005)
R1
R2
R3
R4
R5
1-218-990-81
1-218-990-81
1-208-871-81
1-208-871-81
1-208-919-81
s
s
s
s
s

RES, CHIP 220 (1005)
RES, CHIP 220 (1005)
R158
R159
R160
R161
R162
1-208-907-81
1-208-871-81
1-208-871-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
6.8K (1005)
220 (1005)
220 (1005)
22 (1005)
22 (1005)
R6
R7
R8
R9
R10
1-208-919-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
47K
47K
22K
R163
R164
R166
R167
R168
1-220-878-81
1-220-878-81
1-208-871-81
1-208-871-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
22 (1005)
220 (1005)
220 (1005)
47 (1005)
R11
R12
R21
R22
R23
1-208-887-81
1-208-911-81
1-208-927-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
47K (1005)
10K (1005)
10K (1005)
R169
R201
R202
R203
R204
1-208-855-81
1-208-863-81
1-208-903-81
1-218-990-81
1-208-875-81
s
s
s
s
s
RES, CHIP 47 (1005)

RES, CHIP 100 (1005)
RES, CHIP 4.7K (1005)
RES, CHIP 330 (1005)
R24
R25
R26
R27
R28
1-208-919-81
1-208-927-81
1-208-863-81
1-208-927-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
47K (1005)
100 (1005)
47K (1005)
1.0K (1005)
R205
R206
R207
R210
R212
1-208-863-81
1-218-990-81
1-208-887-81
1-208-859-81
1-208-887-81
s
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 68 (1005)
RES, CHIP 1.0K (1005)
R29
R30
R31
R32
R33
1-208-887-81
1-208-911-81
1-220-878-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
22 (1005)
22 (1005)
22 (1005)
R213
R221
R222
R223
R224
1-211-990-91
1-208-863-81
1-208-903-81
1-218-990-81
1-208-875-81
s
s
s
s
s
RES, CHIP 75 (1608)

RES, CHIP 100 (1005)
RES, CHIP 4.7K (1005)
RES, CHIP 330 (1005)
R103
1-211-986-91 s RES, CHIP 51 (1608)
R225
R226
R227
R230
1-208-863-81
1-218-990-81
1-208-887-81
1-208-859-81
s
s
s
s
RES, CHIP 100 (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 68 (1005)
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
7-53
(SDI-97B BOARD)
(SDI-97B BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
R232
R233
R241
R242
R243
1-208-887-81
1-211-990-91
1-208-863-81
1-208-903-81
1-218-990-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 75 (1608)
RES, CHIP 100 (1005)
RES, CHIP 4.7K (1005)
R369
R371
R501
R502
R503
1-211-990-91
1-211-990-91
1-208-919-81
1-208-859-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
75 (1608)
75 (1608)
22K (1005)
68 (1005)
47 (1005)
R244
R245
R246
R247
R250
1-208-875-81
1-208-863-81
1-218-990-81
1-208-887-81
1-208-859-81
s
s
s
s
s
RES, CHIP 330 (1005)

RES, CHIP 100 (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 68 (1005)
R504
R505
R507
R508
R509
1-208-887-81
1-208-875-81
1-208-887-81
1-208-875-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
330 (1005)
1.0K (1005)
330 (1005)
100 (1005)
R252
R253
R261
R262
R263
1-208-887-81
1-211-990-91
1-208-863-81
1-208-875-81
1-218-990-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 75 (1608)
RES, CHIP 100 (1005)
RES, CHIP 330 (1005)
R521
R522
R523
R524
R525
1-208-919-81
1-208-859-81
1-208-855-81
1-208-887-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
68 (1005)
47 (1005)
1.0K (1005)
330 (1005)
R264
R265
R267
R268
R301
1-208-887-81
1-218-990-81
1-208-887-81
1-211-990-91
1-208-863-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 75 (1608)
RES, CHIP 100 (1005)
R527
R528
R529
1-208-887-81 s RES, CHIP 1.0K (1005)

1-208-875-81 s RES, CHIP 330 (1005)
1-208-863-81 s RES, CHIP 100 (1005)
R302
R303
R305
R306
R307
1-208-887-81
1-208-871-81
1-208-879-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
220 (1005)
470 (1005)
22 (1005)
22 (1005)
R308
R309
R310
R311
R312
1-208-887-81
1-208-887-81
1-208-863-81
1-208-863-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
100 (1005)
1.0K (1005)
R313
R316
R318
R321
R322
1-208-887-81
1-208-887-81
1-208-887-81
1-208-863-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
1.0K (1005)
R323
R324
R325
R326
R327
1-208-871-81
1-208-879-81
1-220-878-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
470 (1005)
22 (1005)
1.0K (1005)
100 (1005)
R328
R330
R331
R333
R334
1-208-887-81
1-208-887-81
1-211-990-91
1-211-990-91
1-211-990-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
75 (1608)
75 (1608)
75 (1608)
R341
R344
R345
R348
R349
1-208-863-81
1-208-887-81
1-208-871-81
1-208-879-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
1.0K (1005)
220 (1005)
470 (1005)
22 (1005)
R352
R353
R354
R356
R361
1-208-887-81
1-208-863-81
1-208-887-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100 (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
R363
R364
R365
R367
1-220-878-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
22 (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
7-54
THP1
THP2
!
!

HSCU-300
-----------SY-364 BOARD
-----------Ref. No.
or Qty Part No.
(SY-364 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
1-756-076-21 s HOLDER, LITHIUM BATTERY
C56
C57
C58
C59
C60
1-126-391-21
1-125-777-81
1-126-399-21
1-164-878-81
1-100-159-91
s
s
s
s
s
CAP, CHIP ELECT 47MF (5X5.7)

C1
C2
C3
C4
C5
1-125-777-81
1-125-777-81
1-100-159-91
1-100-159-91
1-126-391-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP ELECT 47MF (5X5.7)
C61
C62
C63
C64
C65
1-100-159-91
1-125-777-81
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
B (SMD)
0.1MF B
0.1MF B
B (SMD)
0.1MF B
3216
1005
1005
3216
1005
C6
C7
C8
C9
C10
1-126-391-21
1-164-866-81
1-125-777-81
1-125-777-81
1-164-850-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C66
C67
C68
C69
C70
1-100-567-81
1-100-567-81
1-125-777-81
1-100-159-91
1-165-989-91
s
s
s
s
s

1005
1005
1005
3216
C11
C12
C13
C15
C16
1-164-858-81
1-125-777-81
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
22PF CH
0.1MF B
0.1MF B
B (SMD)
0.1MF B
1005
1005
1005
3216
1005
C71
C72
C73
C74
C75
1-100-159-91
1-117-144-21
1-125-777-81
1-125-777-81
1-127-956-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

ELECT 0.47MF
CHIP FILM 0.1MF (3225)
C17
C18
C19
C20
C21
1-100-159-91
1-125-777-81
1-112-692-81
1-112-692-81
1-100-159-91
s
s
s
s
s

3216
1005
1005
1005
3216
C76
C77
C78
C79
C80
1-125-777-81
1-125-777-81
1-125-777-81
1-127-956-21
1-127-956-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C22
C23
C24
C25
C26
1-100-159-91
1-164-874-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s

3216
1005
1005
1005
1005
C81
C82
C83
C84
C85
1-165-989-91
1-165-989-91
1-165-989-91
1-165-989-91
1-127-956-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C27
C28
C29
C30
C31
1-164-874-81
1-125-777-81
1-165-989-91
1-100-159-91
1-125-777-81
s
s
s
s
s

1005
1005
3216
1005
C86
C87
C88
C89
C90
1-164-845-81
1-164-858-81
1-127-956-21
1-100-159-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C32
C33
C34
C35
C36
1-125-777-81
1-164-874-81
1-126-391-21
1-164-850-81
1-126-391-21
s
s
s
s
s

C91
C92
C93
C94
C95
1-125-777-81
1-125-777-81
1-125-777-81
1-112-692-81
1-126-399-21
s
s
s
s
s

C37
C38
C39
C40
C41
1-125-777-81
1-164-882-81
1-100-159-91
1-125-777-81
1-164-882-81
s
s
s
s
s

1005
1005
3216
1005
1005
C96
C97
C98
C99
C100
1-164-878-81
1-112-717-91
1-126-391-21
1-112-717-91
1-125-777-81
s
s
s
s
s

C42
C43
C44
C45
C46
1-125-777-81
1-117-144-21
1-126-391-21
1-127-956-21
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

ELECT 0.47MF
CHIP ELECT 47MF (5X5.7)
C101
C102
C103
C104
C105
1-100-159-91
1-125-777-81
1-164-850-81
1-164-850-81
1-164-850-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
B (SMD)
0.1MF B
10PF CH
10PF CH
10PF CH
3216
1005
1005
1005
1005
C47
C48
C49
C50
C51
1-125-777-81
1-125-777-81
1-125-777-81
1-127-956-21
1-100-159-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C106
C107
C108
C109
C110
1-125-777-81
1-165-989-91
1-100-159-91
1-100-567-81
1-125-777-81
s
s
s
s
s

1005
C52
C53
C54
C55
1-100-567-81
1-125-777-81
1-127-956-21
1-125-777-81
s
s
s
s

C111
C112
C113
C114
1-165-989-91
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
1pc
1pc
6pcs
A-1707-190-A s MOUNTED CIRCUIT BOARD, SY-364

3-179-085-01 s LEVER (L), PC BOARD
4-382-854-51 s SCREW (M3X6), P, SW (+)
BT801
HSCU-300
ELECT 47MF (5X5.7)

CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC

FILM 0.1MF (3225)
FILM 0.1MF (3225)
CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
3216
1005
1005
(2012)
0.1MF B 1005
B (SMD) 3216
0.1MF B 1005
7-55
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C115
C116
C117
C118
C119
1-112-717-91
1-125-777-81
1-112-717-91
1-125-777-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
C175
C176
C177
C300
C301
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-100-415-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C120
C121
C122
C123
C124
1-125-777-81
1-127-956-21
1-165-989-91
1-165-989-91
1-100-159-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C302
C304
C305
C306
C307
1-125-777-81
1-112-791-11
1-165-989-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

ELECT 100MF
CERAMIC 10MF (2012)
C125
C126
C127
C128
C129
1-127-956-21
1-100-159-91
1-127-956-21
1-100-567-81
1-125-777-81
s
s
s
s
s

C308
C309
C310
C311
C312
1-125-777-81
1-125-777-81
1-165-989-91
1-165-989-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
C130
C131
C132
C133
C134
1-125-777-81
1-112-692-81
1-112-717-91
1-112-717-91
1-164-850-81
s
s
s
s
s

C313
C314
C315
C316
C317
1-164-939-81
1-164-939-81
1-164-939-81
1-164-939-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIPCERAMIC 2200PF
CHIPCERAMIC 2200PF
CHIPCERAMIC 2200PF
CHIPCERAMIC 2200PF
CHIP CERAMIC 0.1MF
C135
C136
C137
C138
C139
1-164-850-81
1-165-989-91
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
10PF CH
(2012)
0.1MF B
0.1MF B
B (SMD)
1005
1005
3216
C318
C319
C320
C321
C322
1-165-989-91
1-165-989-91
1-125-777-81
1-164-850-81
1-164-850-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C140
C141
C142
C143
C144
1-125-777-81
1-125-777-81
1-165-989-91
1-165-989-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
0.1MF B 1005
0.1MF B 1005
(2012)
(2012)
0.1MF B 1005
C323
C324
C325
C326
C327
1-126-402-21
1-126-402-21
1-112-717-91
1-112-717-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP ELECT 2.2MF (4X5.7)

C145
C146
C147
C148
C149
1-125-777-81
1-112-717-91
1-164-845-81
1-112-717-91
1-164-850-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C328
C329
C330
C331
C332
1-125-777-81
1-112-717-91
1-165-989-91
1-125-777-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C150
C151
C152
C153
C154
1-164-874-81
1-165-989-91
1-125-777-81
1-165-989-91
1-100-159-91
s
s
s
s
s

C333
C334
C335
C336
C337
1-125-777-81
1-112-692-81
1-114-214-81
1-165-989-91
1-114-214-81
s
s
s
s
s

C155
C156
C158
C159
C160
1-125-777-81
1-125-777-81
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C338
C339
C340
C341
C342
1-114-214-81
1-125-777-81
1-112-692-81
1-112-692-81
1-112-717-91
s
s
s
s
s

C161
C162
C163
C164
C165
1-165-989-91
1-125-777-81
1-112-717-91
1-112-717-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

C343
C344
C345
C346
C347
1-164-935-81
1-112-717-91
1-112-692-81
1-114-214-81
1-164-882-81
s
s
s
s
s

C166
C167
C168
C169
C170
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C348
C349
C350
C351
C352
1-112-692-81
1-164-866-81
1-164-866-81
1-114-214-81
1-125-777-81
s
s
s
s
s

C171
C172
C173
C174
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
1005
1005
1005
1005
C353
C354
C355
C356
1-100-055-21
1-100-055-21
1-107-781-21
1-107-781-21
s
s
s
s
CAP,
CAP,
CAP,
CAP,
7-56
1005
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.47MF(1005)
0.1MF B 1005
0.1MF B 1005
(2012)
(2012)
(2012)
B
B
B
B
B
1005
1005
1005
1005
1005
(2012)
(2012)
0.1MF B 1005
10PF CH 1005
10PF CH 1005

ELECT 47MF
ELECT 47MF
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C357
C358
C359
C360
C361
1-125-777-81
1-117-145-21
1-114-214-81
1-117-145-21
1-117-145-21
s
s
s
s
s

CAP, ELECT 1MF
CAP, ELECT 1MF
CAP, ELECT 1MF
C441
C442
C443
C444
C445
1-125-777-81
1-125-777-81
1-114-214-81
1-114-214-81
1-164-882-81
s
s
s
s
s

C362
C363
C364
C365
C366
1-125-777-81
1-112-692-81
1-112-692-81
1-100-581-81
1-112-692-81
s
s
s
s
s

C446
C447
C448
C449
C450
1-164-882-81
1-114-214-81
1-114-214-81
1-112-692-81
1-112-692-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C367
C368
C369
C370
C371
1-125-777-81
1-125-777-81
1-125-777-81
1-100-415-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
0.47MF(1005)
0.1MF B 1005
C451
C452
C453
C454
C455
1-112-692-81
1-112-692-81
1-100-581-81
1-100-581-81
1-165-989-91
s
s
s
s
s

C372
C373
C374
C400
C401
1-165-989-91
1-164-882-81
1-164-882-81
1-112-791-11
1-125-777-81
s
s
s
s
s

CAP, ELECT 100MF
C456
C458
C459
C462
C463
1-165-989-91
1-112-746-91
1-112-746-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF (2012)
4.7MF B (1608)
4.7MF B (1608)
4.7MF B (1608)
4.7MF B (1608)
C402
C403
C404
C405
C406
1-165-989-91
1-164-850-81
1-125-777-81
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

C530
C531
C532
C533
C534
1-165-989-91
1-165-989-91
1-112-717-91
1-112-717-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF (2012)
10MF (2012)
1UF B (1005)
1UF B (1005)
10MF (2012)
C407
C408
C409
C410
C411
1-165-989-91
1-165-989-91
1-164-939-81
1-164-939-81
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C535
C536
C537
C538
C539
1-125-777-81
1-164-935-81
1-164-939-81
1-164-935-81
1-164-939-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC 0.1MF

CHIP CERAMIC 470PF
CHIPCERAMIC 2200PF
CHIP CERAMIC 470PF
CHIPCERAMIC 2200PF
B
B
B
B
B
1005
1005
1005
1005
1005
C412
C413
C414
C415
C416
1-112-692-81
1-112-692-81
1-112-692-81
1-112-692-81
1-114-214-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CERAMIC470PF CH1005
C540
C541
C542
C543
C544
1-112-692-81
1-112-692-81
1-125-777-81
1-164-850-81
1-165-989-91
s
s
s
s
s
1005
1005
1005
1005
C417
C418
C419
C420
C421
1-114-214-81
1-112-692-81
1-112-692-81
1-112-717-91
1-112-717-91
s
s
s
s
s

C545
C546
C547
C548
C549
1-125-777-81
1-125-777-81
1-125-777-81
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C422
C423
C424
C425
C426
1-112-717-91
1-114-214-81
1-114-214-81
1-125-777-81
1-125-777-81
s
s
s
s
s

C550
C551
C552
C553
C554
1-126-402-21
1-112-717-91
1-112-717-91
1-165-989-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
C427
C428
C429
C430
C431
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
1005
1005
1005
1005
1005
C555
C556
C557
C558
C559
1-165-989-91
1-165-989-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C432
C433
C434
C435
C436
1-125-777-81
1-164-882-81
1-164-882-81
1-100-055-21
1-100-055-21
s
s
s
s
s

C560
C561
C562
C563
C564
1-125-777-81
1-114-214-81
1-114-214-81
1-125-777-81
1-125-777-81
s
s
s
s
s

C437
C438
C439
C440
1-100-055-21
1-100-055-21
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
C565
C566
C567
C568
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s

HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
22MF B 3225
22MF B 3225
0.1MF B 1005
0.1MF B 1005

CERAMIC470PF CH1005
CERAMIC470PF CH1005
(2012)
(2012)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
B
B
B
B
1005
1005
1005
1005
7-57
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C569
C570
C571
C572
C573
1-114-214-81
1-125-777-81
1-125-777-81
1-114-214-81
1-125-777-81
s
s
s
s
s

C730
C731
C732
C733
C734
1-107-819-81
1-107-819-81
1-107-819-81
1-107-819-81
1-107-819-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C574
C575
C576
C577
C578
1-125-777-81
1-112-692-81
1-112-692-81
1-164-935-81
1-164-935-81
s
s
s
s
s

1005
1005
1005
1005
1005
C735
C736
C737
C738
C739
1-107-819-81
1-125-777-81
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
s

C579
C580
C581
C582
C583
1-114-214-81
1-114-214-81
1-112-717-91
1-112-717-91
1-112-692-81
s
s
s
s
s

C740
C741
C742
C743
C744
1-100-581-81
1-100-581-81
1-100-581-81
1-100-159-91
1-100-159-91
s
s
s
s
s

C584
C585
C586
C587
C588
1-112-692-81
1-112-692-81
1-112-692-81
1-112-692-81
1-125-777-81
s
s
s
s
s
1005
1005
1005
1005
1005
C746
C747
C748
C749
C750
1-100-159-91
1-125-777-81
1-125-777-81
1-125-777-81
1-119-869-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C589
C590
C591
C592
C593
1-125-777-81
1-125-777-81
1-125-777-81
1-112-692-81
1-164-874-81
s
s
s
s
s

1005
1005
1005
1005
1005
C751
C753
C754
C756
C757
1-119-869-91
1-100-159-91
1-125-777-81
1-100-159-91
1-100-581-81
s
s
s
s
s
CAP, CHIP CERAMIC 10MF 3225

C594
C595
C596
C597
C598
1-164-874-81
1-107-781-21
1-107-781-21
1-107-781-21
1-107-781-21
s
s
s
s
s

CAP, ELECT 47MF
CAP, ELECT 47MF
CAP, ELECT 47MF
CAP, ELECT 47MF
C758
C759
C760
C761
C762
1-100-581-81
1-164-940-81
1-164-940-81
1-164-940-81
1-164-940-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C601
C602
C603
C604
C605
1-135-960-91
1-135-960-91
1-100-055-21
1-100-055-21
1-100-055-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C800
C801
C802
C803
C804
1-112-692-81
1-164-874-81
1-100-159-91
1-125-777-81
1-125-777-81
s
s
s
s
s
1005
1005
3216
1005
1005
C606
C607
C608
C609
C610
1-100-055-21
1-117-713-21
1-117-713-21
1-100-055-21
1-100-055-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC 22MF B 3225

ELECT 100MF
ELECT 100MF
CERAMIC 22MF B 3225
CERAMIC 22MF B 3225
C805
C806
C807
C808
C809
1-125-777-81
1-164-850-81
1-125-777-81
1-125-777-81
1-100-567-81
s
s
s
s
s

1005
1005
1005
1005
1005
C611
C612
C613
C614
C615
1-100-055-21
1-100-055-21
1-100-505-91
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C810
C811
C812
C813
C814
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
1-114-999-11
s
s
s
s
s

CAP, DOUBLE LAYERS 0.22F
1005
1005
1005
1005
C616
C617
C618
C619
C620
1-100-505-91
1-100-055-21
1-100-055-21
1-100-055-21
1-100-055-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C815
C816
C817
C818
C819
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C621
C626
C627
C630
C631
1-112-791-11
1-164-882-81
1-164-882-81
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP, ELECT 100MF

CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
CAP, CERAMIC 1UF
220PF CH 1005
220PF CH 1005
B (1005)
B (1005)
C820
C822
C823
C824
C825
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C633
C634
C635
C637
1-164-858-81
1-112-717-91
1-112-717-91
1-164-858-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,

C826
C827
C828
C829
1-100-159-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
B (SMD)
0.1MF B
0.1MF B
0.1MF B
3216
1005
1005
1005
7-58
10MF
10MF
22MF
22MF
22MF
B(3225)
B(3225)
B 3225
B 3225
B 3225
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC 22MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
22000PF
22000PF
22000PF
22000PF
22000PF
B1005
B1005
B1005
B1005
B1005
B (SMD) 3216
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
10MF 3225
CERAMIC 3300PF B 1005
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C830
C831
C832
C833
C834
1-125-777-81
1-125-777-81
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
0.1MF B
0.1MF B
0.1MF B
B (SMD)
0.1MF B
1005
1005
1005
3216
1005
C889
C890
C891
C892
C893
1-112-717-91
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

1005
1005
1005
1005
C835
C836
C837
C838
C839
1-125-777-81
1-125-777-81
1-125-777-81
1-164-935-81
1-164-935-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
470PF
470PF
B
B
B
B
B
1005
1005
1005
1005
1005
C894
C895
C896
C897
C898
1-125-777-81
1-125-777-81
1-112-692-81
1-112-692-81
1-112-692-81
s
s
s
s
s

1005
1005
1005
1005
1005
C840
C841
C842
C843
C844
1-125-777-81
1-125-777-81
1-125-777-81
1-100-567-81
1-100-567-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C899
C900
C901
C902
C903
1-112-692-81
1-112-692-81
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
s
1005
1005
1005
1005
3216
C845
C846
C847
C848
C849
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C904
C905
C906
C907
C908
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C850
C851
C852
C853
C854
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C909
C910
C911
C912
C913
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C855
C856
C857
C858
C859
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C914
C915
C916
C917
C918
1-125-777-81
1-112-692-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C860
C861
C862
C863
C864
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C919
C920
C921
C922
C923
1-112-692-81
1-125-777-81
1-112-692-81
1-125-777-81
1-100-567-81
s
s
s
s
s
1005
1005
1005
1005
1005
C865
C866
C867
C868
C869
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C924
C925
C926
C927
C928
1-165-989-91
1-112-692-81
1-112-692-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
C870
C871
C872
C873
C874
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C929
C930
C931
C932
C933
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C875
C876
C877
C878
C879
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-100-159-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 22MF
0.1MF B
0.1MF B
0.1MF B
0.1MF B
B (SMD)
1005
1005
1005
1005
3216
C935
C936
C937
C939
C940
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C880
C881
C882
C883
C884
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C941
C942
C943
C944
C945
1-125-777-81
1-125-777-81
1-165-989-91
1-165-989-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC 10MF
0.1MF B 1005
0.1MF B 1005
(2012)
(2012)
(2012)
C885
C886
C887
C888
1-100-159-91
1-125-777-81
1-100-159-91
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF
CHIP CERAMIC
CERAMIC 22MF
CHIP CERAMIC
B (SMD)
0.1MF B
B (SMD)
0.1MF B
3216
1005
3216
1005
C946
C947
C948
C949
1-165-989-91
1-165-989-91
1-165-989-91
1-165-989-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
(2012)
(2012)
(2012)
(2012)
HSCU-300
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF
10MF
10MF
10MF
7-59
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
1005
1005
C1016
C1017
C1019
C1020
C1021
1-100-567-81
1-100-567-81
1-100-567-81
1-112-717-91
1-100-567-81
s
s
s
s
s
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
CAP,CHIP CERAMIC
0.01MF B
0.01MF B
0.01MF B
B (1005)
0.01MF B
(2012)
(2012)
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
C1022
C1023
C1024
C1025
C1026
1-112-717-91
1-100-567-81
1-112-717-91
1-100-567-81
1-112-717-91
s
s
s
s
s
CAP, CERAMIC 1UF

CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
B (1005)
0.01MF B 1005
B (1005)
0.01MF B 1005
B (1005)
s
s
s
s
s

C1027
C1031
C1032
C1035
C1036
1-100-567-81
1-164-939-81
1-125-777-81
1-165-871-21
1-112-746-91
s
s
s
s
s

CAP, ELECT 22MF (4.0X5.5)
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
0.01MF
0.01MF
0.01MF
0.01MF
0.01MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1037
C1038
C1039
C1040
C1042
1-100-567-81
1-112-746-91
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
s

C970
C971
C972
C973
C974
1-100-567-81
1-100-567-81
1-100-567-81
1-125-777-81
1-125-777-81
s
s
s
s
s

B
B
B
B
B
1005
1005
1005
1005
1005
C1043
C1044
C1045
C1047
C1048
1-112-717-91
1-100-567-81
1-100-567-81
1-100-567-81
1-112-717-91
s
s
s
s
s
CAP, CERAMIC 1UF

CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
B (1005)
0.01MF B 1005
0.01MF B 1005
0.01MF B 1005
B (1005)
C975
C976
C977
C978
C979
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B
0.1MF B
(2012)
0.1MF B
0.1MF B
1005
1005
C1049
C1050
C1051
C1052
C1053
1-100-567-81
1-112-717-91
1-100-567-81
1-112-717-91
1-100-567-81
s
s
s
s
s
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
CAP,CHIP CERAMIC
0.01MF B 1005
B (1005)
0.01MF B 1005
B (1005)
0.01MF B 1005
C980
C981
C982
C983
C984
1-100-159-91
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 22MF
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
B (SMD)
0.1MF B
(2012)
0.1MF B
0.1MF B
3216
1005
1005
1005
C1054
C1055
C1056
C1057
C1060
1-112-717-91
1-100-567-81
1-125-777-81
1-125-777-81
1-112-717-91
s
s
s
s
s

C985
C986
C988
C989
C990
1-164-858-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
22PF CH
0.1MF B
0.1MF B
0.1MF B
0.1MF B
1005
1005
1005
1005
1005
C1062
C1063
C1064
C1065
C1066
1-125-777-81
1-125-777-81
1-125-777-81
1-126-391-21
1-126-391-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C991
C993
C994
C995
C996
1-164-874-81
1-125-777-81
1-100-567-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1067
C1068
C1069
C1070
C1071
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B
0.1MF B
(2012)
0.1MF B
0.1MF B
1005
1005
C997
C998
C999
C1001
C1003
1-125-777-81
1-125-777-81
1-125-777-81
1-100-567-81
1-164-939-81
s
s
s
s
s

CAP, CHIPCERAMIC 2200PF
1005
1005
1005
1005
1005
C1072
C1073
C1074
C1075
C1076
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
1005
1005
1005
1005
1005
C1004
C1007
C1008
C1009
C1010
1-125-777-81
1-165-871-21
1-112-746-91
1-100-567-81
1-112-746-91
s
s
s
s
s

CAP, ELECT 22MF (4.0X5.5)
C1077
C1078
C1080
C1081
C1082
1-165-989-91
1-125-777-81
1-165-989-91
1-165-989-91
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
C1011
C1012
C1014
C1015
1-100-567-81
1-100-567-81
1-100-567-81
1-112-717-91
s
s
s
s
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP,CHIP CERAMIC
CAP, CERAMIC 1UF
C1083
C1086
C1087
C1088
1-100-567-81
1-100-567-81
1-100-567-81
1-100-567-81
s
s
s
s
CAP,CHIP
CAP,CHIP
CAP,CHIP
CAP,CHIP
C950
C951
C952
C953
C954
1-125-777-81
1-125-777-81
1-165-989-91
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
0.1MF B
0.1MF B
(2012)
0.1MF B
0.1MF B
C955
C956
C957
C958
C959
1-165-989-91
1-165-989-91
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
C960
C961
C962
C963
C964
1-165-989-91
1-165-989-91
1-125-777-81
1-112-692-81
1-112-692-81
C965
C966
C967
C968
C969
7-60
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
1005
1005
1005
1005
0.01MF B 1005
0.01MF B 1005
0.01MF B 1005
B (1005)
1005
1005
1005
1005

ELECT 47MF (5X5.7)
ELECT 47MF (5X5.7)
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
B
B
B
B
B
1005
1005
(2012)
0.1MF B 1005
(2012)
(2012)
0.1MF B 1005
0.01MF
0.01MF
0.01MF
0.01MF
B
B
B
B
1005
1005
1005
1005
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
C1089
C1103
C1105
C1106
C1107
1-100-567-81
1-164-882-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s

1005
1005
1005
1005
1005
C1162
C1163
C1164
C1165
C1166
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C1108
C1109
C1110
C1111
C1112
1-165-989-91
1-125-777-81
1-112-717-91
1-112-717-91
1-164-882-81
s
s
s
s
s

C1167
C1168
C1169
C1170
C1501
1-125-777-81
1-165-989-91
1-165-989-91
1-125-777-81
1-100-566-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CHIP CERAMIC
CHIP CERAMIC
C1113
C1114
C1115
C1116
C1117
1-125-777-81
1-125-777-81
1-125-777-81
1-165-989-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
0.1MF B 1005
0.1MF B 1005
0.1MF B 1005
(2012)
(2012)
C1502
C1503
C1504
C1505
C1506
1-164-936-81
1-112-692-81
1-100-567-81
1-125-777-81
1-114-214-81
s
s
s
s
s

C1118
C1119
C1120
C1121
C1122
1-112-717-91
1-112-717-91
1-125-777-81
1-125-777-81
1-100-567-81
s
s
s
s
s

C1507
C1509
C1510
C1511
C1512
1-164-874-81
1-164-874-81
1-100-505-91
1-100-505-91
1-114-214-81
s
s
s
s
s

C1123
C1124
C1125
C1126
C1127
1-100-567-81
1-126-391-21
1-126-391-21
1-125-777-81
1-125-777-81
s
s
s
s
s

C1514
C1515
C1517
C1518
C1519
1-100-505-91
1-165-875-91
1-164-858-81
1-100-505-91
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1128
C1129
C1130
C1131
C1132
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1520
C1521
C1522
C1523
C1524
1-100-566-91
1-100-566-91
1-100-566-91
1-164-936-81
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF B 1608
0.1MF B 1608
0.1MF B 1608
680PF B 1005
10MF B 3216
C1133
C1134
C1135
C1136
C1137
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1525
C1526
C1527
C1528
C1529
1-165-875-91
1-112-015-91
1-164-936-81
1-165-875-91
1-165-875-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10MF B 3216
47MF B 3225
680PF B 1005
10MF B 3216
10MF B 3216
C1138
C1139
C1140
C1141
C1142
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-126-391-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP

ELECT 47MF (5X5.7)
C1530
C1531
C1532
C1533
C1534
1-165-989-91
1-131-661-21
1-131-661-21
1-131-661-21
1-131-661-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC 10MF (2012)

CHIP ELECT 100MF(6.3X5.7)
C1143
C1144
C1145
C1146
C1147
1-126-391-21
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
ELECT 47MF (5X5.7)

C1535
C1536
C1537
C1538
C1539
1-112-015-91
1-112-015-91
1-165-585-21
1-165-585-21
1-131-661-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
C1148
C1149
C1150
C1151
C1152
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1540
C1541
C1542
C1543
C1544
1-135-960-91
1-131-661-21
1-135-960-91
1-112-015-91
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C1153
C1154
C1155
C1156
C1157
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
C1546
C1547
C1548
C1549
C1550
1-112-015-91
1-112-015-91
1-112-015-91
1-165-989-91
1-131-661-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
C1158
C1159
C1160
C1161
1-125-777-81
1-125-777-81
1-125-777-81
1-125-777-81
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
1005
1005
1005
1005
C1551
C1552
C1553
C1554
1-100-505-91
1-165-875-91
1-165-875-91
1-100-505-91
s
s
s
s
CAP,
CAP,
CAP,
CAP,

HSCU-300
CHIP CERAMIC
CHIP CERAMIC
CHIP CERAMIC
CERAMIC 10MF
CERAMIC 10MF
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1MF
0.1MF
0.1MF
0.1MF
0.1MF
B
B
B
B
B
1005
1005
1005
1005
1005
0.1MF B 1005
(2012)
(2012)
0.1MF B 1005
0.1MF B 1608
CERAMIC 47MF B 3225

CERAMIC 47MF B 3225
ELECT 47MF
ELECT 47MF
ELECT 100MF(6.3X5.7)
7-61
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
C1555
C1556
C1557
C1558
C1559
1-165-585-21
1-164-935-81
1-164-935-81
1-165-585-21
1-125-827-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
ELECT 47MF
ELECT 47MF
CERAMIC 1MF B
C1621
C1622
C1623
C1624
C1625
1-100-566-91
1-100-566-91
1-165-585-21
1-165-585-21
1-131-661-21
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP

ELECT 47MF
ELECT 47MF
C1560
C1562
C1563
C1564
C1565
1-125-827-91
1-164-882-81
1-100-567-81
1-100-567-81
1-100-505-91
s
s
s
s
s

C1626
C1627
C1628
C1629
C1630
1-135-960-91
1-131-661-21
1-135-960-91
1-112-015-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP
CHIP
CHIP
CHIP
CHIP
CERAMIC 10MF B(3225)

CERAMIC 10MF B(3225)
CERAMIC 47MF B 3225
CERAMIC 47MF B 3225
C1566
C1567
C1568
C1569
C1570
1-100-505-91
1-100-567-81
1-165-585-21
1-165-585-21
1-131-661-21
s
s
s
s
s

CAP, CHIP ELECT 47MF
C1631
C1632
C1633
C1634
C1635
1-131-661-21
1-100-505-91
1-100-505-91
1-112-717-91
1-100-567-81
s
s
s
s
s

C1571
C1572
C1573
C1574
C1575
1-131-661-21
1-100-567-81
1-100-055-21
1-112-015-91
1-100-567-81
s
s
s
s
s

C1636
C1637
C1638
C1639
C1640
1-100-505-91
1-100-566-91
1-100-505-91
1-112-717-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
C1576
C1577
C1578
C1579
C1580
1-164-874-81
1-164-874-81
1-164-874-81
1-164-874-81
1-126-402-21
s
s
s
s
s

CAP, CHIP ELECT 2.2MF (4X5.7)
C1641
1-165-989-91 s CAP, CERAMIC 10MF (2012)
C1581
C1582
C1584
C1585
C1587
1-126-402-21
1-164-874-81
1-164-874-81
1-100-505-91
1-100-505-91
s
s
s
s
s
CAP, CHIP ELECT 2.2MF (4X5.7)

CN1
CN2
CN802
CN804
CN806
1-784-625-31
1-784-625-31
1-573-290-21
1-817-653-42
1-770-627-21
s
s
s
s
s
CONNECTOR, FFC/FPC(ZIF) AN 30P

CONNECTOR, FFC/FPC(ZIF) AN 30P
PIN, CONNECTOR (1.5MM) (SMD)4P
MEMORY STICK CONNECTOR
PIN, CONNECTOR 10P
C1588
C1589
C1590
C1591
C1592
1-112-015-91
1-100-505-91
1-126-396-21
1-126-396-21
1-100-505-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
D1
D2
D3
D4
D5
8-719-070-20
8-719-991-01
8-719-989-01
8-719-989-01
8-719-989-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
RB706F-40
DAP222-TL
DA221-TL
DA221-TL
DA221-TL
C1593
C1594
C1595
C1596
C1597
1-100-505-91
1-100-505-91
1-100-567-81
1-100-567-81
1-131-661-21
s
s
s
s
s

D6
D7
D8
D9
D10
8-719-989-01
8-719-989-01
8-719-989-01
8-719-989-01
8-719-989-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DA221-TL
DA221-TL
DA221-TL
DA221-TL
DA221-TL
C1598
C1599
C1600
C1601
C1602
1-131-661-21
1-112-015-91
1-100-505-91
1-100-505-91
1-112-015-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

D300
D530
D531
D730
D731
8-719-989-01
8-719-989-01
8-719-989-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DA221-TL
DA221-TL
DA221-TL
DAP222-TL
DAP222-TL
C1603
C1604
C1605
C1606
C1608
1-112-015-91
1-100-505-91
1-165-989-91
1-100-505-91
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CERAMIC 10MF (2012)
CERAMIC 10MF (2012)
D732
D733
D734
D735
D736
8-719-991-01
8-719-989-04
8-719-989-04
8-719-989-04
8-719-069-55
s
s
s
s
s
DIODE DAP222-TL
DIODE DAN222-TL
DIODE DAN222-TL
DIODE DAN222-TL
DI UDZSUSTE-175.6B
C1610
C1611
C1613
C1614
C1615
1-100-505-91
1-100-505-91
1-100-566-91
1-100-567-81
1-125-777-81
s
s
s
s
s

D737
D738
D739
D740
D741
8-719-069-55
8-719-069-55
8-719-069-55
8-719-069-55
8-719-069-55
s
s
s
s
s
DI
DI
DI
DI
DI
C1616
C1617
C1619
C1620
1-114-214-81
1-164-874-81
1-165-875-91
1-100-566-91
s
s
s
s

D742
D743
D744
D745
D746
8-719-989-04
8-719-989-04
8-719-991-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
D747
D748
8-719-989-04 s DIODE DAN222-TL

8-719-989-04 s DIODE DAN222-TL
7-62
CHIP
CHIP
CHIP
CHIP
CHIP

CHIP ELECT 47MF (6.3X5.7)
CHIP ELECT 47MF (6.3X5.7)

CERAMIC 10MF (2012)
UDZSUSTE-175.6B
UDZSUSTE-175.6B
UDZSUSTE-175.6B
UDZSUSTE-175.6B
UDZSUSTE-175.6B
DAN222-TL
DAN222-TL
DAP222-TL
DAP222-TL
DAP222-TL
HSCU-300
(SY-364 BOARD)
Ref. No.
or Qty Part No.
D749
D752
D753
D754
D755
(SY-364 BOARD)
Ref. No.
or Qty Part No.
SP Description
SP Description
8-719-991-01
8-719-991-01
8-719-991-01
8-719-989-04
8-719-989-04
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DAP222-TL
DAP222-TL
DAP222-TL
DAN222-TL
DAN222-TL
FB909
FB910
FB911
FB912
FB913
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
8-719-989-01
8-719-070-20
8-719-989-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DA221-TL
RB706F-40
DA221-TL
DAP222-TL
DAP222-TL
FB914
FB915
FB922
FB923
FB924
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D822
D823
D824
D825
D826
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
FB925
FB926
FB927
FB928
FB929
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D827
D828
D829
D830
D831
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
FB1500
FB1501
FB1502
FB1503
FB1504
1-469-094-21
1-469-094-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D832
D833
D834
D835
D836
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
8-719-991-01
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
DAP222-TL
FB1505
FB1506
FB1507
FB1508
FB1509
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D837
D838
D839
D1501
D1502
8-719-991-01
8-719-991-01
8-719-991-01
8-719-070-20
8-719-048-98
s
s
s
s
s
DIODE
DIODE
DIODE
DIODE
DIODE
DAP222-TL
DAP222-TL
DAP222-TL
RB706F-40
RB160L-40TE25
FB1510
FB1511
FB1512
FB1513
FB1514
1-414-864-21
1-414-864-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D1503
D1504
D1505
D1506
D1507
6-501-123-01
6-501-123-01
8-719-083-60
8-719-083-60
8-719-083-60
s
s
s
s
s
DIODE RB160M-60TR
DIODE RB160M-60TR
DI UDZSUSTE-174.7B
DI UDZSUSTE-174.7B
DI UDZSUSTE-174.7B
FB1515
FB1516
FB1517
FB1518
FB1519
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
D1508
D1509
D1511
D1512
D1513
8-719-083-60
8-719-989-01
8-719-070-20
8-719-048-98
8-719-083-60
s
s
s
s
s
DI UDZSUSTE-174.7B
DIODE DA221-TL
DIODE RB706F-40
DIODE RB160L-40TE25
DI UDZSUSTE-174.7B
FB1520
FB1521
FB1522
FB1523
FB1524
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
E1500
E1501
E1502
E1503
E1504
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
FB1525
FB1526
FB1527
FB1528
FB1529
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
E1505
FB1
FB2
FB3
FB4
FB5
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1530
FB1531
FB1532
FB1533
FB1534
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB901
FB902
FB903
FB904
FB905
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
1-469-094-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB1535
FB1536
FB1537
FB1538
FB1539
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
(1608)
FB906
FB908
1-469-094-21 s FERRITE, EMI (SMD) (1608)

1-469-094-21 s FERRITE, EMI (SMD) (1608)
FB1542
FB1543
FB1544
FB1545
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
D801
D802
D807
D820
D821
HSCU-300
7-63
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
FB1546
FB1547
FB1548
FB1549
1-414-864-21
1-414-864-21
1-414-864-21
1-414-864-21
s
s
s
s
FERRITE,
FERRITE,
FERRITE,
FERRITE,
IC1
IC2
IC3
IC4
IC5
8-759-327-14
8-759-327-14
8-759-327-14
6-706-476-01
8-759-344-12
s
s
s
s
s
IC
IC
IC
IC
IC
TL712CPSR
TL712CPSR
TL712CPSR
TC7SET04FU(T5RSOJF)
GS4981CTAE3
IC6
IC7
IC8
IC9
IC10
6-706-476-01
6-706-478-01
6-706-489-01
8-759-485-24
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SET04FU(T5RSOJF)
TC7SET08FU(T5RSOJF)
TC7SH32FU(T5RSOYJF)
MC74HC4046ADTR2
TC7W53FK(TE85R)
IC11
IC12
IC13
IC14
IC15
8-759-675-54
8-759-327-14
8-759-287-55
8-759-675-54
8-759-344-12
s
s
s
s
s
IC
IC
IC
IC
IC
TC7W53FK(TE85R)
TL712CPSR
TC7S66FU(TE85R)
TC7W53FK(TE85R)
GS4981CTAE3
IC16
IC17
IC18
IC19
IC20
6-707-839-01
8-759-485-24
8-759-675-54
6-707-856-01
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX04FT(EKJ)
MC74HC4046ADTR2
TC7W53FK(TE85R)
TC74LCX74FT(EKJ)
TC7W53FK(TE85R)
IC21
IC22
IC23
IC24
IC25
8-759-592-42
6-706-357-01
6-707-839-01
6-707-839-01
8-759-287-55
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ00FU(TE85R)
LTC1664IGN#TR
TC74LCX04FT(EKJ)
TC74LCX04FT(EKJ)
TC7S66FU(TE85R)
IC26
IC27
IC28
IC29
IC30
6-707-856-01
8-759-592-42
8-759-561-46
8-759-561-46
8-759-669-66
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX74FT(EKJ)
TC7SZ00FU(TE85R)
AD8014ARTZ-REEL7
AD8014ARTZ-REEL7
TLC272CPWR-12
IC31
IC32
IC33
IC34
IC35
8-759-669-66
8-759-669-66
8-759-669-66
8-759-669-66
8-759-669-66
s
s
s
s
s
IC
IC
IC
IC
IC
TLC272CPWR-12
TLC272CPWR-12
TLC272CPWR-12
TLC272CPWR-12
TLC272CPWR-12
IC36
IC37
IC38
IC39
IC40
8-759-669-66
8-759-669-41
8-759-663-35
8-759-663-35
8-759-523-04
s
s
s
s
s
IC
IC
IC
IC
IC
TLC272CPWR-12
SN74LVC125APWR-12
74VHC4053MTCX
74VHC4053MTCX
TC74HC4538AFT(EL)
IC41
IC42
IC43
IC44
IC45
8-759-523-04
8-759-669-41
8-759-592-42
6-706-489-01
6-706-478-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC74HC4538AFT(EL)
SN74LVC125APWR-12
TC7SZ00FU(TE85R)
TC7SH32FU(T5RSOYJF)
TC7SET08FU(T5RSOJF)
IC46
IC47
IC48
IC49
IC50
8-759-592-42
8-759-592-42
8-759-592-42
6-707-884-01
8-759-592-42
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ00FU(TE85R)
TC7SZ00FU(TE85R)
TC7SZ00FU(TE85R)
TC74VHCT04AFT(EKJ)
TC7SZ00FU(TE85R)
IC51
IC300
IC301
IC302
IC303
8-759-592-42
6-711-237-01
6-700-563-01
6-700-563-01
6-706-906-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ00FU(TE85R)
NJM2878F3-33 (TE2)
AK4552VT-E2
AK4552VT-E2
NJM2732RB1(TE2)
7-64
EMI
EMI
EMI
EMI
(SMD)
(SMD)
(SMD)
(SMD)
(1608)
(1608)
(1608)
(1608)
SP Description
IC304
IC305
IC306
IC307
IC308
6-706-906-01
6-706-906-01
6-706-906-01
6-706-906-01
8-759-356-17
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2732RB1(TE2)
NJM2732RB1(TE2)
NJM2732RB1(TE2)
NJM2732RB1(TE2)
NJM4556AM-A-TE2
IC309
IC400
IC401
IC402
IC403
6-711-237-01
6-701-111-01
8-759-675-54
8-759-675-54
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
NJM2878F3-33 (TE2)
AK4382AVT-E2
TC7W53FK(TE85R)
TC7W53FK(TE85R)
TC7W53FK(TE85R)
IC404
IC405
IC406
IC407
IC408
8-759-675-54
6-707-884-01
6-706-906-01
8-759-278-58
8-759-422-21
s
s
s
s
s
IC
IC
IC
IC
IC
TC7W53FK(TE85R)
TC74VHCT04AFT(EKJ)
NJM2732RB1(TE2)
NJM4558V-TE2
NJM4580V(TE2)
IC409
IC410
IC411
IC530
IC531
8-759-422-21
8-759-278-58
8-759-278-58
6-700-563-01
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
NJM4580V(TE2)
NJM4558V-TE2
NJM4558V-TE2
AK4552VT-E2
TC7W53FK(TE85R)
IC532
IC536
IC537
IC538
IC539
8-759-675-54
6-706-906-01
6-706-906-01
8-759-278-58
8-759-278-58
s
s
s
s
s
IC
IC
IC
IC
IC
TC7W53FK(TE85R)
NJM2732RB1(TE2)
NJM2732RB1(TE2)
NJM4558V-TE2
NJM4558V-TE2
IC540
IC541
IC542
IC543
IC544
8-759-278-58
8-759-422-21
8-759-422-21
8-759-356-17
8-759-356-17
s
s
s
s
s
IC
IC
IC
IC
IC
NJM4558V-TE2
NJM4580V(TE2)
NJM4580V(TE2)
NJM4556AM-A-TE2
NJM4556AM-A-TE2
IC545
IC546
IC730
IC801
IC802
8-759-663-35
8-759-663-35
6-707-884-01
6-710-018-01
6-702-879-01
s
s
s
s
s
IC
IC
IC
IC
IC
74VHC4053MTCX
74VHC4053MTCX
TC74VHCT04AFT(EKJ)
CAT24C02WI-GT3
R3112N281A-TR-FA
IC804
IC805
IC806
IC807
IC808
8-759-248-78
8-759-648-04
6-707-856-01
6-710-628-01
6-705-527-11
s
s
s
s
s
IC
IC
IC
IC
IC
MB88102PFV-G-BND-ER
RTC-4574JE
TC74LCX74FT(EKJ)
CY23EP05SXC-1HT
HD6417616SFV
IC809
IC810
IC811
IC812
IC813
6-707-856-01
6-707-845-01
8-759-669-68
6-707-621-01
6-707-621-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX74FT(EKJ)
TC74LCX138FT(EKJ)
SN74CBT3253PWR-12
S29AL016D70TFI020
S29AL016D70TFI020
IC814
IC815
IC816
IC817
IC818
6-705-721-01
6-705-721-01
6-707-845-01
6-707-947-01
6-707-947-01
s
s
s
s
s
IC
IC
IC
IC
IC
MT48LC8M16A2P-75-Y15WTR
TC74LCX138FT(EKJ)
MB85R256PFTN-G-BNDE1
IC819
IC820
IC821
IC822
IC823
8-759-584-32
6-706-484-01
6-706-484-01
6-707-850-01
6-707-850-01
s
s
s
s
s
IC
IC
IC
IC
IC
MB86189PFV-G-BND-ER-E1
TC7SH04FU(T5RSOYJF)
TC7SH04FU(T5RSOYJF)
TC74LCX245FT(EKJ)
TC74LCX245FT(EKJ)
IC824
IC825
IC826
IC828
6-707-850-01
6-706-487-01
6-706-487-01
8-759-592-47
s
s
s
s
IC
IC
IC
IC
TC74LCX245FT(EKJ)
TC7SH08FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
TC7SZ08FU(TE85R)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
IC830
IC831
IC832
IC833
IC834
8-759-592-44
8-759-592-44
8-759-592-47
6-706-906-01
6-706-488-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ04FU(TE85R)
TC7SZ04FU(TE85R)
TC7SZ08FU(TE85R)
NJM2732RB1(TE2)
TC7SH14FU(T5RSOYJF)
IC1502
IC1503
IC1504
IC1505
IC1506
6-706-136-01
8-759-592-44
6-706-220-01
8-759-592-44
6-712-135-01
s
s
s
s
o
IC
IC
IC
IC
IC
LTC3412EFE#TR
TC7SZ04FU(TE85R)
LTC3411EMS#TR
TC7SZ04FU(TE85R)
R1173H001D-T1-F
IC835
IC836
IC837
IC838
IC839
6-706-488-01
6-706-487-01
6-706-488-01
6-706-906-01
8-759-669-66
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SH14FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
TC7SH14FU(T5RSOYJF)
NJM2732RB1(TE2)
TLC272CPWR-12
IC1507
IC1508
IC1509
IC1510
IC1511
6-705-481-01
6-705-481-01
6-704-976-01
8-759-338-95
8-759-338-95
s
s
s
s
s
IC
IC
IC
IC
IC
LT1931ES5#TR
LT1931ES5#TR
ADR381ARTZ-REEL7
NJM2903V(TE2)
NJM2903V(TE2)
IC840
IC841
IC842
IC843
IC844
6-706-484-01
6-706-488-01
6-706-488-01
6-706-487-01
6-706-489-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SH04FU(T5RSOYJF)
TC7SH14FU(T5RSOYJF)
TC7SH14FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
TC7SH32FU(T5RSOYJF)
IC1512
IC1513
IC1514
IC1515
8-759-278-58
6-701-549-01
8-759-338-95
6-712-135-01
s
s
s
o
IC
IC
IC
IC
NJM4558V-TE2
LTC1778EGN
NJM2903V(TE2)
R1173H001D-T1-F
IC845
IC846
IC847
IC848
IC849
8-759-592-44
6-706-487-01
6-712-382-01
6-712-382-01
6-712-382-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SZ04FU(TE85R)
TC7SH08FU(T5RSOYJF)
TC74VHC4053AFT(EK)
TC74VHC4053AFT(EK)
TC74VHC4053AFT(EK)
JC730
JC731
JC732
JC733
JC734
1-216-864-91
1-216-864-91
1-216-864-91
1-216-864-91
1-216-864-91
s
s
s
s
s
CONDUCTOR,
CONDUCTOR,
CONDUCTOR,
CONDUCTOR,
CONDUCTOR,
IC851
IC852
IC853
IC854
IC855
6-706-487-01
6-706-487-01
8-759-594-17
6-702-691-01
6-706-484-01
s
s
o
s
s
IC
IC
IC
IC
IC
TC7SH08FU(T5RSOYJF)
TC7SH08FU(T5RSOYJF)
CXD9093R
BCM5221A4KPT
TC7SH04FU(T5RSOYJF)
JC736
JC738
1-216-864-91 s CONDUCTOR, CHIP (1608)

1-216-864-91 s CONDUCTOR, CHIP (1608)
IC856
IC857
IC858
IC859
IC860
6-706-484-01
6-712-922-01
6-702-879-01
8-759-592-49
8-759-592-49
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SH04FU(T5RSOYJF)
EPCS16SI8N
R3112N281A-TR-FA
TC7SZ125FU(TE85R)
TC7SZ125FU(TE85R)
L1
L2
L3
L4
L5
1-414-398-41
1-414-398-41
1-414-396-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
4.7UH
10.0UH
10.0UH
IC861
IC862
IC870
IC871
IC873
6-707-842-01
6-701-874-01
8-759-669-66
8-759-592-44
8-759-592-49
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX08FT(EKJ)
IDT71V016SA15PHG-TL
TLC272CPWR-12
TC7SZ04FU(TE85R)
TC7SZ125FU(TE85R)
L6
L7
L8
L9
L10
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC874
IC875
IC876
IC877
IC879
6-707-850-01
6-707-850-01
6-707-850-01
8-759-485-24
6-707-850-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX245FT(EKJ)
TC74LCX245FT(EKJ)
TC74LCX245FT(EKJ)
MC74HC4046ADTR2
TC74LCX245FT(EKJ)
L11
L12
L13
L14
L15
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC880
IC881
IC883
IC903
IC904
6-707-850-01
6-707-850-01
6-707-850-01
6-708-506-01
8-759-675-54
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX245FT(EKJ)
TC74LCX245FT(EKJ)
TC74LCX245FT(EKJ)
ML86V7666TBZ03A
TC7W53FK(TE85R)
L16
L17
L18
L19
L20
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC905
IC910
IC911
IC912
IC915
6-706-478-01
6-707-855-01
6-707-855-01
6-707-855-01
6-707-855-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC7SET08FU(T5RSOJF)
TC74LCX574FT(EKJ)
TC74LCX574FT(EKJ)
TC74LCX574FT(EKJ)
TC74LCX574FT(EKJ)
L21
L22
L23
L24
L25
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
IC916
IC917
IC918
IC919
IC920
6-707-855-01
6-707-855-01
8-759-592-42
8-759-592-42
6-713-495-01
s
s
s
s
s
IC
IC
IC
IC
IC
TC74LCX574FT(EKJ)
TC74LCX574FT(EKJ)
TC7SZ00FU(TE85R)
TC7SZ00FU(TE85R)
W9864G2GH-6-W-ER10
L26
L27
L28
L29
L30
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-392-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
1.0UH
IC921
IC922
IC1500
IC1501
6-713-495-01
6-712-135-01
8-759-278-58
6-701-549-01
s
o
s
s
IC
IC
IC
IC
W9864G2GH-6-W-ER10
R1173H001D-T1-F
NJM4558V-TE2
LTC1778EGN
L31
L32
L33
L34
L35
1-414-392-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
10.0UH
10.0UH
10.0UH
10.0UH
L36
L37
1-414-398-41 s INDUCTOR (SMD) 10.0UH

1-414-398-41 s INDUCTOR (SMD) 10.0UH
HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
(1608)
(1608)
(1608)
(1608)
(1608)
7-65
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
L38
L39
L40
L300
L301
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
Q4
Q5
Q6
Q7
Q8
8-729-928-05
8-729-142-11
8-729-928-25
8-729-928-05
8-729-142-11
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SA1226-T1E3E4
2SA1774TL-QR
2SC4617TL-QR
2SA1226-T1E3E4
L530
L531
L532
L533
L730
1-414-400-41
1-414-400-41
1-414-400-41
1-414-400-41
1-414-400-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
22.0UH
22.0UH
22.0UH
22.0UH
22.0UH
Q9
Q10
Q304
Q306
Q307
8-729-928-25
8-729-928-25
8-729-928-25
8-729-928-25
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1774TL-QR
2SA1774TL-QR
2SA1774TL-QR
2SA1774TL-QR
2SA1774TL-QR
L732
L733
L801
L802
L803
1-414-400-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
22.0UH
10.0UH
10.0UH
10.0UH
10.0UH
Q315
Q316
Q317
Q318
Q400
8-729-928-91
8-729-928-91
8-729-013-37
8-729-013-37
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EE-TL
DTC114EE-TL
2SC4213-AB-TE85L
2SC4213-AB-TE85L
2SA1774TL-QR
L805
L807
L808
L809
L810
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
Q401
Q402
Q403
Q404
Q405
8-729-928-25
8-729-928-25
8-729-928-91
8-729-928-91
8-729-013-37
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1774TL-QR
2SA1774TL-QR
DTC114EE-TL
DTC114EE-TL
2SC4213-AB-TE85L
L811
L812
L814
L820
L821
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
Q406
Q407
Q408
Q530
Q531
8-729-013-37
8-729-013-37
8-729-013-37
8-729-013-37
8-729-013-37
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4213-AB-TE85L
2SC4213-AB-TE85L
2SC4213-AB-TE85L
2SC4213-AB-TE85L
2SC4213-AB-TE85L
L822
L823
L830
L831
L904
1-414-392-41
1-414-392-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
1.0UH
1.0UH
10.0UH
10.0UH
10.0UH
Q532
Q533
Q534
Q535
Q536
8-729-013-37
8-729-013-37
8-729-928-25
8-729-928-05
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4213-AB-TE85L
2SC4213-AB-TE85L
2SA1774TL-QR
2SC4617TL-QR
2SA1774TL-QR
L905
L908
L909
L910
L911
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
Q537
Q538
Q539
Q540
Q541
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-25
8-729-928-05
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SA1774TL-QR
2SC4617TL-QR
L920
L921
L922
L1500
L1501
1-414-398-41
1-414-398-41
1-414-398-41
1-419-630-21
1-457-372-21
s
s
s
s
s

COIL, CHOKE 4.7UH
COIL, CHOKE 1UH
Q542
Q543
Q544
Q545
Q546
8-729-928-25
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-25
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1774TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SA1774TL-QR
L1502
L1503
L1504
L1505
L1506
1-419-491-21
1-416-344-21
1-416-344-21
1-416-344-21
1-416-344-21
s
s
s
s
s
COIL,
COIL,
COIL,
COIL,
COIL,
Q547
Q548
Q730
Q731
Q732
8-729-928-25
8-729-928-25
8-729-928-05
8-729-928-05
8-729-928-05
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1774TL-QR
2SA1774TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
L1507
L1508
L1509
L1510
L1511
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
1-414-398-41
s
s
s
s
s
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
Q733
Q734
Q735
Q736
Q737
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-05
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
L1512
L1513
L1516
1-416-344-21 s COIL, CHOKE 10UH

1-416-344-21 s COIL, CHOKE 10UH
1-419-491-21 s COIL, CHOKE 10UH
PH730
PH731
8-749-011-37 s PHOTO COUPLER TLP181(BL-TPR)

8-749-011-37 s PHOTO COUPLER TLP181(BL-TPR)
Q738
Q739
Q740
Q741
Q742
8-729-928-05
8-729-141-76
8-729-141-76
8-729-141-76
8-729-141-76
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SD596T1-DV345
2SD596T1-DV345
2SD596T1-DV345
2SD596T1-DV345
Q1
Q2
Q3

8-729-928-25 s TRANSISTOR 2SA1774TL-QR
Q743
Q801
Q802
Q803
8-729-928-05
8-729-928-05
8-729-928-05
8-729-928-05
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
2SC4617TL-QR
7-66
CHOKE
CHOKE
CHOKE
CHOKE
CHOKE
10UH
10UH
10UH
10UH
10UH
(SMD)
(SMD)
(SMD)
(SMD)
(SMD)
10.0UH
10.0UH
10.0UH
10.0UH
10.0UH
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
Q804
Q805
Q810
Q811
Q812
6-550-631-01
8-729-928-05
8-729-928-05
8-729-928-91
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1797-T100-Q
2SC4617TL-QR
2SC4617TL-QR
DTC114EE-TL
DTC114EE-TL
R33
R34
R35
R36
R37
1-208-863-81
1-208-895-81
1-220-870-81
1-220-870-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
2.2K (1005)
10 (1005)
10 (1005)
2.2K (1005)
Q813
Q814
Q815
Q816
Q817
8-729-928-91
8-729-928-91
8-729-928-91
8-729-928-91
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
DTC114EE-TL
R39
R40
R41
R42
R43
1-220-870-81
1-208-863-81
1-208-875-81
1-208-855-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
100 (1005)
330 (1005)
47 (1005)
220 (1005)
Q818
Q819
Q820
Q821
Q908
8-729-928-91
8-729-928-91
8-729-928-05
8-729-928-05
8-729-403-30
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EE-TL
DTC114EE-TL
2SC4617TL-QR
2SC4617TL-QR
XN6435-TX
R45
R46
R47
R48
R49
1-220-870-81
1-208-863-81
1-208-863-81
1-208-903-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
100 (1005)
100 (1005)
4.7K (1005)
10 (1005)
Q909
Q910
Q1500
Q1501
Q1503
8-729-403-30
8-729-403-33
8-729-054-35
8-729-054-35
6-550-631-01
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
XN6435-TX
XN6534-TX
HAT2070R-EL
HAT2070R-EL
2SA1797-T100-Q
R50
R51
R52
R53
R54
1-208-863-81
1-208-899-81
1-208-863-81
1-208-879-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
3.3K (1005)
100 (1005)
470 (1005)
4.7K (1005)
Q1504
Q1505
Q1506
Q1508
Q1509
6-550-632-01
6-550-631-01
6-550-632-01
8-729-928-05
8-729-928-91
s
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4672-T100-Q
2SA1797-T100-Q
2SC4672-T100-Q
2SC4617TL-QR
DTC114EE-TL
R55
R56
R57
R58
R59
1-208-863-81
1-208-879-81
1-208-911-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
470 (1005)
10K (1005)
4.7K (1005)
10K (1005)
Q1510
Q1511
Q1512
Q1513
8-729-054-35
8-729-054-35
8-729-928-05
8-729-928-05
s
s
s
s
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
HAT2070R-EL
HAT2070R-EL
2SC4617TL-QR
2SC4617TL-QR
R1
R2
R3
R4
R5
1-208-863-81
1-208-863-81
1-208-883-81
1-208-875-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
680 (1005)
330 (1005)
1.0K (1005)
R60
R61
R62
R63
R64
1-208-919-81
1-208-863-81
1-208-903-81
1-208-911-81
1-208-879-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
100 (1005)
4.7K (1005)
10K (1005)
470 (1005)
R6
R7
R8
R9
R10
1-208-863-81
1-208-863-81
1-208-879-81
1-208-863-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
470 (1005)
100 (1005)
1.5K (1005)
R65
R66
R67
R68
R69
1-208-879-81
1-208-895-81
1-208-911-81
1-208-919-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
2.2K (1005)
10K (1005)
22K (1005)
15K (1005)
R12
R13
R14
R15
R16
1-208-903-81
1-208-927-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
47K (1005)
100 (1005)
100 (1005)
100 (1005)
R70
R71
R72
R73
R74
1-208-955-81
1-208-919-81
1-208-947-81
1-208-855-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680K (1005)
22K (1005)
330K (1005)
47 (1005)
100 (1005)
R17
R18
R19
R20
R21
1-208-863-81
1-208-895-81
1-208-887-81
1-208-919-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
2.2K (1005)
1.0K (1005)
22K (1005)
47 (1005)
R75
R76
R77
R78
R80
1-208-855-81
1-208-899-81
1-208-863-81
1-208-907-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
3.3K (1005)
100 (1005)
6.8K (1005)
100 (1005)
R22
R23
R24
R25
R26
1-208-855-81
1-208-871-81
1-208-863-81
1-208-863-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
220 (1005)
100 (1005)
100 (1005)
2.2K (1005)
R81
R82
R83
R84
R85
1-208-911-81
1-208-863-81
1-208-903-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
4.7K (1005)
100 (1005)
100 (1005)
R27
R28
R29
R30
R31
1-208-895-81
1-208-915-81
1-208-887-81
1-220-870-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
15K (1005)
1.0K (1005)
10 (1005)
47 (1005)
R86
R88
R89
R90
R91
1-208-895-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
100 (1005)
100 (1005)
100 (1005)
100 (1005)
R92
R93
R94
R95
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100
100
100
100
HSCU-300
(1005)
(1005)
(1005)
(1005)
7-67
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R96
R97
R98
R99
R100
1-208-903-81
1-208-863-81
1-208-895-81
1-208-903-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
100 (1005)
2.2K (1005)
4.7K (1005)
2.2K (1005)
R158
R159
R160
R161
R162
1-208-863-81
1-208-863-81
1-220-870-81
1-220-870-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
10 (1005)
10 (1005)
100 (1005)
R101
R102
R103
R104
R105
1-208-855-81
1-208-887-81
1-220-870-81
1-208-863-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
1.0K (1005)
10 (1005)
100 (1005)
4.7K (1005)
R163
R164
R165
R166
R167
1-208-863-81
1-208-863-81
1-208-903-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
4.7K (1005)
4.7K (1005)
10K (1005)
R106
R107
R108
R109
R110
1-208-855-81
1-208-919-81
1-208-911-81
1-208-895-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
22K (1005)
10K (1005)
2.2K (1005)
3.3K (1005)
R168
R169
R170
R171
R172
1-208-911-81
1-208-911-81
1-208-895-81
1-220-870-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
2.2K (1005)
10 (1005)
2.2K (1005)
R111
R112
R114
R115
R116
1-208-919-81
1-208-903-81
1-208-895-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
4.7K (1005)
2.2K (1005)
10K (1005)
22K (1005)
R173
R174
R175
R176
R177
1-208-895-81
1-208-863-81
1-208-923-81
1-220-870-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
100 (1005)
33K (1005)
10 (1005)
2.2K (1005)
R117
R118
R119
R120
R121
1-208-915-81
1-208-955-81
1-208-919-81
1-208-947-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
680K (1005)
22K (1005)
330K (1005)
22K (1005)
R178
R179
R180
R181
R182
1-220-870-81
1-220-870-81
1-208-927-81
1-208-927-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
47K (1005)
47K (1005)
1.0K (1005)
R122
R123
R124
R125
R126
1-208-855-81
1-208-855-81
1-208-863-81
1-208-863-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
100 (1005)
100 (1005)
2.2K (1005)
R183
R184
R185
R186
R187
1-208-903-81
1-208-911-81
1-208-911-81
1-208-903-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
10K (1005)
10K (1005)
4.7K (1005)
100K (1005)
R127
R128
R129
R130
R131
1-208-903-81
1-208-899-81
1-208-907-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
3.3K (1005)
6.8K (1005)
10K (1005)
100 (1005)
R188
R189
R190
R191
R192
1-244-161-81
1-208-911-81
1-208-903-81
1-208-935-81
1-244-161-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2 (1005)
10K (1005)
4.7K (1005)
100K (1005)
2.2 (1005)
R132
R133
R134
R135
R136
1-208-927-81
1-208-927-81
1-208-911-81
1-208-863-81
1-208-955-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
47K (1005)
10K (1005)
100 (1005)
680K (1005)
R193
R194
R195
R196
R197
1-208-863-81
1-208-863-81
1-208-923-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
33K
47K
10K
R137
R138
R139
R140
R141
1-208-951-81
1-208-887-81
1-208-939-81
1-208-935-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470K
1.0K
150K
100K
4.7K
(1005)
(1005)
(1005)
(1005)
(1005)
R198
R199
R200
R201
R202
1-208-935-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100 (1005)
100 (1005)
100 (1005)
100 (1005)
R142
R143
R144
R145
R148
1-208-903-81
1-208-911-81
1-208-911-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
10K (1005)
10K (1005)
1.0K (1005)
100 (1005)
R203
R204
R205
R206
R207
1-208-911-81
1-208-911-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
47K
47K
47K
R149
R150
R151
R152
R153
1-208-863-81
1-208-911-81
1-208-919-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
10K (1005)
22K (1005)
10 (1005)
10 (1005)
R208
R209
R210
R211
R212
1-208-855-81
1-208-911-81
1-208-863-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
10K (1005)
100 (1005)
10K (1005)
100 (1005)
R154
R155
R156
R157
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100
100
100
100
R213
R214
R215
R216
1-208-863-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100 (1005)
10 (1005)
10 (1005)
10 (1005)
7-68
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R217
R218
R219
R220
R221
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10
10
10
10
10
(1005)
(1005)
(1005)
(1005)
(1005)
R343
R344
R345
R346
R347
1-208-863-81
1-208-919-81
1-208-863-81
1-208-919-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
22K (1005)
100 (1005)
22K (1005)
3.3K (1005)
R222
R223
R224
R225
R226
1-208-891-81
1-208-891-81
1-208-891-81
1-220-870-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
1.5K (1005)
1.5K (1005)
10 (1005)
100 (1005)
R348
R349
R350
R351
R352
1-208-887-81
1-208-887-81
1-208-915-81
1-208-919-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
15K (1005)
22K (1005)
100 (1005)
R227
R228
R230
R231
R234
1-208-863-81
1-208-895-81
1-208-871-81
1-208-863-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
2.2K (1005)
220 (1005)
100 (1005)
220 (1005)
R353
R354
R355
R356
R357
1-208-863-81
1-208-915-81
1-220-878-81
1-208-943-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
15K (1005)
22 (1005)
220K (1005)
22K (1005)
R235
R236
R237
R238
R239
1-208-855-81
1-220-870-81
1-208-911-81
1-208-915-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
10 (1005)
10K (1005)
15K (1005)
1.0K (1005)
R358
R360
R361
R362
R363
1-208-943-81
1-208-927-81
1-208-915-81
1-208-895-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220K (1005)
47K (1005)
15K (1005)
2.2K (1005)
15K (1005)
R240
R243
R245
R246
R247
1-208-887-81
1-208-875-81
1-220-870-81
1-220-870-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
330 (1005)
10 (1005)
10 (1005)
10K (1005)
R364
R366
R368
R370
R371
1-208-907-81
1-220-242-91
1-220-242-91
1-208-915-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP 6.8K (1005)

SQUARE TYPE CHIP 22(3225)
SQUARE TYPE CHIP 22(3225)
CHIP 15K (1005)
CHIP 15K (1005)
R301
R303
R304
R308
R310
1-208-919-81
1-208-919-81
1-208-927-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
47K
10K
10K
R373
R374
R379
R380
R381
1-208-883-81
1-208-883-81
1-208-935-81
1-208-935-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
680 (1005)
100K (1005)
100K (1005)
100K (1005)
R311
R312
R314
R315
R316
1-208-959-81
1-208-919-81
1-208-919-81
1-208-935-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
22K (1005)
22K (1005)
100K (1005)
100K (1005)
R382
R383
R384
R385
R386
1-208-935-81
1-208-919-81
1-208-935-81
1-208-935-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
22K (1005)
100K (1005)
100K (1005)
10 (1005)
R317
R318
R319
R320
R321
1-208-903-81
1-220-870-81
1-220-870-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
10 (1005)
10 (1005)
100 (1005)
100 (1005)
R387
R388
R389
R390
R391
1-208-903-81
1-208-903-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
4.7K (1005)
10K (1005)
10K (1005)
22K (1005)
R322
R323
R324
R327
R328
1-208-903-81
1-218-990-81
1-218-990-81
1-208-919-81
1-208-863-81
s
s
s
s
s
RES, CHIP 4.7K (1005)

RES, CHIP 100 (1005)
R392
R393
R400
R401
R402
1-208-883-81
1-208-883-81
1-208-911-81
1-208-911-81
1-208-959-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
680 (1005)
680 (1005)
10K (1005)
10K (1005)
1M (1005)
R329
R330
R331
R332
R333
1-218-990-81
1-218-990-81
1-220-870-81
1-220-870-81
1-208-935-81
s
s
s
s
s

RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
RES, CHIP 100K (1005)
R403
R404
R405
R406
R407
1-208-919-81
1-208-919-81
1-208-903-81
1-218-990-81
1-208-863-81
s
s
s
s
s

RES, CHIP 4.7K (1005)
RES, CHIP 100 (1005)
R334
R335
R336
R337
R338
1-208-919-81
1-208-919-81
1-208-935-81
1-208-935-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
22K (1005)
100K (1005)
100K (1005)
10 (1005)
R408
R409
R410
R411
R412
1-208-863-81
1-220-870-81
1-220-870-81
1-208-899-81
1-208-899-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
10 (1005)
10 (1005)
3.3K (1005)
3.3K (1005)
R339
R340
R341
R342
1-208-915-81
1-208-915-81
1-208-915-81
1-208-915-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
15K
15K
15K
15K
R413
R414
R415
R416
1-208-899-81
1-208-899-81
1-208-899-81
1-208-899-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
3.3K
3.3K
3.3K
3.3K
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-69
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R417
R418
R419
R420
R421
1-208-891-81
1-208-891-81
1-208-891-81
1-208-891-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
1.5K (1005)
1.5K (1005)
1.5K (1005)
10 (1005)
R478
R479
R480
R481
R482
1-208-927-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
47K
47K
10K
R422
R423
R424
R425
R426
1-208-899-81
1-208-899-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
3.3K (1005)
3.3K (1005)
10K (1005)
10K (1005)
10K (1005)
R483
R484
R485
R486
R487
1-208-911-81
1-208-895-81
1-208-895-81
1-208-895-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
2.2K (1005)
2.2K (1005)
2.2K (1005)
2.2K (1005)
R427
R428
R429
R430
R431
1-208-911-81
1-208-935-81
1-208-935-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100K (1005)
100K (1005)
47K (1005)
47K (1005)
R488
R489
R490
R491
R492
1-216-813-91
1-216-813-91
1-216-813-91
1-216-813-91
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
220
220
10K
(1608)
(1608)
(1608)
(1608)
(1005)
R432
R433
R434
R435
R436
1-208-887-81
1-208-935-81
1-208-887-81
1-208-935-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100K (1005)
1.0K (1005)
100K (1005)
10K (1005)
R493
R494
R495
R496
R497
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R437
R438
R439
R440
R441
1-208-911-81
1-208-863-81
1-208-863-81
1-208-891-81
1-208-879-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
100 (1005)
1.5K (1005)
470 (1005)
R502
R503
R504
R505
R510
1-216-813-91
1-216-813-91
1-216-813-91
1-216-813-91
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1608)
220 (1608)
220 (1608)
220 (1608)
100K (1005)
R442
R443
R445
R447
R448
1-208-891-81
1-208-879-81
1-208-911-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
470 (1005)
10K (1005)
10K (1005)
100 (1005)
R511
R512
R513
R514
R515
1-208-935-81
1-220-870-81
1-220-870-81
1-208-935-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
10 (1005)
10 (1005)
100K (1005)
100K (1005)
R449
R450
R451
R452
R453
1-208-863-81
1-208-919-81
1-208-919-81
1-208-923-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
22K
22K
33K
33K
R530
R531
R532
R533
R534
1-220-870-81
1-220-870-81
1-208-863-81
1-208-863-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
100 (1005)
100 (1005)
15K (1005)
R454
R455
R456
R457
R458
1-208-927-81
1-208-927-81
1-208-875-81
1-208-891-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
47K (1005)
330 (1005)
1.5K (1005)
330 (1005)
R535
R536
R537
R538
R540
1-208-915-81
1-208-915-81
1-208-915-81
1-218-990-81
1-208-935-81
s
s
s
s
s

RES, CHIP 100K (1005)
R459
R460
R461
R462
R463
1-208-891-81
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.5K (1005)
10 (1005)
10 (1005)
10 (1005)
10 (1005)
R541
R542
R543
R544
R545
1-208-935-81
1-218-990-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES, CHIP 100K (1005)

RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
RES, CHIP 10 (1005)
R464
R465
R466
R467
R468
1-208-911-81
1-208-911-81
1-208-879-81
1-208-879-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
470
470
22K
(1005)
(1005)
(1005)
(1005)
(1005)
R546
R547
R548
R549
R550
1-220-870-81
1-208-911-81
1-208-919-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10K (1005)
22K (1005)
10K (1005)
22K (1005)
R469
R470
R471
R472
R473
1-208-919-81
1-208-863-81
1-208-863-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
100
100
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R551
R552
R553
R554
R555
1-208-927-81
1-208-927-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
100
100
100
R474
R475
R476
R477
1-208-919-81
1-208-919-81
1-208-911-81
1-208-911-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
22K
22K
10K
10K
(1005)
(1005)
(1005)
(1005)
R556
R557
R558
R559
1-208-863-81
1-208-911-81
1-208-911-81
1-208-935-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100 (1005)
10K (1005)
10K (1005)
100K (1005)
7-70
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R560
R561
R562
R563
R564
1-208-887-81
1-208-935-81
1-208-887-81
1-208-915-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100K (1005)
1.0K (1005)
15K (1005)
100 (1005)
R619
R620
R621
R622
R623
1-208-923-81
1-208-911-81
1-208-919-81
1-208-923-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33K
10K
22K
33K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R565
R566
R567
R568
R569
1-208-863-81
1-208-915-81
1-208-911-81
1-208-911-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
15K
10K
10K
15K
(1005)
(1005)
(1005)
(1005)
(1005)
R624
R625
R626
R627
R628
1-208-919-81
1-208-927-81
1-208-927-81
1-216-813-91
1-216-813-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
47K
220
220
(1005)
(1005)
(1005)
(1608)
(1608)
R570
R571
R572
R573
R574
1-208-915-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K
10K
10K
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R629
R630
R631
R632
R633
1-216-813-91
1-216-813-91
1-216-813-91
1-216-813-91
1-216-813-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
220
220
220
(1608)
(1608)
(1608)
(1608)
(1608)
R575
R576
R577
R578
R579
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-935-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10K (1005)
100K (1005)
R634
R635
R636
R637
R638
1-216-813-91
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
10K
10K
10K
10K
(1608)
(1005)
(1005)
(1005)
(1005)
R580
R581
R582
R583
R584
1-208-935-81
1-208-935-81
1-208-935-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100K (1005)
100K (1005)
10K (1005)
10K (1005)
R639
R640
R641
R642
R643
1-208-927-81
1-208-911-81
1-208-911-81
1-208-927-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
10K
10K
47K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R585
R586
R587
R588
R589
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-891-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10K (1005)
1.5K (1005)
R644
R645
R646
R655
R656
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R590
R591
R592
R593
R594
1-208-903-81
1-208-935-81
1-208-891-81
1-208-935-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K
100K
1.5K
100K
4.7K
R657
R658
R659
R660
R661
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R595
R596
R597
R598
R599
1-208-927-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
47K
47K
47K
(1005)
(1005)
(1005)
(1005)
(1005)
R662
R663
R664
R665
R666
1-208-911-81
1-208-911-81
1-208-911-81
1-211-969-91
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10 (1608)
10K (1005)
R600
R601
R602
R603
R604
1-208-927-81
1-208-911-81
1-208-911-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
10K
10K
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R667
R668
R669
R670
R671
1-211-969-91
1-208-911-81
1-211-969-91
1-208-911-81
1-211-969-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1608)
10K (1005)
10 (1608)
10K (1005)
10 (1608)
R605
R606
R607
R608
R609
1-208-927-81
1-208-927-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
10K
10K
22K
(1005)
(1005)
(1005)
(1005)
(1005)
R672
R673
R674
R675
R676
1-208-911-81
1-208-935-81
1-208-935-81
1-208-903-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100K (1005)
100K (1005)
4.7K (1005)
4.7K (1005)
R610
R611
R612
R613
R614
1-208-919-81
1-208-919-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
22K
10K
10K
22K
(1005)
(1005)
(1005)
(1005)
(1005)
R677
R678
R679
R680
R681
1-208-903-81
1-208-903-81
1-208-935-81
1-208-935-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
4.7K (1005)
100K (1005)
100K (1005)
10K (1005)
R615
R616
R617
R618
1-208-919-81
1-208-919-81
1-208-863-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
22K
22K
100
100
(1005)
(1005)
(1005)
(1005)
R682
R683
R684
R685
1-208-911-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
22K
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-71
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R686
R687
R688
R689
R690
1-208-919-81
1-208-903-81
1-208-903-81
1-208-903-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
4.7K (1005)
4.7K (1005)
4.7K (1005)
4.7K (1005)
R746
R747
R748
R749
R750
1-208-895-81
1-208-927-81
1-208-915-81
1-208-915-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
47K (1005)
15K (1005)
15K (1005)
15K (1005)
R691
R692
R693
R694
R695
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
22K
(1005)
(1005)
(1005)
(1005)
(1005)
R751
R752
R753
R754
R755
1-208-887-81
1-208-887-81
1-208-887-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
1.0K (1005)
47K (1005)
47K (1005)
R696
R697
R698
R699
R700
1-208-919-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
47K
47K
47K
(1005)
(1005)
(1005)
(1005)
(1005)
R756
R757
R758
R759
R760
1-208-927-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
10K (1005)
10K (1005)
10K (1005)
4.7K (1005)
R701
R702
R703
R704
R705
1-208-903-81
1-208-919-81
1-208-919-81
1-208-959-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
4.7K (1005)
22K (1005)
22K (1005)
1M (1005)
10K (1005)
R761
R762
R763
R764
R765
1-208-911-81
1-208-903-81
1-208-911-81
1-208-903-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
4.7K (1005)
10K (1005)
4.7K (1005)
10K (1005)
R706
R707
R708
R709
R710
1-208-911-81
1-208-923-81
1-208-923-81
1-208-919-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
33K
33K
22K
22K
R766
R767
R768
R769
R770
1-208-855-81
1-208-855-81
1-208-923-81
1-208-923-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
33K (1005)
33K (1005)
1.0K (1005)
R711
R712
R713
R714
R715
1-208-919-81
1-208-919-81
1-208-935-81
1-208-935-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
22K (1005)
100K (1005)
100K (1005)
100 (1005)
R771
R772
R773
R774
R775
1-208-887-81
1-208-903-81
1-208-923-81
1-208-923-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
4.7K (1005)
33K (1005)
33K (1005)
10K (1005)
R716
R717
R718
R719
R720
1-208-911-81
1-208-911-81
1-208-863-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
100
47K
47K
R776
R777
R778
R779
R780
1-208-887-81
1-208-887-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
100 (1005)
100 (1005)
R721
R722
R723
R724
R725
1-208-943-81
1-208-943-81
1-208-943-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220K (1005)
220K (1005)
220K (1005)
47K (1005)
47K (1005)
R801
R802
R803
R804
R805
1-220-870-81
1-208-911-81
1-208-887-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10K (1005)
1.0K (1005)
47K (1005)
47K (1005)
R726
R727
R728
R730
R731
1-208-943-81
1-208-943-81
1-208-943-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220K
220K
220K
1.0K
1.0K
(1005)
(1005)
(1005)
(1005)
(1005)
R806
R807
R808
R809
R810
1-208-935-81
1-208-863-81
1-208-935-81
1-208-935-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100 (1005)
100K (1005)
100K (1005)
100 (1005)
R732
R733
R734
R735
R736
1-208-887-81
1-208-927-81
1-208-927-81
1-208-927-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
47K (1005)
47K (1005)
47K (1005)
15K (1005)
R811
R812
R813
R814
R815
1-208-863-81
1-208-863-81
1-208-863-81
1-208-919-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
100 (1005)
100 (1005)
22K (1005)
1.0K (1005)
R737
R738
R739
R740
R741
1-208-915-81
1-208-915-81
1-208-887-81
1-208-895-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
15K (1005)
15K (1005)
1.0K (1005)
2.2K (1005)
47K (1005)
R816
R817
R818
R819
R820
1-208-887-81
1-208-887-81
1-208-863-81
1-208-863-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
100 (1005)
10K (1005)
R742
R743
R744
R745
1-208-887-81
1-208-895-81
1-208-927-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
2.2K (1005)
47K (1005)
1.0K (1005)
R821
R822
R825
R826
1-208-911-81
1-208-911-81
1-208-887-81
1-208-887-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
1.0K (1005)
1.0K (1005)
7-72
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R827
R829
R830
R831
R832
1-208-935-81
1-208-855-81
1-208-855-81
1-208-911-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
47 (1005)
47 (1005)
10K (1005)
47 (1005)
R899
R900
R901
R902
R903
1-220-878-81
1-220-878-81
1-220-878-81
1-220-878-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22
22
22
22
22
R833
R834
R835
R836
R837
1-208-855-81
1-208-855-81
1-208-855-81
1-208-855-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
47 (1005)
47 (1005)
10K (1005)
R904
R905
R906
R907
R909
1-208-935-81
1-208-935-81
1-208-935-81
1-208-935-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100K (1005)
100K (1005)
100K (1005)
47K (1005)
R838
R839
R840
R841
R842
1-220-870-81
1-220-870-81
1-208-911-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
10K (1005)
100 (1005)
100 (1005)
R910
R911
R912
R913
R914
1-208-919-81
1-208-927-81
1-208-927-81
1-208-919-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
47K
47K
22K
10K
R843
R844
R846
R847
R848
1-208-863-81
1-208-927-81
1-208-863-81
1-208-935-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
47K (1005)
100 (1005)
100K (1005)
10K (1005)
R915
R916
R917
R918
R919
1-208-899-81
1-208-895-81
1-208-863-81
1-208-855-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
3.3K (1005)
2.2K (1005)
100 (1005)
47 (1005)
100 (1005)
R850
R851
R852
R853
R857
1-208-911-81
1-208-863-81
1-220-878-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
22 (1005)
10K (1005)
10K (1005)
R920
R921
R922
R923
R924
1-208-887-81
1-208-935-81
1-208-919-81
1-208-935-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100K (1005)
22K (1005)
100K (1005)
47K (1005)
R859
R860
R861
R862
R863
1-220-878-81
1-220-878-81
1-208-911-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22 (1005)
22 (1005)
10K (1005)
10K (1005)
100 (1005)
R928
R932
R933
R934
R935
1-220-870-81
1-208-855-81
1-208-895-81
1-208-895-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
47 (1005)
2.2K (1005)
2.2K (1005)
47 (1005)
R864
R865
R866
R867
R868
1-208-935-81
1-208-935-81
1-208-863-81
1-208-871-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
100K (1005)
100 (1005)
220 (1005)
10K (1005)
R936
R937
R938
R939
R940
1-208-855-81
1-220-870-81
1-220-870-81
1-208-855-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47
10
10
47
10
R869
R870
R871
R872
R873
1-208-911-81
1-208-911-81
1-208-927-81
1-208-895-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
47K (1005)
2.2K (1005)
100 (1005)
R941
R942
R943
R951
R952
1-208-855-81
1-208-855-81
1-208-935-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
100K (1005)
1.0K (1005)
100 (1005)
R875
R876
R877
R878
R879
1-208-863-81
1-208-911-81
1-208-935-81
1-208-911-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
10K (1005)
100K (1005)
10K (1005)
10 (1005)
R953
R954
R955
R956
R957
1-208-927-81
1-208-863-81
1-208-911-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
100 (1005)
10K (1005)
1.0K (1005)
1.0K (1005)
R880
R881
R882
R883
R884
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
10K
10K
R958
R959
R960
R961
R962
1-208-911-81
1-208-907-81
1-208-907-81
1-220-870-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
6.8K (1005)
6.8K (1005)
10 (1005)
2.2K (1005)
R885
R886
R891
R892
R893
1-208-911-81
1-208-935-81
1-208-911-81
1-208-911-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100K (1005)
10K (1005)
10K (1005)
10 (1005)
R963
R964
R965
R966
R967
1-208-911-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
R895
R896
R897
R898
1-208-935-81
1-208-911-81
1-208-887-81
1-220-878-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
100K (1005)
10K (1005)
1.0K (1005)
22 (1005)
R968
R969
R970
R971
1-208-911-81
1-208-911-81
1-208-911-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
10 (1005)
HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-73
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1071
R1072
R1073
R1074
R1075
1-208-887-81
1-208-887-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
100 (1005)
100 (1005)

RES, CHIP 33 (1005)
RES, CHIP 33 (1005)
RES, CHIP 100 (1005)
RES, CHIP 1.5K (1005)
R1076
R1077
R1079
R1080
R1081
1-208-887-81
1-208-911-81
1-220-870-81
1-208-887-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
10 (1005)
1.0K (1005)
10K (1005)
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
4.7K (1005)
100 (1005)
100 (1005)
100 (1005)
R1082
R1083
R1084
R1085
R1086
1-208-863-81
1-208-887-81
1-208-887-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
1.0K (1005)
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100
100
100
100
10K
(1005)
(1005)
(1005)
(1005)
(1005)
R1087
R1088
R1089
R1090
R1092
1-208-887-81
1-208-887-81
1-208-927-81
1-208-927-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
47K (1005)
47K (1005)
1.0K (1005)
R1003
R1004
R1005
R1006
R1007
1-208-927-81
1-208-863-81
1-208-863-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
100
100
10K
100
(1005)
(1005)
(1005)
(1005)
(1005)
R1093
R1094
R1095
R1096
R1097
1-208-887-81
1-208-911-81
1-208-903-81
1-208-903-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
10K (1005)
4.7K (1005)
4.7K (1005)
100 (1005)
R1008
R1009
R1010
R1011
R1012
1-208-855-81
1-208-911-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
10K (1005)
10K (1005)
10K (1005)
10K (1005)
R1098
R1099
R1100
R1101
R1102
1-208-887-81
1-208-863-81
1-208-887-81
1-208-923-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
100 (1005)
1.0K (1005)
33K (1005)
22K (1005)
R1013
R1014
R1015
R1017
R1020
1-208-911-81
1-208-911-81
1-208-911-81
1-208-855-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
47 (1005)
47 (1005)
R1103
R1104
R1105
R1106
R1107
1-208-919-81
1-220-870-81
1-220-870-81
1-208-927-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
10 (1005)
10 (1005)
47K (1005)
100 (1005)
R1021
R1023
R1024
R1050
R1051
1-208-855-81
1-208-863-81
1-208-935-81
1-208-887-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
100 (1005)
100K (1005)
1.0K (1005)
1.0K (1005)
R1109
R1111
R1112
R1113
R1114
1-218-990-81
1-218-990-81
1-208-863-81
1-220-870-81
1-208-895-81
s
s
s
s
s

RES, CHIP 100 (1005)
RES, CHIP 10 (1005)
RES, CHIP 2.2K (1005)
R1052
R1053
R1054
R1055
R1056
1-208-887-81
1-208-887-81
1-208-863-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
1.0K (1005)
100 (1005)
R1115
R1117
R1118
R1119
R1120
1-208-959-81
1-220-870-81
1-208-895-81
1-208-911-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1M (1005)
10 (1005)
2.2K (1005)
10K (1005)
100 (1005)
R1057
R1058
R1059
R1060
R1061
1-208-911-81
1-208-887-81
1-208-887-81
1-208-927-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
1.0K (1005)
1.0K (1005)
47K (1005)
100 (1005)
R1122
R1123
R1124
R1125
R1126
1-208-855-81
1-208-855-81
1-208-871-81
1-208-871-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
47 (1005)
220 (1005)
220 (1005)
100 (1005)
R1062
R1063
R1064
R1065
R1066
1-208-927-81
1-208-863-81
1-208-927-81
1-208-911-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
100 (1005)
47K (1005)
10K (1005)
4.7K (1005)
R1130
R1131
R1132
R1133
R1134
1-208-911-81
1-208-863-81
1-208-863-81
1-208-863-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
100
100
100
100
(1005)
(1005)
(1005)
(1005)
(1005)
R1067
R1068
R1069
R1070
1-208-927-81
1-208-911-81
1-208-863-81
1-208-911-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47K
10K
100
10K
R1135
R1136
R1137
R1138
1-208-927-81
1-208-919-81
1-208-863-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
47K
22K
100
100
(1005)
(1005)
(1005)
(1005)
R972
R973
R974
R975
R976
1-208-887-81
1-220-878-81
1-208-903-81
1-208-887-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R977
R978
R979
R980
R981
1-218-990-81
1-220-882-81
1-220-882-81
1-208-863-81
1-208-891-81
s
s
s
s
s
R982
R983
R984
R985
R986
1-208-863-81
1-208-903-81
1-208-863-81
1-208-863-81
1-208-863-81
R987
R988
R989
R1001
R1002
7-74
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
22 (1005)
4.7K (1005)
1.0K (1005)
220 (1005)
(1005)
(1005)
(1005)
(1005)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1240
R1241
R1242
R1244
R1245
1-218-990-81
1-220-870-81
1-220-878-81
1-208-863-81
1-208-863-81
s
s
s
s
s

RES, CHIP 10 (1005)
RES, CHIP 22 (1005)
RES, CHIP 100 (1005)
RES, CHIP 100 (1005)

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
R1246
R1249
R1250
R1253
R1254
1-208-863-81
1-208-907-81
1-208-907-81
1-208-855-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
100 (1005)
6.8K (1005)
6.8K (1005)
47 (1005)
100 (1005)
s
s
s
s
s

RES, CHIP 220 (1005)
R1255
R1256
R1257
R1258
R1259
1-208-899-81
1-208-875-81
1-208-903-81
1-208-903-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
3.3K (1005)
330 (1005)
4.7K (1005)
4.7K (1005)
10 (1005)
1-208-887-81
1-208-887-81
1-218-990-81
1-218-990-81
1-208-923-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 1.0K (1005)
R1260
R1261
R1262
R1263
R1264
1-220-870-81
1-218-990-81
1-208-903-81
1-208-903-81
1-220-870-81
s
s
s
s
s
RES, CHIP 10 (1005)

RES, CHIP 4.7K (1005)
RES, CHIP 4.7K (1005)
RES, CHIP 10 (1005)
R1185
R1188
R1189
R1190
R1191
1-218-990-81
1-218-990-81
1-208-887-81
1-208-887-81
1-208-875-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
RES, CHIP 1.0K (1005)
RES, CHIP 330 (1005)
R1265
R1266
R1267
R1300
R1301
1-220-870-81
1-218-990-81
1-218-990-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES, CHIP 10 (1005)

RES, CHIP 220 (1005)
RES, CHIP 220 (1005)
R1193
R1194
R1195
R1196
R1198
1-208-927-81
1-218-990-81
1-208-871-81
1-218-990-81
1-208-887-81
s
s
s
s
s

RES, CHIP 220 (1005)
RES, CHIP 1.0K (1005)
R1302
R1303
R1304
R1305
R1306
1-208-871-81
1-208-871-81
1-220-870-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
10 (1005)
220 (1005)
220 (1005)
R1199
R1200
R1201
R1202
R1203
1-208-887-81
1-218-990-81
1-218-990-81
1-208-875-81
1-218-990-81
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 330 (1005)
R1307
R1308
R1309
R1310
R1311
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220
220
220
220
220
R1204
R1205
R1206
R1207
R1208
1-208-875-81
1-218-990-81
1-208-863-81
1-208-863-81
1-208-903-81
s
s
s
s
s
RES, CHIP 330 (1005)

RES, CHIP 100 (1005)
RES, CHIP 100 (1005)
RES, CHIP 4.7K (1005)
R1312
R1313
R1314
R1315
R1316
1-220-870-81
1-208-871-81
1-208-871-81
1-208-871-81
1-220-878-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
220 (1005)
220 (1005)
220 (1005)
22 (1005)
R1209
R1210
R1211
R1212
R1213
1-208-903-81
1-208-911-81
1-208-911-81
1-208-863-81
1-208-923-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1317
R1318
R1319
R1320
R1322
1-208-871-81
1-208-871-81
1-208-855-81
1-208-855-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
47 (1005)
47 (1005)
10 (1005)
R1214
R1215
R1217
R1218
R1219
1-208-923-81
1-208-863-81
1-218-990-81
1-218-990-81
1-208-927-81
s
s
s
s
s

RES, CHIP 100 (1005)
R1323
R1324
R1325
R1326
R1327
1-208-895-81
1-208-863-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
100 (1005)
10 (1005)
10 (1005)
10 (1005)
R1220
R1221
R1223
R1225
R1227
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
10 (1005)
10 (1005)
10 (1005)
10K (1005)
R1328
R1331
R1332
R1333
R1334
1-220-870-81
1-208-871-81
1-220-870-81
1-208-895-81
1-208-895-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10 (1005)
220 (1005)
10 (1005)
2.2K (1005)
2.2K (1005)
R1228
R1234
R1236
R1239
1-208-911-81
1-208-911-81
1-208-911-81
1-208-863-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10K
10K
10K
100
R1335
R1336
R1337
R1338
1-220-870-81
1-220-870-81
1-220-870-81
1-220-870-81
s
s
s
s
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
10
10
10
10
R1139
R1140
R1141
R1142
R1143
1-208-911-81
1-208-863-81
1-208-887-81
1-208-887-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1158
R1159
R1162
R1163
R1164
1-208-923-81
1-218-990-81
1-218-990-81
1-208-887-81
1-208-887-81
s
s
s
s
s
R1165
R1167
R1168
R1169
R1170
1-218-990-81
1-208-927-81
1-218-990-81
1-208-871-81
1-218-990-81
R1172
R1173
R1174
R1175
R1184
HSCU-300
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
100 (1005)
1.0K (1005)
1.0K (1005)
100 (1005)
4.7K (1005)
10K (1005)
10K (1005)
100 (1005)
33K (1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-75
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
SP Description
Ref. No.
or Qty Part No.
SP Description
R1339
R1340
R1341
R1342
R1343
1-208-871-81
1-208-871-81
1-208-871-81
1-220-870-81
1-220-870-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
220 (1005)
220 (1005)
10 (1005)
10 (1005)
R1547
R1548
R1549
R1550
R1551
1-208-943-81
1-208-887-81
1-208-903-81
1-208-903-81
1-208-903-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1344
R1345
R1346
R1349
R1350
1-208-911-81
1-208-911-81
1-208-911-81
1-208-895-81
1-208-863-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K (1005)
10K (1005)
10K (1005)
2.2K (1005)
100 (1005)
R1552
R1553
R1554
R1555
R1556
1-208-911-81
1-208-911-81
1-220-242-91
1-220-242-91
1-220-230-91
s
s
s
s
s

RES, SQUARE TYPE CHIP 22(3225)
RES, SQUARE TYPE CHIP 22(3225)
R1352
R1355
R1356
R1357
R1358
1-208-895-81
1-208-855-81
1-220-870-81
1-208-899-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
47 (1005)
10 (1005)
3.3K (1005)
220 (1005)
R1557
R1558
R1559
R1560
R1561
1-220-230-91
1-208-911-81
1-208-927-81
1-208-887-81
1-208-923-81
s
s
s
s
s

RES, CHIP 1.0K (1005)
R1359
R1360
R1361
R1362
R1363
1-208-871-81
1-208-855-81
1-208-855-81
1-208-871-81
1-208-855-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
47 (1005)
47 (1005)
220 (1005)
47 (1005)
R1562
R1563
R1564
R1565
R1566
1-208-919-81
1-208-907-81
1-208-871-81
1-208-871-81
1-208-871-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
6.8K (1005)
220 (1005)
220 (1005)
220 (1005)
R1364
R1365
R1366
R1502
R1503
1-208-855-81
1-208-915-81
1-208-911-81
1-208-959-81
1-208-959-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47 (1005)
15K (1005)
10K (1005)
1M (1005)
1M (1005)
R1567
R1568
R1570
R1572
R1573
1-208-871-81
1-208-911-81
1-208-959-81
1-208-915-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220 (1005)
10K (1005)
1M (1005)
15K (1005)
47K (1005)
R1504
R1505
R1506
R1508
R1509
1-218-990-81
1-208-919-81
1-208-919-81
1-208-863-81
1-208-923-81
s
s
s
s
s

RES, CHIP 100 (1005)
R1574
R1575
R1576
R1577
R1578
1-208-923-81
1-208-903-81
1-208-911-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
33K (1005)
4.7K (1005)
10K (1005)
47K (1005)
47K (1005)
R1510
R1511
R1513
R1514
R1515
1-208-919-81
1-208-923-81
1-208-911-81
1-208-943-81
1-218-990-81
s
s
s
s
s

RES, CHIP 220K (1005)
R1579
R1580
R1581
R1582
R1583
1-208-927-81
1-208-927-81
1-208-911-81
1-208-927-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K
47K
10K
47K
47K
R1518
R1519
R1520
R1522
R1523
1-208-935-81
1-208-919-81
1-208-943-81
1-243-975-81
1-243-975-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R1584
R1585
R1586
R1588
R1589
1-208-927-81
1-208-927-81
1-208-959-81
1-208-927-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
47K (1005)
47K (1005)
1M (1005)
47K (1005)
15K (1005)
R1524
R1525
R1526
R1527
R1528
1-208-959-81
1-208-927-81
1-243-975-81
1-218-990-81
1-208-943-81
s
s
s
s
s
RES, CHIP 1M (1005)

RES, CHIP 4.7M (1005)
RES, CHIP 220K (1005)
R1590
R1591
R1592
R1593
R1594
1-208-879-81
1-208-915-81
1-208-927-81
1-208-903-81
1-208-915-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
470 (1005)
15K (1005)
47K (1005)
4.7K (1005)
15K (1005)
R1529
R1530
R1531
R1532
R1533
1-208-943-81
1-208-911-81
1-208-887-81
1-208-943-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220K (1005)
10K (1005)
1.0K (1005)
220K (1005)
22K (1005)
R1595
R1597
R1598
R1599
R1600
1-208-919-81
1-208-895-81
1-208-911-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
2.2K (1005)
10K (1005)
10K (1005)
10K (1005)
R1534
R1538
R1539
R1540
R1541
1-208-895-81
1-208-951-81
1-208-923-81
1-216-789-91
1-216-789-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
2.2K (1005)
470K (1005)
33K (1005)
2.2 (1608)
2.2 (1608)
R1604
R1605
R1606
R1607
R1608
1-218-990-81
1-218-990-81
1-208-923-81
1-208-863-81
1-208-911-81
s
s
s
s
s

RES, CHIP 100 (1005)
R1542
R1543
R1545
R1546
1-220-230-91
1-220-230-91
1-220-230-91
1-208-935-81
s
s
s
s

RES, CHIP 100K (1005)
R1610
R1611
R1612
R1613
1-208-935-81
1-208-959-81
1-208-927-81
1-208-899-81
s
s
s
s
RES,
RES,
RES,
RES,
7-76
CHIP
CHIP
CHIP
CHIP
CHIP
100K (1005)
22K (1005)
220K (1005)
4.7M (1005)
4.7M (1005)
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
CHIP
220K
1.0K
4.7K
4.7K
4.7K
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
100K (1005)
1M (1005)
47K (1005)
3.3K (1005)
HSCU-300
(SY-364 BOARD)
(SY-364 BOARD)
Ref. No.
or Qty Part No.
Ref. No.
or Qty Part No.
SP Description
SP Description
R1614
R1615
R1616
R1617
R1618
1-208-887-81
1-208-895-81
1-216-789-91
1-216-789-91
1-220-230-91
s
s
s
s
s
RES, CHIP 1.0K (1005)

RES, CHIP 2.2K (1005)
RES, CHIP 2.2 (1608)
RES, CHIP 2.2 (1608)
RB838
RB839
RB840
RB841
RB842
1-234-380-21
1-234-380-21
1-234-380-21
1-234-380-21
1-234-375-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47K (1005X4)
47K (1005X4)
47K (1005X4)
47K (1005X4)
1K (1005X4)
R1621
R1622
R1623
R1624
R1625
1-208-943-81
1-208-879-81
1-208-863-81
1-208-911-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
220K (1005)
470 (1005)
100 (1005)
10K (1005)
10K (1005)
RB843
RB844
RB847
RB848
RB849
1-234-372-21
1-234-380-21
1-234-372-21
1-234-376-21
1-234-381-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100 (1005X4)
47K (1005X4)
100 (1005X4)
2.2K (1005X4)
100K (1005X4)
R1631
R1632
R1633
R1634
R1635
1-208-919-81
1-208-911-81
1-208-919-81
1-208-911-81
1-208-919-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
10K
22K
10K
22K
RB850
RB851
RB852
RB853
RB855
1-234-375-21
1-234-375-21
1-234-375-21
1-234-376-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
1K (1005X4)
1K (1005X4)
1K (1005X4)
2.2K (1005X4)
100 (1005X4)
R1636
R1637
R1638
R1639
R1640
1-208-919-81
1-218-990-81
1-208-911-81
1-208-883-81
1-208-903-81
s
s
s
s
s

RES, CHIP 680 (1005)
RES, CHIP 4.7K (1005)
RB856
RB857
RB858
RB859
RB900
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB1
RB300
RB301
RB400
RB530
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100
100
100
100
100
RB901
RB902
RB903
RB904
RB905
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB800
RB801
RB802
RB803
RB804
1-234-378-21
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10K (1005X4)
100K (1005X4)
100K (1005X4)
100K (1005X4)
100K (1005X4)
RB906
RB907
RB908
RB909
RB910
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB805
RB806
RB807
RB808
RB809
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100K
100K
100K
100K
100K
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB911
RB912
RB913
RB914
RB915
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220
220
220
220
220
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB810
RB811
RB812
RB813
RB814
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100K
100K
100K
100K
100K
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
RB916
RB919
RB920
RB921
RB922
1-234-373-21
1-234-371-21
1-234-371-21
1-234-371-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
47 (1005X4)
47 (1005X4)
47 (1005X4)
47 (1005X4)
RB815
RB816
RB817
RB818
RB819
1-234-381-21
1-234-381-21
1-234-381-21
1-234-381-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
100K (1005X4)
100K (1005X4)
100K (1005X4)
100K (1005X4)
47 (1005X4)
RB925
RB926
RB927
RB928
RB931
1-234-373-21
1-234-373-21
1-234-373-21
1-234-373-21
1-234-371-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
220 (1005X4)
220 (1005X4)
220 (1005X4)
220 (1005X4)
47 (1005X4)
RB820
RB821
RB822
RB824
RB825
1-234-371-21
1-234-371-21
1-234-371-21
1-234-372-21
1-234-372-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
47 (1005X4)
47 (1005X4)
47 (1005X4)
100 (1005X4)
100 (1005X4)
RB932
RB933
RB934
1-234-371-21 s RES, NETWORK 47 (1005X4)

1-234-371-21 s RES, NETWORK 47 (1005X4)
1-234-371-21 s RES, NETWORK 47 (1005X4)
RB826
RB830
RB831
RB832
RB833
1-234-378-21
1-234-375-21
1-234-375-21
1-234-375-21
1-234-375-21
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
NETWORK
10K (1005X4)
1K (1005X4)
1K (1005X4)
1K (1005X4)
1K (1005X4)
RV1
RV530
RV531
1-225-791-21 s RES, ADJ, CERMET 5K

RB834
RB835
RB836
RB837
1-234-375-21
1-234-375-21
1-234-380-21
1-234-378-21
s
s
s
s
RES,
RES,
RES,
RES,
NETWORK
NETWORK
NETWORK
NETWORK
1K (1005X4)
1K (1005X4)
47K (1005X4)
10K (1005X4)
S530
S531
S730
S731
S733
1-771-796-21
1-771-796-21
1-771-796-21
1-771-796-21
1-771-796-21
S734
S801

HSCU-300
(1005)
(1005)
(1005)
(1005)
(1005)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
(1005X4)
s
s
s
s
s
SWITCH,
SWITCH,
SWITCH,
SWITCH,
SWITCH,
SLIDE
SLIDE
SLIDE
SLIDE
SLIDE
7-77
-----------VIF-39 BOARD
-----------Ref. No.
or Qty Part No.
(SY-364 BOARD)
Ref. No.
or Qty Part No.
T730
SP Description
1-443-158-11 s TRANSFORMER, DC-DC CONVERTER
THP801
THP950
THP951
THP952
THP953
!
!
!
!
!
1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
THP954
THP955
THP956
THP957
THP958
!
!
!
!
!
1-802-108-11
1-803-615-21
1-803-615-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
THP959
THP960
THP961
THP962
THP963
!
!
!
!
!
1-803-615-21
1-803-615-21
1-804-616-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
THP964
THP965
THP966
THP967
THP968
!
!
!
1-802-108-11
1-804-616-21
1-804-616-21
1-804-616-21
1-804-616-21
s
s
s
s
s
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
THERMISTOR,
POSITIVE
POSITIVE
POSITIVE
POSITIVE
POSITIVE
THP969
TP1
TP4
TP5
TP6
TP7
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
TP530
TP531
TP801
TP802
TP803
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
1-535-877-22
s
s
s
s
s
CHIP,
CHIP,
CHIP,
CHIP,
CHIP,
CHECKER
CHECKER
CHECKER
CHECKER
CHECKER
TP901
TP902

X1
X2
X3
X801
X802
1-813-212-11
1-795-671-12
1-795-670-12
1-813-480-11
1-795-983-11
X803
X900
X901
1-813-253-12 s OSCILLATOR, CRYSTAL (VCXO) 5V

1-814-162-11 s OSCILLATOR (VCO)
1-814-162-11 s OSCILLATOR (VCO)
7-78
s
s
s
s
s
OSCILLATOR,
OSCILLATOR,
OSCILLATOR,
OSCILLATOR,
OSCILLATOR,
CRYSTAL
CRYSTAL (VCXO)3.3V
CRYSTAL (VCXO)3.3V
CRYSTAL
CRYSTAL
SP Description
1pc
3pcs
A-1707-206-A s MOUNTED CIRCUIT BOARD, VIF-39

3-637-901-02 s SCREW M2.6X5
C1
C2
C3
C4
C11
1-165-585-21
1-125-777-81
1-125-777-81
1-165-585-21
1-165-989-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CHIP ELECT 47MF

CHIP ELECT 47MF
CERAMIC 10MF (2012)
C12
C13
C14
C15
C16
1-165-989-91
1-112-717-91
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C17
C18
C19
C20
C21
1-125-777-81
1-125-777-81
1-112-717-91
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

C22
C23
C24
C25
C26
1-112-717-91
1-112-717-91
1-112-717-91
1-112-746-91
1-112-746-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
C27
C28
C41
C42
C43
1-112-746-91
1-112-746-91
1-165-585-21
1-112-717-91
1-112-717-91
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,

CHIP ELECT 47MF
C44
C45
C46
C61
C62
1-165-585-21
1-112-717-91
1-112-717-91
1-131-661-21
1-112-692-81
s
s
s
s
s

C63
C64
C65
C81
C82
1-112-692-81
1-164-850-81
1-164-850-81
1-165-585-21
1-165-585-21
s
s
s
s
s

C83
C84
C85
C86
C87
1-112-717-91
1-112-717-91
1-100-055-21
1-100-055-21
1-125-777-81
s
s
s
s
s
CAP,
CAP,
CAP,
CAP,
CAP,
CN1
CN2
CN3
CN4
CN5
1-819-993-11
1-819-993-11
1-819-993-11
1-770-623-21
1-815-921-11
s
s
s
s
s
CONNECTOR, COAXIAL(BNC DOUBLE)

PIN, CONNECTOR 6P
JACK, MODULAR
E1
FB11
FB12
1-414-554-21 s FERRITE, EMI (SMD) (1608)

1-414-554-21 s FERRITE, EMI (SMD) (1608)
IC1
IC2
IC3
IC6
IC41
8-759-561-46
6-709-612-01
6-709-612-01
6-712-135-01
8-759-561-46
IC42
8-759-561-46 s IC AD8014ARTZ-REEL7
s
s
s
o
s
IC
IC
IC
IC
IC
10MF (2012)
1UF B (1005)
1UF B (1005)
1UF B (1005)
1UF B (1005)
1UF B
1UF B
1UF B
4.7MF
4.7MF
(1005)
(1005)
(1005)
B (1608)
B (1608)

AD8014ARTZ-REEL7
GS1574ACNE3
GS1574ACNE3
R1173H001D-T1-F
AD8014ARTZ-REEL7
HSCU-300
7-4. Supplied Accessories

(VIF-39 BOARD)
Ref. No.
or Qty Part No.
*J: [HSCU-300(J)]
*UC: [HSCU-300(UC)]
*CE: [HSCU-300(CE)]
SP Description
JC42
1-216-864-91 s CONDUCTOR, CHIP (1608)
L1
L2
L11
L12
L41
1-414-398-41
1-414-398-41
1-414-459-21
1-414-459-21
1-414-398-41
L42
L81
L82
1-414-398-41 s INDUCTOR (SMD) 10.0UH

1-416-344-21 s COIL, CHOKE 10UH
1-416-344-21 s COIL, CHOKE 10UH
Q81
R1
R2
R3
R4
R5
1-208-863-81
1-208-911-81
1-208-887-81
1-208-887-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
R13
R14
R17
R18
R19
1-218-990-81
1-218-990-81
1-211-990-91
1-211-990-91
1-211-990-91
s
s
s
s
s

RES, CHIP 75 (1608)
RES, CHIP 75 (1608)
RES, CHIP 75 (1608)
R20
R21
R22
R23
R24
1-211-990-91
1-211-990-91
1-211-990-91
1-211-990-91
1-211-990-91
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
75
75
75
75
75
R25
R26
R27
R28
R29
1-208-919-81
1-208-911-81
1-208-919-81
1-208-919-81
1-208-911-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K
10K
22K
22K
10K
R30
R41
R42
R43
R44
1-208-919-81
1-211-990-91
1-211-990-91
1-208-863-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
22K (1005)
75 (1608)
75 (1608)
100 (1005)
47K (1005)
R45
R46
R47
R48
R49
1-208-887-81
1-208-887-81
1-208-863-81
1-208-927-81
1-208-875-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
100 (1005)
47K (1005)
330 (1005)
R50
R51
R52
R81
R82
1-208-887-81
1-208-887-81
1-208-875-81
1-208-919-81
1-208-887-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
1.0K (1005)
1.0K (1005)
330 (1005)
22K (1005)
1.0K (1005)
R83
R84
R85
R86
R87
1-208-911-81
1-208-919-81
1-208-919-81
1-208-919-81
1-208-927-81
s
s
s
s
s
RES,
RES,
RES,
RES,
RES,
CHIP
CHIP
CHIP
CHIP
CHIP
10K
22K
22K
22K
47K
R88
R89
R90
1-208-863-81 s RES, CHIP 100 (1005)

1-208-927-81 s RES, CHIP 47K (1005)
1-208-927-81 s RES, CHIP 47K (1005)
HSCU-300
s
s
s
s
s
INDUCTOR (SMD)
INDUCTOR (SMD)
INDUCTOR, CHIP
INDUCTOR, CHIP
INDUCTOR (SMD)
CHIP
CHIP
CHIP
CHIP
CHIP
10.0UH
10.0UH
(S) 4.7NH
(S) 4.7NH
10.0UH
100 (1005)
10K (1005)
1.0K (1005)
1.0K (1005)
330 (1005)
Qty
1pc
1pc *J
1pc *UC*CE
1pc
Part No.
SP Description
2-249-307-01
4-140-408-01
4-140-409-01
4-140-417-01
!
!
s
s
s
s
INDICATOR, REMOTE
MANUAL, OPERATION (Japanese)
MANUAL, OPERATION (English)
CD-ROM PACK
7-5. Optional Fixtures

Part No.
A-1727-365-A
A-1727-367-A
A-1727-368-A
A-1727-369-A
A-8326-017-A
SP Description
s
s
s
s
s
MOUNTED
MOUNTED
MOUNTED
MOUNTED
MOUNTED
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
CIRCUIT
BOARD,
BOARD,
BOARD,
BOARD,
BOARD,
EX-1121
EX-1098
EX-1099
EX-1100
ROM-28
J-7120-220-A o PLD DOWNLOAD TOOL FOR USB
(1608)
(1608)
(1608)
(1608)
(1608)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
(1005)
7-79
Section 8
Block Diagrams
HSCU-300
8-1
8-1
Overall (1/2)
AU-321
SY-364
+10V
D1-3,Q1
D6-8,Q4
D4,Q2
D5,Q3
D10,Q5
D14,Q7
D20,Q19
CN-3083
INTERCOM
CN1
2-2,3
2-5
2-7
2-2,3
MAIN POWER
CAM POWER
CABLE OPEN
CABLE SHORT
NETWORK
INCOM-TALK
NC
FRONT TALK
1-12
1-13
1-14
1-8
1-9
1-10
1-11
1-7
1-17,18
EN1
FRONT-RCV
FRONT-PGM
(A)
FRONT-ENC
(B)
(ENT)
S1
CLEAR
ENTER
IC305
STBY INCOM TX
3-13,14
MENU ENTER...
3-11
3-10
3-3
3-4
3-5
1-21
FRONT RCV
Q317
MUTE
FRONT PGM
FROM
CN-3081B
11
MIC1(X)
3-17...
IC408
MUTE
S4
PROD
PRIVATE
ENG
MIC2(X)
RV1 FRONT
INC VR
INCOM
LEVEL
IC3
+10V
+10V
REG
3-26
1-5
1-22...
1-3,4
1-26
1-14...
+3.3V(VR-DC)
3-24
1-6
IC409
SY
PLD
D/A
IC401
IC402
MUTE
FRONT INC VR
AUDIO
AND
TG
IC302
ENG IN(X)(Y)
IC538,543
2W
I/F
Q530,532
MUTE
RV530
RTS
CANCEL
2W
I/F
RV539
RTS
CANCEL
RTS
4W
PROD OUT(X)
PROD OUT(Y)
101-A10,B10
101-E11
101-D11
S531
ENG OUT(X)
ENG OUT(Y)
IC542
Q531,533
MUTE
AUDIO
AUDIO
STBY INCOM
SYBY INCOM
D/A
IC407
101-A11,B11
S530
IC541
IC539,544
Q546-548
MUTE
IC400
RTS
4W
101-C8,A8
LPF
TX
RX
RX
TX
IC804
ADC
101-E10
101-D10
102-E24...
102-E23...
102-E25
102-D25
TO MB-1124(2/2)
2
IC5,15
FRONT-ENC(ENT)
IC22
D/A
SYNC
SEP
MENU ENTER
+3.3V
IC12
IC35
IC17
H-PHASE
ADJ.(HD)
IC3
IC28
IC31
COMPARATE
for SD
IC819
IC9
H-PHASE
ADJ.(SD)
ASSIGN VR IRIS etc
IC36,X2,3
IC18
LPF
PHASE
COMP.(HD)
74M
VCO
IC34,X1
IC11
LPF
PHASE
COMP.(SD)
27M
VCO
IC29
SEL
PGM1
PGM2
MIC1(X)
MIC2(X)
27MHz
PLD-CLK
FLASH
x2
SDRAM
x2
IC920
FRAM
x2
IC903
IC900
VBS SD
DIGIT
SDRAM
IC921
IC854
SDRAM
SDI
DESERIALIZER
IC804
A/D
IC876
BUS
TRANSCEIVER
AO SERIAL DATA
IC805
BT101
REAL TIME
CLOCK
CR
2032
SDI
DESERIALIZER
IC1507
-12.5V
REG
+5V-P
CONTROL
+5.5V
REG
+2.5V
REG
IC876
(PANEL EXIST/NONE)
IC1508
IC1514
Q1512,Q1513
IC1512
Q1505,Q1506
5V
REG
+5.5V
+5V-T
+3.3V
REG
IC1515
+3.3V-2
REG
8-2
101-D24
101-E23
TO MB-1124(2/2)
3
101-A24
101-A21
101-E4,E2
101-D22
101-E22
101-C22,B22
102-A8...
102-D11...
TO MB-1124(2/2) 4
TO MB-1124(2/2) 1
+5.5V
-5.5V
101-A17
101-B17
+5V-2
+5V-A
+5V
-5V
-5V-A
-5.5V
IC1502
IC1504
+1.8V
REG
8-2
-12V
-5.5V
REG
IC1501
Q1500,Q1501
101-E25
+12V
12V
REG
IC1509
Q1509
HD/SD-SDI-RET2
HD RET-Y/C
DIGITAL PROMPTER
IC1500
Q1503,Q1504
+5V REG
HD/SD-SDI-RET1
LAN-COM-TX,RX
700P-TX-CCU-DATA
700P-RX-CAM-DATA
RCP-COM-TX,RX
PNL IIC SDA IN

PNL IIC SCL OUT
IC513
Q1510,Q1511
RETURN1-VBS
RETURN2-VBS
101-E17
102-E4
102-E3
IC902
700P
IC847-849
IC904
101-A15
101-E15
101-B1
101-B2
IC901
RET-PLD
UP CONV.
74M,27M PLD
CLK
IC853
CPU
REG
RESET
HD/SD-SYNC
EXTERNAL-REF-SYNC
EXTERNAL-REF-SC
IC6
IC812,813 IC814,815 IC817,818
+5V-P
PANEL ID IN
IC16
IC24
74MHz
PLD-CLK
EXT-REF
PHY
IIC SDA
IIC SCL
PANEL RESET
UNREG(+14V)
IC23
RV1
IC4
FRONT-ENC(A)(B)
102A2,B2,C2,
D2,E2
2-21
IC540
IC537
D/A
IC801
EEPROM
NC
IC532
LPF
IC808
NC
FROM
MB-1124(1/2)
12
LPF
LPF
MS
I/F
2-20
2-19
2-18
2-10
2-16
A/D
D/A
-20db
CN804
NC
NC
NC
IC537
LPF
COMPARATE
for SC
2-22...
PROD IN(X)(Y)
IC536
IC2
NC
IC540
LPF
A/D
IC407
-20db
0db
IC531
INCOM G0...
REF IN
1-27,28
IC536
MUTE
CONTROL
COMPARATE
for HD
MEMORY
STICK
CN
IC530
102-C5...
101-E9...
101-C18,D18,E20
RED TALLY,GREEN TALLY
R/G
TALLY I/F
Q315,316
0db
RED TALLY PANEL

WFM RECALL
MIC GAIN CTL
Q811-819
BUFFER
Q822-836
BUFFER
S730,731,PH730,731
A/D
Q318
MUTE
Q400-402
MUTE
DISP
MENU
MIC ON
OFF
PGMON
IC411
PGM2
S2
S3
IC800
IC301
IC406
LPF
IC406
LPF
IC307
LPF
IC307
LPF
IC410
PGM1
3-9...
IC306
LPF
IC304
LPF
IC305
LPF
IC304
Q14,17
INCOM G0...
INCOM-RCV
INCOM-PGM
IC306
FRONT TALK
STBY INCOM RX
1-20
UNBAL
ON/OFF
IC862
AUDIO
SRAM
R-TALLY
G-TALLY
IC1
Q8,9,11,12
2-5
2-7
Overall (1/2)
IC1506
+1.5V
REG
+3.3V
+3V-T
+1.8V
+1.5V
+3.3V-2
HSCU-300
Overall (1/2)
PS-739
T2
HIGH VOLTAGE
CONVERTER
180V
38V
180V RY2001
CHANGE
OVER
SWICH
Overall (1/2)
CN2002
CHU OUT
FL-349
FERRITE
CORE
DC180V(H)
DC180V(C)
LPF
CN1004
POWER CONTROL,
CABLE STATUS
LPF
CT-257
CN1010
CN1009
UNREG+12V
CN5002
CN5003
IC5010
IC5012
REG
IC5002
PLD
AC INLET/FILTER
CN1
F1
D1
T1
LOW VOLTAGE
CONVERTER
LINE
FILTER
CN1008
+15V
RCP
CN5006
+15V
CN5004
D2
IC5013
+12.5V
REG
CN5007
IC5014
REG
START
UP
D101
TO AU-321
11
R TALLY etc
MB-1124(1/2)
14
TO DPR-300
15
TO SY-364 12
TO DPR-300 5
IC101
REG
5-1,3,5
5-7
6-1
RCP PWR OK/NG

7-12,13
7-4...
5-23E
4-5C...
4-6A
4-6C
5-4C... 921-C22...
921-A23
5-3A
921-C23
5-3C
3-3B
3-18A
3-18C
3-18B
5-21B
5-5D
5-5C
5-5B
921-B5
921-D21
921-C21
921-B21
2-6C
2-6B
5-2B
5-2E
921-B24
921-E24
3-9E
3-18E
3-6B
1-17A
1-17B
5-17D
5-8E
5-20B
5-9A
5-9B
921-E9
921-E18
921-B6
921-A17
921-B17
3-8E
3-8A
3-11A
3-10A
3-11E
3-10E
3-15A
3-15E
5-18E
5-18A
5-15A
5-16A
5-15E
5-16E
5-11A
5-11E
921-E8
921-A8
921-A11
921-A10
921-E11
921-E10
921-A15
921-E15
3-4E
3-2E
911-E4
911-E2
3-24D
3-23E
911-D24
911-E23
3-24A
3-21A
3-25E
911-A24
911-A21
911-E25
9-1
9-2
8-1
10-7
TO CN-3080B
13
CN-3081B
2-2E
2-2A...
4-2A...
FAN
+12V
FAN ALARM
RCP PWR(+30V)
UNREG DRIVE
921-E3
UNREG(+14V)
5-22A... 921-A3...
R TALLY etc
RCP PWR OK/NG
FAN ALARM
CAMERA POWER ON/OFF
CAMERA POWER STATUS
CABLE OPEN STATUS
CABLE SHORT STATUS
IC2
TRUNK1(TX)
422A
DRIVER/
TRUNK1(RX)
RECEIVER
WFM RECALL
MIC GAIN CTL
RED TALLY REAR
+5.5V
-5.5V
10-1
10-2
10-3
10-4
CN4
TRUNK
(RS-422A)
CN3
WF REMOTE
CN2
MIC REMOTE
IC1
+5V
REG
+5V
RED TALLY
GREEN TALLY
PROD-T
ENG-T
PROD-R
ENG-R
PGM1
PGM2
VIF-39
CN1
INCOM/
TALLY/PGM
CN5
ETHER COM RC
ETHER COM TR
CN3
RETURN1 VBS
RETURN2 VBS
IC41
IC42
HD/SD SDI RET1

HD/SD SDI RET2
EXT REF
VBS1/3
VBS2/4
IC2
CABLE EQ.
IC3
CABLE EQ.
CN2
RETURN INPUT
SDI1/3
SDI2/4
CN1
IC1
Overall (1/2)
REFERENCE INPUT
(LOOP THROUGH)
CN-3082
HSCU-300
3-1B
3-2B
911-B1
911-B2
3-17A
3-17B
911-A17
911-B17
TO
DPR-300
MPX-FILTER
CN1
EXT MIC1(X)(Y)
EXT MIC2(X)(Y)
4-4
4-1
+5.5V
-5.5V
3-4
3-1
MIC1
CN1
MIC2
IC6
+3.3V
REG
+3.3V
8-3
8-3
CN2
FERRITE
CORE
HPF
TRIAX(H)
TRIAX(C)
1-5
CAMERA(TRIAX)
1-3
FERRITE
CORE
Overall (2/2)
Overall (2/2)
DPR-300
F8
IC207
T201
IC204
ATT
T203
IC208
ATT
TRAP
FILTER
FROM
FL-349
CN2
IC202
IC201
MIXER
IC206
IC205
MIXER
IC215,217
DY-23(RET)(1/2)
IC1101
IC1103
D/A
IC201
CAFE-T
OFDM-MUX
IC1104
D/A
DAYTONA
GAIN
CONTROL
IC700
HPF
IC601
IC100
+2.5V
TORINO
+1.0V
SD
RAM
SD
RAM
IC101
IC102
IC602
PLD
MAPPING
DDR
SRAM
DDR
SRAM
IC401
IC402
HD-RET-Y/C
700P TX CCU DATA
DIGITAL PROMPTOR
700P RX CAM DATA
Q601
VBS SD
DIGIT
CN100
CN701
CN10095-102
+1.0V
CN70195-102
MPX
FILTER
BPF
LPF
CN3901
+2.5V
CN100113-120
FL3901
CN701113-120
HPF
ENC-112
CN101
CN900
IC203
F9/F7
CN900
CN101
T202,204
PROMPTER1
Q602
VBS SD
DIGIT
PROMPTER2
TRUNK1(TX)
TRUNK1(RX)
SDRAM
IC800
FL1502
BPF
1.4MHz
FROM
MB-1124(1/2)
14
IC1502
Q1503,1504
FM
DEMOD
IC1510
LPF
60kHz
HPF
14kHz
+5.5V
REG
+5.5V-a
IC305,IC306
Q303,Q304
IC301,Q301,Q302
UNREG(+14V)
+5.5V-a
+5V-a
-5V-a
5V
REG
IC303,Q308
REG
RESET
-5.5V
REG
IC311,Q305
IC309,Q310
FL1501
BPF
1.0MHz
IC1501
-5.5V-a
-5.5V
REG
+3.3V
REG
IC308
+1.2V
REG
IC417,Q403
LV1501
FERQ
ADJ.
+3.3V-A
+1.2V-LLVC-A
IC3906
F6
IC310
REG
RESET
+1.2V
REG
+5.5V
IC408,IC411
Q404,Q405
IC401,Q401,Q402
IC412,Q414
FM
MOD
5V
REG
-5.5V
REG
FL3902 IC3905
BPF
IC2400
RF DETECT
IC2703
IC2704
IC2705
IC1506
TRIAX-H
LPF
60kHz
D1506,1507
IC1505
LIMITER
LPF
7kHz
IC1504
RV1501
DEV
ADJ.
+5.5V
F5
FL3801 IC3805
BPF
+5V-D
-5V-D
IC2501
PLD
ANALOG
F4
FL3701 IC3705
BPF
IC3801
STEP
GAIN
AGC
AMP
AMP
IC410
IC404,Q413
+1.8V
REG
+1.5V
REG
IC409
IC405,IC418
+1.0V
REG
+1.2V
REG
IC3606
F3
FL3601 IC3605
BPF
IC3804
DEMOD
IC2001
DY-23(MAIN)(1/2)
IC3702
MIXER
IC3704
DEMOD
PLD
DEMUX
IC3602
MIXER
DAYTONA
DDR
SRAM
DDR
SRAM
IC2602
ENCODER
IC2601
IC2602
CHARA
GEN
CHARA
GEN
ENCODER
101-E21
IC2807
IC2806
IC2805
STBY INCOM TX
STBY INCOM RX
AUDIO TX
AUDIO RX
EXT-REF-SC
EXT-REF-SYNC
R/R-Y
D/A
G/Y
D/A
B/B-Y
D/A
D/A
D/A
D/A
WF
PIX
VBS
STAIR CASE
102-D25
102-E25
102-E24...
102-E23...
102-E3
102-E4
101-D9
101-B10
101-A9
101-A3
101-D3
101-D15
101-C20
RV2601,2602
+1.0V
F2
FL3501 IC3505
BPF
IC3501
STEP
GAIN
AGC
AMP
AMP
IC401
IC402
SD
RAM
IC3502
MIXER
IC3401
STEP
GAIN
AMP
IC3402
MIXER
IC3403
AGC
AMP
SD
RAM
IC2103,2104
IC2201
IC2202
IC2203
CHARA
GEN
CHARA
GEN
CHARA
GEN
POST
PLD
SDI1,2
101-A24
IC2309
SDI
SERIALIZER
SDI3,4
101-A21
IC2002
AUDIO
SRAM
DY-23(RET)(2/2)
IC3504
DEMOD
+2.5V
+1.2V-DAY
FL3401 IC3405
BPF
IC2308
SDI
SERIALIZER
MONI
MAIN SD
MAIN HD
DEMUX AUDIO
+1.2V-DAY
F1
IC2000
PROCYON-V
IC2101,2102
IC3604
DEMOD
AGC CTL
IC414
IC415,IC416
DAYTONA MAIN
IC201
IC3601
STEP
GAIN
AGC
AMP
AMP
IC407
+1.2V
REG
TO
5 MB-1124(1/2)
SD(8:4:4)
AGC CTL
+1.5V
+1.2V
HALF
BAND
FILTER
SKIN GATE
AGC CTL
+2.5V
+1.8V
IC3904
DEMOD
102-B6
102-E6
HD
IC3802
MIXER
IC3701
STEP
GAIN
AGC
AMP
AMP
+3.2V
IC403,Q412
+2.5V
REG
IC3902
MIXER
IC1700
AGC CTL
-5.5V-D
+3.2V
REG
IC3901
STEP
GAIN
AGC
AMP
AMP
101-E23
AGC CTL
+1.2V-LLVC-B
IC402,Q411
DELAY
INCOM
MUTE
IC1512
COMPARATOR
RV1502
STB INCOM
LEVEL
IC307
+3.8V
+3.8V
REG
IC1514
Q1501,1502
-5.5V-R
IC304,Q307
+5.5V
REG
D1508
DETECT
IC1509
CN101
CN1800
FROM
MB-1124(1/2)
15
102A2,B2,
C2,D2
LPF
7kHz
+12V
TONE DETECT
101-D24
RV1503
TONE ADJ.
CN1800
CN101
102-E2
+12V
REG
TONE
DETECT
IC1508
IC302
UNREG-D
IC1512
HOLD
IC1511
102-A7...
102-D22
102-E11...
102-E22
IC3404
DEMOD
CN90039,41
CN10139,41
CN900CN10143,45,47,49 43,45,47,49
+2.5V
+1.2V
+1.2V-DAY
CN180039,41
CN10139,41
CN1800CN10143,45,47,49 43,45,47,49
+2.5V
+1.2V
IC101
+2.5V
AGC CTL
CN90052,54,56
CN10152,54,56
+V-REG
IC901
+5V-D
+1.8V
REG
IC101
+2.5V
+1.8V(DDR)
IC301
+3.3V
REG
CN90057,58
+3.2V
8-4
DY-23(MAIN)(2/2)
+2.5V
CN10157,58
CN900IC10159,61,63,65 59,61,63,65
8-4
+3.3V-PLL
+3.3V
+1.2V
REG
CN180052,54,56
CN10152,54,56
+V-REG
IC1800
+1.2V(PLL)
+5V-D
+1.8V
REG
+1.8V(DDR)
IC301
+3.3V
REG
CN180057,58
+3.2V
CN10157,58
CN1800IC10159,61,63,65 59,61,63,65
+3.3V-PLL
+3.3V
+1.2V
REG
+1.2V(PLL)
+5.5V-A
101-A17
-5.5V-R
101-B17
(CHARGE/PUMP SIGNAL)
101-D17
UNREG(+14V)
101-C17
HSCU-300
Overall (2/2)
FROM
SY-364
1
MB-1124(2/2)
2-22D
2-22E
2-7D...
2-11D...
Overall (2/2)
4-22D
4-22E
4-7D...
4-11B...
FROM
SY-364
2
4-25D,25E
4-23E,24E...
FROM
SY-364
3
2-25D,25E
2-23E,24E...
SDI-97B
1-24D 921-D24
1-23E 921-E23
4-3E
4-4E
1-15A 921-A15
2-3E
2-4E
1-9D
921-D9
1-10B 921-B10
FROM
SY-364
4
1-9A
921-A9
1-3A
921-A3
1-3D
921-D3
PROMPTER 1
PROMPTER 2
HD/SD-SYNC
IC501
1-19A 921-A19
1-18A 921-A18
1-20C 921-C20
1-15D 921-D15
FL241
LPF
FL201
G/Y
LPF
FL221
B/B-Y
LPF
FL321
WF
LPF
FL341
PIX
LPF
R/R-Y
RCP-COM-TX
RCP-COM-RX
STAIR CASE
VBS
FL301
LPF
1-21A 921-A21
1-17A
+5.5V
921-A17
12-12
12-3
12-6
12-25
12-23
12-14
12-20
12-18
12-16
12-29
12-27
IC241
10-14
IC201
10-16
IC221
10-18
IC321
10-5
IC341
PIX
RCP-PIX
IC141,PH141
TRANCEIVER
10-7
10-22
12-9
HD/SD-SDI3,4
IC102
DRIVER
+5.5V
IC1,2,Q1,2
+5V
5V
-5V
REG
REMOTE
CN1
CN2
CN8
CN9
CN10
CN11
CN7
CN6
1
PROMPTER
INPUT
2
HD/SD SYNC
R/R-Y
G/Y
B/B-Y
WF
PIX
CN5
10-25
CN3
IC301
IC101
DRIVER
RCP PIX
RCP COM-TX,RX
10-31
10-28
IC121
HD/SD-SDI1,2
3-1
CN4
10-20
IC302
1-24A 921-A24
RCP-PWR(+30V)
IC261
IC342
4-22C
4-22B
CN-3080B
10-9
10-11
IC502
FROM
CN-3081B
13
STAIR CASE
5-3
WF
MODE
VBS OUTPUT
CN1
1
2
SDI OUTPUT
CN2
3
4
+5V
10-3
12-31
+5V
-5.5V
IC3
1-17B
-5.5V
921-B17
+3.3V
REG
+3.3V
IC11
1-17D
1-17C
HSCU-300
CHARGE/PUMP
SIGNAL
+14V
921-D17
921-C17
-10V
GEN
-10V
+14V
Overall (2/2)
8-5
8-5
Section 9
Schematic Diagrams
Index
Board name
Page
A.
AU-321
9-2
C.
CN-3080B
9-3
CN-3081B
9-4
CN-3082
9-6
CN-3083
9-6
CT-257
D.
DPR-300
9-7
DY-23
9-43
E.
ENC-112
9-48
F.
FL-349
9-50
Frame Wiring
9-75
M.
MB-1124
9-51
P.
PS-739
S.
V.
SDI-97B
9-54
SY-364
9-56
VIF-39
9-74
*: The schematic diagram of this board is not described in this manual.
HSCU-300
9-1
9-1
AU-321
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
AU-321
D2
SML-D12U8WT86
D11 NM
SML-D12Y8WT86SP
D12 NM
SML-D12Y8WT86SP
D3
SML-D12U8WT86
GND
D13 NM
SML-D12Y8WT86SP
R13
470
NM
FB2
RB2
470
FB3
C11
0.01uF
L1
D4
D5
CL-197HG5-CD-T CL-197HG5-CD-T
GREEN
R2
2.2k
R4
10k
NM
R5
2.2k
C2
0.01uF
R11
1.5k
R6
10k
NM
C4
0.01uF
Q6 DTC114EE-TL
NM
D14
SML-D12U8WT86
D10
SML-D12U8WT86
GREEN
R18
1.5k
C6
0.1uF
R15
1.5k
RED
C12
0.01uF
RED
R17
1.5k
R12
1.5k
+10V
3
VIN VOUT1
6
VOUT2
2
4
CTL
VADJ
C13
GND
R84
22uF
1.5k
35V
5
R16
1.5k
C8
0.01uF
R86
10k
R85
470
C16
47uF
16V
D18
SML-D12M8WT86SM
+10V
GND
MAIN POWER
CAM POWER
Q5
DTC114EE-TL
C31
0.01uF
4567
S3
2
G1
B-13
1
3
R54 470
R55 470
C39
0.01uF
4567
3.0V
C38 0.01uF
PROD
PRIVATE
ENG
C32
0.01uF
S4
2
G1
B-13
1
3
R56 470
R57 470
C44
1uF
RV1
10k
C40
0.01uF
4567
R65
1.5k
R66
1.5k
C52
0.01uF
Q18
DTC114EE-TL
GND
R60 220
R61 220
R68
1.5k
C53
0.01uF
R35
22k
R75
2.2k
GND
Q19
DTC114EE-TL
NETWORK
Q13
2SC4617TL-QR
Q8
2SA1774TL-QR
1
2
3
4
5
6
7
8
CN2
Incom-Talk(g)
Incom-Talk(x)
Incom-Talk(y)
Incom-GND
Incom-RCV(x)
Incom-RCV(y)
Incom-PGM(x)
Incom-PGM(y)
R27
100k
R76
2.2k
R34
2.2k
R29
22k
R42
2.2k
R40
22k
C30
47uF
16V
R36
2.2k
R74
2.2k
R28
100k
R37
2.2k
C24
0.22uF
C25
0.22uF
C55
0.1uF
R38
22k
R62 33
C21
0.0047uF
R82
22k
R39
22k
R33
100
R41
22k
R63 33
0.01uF
C14
C22
C20
1000pF 1000pF
Q9
2SC4617TL-QR
C23
0.01uF
C26
0.01uF
C56 C27
0.1uF 47uF
16V
2 -
R52
10k
R48
2.2k
R77
4.7M
C49
0.0047uF
C41
1uF
GND
C35
470pF
R71
100
R78
4.7M
R79
4.7M
S
+10V
C36
470pF
5 +
Q12
DTC114EE-TL
R53
10k
7
C42
1uF
C33
0.01uF
Q17
DTC114EE-TL
GND
R80
33
R83
33
C47
0.1uF
V+
V-
C43
1000pF
IC1 (2/3)
NJM4580V(TE2)
Q14
DTC114EE-TL
Q11
DTC114EE-TL
GND
(1/3)
IC1
NJM4580V(TE2)
R73
33
R81
0
S
10 9
C48
0.0047uF
Q16
2SK880GR-TE85L
Q15
2SK880GR-TE85L
3
C54
0.1uF
FB1
R69
1.5k
R70
1.5k
C46
0.01uF
MENU ON
CABLE SHORT
CN3
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
GND
GND
Front-PIX(x)
Front-PIX(g)
Front-Inc-VR
VR-DC
MIC-on
PGM-on
Front-INC-PROD
Front-Inc-ENG
DISP-on
MENU-on
MENU-Clear
MENU-Enter
MENU-LED
GND
Front-Talk(x)
Front-Talk(y)
GND
Front-RCV
Front-PGM
INCOM-G0
INCOM-G1
INCOM-UNBAL
INCOM-PW
Front-ENC(ENT)
Front-ENC(A)
Front-ENC(B)
GND
GND
R72
470
+10V
D20
SML-D12M8WT86SM
YellowGreen
31 32
R64
470
INCOM LEVEL
GND
R67
1.5k
C51
0.1uF
Q7
DTC114EE-TL
CABLE OPEN
G1
MENU
C10
0.01uF
C37 0.01uF
MIC ON
OFF
PGM ON
C29 0.01uF
S2 B-18
R46 470
MT1 1
2
R47 470
MT2 3
DISP
C15
0.1uF GND
C7
0.1uF
4567
+10V
YellowGreen
Q3
Q2
DTC114EE-TL DTC114EE-TL
G1
ENTER
3
2
IC3
NJM2387ADL3(TE2)
GND Q1 DTC114EE-TL Q4 DTC114EE-TL
C28 0.01uF
S1 B-18
R44 470
MT1 1
2
R45 470
MT2 3
CLEAR
4
1
C9
0.01uF
NM
C5
0.01uF
C3
1uF
C1
0.01uF
RB1
470
R14
470
NM
7
5
3
1
7
5
3
1
R3 R7
470 10k
NM
R1
470
8
6
4
2
8
6
4
2
R9
2.2k
R10
10k
NM
R8
1.5k
YELLOW
4 2 5
GREEN
CN1
RED
+10V
16 17
D1
SML-D12U8WT86
GND
Y-Tally
G-Tally
R-Tally
Short-LED
Open-LED
CAM-PW-LED
MAIN-ALR-LED
Ether-LED
GND
NC
14V
14V
NC
GND
R/G/Y TALLY
D6
D7
CL-197HG5-CD-T
CL-197HG5-CD-T
D8
CL-197HG5-CD-T
C45
R58 R59
100k 100k 1000pF GND-A
GND
IC1 (3/3)
NJM4580V(TE2)
C34
0.01uF
EN1
R24 220
R25 220
R26 220
2
A
3
B
1
C
5
4
C19
0.0047uF
6 7
GND
C18
C17
0.0047uF 0.0047uF
AU-321
BOARD NO. 1-879-647-11
HDCU-300_AU-321_011_1
9-2
A
9-2
HSCU-300
CN-3080B
R5
10
1
R2
47k
1
2
JC1 SL1
0
NM
R6
10
R1
0
A-side B-side
R3
47k
001
GND
001
Prompter2(X)-out
001
GND
001
GND
001
001
PIX
WF
HD/SD-SYNC
1
R/R-Y
G/Y
B/B-Y
RCP/CNU
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
WF MODE
R10
0 NM
GND
4 2 5 7
PIX(X)-in
GND
GND
1
+
001
001
PROMPTER1 PROMPTER2
RY1
1
GND
CN2
Prompter1(X)-out
CN6
2
PROMPTER in
SC
WFM(X)-in
GND
PIX out
GND
8
CN1
0 NM
R11
CN7
2
WF out
GND
L1
10uH
D1
DAN222-TL
+5V
001
001
HD/SD-Sync(X)-in
GND
CN8
HD/SD-SYNC out
C1
10uF
GND
GND +5V
001
001
R8
47k
R/R-Y(X)-in
GND
001
Relay-(PIX_WFM)-in
R/R-Y out
GND
R12
4.7k
R7
47k
CN9
R9
47k
R4
47k
CN-3080B
001
001
G/Y(X)-in
GND
CN10
G/Y out
GND
R13
47k
001
B/B-Y(X)-in
GND
Q2
001
2SA1774TL-QR
Q1
Q3
2SC4617TL-QR 2SC4617TL-QR
GND
CN11
B/B-Y out
CN12
GND
RCP-COM-TX(Y)-in
RCP-COM-TX(X)-in
GND
RCP-COM-RX(Y)-out
RCP-COM-RX(X)-out
WFM-CONT(X)-in
Stair-case(G)-in
Stair-case(X)-in
GND
RCP-PIX(G)-in
RCP-PIX(X)-in
HD/SD-Sync(G)-in
HD/SD-Sync(X)-in
B/B-Y(G)-in
B/B-Y(X)-in
Y(G)-in
Y(X)-in
R/R-Y(G)-in
R/R-Y(X)-in
GND
Prompter2(G)-out
Prompter2(X)-out
Prompter1(G)-out
Prompter1(X)-out
GND
PIX(X)-in
PIX(G)-in
WFM(X)-in
WFM(G)-in
+5V
Relay-(PIX_WFM)-in
GND
+5V
RCP-COM-TX(Y)-in
RCP-COM-TX(X)-in
001
001
RCP-COM-RX(Y)-out
RCP-COM-RX(X)-out
WFM-CONT(X)-in
GND
Stair-case(X)-in
001
001
001
001
001
RCP-PIX(X)-in
GND
HD/SD-Sync(X)-in
GND
B/B-Y(X)-in
GND
G/Y(X)-in
GND
R/R-Y(X)-in
001
001
001
001
001
001
001
001
001
GND
Prompter2(X)-out
GND
Prompter1(X)-out
001
001
001
001
PIX(X)-in
GND
WFM(X)-in
GND
001
001
001
001
Relay-(PIX_WFM)-in
001
39 38 37 36 35 34
GND
GND
1
2
001
001
001
001
CN3
RCP-PWR(+30V)
GND
RCP-COM-TX(X)-in
RCP-COM-TX(Y)-in
RCP-COM-RX(X)-out
RCP-COM-RX(Y)-out
4 3
GND
EMI
IN OUT
GND
3
GND
FL1
2
FL2
EMI 2
IN OUT
GND
3
GND
FL4
2 EMI 1
OUT IN
GND
3
GND
FL5
2 EMI 1
OUT IN
GND
3
GND
1
C2
1000pF
001
WFM-CONT(X)-in
001
Stair-case(X)-in
001
GND
TX-RCP-DATA(X)
TX-RCP-DATA(Y)
RX-RCP-DATA(X)
RX-RCP-DATA(Y)
TX-GND
RCP-PWR-OUT
RCP-PWR-GND
(PIX)
1
2
3
4
5
6
7
8
CN5
SEQ CONT out(G)
SEQ CONT out(X)
Stair CASE out(X)
Stair CASE out(G)
1
2
3
4
RCP/CNU
LP1
9
GND
C3
1000pF
GND
RCP-PIX(X)-in
001
CN4
FL3
1 EMI 2
IN OUT
GND
3
FB1
4
WF MODE
5 6
GND
CN-3080B
GND
BOARD NO. 1-879-651-11

HDCU-300_CN-3080B_011_1
9-3
HSCU-300
9-3
E
CN-3081B (1/2)
CN-3081B (1/2)
INCOM/TALLY/PGM
2W i/o
2W i/o
WF-REMOTE
CN1
ENG-R(X)out
ENG-R(Y)out
ENG(G)
ENG-T(X)in
ENG-T(Y)in
PGM1(X)in
PGM1(Y)in
PGM1(G)
GND(AUX)
AUX3
R-TALLY(X)in
R-TALLY(Y)in
GND
PROD-R(X)out
PROD-R(Y)out
PROD(G)
PROD-T(X)in
PROD-T(Y)in
PGM2(X)in
PGM2(Y)in
PGM2(G)
AUX4(Y-TALLY(X)in)
AUX5(Y-TALLY(Y)in)
G-TALLY(X)in
G-TALLY(Y)in
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
FB1
C1
1000pF
2
3
C5
470pF
L2
1
4
2
3
C2
0.0022uF
C6
470pF
C10
0.0022uF
13
ENG-IN(X)-out
ENG-IN(Y)-out
a10
PGM1-IN(X)-out
PGM1-IN(Y)-out
a15
CN3
CN921
(80/135)
CN921
(79/135)
b10
b15
AUX3
RED-Tally-(X)-out
RED-Tally-(Y)-out
c8
e8
d8
CN921
(76/135)
CN921
(77/135)
CN921
(61/135)
CN921
(62/135)
Dsub15
15
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1
9
(Back-side-view)
CN921
(90/135)
CN921
(92/135)
CN921
(91/135)
NC
NC
Recall9(R+G+B)
NC
Recall2(G)
Recall3(B)
Recall1(R)
Recall4(SEQ)
GND
NC
NC
Recall5(ENC)
Recall6(R+B)
Recall7(R+G)
Recall8(G+B)
NM
JC410
C41
0.0022uF
C44
0.0022uF
C42
0.0022uF
FB4
PROD-R(X)
PROD-R(Y)
PROD-OUT(X)-in
PROD-OUT(Y)-in
e11
d11
PROD-T(X)
PROD-T(Y)
PROD-OUT(X)-out
PROD-OUT(Y)-out
a11
b11
CN921
(70/135)
CN921
(71/135)
PGM2(X)
PGM2(Y)
PGM2-IN(X)-out
PGM2-IN(Y)-out
e15
d15
CN921
(65/135)
CN921
(64/135)
YELLOW-Tally-(X)-out
YELLOW-Tally-(Y)-out
e6
d6
CN921
(104/135)
CN921
(103/135)
GREEN-Tally(X)-out
GREEN-Tally(Y)-out
a8
C47
0.0022uF
C7
470pF
2
3
C8
470pF
d5
CN921
(109/135)
WFM-Recall(2G)-in
WFM-Recall(3B)-in
d9
b9
CN921
(85/135)
CN921
(83/135)
WFM-Recall(1R)-in
WFM-Recall(4Q)-in
e9
a9
CN921
(86/135)
CN921
(82/135)
WFM-Recall(5E)-in
e7
CN921
(98/135)
WFM-Recall(6RB)-in
WFM-Recall(7RG)-in
WFM-Recall(8GB)-in
d7
b7
a7
CN921
(97/135)
CN921
(95/135)
CN921
(94/135)
C45
0.0022uF
GND
C48
0.0022uF
C43
0.0022uF
CN921
(74/135)
CN921
(73/135)
C46
0.0022uF
C49
0.0022uF
C12
1000pF
2
3
WFM-Recall(9add)-in
17 16
(Dsub-15P)
C13
0.0022uF
L4
1
4
Dsub25
ENG-T(X)
ENG-T(Y)
R-TALLY(X)
R-TALLY(Y)
L3
1
4
GND
e10
d10
PGM1(X)
PGM1(Y)
FB2
C4
1000pF
ENG-OUT(X)-in
ENG-OUT(Y)-in
C9
1000pF
L1
1
4
27 26
(Dsub-25P)
FB3
ENG-R(X)
ENG-R(Y)
GND
25
14
Y-TALLY(X)
Y-TALLY(Y)
C14
0.0022uF
(Back-side-view)
C3
0.0022uF
C11
0.0022uF
G-TALLY(X)
G-TALLY(Y)
b8
CN921
(88/135)
CN921
(89/135)
+5V
+5.5V
C15
0.0022uF
R61
10k
GND
C61
10uF
0.5A/24V
ADJ
GND
2
MIC REMOTE (WF-RMT)
CN2
+5.5V-out
TALLY(G)
G-TALLY-out
R-TALLY-out
MIC-GAIN2
MIC-GAIN1
MIC-GAIN0
MIC1-GAIN-CONT
GND
TALLY(COM_or_Y)-out
PreView-out
ASPECT-REM
ASPECT-CTL0
ASPECT-CTL1
MIC2-GAIN-CONT
+5.5V
C21
0.0022uF
C22
0.0022uF
C26
0.0022uF
C27
0.0022uF
C31
0.0022uF
R-TALLYout
MG2
MG1
C32
0.0022uF
MG0
C23
0.0022uF
MGC1
JC210
JC220
GND
8
15
COM-TALLYout
NM
C24
0.0022uF
C29
0.0022uF
9
(Back-side-view)
RED-TALLY-Rear-in
MIC-Gain-CTL(2)-out
MIC-Gain-CTL(1)-out
MIC-Gain-CTL(0)-out
MIC1-CTL-on/off-out
a17
c6
a6
b6
e20
d18
e18
a16
C30
0.0022uF
Y-TALLYout
Pre-view
ASPECT-REM
COM-TALLY-Rear-in
YELLOW-TALLY-Rear-in
Pre-View(rear)-out
Aspect-CTL-on/off-out
e17
d17
c20
d20
CN921
(53/135)
CN921
(52/135)
CN921
(33/135)
CN921
(34/135)
ASPECT0
ASPECT1
MGC2
C34
0.0022uF
Aspect-CTL(0)-out
Aspect-CTL(1)-out
MIC2-CTL-on/off-out
e16
d16
b16
R65
10k
+5V
L61
10uH
CN921
(101/135)
CN921
(35/135)
CN921
(46/135)
CN921
(47/135)
CN921
(55/135)
R64
10k
1 GND
GND
CN921
(49/135)
CN921
(102/135)
CN921
(100/135)
TRUNK-LINE
1
2
3
4
5
6
7
8
9
Dsub9
1
(Back-side-view)
C63
10uF
CN4
Frame-GND
TRUNK1(RY)-in
TRUNK1(TX)-out
COM-GND
GND
COM-GND
TRUNK1(RX)-in
TRUNK1(TY)-out
Frame-GND
(Dsub-9P)
C33
0.0022uF
1
C25
0.0022uF
Rear +5.5V
TALLY-GND
GREEN-TALLY-Rear-in
C28
0.0022uF
17 16
Dsub15
TALLY-GND
G-TALLYout
R63
10k
IC2 (3/3)
SN75179BPSR
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
C62
10uF
4
5
VDD
CE VOUT
GND
0.5A/24V
THP21
R62
10k
IC1
R1173H001D-T1-F
THP61
FL63
EMI 1
OUT IN
GND
3
FL62
1 EMI 2
IN OUT
GND
FL61
3
2 EMI 1
OUT IN
GND
3
2
11 10
FL64
1 EMI 2
IN OUT
GND
3
C64 VCC
10uF
GND
R71
22k
R66
10
R67
10
IC2(1/3)
SN75179BPSR
5
6
GND
R70
2.2k
GND
b24
CN921
(8/135)
TRUNK1(RX)-out
e24
CN921
(11/135)
IC2(2/3)
SN75179BPSR
R68
100
R72
22k
CN921
(59/135)
CN921
(58/135)
CN921
(56/135)
TRUNK1(TX)-in
R69
2.2k
8
7
R73
100
2
GND
GND
CN-3081B (1/2)
BOARD NO. 1-879-652-11
HDCU-300_CN-3081B_011_1
9-4
A
9-4
HSCU-300
CN-3081B (2/2)
CN5
+14V
GND
+14V
GND
+14V
GND
+14V
GND
1
2
3
4
5
6
7
8
0.5A/24V
THP101
7A
C101
470uF
25V
NM
C103
C102
470uF 470uF
25V
25V
NM
NM
IC101
NJM2387ADL3(TE2)
FB101
C104
470uF
25V
NM
FB102
C105
0.01uF
25V
C106
22uF
35V
R105
10k
3
VOUT1
6
VOUT2
2
4
CTL
VADJ
GND
5
CN-3081B (2/2)
100mA_200mA
VIN
R102
4.7k
R103
1.5k
C109 C110 C113

L101 10uF 10uF 10uF
10uH 25V 25V 25V
CN9
+12V
FAN1-ALARM-Status-in
GND
L102
10uH
C107
0.1uF
C108
47uF
16V
1
2
3
1
Q101
2SC4617TL-QR
+5.5V
R104
220
FAN1-ALARM-Status-out
R112
4.7k
10 9
C119
0.01uF
C123
10uF
R115
22k
GND
a22
b22
c22
d22
e22
e23
d23
e21
YELLOW-TALLY-Panel-in
GREEN-TALLY-Panel-in
RED-TALLY-Panel-in
CABLE-SHORT-LED-in
CABLE-OPEN-LED-in
CAM-POWER-LED-in
MAIN-Alarm-LED-in
Ether-LED-in
0.5A/24V
THP102
1
3
5
7
1
3
5
7
CN7
GND
Y-Tally-out
G-Tally-out
R-Tally-out
Short-LED-out
Open-LED-out
CAM-PW-LED-out
MAIN-ALR-LED-out
Ether-LED-out
GND
NC
14V
14V
NC
GND
RB101
470
2
4
6
8
2
4
6
8
RB102
470
FB103
FB104
1
2
3
C112
22uF D101
35V F1J6TP
CN6
RCP-PWR(+30V)
NC
GND
c18
c19
MODE0
MODE1
GND
2
RCP-POW-OK/NG-out
a23
CN921
(13/135)
Q102
2SC4617TL-QR
R119
22k
GND
GND
R120
22k
GND
C122
0.1uF
GND
16 17 18 19
Unreg (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg-Drive (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
a3
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
Unreg-GND
a1
b3
d3
e3
a4
b4
d4
e4
b1
c1
d1
e1
a2
b2
c2
d2
e2
R107
0
NM
R108
1k
3
R109
1k
C114
0.01uF
25V
R110
1k
C116
0.01uF
25V
R111
1k
C117
0.01uF
25V
C118
0.01uF
25V
R113
1k
C120
0.01uF
25V
R114
1k
C121
0.01uF
25V
12 11
CN921
(118/135)
CN921
(119/135)
CN921
(121/135)
CN921
(122/135)
CN921
(112/135)
CN921
(113/135)
CN921
(115/135)
CN921
(116/135)
CAM-POWER-ON/OFF-in
CAM-POWER-Status-out
Cable-OPEN-Status-out
Cable-SHORT-Status-out
POW-UNIT DC/AC-out
ANA1(TEMP-Level)-out
b5
d21
c21
b21
a21
c11
CN921
(107/135)
CN921
(28/135)
CN921
(27/135)
CN921
(26/135)
CN921
(25/135)
CN921
(72/135)
R117
0
GND
GND
CN921
(130/135)
CN921
(131/135)
CN921
(132/135)
CN921
(133/135)
CN921
(134/135)
CN921
(124/135)
CN921
(125/135)
CN921
(126/135)
CN921
(127/135)
CN921
(128/135)
CN921
(129/135)
CN921
(117/135)
CN921
(105/135)
CN921
(93/135)
CN921
(81/135)
CN921
(69/135)
CN921
(67/135)
CN921
(60/135)
CN921
(48/135)
CN921
(36/135)
CN921
(24/135)
CN921
(12/135)
144
132
120
108
96
84
72
60
48
36
24
12
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
R201
100
R202
100
NM
GND
E1
CN921
(45/135)
CN921
(39/135)
GND
R118
100k
1
2
5 4
A-side
NM
CN8
RCP-PWR(+30V)
GND
3
CN10
1 CAMERA-POWER-ON/OFF-out
2 CAMERA-POWER-Status-in
3
CABLE-OPEN-Status-in
4
CABLE-SHORT-Status-in
5
POW-UNIT DC/AC-in
R106
6
POWER-TEMPERATURE-in
1k
7
RCP-POW-OK/NG-in
8
Spare1
C111
0.01uF
9
Spare2
25V
10
GND
R101
0
L103
10uH
C115
0.1uF
50V
L104
10uH
GND
GND
GND
C124
10uF
R121
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
CN921
(15/135)
R116
100
GND
CN921
(19/135)
CN921
(20/135)
CN921
(21/135)
CN921
(22/135)
CN921
(23/135)
CN921
(17/135)
CN921
(16/135)
CN921
(29/135)
c23
GND
CN921
(135/135)
f1
SHIELD
CN921
(123/135)
f3
SHIELD
CN921
(111/135)
f5
SHIELD
CN921
(99/135)
f7
SHIELD
CN921
(87/135)
f9
SHIELD
CN921
(75/135)
f11
SHIELD
CN921
(68/135)
f13
SHIELD
CN921
(66/135)
f15
SHIELD
CN921
(54/135)
f17
SHIELD
CN921
(42/135)
f19
SHIELD
CN921
(30/135)
f21
SHIELD
CN921
(18/135)
f23
SHIELD
CN921
(6/135)
f25
SHIELD
CN921
(1/135)
CN921
(2/135)
CN921
(120/135)
CN921
(114/135)
CN921
(84/135)
CN921
(78/135)
CN921
(63/135)
CN921
(57/135)
CN921
(9/135)
CN921
(3/135)
CN921
(4/135)
CN921
(5/135)
a25
b25
c3
c4
c9
c10
c15
c16
c24
c25
d25
e25
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
CN921
(96/135)
CN921
(51/135)
c7
c17
CN921
(40/135)
CN921
(10/135)
CN921
(110/135)
CN921
(41/135)
d19
d24
e5
e19
(NC)
(NC)
CN921
(106/135)
CN921
(43/135)
CN921
(37/135)
CN921
(31/135)
CN921
(7/135)
CN921
(50/135)
CN921
(44/135)
CN921
(38/135)
CN921
(32/135)
CN921
(14/135)
a5
a18
a19
a20
a24
b17
b18
b19
b20
b23
TRIAX/Co-AX(BNC) -in
(SDI(X))
Rear -5.5V
GND
CN-3081B (2/2)
GND
BOARD NO. 1-879-652-11

HDCU-300_CN-3081B_011_2
9-5
HSCU-300
9-5
E
CN-3082, CN-3083
MIC1 (RTS1)
MIC1
CN1
(2/2) 7
GND
MIC1(X)OUT
4
5
FB1
CN-3082, CN-3083
FB7
C1
1000pF
FB8
GND
NM
MIC1(Y)OUT
FB2
C2
1000pF
MIC1,2
1mm,H,J5359
FB9
GND
NM
MIC1(G)OUT
MIC2(RTS2)
FB3
FB10
J5359
GND
EXT-MIC1(G)-in
EXT-MIC1(Y)-in
EXT-MIC1(X)-in
EXT-MIC2(G)-in
EXT-MIC2(Y)-in
EXT-MIC2(X)-in
C3
1000pF
MIC2
CN1
(1/2)
MIC2(X)OUT
FB4
GND
FB11
C4
1000pF
FB12
NM
GND
MIC2(Y)OUT
RTS1i/o(ENG)
RTS1i/o(PROD)
RTS1i/o(GND)
RTS2i/o(ENG)
RTS2i/o(PROD)
RTS2i/o(GND)
FB5
C5
1000pF
FB13
GND
MIC2(G)OUT
ANG
CN3
6
5
4
3
2
1
NM
FB6
FB14
C6
1000pF
GND
CN-3082
BOARD NO. 1-879-653-11
HDCU-300_CN-3082_011_1
1
4
1:Talk-Y
2:Talk-X
3:GND
4:Receive
5:PGM
L1
2
3
CN2
Incom-Talk(g)
Incom-Talk(x)
Incom-Talk(y)
Incom-GND
Incom-RCV(x)
Incom-RCV(y)
Incom-PGM(x)
Incom-PGM(y)
C1
470pF
CN1
1
2
FB2
FB3
5
4
FB4
6 3
FB1
NM
C2
1000pF
1
2
3
4
5
6
7
8
9 10
C3
1000pF
GND
CN-3083
BOARD NO. 1-879-654-11
HDCU-300_CN-3083_011_1
9-6
A
9-6
HSCU-300
DPR-300 (2/28)
DPR-300 (2/28)
CN101
CN101
a1
(1/135)
CN101
a2
(7/135)
CN101
(13/135) a3
CN101
(19/135) a4
CN101
(25/135) a5
CN101
(31/135) a6
CN101
(37/135) a7
CN101
(43/135) a8
CN101
(49/135) a9
CN101
(55/135) a10
CN101
(61/135) a11
CN101
(70/135)
CN101
(76/135)
CN101
(82/135)
CN101
(88/135)
CN101
(94/135)
CN101
(100/135)
CN101
(106/135)
CN101
(112/135)
CN101
(118/135)
CN101
(124/135)
CN101
(130/135)
a15
a16
a17
a18
a19
a20
a21
a22
a23
a24
a25
WFM0(X)_out
(HIRA-PIN)
FRONT-PIX(X)_if
(HIRA-PIN)
WFM(X)_out
ANA0-B/B-Y(X)_out
ANA0-G/Y(G)_out
028
B/B-Y(X)_out
027
GUARD GND for G/Y
GND-A
HD/SD-SYNC(X)_if
REAR_+5.5V
RCP-COM-RX(X)_if
RCP-COM-TX_if
GUARD-GND
HD/SD-SDI3.4_out(X)
HD/SD-SDI3.4_out(Y)
GUARD-GND
HD/SD-SDI1.2_out(X)
HD/SD-SDI1.2_out(Y)
CN101
b1
(2/135)
CN101
b2
(8/135)
CN101
b3
(14/135)
CN101
b4
(20/135)
CN101
b5
(26/135)
CN101
b6
(32/135)
CN101
b7
(38/135)
CN101
b8
(44/135)
CN101
b9
(50/135)
CN101
b10
(56/135)
CN101
b11
(62/135)
CN101
(71/135)
CN101
(77/135)
CN101
(83/135)
CN101
(89/135)
CN101
(95/135)
CN101
(101/135)
CN101
(107/135)
CN101
(113/135)
CN101
(119/135)
CN101
(125/135)
CN101
(131/135)
+5.5V_a
FB21
(500mA)
213mA@5.5V
SDI_3.4_OUT(X)
SDI_3.4_OUT(Y)
023
023
SDI_1.2_OUT(X)
SDI_1.2_OUT(Y)
023
023
b15
b16
b17
b18
b19
b20
b21
b22
b23
b24
b25
WFM0(G)_out
RELAY-(PIX.WFM)_out
FRONT-PIX(G)_if
(HIRA-PIN)
GUARD GND for WFM

RELAY-(PIX_WFM)
022
GND-A
ANA0-B/B-Y(G)_out
ANA0-G/Y(X)_out
GND-A
GUARD GND for B/B-Y

G/Y(X)_out
027
HD/SD-SYNC(G)_if
REAR_-5.5V
RCP-COM-RX(Y)_if
FB22
-5.5V_R
GURAD-GND
GUARD-GND
GUARD-GND
GUARD-GND
GUARD-GND
GUARD-GND
CN101
c1
(3/135)
CN101
c2
(9/135)
CN101
(15/135) c3
CN101
(21/135) c4
CN101
(27/135) c5
CN101
(33/135) c6
CN101
(39/135) c7
CN101
(45/135) c8
CN101
(51/135) c9
CN101
(57/135) c10
CN101
(63/135) c11
REAR-ALARM_in
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
MB-GND(ANA)
ANA0(DPR-LEVEL)_out
CN101
(72/135)
CN101
(78/135)
CN101
(84/135)
CN101
(90/135)
CN101
(96/135)
CN101
(102/135)
CN101
(108/135)
CN101
(114/135)
CN101
(120/135)
CN101
(126/135)
CN101
(132/135)
MB-GND(ANA)
MB-GND(ANA)
Rear_+14V
WFM-SEQ1-ON/OFF_out
(RESERVED)
WFM-STAIR-CASE_out
(RESERVED)
(RESERVED)
IRQ(TORINO&DAYTONA)
PLD-RECONFIG_in
PLD-CONF-DONE_out
c15
c16
c17
c18
c19
c20
c21
c22
c23
c24
c25
SDI-DIAG_NG/OK
004,020
GND-A
ANA0(DPR-LEVEL)_out 016
Rear_+14V(Unreg)
004
WFM-SEQ1-ON/OFF_out 028
SY_UT0
WFM-STAR-CASE(X)_out 026
SY_UT1
SY_UT2
IRQ_out
PLD-RECONFIG_in
PLD-CONF-DONE_out
007
007
007
CN101
(4/135)
CN101
(10/135)
CN101
(16/135)
CN101
(22/135)
CN101
(28/135)
CN101
(34/135)
CN101
(40/135)
CN101
(46/135)
CN101
(52/135)
CN101
(58/135)
CN101
(64/135)
d1
d2
d3
d4
d5
d6
d7
d8
d9
d10
d11
CN101
(73/135)
CN101
(79/135)
CN101
(85/135)
CN101
(91/135)
CN101
(97/135)
CN101
(103/135)
CN101
(109/135)
CN101
(115/135)
CN101
(121/135)
CN101
(127/135)
CN101
(133/135)
d15
VBS(X)_out
d16
d17 CHARGE-PUMP-SIGNAL_out
d18
d19
(RESERVED)
d20
GUARD-GND
d21
TONE1-DETECT_out
d22
d23
PROMPTER2(G)_in
d24
PROMPTER1(X)_in
d25
REAR-SEL1_out
PIX0(X)_out
PIX(X)_out
ANA0-R/R-Y(X)_out
028
R/R-Y(X)_out
027
VBS(X)_out
028
-12V-CHARGE-PUMP
020
SY_UT3
GND_(WFM-STAR-CASE)
026
PROMPTER2(G)_in
006
PROMPTER1(X)_in
006
REAR-SEL-B-HD/SD_out 020
GND-SDI
SY_UT
CN101
(5/135)
CN101
(11/135)
CN101
(17/135)
CN101
(23/135)
CN101
(29/135)
CN101
(35/135)
CN101
(41/135)
CN101
(47/135)
CN101
(53/135)
CN101
(59/135)
CN101
(65/135)
e1
e2
e3
e4
e5
e6
e7
e8
e9
e10
e11
CN101
(74/135)
CN101
(80/135)
CN101
(86/135)
CN101
(92/135)
CN101
(98/135)
CN101
(104/135)
CN101
(110/135)
CN101
(116/135)
CN101
(122/135)
CN101
(128/135)
CN101
(134/135)
e15
e16
e17
e18
e19
e20
e21
e22
e23
e24
e25
PIX0(G)_out
(HIRA-PIN)
(NC)
GND-A
ANA0-R/R-Y(G)_out
GND-A
VBS(G)_out
GND-A
RCP-PWR-NG-STATUS_if
GUARD GND for PIX
GUARD GND for R/R-Y
GUARD GND for VBS
RCP-PWR-NG-STATUS_if 020
TONE0-DETECT_out
TONE0-DETECT_out
PROMPTER2(X)_in
PROMPTER1(G)_in
REAR-SEL0_out
PROMPTER2(X)_in
006
PROMPTER1(G)_in
006
REAR-SEL-A-HD/SD_out 020
CN101
(6/135)
f1
SHIELD
CN101
(18/135)
f3
SHIELD
CN101
(30/135)
f5
SHIELD
CN101
(42/135)
f7
SHIELD
CN101
(54/135)
f9
SHIELD
CN101
(66/135)
f11
SHIELD
CN101
(68/135)
f13
SHIELD
CN101
(75/135)
f15
SHIELD
CN101
(87/135)
f17
SHIELD
CN101
(99/135)
f19
SHIELD
CN101
(111/135) f21
SHIELD
CN101
(123/135) f23
SHIELD
CN101
(135/135) f25
SHIELD
GND-A
015
020
(Analog)
CN101
(12/135)
CN101
(24/135)
CN101
(36/135)
CN101
(48/135)
CN101
(60/135)
CN101
(67/135)
CN101
(69/135)
CN101
(81/135)
CN101
(93/135)
CN101
(105/135)
CN101
(117/135)
CN101
(129/135)
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
12
24
36
48
60
72
84
96
108
120
132
144
(Digital)
CN102
b1
b2
b3
b4
b5
b6
b7
b8
b9
b10
b11
CN102
(71/135)
CN102
(77/135)
CN102
(83/135)
CN102
(89/135)
CN102
(95/135)
CN102
(101/135)
CN102
(107/135)
CN102
(113/135)
CN102
(119/135)
CN102
(125/135)
CN102
(131/135)
b15
b16
b17
b18
b19
b20
b21
b22
b23
b24
b25
HD-RET-Y5_in
HD-RET-Y9_in
HD-RET-C5_in
HD-RET-C9_in
HD-RET-Y5_in
HD-RET-Y9_in
HD-RET-C5_in
HD-RET-C9_in
HD-PROMPT-Y5_in
HD-PROMPT-Y_in5
HD-PROMPT-Y_in9
HD-PROMPT-C_in5
HD-PROMPT-C_in9
HD-PROMPT-Y9_in
HD-PROMPT-C5_in
HD-PROMPT-C9_in
SDA_in/out
SCL_in
BUS(3)_in
BUS(7)_in
CHARA-CK_in
CHARA-DATA_in
AUDIO-TX-LRCK_in
MB-GND(Digital)
CN102
(72/135)
CN102
(78/135)
CN102
(84/135)
CN102
(90/135)
CN102
(96/135)
CN102
(102/135)
CN102
(108/135)
CN102
(114/135)
CN102
(120/135)
CN102
(126/135)
CN102
(132/135)
SDA_in/out
SCL_in
BUS(3)_in
BUS(7)_in
CHARA-CK_in
CHARA-DATA_in
026
026
AUDIO-TX-LRCK_in
GND_URG
+14V(URG)
GUARD-GND
GUARD-GND
CN102
d1
(4/135)
CN102
(10/135) d2
CN102
(16/135) d3
CN102
(22/135) d4
CN102
(28/135) d5
CN102
(34/135) d6
CN102
(40/135) d7
CN102
(46/135) d8
CN102
(52/135) d9
CN102
(58/135) d10
CN102
(64/135) d11
GUARD-GND(MST-27CLK) 005
GUARD-GND(MST-74CLK) 005
TRUNK1(TX)_out
HD-RET-Y4_in
HD-RET-Y8_in
HD-RET-C4_in
HD-RET-C8_in
HD-PROMPT-Y4_in
TRUNK1(TX)_out
017
HD-RET-Y4_in
HD-RET-Y8_in
HD-RET-C4_in
HD-RET-C8_in
HD-PROMPT-Y_in4
HD-PROMPT-Y_in8
HD-PROMPT-C_in4
HD-PROMPT-C_in8
HD-PROMPT-Y8_in
HD-PROMPT-C4_in
HD-PROMPT-C8_in
ADDR(4)_in
ADDR(2)_in
BUS(2)_in
BUS(6)_in
CN102
(73/135)
CN102
(79/135)
CN102
(85/135)
CN102
(91/135)
CN102
(97/135)
CN102
(103/135)
CN102
(109/135)
CN102
(115/135)
CN102
(121/135)
CN102
(127/135)
CN102
(133/135)
ADDR(4)_in
ADDR(2)_in
BUS(2)_in
BUS(6)_in
AUDIO-TX-64FS_in
AUDIO-TX-64FS_in
MB-GND(Digital)
c15
c16
c17
c18
c19
c20
c21
c22
c23
c24
c25
d15
d16
d17
d18
d19
d20
d21
d22
d23
d24
d25
GUARD-GND
HD-RET-Y3_in
HD-RET-Y7_in
HD-RET-C3_in
HD-RET-C7_in
HD-PROMPT-Y3_in
MST-27M-CLK_in
MST-SD-F_in
005
020
GND-TRUNK
017
HD-RET-Y3_in
HD-RET-Y7_in
HD-RET-C3_in
HD-RET-C7_in
HD-PROMPT-Y_in3
ADDR(3)_in
ADDR(1)_in
BUS(1)_in
BUS(5)_in
AUDIO-RX56-INCOM_out
AUDIO-TX56-INCOM_in
MB-GND(Digital)
GND_URG
+14V(URG)
GUARD-GND
FRAME-RESET-GATE_in
CN102
(74/135)
CN102
(80/135)
CN102
(86/135)
CN102
(92/135)
CN102
(98/135)
CN102
(104/135)
CN102
(110/135)
CN102
(116/135)
CN102
(122/135)
CN102
(128/135)
CN102
(134/135)
HD-PROMPT-Y_in7
HD-PROMPT-C_in3
HD-PROMPT-C_in7
HD-PROMPT-Y7_in
HD-PROMPT-C3_in
HD-PROMPT-C7_in
ADDR(3)_in
ADDR(1)_in
BUS(1)_in
BUS(5)_in
AUDIO-RX56-INCOM_out 005
GUARD-GND(REF-SC)
FRAME-RESET-GATE_in 020
CN102
(5/135)
CN102
(11/135)
CN102
(17/135)
CN102
(23/135)
CN102
(29/135)
CN102
(35/135)
CN102
(41/135)
CN102
(47/135)
CN102
(53/135)
CN102
(59/135)
CN102
(65/135)
AUDIO-TX56-INCOM_in
e1
e2
e3
e4
e5
e6
e7
e8
e9
e10
e11
e15
e16
e17
e18
e19
e20
e21
e22
e23
e24
e25
GND_URG
+14V(URG-DRV)
EXTERNAL-REF-SC_in
EXTERNAL-REF-SYNC_in
TRUNK1(RX)_in
GUARD-GND
HD-RET-CLK_in
HD-RET-H_in
HD-RET-F_in
GUARD-GND
EXTERNAL-REF-SC_in 024
EXTERNAL-REF-SYNC_in 024
TRUNK1(RX)_in
007
HD-RET-H_in
HD-RET-F_in
HD-PROMPT-CLK_in
HD-PROMPT-H_in
HD-PROMPT-F_in
CPU-CK_in
MST-RESET_in
WR_in
RD_in
700P-RX-CAM-DATA_out
AUDIO-RX12-MIC_out
AUDIO-TX12-PGM_in
STBY-INCOM-RX(fr_CAM)
GUARD-GND(HD-Prom-CK) 005
HD-PROMPT-CLK_in
005
HD-PROMPT-H_in
HD-PROMPT-F_in
CPU-CK_in
MST-RESET_in
WR_in
RD_in
AUDIO-RX12-MIC_out
STBY-INCOM-RX(fr_CAM) 015
VCC
GND
+3.2V
R25
IC21
(1/2)
TC7SH08FU(T5RSOYJF) 10k
2
R21 4
1
100
HD-PROMPT-Y_in2
HD-PROMPT-Y_in6
HD-PROMPT-C_in2
HD-PROMPT-C_in6
CN102
(6/135)
f1
SHIELD
CN102
(18/135)
f3
SHIELD
CN102
(30/135)
f5
SHIELD
CN102
(42/135)
f7
SHIELD
CN102
(54/135)
f9
SHIELD
CN102
(66/135)
f11
SHIELD
CN102
(68/135)
f13
SHIELD
CN102
(75/135)
f15
SHIELD
CN102
(87/135)
f17
SHIELD
CN102
(99/135)
f19
SHIELD
CN102
(111/135) f21
SHIELD
CN102
(123/135) f23
SHIELD
CN102
(135/135) f25
SHIELD
GND
+3.2V
IC21
(2/2)
TC7SH08FU(T5RSOYJF)
C21
0.1uF
10V
VCC
GND
IC22
(2/2)
TC7SH08FU(T5RSOYJF)
C22
0.1uF
10V
GND
GND
R22
100
700P-RX
017
CMD_700P
011
IC22
(1/2)
TC7SH08FU(T5RSOYJF)
CS0_in
ADDR(0)_in
BUS(0)_in
BUS(4)_in
005
005
AUDIO-TX12-PGM_in
+3.2V
HD-RET-Y2_in
HD-RET-Y6_in
HD-RET-C2_in
HD-RET-C6_in
AUDIO-RX34-AES_out
024
HD-RET-Y2_in
HD-RET-Y6_in
HD-RET-C2_in
HD-RET-C6_in
HD-PROMPT-Y2_in
HD-PROMPT-Y6_in
HD-PROMPT-C2_in
HD-PROMPT-C6_in
CS0_in
ADDR(0)_in
BUS(0)_in
BUS(4)_in
700P-TX-CCU-DATA_in
AUDIO-RX34-AES_out
AUDIO-TX34-SPARE_in
STBY-INCOM-TX(to_CAM)
003
CN102
(2/135)
CN102
(8/135)
CN102
(14/135)
CN102
(20/135)
CN102
(26/135)
CN102
(32/135)
CN102
(38/135)
CN102
(44/135)
CN102
(50/135)
CN102
(56/135)
CN102
(62/135)
020
005
GND_URG
+14V(URG)
MST-27M-CLK_in
MST-SD-F_in
003
+14V(URG-DRV)
a15
a16
a17
a18
a19
a20
a21
a22
a23
a24
a25
MST-HD-F_in
MST-74M-CLK_in
CN102
c1
(3/135)
CN102
c2
(9/135)
CN102
(15/135) c3
CN102
(21/135) c4
CN102
(27/135) c5
CN102
(33/135) c6
CN102
(39/135) c7
CN102
(45/135) c8
CN102
(51/135) c9
CN102
(57/135) c10
CN102
(63/135) c11
CN102
(70/135)
CN102
(76/135)
CN102
(82/135)
CN102
(88/135)
CN102
(94/135)
CN102
(100/135)
CN102
(106/135)
CN102
(112/135)
CN102
(118/135)
CN102
(124/135)
CN102
(130/135)
GND_URG
+14V(URG)
MST-HD-F_in
MST-74M-CLK_in
003,004
CN102
a1
(1/135)
CN102
a2
(7/135)
CN102
(13/135) a3
CN102
(19/135) a4
CN102
(25/135) a5
CN102
(31/135) a6
CN102
(37/135) a7
CN102
(43/135) a8
CN102
(49/135) a9
CN102
(55/135) a10
CN102
(61/135) a11
GND_URG
+14V(URG)
2
1
R24
100
R23
100
R26
10k
CN102
(12/135)
CN102
(24/135)
CN102
(36/135)
CN102
(48/135)
CN102
(60/135)
CN102
(67/135)
CN102
(69/135)
CN102
(81/135)
CN102
(93/135)
CN102
(105/135)
CN102
(117/135)
CN102
(129/135)
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
12
24
36
48
60
72
84
96
108
120
132
144
GND
AUDIO-TX34-SPARE_in
STBY-INCOM-TX(to_CAM) 015
GND
HD-RET-Y/C_in
007,009
HD-PROMPT-Y/C_in
007
CPU_BUS
005
DPR-300 (2/28)
AUDIO-TX_in
005
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_2
*: DPR-300 (1/28) of schematic diagram is not described in this manual.
9-7
HSCU-300
9-7
E
DPR-300 (3/28)
DPR-300 (3/28)
0.5A/13.2V
002
+14V(URG-DRV)
THP301
FB326
1.3A
6x6
8
C328
22uF
25V
C375
0.1uF
50V
C367
22uF
25V
C304
0.1uF
50V
C327
22uF
25V
3225
C326
0.1uF
50V
R354
22k
IN
OUT
5
SHDN
4
NC
ADJ
1
2
(11.96V)
R355
100k
R358
47k
C305 22uF 25V
002
C388
10uF
25V
3225
C390
10uF
25V
3225
C306 22uF 25V
CL301
1.2
THP302
+14V(URG)
C396
10uF
25V
3225
C329
0.01uF
25V
R356
3.3k
(0.3mA)
R357
330
Unreg_a
2.5A/15V
+14V(URG)
C389
47uF
20V
(1.21V)
3
GND1
6
GND2
7
GND3
+12V +12V
CL303
1.2
IC302
LT1963ES8#TR
L301
10uH
GND-A
C3008 22uF 25V
11.96V=1.21(1+31.97k/3.63k)+0.003m*3.63k
C3009 22uF 25V
C3003
0.01uF
25V
GND-A
R366 100
C310 470pF R302 33k
(OK=5V)
C311 100pF
C3970.01uF
25V
IC311 (2/3)
NJM2903V(TE2)
R303 10k
R377
470k
R304
47k
NM
C312
0.0022uF R305
50V
12k
6 -
(COMP=2.9V)
C399
0.1uF
GND-A
(NG=1)
R306
470k
0.1uF
16V 3
FB303
FB304
C315
10uF
10V
FB306
C3004
0.0022uF
50V
NM
C3010
0.047uF
2012 50V
1/4W 1
R307
150k
L303
10uH
GND-A
+5.5V_a
C3005
C318 C319 47uF C320
47uF 47uF 10V 47uF
10V 10V
10V
C321
47uF
10V
FB311
FB312
FB313
FB314
Q302
S
1 2 3
+5.5V_a
C322 C3006
47uF
47uF C323
10V
10V 0.1uF
3225
3225 16V
C324
0.1uF
16V
C3002
10uF
10V
3216
2
1
R375
100
P-GND-A
PWR(5V-a)-NG/OK
IC305 (3/3) V+
NJM062V(TE2) V-
R327
220
R353
100
Q306
2SC4617TL-QR
C356
47uF
10V
3225
C355
0.1uF
16V
0.5A/13.2V
GND-A
Q304
2SC4672-T100-Q
R332
47k
R331
220
D304
UDZSUSTE-174.7B
FB319
C359
0.1uF
16V
C360
0.1uF
16V
FB:
0.02_0.12 ohm at DC
30 ohm at 100MHz
max1500mA
NM
C363
0.1uF
16V
R329
47k
C361 100pF
-5.5V_a
Q302
HAT2070R-EL
004
R330
47k
C357
100pF
C354
47uF
10V
3225
+5V
3
- 2
THP308
C353
0.1uF
16V
FB315
FB316
FB317
FB318
(OK=5V)
(NG=0)
R376
47k
R352
100
1.1A/6V
THP305
+5V
CL304
1.2
R328
47k
C358
100pF
FB320
5
GND-A
+2.5V/5mA(Max)
IC305 (2/3)
NJM062V(TE2)
+5.5V_a
THP306
C325
0.1uF
16V
GND-A
Q303
2SA1615-Z-E2
+5.5V/1.2A(Max)
CL302
1.2
+5.5V_a
C317
0.1uF
16V
8 7 6 5
4
R308
C316
0.1uF
16V
1 2 3
FB305
3225
GND-A
16V
4
16
RUN/SS BOOST
15
TG
PGOOD
14
SW
VRNG
13
FCB
PGND
12
BG
ITH
11
SGND INTVCC
10
ION
VIN
9
VFB
EXTVCC
1.267MHz = 5.5V/(0.7V*620k*10pF)
C398 0.1uF
16V
5.52V = 0.8V(1+59k/10k)
R309 2.2
R378
100k
IC312
TC7SH00FU(T5RSOYJF)
1
2
3
4
5
6
7
8
NM
FB329
[out puts]
+5V(Analog/Rear)
-5V(Analog)
-5V(Rear)
+3.3V
+1.2V
+12V
100k
16V
Q301
S HAT2070R-EL
E2
GND
3
C309
0.1uF
IC311 (1/3)
NJM2903V(TE2)
R350
22k
VIN VOUT
8 7 6 5
C313
RB706F-40
IC301
0.1uF
LTC1778EGN 16V C314 1 D302
R367
R301
47k
(URA)
E1
+2.5V-REF
1
(INTVCC=5V)
Analog_P.S.
+5.5V/-5.5V
+3.8V
1M
NM
242k:1.28MHz
320k:979kHz
2SC4617TL-QR
R373
Q305
R351
22k
D301
RB160L-40TE25
8
4
R359
10k
2 -
R372
10k
GND-A
R374
1M
R371
0
V+
GND
22uF 25V
(URA)
IC306
ADR381ARTZ-REEL7
R326
0
FB301
FB302
R349
10k
(3/3) IC311
NJM2903V(TE2)
C382
0.1uF
50V
2012
C308
(URG=16.4V)
D305
UDZSUSTE-174.7B
22uF 25V
FB330
GND_URG
C307
FB307
FB308
FB309
FB310
002,004
C301
C302
C303
4.7uF 0.01uF 0.01uF
25V
25V
25V
GND-A
C364
0.1uF
16V
- 6
C362
1uF
6.3V
R333
47k
IC305 (1/3)
NJM062V(TE2)
C365
47uF
10V
CL305
1.2
C366
47uF
10V
-5V
-5V
(NG=1)
Q309
DTC144EE-TL
FB331
C3001
470pF
GND-A
NM
GND-A
GND-A
+3.3V-A
0.5A/13.2V
+5.5V_a
THP303
0.5A/13.2V
5
4
VIN
SW
THP307
R311
22k
C333
220pF
SHDN
NFB
GND
2
C331
1uF
25V
3216
C376
10uF R370
10V 22k
3216
R314
10k
R312
1k
R310
2.2
3225
L305
10uH
C332 470pF
D303
RB160M-60TR
4.98V-1.255V = R1(1.255/R2 + 4x10**(-3))
= R1(0.1255+0.004)
= 28.8*(0.1295)
5
4
C334
47uF GND-A
10V
R313
10k
Q308
DTC144EE-TL
IC309
L307
LT1931ES5#TR 10uH
Q310
DTC144EE-TL
C346
0.1uF
16V
VIN
SW
R345
22k
C379
220pF
SHDN
NFB
GND
2
C377
1uF
25V
3216
C378 470pF
D307
RB160M-60TR
-5.5V_a
IC308
R1173H001D-T1-F
R338
4.7
(1/4W)
3225
(MAX 200mA)
R348
10k
R339 2.2k
R346
1k
R344
2.2
3225
R347
10k
L308
10uH
C381
0.1uF
16V
C380
47uF GND-A
10V
C374
4.7uF
6.3V
C373
47uF
6.3V
3216
ADJ
GND
2
IC310
R1173H001D-T1-F
R360
4.7
1.1A/6V
THP304
C350
680pF
16V
GND-A
R325 R318
4.7M 4.7M
C351
100pF
GND-A
R322
3.3k
R321
10k
R324
22k
GND-A
R323
220k
(NG=1)
C352
470pF
Q307
DTC144EE-TL
C336
47uF
10V
3225
C349 22pF
R316 3.3k
R317 47k
IC304
LTC3412EFE#TR
1
2
3
4
5
6
7
8
SVIN
PVIN2
PGOOD
SW4
ITH
SW3
VFB
PGND2
RT
PGND1
SYNC/MODE SW2
RUN/SS
SW1
SGND
PVIN1
NC(TM)
17
C337
10uF
10V
3216
C385
10uF
6.3V
16
15
14
13
12
11
10
9
C342 C343 C344

L306
47uF 47uF 47uF
FB323
10uH (1.3A)
10V 6.3V 6.3V
C341
B B 10uF
10V
C338 680pF
B
3216 3225 3216 3216 FB324
3225
R315 2.2
C339
47uF
10V
3225
C345
0.1uF
10V
G-GND
C386
10uF
6.3V
DC-DC(IC301)
SL3
+1.2V-L_B
CL309 +1.2V-LLVC_B
1.2
D308
RSX101VA-30TR
4
VDD
5
CE VOUT
C391
4.7uF
1608
ADJ
GND
2
R362
10k
GND
R363
22k
GND
C392
0.1uF
16V
C394
10uF
6.3V
C395
10uF
6.3V
FG-4
FG1
FG2
FG5
(DIGITAL_GND)
DIGITAL
GND
+3.3V-A
CL306
1.2
IC307
R1173H001D-T1-F
C347
47uF
6.3V
3216
SC
ANALOG
+3.8V
(+3.8V)
FG-3
(D:2mm)
C393
47uF
6.3V
R364
2.2k
CL308
1.2
SC
SL4
R365
10k
(1.0V)
C335
0.1uF
16V
GND-A
FB322
G-GND
16V
GND-A
C384
47uF
6.3V
(1.2066V)
C387
47uF
6.3V
3216
+5.5V_a
FB321
GND-A
G-GND
(DIGITAL_GND)
R361 2.2k
C348
0.1uF
NM
NM
GND-A
C3007
0.1uF
C383
0.1uF
16V
R341
22k
G-GND
FB333
R342
2.2k
(1/4W)
3225
(MAX 200mA)
R320
22k
(1.0V)
GND-A
FB335
R343
10k
NM
G-GND
GND
(NG=1)
R319
22k
R340
10k
-5.5V_R
5.53V-1.255V = 0.1295*R1
= 0.1295*33
PWR(+3.8V)-NG/OK
D306
RSX101VA-30TR
(1.2066V)
4.98V-1.255V = R1(1.255/R2 + 4x10**(-3))

= R1(0.1255+0.004)
= 28.8*(0.1295)
5.53V-1.255V = 0.1295*R1
= 0.1295*33
004
4
3
VDD
5
CE VOUT
+1.2V-L_A
CL307
1.2 +1.2V-LLVC_A
G-GND
FB332
NM
GND-A
+5.5V_a
IC303
L304
LT1931ES5#TR 10uH
C330 R369
10uF 22k
10V
3216
FB334
FG4
FG3
+3.3V-A
(3.299V)
3
FB325
C368
4.7uF
1608
GND-A
C340
10uF
10V
3216
4
VDD
5
CE VOUT
ADJ
GND
2
R334
47k
R337
47k
1
(1.0V)
R335
10k
C369
0.1uF
16V
C370
47uF
6.3V
C371
10uF
6.3V
C372
10uF
6.3V
R336
220
GND-A
3.826V = 0.8V(1+50.3k/13.3k)
242k:1.28MHz
330k:950kHz
DPR-300 (3/28)
BOARD NO. 1-879-649-11
GND-A
HDCU-300_DPR-300_011_3
9-8
A
9-8
HSCU-300
DPR-300 (4/28)
Each OUT-PUTs:Open-drain
C404 22uF 25V
C406 22uF 25V
002,020
SDI-DIAG_NG/OK
R482 100
R416
22k
R483 100
C408
0.1uF
16V
IC417 (1/3)
NJM2903V(TE2)
(OK=5V)
R401
47k
1
2
3
4
5
6
7
8
C410 100pF
C499 0.01uF
25V
IC417 (2/3)
NJM2903V(TE2)
+
R403 10k
4
FB405
FB411(1.5A)
FB412
FB413
FB414
2529mA@5.5V(-03)
Q401
S HAT2070R-EL
1 2 3
L402
10uH
C414
10uF
10V
FB406
R408
C415
0.1uF
16V
8 7 6 5
1/4W 1
C4061
0.047uF
2012 50V
Q402
C4056
0.0022uF
50V
NM
1.267MHz = 5.5V/(0.7V*620k*10pF)
C4001 0.1uF
16V
C4038
C417 C418 C4057
C419
47uF 47uF
47uF 47uF 47uF
10V 10V 10V
10V 10V
C420
47uF
10V
Q411
DTC144EE-TL
+5.5V
S
1 2 3
C416
0.1uF
16V
C425
0.1uF
+3.2V
C421 C4058
47uF 47uF
10V 10V
3225 3225
C422
0.1uF
16V
C4008 C4009 C4010 C4011

10uF
10uF
10uF
10uF
6.3V
6.3V
6.3V
6.3V
C4041
10uF
10V
3216
C423
0.1uF
16V
+2.5V
FB415
FB416
FB417
FB418
GND
25V
4
(NG=1)
2
1
3
GND
R412
100
PWR(5.5V)-NG/OK
NM
R413
47k
5.5V-NG-N
(OK=5V)
(NG=0V)
004
C446
100pF
C447
680pF
GND
FB:
0.02_0.12 ohm at DC
30 ohm at 100MHz
max1500mA
E7
(URA)
(URA)
E8
E9
GND
R432
680
R431
15k
R434
100k
R433
220k
1
2
3
4
5
6
7
8
GND
R410
22k
5
4
VIN
SW
C4025
220pF
SHDN
NFB
GND
2 C4021
1uF
25V
3216
R492
10k
R474
22k
R490
1k
R486
2.2
3225
R491
10k
L408
10uH
Q414
DTC144EE-TL
(+2.2V@1A)
C4026
0.1uF
16V
D403
C4022
RB160M-60TR 470pF
C4004
10uF
6.3V
C4027
47uF GND
10V
-5.5V_D
IN
OUT
5
SHDN
4
NC
ADJ
3
GND1
6
GND2
7
GND3
C4016
10uF
10V
3216
R471
0.22
3225
(1/4W)
R489
22k
+1.8V
CL409
1.2
IC410
LT1963ES8#TR
dV = 0.7V
Pd = 0.7W
dT = 49'C
1
2
+1.5V
THP407
+1.8V
C494
47uF
6.3V
3216
R476
47k
(1.21V)
C4005
10uF
6.3V
1608
R478
6.8k
VDD
5
CE VOUT
CL408
1.2
GND
GND
R447
3.3k
R446
15k
R449
100k
R448
220k
R466 220
C497
47uF
6.3V
3216
C496
4.7uF
R4011
10k
Q413
DTC144EE-TL
dV = 0.5V
Pd = 0.5*0.6
=300mW
R453 22k
NM
R454 22k
+2.5V/5mA(Max)
GND
1.1A/6V
THP409
C4017
0.1uF
16V
IC411 (3/3) V+
NJM062V(TE2) V-
C4018
0.1uF
16V
THP410
-5.5V_D
D404
UDZSUSTE-174.7B
R487
220
1
C4019
47uF
10V
3225
C4020
47uF
10V
3225
C4023
100pF
3
C4029
0.1uF
- 2 16V
R494
47k
R496
47k
C4032
0.1uF
16V
C4033
47uF
10V
5
- 6
R488
220
D405
UDZSUSTE-174.7B
028
C4031
1uF
6.3V
R497
47k
for
DA_OUT Amp(AD8014x6)
STAIR_CASE_OUT Amp(NJM4560x1)
Prompter_INPUT Tr-drive
GND
C4035
47uF
10V
C4034
0.1uF
16V
PWR
2SA1774TL-QR
Q407
+5V-D
R4005
10k
(ON=0V) 100k
IC418
TC7SH00FU(T5RSOYJF)
C4037
0.1uF
16V
Q415
2SC4617TL-QR
R4010
10k
R498
10k
GND
R4006
10k
GND
Q410
2SC4617TL-QR
C492
1000pF
PWR(LV)-NG/OK
GND
GND
+3.2V
IC415
R3112N281A-TR-FA
-5V-D
-5V-D
Q408
2SC4617TL-QR
R499
10k
R4001
22k
NC
2
VDD
1
OUT
CD
IC416
R3112N281A-TR-FA
DAY_PLL33_P-ON-p
009,018
GND
3
+1.5V
FB436
(1.5A)
C476
47uF GND
6.3V
3216
4
C4054
0.01uF
NC
2
VDD
1
OUT
CD
GND
3
R4024
22k
GND
220k
R435
1M
R4025
1k
GND
R461
10k
C483
10uF FB437
10V
3216
C484
22uF
16V
3225
R462
0
+1.2V
GND
CL403
0.8
+1.2V
FB438
L401
(1.200V) FB439
4.7uH
(1.6A)
GND
1.1A/6V +5.5V
THP406
C489
22uF
16V
3225
C490
47uF
6.3V
3216
FB440
FB441
R460 C481 C485 C486 C487 C488

2.2 680pF 0.1uF 10uF 47uF 22uF
3225
10V 6.3V 6.3V
3216 3216 2012
C491
22uF
6.3V
2012
GND
GND
C4043
22pF
R4022
10k
C4044
10uF FB442
10V
3216
C4045
22uF
16V
3225
GND
1.1A/6V +5.5V
THP412
C4050
22uF
16V
3225
R4023
0
+1.2V_DAY
GND
CL407
0.8
+1.2V_DAY
FB443
L406
4.7uH
(1.6A)
(1.237V) FB444
C4051 C4052
22uF
47uF
6.3V
6.3V
2012
3216
FB445
FB446
R4021 C4039
2.2 680pF C4046 C4047C4048 C4049
0.1uF 10uF 47uF 22uF
3225
10V 6.3V 6.3V
3216 3216 2012
GND
GND
(ON:Lo)
+5.5V
5
C4055
0.022uF
C4053 VCC
0.1uF
10V GND
(DELAY:100mS)
GND
R436
1M
IC414 (1/2)
TC7SH00FU(T5RSOYJF)
2
1
C482
22pF
IC407
+5.5V
(DELAY:50mS)
GND
C4002
47pF
242k:1.28MHz
330k:950kHz
R4017 R4019
FB447
CL411
1.2
C469
47uF
10V
3225
C471
0.1uF
16V
+1.5V
CL406
1.2
C40030.1uF
004
Q406
2SC4617TL-QR
GND
GND
GND
C473 C474 C475

(2.7A)
47uF 47uF 47uF FB433 (1.5A)
L405
10V 6.3V 6.3V
1uH (1.521V) 3225 3216 3216
R452 2.2
C472
FB434
10uF
(1.5A)
10V
3225
3216
FB435 (1.5A)
C470 680pF
C480 0.1uF
C493 10pF
R4018
R4012
3.3k
15k
R464 22k
1.2V x103% =1.236V
NM
1.237V = 0.8V(1+10k/18.3k)
@43.71uA
R465 22k
R4008
100
C461
0.1uF
16V
IC407
LTC3411EMS#TR
R463
22
VDD_DAY_CORE_NG/OK
R4007
2.2k
GND
R414
1M
GND
100k
IC411 (1/3)
NJM062V(TE2)
220k
R426
1M
D406
SML-D12M8WT86SM
R4009
10k
0.5A/13.2V
Q405
2SC4672-T100-Q
020
C426
0.1uF
10V
GND
R495
47k
C4024100pF
(NG=0V)
+5V-D
+2.5V
FB432
C467
10uF
10V
3216
IC405
GND
242k:1.28MHz
330k:950kHz
R456 R458
R493
47k
C4030
100pF
C4028
0.1uF
16V
GND
+5.5V
2
1
5.5V-NG-N
004
PS-EN-n
R4013
22k
+5V-D
CL410
1.2
IC411 (2/3)
NJM062V(TE2)
+5.5V
R4026
22k
GND
C479
47pF
C477
1000pF
R4004
47k
R4003
22k
Q409
2SC4617TL-QR
C460
47uF
10V
3225
C468
10uF
10V
3216
C478 10pF
R455
R457
10k
10k
1.200V = 0.8V(1+10k/20k)
GND
R4002
22k
+5.5V
1.1A/6V
THP405
16
15
14
13
12
11
10
9
R459
4.7M
near to CN701
GND
3
Q404
2SA1797-T100-Q
C459
47uF GND
6.3V
3216
IC414
DPR-300 (4/28)
C4036
0.1uF
16V
+2.5V
IC405
LTC3411EMS#TR
near to IC1101
IC408
ADR381ARTZ-REEL7
VIN VOUT
2
+2.5V
CL405
1.2
FB431
(1.5A)
GND
GND
+5.5V
SVIN
PVIN2
PGOOD
SW4
ITH
SW3
VFB
PGND2
RT
PGND1
SYNC/MODE SW2
RUN/SS
SW1
SGND
PVIN1
NC(TM)
17
C464
470pF
(NG=1)
5.53V-1.255V = 0.1295*R1
= 0.1295*33
+5.5V
C454
0.1uF
16V
C452
10uF
10V
3216
IC404
LTC3412EFE#TR
1
2
3
4
5
6
7
8
+1.0V
(1.022V)
1
ADJ (1.0V)
GND
2
C495
4.7uF
C4006
10uF
6.3V
1608
GND
1.829V = 1.21V(1+8.2456k/16.8k)+0.003m*8.2456k
4.98V-1.255V = R1(1.255/R2 + 4x10**(-3))

= R1(0.1255+0.004)
= 28.8*(0.1295)
GND
GND
C456 C457 C458

(2.7A)
47uF 47uF 47uF FB428 (1.5A)
L404
10V 6.3V 6.3V
1uH (2.535V) 3225 3216 3216
R439 2.2
C455
FB429
10uF
(1.5A)
10V
C451 680pF
3216
FB430 (1.5A)
3225
C463 22pF
R441 1.5k
R442 15k
GND
R444 R443
4.7M 4.7M
C466
100pF
C465
680pF
+1.0V
IC409
4 R1173H001D-T1-F
R477
10k
C444
0.1uF
16V
1.521V = 0.8V(1+16.5k/18.3k)
R445
22k
1.1A/6V
(1.829V)
R475
10k
+5.5V
GND
C462
0.1uF
+2.5V
C443
47uF
10V
3225
C453
47uF
10V
3225
+3.2V
C442
47uF GND
6.3V
3216
1.1A/6V
THP404
16
15
14
13
12
11
10
9
+3.2V
CL404
1.2
FB426
(1.5A)
GND
004
IC412
L407
LT1931ES5#TR 10uH
SVIN
PVIN2
PGOOD
SW4
ITH
SW3
VFB
PGND2
RT
PGND1
SYNC/MODE SW2
RUN/SS
SW1
SGND
PVIN1
NC(TM)
17
C448
470pF
R440
22k
0.5A/13.2V
THP408
C435
0.1uF
16V
FB427
C450
10uF
10V
3216
C449 22pF
R438 33k
Q412
DTC144EE-TL
GND
+5.5V
B B C433
47uF
10V
3225
C432
10uF
10V
3216
IC403
LTC3412EFE#TR
R430
22k
C4012 C4013 C4014 C4015

10uF
10uF
10uF
10uF
6.3V
6.3V
6.3V
6.3V
GND
E5
R437 1k
C441
THP411 0.1uF
16V
GND
GND
C437
47uF C438 C439
(2.7A)
10V 47uF 47uF FB423 (1.5A)
L403
B
6.3V
6.3V
1uH (3.239V) 3225 3216 3216
R425 2.2
C436
FB424
(1.5A)
B 10uF
10V
3225 B
3216
C434 680pF
FB425 (1.5A)
2.535V = 0.8V(1+34k/15.68k)
GND
R428 R427
4.7M 4.7M
R429
22k
GND
E4
Q402
HAT2070R-EL
GND
GND
C445
0.1uF
R409 2.2
(Digital_GND)
16
15
14
13
12
11
10
9
C440
47uF
10V
3225
CL402
1.2
+5.5V
P-GND
+5.5V
R422 4.7M
FB402
FB403
FB404
FB401
8 7 6 5
C424
0.1uF
16V
GND
220k
242k:1.28MHz
330k:950kHz
SVIN
PVIN2
PGOOD
SW4
ITH
SW3
VFB
PGND2
RT
PGND1
SYNC/MODE SW2
RUN/SS
SW1
SGND
PVIN1
NC(TM)
17
C430
470pF
3225
(NG=0V)
(OK=5V)
IC406
TC7SH00FU(T5RSOYJF)
R421
22k
R418
15k
R420
(6.7A)
R407
150k
5.52V = 0.8V(1+59k/10k)
GND
0.1uF
16V 3
16
RUN/SS BOOST
15
TG
PGOOD
14
VRNG
SW
13
FCB
PGND
12
ITH
BG
11
SGND INTVCC
10
ION
VIN
9
VFB
EXTVCC
R406
470k
R404
47k
NM
C411
0.0022uF R405
50V
12k
2 -
R450
100k
R419
1.5k
1
2
3
4
5
6
7
8
(INTVCC=5V)
RB706F-40
C412
IC401
0.1uF
LTC1778EGN 16V C413 1 D402
R473
100k
NM
R472 100
C409 470pF R402 33k
C4042
0.01uF
25V
GND
242k:1.28MHz
320k:979kHz
1M
R470
22k
C429
100pF
FB422
C431
10uF
10V
3216
IC402
LTC3412EFE#TR
R415
4.7M
R417
22k
C428
680pF
GND
2SC4617TL-QR
R4020
Q403
6 R468
22k
(COMP=2.9V)
PWR(LV)-NG/OK
+5.5V
THP403
3.239V = 0.8V(1+50.3k/16.5k)
C427
0.1uF
C4007
22pF
GND
R423 3.3k
R424 47k
to ANALOG FPGA
PWR-NG/OK-STUS
024
R484 10
10
9
8
7
6
R411
470k
004
D401
RB160L-40TE25
R4014
0
GND
C4060 22uF 25V
R481 100
GND
R4016
1M
R469
10k
R4015
10k
PWR(5.5V)-NG/OK
FB407
FB408
FB409
FB410
R467
10k
V+
GND
004
1.1A/6V
R485
10k
(URG=16.4V)
D407
UDZSUSTE-174.7B
IC417
(3/3)
NJM2903V(TE2)
C4059 22uF 25V
+3.2V
R480 100
C407 22uF 25V
FB421
FB419
FB:
0.02_0.12 ohm at DC
30 ohm at 100MHz
max1500mA
FB420
GND_URG
PWR(+3.8V)-NG/OK
10
9
8
7
6
C401
4.7uF C402
C403
25V 0.01uF 0.01uF
25V
25V
002,003
C498
0.1uF
50V
2012
C405 22uF 25V
003
R479 100
SHDN/RT ITH
SYNC/MODE VFB
SGND
PGOOD
SW
SVIN
PGND
PVIN
2.5A/15V
THP401
-->>22uF/25V
PWR(5V-a)-NG/OK
SHDN/RT ITH
SYNC/MODE VFB
SGND
PGOOD
SW
SVIN
PGND
PVIN
+14V(URG)
Unreg
CL401
1.2
003
1
2
3
4
5
002
0.5A/13.2V
THP402
1
2
3
4
5
Rear_+14V(Unreg)
DPR-300 (4/28)
GND
GND (2/2)
TC7SH00FU(T5RSOYJF)
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_4
9-9
HSCU-300
9-9
E
R513
470
12
FBOUT
007
009
74M-CLK-FPGA-MAP
74M-CLK-DAYTONA-RET
RB509
100k
RB507
100k
MST HD-F FF(near CN)

RET-Y/C/F/H FF(near CN)
74M-CLK-FF
2
MAIN
DEMUX
1
3
5
7
1
3
5
7
BUS(0)_in
BUS(1)_in
BUS(2)_in
BUS(3)_in
BUS(4)_in
BUS(5)_in
BUS(6)_in
BUS(7)_in
GND
DAYTONA
MAIN DEC
IC507
TC74VHC245FT(EKJ)
FB504
C513
0.1uF
RB510
220
2
3
4
5
6
7
8
9
2
4
6
8
2
4
6
8
RB511
220
PROCYON
20
VCC
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
PLL
18
17
16
15
14
13
12
11
B1
B2
B3
B4
B5
B6
B7
B8
1
3
5
7
1
3
5
7
007,011,017,020,022,024,025
2
4
6
8
2
4
6
8
CPU-D0
CPU-D1
CPU-D2
CPU-D3
CPU-D4
CPU-D5
CPU-D6
CPU-D7
RB516
47
GND
10
+3.2V
DAYTONA
RET ENC
CS0
CPU-RD
+3.2V
FF
IC508
2
4
6
8
2
4
6
8
IC503
CDCVF2505PWR
R553
22
from MB
HD-PROMPT-CLK_in
002
002 GUARD-GND(HD-Prom-CK)
C531 0.1uF
1
R555
2.2k
R554
0
GND
6
VDD3.3V
CLKIN CLKOUT
1Y0
1Y1
1Y2
1Y3
GND
4
GND
8
3
2
5
7
R565
R566
R556
R567
10
CLK-VIDEO-TRUNK_1
CLK-VIDEO-TRUNK_2
10
10 CL502
10 1.2
007
007
C514
0.1uF
FPGA(MAP)
VIDEO-TRUNK-Y/C/F/H FF(near CN)
RB513
220
2
3
4
5
6
7
8
9
2
4
6
8
2
4
6
8
RB514
220
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
20
VCC
18
17
16
15
14
13
12
11
B1
B2
B3
B4
B5
B6
B7
B8
GND
GND
1
3
5
7
1
3
5
7
RB517
47
2
4
6
8
2
4
6
8
CPU-A0
CPU-A1
CPU-A2
CPU-A3
CPU-A4
CS0
IC517 (2/2)
IC519 (2/2)
TC7SZ08FU(TE85R) TC7SZ08FU(TE85R)
+3.2V
RB518
47
MST-27M
R518
100
R521
10k
R519
0
R523
470
24
CLK
13
FBIN
12
C532
10pF
NM
GNDNM
R522
1k
FBOUT
27M-CLK-FPGA-MAP
27M-CLK-PROMPTER
27M-CLK-SDI
023
GENNUM SDI
27M-CLK-PROCYON
27M-CLK-FPGA-POST
27M-CLK-FPGA-ANALOG
27M-CLK-ENCODER
27M-CLK-DA-COMPOSITE
022
020
020,024
026
028
PROCYON
FPGA(POST)
FPGA(ANALOG)
ENCODER(CXD9184)
THS5661 D/A for COMPOSITE OUT
RB519
100k
1
3
5
7
WR_in
RD_in
MST-RESET_in
RB520
220
2
3
4
5
6
7
8
9
2
4
6
8
+3.2V
R558
47k
R559
47
RB503
220
2
4
6
8
100
1
3
5
7
2
4
6
8
RB504
220
017
AUDIO-RX
2
3
4
5
6
7
8
9
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
20
VCC
C510
0.1uF
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
to FPGA-DEMUX(LRCK,64FS)
to FPGA-MAP
GND
RB505
47
1
3
5
7
1
3
5
7
AUDIO-TX
2
4
6
8
2
4
6
8
AU-TX12-PGM
AU-TX34-SPARE
AU-TX56-INCOM
AU-TX-64FS
AU-TX-LRCK
007,017
FB503
5
GND
to MB
C518
0.1uF
2
VDD
1
OUT
GND
R505
22
NC
CD
GND
3
1
3
5
7
020
CP-CLK_3
017
CP-CLK_4
007
4
R572
10
CP-CLK_5
022
IC523 (2/2)
IC515 (2/2)
IC518 (2/2)
TC7SZ08FU(TE85R) TC7SZ08FU(TE85R) TC7SZ08FU(TE85R)
RB521
47
2
4
6
8
CPU-WR
CPU-RD
+2.5V
+3.2V
VCC
GND
C541
0.1uF
GND
100
R539
R544
R540
47k
2
1
100
GND
+3.2V
C526
0.1uF
VCC
GND
C528
0.1uF
GND
013,014
CXD1968*6
007,009,011,017,018
TORINO
DAYTONA RET ENC
CAFE-T
DAYTONA MAIN DEC
FPGA MAP
FPGA DEMUX
020,022,024,026
ZXCV(RST,TRST)
SD CHAR GEN
ENCODER
FPGA POST
FPGA ANALOG
DPR-RESET_1
025
CXD9186(HBF)
PROCYON_PLL_RST
022
RESET_1968
DPR-RESET_2
100
R541
100
DPR-RESET_3
+2.5V
C521
C520
0.01uF 0.01uF
+3.2V
(0.02uF-> 90mS)
4.49 x C(uF)[S]
C522
0.1uF
VCC
GND
TC7SZ08FU(TE85R)
R574
R576
47k 2
100
4
1
IC524 (1/2)
R575
100
TC7SZ08FU(TE85R)
C540
+2.5V
0.1uF
VCC
GND
IC514 (2/2)
GND TC7SZ08FU(TE85R) GND
VCC
GND
GND
10
IC514 (1/2)
TC7SZ08FU(TE85R)
(N-ch_Open_Drain_Output)
9-10
B
GND
GND
IC502 (1/2)
R538
47
R537
47k
GND
TC7SZ08FU(TE85R)
VCC
GND IC502 (2/2)
3
+3.2V
+3.2V
GND
024,025
CP-CLK_2
+3.2V
+3.2V
4
18
17
16
15
14
13
12
11
R542
100
IC513
R3112N281A-TR-FA
2
1
B1
B2
B3
B4
B5
B6
B7
B8
R543
AUDIO-RX12-MIC_out 002
AUDIO-RX34-AES_out 002
AUDIO-RX56-INCOM_out 002
R504
22
20
VCC
A1
A2
A3
A4
A5
A6
A7
A8
RESET
C519
0.1uF
R562
10
CP-CLK_1
GND
RB506
47
GND
10
C516
0.1uF
1
AUDIO-TX12-PGM_in
3
AUDIO-TX34-SPARE_in
5
AUDIO-TX56-INCOM_in
7
AUDIO-TX-64FS_in
AUDIO-TX-LRCK_in
R524
AU-RX12-MIC
AU-RX34-AES
AU-RX56-INCOM
+3.2V
IC505
TC74VHC245FT(EKJ)
AUDIO-TX_in
2
IC519 (1/2)
TC7SZ08FU(TE85R) 1
R561
10
2
IC523 (1/2)
TC7SZ08FU(TE85R) 1
+3.2V
19
OE
1
DIR
AUDIO I/O
from MB
002
R548
10
+2.5V
IC510
TC74VHC245FT(EKJ)
GND
GND
2
IC518 (1/2)
TC7SZ08FU(TE85R) 1
GND
R573
10k
FPGA(MAP)
VBS DEC for PROMPTER
007
006
AGND
GND1
GND2
GND3
GND4
from MB
002
MST-27M-CLK_in
002 GUARD-GND(MST-27CLK)
+3.2V
1
6
7
18
19
1
3
5
7
R552
R564
1
3
5
7
2
IC517 (1/2)
TC7SZ08FU(TE85R) 1
R547
10
IC504
CDCVF2510APWR
3
4
5
8
9
15
16
17
20
21
GND
RB501
22
2
4
6
8
NM 22
22
2
4 RB502
6 22
C529
0.1uF
1Y0
1Y1
1Y2
1Y3
1Y4
1Y5
1Y6
1Y7
1Y8
1Y9
R532
22
8
6
4
2
IC509 (1/2)
TC7SZ08FU(TE85R)
R531
2.2k
7
5
3
1
11
AVCC
VCC1
VCC2
VCC3
VCC4
23
2
10
14
22
R549
100
10
R530
CPU-CK_in
GND
TP502
FB506
C515
0.1uF
2
IC515 (1/2)
TC7SZ08FU(TE85R) 1
DPR-300 (5/28)
FB507
27MHz
VCC
GND
GND
CL501
0.8
2
1
C508
10uF
10uH
+3.2V
+3.2V
+3.2V L501
VCC
GND
C527
0.1uF
GND
R546
10k
GND
IC509 (2/2)
TC7SZ08FU(TE85R)
VCC
GND
+3.2V
GND
10
GND
C533 C535 C537

0.1uF 0.1uF 0.1uF
C534 C536
0.1uF 0.1uF
+3.2V
HD-PROMPT-CLK
FB505
74/27MHz
1
3
5
7
1
3
5
7
ADDR(0)_in
ADDR(1)_in
ADDR(2)_in
ADDR(3)_in
ADDR(4)_in
CS0_in
SYS CLK
(-05)
1
3
5
7
1
3
5
7
+3.2V
CS_ZXCV
CS_HBF
CS_DEMUX
CS_ANALOG
CS_POST
CS_CAFE-T
CS_TORINO
CS_MAP
TC74LCX138FT(EKJ)
+3.2V TC74VHC245FT(EKJ)
RB512
100k
RB508
100k
MAP
PLL
C523
0.1uF 10V
GND
16
VCC
1
15
A
Y0
2
14
B
Y1
3
13
C
Y2
12
Y3
6
11
G1
Y4
10
4
G2A Y5
5
9
G2B Y6
7
Y7
GND
8
IC511
CPU-A2
CPU-A3
CPU-A4
GND
CAFE-T
+3.2V
CPU_I/F
RB515
47
GND
SYS CLK
RET
RB523
100k
+3.2V
FPGA(MAP)
DAYTONA RET ENC
007,009,020
GND
RB522
100k
+3.2V
1
6
7
18
19
C505
10pF
NM
GNDNM
R512
1k
+3.2V
PROCYON
FPGA(POST)
FPGA(ANALOG)
GENNUM PS
FPGA(DEMUX)
022
020
024
023
017
74M-CLK-PROCYON
74M-CLK-FPGA-POST
74M-CLK-FPGA-ANALOG
74M-CLK-SDI
74M-CLK-FPGA-DEMUX
from/to ENCODER
026
IIC2-BUS
R511
2.2k
R510
0
24
CLK
13
FBIN
22
22
22
22
22
22
22
22
22
22
AGND
GND1
GND2
GND3
GND4
R509
22
GND
SCL
MST 74MHz
R514
R520
R525
R526
R527
R528
R529
R550
R560
R563
3
4
5
8
9
15
16
17
20
21
1Y0
1Y1
1Y2
1Y3
1Y4
1Y5
1Y6
1Y7
1Y8
1Y9
IC506 (1/2)
TC7SET08FU(T5RSOJF)
TP501
11
GND
from MB
002
MST-74M-CLK_in
002 GUARD-GND(MST-74CLK)
IC501
CDCVF2510APWR
C507
47uF
6.3V
3216
GND
IC506 (2/2)
TC7SET08FU(T5RSOJF)
C503
1uF
6.3V
SDA
3
N_BYP
GND
C502
2
0.1uF
R533
R534
SDA_in/out
SCL_in
MST-74M
2
4
6
8
2
4
6
8
CTL
(MAX:90mA@74MHz)
1
3
5
7
1
3
5
7
FB502
FB501
VCC
GND
CPU-D7
CPU-D6
CPU-D5
CPU-D4
CPU-D3
CPU-D2
CPU-D1
CPU-D0
R501
22k
VOUT
0.1uF
R535
10k
10
2
10
1
CPU_BUS
2
4
6
8
2
4
6
8
C501
0.1uF
10V
VIN
+3.2V C517
+3.2V
+3.3V
1
3
5
7
1
3
5
7
R503 C504
10
(1/10W) 10uF
6.3V
(Vd=0.75V@75mAx2)1608
23
2
10
14
22
(1/10W)
R502
10
(4.25-5.0V)
from/to MB
002
+3.3V_DRV
IC520
NJM2871BF33-TE2
AVCC
VCC1
VCC2
VCC3
VCC4
+5V-D
CLOCK CPU_I/F
C506 C511 C530

0.1uF 0.1uF 0.1uF
C509 C512
0.1uF 0.1uF
Vd=1.7--0.97V
I= 0--150mA
150mA=>
Pd=0.97x0.15=145.5mW
(MAX:350mW)
DPR-300 (5/28)
DPR-300 (5/28)
BOARD NO. 1-879-649-11
IC524 (2/2)
TC7SZ08FU(TE85R)
HDCU-300_DPR-300_011_5
9-10
HSCU-300
DPR-300 (6/28)
DPR-300 (6/28)
to MAP FPGA
PROMPTER-NTSC/PAL_1 007
to MAP FPGA
PROMPTER-NTSC/PAL_2 007
+3.2V
C602
10uF
6.3V
R603
0 R672
0
C603
22pF
NM
L602
10uH
C620
0.1uF
-5V-D
C619
0.1uF
C617
0.1uF
C618
0.1uF
+3.2V
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
ADGND1
ADVDD1
VIN1
VIN2
VIN3
VIN4
VIN5
VIN6
AVDD1
AGND1
REFP1
CM1
REFN1
REFP2
CM2
REFN2
AVDD2
AGND2
LPFOUT1
LPFOUT2
AVDD3
AGND3
ADVDD2
ADGND2
ADGND3
A.G
007
007
R632
0
I2C
1000 001x
IC601
ML86V7666TBZ03A
R631
R671
10
10
IIC-SCL-PROMPTER
IIC-SDA-PROMPTER
C611
0.1uF TP601
R622 22
P1 F
PROMPTER1_F
R624
100
R626
100
to MAP FPGA
007
PROMPTER1
CL602
0.8
R623 22 NM
CL603
0.8
P1 H
R625
100
NM
PROMPTER1_H
C612
0.1uF
PROMPTER1_YC9
PROMPTER1_YC8
PROMPTER1_YC7
PROMPTER1_YC6
PROMPTER1_YC5
PROMPTER1_YC4
PROMPTER1_YC3
PROMPTER1_YC2
C613
0.1uF
3
+3.2V
R629
10
R627
10k
GND
+3.2V
+5V-D
R628
10k
PROMPTER2
from MB
002
002
2SA1774TL-QR
Q602
R638
1.5k
C625
22uF
6.3V
R639
0
R635
100
PROMPTER2(X)_in
PROMPTER2(G)_in
C624
1uF
R636
330
C622
10uF
6.3V
R637
0 R673
0
GND
A.G
C623
22pF
NM
L608
10uH
C639
0.1uF
-5V-D
C640
0.1uF
C638
0.1uF
C637
0.1uF
+3.2V
ADGND1
ADVDD1
VIN1
VIN2
VIN3
VIN4
VIN5
VIN6
AVDD1
AGND1
REFP1
CM1
REFN1
REFP2
CM2
REFN2
AVDD2
AGND2
LPFOUT1
LPFOUT2
AVDD3
AGND3
ADVDD2
ADGND2
ADGND3
R669
0
A.G
007
R652
10k
L611
10uH
R655
0
GND
R653
10k
C630
10uF
I2C
1000 011x
IC602
ML86V7666TBZ03A
CLKSEL
CLKX2
DGND4
DVDD11
CLKX2O
CLKXO
ODD/EVEN
HSYNC_L
VSYNC_L
VVALID
HVALID
DGND3
DVDD10
Y9
Y8
Y7
Y6
Y5
Y4
Y3
Y2
Y1/B0
Y0/B1
DGND2
DVDD9
GND
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
R656
10
P2 27M
C631
0.1uF TP602
R657 22
CL605
0.8
R658 22 NM
to MAP FPGA
007
P2 F
PROMPTER2_F
R659
100
R661
100
PROMPTER2
CL606
0.8
R660
100
NM
P2 H
PROMPTER2_H
C632
0.1uF
PROMPTER2_YC9
PROMPTER2_YC8
PROMPTER2_YC7
PROMPTER2_YC6
PROMPTER2_YC5
PROMPTER2_YC4
PROMPTER2_YC3
PROMPTER2_YC2
C633
0.1uF
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
L612
10uH
C636
22uF
6.3V
R648
10k
C628
0.1uF
+3.2V
NTSC/PAL
R654
100
C629
0.1uF
C626
0.1uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CL604
0.8
MODE[3,2]=[0,1]:10bit
C627
10uF
L609
10uH
L607
10uH
C621
10uF 6.3V
Default=AUTO
L610
10uH
+3.2V
R634
47k
007
007
from CLK Driver

27M-CLK-PROMPTER
005
P1 27M
R621
10
C614
0.1uF
C615
0.1uF
R633
0
PROMPTER1-SLEEP
PROMPTER_RESET
from/to FPGA MAP
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
L606
10uH
C616
22uF
6.3V
GND
CLKSEL
CLKX2
DGND4
DVDD11
CLKX2O
CLKXO
ODD/EVEN
HSYNC_L
VSYNC_L
VVALID
HVALID
DGND3
DVDD10
Y9
Y8
Y7
Y6
Y5
Y4
Y3
Y2
Y1/B0
Y0/B1
DGND2
DVDD9
C634
0.1uF
C635
0.1uF
R670
0
R666
R667
PROMPTER2-SLEEP
R668
47k
GND
10
10
5
R665 10
R602
330
C610
10uF
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
PROMPTER1(X)_in
PROMPTER1(G)_in
A.G
C604
1uF
R620
0
GND
R618
10k
PGND
PLLLPF
PLLVREF
PVDD
DGND6
DVDD12
INS0
INS1
INS2
GAINS0
GAINS1
GAINS2
MODE0
MODE1
MODE2
MODE3
DGND5
M0
M1
M2
STATUS1
STATUS2
CSYNC/SCALR
VHVAL/SCALW
PLLSEL
R601
100
C606
0.1uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
L605
10uH
DVDD7
SCAN
TEST0
TEST1
TEST2
SLEEP
RESET_L
SCL
SDA
DVDD8
DGND1
C9
C8
C7
C6
C5
C4
C3
C2
C1/B7
C0/B6
B5
B4
B3
B2
R605
0
C608
0.1uF
+3.2V
NTSC/PAL
R619
100
PGND
PLLLPF
PLLVREF
PVDD
DGND6
DVDD12
INS0
INS1
INS2
GAINS0
GAINS1
GAINS2
MODE0
MODE1
MODE2
MODE3
DGND5
M0
M1
M2
STATUS1
STATUS2
CSYNC/SCALR
VHVAL/SCALW
PLLSEL
C605
22uF
6.3V
GND
R614
10k
CL601
0.8
DVDD7
SCAN
TEST0
TEST1
TEST2
SLEEP
RESET_L
SCL
SDA
DVDD8
DGND1
C9
C8
C7
C6
C5
C4
C3
C2
C1/B7
C0/B6
B5
B4
B3
B2
from MB
002
002
2SA1774TL-QR
Q601
R604
1.5k
C609
0.1uF
C607
10uF
L603
10uH
L601
10uH
C601
10uF 6.3V
Default=AUTO
MODE[3,2]=[0,1]:10bit
R630 10
+3.2V
+5V-D
PROMPTER1
L604
10uH
R664
10
+3.2V
R662
10k
R663
10k
DPR-300 (6/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_6
9-11
HSCU-300
9-11
E
DPR-300 (7/28)
DPR-300 (7/28)
005,009,020
R722
74M-CLK-FF
005
+3.2V
005
005
R769
2.2k
D701
SML-D12U8WT86
CONF
R709
R710
R711
R712
27M-CLK-FPGA-MAP
005
CP-CLK_4
74M-CLK-FPGA-MAP
CLK-VIDEO-TRUNK_1
+3.2V-7 R702
R703
R704
DTA144EE-TL
Q701
+3.2V
3
VCC1
7
VCC2
8
VCC3
5
2
ASDI DATA
6
DCLK
1
CS
291
R701
R705
10k
R706
R707
R708
47
GND
GND
IC701
EPCS16SI8N
GND
R713
0
NM
R714
nCEO[K2]
HD-RET-H_in
290
DATA0[H7]
47 11
DCLK[L1]
9
IO4/nCSO[J1]
265
IO212/ASDO[K6]
R760
47
CONFIG_CONF_DONE
+3.2V
from MB
002
R763
100
PLD-RECONFIG_in
R764
47k
IC710 (1/2)
TC7SZ08FU(TE85R)
2
1
R759
100
+3.2V
1
GND
R719
47
1
GND
C730 0.1uF
14
VCC
1PR
1D
1Q
1CK
1CLR 1Q
2PR
2D
2Q
2CK
2CLR 2Q
GND
7
VCC
GND
GND
C703
0.1uF
GND
PROMPTER
(+3.2V)
CONFIG_CHAIN
017,020,024
006
7
5
3
1
7
5
3
1
8
6
4
2
8
6
4
2
PROMPTER2_YC2
PROMPTER2_YC3
RB703 PROMPTER2_YC4
220
PROMPTER2_YC5
PROMPTER2_YC6
PROMPTER2_YC7
RB704
220
PROMPTER2_YC8
PROMPTER2_YC9
R725 PROMPTER2_F
220
R726 PROMPTER2_H
220
+3.2V
C702
0.1uF
VCC
GND
IC703 (1/2)
TC7SZ125FU(TE85R)
CONFIG_nCONFIG
PROMPTER1
R765
10k
2
1
PLD-CONF-DONE_out
100
006
IC711 (1/2)
TC7SZ08FU(TE85R)
R762
PROMPTER1_YC2
PROMPTER1_YC3
PROMPTER1_YC4
PROMPTER1_YC5
PROMPTER1_YC6
PROMPTER1_YC7
PROMPTER1_YC8
PROMPTER1_YC9
PROMPTER1_F
PROMPTER1_H
RB702
220
IC703 (2/2)
IC702 (2/2)
CONFIG_DCLK
to MB
002
100
R723
220
R724
220
R715
47
R721
GND
IC702 (1/2)
TC7SZ125FU(TE85R)
+3.2V
GND
CONFIG_CONF_DONE
CONFIG_nSTATUS
CONFIG_nCONFIG
GND
100
RB701
220
292
MSEL1[K7]
136
MSEL0[K3]
CONFIG_nCE_1-2
C740
0.1uF
R720
4
2
3
1
10
12
11
13
GND
IC704
TC74LCX74FT(EKJ)
5
6
(NEAR IC902/903)
9
8
GND
IC700
(6/6)
EP1C20F324C8N(300)
CONFIG_DATA0
VCC
GND
C739
0.1uF
VCC
GND
+3.2V
FB704
R716
0
77
+3.2V
+3.2V
GND
HD-RET-F_in
PLL
nCE[J7]
107
TDI[J17]
247
TMS[K14]
43
TCK[K18]
278
TDO[K13]
10k
10k
10k
47
HD-RET-Y/C_in
CLK
CONFIG
106
CONF_DONE[K17]
300
nSTATUS[L12]
76
nCONFIG[J2]
10k
10k
10k
IC710 (2/2)
IC711 (2/2)
135
CLK0/LVDSCLK1p[J3]
186
CLK1/LVDSCLK1n[J4]
209
CLK2/LVDSCLK2p[J15]
162
CLK3/LVDSCLK2n[J16]
47
47
47
47
C701 0.1uF
GND
GND
from MB
002,009
1
3
5
7
1
3
5
7
PROMPT1_YC2
PROMPT1_YC3
PROMPT1_YC4
PROMPT1_YC5
PROMPT1_YC6
PROMPT1_YC7
PROMPT1_YC8
PROMPT1_YC9
PROMPT1_F
PROMPT1_H
2
4
6
8
2
4
6
8
PROMPT1_YC9
PROMPT1_YC6
PROMPT1_YC4
PROMPT1_YC2
EPR2
3
angle-type
1
2
3
4
5
6
7
8
9
10
PROMPT2_YC2
PROMPT2_YC3
PROMPT2_YC4
PROMPT2_YC5
PROMPT2_YC6
PROMPT2_YC7
PROMPT2_YC8
PROMPT2_YC9
PROMPT2_F
PROMPT2_H
PROMPTER2
100
+3.2V
CN702
VCC
DATAOUT
ASDI
CONF_DONE
nCONFIG
DCLK
MODE(H)
GND
nCE
nCS
RB705
1
AU-TX12-PGM
AU-TX34-SPARE 3
AU-TX56-INCOM 5
7
AU-TX-LRCK
R729
AU-TX-64FS
005,017
AUDIO-TX
+3.2V
GND
+2.5V
L701
1uH
C707 1uF
C708 0.1uF
C709 0.1uF
C704
10uF
6.3V
C710 1uF
C711 0.1uF
C712 1uF
C713 0.1uF
GND
C714 1uF
C715 0.1uF
C716 1uF
+3.2V
L702
1uH
+3.2V-7
C705
10uF
6.3V
C717 1uF
C718 0.1uF
C719 0.1uF
GND
+1.5V
L703
1uH
C706
10uF
6.3V
C720 1uF
C721
C722 1uF
C723
C724 1uF
C725
C726 1uF
C727
C728 1uF
C729
GND
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
GND36[J10]
GND35[K9]
GND34[H9]
GND33[H11]
GND32[J11]
GND31[K11]
GND30[L11]
GND29[L10]
GND28[L8]
GND27[K8]
GND26[J8]
GND25[H8]
GND24[G8]
GND23[G10]
GND22[M11]
GND21[M9]
GND20[F9]
GND19[F11]
GND18[N10]
GND17[N8]
GND16[B17]
GND15[U17]
GND14[U2]
GND13[B2]
GND12[A3]
GND11[A16]
GND10[A18]
GND9[C18]
GND8[T18]
GND7[V18]
GND6[V16]
GND5[V3]
GND4[V1]
GND3[T1]
GND2[C1]
GND1[A1]
5
VCCIO1_1[E1]
14
VCCIO1_2[P1]
289
VCCIO1_3[G7]
294
VCCIO1_4[M7]
56
VCCIO2_1[A14]
65
VCCIO2_2[A5]
254
VCCIO2_3[E12]
257
VCCIO2_4[E9]
39
VCCIO3_1[P18]
48
VCCIO3_2[E18]
299
VCCIO3_3[M12]
303
VCCIO3_4[H12]
22
VCCIO4_1[V5]
31
VCCIO4_2[V14]
237
VCCIO4_3[P8]
240
VCCIO4_4[P11]
2
17
19
34
36
51
53
68
271
273
285
287
295
297
305
307
313
319
321
323
VCCINT1[B1]
VCCINT2[U1]
VCCINT3[V2]
VCCINT4[V17]
VCCINT5[U18]
VCCINT6[B18]
VCCINT7[A17]
VCCINT8[A2]
VCCINT9[N9]
VCCINT10[N11]
VCCINT11[F10]
VCCINT12[F8]
VCCINT13[M8]
VCCINT14[M10]
VCCINT15[G11]
VCCINT16[G9]
VCCINT17[L9]
VCCINT18[H10]
VCCINT19[J9]
VCCINT20[K10]
229
VCCA_PLL1[J5]
302
VCCA_PLL2[J12]
324
322
320
318
317
316
315
314
312
311
310
309
308
306
298
296
286
284
272
270
114
99
84
69
67
54
52
50
37
35
33
20
18
16
3
1
1
IC700
MAP
EP1C20
EPCS16
2
IC1700
DEMUX
EP1C20
HD-PROMPT-F_in
HD-PROMPT-H_in
R739
100
R740
47
VIDEO-TRUNK
(+3.3V)
from MB
002
GND
IC705
PROMPTER_RESET
PROMPTER1-SLEEP
PROMPTER2-SLEEP
GND
near IC1701
VTRUNK-F_T
CPU_WR_f
CPU_RD_f
CPU_CS7_f
CPU_CS6_f
DRET-UART-TX
DRET-UART-RX
005,007,009,011,017,018
DPR-RESET_2
6
9
VTRUNK-H_T
266
267
268
269
288
293
IO213/LVDS12n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO226/LVDS24n[F7]
IO227/LVDS12p/DM1L[L7]
IC700
(1/6)
EP1C20F324C8N(300)
HD-PROMPT-Y/C_in
+3.2V
FB701 C737 0.1uF
HD-PROMPT-Y_in2
HD-PROMPT-Y_in3
HD-PROMPT-Y_in4
HD-PROMPT-Y_in5
HD-PROMPT-Y_in6
HD-PROMPT-Y_in7
HD-PROMPT-Y_in8
HD-PROMPT-Y_in9
301
GNDA_PLL2[K12]
10
GNDA_PLL1[K1]
005
SYNC_IN
006 PROMPTER-NTSC/PAL_2
006 PROMPTER-NTSC/PAL_1
006
IIC-SCL-PROMPTER
006
IIC-SDA-PROMPTER
IC706
TC74LCX74FT(EKJ)
5
2
1
2
4
6
8
IO5/DQ1L0[M1]
IO6/LVDS6p[N1]
IO7/VREF2B1[R1]
IO36/LVDS31n/CRC_ERROR[C2]
IO37/LVDS30n[D2]
IO38/LVDS29n/DQ0L1[E2]
IO39/LVDS27p[F2]
IO40/LVDS25n[G2]
IO41/LVDS21p[H2]
IO42/LVDS11p[L2]
IO43/LVDS8n/DQ1L2[M2]
IO44/LVDS6n[N2]
IO45/LVDS2p/DQ1L6[P2]
IO46/LVDS1p[R2]
IO47/LVDS0p[T2]
IO88/LVDS31p/INIT_DONE[C3]
IO89/LVDS30p/CLKUSR[D3]
IO90/LVDS29p/DQ0L0[E3]
IO91/LVDS27n[F3]
IO92/LVDS23p[G3]
IO93/LVDS21n[H3]
IO94/LVDS11n[L3]
IO95/LVDS8p/DQ1L1[M3]
IO96/LVDS3p/DQ1L4[N3]
IO97/LVDS2n/DQ1L7[P3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
IO137/VREF0B1[D4]
IO139/LVDS26p[F4]
IO140/LVDS23n/DQ0L4[G4]
IO141/LVDS20p[H4]
IO142/PLL1_OUTp[K4]
IO143/LVDS10n[L4]
IO144/LVDS7n[M4]
IO145/LVDS3n/DQ1L5[N4]
IO146[P4]
IO180/LVDS26n[F5]
IO181/LVDS22p/DQ0L5[G5]
IO182/LVDS20n/DM0L[H5]
IO183/PLL1_OUTn[K5]
IO184/LVDS10p[L5]
IO186/LVDS4p[N5]
IO187/DPCLK0/DQS1L[P5]
IO209/LVDS24p[F6]
IO211/VREF1B1[H6]
GND
CLK-VIDEO-TRUNK_2
8
6
4
2
8
6
4
2
RB715
100
R741
RB714
100
47
7
5
3
1
7
5
3
1
2
3
4
5
6
7
8
9
11
1
20
VCC
Q0
D0
Q1
D1
Q2
D2
Q3
D3
Q4
D4
Q5
D5
Q6
D6
Q7
D7
CK
OE
GND
10
19
18
17
16
15
14
13
12
GND
VTRUNK-Y_T0
VTRUNK-Y_T1
VTRUNK-Y_T2
VTRUNK-Y_T3
VTRUNK-Y_T4
VTRUNK-Y_T5
VTRUNK-Y_T6
VTRUNK-Y_T7
IC707
TC74LCX574FT(EKJ)
+3.2V
FB702 C738 0.1uF
RB716
100
HD-PROMPT-C_in2
HD-PROMPT-C_in3
HD-PROMPT-C_in4
HD-PROMPT-C_in5
HD-PROMPT-C_in6
HD-PROMPT-C_in7
HD-PROMPT-C_in8
HD-PROMPT-C_in9
2
4
6
8
2
4
6
8
RB717
100
1
3
5
7
1
3
5
7
R742
R768
47
2
3
4
5
6
7
8
9
11
1
20
VCC
Q0
D0
Q1
D1
Q2
D2
Q3
D3
Q4
D4
Q5
D5
Q6
D6
Q7
D7
CK
OE
GND
10
2.2k
NM
GND
GND
GND
19
18
17
16
15
14
13
12
GND
VTRUNK-C_T0
VTRUNK-C_T1
VTRUNK-C_T2
VTRUNK-C_T3
VTRUNK-C_T4
VTRUNK-C_T5
VTRUNK-C_T6
VTRUNK-C_T7
RB710
100
RB711
100
RB712
100
RB713
100
IC708
TC74LCX574FT(EKJ) R732
100
R733
100
VTRUNK-Y_T0
VTRUNK-Y_T1
VTRUNK-Y_T2
VTRUNK-Y_T3
VTRUNK-Y_T4
VTRUNK-Y_T5
VTRUNK-Y_T6
VTRUNK-Y_T7
VTRUNK-C_T0
VTRUNK-C_T1
VTRUNK-C_T2
VTRUNK-C_T3
VTRUNK-C_T4
VTRUNK-C_T5
VTRUNK-C_T6
VTRUNK-C_T7
VTRUNK-F_T
VTRUNK-H_T
7
5
3
1
7
5
3
1
1
3
5
7
1
3
5
7
8
6
4
2
8
6
4
2
2
4
6
8
2
4
6
8
VTRUNK-Y_F0
VTRUNK-Y_F1
VTRUNK-Y_F2
VTRUNK-Y_F3
VTRUNK-Y_F4
VTRUNK-Y_F5
VTRUNK-Y_F6
VTRUNK-Y_F7
VTRUNK-C_F0
VTRUNK-C_F1
VTRUNK-C_F2
VTRUNK-C_F3
VTRUNK-C_F4
VTRUNK-C_F5
VTRUNK-C_F6
VTRUNK-C_F7
VTRUNK-F_F
VTRUNK-H_F
GND
9-12
B
R738
100
14
VCC
1PR
1D
1Q
1CK
1CLR 1Q
2PR
2Q
2D
2CK
2CLR 2Q
GND
7
1
3
5
7
3 TC7SH08FU(T5RSOYJF)
006
006
006
GND
4
2
3
1
10
12
11
13
R737
220
from MB 0-5V
002
TRUNK1(RX)_in
100
011
C731 0.1uF
+3.2V
FB703 C732 0.1uF
44
GNDG_PLL2[J18]
264
GNDG_PLL1[J6]
4
IC2400
ANALOG
EP1C12
EPR2
GND
IC700
(5/6)
EP1C20F324C8N(300)
3
IC2000
POST
EP1C12
220
2
4
6
8
017
IRQ-1968
002
IRQ_out
018 DAYTONA-MAIN-GPIO_0a
12 11
12
13
15
70
71
PROMPT1_YC8
72
PROMPT1_YC7
73
PROMPT1_YC5
74
PROMPT1_YC3
75
PROMPT1_F
78
PROMPT1_H
79
PROMPT2_YC3
80
PROMPT2_YC5
81
PROMPT2_YC6
82
PROMPT2_YC8
83
PROMPT2_YC9
100 129
R728
130
131
1.2
132
CL708
1.2
133
CL709
134
137
138
PROMPT2_F
139
PROMPT2_H
140
141
142
181
182
183
184
RB729
220
185
187
188
189
190
CL703
1.2
191
225
100
R736
226
R776
47
227
228
230
231
232
SIGN30257
233
SIGN30256
234
261
R735
10 262
R734
10 263
PROMPT2_YC2
PROMPT2_YC4
PROMPT2_YC7
100
R727
+3.2V
R766 47k R761
4
IO0[D1]
6
IO1/DPCLK1/DQS0L[F1]
7
IO2/LVDS25p[G1]
8
IO3/DQ0L7[H1]
9-12
HSCU-300
DPR-300 (7/28)
to CAFE-T
011
74M-CLK-PLL-CAFE-T
1.2
CL704
DPR-300 (7/28)
TORINO-RESET
TORINO I/F
BANK2
2.5V
MAP FPGA
BANK3
3.2V
BANK4
3.2V
14 TC74LCX08FT(EKJ)
VCC
3 TORINO_AUDIO_64FS
1Y
6
2Y
4Y
GND
7
R756
TORINO_AUDIO_FS
TORINO_AUDIO_DT12
11
TORINO_AUDIO_DT34
3Y
+2.5V
005,007,009,011,017,018
DPR-RESET_2
R743
3.2<-2.5
R744
TORINO_VIDEO_VD
TORINO_VIDEO_HD
TORINO_VIDEO_C0
TORINO_VIDEO_C2
TORINO_VIDEO_C4
TORINO_VIDEO_C6
74M-CLK-SDRAM-MAP
008
47
7
5
3
1
RB719
8
6
4
2
47
8
6
4
2
47
10
47
8
6
4
2
RB730
7
5
3
1
TORINO_AUDIO_64FS
TORINO_AUDIO_DT34
TORINO_AUDIO_OADT34
TORINO_AUDIO_FS
TORINO_HCSX
TORINO_HRDX
TORINO_HDT7
TORINO_HDT5
TORINO_HDT3
TORINO_HDT1
10
NM
R746
R747
TORINO_HCLK
10
47
7
5
3
1
RB718
TORINO_VIDEO_Y0
TORINO_VIDEO_Y2
TORINO_VIDEO_Y4
TORINO_VIDEO_Y6
10
NM
R745
[27MHz]
R748
47
R749
47
R750
47
7
5
3
1
RB720 100
7
RB721
100 5
NM 3
1
TORINO_A_STRM_ADT
TORINO_A_STRM_CLK
R772
R773
TORINO_STRM_D0
TORINO_STRM_D2
TORINO_STRM_D4
TORINO_STRM_D6
TORINO_STRM_IBRDY
TORINO_IBCLK_675
RB722
100
7
5
3
1
R751
R752
8
6
4
2
8
6
4
2
47
47
8
6
4
2
100
100
+2.5V_TRN
SDRAM I/F
(+3.2V)
008
008
008
+1.0V_TRN
to CAFE-T
011
011
IC709 (2/2)
TC7SZ08FU(TE85R)
47
C733
0.1uF
VCC
GND
(RESET_TORINO_CHIP)
[+2.5V]
GND
ENC-112
TORINO
CN701
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
38
37
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101 102
103 104
105 106
107 108
109 110
111 112
113 114
115 116
117 118
119 120
ISCLK [27MHz]
GND
OV_CLK74
GND
TORINO_VIDEO_VD
TORINO_VIDEO_HD
TORINO_VIDEO_C0
TORINO_VIDEO_C2
TORINO_VIDEO_C4
TORINO_VIDEO_C6
GND
TORINO_VIDEO_Y0
TORINO_VIDEO_Y2
TORINO_VIDEO_Y4
TORINO_VIDEO_Y6
GND
TORINO_IV_CLK74
GND
TORINO_IPCLK
TORINO_AUDIO_DT34
TORINO_AUDIO_OADT34
TORINO_AUDIO_FS
GND
TORINO_HCLK
GND
TORINO_HCSX
TORINO_HRDX
TORINO_HDT7
TORINO_HDT5
TORINO_HDT3
TORINO_HDT1
GND
TORINO_JTSEL_S1
TORINO_JTSEL_S3
TORINO_SER_RX
TORINO_SER_RTSX
GND
TORINO_A_STRM_ADT
TORINO_A_STRM_CLK
GND
TORINO_STRM_D0
TORINO_STRM_D2
TORINO_STRM_D4
TORINO_STRM_D6
TORINO_STRM_IBRDY
TORINO_IBCLK
GND
+2.5V
+2.5V
+2.5V
+2.5V
GND
GND
GND
GND
GND
+1.0V
+1.0V
+1.0V
+1.0V
121
GND
to DAYTONA_RET
DAYTONA-RET-FVH
009
DAYTONA-RET-UART
009
DAYTONA-RET-GPIO
009
DAYTONA-RET-FRSEL
009
DAYTONA-RET-FFWRT
009
DAYTONA-RET-FSYNC
009
DAYTONA-RET-RESET
009
CPU_DT_f0
CPU_DT_f1
CPU_DT_f2
CPU_DT_f3
CPU_DT_f4
CPU_DT_f5
CPU_DT_f6
CPU_DT_f7
CPU_ADR0_f
CPU_ADR1_f
CPU_WR_f
CPU_RD_f
CPU_CS7_f
CPU_CS6_f
R758
GND
R778
CPU_DT_f2
CPU_DT_f3
AUDIO_FS64
47
3.2->2.5
SDRAM-MAP-CNT
SDRAM-MAP-ADRS
SDRAM-MAP-DQ
CL706 CL707
1.2 1.2
2
1
FB708
R767
10k
IC709 (1/2)
TC7SZ08FU(TE85R)
from CPU_I/F[+3.3V]
TORINO_AUDIO_OADT12
TORINO_AUDIO_OADT34
CAFE-T_AU
CAFE-T_SV
R757
47
1A
1B
2A
2B
3A
3B
4A
4B
GND
IC700
(3/6)
EP1C20F324C8N(300)
AUDIO_AES
AUDIO_INCOM
AUDIO_TRUNK
VTRUNK-H_F
SUB_VIDEO_DATA_2
SUB_VIDEO_DATA_4
AUDIO_FS
AUDIO_MIC
VTRUNK-C_F2
VTRUNK-C_F4
VTRUNK-C_F6
VTRUNK-F_F
CPU_DT_f0
CPU_DT_f1
CPU_DT_f4
CPU_DT_f6
SUB_VIDEO_CLK
SUB_VIDEO_REQ
VTRUNK-C_F0
VTRUNK-Y_F6
VTRUNK-Y_F5
VTRUNK-Y_F3
VTRUNK-Y_F1
DAYTONA-RET-F
DAYTONA-RET-V
DAYTONA-RET-H
SUB_VIDEO_DATA_0
SUB_VIDEO_DATA_1
SUB_VIDEO_DATA_3
SUB_VIDEO_DATA_5
SUB_VIDEO_DATA_6
SUB_VIDEO_DATA_7
VTRUNK-C_F1
VTRUNK-C_F3
VTRUNK-C_F5
VTRUNK-C_F7
CPU_ADR1_f
CPU_ADR0_f
CPU_DT_f5
CPU_DT_f7
VTRUNK-Y_F7
VTRUNK-Y_F4
VTRUNK-Y_F2
VTRUNK-Y_F0
DAYTONA-RET-GPIO_0
DAYTONA-RET-GPIO_1
TS_MODE_SEL_0
21
23
24
25
26
27
28
29
30
32
85
86
87
88
89
90
91
92
93
94
95
96
97
98
143
144
145
146
147
148
149
150
151
152
153
154
192
193
194
195
196
197
198
199
200
201
202
235
236
238
239
241
242
IO8/LVDS128n[V4]
IO9/LVDS124p[V6]
IO10/LVDS121n/DQ1B2[V7]
IO11/LVDS119n[V8]
IO12/LVDS117n[V9]
IO13/LVDS112n[V10]
IO14/LVDS108n[V11]
IO15/LVDS107p[V12]
IO16/LVDS105p/DQ0B5[V13]
IO48/LVDS128p[U3]
IO49/LVDS127n[U4]
IO50/LVDS126n/DQ1B6[U5]
IO52/LVDS121p/DQ1B3[U7]
IO53/LVDS119p[U8]
IO54/LVDS117p[U9]
IO55/LVDS112p[U10]
IO56/LVDS108p/DM0B[U11]
IO57/LVDS107n[U12]
IO59/DPCLK6/DQS0B[U14]
IO61/LVDS97p[U16]
IO100/LVDS127p[T4]
IO101/LVDS126p/DQ1B7[T5]
IO102/LVDS122p[T6]
IO104/LVDS118p[T8]
IO105/LVDS116n[T9]
IO106/LVDS111p[T10]
IO107/LVDS109n[T11]
IO109/LVDS104p[T13]
IO111/LVDS97n[T15]
IO147/DPCLK7/DQS1B[R4]
IO148/VREF2B4[R5]
IO149/LVDS122n[R6]
IO150/LVDS120n/DQ1B0[R7]
IO151/LVDS118n[R8]
IO152/LVDS116p/DM1B[R9]
IO153/LVDS111n[R10]
IO154/LVDS109p[R11]
IO156/LVDS104n[R13]
IO188/LVDS123p/DQ1B4[P6]
IO189/LVDS123n[P7]
IO190/VREF1B4[P9]
IO191/LVDS110n[P10]
IO192/LVDS101n[P12]
IO193/VREF0B4[P13]
IC700
(4/6)
EP1C20F324C8N(300)
1
2
4
5
9
10
12
13
IO208/LVDS37n[E6]
IO207/LVDS40p/DQ1T1[E7]
IO206/LVDS40n/DQ1T0[E8]
IO205/VREF1B2[E10]
IO204/LVDS50n[E11]
IO203/LVDS59n[E13]
IO178/LVDS34p/DQ1T5[D5]
IO177/LVDS37p[D6]
IO176/LVDS38n[D7]
IO175/LVDS42n[D8]
IO174/LVDS44n/DM1T[D9]
IO173/LVDS49p[D10]
IO172/LVDS52p[D11]
IO171/LVDS54n/DQ0T6[D12]
IO136/LVDS32p/DEV_CLRn[C4]
IO135/LVDS34n/DQ1T4[C5]
IO134/LVDS36p[C6]
IO133/LVDS38p[C7]
IO132/LVDS42p[C8]
IO131/LVDS44p[C9]
IO130/LVDS49n[C10]
IO129/LVDS52n[C11]
IO128/LVDS54p/DQ0T7[C12]
IO126/VREF0B2[C14]
IO124/LVDS63n[C16]
IO87/LVDS32n/DEV_OE[B3]
IO86/LVDS33p/DQ1T7[B4]
IO85/DPCLK2/DQS1T[B5]
IO84/LVDS36n[B6]
IO82/LVDS41p[B8]
IO81/LVDS43p[B9]
IO80/LVDS48n[B10]
IO79/LVDS51n[B11]
IO78/LVDS53n[B12]
IO77/LVDS56n[B13]
IO75/LVDS62n/DQ0T0[B15]
IO74/LVDS63p[B16]
IO35/LVDS33n/DQ1T6[A4]
IO34/VREF2B2[A6]
IO32/LVDS41n[A8]
IO31/LVDS43n[A9]
IO30/LVDS48p[A10]
IO29/LVDS51p/DM0T[A11]
IO28/LVDS53p[A12]
IO27/LVDS56p[A13]
IO26/LVDS62p/DQ0T1[A15]
IO228/LVDS70n[G12]
IO225/LVDS70p[F12]
IO224/LVDS68n[F13]
IO223/LVDS72n/DQ0R4[G13]
IO222/LVDS76p/DM0R[H13]
IO221/LVDS76n[J13]
IO220/LVDS85p[L13]
IO219/LVDS85n[M13]
IO218/LVDS91n[N13]
IO217/LVDS91p[N12]
IO202/VREF0B3[E14]
IO201/LVDS68p[F14]
IO200/LVDS72p[G14]
IO199/LVDS75n[H14]
IO198/VREF1B3[J14]
IO197[L14]
IO196/LVDS88n/DQ1R2[M14]
IO195/LVDS93p/DQ1R4[N14]
IO194/LVDS93n/DQ1R5[P14]
IO168/LVDS65p[D15]
IO167/LVDS66p/DQ0R1[E15]
IO166/LVDS67p/DQ0R3[F15]
IO165/LVDS71n[G15]
IO164/LVDS75p[H15]
IO163/PLL2_OUTp[K15]
IO162/LVDS84p[L15]
IO161/LVDS88p/DQ1R1[M15]
IO160/LVDS90p[N15]
IO159/DPCLK5/DQS1R[P15]
IO158/LVDS94n/DQ1R7[R15]
IO123/LVDS65n[D16]
IO122/LVDS66n/DQ0R2[E16]
IO121/LVDS67n[F16]
IO120/LVDS71p[G16]
IO119/LVDS74n[H16]
IO118/PLL2_OUTn[K16]
IO117/LVDS84n/DM1R[L16]
IO116/DQ1R0[M16]
IO115/LVDS90n[N16]
IO114/VREF2B3[P16]
IO113/LVDS94p[R16]
IO112/LVDS96n[T16]
IO73/LVDS64n[C17]
IO72/LVDS64p[D17]
IO71/DPCLK4/DQS0R[E17]
IO70/LVDS69p[F17]
IO69/LVDS73p/DQ0R5[G17]
IO68/LVDS74p[H17]
IO67/LVDS86p[L17]
IO65/LVDS92p[N17]
IO64/DQ1R6[P17]
IO63/LVDS95n[R17]
IO62/LVDS96p[T17]
IO25/DQ0R0[D18]
IO24/LVDS69n[F18]
IO22/DQ0R7[H18]
IO21/LVDS86n[L18]
IO20/LVDS89n[M18]
IO19/LVDS92n[N18]
IO18/LVDS95p[R18]
IC700
(2/6)
EP1C20F324C8N(300)
BANK1
3.2V
IC713
GND
304
283
282
SDRAM_DQM3
10
281 R779
280
279
277
SDRAM_DQ7
276
SDRAM_DQ3
275
SDRAM_DQ28
274
SDRAM_DQ1
252
251
250
SDRAM_DQM0
249
SDRAM_BA1
248
SDRAM_DQ5
246
SDRAM_DQ6
245
SDRAM_DQ2
244
SDRAM_DQ27
243
SDRAM_DQ13
214
SDRAM_WE
213
SDRAM_RAS
212
SDRAM_DQM2
211
SDRAM_BA0
210
SDRAM_A1
208
207
SDRAM_DQ8
206
SDRAM_DQ26
205
SDRAM_DQ10
204
SDRAM_DQ12
203
SDRAM_DQ15
167
SDRAM_CAS
166
SDRAM_CS
165
SDRAM_DQM1
164
SDRAM_CKE
163
SDRAM_A0
161
SDRAM_DQ29
160
SDRAM_DQ4
159
SDRAM_DQ25
158
SDRAM_DQ9
157
SDRAM_DQ11
156
SDRAM_DQ14
155
SDRAM_DQ16
113
SDRAM_A3
112
SDRAM_A2
111
SDRAM_DQ19
110
SDRAM_DQ18
109
SDRAM_DQ22
108
SDRAM_DQ21
105
SDRAM_DQ31
104
SDRAM_A7
103
SDRAM_A5
102
SDRAM_A4
101
SDRAM_A8
100
SDRAM_A9
49
SDRAM_DQ17
47
SDRAM_DQ20
46
SDRAM_DQ24
45
SDRAM_DQ23
42
SDRAM_DQ30
41
SDRAM_DQ32
40
SDRAM_A6
38
SDRAM_A10
74M-CLK-TORINO
260
TORINO_STRM_D6
259
TORINO_HRDX
258
TORINO_STRM_D3
256
TORINO_HDT3
255
TORINO_HDT7
253
TORINO_HDT4
224
TORINO_STRM_D4
223
TORINO_STRM_D2
222
TORINO_STRM_D7
221
TORINO_STRM_IBRDY
220
TORINO_STRM_OBRDY
219
TORINO_HCLK
218
TORINO_A_STRM_ADT
217
TORINO_A_STRM_CLK
216 TORINO_A_STRM_IBARDY
215 TORINO_A_STRM_OBARDY
180
TORINO_HALE
179
TORINO_HCSX
178
TORINO_STRM_D0
177
TORINO_STRM_D5
176
TORINO_STRM_D1
175
TORINO_HDT1
174
TORINO_HDT5
173
TORINO_HDT0
172
TORINO_HDT2
171
TORINO_HDT6
170
TORINO_INT
169
TORINO_HWRX
168
128
127
126
TORINO_IBCLK_675
125
TORINO_VIDEO_Y4
124
TORINO_VIDEO_Y2
123
TORINO_VIDEO_Y7
122
TORINO_VIDEO_Y3
121
TORINO_VIDEO_C6
120
TORINO_VIDEO_C2
119
TORINO_VIDEO_C7
118
TORINO_VIDEO_C3
117
TORINO_VIDEO_FRM
116
TORINO_VIDEO_HD
115
TORINO_VIDEO_FLD
66
TORINO_VIDEO_Y6
64
74M-CLK-TORINO
63
TORINO_VIDEO_Y0
62
TORINO_VIDEO_Y5
61
TORINO_VIDEO_Y1
60
TORINO_VIDEO_C4
59
TORINO_VIDEO_C0
58
TORINO_VIDEO_C5
57
TORINO_VIDEO_C1
55
TORINO_VIDEO_VD
+2.5V
C741 0.1uF
GND
RST_TORINO
GND
GND
TORINO_VIDEO_FLD
TORINO_VIDEO_FRM
TORINO_VIDEO_C1
TORINO_VIDEO_C3
TORINO_VIDEO_C5
TORINO_VIDEO_C7
GND
TORINO_VIDEO_Y1
TORINO_VIDEO_Y3
TORINO_VIDEO_Y5
TORINO_VIDEO_Y7
GND
GND
(Reserve)
GND
TORINO_AUDIO_DT12
TORINO_AUDIO_OADT12
GND
(Reserve)
GND
TORINO_HALE
TORINO_HWRX
TORINO_INT
TORINO_HDT6
TORINO_HDT4
TORINO_HDT2
TORINO_HDT0
GND
GND
TORINO_JTSEL_S2
TORINO_SER_TX
TORINO_SER_CTSX
GND
TORINO_A_STRM_OBARDY
TORINO_A_STRM_IBARDY
GND
TORINO_STRM_D1
TORINO_STRM_D3
TORINO_STRM_D5
TORINO_STRM_D7
TORINO_STRM_OBRDY
GND
GND
+2.5V
+2.5V
+2.5V
+2.5V
GND
GND
GND
GND
GND
+1.0V
+1.0V
+1.0V
+1.0V
122
GND
2
R753
47
47
R754
7
5
3
1
RB723
8
6
4
2
TORINO_VIDEO_FLD
TORINO_VIDEO_FRM
TORINO_VIDEO_C1
TORINO_VIDEO_C3
TORINO_VIDEO_C5
TORINO_VIDEO_C7
8
6
4
2
TORINO_VIDEO_Y1
TORINO_VIDEO_Y3
TORINO_VIDEO_Y5
TORINO_VIDEO_Y7
47
7
5
3
1
RB724
47
CL701
1.2
R770
R771
47
47
TORINO_AUDIO_DT12
TORINO_AUDIO_OADT12
RB725
100
7
8 TORINO_HALE
5
6 TORINO_HWRX
3
4
TORINO_INT
R777 10k
1
2
CL702
1.2
RB726 7
100 5
3
1
R774
R775
7
5
3
1
8
6
4
2
7
5
3
1
8
6
4
2
RB727
100
NM
47
47
RB728
100
GND
TORINO_HDT6
TORINO_HDT4
TORINO_HDT2
TORINO_HDT0
8
6
4
2
TORINO_STRM_D1
TORINO_STRM_D3
TORINO_STRM_D5
TORINO_STRM_D7
TORINO_STRM_OBRDY
R755 100
+2.5V_TRN
+2.5V
FB705
FB706
C734
10uF
6.3V
GND
+1.0V_TRN
+1.0V
FB707
+1.0V_PLL
L704
10uH
+1.0V
C735
10uF
6.3V
GND
C736
10uF
6.3V
GND
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
CPU-D0
CPU-D1
CPU-D2
CPU-D3
CPU-D4
CPU-D5
CPU-D6
CPU-D7
CPU-A0
CPU-A1
CPU-WR
CPU-RD
CS_MAP
CS_TORINO
CS7:Mapping
CS6:TORINO
RB709
220
RB708
220
RB707
220
DPR-300 (7/28)
CPU_I/F
005,011,017,020,022,024,025
RB706
220
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_7
9-13
HSCU-300
9-13
M
DPR-300 (8/28)
DPR-300 (8/28)
from MAP FPGA PLL

74M-CLK-SDRAM-MAP
007
CS
RAS
CAS
WE
BA1
CKE
BA0
DQM0
DQM1
DQM2
DQM3
DQ31
A6
A3
A9
DQ15
DQ10
DQ7
DQ2
BA0
CAS
+3.2V
A2
A10
DQ23
DQ18
FB801
47
C803
0.1uF
10V
GND
DQ12
DQ14
DQ16
VccINT:+3.2V
VccIO :+3.2V
C811
0.1uF
10V
VDD1[R7]
DQ0[R8]
DQ2[R9]
DQ4[P9]
VDDQ3[N9]
VDDQ4[M9]
VSSQ5[L9]
28
29
30
31
32
33
34
35
36
37
38
39
GND
C810
0.1uF
DQ20
DQ22
DQ24
DQM0
RAS
A1
10V
GND-RAMI
C807
C808 0.1uF
0.1uF 10V
10V
C809
0.1uF
10V
GND
C804
10uF
6.3V
GND-RAMI
GND
A2
A3
A0
A1
A4
A5
A6
A7
A9
A8
A10
C805
0.1uF
10V
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
DQ21
DQ19
DQ17
DQM2
A0
BA1
CS
WE
DQ8
DQ6
DQ4
DQ4
DQ2
DQ3
DQ1
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
DQ16
DQ20
DQ18
DQ19
DQ17
DQ23
DQ21
DQ24
DQ22
DQ28
DQ27
DQ25
DQ26
DQ29
DQ30
DQ31
DQ32
C806
0.1uF
10V
58
VSSQ7[P3]
57
VDDQ8[P2]
56
DQ12[N2]
55
DQ10[M2]
DQM0[K9]
RAS[J9]
A11[H9]
A1[G9]
VDD2[F9]
VSSQ6[E9]
VDDQ5[D9]
VDDQ6[C9]
DQ19[B9]
DQ21[A9]
DQ23[A8]
VDD3[A7]
DQ1
DQ3
DQ5
21
22
23
24
25
26
27
91
90
89
88
87
86
85
84
83
82
SDRAM(256Mbit)
C812
0.1uF
10V
GND-RAMI
DQ14[N3]
DQ9[M3]
VSS4[L3]
NC4[K3]
A9[J3]
NC3[H3]
A6[G3]
A3[F3]
NC2[E3]
DQ30[D3]
IC800
W9825G2DB-75-ER25
DQ26
GND
DQ13
DQ11
FB803
GND-RAMI
GND
DQ9
R801
DQM1
VDDQ10[B7]
VSSQ9[B8]
DQ20[C8]
DQ18[D8]
DQ16[E8]
DQM2[F8]
A0[G8]
BA1[H8]
CS[J8]
WE[K8]
DQ7[L8]
DQ5[M8]
DQ3[N8]
VSSQ8[P8]
VDDQ9[P7]
DQ28
DQ30
DQ32
DQM3
A5
A8
CKE
GND
FB802
VSS3[A3]
DQ24[A2]
VDDQ7[B2]
DQ27[C2]
DQ29[D2]
DQ31[E2]
DQM3[F2]
A5[G2]
A8[H2]
CKE[J2]
NC1[K2]
DQ8[L2]
10V
A4
A7
+3.2V
81
DQ25[C3]
80
VSSQ10[B3]
43
44
45
46
47
48
49
50
51
52
53
54
DQ26[A1]
DQ28[B1]
VSSQ1[C1]
VSSQ2[D1]
VDDQ1[E1]
VSS1[F1]
A4[G1]
A7[H1]
CLK[J1]
DQM1[K1]
VDDQ2[L1]
VSSQ3[M1]
VSSQ4[N1]
DQ11[P1]
DQ13[R1]
DQ15[R2]
VSS2[R3]
DQ25
C802
0.1uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
DQ22[C7]
DQ17[D7]
NC6[E7]
A2[F7]
A10[G7]
NC5[H7]
BA0[J7]
CAS[K7]
VDD4[L7]
DQ6[M7]
DQ1[N7]
DQ27
DQ29
105
104
103
102
101
100
99
98
97
96
95
C801
10uF
6.3V
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
SDRAM_CS
SDRAM_RAS
SDRAM_CAS
SDRAM_WE
SDRAM_BA1
SDRAM_CKE
SDRAM_BA0
SDRAM_DQM0
SDRAM_DQM1
SDRAM_DQM2
SDRAM_DQM3
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
SDRAM_A2
SDRAM_A3
SDRAM_A0
SDRAM_A1
SDRAM_A4
SDRAM_A5
SDRAM_A6
SDRAM_A7
SDRAM_A9
SDRAM_A8
SDRAM_A10
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
7
5
3
1
8
6
4
2
SDRAM_DQ4
SDRAM_DQ2
SDRAM_DQ3
SDRAM_DQ1
SDRAM_DQ5
SDRAM_DQ6
SDRAM_DQ7
SDRAM_DQ8
SDRAM_DQ9
SDRAM_DQ10
SDRAM_DQ11
SDRAM_DQ12
SDRAM_DQ13
SDRAM_DQ14
SDRAM_DQ15
SDRAM_DQ16
SDRAM_DQ20
SDRAM_DQ18
SDRAM_DQ19
SDRAM_DQ17
SDRAM_DQ23
SDRAM_DQ21
SDRAM_DQ24
SDRAM_DQ22
SDRAM_DQ28
SDRAM_DQ27
SDRAM_DQ25
SDRAM_DQ26
SDRAM_DQ29
SDRAM_DQ30
SDRAM_DQ31
SDRAM_DQ32
SDRAM-MAP-CNT
007
SDRAM-MAP-ADRS
007
SDRAM-MAP-DQ
007
RB801
220
RB802
220
RB803
220
RB804
220
RB805
220
RB806
220
RB807
220
RB808
220
RB809
220
RB810
220
RB811
220
RB812
220
RB813
220
RB814
220
+3.2V
R802 4.7k
R803 4.7k
NM
GND
DPR-300 (8/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_8
9-14
A
9-14
HSCU-300
DPR-300 (9/28)
from MB
002,007
DPR-300 (9/28)
HD-RET-Y/C_in
+2.5V
FB900 C900 0.1uF
HD-RET-Y2_in
HD-RET-Y3_in
HD-RET-Y4_in
HD-RET-Y5_in
HD-RET-Y6_in
HD-RET-Y7_in
HD-RET-Y8_in
HD-RET-Y9_in
RB900
RB901
8
6
4
2
8
6
4
2
100
2
3
4
5
6
7
8
9
11
1
7
5
3
1
7
5
3
1
100
R900 47
74M-CLK-FF
20
VCC
D0
Q0
D1
Q1
D2
Q2
D3
Q3
D4
Q4
D5
Q5
D6
Q6
Q7
D7
CK
OE
GND
10
19
18
17
16
15
14
13
12
+2.5V
FB902 C904 0.1uF
GND
HD_SDI_IN_Y_2
HD_SDI_IN_Y_3
HD_SDI_IN_Y_4
HD_SDI_IN_Y_5
HD_SDI_IN_Y_6
HD_SDI_IN_Y_7
HD_SDI_IN_Y_8
HD_SDI_IN_Y_9
HD-RET-C2_in
HD-RET-C3_in
HD-RET-C4_in
HD-RET-C5_in
HD-RET-C6_in
HD-RET-C7_in
HD-RET-C8_in
HD-RET-C9_in
RB902 2
100 4
6
8
RB903 2
100 4
6
8
1
3
5
7
1
3
5
7
R902 47
IC900
TC74LCX574FT(EKJ)
2
3
4
5
6
7
8
9
11
1
20
VCC
D0
Q0
D1
Q1
D2
Q2
D3
Q3
D4
Q4
D5
Q5
D6
Q6
Q7
D7
CK
OE
GND
10
19
18
17
16
15
14
13
12
GND
HD_SDI_IN_C_2
HD_SDI_IN_C_3
HD_SDI_IN_C_4
HD_SDI_IN_C_5
HD_SDI_IN_C_6
HD_SDI_IN_C_7
HD_SDI_IN_C_8
HD_SDI_IN_C_9
IC902
TC74LCX574FT(EKJ)
005,007,020
GND
GND
to/from MAP FPGA

007
DAYTONA-RET-GPIO
tp/from MAP FPGA
007
DAYTONA-RET-UART
from MAP FPGA
007
DAYTONA-RET-FVH
DAYTONA-RET-F
RB905
47
HD_SDI_IN_Y_9GND 7
HD_SDI_IN_Y_7 5
HD_SDI_IN_Y_5 3
HD_SDI_IN_Y_3 1
GND
R913
DAYTONA-RET-GPIO_1
8
6
4
2
8
6
4
2
220
+2.5V
FB903
+5V-D
IC901
NJM2871BF33-TE2
R935
47
5
C910
1uF
6.3V
R901
2.2k
1
C901
0.1uF
10V
004,018
DAY_PLL33_P-ON-p
R916
100
VIN
CTL
VOUT
3
N_BYP
GND
C902
0.1uF
2
10V
GND
CL900
0.8
+3.3V_PLL_ENC
FB901
C903
1uF
6.3V
C905
10uF
from MAP FPGA
007
DAYTONA-RET-FRSEL
007
DAYTONA-RET-FFWRT
from MAP FPGA
007
DAYTONA-RET-FSYNC
DRET-UART-RX
MDTR_DHEN_TX
RB906
22
RB907
22
RB908
22
RB909
22
R905
R906
R907
R917
22
R908
MDTR_DT_TX_31
MDTR_DT_TX_29
MDTR_DT_TX_27
MDTR_DT_TX_25
2
4
6
8
1
3
5
7
MDTR_DT_TX_23
MDTR_DT_TX_21
MDTR_DT_TX_19
MDTR_DT_TX_17
MDTR_DT_TX_15
MDTR_DT_TX_13
MDTR_DT_TX_11
MDTR_DT_TX_9
2
4
6
8
2
4
6
8
1
3
5
7
1
3
5
7
MDTR_DT_TX_7
MDTR_DT_TX_5
MDTR_DT_TX_3
MDTR_DT_TX_1
2
4
6
8
1
3
5
7
220
220
220
22
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
48
50
52
54
56
58
60
62
64
66
68
70
72
74
76
78
80
82
84
86
88
90
92
94
96
98
100
102
104
106
108
110
112
114
116
118
120
122
GND
CN900
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
35
37
39
41
43
45
47
49
51
53
55
57
59
61
63
65
67
69
71
73
75
77
79
81
83
85
87
89
91
93
95
97
99
101
103
105
107
109
111
113
115
117
119
121
MCLC_VAL_DE
MCLC_FLD
MCLC_CK
GND
MCLC_C(10)
MCLC_C(8)
MCLC_C(6)
MCLC_C(4)
MCLC_C(2)
MCLC_C(0)
GND
MCLC_Y(10)
MCLC_Y(8)
MCLC_Y(6)
MCLC_Y(4)
MCLC_Y(2)
MCLC_Y(0)
GND
GPIO(0)
+2.5V
+2.5V
+1.2V
+1.2V
+1.2V
+1.2V
GND
GND
GND
+3.3V_PLL
+3.3V
+3.3V
+3.3V
+3.3V
GND
EXT_PCLK
SYS_RESET_X
UART0_TXD
DTIF_DDEN
DTIF_DATA(30)
GND
DTIF_DATA(28)
DTIF_DATA(26)
DTIF_DATA(24)
DTIF_DATA(22)
DTIF_DATA(20)
GND
DTIF_DATA(18)
DTIF_DATA(16)
DTIF_DATA(14)
DTIF_DATA(12)
DTIF_DATA(10)
GND
DTIF_DATA(8)
DTIF_DATA(6)
DTIF_DATA(4)
DTIF_DATA(2)
DTIF_DATA(0)
GND
DTIF_PCLK
ENC/DEC_MODE
47
R921
7
5
3
1
RB910
47
8
6
4
2
HD_SDI_IN_C_8
HD_SDI_IN_C_6
HD_SDI_IN_C_4
HD_SDI_IN_C_2
7
5
3
1
RB911
47
8GND
6
4
2
R920
220 GND
HD_SDI_IN_Y_8
HD_SDI_IN_Y_6
HD_SDI_IN_Y_4
HD_SDI_IN_Y_2
+2.5V
DAYTONA-RET-GPIO_0
FB906
C908 10uF
FB907
+1.2V_DAY
FB908
C906 10uF
+3.3V_PLL_ENC
74M-CLK-DAYTONA-RET 005
+3.2V
+3.2V
FB911
C907 10uF
R928
R929
R930
R927
22
22
22
22
IC903 (1/2)
TC7SZ08FU(TE85R)
R926 NM 2.2k
GND
47
R932
2
1
DRET-UART-TX
MDTR_DDEN_TX
2
4
6
8
1
3
5
7
MDTR_DT_TX_30
MDTR_DT_TX_28
MDTR_DT_TX_26
MDTR_DT_TX_24
2
4
6
8
2
4
6
8
1
3
5
7
1
3
5
7
MDTR_DT_TX_22
MDTR_DT_TX_20
MDTR_DT_TX_18
MDTR_DT_TX_16
MDTR_DT_TX_14
MDTR_DT_TX_12
MDTR_DT_TX_10
MDTR_DT_TX_8
2
4
6
8
1
3
5
7
MDTR_DT_TX_6
MDTR_DT_TX_4
MDTR_DT_TX_2
MDTR_DT_TX_0
RB912
22
47
47
R933
R934
005,007,011,017,018
DPR-RESET_2
DAYTONA-RET-RESET
007
+3.2V from FPGA MAP
+3.2V
IC903 (2/2)
TC7SZ08FU(TE85R)
RB904
47
(Reserve)
MCLC_VAL_V
MCLC_VAL_H
GND
MCLC_C(11)
MCLC_C(9)
MCLC_C(7)
MCLC_C(5)
MCLC_C(3)
MCLC_C(1)
GND
MCLC_Y(11)
MCLC_Y(9)
MCLC_Y(7)
MCLC_Y(5)
MCLC_Y(3)
MCLC_Y(1)
GND
GPIO(1)
GND
GND
GND
GND
GND
GND
+V_RG18
+V_RG18
+V_RG18
+3.3V_PLL
GND
GND
GND
GND
FRSEL
FFWRT
FSYNC
UART0_RXD
DTIF_DHEN
DTIF_DATA(31)
GND
DTIF_DATA(29)
DTIF_DATA(27)
DTIF_DATA(25)
DTIF_DATA(23)
DTIF_DATA(21)
GND
DTIF_DATA(19)
DTIF_DATA(17)
DTIF_DATA(15)
DTIF_DATA(13)
DTIF_DATA(11)
GND
DTIF_DATA(9)
DTIF_DATA(7)
DTIF_DATA(5)
DTIF_DATA(3)
DTIF_DATA(1)
GND
DTIF_PLD_EN
DTIF_PLD_ST
RB913
22
C909
0.1uF
VCC
GND
3
7
5
3
1
HD_SDI_IN_C_9
HD_SDI_IN_C_7
HD_SDI_IN_C_5
HD_SDI_IN_C_3
47
47
R931
10k
R903
R904
DAYTONA-RET-V
DAYTONA-RET-H
2
+2.5V
GND
DY-23 RET(ENC)
CL901
1.2
GND
RB914
22
RB915
22
GND
ENC
GND
MDTR_TX
to CAFE-T
011
DPR-300 (9/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_9
9-15
HSCU-300
9-15
E
DPR-300 (11/28)
DPR-300 (11/28)
+1.8V
R1101
0
R1102
0
TS IN/OUT
35
I_MUX_BUS_SEL_0
58
I_MUX_BUS_SEL_1
195
GND
124
123
122
118
117
116
184
185
186
190
191
192
193
194
172
173
177
179
180
181
182
183
161
162
163
164
165
167
170
171
149
150
151
152
155
156
157
158
138
139
140
141
142
143
144
145
127
128
129
130
131
132
136
137
L1101
1uH
L1102
1uH
C1101 1uF
C1113 0.1uF
C1102 1uF
C1114 0.1uF
C1103 1uF
C1115 0.1uF
C1104 1uF
C1116 0.1uF
C1105 1uF
C1117 0.1uF
C1106 1uF
C1118 0.1uF
C1107 1uF
C1119 0.1uF
O_TS_REQ1
O_TS_REQ2
O_TS_REQ3
O_TS_REQ4
O_TS_REQ5
O_TS_REQ6
B_TS_DATA1_0
B_TS_DATA1_1
B_TS_DATA1_2
B_TS_DATA1_3
B_TS_DATA1_4
B_TS_DATA1_5
B_TS_DATA1_6
B_TS_DATA1_7
C1108 1uF
C1120 0.1uF
C1109 1uF
C1121 0.1uF
C1110 1uF
C1122 0.1uF
C1111 1uF
C1123 0.1uF
C1112 1uF
+3.2V
L1103
1uH
C1125 10uF
6.3V
B_TS_DATA3_0
B_TS_DATA3_1
B_TS_DATA3_2
B_TS_DATA3_3
B_TS_DATA3_4
B_TS_DATA3_5
B_TS_DATA3_6
B_TS_DATA3_7
31
38
56
90
101
159
166
211
230
GND
SIGN31694
C1126 1uF
C1139 0.1uF
C1127 1uF
C1140 0.1uF
C1128 1uF
C1141 0.1uF
C1129 1uF
C1142 0.1uF
C1130 1uF
25
40
85
97
109
153
168
213
225
237
C1143 0.1uF
C1131 1uF
C1144 0.1uF
C1132 1uF
C1145 0.1uF
C1133 1uF
C1146 0.1uF
C1134 1uF
C1147 0.1uF
C1135 1uF
C1148 0.1uF
C1136 1uF
C1149 0.1uF
C1137 1uF
C1150 0.1uF
C1138 0.1uF
B_TS_DATA4_0
B_TS_DATA4_1
B_TS_DATA4_2
B_TS_DATA4_3
B_TS_DATA4_4
B_TS_DATA4_5
B_TS_DATA4_6
B_TS_DATA4_7
B_TS_DATA5_0
B_TS_DATA5_1
B_TS_DATA5_2
B_TS_DATA5_3
B_TS_DATA5_4
B_TS_DATA5_5
B_TS_DATA5_6
B_TS_DATA5_7
6
19
47
74
79
114
121
134
147
175
188
202
207
242
249
7
17
30
52
61
71
78
103
120
125
135
148
176
189
196
248
VDDL1
VDDL2
VDDL3
VDDL4
VDDL5
VDDL6
VDDL7
VDDL8
VDDL9
VDDL10
VDDL11
VDDL12
VDDL13
VDDL14
VDDL15
PLLVDD
PLLVSS
60
C1151 1uF
C1152 0.1uF
59
from Daytona Main ENC

009
O_VDD18_1
O_VDD18_2
O_VDD18_3
O_VDD18_4
O_VDD18_5
O_VDD18_6
O_VDD18_7
O_VDD18_8
O_VDD18_9
VDDH1
VDDH2
VDDH3
VDDH4
VDDH5
VDDH6
VDDH7
VDDH8
VDDH9
VDDH10
O_VDD3_1
O_VDD3_2
O_VDD3_3
O_VDD3_4
O_VDD3_5
O_VDD3_6
O_VDD3_7
O_VDD3_8
O_VDD3_9
O_VDD3_10
O_VDD3_11
O_VDD3_12
O_VDD3_13
O_VDD3_14
O_VDD3_15
O_VDD3_16
VSS1
VSS2
VSS3
VSS4
VSS5
VSS6
VSS7
VSS8
VSS9
VSS10
VSS11
VSS12
VSS13
VSS14
VSS15
VSS16
VSS17
VSS18
VSS19
O_VSS_1
O_VSS_2
O_VSS_3
O_VSS_4
O_VSS_5
O_VSS_6
O_VSS_7
O_VSS_8
O_VSS_9
O_VSS_10
O_VSS_11
O_VSS_12
5
18
32
46
72
84
96
108
119
133
146
160
174
187
200
212
224
236
247
MDTR_TX
MDTR_DHEN_TX
MDTR_DDEN_TX
MDTR_DT_TX_0
MDTR_DT_TX_1
MDTR_DT_TX_2
MDTR_DT_TX_3
MDTR_DT_TX_4
MDTR_DT_TX_5
MDTR_DT_TX_6
MDTR_DT_TX_7
MDTR_DT_TX_8
MDTR_DT_TX_9
MDTR_DT_TX_10
MDTR_DT_TX_11
MDTR_DT_TX_12
MDTR_DT_TX_13
MDTR_DT_TX_14
MDTR_DT_TX_15
MDTR_DT_TX_16
MDTR_DT_TX_17
MDTR_DT_TX_18
MDTR_DT_TX_19
MDTR_DT_TX_20
MDTR_DT_TX_21
MDTR_DT_TX_22
MDTR_DT_TX_23
MDTR_DT_TX_24
MDTR_DT_TX_25
MDTR_DT_TX_26
MDTR_DT_TX_27
MDTR_DT_TX_28
MDTR_DT_TX_29
MDTR_DT_TX_30
MDTR_DT_TX_31
FB1101
from MAP FPGA

007
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
RB1105
47
RB1106
47
RB1107
47
RB1108
47
RB1109
47
RB1110
47
RB1111
47
RB1112
47
R1134 47
CAFE-T_SV
SUB_VIDEO_CLK
R1130
SUB_VIDEO_REQ
SUB_VIDEO_DATA_0 7
SUB_VIDEO_DATA_1 5
SUB_VIDEO_DATA_2 3
SUB_VIDEO_DATA_3 1
SUB_VIDEO_DATA_4 7
SUB_VIDEO_DATA_5 5
SUB_VIDEO_DATA_6 3
SUB_VIDEO_DATA_7 1
002
007
GND
R1127 47
R1128 47
R1129
26
54
62
80
93
102
126
154
169
178
197
206
INPUT DATA
R1196
2.2k
NM
GND
IC1101 (5/5)
CXD9217R
GND
R1126 47
L1104
10uH
PWR/GND
C1124
10uF
6.3V
O_TS_CLK
B_TS_DATA2_0
B_TS_DATA2_1
B_TS_DATA2_2
B_TS_DATA2_3
B_TS_DATA2_4
B_TS_DATA2_5
B_TS_DATA2_6
B_TS_DATA2_7
from MAP FPGA

007 74M-CLK-PLL-CAFE-T
+1.8V
GND
47
47
8
6
4
2
8
6
4
2
RB1113
47
RB1114
47
R1131 47
CMD_700P
CAFE-T_AU
AUDIO_FS
AUDIO_MIC
AUDIO_AES
AUDIO_INCOM
AUDIO_TRUNK
AUDIO_FS64
GND
R1132
47
1
3
5
7
2
4
6 RB1115
8 47
R1133 47
B_TS_DATA6_0
B_TS_DATA6_1
B_TS_DATA6_2
B_TS_DATA6_3
B_TS_DATA6_4
B_TS_DATA6_5
B_TS_DATA6_6
B_TS_DATA6_7
198
199
201
203
204
205
208
209
210
214
215
216
217
218
219
220
221
222
223
226
227
228
229
231
232
233
234
235
238
239
240
241
243
244
245
4
246
2
1
256
255
254
253
252
251
250
8
9
10
11
12
13
14
I_DTIF_PCLK
I_MDTR_DHEN_TX
I_MDTR_DDEN_TX
I_MDTR_DT_TX_0
I_MDTR_DT_TX_1
I_MDTR_DT_TX_2
I_MDTR_DT_TX_3
I_MDTR_DT_TX_4
I_MDTR_DT_TX_5
I_MDTR_DT_TX_6
I_MDTR_DT_TX_7
I_MDTR_DT_TX_8
I_MDTR_DT_TX_9
I_MDTR_DT_TX_10
I_MDTR_DT_TX_11
I_MDTR_DT_TX_12
I_MDTR_DT_TX_13
I_MDTR_DT_TX_14
I_MDTR_DT_TX_15
I_MDTR_DT_TX_16
I_MDTR_DT_TX_17
I_MDTR_DT_TX_18
I_MDTR_DT_TX_19
I_MDTR_DT_TX_20
I_MDTR_DT_TX_21
I_MDTR_DT_TX_22
I_MDTR_DT_TX_23
I_MDTR_DT_TX_24
I_MDTR_DT_TX_25
I_MDTR_DT_TX_26
I_MDTR_DT_TX_27
I_MDTR_DT_TX_28
I_MDTR_DT_TX_29
I_MDTR_DT_TX_30
I_MDTR_DT_TX_31
I_SKIN_GATE
I_SUB_VID_CLK
I_SUB_VID_REQ
I_SUB_VID_DATA0
I_SUB_VID_DATA1
I_SUB_VID_DATA2
I_SUB_VID_DATA3
I_SUB_VID_DATA4
I_SUB_VID_DATA5
I_SUB_VID_DATA6
I_SUB_VID_DATA7
I_CMD_700P
I_AUD_FS
I_AUD_MIC
I_AUD_AES
I_AUD_INCOM
I_AUD_TRUNK
I_AUD_FS64
IC1101 (1/5)
CXD9217R
IC1101 (3/5)
CXD9217R
9-16
A
9-16
HSCU-300
DPR-300 (11/28)
DPR-300 (11/28)
IC1109
NJM2871BF33-TE2
+5V-D
5
R1153
47k 1
C1170
0.1uF
10V
+1.8V
VIN
CTL
+1.8V-BI
VOUT
4
3
N_BYP
GND
C1171
0.1uF
2
10V
C1172
10uF
6.3V
1608
CL1112
0.8
1
(+3.3V)
+1.2V-BI
L1105
10uH
R1136
3.3k
R1135
0
R1137
3.3k
OFDM-T-GND
R1138
3.3k
+1.2V-REF1
C1160
10uF
6.3V
C1161
0.1uF
C1162
0.1uF
R1139
1k
NM
R1151
R1152
OFDM_LOW_DATA_13
OFDM_LOW_DATA_12
OFDM_LOW_DATA_11
OFDM_LOW_DATA_10
OFDM_LOW_DATA_9
OFDM_LOW_DATA_8
GND
22
22
1
3
5
7
R1155
3.3k
2
4
6
8
RB1116
22
SL1101
SC
R1154 10k
NM
CPU_I/F
CPU-WR
CPU-A0
CPU-D0
CPU-D1
CPU-D2
CPU-D3
CPU-D4
CPU-D5
CPU-D6
CPU-D7
CS_CAFE-T
CPU-RD
005,007,017,020,022,024,025
R1113
100
007
1
3
5
7
1
3
5
7
1
3
5
7
RB1101
47
2
4
6
8
2
4
6
8
2
4
6
8
33
34
15
16
20
21
22
23
24
27
28
29
R1115
47
+3.2V
R1121
R1122
R1123
R1114
1k
3
42
43
44
48
45
1k
1k
1k
R1124
NM
89
I_PCML_BIAS
88
O_PCML_BIAS
87
O_OFDM_LOW_CK_P
86
O_OFDM_LOW_CK_N
183MHz
LO
LO
LO
18MHz
O_OFDM_LOW_DT_0
O_OFDM_LOW_DT_1
O_OFDM_LOW_DT_2
O_OFDM_LOW_DT_3
O_OFDM_LOW_DT_4
O_OFDM_LOW_DT_5
O_OFDM_LOW_DT_6
O_OFDM_LOW_DT_7
O_OFDM_LOW_DT_8
O_OFDM_LOW_DT_9
O_OFDM_LOW_DT_10
O_OFDM_LOW_DT_11
O_OFDM_LOW_DT_12
O_OFDM_LOW_DT_13
37
I_SRST_X
39
I_PLL_RST_X
57
I_RST_X
RB1102
47
RB1103
47
SYNC_IN
GND
LO
LO
R1116 1k
R1120 0
I_CPU_CS_X
I_CPU_RD_X
I_CPU_WR_X
I_CPU_ADRS_0
B_CPU_DATA_0
B_CPU_DATA_1
B_CPU_DATA_2
B_CPU_DATA_3
B_CPU_DATA_4
B_CPU_DATA_5
B_CPU_DATA_6
B_CPU_DATA_7
92
O_OFDM_MID_CK_P
91
O_OFDM_MID_CK_N
O_OFDM_MID_DT_0
O_OFDM_MID_DT_1
O_OFDM_MID_DT_2
O_OFDM_MID_DT_3
O_OFDM_MID_DT_4
O_OFDM_MID_DT_5
O_OFDM_MID_DT_6
O_OFDM_MID_DT_7
O_OFDM_MID_DT_8
O_OFDM_MID_DT_9
O_OFDM_MID_DT_10
O_OFDM_MID_DT_11
O_OFDM_MID_DT_12
O_OFDM_MID_DT_13
I_SYNC_IN
TDI
TCK
TMS
TRST
TDO
36
I_PLL_THRU
50
I_PC
IC1101 (2/5)
CXD9217R
GND
64
65
66
67
68
69
70
73
75
76
77
81
82
83
94
95
98
99
100
104
105
106
107
110
111
112
113
115
R1143
R1144
C1015
0.1uF NM
100
100
+1.2V-BI
+1.8V-BI
PECL
0.1uF NM
C1016
OFDM_LOW_DATA_0
OFDM_LOW_DATA_1
OFDM_LOW_DATA_2
OFDM_LOW_DATA_3
OFDM_LOW_DATA_4
OFDM_LOW_DATA_5
OFDM_LOW_DATA_6
OFDM_LOW_DATA_7
OFDM_LOW_DATA_8
OFDM_LOW_DATA_9
OFDM_LOW_DATA_10
OFDM_LOW_DATA_11
OFDM_LOW_DATA_12
OFDM_LOW_DATA_13
1
3
5
7
1
3
5
7
OFDM_LOW_DATA_7
OFDM_LOW_DATA_6
OFDM_LOW_DATA_5
OFDM_LOW_DATA_4
OFDM_LOW_DATA_3
OFDM_LOW_DATA_2
OFDM_LOW_DATA_1
OFDM_LOW_DATA_0
RB1117
22
1
2
3
4
5
6
7
8
2
4
6
8
2
4
6
8
DB7
DB6
DVDD
DB5
DB4
DB3
DB2
DB1
RB1118
22
IC1103
AD9744ACPZ
C1179
0.1uF
FSADJ
REFIO
ACOM2
IOUTA
IOUTB
ACOM1
AVDD2
AVDD1
0.1uF NM
C1018
OFDM_MID_DATA_0
OFDM_MID_DATA_1
OFDM_MID_DATA_2
OFDM_MID_DATA_3
OFDM_MID_DATA_4
OFDM_MID_DATA_5
OFDM_MID_DATA_6
OFDM_MID_DATA_7
OFDM_MID_DATA_8
OFDM_MID_DATA_9
OFDM_MID_DATA_10
OFDM_MID_DATA_11
OFDM_MID_DATA_12
OFDM_MID_DATA_13
R1164
R1165
OFDM_MID_DATA_13
OFDM_MID_DATA_12
OFDM_MID_DATA_11
OFDM_MID_DATA_10
OFDM_MID_DATA_9
OFDM_MID_DATA_8
GND
1/10W
C1157
10uF
R1111
47k
C1158
0.1uF
10V
VIN
CTL
VOUT
4
3
N_BYP
GND
C1159
0.1uF
2
10V
C1163
10uF
6.3V
1608
6
+DC
1 STNBY
4
OUT1
2
5
NC
OUT2
GND
X1101
3
0Hz
181422311
GND
(82.857143MHz)
4
DIFF. 100(OHRM)
R1140
100
IN+
R1168
3.3k
OUT
INGND1 GND2
2
5
R1104
10
FB1109
2
GND-A
R1178
68
OFDM-T-GND
SC
R1166 10k
NM
+3.2V
EPAD
DB8
DB9
DB10
DB11
DB12
DB13
DCOM2
SLEEP
1
2
3
4
5
6
7
8
2
4
6
8
2
4
6
8
DB7
DB6
DVDD
DB5
DB4
DB3
DB2
DB1
IC1104
AD9744ACPZ
9
10
11
12
13
14
15
16
0.1uF
C1189
10uF
C1190
R1195
47
NM
RB1120
22
DB0
DCOM1
CLKVDD
CLK+
CLKCLKCOM
CMODE
MODE
1
3
5
7
1
3
5
7
FSADJ
REFIO
ACOM2
IOUTA
IOUTB
ACOM1
AVDD2
AVDD1
0 R1169
NM
R1172
1k
24
23
22
21
20
19
18
17
R1173
1k
C1184
0.1uF
R1186
0
FB1107
R1187
0
R1182
68
NM
R1183
68
R1175
0
R1185
68
NM
OF_F8(X)
OF_F8(Y)
012
012
FB1110
GND-A
R1184
68
C1185 C1186 C1187

0.1uF 0.1uF 10uF
GND
FB1108
OFDM-T-GND
GND
R1141
220
L1106
10nH
183MHz
1608
C1164
0.1uF
C1153
10pF
IC1108
MAX9130EXT+TG069
GND
012
012
C1183
0.1uF
SL1102
TP1100
1
VCC
FB1105
R1179
100
OF_F9/7(X)
OF_F9/7(Y)
+1.2V-REF2
R1167
3.3k
R1170 R1171
1k
0
33
32
31
30
29
28
27
26
25
IC1102
NJM2871BF33-TE2
R1110
10
183M
C1165
0.1uF
R1176
100
C1176 C1177 C1178

0.1uF 0.1uF 10uF
R1192
47
2
4
6
8
C1188
0.1uF
(+3.3V)
FB1104
R1181
0
R1177
68
R1163
0
22
22
1
3
5
7
RB1121
22
C1156
10uF
6.3V
GND
R1180
0
OFDM_MID_DATA_7
OFDM_MID_DATA_6
OFDM_MID_DATA_5
OFDM_MID_DATA_4
OFDM_MID_DATA_3
OFDM_MID_DATA_2
OFDM_MID_DATA_1
OFDM_MID_DATA_0
FB1111
C1175
0.1uF
C1017
0.1uF NM
FB1106
FB1102
R1161
1k
GND
RB1119
22
183MHz SPXO
R1160
1k
PECL
IC1101 (4/5)
CXD9217R
+5V-D
C1173
0.1uF
0 R1157
NM
24
23
22
21
20
19
18
17
NM
GND
HI
LO
183MHz
EPAD
DB8
DB9
DB10
DB11
DB12
DB13
DCOM2
SLEEP
33
32
31
30
29
28
27
26
25
R1103
10k
HI
HI
R1145
0
DB0
DCOM1
CLKVDD
CLK+
CLKCLKCOM
CMODE
MODE
DPR-RESET_2
R1112
R1125
R1119
51
I_CLK183
1k 53
I_XTAL_A
1k 55
I_CLK18
1k 41
I_TCLK185
MODE1
9
10
11
12
13
14
15
16
R1106
47
005,007,009,017,018
C576
+3.2V
22
100pF
NM
R1117
MODE2
C1180
10uF
R1142 1k 63
I_CLK_MODE_SEL_1
R1118 1k 49
I_CLK_MODE_SEL_2
FB1103
OFDM OUT
MODE3
C1181
0.1uF
CLK/RST/CPU
+3.2V
R1158 R1159
1k
0
R1156
3.3k
+3.2V
C1174
1uF
DPR-300 (11/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_11
9-17
HSCU-300
9-17
M
DPR-300 (12/28)
DPR-300 (12/28)
+5V
Q201
2SC4176T1B33B34B35
L201
10uH
C201 C202
10uF 0.1uF
Q202
2SC4176T1B33B34B35
R201
15k
X201
4MHz
Q203
2SC4176T1B33B34B35
C1247
22pF
R211
470
Q215
2SC4176T1B33B34B35
R205
4.7k
C203
5pF
R202
22k
R203
10k
NM
C209
0.1uF
CL201
1.5
R209
6.8k
R206
330
C206
10pF
R1204
1k
C208
0.1uF
C210
0.1uF
CL202
1.5
C204
100pF
C207
6pF
R210
6.8k
R207
330
R208
6.8k
C205 R204
470pF 1k
R212
470
D203
DA221-TL
GND-A
Q204
2SC4176T1B33B34B35
Q205
2SC4176T1B33B34B35
C1248
22pF
R218
470
Q214
2SC4176T1B33B34B35
C212
0.1uF
R216
6.8k
R213
330
R283
1k
C211
0.1uF
R214
330
R217
6.8k
R215
6.8k
TRX001_20
013,014
TRX001_19
013,014
C213
0.1uF
R219
470
4MHz_X
4MHz_Y
L213
1uH
Q210
2SC3356-T1K
R1220
10k
C1252
10uF
Q211
2SC3356-T1K
R1222
330
R1223
330
R1225
10k
R1210
1k
C1251
0.1uF
R1211
1k
C1253
3pF
R1221
10k
R1227
470
C1254
3pF
C1255
0.1uF
NM
R1228
2.2k
NM
C1250
0.1uF
014
014
R1224
100
Q212
2SC4176T1B33B34B35
R1226
10k
R1229
220
Q213
2SC4176T1B33B34B35
9-18
A
9-18
HSCU-300
DPR-300 (12/28)
+5V
DPR-300 (12/28)
0.47uH
L212
L203
0.47uH
C237
2.2uF
1608
C236
10uF
C243 1pF NM
L204
82nH
C245 22pF
D201
R24210k
HVU363ATRU
C253
1000pF
100pF
C240
NM
R243
C241
NM 0.01uF 47k
C242
220pF
GND-A
C249
8pF
C250
0.01uF
C248
6pF
R244
33
C261
100pF
R237
10
R232 R233
10 15k
R1214
22
NM
Q206
2SC3356-T1K
IC204 (1/2)
LMH6550MAX
C233
0.01uF
V+
V-
C231
0.01uF
C230
R235 0.01uF
2.2k
R234
10k
R238
10k
C234 V+
0.01uF V-
Q207
2SC3356-T1K
IC203 (2/2)
LMH6550MAX
FL201
C292
10uF
20
19
18
17
16
15
14
13
12
11
REF2
REF1
NC1
CP
VT
SUB3
OSCB2
OSCC2
OSCC1
OSCB1
C278
0.01uF
4
5
R1209
100
7
2
C1242
1pF
E201
R270
330
C282
0.01uF
R1216
22
NM
R263 R264
10 15k
R265
10k
IC208 (1/2)
LMH6550MAX
R266
2.2k
Q208
2SC3356-T1K
C289
0.01uF
R1217
22
NM
C285
1000pF
C280
0.1uF
IC207 (1/2)
LMH6550MAX
R267
15k
C288
0.01uF
R271
330
R268
10
C1244
1pF
C276
0.01uF
C275
0.1uF
GND-A
C281
0.01uF
V+
V-
C287
0.01uF
C286
0.01uF
R269
10k
R272
2.2k
R277
0
On Board Contact for IC208
Driver_Temp
VS
VO
016,017
R1212
100
R278
Cable_550m
1
2
016
GND
3
016,017
R280
Cable_370m
2
1
210
209
R276
330
OF_F8(Y)
OF_F8(X)
011
011
P11
36MHz OFDM
VCC
GND
IC211 (1/2)
TC7SH08FU(T5RSOYJF)
1
4 2
211
016,017
R282
Cable_720m
2
1
213
1
2
VCC
GND
212
C1217
0.01uF
R285
0
IC213 (1/2)
IC212 (1/2)
TC7SH00FU(T5RSOYJF)TC7SH32FU(T5RSOYJF)
+5V
GND-A
GND-A
R275
330
R274
470
C299
1000pF
IC209 (2/2)
TC7SH00FU(T5RSOYJF)
IC210 (2/2)
TC7SH00FU(T5RSOYJF)
IC209 (1/2)
TC7SH00FU(T5RSOYJF)
IC210 (1/2)
TC7SH00FU(T5RSOYJF)
TEMP-IN
C1236
2pF
FL202
13 12 16 15 5 10 18 4 6 11 14 17
O1 I1 O2 I2 LC1LC2LC3NC1NC2NC3NC4NC5
1
9
IN
OUT
GND1 GND2
GND3 GND4
2
3
7
8
20
19
C298 R247 R273
1pF 3.3k 470
NM NM
IC208 (2/2)
LMH6550MAX
IC207 (2/2)
LMH6550MAX
Q209
2SC3356-T1K
+5V
C291
0.01uF
1
2
3
4
5
6
7
8
Hi :ATT_ON
E204
IC216
LM45BIM3X
V+
C290
0.01uF V-
VCC1
INPUT1
INPUT2
GND1
IC206
VCC2
CXA3793R-T4
RSSIC1
RSSIC2
GND2
C1216 0.01uF
C277
0.01uF
C1210 0.01uF
C1209
0.1uF
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
VCC4
GND4
SUB
NC
C1214 10uF
C1215 0.01uF
L210
C1206 120nH
47pF
NM
C1235
10pF
GND-A
R1213
470
0.01uF
C1200 2pF
C1208
0.1uF
C1207
3pF
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
T203
C1233
2pF
C1234
GND-A 10pF
NM C1204
L209
47pF 120nH
C1203 C1205
4pF 22pF
C1202
1
2
3
C1201
0.01uF
VCC
GND
3
8
R256
470
R258
220
R254
15
R257
220
R255
470
1
C293
0.01uF
IC205
CXA3792Q-T4
10
9
8
7
6
5
4
3
2
1
IF2GND
IF2IN1
IF2IN2
REG
SUB5
NC3
IF1VCC
IF1OUT
NC4
IF1GND
R253
15
C1260
GND-A
31
32
33
34
35
36
37
38
39
40
R252
15
C273
0.01uF
GND-A
VCOVCC
VCOGND
SUB2
MIXGND
MIXIN2
MIXIN1
MIXVCC
SUB1
MIXOUT2
MIXOUT1
C294 0.01uF
C295 0.01uF
C296 10uF
C272
0.01uF
C284
10uF
16V
C283
100pF
1000pF
1000pF
1000pF
3
2
1
C1243 1pF
R281
3.3k
680
R259
R261
75
1
R262
75
+
8
R260
680
R284
3.3k
C1259
PLLVCC
DATA1
DATA2
DATA3
PLLGND
SUB4
NC2
IF2VCC
IF2OUT1
IF2OUT2
T204
4
R1208
100
GND-A
21
22
R1231
23
330 330 24
R1232 25
26
27
28
29
30
R1230
330
C1258
R251
15
P11
C297
0.01uF
L207
0.47uH
+12V
C279
0.1uF
011
011
26/46MHz OFDM
C251
4pF
NM
IC204 (2/2)
LMH6550MAX
GND-A
GND-A
C1241
1pF
OF_F9/7(Y)
OF_F9/7(X)
+5V
L208
0.47uH
C274
0.1uF
R250
330
13 12 16 15 5 10 18 4 6 11 14 17
1
9
IN
OUT
R245
GND1 GND2
GND3 GND4
470
2
3
7
8
20
19
E203
On Board Contact for IC204
F8 96MHz
R249
330
R248
470
C252
1000pF
C235
0.01uF
R241
2.2k
HOLD_PULSE
HIGH-P
LOW-P
REG25_2
STEP_LOW_SW-OUT
LL-POINT
STEP_HIGH_SW-OUT
ATT_DRIVER
C1246
1pF
NM
C1213 1000pF
E202
R236
15k
C229
1000pF
C1240
1k
C232
0.01uF
R240
330
R1215
22
NM
VCC3
VCONT2
VCONT1
GND3
REG25_1
INPUTP
INPUTN
DETOUT
C226
0.01uF
16
15
14
13
12
C269 10uF
11
C270 0.01uF 10
C271 0.01uF 9
R231
75
C264
0.1uF
C1232
10pF
C266
+
8
R229
680
C260
47pF
NM
GND-A
1
2
3
4
5
6
7
8
25
26
27
28
29
30
31
32
GND-A
R239
330
C224
0.1uF
IC203 (1/2)
LMH6550MAX
GND-A
66MHz TRAP
4
5
C220
0.01uF
C219
0.1uF
GND-A
C222
0.01uF
C225
0.01uF
VCC1
INPUT1
INPUT2
GND1
IC202
VCC2
CXA3793R-T4
RSSIC1
RSSIC2
GND2
HOLD_PULSE
HIGH-P
LOW-P
REG25_2
STEP_LOW_SW-OUT
LL-POINT
STEP_HIGH_SW-OUT
ATT_DRIVER
C1238
1pF
NM
R279
10
GND-A
R230
75
C265 0.01uF
C262
4pF
L206
120nH
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
VCC4
GND4
SUB
NC
VCC3
VCONT2
VCONT1
GND3
REG25_1
INPUTP
INPUTN
DETOUT
R227
220
R1207
100
R228
680
1
C257 C259
2pF 22pF
R246
470
C256 0.01uF
C1249 2pF
24
23
22
21
20
19
18
17
C1211 0.01uF
C1212 0.01uF
8
R225
470
C221
0.01uF
C263
0.1uF
C1218
0.01uF
R223
15
T201 6
C1231
8pF
GND-A
NM C258
L205
47pF 120nH
VCC
GND
VCC
GND
C1219
0.01uF
1
2
3
C1245
1pF
C215
22pF
1608
L214
0.47uH
R226
220
C255
0.01uF
R222
15
R224
470
1
10
9
8
7
6
5
4
3
2
1
IF2GND
IF2IN1
IF2IN2
REG
SUB5
NC3
IF1VCC
IF1OUT
NC4
IF1GND
C217
0.01uF
IC201
CXA3792Q-T4
31
32
33
34
35
36
37
38
39
40
C216
0.01uF
C228
10uF
16V
C227
100pF
VCOVCC
VCOGND
SUB2
MIXGND
MIXIN2
MIXIN1
MIXVCC
SUB1
MIXOUT2
MIXOUT1
C244 0.01uF
C246 0.01uF
C247 10uF
C214
22pF
1608
3
2
1
GND-A
C1239
1k
C1257
10pF
NM
C1256
9pF
C223
0.1uF
R1206
100
PLLVCC
DATA1
DATA2
DATA3
PLLGND
SUB4
NC2
IF2VCC
IF2OUT1
IF2OUT2
T202
MPX_HIGH
GND-A
C1237
1pF
NM
C254
014
R220
15
R221
15
C218
0.1uF
L202
0.47uH
F9/F7 106/86MHz
21
R1233 22
330 23
R1234
330 24
R1235
1000pF
330 25
26
27
C239
28
0.01uF
29
30
0.01uF
C267 0.01uF
C268 1000pF
REF2
REF1
NC1
CP
VT
SUB3
OSCB2
OSCC2
OSCC1
OSCB1
C238
0.01uF
+12V
25
26
27
28
29
30
31
32
20
19
18
17
16
15
14
13
12
11
GND-A
C1220
0.01uF
C1221
0.01uF
IC211 (2/2)
TC7SH08FU(T5RSOYJF)
IC212 (2/2)
TC7SH32FU(T5RSOYJF)
IC213 (2/2)
TC7SH00FU(T5RSOYJF)
L211
10uH
C1222
10uF
C1227
0.1uF
R295
100k
R297
33k
R299 R1201
33k 10k
R1202
10k
D202
DAN222-TL
0.74V
1.19V
0.75V
1.06V
R1219
1.5k
R287
15k
NM
R296
47k
R292
47k
RV201
5k
NM
R1218
2.2k
R290
10k
R288 C1223
22k 0.1uF
C1224
0.1uF
R1200
22k
C1225
0.1uF
R294
10k
R298
3.3k
C1226
0.1uF
C1229
1uF
1608
9-19
J
0
1
2
3
4
3
5
COM
6
7
A
B
C
INH
GND2 GND1
8
7
IC217
TC74VHC4051AFT(EK)
GND-A
HSCU-300
C1230
1uF
1608
13
14
15
12
1
5
2
4
11
10
9
6
16
VCC
IC215 (1/3)
NJM2732RB1(TE2)
3
+
AGC_CTL
CL203
1.5
2 R1203
100k
8
R293
47k
C1228
0.1uF
V+
GND
IC215 (2/3)
NJM2732RB1(TE2)
5
+
6 -
DPR-300 (12/28)
R291
470k
NM
R289
47k
R1205
33k
NM
1
2
R286
33k
BOARD NO. 1-879-649-11
IC215 (3/3)
NJM2732RB1(TE2)
HDCU-300_DPR-300_011_12
9-19
M
DPR-300 (13/28)
DPR-300 (13/28)
+5V
L3609 1uH
R3651
10k NM
C3613 0.1uF
C3614 470pF
C3615 470pF
1
2
3
4
C3616 0.1uF
5
C3617 0.01uF 6
C3618 0.01uF 7
8
4 -
IC3605
R3610
100
V+
V-
IC3605
(2/2)
AD8014ARTZ-REEL7
2
C3611
0.01uF
L3602
1uH
GND-A
C3612
0.01uF
016
C3627
0.01uF
R3626
100k
NM
C3677
10uF GND-A
CL3610
0.8
R3649 22k
R3615 15k
R3652 15k
R3616 22k
0.8
CL3611
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3601
VCC4
CXA3793R-T4
GND4
SUB
NC
R3648 10k
R3627 33k
24
23
22
21
20
19
18
17
C3650
0.01uF
0.01uF
CL3601
0.8
C3651
C3656
0.01uF
9
10
11
12
13
14
15
16
C3609
1000pF
(1/2)
AD8014ARTZ-REEL7
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
CL3604
1.5
R3625
1k
F3_RSSI_VOLT
C3602
10uF
C3620
4.7uF
R3612
68k
CL3612
1.5
+5V
C3654 1000pF
0.01uF NM
10uF
1000pF
1000pF
32
31
30
29
28
27
26
25
C3610
2pF
R3609
1k
C3653 1000pF
FL3601
13 12 16 15 1 4 6 9 3 5 7
O1 I1 O2 I2 LC1LC2LC3LC4NC1NC2NC3
2
8
IN
OUT
GND1 GND2
19
18
10
20
C3623
C3624
C3625
C3626
NM
C3619 1000pF
GND-A
R3611
2.2k
-5V
L3610
1uH
R3673 R3647 R3613 R3614

4.7k 4.7k
NM 33k 2.2k
F3-29
F3-31
F3-32
C3621 0.01uF
C3622 1000pF
016
016
016
F3 26MHz
R3608
1k
CL3609
0.8
HOLD
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
GND-A
CL3608
0.8
013,014,016,017
C3605
2.2uF
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
L3601
1uH
C3601
10uF
R3624 100
R3623
100
C3655
0.01uF
C3652
10uF
R3653
330k
L3509 1uH
CL3508
0.8
C3503
2.2uF
HOLD
GND-A
NM
R3504
2.2k
FL3501
13 12 16 15 1 4 6 9 3 5 7
O1 I1 O2 I2 LC1LC2LC3LC4NC1NC2NC3
2
8
IN
OUT
GND1 GND2
10
20
19
18
32
31
30
29
28NM
C3505
2pF
R3502
1k
C3508 0.1uF
C3509 470pF
C3510 470pF
4
-
3 +
IC3505
(1/2)
AD8014ARTZ-REEL7
C3511 0.1uF
C3512 0.01uF
C3513 0.01uF
R3503
100
C3504
1000pF
1
2
3
4
5
6
7
8
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
IC3505
R3519
100k
NM
C3577
10uF GND-A
CL3510
0.8
R3541
R3509
R3539
R3510
0.8
CL3511
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3501
VCC4
CXA3793R-T4
GND4
SUB
NC
33k
10k
6.8k
33k
R3540 10k
R3574 47k
24
23
22
21
20
19
18
17
CL3501
0.8
C3545
0.01uF
0.01uF
C3546
C3551
0.01uF
9
10
11
12
13
14
15
16
(2/2)
V+
AD8014ARTZ-REEL7
V-
C3522
0.01uF
C3518 0.01uF
C3519 10uF
C3520 1000pF
C35211000pF
NM
R3543
0
C3570
10pF
27
26
25
R3551
4.7k
F2-29
F2-31
F2-32
C3514 1000pF
016
016
016
C3516 0.01uF
C3517 1000pF
GND-A
F2 16MHz
R3501
1k
L3510
1uH
R3573 R3552 R3507 R3508

4.7k 4.7k
33k 2.2k
NM
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
GND-A
CL3509
0.8
013,014,016,017
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
L3501
1uH
C3501
10uF
CL3504
1.5
-5V
C3507
0.01uF
016
F2_RSSI_VOLT
R3505
1k
C3502
10uF
6.3V
R3506
47k
C3515
4.7uF
R3518 100
R3517 100
C3550
0.01uF
C3547
10uF
R3553
470k
CL3512
1.5
+5V
C3548 1000pF
C3549 1000pF
C3506
0.01uF
L3502
1uH
L3409 1uH
HOLD
HPF:0.9MHz
C3659
680pF
014
MPX_LOW
R3451
1.5k
C3604
2pF
R3605
470
C3660
1000pF
C3683
0.0047uF
L3606
15uH
C3684
1000pF
C3685
0.01uF
L3611
12uH
C3687
470pF
C3688
1000pF
R3601
100
R3603
100
R3602
100
R3604
100
C3608
1000pF
4 3
R3401
1k
IC3606
(1/2)
FL3401
4 8 15 16 1 6 7 2 5
O1 I1 I2 O2 LC1LC2LC3NC1NC2
3
9
IN
OUT
GND1 GND2 GND3 GND4
13
18 20
19 10
12
5
V+
V-
1
2
3
4
5
6
7
8
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
IC3405
(2/2)
V+
AD8014ARTZ-REEL7
V2
R3606
100
C3411 0.1uF
C3412 0.01uF
C3413 0.01uF
R3403
100
C3603
0.1uF
IC3405
AD8014ARTZ-REEL7
C3404
1000pF
MPX_LOW_STB
C3408 0.1uF
C3409 0.1uF
C3410 0.1uF
4
3 +
C3606
0.01uF
C3607
0.01uF
C3406
0.01uF
L3402
1uH
-5V
IC3606
(2/2)
LMH6624MFX
C3402
10uF
CL3410
0.8
C3407
0.01uF
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3401
VCC4
CXA3793R-T4
GND4
SUB
NC
NM
R3439 33k
R3409 470k
R3437 6.8k
R3473 100k
NM
NM
R3410 100k
R3438 100k
NM
NM
0.8
CL3411
C3405
1pF
R3402
1k
LMH6624MFX
GND-A
015
GND-A
(1/2)
D3602
1SS400TE-61
R3443
1.5k
C3470
15pF
R3404
6.8k
C3686
0.0047uF
F1 6MHz
R3607
330
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
D3601
1SS400TE-61
R3408
R3452 R3407
2.2k 47k 33k
NM
NM
F1-29
F1-31
F1-32
32 C3414 1000pF
31 C3416 0.01uF NM
30
C3417 1000pF
29
28NM C3418 0.01uF
C3419 10uF
27
C3420 1000pF
26
C3421 1000pF
25
C3422
0.01uF
016
016
016
GND-A
CL3409
0.8
24
23
22
21
20
19
18
17
R3412
0
R3413
0
GND-A
C3423
1pF
NM
C3424
22pF
C3425
1pF
NM
GND-A
C3469
5pF
CL3405
1.5
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
GND-A
CL3408
0.8
013,014,016,017
C3403
2.2uF
9
10
11
12
13
14
15
16
L3401
1uH
C3401
10uF
CL3404
1.5
016
F1_RSSI_VOLT
CL3412
1.5
R3419
1k
R3406
100k
C3415
4.7uF
R3453 150k
9-20
A
9-20
HSCU-300
DPR-300 (13/28)
+1.2V-LLVC_A
R3630
220
R3631 R3632
1M
1M
FB3603
C3665
0.1uF
C3632
0.01uF
GND-A
C3680
47pF
C3648
0.01uF
R3659 330
R3660 330
R3661 330
R3656
C3637
100 0.01uF
012,013,014
TRX001_19
TRX001_20
R3657
100
C3638
0.01uF
C3678
C3639
012,013,014
C3689
C3690
C3662
0.1uF
R3670
220
1000pF
1000pF
R3671
220
R3672
220
NM
L3608
820nH
C3663
0.1uF
CL3606
1.5
C3681
47pF
C3649
0.01uF
GND-A
C3645
R3622
68k
100pF
R3654
6.8k
C3646
1000pF
C3669
0.47uF
R3655
1k
R3621
10k
D3603
HVU363ATRU
C3643 33pF
CL3607
1.5
IC3604
CXD1968AR-T6
R3633
1k
C3670
0.1uF
L3605
330nH
C3644 2pF NM
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
R3640
10k
R3641 22
R3642
22
FB3606
FB3607
FB3608
FB3609
005,013,014
RESET_1968
C3671
10uF
C3674
0.1uF
C3673
10uF
+3.3V-A
2
4
6
8
FB3504
C3579 1uF
R3529
FB3503
R3521 R3522
1M
1M
C3556
0.1uF
10k
R3556
C3532
100 0.01uF
TRX001_19
TRX001_20
012,013,014
012,013,014
C3543
0.01uF
C3589
C3590
R3559 330
R3560 330
R3561 330
C3533
0.01uF
R3557
100
C3553
0.1uF
R3570
220
1000pF
1000pF
R3571
220
R3572
220
CL3506
NM
1.5
L3508
820nH
C3554
0.1uF
C3569
47pF
C3544
0.01uF
GND-A
R3554
6.8k
C3540 100pF
R3516
68k
R3515
10k
C3538 33pF
L3505 220nH
C3560
0.47uF
C3541
1000pF
R3555
1k
D3501
HVU363ATRU
L3506
CL3507
1.5
IC3504
CXD1968AR-T6
R3523
1k
C3561
0.1uF
005,013,014
IIC_F2_F3
R3530
10k
R3531
22
R3532
22
C3565
0.1uF
C3564
10uF
TS_2
R3535
47
2
4
6
8
R3420
220
C3453
0.01uF
R3429
FB3403
C3457
0.1uF
R3421 R3422
1M
1M
C3454
0.1uF
C3452
0.01uF
L3408
820nH
C3455
0.1uF
CL3406
1.5
C3472
47pF
GND-A
L3405 330nH L3406 330nH

C3440 6pF NM
R3471
220
R3472
220
NM
R3454
6.8k
R3418
100
C3461
0.47uF
R3455
1k
CL3407
1.5
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
R3433 R3434
10k
10k
R3430
10k
R3431 22
R3432 22
CL3416
1.5
R3423
1k
C3462
0.1uF
005,013,014
RESET_1968
FB3407
9-21
CL3415
1.5
R3441
0
IIC_F1_F6
017
IIC_2_SDA
IIC_2_SCL
014
014
P14-F6
FB3408
GND
C3465
10uF
C3466
0.1uF
TS_1
R3435
47
1
RB3401
47 3
5
7
2
4
6
8
017
TS1_DT0
TS1_CLK
TS1_VALID
TS1_SYNC
TS1_ERR
TS1_INTRAPT
DPR-300 (13/28)
BOARD NO. 1-879-649-11
R3436
47
HSCU-300
R3440
0
FB3409
C3464
0.1uF
C3463
10uF
CL3414
1.5
IIC_2_SDA_F1
IIC_2_SCL_F1
FB3406
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
R3417
100
C3449 1000pF
C3450 1000pF
C3451 0.01uF
D3401
HVU363ATRU
R3470
220
IC3404
CXD1968AR-T6
R3424 10k
C3471
47pF
9
10
11
12
13
14
15
16
R3415
10k
C3442
1000pF
C3447 0.01uF
C3448 10uF
C3441 100pF
R3416
68k
C3439 33pF
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3403
VCC4
CXA3793R-T4
GND4
SUB
NC
GND-A
24
23
22
21
20
19
18
17
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
R3425 10k
C3445
0.01uF
1000pF
1000pF
1000pF
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
32
31
30
29
28
27
26
25
C3489
C3490
C3491
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
11
12
13
14
15
16
17
18
19
20
C3433
0.01uF
C3478 0.01uF
R3457
100
C3444
0.01uF
1
2
3
4
5
6
7
8
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
30
29
28
27
26
25
24 R3459 330
23 R3460 330
22 R3461 330
21
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
40
39
38
37
36
35
34
33
32
31
IC3402
CXA3792Q-T4
C3482 100pF
NM
TRX001_19
TRX001_20
R3456 C3432
100 0.01uF
C3434 47pF
012,013,014
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
C3427
0.01uF
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
C3446 0.01uF
L3404
1uH
1
2
3
4
C3430 0.1uF 5
C3431 0.1uF 6
7
8
9
10
C3429
18pF
012,013,014
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
C3428
18pF
C3435 8pF
C3436 0.01uF
C3438 6pF R3414 33
C3426
0.01uF
49
50
51
52
53
C3460
0.1uF
54
55
C3458 10uF 56
57
58
C3459 0.1uF 59
60
61
62
63
C3456
64
0.1uF
10k
C3467
0.1uF
C3468
0.1uF
L3403
1uH
C3479 1uF
L3407
1uH
FB3402
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3437 3
0.01uF
47
017
TS2_DT0
TS2_CLK
TS2_VALID
TS2_SYNC
TS2_ERR
TS2_INTRAPT
6/16/46_MHz:GND
26/56/66_MHz:3.3v
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
SWF1
R3538
0
GND
1
RB3501
47 3
5
7
* A0(35pin)
FB3404
CL3515
1.5
017
IIC_1_SDA
IIC_1_SCL
FB3507
R3536
+3.3V-A
R3537
0
FB3506
RESET_1968
+1.2V-LLVC_A
CL3514
1.5
CL3516
1.5
C3563
0.1uF
C3562
10uF
180nH
C3539 3pF
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
R3525 10k
C3527
0.01uF
C3582 100pF
NM
GND-A
CL3505
1.5
C3568
47pF
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
C3525
1pF
NM
IC3502
CXA3792Q-T4
GND-A
30
29
28
27
26
25
24
23
22
21
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
C3524
22pF
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
1
2
3
4
5
R3524 10k 6
7
8
9
10
11
12
13
14
15
16
C3530
0.1uF
C3531
0.1uF
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
11
12
13
14
15
16
17
18
19
20
R3513
0
1
2
3
4
5
6
7
8
9
10
C3578 0.01uF
R3550
220
NM
40
39
38
37
36
35
34
33
32
31
L3504
1uH
C3529
18pF
C3523 GND-A
1pF
NM
R3512
0
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
C3528
18pF
C3534 47pF
0.01uF
C3535
C3537 6pF R3514 33
C3526
0.01uF
49
50
51
52
53
C3559
0.1uF
54
55
C3557 10uF 56
57
58
C3558 0.1uF 59
60
61
62
63
C3555
64
0.1uF
R3533 R3534
10k
10k
C3566
0.1uF
C3567
0.1uF
L3503
1uH
47
L3507
1uH
FB3502
R3520 C3552
220 0.01uF
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3536 3
0.01uF
017
TS3_DT0
TS3_CLK
TS3_VALID
TS3_SYNC
TS3_ERR
TS3_INTRAPT
6/16/46_MHz:GND
26/56/66_MHz:3.3v
* A0(35pin)
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
SWF2
TS_3
R3645
47
1
RB3601
47 3
5
7
R3646
+1.2V-LLVC_A
GND
C3672
0.1uF
R3634 10k
CL3605
1.5
IC3602
CXA3792Q-T4
GND-A
30
29
28
27
26
25
24
23
22
21
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
C3630
1pF
NM
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
R3643 R3644
10k
10k
C3675
0.1uF
C3676
0.1uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
C3629
22pF
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
11
12
13
14
15
16
17
18
19
20
R3619
0
1
2
3
4
C3635 0.1uF 5
C3636 0.1uF 6
7
8
9
10
0.01uF
8pF
C3640 0.01uF
C3642 6pF R3620 33
R3650
220
NM
L3604
1uH
C3634
18pF
GND-A
C3628
1pF
NM
C3682 100pF
NM
C3631
0.01uF
R3618
0
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
C3633
18pF
10k
49
50
51
52
53
C3668
0.1uF
54
55
C3666 10uF 56
57
58
C3667 0.1uF 59
60
61
62
63
C3664
64
0.1uF
40
39
38
37
36
35
34
33
32
31
L3603
1uH
1
R3639
C3658 10uF
R3635 10k
FB3602
C3661
0.01uF
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3641 3
0.01uF
6/16/46_MHz:GND
26/56/66_MHz:3.3v
* A0(35pin)
FB3604
C3679 1uF
L3607
1uH
+3.3V-A
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
4MHz_CLK
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
014
SWF3
DPR-300 (13/28)
HDCU-300_DPR-300_011_13
9-21
M
DPR-300 (14/28)
+5V
L3908
1uH
CL3908
0.8
C3912
2.2uF
HOLD
C3917 0.1uF
C3918 100pF
C3919 100pF
R3911
470
4 1
C3913
1000pF
C3920 0.1uF
C3921 0.01uF
C3922 0.01uF
IC3905
(1/2)
LMH6624MFX
R3912
100
IC3905
(2/2)
LMH6624MFX
E14
-5V
C3901
10uF
CL3808
0.8
HOLD
C3908
1000pF R3907
100
C3808 0.1uF
C3809 100pF
C3810 100pF
4 1
+
3
C3905
0.01uF
C3804
1000pF
IC3805
(1/2)
R3803
100
C3811 0.1uF
C3812 0.01uF
C3813 0.01uF
LMH6624MFX
LMH6624MFX
R3909
1k
R3806
68k
C3802
10uF
CL3812
1.5
IC3907
TC7W53FK(TE85R)
5
A
2
INH
GND
4
CH1
24
23
22
21
20
19
18
17
C3851
0.01uF
C3931
0.01uF
R3818 100
R3817 100
C3850
0.01uF
+5V
L3708
1uH
L3701
1uH
C3701
10uF
GND-A
CL3708
0.8
013,014,016,017
C3703
2.2uF
HOLD
016
016
016
GND-A
VEE
3
R3749
10k NM
C3705
1pF
R3701
470
13 12 16 15 5 10 18 4 6 11 14 17
9
IN
OUT
GND1 GND2
GND3 GND4
2
3
7
8
20
19
4 +
3
C3708 0.1uF
C3709 100pF
C3710 100pF
R3702
470
C3711 0.1uF
C3712 0.01uF
C3713 0.01uF
IC3705
(1/2)
LMH6624MFX
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
C3704
1000pF
R3703
100
1
2
3
4
5
6
7
8
CL3710
0.8
NM
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3701
VCC4
CXA3793R-T4
GND4
SUB
NC
NM
24
23
22
21
20
19
18
17
C3745
0.01uF
R3738
R3708
R3736
R3739
47k
6.8k
6.8k
33k
R3709 6.8k
R3737 68k
CL3701
0.8
0.01uF
C3746
C3751
0.01uF
9
10
11
12
13
14
15
16
V+ IC3705
V- (2/2)
C3788
10uF GND-A
0.8
CL3711
32
31
30
29
28
27
26
25
R3704
3.3k
FL3701
L3709
1uH
R3757 R3706 R3707

2.2k 6.8k 4.7k
F4-29
F4-31
F4-32
GND-A
F4 46MHz
CL3709
0.8
C3722
0.01uF
RF_ATT1_CONT
R3810 6.8k
R3840 33k
CL3801
0.8
C3845
0.01uF
0.01uF
C3846
R3858 C3815
330k 4.7uF
8
1
7
VCC
COMMON CH0
016
R3805
1k
C3720 1000pF
C3721 1000pF
F5_RSSI_VOLT
C3807
0.01uF
C3806
0.01uF
R3841 33k
R3809 10k
R3839 10k
R3819 22k
CL3804
1.5
016
R3904
22
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3801
VCC4
CXA3793R-T4
GND4
SUB
NC
C3714 1000pF
-5V
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
V+ IC3805
V- (2/2)
C3904
1000pF
L3801
1uH
1
2
3
4
5
6
7
8
CL3810
0.8
0.8
CL3811
32
31
30
29
28
27
26
25
R3802
470
C3847 10uF
MPX_LOW
R3801
470
IC3906 (1/2)
LMH6624MFX
C3805
1pF
C3716 0.01uF NM
C3717 1000pF
C3718 0.01uF NM
C3719 10uF
013
C3903
0.1uF
FL3801
13 12 16 15 5 10 18 4 6 11 14 17
1
9
IN
OUT
GND1 GND2
GND3 GND4
2
3
7
8
20
19
MPX_HIGH
C3911
100pF
D3904
1SS390-TE61
R3902
680
012
3 +
C3902
1000pF
D3905
1SS390-TE61
GND-A
R3849
10k NM
C3848 1000pF
C3849 1000pF
F5 56MHz
C3888
10uF GND-A
9
10
11
12
13
14
15
16
R3903
680
C3814 1000pF
GND-A
4
-
R3901
100
F5-29
F5-31
F5-32
R3804
3.3k
R3906
680
L3809
1uH
R3857 R3807 R3808

4.7k4.7k
2.2k
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
5432
2
BPF
4
LPF
6
GND1 GND3 GND5 HPF
GND2 GND4 GND6
11 1 3 5 8 9 10 12
R3925 100
C3822
0.01uF
016
016
016
R3905
3.3k
FL3901
C3960
0.01uF
C3959
0.01uF
CL3809
0.8
C3816 0.01uF NM
C3817 1000pF
C3818 0.01uF NM
C3819 10uF
C3820 1000pF
C3821 1000pF
GND-A
IN
0.01uF
R3926 100
013,014,016,017
V+
V-
R3908
680
CL3901
0.8
C3955
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
C3954
0.01uF
R3958 C3924
100k 4.7uF
C3910
0.01uF
RF
CN3901
R3927
1k
CL3912
1.5
GND-A
C3906
1pF
F6_RSSI_VOLT
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
C3909
0.01uF
24
23
22
21
20
19
18
17
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
C3803
2.2uF
AMPOUTP
AMPOUTN
AGCOUTP
AGCOUTN
IC3901
VCC4
CXA3793R-T4
GND4
SUB
NC
R3914
100k
L3808
1uH
GND-A
016
C3916
0.01uF
IC3906 (2/2)
LMH6624MFX
+5V
L3802
1uH
C3801
10uF
C3915
0.01uF
L3901
1uH
R3953 15k
R3917 15k
R3947 6.8k
R3961 100k
R3918 10k
R3948 10k
CL3904
1.5
V+
V-
VCC1
INPUT1
INPUT2
GND1
VCC2
RSSIC1
RSSIC2
GND2
C3956 10uF
+
3
1
2
3
4
5
6
7
8
CL3910
0.8
9
10
11
12
13
14
15
16
FL3902
13 12 16 15 5 10 18 4 6 11 14 17
1
9
IN
OUT
GND1 GND2
GND3 GND4
2
3
7
8
20
19
C3914
1pF
C3988
10uF GND-A
0.8
CL3911
32
31
30
29
28
27
26
25
R3913
3.3k
NM
R3945
10k NM
C3927 0.01uF
C3928 10uF
C3929 1000pF
C3930 1000pF
F6-29
F6-31
F6-32
C3923 1000pF
016
016
016
NM
GND-A
F6 66MHz
R3910
470
L3909
1uH
R3957 R3915 R3916

2.2k 4.7k 4.7k
C3925 0.01uF
C3926 1000pF
GND-A
CL3909
0.8
013,014,016,017
ATT_DRIVER
STEP_HIGH_SW-OUT
LL-POINT
STEP_LOW_SW-OUT
REG25_2
LOW-P
HIGH-P
HOLD_PULSE
C3957 1000pF
C3958 1000pF
L3902
1uH
C3907
10uF
DETOUT
INPUTN
INPUTP
REG25_1
GND3
VCONT1
VCONT2
VCC3
DPR-300 (14/28)
LMH6624MFX
CL3704
1.5
CL3712
1.5
R3717 100
R3718
1k
R3705
47k
10uF
F4_RSSI_VOLT
C3715
4.7uF
C3748 1000pF
C3749 1000pF
C3702
10uF
016
C3747
-5V
C3707
0.01uF
C3706
0.01uF
L3702
1uH
R3716 100
C3750
0.01uF
R3758 470k
9-22
A
9-22
HSCU-300
+1.2V-LLVC_B
FB3902
R3928
220
R3929 R3930
1M
1M
FB3903
C3965
0.1uF
012,013,014
012,013,014
C3936
0.01uF
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
30
29
28
27
26
25
24 R3965 330
23 R3966 330
22 R3967 330
21
R3962
C3941
100 0.01uF
TRX001_19
TRX001_20
R3963
100
GND-A
C3952
0.01uF
C3978
R3946
220
R3956
220
NM
R3955
220
1000pF
C3985
47pF
C3961
0.1uF
L3906
820nH
C3962
0.1uF
CL3906
1.5
C3986
47pF
GND-A
C3953
0.01uF
C3942
0.01uF
C3949 100pF
R3924
68k
R3923
10k
R3959
6.8k
C3950
1000pF
C3969
0.47uF
R3960
1k
D3902
HVU363ATRU
C3947 33pF
L3905 110nH
CL3907
1.5
IC3904
CXD1968AR-T6
1
2
3
4
5
R3932 10k 6
7
8
9
10
11
12
13
14
15
16
C3934
1pF CL3905
NM
1.5
GND-A
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
IC3902
CXA3792Q-T4
C3987 100pF
NM
R3921
0
C3977
5pF
NM
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
R3964
220
NM
C3939
0.1uF
C3940
0.1uF
1
2
3
4
5
6
7
8
9
10
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
11
12
13
14
15
16
17
18
19
20
R3920
0
L3904
1uH
C3938
18pF
GND-A
C3932
1pF
NM
C3982 0.01uF
C3943 8pF
C3944 0.01uF
C3946 6pF R3922 33
C3935
0.01uF
C3937
18pF
R3931
1k
005,013,014
R3941 R3942
10k
10k
C3975
0.1uF
C3976
0.1uF
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
R3938
10k
R3939 22
IIC_2_SDA_F1
IIC_2_SCL_F1
R3940 22
FB3906
FB3907
2
C3973
10uF
C3974
0.1uF
2
4
6
8
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
R3862 C3832
100 0.01uF
R3863
100
C3870
0.1uF R3842
10k
R3843
10k
IC3802
CXA3792Q-T4
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
30
29
28
27
26
25
24 R3865 330
23 R3866 330
22 R3867 330
21
C3833
0.01uF
3 +
R3844
100k
5
R3850
100k
C3872
0.01uF
C3878
C3852
0.1uF
R3846
220
1000pF
R3847
220
R3848
220
NM
GND-A
C3873
47pF
GND-A
L3806
820nH
C3853
0.1uF
CL3806
1.5
C3874
47pF
GND-A
C3844
0.01uF
R3859
6.8k
C3840 100pF
R3816
68k
R3815
10k
C3841
1000pF
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
C3860
0.47uF
R3860
1k
D3801
HVU363ATRU
C3838 33pF
L3805 150nH
CL3807
1.5
IC3804
CXD1968AR-T6
R3823
1k
C3861
0.1uF
C3839 1pF NM
005,013,014
RESET_1968
R3719
220
TRX001_19
TRX001_20
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24 R3765 330
23 R3766 330
22 R3767 330
21
C3732
0.01uF
R3763
100
C3733
0.01uF
C3778
C3779
C3752
0.1uF
R3746
220
1000pF
1000pF
R3747
220
R3748
220
NM
L3706
820nH
C3753
0.1uF
CL3706
1.5
C3757 10uF
C3758 0.1uF
C3770
47pF
GND-A
C3755
0.1uF
R3759
6.8k
C3740 100pF
R3715
68k
C3741
1000pF
R3714
10k
C3738 33pF
C3743
0.01uF
C3769
47pF
C3744
0.01uF
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
R3762
100
C3759
0.1uF
GND-A
D3701
HVU363ATRU
CL3707
1.5
R3722
1k
IC3704
CXD1968AR-T6
005,013,014
RESET_1968
9-23
R3838
0
C3865
0.1uF
C3864
10uF
TS_5
R3835
47
2
4
6
8
017
TS5_DT0
TS5_CLK
TS5_VALID
TS5_SYNC
TS5_ERR
TS5_INTRAPT
10k
C3766
0.1uF
C3767
0.1uF
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
R3732 R3733
10k
10k
R3729
10k
R3730 22
R3731 22
FB3706
FB3707
FB3708
FB3709
GND
C3763
0.1uF
C3765
0.1uF
C3764
10uF
TS_4
R3734
47
1
RB3701
47 3
5
7
2
4
6
8
017
TS4_DT0
TS4_CLK
TS4_VALID
TS4_SYNC
TS4_ERR
TS4_INTRAPT
DPR-300 (14/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_14
9-23
M
FB3807
R3735
47
HSCU-300
CL3815
1.5
017
6/16/46_MHz:GND
26/56/66_MHz:3.3v
C3762
10uF
C3761
0.1uF
L3705 180nH
C3739 1pF
AINP_Q
AINM_Q
AVDD_Q
AVSS_Q
GUARD_Q
DAREFP
DAREFM
GUARD_I
AINM_I
AINP_I
AVSS_I
AVDD_I
REFIN
REFOUT
TUNERDAT
TUNERCLK
C3760
0.47uF
R3760
1k
R3837
0
FB3808
R3724 10k
012,013,014
012,013,014
C3727
0.01uF
IF2OUT2
IF2OUT1
IF2VCC
NC2
SUB4
PLLGND
DATA3
DATA2
DATA1
PLLVCC
22
1
RB3801
47 3
5
7
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
C3725
1pF CL3705
NM 1.5
GND-A
IC3702
CXA3792Q-T4
11
12
13
14
15
16
17
18
19
20
R3712
0
C3768
5pF
NM
MIXOUT1
MIXOUT2
SUB1
MIXVCC
MIXIN1
MIXIN2
MIXGND
SUB2
VCOGND
VCOVCC
C3782 0.01uF
C3734
8pF
C3735 0.01uF
C3737 6pF R3713 33
R3764
220
NM
C3730
0.1uF
C3731
0.1uF
1
2
3
4
5
6
7
8
9
10
R3832
CL3814
IIC_3_SDA 1.5
IIC_3_SCL
GND
C3862
10uF
1
2
3
4
5
R3723 10k 6
7
8
9
10
11
12
13
14
15
16
C3723
1pF
NM
R3711
0
L3704
1uH
C3787 100pF
NM
C3729
18pF
GND-A
IF1GND
NC4
IF1OUT
IF1VCC
NC3
SUB5
REG
IF2IN2
IF2IN1
IF2GND
C3726
0.01uF
C3728
18pF
22
FB3806
L3703
1uH
R3831
CL3803
1.5
C3863
0.1uF
R3728
R3720 R3721
1M
1M
C3756
0.1uF
FB3703
IIC_F4_F5
R3830
10k
FB3809
* A0(35pin)
FB3704
C3784 1uF
L3707 1uH
FB3702
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
C3754
0.01uF
TMS
TDI
TDO
TCK
CVSS3
CVDD3
SDA
SCL
DVDD2
DVSS2
TSDATA7
TSDATA6
TSDATA5
TSDATA4
TSDATA3
TSDATA2
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3736 3
0.01uF
R3833 R3834
10k
10k
C3866
0.1uF
C3867
0.1uF
R3836
47
+1.2V-LLVC_B
+3.3V-A
SWF4
10k
49
50
51
52
53
C3859
0.1uF
54
55
C3857 10uF 56
57
58
C3858 0.1uF 59
60
61
62
63
C3855
64
0.1uF
CL3813
1.5
GND-A
C3843
0.01uF
R3821 R3822
1M
1M
C3856
0.1uF
FB3803
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
R3829
R3820
220
6 R3845
6.8k
1
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
4MHz_Y
40
39
38
37
36
35
34
33
32
31
C3827
0.01uF
TRX001_19
TRX001_20
012
C3884 1uF
R3824 10k
012,013,014
012,013,014
4MHz_X
GND-A
FB3804
L3807 1uH
FB3802
C3854
0.01uF
R3825 10k
C3825
1pF CL3805
NM
1.5
GND-A
1
2
3
4
5
6
7
8
9
10
C3887 100pF
NM
C3868
5pF
NM
012
C3871
0.01uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
C3830
0.1uF
C3831
0.1uF
C3869
0.1uF
OSCB1
OSCC1
OSCC2
OSCB2
SUB3
VT
CP
NC1
REF1
REF2
R3864
220
NM
L3804
1uH
IC3806
LMH6732MFX/NOPB
R3944
47
11
12
13
14
15
16
17
18
19
20
GND-A
C3823
1pF
NM
R3812
0
R3813
0
C3829
18pF
C3882 0.01uF
C3834 8pF
C3835 0.01uF
C3837 6pF R3814 33
C3826
0.01uF
C3828
18pF
L3803
1uH
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3836 3
0.01uF
017
TS6_DT0
TS6_CLK
TS6_VALID
TS6_SYNC
TS6_ERR
TS6_INTRAPT
6/16/46_MHz:GND
26/56/66_MHz:3.3v
* A0(35pin)
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
SWF5
TS_6
R3943
47
1
RB3901
47 3
5
7
RESET_1968
+1.2V-LLVC_B
+3.3V-A
013
013
P13-F1
GND
C3972
0.1uF
C3971
10uF
C3970
0.1uF
C3948 1pF
10k
49
50
51
52
53
C3968
0.1uF
54
55
C3966 10uF 56
57
58
C3967 0.1uF 59
60
61
62
63
C3964
64
0.1uF
40
39
38
37
36
35
34
33
32
31
L3903
1uH
1
R3937
C3983 10uF
R3933 10k
C3963
0.01uF
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
1
4
IN
OUT1
2
5
SW_IN OUT2
GND
C3945
3
0.01uF
6/16/46_MHz:GND
26/56/66_MHz:3.3v
* A0(35pin)
FB3904
C3984 1uF
L3907 1uH
PADVDD
PADVSS
DIVSS
DIVDD
XVSS
XTALO
XTALI
XVDD
OSCEN
CVDD4
CVSS4
DVSS3
DVDD3
A0
TRSTN
TESTMODE
+3.3V-A
4MHz_CLK
013
SWF6
DPR-300 (14/28)
RF_IFAGC_Q
IFAGC_I
CVSS1
CVDD1
INTRPTN
RESETN
TSERR
TSSYNC
TSVALID
TSCLK
DVSS1
DVDD1
TSDATA0
TSDATA1
CVDD2
CVSS2
DPR-300 (14/28)
DPR-300 (15/28)
DPR-300 (15/28)
1.0M_FREQ_ADJ
IC1501
LMH6732MFX/NOPB
L1501
10uH
C1503
0.01uF
R1507
0
7 5 3 18 9 6 4 1 15 16 12 13
NC3NC2NC1LC5LC4LC3LC2LC1 I2 O2 I1 O1
2
OUT
IN
GND
10
19
20
R1510
1.5k
C1504
10uF
6.3V
8 7
R1515
22k R1516
100k
C1513 R1511
0.1uF 2.2k
C1510 C1511 C1512

0.0033uF 470pF 100pF
GND-A
R1514
15k
NM
R1517
2.2k
C1515
100pF
R1518
15k
R1526 C1521
0.1uF
100k
C1523 RV1501
2.2uF 10k
16V
R1509
1.5k
R1508
100
R1523
15k
R1521 D1504
22k KV1470TL00-G
+ 3
C1517 C1518
33pF 100pF
C1516
10pF
NM
3
2
1
4
NC1
6
NC2
R1522
10k
R1520
R1524
10k R1525
R1519 22k
C1519
100k
0.1uF C1520
47k
D1503
68pF
DA221-TL
NM
*1
C1522
47uF R1527
6.3V 4.7k
E1501
FL1501
R1513 C1514
3.3k 0.1uF
1
D1505
DA221-TL
R1506
220k
1.0M
D1502
1SS400TE-61
NM
R1505
100k 6
1
C1501
0.1uF
2
3
R1503
100
LV1501
R1512
6.8k
C1508
0.1uF
MPX_LOW_STB
R1502
100
C1505
0.01uF
013
R1501
100
C1509
10uF
6.3V
C1507
0.1uF
R1504
6.8k
D1501
1SS400TE-61
NM
C1502
1pF
Q1502
2SC4617TL-QR
Q1501
2SC4617TL-QR
L1502
100uH
TP1501
+5V
ST INCOM DEV ADJ
C1506
0.1uF
L1503
10uH
-5V
R1561
33k
L1504 C1548
47uH
220pF
C1595
0.01uF
FL1502
C1550
0.1uF
5
+
C1546
0.1uF
C1554
0.1uF
6 R1563
1.5k
R1901
33k
IC1514 (2/3)
NJM4580V(TE2)
3
+
R1562 C1547
33k
0.1uF
R1564
1.5k
D1508
1SS375-TL-E
R1902
2.2M
2 -
R1905 33k
C1597
1uF
16V
C1598
10uF
LV1502
NC1 NC2
C1555
0.1uF
C1599
V+
V-
NM
*1
C1551
0.1uF 22uF
R1567
6.3V R1566 22k
100k
NM
R1903 R1904
10k 33k
C1552
22uF
6.3V
C1600
10uF
IC1502
LA1235M-TLM-E
TP1502
R1909
22k
R1908
47k
R1907
10
R1910
10k
R1571
C1556 R1568 100k L1505
22pF 100k NM
330uH
7
8
1
6
3
4
2
NC
7 8
L1507
10uH
L1506
10uH
R1569
3.3k
R1570
15k
C1557
100uF
10V C1558
1uF
LPF:60KHz
11
1
VCC
6
IFIN
AFOUT
3
2
5
8
9
10
7
BIAS S-METER
BYPASS
12
MUTEIN MUTED
15
IFOUT
15
16
16
QUADIN
VREF
AFCOUT
GND1 GND2
4
14
R1572
10k
C1563 C1564
0.01uF 0.01uF
R1573
150k
NM
R1581
4.7k
R1584
0
IC1503 (1/3)
NJM4558V-TE2
R1585
4.7k
R1586
0
R1579
47k
C1565
470pF
R1580
0
R1576
4.7k
NM
R1575
33k
C1566
100pF
NM
IC1503 (3/3)
NJM4558V-TE2
3
+
C1562
470pF
13
2 -
R1582
33k
R1578
10k
NM
C1567
100pF
NM
R1583
150k
C1559 C1560
0.1uF
1uF
C1561
4.7uF
V+
V-
C1568
100pF
C1569
0.01uF
C1570
0.01uF
LV1503
R1574
22k
1.4M TUNE_2
R1577
68k
L1508
10uH
L1509
22uH
-5V
IC1514 (3/3)
NJM4580V(TE2)
From PLD(demux)
017
1
4
2
C1553
0.1uF
R1906
10
C1545
0.0033uF
+5V
Q1505
2SA1774TL-QR
R1565
3.3k
IC1514 (1/3)
NJM4580V(TE2)
13 12 16 15 1 4 6 9 18 3 5 7
O1 I1 O2 I2 LC1LC2LC3LC4LC5NC1NC2NC3
8
IN
OUT
GND
19
10
20
1.4M TUNE_1
R1560
1.5k 2
C1549
22pF
1.4M
Q1504
2SC4617TL-QR
015
Q1503
2SC4617TL-QR
MUTE-cont
MUTE-cont
ST_INCOM_MUTE_IN
9-24
A
9-24
HSCU-300
DPR-300 (15/28)
DPR-300 (15/28)
From PLD(demux)
H/INCOM
LPF:7KHz
IC1504
TC4W53FU(TE12R)
R1537
10k
C1526
0.0022uF
CH
2012
C1524
680pF
- 2
D1506
UDZSNPTE-172.7B
R1538
10k
C1527
0.1uF
C1528
0.1uF
R1540
1k
R1539
100k
C1529
0.1uF
5
+
R1542
3.3k
R1544
22k
C1525
680pF
R1541
330
R1543
2.2k
V+
V-
R1592
10k
R1545
15k
D1507
UDZSNPTE-172.7B
R1548
22k
- 6
R1558
2.2k
R1557
1 100k
2
C1537
220pF
C1535
68pF
C1534
0.01uF
C1532
0.01uF
R1554
47k
R1556
100
R1555
100k
C1533
0.01uF
C1531
0.01uF
C1541
47uF
10V
C1543
0.1uF
C1542
0.1uF
C1544
47uF
10V
C1538
680pF
- 6
C1536
1000pF
- 2
V+
V-
C1539
10uF
6.3V
R1553
2.2k
R1536
10k
R1552
15k
VCC
GND
R1559 C1540
4.7k 22uF
6.3V
R1535
10k
R1534
NM 1k
R1533
33k
R1530
2.2k
R1551
3.3k
INH
VEE VSS
3 4
7
6
5
2
R1549 R1550
330
1.5k
IC1507 (1/2)
TC7SH08FU(T5RSOYJF)
IC1506 (2/3)
NJM4558V-TE2
IC1506 (1/3)
NJM4558V-TE2
R1547 C1530
100 0.1uF
8
VDD
IC1506 (3/3)
NJM4558V-TE2
R1529
22k
IC1505 (3/3)
NJM4558V-TE2
IC1505 (2/3)
NJM4558V-TE2
IC1505 (1/3)
NJM4558V-TE2
R1528
68k
Low:Advance_H/F mode
LPF:60KHz
R1531
0
R1532
100k
017
to P17
IC1507 (2/2)
TC7SH08FU(T5RSOYJF)
From PLD(map)
TRIAX-H
020
STBY-INCOM-TX(to_CAM) 002
to P2
220mVpp/0dB
NJM4558V-TE2
IC1509
(2/3)
IC1503 (2/3)
NJM4558V-TE2
IC1508
TC4W53FU(TE12R)
IC1509 (1/3)
NJM4558V-TE2
IC1509 (3/3)
NJM4558V-TE2
LPF:7KHz
R1589
10k
5
+
R1590
10k
R1591
10k
R1594
10
3
+
6 -
C1572
0.022uF
2 C1596 C1694
0.022uF 0.0033uF
C1574
220pF
C1571
0.01uF
R1595
2.2k
NM
7
6
5
2
8
VDD
R1939
10k NM
R1599
4.7k
5
+
6 -
2
RV1502
20k
INH
VSS VEE
4 3
R1597
22k
C1575
220pF
C1573
330pF
TP1503
R1596
68k
220mVpp/0dB
R1911
10
C1695
1000pF
R1938
100
R1598
100k
7
R1593
10k
STBY-INCOM-RX(fr_CAM) 002
to P2
R1588
10k
V+
V4
R1587
10k
C1577
0.01uF
C1576
0.01uF
ST INCOM LEV ADJ
Hi:Tone detect
R1912
4.7k
RV1503
5k
R1916
150k
R1917
47k
R1919
22k
R1918
3.3k
R1920
22k
R1921
33k
C1582
0.01uF
C1583
0.01uF
R1546
10k
2 -
C1587
0.0022uF
CH
2012
C1588
0.0022uF
CH
2012
C1589
100uF
10V
V+
V-
R1926
47k
C1590
0.1uF
C1592
1uF
2
1
R1925
22k
D1509
1SS375-TL-E
GND-A
R1927
10k
3
C1593
0.01uF
IC1512 (2/3)
UPC393G2-E2
R1931
4.7k
C1650
0.01uF
R1924
22k
C1585
22uF
6.3V
C1578
0.1uF
R1923
68k
C1651
0.01uF
R1936
22k
C1591
4.7uF
10V
V+
V4
R1913
150
6 -
R1915
68
4
3
VS
8
IN
OUT
5
1
T_R OUTFIL
2
LPFIL
6
T_CR
GND
7
C1586
0.1uF
R1934
10k
6 -
7
R1935
22k
4
R1928
10k
R1929
C1594
22k
22uF
6.3V
C1500
1uF
R1932
0
R1933
4.7k
GND-A
5
+
2 -
R1930
330
R1922
10
R1914
680
(TONE)
IC1515
TC7SH08FU(T5RSOYJF)
TP1505
C1584
0.1uF
IC1513
TC7SH08FU(T5RSOYJF)
C1581
1000pF
IC1512 (1/3)
UPC393G2-E2
IC1511
NJM567M(TE2)
C1580
1000pF
IC1510 (3/3)
NJM4558V-TE2
C1579
1000pF
IC1510 (2/3)
NJM4558V-TE2
IC1510 (1/3)
NJM4558V-TE2
HPF:14KHz
to P2
002
TONE0-DETECT_out
C1692
0.1uF
2
1
MUTE-cont
R1937
100
Hi:RF detect
RF-DETECT-out
017
MUTE-cont
015
C1693
10uF
IC1512 (3/3)
UPC393G2-E2
TONE ADJ.
DPR-300 (15/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_15
9-25
HSCU-300
9-25
M
DPR-300 (16/28)
DPR-300 (16/28)
1
IC1601 (2/3)
NJM2904V(TE2)
F5-31
014
F6-H
R1608
100
R1605
1k
3
+
2 -
014
R1602
1k
F6-29
C1601
0.01uF
F5-29
014
F6-L
6 -
R1606
1k
IC1602 (1/3)
NJM2904V(TE2)
5
+
C1602
0.01uF
IC1603 (2/3)
NJM2904V(TE2)
F4-H
R1610
1k
F4-29
IC1603 (1/3)
NJM2904V(TE2)
5
+
C1604
0.01uF
F4-L
6 -
GND-A
GND-A
F5-32
014
R1607
1k
F5-LL
V+ IC1602 (3/3)
GND NJM2904V(TE2)
014
V+
IC1601 (3/3)
GND NJM2904V(TE2)
F6-LL
014
F5-L
GND-A
R1603
1k
F6-32
F4-31
2 -
6 -
014
014
F5-H
R1612
22k
R1609
1k
2 -
IC1601 (1/3)
NJM2904V(TE2)
IC1602 (2/3)
NJM2904V(TE2)
F6-31
R1611
1k
F4-32
R1613
22k
V+ IC1603 (3/3)
GND NJM2904V(TE2)
C1603
0.1uF
014
R1604
100
R1601
1k
F4-LL
GND-A
014
014
+5V
F6_RSSI_VOLT
F5_RSSI_VOLT
014
013
F4_RSSI_VOLT
F3_RSSI_VOLT
013
013
F1_RSSI_VOLT
F2_RSSI_VOLT
L1602
10uH
R1639
10k
3
+
IC1611 (1/3)
NJM2904V(TE2)
R1641
10k
IC1612 (1/3)
NJM2904V(TE2)
3
+
2 -
R1643
10k
IC1613 (1/3)
NJM2904V(TE2)
3
+
2 -
2 -
3
+
IC1611 (2/3)
NJM2904V(TE2)
R1642
10k
5
+
6 -
IC1612 (2/3)
NJM2904V(TE2)
R1644
10k
6 -
C1622
0.01uF
C1619
0.01uF GND-A
V+ IC1611 (3/3)
NJM2904V(TE2)
GND
C1620
0.1uF
C1618
0.1uF
6 -
C1625
0.01uF GND-A
GND-A
V+ IC1612 (3/3)
GND NJM2904V(TE2)
C1621
0.1uF
C1623
0.1uF
C1617
0.1uF
IC1613 (2/3)
NJM2904V(TE2)
V+ IC1613 (3/3)
GND NJM2904V(TE2)
C1624
0.1uF
R1640
10k
C1614
10uF
GND-A
012
TEMP-IN
R1946
10k
R1942
100k
RSSI_offset_ADJ
5
R1944
10k
2 1
+
3
L1603
10uH
C1644
0.01uF
C1643
0.1uF
V+
V-
C1642
0.1uF
IC1617 (1/3)
NJM4558V-TE2
R1631
68k
C1633
0.01uF GND-A
C1646
0.01uF
V+
V-
IC1616 (3/3)
NJM4558V-TE2
C1645
0.01uF
R1629
10k
IC1617 (3/3) C1647

NJM4558V-TE2 0.01uF
R1630
47k
C1641
0.01uF
C1632
10uF
Ref=1.868/1.805V
Detect 550m
R1632
330k
V+
GND
IC1607 (3/3)
NJM2904V(TE2)
R1668
10k
2 -
C1610
0.1uF
R1941
220
IC1616 (1/3)
NJM4558V-TE2
+
3
IC1616 (2/3)
NJM4558V-TE2
IC1607 (2/3)
NJM2904V(TE2)
3
024
R1646
33k
R1679
1k
R1627
10k
2 -
+5V
R1947
10k
6 -
C1629
10uF
R1943
4.7k
R1940
10k
R1645
330k
R1948
10k
R1945
10k
R1666
3.3k
C1612
0.1uF
C1611
0.01uF
R1667
15k
Q1601 2SC4617TL-QR
-5V
9-26
A
9-26
HSCU-300
DPR-300 (16/28)
DPR-300 (16/28)
+5V
L1601
10uH
R1614
1k
R1617
100
IC1604 (2/3)
NJM2904V(TE2)
3
+
013
F3-H
R1618
1k
F2-31
F3-29
R1615
1k
IC1605 (2/3)
NJM2904V(TE2)
2 -
013
R1621
100
013
F2-H
IC1604 (1/3)
NJM2904V(TE2)
5
+
C1605
0.01uF
013
F3-L
R1619
1k
F2-29
C1606
0.01uF
F1-H
IC1606 (1/3)
NJM2904V(TE2)
5
+
C1608
0.01uF
F1-L
6 -
GND-A
V+ IC1604 (3/3)
GND NJM2904V(TE2)
013
R1620
1k
F2-32
V+ IC1605 (3/3)
GND NJM2904V(TE2)
F2-LL
F3-LL
R1623
1k
F1-29
GND-A
8
R1616
1k
013
F2-L
6 -
GND-A
F3-32
+
2 -
IC1605 (1/3)
NJM2904V(TE2)
IC1606 (2/3)
NJM2904V(TE2)
2 -
6 -
013
R1625
22k
R1622
1k
F1-31
C1609
10uF
F3-31
013
R1624
1k
F1-32
R1626
22k
V+ IC1606 (3/3)
GND NJM2904V(TE2)
C1607
0.1uF
013
F1-LL
To PLD(demux)
STEP-MONI
017
D1602
DAN222-TL
IC1609 (2/2)
TC7SH08FU(T5RSOYJF)
R1635
470k
1
2
C1615
0.01uF
VCC
GND
IC1609
(1/2)
TC7SH08FU(T5RSOYJF) R1636
22k
R1653 10
10
10
10
10
10
10
C1630 0.01uF
16
VCC
13
0
14
1
15
2
12
3
1
4
3
5
COM
5
2
6
4
7
11
A
10
B
9
C
6
INH
GND2 GND1
8
7
R1655 47k
R1647
R1648
R1649
R1650
R1651
R1652
HOLD
1
2
R1638
4.7k
From PLD(demux)
HOLD_IN
017
Hi:HOLD ON
R1656 47k
R1657 47k
GND-A
F1_RSSI
F2-RSSI
F3_RSSI
F4_RSSI
F5-RSSI
F6_RSSI
R1634
100
013,014,017
IC1614
TC74VHC4051AFT(EK)
C1616
22uF
IC1617 (2/3)
NJM4558V-TE2
+
GND-A
ANA0(DPR-LEVEL)_out 002
to P2
6 -
R1658
100k
R1663
10
R1659
10k
R1660 22k
R1661 22k
C1626
0.01uF
NM
R1662 22k
ANALOG_SEL_C
ANALOG_SEL_B
ANALOG_SEL_A
017
017
017
From PLD(demux)
Mid Band Gain ctl
R1665
1k
RF_ATT1_CONT
014
Hi:ATT ON
R1673
330k
R1949
330k
R1674
33k
R1678
330
R1654
10k
IC1607 (1/3)
NJM2904V(TE2)
5
+
R1677
10k
R1672
330k
R1675
470
R1669
10k
C1627
0.01uF
C1628
0.1uF
8
Ref=2.128/2.079V
Detect 300m
R1694
100k
R1700
10k
R1698
4.7k
R1680
10k
IC1615
NJM2904V(TE2)
+
6 R1683
33k
R1684
330k
R1690
10k
C1636
0.1uF
Ref=1.749/1.698V
Detect 620m
R1688
1.5k
R1681
10k
R1699
15k
(2/3)
C1640
0.1uF
C1639
0.01uF
R1637
47k
R1686
33k
R1687
680
C1634
0.1uF
Ref=1.924/1.871V
Detect 460m
R1695
330k
R1692
10k
R1693
47k
Q1602 2SC4617TL-QR
2 -
C1637
0.01uFGND-A
V+
GND
R1676
22k
R1670
47k
3
C1638
0.1uF
R1671
220k
IC1615 (1/3)
NJM2904V(TE2)
R1697
1.5k
R1691
10k
6 -
C1613
0.1uF
R1685
330k
R1696
33k
R1628
47k
C1635
0.01uF
R1689
15k
R1682
47k
R1633
47k
Q1604 2SC4617TL-QR
Q1603 2SC4617TL-QR
2
3
4
5
6
7
8
9
11
1
C1631
0.01uFGND-A
20
VCC
19
D0
Q0
18
D1
Q1
17
D2
Q2
16
Q3
D3
15
Q4
D4
14
Q5
D5
13
Q6
D6
12
Q7
D7
LE
OE
GND
10
Cable_220m
to DEMUX FPGA
017
Cable_370m
012,017
Cable_550m
012,017
Cable_720m
012,017
Hi
Hi
Hi
Hi
0_550m
0_300m
0_460m
0_620m
IC1618
TC74VHC573FK(EL,K)
Q1605
2SC4617TL-QR
IC1615 (3/3)
NJM2904V(TE2)
DPR-300 (16/28)
BOARD NO. 1-879-649-11
9-27
HSCU-300
HDCU-300_DPR-300_011_16
9-27
M
DPR-300 (17/28)
DPR-300 (17/28)
+3.2V
C1706 1uF
C1718 0.1uF
C1719 0.1uF
GND
2
17
19
34
36
51
53
68
271
273
285
287
295
297
305
307
313
319
321
323
+1.5V
L1702
1uH
C1702
10uF
6.3V
C1707 1uF
C1720
C1708 1uF
C1721
C1709 1uF
C1722
C1710 1uF
C1723
C1711 1uF
C1724
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
VCCINT1[B1]
VCCINT2[U1]
VCCINT3[V2]
VCCINT4[V17]
VCCINT5[U18]
VCCINT6[B18]
VCCINT7[A17]
VCCINT8[A2]
VCCINT9[N9]
VCCINT10[N11]
VCCINT11[F10]
VCCINT12[F8]
VCCINT13[M8]
VCCINT14[M10]
VCCINT15[G11]
VCCINT16[G9]
VCCINT17[L9]
VCCINT18[H10]
VCCINT19[J9]
VCCINT20[K10]
RB1722 22k
1
2
3
4
5
6
7
8
(0->2.5V)
2
4
6
8
+5V
Cable_550m
Cable_720m
Cable_220m
Cable_370m
1
3
5
7
RB1723
22k
from STEP/AGC_MONI
+5V
016
STEP-MONI
GND
to DAYTONA MAIN DEC

018
F1-H
F1-L
F1-LL
F2-L
RB1701 22k
1
2
3
4
5
6
7
8
(0->2.5V)
RTP_OUT
F3-H
F3-L
F3-LL
F2-H
RTP-DT18
RTP-DT22
RTP-DT28
RTP-STA
RTP-DT0
RTP-DT2
RTP-DT6
RTP-DT10
RTP-DT14
RTP-DT16
RTP-DT20
RTP-DT24
RTP-DT26
RTP-DT30
RTP-DT31
GND
RB1702 22k
1
2
3
4
5
6
7
8
33_F3-H
33_F3-L
33_F3-LL
33_F2-H
RB1718
22k
301
GNDA_PLL2[K12]
10
GNDA_PLL1[K1]
F4-H
F4-L
F4-LL
IC1700 (5/6)
EP1C20F324C8N(300)
RTP-DT1
RTP-DT5
RTP-DT7
RTP-DT11
RTP-DT13
RTP-DT17
RTP-DT21
RTP-DT23
RTP-DT25
RTP-DT27
RTP-DT29
33_F4-H
33_F4-L
33_F4-LL
2
4
6
8
44
GNDG_PLL2[J18]
264
GNDG_PLL1[J6]
GND
RB1703 22k
1
2
3
4
5
6
7
8
RB1719
22k
1
3
5
7
GND
GND
291
+3.2V-17
RB1724 10k
1
2
3
4
5
6
7
8
4
007,020,024
nCE[J7]
RTP-DT9
2
4
6
8
nCEO[K2]
CL1711
1.2
1
3
5
7
F6-H
F6-L
F6-LL
F2-LL
77
GND
RB1705 22k
1
2
3
4
5
6
7
8
33_F6-H
33_F6-L
33_F6-LL
33_F2-LL
1
3
5
7
GND
R1730
CS_DEMUX
1
CPU-D0
CPU-D1 RB1706 3
220 5
CPU-D2
7
CPU-D3
1
CPU-D4
RB1707 3
CPU-D5
220 5
CPU-D6
7
CPU-D7
GND
CONFIG_CHAIN
EPCS16
CPU-A0
CPU-A1
CPU-RD
CPU-WR
2
IC1700
DEMUX
EP1C20
R1774
DPR-RESET_2
005,007,009,011,018
+3.2V-17
292
MSEL1[K7]
136
MSEL0[K3]
EP1C20F324C8N(300)
IC1700 (6/6)
1
IC700
MAP
EP1C20
RTP-DT15
RTP-DT19
RB1721
22k
290
DATA0[H7]
11
DCLK[L1]
9
IO4/nCSO[J1]
265
IO212/ASDO[K6]
3
IC2000
POST
EP1C12
CL1703
1.2
RTP-DT3
RB1720
22k
CLK
CONFIG
107
TDI[J17]
247
TMS[K14]
43
TCK[K18]
278
TDO[K13]
CONFIG_CONF_DONE
CONFIG_nSTATUS
CONFIG_nCONFIG
CONFIG_nCE_1-2
CONFIG_DATA0
CONFIG_DCLK
GND
106
CONF_DONE[K17]
300
nSTATUS[L12]
76
nCONFIG[J2]
33_F5-H
33_F5-L
33_F5-LL
2
4
6
8
R1775
47 135
CLK0/LVDSCLK1p[J3]
47 186
CLK1/LVDSCLK1n[J4]
47 209
CLK2/LVDSCLK2p[J15]
162
0
CLK3/LVDSCLK2n[J16]
GND
RB1704 22k
1
2
3
4
5
6
7
8
CONFIG_nCE_2-3
R1705
R1729
R1707
005 74M-CLK-FPGA-DEMUX
005
CP-CLK_3
F5-H
F5-L
F5-LL
4
IO0[D1]
6
7
IO2/LVDS25p[G1]
8
IO3/DQ0L7[H1]
RTP-EN
RTP-DT4
RTP-DT8
RTP-DT12
33_F1-H
33_F1-L
33_F1-LL
33_F2-L
RB1717
22k
GND
229
VCCA_PLL1[J5]
302
VCCA_PLL2[J12]
GND
012,016
012,016
016
012,016
2
4
6
8
C1705 1uF
C1716 0.1uF
C1717 0.1uF
324
322
320
318
317
316
315
314
312
311
310
309
308
306
298
296
286
284
272
270
114
99
84
69
67
54
52
50
37
35
33
20
18
16
3
1
1
3
5
7
C1704 1uF
C1714 0.1uF
C1715 0.1uF
GND36[J10]
GND35[K9]
GND34[H9]
GND33[H11]
GND32[J11]
GND31[K11]
GND30[L11]
GND29[L10]
GND28[L8]
GND27[K8]
GND26[J8]
GND25[H8]
GND24[G8]
GND23[G10]
GND22[M11]
GND21[M9]
GND20[F9]
GND19[F11]
GND18[N10]
GND17[N8]
GND16[B17]
GND15[U17]
GND14[U2]
GND13[B2]
GND12[A3]
GND11[A16]
GND10[A18]
GND9[C18]
GND8[T18]
GND7[V18]
GND6[V16]
GND5[V3]
GND4[V1]
GND3[T1]
GND2[C1]
GND1[A1]
5
VCCIO1_1[E1]
14
VCCIO1_2[P1]
289
VCCIO1_3[G7]
294
VCCIO1_4[M7]
56
VCCIO2_1[A14]
65
VCCIO2_2[A5]
254
VCCIO2_3[E12]
257
VCCIO2_4[E9]
39
VCCIO3_1[P18]
48
VCCIO3_2[E18]
299
VCCIO3_3[M12]
303
VCCIO3_4[H12]
22
VCCIO4_1[V5]
31
VCCIO4_2[V14]
237
VCCIO4_3[P8]
240
VCCIO4_4[P11]
C1703 1uF
C1712 0.1uF
C1713 0.1uF
1
3
5
7
C1701
10uF
6.3V
2
4
6
8
L1701 +3.2V-17
1uH
4
IC2400
ANALOG
EP1C12
1
RB1708 3
220 5
7
22
2
4
6
8
2
4
6
8
%CS
%D0
%D1
%D2
%D3
%D4
%D5
%D6
%D7
2
4
6
8
%ADR0
%ADR1
%RD
%WR
47
12
13
15
70
71
72
73
74
75
78
79
80
81
82
83
129
130
131
132
133
134
137
138
139
140
141
142
181
182
183
184
185
187
188
189
190
191
225
226
227
228
230
231
232
233
234
261
262
263
266
267
268
269
288
293
IO5/DQ1L0[M1]
IO6/LVDS6p[N1]
IO7/VREF2B1[R1]
IO36/LVDS31n/CRC_ERROR[C2]
IO37/LVDS30n[D2]
IO39/LVDS27p[F2]
IO40/LVDS25n[G2]
IO41/LVDS21p[H2]
IO42/LVDS11p[L2]
IO44/LVDS6n[N2]
IO46/LVDS1p[R2]
IO47/LVDS0p[T2]
IO91/LVDS27n[F3]
IO92/LVDS23p[G3]
IO93/LVDS21n[H3]
IO94/LVDS11n[L3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
IO137/VREF0B1[D4]
IO139/LVDS26p[F4]
IO141/LVDS20p[H4]
IO142/PLL1_OUTp[K4]
IO143/LVDS10n[L4]
IO144/LVDS7n[M4]
IO146[P4]
IO180/LVDS26n[F5]
IO183/PLL1_OUTn[K5]
IO184/LVDS10p[L5]
IO186/LVDS4p[N5]
IO209/LVDS24p[F6]
IO211/VREF1B1[H6]
IO213/LVDS12n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO226/LVDS24n[F7]
IC1700 (1/6)
EP1C20F324C8N(300)
005,007,011,020,022,024,025
CPU_I/F
SKIN_GATE
EPR2
to ANALOG(POST) FPGA
020,024
DEMUX-SKIN-GATE
020,024
DEMUX-F
020
DEMUX-UTIL
to MB
002
700P-RX
9-28
A
9-28
HSCU-300
DPR-300 (17/28)
DPR-300 (17/28)
to Daytona MAIN DEC

018 74M-CLK-PLL-DAY-MAIN
007
HOLD_IN
016
IRQ-1968
GND
260
259
258
256
255
253
33_F6-LL
224
223
222
221
220
219
218
217
216
33_F4-H
215
33_F4-L
180
179
178
177
176
175
174
173
172
171
33_F5-H
170
33_F5-L
169
33_F5-LL
168
128
127
CL1701
126
1.2
125
124 R1734
22
123
122
121
TS5_VALID
120 R1770
47
119
R1733
47
118
TS5_CLK
117
116
RB1709
220
115
7
8
TS5_SYNC
66
5
6
TS5_ERR
64
3
4
TS5_INTRAPT
63
1
2
TS5_DT0
62
61
R1736
22
IIC_3_SCL
60
R1735
22
IIC_3_SDA
59
R1738
47
TS4_CLK
58
R1737
22
TS4_VALID
57
1
2
TS4_DT0
55
3
4 TS4_INTRAPT
TS_5
GND
IIC_F4_F5
CL1704
1.2
6
8
5
7
BANK2
3.2V
DEMUX FPGA
GND
RB1710
220
GND
IC1700 (2/6)
EP1C20F324C8N(300)
BANK1
3.2V
BANK3
3.2V
BANK4
3.2V
21
23
24
25
26
27
28
29
30
32
85
86
87
88
89
90
91
92
R1732
22
93
AULRCK
94
AU64FS
95
AU_RX12MIC
96
AU_RX34AES
97
AU_RX56INCM
98
TRNK_RXO_1
143
CL1707
1.2
144
145
146
147
148
149
150
151
152
153
154
192
193
194
195
196
197
198
199
200
201
202
235
236
238
239
241
242
IO8/LVDS128n[V4]
IO9/LVDS124p[V6]
IO11/LVDS119n[V8]
IO12/LVDS117n[V9]
IO13/LVDS112n[V10]
IO14/LVDS108n[V11]
IO15/LVDS107p[V12]
IO48/LVDS128p[U3]
IO49/LVDS127n[U4]
IO53/LVDS119p[U8]
IO54/LVDS117p[U9]
IO55/LVDS112p[U10]
IO57/LVDS107n[U12]
IO61/LVDS97p[U16]
IO100/LVDS127p[T4]
IO102/LVDS122p[T6]
IO104/LVDS118p[T8]
IO105/LVDS116n[T9]
IO106/LVDS111p[T10]
IO107/LVDS109n[T11]
IO109/LVDS104p[T13]
IO111/LVDS97n[T15]
IO148/VREF2B4[R5]
IO149/LVDS122n[R6]
IO151/LVDS118n[R8]
IO153/LVDS111n[R10]
IO154/LVDS109p[R11]
IO156/LVDS104n[R13]
IO189/LVDS123n[P7]
IO190/VREF1B4[P9]
IO191/LVDS110n[P10]
IO192/LVDS101n[P12]
IO193/VREF0B4[P13]
IC1700 (4/6)
EP1C20F324C8N(300)
IO228/LVDS70n[G12]
IO225/LVDS70p[F12]
IO224/LVDS68n[F13]
IO221/LVDS76n[J13]
IO220/LVDS85p[L13]
IO219/LVDS85n[M13]
IO218/LVDS91n[N13]
IO217/LVDS91p[N12]
IO202/VREF0B3[E14]
IO201/LVDS68p[F14]
IO200/LVDS72p[G14]
IO199/LVDS75n[H14]
IO198/VREF1B3[J14]
IO197[L14]
IO168/LVDS65p[D15]
IO165/LVDS71n[G15]
IO164/LVDS75p[H15]
IO162/LVDS84p[L15]
IO160/LVDS90p[N15]
IO123/LVDS65n[D16]
IO121/LVDS67n[F16]
IO120/LVDS71p[G16]
IO119/LVDS74n[H16]
IO116/DQ1R0[M16]
IO115/LVDS90n[N16]
IO114/VREF2B3[P16]
IO113/LVDS94p[R16]
IO112/LVDS96n[T16]
IO73/LVDS64n[C17]
IO72/LVDS64p[D17]
IO70/LVDS69p[F17]
IO68/LVDS74p[H17]
IO67/LVDS86p[L17]
IO65/LVDS92p[N17]
IO64/DQ1R6[P17]
IO63/LVDS95n[R17]
IO62/LVDS96p[T17]
IO25/DQ0R0[D18]
IO24/LVDS69n[F18]
IO22/DQ0R7[H18]
IO21/LVDS86n[L18]
IO20/LVDS89n[M18]
IO19/LVDS92n[N18]
IO18/LVDS95p[R18]
304
283
282
281
280
279
277
276
275
274
252
251
250
249
248
246
245
244
243
214
213
212
211
210
208
207
206
205
204
203
167
166
165
164
163
161
160
159
158
157
156
155
113
112
111
110
109
108
105
104
103
102
101
100
49
47
46
45
42
41
40
38
33_F1-L
33_F3-H
33_F2-H
R1776 22k
R1741
TS_6CK
R1742
TS_6VAL
RB1712 1
TS_6D0
220 3
TS_6INTRAPT
5
TS_6ER
7
TS_6SYN
CL1710
1.2
33_F6-H
33_F1-H
33_F2-L
33_F3-LL
from/to CXD1968 (OFDM DEMOD)
015
47
22
TS6_CLK
TS6_VALID
TS6_DT0
TS6_INTRAPT
TS6_ERR
TS6_SYNC
2
4
6
8
GND
GND
TS_6
IIC_F1_F6
33_F4-LL
33_F6-L
33_F2-LL
33_F1-LL
33_F3-L
CL1709
1.2
R1739
R1740
IIC_2SDA
IIC_2SCL
47
47
IIC_2_SDA
IIC_2_SCL
TS-6:66MHz
014
IIC-2
013
TS_1
TS-1:6MHz
013
GND
R1751
R1752
TS_1CK
TS_1VAL
TS_1D0
TS_1INTRAPT
IIC_1SCL
IIC_1SDA
47
22
RB1716 1
220 3
5
7
TS_1ER
TS_1SYN
2
4
6
8
TS1_CLK
TS1_VALID
TS1_DT0
TS1_INTRAPT
TS1_ERR
TS1_SYNC
GND
GND
TS_6CK
TS_6SYN
TS_6D0
TS_1SYN
TS_1D0
R1745
R1746
RB1714 1
220 3
TS_3CK
TS_3VAL
TS_3D0
TS_3INTRAPT
47
22
2
4
6
8
5
7
TS_3ER
TS_3SYN
TS_3D0
TS3_CLK
TS3_VALID
TS3_DT0
TS3_INTRAPT
TS3_ERR
TS3_SYNC
GND
TS_3
TS-3:26MHz
013
GND
IIC_F2_F3
TS_2D0
TS_6VAL
TS_6INTRAPT
TS_1CK
TS_1ER
IIC_2SCL
TS_3SYN
TS_3ER
TS_2VAL
TS_2SYN
TS_2ER
IIC_1SDA
IIC_1SCL
R1747
R1748
47
47
TS_2CK
TS_2VAL
TS_2D0
TS_2INTRAPT
TS_2ER
TS_2SYN
R1749
R1750
RB1715 1
220
3
47
22
TS_2INTRAPT
TS_6ER
TS_1VAL
TS_1INTRAPT
IIC_2SDA
TS_3CK
TS_3VAL
5
7
2
4
6
8
TS-2:16MHz
013
TS2_CLK
TS2_VALID
TS2_DT0
TS2_INTRAPT
GND
TS2_ERR
TS2_SYNC
GND
R1772 1k
H/INCOM
015
AUDIO
TS_3INTRAPT
TS_2CK
%LRCK
%64FS
%12MIC
%34AES
AULRCK
AU64FS
R1743
R1708
220
100
AU-TX-LRCK
AU-TX-64FS
AU_RX12MIC
AU_RX34AES
AU_RX56INCM
TRNK_RXO_1
RB1713
1
3
5
7
220
2
4
6
8
AU-RX12-MIC
AU-RX34-AES
AU-RX56-INCOM
R1771 1k
013,014,016
IIC-1
013
IIC_1_SDA
IIC_1_SCL
TS_2
IC1700 (3/6)
EP1C20F324C8N(300)
HOLD
ANALOG_SEL_C
ANALOG_SEL_B
ANALOG_SEL_A
RF-DETECT-out
R1777
22k
CL1708
1.2
%CS
%D0
%D1
%D2
%D3
%D4
%D5
%D6
%D7
%ADR0
%ADR1
%RD
%WR
TS-4:46MHz
014
TS4_ERR
TS4_SYNC
TS_4
IO208/LVDS37n[E6]
IO205/VREF1B2[E10]
IO204/LVDS50n[E11]
IO203/LVDS59n[E13]
IO177/LVDS37p[D6]
IO176/LVDS38n[D7]
IO175/LVDS42n[D8]
IO173/LVDS49p[D10]
IO172/LVDS52p[D11]
IO134/LVDS36p[C6]
IO133/LVDS38p[C7]
IO132/LVDS42p[C8]
IO131/LVDS44p[C9]
IO130/LVDS49n[C10]
IO129/LVDS52n[C11]
IO126/VREF0B2[C14]
IO124/LVDS63n[C16]
IO84/LVDS36n[B6]
IO82/LVDS41p[B8]
IO81/LVDS43p[B9]
IO80/LVDS48n[B10]
IO79/LVDS51n[B11]
IO78/LVDS53n[B12]
IO77/LVDS56n[B13]
IO74/LVDS63p[B16]
IO34/VREF2B2[A6]
IO32/LVDS41n[A8]
IO31/LVDS43n[A9]
IO30/LVDS48p[A10]
IO28/LVDS53p[A12]
IO27/LVDS56p[A13]
CL1705
1.2
CL1706
1.2
TS-5:56MHz
014
IIC-3
014
RB1711
1
%LRCK
3
%64FS
%12MIC 5
%34AES 7
220
2
4
6
8
AUDIO-TX
AUDIO-RX
005,007
005
+5V-D
L1703
10uH
C1725 0.1uF
R1778
22k
ST_INCOM_MUTE_IN
2
1
near CN102
near IC705
015
DEMUX-AU-LRCK
DEMUX-AU-64FS
DEMUX-AU-1/2
DEMUX-AU-3/4
GND
to MB
R1753 100
TRUNK1(TX)_out
GND-TRUNK
3 R1754 0
002
002
TRUNK TX(from CAM)
GND
IC1701
TC7SH08FU(T5RSOYJF)
016
016
016
DEMUX-AUDIO
to POST FPGA
020
AUDIO EMB
DPR-300 (17/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_17
9-29
HSCU-300
9-29
M
DPR-300 (18/28)
DPR-300 (18/28)
to POST FPGA
+3.2V
DAYTONA-MAIN-GPIO
020
1
from DEMUX FPGA
017
+3.2V
RTP_OUT
+2.5V
DAYTONA-MAIN
to ZXCV
020
DAYTONA-MAIN-F
1
3
5
7
1
3
5
7
2
4
6
8
1
3
5
7
DAYTONA-MAIN-Y5
DAYTONA-MAIN-Y3
DAYTONA-MAIN-Y1 RB1806
22
220
R1801
DAYTONA-MAIN-GPIO_1
+2.5V
FB1801
+5V-D
IC1800
NJM2871BF33-TE2
R1826
47
5
R1800
2.2k
1
C1800
0.1uF
10V
C1808
1uF
6.3V
VIN
CTL
VOUT
CL1800
0.8
3
N_BYP
GND
C1801
0.1uF
2
10V
GND
004,009
DAY_PLL33_P-ON-p
R1829
100
+3.3V_PLL_DEC
FB1800
C1802
1uF
6.3V
C1809
10uF
from POST FPGA +3.2V
020 DAYTONA-MAIN-FRSEL
020 DAYTONA-MAIN-FFWRT
020 DAYTONA-MAIN-F-RESET
020 DAYTONA-MAIN-UART-RX
R1802
R1803
R1804
R1810
220
220
10
22
RTP-DT31
RTP-DT29
RTP-DT27
RTP-DT25
7
RB1800 5
47
3
1
8
6
4
2
RTP-DT23
RTP-DT21
RTP-DT19
RTP-DT17
7
RB1801 5
47
3
1
8
6
4
2
RTP-DT15
RTP-DT13
RTP-DT11
RTP-DT9
7
RB1802 5
47
3
1
8
6
4
2
RTP-DT7
RTP-DT5
RTP-DT3
RTP-DT1
7
RB1803 5
47
3
1
8
6
4
2
RTP-EN
RTP-STA
R1808
R1809
47
47
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
48
50
52
54
56
58
60
62
64
66
68
70
72
74
76
78
80
82
84
86
88
90
92
94
96
98
100
102
104
106
108
110
112
114
116
118
120
122
CN1800
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
35
37
39
41
43
45
47
49
51
53
55
57
59
61
63
65
67
69
71
73
75
77
79
81
83
85
87
89
91
93
95
97
99
101
103
105
107
109
111
113
115
117
119
121
MCLC_VAL_DE
MCLC_FLD
MCLC_CK
GND
MCLC_C(10)
MCLC_C(8)
MCLC_C(6)
MCLC_C(4)
MCLC_C(2)
MCLC_C(0)
GND
MCLC_Y(10)
MCLC_Y(8)
MCLC_Y(6)
MCLC_Y(4)
MCLC_Y(2)
MCLC_Y(0)
GND
GPIO(0)
+2.5V
+2.5V
+1.2V
+1.2V
+1.2V
+1.2V
GND
GND
GND
+3.3V_PLL
+3.3V
+3.3V
+3.3V
+3.3V
GND
EXT_PCLK
SYS_RESET_X
UART0_TXD
DTIF_DDEN
DTIF_DATA(30)
GND
DTIF_DATA(28)
DTIF_DATA(26)
DTIF_DATA(24)
DTIF_DATA(22)
DTIF_DATA(20)
GND
DTIF_DATA(18)
DTIF_DATA(16)
DTIF_DATA(14)
DTIF_DATA(12)
DTIF_DATA(10)
GND
DTIF_DATA(8)
DTIF_DATA(6)
DTIF_DATA(4)
DTIF_DATA(2)
DTIF_DATA(0)
GND
DTIF_PCLK
ENC/DEC_MODE
GND
R1816
22
DAYTONA-MAIN-F
2
4
RB1811 6
22 8
2
4
RB1812 6
22 8
1
3
5
7
1
3
5
7
DAYTONA-MAIN-C8
DAYTONA-MAIN-C6
DAYTONA-MAIN-C4
DAYTONA-MAIN-C2
DAYTONA-MAIN-C0
2
4
RB1813 6
22 8
1
3
5
7
DAYTONA-MAIN-Y4
DAYTONA-MAIN-Y2
DAYTONA-MAIN-Y0
R1814
+2.5V
DAYTONA-MAIN-V
DAYTONA-MAIN-Fa
to POST FPGA
020,024
020,024
DAYTONA-MAIN-Y8
DAYTONA-MAIN-Y6
R1828
220
DAYTONA-MAIN-GPIO_0
FB1812
C1806 10uF
+2.5V
+3.2V
to MAP FPGA
DAYTONA-MAIN-GPIO_0a 007
FB1804
+1.2V_DAY
FB1805
C1804 10uF
+3.3V_PLL_DEC
from DEMUX FPGA

74M-CLK-PLL-DAY-MAIN 017
+3.2V
FB1808
+3.2V
C1805 10uF
R1818
R1830
R1819
R1820
22
22
22
NM 2.2k
GND
IC1801 (1/2)
TC7SZ08FU(TE85R)
47
R1823
2
1
R1824
47
R1825
47
7
RB1807 5
47 3
1
8
6
4
2
RTP-DT30
RTP-DT28
RTP-DT26
RTP-DT24
7
RB1808 5
47 3
1
8
6
4
2
RTP-DT22
RTP-DT20
RTP-DT18
RTP-DT16
7
RB1809 5
47 3
1
8
6
4
2
RTP-DT14
RTP-DT12
RTP-DT10
RTP-DT8
7
RB1810 5
47 3
1
8
6
4
2
RTP-DT6
RTP-DT4
RTP-DT2
RTP-DT0
DAYTONA-MAIN-UART-TX
005,007,009,011,017
DPR-RESET_2
DAYTONA-MAIN-RESET 020
+3.2V from POST FPGA
020
+3.2V
IC1801 (2/2)
TC7SZ08FU(TE85R)
5
2
DAYTONA-MAIN-C9
4
DAYTONA-MAIN-C7
RB1804
6
DAYTONA-MAIN-C5
22
8
DAYTONA-MAIN-C3
2
DAYTONA-MAIN-C1
4
RB1805
6
DAYTONA-MAIN-Y9
22 8
DAYTONA-MAIN-Y7
(Reserve)
MCLC_VAL_V
MCLC_VAL_H
GND
MCLC_C(11)
MCLC_C(9)
MCLC_C(7)
MCLC_C(5)
MCLC_C(3)
MCLC_C(1)
GND
MCLC_Y(11)
MCLC_Y(9)
MCLC_Y(7)
MCLC_Y(5)
MCLC_Y(3)
MCLC_Y(1)
GND
GPIO(1)
GND
GND
GND
GND
GND
GND
+V_RG18
+V_RG18
+V_RG18
+3.3V_PLL
GND
GND
GND
GND
FRSEL
FFWRT
FSYNC
UART0_RXD
DTIF_DHEN
DTIF_DATA(31)
GND
DTIF_DATA(29)
DTIF_DATA(27)
DTIF_DATA(25)
DTIF_DATA(23)
DTIF_DATA(21)
GND
DTIF_DATA(19)
DTIF_DATA(17)
DTIF_DATA(15)
DTIF_DATA(13)
DTIF_DATA(11)
GND
DTIF_DATA(9)
DTIF_DATA(7)
DTIF_DATA(5)
DTIF_DATA(3)
DTIF_DATA(1)
GND
DTIF_PLD_EN
DTIF_PLD_ST
R1827
R1811
100
C1807
0.1uF
VCC
GND
DAYTONA-MAIN-H
22
22
MAIN(DEC)
R1822
10k
R1806
R1807
DY-23
GND
CL1801
1.2
TP1800
GND
+3.2V
DEC
DPR-300 (18/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_18
9-31
HSCU-300
9-31
E
DAYTONA-MAIN-Y2
DAYTONA-MAIN-Y3
DAYTONA-MAIN-Y1
DAYTONA-MAIN-Y9
DAYTONA-MAIN-Y0
DAYTONA-MAIN-Y8
DAYTONA-MAIN-Y7
DAYTONA-MAIN-Y4
DAYTONA-MAIN-Y5
DAYTONA-MAIN-Y6
DAYTONA-MAIN-C0
DAYTONA-MAIN-C1
DAYTONA-MAIN-C5
DAYTONA-MAIN-C6
DAYTONA-MAIN-C7
DAYTONA-MAIN-C2
DAYTONA-MAIN-C3
DAYTONA-MAIN-C4
DAYTONA-MAIN-C9
DAYTONA-MAIN-C8
1
3
5
7
2 RB2001
22
4
6
8
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
DAYTONA in
K2
I_MAIN_A_H_X
K1
I_MAIN_A_F_X
K3
I_MAIN_ASKIN
MAIN-AinY2
RB2002
22
MAIN-AinY3
MAIN-AinY1
MAIN-AinY9
MAIN-AinY0
MAIN-AinY8
MAIN-AinY7
MAIN-AinY4
MAIN-AinY5
MAIN-AinY6
RB2003
22
RB2004
22
MAIN-AinC0
MAIN-AinC1
MAIN-AinC5
MAIN-AinC6
MAIN-AinC7
MAIN-AinC2
MAIN-AinC3
MAIN-AinC4
MAIN-AinC9
MAIN-AinC8
RB2005
22
RB2006
22
MAIN-AinY9
MAIN-AinY8
MAIN-AinY7
MAIN-AinY6
MAIN-AinY5
MAIN-AinY4
MAIN-AinY3
MAIN-AinY2
MAIN-AinY1
MAIN-AinY0
MAIN-AinC9
MAIN-AinC8
MAIN-AinC7
MAIN-AinC6
MAIN-AinC5
MAIN-AinC4
MAIN-AinC3
MAIN-AinC2
MAIN-AinC1
MAIN-AinC0
L8
L7
L6
L4
L3
L2
L1
K8
K5
K4
N3
N2
N1
M8
M7
M6
M4
M3
M2
M1
+2.5V
from DAYTONA MAIN DEC
DAYTONA-MAIN
018
I_MAIN_AY9
I_MAIN_AY8
I_MAIN_AY7
I_MAIN_AY6
I_MAIN_AY5
I_MAIN_AY4
I_MAIN_AY3
I_MAIN_AY2
I_MAIN_AY1
I_MAIN_AY0
I_MAIN_AC9
I_MAIN_AC8
I_MAIN_AC7
I_MAIN_AC6
I_MAIN_AC5
I_MAIN_AC4
I_MAIN_AC3
I_MAIN_AC2
I_MAIN_AC1
I_MAIN_AC0
IC2001
CXD9223GG
(1/21)
C17
C18
A22
B21
A19
B18
A23
B22
A20
B19
B15
A14
B12
A11
B16
A15
B13
A12
G20
H20
G21
EAREFCLKN_2_27
EAREFCLKP_2_28
EARXIN0_2_22
EARXIN1_3_23
EARXIN2_2_24
EARXIN3_3_25
EARXIP0_2_21
EARXIP1_3_22
EARXIP2_2_23
EARXIP3_3_24
EXTXON0_2_30
EXTXON1_3_31
EXTXON2_2_32
EXTXON3_3_33
EXTXOP0_2_29
EXTXOP1_3_30
EXTXOP2_2_31
EXTXOP3_3_32
SDO0
SDO1
SDO2
NC:1
NC:2
NC:3
NC:4
NC:5
NC:6
NC_EN063
NC_EN070
NC_EN074
NC_EN077
NC_EN081
NC_EN082
NC_EN083
NC_EN084
NC_ES024
NC_ES038
NC_ES042
NC_ES043
NC_ES044
NC_ES045
NC_ES057
NC_ES058
NC_ES063
NC_ES064
NC_ES073
NC_ES081
NC_ES082
NC_ES084
NC_NE008
NC_NE009
NC_NE018
NC_NE023
NC_NE080
NC_NE081
NC_NW037
NC_NW038
NC_NW041
NC_NW042
NC_NW043
NC_NW044
NC_NW048
NC_NW049
NC_NW050
NC_NW073
NC_NW074
NC_NW080
NC_NW085
NC_NW086
NC_WN070
NC_WN077
NC_WN080
NC_WN081
NC_WS035
NC_WS050
NC_WS051
NC_WS052
NC_WS053
NC_WS058
NC_WS059
NC_WS060
NC_WS065
NC_WS071
NC_WS072
NC_WS078
NC_WS079
NC_WS082
G15
G18
H15
H18
J15
K15
AE6
AC8
AD7
AB9
AG4
AH3
AJ2
AF5
AD17
AC21
AE24
AK22
AJ22
AF25
AG21
AF21
AC22
AC20
AD23
AG26
AJ28
AH27
U2
U1
U4
U3
AH1
AH2
J3
F1
J2
J1
J4
G2
H2
H1
J5
C3
E5
G7
D4
B2
H10
G8
G9
H9
G19
B28
A28
G22
H22
H21
G23
H23
D27
E26
D26
F25
G24
C28
R2
P8
P7
P6
P5
P4
P3
P2
P1
N8
T8
T7
T5
T4
T3
T2
R8
R7
R4
R3
IC2001
CXD9223GG
(5/21)
H12
D11
E11
F11
G11
H11
E10
G10
D9
E9
IC2001
CXD9223GG
(15/21)
E24
D24
C24
E25
D25
B25
B26
A26
B27
A27
IC2001
CXD9223GG
(2/21)
IC2001
CXD9223GG
(7/21)
IC2001
CXD9223GG
(3/21)
AA1
O_ZEBRA_CK
AA2
O_ZEBRA1
AA3
O_ZEBRA2
AA4
O_ZEBRA3
AF1
O_MARK_Y1
AF2
O_MARK_Y2
AD1
O_MARK_S1
AE1
O_MARK_S2
moni-HD-PB/PR0
moni-HD-PB/PR6
moni-HD-PB/PR1
moni-HD-PB/PR2
moni-HD-PB/PR3
moni-HD-PB/PR7
moni-HD-PB/PR8
moni-HD-PB/PR4
O_VFPB9
O_VFPB8
O_VFPB7
O_VFPB6
O_VFPB5
O_VFPB4
O_VFPB3
O_VFPB2
O_VFPB1
O_VFPB0
O_VFPR9
O_VFPR8
O_VFPR7
O_VFPR6
O_VFPR5
O_VFPR4
O_VFPR3
O_VFPR2
O_VFPR1
O_VFPR0
NM
IC2001
CXD9223GG
(4/21)
AK4
AJ4
AH4
AH5
AG5
AG6
AF6
AE7
AE8
AD8
SDSDI-YC8
SDSDI-YC9
SDSDI-F
SDSDI-H
SDSDI-YC1
SDSDI-YC0
SDSDI-YC3
SDSDI-YC4
SDSDI-YC2
SDSDI-YC7
SDSDI-YC6
SDSDI-YC5
SDSDI-YC9
SDSDI-YC8
SDSDI-YC7
SDSDI-YC6
SDSDI-YC5
SDSDI-YC4
SDSDI-YC3
SDSDI-YC2
SDSDI-YC1
SDSDI-YC0
NM
2.5V -> 3.2V
main-HD-H
main-HD-F
AD2
AC1
AB1
AC2
AB2
AB3
AC4
AB4
AC5
AB5
AB6
main-HD-H
main-HD-F
main-HD-Y1
main-HD-Y0
main-HD-Y9
main-HD-Y6
main-HD-Y7
main-HD-Y8
main-HD-Y2
main-HD-Y3
main-HD-Y4
main-HD-Y5
main-HD-PB/PR6
main-HD-PB/PR7
IC2001
CXD9223GG
(6/21)
main-HD-Y9
main-HD-Y8
main-HD-Y7
main-HD-Y6
main-HD-Y5
main-HD-Y4
main-HD-Y3
main-HD-Y2
main-HD-Y1
main-HD-Y0
W2
W1
V8
V7
V6
V5
V4
V3
V2
V1
main-HD-PB/PR0
main-HD-PB/PR1
main-HD-PB/PR9
main-HD-PB/PR8
main-HD-PB/PR2
main-HD-PB/PR3
main-HD-PB/PR5
main-HD-PB/PR4
main-HD-PB/PR9
main-HD-PB/PR8
main-HD-PB/PR7
main-HD-PB/PR6
main-HD-PB/PR5
main-HD-PB/PR4
main-HD-PB/PR3
main-HD-PB/PR2
main-HD-PB/PR1
main-HD-PB/PR0
1
3
5
7
1
RB2020 3
220
5
7
1
RB2021 3
220
5
7
RB2019
220
2
4
6
8
2
4
6
8
2
4
6
8
1
3
5
7
1
RB2014 3
220 5
7
1
RB2015 3
220 5
7
1
RB2016 3
220 5
7
1
RB2017 3
220 5
7
1
3
5
7
RB2013
220
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
RB2008
220
RB2009
220
RB2010
220
RB2011
220
RB2012
220
moni-HD/SD-Y_f4
moni-HD/SD-Y_f8
moni-HD/SD-Y_f7
moni-HD/SD-Y_f5
moni-HD/SD-Y_f1
moni-HD/SD-Y_f2
moni-HD/SD-Y_f3
moni-HD/SD-Y_f0
moni-HD/SD-Y_f6
moni-HD/SD-Y_f9
moni-HD/SD-F_f
moni-HD/SD-H_f
moni-HD-PB/PR_f9
moni-HD-PB/PR_f5
moni-HD-PB/PR_f0
moni-HD-PB/PR_f6
moni-HD-PB/PR_f1
moni-HD-PB/PR_f2
moni-HD-PB/PR_f3
moni-HD-PB/PR_f7
moni-HD-PB/PR_f8
moni-HD-PB/PR_f4
SDSDI-YC_f8
SDSDI-YC_f9
SDSDI-F_f
SDSDI-H_f
SDSDI-YC_f1
SDSDI-YC_f0
SDSDI-YC_f3
SDSDI-YC_f4
SDSDI-YC_f2
SDSDI-YC_f7
SDSDI-YC_f6
SDSDI-YC_f5
main-HD-H_f
main-HD-F_f
main-HD-Y_f1
main-HD-Y_f0
main-HD-Y_f9
main-HD-Y_f6
main-HD-Y_f7
main-HD-Y_f8
main-HD-Y_f2
main-HD-Y_f3
main-HD-Y_f4
main-HD-Y_f5
main-HD-PB/PR_f6
main-HD-PB/PR_f7
main-HD-PB/PR_f0
main-HD-PB/PR_f1
main-HD-PB/PR_f9
main-HD-PB/PR_f8
main-HD-PB/PR_f2
main-HD-PB/PR_f3
main-HD-PB/PR_f5
main-HD-PB/PR_f4
RB2018
220
Y6
Y4
Y3
Y2
Y1
W8
W7
W6
W4
W3
+2.5V
FB2001C2025 0.1uF
10
NM SD844-H
AJ6
AK7
AJ7
AF7
AJ8
AH8
AG8
AF8
AG9
AF9
SD844-Y9
SD844-Y8
SD844-Y7
SD844-Y6
SD844-Y5
SD844-Y4
SD844-Y3
SD844-Y2
SD844-Y1
SD844-Y0
AD9
AC9
AH10
AG10
AF10
AB10
AD11
AB11
AD12
AC12
SD844-C9
SD844-C8
SD844-C7
SD844-C6
SD844-C5
SD844-C4
SD844-C3
SD844-C2
SD844-C1
SD844-C0
O_SDI_BC9
O_SDI_BC8
O_SDI_BC7
O_SDI_BC6
O_SDI_BC5
O_SDI_BC4
O_SDI_BC3
O_SDI_BC2
O_SDI_BC1
O_SDI_BC0
RB2007
220
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
SDSDI-H
SDSDI-F
AK6
O_SDI_B_H_X
AK5
O_SDI_B_F_X
AJ5
O_SDI_B_V_X
O_SDI_BY9
O_SDI_BY8
O_SDI_BY7
O_SDI_BY6
O_SDI_BY5
O_SDI_BY4
O_SDI_BY3
O_SDI_BY2
O_SDI_BY1
O_SDI_BY0
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
R2003
10
R2004
SD 8:4:4
AE11
O_SDI_B_CK
PROCYON
moni-HD/SD-Y4
moni-HD/SD-Y8
moni-HD/SD-Y7
moni-HD/SD-Y5
moni-HD/SD-Y1
moni-HD/SD-Y2
moni-HD/SD-Y3
moni-HD/SD-Y0
moni-HD/SD-Y6
moni-HD/SD-Y9
moni-HD/SD-F
moni-HD/SD-H
moni-HD-PB/PR9
moni-HD-PB/PR5
AA5
O_VF_SYNC_U
AA6
O_VF_SYNC_L
Y7
O_VF_BLK_X
IC2001 (21/21)
CXD9223GG
9-32
O_SDSDI9
O_SDSDI8
O_SDSDI7
O_SDSDI6
O_SDSDI5
O_SDSDI4
O_SDSDI3
O_SDSDI2
O_SDSDI1
O_SDSDI0
O_VFY10
O_VFY9
O_VFY8
O_VFY7
O_VFY6
O_VFY5
O_VFY4
O_VFY3
O_VFY2
O_VFY1
O_VFY0
I_RET_BY9
I_RET_BY8
I_RET_BY7
I_RET_BY6
I_RET_BY5
I_RET_BY4
I_RET_BY3
I_RET_BY2
I_RET_BY1
I_RET_BY0
I_RET_BC9
I_RET_BC8
I_RET_BC7
I_RET_BC6
I_RET_BC5
I_RET_BC4
I_RET_BC3
I_RET_BC2
I_RET_BC1
I_RET_BC0
moni-HD-PB/PR9
moni-HD-PB/PR8
moni-HD-PB/PR7
moni-HD-PB/PR6
moni-HD-PB/PR5
moni-HD-PB/PR4
moni-HD-PB/PR3
moni-HD-PB/PR2
moni-HD-PB/PR1
moni-HD-PB/PR0
AB7
O_VF_H_X
AC7
O_VF_F_X
AA7
O_VF_V_X
Y8
O_VF_SKIN
A25
I_RET_B_CK
F19
I_RET_B_H_X
E19
I_RET_B_F_X
F20
E20
F21
E21
D21
E22
D22
E23
D23
F24
AG12
AF12
AE12
AB12
AH13
AF13
AE13
AD13
AC13
AB13
MAIN-HDO_VF_CK AB8R2001
10
I_RET_AY9
I_RET_AY8
I_RET_AY7
I_RET_AY6
I_RET_AY5
I_RET_AY4
I_RET_AY3
I_RET_AY2
I_RET_AY1
I_RET_AY0
I_RET_AC9
I_RET_AC8
I_RET_AC7
I_RET_AC6
I_RET_AC5
I_RET_AC4
I_RET_AC3
I_RET_AC2
I_RET_AC1
I_RET_AC0
moni-HD/SD-Y9
moni-HD/SD-Y8
moni-HD/SD-Y7
moni-HD/SD-Y6
moni-HD/SD-Y5
moni-HD/SD-Y4
moni-HD/SD-Y3
moni-HD/SD-Y2
moni-HD/SD-Y1
moni-HD/SD-Y0
AJ3
O_SDSDI_H_X
AK3
O_SDSDI_F_X
D10
I_RET_A_CK
F14
I_RET_A_H_X
E14
I_RET_A_F_X
G14
D13
E13
F13
G13
H13
D12
E12
F12
G12
O_SDI_AC9
O_SDI_AC8
O_SDI_AC7
O_SDI_AC6
O_SDI_AC5
O_SDI_AC4
O_SDI_AC3
O_SDI_AC2
O_SDI_AC1
O_SDI_AC0
moni-HD/SD-H
moni-HD/SD-F
AJ10
AD10
AC10
AK11
AJ11
AH11
AG11
AF11
AC11
AH12
MAIN-SD
AG7
O_SDSDI_CK
I_MAIN_BY9
I_MAIN_BY8
I_MAIN_BY7
I_MAIN_BY6
I_MAIN_BY5
I_MAIN_BY4
I_MAIN_BY3
I_MAIN_BY2
I_MAIN_BY1
I_MAIN_BY0
I_MAIN_BC9
I_MAIN_BC8
I_MAIN_BC7
I_MAIN_BC6
I_MAIN_BC5
I_MAIN_BC4
I_MAIN_BC3
I_MAIN_BC2
I_MAIN_BC1
I_MAIN_BC0
R2002
AG13 10
O_SDI_A_CK
NM
AK10
O_SDI_A_H_X
AJ9
O_SDI_A_F_X
AH9
O_SDI_A_V_X
O_SDI_AY9
O_SDI_AY8
O_SDI_AY7
O_SDI_AY6
O_SDI_AY5
O_SDI_AY4
O_SDI_AY3
O_SDI_AY2
O_SDI_AY1
O_SDI_AY0
MDL
N6
I_MAIN_B_H_X
N5
I_MAIN_B_F_X
N7
I_MAIN_BSKIN
MONI
R2034
47
+3.2V
74M-CLK-FF
SD844-F
GND
005,007,009
from MB +3.3V
002
002
MST-HD-F_in
MST-SD-F_in
4
2
3
1
10
12
11
13
R2028
47
R2029
47
R2035
47
005,024 27M-CLK-FPGA-ANALOG
14
VCC
1PR
1D
1Q
1CK
1CLR 1Q
2PR
2D
2Q
2CK
2CLR 2Q
GND
7
GND
IC2003
TC74LCX74FT(EKJ)
5
6
9
8
+2.5V
R2027
10k
002 FRAME-RESET-GATE_in
2
IC2005(1/2)
TC7SZ08FU(TE85R) 1
R2030
47
IC2005 (2/2)
TC7SZ08FU(TE85R)
+2.5V
from ANALOG FPGA

024
ANA-SKIN-GATE
DAYTONA-MAIN-H
DAYTONA-MAIN-F
DPR-300 (20/28)
ZXCV_SD844
VCC
GND
to ANALOG FPGA
024
C2027
0.1uF
DPR-300 (20/28)
GND
9-32
HSCU-300
DPR-300 (20/28)
DPR-300 (20/28)
TP2003
HD-F
TP2001
R2031
100
SD-F
FRG
TP2002
TP2004
R2032
100
R2048
100
CPU-D0_f
CPU-D2_f
CPU-D5_f
MA11
MA9
MWE
MCE
MA6
MA4
MA10
MA8
MOE
MA7
MA5
CPU-D1_f
CPU-D3_f
CPU-D4_f
CPU-D6_f
CPU-D7_f
100
180 R2040
100
179 R2041
178
MA12
177
MA13
176
MA14
175
MA15
174
MD6
173
MD4
172
MD2
171
MD0
170
MA2
169
168
L2001
1uH
GND
C2001
10uF
6.3V
C2012 1uF
C2018 0.1uF
C2019 0.1uF
VCCIO1_1[E1]
VCCIO1_2[P1]
VCCIO1_3[G7]
VCCIO1_4[M7]
VCCIO2_1[A14]
VCCIO2_2[A5]
VCCIO2_3[E12]
VCCIO2_4[E9]
VCCIO3_1[P18]
VCCIO3_2[E18]
VCCIO3_3[M12]
VCCIO3_4[H12]
VCCIO4_1[V5]
VCCIO4_2[V14]
VCCIO4_3[P8]
VCCIO4_4[P11]
GND
66
64
63
62
61
60
59
58
57
55
IO34/VREF2B2[A6]
IO32/LVDS33n[A8]
IO31/LVDS35n[A9]
IO30/LVDS38p[A10]
IO28/LVDS42p[A12]
IO27/LVDS45p[A13]
BANK3
3.2V
IO240/LVDS57n[G12]
IO229/LVDS57p[F12]
IO228/LVDS55n[F13]
IO225/LVDS63n[J13]
IO224/LVDS65p[L13]
IO223/LVDS65n[M13]
IO222/LVDS70n[N13]
IO221/LVDS70p[N12]
IO162/LVDS64p[L15]
IO160/LVDS69p[N15]
IO123/LVDS52n[D16]
IO121/LVDS54n[F16]
IO120/LVDS58p[G16]
IO119/LVDS61n[H16]
IO116/DQ1R0[M16]
IO115/LVDS69n[N16]
IO114/VREF2B3[P16]
IO113/LVDS73p[R16]
IO112/LVDS75n[T16]
GND
IO73/LVDS51n[C17]
IO72/LVDS51p[D17]
IO70/LVDS56p[F17]
IO68/LVDS61p[H17]
IO67/LVDS66p[L17]
IO65/LVDS71p[N17]
IO64/DQ1R6[P17]
IO63/LVDS74n[R17]
IO62/LVDS75p[T17]
GND
295
IO236/LVDS101p[M8]
296
IO237/LVDS89p[M9]
297
IO238/LVDS80n[M10]
298
IO239/LVDS77n[M11]
270
IO217/LVDS101n[N8]
271
IO218/LVDS89n[N9]
272
IO219/LVDS80p[N10]
273
IO220/LVDS77p[N11]
277
276
275 R2018
274 R2019
RB2029
220
208 SDI-B-C6
207 SDI-B-C3
206
205
204
203
167
166
165 SDI-B-Y8
164 SDI-B-Y3
163 SDI-B-C8
161 SDI-B-C5
160 SDI-B-C0
159
158
157
156
155
to ANALOG FPGA
024
PROCYON-RESET
022
022
022
022
ZXCV-MST-HD-F
ZXCV-MST-HD-H
ZXCV-MST-FRG
ZXCV-MST-SD-F
to MB
REAR-SEL-B-HD/SD_out
REAR-SEL-A-HD/SD_out
SDI-DIAG_NG/OK
-12V-CHARGE-PUMP
MA1
SDI-A-LOCKED
SDI-A-HD/SD
SDI-OUT-RESET
MA15
MA14
MA13
MA12
MA11
MA10
MA9
MA8
MA7
MA6
MA5
MA4
MA3
MA2
MA1
MA0
7
5
3
1
MCE
MOE
MWE
8
6
4
2
RB2031
47
18
19
20
21
24
25
26
27
42
43
44
1
2
3
4
5
6
41
17
40
39
+3.2V +3.2V
11
33
VDD1 VDD2
A15 I/O15
A14 I/O14
A13 I/O13
A12 I/O12
A11 I/O11
A10 I/O10
I/O9
A9
I/O8
A8
A7
I/O7
I/O6
A6
I/O5
A5
A4
I/O4
A3
I/O3
A2
I/O2
A1
I/O1
A0
I/O0
C2024
0.1uF
38
37
36
35
32
31
30
29
16
15
14
13
10
9
8
7
CS
OE
22
WE
NC1
23
BHE
NC2
28
BLE
NC3
VSS1 VSS2
12
34
GND
GND
RB2032
220
8
6
4
2
8
6
4
2
7
5
3
1
7
5
3
1
MD7
MD6
MD5
MD4
MD3
MD2
MD1
MD0
RB2033
220
GND
MA3
SDI-A-Y5
SDI-A-C3
SDI-A-C6
SDI-A-C5
CPU-A1_f
CPU-RD_f
1
CPU-D0_f
3
CPU-D1_f
5
CPU-D2_f
7
CPU-D3_f
1
CPU-D4_f
3
CPU-D5_f
5
CPU-D6_f
7
CPU-D7_f
7
CPU-A0_f
5
CPU-A1_f
3
CPU-RD_f
1
CPU-WR_f
CPU-CS4_f R2021
2
4
6
8
2
4
6
8
CPU-D0
CPU-D1
CPU-D2
CPU-D3
CPU-D4
CPU-D5
CPU-D6
CPU-D7
CPU-A0
CPU-A1
CPU-RD
CPU-WR
CS_POST
RB2024
220
RB2025
220
8
6 RB2026
4 220
2
220
005,007,011,017,022,024,025
CPU_I/F
SDI-A-Y6
SDI-A-Y3
SDI-A-Y0
SDI-A-C8
SDI-A-C4
+3.2V-20
R2047
10k
R2023
10k
CONFIG_DATA0
CONFIG_DCLK
CL2009
1.2
IC2000(5/7)
EP1C12F324C8N(300)
107
247
43
R2025 278
0
NM 290
11
R2024
1k
CONFIG_nCE_2-3
CONFIG_nCE_3-4
CONFIG_nCONFIG
CONFIG_nSTATUS
CONFIG_CONF_DONE
291
77
76
300
106
TDI[J17]
TMS[K14]
TCK[K18]
TDO[K13]
DATA0[H7]
DCLK[L1]
nCE[J7]
nCEO[K2]
nCONFIG[J2]
nSTATUS[L12]
CONF_DONE[K17]
+3.2V-20
136
MSEL0[K3]
292
MSEL1[K7]
007,017,024
CONFIG_CHAIN
GND
CL2010
1.2
1
IC700
MAP
EP1C20
EPCS16
SDI-A-Y9
SDI-A-Y7
SDI-A-Y2
2
IC1700
DEMUX
EP1C20
3
IC2000
POST
EP1C12
4
IC2400
ANALOG
EP1C12
EPR2
SDI-A_out
SDI-B_out
to SDI OUT
023
023
from/to MB(SY)
RCP-PWR-NG-STATUS_if 002
SY_UT
002
to ANALOG FPGA
024
CL2004
1.2
EXT-CG
DPR-300 (20/28)
BOARD NO. 1-879-649-11
PROCYON MST SYNC
HDCU-300_DPR-300_011_20
9-33
HSCU-300
CPU-A0_f
SDI-A-Y8
SDI-A-Y4
SDI-A-Y1
SDI-A-C9
SDI-A-C7
SDI-B-Y7
SDI-B-Y4
SDI-B-Y1
SDI-B-C2
0.5mA
023
023
023
CPU-WR_f
CPU-CS4_f
SDI-B-Y6
SDI-B-Y2
SDI-B-C9
SDI-B-C1
002
002
002,004
002
RB2030
220
RB2027 GND
220
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
SDI-A-C0
SDI-A-C1
SDI-A-C2
ANALOG
to Procyon-V
022
to SDI OUT
023
023
SDI-B-LOCKED
SDI-B-HD/SD
100
100
214
213
212 SDI-B-Y9
211 SDI-B-Y5
210 SDI-B-Y0
49
47
46
45
42
41
40
38
RB2028
220
005
100
252
251
250
249
248 SDI-B-C7
246 SDI-B-C4
245
244
243
113
112
111
110
109
108
105
104
103
102
101
100
CP-CLK_2
CL2007
1.2
CL2005
+3.2V
1.2
CL2006
1.2
R2020
CL2008
100k
1.2
470
220
IO25/DQ0R0[D18]
IO24/LVDS56n[F18]
IO22/DQ0R7[H18]
IO21/LVDS66n[L18]
IO20/LVDS68n[M18]
IO19/LVDS71n[N18]
IO18/LVDS74p[R18]
304
283
282
281
280 R2016
279 R2017
R2033
IO189/LVDS97n[P7]
IO190/VREF1B4[P9]
IO191[P10]
IO192[P12]
IO193/VREF0B4[P13]
235
236
238
239
241
242
220
220
220
220
CL2003
1.2
R2014
47
209
CLK2/LVDSCLK2p[J15]
162R2022
47
CLK3/LVDSCLK2n[J16]
IO168/LVDS52p[D15]
IO165/LVDS58n[G15]
IO164/LVDS62p[H15]
BANK4
2.5V
IC2000(2/7)
EP1C12F324C8N(300)
SYSTEM-HD-F
022
IO134/LVDS28p[C6]
IO133/LVDS30p[C7]
IO132/LVDS34p[C8]
IO131/LVDS36p[C9]
IO130/LVDS39n[C10]
IO129/LVDS41n[C11]
IO126/VREF0B2[C14]
IO124/LVDS50n[C16]
MD7
MD5
MD3
MD1
MA0
2 DEMUX-AU-3/4
4 DEMUX-AU-1/2
6
8DEMUX-AU-LRCK
1
3
5
7
224
223
222
221
220
219
218
217
216
215
IO177/LVDS29p[D6]
IO176/LVDS30n[D7]
IO175/LVDS34n[D8]
IO173/LVDS39p[D10]
IO172/LVDS41p[D11]
220
220
220
260
259
258
256
255
253
287
286
285
284
IO233/LVDS25n[F8]
IO232/LVDS37p[F9]
IO231/LVDS46p[F10]
IO230/LVDS49p[F11]
IO180/LVDS18n[F5]
IO183/PLL1_OUTn[K5]
IO184/LVDS9p[L5]
IO186/LVDS4p[N5]
CLK0/LVDSCLK1p[J3]
CLK1/LVDSCLK1n[J4]
IC2000 (3/7)
EP1C12F324C8N(300)
IO202/VREF0B3[E14]
IO201/LVDS55p[F14]
IO200/LVDS59p[G14]
IO199/LVDS62n[H14]
IO198/VREF1B3[J14]
IO197[L14]
R2036
R2037
R2038
R2039
R2006
220
+2.5V
5
14
289
294
56
65
254
257
39
48
299
303
22
31
237
240
1
3
16
18
20
33
35
37
50
52
54
67
69
84
99
114
309
310
311
312
314
315
316
317
318
320
322
324
10
301
264
44
C2023
0.1uF
SY_UT0
SY_UT1
SY_UT2
SY_UT3
186
IO142/PLL1_OUTp[K4]
IO143/LVDS9n[L4]
IO144/LVDS7n[M4]
IO146[P4]
C2007 1uF
C2013 0.1uF
C2014 0.1uF
C2008 1uF
C2015 0.1uF
C2009 1uF
C2016 0.1uF
C2010 1uF
C2017 0.1uF
C2011 1uF
VCCINT1[B1]
VCCINT2[U1]
VCCINT3[V2]
VCCINT4[V17]
VCCINT5[U18]
VCCINT6[B18]
VCCINT7[A17]
VCCINT8[A2]
VCCINT9[L9]
VCCINT10[H10]
VCCINT11[J9]
VCCINT12[K10]
ANALOG-Y2
ANALOG-H
ANALOG-V
ANALOG-F
ANALOG-RES1
R2005
47 135
DEMUX-AU-64FS
C2002
10uF
6.3V
2
17
19
34
36
51
53
68
313
319
321
323
GND1[A1]
GND2[C1]
GND3[T1]
GND4[V1]
GND5[V3]
GND6[V16]
GND7[V18]
GND8[T18]
GND9[C18]
GND10[A18]
GND11[A16]
GND12[A3]
GND13[B2]
GND14[U2]
GND15[U17]
GND16[B17]
GND17[H8]
GND18[J8]
GND19[K8]
GND20[L8]
GND21[L10]
GND22[L11]
GND23[K11]
GND24[J11]
GND25[H11]
GND26[H9]
GND27[K9]
GND28[J10]
GNDA_PLL1[K1]
GNDA_PLL2[K12]
GNDG_PLL1[J6]
GNDG_PLL2[J18]
IO148/VREF2B4[R5]
IO149/LVDS96n[R6]
IO151/LVDS92n[R8]
IO153/LVDS87n[R10]
IO154/LVDS86p[R11]
IO156/LVDS81n[R13]
74M-CLK-FPGA-POST
+3.2V-20
229
VCCA_PLL1[J5]
302
VCCA_PLL2[J12]
192
193
194
195
196
197
198
199
200
201
202
DPR-RESET_3
IC2000(4/7)
EP1C12F324C8N(300)
main-HD-Y_f9
main-HD-Y_f6
005,022,024,026
C2029 0.1uF
C2030 0.1uF
EXT-CG-VSYNC
EXT-CG-OSC
R2052 R2053 R2054

100k 100k 100k
GND
IO137/VREF0B1[D4]
IO139/LVDS18p[F4]
IO141/LVDS12p[H4]
IO209/LVDS16p[F6]
IO211/VREF1B1[H6]
IO212/ASDO[K6]
IO213/LVDS11n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO234/LVDS16n[F7]
IC2002
IDT71V016SA15PHG-TL
IC2000 (7/7)
IC2000 (6/7)
EP1C12F324C8N(300)EP1C12F324C8N(300)
ANALOG-Y1
ANALOG-Y5
ANALOG-Y7
ANALOG-C9
ANALOG-C6
ANALOG-C3
VER_2
VER_1
VER_0
L2002
1uH
EXT-CG-HSYNC
NM
NM
261
262
263
265
266
CL2002 267
1.2
268
269
CL2001
1.2
288
R2042
47 293
GND
143
main-HD-Y_f8
IO100/LVDS100p[T4]
main-HD-PB/PR_f0 144 IO101/LVDS99p/DQ1B7[T5]
main-HD-PB/PR_f1 145 IO102/LVDS96p[T6]
146
147
R2012 100
IO104/LVDS92p[T8]
148
IO105/LVDS90n[T9]
149
IO106/LVDS87p[T10]
150
IO107/LVDS86n[T11]
151
152
IO109/LVDS81p[T13]
153
154
IO111/LVDS76n[T15]
VER_2
VER_1
VER_0
main-HD-Y_f4
+3.2V
R2049 R2050 R2051
100k 100k 100k
NM
225
226
227
228
230
231
232
233
234
POST_S1
POST_S2
POST_S3
POST_S4
BANK1
3.2V
ANALOG-Y0
ANALOG-Y4
ANALOG-Y8
ANALOG-C7
ANALOG-C4
ANALOG-C2
ANALOG-C1
POST_S1
POST_S2
POST_S3
POST_S4
GND
+3.2V
005
187
188
189
190
191
SDSDI-YC_f1
SDSDI-YC_f3
SDSDI-YC_f8
SDSDI-F_f
main-HD-Y_f3
C2003
10uF
6.3V
GND
IO48/LVDS102p[U3]
IO49/LVDS100n[U4]
IO53/LVDS93p[U8]
IO54/LVDS91p[U9]
IO55/LVDS88p[U10]
IO57/LVDS84n[U12]
IO61/LVDS76p[U16]
2
4
6
8
181
182
183
184
185
GND
+3.2V
85
86
87
88
89
90
91
92
93
94
95
96
97
98
1
3
5
7
1:CLEAN
2:
3:
4:
1
3
5
7
S2001
moni-HD/SD-Y_f0
moni-HD/SD-Y_f8
moni-HD/SD-Y_f5
moni-HD/SD-Y_f9
moni-HD/SD-H_f
IO94/LVDS10n[L3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
AUDIO SRAM
C2028
1uF
C2004 1uF
C2020 0.1uF
C2005 1uF
C2021 0.1uF
C2006 1uF
C2022 0.1uF
main-HD-PB/PR_f9
main-HD-PB/PR_f8
main-HD-PB/PR_f3
main-HD-PB/PR_f5
main-HD-PB/PR_f6
R2011
100
RB2034
22k
137
138
139
140
141
142
L2004
10uH
L2003
1uH
POST FPGA
IO91/LVDS19n[F3]
IO92/LVDS15p[G3]
IO93/LVDS13n[H3]
ANALOG-Y3
ANALOG-Y6
ANALOG-Y9
ANALOG-C8
ANALOG-C5
ANALOG-C0
2
4
6
8
+3.2V
SDSDI-YC_f0
SDSDI-YC_f4
SDSDI-YC_f9
main-HD-Y_f2
main-HD-Y_f5
main-HD-Y_f7
+1.5V
IO8/LVDS102n[V4]
IO9/LVDS98p[V6]
IO11/LVDS93n[V8]
IO12/LVDS91n[V9]
IO13/LVDS88n[V10]
IO14/LVDS85n[V11]
IO15/LVDS84p[V12]
moni-HD-PB/PR_f1 129
moni-HD/SD-Y_f3 130
moni-HD/SD-Y_f4 131
moni-HD/SD-Y_f7 132
moni-HD/SD-Y_f6 133
moni-HD/SD-F_f 134
004
BANK2
3.2V
21
23
24
25
26
27
28
29
30
32
main-HD-Y_f0
IO36/LVDS23n[C2]
IO37/LVDS22n[D2]
IO39/LVDS19p[F2]
IO40/LVDS17n[G2]
IO41/LVDS13p[H2]
IO42/LVDS10p[L2]
IO44/LVDS6n[N2]
IO46/LVDS1p[R2]
IO47/LVDS0p[T2]
RB2022
220
main-HD-PB/PR_f2
main-HD-PB/PR_f4
main-HD-PB/PR_f7
R2007 100
70
71
72
73
74
75
78
79
80
81
82
83
moni-HD-PB/PR_f0
moni-HD-PB/PR_f2
moni-HD-PB/PR_f3
moni-HD-PB/PR_f8
moni-HD-PB/PR_f9
moni-HD/SD-Y_f1
SDSDI-YC_f2
SDSDI-YC_f6
SDSDI-H_f
main-HD-H_f
main-HD-Y_f1
IO244/LVDS25p[G8]
IO243/LVDS37n[G9]
IO242/LVDS46n[G10]
IO241/LVDS49n[G11]
moni-HD-PB/PR_f6 4 IO0[D1]
moni-HD-PB/PR_f7 6 IO1/DPCLK1/DQS0L[F1]
moni-HD-PB/PR_f4 7 IO2/LVDS17p[G1]
moni-HD-PB/PR_f5 8 IO3/DQ0L7[H1]
9
moni-HD/SD-Y_f2
IO4/nCSO[J1]
12
SDSDI-YC_f7
IO5/DQ1L0[M1]
13
SDSDI-YC_f5
IO6/LVDS6p[N1]
15
main-HD-F_f
IO7/VREF2B1[R1]
308
307
306
305
IC2000 (1/7)
EP1C12F324C8N(300)
R2009
R2010
DEMUX-AUDIO
DEMUX-UTIL
DEMUX-F
DEMUX-SKIN-GATE
IO208/LVDS29n[E6]
IO205/VREF1B2[E10]
IO204[E11]
IO203[E13]
from DEMUX
017
017
017,024
017,024
R2008
TRIAX-H
015
1
VDD_DAY_CORE_NG/OK
R2046
R2013
R2043
R2044
R2045
100
005
R2015
10k
128
127
126
125
124
123
122
121
120
119
118
117
116
115
TRIAX-H
27M-CLK-FPGA-POST
+3.2V
IO84/LVDS28n[B6]
IO82/LVDS33p[B8]
IO81/LVDS35p[B9]
IO80/LVDS38n[B10]
IO79/LVDS40n[B11]
IO78/LVDS42n[B12]
IO77/LVDS45n[B13]
IO74/LVDS50p[B16]
018,024
DAYTONA-MAIN-V
018,024
DAYTONA-MAIN-Fa
018 DAYTONA-MAIN-F-RESET
018 DAYTONA-MAIN-UART-RX
018 DAYTONA-MAIN-UART-TX
018 DAYTONA-MAIN-FRSEL
018 DAYTONA-MAIN-FFWRT
018 DAYTONA-MAIN-RESET
100
100
100 DAYTONA-MAIN-GPIO_0
100 DAYTONA-MAIN-GPIO_1
from/to DAYTONA MAIN DEC

018
DAYTONA-MAIN-GPIO
9-33
M
IC2001
CXD9223GG
(9/21)
Y30
O_SDR_CK1
AK28
O_SDR_CKE1
7
5
3
1
7
5
3
1
7
5
3
1
8
6
4
2
8
6 RB2103
100
4
2
8
6
4
2
RB2101
100
GND
SDRAMCAS
SDRAMRAS
SDRAMCS
SDRAMBANK1
1
3
5
7
RB2104
100
2
4
6
8
SDRAMCLK
SDRAMWE
7
5
3
1
8
6
4
2
SDRAMCKE
59
28
71
16
18
19
20
17
68
67
14
21
30
57
69
70
73
RB2105
47
+3.2V
C2106 C2108
0.1uF 0.1uF
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
SDRAMBUS62
SDRAMBUS61
SDRAMBUS60
SDRAMBUS59
SDRAMBUS58
SDRAMBUS57
SDRAMBUS56
SDRAMBUS55
SDRAMBUS54
SDRAMBUS53
SDRAMBUS52
SDRAMBUS51
SDRAMBUS50
SDRAMBUS49
SDRAMBUS48
SDRAMBUS47
SDRAMBUS46
SDRAMBUS45
SDRAMBUS44
SDRAMBUS43
SDRAMBUS42
SDRAMBUS41
SDRAMBUS40
SDRAMBUS39
SDRAMBUS38
SDRAMBUS37
SDRAMBUS36
SDRAMBUS35
SDRAMBUS34
SDRAMBUS33
SDRAMBUS32
SDRAMBANK0
SDRAMAD9
SDRAMAD8
SDRAMAD7
SDRAMAD6
SDRAMAD5
SDRAMAD4
SDRAMAD3
SDRAMAD2
SDRAMAD1
SDRAMAD0
SDRAMAD10
7
5
3
1
7
5
3
1
7
5
3
1
8
6
4
2
8
6
4
2
8
6
4
2
GND
23
22
24
66
65
64
63
62
61
60
27
26
25
RB2107
100
RB2108
100
RB2106
100
GND
SDRAMCAS
SDRAMRAS
SDRAMCS
SDRAMBANK1
1
3
5
7
RB2109
100
2
4
6
8
SDRAMCLK
SDRAMWE
7
5
3
1
8
6
4
2
SDRAMCKE
RB2110
47
59
28
71
16
18
19
20
17
68
67
IC2001
CXD9223GG
(10/21)
1
RB21193
100
5
7
1
RB21203
100
5
7
1
RB21213
100
5
7
1
RB21223
100
5
7
1
RB21233
100
5
7
1
RB21243
100
5
7
1
RB21253
100
5
7
1
RB21263
100
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
J29
L27
M25
L23
M28
M27
M23
L28
J28
K24
K28
H30
G30
SDRAMbAD0
SDRAMbAD1
SDRAMbAD2
SDRAMbAD3
SDRAMbAD4
SDRAMbAD5
SDRAMbAD6
SDRAMbAD7
SDRAMbAD8
SDRAMbAD9
SDRAMbAD10
SDRAMbBANK0
SDRAMbBANK1
G29
O_SDR_CAS2
K27
O_SDR_RAS2
L24
O_SDR_CS2
K23
O_SDR_WE2
SDRAMbCAS
SDRAMbRAS
SDRAMbCS
SDRAMbWE
J30
O_SDR_CK2
B29
O_SDR_CKE2
SDRAMbCLK
SDRAMbCKE
+3.2V
L2103
1uH
GND
1
15
29
43
3
9
35
41
49
55
75
81
SDRAMBUSb32
SDRAMBUSb33
SDRAMBUSb34
SDRAMBUSb35
SDRAMBUSb36
SDRAMBUSb37
SDRAMBUSb38
SDRAMBUSb39
SDRAMBUSb40
SDRAMBUSb41
SDRAMBUSb42
SDRAMBUSb43
SDRAMBUSb44
SDRAMBUSb45
SDRAMBUSb46
SDRAMBUSb47
SDRAMBUSb48
SDRAMBUSb49
SDRAMBUSb50
SDRAMBUSb51
SDRAMBUSb52
SDRAMBUSb53
SDRAMBUSb54
SDRAMBUSb55
SDRAMBUSb56
SDRAMBUSb57
SDRAMBUSb58
SDRAMBUSb59
SDRAMBUSb60
SDRAMBUSb61
SDRAMBUSb62
SDRAMbBANK0 7
SDRAMbAD9 5
SDRAMbAD8 3
SDRAMbAD7 1
SDRAMbAD6 7
SDRAMbAD5 5
SDRAMbAD4 3
SDRAMbAD3 1
SDRAMbAD2 7
SDRAMbAD1 5
SDRAMbAD0 3
SDRAMbAD10 1
8
6
4
2
8
6
4
2
8
6
4
2
23
22
24
66
65
64
63
62
61
60
27
26
25
RB2128
100
RB2129
100
RB2127
100
GND
SDRAMbCAS 1
SDRAMbRAS 3
5
SDRAMbCS
SDRAMbBANK1 7
RB2130
100
2
4
6
8
7
5
3
1
8
6
4
2
SDRAMbCLK
SDRAMbWE
SDRAMbCKE
68
67
14
21
30
57
69
70
73
R2102
10k
56
54
53
51
50
48
47
45
42
40
39
37
36
34
33
31
85
83
82
80
79
77
76
74
13
11
10
8
7
5
4
2
BA1
DQ31
BA0
DQ30
A10/AP
DQ29
A9
DQ28
A8
DQ27
A7
DQ26
A6
DQ25
A5
DQ24
A4
DQ23
IC2103
A3
W9864G2GH-6-W-ER10 DQ22
A2
DQ21
A1
DQ20
DQ19
A0
DQ18
DQM3
DQ17
DQM2
DQ16
DQM1
DQ15
DQM0
DQ14
DQ13
CAS
DQ12
RAS
DQ11
CS
DQ10
WE
DQ9
DQ8
CLK
DQ7
CKE
DQ6
DQ5
NC1
DQ4
NC2
DQ3
NC3
DQ2
NC4
DQ1
NC5
DQ0
NC6
NC7
1
RB21373
100
5
7
1
RB21383
100
5
7
1
RB21393
100
5
7
1
RB21403
100
5
7
1
RB21413
100
5
7
1
RB21423
100
5
7
1
RB21433
100
5
7
1
RB21443
100
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
SDRAMBUSb62
SDRAMBUSb61
SDRAMBUSb60
SDRAMBUSb59
SDRAMBUSb58
SDRAMBUSb57
SDRAMBUSb56
SDRAMBUSb55
SDRAMBUSb54
SDRAMBUSb53
SDRAMBUSb52
SDRAMBUSb51
SDRAMBUSb50
SDRAMBUSb49
SDRAMBUSb48
SDRAMBUSb47
SDRAMBUSb46
SDRAMBUSb45
SDRAMBUSb44
SDRAMBUSb43
SDRAMBUSb42
SDRAMBUSb41
SDRAMBUSb40
SDRAMBUSb39
SDRAMBUSb38
SDRAMBUSb37
SDRAMBUSb36
SDRAMBUSb35
SDRAMBUSb34
SDRAMBUSb33
SDRAMBUSb32
1
RB21453
100
5
7
1
RB21463
100
5
7
1
RB21473
100
5
7
1
RB21483
100
5
7
1
RB21493
100
5
7
1
RB21503
100
5
7
1
RB21513
100
5
7
1
RB21523
100
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
SDRAMBUSb31
SDRAMBUSb30
SDRAMBUSb29
SDRAMBUSb28
SDRAMBUSb27
SDRAMBUSb26
SDRAMBUSb25
SDRAMBUSb24
SDRAMBUSb23
SDRAMBUSb22
SDRAMBUSb21
SDRAMBUSb20
SDRAMBUSb19
SDRAMBUSb18
SDRAMBUSb17
SDRAMBUSb16
SDRAMBUSb15
SDRAMBUSb14
SDRAMBUSb13
SDRAMBUSb12
SDRAMBUSb11
SDRAMBUSb10
SDRAMBUSb9
SDRAMBUSb8
SDRAMBUSb7
SDRAMBUSb6
SDRAMBUSb5
SDRAMBUSb4
SDRAMBUSb3
SDRAMBUSb2
SDRAMBUSb1
SDRAMBUSb0
GND
C2118 C2120
10uF 10uF
6.3V 6.3V
+3.2V
C2122 C2124
0.1uF 0.1uF
C2126 C2128 C2130 C2132

0.1uF 0.1uF 0.1uF 0.1uF
L2104
1uH
GND
<PROCYON>
SDRAMBUS31
SDRAMBUS30
SDRAMBUS29
SDRAMBUS28
SDRAMBUS27
SDRAMBUS26
SDRAMBUS25
SDRAMBUS24
SDRAMBUS23
SDRAMBUS22
SDRAMBUS21
SDRAMBUS20
SDRAMBUS19
SDRAMBUS18
SDRAMBUS17
SDRAMBUS16
SDRAMBUS15
SDRAMBUS14
SDRAMBUS13
SDRAMBUS12
SDRAMBUS11
SDRAMBUS10
SDRAMBUS9
SDRAMBUS8
SDRAMBUS7
SDRAMBUS6
SDRAMBUS5
SDRAMBUS4
SDRAMBUS3
SDRAMBUS2
SDRAMBUS1
SDRAMBUS0
59
28
71
16
18
19
20
17
RB2131
47
SDRAMbBANK0 7
SDRAMbAD9 5
SDRAMbAD8 3
SDRAMbAD7 1
SDRAMbAD6 7
SDRAMbAD5 5
SDRAMbAD4 3
SDRAMbAD3 1
SDRAMbAD2 7
SDRAMbAD1 5
SDRAMbAD0 3
SDRAMbAD10 1
8
6
4
2
8
6
4
2
8
6
4
2
23
22
24
66
65
64
63
62
61
60
27
26
25
RB2133
100
RB2134
100
RB2132
100
GND
SDRAMbCAS 1
SDRAMbRAS 3
5
SDRAMbCS
SDRAMbBANK1 7
RB2135
100
2
4
6
8
7
5
3
1
8
6
4
2
SDRAMbCLK
SDRAMbWE
SDRAMbCKE
RB2136
47
59
28
71
16
18
19
20
17
68
67
14
21
30
57
69
70
73
56
BA1
DQ31
54
BA0
DQ30
53
A10/AP
DQ29
51
A9
DQ28
50
A8
DQ27
48
A7
DQ26
47
DQ25
A6
45
DQ24
A5
42
DQ23
A4
IC2104
40
A3
W9864G2GH-6-W-ER10 DQ22 39
DQ21
A2
37
DQ20
A1
36
DQ19
A0
34
DQ18
33
DQM3
DQ17
31
DQM2
DQ16
85
DQM1
DQ15
83
DQM0
DQ14
82
DQ13
80
CAS
DQ12
79
RAS
DQ11
77
CS
DQ10
76
WE
DQ9
74
DQ8
13
CLK
DQ7
11
CKE
DQ6
10
DQ5
8
NC1
DQ4
7
NC2
DQ3
5
NC3
DQ2
4
NC4
DQ1
2
NC5
DQ0
NC6
NC7
44
58
72
86
6
12
32
38
46
52
78
84
44
58
72
86
6
12
32
38
46
52
78
84
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
14
21
30
57
69
70
73
56
BA1
DQ31
54
BA0
DQ30
53
A10/AP
DQ29
51
A9
DQ28
50
A8
DQ27
48
A7
DQ26
47
DQ25
A6
45
DQ24
A5
42
DQ23
A4
IC2102
40
A3
W9864G2GH-6-W-ER10 DQ22 39
DQ21
A2
37
DQ20
A1
36
DQ19
A0
34
DQ18
33
DQM3
DQ17
31
DQM2
DQ16
85
DQM1
DQ15
83
DQM0
DQ14
82
DQ13
80
CAS
DQ12
79
RAS
DQ11
77
CS
DQ10
76
WE
DQ9
74
DQ8
13
CLK
DQ7
11
CKE
DQ6
10
DQ5
8
NC1
DQ4
7
NC2
DQ3
5
NC3
DQ2
4
NC4
DQ1
2
NC5
DQ0
NC6
NC7
C29
C30
D29
D30
E29
E30
F29
F30
F28
G27
E28
F27
D28
E27
F26
G26
J23
H24
J24
H25
J25
K22
K25
L25
J26
K26
H29
J27
H26
H27
G25
B_SDR_D2_U0
B_SDR_D2_U1
B_SDR_D2_U2
B_SDR_D2_U3
B_SDR_D2_U4
B_SDR_D2_U5
B_SDR_D2_U6
B_SDR_D2_U7
B_SDR_D2_U8
B_SDR_D2_U9
B_SDR_D2_U10
B_SDR_D2_U11
B_SDR_D2_U12
B_SDR_D2_U13
B_SDR_D2_U14
B_SDR_D2_U15
B_SDR_D2_U16
B_SDR_D2_U17
B_SDR_D2_U18
B_SDR_D2_U19
B_SDR_D2_U20
B_SDR_D2_U21
B_SDR_D2_U22
B_SDR_D2_U23
B_SDR_D2_U24
B_SDR_D2_U25
B_SDR_D2_U26
B_SDR_D2_U27
B_SDR_D2_U28
B_SDR_D2_U29
B_SDR_D2_U30
O_SDR_A20
O_SDR_A21
O_SDR_A22
O_SDR_A23
O_SDR_A24
O_SDR_A25
O_SDR_A26
O_SDR_A27
O_SDR_A28
O_SDR_A29
O_SDR_A210
O_SDR_A211
O_SDR_A212
C2110 C2112 C2114 C2116

0.1uF 0.1uF 0.1uF 0.1uF
L2102
1uH
<PROCYON>
1
RB21113
100
5
7
1
RB21123
100
5
7
1
RB21133
100
5
7
1
RB21143
100
5
7
1
RB21153
100
5
7
1
RB21163
100
5
7
1
RB21173
100
5
7
1
RB21183
100
5
7
B_SDR_D2_L0
B_SDR_D2_L1
B_SDR_D2_L2
B_SDR_D2_L3
B_SDR_D2_L4
B_SDR_D2_L5
B_SDR_D2_L6
B_SDR_D2_L7
B_SDR_D2_L8
B_SDR_D2_L9
B_SDR_D2_L10
B_SDR_D2_L11
B_SDR_D2_L12
B_SDR_D2_L13
B_SDR_D2_L14
B_SDR_D2_L15
B_SDR_D2_L16
B_SDR_D2_L17
B_SDR_D2_L18
B_SDR_D2_L19
B_SDR_D2_L20
B_SDR_D2_L21
B_SDR_D2_L22
B_SDR_D2_L23
B_SDR_D2_L24
B_SDR_D2_L25
B_SDR_D2_L26
B_SDR_D2_L27
B_SDR_D2_L28
B_SDR_D2_L29
B_SDR_D2_L30
B_SDR_D2_L31
GND
C2102 C2104
10uF 10uF
6.3V 6.3V
SDRAMCLK
SDRAMCKE
BA1
DQ31
BA0
DQ30
A10/AP
DQ29
A9
DQ28
A8
DQ27
A7
DQ26
A6
DQ25
A5
DQ24
A4
DQ23
IC2101
A3
W9864G2GH-6-W-ER10 DQ22
A2
DQ21
A1
DQ20
DQ19
A0
DQ18
DQM3
DQ17
DQM2
DQ16
DQM1
DQ15
DQM0
DQ14
DQ13
CAS
DQ12
RAS
DQ11
CS
DQ10
WE
DQ9
DQ8
CLK
DQ7
CKE
DQ6
DQ5
NC1
DQ4
NC2
DQ3
NC3
DQ2
NC4
DQ1
NC5
DQ0
NC6
NC7
R2101
10k
56
54
53
51
50
48
47
45
42
40
39
37
36
34
33
31
85
83
82
80
79
77
76
74
13
11
10
8
7
5
4
2
K29
K30
L29
L30
M29
M30
N29
N30
R26
R27
P27
N28
N27
P26
N26
N25
N23
P23
R23
P24
N24
M24
R24
P25
P29
P30
T29
T28
T27
R29
R28
P28
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
SDRAMCAS
SDRAMRAS
SDRAMCS
SDRAMWE
SDRAMBANK0
SDRAMAD9
SDRAMAD8
SDRAMAD7
SDRAMAD6
SDRAMAD5
SDRAMAD4
SDRAMAD3
SDRAMAD2
SDRAMAD1
SDRAMAD0
SDRAMAD10
RB2102
100
23
22
24
66
65
64
63
62
61
60
27
26
25
SDRAMBUSb0
SDRAMBUSb1
SDRAMBUSb2
SDRAMBUSb3
SDRAMBUSb4
SDRAMBUSb5
SDRAMBUSb6
SDRAMBUSb7
SDRAMBUSb8
SDRAMBUSb9
SDRAMBUSb10
SDRAMBUSb11
SDRAMBUSb12
SDRAMBUSb13
SDRAMBUSb14
SDRAMBUSb15
SDRAMBUSb16
SDRAMBUSb17
SDRAMBUSb18
SDRAMBUSb19
SDRAMBUSb20
SDRAMBUSb21
SDRAMBUSb22
SDRAMBUSb23
SDRAMBUSb24
SDRAMBUSb25
SDRAMBUSb26
SDRAMBUSb27
SDRAMBUSb28
SDRAMBUSb29
SDRAMBUSb30
SDRAMBUSb31
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
AA30
O_SDR_CAS1
AA29
O_SDR_RAS1
AA28
O_SDR_CS1
AA26
O_SDR_WE1
GND
C2125 C2127 C2129 C2131

0.1uF 0.1uF 0.1uF 0.1uF
44
58
72
86
6
12
32
38
46
52
78
84
SDRAMAD0
SDRAMAD1
SDRAMAD2
SDRAMAD3
SDRAMAD4
SDRAMAD5
SDRAMAD6
SDRAMAD7
SDRAMAD8
SDRAMAD9
SDRAMAD10
SDRAMBANK0
SDRAMBANK1
L2101
1uH
C2121 C2123
0.1uF 0.1uF
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
AB27
AE29
AF28
AD27
AA25
Y29
AB26
Y24
AA24
Y23
AD29
AA27
AD30
O_SDR_A10
O_SDR_A11
O_SDR_A12
O_SDR_A13
O_SDR_A14
O_SDR_A15
O_SDR_A16
O_SDR_A17
O_SDR_A18
O_SDR_A19
O_SDR_A110
O_SDR_A111
O_SDR_A112
+3.2V
1
15
29
43
3
9
35
41
49
55
75
81
SDRAMBUS32
SDRAMBUS33
SDRAMBUS34
SDRAMBUS35
SDRAMBUS36
SDRAMBUS37
SDRAMBUS38
SDRAMBUS39
SDRAMBUS40
SDRAMBUS41
SDRAMBUS42
SDRAMBUS43
SDRAMBUS44
SDRAMBUS45
SDRAMBUS46
SDRAMBUS47
SDRAMBUS48
SDRAMBUS49
SDRAMBUS50
SDRAMBUS51
SDRAMBUS52
SDRAMBUS53
SDRAMBUS54
SDRAMBUS55
SDRAMBUS56
SDRAMBUS57
SDRAMBUS58
SDRAMBUS59
SDRAMBUS60
SDRAMBUS61
SDRAMBUS62
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
AB25
AA23
AC24
AB24
AB23
AD24
AB22
AC23
AD25
AE25
AC25
AE26
AD26
AC26
AC27
AB28
AE30
AF30
AF29
AG30
AG29
AH30
AH29
AJ29
AF26
AH28
AG27
AG28
AF27
AE27
AE28
B_SDR_D1_U0
B_SDR_D1_U1
B_SDR_D1_U2
B_SDR_D1_U3
B_SDR_D1_U4
B_SDR_D1_U5
B_SDR_D1_U6
B_SDR_D1_U7
B_SDR_D1_U8
B_SDR_D1_U9
B_SDR_D1_U10
B_SDR_D1_U11
B_SDR_D1_U12
B_SDR_D1_U13
B_SDR_D1_U14
B_SDR_D1_U15
B_SDR_D1_U16
B_SDR_D1_U17
B_SDR_D1_U18
B_SDR_D1_U19
B_SDR_D1_U20
B_SDR_D1_U21
B_SDR_D1_U22
B_SDR_D1_U23
B_SDR_D1_U24
B_SDR_D1_U25
B_SDR_D1_U26
B_SDR_D1_U27
B_SDR_D1_U28
B_SDR_D1_U29
B_SDR_D1_U30
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
B_SDR_D1_L0
B_SDR_D1_L1
B_SDR_D1_L2
B_SDR_D1_L3
B_SDR_D1_L4
B_SDR_D1_L5
B_SDR_D1_L6
B_SDR_D1_L7
B_SDR_D1_L8
B_SDR_D1_L9
B_SDR_D1_L10
B_SDR_D1_L11
B_SDR_D1_L12
B_SDR_D1_L13
B_SDR_D1_L14
B_SDR_D1_L15
B_SDR_D1_L16
B_SDR_D1_L17
B_SDR_D1_L18
B_SDR_D1_L19
B_SDR_D1_L20
B_SDR_D1_L21
B_SDR_D1_L22
B_SDR_D1_L23
B_SDR_D1_L24
B_SDR_D1_L25
B_SDR_D1_L26
B_SDR_D1_L27
B_SDR_D1_L28
B_SDR_D1_L29
B_SDR_D1_L30
B_SDR_D1_L31
44
58
72
86
6
12
32
38
46
52
78
84
U23
T23
U24
T24
V24
V23
W23
W24
U28
V28
U30
U29
V30
V29
W30
W29
V25
U25
U27
U26
V26
V27
Y25
W25
AC30
AC29
AB30
AB29
Y28
Y27
W28
W27
C2117 C2119
10uF 10uF
6.3V 6.3V
SDRAM2(DC)
1
15
29
43
3
9
35
41
49
55
75
81
SDRAMBUS0
SDRAMBUS1
SDRAMBUS2
SDRAMBUS3
SDRAMBUS4
SDRAMBUS5
SDRAMBUS6
SDRAMBUS7
SDRAMBUS8
SDRAMBUS9
SDRAMBUS10
SDRAMBUS11
SDRAMBUS12
SDRAMBUS13
SDRAMBUS14
SDRAMBUS15
SDRAMBUS16
SDRAMBUS17
SDRAMBUS18
SDRAMBUS19
SDRAMBUS20
SDRAMBUS21
SDRAMBUS22
SDRAMBUS23
SDRAMBUS24
SDRAMBUS25
SDRAMBUS26
SDRAMBUS27
SDRAMBUS28
SDRAMBUS29
SDRAMBUS30
SDRAMBUS31
C2109 C2111 C2113 C2115

0.1uF 0.1uF 0.1uF 0.1uF
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
C2105 C2107
0.1uF 0.1uF
1
15
29
43
3
9
35
41
49
55
75
81
C2101 C2103
10uF 10uF
6.3V 6.3V
SDRAM1(FC)
DPR-300 (21/28)
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
DPR-300 (21/28)
GND
GND
DPR-300 (21/28)
BOARD NO. 1-879-649-11
9-34
A
HDCU-300_DPR-300_011_21
9-34
HSCU-300
DPR-300 (22/28)
DPR-300 (22/28)
+2.5V
CPU_I/F
005,007,011,017,020,024,025
VSS:93
VSS:94
VSS:95
VSS:96
VSS:97
VSS:98
VSS:99
VSS:100
VSS:101
VSS:102
VSS:103
VSS:104
VSS:105
VSS:106
VSS:107
VSS:108
VSS:109
VSS:110
VSS:111
VSS:112
VSS:113
VSS:114
VSS:115
VSS:116
VSS:117
VSS:118
VSS:119
VSS:120
VSS:121
VSS:122
VSS:123
VSS:124
VSS:125
VSS:126
VSS:127
VSS:128
VSS:129
VSS:130
VSS:131
VSS:132
VSS:133
VSS:134
VSS:135
VSI1
VSI2
VSI3
VSN:1
VSN:2
VSN:3
VSN:4
VSN:5
VSN:6
VSN:7
VSN:8
VSN:9
VSN:10
VSN:11
VSN:12
VSN:13
VSN:14
VSN:15
VSN:16
VSN:17
VSN:18
VSN:19
VSN:20
VSN:21
VSN:22
VSN:23
VSN:24
VSN:25
VSN:26
VSN:27
VSN:28
VSN:29
VSN:30
VSN:31
VSU:1
VSU:2
C2212
0.1uF
C2202
1uF
C2213
0.1uF
C2203
1uF
C2214
0.1uF
C2204
1uF
C2215
0.1uF
C2205
1uF
C2216
0.1uF
C2206
1uF
C2217
0.1uF
C2207
1uF
C2218
0.1uF
C2208
1uF
C2219
0.1uF
C2209
1uF
C2220
0.1uF
C2210
1uF
C2221
0.1uF
GND
AJ14
AJ15
A8
A10
A16
A17
A18
A24
B11
B17
B23
B24
C13
C14
C16
C20
C21
C22
C23
D14
D19
D20
E15
E18
F15
F18
G16
G17
H16
H17
J16
J17
K16
K17
D17
E17
IC2001
CXD9223GG
(20/21)
<PROCYON>
GND
C2201
1uF
VDDI-1.2V
A2
B8
B30
C9
H14
K10
K11
K13
K14
K18
K19
K20
M10
M12
M13
M14
M15
M16
M17
M18
M19
M21
N10
N12
N19
N21
P10
P12
P14
P15
P16
P17
P19
P21
R6
R10
R12
R14
R17
R19
R21
T10
T12
T14
T17
T19
T21
T25
U10
U12
U14
U15
U16
U17
U19
U21
V10
V12
V19
V21
W12
W13
W14
W15
W16
W17
W18
W19
Y10
Y21
AA10
AA12
AA13
AA14
AA15
AA16
AA17
AA18
AA20
AA21
AB16
AC16
AD16
AE16
AF16
AG15
AH15
AJ1
AK29
VDI2
VDD:1
VDD:2
VDD:3
VDD:4
VDD:5
VDD:6
VDD:7
VDD:8
VDD:9
VDD:10
VDD:11
VDD:12
VDD:13
VDD:14
VDD:15
VDD:16
VDD:17
VDD:18
VDD:19
VDD:20
VDD:21
VDD:22
VDD:23
VDD:24
VDD:25
VDD:26
VDD:27
VDD:28
VDD:29
VDD:30
VDD:31
VDD:32
VDD:33
VDD:34
VDD:35
VDD:36
VDD:37
VDD:38
VDD:39
VDD:40
VDD:41
VDD:42
VDD:43
VDD:44
VDD:45
VDD:46
VDD:47
VDD:48
VDD:49
VDD:50
VDD:51
VDD:52
VDD:53
VDD:54
VDD:55
VDD:56
VDD:57
VDD:58
VDD:59
VDD:60
VDD:61
VDD:62
VDD:63
VDD:64
VDD:65
VDD:66
VDD:67
VDD:68
VDD:69
VDD:70
VDD:71
VDD:72
VDD:73
VDD:74
VDD:75
VDD:76
VDD:77
VDD:78
VDD:79
VDD:80
VDD:81
VDD:82
VDD:83
VDD:84
VDD:85
VDD:86
VDD:87
VDD:88
VDD:89
AK14
VDI1
A9
VDI3
+1.2V
C2247
0.1uF
VDN:1
VDN:2
VDN:3
VDN:4
VDN:5
VDN:6
VDN:7
VDN:8
VDU:1
VDU:2
A13
A21
B14
B20
C15
C19
D15
D18
D16
E16
H28
L21
M22
M26
R30
T26
W21
W26
Y22
AC28
AJ30
C2242
1uF
C2245
10uF 6.3V
C2248
0.1uF
GNDGND
+1.2V
GND
C2262 L2207
10uF 6.3V 1uH
C2243
1uF
C2249
0.1uF
C2263
10uF 6.3V
C2244
1uF
GNDGND
0.1uF
C2250
VDDE2-3.3V
or
VDDE2:1
2.5V
VDDE2:2
VDDE2:3
VDDE2:4
VDDE2:5
VDDE2:6
VDDE2:7
VDDE2:8
VDDE2:9
VDDE2:10
VDDE2:11 IC2001
CPU-D0
CPU-D1
CPU-D2
CPU-D3
CPU-D4
CPU-D5
CPU-D6
CPU-D7
1
3
5
7
1
3
5
7
CPU-A0
CPU-A1
1
3
5
7
CXD9223GG
(18/21)
C2251
0.1uF
GND
<PROCYON>
C2252
22uF
RB2201
220
2
4
6
8
2
4
6
8
RB2202 220
H8
H6
H5
G5
G1
F4
F3
E1
B7
C7
D7
E7
F7
C6
D6
E6
A5
B5
C5
D5
B4
B3
2
4
6
8
RB2203
220
C2261
0.1uF
GND
005
CP-CLK_5
1
3
5
7
CPU-WR
CPU-RD
CS_ZXCV
+2.5V
R2206
47k
020
005
PROCYON-RESET
PROCYON_PLL_RST
R2211
R2212
100
100
2
4
6
8
RB2204
47
2
1
R2207
100
IC2204 (1/2) R2208

TC7SZ08FU(TE85R) 100
+2.5V
B_CPUD0
B_CPUD1
B_CPUD2
B_CPUD3
B_CPUD4
B_CPUD5
B_CPUD6
B_CPUD7
L2203
1uH
C2232
0.1uF
C2223
1uF
C2233
0.1uF
C2224
1uF
C2234
0.1uF
C2225
1uF
C2235
0.1uF
C2226
1uF
C2236
0.1uF
C2227
1uF
C2237
0.1uF
C2228
1uF
C2238
0.1uF
C2229
1uF
C2239
0.1uF
C2230
1uF
C2240
0.1uF
C2231
1uF
GND
IC2001
CXD9223GG
(19/21)
A6
A29
B1
B10
C11
C26
F10
F22
H3
J13
J22
K12
K21
L10
M5
M9
R5
T1
W5
W10
Y9
AA11
AA19
AC3
AE10
AE21
AH6
AH21
AK2
AK9
AK23
OSD:CGCG1-in(HD)
I_OSD1_R
I_OSD1_G
I_OSD1_B
I_OSD1_S
I_OSD2_R
CG2-in(HD/SD)
I_OSD2_G
I_OSD2_B
I_OSD2_S
CG3-in(SD)
C8
I/O
I_CPUIF_MPX_DIR
IC2001
CXD9223GG
(11/21)
E2
F6
J6
U5
U6
AB18
AD14
AD19
AE18
AE23
AJ18
AJ19
AJ24
I_EXTIO0
I_EXTIO1
I_EXTIO2
I_EXTIO3
I_EXTIO4
I_EXTIO5
I_EXTIO6
I_EXTIO7
12.5k ohrm
internal
PULL DOWN
I_ZXCV_MODE = L
: New Function Active
<PROCYON>
O_EXTIO0
O_EXTIO1
O_EXTIO2
O_EXTIO3
O_EXTIO4
O_EXTIO5
O_EXTIO6
O_EXTIO7
+2.5V
GND
GND
IC2204 (2/2)
TC7SZ08FU(TE85R)
IC2001
CXD9223GG
(12/21)
AG16
AH23
AJ23
AJ13
AJ12
AK12
+2.5V
R2219
100
CG2-CS (SD-moni)
A3
C1
C2
C4
D3
H7
J8
J9
R2258
100
NM
GND
R2255 1k
SW-POS
R2254
4.7k
R2221
100
R2222
100
R2253
4.7k
D1 CG1-CS (HD-moni)
D2 CG2-CS (SD-moni)
E3 CG3-CS (BAR-Chara)
E4
F2
F5
CL2204
G6
1.2
J7 R2209 100
NM
CG-CS0(BAR)
CG-CS1(PIX)
RELAY-OFF/ON
R2223
100
026
026
022
R2224
100
CG3-CS (BAR-Chara)
EXT-CG-HSYNC
EXT-CG-VSYNC
R2230
R2225
100
R2226
100
R2227
100
8
OSCIN
7
OSCOUT
GND
10
GND
HD/SD-BAR-Chara
R2236
10
C2259 0.1uF
R2233
5
GND
10
100
3
VDD
16 R2239
VR
DATA
100
6
17 R2240
VG
CMDCT
1
100
18 R2241
VB
CLK
100 2
15
CS
VBLK/BBLK
4
12
PCL
VC1
9
11
TEST
BLK1
20
14
R2242
HSYNC VC2/GBLK
100
19
13
VSYNC BLK2/RBLK
HD
SD
8
OSCIN
7
OSCOUT
GND
10
GND
+2.5V
CL2208
0.8
CL2207
0.8
P-HD-H
P-HD-F
TP2200 TP2201
I_PLL_BYPASS
005
SDI0
SDI1
SDI2
SDI3
SDI4
R2201
100
from POST FPGA
020
020
020
020
H4
CRES1
C27
CRES2
R2256
100
005
74M-CLK-PROCYON
27M-CLK-PROCYON
1
3
5
7
ZXCV-MST-HD-F
ZXCV-MST-HD-H
ZXCV-MST-SD-F
ZXCV-MST-FRG
D2201
RB715W-TL
R2259
33
R2203
10 AK18
R2260
33
R2204
10 AK19
VBS
CLK/TG
AG17
AF17
I_FRG_X
I_SD_F_X
AH18
I_TEMP_H
N4
I_WIPEKEY
<PROCYON>
AD21
O_PLL74_A
AB20
O_PLL74_B
AC18
O_VBS_CK
AD4
AA8
O_VBS_CF
AA9
O_VBS_SYNC
I_CK27
AE17
I_REF_H_X
AG18
I_REF_F_X
2
4
6
8
RB2205
100
IC2001
CXD9223GG
(16/21)
I_CK74
IC2001
CXD9223GG
(8/21)
AK21
O_PLL27_A
AJ21
O_PLL27_B
O_VBS11
O_VBS10
O_VBS9
O_VBS8
O_VBS7
O_VBS6
O_VBS5
O_VBS4
O_VBS3
O_VBS2
O_VBS1
O_VBS0
AC6
AD6
AD5
AE5
AE4
AE3
AE2
AF4
AF3
AG3
AG2
AG1
<PROCYON>
O_FRG_X
AJ20
O_REF_EXTINT
AK20
O_REF_HDSD
CXD9223GG
(17/21)
+2.5V
<PROCYON>
R2250
47k
RELAY-OFF/ON
AF20
O_SYNC_CLP1
AG20
O_SYNC_CLP2
AD20
O_SYNC_GATE
+5V-D
R2202
10k
from PROCYON
022
C2222
GND 22uF
R2251
100
2
1
C2253
0.1uF
5
R2261 100
RELAY-(PIX_WFM)
+5V to MB
002
GND
CL2202
0.8
CL2201
0.8
+2.5v==>+5V
AG19
O_TG1_H_X
AE19
O_TG1_F_X
VHCT08==>Single_GATE
AF18
O_TG2_H_X
AH19
O_TG2_F_X
AD18
O_TG3_H_X
AC19
O_TG3_F_X
IC2001
CXD9223GG
(13/21)
DPR-300 (22/28)
<PROCYON>
9-35
HSCU-300
SD
+2.5V
IC2205
TC7SET08FU(T5RSOJF)
R2235
10
C2258 0.1uF
5
GND NM
VDD
16 R2246
100
VR
DATA
17 R2247
100
VG
CMDCT
18 R2248
100
VB
CLK
NM
15
CS
VBLK/BBLK
12
PCL
VC1
11
TEST
BLK1
14
R2238
HSYNC VC2/GBLK
100
13
VSYNC BLK2/RBLK
IC2203
UPD6467GR-525-E2
F16
VDP:1
F17
VDP:2 IC2001
C2241
GND 22uF
6.75 MHz(27M/4)
028
R2232
10
3
6
1
100 2
4
9
20
19
+2.5V
CL2203
1.2
CL2205
1.2
SD-MONI-Chara

020
EXT-CG
AB21
O_PLL_LOCK
AF19
O_PLL_MON
GND
R2229
R2220
100
OTHERS
AE14
VPD1
AF14
VPD2
R2257
47k
VDE:1
VDE:2
VDE:3
VDE:4
VDE:5
VDE:6
VDE:7
VDE:8
VDE:9
VDE:10
VDE:11
VDE:12
VDE:13
TRST
TMS
TDO
TDI
TCK
GND
10
GND
IC2202
UPD6467GR-525-E2
R2218
100
EXT-CG-OSC
AK17
AH16
AJ17
AJ16
AK16
8
OSCIN
7
OSCOUT
<PROCYON>
R2210
100
HD
+2.5V
<PROCYON>
B6
I_RST_X
AK13
I_RST_PLL_X
AH22
I_OSD3_Y
AG22
I_OSD3_S
AD22
O_OSD_TGB_CK
CG2-SG(HD/SD)
AG25
O_OSD_TGB_H_X
IC2001
AH25
O_OSD_TGB_V_X
CXD9223GG
(14/21)
R2231
10
3
6
1
100 2
4
9
20
19
AK26
AJ25
AK25
AJ26
AG24
AF23
AG23
AF22
AK27
O_OSD_TGA_CK
CG1-SG(HD)
AH26
O_OSD_TGA_H_X
AJ27
O_OSD_TGA_V_X
A4
I_CPU_CK
F8
I_CPUCS_X
E8
I_CPURD_X
D8
I_CPUWR_X
VCC
GND
R2216
100
R2217
100
C2260
0.1uF
VDDE1:1
VDDE1:2
VDDE1:3
VDDE1:4
VDDE1:5
VDDE1:6
VDDE1:7
VDDE1:8
VDDE1:9
VDDE1:10
VDDE1:11
VDDE1:12
VDDE1:13
VDDE1:14
VDDE1:15
VDDE1:16
VDDE1:17
VDDE1:18
VDDE1:19
VDDE1:20
VDDE1:21
VDDE1:22
VDDE1:23
VDDE1:24
VDDE1:25
VDDE1:26
VDDE1:27
VDDE1:28
VDDE1:29
VDDE1:30
VDDE1:31
R2228
R2215
100
I_CPUA0
I_CPUA1
I_CPUA2
I_CPUA3
I_CPUA4
I_CPUA5
I_CPUA6
I_CPUA7
I_CPUA8
I_CPUA9
I_CPUA10
I_CPUA11
I_CPUA12
I_CPUA13
+2.5V
VDDE-2.5V
CG1-CS (HD-moni)
R2252
100
14.8MHz(74M/5)
AC17
I_ZXCV_MODE
R2249
100
GND
(500mA)
R2214
100
CPU-IF
R2205
100
G4
NM
O_CPUWAIT
<PROCYON>
GND
L2205
1uH
C2246
AK15 0.1uF
R2213
100
CG-DATA
CG-CLK
005,020,024,026
VSS:1
VSS:2
VSS:3
VSS:4
VSS:5
VSS:6
VSS:7
VSS:8
VSS:9
VSS:10
VSS:11
VSS:12
VSS:13
VSS:14
VSS:15
VSS:16
VSS:17
VSS:18
VSS:19
VSS:20
VSS:21
VSS:22
VSS:23
VSS:24
VSS:25
VSS:26
VSS:27
VSS:28
VSS:29
VSS:30
VSS:31
VSS:32
VSS:33
VSS:34
VSS:35
VSS:36
VSS:37
VSS:38
VSS:39
VSS:40
VSS:41
VSS:42
VSS:43
VSS:44
VSS:45
VSS:46
VSS:47
VSS:48
VSS:49
VSS:50
VSS:51
VSS:52
VSS:53
VSS:54
VSS:55
VSS:56
VSS:57
VSS:58
VSS:59
VSS:60
VSS:61
VSS:62
VSS:63
VSS:64
VSS:65
VSS:66
VSS:67
VSS:68
VSS:69
VSS:70
VSS:71
VSS:72
VSS:73
VSS:74
VSS:75
VSS:76
VSS:77
VSS:78
VSS:79
VSS:80
VSS:81
VSS:82
VSS:83
VSS:84
VSS:85
VSS:86
VSS:87
VSS:88
VSS:89
VSS:90
VSS:91
VSS:92
C2211
0.1uF
V22
W9
W11
W20
W22
Y5
Y11
Y12
Y13
Y14
Y15
Y16
Y17
Y18
Y19
Y20
Y26
AA22
AB14
AB15
AB17
AB19
AC14
AC15
AD3
AD15
AD28
AE9
AE15
AE20
AE22
AF15
AF24
AG14
AH7
AH14
AH17
AH20
AH24
AK1
AK8
AK24
AK30
L2204
1uH
(500mA)
1
2
GND
+3.2V
(500mAx2)
A1
A7
A30
B9
C10
C12
C25
F9
F23
G3
G28
H19
J10
J11
J12
J14
J18
J19
J20
J21
K6
K7
K9
L5
L9
L11
L12
L13
L14
L15
L16
L17
L18
L19
L20
L22
L26
M11
M20
N9
N11
N13
N14
N15
N16
N17
N18
N20
N22
P9
P11
P13
P18
P20
P22
R1
R9
R11
R13
R15
R16
R18
R20
R22
R25
T6
T9
T11
T13
T15
T16
T18
T20
T22
T30
U7
U8
U9
U11
U13
U18
U20
U22
V9
V11
V13
V14
V15
V16
V17
V18
V20
L2201
1uH
L2202
1uH
+2.5V
026
026
DPR-RESET_3
+1.2V
R2234
10
C2257 0.1uF
HD-MONI-Chara
5
GND
VDD
16 R2243
100
DATA
VR
17 R2244
100
CMDCT
VG
18 R2245
100
VB
CLK
15
CS
VBLK/BBLK
12
PCL
VC1
11
TEST
BLK1
14
R2237
HSYNC VC2/GBLK
100
13
VSYNC BLK2/RBLK
IC2201
UPD6467GR-525-E2
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_22
9-35
E
RB2303
220
RB2304
220
RB2305
220
SDI-A-C0
SDI-A-C1
SDI-A-C2
SDI-A-C3
+3.3V-SDI_A
+1.8V-SDI_A
+1.8V-SDI_A
SDI-A-10bit/20bit
023
FB2307
IC2306 (1/2)
TC7SZ125FU(TE85R)
4 R2310 10 74M
SDI-B-CLK
023
R2314
10
IC2307 (1/2)
TC7SZ125FU(TE85R)
R2307
2.2k
NM
NM
C2363
10uF
6.3V
1608
4 R2311 10 27M
2
1
GND
C2322
1uF
X2301
1483.5-1485.0MHz
C2323
1uF
+2.5V-VCO_A
3
7
NC
VCC
5 CONT
OUT 1
G1 G2 G3 G4
2 4 6 8
C2365
GND 4.7uF
C2324
1uF
R2317
10k
GND-VCO_A
IC2303 (1/2)
TC7SH04FU(T5RSOYJF)
IC2304(2/2)
TC7SZ125FU(TE85R)
GND
GND
C2306
0.1uF
GND
R2318
47
SDI-A-CLK
023
C2361
0.1uF
GND-GS_A
VCO
VCO_VCC
VCO_GND2
VCO_GND1
CP_RES
LF
+3.3V-SDI_A
J9 R2320
SDOUT_TDO
K10 1k
SDIN_TDI
CD-VDD_A
R2321
J10
1k
C2327
SCLK_TCLK
1uF
K9
C2328 1uF
CS_TMS
R2323
1k
GND GND-GS_A
GND-GS_A
DIN19
DIN18
DIN17
DIN16
DIN15
DIN14
DIN13
DIN12
DIN11
DIN10
DIN9
DIN8
DIN7
DIN6
DIN5
DIN4
DIN3
DIN2
DIN1
DIN0
R2338
51
C2308
0.1uF
1
3
5
7
2
4
6
8
RSET
IC2308(1/1)
GS1572-IBE3
NC1
NC2
NC3
NC4
NC5
NC6
(1/10W)
R2301
+5.0V 10
(4.0__5.0V)
1608
dV=1.0V@100mA
=>100mW
+3.3V-SDI_A
IC2305
NJM2871BF33-TE2
C2303
10uF
6.3V
1608
R2302
22k 1
VIN
CTL
VOUT
CL2301
1.2
C2309
1uF
6.3V
3
N_BYP
GND
C2304
0.1uF
2
10V
C2310
10uF
6.3V
1608
RSV11
RSV10
RSV9
RSV8
RSV7
RSV6
RSV5
RSV4
RSV3
RSV2
RSV1
20BIT/10BIT
IOPROC_EN/DIS
ANC_BLANK
JTAG/HOST
DVB_ASI
SD/HD
SMPTE_BYPASS
RESET
GND-GS_A
(+2.5V)
R2303 2.2k
C2367
4.7uF
6.3V
D6
D7
D8
E4
E8
F8
CD-VDD_A
R2324 R2325
680
0
C2326
0.01uF
NM
R2344
R2345
0
0
SDI_1.2_OUT(Y)
to MB
002
SDI_1.2_OUT(X)
002
GND-SDI
GND-GS_A
I(Drv)
+3.3V-SDI_A
R2340
1k
H4
R2327
1k
R2328
1k
47k
47k
R2329
R2334
R2333
CL2303
0.8
SDI-A-LOCKED
020
R2341
1k
47k
R2335
G4
G7
R2336
47k
H3
R2330
1k
H8
1k
R2331
G5 R2326
R2337
1k
47k
E3
G6
1k
R2332
G8
DRFF. 100(OHRM)
C2330
4.7uF
R2342
1k
R2343
1k
47k
GND-GS_A
GND
+1.8V-SDI_A
+1.8V-SDI_A
CL2305
1.2
IC2311
R1173H001D-T1-F
FB2319
C2329
4.7uF
from POST FPGA

020,023
SDI-A-HD/SD
023
SDI-A-10bit/20bit
FB2308
GND
+2.5V
R2339
51
GND
Pd=70mW(@100mA)
F10
G3
TIM_861
D3
STANDBY
F3
DETECT_TRS
D4
SDO_EN/DIS
C6
C7
C8
C9
D9
E9
F9
L2302
1uH
K7
K6
K5
K4
J7
J6
J5
J4
H7
H6
H5
SDI-A(1,2)_OUT
D10
SDO
C10
SDO
R2319
B4
2.2k
PCLK
NM
GND
A3
F/DE
C4
V/VSYNC
A4
H/HSYNC
RB2311
NM 100
+5V-D
C2321
4.7uF
LOCKED
VCC
GND
3
C2302
0.1uF
C2307
0.1uF
IC2307(2/2)
TC7SZ125FU(TE85R)
C2305
0.1uF
VCC
GND
VCC
GND
GND
GND
C2301
0.1uF
IC2302(2/2)
TC7SZ125FU(TE85R)
VCC
GND
3
VCC
GND
GND
VCC
GND
B3
A2
A1
B2
B1
C2
C1
C3
D1
D2
F1
F2
H1
H2
J1
J2
K1
K2
J3
K3
SDI-DiA-Y9
SDI-DiA-Y8
SDI-DiA-Y7
SDI-DiA-Y6
SDI-DiA-Y5
SDI-DiA-Y4
SDI-DiA-Y3
SDI-DiA-Y2
SDI-DiA-Y1
SDI-DiA-Y0
SDI-DiA-C9
SDI-DiA-C8
SDI-DiA-C7
SDI-DiA-C6
SDI-DiA-C5
SDI-DiA-C4
SDI-DiA-C3
SDI-DiA-C2
SDI-DiA-C1
SDI-DiA-C0
023
SIGN32114
GND
SDI-B-10bit/20bit
IC2306(2/2)
TC7SZ125FU(TE85R)
C2375
10uF
6.3V
1608
FB2309
IC2303 (2/2)
TC7SH04FU(T5RSOYJF)
FB2305
CORE_GND1
CORE_GND2
CORE_GND3
CORE_GND4
CORE_GND5
CORE_GND6
CORE_GND7
CORE_GND8
CORE_GND9
CORE_GND10
CORE_GND11
CORE_GND12
CORE_GND13
IC2301 (2/2)
TC7SH04FU(T5RSOYJF)
+3.3V_DRV
SDI-B-HD/SD
C2320
4.7uF
B5
C5
D5
E2
E5
E6
E7
F4
F5
F6
F7
G9
J8
020,023
A9
A8
B9
B8
B7
A7
CD-VDD_A
GND
GND GND
C2325
0.047uF
FB2304
1uF
IC2301 (1/2)
TC7SH04FU(T5RSOYJF)
+1.8V-SDI_A
PD_GND1
PD_GND2
PD_GND3
CD_GND1
CD_GND2
CD_GND3
CD_GND4
SDI-A-HD/SD
B10
CP_GND
A10
CP_VDD
020,023
C2312
0.1uF
+1.8V-SDI_A
FB2303
C2318
+2.5V-VCO_A
C2314
1uF
R2313
0
C2359
4.7uF
C2315
1uF
FB2302
GND
GND
+3.3V-SDI_A
E10
C2311 1uF
R2312
0
GND
+3.3V-SDI_A
+3.3V-SDI_A
CD_VDD
GND
G2
IO_GND1
H9
IO_GND2
G1
IO_VDD1
H10
IO_VDD2
SDI-DiA-C4
SDI-DiA-C5
SDI-DiA-C6
SDI-DiA-C7
R2306
2.2k
NM
SDI-DiA-C8
SDI-DiA-C9
SDI-DiA-Y0
SDI-DiA-Y1
4 R2309 10 27M
27M-CLK-SDI
SDI-DiA-Y2
SDI-DiA-Y3
SDI-DiA-Y4
SDI-DiA-Y5
005
SDI-DiA-Y6
SDI-DiA-Y7
SDI-DiA-Y8
SDI-DiA-Y9
IC2304 (1/2)
TC7SZ125FU(TE85R)
C2319
10uF
6.3V
C2355
1uF
C2356
1uF
C2313 4.7uF
C2316
1uF
8
6
4
2
FB2301
SDI-DiA-C0
SDI-DiA-C1
SDI-DiA-C2
SDI-DiA-C3
8
6
4
2
023
8
6
4
2
SDI-A-CLK
8
6
4
2
4 R2308 10 74M
74M-CLK-SDI
8
6
4
2
005
C2317
10uF
6.3V
A5
CORE_VDD1
E1
CORE_VDD2
G10
CORE_VDD3
K8
CORE_VDD4
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
+3.3V-SDI_A
+3.3V-SDI_A
IC2302 (1/2)
TC7SZ125FU(TE85R)
A6
PD_VDD1
B6
PD_VDD2
SDI-A-Y2
SDI-A-Y3
SDI-A-Y4
SDI-A-Y5
SDI-A_out
SDI-A-Y6
SDI-A-Y7
SDI-A-Y8
SDI-A-Y9
RB2302
220
SDI-A-C4
SDI-A-C5
SDI-A-C6
SDI-A-C7
RB2301
220
020
DPR-300 (23/28)
SDI-A-C8
SDI-A-C9
SDI-A-Y0
SDI-A-Y1
DPR-300 (23/28)
(1.833V)
3
4
VDD
5
CE VOUT
ADJ
GND
2
R2304
15k
R2316
15k
1
(1.0V)
R2305
6.8k
C2368
0.1uF
10V
C2369
10uF
6.3V
C2370
10uF
6.3V
R2315
220
Pd=105mW(@150mA)
GND
020
SDI-OUT-RESET
9-36
A
9-36
HSCU-300
RB2310
220
+3.3V-SDI_B
FB2310
+3.3V-SDI_B
C2344
1uF
GND
R2351
10k
C2366
4.7uF GND-VCO_B
B3
A2
A1
B2
B1
C2
C1
C3
D1
D2
F1
F2
H1
H2
J1
J2
K1
K2
J3
K3
SDI-DiB-Y9
SDI-DiB-Y8
SDI-DiB-Y7
SDI-DiB-Y6
SDI-DiB-Y5
SDI-DiB-Y4
SDI-DiB-Y3
SDI-DiB-Y2
SDI-DiB-Y1
SDI-DiB-Y0
SDI-DiB-C9
SDI-DiB-C8
SDI-DiB-C7
SDI-DiB-C6
SDI-DiB-C5
SDI-DiB-C4
SDI-DiB-C3
SDI-DiB-C2
SDI-DiB-C1
SDI-DiB-C0
023
+5V-D
L2301
1uH
+3.3V-SDI_B
IC2310
NJM2871BF33-TE2
(1/10W)
R2375
+5.0V 10
(4.0__5.0V)
1608
dV=1.0V@100mA
=>100mW
C2351
10uF
6.3V
1608
R2374
22k 1
VIN
CTL
VOUT
C2353
1uF
6.3V
C2354
10uF
6.3V
Pd=70mW(@100mA)
GND
+2.5V
+1.8V-SDI_A
CL2306
1.2
IC2312
R1173H001D-T1-F
FB2306
(+2.5V)
+1.8V-SDI_B
C2371
4.7uF
6.3V
4
VDD
5
CE VOUT
ADJ
GND
2
R2349
15k
(1.0V)
R2350
6.8k
C2357
1uF
C2358
1uF
SIGN32140
C2340
4.7uF
E10
C2362
0.1uF
VCO
VCO_VCC
VCO_GND2
VCO_GND1
CP_RES
LF
DIN19
DIN18
DIN17
DIN16
DIN15
DIN14
DIN13
DIN12
DIN11
DIN10
DIN9
DIN8
DIN7
DIN6
DIN5
DIN4
DIN3
DIN2
DIN1
DIN0
IC2309(1/1)
GS1572-IBE3
2
4
6
8
B4
GND-GS_B
NC1
NC2
NC3
NC4
NC5
NC6
GND
A3
F/DE
C4
V/VSYNC
A4
H/HSYNC
K7
K6
K5
K4
J7
J6
J5
J4
H7
H6
H5
RSV11
RSV10
RSV9
RSV8
RSV7
RSV6
RSV5
RSV4
RSV3
RSV2
RSV1
F10
D6
D7
D8
E4
E8
F8
20BIT/10BIT
IOPROC_EN/DIS
ANC_BLANK
JTAG/HOST
DVB_ASI
SD/HD
SMPTE_BYPASS
RESET
CD-VDD_B
R2358 R2359
680
0
R2378
1k
SDI_3.4_OUT(Y)
to MB
002
SDI_3.4_OUT(X)
002
CL2304
0.8
SDI-B-LOCKED
020
1k
1k
47k
47k
R2379
1k
R2369
47k
G4
G7
R2370
47k
H3
R2364
1k
H8
R2365
1k
G5 R2360
R2371
1k
47k
E3
G6
R2366
1k
R2367
DRFF. 100(OHRM)
GND-SDI
+3.3V-SDI_B
G8
SDI-A(3,4)_OUT
R2373
0
GND-GS_B
C2346
0.01uF
NM
R2361
R2362
R2363
R2368
R2372
0
H4
G3
TIM_861
D3
STANDBY
F3
DETECT_TRS
D4
SDO_EN/DIS
PCLK
R2380
1k
R2381
1k
47k
GND
GND-GS_B
C2373
10uF
6.3V
C2341
4.7uF
RSET
from POST FPGA

020,023
SDI-B-HD/SD
023
SDI-B-10bit/20bit
FB2317
C2372
0.1uF
10V
FB2314
+3.3V-SDI_B
J9 R2354
SDOUT_TDO
K10 1k
SDIN_TDI
R2355
CD-VDD_B
J10
1k
C2347
SCLK_TCLK
1uF
K9
C2348 1uF
CS_TMS
R2357
1k GND GND-GS_B
GND-GS_B
R2377
R2376
51
51
C2349 4.7uF
D10
SDO
C2350 4.7uF
C10
SDO
R2382
15k
C2336
1uF
C6
C7
C8
C9
D9
E9
F9
(1.833V)
R2322 2.2k
R2353
2.2k
NM
RB2312
NM 100
CL2302
1.2
3
N_BYP
GND
C2352
0.1uF
2
10V
1
3
5
7
CD-VDD_B
LOCKED
R2352
47
SDI-B-CLK
SIGN32137
B10
CP_GND
A10
CP_VDD
A9
A8
B9
B8
B7
A7
C2345
0.047uF
+1.8V-SDI_B
FB2313
GND
C2334
1uF
GND GND
+1.8V-SDI_B
CORE_GND1
CORE_GND2
CORE_GND3
CORE_GND4
CORE_GND5
CORE_GND6
CORE_GND7
CORE_GND8
CORE_GND9
CORE_GND10
CORE_GND11
CORE_GND12
CORE_GND13
C2342
1uF
+3.3V-SDI_B
FB2312
CD_VDD
X2302
1483.5-1485.0MHz
C2343
1uF
+2.5V-VCO_B
FB2311
C2335
1uF
GND
A5
CORE_VDD1
E1
CORE_VDD2
G10
CORE_VDD3
K8
CORE_VDD4
C2338 1uF
C2332
0.1uF
3
7
NC
VCC
5 CONT
OUT 1
G1 G2 G3 G4
2 4 6 8
+3.3V-SDI_B
+3.3V-SDI_B
C2331
1uF
R2347
0
C2360
4.7uF
C2339
10uF
6.3V
GND
G2
IO_GND1
H9
IO_GND2
G1
IO_VDD1
H10
IO_VDD2
8
6
4
2
SDI-DiB-C0
SDI-DiB-C1
SDI-DiB-C2
SDI-DiB-C3
R2346
0
C2337
10uF
6.3V
PD_GND1
PD_GND2
PD_GND3
CD_GND1
CD_GND2
CD_GND3
CD_GND4
8
6
4
2
SDI-DiB-C4
SDI-DiB-C5
SDI-DiB-C6
SDI-DiB-C7
7
5
3
1
SDI-B-C8
SDI-B-C9
SDI-B-Y0
SDI-B-Y1
8
6
4
2
SDI-DiB-C8
SDI-DiB-C9
SDI-DiB-Y0
SDI-DiB-Y1
7
5
3
1
SDI-B-Y2
SDI-B-Y3
SDI-B-Y4
SDI-B-Y5
8
6
4
2
SDI-DiB-Y2
SDI-DiB-Y3
SDI-DiB-Y4
SDI-DiB-Y5
7
5
3
1
SDI-B-Y6
SDI-B-Y7
SDI-B-Y8
SDI-B-Y9
7
5
3
1
8
6
4
2
SDI-DiB-Y6
SDI-DiB-Y7
SDI-DiB-Y8
SDI-DiB-Y9
R2348
10
NM
C2364
10uF
6.3V
1608
C2333
4.7uF
GND
+2.5V-VCO_B
FB2316
+1.8V-SDI_B
+1.8V-SDI_B
+3.3V-SDI_B
A6
PD_VDD1
B6
PD_VDD2
RB2309
220
SDI-B_out
DPR-300 (23/28)
B5
C5
D5
E2
E5
E6
E7
F4
F5
F6
F7
G9
J8
RB2308
220
SDI-B-C0
SDI-B-C1
SDI-B-C2
SDI-B-C3
RB2307
220
7
5
3
1
RB2306
220
020
SDI-B-C4
SDI-B-C5
SDI-B-C6
SDI-B-C7
DPR-300 (23/28)
GND-GS_B
GND
C2374
10uF
6.3V
R2356
220
(dV=0.7V)
Pd=105mW(@150mA)
GND
DPR-300 (23/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_23
9-37
HSCU-300
9-37
M
DPR-300 (24/28)
HBF-CLK-74M/27M
025
HBF-B/CB4
HBF-B/CB1
HBF-G/Y1
RB2407
220
RB2408
220
RB2409
220
025
025
025
181
182
183
184
185
HBF-C6
HBF-COMPONENT-R
HBF-Y5
HBF-Y8
HBF-R/CR4
HBF-R/CR1
HBF-C4
R/CR9
R/CR8
R/CR7
R/CR6
R/CR5
R/CR4
R/CR3
R/CR2
R/CR1
R/CR0
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
225
HBF-Y9
226
HBF-R/CR5
227
HBF-R/CR2
228
HBF-C5
R24010 230
NM
231
HBF-C7
232
HBF-B/CB5
233
HBF-B/CB2
234
HBF-R/CR9
HBF-R/CR8
HBF-R/CR7
HBF-R/CR6
HBF-R/CR5
HBF-R/CR4
HBF-R/CR3
HBF-R/CR2
HBF-R/CR1
HBF-R/CR0
HBF-F
HBF-V
HBF-H
7
5
3
1
8
6
4
2
261
262
263
265
RB2426
220
266
267
HBF-C8
268
HBF-C9
269
288
R2435
47 293
R2428 0
NM
005,020,022,026
DPR-RESET_3
R2402
47 135
005 74M-CLK-FPGA-ANALOG
005,025
CP-CLK_1
004
187
188
189
190
191
186
R2403 47
BANK1
3.2V
CONFIG_CHAIN
GND
+2.5V
L2401
1uH
+3.2V-24
C2402
10uF
6.3V
IC2400(2/7)
EP1C12F324C8N(300)
CLK0/LVDSCLK1p[J3]
CLK1/LVDSCLK1n[J4]
R2429
220
C2407 1uF
C2413 0.1uF
C2414 0.1uF
C2408 1uF
C2415 0.1uF
C2409 1uF
C2416 0.1uF
C2410 1uF
C2417 0.1uF
C2411 1uF
GND
+3.2V
L2402
1uH
IO209/LVDS16p[F6]
IO211/VREF1B1[H6]
IO212/ASDO[K6]
IO213/LVDS11n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO234/LVDS16n[F7]
ZXCV-SD844-Y6
ZXCV-SD844-Y1
ZXCV-SD844-C1
ZXCV-SD844-C7
ZXCV-SD844-C5
HD-ANA-F
HD-ANA-Y0
HD-ANA-Y2
HD-ANA-Y8
HD-ANA-C1
66
64
63
62
61
60
59
58
57
55
IO34/VREF2B2[A6]
IO32/LVDS33n[A8]
IO31/LVDS35n[A9]
IO30/LVDS38p[A10]
IO28/LVDS42p[A12]
IO27/LVDS45p[A13]
128
127
126
125
124
123
122
121
120
119
118
117
116
115
C2404 1uF
C2420 0.1uF
C2405 1uF
C2421 0.1uF
C2406 1uF
C2422 0.1uF
C2401
10uF
6.3V
FPGA ANALOG
IC2400 (7/7)
IC2400 (6/7)
EP1C12F324C8N(300)EP1C12F324C8N(300)
C2425 0.1uF
C2426 0.1uF
C2403
10uF
6.3V
GND
IO180/LVDS18n[F5]
IO183/PLL1_OUTn[K5]
IO184/LVDS9p[L5]
IO186/LVDS4p[N5]
HD-ANA-V
HD-ANA-Y1
HD-ANA-Y3
HD-ANA-Y9
HD-ANA-C0
HD-ANA-C8
HD-ANA-C9
ZXCV-SD844-H
ZXCV-SD844-F
ZXCV-SD844-Y2
ZXCV-SD844-Y5
ZXCV-SD844-C0
ZXCV-SD844-C9
ZXCV-SD844-C6
HD-ANA-H
HD-ANA-Y4
HD-ANA-Y6
HD-ANA-C2
HD-ANA-C4
HD-ANA-C6
HD-ANA-C7
180
179
178
177
176
175
174
173
172
171
170
169
168
TDI[J17]
TMS[K14]
TCK[K18]
TDO[K13]
DATA0[H7]
DCLK[L1]
291
nCE[J7]
R2409 77
0
nCEO[K2]
NM 76
nCONFIG[J2]
300
nSTATUS[L12]
106
CONF_DONE[K17]
+3.2V-24
136
MSEL0[K3]
292
MSEL1[K7]
007,017,020
IO142/PLL1_OUTp[K4]
IO143/LVDS9n[L4]
IO144/LVDS7n[M4]
IO146[P4]
PWR-NG/OK-STUS
IC2400(5/7)
EP1C12F324C8N(300)
107
247
43
R2408 278
0
NM 290
11
R2407
1k
CONFIG_nCE_3-4
CONFIG_nCONFIG
CONFIG_nSTATUS
CONFIG_CONF_DONE
IO137/VREF0B1[D4]
IO139/LVDS18p[F4]
IO141/LVDS12p[H4]
IO84/LVDS28n[B6]
IO82/LVDS33p[B8]
IO81/LVDS35p[B9]
IO80/LVDS38n[B10]
IO79/LVDS40n[B11]
IO78/LVDS42n[B12]
IO77/LVDS45n[B13]
IO74/LVDS50p[B16]
IO208/LVDS29n[E6]
IO205/VREF1B2[E10]
IO204[E11]
IO203[E13]
287
286 8
285 6
284 4
2
IO233/LVDS25n[F8]
IO232/LVDS37p[F9]
IO231/LVDS46p[F10]
IO230/LVDS49p[F11]
CONFIG_DATA0
CONFIG_DCLK
R2406
10k
C2400
1uF
BANK4
3.2V
C2412 1uF
C2418 0.1uF
C2419 0.1uF
229
VCCA_PLL1[J5]
302
VCCA_PLL2[J12]
2
17
19
34
36
51
53
68
313
319
321
323
5
14
289
294
56
65
254
257
39
48
299
303
22
31
237
240
VCCINT1[B1]
VCCINT2[U1]
VCCINT3[V2]
VCCINT4[V17]
VCCINT5[U18]
VCCINT6[B18]
VCCINT7[A17]
VCCINT8[A2]
VCCINT9[L9]
VCCINT10[H10]
VCCINT11[J9]
VCCINT12[K10]
VCCIO1_1[E1]
VCCIO1_2[P1]
VCCIO1_3[G7]
VCCIO1_4[M7]
VCCIO2_1[A14]
VCCIO2_2[A5]
VCCIO2_3[E12]
VCCIO2_4[E9]
VCCIO3_1[P18]
VCCIO3_2[E18]
VCCIO3_3[M12]
VCCIO3_4[H12]
VCCIO4_1[V5]
VCCIO4_2[V14]
VCCIO4_3[P8]
VCCIO4_4[P11]
GND1[A1]
GND2[C1]
GND3[T1]
GND4[V1]
GND5[V3]
GND6[V16]
GND7[V18]
GND8[T18]
GND9[C18]
GND10[A18]
GND11[A16]
GND12[A3]
GND13[B2]
GND14[U2]
GND15[U17]
GND16[B17]
GND17[H8]
GND18[J8]
GND19[K8]
GND20[L8]
GND21[L10]
GND22[L11]
GND23[K11]
GND24[J11]
GND25[H11]
GND26[H9]
GND27[K9]
GND28[J10]
GNDA_PLL1[K1]
GNDA_PLL2[K12]
GNDG_PLL1[J6]
GNDG_PLL2[J18]
GND
1
3
16
18
20
33
35
37
50
52
54
67
69
84
99
114
309
310
311
312
314
315
316
317
318
320
322
324
10
301
264
44
209
CLK2/LVDSCLK2p[J15]
162
CLK3/LVDSCLK2n[J16]
IO240/LVDS57n[G12]
IO229/LVDS57p[F12]
IO228/LVDS55n[F13]
IO225/LVDS63n[J13]
IO224/LVDS65p[L13]
IO223/LVDS65n[M13]
IO222/LVDS70n[N13]
IO221/LVDS70p[N12]
IO202/VREF0B3[E14]
IO201/LVDS55p[F14]
IO200/LVDS59p[G14]
IO199/LVDS62n[H14]
IO198/VREF1B3[J14]
IO197[L14]
IO168/LVDS52p[D15]
IO165/LVDS58n[G15]
IO164/LVDS62p[H15]
PLL x2
IO162/LVDS64p[L15]
IO160/LVDS69p[N15]
IO123/LVDS52n[D16]
IO121/LVDS54n[F16]
IO120/LVDS58p[G16]
IO119/LVDS61n[H16]
IO116/DQ1R0[M16]
IO115/LVDS69n[N16]
IO114/VREF2B3[P16]
IO113/LVDS73p[R16]
IO112/LVDS75n[T16]
IO73/LVDS51n[C17]
IO72/LVDS51p[D17]
IO70/LVDS56p[F17]
IO68/LVDS61p[H17]
IO67/LVDS66p[L17]
IO65/LVDS71p[N17]
IO64/DQ1R6[P17]
IO63/LVDS74n[R17]
IO62/LVDS75p[T17]
GND
GND
295
IO236/LVDS101p[M8]
296
IO237/LVDS89p[M9]
297
IO238/LVDS80n[M10]
298
IO239/LVDS77n[M11]
HBF-B/CB9
HBF-B/CB8
HBF-B/CB7
HBF-B/CB6
HBF-B/CB5
HBF-B/CB4
HBF-B/CB3
HBF-B/CB2
HBF-B/CB1
HBF-B/CB0
R2436
10k
L2405
10uH
L2403
1uH
270
IO217/LVDS101n[N8]
271
IO218/LVDS89n[N9]
272
IO219/LVDS80p[N10]
273
IO220/LVDS77p[N11]
025
2
4
6
8
2
4
6
8
2
4
6
8
IO91/LVDS19n[F3]
IO92/LVDS15p[G3]
IO93/LVDS13n[H3]
IO94/LVDS10n[L3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
RB2425
220
1
2
3
4
5
6
7
8
IC2400 (3/7)
EP1C12F324C8N(300)
IO25/DQ0R0[D18]
IO24/LVDS56n[F18]
IO22/DQ0R7[H18]
IO21/LVDS66n[L18]
IO20/LVDS68n[M18]
IO19/LVDS71n[N18]
IO18/LVDS74p[R18]
DA-B/B-Y-0
DA-R/R-Y-4
RB2406
220
1
3
5
7
1
3
5
7
1
3
5
7
137
138
139
140
141
142
+1.5V
+3.2V-24
IO189/LVDS97n[P7]
IO190/VREF1B4[P9]
IO191[P10]
IO192[P12]
IO193/VREF0B4[P13]
RB2405
220
B/CB9
B/CB8
B/CB7
B/CB6
B/CB5
B/CB4
B/CB3
B/CB2
B/CB1
B/CB0
HBF-B/CB6
HBF-B/CB3
HBF-B/CB0
HBF-G/Y2
HBF-G/Y0
HBF-G/Y3
+3.2V
BANK3
3.2V
EPR2
GND
R2413
47
NM
RB2428
220
1
3
5
7
277
276
275
274
7
5
3
1
CPU-A1
CPU-A0
005,007,011,017,020,022,025
CPU_I/F
CPU-D4 1
CPU-D5 3
CPU-D6 5
CPU-D7 7
CPU-D0
CPU-D1
CPU-D2
CPU-D3
1
3
5
7
RB2418
220
SC_INT/EXT
SC-LALTR
026
8
6
4
2
RB2423
220
RB2424
220
7
CPU-WR
CS_ANALOG 5
3
CPU-RD
1
2
4
6
8
2
4
6
8
8
6
4
2
COMPOSITE-PAL/NTSC
AO12
AO11
AO10
AO9
AO8
R2424 100 16
ECL
AO7
AO6
R2425 100 18
CS/LD AO5
AO4
"HI":CS I/F
AO3
R2412 10k
AO2
15
SEL
AO1
NM
GND VSS
R242710k
23
24
"LO":LD I/F
R2430 0 NM
R2418 100
12
11
10
9
8
7
6
5
4
3
2
1
RSSI_offset_ADJ
CL247
1.2
CL243
1.2
CL242
1.2
B-GAIN
G-GAIN
R-GAIN
PIX-GAIN
WFM-GAIN
VBS-GAIN
016
027
027
027
028
028
028
FB2402
GND-A
(0-3.2V) R2419 100

[3.2V]
[0-2.5V]or(0-3.2V)
WFM-SEQ_OFF/ON
DA-G/Y-9
ENC_Y4
ENC_Y6
ENC_Y8
ENC_C0
ENC_C2
R2416
2.2k
R2417
2.2k
NM
NM
[0-2.5V]
GND
[5V]
028
ENC-CB_OFF/ON
026
ENCODER
026
ENC-SKIN-GATE
026
ENC-SETUP_OFF/ON
026
ENC-EXT-COLOR-FRAME 026
DA-G/Y-8
DA-G/Y-4
ENC_Y5
ENC_Y7
ENC_Y9
ENC_C1
ENC_C3
R2415
to SC-Comp
13.5M-SC-CLK
026
ENC-SKIN-GATE(Y_LEV) 026
ENC-NTSC/PAL
026
ENCODER
(CXD9184)
DA-G/Y-6
DA-G/Y-2
DA-G/Y-1
ENC_Y0
ENC_Y1
ENC_Y3
ENC_C4
ENC_C6
ENC_C8
GND
ENC-REF-F
to ENCORDER
026
DA-G/Y-7
DA-G/Y-3
DA-G/Y-0
ENC_C5
ENC_C7
ENC_C9
ENC_Y2
ENC-REF-H
026
DA-CLK-74M/54M
027
DA-G/Y
DA-B/B-Y
DA-R/R-Y
027
027
027
DA-G/Y-5
D/A CONVERTER
028
CMP(DA)-SW1
CMP(DA)-SW0
to SC-Comp
026
026
SCCOM
from MB
002 EXTERNAL-REF-SC_in
002 EXTERNAL-REF-SYNC_in
GUARD-GND(REF-SC)
002
from SC-Comp
INT-SC
026
R2421 100 22
EA1
21
EA0
R2422 100
R2423 100 19
CLK
GND-A
GND
from SD BAR-CHARA GEN
SD-BAR-CHARA_CHR
026
SD-BAR-CHARA_BLK
026
R2434 220
167
166
165
164
163
49
47
46
45
42
41
40
38
14
13
R2420 100 20 VCC VDD 17
DI
DO
CL241
1.2
208
207
206
205
204
203
113
112
111
110
109
108
105
104
103
102
101
100
GND
2
4 (3.2V)
6
8
R2433 220
214
213
212
211
210
161
160
159
158
157
156
155
1
2
4
5
9
10
12
13
TC74VHCT08AFT(EKJ)
0
R2414
GND
304
283
282
281
280 CL244
1.2
279
252
251
250
249
248
246
245
244
243
14
VCC
3
1A
1Y
1B
(5V)
6
2Y
2A
2B
8
3Y
3A
3B
11
4Y
4A
4B
GND
IC2401
7 NM
GND
RB2422
220
["DC-DC"at D/A]
C2427
0.1uF
IC2402
AK9813BF-E2
C2424
0.1uF
BANK2
2.5V
4
IC2400
ANALOG
EP1C12
235
236
238
239
241
242
RB2404
220
129
130
131
132
133
134
3
IC2000
POST
EP1C12
R2411 100
HBF-COMPONENT-B
HBF-Y1
HBF-Y4
HBF-Y7
HBF-R/CR3
HBF-R/CR0
HBF-C1
EPCS16
2
IC1700
DEMUX
EP1C20
DA-B/B-Y-1
DA-R/R-Y-3
DA-R/R-Y-7
025
HBF-B/CB9
HBF-B/CB7
HBF-G/Y8
HBF-G/Y7
HBF-G/Y5
HBF-G/Y4
1
IC700
MAP
EP1C20
IO148/VREF2B4[R5]
IO149/LVDS96n[R6]
IO151/LVDS92n[R8]
IO153/LVDS87n[R10]
IO154/LVDS86p[R11]
IO156/LVDS81n[R13]
HBF-G/Y9
HBF-G/Y8
HBF-G/Y7
HBF-G/Y6
HBF-G/Y5
HBF-G/Y4
HBF-G/Y3
HBF-G/Y2
HBF-G/Y1
HBF-G/Y0
192
193
194
195
196
197
198
199
200
201
202
RB2403
220
2
4
6
8
2
4
6
8
2
4
6
8
IC2400(4/7)
EP1C12F324C8N(300)
DA-B/B-Y-3
DA-B/B-Y-6
DA-R/R-Y-0
DA-R/R-Y-6
DA-R/R-Y-9
RB2402
220
1
3
5
7
1
3
5
7
1
3
5
7
IO36/LVDS23n[C2]
IO37/LVDS22n[D2]
IO39/LVDS19p[F2]
IO40/LVDS17n[G2]
IO41/LVDS13p[H2]
IO42/LVDS10p[L2]
IO44/LVDS6n[N2]
IO46/LVDS1p[R2]
IO47/LVDS0p[T2]
DA-B/B-Y-4
DA-B/B-Y-7
DA-B/B-Y-9
DA-R/R-Y-1
DA-R/R-Y-5
DA-R/R-Y-8
RB2401
220
G/Y9
G/Y8
G/Y7
G/Y6
G/Y5
G/Y4
G/Y3
G/Y2
G/Y1
G/Y0
70
71
72
73
74
75
78
79
80
81
82
83
HBF-Y0
HBF-Y3
HBF-Y6
HBF-R/CR8
HBF-R/CR6
HBF-C3
IO48/LVDS102p[U3]
IO49/LVDS100n[U4]
IO53/LVDS93p[U8]
IO54/LVDS91p[U9]
IO55/LVDS88p[U10]
IO57/LVDS84n[U12]
IO61/LVDS76p[U16]
HBF-COMPONENT-G
85
86
87
88
89
90
91
92
93
94
95
96
97
98
025
IC2400 (1/7)
EP1C12F324C8N(300)
IO0[D1]
IO2/LVDS17p[G1]
IO3/DQ0L7[H1]
IO4/nCSO[J1]
IO5/DQ1L0[M1]
IO6/LVDS6p[N1]
IO7/VREF2B1[R1]
DA-B/B-Y-2
DA-B/B-Y-5
DA-B/B-Y-8
DA-R/R-Y-2
HBF-B/CB8
HBF-G/Y9
HBF-G/Y6
4
6
7
8
9
12
13
15
308
307
306
305
HBF-Y2
HBF-R/CR9
HBF-R/CR7
HBF-C0
HBF-C2
IO244/LVDS25p[G8]
IO243/LVDS37n[G9]
IO242/LVDS46n[G10]
IO241/LVDS49n[G11]
HBF-COMPOSITE-Y
HBF-COMPOSITE-Cd
HBF-REF-F
HBF-REF-V
HBF-REF-H
IO8/LVDS102n[V4]
IO9/LVDS98p[V6]
IO11/LVDS93n[V8]
IO12/LVDS91n[V9]
IO13/LVDS88n[V10]
IO14/LVDS85n[V11]
IO15/LVDS84p[V12]
025
025
025
025
025
+5V-D
CL246
1.2
21
23
24
25
26
27
28
29
30
32
HBF(CXD9186)
CL245
1.2
260R2410 100
259
258
256
255
253
7
5
3
1
RB2427
100
+5V-DA
FB2401
ZXCV-SD844-Y3
ZXCV-SD844-Y9
ZXCV-SD844-Y7
ZXCV-SD844-Y0
ZXCV-SD844-C3
ZXCV-SD844-C8
HD-ANA-RES1 1
3
HD-ANA-F
5
HD-ANA-V
7
HD-ANA-H
HD-ANA-Y0 1
HD-ANA-Y1 3
HD-ANA-Y2 5
HD-ANA-Y3 7
HD-ANA-Y4 1
HD-ANA-Y5 3
HD-ANA-Y6 5
HD-ANA-Y7 7
HD-ANA-Y8 1
HD-ANA-Y9 3
HD-ANA-C0 5
HD-ANA-C1 7
HD-ANA-C2 1
HD-ANA-C3 3
HD-ANA-C4 5
HD-ANA-C5 7
HD-ANA-C6 1
HD-ANA-C7 3
HD-ANA-C8 5
HD-ANA-C9 7
from MB(SY)
020
SYSTEM-HD-F
from DAYTONA-MAIN
018,020
DAYTONA-MAIN-Fa
018,020
DAYTONA-MAIN-V
to PROCYON
020
ANA-SKIN-GATE
FB2404
NM
FB2403
C2423
0.1uF
IO134/LVDS28p[C6]
IO133/LVDS30p[C7]
IO132/LVDS34p[C8]
IO131/LVDS36p[C9]
IO130/LVDS39n[C10]
IO129/LVDS41n[C11]
IO126/VREF0B2[C14]
IO124/LVDS50n[C16]
ANALOG-RES1
ANALOG-F
ANALOG-V
ANALOG-H
ANALOG-Y0
ANALOG-Y1
ANALOG-Y2
ANALOG-Y3
ANALOG-Y4
ANALOG-Y5
ANALOG-Y6
ANALOG-Y7
ANALOG-Y8
ANALOG-Y9
ANALOG-C0
ANALOG-C1
ANALOG-C2
ANALOG-C3
ANALOG-C4
ANALOG-C5
ANALOG-C6
ANALOG-C7
ANALOG-C8
ANALOG-C9
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
SKIN GATE
+5V-D
(+3.2V_Digital)--> +3.2V
IO100/LVDS100p[T4]
IO102/LVDS96p[T6]
IO104/LVDS92p[T8]
IO105/LVDS90n[T9]
IO106/LVDS87p[T10]
IO107/LVDS86n[T11]
IO109/LVDS81p[T13]
IO111/LVDS76n[T15]
RB2415
220
143
144
145
146
147
148
149
150
151
152
153
154
RB2414
220
RB2413
220
27M-CLK-FPGA-ANALOG 005,020
HD-ANA-RES1
HD-ANA-Y5
HD-ANA-Y7
HD-ANA-C3
HD-ANA-C5
RB2412
220
ANALOG
from DEMUX FPGA

017,020
DEMUX-SKIN-GATE
017,020
DEMUX-F
RB2421
220
ZXCV-SD844-Y4
ZXCV-SD844-Y8
ZXCV-SD844-C2
ZXCV-SD844-C4
RB2411
220
RB2420
220
224
223
222
221
220
219
218
217
216
215
RB2410
220
from POST FPGA

020
RB2419
220
IO177/LVDS29p[D6]
IO176/LVDS30n[D7]
IO175/LVDS34n[D8]
IO173/LVDS39p[D10]
IO172/LVDS41p[D11]
1
HD ANALOG
RB2416
220
ZXCV_SD844
R2677 0
RB2417
220
from ZXCV
020
ZXCV-SD844-F R2404 220 SD844-F

220 SD844-H
ZXCV-SD844-H R2405
2 SD844-Y4
ZXCV-SD844-Y4 1
4 SD844-Y7
ZXCV-SD844-Y7 3
6 SD844-Y8
ZXCV-SD844-Y8 5
8 SD844-Y0
ZXCV-SD844-Y0 7
2 SD844-Y6
ZXCV-SD844-Y6 1
4 SD844-Y2
ZXCV-SD844-Y2 3
6 SD844-Y3
ZXCV-SD844-Y3 5
8 SD844-Y9
ZXCV-SD844-Y9 7
2 SD844-Y5
ZXCV-SD844-Y5 1
4 SD844-Y1
ZXCV-SD844-Y1 3
6 SD844-C0
ZXCV-SD844-C0 5
8 SD844-C1
ZXCV-SD844-C1 7
2 SD844-C2
ZXCV-SD844-C2 1
4 SD844-C3
ZXCV-SD844-C3 3
6 SD844-C4
ZXCV-SD844-C4 5
8 SD844-C8
ZXCV-SD844-C8 7
2 SD844-C9
ZXCV-SD844-C9 1
4 SD844-C7
ZXCV-SD844-C7 3
6 SD844-C6
ZXCV-SD844-C6 5
8 SD844-C5
ZXCV-SD844-C5 7
ZXCV SD8:4:4
DPR-300 (24/28)
R2439
R2438
47
47
R2437
47
027
027
DPR-300 (24/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_24
9-38
A
9-38
HSCU-300
DPR-300 (25/28)
005,024
DPR-300 (25/28)
CP-CLK_1
CPU_I/F
HBF-Y2
HBF-Y3
HBF-Y4
HBF-Y5
HBF-Y6
HBF-Y7
HBF-Y8
HBF-Y9
RB2501
220
2
4
6
8
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
RB2502
220
RB2503
220
G/Y0
G/Y1
G/Y2
G/Y3
G/Y4
G/Y5
G/Y6
G/Y7
G/Y8
G/Y9
from/to FPGA ANALOG

024
024
024
024
024
024
R2501
100
HBF-REF-F
HBF-REF-V
HBF-REF-H
HBF-F
HBF-V
HBF-H
R2502
100
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
R2520 30
100 31
32
33
34
35
36
C2506
10uF
C2513
10uF
C2514
0.1uF
R2505 47
R2504 220
R2503
100
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
1
3
5
7
C2512
0.1uF
VDD1
VDD2
I_A0
I_A1
I_A2
I_A3
I_A4
I_A5
I_A6
I_A7
I_A8
I_A9
O_A0
O_A1
O_A2
O_A3
O_A4
O_A5
O_A6
O_A7
O_A8
O_A9
NC1
NC2
NC3
NC4
NC5
NC6
I_F
I_V
I_H
O_F
O_V
O_H
VDD3
VDD4
VDD8
VDD7
TOUT
TSMI
TMD2
TMD1
TMD0
TCK1
TCK0
RCLK
GND5
NC18
NC17
NC16
O_C9
O_C8
O_C7
O_C6
O_C5
O_C4
O_C3
O_C2
O_C1
O_C0
I_C9
I_C8
I_C7
I_C6
I_C5
I_C4
I_C3
I_C2
I_C1
I_C0
VDD6
VDD5
IC2501
CXD9186R
O.V.S. FILTER
& MTARIX
(8:4:4->8:8:8)
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
C2510
0.1uF
GND9
GND8
NC28
NC27
TCK
TDO
TMS
TDI
TRST
NC26
NC25
NC24
NC23
NC22
NC21
NC20
NC19
IO_PDA7
IO_PDA6
IO_PDA5
IO_PDA4
IO_PDA3
IO_PDA2
IO_PDA1
IO_PDA0
I_PWR
I_PRD
I_PCS
I_PAD1
I_PAD0
I_PCL
I_SCL
IO_SDA
I_RSTL
GND7
GND6
HBF-Y0
HBF-Y1
C2508
0.1uF
C2504
10uF
C2509
0.1uF
C2505
10uF
7
5
3
1
C2507
10uF
RB2512
10k
C2515
10uF
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
RB2513
100
RB2511
100
from FPGA ANALOG
HBF-CLK-74M/27M 024
R2519
47
R2518
10k
R/CR9
R/CR8
R/CR7
R/CR6
R/CR5
R/CR4
R/CR3
R/CR2
R/CR1
R/CR0
C2516
10uF
C2517
0.1uF
C2518
10uF
C2519
0.1uF
to FPGA ANALOG
024
HBF-COMPONENT-R
024
HBF-COMPONENT-B
024
HBF-COMPONENT-G
7
5
3
1
7
5
3
1
1
3
5
7
8
6
4
2
C2511
0.1uF
005
R2510
100
GND1
GND2
I_B0
I_B1
I_B2
I_B3
I_B4
I_B5
I_B6
I_B7
I_B8
I_B9
O_B0
O_B1
O_B2
O_B3
O_B4
O_B5
O_B6
O_B7
O_B8
O_B9
NC7
NC8
NC9
NC10
NC11
NC12
NC13
NC14
NC15
I_OC_A
I_OC_B
I_OC_C
GND3
GND4
from FPGA ANALOG

024
HBF-COMPOSITE-Y
024
HBF-COMPOSITE-Cd
C2503
47uF
6.3V
DPR-RESET_1
RB2510
220
1
3
5
7
1
3
5
7
1
3
5
7
L2501 C2502
10uH 0.1uF
C2501
0.1uF
CPU-D7
CPU-D6
CPU-D5
CPU-D4
CPU-D3
CPU-D2
CPU-D1
CPU-D0
CPU-WR
CPU-RD
CS_HBF
CPU-A1
CPU-A0
L2502
10uH
RB2508
220
+3.2V
RB2509
220
+2.5V
2
4
6
8
2
4
6
8
2
4
6
8
005,007,011,017,020,022,024
8
6
4
2
8
6
4
2
HBF-C0
HBF-C1
HBF-C2
HBF-C3
HBF-C4
HBF-C5
HBF-C6
HBF-C7
HBF-C8
HBF-C9
2
4
6
8
B/CB0
B/CB1
B/CB2
B/CB3
B/CB4
B/CB5
B/CB6
B/CB7
B/CB8
B/CB9
RB2504
220
RB2506
220
DPR-300 (25/28)
RB2507
220
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_25
9-39
HSCU-300
9-39
E
DPR-300 (26/28)
CHAR-HR
CHAR-VR
+2.5V
R2659
2.2k
R2658
2.2k
8
OSCIN
7
OSCOUT
CHAR-CK
GND
RB2603
220
GND
GND
10
160
159
158
157
7
8
156
5
6
155
3
4
154
1
2
153
RB2615 NM
220
152
151
R2629
1k 150
R2628
149
1k
148
147
146
145
144
143
142
R2624 R2623
R2626
10
10k
0
141
R2625
220
140
139
RB2614
220
138
7
8
R2622
10k R2621 137
5
6
0
136
3
4
135
1
2
134
R2620
10k R2619 133
0 NM 132
131
130
129
128
127
126
7
8
125
5
6
124
3
4
123
1
2
122
RB2613
220
121
DPR-RESET_3
2
4
6
8
PIX-CHARA
R2675
10
+3.2V
5
VDD
16
DATA
VR
17
CMDCT
VG
18
CLK
VB
15
CS
VBLK/BBLK
12
PCL
VC1
11
TEST
BLK1
14
HSYNC VC2/GBLK
13
VSYNC BLK2/RBLK
8
OSCIN
7
OSCOUT
CHAR-CK
GND
10
GND
0V
R2635
10k
R2636
0
5
+
RV2602
1 10k 3
6 -
IC2615 (1/2)
TC7SET00FU(T5RSOJF)
+5V-STR
3 +
R2676
to MB
WFM-STAR-CASE(X)_out 002
GND_(WFM-STAR-CASE) 002
R2686
10k
RV2601
5k
DC(Position)
+5V-D
L2601
10uH
R2639
4.7k
+5V-STR
C2618
47uF
10V
C2617
1uF
R2687
10k
-5V-STR
OUTPUTx40%
R2642
220
GND
+5V-STR
R2685
10k
-5V-STR
R2690
10k
NM
GND
R2684
10k
TP262
R2688
680
R2689
R2683
10k
R2682
10k
IC2603(2/2)
TC7SET00FU(T5RSOJF)
R2638
3.3k
from ANALOG FPGA

024 ENC-SKIN-GATE(Y_LEV)
ENC-SKIN-GATE
024
STAIR STEP
C2619
1uF
16V
C2621
1uF
16V
C2620
47uF
L2602 10V
10uH
GND
GND
V+
V-
C2609
0.1uF
16V
GND2
GND3
EXT_CF_IN
SMC
SIN
SOT
SCK
AMC
WFM_OE
PIX_OE
GND4
VBS0
VBS1
VBS2
VBS3
VBS4
VBS5
VBS6
VBS7
VBS8
VBS9
VBS10
VBS11
GND5
CK27M_O1
WFM0
WFM1
WFM2
WFM3
WFM4
WFM5
WFM6
WFM7
WFM8
WFM9
WFM10
WFM11
CK27M_O2
GND6
GND7
IC2602
CXD9184R
Composite
-Encoder
C2615
0.1uF
16V
IC2604 (3/3)
NJM4580V(TE2)
C2614
10uF
6.3V
RB2612
47
R2681
100
R2640 33k R2691

100
R2641 33k
LEVEL(Interval)
R2637
10k
40%
+0.8V
0V -0.8V
C2608
10uF
6.3V
41
42
43
44
45
46
47
48
R2613 R2611 NM
49
10k
R2612 NM
0
50
10k
0
51
R2614
52
VBS0
53
VBS1
54
VBS2
55
VBS3
56
VBS4
57
VBS5
58
VBS6
59
VBS7
60
VBS8
61
VBS9
62
VBS10
63
VBS11
64
R2615
22 NM
65
66
WFM0
67
WFM1
68
WFM2
69
WFM3
70
WFM4
71
WFM5
72
WFM6
73
WFM7
74
WFM8
75
WFM9
76
WFM10
77
WFM11
78
R2616
79
22
NM
80
120
119
118
117
116
115
114
NM
113
112
111
110
109
108
107
106
105
104
103
C2613102
101
0.1uF 100
16V 99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
R2634
10k
PIX_BLK
PIX_CHR
BAR_BLK
BAR_CHR
CHAR-VR
CHAR-HR
CHAR-CK
TEB
VDD7
OUT_P3
OUT_P2
OUT_P1
OUT_P0
IN_P1
IN_P0
SDA
SCL
ID_A1
ID_A0
BAR_ON
SETUP_ON
NP_SEL
EXT_MODE
PIX_BLK
PIX_CHR
BAR_BLK
BAR_CHR
CHAR_V
CHAR_H
CHAR_CK
ASPE_FLAG
ASPE_MK
ZGATE_IN2
ZGATE_IN1
GND11
GND10
8
6
4
2
GND
R2633
10k
VCC
GND
2
1
2
1
5
VCC
GND
IC2615 (2/2) GND

TC7SET00FU(T5RSOJF)
IC2604 (2/3)
NJM4580V(TE2)
TC7SET00FU(T5RSOJF)
IC2603 (1/2)
C2616
0.1uF 16V
40%
4.8 +0.4V
-2.4V
IC2604 (1/3)
NJM4580V(TE2)
005
IIC2-BUS
from ANALOG FPGA
024
ENC-CB_OFF/ON
024
ENC-SETUP_OFF/ON
024
ENC-NTSC/PAL
GND13
GND12
EXT_TG_EN
SYNC_TG_IN
BLKG_TG_IN
BURST_TG_IN
VDD8
FD_OUT
HD_OUT
TOUT
DC_TEST_EN
7
5
3
1
0V
SDA
SCL
IC2612
UPD6467GR-525-E2
R2631
0
R2627
10k
3
6
1
2
4
9
20
19
CHAR-HR
CHAR-VR
R2632
10
C2649
0.1uF
16V
GND
005,020,022,024,026
+5V-D
R2630
10k
IC2601
UPD6467GR-525-E2
1
3
5
7
CG-CS0(BAR)
CG-CS1(PIX)
C2605
10uF
6.3V
C2604
0.1uF
16V
C2602 C2603
47uF 0.1uF
16V
6.3V
GND
022
022
FB2602
FB2601
-5V-STR
-5V-D
C2611
0.1uF
16V
R2617 220
R2679
10
ENCODER-VBS_out
028
ENCODER-WFM_out
028
ENCODER-PIX_out
028
C2610
10uF
6.3V
PIX11
PIX10
PIX9
PIX8
PIX7
PIX6
PIX5
PIX4
PIX3
PIX2
PIX1
PIX0
+3.2V
10uF
6.3V
2
IC2614(1/2)
TC7SZ08FU(TE85R) 1
BAR_CHR
BAR_BLK
PIX_CHR
PIX_BLK
C2612
R2657
10
2
4
6
8
RB2611 220
RB2610 220
7
8
5
6
3
4
1
2
R2678
10
1
3
5
7
SC-CONT-DATA3
SC-CONT-DATA2
SC-CONT-DATA1
SC-CONT-DATA0
RB2604
220
16
DATA
VR
17
CMDCT
VG
18
CLK
VB
15
CS
VBLK/BBLK
12
PCL
VC1
11
TEST
BLK1
14
HSYNC VC2/GBLK
13
VSYNC BLK2/RBLK
8
6
4
2
2
IC2613(1/2)
TC7SZ08FU(TE85R) 1
0.1uF GND
7
5
3
1
CHARA-CK_in
R2656
10
3
6
1
2
4
9
20
19
R2618
100
CHARA-DATA_in
from MB +3.2V
002
R2680
10k
C2601
5
VDD
NM
GND
R2601
10
ENCODER
ENC-SC-DATA7
ENC-SC-DATA6
ENC-SC-DATA5
ENC-SC-DATA4
ENC-SC-DATA3
ENC-SC-DATA2
ENC-SC-DATA1
ENC-SC-DATA0
SC-CONT-DATA7
SC-CONT-DATA6
SC-CONT-DATA5
SC-CONT-DATA4
RB2602
220
1
2
3
4
5
6
7
8
024
+3.2V
1
2
3
4
5
6
7
8
9
10
11
12
R2602
100
13
47
R2603
R2604
14
R2605 220
ENC_Y0
2.2k
15
R2606 220
ENC_Y1
16
7
8 RB2605 ENC_Y2
220
17
5
6
ENC_Y3
18
3
4
ENC_Y4
19 C2606
1
2
ENC_Y5
20 0.1uF 16V
21
22 C2607 10uF 7
8 RB2606
ENC_Y6
6.3V
220
23
5
6
ENC_Y7
24
3
4
ENC_Y8
25
1
2
ENC_Y9
26
R2607
ENC_C0
220
R2608 220
27
ENC_C1
28
7
8 RB2607
ENC_C2
220
29
5
6
ENC_C3
30
3
4
ENC_C4
31
1
2
ENC_C5
32
7
8 RB2608
ENC_C6
220
33
5
6
ENC_C7
34
3
4
ENC_C8
35
1
2
ENC_C9
36
7
8 RB2609
220
37
5
6
38 R2610 R2609 NM
3
4
0
10k
39
1
2
40
from MB
002
BAR-CHARA
RB2601
22k
+2.5V
GND
005,020,022,024,026
+3.2V
C2653
0.1uF
from ANALOG FPGA

024 ENC-EXT-COLOR-FRAME
024
SC-LALTR
ENC-REF-F
024
ENC-REF-H
024
27M-CLK-ENCODER
DPR-RESET_3
VDD1
R_IN0
R_IN1
R_IN2
R_IN3
R_IN4
R_IN5
R_IN6
R_IN7
R_IN8
R_IN9
RESET
CK27M
G_IN0
G_IN1
G_IN2
G_IN3
G_IN4
G_IN5
VDD2
GND1
G_IN6
G_IN7
G_IN8
G_IN9
B_IN0
B_IN1
B_IN2
B_IN3
B_IN4
B_IN5
B_IN6
B_IN7
B_IN8
B_IN9
HD_IN
FD_IN
EXT_LALT_EN
LALT_IN
VDD3
5
VCC
GND
C2652
0.1uF
VCC
GND
005,026
VDD6
STAIR1
STAIR0
S_SYNC_OUT
S_SYNC_IN
ADV_SYNC_OUT
SYNC_OUT
SC_WAVE7
SC_WAVE6
SC_WAVE5
SC_WAVE4
SC_WAVE3
SC_WAVE2
SC_WAVE1
SC_WAVE0
SC_FCNT7
SC_FCNT6
SC_FCNT5
SC_FCNT4
GND9
VDD5
SC_FCNT3
SC_FCNT2
SC_FCNT1
SC_FCNT0
EXT_REF_EN
GND8
PIX11
PIX10
PIX9
PIX8
PIX7
PIX6
PIX5
PIX4
PIX3
PIX2
PIX1
PIX0
VDD4
+2.5V
2
4
6
8
+2.5V
IC2613 (2/2)
IC2614 (2/2)
1
3
5
7
to ANALOG FPGA
SD-BAR-CHARA_CHR
024
SD-BAR-CHARA_BLK
024
to ZXCV_CG +2.5V
022
022
CG-CLK
CG-DATA
DPR-300 (26/28)
+5V-S
2.2k
R2648
0
C2628 R2650
0.1uF 22k
16V
L2605
4.7uH
C2631
22pF
27MHz-SC-Fil
for SC-D/A
INT-SC
R2653
470
R2654
100k
to ANALOG FPGA
024
from ANALOG FPGA
024
SCCOM
024
SC_INT/EXT
GND-S
R2668
330
3
+
R2669
1.5k
2 -
C2635
0.047uF
FILM
C2636
0.001uF
+5V-S
GND-S
C2651
10uF
6.3V
VCC
IC2606 (2/2)
TC7SH04FU(T5RSOYJF) GND
IC2608(2/3)
TLC272CPSR
+
GND-S
6 -
7
R2665
10k
C2644
0.1uF
16V
R2672
100
3.2->5V
SC-CONT-DATA0
SC-CONT-DATA1
SC-CONT-DATA2
SC-CONT-DATA3
SC-CONT-DATA4
SC-CONT-DATA5
SC-CONT-DATA6
SC-CONT-DATA7
C2647
10uF
6.3V
C2645
0.1uF
16V
R2673
47
18
17
21
25
24
26
27
15
14
13
29
12
30
VRT
2.6V
VRTS
VIN
VRBS
0.5V
VRB
VREF
CCP
PW
SYNC
SEL
CLE
CLK
OE
D7
D6
D5
D4
D3
D2
D1
D0
GND
+3.2V
8
7
6
5
4
3
2
1
C2648
0.1uF
GND
16V
IC2611
TC74LCX574FT(EKJ)
R2644
100
GND
GND
RB2618
100k
RB2619
100k
+3.2V
R2645
0.22
VCC IC2609 (2/2)

GND TC7SET00FU(T5RSOJF)
GND-S
3225
NM
GND
GND-S
024
Drv:+3.2V
GND-S
-5V-S
2
1
C2643
0.1uF
16V
IC2609 (1/2)
TC7SET00FU(T5RSOJF)
+5V-S
C2634
0.1uF
16V
L2611
10uH
-5V
R2671
100
C2633
10uF
6.3V
C2650
10uF
6.3V
C2640
10uF -5V-S
6.3V
+5V-S
GND-S
L2612
10uH
L2608
10uH
C2639
0.1uF
16V
+3.2V
R2670
22k
L2610
10uH
R2674
100
GND-S
GND
+5V
C2646
0.1uF
16V
C2641 C2642
10uF
0.1uF
6.3V
16V
19
18
17
16
15
14
13
12
R2655
C2632
220
0.001uF 2
4
GND-S
VDD
IC2608(3/3)
GND TLC272CPSR
2
3
4
5
6
7
8
9
11
1
R2646
470 R2647
R2651
1k
C2629
47pF
GND-S
20
VCC
D0
Q0
D1
Q1
D2
Q2
D3
Q3
D4
Q4
D5
Q5
Q6
D6
Q7
D7
CK
OE
GND
10
R2649
33k
R2652
470
TP261
IC2606 (1/2)
TC7SH04FU(T5RSOYJF)
AVDD1
AVDD2
AVDD3
DVDD1
DVDD2
GND-S
C2630
10pF
2
4
6
8
2
4
6
8
R2643
100
24
23
22
21
20
19
18
17
16
15
14
13
1
3
5
7
1
3
5
7
10V
GND-S
DVDD2
DVDD1
AVDD3
I0
IO
AVDD2
AVDD1
VG
VREF
IREF
AVSS
DVSS2
IC2610
CXD1176Q-T4
10uH
28
DVSS1
31
DVSS2
RB2617
220
C2622
0.1uF
D0
D1
D2
D3
D4
D5
D6
D7
BLK
DVSS1
VB
CLK
+5V-S L2609
L2607
10uH
C2638
0.1uF
16V
16
19
20
10
11
1
2
3
4
5
6
7
8
9
10
11
12
C2637
10uF
6.3V
INT-SC
C2625
C2623 C2624 0.1uF
0.1uF 10uF
6.3V 16V
16V
+5V-S
L2606
10uH
IC2608(1/3)
TLC272CPSR
SC_Compare
22
AVSS1
23
AVSS2
RB2616
220
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
16V
C2626 C2627
0.1uF 10uF
ENC-SC-DATA0
ENC-SC-DATA1
ENC-SC-DATA2
ENC-SC-DATA3
ENC-SC-DATA4
ENC-SC-DATA5
ENC-SC-DATA6
ENC-SC-DATA7
L2604
10uH
IC2605
CXD1171M-TH
L2603
10uH
DPR-300 (26/28)
13.5M-SC-CLK
Drv:+3.2V
005,026 27M-CLK-ENCODER
BOARD NO. 1-879-649-11

HDCU-300_DPR-300_011_26
9-40
A
9-40
HSCU-300
DPR-300 (27/28)
DPR-300 (27/28)
+5V-DA
L2701
10uH
L2704
10uH
+5V-D
+5V-DRV_1
C2706
10uF
C2770
0.1uF
10V B
1
ADJ
GND
(1.0V)
2
(R1)
(PD=dVxi=1.8x0.02=0.036W)
R2753
15k
C2779
10uF
6.3V
R2757
0
DA-R/R-Y-3
DA-R/R-Y-4
DA-R/R-Y-5
DA-R/R-Y-6
1
3
RB2702
5
220
7
DA-R/R-Y-7
DA-R/R-Y-8
DA-R/R-Y-9
3.2V = 1.0+(0.8uA+1/R1)*R2
=> = 1.0+(0.8uA+1/15k)*33.1k =3.233V GND-A
from ANALOG FPGA
024
DA-R/R-Y
2
4
6
8
1
2
3
4
5
6
7
8
2
4
6
8
1
3
5
7
2
4
6
8
D3
D4
D5
D6
D7
D8
D9
NC1
RB2703
220
IC2703
CXD2315Q-T4
from ANALOG FPGA

DA-CLK-74M/54M
024
24
23
22
21
20
19
18
17
R2714
330
R2744
150
C2724
0.1uF
R2721
2.2k
C2727
0.1uF
R2722
1k
R2759
220
R2711
3.3k
C2748
0.1uF
FB2703
C2749
10uF
+3.2V-DA
C2733
0.1uF
R-GAIN
R2738
R2795
R2739
R2761
680
R2782
680
C2773
0.1uF
GND
R2780
150
R2746
R2796
R2732
100 2 0:
100 1
10010 1:
SW1
(URA)
R2758
15 15k
L2716
10uH
C2755
10uF
L2702
10uH
C2704
0.1uF
R2702
100
+5V-D
2
1
IC2702
TC7SET08FU(T5RSOJF)
DA-G/Y-0
DA-G/Y-1
DA-G/Y-2
R2706
100
GND-A
-5V-DRV_1
gain:x2.722
R2783
100
NM
PbPr
PbPr
(PAL/HD) (NTSC)
1
1
0
1
RGB
0
1
SW0
SW1
DA-G/Y-3
DA-G/Y-4
DA-G/Y-5
DA-G/Y-6
C2702
0.1uF
GND
3V->5V Level Shift
from ANALOG FPGA

024
DA-G/Y-7
DA-G/Y-8
DA-G/Y-9
DA-G/Y
1
3
5
7
RB2704
220
2
4
6
8
1
3
RB2705
220 5
7
1
2
3
4
5
6
7
8
2
4
6
8
D3
D4
D5
D6
D7
D8
D9
NC1
54MHz-Trap &
74MHz-D/A-Post-Fil
C2722
22uF
C2719
0.1uF
24
IO
23
IO
22
VG
21
AVDD2
20
AVDD1
19
VREF
18
SREF
17
IREF
IC2704
CXD2315Q-T4
R2716
330
C2737
10pF
C2725
0.1uF
R2742
150
C2728
0.1uF
R2776
10k
R2710
100
R2747
100
L2708
1uH
C2746
12pF
R2765
680
R2752
220
R2760
150
R2799
0
R2724
3.3k
C2731
0.1uF
R2791
220
3
+
X2
R2794
220
1
R2784
680
GND-A
GND-A
C2768
6pF
R2777
680
to MB
G/Y(X)_out
002
GUARD GND to MB CN
4 -
R2781
150 C2769
NM 1pF GND-A
V+
V-
R2725
2.2k
R2730
10k
GND-A
R2712
3.3k
C2756
0.1uF
IC2708 (2/2)
AD8014ARTZ-REEL7
C2757
10uF
NM
R2708
47
C2734
0.1uF
C2712 C2716
0.1uF 0.1uF
GND
TP2703
Y/G OUT
C2741
3pF
C2742
5pF
R2723
1k
GND-A
C2763
0.1uF
R2775
1.5k
FB2704
024
L2714 C2762
10uF
10uH
C2711
0.1uF
9
10
11
12
13
14
15
16
RB2706
220
IC2708(1/2)
AD8014ARTZ-REEL7
+5V-DRV_1
C2707
10uF
GND
2
4
6
8
1
3
5
7
L2705
10uH
+5V-D
32
31
30
29
28
27
26
25
3V->5V Level Shift
from ANALOG FPGA

CMP(DA)-SW1
024
E271 E272
C2754
0.1uF
C2701
0.1uF
GND
R2704
10k
C2767
NM 1pF GND-A
IC2707 (1/2)
AD8014ARTZ-REEL7
D2
D1
D0
NC5
DVDD2
DVSS2
NC4
AVSS
IC2701
TC7SET08FU(T5RSOJF)
GND-A
+5V-DA
R2705
100
CLK
BLK
CE
NC2
DVDD1
VB
DVSS1
NC3
GND-A
C2766
6pF
R2774
680
+5V-D
2
1
to MB
R/R-Y(X)_out
002
GUARD GND to MB CN
IC2706 (2/3)
TC74VHC4053AFT(EK)
L2710
1uH
R2762 100 5
R2763 100 3
R2764 100 9
from ANALOG FPGA

CMP(DA)-SW0
024
X2
R2793
220
IC2706 (3/3)
TC74VHC4053AFT(EK)
R2703
10k
R-Y/R OUT
R2789
220
16
R2737
100 12 0:VDD
14 15k
100 13
100 11 1:
6
SW0
INH
VSS VEE
8 7
C2774
10uF
R2701
100
TP2702
4 -
IC2706 (1/3)
TC74VHC4053AFT(EK)
R2729
2.2k
C2710 C2715
0.1uF 0.1uF
R2748
100
R2750
220
C2745
12pF
GND-A
C2730
0.1uF
R2773
22k
R2740
100
IC2707 (2/2)
AD8014ARTZ-REEL7
GND-A
C2761
0.1uF
V+
V-
L2707
1uH
C2736
10pF
NM
R2707
47
GND
024
C2739
3pF
C2740
5pF
R2720
220
IO
IO
VG
AVDD2
AVDD1
VREF
SREF
IREF
R2772
22k
54MHz-Trap &
74MHz-D/A-Post-Fil
C2721
22uF
C2718
0.1uF
GND
DA-R/R-Y-0
DA-R/R-Y-1
DA-R/R-Y-2
RB2701
220
32
31
30
29
28
27
26
25
FB2706
R2719
100
C2778
0.1uF B
10V
1
3
5
7
D2
D1
D0
NC5
DVDD2
DVSS2
NC4
AVSS
C2777
10uF
6.3V
1608
R2717
33k
(R2)
+3.2V-DA
CLK
BLK
CE
NC2
DVDD1
VB
DVSS1
NC3
R2715
22k
4
3
VDD
5
CE VOUT
+3.2V-DA
CL2701
1.2
(3.233V)
9
10
11
12
13
14
15
16
IC2711
R1173H001D-T1-F
+5V-DA
L2713 C2760
10uF
10uH
C2709
0.1uF
C2703
0.1uF
G-GAIN
GND
L2717
10uH
Vfs=1.667V
Vref=1.773V
Vfs=Vrefx16x(330//470)/3.3k
=Vrefx0.94
-5V-DRV_1
+5V-DA
+5V-D
L2703
10uH
+5V-DRV_1
C2708
10uF
C2713
0.1uF
RB2707
220
2
4
6
8
DA-B/B-Y-7
DA-B/B-Y-8
DA-B/B-Y-9
from ANALOG FPGA

024
DA-B/B-Y
1
3
5
7
1
2
3
4
5
6
7
8
2
4
6
8
D3
D4
D5
D6
D7
D8
D9
NC1
IC2705
CXD2315Q-T4
IO
IO
VG
AVDD2
AVDD1
VREF
SREF
IREF
24
23
22
21
20
19
18
17
R2718
330
C2738
10pF
C2726
0.1uF
R2727
2.2k
R2728
1k
GND-A
TP2701
B-Y/B OUT
C2750
0.1uF
R2713
3.3k
R2797
R2798
R2745
C2751
10uF
C2735
0.1uF
B-GAIN
GND
(-05)
Vfs
Vref
R2756
680
IC2709 (1/3)
TC74VHC4053AFT(EK)
R2731
2.2k
C2714 C2717
0.1uF 0.1uF
R2787
220
R/B
PAL
NTSC
1.69V
1.80V
1.30V
1.38V
1.85V
1.97V
X2
R2788
220
to MB
B/B-Y(X)_out
002
GUARD GND to MB CN
4 R2755
220
NM
R2709
47
R2749
100
R2751
220
FB2705
GND
R2770
22k
R2754
100
L2709
1uH
C2747
12pF
GND-A
C2732
0.1uF
C2729
0.1uF
R2743
150
9
10
11
12
13
14
15
16
RB2709
220
024
IC2710 (2/2)
AD8014ARTZ-REEL7
1
3
RB2708
220 5
7
C2743
3pF
C2744
5pF
R2726
220
32
31
30
29
28
27
26
25
DA-B/B-Y-3
DA-B/B-Y-4
DA-B/B-Y-5
DA-B/B-Y-6
GND
C2759
0.1uF
V+
V-
R2769
22k
54MHz-Trap &
74MHz-D/A-Post-Fil
C2723
22uF
C2720
0.1uF
D2
D1
D0
NC5
DVDD2
DVSS2
NC4
AVSS
2
4
6
8
CLK
BLK
CE
NC2
DVDD1
VB
DVSS1
NC3
DA-B/B-Y-0
DA-B/B-Y-1
DA-B/B-Y-2
1
3
5
7
L2712 C2758
10uF
10uH
C2705
0.1uF
L2706
10uH
R2779
680
R2771
680
GND-A
GND-A
C2764
6pF
R2778
150
C2765
NM 1pF
16
R2735
10012 0:VDD
14 15k
10013
10011 1:
6
SW0
INH
VSS VEE
8 7
GND-A
IC2710(1/2)
AD8014ARTZ-REEL7
+5V-DA
(500mA)
IC2709 (2/3)
TC74VHC4053AFT(EK)
+3.2V-DA
L2718
1uH
C2775
0.1uF
C2776
10uF
R2741
R2733
R2736
100 2 0:
100 1
10010 1:
SW1
+5V-DRV_1
FB2701
FB2702
R2734
15 15k
C2752
0.1uF
C2753
10uF
-5V-DA
L2715
10uH
C2771 10uF
6.3V
C2772 10uF
6.3V
GND-A
-5V-DRV_1
-5V-DRV_1
IC2709 (3/3)
TC74VHC4053AFT(EK)
R2766 100 5
R2767 100 3
R2768 100 9
R2785
100
NM
DPR-300 (27/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_27
9-41
HSCU-300
9-41
E
DPR-300 (28/28)
DPR-300 (28/28)
+5V-DA
+3.2V
(+3.2V_Digital)-->
+5V-DA
+5V-DRV_2
FB2801
IC2802
TC7SET08FU(T5RSOJF)
R2810
100
2
1
C2804
0.1uF
10V
3
GND
PS-EN-n
026
(NG:3.9V)
Q2804
DTC144EE-TL
R2817
68k
1
ADJ (1.0V)
GND
2
C2864
4.7uF
6.3V
C2861
47uF
10V
3225
IC2803 (3/3) V+
NJM062V(TE2) VIC2803 (2/3)
NJM062V(TE2)
C2806
0.1uF
16V
C2862
47uF
10V
3225
C2870
0.1uF
16V
R2844
6.8k
GND-A
- 2
- 6
R2889
47k
C2869
1uF
6.3V
IC2803(1/3)
NJM062V(TE2)
Q2805
2SC4672-T100-Q
-5.5V_DA
PIX11
PIX10
PIX9
PIX8
PIX7
PIX6
PIX5
PIX4
PIX3
PIX2
PIX1
PIX0
GND-A
C2875
47uF
10V
3225
C2872
0.1uF
16V
FB2808
(-5.096V)
CL2802
1.2
-5V-DA
-5V-DA
220
RB2804
1
2
3
4
5
6
7
8
1
2
4
220 3
RB2805 5
6
7
8
1
2
RB2806
3
4
220
5
6
7
8
ENCODER-PIX_out
1
2
3
4
5
6
7
8
9
10
11
12
13
14
VIN
SW
C2867
220pF
3
SHDN
NFB
GND
2 C2865
1uF
25V
3216
C2866
D2802
RB160M-60TR
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
NC1
NC2
CLK
DVDD
DGND
MODE
AVDD
COMP2
IOUT1
IOUT2
AGND
COMP1
BIASJ
EXTIO
EXTLO
SLEEP
R2815
2.2
3225
L2817
10uH
470pF
R2876
33k
C2868
0.1uF
16V
R2824
100
-5.5V_DA
Q2802
2SC4617TL-QR
C2802
0.1uF
RB2807
220
1
2
3
4
5
6
7
8
1
2
3
4
RB2808
6
220 5
7
8
1
2
3
4
5
6
7
8
RB2809
220
ENCODER-WFM_out
1
2
3
4
5
6
7
8
9
10
11
12
13
14
IC2801 (2/2)
TC7SET08FU(T5RSOJF)
VCC
GND
GND
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
NC1
NC2
CLK
DVDD
DGND
MODE
AVDD
COMP2
IOUT1
IOUT2
AGND
COMP1
BIASJ
EXTIO
EXTLO
SLEEP
-:NPN
X2
R2880
220
R2882
220
to MB
PIX(X)_out
4 -
R2850
330
R2874
680
R2856 R2857
1k
470
R2871 C2854
10pF
150
C2843
10uF
L2814
10uH
FB2804
GND-A
GND-A
R2866
680
C2842
0.1uF
002
GND-A
PIX
GND-A
C2855
8pF
-5V-DRV_2
IC2809(1/2)
AD8014ARTZ-REEL7
+5V-DA
L2803
10uH
L2806
10uH
C2812 C2821
28
0.1uF
10uF
27
6.3V 10V
26
25
GND
24
C2817 0.1uF
23
R2839
22
330
21 R2827
150
20
C2818 0.1uF
19
R2842
18 R2832
3.3k
680
R2847 100
17
R2836
16
15k
15
IC2810 (2/2)
AD8014ARTZ-REEL7
C2824 C2827
0.1uF
10uF
6.3V 10V
R2867
680
C2835
5pF
C2836
10pF
L2809
4.7uH
C2839
47pF
C2830
47pF
R2888 0
R2868
10k
R2858
100
+
R2851
330
GND
TP2803
WFM
R2872
150
GND-A
PNP
R2808
22k
+:PNP
+
+2.5V
GND
R2885
to MB
WFM(X)_out
GND-A
002
WFM
GND-A
C2856
10pF
C2857
8pF
L2815
10uH
-5V-DRV_2
IC2810(1/2)
AD8014ARTZ-REEL7
R2833
3.3k
X2
R2881
220 R2883
220
1
R2875
680
C2845
10uF
GND-A
GND-A
4 R2860 R2859 R2869

1k
680
470
C2844
0.1uF
GND-A
C2851
0.1uF
V+
V-
FB2805
NM
C2850
10uF
L2812
10uH
100%
GND
Q2803
2SA1774TL-QR
-5V-D
PIX
1300mV(NTSC)
1275mV(PAL)
714mV(NTSC)
700mV(PAL)
0mV
SEQ
6 4 5
+
Q2801
2SA1774TL-QR
R2803
10
C2801
0.1uF
TP2802
3
+
C2829 GND-A
47pF
GND-A
C2809
0.1uF
R2806
10k
R2805
47k
+5V-D
R2865
10k
R2855
100
R2887 0
L2808
4.7uH
C2838
47pF
C2849
0.1uF
V+
V-
+5V-DRV_2
R2818
680k
-286mV(NTSC)
-300mV(PAL)
-
3 1 2
PNP
NPN
SEQ
C2803
0.1uF
C2848
10uF
R2831
3.3k
R2821
47k
WFM-GAIN
024
GND
R2804
33k
R2864
680
C2833
5pF
C2834
10pF
IC2807
THS5661AIPWR
R2809
10k
IC2801(1/2)
TC7SET08FU(T5RSOJF)
-5V-DRV_2
(+3.2V_Digital)-->
(-5.5285V)
R2807
22k
C2808
0.1uF
+3.2V
C2871
47uF GND-A
10V
FB2806
WFM11
WFM10
WFM9
WFM8
WFM7
WFM6
WFM5
WFM4
WFM3
WFM2
WFM1
WFM0
R2802
10
2
1
C2853
8pF
GND
026
R2801
100
VBS
IC2809 (2/2)
L2811
10uH
C2823 C2826
0.1uF
10uF
6.3V 10V
GND
R2877
10k
+5V-D
from ANALOG FPGA +3.2V

WFM-SEQ_OFF/ON
024
GND-A
GND-A
R2870
150
L2813
10uH
C2841
10uF
GND-A
GND-A
C2852
10pF
+5V-DRV_2 AD8014ARTZ-REEL7
28
27
26
25
GND
24
C2815 0.1uF
23
R2838
22
330
21 R2826
150
20
C2816 0.1uF
19
R2841
18 R2830
680
3.3k
R2845 100
17
R2835
16
15k
15
R2816
680k
Vo-1.255 = R1(1.255/R2 + 4x10**(-6))

= 33k(1.255/10k+4u)
= 33k(0.1295x10**(-3))
=4.2735
Vo = 4.2735+1.255
= 5.5285V
R2863
680
C2840
0.1uF
L2805
10uH
C2811 C2820
0.1uF
10uF
6.3V 10V
R2820
47k
(-1.255V)
5
R2873
680
R2853 R2854
1k
470
002
+5V-DA
L2802
10uH
IC2806
THS5661AIPWR
PIX-GAIN
024
L2816
IC2811
LT1931ES5#TR 10uH
C2860 R2811
10uF 22k
10V
3216
to MB
VBS(X)_out
IC2808(1/2)
AD8014ARTZ-REEL7
NM
0.5A/13.2V
THP282
R2849
330
GND-A
R2879
220 R2884
220
4 -
FB2803
GND
R2823
100
026
+5.5V
-5V-DRV_2
-5V-DA
X2
(+3.2V_Digital)-->
C2828
47pF
VBS
GND-A
C2859 10uF
6.3V
C2807
0.1uF
C2874
47uF
10V
3225
R2878
47k
R2813
220
D2801
UDZSUSTE-174.7B
R2886 0
L2807
4.7uH
C2837
47pF
TP2801
V+
V-
R2862
10k
R2852
100
R2829
3.3k
+3.2V
C2873
10uF
6.3V
1608
R2861
680
FB2802
GND-A
C2847
0.1uF
R2848
68k
R2846
1.5k
C2863100pF
10MHz-LPF
C2831
5pF
C2832
10pF
NM
R2814
680k
+5V-DA
C2822 C2825
0.1uF
10uF
6.3V 10V
GND
C2805
0.1uF
16V
4
3
VDD
5
CE VOUT
C2810 C2819
28
0.1uF
10uF
27
6.3V 10V
26
25
GND
24
C2813 0.1uF
23
R2837
22
330
R2825
21 150
20
C2814 0.1uF
19
R2840
18 R2828
3.3k
680
R2843 100
17
R2834
16
15k
15
FB2807
(+5.096V)
R2812
2.2k
CLK
DVDD
DGND
MODE
AVDD
COMP2
IOUT1
IOUT2
AGND
COMP1
BIASJ
EXTIO
EXTLO
SLEEP
C2846
10uF
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
NC1
NC2
R2819
47k
VBS-GAIN
024
+5V-DA
CL2801
1.2
IC2804
R1173H001D-T1-F
1
2
3
4
5
6
7
8
9
10
11
12
13
14
C2858 10uF
6.3V
IC2808 (2/2)
AD8014ARTZ-REEL7
L2810
10uH
+5.5V 1.1A/6V
THP281
RB2803
220
ENCODER-VBS_out
+5V-DRV_2
from ANALOG FPGA +3.2V

024 COMPOSITE-PAL/NTSC
RB2801
220
1
2
3
4
5
6
7
8
1
2
3
4
RB2802
5
6
220
7
8
1
2
3
4
5
6
7
8
L2804
10uH
IC2805
THS5661AIPWR
VBS11
VBS10
VBS9
VBS8
VBS7
VBS6
VBS5
VBS4
VBS3
VBS2
VBS1
VBS0
+5V-D
004
L2801
10uH
R2822
100
005 27M-CLK-DA-COMPOSITE
NPN
2
3
5
6
to MB
WFM-SEQ1-ON/OFF_out 002
to PROCYON_I/O
SW-POS
022
1
4
Vfs=IOUTfs X Rout
=(32 X Vextio/Rbiasj) X Rout
=(32 X Vextio/(3.3k+680)) X (330//330)
=Vextio X 1.3266
S2801
NTSC
PAL
Vref
955mV
936mV
Vfs
TP
1267mV
2600mV
1242mV
2550mV
gain=2.0525
4.7k
DPR-300 (28/28)
BOARD NO. 1-879-649-11
HDCU-300_DPR-300_011_28
9-42
A
9-42
HSCU-300
DY-23 (1/4)
002
Video_IF
001,003
GPIO(0-7)
1
CL101
0.8
CN101
(Reserve)
MCLC_VAL_V
MCLC_VAL_H
GND
MCLC_C(11)
MCLC_C(9)
MCLC_C(7)
MCLC_C(5)
MCLC_C(3)
MCLC_C(1)
GND
MCLC_Y(11)
MCLC_Y(9)
MCLC_Y(7)
MCLC_Y(5)
MCLC_Y(3)
MCLC_Y(1)
GND
GPIO(1)
GND
GND
GND
GND
GND
GND
+V_RG18
+V_RG18
+V_RG18
+3.3V_PLL
GND
GND
GND
GND
FRSEL
FFWRT
FSYNC
UART0_RXD
DRIF_DHEN
DTIF_DATA(31)
GND
DTIF_DATA(29)
DTIF_DATA(27)
DTIF_DATA(25)
DTIF_DATA(23)
DTIF_DATA(21)
GND
DTIF_DATA(19)
DTIF_DATA(17)
DTIF_DATA(15)
DTIF_DATA(13)
DTIF_DATA(11)
GND
DTIF_DATA(9)
DTIF_DATA(7)
DTIF_DATA(5)
DTIF_DATA(3)
DTIF_DATA(1)
GND
DTIF_PLD_EN
DTIF_PLD_ST
V_V
V_H
V_C[11]
V_C[9]
V_C[7]
V_C[5]
V_C[3]
V_C[1]
V_Y[11]
V_Y[9]
V_Y[7]
V_Y[5]
V_Y[3]
V_Y[1]
GPIO[1]
GPIO[2]
+V_REG
+3.3V_PLL
003
003
002
002
DY-23 (1/4)
FRSEL
FFWRT
FSYNC
UART0_RXD
R101
R102
47
47
R104
47
DRIF_DHEN
DTIF_D[31]
DTIF_D[29]
DTIF_D[27]
DTIF_D[25]
DTIF_D[23]
DTIF_D[21]
DTIF_D[19]
DTIF_D[17]
DTIF_D[15]
DTIF_D[13]
DTIF_D[11]
DTIF_D[9]
DTIF_D[7]
DTIF_D[5]
DTIF_D[3]
DTIF_D[1]
DTIF_PLD_EN
DTIF_PLD_ST
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
48
50
52
54
56
58
60
62
64
66
68
70
72
74
76
78
80
82
84
86
88
90
92
94
96
98
100
102
104
106
108
110
112
114
116
118
120
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
35
37
39
41
43
45
47
49
51
53
55
57
59
61
63
65
67
69
71
73
75
77
79
81
83
85
87
89
91
93
95
97
99
101
103
105
107
109
111
113
115
117
119
MCLC_VAL_DE
MCLC_FLD
MCLC_CK
GND
MCLC_C(10)
MCLC_C(8)
MCLC_C(6)
MCLC_C(4)
MCLC_C(2)
MCLC_C(0)
GND
MCLC_Y(10)
MCLC_Y(8)
MCLC_Y(6)
MCLC_Y(4)
MCLC_Y(2)
MCLC_Y(0)
GND
GPIO(0)
+2.5V
+2.5V
+1.2V
+1.2V
+1.2V
+1.2V
GND
GND
GND
+3.3V_PLL
+3.3V
+3.3V
+3.3V
+3.3V
GND
EXT_PCLK
SYS_RESET_X
UART0_TXD
DRIF_DDEN
DTIF_DATA(30)
GND
DTIF_DATA(28)
DTIF_DATA(26)
DTIF_DATA(24)
DTIF_DATA(22)
DTIF_DATA(20)
GND
DTIF_DATA(18)
DTIF_DATA(16)
DTIF_DATA(14)
DTIF_DATA(12)
DTIF_DATA(10)
GND
DTIF_DATA(8)
DTIF_DATA(6)
DTIF_DATA(4)
DTIF_DATA(2)
DTIF_DATA(0)
GND
DTIF_PCLK
ENC/DEC_MODE
V_DE
V_FLD
V_CK
FFC(30p)
V_C[10]
V_C[8]
V_C[6]
V_C[4]
V_C[2]
V_C[0]
TEST_MON(0-15)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
V_Y[10]
V_Y[8]
V_Y[6]
V_Y[4]
V_Y[2]
V_Y[0]
+2.5V
R114
R115
47
NM
GPIO[0]
IRQ_UWB_0
001,002
+1.2V
FB101
+3.3V_PLL
GND_PLL
+3.3V
R105
DRIF_DDEN
DTIF_D[30]
47
EXT_PCLK
SYS_RESET_X
UART0_TXD
003
003,004
002
+1.8V
C105
10uF
6.3V
1608
C106
10uF
6.3V
1608
+V_REG
+1.8V
C101
10uF
6.3V
4
VDD
5
CE VOUT
ADJ
GND
2
(+1.819V)
R110
10k
CL102
0.8
R113
1M C102 C103
10uF 10uF
NM
6.3V 6.3V
TEST_MON[11]
TEST_MON[12]
TEST_MON[13]
TEST_MON[14]
TEST_MON[15]
TEST_MDSEL(0-4)
TEST_MDSEL[0]
003
TEST_MDSEL[1]
TEST_MDSEL[2]
TEST_MDSEL[3]
TEST_MDSEL[4]
DTIF_D[18]
DTIF_D[16]
DTIF_D[14]
DTIF_D[12]
DTIF_D[10]
FFC(30p)
+1.2V
DTIF_D[8]
DTIF_D[6]
DTIF_D[4]
DTIF_D[2]
DTIF_D[0]
C108
10uF
6.3V
1608
C109
10uF
6.3V
1608
GND
DTIF_PCLK
+3.3V
002
C112
10uF
6.3V
1608
C113
10uF
6.3V
1608
C114
10uF
6.3V
1608
C115
10uF
6.3V
1608
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
CN103
FLASHSEL
HALTBOOTUP
IRQ_UBW_0
IRQ_UBW_1
GND
FLASHSEL
HALTBOOTUP
IRQ_UWB_0
IRQ_UWB_1
003
003
001,002
002
MULTI_ICE
AMI_TRST
AMI_TDI
AMI_TMS
AMI_TRST
AMI_TDI
AMI_TMS
GND
AMI_TCK
AMI_RTCT
AMI_TDO
003
AMI_TCK
AMI_RTCK
AMI_TDO
GND
UART1_RXD
UART_1TXD
GND
SCL
SDA
SCL
SDA
002
002
+3.3V
GND
(+1.8V for DDR)
002
002
GPIO[4]
GPIO[5]
GPIO[6]
GPIO[7]
GND
+1.8V
UART1_RXD
UART1_TXD
GPIO[3]
GPIO[3]
GND
GPIO[4]
GPIO[5]
GPIO[6]
GPIO[7]
GND
32 31
IC101
R1173H001D-T1-F
R109
22k
TEST_MON[7]
TEST_MON[8]
TEST_MON[9]
TEST_MON[10]
GND
C107
10uF
6.3V
1608
GND
(+2.5V)
TEST_MON[3]
TEST_MON[4]
TEST_MON[5]
TEST_MON[6]
TEST_MDSEL[0]
GND
TEST_MDSEL[1]
TEST_MDSEL[2]
TEST_MDSEL[3]
TEST_MDSEL[4]
GND
GND
DTIF(0-31)
D103
1SS302-TE85L
1
2
3
003
GND
C104
10uF
6.3V
1608
DTIF_D[28]
DTIF_D[26]
DTIF_D[24]
DTIF_D[22]
DTIF_D[20]
GND
R108
220
TIC_MODE
TEST_MON[0]
TEST_MON[1]
TEST_MON[2]
003
32 31
121
122
CN102
TIC_MODE
TEST_MON[0]
TEST_MON[1]
TEST_MON[2]
GND
TEST_MON[3]
TEST_MON[4]
TEST_MON[5]
TEST_MON[6]
GND
TEST_MON[7]
TEST_MON[8]
TEST_MON[9]
TEST_MON[10]
GND
TEST_MON[11]
TEST_MON[12]
TEST_MON[13]
TEST_MON[14]
GND
TEST_MON[15]
D102
SML-D12M8WT86SM
R107 4.7k
GPIO[7]
GPIO(0-7)
001,003
1.CN/PWR
2.DAYTONA(VIDEO/RTP IF,DDR IF, FLASH IF)
3.DAYTONA(PLL/TEST IF,PWR,GND)
4.DDR/FLASH
(+1.0V)
R111
10k
R112
2.2k
DY-23 (1/4)
BOARD NO. 1-879-648-11
GND
HDCU-300_DY-23_011_1
9-43
HSCU-300
9-43
E
DY-23 (2/4)
001
Video_IF
V_FLD
V_CK
V_V
V_H
V_DE
001
RB201
10
RB202
10
FSYNC
V_Y[0]
V_Y[1]
V_Y[2]
V_Y[3]
V_Y[4]
V_Y[5]
V_Y[6]
V_Y[7]
V_Y[8]
V_Y[9]
V_Y[10]
V_Y[11]
V_C[0]
V_C[1]
V_C[2]
V_C[3]
V_C[4]
V_C[5]
V_C[6]
V_C[7]
V_C[8]
V_C[9]
V_C[10]
V_C[11]
1
3
5
7
1
3
5
7
CL201
0.8
CL202
0.8
A4
D5
C5
B5
A5
U20
1
RB203 3
10 5
7
1
RB204 3
10 5
7
1
RB205 3
10 5
7
2
4
6
8
2
4
6
8
2
4
6
8
G4
G3
G2
G1
F4
F3
F2
F1
E4
E3
E2
E1
7
5
3
1
1
3
5
7
1
3
5
7
8
6
4
2
2
4
6
8
2
4
6
8
D4
D3
D2
D1
C3
C2
C1
B1
B3
A3
C4
B4
10
RB206
RB207
10
RB208
10
DTIF(0-31)
Video/RTP Data IF
2
4
6
8
2
4
6
8
H3
H2
J3
J2
J1
H4
MCLC_CK
MCLC_FIELDID
MCLC_VAL_V
MCLC_VAL_H
MCLC_VAL_DE
FSYNC
MCLC_Y[0]
MCLC_Y[1]
MCLC_Y[2]
MCLC_Y[3]
MCLC_Y[4]
MCLC_Y[5]
MCLC_Y[6]
MCLC_Y[7]
MCLC_Y[8]
MCLC_Y[9]
MCLC_Y[10]
MCLC_Y[11]
MCLC_C[0]
MCLC_C[1]
MCLC_C[2]
MCLC_C[3]
MCLC_C[4]
MCLC_C[5]
MCLC_C[6]
MCLC_C[7]
MCLC_C[8]
MCLC_C[9]
MCLC_C[10]
MCLC_C[11]
MCIS_LRCK
MCIS_BCK
MCIS_CH12
MCIS_CH34
MCIS_CH56
MCIS_CH78
DTIF_PCLK
DRIF_TX_RD_RDY2
DRIF_DHEN
DRIF_DDEN
DTIF_PLD_REQ
DTIF_PLD_ST
DTIF_PLD_EN
DRIF_PATHSEL0
DRIF_PATHSEL1
DTIF_DATA[0]
DTIF_DATA[1]
DTIF_DATA[2]
DTIF_DATA[3]
DTIF_DATA[4]
DTIF_DATA[5]
DTIF_DATA[6]
DTIF_DATA[7]
DTIF_DATA[8]
DTIF_DATA[9]
DTIF_DATA[10]
DTIF_DATA[11]
DTIF_DATA[12]
DTIF_DATA[13]
DTIF_DATA[14]
DTIF_DATA[15]
DTIF_DATA[16]
DTIF_DATA[17]
DTIF_DATA[18]
DTIF_DATA[19]
DTIF_DATA[20]
DTIF_DATA[21]
DTIF_DATA[22]
DTIF_DATA[23]
DTIF_DATA[24]
DTIF_DATA[25]
DTIF_DATA[26]
DTIF_DATA[27]
DTIF_DATA[28]
DTIF_DATA[29]
DTIF_DATA[30]
DTIF_DATA[31]
V20
AA14
AB14
U13
V21
W20
V22
Y13
W13
W21
W22
Y21
Y22
AA22
AB21
Y20
AA20
AB20
W19
Y19
AA19
AB19
W18
Y18
AA18
AB18
W17
Y17
AA17
AB17
W16
Y16
AA16
AB16
U15
W15
Y15
AA15
AB15
W14
Y14
R205
10
2
4
6
8
1k
R207
1k
1
RB210 3
10 5
7
1
RB211 3
10 5
7
1
RB212 3
10 5
7
1
RB213 3
10 5
7
1
RB214 3
10 5
7
1
RB215 3
10 5
7
1
RB216 3
10 5
7
1
RB217 3
10 5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
001
DTIF_PCLK
1
RB209 3
10 5
7
R206
DY-23 (2/4)
DRIF_DHEN
DRIF_DDEN
DTIF_PLD_ST
DTIF_PLD_EN
DDR_IF
DDR_BA1
DDR_BA0
DDR_CAS
DDR_ADDR[3]
DDR_ADDR[11]
DDR_ADDR[12]
DDR_ADDR[7]
DDR_ADDR[8]
DDR_ADDR[4]
DDR_ADDR[9]
DDR_ADDR[6]
DDR_ADDR[10]
DDR_ADDR[1]
DDR_WE
DDR_CS
DDR_CKE
DDR_ADDR[5]
DDR_ADDR[2]
DDR_ADDR[0]
DDR_RAS
GND
DTIF_D[1]
DTIF_D[0]
DTIF_D[3]
DTIF_D[2]
DTIF_D[4]
DTIF_D[5]
DTIF_D[6]
DTIF_D[7]
DTIF_D[8]
DTIF_D[9]
DTIF_D[10]
DTIF_D[11]
DTIF_D[12]
DTIF_D[13]
DTIF_D[14]
DTIF_D[15]
DTIF_D[16]
DTIF_D[17]
DTIF_D[18]
DTIF_D[19]
DTIF_D[20]
DTIF_D[21]
DTIF_D[22]
DTIF_D[23]
DTIF_D[24]
DTIF_D[25]
DTIF_D[26]
DTIF_D[27]
DTIF_D[28]
DTIF_D[29]
DTIF_D[30]
DTIF_D[31]
RB218
22
RB219
22
RB220
22
RB221
22
RB222
22
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
BA1
BA0
CAS
ADDR[3]
ADDR[11]
ADDR[12]
ADDR[7]
ADDR[8]
ADDR[4]
ADDR[9]
ADDR[6]
ADDR[10]
ADDR[1]
WE
CS
CKE
ADDR[5]
ADDR[2]
ADDR[0]
RAS
DDR_CKE
E22
O_DDR_CLK
E21
O_DDR_CLKN
C21
O_DDR_CKE
DDR_BA0
DDR_BA1
DDR_CS
DDR_RAS
DDR_CAS
DDR_WE
E20
E19
B22
D21
D20
C22
R208
0
F17
O_DDR_ADDR[0]
O_DDR_ADDR[1]
O_DDR_ADDR[2]
O_DDR_ADDR[3]
O_DDR_ADDR[4]
O_DDR_ADDR[5]
O_DDR_ADDR[6]
O_DDR_ADDR[7]
O_DDR_ADDR[8]
O_DDR_ADDR[9]
O_DDR_ADDR[10]
O_DDR_ADDR[11]
O_DDR_ADDR[12]
O_DDR_BA[0]
O_DDR_BA[1]
O_DDR_CS
O_DDR_RAS
O_DDR_CAS
O_DDR_WE
VREF
GND
004
Flash/UART IF
FLASH_IF
FL_WE
FL_CE
FL_OE
FL_RY/BY
DDR IF
R209 22
R210 22
DDR_CLK
DDR_CLK
IC201
(1/6)
CXD9218GG
004
A21
B21
A20
B20
C20
B19
C19
A18
B18
C18
D18
A17
B17
DDR_ADDR[0]
DDR_ADDR[1]
DDR_ADDR[2]
DDR_ADDR[3]
DDR_ADDR[4]
DDR_ADDR[5]
DDR_ADDR[6]
DDR_ADDR[7]
DDR_ADDR[8]
DDR_ADDR[9]
DDR_ADDR[10]
DDR_ADDR[11]
DDR_ADDR[12]
DDR_0_DQS[0]
DDR_0_DQS[1]
DDR_0_DQS[2]
DDR_0_DQS[3]
R21
B_DDR_DQS0[0]
M22
B_DDR_DQS0[1]
J22
B_DDR_DQS0[2]
G20
B_DDR_DQS0[3]
D13
B_DDR_DQS1[0]
D16
B_DDR_DQS1[1]
B7
B_DDR_DQS1[2]
B10
B_DDR_DQS1[3]
DDR_1_DQS[0]
DDR_1_DQS[1]
DDR_1_DQS[2]
DDR_1_DQS[3]
DDR_0_DM[0]
DDR_0_DM[1]
DDR_0_DM[2]
DDR_0_DM[3]
P21
O_DDR_DM0[0]
M21
O_DDR_DM0[1]
K19
O_DDR_DM0[2]
G19
O_DDR_DM0[3]
C13
O_DDR_DM1[0]
A15
O_DDR_DM1[1]
D8
O_DDR_DM1[2]
C10
O_DDR_DM1[3]
DDR_1_DM[0]
DDR_1_DM[1]
DDR_1_DM[2]
DDR_1_DM[3]
DDR_0_D[0]
DDR_0_D[1]
DDR_0_D[2]
DDR_0_D[3]
DDR_0_D[4]
DDR_0_D[5]
DDR_0_D[6]
DDR_0_D[7]
DDR_0_D[8]
DDR_0_D[9]
DDR_0_D[10]
DDR_0_D[11]
DDR_0_D[12]
DDR_0_D[13]
DDR_0_D[14]
DDR_0_D[15]
DDR_0_D[16]
DDR_0_D[17]
DDR_0_D[18]
DDR_0_D[19]
DDR_0_D[20]
DDR_0_D[21]
DDR_0_D[22]
DDR_0_D[23]
DDR_0_D[24]
DDR_0_D[25]
DDR_0_D[26]
DDR_0_D[27]
DDR_0_D[28]
DDR_0_D[29]
DDR_0_D[30]
DDR_0_D[31]
T21
T20
T19
R22
R20
P22
R19
P20
L21
L22
M19
M20
N19
N20
N21
P19
H22
J19
J20
J21
K20
K21
L19
L20
H21
H20
H19
G21
F22
F21
F20
F19
B14
C14
D14
B13
A12
B12
C12
D12
A14
D15
C15
B15
C16
B16
D17
C17
B6
A6
D7
C7
C8
B8
A8
D9
A11
B11
C11
D11
D10
A9
B9
C9
DDR_1_D[0]
DDR_1_D[1]
DDR_1_D[2]
DDR_1_D[3]
DDR_1_D[4]
DDR_1_D[5]
DDR_1_D[6]
DDR_1_D[7]
DDR_1_D[8]
DDR_1_D[9]
DDR_1_D[10]
DDR_1_D[11]
DDR_1_D[12]
DDR_1_D[13]
DDR_1_D[14]
DDR_1_D[15]
DDR_1_D[16]
DDR_1_D[17]
DDR_1_D[18]
DDR_1_D[19]
DDR_1_D[20]
DDR_1_D[21]
DDR_1_D[22]
DDR_1_D[23]
DDR_1_D[24]
DDR_1_D[25]
DDR_1_D[26]
DDR_1_D[27]
DDR_1_D[28]
DDR_1_D[29]
DDR_1_D[30]
DDR_1_D[31]
B_DDR_DATA0[0]
B_DDR_DATA0[1]
B_DDR_DATA0[2]
B_DDR_DATA0[3]
B_DDR_DATA0[4]
B_DDR_DATA0[5]
B_DDR_DATA0[6]
B_DDR_DATA0[7]
B_DDR_DATA0[8]
B_DDR_DATA0[9]
B_DDR_DATA0[10]
B_DDR_DATA0[11]
B_DDR_DATA0[12]
B_DDR_DATA0[13]
B_DDR_DATA0[14]
B_DDR_DATA0[15]
B_DDR_DATA0[16]
B_DDR_DATA0[17]
B_DDR_DATA0[18]
B_DDR_DATA0[19]
B_DDR_DATA0[20]
B_DDR_DATA0[21]
B_DDR_DATA0[22]
B_DDR_DATA0[23]
B_DDR_DATA0[24]
B_DDR_DATA0[25]
B_DDR_DATA0[26]
B_DDR_DATA0[27]
B_DDR_DATA0[28]
B_DDR_DATA0[29]
B_DDR_DATA0[30]
B_DDR_DATA0[31]
B_DDR_DATA1[0]
B_DDR_DATA1[1]
B_DDR_DATA1[2]
B_DDR_DATA1[3]
B_DDR_DATA1[4]
B_DDR_DATA1[5]
B_DDR_DATA1[6]
B_DDR_DATA1[7]
B_DDR_DATA1[8]
B_DDR_DATA1[9]
B_DDR_DATA1[10]
B_DDR_DATA1[11]
B_DDR_DATA1[12]
B_DDR_DATA1[13]
B_DDR_DATA1[14]
B_DDR_DATA1[15]
B_DDR_DATA1[16]
B_DDR_DATA1[17]
B_DDR_DATA1[18]
B_DDR_DATA1[19]
B_DDR_DATA1[20]
B_DDR_DATA1[21]
B_DDR_DATA1[22]
B_DDR_DATA1[23]
B_DDR_DATA1[24]
B_DDR_DATA1[25]
B_DDR_DATA1[26]
B_DDR_DATA1[27]
B_DDR_DATA1[28]
B_DDR_DATA1[29]
B_DDR_DATA1[30]
B_DDR_DATA1[31]
U3
MBUS_WE_X
U2
MBUS_CS_X
U1
MBUS_OE_X
T6
MBUS_RDY
FL_A[0]
FL_A[1]
FL_A[2]
FL_A[3]
FL_A[4]
FL_A[5]
FL_A[6]
FL_A[7]
FL_A[8]
FL_A[9]
FL_A[10]
FL_A[11]
FL_A[12]
FL_A[13]
FL_A[14]
FL_A[15]
FL_A[16]
FL_A[17]
FL_A[18]
FL_A[19]
AB5
Y4
AA4
AB4
AA3
AB3
AB2
AA1
Y3
Y2
Y1
W4
W3
W2
W1
V4
V3
V2
V1
U4
FL_DT[0]
FL_DT[1]
FL_DT[2]
FL_DT[3]
FL_DT[4]
FL_DT[5]
FL_DT[6]
FL_DT[7]
AB7
W6
Y6
AA6
AB6
W5
Y5
AA5
MBUS_ADDR[0]
MBUS_ADDR[1]
MBUS_ADDR[2]
MBUS_ADDR[3]
MBUS_ADDR[4]
MBUS_ADDR[5]
MBUS_ADDR[6]
MBUS_ADDR[7]
MBUS_ADDR[8]
MBUS_ADDR[9]
MBUS_ADDR[10]
MBUS_ADDR[11]
MBUS_ADDR[12]
MBUS_ADDR[13]
MBUS_ADDR[14]
MBUS_ADDR[15]
MBUS_ADDR[16]
MBUS_ADDR[17]
MBUS_ADDR[18]
MBUS_ADDR[19]
MBUS_DATA[0]
MBUS_DATA[1]
MBUS_DATA[2]
MBUS_DATA[3]
MBUS_DATA[4]
MBUS_DATA[5]
MBUS_DATA[6]
MBUS_DATA[7]
001
001
IRQ_UWB_0
IRQ_UWB_1
Y7
IRQ_UWB[0]
AA7
IRQ_UWB[1]
001
001
001
001
UART0_RXD
UART0_TXD
UART1_RXD
UART1_TXD
P3
UART0_RXD
P4
UART0_TXD
R1
UART1_RXD
R2
UART1_TXD
001
001
SCL
SDA
L1
SCL
L2
SDA
IC201
(3/6)
CXD9218GG
DY-23 (2/4)
IC201
(2/6)
CXD9218GG
BOARD NO. 1-879-648-11

HDCU-300_DY-23_011_2
9-44
A
9-44
HSCU-300
DY-23 (3/4)
DY-23 (3/4)
DDR_CONT.LOGIC
+1.2V
PWR
OSC_27MHz
PLL/Test IF
+3.3V
FB301
C301 0.1uF
C302 1uF
X301
4 27MHz GND
VDD
1
3
CONT
OUT
OE
GND
2
001,004
R305
47
CL309
CL308 0.8
CL305 0.8
CL301 0.8
0.8
SYS_RESET_X
R301 10k
R302
22
R303
22
GND
R306
GND
001
+3.3V_PLL
EXT_PCLK
R304
100
IC301
C303
47uF
4 R1173H001D-T1-F
R311
3
VDD
5 (+1.2V)
0
CE VOUT
R308 1k
R309
1
C346
1k
ADJ
10uF
GND
(1.0V)
C347
2
R310
10uF
10k
GND_PLL
R307
L301
1uH
10
CL302
0.8
L302
1uH
C304 0.1uF
L303
1uH
C305 0.1uF
C306 0.1uF
GND_PLL
CL303
0.8
CL307
CL304 0.8
0.8 CL310
0.8
CL306
0.8
GND_PLL
001
FRSEL
001
001
FLASHSEL
FFWRT
001
001
MULTI_ICE
001
001
1k
GPIO(0-7)
GPIO[0]
GPIO[1]
GPIO[2]
GPIO[3]
GPIO[4]
GPIO[5]
GPIO[6]
GPIO[7]
001
001
TEST_MON(0-15)
TEST_MDSEL(0-4)
HALTBOOTUP
TIC_MODE
AMI_TRST
AMI_TDI
AMI_TMS
AMI_TCK
AMI_RTCK
AMI_TDO
RB301
47
1
2
3
4
5
6
7
8
P2
M1
N2
N3
P1
H1
N1
N6
L4
L3
M3
M2
N4
M4
C6
D6
W7
C308 10uF
SYS_RESET_X
PLL_BP0
BP_CKSEL
BP_GCELL
FORCEBYPASS
CLK_27M
CLK_27M_VCO
CLK_27M_DDR
EXT_PCLK
EXT_ACLK
PL0_AVD
PL0_AVS
PL1_AVD
PL1_AVS
PL3_AVD
PL3_AVS
C313 0.1uF
C314 0.1uF
C315 0.1uF
C316 0.1uF
C317 0.1uF
C318 0.1uF
C328 0.1uF
DAYTONA_CORE
C329 0.1uF
PWM
C330 0.1uF
U17
CHIP_TEST_MODE
U21
ARM_TESTEN
U22
ARM_INNOTEXTEST
V19
ARM_BISTOUT
Y8
AA8
AB8
U7
U19
T4
T3
T2
T1
R4
R3
L6
K6
J6
K4
K3
K2
K1
J4
TEST_MON[0]
TEST_MON[1]
TEST_MON[2]
TEST_MON[3]
TEST_MON[4]
TEST_MON[5]
TEST_MON[6]
TEST_MON[7]
TEST_MON[8]
TEST_MON[9]
TEST_MON[10]
TEST_MON[11]
TEST_MON[12]
TEST_MON[13]
TEST_MON[14]
TEST_MON[15]
AA13
AB13
W12
Y12
AA12
AB12
U11
W11
Y11
AA11
AB11
W10
Y10
AA10
AB10
U9
TEST_MDSEL[0]
TEST_MDSEL[1]
TEST_MDSEL[2]
TEST_MDSEL[3]
TEST_MDSEL[4]
W8
W9
Y9
AA9
AB9
C312 0.1uF
C331 0.1uF
C332 0.1uF
FRSEL
FLASHSEL
FFWRT
HALTBOOTUP
TIC_MODE
C333 0.1uF
C334 0.1uF
C335 0.1uF
DDR_IO
+1.8V
AMI_TRST
AMI_TDI
AMI_TMS
AMI_TCK
AMI_RTCK
AMI_TDO
GND
FB304
FB305
C309 10uF C319 0.1uF

C320 0.1uF
GPIO[0]
GPIO[1]
GPIO[2]
GPIO[3]
GPIO[4]
GPIO[5]
GPIO[6]
GPIO[7]
C321 0.1uF
C322 0.1uF
C323 0.1uF
C324 0.1uF
C325 0.1uF
TEST_MON[0]
TEST_MON[1]
TEST_MON[2]
TEST_MON[3]
TEST_MON[4]
TEST_MON[5]
TEST_MON[6]
TEST_MON[7]
TEST_MON[8]
TEST_MON[9]
TEST_MON[10]
TEST_MON[11]
TEST_MON[12]
TEST_MON[13]
TEST_MON[14]
TEST_MON[15]
C326 0.1uF
C327 0.1uF
Video_IF_DRV
+2.5V
H10
H11
H14
H15
J8
J9
J12
J13
K14
K15
M14
M15
P14
P15
K8
K9
K12
K13
L10
L11
M9
M12
N8
N9
N12
N13
P10
P11
R8
R9
R12
R13
F8
F10
F12
F14
F16
G8
G10
G12
G14
G16
G17
J16
J17
L16
L17
N16
N17
R16
R17
GND C345 0.1uF

C336
0.1uF
C311
10uF
GND
+3.3V
IO_DRV
C337 0.1uF
C338 0.1uF
C307 10uF
C339 0.1uF
C340 0.1uF
TEST_MDSEL[4]
TEST_MDSEL[0]
TEST_MDSEL[1]
TEST_MDSEL[2]
TEST_MDSEL[3]
C341 0.1uF
C342 0.1uF
C343 0.1uF
IC201
(4/6)
CXD9218GG
C344 0.1uF
GND
K10
K11
L8
L9
L12
L13
M8
M10
M11
M13
N10
N11
P8
P9
P12
P13
R10
R11
VDD12_1
VDD12_2
VDD12_3
VDD12_4
VDD12_5
VDD12_6
VDD12_7
VDD12_8
VDD12_9
VDD12_10
VDD12_11
VDD12_12
VDD12_13
VDD12_14
VDD_1
VDD_2
VDD_3
VDD_4
VDD_5
VDD_6
VDD_7
VDD_8
VDD_9
VDD_10
VDD_11
VDD_12
VDD_13
VDD_14
VDD_15
VDD_16
VDD_17
VDD_18
GND
VDD18_1
VDD18_2
VDD18_3
VDD18_4
VDD18_5
VDD18_6
VDD18_7
VDD18_8
VDD18_9
VDD18_10
VDD18_11
VDD18_12
VDD18_13
VDD18_14
VDD18_15
VDD18_16
VDD18_17
VDD18_18
VDD18_19
A1
A2
F6
G6
H6
L7
M7
N7
P7
R7
T8
T9
T10
T15
U12
U14
U16
AB1
AB22
GND
VSS1
VSS2
VSS3
VSS4
VSS5
VSS6
VSS7
VSS8
VSS9
VSS10
VSS11
VSS12
VSS13
VSS14
VSS15
VSS16
VSS17
VSS18
VSS_DDR1
VSS_DDR2
VSS_DDR3
VSS_DDR4
VSS_DDR5
VSS_DDR6
VSS_DDR7
VSS_DDR8
VSS_DDR9
VSS_DDR10
VSS_DDR11
VSS_DDR12
VSS_DDR13
VSS_DDR14
VSSIO1
VSSIO2
VSSIO3
VSSIO4
VSSIO5
VSSIO6
VSSIO7
VSSIO8
VSSIO9
VSSIO10
VSSIO11
VSSIO12
VSSIO13
VSSIO14
VSSIO15
VSSIO16
VSSIO17
VSSIO18
VSSIO19
VSSIO_DDR1
VSSIO_DDR2
VSSIO_DDR3
VSSIO_DDR4
VSSIO_DDR5
VSSIO_DDR6
VSSIO_DDR7
VSSIO_DDR8
VSSIO_DDR9
VSSIO_DDR10
VSSIO_DDR11
VSSIO_DDR12
VSSIO_DDR13
VSSIO_DDR14
VSSIO_DDR15
VSSIO_DDR16
VSSIO_DDR17
VSSIO_DDR18
VSSIO_DDR19
VSSIO_DDR20
VSSIO_DDR21
VSSIO_DDR22
VSSIO_DDR23
VSSIO_DDR24
VSSIO_DDR25
VSSIO_DDR26
VSSIO_DDR27
VSSIO_DDR28
VSSIO_DDR29
VSSIO_DDR30
IC201
(6/6)
CXD9218GG
1
H8
H9
H12
H13
J10
J11
J14
J15
L14
L15
N14
N15
R14
R15
GND
A7
A10
A13
A16
A19
A22
D19
D22
F7
F9
F11
F13
F15
G7
G9
G11
G13
G15
G22
H16
H17
K16
K17
K22
M16
M17
N22
P16
P17
T22
GND
H7
VDDIO_1_1
J7
VDDIO_1_2
K7
VDDIO_1_3
B2
M6
P6
R6
T7
T11
T12
T13
T14
T16
T17
U6
U8
U10
AA2
AA21
VDDIO1
VDDIO2
VDDIO3
VDDIO4
VDDIO5
VDDIO6
VDDIO7
VDDIO8
VDDIO9
VDDIO10
VDDIO11
VDDIO12
VDDIO13
VDDIO14
VDDIO15
VDDIO16
GND
IC201
(5/6)
CXD9218GG
DY-23 (3/4)
BOARD NO. 1-879-648-11
HDCU-300_DY-23_011_3
9-45
HSCU-300
9-45
E
DY-23 (4/4)
DY-23 (4/4)
002
FLASH_IF
47
47
47
47
IC401
MT46H16M32LFCM-6IT:B
CS
WE
CAS
RAS
DM3
DM2
DM1
DM0
DQS3
DQS2
DQS1
DQS0
CKE
CK
CK
BA1
BA0
ADDR[12]
ADDR[11]
ADDR[10]
ADDR[9]
ADDR[8]
ADDR[7]
ADDR[6]
ADDR[5]
ADDR[4]
ADDR[3]
ADDR[2]
ADDR[1]
ADDR[0]
H9
H8
H3
H2
J7
H1
J3
J2
J1
K3
K1
K9
K7
J9
J8
CS
WE
CAS
RAS
H7
G7
G8
G9
F2
F8
K2
K8
E2
E8
L2
L8
G1
G2
G3
MDDR_1_DM[3]
MDDR_1_DM[2]
MDDR_1_DM[1]
MDDR_1_DM[0]
DDR_1_DQS[3]
DDR_1_DQS[2]
DDR_1_DQS[1]
DDR_1_DQS[0]
CKE
DDR_CLK
DDR_CLK
R416
R407
R417
R406
47
47
47
47
BA1
BA0
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
IC402
MT46H16M32LFCM-6IT:B
CS
WE
CAS
RAS
DM3
DM2
DM1
DM0
DQS3
DQS2
DQS1
DQS0
CKE
CK
CK
F3
NC1
F7
NC2
47
RB416
47
RB415
47
RB409
DQ31
DQ30
DQ29
DQ28
DQ27
DQ26
DQ25
DQ24
DQ23
DQ22
DQ21
DQ20
DQ19
DQ18
DQ17
DQ16
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
A2
B3
B2
C3
C2
D3
D2
E3
E7
D8
D7
C8
C7
B8
B7
A8
R2
P3
P2
N3
N2
M3
M2
L3
L7
M8
M7
N8
N7
P8
P7
R8
MDDR_1_DQ[31]
MDDR_1_DQ[30]
MDDR_1_DQ[29]
MDDR_1_DQ[28]
MDDR_1_DQ[27]
MDDR_1_DQ[26]
MDDR_1_DQ[25]
MDDR_1_DQ[24]
MDDR_1_DQ[23]
MDDR_1_DQ[22]
MDDR_1_DQ[21]
MDDR_1_DQ[20]
MDDR_1_DQ[19]
MDDR_1_DQ[18]
MDDR_1_DQ[17]
MDDR_1_DQ[16]
MDDR_1_DQ[15]
MDDR_1_DQ[14]
MDDR_1_DQ[13]
MDDR_1_DQ[12]
MDDR_1_DQ[11]
MDDR_1_DQ[10]
MDDR_1_DQ[9]
MDDR_1_DQ[8]
MDDR_1_DQ[7]
MDDR_1_DQ[6]
MDDR_1_DQ[5]
MDDR_1_DQ[4]
MDDR_1_DQ[3]
MDDR_1_DQ[2]
MDDR_1_DQ[1]
MDDR_1_DQ[0]
FL_RY/BY
1
3
5
7
MDDR_0_DQ[31]
MDDR_0_DQ[30]
MDDR_0_DQ[29]
MDDR_0_DQ[28]
MDDR_0_DQ[27]
MDDR_0_DQ[26]
MDDR_0_DQ[25]
MDDR_0_DQ[24]
MDDR_0_DQ[23]
MDDR_0_DQ[22]
MDDR_0_DQ[21]
MDDR_0_DQ[20]
MDDR_0_DQ[19]
MDDR_0_DQ[18]
MDDR_0_DQ[17]
MDDR_0_DQ[16]
MDDR_0_DQ[15]
MDDR_0_DQ[14]
MDDR_0_DQ[13]
MDDR_0_DQ[12]
MDDR_0_DQ[11]
MDDR_0_DQ[10]
MDDR_0_DQ[9]
MDDR_0_DQ[8]
MDDR_0_DQ[7]
MDDR_0_DQ[6]
MDDR_0_DQ[5]
MDDR_0_DQ[4]
MDDR_0_DQ[3]
MDDR_0_DQ[2]
MDDR_0_DQ[1]
MDDR_0_DQ[0]
+3.3V
001,003
47 NM 6
CE[F1]
47 NM 7
OE[G1]
47 NM 22
WE[A4]
15
BYTE[F6]
39
RESET[B4]
R401 47
23
RY/BY[A3]
VSS1[H1]
NM
GND
8
GND
14
34
33
45
31
44
30
29
35
12
46
11
10
43
9
28
R402
R403
R404
FL_CE
FL_OE
FL_WE
A9
F1
R9
A7
B1
C9
D1
E9
L9
M1
N9
P1
R7
A2
B3
B2
C3
C2
D3
D2
E3
E7
D8
D7
C8
C7
B8
B7
A8
R2
P3
P2
N3
N2
M3
M2
L3
L7
M8
M7
N8
N7
P8
P7
R8
NM
RB417
10k
1
RB418 3
10k 5
NM
7
1
RB419 3
10k 5
NM
7
1
RB420 3
47 5
NM
7
1
RB421 3
47 5
NM
7
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
GND
FL_DT[7]
FL_DT[6]
FL_DT[5]
FL_DT[4]
FL_DT[3]
FL_DT[2]
FL_DT[1]
FL_DT[0]
FLASH MEMORY
40
NC1[B3]
42
NC2[D3]
48
NC3[C4]
VSS2[H6]
13
GND
SYS_RESET_X
R405 47
NM
A1
F9
R1
A3
B9
C1
D9
E1
L1
M9
N1
P9
R3
A1
F9
R1
A3
B9
C1
D9
E1
L1
M9
N1
P9
R3
VSS1
VSS2
VSS3
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
VSSQ9
VSSQ10
F3
NC1
F7
NC2
DQ31
DQ30
DQ29
DQ28
DQ27
DQ26
DQ25
DQ24
DQ23
DQ22
DQ21
DQ20
DQ19
DQ18
DQ17
DQ16
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
NM
32
VCC[G4]
A19[D4] DQ15/A-1[G6]
A18[C3]
DQ14[F5]
A17[B2]
DQ13[G5]
A16[E6]
DQ12[F4]
A15[D6]
DQ11[G3]
A14[C6]
DQ10[F3]
A13[A6]
DQ9[G2]
A12[B6]
DQ8[F2]
A11[D5]
DQ7[E5]
A10[C5]
DQ6[H5]
A9[A5]
DQ5[E4]
A8[B5]
DQ4[H4]
A7[A2]
DQ3[H3]
A6[C2]
DQ2[E3]
A5[D2]
DQ1[H2]
A4[B1]
DQ0[E2]
A3[A1]
A2[C1]
A1[D1]
A0[E1]
2
4
6
8
BA1
BA0
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
VDD1
VDD2
VDD3
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
VDDQ9
VDDQ10
H7
G7
G8
G9
F2
F8
K2
K8
E2
E8
L2
L8
G1
G2
G3
R412
R410
R418
R413
47
RB410
GND
GND
GND
47
41
25
16
17
18
20
19
36
37
21
38
24
26
27
2
1
3
4
5
VSS1
VSS2
VSS3
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
VSSQ9
VSSQ10
CS
WE
CAS
RAS
DDR_0_DQS[3]
DDR_0_DQS[2]
DDR_0_DQS[1]
DDR_0_DQS[0]
CKE
DDR_CLK
DDR_CLK
47
RB411
C418 1uF
C410
10uF
A9
F1
R9
A7
B1
C9
D1
E9
L9
M1
N9
P1
R7
H9
H8
H3
H2
J7
H1
J3
J2
J1
K3
K1
K9
K7
J9
J8
VDD1
VDD2
VDD3
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
VDDQ9
VDDQ10
BA1
BA0
ADDR[12]
ADDR[11]
ADDR[10]
ADDR[9]
ADDR[8]
ADDR[7]
ADDR[6]
ADDR[5]
ADDR[4]
ADDR[3]
ADDR[2]
ADDR[1]
ADDR[0]
MDDR_0_DM[3]
MDDR_0_DM[2]
MDDR_0_DM[1]
MDDR_0_DM[0]
47
RB412
47
RB413
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
7
5
3
1
@500mA
GND
GND
FL_A[19]
FL_A[18]
FL_A[17]
FL_A[16]
FL_A[15]
FL_A[14]
FL_A[13]
FL_A[12]
FL_A[11]
FL_A[10]
FL_A[9]
FL_A[8]
FL_A[7]
FL_A[6]
FL_A[5]
FL_A[4]
FL_A[3]
FL_A[2]
FL_A[1]
GND
FB404
C409 1uF
C401
10uF
C420
10uF
NM
C419
0.1uF NM
IC403
S29AL016D70BFI020
MDDR_1_DM[3]
MDDR_1_DM[1]
MDDR_1_DQ[8]
MDDR_1_DQ[12]
MDDR_1_DQ[5]
MDDR_1_DQ[4]
MDDR_1_DQ[3]
MDDR_1_DQ[2]
MDDR_1_DQ[23]
MDDR_1_DM[0]
MDDR_1_DQ[7]
MDDR_1_DQ[6]
MDDR_1_DQ[0]
MDDR_1_DQ[1]
MDDR_1_DQ[10]
MDDR_1_DQ[9]
MDDR_1_DQ[15]
MDDR_1_DQ[14]
MDDR_1_DQ[13]
MDDR_1_DQ[11]
MDDR_1_DQ[19]
MDDR_1_DQ[18]
MDDR_1_DQ[20]
MDDR_1_DM[2]
MDDR_1_DQ[22]
MDDR_1_DQ[21]
MDDR_1_DQ[17]
MDDR_1_DQ[16]
MDDR_1_DQ[24]
MDDR_1_DQ[25]
MDDR_1_DQ[26]
MDDR_1_DQ[27]
MDDR_1_DQ[28]
MDDR_1_DQ[29]
MDDR_1_DQ[31]
MDDR_1_DQ[30]
FB403
FB402
FB401
@500mA
FB405
C411 C412 C413 C414 C415 C416 C417

0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
+1.8V
GND
+3.3V
NM
C402 C403 C404 C405 C406 C407 C408

0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
+1.8V
FL_A[0]
8
6
4
2
8
6
4
2
8
6
4
2
8
6
4
2
8
6
4
2
8
6
4
2
8
6
4
2
8
6
4
2
R411
R419
R414
R420
47
47
47
47
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
1
RB401 3
47 5
7
1
RB402 3
47 5
7
1
RB403 3
47 5
7
1
RB404 3
47 5
7
1
RB405 3
47 5
7
1
RB406 3
47 5
7
1
RB407 3
47 5
7
1
RB408 3
47 5
7
MDDR_0_DM[3]
MDDR_0_DM[1]
MDDR_0_DM[0]
MDDR_0_DQ[0]
MDDR_0_DQ[11]
MDDR_0_DQ[5]
MDDR_0_DQ[7]
MDDR_0_DQ[3]
MDDR_0_DQ[6]
MDDR_0_DQ[4]
MDDR_0_DQ[2]
MDDR_0_DQ[1]
MDDR_0_DM[2]
MDDR_0_DQ[8]
MDDR_0_DQ[9]
MDDR_0_DQ[10]
MDDR_0_DQ[14]
MDDR_0_DQ[15]
MDDR_0_DQ[12]
MDDR_0_DQ[13]
MDDR_0_DQ[17]
MDDR_0_DQ[18]
MDDR_0_DQ[19]
MDDR_0_DQ[16]
MDDR_0_DQ[20]
MDDR_0_DQ[21]
MDDR_0_DQ[22]
MDDR_0_DQ[23]
MDDR_0_DQ[24]
MDDR_0_DQ[25]
MDDR_0_DQ[26]
MDDR_0_DQ[27]
MDDR_0_DQ[28]
MDDR_0_DQ[29]
MDDR_0_DQ[30]
MDDR_0_DQ[31]
R408
R409
R421
R415
47
47
47
47
47
RB414
DDR_1_DM[3]
DDR_1_DM[1]
DDR_1_D[8]
DDR_1_D[12]
DDR_1_D[5]
DDR_1_D[4]
DDR_1_D[3]
DDR_1_D[2]
DDR_1_D[23]
DDR_1_DM[0]
DDR_1_D[7]
DDR_1_D[6]
DDR_1_D[0]
DDR_1_D[1]
DDR_1_D[10]
DDR_1_D[9]
DDR_1_D[15]
DDR_1_D[14]
DDR_1_D[13]
DDR_1_D[11]
DDR_1_D[19]
DDR_1_D[18]
DDR_1_D[20]
DDR_1_DM[2]
DDR_1_D[22]
DDR_1_D[21]
DDR_1_D[17]
DDR_1_D[16]
DDR_1_D[24]
DDR_1_D[25]
DDR_1_D[26]
DDR_1_D[27]
DDR_1_D[28]
DDR_1_D[29]
DDR_1_D[31]
DDR_1_D[30]
DDR_IF
DDR_0_DM[3]
DDR_0_DM[1]
DDR_0_DM[0]
DDR_0_D[0]
DDR_0_D[11]
DDR_0_D[5]
DDR_0_D[7]
DDR_0_D[3]
DDR_0_D[6]
DDR_0_D[4]
DDR_0_D[2]
DDR_0_D[1]
DDR_0_DM[2]
DDR_0_D[8]
DDR_0_D[9]
DDR_0_D[10]
DDR_0_D[14]
DDR_0_D[15]
DDR_0_D[12]
DDR_0_D[13]
DDR_0_D[17]
DDR_0_D[18]
DDR_0_D[19]
DDR_0_D[16]
DDR_0_D[20]
DDR_0_D[21]
DDR_0_D[22]
DDR_0_D[23]
DDR_0_D[24]
DDR_0_D[25]
DDR_0_D[26]
DDR_0_D[27]
DDR_0_D[28]
DDR_0_D[29]
DDR_0_D[30]
DDR_0_D[31]
002
DY-23 (4/4)
GND
BOARD NO. 1-879-648-11
GND
HDCU-300_DY-23_011_4
9-47
HSCU-300
9-47
E
ENC-112
001
TORINOA_BMDTL
001
TORINO_AUDIO
2
001
001
TORINOA_OMDQL
TORINO_VIDEO
001
001
ISCLK
001
OV_CLK74
ISCLK
GND
OV_CLK74
GND
TORINO_VIDEO_VD
TORINO_VIDEO_HD
TORINO_VIDEO_C0
TORINO_VIDEO_C2
TORINO_VIDEO_C4
TORINO_VIDEO_C6
GND
TORINO_VIDEO_Y0
TORINO_VIDEO_Y2
TORINO_VIDEO_Y4
TORINO_VIDEO_Y6
GND
TORINO_IV_CLK74
GND
TORINO_IPCLK
TORINO_AUDIO_DT34
TORINO_AUDIO_OADT34
TORINO_AUDIO_FS
GND
TORINO_HCLK
GND
TORINO_HCSX
TORINO_HRDX
TORINO_HDT7
TORINO_HDT5
TORINO_HDT3
TORINO_HDT1
GND
TORINO_JTSEL_S1
TORINO_JTSEL_S3
TORINO_SER_RX
TORINO_SER_RTSX
GND
TORINO_A_STRM_ADT
TORINO_A_STRM_CLK
GND
TORINO_STRM_D0
TORINO_STRM_D2
TORINO_STRM_D4
TORINO_STRM_D6
TORINO_STRM_IBRDY
TORINO_IBCLK
GND
+2.5V
+2.5V
+2.5V
+2.5V
GND
GND
GND
GND
GND
+1.0V
+1.0V
+1.0V
+1.0V
TORINO_VIDEO_VD
TORINO_VIDEO_HD
TORINO_VIDEO_C0
TORINO_VIDEO_C2
TORINO_VIDEO_C4
TORINO_VIDEO_C6
TORINO_VIDEO_Y0
TORINO_VIDEO_Y2
TORINO_VIDEO_Y4
TORINO_VIDEO_Y6
TORINO_IV_CLK74
TORINO_IPCLK
001
001
TORINO_AUDIO_DT34
TORINO_AUDIO_OADT34
TORINO_AUDIO_FS
001
001
001
001
001
TORINO_HCLK
TORINO_HIF
TORINO_JTSEL
TORINO_SER
TORINO_HCSX
TORINO_HRDX
TORINO_HDT7
TORINO_HDT5
TORINO_HDT3
TORINO_HDT1
TORINO_JTSEL_S1
TORINO_JTSEL_S3
TORINO_SER_RX
TORINO_SER_RTSX
TORINO_A_STRM
TORINO_A_STRM_ADT
TORINO_A_STRM_CLK
001
TORINO_STRM
001
TORINO_IBCLK
TORINO_STRM_D0
TORINO_STRM_D2
TORINO_STRM_D4
TORINO_STRM_D6
TORINO_STRM_IBRDY
SIGN1905
+2.5V
+1.0V
CN100
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101 102
103 104
105 106
107 108
109 110
111 112
113 114
115 116
117 118
119 120
GND
121
GND
GND
RST_TORINO
GND
GND
TORINO_VIDEO_FLD
TORINO_VIDEO_FRM
TORINO_VIDEO_C1
TORINO_VIDEO_C3
TORINO_VIDEO_C5
TORINO_VIDEO_C7
GND
TORINO_VIDEO_Y1
TORINO_VIDEO_Y3
TORINO_VIDEO_Y5
TORINO_VIDEO_Y7
GND
GND
(Reserve)
GND
TORINO_AUDIO_DT12
TORINO_AUDIO_OADT12
GND
(Reserve)
GND
TORINO_HALE
TORINO_HWRX
TORINO_INTX
TORINO_HDT6
TORINO_HDT4
TORINO_HDT2
TORINO_HDT0
GND
GND
TORINO_JTSEL_S2
TORINO_SER_TX
TORINO_SER_CTSX
GND
GND
TORINO_STRM_D1
TORINO_STRM_D3
TORINO_STRM_D5
TORINO_STRM_D7
TORINO_STRM_OBRDY
GND
GND
+2.5V
+2.5V
+2.5V
+2.5V
GND
GND
GND
GND
GND
+1.0V
+1.0V
+1.0V
+1.0V
122
RST_TORINO
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
267
122
203
124
34
123
33
202
266
32
200
120
31
265
30
119
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
29
116
28
117
27
195
26
113
263
110
264
108
112
19
109
18
BMDT00[Y12]
BMDT01[AC10]
BMDT02[AA13]
BMDT03[AC12]
BMDT04[AD11]
BMDT05[AC11]
BMDT06[AD10]
BMDT07[AA12]
BMDT08[Y11]
BMDT09[AD9]
BMDT10[AA10]
BMDT11[AC8]
BMDT12[AD8]
BMDT13[Y10]
BMDT14[AD7]
BMDT15[AC7]
BMDT32[G1]
BMDT33[H1]
BMDT34[F1]
BMDT35[H2]
BMDT36[E2]
BMDT37[D2]
BMDT38[F2]
BMDT39[G2]
BMDT40[D7]
BMDT41[A4]
BMDT42[B5]
BMDT43[A5]
BMDT44[B7]
BMDT45[B6]
BMDT46[D8]
BMDT47[A6]
BMDT16[AD6]
BMDT17[AC4]
BMDT18[AD5]
BMDT19[AC5]
BMDT20[AD4]
BMDT21[AA5]
BMDT22[AD3]
BMDT23[AB2]
BMDT24[Y8]
BMDT25[W2]
BMDT26[Y9]
BMDT27[U2]
BMDT28[AA2]
BMDT29[W1]
BMDT30[V2]
BMDT31[V1]
BMDT48[B8]
BMDT49[A7]
BMDT50[D9]
BMDT51[A9]
BMDT52[B9]
BMDT53[B10]
BMDT54[A10]
BMDT55[A11]
BMDT56[B13]
BMDT57[A12]
BMDT58[D15]
BMDT59[B11]
BMDT60[B12]
BMDT61[B14]
BMDT62[A13]
BMDT63[B15]
%0
%1
%2
%3
201
OMDQ0[AA11]
199
OMDQ1[AA9]
118
OMDQ2[AC6]
20
OMDQ3[Y1]
%0
%1
251
OMADB0[L5]
185
OMADB1[M4]
TORINOA_OMADB
CN100
ENC-112
115
BMDQS0[AC3]
111
BMDQS1[Y2]
5
BMDQS2[E1]
93
BMDQS3[B2]
001
TORINO_VIDEO_FLD
TORINO_VIDEO_FRM
TORINO_VIDEO_C1
TORINO_VIDEO_C3
TORINO_VIDEO_C5
TORINO_VIDEO_C7
TORINO_VIDEO_Y1
TORINO_VIDEO_Y3
TORINO_VIDEO_Y5
TORINO_VIDEO_Y7
001
001
001
001
TORINOA_OMCKE
TORINOA_OMRSX
TORINOA_OMCSX
TORINOA_OMWEX
001
TORINOA_OMCEX
001
TORINOA_OMCLK
CL100
0.8
R100
22
102
OMCKE[L2]
182
OMRSX[J4]
101
OMCSX[K2]
100
OMWEX[J2]
9
OMCEX[J1]
CL101
0.8
7
8
6
99
96
95
97
98
242
90
174
89
172
173
241
88
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
171
87
240
85
170
169
84
83
166
82
234
168
167
165
81
164
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
181
OMDQ4[H4]
91
OMDQ5[A3]
86
OMDQ6[A8]
237
OMDQ7[D12]
OMAD00[T1]
OMAD01[U1]
OMAD02[T2]
OMAD03[R4]
OMAD04[R2]
OMAD05[R1]
OMAD06[P5]
OMAD07[N5]
OMAD08[N2]
OMAD09[M2]
OMAD10[P2]
OMAD11[P1]
OMAD12[N1]
OMAD13[M5]
CL102
0.8
001
TORINOA_OMDQU
TORINOA_OMAD
001
001
001
001
001
001
TORINO_STRM
CL106
0.8 231
68
156
232
158
159
73
161
001
001
TORINO_STRM_D1
TORINO_STRM_D3
TORINO_STRM_D5
TORINO_STRM_D7
TORINO_STRM_OBRDY
+2.5V
C167
10uF
6.3V
(2012)
GND
IBCLK1[AD22]
BVYDT0[D23]
BVYDT1[E23]
BVYDT2[E24]
BVYDT3[E21]
BVYDT4[D20]
BVYDT5[D24]
BVYDT6[C23]
BVYDT7[D21]
IBDT10[AD21]
IBDT11[AA21]
IBDT12[AD20]
IBDT13[AC20]
IBDT14[AD19]
IBDT15[AC19]
IBDT16[AA19]
IBDT17[AA18]
BVCDT0[D18]
BVCDT1[C24]
BVCDT2[B23]
BVCDT3[D17]
BVCDT4[B21]
BVCDT5[B20]
BVCDT6[A21]
BVCDT7[B18]
IBRDY1[AA17]
IVFSYNC[E18]
OBRDY1[Y18]
IBCLK[AD12]
BBDT0[Y13]
BBDT1[AC13]
BBDT2[AA14]
BBDT3[AC14]
BBDT4[AA15]
BBDT5[AC15]
BBDT6[AD15]
BBDT7[AC16]
OVCLK[A22]
59
VDDQ1[AC2]
VDDQ5[B3]
VDDQ6[D4]
VDDQ7[K4]
VDDQ8[L4]
VDDQ9[N4]
VDDQ10[P4]
VDDQ11[T4]
VDDQ12[U4]
VDDQ13[W4]
VDDQ14[AA6]
VDDQ15[AA8]
VDDQ16[D14]
VDDQ17[D11]
VDDQ18[D10]
VDDQ19[D6]
VDDQ20[D5]
VDDQ21[F5]
VDDQ22[G5]
VDDQ23[K5]
VDDQ24[T5]
VDDQ25[E11]
VDDQ26[E9]
VDDQ27[E8]
VDDQ28[V12]
VDDQ29[V13]
1uF
C108
1uF
C109
C110
C111
0.01uF
0.1uF
1uF
C112
0.01uF
C113
C114
0.1uF
+2.5V
10uF
C115
0.1uF
324
VDDQ30[V15]
325
VDDQ31[V16]
C116
0.1uF
326
C117
0.1uF
C118
1uF
C121 0.1uF
C122 0.1uF
135
327
328
329
332
368
331
370
TORINO_AUDIO_DT12
TORINO_AUDIO_DT34
TORINO_AUDIO_OADT12
TORINO_AUDIO_OADT34
145
OADT12[N23]
219
OADT34[N21]
TORINO_AUDIO_FS
218
C124 0.01uF
C125 0.1uF
160
C123 1uF
224
OBADT[AA16]
IBARDY[AC18]
OBARDY[Y17]
ICBRD[H21]
OCARD[G24]
ICBDT0[G21]
ICBDT1[J23]
ICBDT2[F20]
ICBDT3[G23]
ICBDT4[K21]
ICBDT5[J21]
ICBDT6[H23]
ICBDT7[H20]
OCADT0[L23]
OCADT1[F23]
OCADT2[L24]
OCADT3[K23]
OCADT4[E20]
OCADT5[E19]
OCADT6[J20]
OCADT7[J24]
RB101
10k 1
3
5
7
RB102
10k 1
3
5
7
2
4
6
8
2
4
6
8
225
149
289
151
222
223
150
287
RB103
10k 1
3
5
7
2
4
6
8
288
OCBRDD[G20]
226
OCBRDP[F21]
63
BBADT[AC17]
ICBCLK[H24]
44
211
43
132
42
131
209
208
207
273
R105
35
268
125
204
126
205
127
38
128
40
39
41
22
TORINO_STRM_D0
TORINO_STRM_D1
TORINO_STRM_D2
TORINO_STRM_D3
TORINO_STRM_D4
TORINO_STRM_D5
TORINO_STRM_D6
TORINO_STRM_D7
TORINO_IBCLK
TORINO_STRM
001
001
TORINO_A_STRM
001
TORINO_STRM_IBRDY
TORINO_STRM_OBRDY
R107
22
TORINO_A_STRM_CLK
129
TORINO_A_STRM_ADT
206
130
272
64
147
152
60
148
290
291
286
62
285
ICARDD[K20]
221
ICARDP[L21]
OCACLK[K24]
GND
61
R108 10k
R109 10k
CL115
0.8
GND
IC100
(2/5)
CXD3195AGG-T6
C132 0.01uF
C133 0.1uF
C134 1uF
C135 0.01uF
C136 0.1uF
C137 1uF
C138 0.01uF
C139 0.1uF
C140 1uF
C141 0.01uF
C142 0.1uF
C143 1uF
C144 0.01uF
C145 0.1uF
C146 1uF
C147 0.01uF
GND
SDLLVDD11[D1]
SDLLGND11[C1]
4
3
R101
0
STBY/SDR
GND
SDLLVDD01[AB1]
SDLLGND01[AA1]
VDDQ2[AC23]
VDDQ33[V18]
VDDQ34[U18]
VDDQ35[T18]
VDDQ38[N18]
VDDQ42[T17]
VDDQ37[P18]
VDDQ44[P17]
IAFS[P21]
IACLK[AD18]
45
C129 10uF
C130 0.1uF
C131 1uF
12
94
121
133
191
197
230
236
298
300
303
323
333
337
338
367
371
372
22
21
VDDQ32[V17]
330
VDDQ36[R18]
369
VDDQ43[R17]
157
334
335
336
373
374
VDD1[M1]
VDD2[C2]
VDD3[AC9]
VDD4[AC21]
VDD5[V4]
VDD6[AA7]
VDD7[D19]
VDD8[D13]
VDD9[E12]
VDD10[E10]
VDD11[E7]
VDD12[V14]
VDD13[M18]
VDD14[H18]
VDD15[G18]
VDD16[U17]
VDD17[N17]
VDD18[M17]
IPCLK[M24]
146
BADT12[M23]
220
BADT34[M21]
+1.0V
114
176
177
183
184
186
187
189
190
192
196
198
235
238
239
243
244
246
247
250
256
299
301
302
321
322
0.01uF
0.1uF
C119 0.01uF
C169
10uF
6.3V
(2012)
GND
22
GND
C105
C120 0.1uF
C168
10uF
6.3V
(2012)
GND
292
CL114
0.8 72
001
C106
C107
GND
+1.0V
IVCLK[F24]
296
BVHSYNC[E14]
295
BVVSYNC[E15]
294
BVFLDID[E16]
R106 10k
C104 0.1uF
TORINO_VIDEO_C0
TORINO_VIDEO_C1
TORINO_VIDEO_C2
TORINO_VIDEO_C3
TORINO_VIDEO_C4
TORINO_VIDEO_C5
TORINO_VIDEO_C6
TORINO_VIDEO_C7
R118
TORINO_IPCLK
TORINO_AUDIO
C100 10uF
TORINO_A_STRM
CL105
0.8 154
153
66
227
229
67
155
228
OBRDY[AD16]
C103 0.01uF
TORINO_JTSEL_S2
TORINO_SER_TX
TORINO_SER_CTSX
TORINO_VIDEO_Y0
TORINO_VIDEO_Y1
TORINO_VIDEO_Y2
TORINO_VIDEO_Y3
TORINO_VIDEO_Y4
TORINO_VIDEO_Y5
TORINO_VIDEO_Y6
TORINO_VIDEO_Y7
IBRDY[AD17]
C101 0.1uF
C102 1uF
TORINO_JTSEL
TORINO_SER
CL104
0.8 65
R104 22
OV_CLK74
+2.5V
TORINO_HIF
R119 22
11
OMCLK[L1]
10
OMCLKX[K1]
TORINO_HALE
TORINO_HWRX
TORINO_INT_X
TORINO_HDT6
TORINO_HDT4
TORINO_HDT2
TORINO_HDT0
+1.0V_PLL
TORINO_IV_CLK74
TORINO_VIDEO
TORINO_VIDEO_FRM
CL103
16 0.8
%0
17
%1
107
%2
188
%3
106
%4
15
%5
254
%6
253
%7
104
%8
103
%9
105
%10
14
%11
13
%12
252
CL117
0.8
GND
001
001
TORINO_VIDEO_HD
TORINO_VIDEO_VD
TORINO_VIDEO_FLD
%0
%1
%2
%3
TORINO_AUDIO_DT12
TORINO_AUDIO_OADT12
CL119
0.8
001
IC100
(1/5)
CXD3195AGG-T6
CL116
0.8
CL118
0.8
TORINOA_BMDTU
R102
0
STBY/SDR
GND
MDLLVDD1[A14]
MDLLGND1[A15]
80
79
R103
0
STBY/SDR
GND
AVDD1[A19]
AGND1[A18]
+1.0V_PLL
FB100
75
76
C126
0.1uF
C170
10uF
GND
VDDQ3[B22]
VDDQ39[L18]
VDDQ40[K18]
VDDQ41[J18]
VDDQ45[L17]
VDDQ46[K17]
AVDD2[A17]
AVDD3[AD14]
VDDQ4[B19]
AGND3[AD13]
AGND2[A16]
77
78
C127
0.1uF
+1.0V_PLL
FB101
C171
10uF
+1.0V_PLL
GND
FB102
37
36
C128
0.01uF
GND
C148
0.1uF
C149
10uF
C150
10uF
GND
IC100
(4/5)
CXD3195AGG-T6
9-48
A
9-48
HSCU-300
ENC-112
OHINT[P20]
R113
1k
277
50
214
137
271
213
49
134
136
212
RB106
2.2k
NM
RB107
2.2k
NM
NM
NM
NM
NM
NM
NM
NM
TMC2[G4]
OCLDT0[V20]
OCLDT1[AA24]
OCLDT2[V21]
OCLDT3[AA23]
OCLDT4[Y16]
OCLDT5[W21]
OCLDT6[AB24]
OCLDT7[AC22]
OCLDT8[AB23]
OCLDT9[Y21]
ISCLK[A20]
ITEST1[B16]
ITEST2[B17]
ISRSTX[D16]
TRST[E17]
180
163
ISCLK
RST_TORINO
C157
0.1uF
GND
001
001
%9
%12
%6
%3
R115 10k
233
GND
293
GND
TORINOA_OMCLK
%1
%11
%13
%15
C155
0.1uF
%0
%2
%4
VDD1[R7]
DQ0[R8]
DQ2[R9]
DQ4[P9]
VDDQ3[N9]
VDDQ4[M9]
VSSQ5[L9]
TORINOA_BMDTU_RB
001
DQ14[N3]
DQ9[M3]
VSS4[L3]
NC4[K3]
A9[J3]
NC3[H3]
A6[G3]
A3[F3]
NC2[E3]
DQ30[D3]
%25
C165
0.1uF
%20
%18
%16
%2
%0
%1
%7
%5
%3
TORINOA_OMCEX
TORINOA_OMWEX
001
001
C166
0.1uF
%12
%10
TORINOA_BMDTU
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
RB119
1
22
3
5
7
RB120
1
22
3
5
7
RB121
1
22
3
5
7
RB122
1
22
3
5
7
RB123
1
22
3
5
7
RB124
1
22
3
5
7
RB125
1
22
3
5
7
RB126
1
22
3
5
7
TORINOA_BMDTU_RB
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
001
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
43
44
45
46
47
48
49
50
51
52
53
54
%3
GND
001
001
001
C162
0.1uF
%19
%21
%23
GND
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
58
VSSQ7[P3]
57
VDDQ8[P2]
56
DQ12[N2]
55
DQ10[M2]
28
29
30
31
32
33
34
35
36
37
38
39
C159
0.1uF
TORINOA_OMADB
TORINOA_OMCSX
TORINOA_OMAD
91
90
89
88
87
86
85
84
83
82
VDDQ10[B7]
VSSQ9[B8]
DQ20[C8]
DQ18[D8]
DQ16[E8]
DQM2[F8]
A0[G8]
BA1[H8]
CS[J8]
WE[K8]
DQ7[L8]
DQ5[M8]
DQ3[N8]
VSSQ8[P8]
VDDQ9[P7]
IC102
W9825Y2DB-6
DQM0[K9]
RAS[J9]
A11[H9]
A1[G9]
VDD2[F9]
VSSQ6[E9]
VDDQ5[D9]
VDDQ6[C9]
DQ19[B9]
DQ21[A9]
DQ23[A8]
VDD3[A7]
C156
0.1uF
21
22
23
24
25
26
27
81
DQ25[C3]
80
VSSQ10[B3]
VSS3[A3]
DQ24[A2]
VDDQ7[B2]
DQ27[C2]
DQ29[D2]
DQ31[E2]
DQM3[F2]
A5[G2]
A8[H2]
CKE[J2]
NC1[K2]
DQ8[L2]
001
CL112
0.8
DQ26[A1]
DQ28[B1]
VSSQ1[C1]
VSSQ2[D1]
VDDQ1[E1]
VSS1[F1]
A4[G1]
A7[H1]
CLK[J1]
DQM1[K1]
VDDQ2[L1]
VSSQ3[M1]
VSSQ4[N1]
DQ11[P1]
DQ13[R1]
DQ15[R2]
VSS2[R3]
%24
C154
0.1uF
%4
%7
DQ22[C7]
DQ17[D7]
NC6[E7]
A2[F7]
A10[G7]
NC5[H7]
BA0[J7]
CAS[K7]
VDD4[L7]
DQ6[M7]
DQ1[N7]
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
%26
%28
001
001
001
001
105
104
103
102
101
100
99
98
97
96
95
IC100
(5/5)
CXD3195AGG-T6
319
320
339
340
341
342
343
344
345
346
347
348
349
350
351
352
353
354
355
356
357
358
359
360
361
362
363
364
365
366
375
376
377
378
379
380
381
382
383
384
%11
%1
GND42[V10]
GND43[V11]
GND44[G17]
GND45[G16]
GND46[G15]
GND47[G14]
GND48[G13]
GND49[G12]
GND50[G11]
GND51[G10]
GND52[G9]
GND53[G8]
GND54[H8]
GND55[J8]
GND56[K8]
GND57[L8]
GND58[M8]
GND59[N8]
GND60[P8]
GND61[R8]
GND62[T8]
GND63[U8]
GND64[U9]
GND65[U10]
GND66[U11]
GND67[U12]
GND68[U13]
GND69[U14]
GND70[U15]
GND71[U16]
GND72[J17]
GND73[H17]
GND74[H16]
GND75[H15]
GND76[H14]
GND77[H13]
GND78[H12]
GND79[H11]
GND80[H10]
GND81[H9]
TORINOA_OMDQL
TORINOA_OMCKE
TORINOA_OMRSX
R117
0
NM
C161
0.1uF
%0
GND
%30
%14
%9
91
90
89
88
87
86
85
84
83
82
DQ14[N3]
DQ9[M3]
VSS4[L3]
NC4[K3]
A9[J3]
NC3[H3]
A6[G3]
A3[F3]
NC2[E3]
DQ30[D3]
162
+2.5V
GND1[A1]
GND2[B1]
GND3[AC1]
GND4[AD1]
GND5[AD2]
GND6[AD23]
GND7[AD24]
GND8[AC24]
GND9[B24]
GND10[A24]
GND11[A23]
GND12[A2]
GND13[E4]
GND14[F4]
GND15[Y4]
GND16[AA4]
GND17[E5]
GND18[H5]
GND19[J5]
GND20[R5]
GND21[U5]
GND22[V5]
GND23[W5]
GND24[Y5]
GND25[Y6]
GND26[Y7]
GND27[E6]
GND28[G7]
GND29[H7]
GND30[J7]
GND31[K7]
GND32[L7]
GND33[M7]
GND34[N7]
GND35[P7]
GND36[R7]
GND37[T7]
GND38[U7]
GND39[V7]
GND40[V8]
GND41[V9]
%12
%10
C158
0.1uF
R121
22
74
IC100
(3/5)
CXD3195AGG-T6
1
2
23
24
25
46
47
48
69
70
71
92
178
179
193
194
245
248
249
255
257
258
259
260
261
262
304
305
306
307
308
309
310
311
312
313
314
315
316
317
318
C164
0.1uF
%8
D100
SML-D12M8WT86SM
D101
SML-D12M8WT86SM
D102
SML-D12M8WT86SM
D103
SML-D12M8WT86SM
D104
SML-D12M8WT86SM
D105
SML-D12M8WT86SM
D106
SML-D12M8WT86SM
D107
SML-D12M8WT86SM
D108
SML-D12M8WT86SM
D109
SML-D12M8WT86SM
ORTSX[Y19]
001
001
001
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
175
%2
RB105
2.2k
8
6
4
2
8
6
4
2
8
6
4
2
TMC1[B4]
TORINOA_OMCEX
TORINOA_OMWEX
%7
%5
%3
%30
274
OTX[U23]
ICTSX[Y14]
%1
TORINOA_BMDTL_RB
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
%8
CL108
0.8
IRX[U24]
%0
RB111
1
22
3
5
7
RB112
1
22
3
5
7
RB113
1
22
3
5
7
RB114
1
22
3
5
7
RB115
1
22
3
5
7
RB116
1
22
3
5
7
RB117
1
22
3
5
7
RB118
1
22
3
5
7
%5
%8
269
58
VSSQ7[P3]
57
VDDQ8[P2]
56
DQ12[N2]
55
DQ10[M2]
%2
%3
R111 10k
+2.5V
7
5
3
1
7
5
3
1
7
5
3
1
C153
0.1uF
VDD1[R7]
DQ0[R8]
DQ2[R9]
DQ4[P9]
VDDQ3[N9]
VDDQ4[M9]
VSSQ5[L9]
%20
%18
%16
%0
141
21
22
23
24
25
26
27
%0
%2
%4
%22
%17
CL107
0.8
C152
0.1uF
2
4
6
8
GND
54
TORINO_SER_CTSX
TORINO_SER_RTSX
RB110
10k
R110 10k
TORINO_SER_RX
TORINO_SER_TX
1
3
5
7
DQM0[K9]
RAS[J9]
A11[H9]
A1[G9]
VDD2[F9]
VSSQ6[E9]
VDDQ5[D9]
VDDQ6[C9]
DQ19[B9]
DQ21[A9]
DQ23[A8]
VDD3[A7]
+2.5V
270
278
52
215
53
2
4
6
8
28
29
30
31
32
33
34
35
36
37
38
39
TORINO_SER
1
3
5
7
IC101
W9825Y2DB-6
%9
TORINO_JTSEL_S1
TORINO_JTSEL_S2
TORINO_JTSEL_S3
210
138
140
139
51
%11
%13
%15
%0
%1
%2
%3
%4
%5
%6
%7
%8
%9
%10
%11
%12
%13
%14
%15
%16
%17
%18
%19
%20
%21
%22
%23
%24
%25
%26
%27
%28
%29
%30
%31
C163
0.1uF
%12
%6
%3
284
IJTSEL1[L20]
276
IJTSEL2[W20]
275
IJTSEL3[Y20]
R114
1k
RB109
10k
CL113
0.8
%1
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
TORINOA_BMDTL
%5
%8
7
5
3
1
8
6
4
2
001
IJTDI1[Y15]
BJTDO1[U20]
BJTRS1[W24]
IJTMS1[U21]
IJTCK1[V24]
TORINOA_OMCLK
VDDQ10[B7]
VSSQ9[B8]
DQ20[C8]
DQ18[D8]
DQ16[E8]
DQM2[F8]
A0[G8]
BA1[H8]
CS[J8]
WE[K8]
DQ7[L8]
DQ5[M8]
DQ3[N8]
VSSQ8[P8]
VDDQ9[P7]
%27
%29
%31
IJTDI0[AA20]
BJTDO0[Y23]
BJTRS0[V23]
IJTMS0[W23]
IJTCK0[Y24]
RB108
10k
001
+2.5V
IPCIMODE[E13]
TORINO_JTSEL
GND
%6
%1
%22
%17
IHCSX[M20]
GND
001
%25
VSS3[A3]
DQ24[A2]
VDDQ7[B2]
DQ27[C2]
DQ29[D2]
DQ31[E2]
DQM3[F2]
A5[G2]
A8[H2]
CKE[J2]
NC1[K2]
DQ8[L2]
297
%4
%7
%6
%1
R112
0
C151
0.1uF
IHWRX[N20]
%0
TORINO_INT_X
IHRDX[P23]
%27
%29
%31
281
001
43
44
45
46
47
48
49
50
51
52
53
54
TORINO_HCSX
TORINOA_BMDTL_RB
001
81
DQ25[C3]
80
VSSQ10[B3]
%24
282
CL111
0.8 283
DQ26[A1]
DQ28[B1]
VSSQ1[C1]
VSSQ2[D1]
VDDQ1[E1]
VSS1[F1]
A4[G1]
A7[H1]
CLK[J1]
DQM1[K1]
VDDQ2[L1]
VSSQ3[M1]
VSSQ4[N1]
DQ11[P1]
DQ13[R1]
DQ15[R2]
VSS2[R3]
%14
%9
144
TORINO_HWRX
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
%26
%28
IHALE[N24]
%19
%21
%23
TORINO_HRDX
001
001
001
R116
0
NM
C160
0.1uF
%10
58
+2.5V
105
104
103
102
101
100
99
98
97
96
95
TORINO_HALE
BHDT0[T20]
BHDT1[T21]
BHDT2[T23]
BHDT3[T24]
BHDT4[R20]
BHDT5[R21]
BHDT6[R23]
BHDT7[R24]
DQ22[C7]
DQ17[D7]
NC6[E7]
A2[F7]
A10[G7]
NC5[H7]
BA0[J7]
CAS[K7]
VDD4[L7]
DQ6[M7]
DQ1[N7]
CL109
0.8 279
216
142
55
280
217
143
56
%1
TORINO_HDT0
TORINO_HDT1
TORINO_HDT2
TORINO_HDT3
TORINO_HDT4
TORINO_HDT5
TORINO_HDT6
TORINO_HDT7
TORINOA_OMADB
TORINOA_OMCSX
TORINOA_OMAD
IHCLK[P24]
%11
CL110
0.8 57
R120
22
TORINO_HCLK
TORINO_HIF
001
001
%10
%2
%0
ENC-112
TORINOA_OMDQU
001
TORINOA_OMCKE
TORINOA_OMRSX
001
001
ENC-112
TORINO
BOARD NO. 1-879-595-11

ENC-112_011_1
9-49
HSCU-300
9-49
M
FL-349
FL-349
From PS-UNIT
POWER
1
BLUE
CN4
NM
2
4
DC180V(C)_IN
L14
100uH
NC2 NC1
FB14
1
3
2
4
L13
100uH
NC2 NC1
1
3
2
4
L11
100uH
NC2 NC1
1
3
C11
0.22uF
250V
C13
0.22uF
250V
TP3
FB13
TP2
3 2 1
A-side
3 2 1
A-side
GND-2
RED
CN3
NM
DC180V(H)_IN
2
4
L5
100uH
NC2 NC1
fs=5.7MHz
C5
0.15uF
400V
1 FB5
3
C4
0.033uF
630V
2
4
L4
100uH
NC2 NC1
1 FB4
3
2
4
L3
100uH
NC2 NC1
C3
0.033uF
630V
1
3
FB3
L2
---
60uH
fs=9MHz
3uH
FB2 fs=200MHz
2
FB11
L1
---
TRIAX
C21
0.01uF
250V
L21
100uH
L22
100uH
2
C22
0.01uF
250V
TRIAX(C)_OUT
TRIAX(G)_OUT
Straight Type
5432
fs=9MHz
To Triax
CN1
TRIAX(H)_OUT
TP1
CN2
1 2 3
A-side
GND-1
FL-349
BOARD NO. 1-879-655-11
HDCU-300_FL-349_011_1
9-50
A
9-50
HSCU-300
A
25
A
1
MB-1124
4
25
(1)
3
A
25
(1)
A
1
(25)
HSCU-300
9-51
D
E
ENG-OUT(Y)-in
ENG-IN(Y)-out
WFM-Recall(2G)-in
WFM-Recall(3B)-in
RED-Tally-(Y)-out
GREEN-Tally-(Y)-out
WFM-Recall(6RB)-in
WFM-Recall(7RG)-in
YELLOW-Tally-(Y)-out
RED-TALLY-Rear-in
WFM-Recall(9add)-in
CAM-POWER-ON/OFF-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg (+14V)-in
Unreg-GND
Unreg-GND
Unreg-GND
16D
16B
17D
17B
18D
18B
19D
19B
20D
20B
21D
21B
22D
22B
23D
23B
24D
24B
25D
25B
Prompt-Y6-out
Prompt-Y8-out
Prompt-Y2-out
Prompt-Y4-out
HD-RET-C6-out
HD-RET-C8-out
HD-RET-C2-out
HD-RET-C4-out
HD-RET-Y6-out
HD-RET-Y8-out
HD-RET-Y2-out
HD-RET-Y4-out
15D
15B
11D
11B
10D
10B
9D
9B
8D
8B
7D
7B
22D
22B
CCU-ID1-in (Pull-Up)
Guard-GND
19B
(reserve)
19D
(POW-UNIT DC/AC-in)
11D
11B
10D
10B
9D
9B
8D
8B
7D
7B
PROD-OUT(Y)-out
PROD-OUT(Y)-in
ENG-OUT(Y)-out
ENG-IN(Y)-in
WFM-Recall(2G)-out
WFM-Recall(3B)-out
RED-Tally-(Y)-in
GREEN-Tally-(Y)-in
WFM-Recall(6RB)-out
WFM-Recall(7RG)-out
GND
4D
3D
3B
2D
2B
1D
1B
CAM-POWER-ON/OFF-out
Ether-GND
MIC2-(X)-out
MIC1-(X)-out
Front-PIX(G)-in
11E
11C
11A
10E
10C
10A
9E
9C
9A
8E
8C
8A
7E
7C
7A
6E
6C
6A
5E
5C
5A
4E
4C
4A
3E
3C
3A
2E
2C
2A
1E
1C
1A
MB-GND
MB-GND
MB-GND
(HIRA-pin-out)
(NC)
MB-GND
Front-PIX(X)-if
(HIRA-pin-out)
MB-GND
(HIRA-pin-out)
PIX(G)-out
MB-GND
WFM(X)-out
MB-GND
GND
GND
GND
GND
GND
UNREG
UNREG-GND
GND
GND
UNREG
GND
GND UNREG-D UNREG
9-51
Rear-Alarm-NG/OK-in
MB-GND
G/Y(G)-out
R/R-Y(G)-out
MB-GND
B/Y-B(X)-out
ANA0(DPR-Level)-out
25E
25C
25A
24E
24C
24A
23E
23C
23A
22E
22C
(reserve)
HD/SD-SDI-3,4-out (Y) 22A
21E
TONE0-DETECT-out
21C
(reserve)
HD/SD-SDI-3,4-out (X) 21A
20E
Guard-GND
20C
WFM-STAIR-CASE-out
20A
Guard-GND
(RCP-PWR-NG-Status-if) 19E
19C
(reserve)
19A
RCP-COM-TX-if
18E
18C
WFM-SEQ1-ON/OFF-out
18A
RCP-COM-RX(X)-if
17E
17C
RCP-Unreg (+12V)
17A
Rear +5V
16E
16C
MB-GND
16A
15E
VBS(G)-out
15C
MB-GND
15A
HD/SD-SYNC(X)-if
Rear-SEL12 HD/SD-out
PLD-Config-Done out
HD/SD-SDI-1,2-out (Y)
Prompter1-(G)-in
PLD-ReConfig in
HD/SD-SDI-1,2-out (X)
Prompter2-(X)-in
IRQ(Torino&Daytona)
Guard-GND
External-Ref-SYNC-in
MST-SD-F-in
MST-74M-CLK-in
External-Ref-SC-in
MST-27M-CLK-in
MST-HD-F-in
Unreg-Drive (+14V)
Unreg (+14V)
Unreg (+14V)
MB-GND
MB-GND
MB-GND
GND
GND
4B
WFM-Recall(9add)-out 5D
5B
COM-TALLY-Rear-out
6D
6B
15D
15B
CN3
PGM2-IN(Y)-in
PGM1-IN(Y)-in
YELLOW-Tally-(Y)-in
RED-TALLY-Rear-out
16D
16B
HD/SD-SYNC(G)-out
17B
Rear -5.5V
Aspect-CTL(1)-in
MIC2-CTL-on/off-in
17D
18D
MIC-Gain-CTL(1)-in
Cable-SHORT-Status-in 18B
20D
20B
Aspect-CTL-on/off-in
Guard-GND
TONE1-DETECT-in
21B
Guard-GND
23D
23B
Return2-VBS(G)-in
Guard-GND
21D
24D
24B
MB-GND
MB-GND
1D
1B
Return1-VBS(X)-in
Guard-GND
Unreg (+14V)
Unreg (+14V)
2D
2B
25D
25B
Guard-GND
Guard-GND
3D
3B
EXT-Ref(G)-in
Guard-GND
Frame-Reset-Gate-out
Guard-GND
4D
4B
TRUNK1(RX)
TRUNK2(RX)
GND
TRUNK1(TX)
TRUNK2(TX)
Guard-GND
Prompt-Y3-in
Prompt-Y5-in
HD-RET-F-in
HD-RET-C7-in
HD-RET-C9-in
HD-RET-H-in
HD-RET-C3-in
HD-RET-C5-in
HD-RET-CLK-in
HD-RET-Y7-in
HD-RET-Y9-in
Guard-GND
HD-RET-Y3-in
HD-RET-Y5-in
TRUNK1(RX)-in
Guard-GND
(reserve-TX)
GND
GND
Front-PIX(X)-in
4A
Ether-COM-TR(Y)-out 3E
3C
MB-GND
TRIAX/Co-AX(BNC) -out 3A
2E
Ether-COM-RC(X)-in
2C
MB-GND
2A
MIC2-(Y)-out
1E
Ether-COM-RC(Y)-in
1C
Rear-Alarm-NG/OK-in
1A
MIC1-(Y)-out
11E
PROD-OUT(X)-out
11C
ANA1(TEMP-Level)-in
11A
PROD-OUT(X)-in
10E
ENG-OUT(X)-out
10C
MB-GND
10A
ENG-IN(X)-in
9E
WFM-Recall(1R)-out
ANA0(DPR-Level)-in
9C
9A
WFM-Recall(4Q)-out
8E
RED-Tally-(X)-in
8C
AUX3
8A
GREEN-Tally-(X)-in
7E
WFM-Recall(5E)-out
7C
ANA2(TEMP-Level)-in
WFM-Recall(8GB)-out 7A
6E
YELLOW-Tally-(X)-in
6C
TALLY-GND
6A
GREEN-TALLY-Rear-out
5E
Ether +3.3V
5C
(reserve)
YELLOW-TALLY-Rear-out 5A
Ether-COM-TR(X)-out 4E
4C
MB-GND
Prompt-C2-out
Prompt-C4-out
16D
16B
GND
Unreg-GND
PROD-OUT(Y)-in
PROD-OUT(Y)-out
15D
15B
Prompt-C6-out
Prompt-C8-out
17D
17B
GND
25C
25A
PGM2-IN(Y)-out
PGM1-IN(Y)-out
11D
11B
17E
HD/SD-SYNC(X)-out
17C
(NC)
17A
Rear +5.5V
16E
Aspect-CTL(0)-in
16C
MB-GND
16A
MIC1-CTL-on/off-in
15E
PGM2-IN(X)-in
15C
MB-GND
15A
PGM1-IN(X)-in
CN3
19E (RCP-PWR-NG-Status-in)
(reserve)
19C
19A
ETHERNET-LED-out
18E
MIC-Gain-CTL(0)-in
Cable-OPEN-Status-in 18C
18A
CAM-POWER-Status-in
(reserve)
22C
HD/SD-SDI-RET2-in (Y) 22A
TONE0-DETECT-in
21E
(reserve)
21C
HD/SD-SDI-RET2-in (X) 21A
20E
MIC-Gain-CTL(2)-in
20C
Pre-View (rear)-out
20A
Guard-GND
CS0-out
ADDR(4)-out
18D
18B
11E
11C
11A
10E
10C
10A
9E
9C
9A
8E
8C
8A
7E
7C
7A
6E
6C
6A
5E
5C
5A
4E
4C
4A
3E
3C
3A
2E
2C
2A
1E
1C
1A
6D
6B
(reserve-RX)
TRUNK1(TX)-out
2D
2B
Unreg (+14V)
Unreg (+14V)
23D
23B
22D
22B
21D
21B
20D
20B
Prompter2-(G)-in
Guard-GND
Guard-GND
TONE1-DETECT-out
Guard-GND
Guard-GND
9D
9B
R/Y-R(X)-out
B/Y-B(G)-out
5D
5B
4D
4B
3D
3B
Front-PIX(G)-if
Relay-(PIX,WFM)-out
PIX(X)-out
WFM(G)-out
1D
1B
2D
2B
6D
6B
(HIRA-pin-out)
7D
7B
8D
8B
10D
10B
11D
11B
15D
15B
CN1
G/Y(X)-out
VBS(X)-out
HD/SD-SYNC(G)-if
17D
17B
charge_pump_signal-out
Rear -5V
16D
16B
18D
18B
RCP-COM-RX(Y)-if
19D
19B
24D
24B
Prompter1-(X)-in
Guard-GND
(reserve)
25D
25B
Rear-SEL34 HD/SD-out
Guard-GND
1D
1B
3D
3B
Guard-GND
Guard-GND
MB-GND
MB-GND
4D
4B
Frame-Reset-Gate-in
Guard-GND
5D
5B
7D
7B
15D
15B
Prompt-Y6-in
Prompt-Y8-in
HD-RET-Y2-in
HD-RET-Y4-in
16D
16B
Prompt-C2-in
Prompt-C4-in
8D
8B
17D
17B
Prompt-C6-in
Prompt-C8-in
HD-RET-Y6-in
HD-RET-Y8-in
18D
18B
CS0-in
ADDR(4)-in
9D
9B
19D
19B
ADDR(0)-in
ADDR(2)-in
HD-RET-C2-in
HD-RET-C4-in
20D
20B
BUS(0)-in
BUS(2)-in
10D
10B
21D
21B
BUS(4)-in
BUS(6)-in
HD-RET-C6-in
HD-RET-C8-in
22D
22B
700P-TX-CCU-DATA-in
11D
11B
23D
23B
AUDIO-RX34-AES-out
(reserve)
Prompt-Y2-in
Prompt-Y4-in
24D
24B
AUDIO-TX34-Spare-in
AUDIO-TX-64FS-in
STBY-Incom-TX(to CAM) 25D

25B
MB-GND
CN2:154p,short
Unreg-GND
Unreg-GND
Unreg-GND
Aspect-CTL(1)-out
MIC2-CTL-on/off-out
10D
10B
C-OPEN-STAT
C-SHORT-STAT
CAM-P-STAT
DC/AC
ETHER-LED
IRQ(Torino&Daytona)
23A
Guard-GND
CCU-ID0-in (Pull-Up) 22E
23C
ADDR(0)-out
ADDR(2)-out
19D
19B
UNREG-GND
UNREG-D UNREG
CN1
PROD-OUT(X)-in
PROD-OUT(X)-out
ENG-OUT(X)-in
MB-GND
ENG-IN(X)-out
WFM-Recall(1R)-in
MB-GND
WFM-Recall(4Q)-in
RED-Tally-(X)-out
AUX3
GREEN-Tally-(X)-out
WFM-Recall(5E)-in
WFM-Recall(8GB)-in
YELLOW-Tally-(X)-out
TALLY-GND
GREEN-TALLY-Rear-in
(NC)
(reserve)
TRIAX/Co-AX(BNC) -in
Unreg (+14V)-in
MB-GND
Unreg (+14V)-in
Unreg-Drive (+14V)-in
MB-GND
Unreg (+14V)-in
Unreg-GND
Unreg-GND
YELLOW-TALLY-Rear-in
Rear -5.5V
9D
9B
Aspect-CTL-on/off-out
MIC-Gain-CTL(1)-out
E
8D
8B
7D
7B
6D
6B
5D
5B
4D
4B
25E
BUS(0)-out
BUS(2)-out
20D
20B
5D
5B
BUS(4)-out
BUS(6)-out
21D
21B
CABLE-SHORT-LED-out
GREEN-TALLY-Panel-out
700P-TX-CCU-DATA-out
RCP-COM-RX(X)-in
22D
22B
6D
6B
AUDIO-RX34-AES-in
RCP-COM-RX(Y)-in
23D
23B
STBY-Incom-RX(fr CAM) 25E

25C
MB-GND
25A
MB-GND
24E
AUDIO-TX12-PGM-in
24C
AUDIO-TX56-Incom-in
24A
AUDIO-TX-LRCK-in
23E
AUDIO-RX12-MIC-out
AUDIO-RX56-Incom-out 23C
23A
Chara-Data-in
700P-RX-CAM-DATA-out 22E
22C
22A
Chara-CK-in
21E
RD-in
21C
BUS(5)-in
21A
BUS(7)-in
20E
WR-in
20C
BUS(1)-in
20A
BUS(3)-in
19E
MST-RESET-in
19C
ADDR(1)-in
19A
SCL-in
18E
CPU-CK-in
18C
ADDR(3)-in
18A
SDA-in/out
17E
Prompt-F-in
17C
Prompt-C7-in
17A
Prompt-C9-in
16E
Prompt-H-in
16C
Prompt-C3-in
16A
Prompt-C5-in
15E
Prompt-CLK-in
15C
Prompt-Y7-in
15A
Prompt-Y9-in
UNREG
15E
15C
15A
16E
16C
16A
17E
17C
17A
18E
18C
18A
19E
19C
19A
20E
20C
20A
21E
21C
21A
22E
22C
22A
23E
23C
23A
24E
24C
24A
25E
GND
CN5
1
(25)
COM-TALLY-Rear-in
(NC)
Tally +5.5V-out
Aspect-CTL(0)-out
MB-GND
MIC1-CTL-on/off-out
PGM2-IN(X)-out
MB-GND
PGM1-IN(X)-out
A
1
(25)
3D
3B
REAR view
TRUNK1(RX)
TRUNK2(RX)
GND
TRUNK1(TX)
TRUNK2(TX)
CAM-LED
MAIN-LED
MAIN-Alarm-LED-in
FAN1-ALARM
FAN2-ALARM
RCP-POW-S
C-OPEN-LED
C-SHORT-LED
CABLE-SHORT-LED-in
R-TALLY(F)
G-TALLY(F)
GREEN-TALLY-Panel-in
Y-TALLY(F)
ETHER-LED
CAM-P-STAT
CAM-POWER-Status-out
C-OPEN-STAT
Cable-SHORT-Status-out C-SHORT-STAT
DC/AC
GND
(reserve-RX)
TRUNK1(TX)-in
EXT-Ref(X)-in
CN4
25C PLD-Config-Done in
HD/SD-SDI-RET1-in (Y) 25A
24E
Return1-VBS(G)-in
PLD-ReConfig out
24C
HD/SD-SDI-RET1-in (X) 24A
23E
Return2-VBS(X)-in
GND
MIC-Gain-CTL(0)-out
MODE0
25
(1)
MAIN-Alarm-LED-out
AUDIO-TX34-Spare-out
AUDIO-TX-64FS-out
24D
24B
GND
2D
2B
MB-GND
MB-GND
CN4:154p,short
CAM-LED
MAIN-LED
FAN1-ALARM
FAN2-ALARM
RCP-POW-S
C-OPEN-LED
C-SHORT-LED
R-TALLY(F)
G-TALLY(F)
Y-TALLY(F)
STBY-Incom-TX(to CAM)
MB-GND
25D
25B
GND
CN2
MODE1
1
1D
1B
MB-GND
MB-GND
MB-GND
TRUNK1(RX)-out
MB-GND
(reserve-TX)
CAM-POWER-LED-in
RCP-PWR-OK/NG-out
CABLE-OPEN-LED-in
RED-TALLY-Panel-in
YELLOW-TALLY-Panel-in
ETHERNET-LED-in
Cable-OPEN-Status-out
(POW-UNIT DC/AC-out)
MIC-Gain-CTL(2)-out
Pre-View (rear)-in
1
Guard-GND
Prompt-Y3-out
Prompt-Y5-out
HD-RET-F-out
HD-RET-C7-out
HD-RET-C9-out
HD-RET-H-out
HD-RET-C3-out
HD-RET-C5-out
HD-RET-CLK-out
HD-RET-Y7-out
HD-RET-Y9-out
Guard-GND
HD-RET-Y3-out
HD-RET-Y5-out
CAM-POWER-LED-out
6E
6C
RCP-PWR-OK/NG-in
6A
CABLE-OPEN-LED-out
5E
RED-TALLY-Panel-out
5C
YELLOW-TALLY-Panel-out 5A
4E
External-Ref-SYNC-out
4C
MST-SD-F-out
4A
MST-74M-CLK-out
3E
External-Ref-SC-out
3C
MST-27M-CLK-out
3A
MST-HD-F-out
2E
Unreg (+14V)
2C
Unreg (+14V)
2A
Unreg (+14V)
1E
MB-GND
1C
MB-GND
1A
MB-GND
MB-GND
AUDIO-TX12-PGM-out
AUDIO-TX56-Incom-out
AUDIO-TX-LRCK-out
AUDIO-RX12-MIC-in
AUDIO-RX56-Incom-in
Chara-Data-out
700P-RX-CAM-DATA-in
RCP-COM-TX-out
Chara-CK-out
RD-out
BUS(5)-out
BUS(7)-out
WR-out
BUS(1)-out
BUS(3)-out
MST-RESET-out
ADDR(1)-out
SCL-out
CPU-CK-out
ADDR(3)-out
SDA-out/in
Prompt-F-out
Prompt-C7-out
Prompt-C9-out
Prompt-H-out
Prompt-C3-out
Prompt-C5-out
Prompt-CLK-out
Prompt-Y7-out
Prompt-Y9-out
CN4
STBY-Incom-RX(fr CAM)
MB-GND
GND
1E
1C
1A
2E
2C
2A
3E
3C
3A
4E
4C
4A
5E
5C
5A
6E
6C
6A
7E
7C
7A
8E
8C
8A
9E
9C
9A
10E
10C
10A
11E
11C
11A
A
25
2
CN2
11E
11C
11A
10E
10C
10A
9E
9C
9A
8E
8C
8A
7E
7C
7A
25C
25A
24E
24C
24A
23E
23C
23A
22E
22C
22A
21E
21C
21A
20E
20C
20A
19E
19C
19A
18E
18C
18A
17E
17C
17A
16E
16C
16A
15E
15C
15A
25E
MB-1124 (1/2)
MB-1124 (1/2)
1:DPR-300/SDI-97
1
UNREG-GND
CN1
2:SY-364/VIF-39
UNREG
UNREG-GND
CN3
GND
UNREG-GND
3:CN-3081
4
UNREG-GND
CN5
CN5:154p,short
MB-1124 (1/2)
BOARD NO. 1-879-656-11
HDCU-300_MB-1124_011_1
MB-1124 (2/2)
154p-short
GND
154p-short
1z
CN5
GND
154p-long
CN4
GND
1f
2z
CN4
CN4
GND
GND
1z
MB-1124 (2/2)
154p-short
CN3
GND
1f
2z
CN3
CN3
GND
GND
1z
154p-long
CN2
GND
1z
CN1
1f
2z
CN2
CN2
GND
GND
1f
2z
CN1
CN1
1z
GND
GND
1f
2z
CN5
CN5
GND
GND
GND
GND
2f
3z
CN5
CN5
GND
GND
2f
3z
CN4
CN4
GND
GND
2f
3z
CN3
CN3
GND
GND
2f
3z
CN2
CN2
GND
GND
2f
3z
CN1
CN1
GND
GND
3f
4z
CN5
CN5
GND
GND
3f
4z
CN4
CN4
GND
GND
3f
4z
CN3
CN3
GND
GND
3f
4z
CN2
CN2
GND
GND
3f
4z
CN1
CN1
GND
GND
4f
5z
CN5
CN5
GND
GND
4f
5z
CN4
CN4
GND
GND
4f
5z
CN3
CN3
GND
GND
4f
5z
CN2
CN2
GND
GND
4f
5z
CN1
CN1
GND
GND
5f
6z
CN5
CN5
GND
GND
5f
6z
CN4
CN4
GND
GND
5f
6z
CN3
CN3
GND
GND
5f
6z
CN2
CN2
GND
GND
5f
6z
CN1
CN1
GND
GND
6f
7z
CN5
CN5
GND
GND
6f
7z
CN4
CN4
GND
GND
6f
7z
CN3
CN3
GND
GND
6f
7z
CN2
CN2
GND
GND
6f
7z
CN1
CN1
GND
GND
7f
8z
CN5
CN5
GND
GND
7f
8z
CN4
CN4
GND
GND
7f
8z
CN3
CN3
GND
GND
7f
8z
CN2
CN2
GND
GND
7f
8z
CN1
CN1
GND
GND
8f
9z
CN5
CN5
GND
GND
8f
9z
CN4
CN4
GND
GND
8f
9z
CN3
CN3
GND
GND
8f
9z
CN2
CN2
GND
GND
8f
9z
CN1
CN1
GND
GND
9f
10z
CN5
CN5
GND
GND
9f
10z
CN4
CN4
GND
GND
9f
10z
CN3
CN3
GND
GND
9f
10z
CN2
CN2
GND
GND
9f
10z
CN1
CN1
GND
GND
10f
11z
CN5
CN5
GND
GND
10f
11z
CN4
CN4
GND
GND
10f
11z
CN3
CN3
GND
GND
10f
11z
CN2
CN2
GND
GND
10f
11z
CN1
CN1
GND
11f
CN5
GND
11f
CN4
GND
11f
CN3
GND
11f
CN2
GND
11f
CN1
GND
15z
CN5
GND
15z
CN4
GND
15z
CN3
GND
15z
CN2
GND
15z
CN1
GND
GND
15f
16z
CN5
CN5
GND
GND
15f
16z
CN4
CN4
GND
GND
15f
16z
CN3
CN3
GND
GND
15f
16z
CN2
CN2
GND
GND
15f
16z
CN1
CN1
GND
GND
16f
17z
CN5
CN5
GND
GND
16f
17z
CN4
CN4
GND
GND
16f
17z
CN3
CN3
GND
GND
16f
17z
CN2
CN2
GND
GND
16f
17z
CN1
CN1
GND
GND
17f
18z
CN5
CN5
GND
GND
17f
18z
CN4
CN4
GND
GND
17f
18z
CN3
CN3
GND
GND
17f
18z
CN2
CN2
GND
GND
17f
18z
CN1
CN1
GND
GND
18f
19z
CN5
CN5
GND
GND
18f
19z
CN4
CN4
GND
GND
18f
19z
CN3
CN3
GND
GND
18f
19z
CN2
CN2
GND
GND
18f
19z
CN1
CN1
GND
GND
19f
20z
CN5
CN5
GND
GND
19f
20z
CN4
CN4
GND
GND
19f
20z
CN3
CN3
GND
GND
19f
20z
CN2
CN2
GND
GND
19f
20z
CN1
CN1
GND
GND
20f
21z
CN5
CN5
GND
GND
20f
21z
CN4
CN4
GND
GND
20f
21z
CN3
CN3
GND
GND
20f
21z
CN2
CN2
GND
GND
20f
21z
CN1
CN1
GND
GND
21f
22z
CN5
CN5
GND
GND
21f
22z
CN4
CN4
GND
GND
21f
22z
CN3
CN3
GND
GND
21f
22z
CN2
CN2
GND
GND
21f
22z
CN1
CN1
GND
GND
22f
23z
CN5
CN5
GND
GND
22f
23z
CN4
CN4
GND
GND
22f
23z
CN3
CN3
GND
GND
22f
23z
CN2
CN2
GND
GND
22f
23z
CN1
CN1
GND
GND
23f
24z
CN5
CN5
GND
GND
23f
24z
CN4
CN4
GND
GND
23f
24z
CN3
CN3
GND
GND
23f
24z
CN2
CN2
GND
GND
23f
24z
CN1
CN1
GND
GND
24f
25z
CN4
CN4
GND
GND
24f
25z
CN3
CN3
GND
GND
24f
25z
CN2
CN2
GND
GND
24f
25z
CN1
CN1
GND
25f
CN4
GND
25f
CN3
GND
25f
CN2
GND
25f
CN1
GND
GND
24f
25z
CN5
CN5
GND
25f
CN5
GND
GND
GND
GND
GND
MB-1124 (2/2)
BOARD NO. 1-879-656-11
HDCU-300_MB-1124_011_2
9-53
HSCU-300
9-53
E
SDI-97B
SDI-97B
+5V
THP1
Rear_+5.5V
Q1
2SA1797-T100-Q
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
C6
100pF
b17
R4
220
7
-5V
1.1A/6V
Q2
2SC4672-T100-Q
2
CN921
(51/135)
c17
B-side
C11
4.7uF
6.3V
GND
3
C14
0.1uF
16V
3
C16
47uF
10V
3225
4
5
VDD
CE VOUT
ADJ
GND
2
1
GND
R10
22k
FL201
R11
1k
CN921
(77/135)
CN921
(76/135)
C17
22uF
16V
1
R12
10k
GND
C204 GND
0.1uF
+3.3V
b10
a10
G/Y(X)-in
G/Y(G)-in
R201
100
12
R202
4.7k
1 5 3 4 2
O I LC1 LC2 NC
6
IN 40M
OUT
FG1 G1 G2 G3 FG2
13 7 9 10 14
GND
R203
0
R208
2.2k
NM
R205
100
3
R209
33k
NM
R207
1k
R204
330
GND
GND
C13
22uF
16V
A-side
C15
0.1uF
16V
E2
GND
GND
L202
10uH
C202
4.7uF
-5V
R8
47k
C9
100pF
-5V
CL3
0.8
-5V
+5V
C223
4.7uF
C224
0.1uF
a9
b9
B/B-Y(X)-in
B/B-Y(G)-in
13 7 9 10 14
L11
10uH
R31
7 22
(2/4) R32
6
2 22
C27
22uF
16V
(3/4) R33
5 22
C29
22uF
16V -10V
FB1
SL1
charge_pump_signal_in
R113
680
1
GND
D28
C28 RB706F-40
22uF
16V
GND2
GND2
SC
GND
-5.5V
R109
47
CN921
(7/135)
CN921
(1/135)
a24
a25
HD/SD-SDI1_2(X)-in
HD/SD-SDI1_2(Y)-in
CN921
(13/135)
CN921
(14/135)
CN921
(8/135)
CN921
(2/135)
a23
Guard-GND
Guard-GND
Guard-GND
Guard-GND
b23
b24
b25
1
2
4
R107 10
R103
51
51
5
C101
C103
4.7uF
4.7uF 6
7
8
GND GND
GND
CN921
(5/135)
CN921
(33/135)
CN921
(35/135)
c20
e20
WFM-STAIR-CASE-in
Guard-GND
C150
100pF
NM
IC121 (1/3)
R151 NJM4560M-TE2
100
3
+
1
R159
220
2 -
R160
220
R152
47k
Rear-SEL0-in
IC121 (2/3)
NJM4560M-TE2
C153
0.1uF
16V
CN921
(31/135)
CN921
(32/135)
CN921
(26/135)
CN921
(20/135)
6 -
R111
47
a21
a22
HD/SD-SDI3_4(X)-in
HD/SD-SDI3_4(Y)-in
a20
Guard-GND
Guard-GND
Guard-GND
Guard-GND
b20
b21
b22
GND
IC121(3/3) V+
NJM4560M-TE2 V-
R123
430
NM
C111
4.7uF
1
2
3
4
5
6
R131
430
NM
GND R128 GND

0
R124
430
NM
1
2
4
R108 10
R104
51
51
5
C102
C104
4.7uF
4.7uF 6
7
8
GND GND
GND
GND
CN921
(4/135)
d25
R106
100
Rear-SEL1-in
-5V
R132
430
NM
GND
GND
GND
C243
4.7uF
L241
10uH
FB104
C110
4.7uF
C108
4.7uF
FB102
GND
GND
C244
0.1uF
GND
C106
R118
4.7uF 9
L104
75
GND
4.7nH
VCC
12
SDI
SDO
R122
11 R116
75
68
SDI
SDO
102
RSET
13
SD/HD NC5
L102
14
4.7nH
NC1
NC6
15
NC2
NC7
R120
16
68
NC3
NC8
17
NC4 NC(TM)
VEE
GND
3
IC102
C114
4.7uF
R129
0
R125
430
NM
C112
4.7uF
1
2
3
4
5
6
R133
430
NM
GND R130 GND

0
R126
430
NM
FL241
CN2
CN921
(85/135)
CN921
(86/135)
d9
e9
R/R-Y(X)-in
R/R-Y(G)-in
GND
R242
4.7k
1 5 3 4 2 GND
O I LC1 LC2 NC
12
6
IN 40M
OUT
FG1 G1 G2 G3 FG2
R241
100
13 7 9 10 14
GND
R134
430
NM
GND
GS1578ACNE3
R112
47k
C154
0.1uFGND2
16V
-10V
L222
10uH
C222
4.7uF
CN1
+5V
R114
680
CN921
(25/135)
CN921
(19/135)
001
001
GND
+3.3V
001
001
+14V
R127
0
+3.3V
NM
NM
R165 C155 GND
1.5k 15pF
GND
C113
4.7uF
GND
Stair_CASE(X)
GND
B/B-Y(X)-out
GND
R232
1k
C221
0.1uF
GS1578ACNE3
STAIR
CL151
0.8
R233
75
1.4Vp-p
B/B-Y
CL221
0.8
NM
NM
R234 C225 GND
1.5k 15pF
GND
C105
R117
L103
4.7uF 9
75
GND
4.7nH
VCC
12
SDI
SDO
R121
11 R115
75
68
SDI
SDO
101
RSET
13
SD/HD NC5
L101
14
4.7nH
NC1
NC6
15
NC2
NC7
R119
16
68
NC3
NC8
17
NC4 NC(TM)
VEE
GND
3
IC101
R110
47k
R158
6.8k
R155
330
R153
4.7k
GND
e25
R105
100
GND
0.6V
IC221 (1/2)
AD8014ARTZ-REEL7
R226
0
FB103
C109
4.7uF
C107
4.7uF
FB101
3
+ V+
R229
4.7k
NM
4 - VR227 R230
68
1k
R224
330
R243
0
R248
6.8k
NM
R245
100
3
R249
4.7k
NM
R244
330
IC241 (1/2)
AD8014ARTZ-REEL7
IC11 (1/4)
TC7WH04FK(TE85R)
R225
100
+ V+
4 - VR250
68
R247
1k
R246
0
GND
R/R-Y
CL241
0.8
R253
75
R/R-Y(X)-out
GND
R252
1k
8
4
C24 C23
4.7uF 0.1uF
6.3V 16V
d17
+3.3V
A-side
-10V
CL30
0.8
GND
GND
R223
0
GND GND
+3.3V
IC11(4/4)
TC7WH04FK(TE85R)
VCC
GND
1 5 3 4 2 GND
O I LC1 LC2 NC
12
6
IN 40M
OUT
FG1 G1 G2 G3 FG2
R221
100
R228
6.8k
NM
5
CN921
(82/135)
CN921
(83/135)
+5.5V
R222
4.7k
FL221
GND
CN921
(52/135)
001
001
NM
NM
R214 C205 GND
1.5k 15pF
B-side
E1
C1
47uF
25V
G/Y(X)-out
GND
R212
1k
L221
10uH
R30
10k
R29
1k
GND
C201
0.1uF
225mAmax
R28
1k
G/Y
CL201
0.8
R213
75
1.4V
0.6V
IC201 (1/2)
AD8014ARTZ-REEL7
+ V+
4 - VR210
68
R206
0
GND
+14V +14V
CL1
0.8
L1
10uH
Rear_+14V
-5.5V
IC3
R1173H001D-T1-F
L2
10uH
R7
47k
IC1(2/3) 5
NJM062V(TE2)
D2
UDZSTE-174.7B
THP2
VOUT VIN
C10
4.7uF
6.3V
- 6
C7
100pF
Rear_-5.5V
C12
22uF
16V
R9
47k
R6
22k
C5
47uF
10V
3225
C3
0.1uF
16V
R5
22k
C8
100pF
3
+
- 2
GND
CN921
(50/135)
+5V
1.3Amax
D1
UDZSTE-174.7B
R3
220
1
C4
47uF
10V
3225
C2
0.1uF
16V
V+
V4
CN921
(126/135) c2
CN921
(120/135) c3
CN921
(114/135) c4
CN921
c5
(108/135)
CN921
c6
(102/135)
CN921
c7
(96/135)
CN921
c8
(90/135)
CN921
c9
(84/135)
CN921
(78/135) c10
CN921
(63/135) c15
CN921
(57/135) c16
IC1(1/3)
NJM062V(TE2)
+5V
a17
+3.3V
CL4
0.8
+5.5V
CN921
(49/135)
+5V
CL2
IC2
ADR381ARTZ-REEL7 0.8
C203
4.7uF
L201
10uH
1.1A/6V
001
001
NM
NM
R254 C245 GND
1.5k 15pF
C241
0.1uF
GND
L242
10uH
C242
4.7uF
GND
-5V
GND
L261
10uH
+5V
+5V
5
GND
L262
10uH
6
7
IC261(2/2) NM
AD8014ARTZ-REEL7
-5V
GND
VCC IC141(3/3)
R157
C157 C156
10k 4.7uF
SN75158PSR
0.1uF GND
6.3V 16V
IC141(1/3)R161 22
SN75158PSR
R162 22
C262
0.1uF
V+ 16V
C263
V- 0.1uF
16V
C261
0.1uF
IC141 (2/3)
SN75158PSR
L151
10uH
+5V
+3.3V
Q3
2SC4617TL-QR
-0.9V
R24
22k
RCP-COM-TX(X)-if
2
1
R25
47k
R22
10k
R23
10k
a19
+5V
R21
47k
CN921
(37/135)
GND
C21
0.1uF
16V
Q3
R26
100
rear_alarm-out
c1
L152
10uH
C151
4.7uF
6.3V
R154R156
6.8k6.8k
CN921
(132/135)
R27
47k
CN921
(43/135)
a18
RCP-COM-RX(X)-if
CN921
(44/135)
b18
RCP-COM-RX(Y)-if
8
VCC
1
2
4
3
RCP-COM-TX(X)-out
RCP-COM-TX(Y)-out
R163 22
R164 22
001
001
CN921
(61/135)
CN921
(62/135)
a15
b15
100
HD/SD-SYNC(X)-if
HD/SD-SYNC(G)-if
R166 220
R168 47
R263
0
R167 220 R169 47

C152
33pF
RCP-COM-RX(X)-in
001
RCP-COM-RX(Y)-in
001
4 -
R262
330
GND
SYNC
CL261
0.8
IC261 (1/2)
R261 AD8014ARTZ-REEL7
R264
1k
R265
0
R268
75
HD/SD-SYNC(X)-out
001
GND
001
R267
1k
NM
NM
R266 C264 GND
1.5k 15pF
GND GND
PH141
HCPL-0630-500 5
GND
GND
-10V
9-54
A
9-54
HSCU-300
SDI-97B
L301
C302
V+ 0.1uF
16V
V- NM
d15
e15
GND
R310
100
R301
100
VBS(X)-in
VBS(G)-in
4 -
R304
47k
NM
R306 R308
1k
22
R316
1k
R320 C309
1.5k 15pF GND
NM
NM
IC302(1/2)
FL301
1
IN 10M OUT
GND
3 4 5 6
R311
100
4 -
R305
470
R302
1k
1
2
3
4
5
6
AD8014ARTZ-REEL7
R334
75
C308
15pF
NM
R315
680 NM
R307 R309
1k
22
R333
75
C307
15pF
NM
R314
680 NM
R312
1k
R303
220
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
IC301 (1/2)
AD8014ARTZ-REEL7
3
+
C306
4.7uF
6.3V
-5V
CN3
GND
R313
1k
GND
R318
1k
R332 C310
1.5k 15pF GND
NM
NM
R327
100
FL321
R323
220
R322
1k
IN 10M OUT
GND
3 4 5 6
+
R324
470
R330
1k
NM
NM
R329 C321 GND
1.5k 15pF
R353
100
FL341
R345
220
R344
1k
IN 10M OUT
GND
3 4 5 6
2
R348
470
IC341(2/2)
IC342(2/2)
AD8014ARTZ-REEL7 AD8014ARTZ-REEL7
100
001
001
L343
10uH
C347
4.7uF
6.3V
001
001
PIX(X)-out
GND
CN921
(129/135)
CN921
(117/135)
CN921
(105/135)
CN921
(93/135)
CN921
(81/135)
CN921
(69/135)
CN921
(67/135)
CN921
(60/135)
CN921
(48/135)
CN921
(36/135)
CN921
(24/135)
CN921
(12/135)
001
001
RCP-PIX
CL362
0.8
R367
1k
NM
NM
R366 C361 GND
1.5k 15pF
RCP-PIX(X)-out
GND
Prompter1(X)-out
Prompter1(G)-out
4 -
Relay-(PIX_WFM)-in
+5V
CN921
b4 (113/135)
GND
WFM(X)-out
GND
PIX(X)-out
001
001
001
001
PROMPTER1(X)-out
GND
PROMPTER2(X)-out
GND
001
001
001
001
R/R-Y(X)-out
GND
G/Y(X)-out
GND
B/B-Y(X)-out
GND
HD/SD-SYNC(X)-out
GND
RCP-PIX(X)-out
GND
001
001
001
001
001
001
001
001
001
001
Stair_CASE(X)
GND
WFM-SEQ1-ON/OFF-in
RCP-COM-RX(X)-in
RCP-COM-RX(Y)-in
c18
001
001
RCP-COM-TX(X)-out
RCP-COM-TX(Y)-out
001
001
001
001
CN921
(45/135)
CN921
(10/135)
CN921
(11/135)
CN921
(135/135)
f1
SHIELD
CN921
(123/135)
f3
SHIELD
CN921
(111/135)
f5
SHIELD
CN921
(99/135)
f7
SHIELD
CN921
(87/135)
f9
SHIELD
CN921
(75/135)
f11
SHIELD
CN921
(68/135)
f13
SHIELD
CN921
(66/135)
f15
SHIELD
CN921
(54/135)
f17
SHIELD
CN921
(42/135)
f19
SHIELD
CN921
(30/135)
f21
SHIELD
CN921
(18/135)
f23
SHIELD
CN921
(6/135)
f25
SHIELD
CN921
(133/135)
CN921
(127/135)
CN921
(115/135)
CN921
(109/135)
CN921
(103/135)
CN921
(97/135)
CN921
(91/135)
CN921
(79/135)
CN921
(73/135)
CN921
(58/135)
CN921
(46/135)
CN921
(40/135)
CN921
(34/135)
CN921
(28/135)
CN921
(22/135)
CN921
(134/135)
CN921
(128/135)
CN921
(116/135)
CN921
(110/135)
CN921
(104/135)
CN921
(98/135)
CN921
(92/135)
CN921
(80/135)
CN921
(74/135)
CN921
(59/135)
CN921
(53/135)
CN921
(47/135)
CN921
(41/135)
CN921
(29/135)
CN921
(23/135)
d1
d2
d4
d5
d6
d7
d8
d10
d11
d16
d18
d19
d20
d21
d22
e1
e2
e4
e5
e6
e7
e8
e10
e11
e16
e17
e18
e19
e21
e22
(reserve)
(TONE1-DETCT-out)
(HIRA-pin-in)
(NC)
CN921
(130/135)
CN921
(124/135)
CN921
(112/135)
CN921
(106/135)
CN921
(100/135)
CN921
(94/135)
CN921
(88/135)
CN921
(70/135)
CN921
(55/135)
CN921
(131/135)
CN921
(125/135)
CN921
(107/135)
CN921
(101/135)
CN921
(95/135)
CN921
(89/135)
CN921
(71/135)
CN921
(56/135)
CN921
(38/135)
CN921
(72/135)
CN921
(39/135)
CN921
(27/135)
CN921
(21/135)
CN921
(15/135)
CN921
(9/135)
CN921
(3/135)
a1
a2
a4
a5
a6
a7
a8
a11
a16
b1
b2
b5
b6
b7
b8
b11
b16
b19
c11
c19
c21
c22
c23
c24
c25
(HIRA-pin-in)
Front-PIX(X)-if
(HIRA-pin-in)
3
Front-PIX(G)-if
(HIRA-pin-in)
(ANA0(DPR-Level)-out)
(reserve)
(reserve)
(reserve)
IRQ(Torino&Daytona)
(PLD-Reconfig-in)
(PLD-Config-Done-out)
RCP-POW-NG-Status-if
(TONE0-DETCT-out)
GND
L501
10uH
+5V
R505
330
R507
1k
NM
NM
R506 C501 GND
1.5k 15pF
d24
e24
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
001
001
GND
R508
330
GND
R2 0
GND
PIX
CL361
0.8
R369
75
R1 0
GND
Relay-(PIX_WFM)-in
+5V
WFM(G)-out
WFM(X)-out
PIX(G)-out
PIX(X)-out
GND
Prompter1(X)-in
Prompter1(G)-in
Prompter2(X)-in
Prompter2(G)-in
GND
R/R-Y(X)-out
R/R-Y(G)-out
Y(X)-out
Y(G)-out
B/B-Y(X)-out
B/B-Y(G)-out
HD/SD-Sync(X)-out
HD/SD-Sync(G)-out
RCP-PIX(X)-out
RCP-PIX(G)-out
GND
Stair-case(X)-out
Stair-case(G)-out
WFM-CONT(X)-out
RCP-COM-RX(X)-out
RCP-COM-RX(Y)-out
GND
RCP-COM-TX(X)-out
RCP-COM-TX(Y)-out
GND
36 35 34
WFM(X)-out
GND
IC501 (1/2) 0.8

AD8014ARTZ-REEL7
+
R504
1k
R503
47
WFM
CL321
0.8
PRMPT1
CL501
R509
100
PROMPTER1(X)-out
GND
4 R365
1k
5
-5V
R362
47k R363 R364
NM
1k
22
GND
C325
4.7uF
6.3V
R371
75
IC342 (1/2)
R361 AD8014ARTZ-REEL7
C341
4.7uF
6.3V
V+ C348
V- 0.1uF
16V
NM
L322
10uH
R356
1k
NM
NM
R355 C345 GND
1.5k 15pF
+
C349
0.1uF
16V
NM
GND
4 R354
1k
C342
0.1uF
V+ 16V
C346
V- 0.1uF
16V
R331
75
R349 R352
1k
22
L341
10uH
-5V
IC341 (1/2)
AD8014ARTZ-REEL7
3
+
GND
+5V
C326
IC321(2/2) 0.1uF
16V
AD8014ARTZ-REEL7 NM
4 R328
1k
R341
100
PIX(X)-in
PIX(G)-in
R325 R326
1k
22
GND
CN921
(121/135) d3
CN921
(122/135) e3
IC321 (1/2)
AD8014ARTZ-REEL7
C323
0.1uF
V+ 16V
V- C324
0.1uF
16V
R321
100
WFM(X)-in
WFM(G)-in
C322
4.7uF
6.3V
L321
10uH
5
+5V
CN921
(118/135) a3
CN921
(119/135) b3
R9064
CN10
C304
0.1uF
16V
L302
10uH
CN921
(64/135)
CN921
(65/135)
C303
4.7uF
6.3V
V+
V- C305
0.1uF
16V
C301
0.1uF
16V
NM
10uH
IC302(2/2) +5V
AD8014ARTZ-REEL7
IC301(2/2)
AD8014ARTZ-REEL7
SDI-97B
C505
IC501(2/2)
AD8014ARTZ-REEL70.1uF
16V
-5V
001
001
R529
100
PROMPTER2(X)-out
GND
IC521 (1/2)
AD8014ARTZ-REEL7
3
+
PRMPT2
CL521
0.8
R528
330
R524
1k
R523
47
R521 R522
22k 68
GND
+5V
e23
d23
CN921
(17/135)
CN921
(16/135)
L521
10uH
C525
0.1uF
IC521(2/2)
16V
AD8014ARTZ-REEL7 NM
C523
0.1uF
V+ 16V
V-
GND
SDI-97B
GND
R525
330
R527
1k
NM
NM
R526 C521 GND
1.5k 15pF
C504
0.1uF
16V
L502
10uH
Prompter2(X)-out
Prompter2(G)-out
4 -
GND
NM
C503
V+ 0.1uF
16V
V-
R501R502
GND 22k 68 GND
-5V
L522
10uH
C524
0.1uF
16V
BOARD NO. 1-879-657-11

HDCU-300_SDI-97B_011_1
9-55
HSCU-300
9-55
M
SY-364 (1/11)
R1511 33k
C1509 100pF
R1513
10k
RUN/SS BOOST
TG
PGOOD
VRNG
SW
FCB
PGND
BG
ITH
SGND INTVCC
ION
VIN
VFB
EXTVCC
R1524
1M
C1504
0.01uF
R1525
47k
16
15
14
13
12
11
10
9
C1522
0.1uF
FB1502
S
1 2 3
FB1503
8 7 6 5
C1541
L1502 100uF
10V
10uH
R1555
22
3225
FB1521
FB1522
FB1523
C1546
47uF
10V
R1540 2.2
R1541 2.2
C1520
0.1uF 25V
1608
R1534
2.2k
+5.5V
R1554
22
3225
0.02_0.12 ohm at DC
30 ohm at 100MHz
max1500mA
C1555
47uF
25V
0.5A/24V
THP955
R1542
2.2 3225
C1552
10uF
10V
3216
C1501
0.1uF 1608
R1627
0
1608
NM
UNREG-VOLT-Sense
R1630
4.7M
NM
R1526
4.7M
R1505
22k
1
2
3
4
5
6
7
8
R1506
22k
C1502
680pF
C1507
100pF
R1519
22k
R1514
220k
C1512
470pF
C1514
0.1uF
R1515 R1520
0
220k
C1535
47uF
10V
3225
FB1500
C1517
22pF
R1532
220k
R1538
470k
SVIN
PVIN2
PGOOD
SW4
ITH
SW3
VFB
PGND2
RT
PGND1
SYNC/MODE SW2
RUN/SS
SW1
SGND
PVIN1
NC(TM)
17
16
15
14
13
12
11
10
9
C1529
10uF C1531 C1533
L1501 10V 100uF 100uF
1uH 3216 10V
10V
R1545
2.2
3225
3216
FB1512
THP952
C1544
0.1uF
16V
FB1513
FB1515
R1510
22k
C1503
1000pF
C1508
100pF
NM
C1510
0.1uF
R1527
0
C1515
10uF
10V
3216
R1528
220k
CL1506 -12.5V
1.2
C1595
0.01uF
25V
C1591
47uF
16V
GND
C1596
0.01uF
25V
- 6
R1583
47k
C1583
100pF
NM
Q1504
2SC4672-T100-Q
0.5A/24V
-12.5V
0.5A/24V
3
D1509
DA221-TL
IC1508
L1504
LT1931ES5#TR 10uH
5
4
VIN
SW
SHDN
NFB
GND
2
C1560
1uF
25V
3216
R1517
100k
NM
C1574
47uF
10V
IC1512 (3/3)
NJM4558V-TE2
R1557
2.2
3225
C1557
470pF
R1558
10k
GND
CL1508
1.2
-12V
-12V
CL1509
1.2 +5V
+5V-2
C1584
100pF
C1565
0.1uF
16V
C1570
100uF
10V
C1576
100pF
C1566
0.1uF
16V
C1571
100uF
10V
C1577 100pF
5
+
C1585
0.1uF
- 6 16V
C1580
2.2uF
50V
V+
V-
L1506
10uH
R1560
1k
IC1512(1/3)
NJM4558V-TE2
3
L1508
10uH
R1577
47k
R1579
47k
R1578
47k
+5V-A
R1584
47k
L1509
10uH
C1592
0.1uF
16V
C1593
0.1uF
16V
- 2
R1565
220
D1508
UDZSUSTE-174.7B
C1586
100pF
NM
R1585
47k
C1597
100uF
10V
C1598 GND
100uF
10V
L1510
10uH
THP958
R1562
22k
CL1505
1.2
C1562
220pF
-5.5V
-5.5V
1.1A/6V
+5V
-5V-A
Q1506
2SC4672-T100-Q
CL1510 -5V
1.2
-5V
Vo=-(1.255V/10k+4uA)*33k-1.255V
=-5.53V
THP953
C1536
47uF
10V
3225
IC1512 (2/3)
NJM4558V-TE2
D1504
RB160M-60TR
R1507
100
NM
Q1505
2SA1797-T100-Q
D1507
UDZSUSTE-174.7B
R1564
220
7
3
ITH SHDN/RT
VFB SYNC/MODE
PGOOD
SGND
SVIN
SW
PVIN
PGND
R1567
220
D1506
UDZSUSTE-174.7B
GND
C1553
10uF
10V
3216
(fext=1.28MHz)
C1611
0.1uF
16V
GND
IC1504
LTC3411EMS#TR
R1523
4.7M
R1563
6.8k
C1590
47uF
16V
R1576
10k
THP957
+5.5V
FB1501
10
9
8
7
6
IC1500(1/3)
NJM4558V-TE2
R1582
47k
1.1A/6V
1.1A/6V
C1516
22pF NM
R1529 R1533 R1539
33k
220k
22k
C1579
100pF
R1580
47k
C1581
2.2uF
50V
THP960
NM
C1561
220pF
R1553
10k
C1511
0.1uF
GND
C1569
47uF
25V
C1587
0.1uF
16V
(-1.255V-Vo)/R1=1.255V/R2+4uA
Vo=-(1.255V/R2+4uA)*R1-1.255V
=-(1.255V/10k+4uA)*86.8k-1.255V
=-12.50V
fosc=3.23e11/(220k+22k+10k)
=1.28MHz
Vout=0.8V(1+(470k+220k)/220k)
=3.309V
5
3
2 4
R1508
100
L1505
10uH
C1547
47uF
10V
3225
C1525
10uF
10V
3216
IC1503 (1/2)
IC1503 (2/2)
IC1505 (1/2)
IC1505 (2/2)
TC7SZ04FU(TE85R)
TC7SZ04FU(TE85R)
4
C1564
0.01uF
25V
C1578
100pF
IC1500 (3/3)
NJM4558V-TE2
R1556
2.2
3225
C1556
470pF
R1559 R1561
33k
47k
THP956
R1509
33k
SW
V+
V-
+3.3V
CL1500
1.2 +3.3V
FB1514
C1527
680pF
C1526
47uF
10V
3225
GND
VCC
GND
VIN
SHDN
NFB
GND
2
R1552
10k
R1548
1k
VCC
GND
C1575
0.01uF
25V
C1573
22uF
16V
3225
C1568
47uF
25V
R1575
4.7k
3
+
GND
C1524
10uF
10V
C1518
0.1uF
THP951
IC1502
LTC3412EFE#TR
R1522
4.7M
D1503
RB160M-60TR
C1559
1uF
25V
3216
IC1507
L1503
LT1931ES5#TR 10uH
1.1A/6Vx2
007
C1582
100pF
- 2
C1563
0.01uF
25V
+12V
R1574
33k
IC1500 (2/3)
NJM4558V-TE2
D1505
UDZSUSTE-174.7B
R1566
220
1
GND
Q1501
HAT2070R-EL
+12V
CL1507
1.2
Q1503
2SA1797-T100-Q
THP959
C1636
0.1uF 16V
NM
C1513
0.0022uF
0.5A/24V
UNREG
C1551 C1554
0.1uF 0.1uF
16V
16V
FB1524
FB1525
FB1526
FB1527
C1543
C1539
100uF
47uF
10V
10V
D1502
RB160L-40TE25
S
1 2 3
+5.5V
CL1504
1.2
C1550
100uF
10V
4.8A
C1519
10uF
10V
R1531
1k
R1530
10k
FB1520
R1504 0
R1623
100
C1506
470pF
1
2
3
4
5
6
7
8
FB1529
8 7 6 5
C1521
0.1uF
C1505
0.1uF
FB1528
C1542
10uF
25V
C1538
47uF
25V
IC1501
LTC1778EGN
Unreg
CL1502
1.2
C1540
10uF
25V
C1537
47uF
25V
D1501
RB706F-40
1
2
3
R1516 R1518
100k 100k
NM
R1631
22k
FB1504
R1503
1M
Q1512
2SC4617TL-QR
Q1500
HAT2070R-EL
f=5.5V/(0.7V*10pF*1001k)=785kHz
Vout=0.8V*(1+(47k+10k+2.2k)/10k)=5.53V
FB1506
FB1508
FB1510
R1502
1M
FB1505
FB1507
FB1509
FB1511
SY-364 (1/11)
1
2
3
4
5
C1523
680pF
R1546
100k
R1547
220k
+1.8V
R1602 100k
NM
C1528 C1532 C1534

10uF 100uF 100uF
10V
3216 10V 10V
L1500
4.7uH
R1543
2.2
3225
FB1516
FB1517
FB1518
CL1501
1.2
C1548
47uF
10V
3225
+1.8V
1.1A/6V
THP967
1.1A/6V
THP950
IC1506
R1173H001D-T1-F
3
FB1519
4
VDD
5
CE VOUT
GND
ADJ
GND
2
C1530
10uF
6.3V
2012
GND
Vout=0.8V(1+(220k+33k+22k)/220k
=1.800V
fint=(9.78e11/(220k+100k))^0.926
=1011kHz
R1549
4.7k
R1550
4.7k
R1551
4.7k
IC1515
R1173H001D-T1-F
4
3
VDD
5
CE VOUT
+1.5V +1.5V
CL1503
1.2
C1640
10uF
6.3V
2012
C1549
10uF
6.3V
2012
GND
ADJ
GND
2
R1638
10k
R1639
680
R1640
4.7k
+3.3V
+3.3V-2
CL1514
1.1A/6V
THP961
L1507
10uH
+3V-T
1.1A/6V
+5.5V
THP962
+5V-T
L1511
10uH
+3.3V-2
1.2
C1588
47uF
10V
C1641
10uF
6.3V
2012
GND
Vout=1.0V*(1+(10k+0.68k)/4.7k)
=3.27V
C1589
0.1uF
16V
C1594
0.1uF
16V
C1599
47uF
10V
C1600
0.1uF
16V
C1601
0.1uF
16V
GND
Vout=1.0V*(1+4.7k/(4.7k+4.7k))
=1.5V
GND
9-56
A
9-56
HSCU-300
SY-364 (1/11)
1.5A/24V
Unreg
Unreg
Unreg
Unreg
Unreg
UNREG
THP954
C1558
47uF
25V
R1568
10k
R1637
0
R1634
10k
- 2
R1625
10k
R1609
100k
NM
IC1513
LTC1778EGN
1
2
3
4
R1606 33k 5
6
7
C1617 100pF
8
R1608
10k
R1605
0
R1607
100
C1616
470pF
PANEL-EXIST/NONE
C1614
0.01uF
R1612
47k
16
RUN/SS BOOST
15
TG
PGOOD
14
SW
VRNG
13
FCB
PGND
12
BG
ITH
11
SGND INTVCC
10
ION
VIN
9
VFB
EXTVCC
R1611
1M
C1621
0.1uF
THP964
C1624
47uF
25V
C1628
10uF
25V
S
1 2 3
FB1530
C1627
L1516 100uF
10uH
10V
C1630
47uF
10V
FB1531
Q1511
HAT2070R-EL
R1617 2.2
C1620
0.1uF
25V
R1615
2.2k
8 7 6 5
4
S
1 2 3
CN102
(1/135)
CN102
(2/135)
CN102
(3/135)
CN102
(4/135)
CN102
(5/135)
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
a1
b1
c1
d1
e1
MB-GND
MB-GND
MB-GND
CN101
c3 (15/135)
CN101
c4 (21/135)
CN101
c16 (78/135)
+5.0V
CL1513
1.2
C1631
100uF
10V
FB1544
FB1545
FB1546
FB1547
C1629
C1625
47uF
100uF
10V
10V
D1512
RB160L-40TE25
CN101
(4/135)
d1
CN101
(16/135)
d3
CN101
(22/135)
CN101
(19/135)
CN101
(20/135)
C1602
47uF
10V
Rear +5.5V
Rear -5.5V
(NC)
C1603
47uF
10V
C1633
0.1uF
16V
GND
0.02_0.12 ohm at DC
30 ohm at 100MHz
max1500mA
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
12
24
36
48
60
72
84
96
108
120
132
144
C1638 0.1uF
R1618
2.2
3225
NM
C1618
0.0022uF
C1613
0.1uF
1608
R1628
0
1608
NM
GND
-5.5V
CN101
(6/135)
f1
SHIELD
CN101
(18/135)
f3
SHIELD
CN101
(30/135)
f5
SHIELD
CN101
(42/135)
f7
SHIELD
CN101
(54/135)
f9
SHIELD
CN101
(66/135)
f11
SHIELD
CN101
(68/135)
f13
SHIELD
CN101
(75/135)
f15
SHIELD
CN101
(87/135)
f17
SHIELD
CN101
(99/135)
GND
GND
(NC)
GND
Front-Inc-VR
+3.3V
MIC-on
PGM-on
Front-INC-PROD
Front-Inc-ENG
DISP-on
MENU-on
MENU-Clear
MENU-Enter
MENU-LED
GND
Front-Talk(x)
Front-Talk(y)
GND
Front-RCV
Front-PGM
INCOM-G0
INCOM-G1
INCOM-UNBAL
INCOM-PW
Front-ENC(ENT)
Front-ENC(A)
Front-ENC(B)
GND
GND
Front-Inc-VR
009
MIC-ON/OFF
009
PGM-ON/OFF
009 FRONT-INC-PRIV/PROD
009 FRONT-INC-PRIV/ENG
009
DISP-on
009
MENU-on
009
MENU-Clear
009
MENU-Enter
009
MENU-LED
L1513
10uH
THP969
1.1A/6V
CN101
(12/135)
CN101
(24/135)
CN101
(36/135)
CN101
(48/135)
CN101
(60/135)
CN101
(67/135)
CN101
(69/135)
CN101
(81/135)
CN101
(93/135)
CN101
(105/135)
CN101
(117/135)
CN101
(129/135)
007
C1604 C1605
0.1uF 10uF
GND
(NC)
GND
GND
THP965
L1512 +5.5V
10uH
a4
b4
1.1A/6V
+3.3V
1.1A/6V
THP968
d4
CN101
(82/135) a17
CN101
(83/135) b17
CN101
(84/135) c17
+5V-P
C1632
0.1uF
16V
CN1:From/To Front Panel(AU-321)
CN101:From/To MB-1124(CN3)
CN102
(7/135)
CN102
(8/135)
CN102
(9/135)
CN102
(10/135)
CN102
(11/135)
FB1549
FB1540 NM
FB1541 NM
FB1542
FB1543
4.8A
C1619
10uF 3216
R1616 2.2
a2
b2
c2
d2
e2
GND
FB1548
4
C1622
0.1uF
C1626
10uF
25V
C1623
47uF
25V
8 7 6 5
R1614
1k
R1613
3.3k
(+14V)
(+14V)
(+14V)
(+14V)
(+14V)
1.5A/24V
Q1510
HAT2070R-EL
D1511
RB706F-40
1
2
3
R1610
100k
C1615
0.1uF
GND
Q1509
DTC114EE-TL
007,009
R1586
1M
f=5.5V/(0.7V*10pF*1001k)
=785kHz
Vout=0.8V*(1+(47k+3.3k+2.2k)/10k)
=5.0V
R1635
22k
R1636
22k
C1635
0.01uF
22k
Q1513
2SC4617TL-QR
6 -
IC1514(1/3)
NJM2903V(TE2) R1633
R1570
1M
NJM2903V(TE2)
3
+
V+
GND
FB1534
FB1536
FB1538
C1637
0.1uF
25V
1608
FB1532
R1624
10k
IC1514 (2/3)
FB1533
FB1535
FB1537
FB1539
8
R1632
10k
C1567 C1572
0.01uF 0.01uF
25V
25V
IC1514 (3/3)
NJM2903V(TE2)
D1513
UDZSUSTE-174.7B
SY-364 (1/11)
003
003
FRONT-TALk(X)
FRONT-TALK(Y)
003
003
009
009
009
009
009
007
007
FRONT-RCV
FRONT-PGM
INCOM-G0
INCOM-G1
INCOM-UNBAL
INCOM-PW
Front-ENC(ENT)
Front-ENC(A)
Front-ENC(B)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
CN1
(1/31)
CN1
(2/31)
CN1
(3/31)
CN1
(4/31)
CN1
(5/31)
CN1
(6/31)
CN1
(7/31)
CN1
(8/31)
CN1
(9/31)
CN1
(10/31)
CN1
(11/31)
CN1
(12/31)
CN1
(13/31)
CN1
(14/31)
CN1
(15/31)
CN1
(16/31)
CN1
(17/31)
CN1
(18/31)
CN1
(19/31)
CN1
(20/31)
CN1
(21/31)
CN1
(22/31)
CN1
(23/31)
CN1
(24/31)
CN1
(25/31)
CN1
(26/31)
CN1
(27/31)
CN1
(28/31)
CN1
(29/31)
CN1
(30/31)
31 32
f19
SHIELD
CN101
(111/135) f21
SHIELD
CN101
(123/135) f23
SHIELD
CN101
(135/135) f25
SHIELD
GND
GND
VOUT VIN
R1604
0
C1610
0.1uF
GND
3
NM
R1601
1k
NM
GND
+5.5V
R1581
10k
R1572
15k
3
C1639
1uF
+1.5V
R1591
15k
(1.34V)
(1.47V)
R1593
4.7k
3
+
2 -
5
5
(1.17V)
R1573
47k
R1589
15k
V+
GND
GND
6 R1621
220k
R1592
47k
E1500 E1501 E1502 E1503
V+
GND
IC1510(3/3)
NJM2903V(TE2)
-12V
UNREG
(Audio)
009
Q1508
2SC4617TL-QR
R1595
22k
R1599
10k
(SIDE-B)
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
12
24
36
48
60
72
84
96
108
120
132
144
-5V
OPTION PANEL
-12.5V
LT1931
E1504 E1505
+5.5V
LTC1778
HAT2070
HAT2070
GND
6 -
+5V
LTC1778
HAT2070
HAT2070
-5.5V
LT1931
GND
PWR-OK/NG
R1598
10k
C1634
1uF
(1.16V)
+
CN102
(12/135)
CN102
(24/135)
CN102
(36/135)
CN102
(48/135)
CN102
(60/135)
CN102
(67/135)
CN102
(69/135)
CN102
(81/135)
CN102
(93/135)
CN102
(105/135)
CN102
(117/135)
CN102
(129/135)
R1600
10k
R1597
2.2k
R1594
15k
+
-12.5V
(SIDE-A)
(P.S) (Digital) (RET)
CN2:From/To Option Panel(SW-1413)

(Revissed 2008/07/04)
R1622
470
(1.34V)
(1.16V)
CN102:From/To MB-1124(CN4)
+3.3V
IC1510 (2/3)
NJM2903V(TE2)
IC1510 (1/3)
NJM2903V(TE2)
R1590
470
R1588
47k
+
- 2
IC1511 (1/3)
NJM2903V(TE2)
IC1511 (3/3) IC1511 (2/3)

NJM2903V(TE2) NJM2903V(TE2)
CL1511
1.2
+2.5V-REF
Q1507
2SC4617TL-QR
IC1509
ADR381ARTZ-REEL7
2SA1797
NJM4558
2SC4672
+12V
2SA1797
NJM4558
2SC4672
+5V,+5V-2,
+5V-A
R1173
+3.3V-2
-12V
CN102
(6/135)
f1
SHIELD
CN102
(18/135)
f3
SHIELD
CN102
(30/135)
f5
SHIELD
CN102
(42/135)
f7
SHIELD
CN102
(54/135)
f9
SHIELD
CN102
(66/135)
f11
SHIELD
CN102
(68/135)
f13
SHIELD
CN102
(75/135)
f15
SHIELD
CN102
(87/135)
f17
SHIELD
CN102
(99/135)
f19
SHIELD
CN102
(111/135) f21
SHIELD
CN102
(123/135) f23
SHIELD
CN102
(135/135) f25
SHIELD
1.1A/6V x2
THP963
C1606
0.1uF
C1608
10uF
009 PANEL_3V_REG_ON/OFF-out
009
PNL-IIC-SCL
009
PNL-IIC-SDA
009
PANEL-ID-in
007
PNL-ASSIGN-VR-in
007
PNL-BLACK-B-in
007
PNL-BLACK-R-in
007
PNL-WHITE-B-in
007
PNL-WHITE-R-in
007 PNL-MASTER-BLACK-in
007
PNL-IRIS(DC1)-in
-5V,-5V-2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
CN2
(1/31)
CN2
(2/31)
CN2
(3/31)
CN2
(4/31)
CN2
(5/31)
CN2
(6/31)
CN2
(7/31)
CN2
(8/31)
CN2
(9/31)
CN2
(10/31)
CN2
(11/31)
CN2
(12/31)
CN2
(13/31)
CN2
(14/31)
CN2
(15/31)
CN2
(16/31)
CN2
(17/31)
CN2
(18/31)
CN2
(19/31)
CN2
(20/31)
CN2
(21/31)
CN2
(22/31)
CN2
(23/31)
CN2
(24/31)
CN2
(25/31)
CN2
(26/31)
CN2
(27/31)
CN2
(28/31)
CN2
(29/31)
CN2
(30/31)
31 32
(GEN-LOCK)
GND
REAR
+5V-T
+3V-T
THP966
+5V-P
GND
Analog
GND
GND
GND
GND
GND
GND
GND
GND
N.C
+5.5V-out
+5.5V-out
+5.5V-out
+5.5V-out
+5.5V-out
+5.5V-out
+5.5V-out
N.C
PANEL-RESET
IIC-SCL-out
IIC-SDA-out
Panel-ID
ASSIGN-VR
BLACK-B
BLACK-R
WHITE-B
WHITE-R
GND
MASTER-BLACK
IRIS
GND
Tally
LTC3412
+3.3V
R1173
INDEX
1/11(SA2):POWER SUPPLY
2/11(SA2):GEN-LOCK
3/11(SA1):STBY/FP
4/11(SA1):PGM/MIC
5/11(SA1):PROD/ENG
6/11(SA1):TALLY
Digital
+1.8V
LTC3411
+1.5V
7/11(SA2):CPU/MEMORY
8/11(SA2):CMD/PHY/IO
9/11(SA2):SY-PLD
10/11(SA2):RETURN-IN
11/11(SA2):RET-PLD
SY-364 (1/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_1
9-57
HSCU-300
9-57
M
R13
47k
R23
220
L2
10uH
-5V
R34
2.2k
R56
470 2 -
C41
220pF
C35
10pF
R58
4.7k
SPECIAL-BB
GND
C9
0.1uF
VIN
R62
4.7k
RSET
R100
2.2k
RB1
100
2
4
6
8
i_SD-TEMP-SYNC
i_SD-TEMP-V
009
009
i_SD-TEMP-H
009
BP
C6
47uF
6.3V
C22
22uF
6.3V
C36
GND
47uF
6.3V
L11
10uH
L8
10uH
R103
10
IC30 (2/3)
TLC272CPWR-12
C61
22uF
6.3V
GND
L18
10uH
6 -
R51
3.3k
-5V
R102
1k
R98
2.2k
C25
0.1uF
C67
0.01uF
R101
47
R97
100
GND
C62
0.1uF
C60
22uF
6.3V
V_SYNC
GND
4
R70
680k
1
3
5
7
H_SYNC
6
-5V
009
C42
0.1uF
-5V
009
+5V-2
C63
0.1uF
R24
100
R18
2.2k
C15
22uF
6.3V
C16
0.1uF
C17
22uF
6.3V
Q2
2SC4617TL-QR
R26
2.2k
C18
0.1uF
R35
10
R27
2.2k
L5
10uH
R94
100
R95
100
HD-SYNC-OE
11
10
13
12
R46
100
009
SD-PEDE-CLIP
PEDE CLP
R14
100
+5V-2
L12
10uH
+
C19
1000pF
C37
0.1uF
6 R41
330
C39
22uF
6.3V
R49
10
SYNC CLP
R15
100
C26
0.1uF
14
+5V-2
VCC
GND
L6
10uH
R28
15k
R31
47
GND
C23
100pF
R5
1k
D1
RB706F-40
3
2
1
R6
100
R29
1k
IC39 (2/3)
2
15
0
COM
1
1
10
SEL
+5V-2
L14
10uH
002
IN+
INOE
4
OUTGND
5
H_SYNC
6
C166
5
0.1uF VCC
4
1
2
R140
100k
R137
470k
RSET
BP
R147
100
NM
R148
100
HD-TEMP-H
009
HD-TEMP-V
009
3
V_SYNC
GND
C106
4
0.1uF
GND
3 H:ON
L:OFF
R149
100
PA2 R125
100
REF-SEL(SD/HD24p)
PA3 R124
100
REF-SEL(SD/HD60i)
009
PA3 PA2 Rset
L
L 680k SD
L
H 374k 24, 25PsF
H
L 310k 60i, 50P
H
H 226k 60P
D4
Q5
2SA1226-T1E3E4 DA221-TL
R66
2.2k
GND
R69
15k
2 -
VEE
7
C176
0.1uF
-5V
R76
3.3k
C54
0.1uF
FILM
V+
R72 GND
330k
IC31 (3/3)
D3
DA221-TL
IC40
(1/3)
1
T1
C56
47uF
6.3V
NM
R79
10k
C59
150pF
15
T1
R80
100
11
12
IC40 (3/3)
TC74HC4538AFT(EL)
C58
10uF
35V
IC31 (2/3)
TLC272CPWR-12
C171
0.1uF
R83
4.7k
R81
10k
R82
100
R78
6.8k
TLC272CPWR-12
C45 R67 C50

0.1uF 10k 0.1uF
FILM
FILM
R55
100
R50
100
16
VCC
14
COM
IC31 (1/3)
TLC272CPWR-12
C43
0.47uF
AL
R71
22k
R68
22k
R60
22k
IC49 (2/7)
TC74VHCT04AFT(EKJ)
12
0
13
1
11
SEL
6
INH
GND
8
IC33 (2/3)
TLC272CPWR-12
+
4
1
R139
150k
8
1
VCC
C_SYNC
C77
0.1uF
C46
0.1uF
SD-H-PHASE
IC33(3/3)
IC39 (1/3)
74VHC4053MTCX TLC272CPWR-12
8
C177
0.1uF
VCC
6
OUT+
R118
680k
5
VCC
VIN
009
CN102
(23/135)
C44
47uF
6.3V
OE GATE
SD-REF-GATE
IC1
TL712CPSR
C32
0.1uF
C29
10uF
6.3V
C2
0.1uF
OUTGND
5
R59
10k
GND
V+
GND C28
0.1uF
-5V
009
R110
3.3k
C76
0.1uF
-5V
e4
External-Ref-SYNC-out
IC32(3/3)
TLC272CPWR-12
GND
+5V-2
R75
47
GND
VCC
GND
5
4
2
T2 6
Q
CD
3
C57
0.1uF
14
T2 10
Q
CD
13
R86
2.2k
IC40
(2/3)
6 -
IC49 (7/7)
TC74VHCT04AFT(EKJ)
R136
680k
C90
0.1uF
V+
GND C172
0.1uF
IC6
TC7SET04FU(T5RSOJF)
R1
100
C97
1uF
GND
3 H:ON
L:OFF
L21
10uH
IC49 (3/7)
TC74VHCT04AFT(EKJ)
SD-SYNC-CLIP
INOE
R54
4
4.7k
C33
100pF
+5V-2
8
VCC
6
OUT+
IN+
4
5
0
COM
3
1
9
SEL
IC15
GS4981CTAE3
IC25
TC7S66FU(TE85R)
IC13
TC7S66FU(TE85R)
IC3
TL712CPSR
R42
47
IC32 (1/3)
R43
TLC272CPWR-12 220
3
+
1
C20
1000pF 2 -
R122
47
GND
IC32 (2/3)
TLC272CPWR-12
15
2
0
COM
1
1
10
SEL
R127
4.7k
-5V
C74
0.1uF
C69
22uF
6.3V
3 1
R16
100
C86
5pF
IC35 (3/3)
TLC272CPWR-12
7
OUTGND
5 C91
0.1uF
GND
Q7
2SC4617TL-QR
R105
4.7k
CN102
(17/135)
+5V-2
R40
100
IC38 (2/3)
IC38 (3/3)
009
e3
External-Ref-SC-out
INOE
4
+5V-2
22uF
6.3V
C53
0.1uF
R74
100
2
V+
GND
VCC
6
OUT+
IN+
C87
22pF
R106
47
GND C71
o_EXT-REF-SYNC
C173
0.1uF
C174
0.1uF
R226
100
R52
2 100
009
C175
0.1uF -5V
IC49 (4/7)
R73
47
GND
IC49 (1/7)
TC74VHCT04AFT(EKJ)
16
12
VCC
14
0
COM
13
1
11
SEL
6
INH
GND VEE
8
7
R2 TC74VHCT04AFT(EKJ)
100
9
8
SD-BURST-GATE
009
IC38 (1/3)
74VHC4053MTCX
3 1
OUTGND
5
R123
47
6 -
PEDE CLP
IC4
TC7SET04FU(T5RSOJF)
R63
10k
IC12
TL712CPSR 8
R104
100
BURST GATE
GND
+5V-2
INOE
R48
4
4.7k
C27
100pF
R36
10
-5V
C1
0.1uF
IN+
R57
10k
VCC
6
OUT+
C100
0.1uF
C98
47uF
6.3V
GND
R25
100
+
C73
0.1uF
5
A
2
INH
GND
IC49 (5/7)
TC74VHCT04AFT(EKJ)
HD-PEDE-CLIP
C48+5V-2
0.1uF
IC2
TL712CPSR 8
R45
10
R30
10
C66
0.01uF
L20
10uH
C31
0.1uF
CH1
R130
10k
IC35 (2/3)
TLC272CPWR-12
-5V
L9
10uH
C30
22uF
6.3V
Q1
2SC4617TL-QR
L4
10uH
L19
10uH
8
1
VCC
CH0 COMMON
GND
IC10
TC7W53FK(TE85R)
VEE
3
IC49 (6/7)
TC74VHCT04AFT(EKJ)
+5V-2
+5V-2
+5V-2
8
1
VCC
C_SYNC
16
C4
22uF
6.3V
R65
470
C49
0.1uF
C38
220pF
R33
100
C47
0.1uF
R64
470
R10
1.5k
R22 SD-REF
47
EXT-Ref(G)-in
L13
10uH
R39
10
IC30 (1/3)
TLC272CPWR-12
C7
47pF
4 -
C10
10pF
C11
22pF
SD-TEMP-REF
R53
470
HD-REF
R21 47
R47
100
R37
2.2k
C24
0.1uF
V+
GND
C21
22uF
6.3V
Q4
2SC4617TL-QR
Q6
2SA1774TL-QR
L17
10uH
1
3
R8
470
C14
R11
3.3k NM 5pF
NM
+
R3
680
CN101
(133/135) d25
L3
4.7uH
R12
4.7k
R9
100
L7
10uH
R17
100
+5V-2
C55
0.1uF
50i:min 150mV
60i:min 150mV
R4
330
EXT-Ref(X)-in
V+
V-
+5V-2
IC28 (1/2)
AD8014ARTZ-REEL7
C34
47uF
6.3V
CN101
(134/135) e25
IC28(2/2)
AD8014ARTZ-REEL7
C8
0.1uF
Q3
2SA1774TL-QR
IC5
GS4981CTAE3
IC30 (3/3)
TLC272CPWR-12
C40
0.1uF
C3
22uF
6.3V
L10
10uH
C5
47uF
6.3V
L1
10uH
+5V-2
TP1
+5V-2
Master-Ref
SY-364 (2/11)
SY-364 (2/11)
+3.3V-2
IC37 (5/5)
SN74LVC125APWR-12
L15
C52
10uH 0.01uF
-5V
R227
100
C13
0.1uF 6 -
PEDE CLP
IC37
(4/5)
12
11
13
SP-BB-FRAME
C51
22uF
6.3V
009
GND
14
VCC
GND
7
IC37
(2/5)
6
GND
R19
1k
IC39 (3/3)
R7
100
4
5
0
COM
3
1
9
SEL
NM
2 C12
0.1uF
R44
15k
NM
R32
3.3k
R20
22k
R61
100
SD-REF-IN-INT/EXT
009
3
2
D2
DAP222-TL
IC33 (1/3)
TLC272CPWR-12
SYNC CLP
-5V
GND
9-58
A
9-58
HSCU-300
SY-364 (2/11)
+3.3V-2
IC41 (3/3)
TC74HC4538AFT(EL)
R156
100
IC44 (1/2)
TC7SH32FU(T5RSOYJF)
GND
R157
2
1
100
5
47k 47k
DAC-SDA-PLD-out
DAC-SCL-PLD-out
DAC-LD-PLD-out
R199
100
R200
R201
100
100
9
8
7
11
10
LTC1664IGN#TR
16
VCC
2 R212
100
DIN VOUTA
3 R213
100
SCK VOUTB
4
CS/LD VOUTC
5
CLR VOUTD
12
DOUT
NC1
13
NC2
14
REF
NC3
15
NC4
GND
1
HD-H-PHASE
SD-H-PHASE
+3.3V-2
SD-ANA-SYNC
HD-ANA-SYNC1
HD-ANA-SYNC2
009
009
009
002,009
REF-SD/HD
R219
R220
R221
10 1
10 3
10 5
9
11
13
14
VCC
1A
1Y
2A
2Y
3A
3Y
4A
4Y
5A
5Y
6A
6Y
GND
7
GND
1.5k
1.5k
1.5k
2 R222
4 R223
6 R224
8
10
12
C151
10uF
6.3V
V+
V-
C167
0.1uF
C178
10pF
NM
R84
100
7
5
C179
10pF
11
NM
12
C168
0.1uF
C1B
INH
R1
R2
C147
5pF
L35
10uH
C149
10pF
R230 R234 R237

220 220 10k
3
+
C150
100pF
4 -
R242
150 NM
R243
330
IC29 (1/2)
AD8014ARTZ-REEL7
CN101
d17 (85/135)
GND
8
R112
4.7k
5
A
2
INH
GND
4
C89
22uF
6.3V
CH1
3
R121
22k
2 -
R126
2.2k
VEE
3
C81
10uF
C83
10uF
C82
10uF
C88
0.1uF
C84
10uF FILM
C92
0.1uF
CH1
VEE
3
C79
0.1uF
FILM
GND
2
1
5
A
2
INH
GND
4
R144
10k
C101
22uF
6.3V
C102
0.1uF
R142
4.7k
V+
GND
R138
1k
C99
1uF
R143
10k
R133
47k
5
+
C103
10pF
X1
27MHz
IC34 (3/3)
TLC272CPWR-12
C94
1000pF
IC8 (1/2)
TC7SH32FU(T5RSOYJF)
R85
100
R132
47k
8
7
1
VCC
CH0 COMMON
VC
4
VDD
GND
2
R176
10
OUT
C104
10pF
C105
10pF
IC16
TC74LCX04FT(EKJ)
R151
22k
TP4
C165
14 0.1uF
VCC
1
2
1A
1Y
3
4
2A
2Y
R152 10
5
6
3A
3Y
9
8
4A
4Y
11
10
5A
5Y
12
13
6Y
6A
GND
R150
7
10k
R153 10
IC34 (2/3)
TLC272CPWR-12
C107
10uF
27M
+3.3V-2
R159
100
R160
10
R16110
L27
10uH
27MHz-PLD-CLK
27MHz-RET-PLD-CLK
IC27(1/2)
IC48 (2/2) TC7SZ00FU(TE85R)
TC7SZ00FU(TE85R)
009
FB1
FB2
C115
1uF
C117
1uF
R171
R247
10k
011
C111
10uF
VCC
GND
10
VCC
GND
2
1
R172
2.2k
b4
+3.3V-2
L38
10uH
MST-HD-F(MAIN)
R231
100
C154
22uF
6.3V
C156
14 0.1uF
VCC
5
1D
1Q
1PR
6
1CK 1Q
1CLR
9
2Q
2D
R236
10
2
4
3
1
12
10
2PR
11
8
2CK 2Q
13
2CLR
GND
7
R245
10
MST-HD-F-out
a3
CN102
(13/135)
GND
C124
22uF
6.3V
C128
0.01uF
14
VCC
5
1D
1Q
1PR
6
1CK 1Q
1CLR
9
2Q
2D
R179
10
MST-SD-F-out
c4
CN102
(21/135)
2PR
8
2CK 2Q
2CLR
GND
7
IC48 (1/2)
TC7SZ00FU(TE85R)
4
CN102
(20/135)
GND
4
2
1
Guard-GND
CN102
(14/135)
CN102
(19/135)
IC26
TC74LCX74FT(EKJ)
TP7
2
4
3
1
12
10
11
13
a4
IC47(2/2)
TC7SZ00FU(TE85R)
IC46(2/2)
L29
10uH
b3
MST-74M-CLK-out
FB3
GND TC7SZ00FU(TE85R)
TP5
R174
100
D8
DA221-TL
011
Guard-GND
IC47 (1/2)
TC7SZ00FU(TE85R)
+3.3V-2
009 MST-SD-F(MAIN)
L24
10uH
2
1
IC19
TC74LCX74FT(EKJ)
SD-F
007
L23
10uH
R225
10
HD-F
C155
0.1uF
C153
10uF
CN101
(86/135)
HD/SD-SYNC(G)-out
011
C146
C148
VCC 1uF VCC 1uF
GND
GND
FB4
e17
74MHz-RET-CLK
R228
2.2k
C144
0.1uF
IC51 (2/2)
TC7SZ00FU(TE85R)
HD/SD-SYNC(X)-out
011
R246
10
C157
0.5pF
NM
R240
1k
009
74MHz-RET-CLK-output
R239
1k
R235
47
3
R109
2.2k
9
VCOIN
10
DEMO
15
PC3O
8
1
7
VCC
COMMON CH0
+3.3V-2
L34
10uH
C143
10uF
009
R92
100
+3.3V-2
IC34 (1/3)
TLC272CPWR-12
C93
0.1uF
R209
10k
IC29(2/2)
AD8014ARTZ-REEL7
R238
15k
C152
0.1uF
GND
R218 10
IC50(2/2)
C145
0.1uF
74MHz-PLD-CLK
74MHz-RET-PLD-CLK
R216 10
2
1
L40
10uH
C161
10uF
3
C65
0.1uF
007
C78
0.1uF
D5
DA221-TL
+3.3V-2
GND
REF-HD/SD
10
C64
22uF
6.3V
002,009
IC37
(3/5) R93
100
IC11
TC7W53FK(TE85R)
16
3
VCC
CIN
1
4
PCPO
VCOUT
2
14
SIN
PC1O
13
6
C1A
PC2O
2
1
L36
10uH
IC24
TC74LCX04FT(EKJ)
002
002
IC14
TC7W53FK(TE85R)
2
1
IC51(1/2)
TC7SZ00FU(TE85R) IC46 (1/2)
TC7SZ00FU(TE85R)
R217 10
C163
C164
VCC 1uF VCC 1uF
GND
GND
SD-PLL-VOLT
L22
10uH
R215 10
IC50(1/2)
TC7SZ00FU(TE85R)
R203
10k
+3.3V-2
R99
4.7k
R214 10
IC43 (1/2)
TC7SZ00FU(TE85R)
R193
100
R210
100
GND
27M-PLL-REF
27M-PLL-VAR
R211
10k
C162
0.1uF
009
R196
47k
2
4
6
8
10
12
-5V
R90
100
2
1
R195
33k
L31
1uH
L37
10uH
R87
IC37 (1/5)
4.7k
SN74LVC125APWR-12
NM
R96
R88
R91
4.7k
100 2
100
3
1
R89
100
R208
47
VCC
GND
R107
22k
C68 C70
0.1uF 10uF
R108
10k
009
C135
10pF
L30
1uH
GND
GND
27M FREQ
RV1
5k
OUT
HD-PLL-VOLT
IC9
MC74HC4046ADTR2
IC7
TC7SET08FU(T5RSOJF)
4
VDD
C134
10pF
C131
1000pF
C125 C127
0.1uF0.1uF
FILM FILM
GND
L16
10uH
VC
GND
X2
2
74.175824MHz
R181
47k
IC22
+5V-2
+5V-2
C140
0.1uF
R205
47k
R185
10k
OUT
2
1
+3.3V
GND
GND
R182
1k
GND
2
X3
74.25MHz
C139
22uF
6.3V
+5V R206
R207
009
009
009
L32
10uH
C110
0.1uF
+5V-2
C121 C122
0.1uF 10uF
C109 IC42(5/5)
0.01uF SN74LVC125APWR-12
14
IC42
IC42
VCC (2/5)
(4/5)
C108
6 12
11
5
22uF
GND
6.3V
13 C114
4
7
0.1uF
VCC
GND
VEE
3
5
A
2
INH
GND
4
4
VDD
C141
0.1uF 14
VCC
1
1A
1Y
3
2A
2Y
5
3A
3Y
9
4A
4Y
11
5A
5Y
13
6Y
6A
GND
7
IC44 (2/2)
TC7SH32FU(T5RSOYJF)
L25
10uH
+5V-2
2 -
CH1
VC
R202
100
R184
10k
IC18
FILM 6.3V
TC7W53FK(TE85R)
VEE
3
GND
IC45(2/2)
TC7SET08FU(T5RSOJF)+3.3V-2
R197
10k
R194
100
GND
IC17
8
MC74HC4046ADTR2
REF-SD/HD
002,009
002,009
REF-HD/SD
HD-REF-IN-INT/EXT
009
CH1
5
A
2
INH
GND
4
6
R177
R175 2.2k
33k
C123
10uF
6.3V
R189
10k
R187
100k
GND
C158
1uF
9
VCOIN
10
DEMO
15
PC3O
8
8
1
7
VCC
COMMON CH0
R191
C142
10uF
C133
1uF
GND 100k
IC36 (1/3)
TLC272CPWR-12
8
1
VCC
CH0 COMMON
R183
4.7k
R180
47k
C130
0.1uF
IC20
TC7W53FK(TE85R)
C120
0.1uF
C132
1uF
R198
D10 100k
DA221-TL
2
1
7
C1B
5
INH
11
R1
12
R2
10
D9
DA221-TL
IC21 (1/2)
TC7SZ00FU(TE85R)
IC23
TC74LCX04FT(EKJ)
C138
0.1uF
R163
100
L33
10uH
IC42
(3/5)
R155
100
74M-PLL-REF
+3.3V-2
R170
2.2k R173
16
2.2k
3
VCC
CIN
1
4
PCPO
VCOUT
2
14
SIN
PC1O
13
6
C1A
PC2O
R162
100
IC45(1/2)
TC7SET08FU(T5RSOJF)
009
6 -
R166
4.7k
TP6
R204 R77
10k 100
74M-PLL-VAR
C119
10uF
6.3V
74M-CK
IC21(2/2)
009
R165
4.7k
+5V-2
2
1
R190
4.7k
C169
0.1uF
R154
100
R186
4.7k
IC42
R158 (1/5) R164

100 2
3 100
C160
1uF
C159
VCC 1uF VCC
GND
GND
R192
2.2
R188
2.2
(2/3)
IC36
TLC272CPWR-12
V+
GND
C118
0.1uF
R169
10k
Q10
2SA1774TL-QR
C75
0.1uF
FILM
R168
10k
Q9
2SA1774TL-QR
FB5
CD
13
C116
0.1uF
IC36 (3/3)
TLC272CPWR-12
C129
0.1uF
C126
22uF
6.3V
IC43(2/2)
TC7SZ00FU(TE85R)
C137
0.1uF
R131
100 11
12
C113
22uF
6.3V
R145
1k
14
T2 10
Q
15
T1
L28
10uH
R167
10k
R146
4.7k
NM
C96
150pF
+3.3V-2
L26
10uH
1000/1001
1001/1000
C80
0.1uF
FILM
CD
3
+5V-2
IC41
(2/3)
5
4
009
009
16
8
D6
DA221-TL
FILM
R115
10k
R120
330k
R135
100
2
T2 6
Q
1
T1
C85
0.1uF
VCC
GND
1
3
R129
6.8k
IC41 (1/3)
TC74HC4538AFT(EL)
C72
0.47uF
AL
2 -
R117
15k
R141
4.7k
R116
22k
R111
22k
R134
10k
C95
10uF
35V
R119
IC35 (1/3)
22k
TLC272CPWR-12
3
R128
+
3.3k
1
D7
Q8
2SA1226-T1E3E4 DA221-TL
R114
2.2k
L39
10uH
C136
10uF
HD-H-PHASE
002
SY-364 (2/11)
R178
10
MST-27M-CLK-out
c3
Guard-GND
d3
CN102
(15/135)
CN102
(16/135)
IC27 (2/2)
C112
GND 0.1uF TC7SZ00FU(TE85R)
6 -
IC8 (2/2)
TC7SH32FU(T5RSOYJF)
5
+3.3V
SY-364 (2/11)
C170
0.1uF
VCC
GND
BOARD NO. 1-879-650-11
GND
HDCU-300_SY-364_011_2
9-59
HSCU-300
9-59
M
SY-364 (3/11)
(For PROD/ENG)
+3.3V-A2
IC309
NJM2878F3-33(TE2)
GND
2
NC
+3.3V-A
R384
100k
+
R385
100k
C370
0.47uF
C369
0.1uF
IC303 (2/3)
NJM2732RB1(TE2)
7
R386
10
(For PROD/ENG)
+1.65V-2
(203.5mVpp)
(Inverted)
STBY_AD
6 C372
10uF
NM
Q312
DTC114EE-TL
NC
C300
0.1uF
GND
2
R315
100k
3
+
R316
100k
C301
0.47uF
2 -
C302
0.1uF
GND
V+
GND
R318
10
(For FP,ST-B,PGM)
+1.65V
R360
47k
C348
1000pF
R391
22k
C346
470pF
V+
GND
R362
2.2k
D300
DA221-TL
STBY-Incom-RX(fr-CAM)
e25
CN102
(134/135)
MB-GND
c25
CN102
(132/135)
STBY-Incom-TX(to-CAM)
d25
CN102
(133/135)
R364
6.8k
IC304 (3/3)
NJM2732RB1(TE2)
IC303 (1/3)
NJM2732RB1(TE2)
C307
1uF
R329
0
R325
10
C308 C310
0.1uF 10uF
AD/DA-RST
2
4
6
8
- 6
CL303
1.2
(fr DPR-300)
C362
0.1uF
C357
0.1uF
C352
0.1uF
R357
22k
+3.3V
C305
10uF
004,005,008
1
3
5
7
C312
10uF
IC304 (1/3)3
NJM2732RB1(TE2)
R351
22k
GND
NM
C317
0.1uF
C306
1uF R321 100
DA-STBY/*
AD-STBY/FP
AD/DA-64FS1
AD/DA-256FS1
AD/DA-LRCK1
R328
100
C367
0.1uF
009
009
009
009
009
- 2
IC303 (3/3)
NJM2732RB1(TE2)
IC304
NJM2732RB1(TE2)
(168mVpp)
7
C319
10uF
R320
100
IC301
AK4552VT-E2
4
5
VD 16
1 VA
RIN
ROUT
2
15
LIN
LOUT
C334
1000pF
C326
1uF
(192.5mVpp) R334
22k
(Inverted)
14
PDN
VCOM
DEM0
DEM1
SDTI
SDTO
BCLK
MCLK
LRCK
VSS
C324
C321
3
2.2uF
10pF
50V
C313
C315
0.0022uF 0.0022uF
R323
0
R346
22k
3
+
R333
100k
13
6
7
9
8
12
11
10
RB301
100
R335
22k
C347
220pF
R331
10
(10KHz)
CL302
1.2
6 -
2 -
C335
470pF
(220mVpp)
STBY_TX
R347
3.3k
R344
22k
7
IC305 (1/3)
NJM2732RB1(TE2)
R345
100
IC305 (2/3)
NJM2732RB1(TE2)
C331
0.1uF
C328
0.1uF
R359
2.2k
IC305 (3/3)
V+ NJM2732RB1(TE2)
GND
C330
10uF
C303
1uF
NM
NM
R300
22k
NM
Q313
Q314
DTC114EE-TL DTC114EE-TL
NM
R306
22k
NM
NM
Q303
2SA1774TL-QR
Q308
2SC4213-AB-TE85L
GND
(to DPR-300)
C358
1uF
AL-C
R355
22
R307
22k
NM
8
NM
CTL
(2/3)
R327
22k
(220mVpp)
STBY_RX
(-2.3dB, 130Hz--12kHz)
Q311
DTC114EE-TL
VOUT
R304
47k
NM
R302
47k
VIN
R319
10
(1.68dB)
R383
22k
+1.65V
(For FP,ST-B,PGM)
+3.3V-A
R322
4.7k
CL300
1.2
C371
0.1uF
IC300
NJM2878F3-33(TE2)
C366
1000pF
CTL
VOUT
VIN
+5.5V
SY-364 (3/11)
NM
NM
NM
Q305
DTC114EE-TL
Short|Open |Tone |STB-ICM

-----+-----+-----+------L | L | L | ON
H | X | X | MUTE
X | H | X | MUTE
X | X | H | MUTE
Short:STBY/Normal
H:CABLE-SHORT
009
Open:Normal/Open
H:CABLE-OPEN
009
Tone:Normal/STBY
TONE-DETECT
009
AD STBY FP-talk
DA STBY --(fcH=15.4kHz)
C373
220pF
(203.5mVpp)
(Inverted)
FP_TALK
CL301
1.2
R350
15k
R343
100
R338
10
(fcH=15kHz)
C345
1000pF
C343
470pF
C361
1uF
AL-C
- 6
7
C336
10uF
+
V+
IC306 (2/3) 5
GND NJM2732RB1(TE2)
R363
15k
(from AU-321)
FRONT-TALk(X)
R379
100k
C363
1000pF
R374 R380
680 100k
R371
15k
C365
0.0047uF
C364
1000pF
C374
220pF
001
(210mVpp)
FRONT-TALK(Y)
(from AU-321)
001
- 2
R373
680
C360
1uF
AL-C
R361
15k
R354
15k
R370
15k
C351
470pF
C359
C368 470pF
0.1uF
IC306 (3/3)
NJM2732RB1(TE2)
IC306 (1/3)
NJM2732RB1(TE2)
GND
+3.3V-A
C340
1000pF
(15KHz)
+3.3V
R339
15k
(192.5mVpp)
(Inverted)
R341
15k
7
5
3
1
13
6
7
9
8
12
11
10
8
6
4
2
C322
10pF
RB300
100
C314
C316
0.0022uF 0.0022uF
14
PDN
VCOM
DEM0
DEM1
SDTI
SDTO
BCLK
MCLK
LRCK
VSS
3
R324
0
C323
2.2uF
50V
6 -
2 -
C337
470pF
IC307 (1/3)
C333
0.1uF
R392
680
NJM2732RB1(TE2)
V+
GND
R356
220k
x34.5
5
R352
100
C332
10uF
R366
22
FP-OUT
CL304
1.2
C355
47uF
16V
AL-C
3225
IC308 (2/3)
NJM4556AM-A-TE2
C329
1uF
IC307(3/3)
NJM2732RB1(TE2)
Q317
2SC4213-AB-TE85L
Q309
2SC4213-AB-TE85L
R389
10k
C325
1uF
R372
10k
IC308 (1/3)
Q304
Q306
2SA1774TL-QR 2SA1774TL-QR
R381
100k
NM
R314
22k
GND
(15KHz)
R340
R342
15k
15k
(192.5mVpp)
(Inverted)
C327
0.1uF
R337
100k
5
+
C350
47pF
R390
10k
7
C344 R349
1uF
1k
R388
4.7k
R393
680
2 -
6 -
C338
470pF
NJM2732RB1(TE2)
IC307 (2/3)
Q318
2SC4213-AB-TE85L
C339
0.1uF
R353
100
L301
10uH
R358
220k
x34.5
1
C353
22uF
V+
V-
L
R
AD PGM1
PGM2
DA FP-INCOM FP-PGM
R368
22
C356
47uF
16V
3225
AL-C
IC308 (3/3)
NJM4556AM-A-TE2
R301
22k
R308
10k
R369 PGM-OUT
10k
NM
CL305
1.2
C304
100uF
16V
R311
1M
Q316
DTC114EE-TL
GND
AUDIO-MUTE-CONTROL
004,005
AUDIO-MUTE
008
Q315
GND DTC114EE-TL
-12V
(to AU-321)
FRONT-PGM
(6.6Vpp)
001
R382
100k
NM
Q310
2SC4213-AB-TE85L GND
C354
22uF
GND
R303
22k
GND
Q307
2SA1774TL-QR
+12V
001
+12V
R310
10k
R312
22k
R317
4.7k
NM
NJM4556AM-A-TE2
C341
1000pF
(to AU-321)
FRONT-RCV
(6.6Vpp)
DA-FP/PGM
AD-PGM1/2
AD/DA-64FS2
AD/DA-256FS2
AD/DA-LRCK2
4
5
VD 16
1 VA
RIN
ROUT
2
15
LIN
LOUT
PGM2-AD
PGM1-AD
004
004
009
009
009
009
009
IC302
AK4552VT-E2
C320
0.1uF
R387
4.7k
C309
0.1uF
C311
10uF
C318
10uF
R336
100k
R348
1k
R326
10
NM
+1.65V
C349
47pF
C342
1uF
R330
0
R332
10
L300
10uH
SY-364 (3/11)
-12V
BOARD NO. 1-879-650-11

HDCU-300_SY-364_011_3
9-60
A
9-60
HSCU-300
SY-364 (4/11)
SY-364 (4/11)
IC405 (1/7)
TC74VHCT04AFT(EKJ)
009
PGM1-Level-0/-20dB
009
PGM1-Level-*/+4dB
IC403
TC7W53FK(TE85R)
8
1
7
VCC
COMMON CH0
IC405 (3/7)
IC405 (2/7)
TC74VHCT04AFT(EKJ) TC74VHCT04AFT(EKJ)
CL400
1.2
R408
100
C418
1000pF
(203.5mVpp)
C421
1uF
C416
470pF
CH1
VEE
3
R464
10k
C443
470pF
- 2
1
R438
100
(2/3) IC410
R478
47k
R472
10k
R452 R457 R466

33k 1.5k 470
- 6
7
- 6
5
A
2
INH
GND
R441
4
470
R436
10k
C420
1uF
R428
100k
R426
10k
R424
10k
C405
1uF
PGM1-AD
IC410 (1/3)
NJM4558V-TE2
R479
47k
+4dB:3.5Vpp
0dB:2.2Vpp
-20dB:0.22Vpp
C450
1000pF
R485
2.2k
C430
0.1uF
IC405 (6/7)
TC74VHCT04AFT(EKJ)
PGM2-Level-0/-20dB
009
PGM2-Level-*/+4dB
13
12
11
10
IC405 (4/7)
IC405 (5/7)
TC74VHCT04AFT(EKJ)TC74VHCT04AFT(EKJ)
+3.3V-A
R421
10
8
PGM2-AD
C456
10uF
R513
10
(203.5mVpp)
CL401
1.2
IC406 (1/3)
NJM2732RB1(TE2)
(22kHz)
C419
1000pF
R425
10k
R429
100k
R427
10k
R437
10k
C422
1uF
CH1
VEE
3
R455
47k
+4dB:700mVpp
0dB:440mVpp
-20dB: 44mVpp
R465
10k
C444
470pF
+
5
IC411 (2/3)
NJM4558V-TE2
+5V-A
R453 R459 R467

33k 1.5k 470
R439
100
C431
0.1uF
R486
2.2k
IC411 (1/3)
NJM4558V-TE2
- 2
IC406(3/3)
NJM2732RB1(TE2)
R481
47k
C454
0.0047uF
R494
10k
V+
IC411 (3/3)
NJM4558V-TE2 V-
C441
0.1uF
C448
470pF
C442
0.1uF
C432
0.1uF
CN101
d15 (73/135)
PGM2-IN(Y)-in
R495
10k
3
R477
10k
CN101
(74/135)
+4dB:3.5Vpp
0dB:2.2Vpp
-20dB:0.22Vpp
C452
1000pF
R487
2.2k
e15
PGM2-IN(X)-in
C451
1000pF
GND
14
GND
R480
47k
R473
10k
- 6
7
C417
470pF
- 2
5
A
2
INH
GND
R443
4
470
CN101
c15 (72/135)
MB-GND
GND
-5V-A
R458
330
003
C406
1uF
V+
GND
R442
1.5k
C424
470pF
PGM2_AD
C411
10uF
R407
100
8
7
VCC
COMMON CH0
CN101
(71/135)
C447
470pF
IC404
TC7W53FK(TE85R)
8
b15
PGM1-IN(Y)-in
C440
0.1uF
009
CN101
a15 (70/135)
PGM1-IN(X)-in
C449
1000pF
R493
10k
R476
10k
C439
0.1uF
C453
0.0047uF
R492
10k
V+
C429 IC410 (3/3)
0.1uF NJM4558V-TE2 V-
NJM4558V-TE2
R484
2.2k
003
(22kHz)
IC406 (2/3)
NJM2732RB1(TE2)
R440
1.5k
C423
470pF
+1.65V
R454
47k
+5V-A
C455
10uF
+4dB:700mVpp
0dB:440mVpp
-20dB: 44mVpp
PGM1_AD
R512
10
R456
330
VCC
GND
7
C404
0.1uF
GND
IC405 (7/7)
TC74VHCT04AFT(EKJ)
3
+12V
R411
3.3k
R417
1.5k
C459
4.7uF
C409
0.0022uF
R418
1.5k
R415
3.3k
R432
1k
6 7
+
5
R412
3.3k
IC401
TC7W53FK(TE85R)
R433
100k
IC407 (2/3)
NJM4558V-TE2
R430
47k
C412
1000pF
Q403
DTC114EE-TL
009
8
7
1
VCC
CH0 COMMON
CH1
VEE
3
C433
220pF
R445
10k
5
A
2
INH
GND
4
C445
220pF
R474
22k
2 -
6 -
+
3
NJM4580V(TE2)
IC408 (1/3)
IC408 (2/3)
NJM4580V(TE2)
V-
R448
100
IC408 (3/3)
NJM4580V(TE2) V+
C425
0.1uF
R502
220
1608
R468
22k
R503
220 1608
R488
220 1608
R489
220
1608
R470
100
C436
22uF
16V
R461
10
C426
0.1uF
L:-20dB/H:0dB
MIC1-Level_-20dB/0dB
C435
22uF
16V
R450
22k
R444
NM 470k
C458
4.7uF
-20dB:Gv=0.2(-14dB)
0dB:Gv=2(6dB)
275mx2=550mVpp
DC0V
C415
1000pF
R460
10
R423
3.3k
0dB:1.1Vpp
-20dB:110mVpp
MIC1X
CL402
1.2
Q407
2SC4213-AB-TE85L
R496
10k
R482
10k
Q405
2SC4213-AB-TE85L
AOUT(-)
275mVpp
DC2.5V
R409
10
1
3
5
7
2
4
6
8
SDTI
2
BICK
4
LRCK
7
8
6
5
1
RB400
100
C403
10pF
CCLK
CDTI
CSN
PDN
MCLK
275mx2
=550mVpp
DC0V
C414
1000pF
10
AOUTR+
9
AOUTR-
C462
4.7uF
R413
3.3k
R419
1.5k
C463
4.7uF
C410
0.0022uF
R420
1.5k
R414
3.3k
16
DZFL
15
DZFR
C407
10uF
VSS
13
+
3
R416
3.3k
C413
1000pF
R410
10
GND
DA
MIC1
MIC2
-5V-A
R434
1k
R435
100k
IC407 (1/3)
NJM4558V-TE2
V+
V-
R431
47k
IC407 (3/3)
NJM4558V-TE2
Q404
DTC114EE-TL
8
1
VCC
CH0 COMMON
CH1
VEE
3
R447
10k
5
A
2
INH
GND
4
+
3
NJM4580V(TE2)
IC409 (1/3)
V-
R449
100
R463
10
IC409 (2/3)
NJM4580V(TE2)
IC409 (3/3)
NJM4580V(TE2) V+
C428
0.1uF
R504
220
1608
6 -
R505
220 1608
R490
220 1608
R491
220
1608
R471
100
C438
22uF
16V
CN101
(1/135)
R401
10k
AUDIO-MUTE-CONTROL
003,005
Q400
2SA1774TL-QR
R402
1M
-12V
R475
22k
R469
22k
2 -
a1
R400
10k
C446
220pF
C437
22uF
16V
R451
22k
R446
NM 470k
C427
0.1uF
C408
10uF
009
C434
220pF
IC402
TC7W53FK(TE85R)
2 -
R406
0
14
VDD
12
AOUTL+
11
AOUTL-
R403
22k
Q401
2SA1774TL-QR
-20dB:Gv=0.2(-14dB)
0dB:Gv=2(6dB)
AD/DA-RST
DA-MIC1/2
AD/DA-256FS3
AD/DA-64FS3
AD/DA-LRCK3
R422
3.3k
MIC1-(Y)-out
GND
C400
100uF
16V
GND
R462
0dB:1.1Vpp
-20dB:110mVpp 10
IC400
AK4382AVT-E2
003,005,008
009
009
009
009
R404
22k
R405
4.7k
+5V-A
C402 C401
10uF 0.1uF
CN101
(2/135)
+12V
Q402
2SA1774TL-QR
275mVpp
DC2.5V
b1
R514
100k
R510
100k
-12V
AOUT(+)
MIC1-(X)-out
MIC1Y
CL404
1.2
MIC2X
CL403
1.2
Q408
2SC4213-AB-TE85L
R497
10k
MIC2-(X)-out
b2
CN101
(8/135)
MIC2-(Y)-out
a2
CN101
(7/135)
MB-GND
c2
CN101
(9/135)
MIC2Y
CL405
1.2
R483
10k
R515
100k
R511
100k
Q406
2SC4213-AB-TE85L
L:-20dB/H:0dB
SY-364 (4/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_4
9-61
HSCU-300
9-61
E
SY-364 (5/11)
SY-364 (5/11)
PROD AD
R546
C551 10
1uF
3
R540
100k
5
A
2
INH
GND
4
C545
0.1uF
C555
10uF
R553
100
IC540 (1/3)
NJM4558V-TE2
PROD-IN
(4W)
- 2
1
VEE
3
R583
10k
R580
100k
R584
10k
R596
47k
C586
1000pF
C565
0.1uF
R572
10k
R577
10k
R557
10k
R612
10k
R571
OUT 10k
+
3
- 6
R576
10k
+3.3V-A2
R587
10k
V+
V-
R564
100
+3.3V
C571
0.1uF
R539
10
C533
1uF
R533
100
13
6
7
9
8
12
11
10
AD/DA-RST
009
009
009
009
009
DA-PROD/ENG
AD-PROD/ENG
AD/DA-64FS4
AD/DA-256FS4
AD/DA-LRCK4
7
5
3
1
8
6
4
2
PDN
VCOM
DEM0
DEM1
SDTI
SDTO
BCLK
MCLK
LRCK
VSS
R538
3
0
C543
10pF
RB530
100
C539
C537
0.0022uF 0.0022uF
GND
C548
1uF
R547
10k
C552
1uF
R548
22k
R710
22k
12
13
11
6
R709
22k
R707
33k
R639
47k
R722
220k
IC543 (1/3)
NJM4556AM-A-TE2
PROD SEL
15
2 -
R635
10k
+
3
5
3
9
R644
10k
R640
10k
IN+OUT
R666
10k
C601
10uF
R720
47k
IC545 (1/3)
74VHC4053MTCX
OUT
R669
10
1608
R665
10
1608
R687
4.7k
C607
100uF
50V
V+
V-
C628
10pF
NM
R673
100k
R679
100k
IC543 (3/3)
GND NJM4556AM-A-TE2
PROD-RTS/CC
R692
10k
R699
47k
12V
(RTS/CC)
C609
22uF
R688
4.7k
C610
22uF
R693
10k
6
5
3
2
4W
S530
CL530
1.2
4
CN101
(65/135)
PROD-OUT(X)-out
e11
PROD-OUT(Y)-out
CN101
d11 (64/135)
R695
22k
12V
Q541
2SC4617TL-QR
009
R636
10k
RTS(CC)
Q544
2SC4617TL-QR
RTS/CC IO
R670
10k
IC545 (3/3)
74VHC4053MTCX
C589
0.1uF
RV530:PROD RTS/CC CANCEL
Q540
2SA1774TL-QR
R659
10k
Q534
2SA1774TL-QR
+12V
L530
22uH
009
R560
1k
PROD-OUT
(192.5mVpp)
R563
15k
R569
15k
5
+
R559
100k
+1.65V-2
C567
10000pF
C577
470pF
C581
1uF
2 -
6.3V
6 -
R723
220k
C596
47uF 16V
IC541 (2/3)
NJM4580V(TE2)
R676
4.7k
R682
10k
C603
22uF
Q532
2SC4213-AB-TE85L
R655
10k
R685 C613
22k 0.1uF
C617
22uF
C614
0.1uF
C618
22uF
C604
22uF
PROD/ENG-MUTE
12V(4W)
CL531
1.2
4W-Y
V+
V-
R663
10k
R660
10k
Q530
2SC4213-AB-TE85L R641
10k
R716
10k
R700
47k
IC541 (3/3)
NJM4580V(TE2)
AL-C
R630
220
1608
R617
100
4W-X
Q538
2SC4617TL-QR
AL-C
R628
220
1608
R629
220 1608
R621
22k
R681
10k
C595
47uF 16V
6 -
R603
100
NM
Q549
2SC4213-AB-TE85L
GND
R614
22k
(*6)
NJM4580V(TE2)
100k
C550
2.2uF
50V
C626 220pF
3 IC541 (1/3)
IC536 (2/3)
NJM2732RB1(TE2) R591
C563
0.1uF
R607
10k
R605
47k
PROD-OUT(4W)
R601
10k
R715
100
R675
4.7k
R627
220 1608
PROD-OUT
(1.1Vpp)
C593
100pF
C576
1000pF
GND
C547
0.1uF
INH
VEE VSS
7 8
C588
0.1uF
PROD-OUT
(RTS/CC)
PROD-STATUS-RTS/4W
14
R590
4.7k
RV530
10k
47k
R551
IC530
AK4552VT-E2
4
5
VD 16
1 VA
RIN
ROUT
2
15
LIN
LOUT
16
VDD
- 6
R625
47k
R611
22k
2
1
10
R657
10k
R719
47k
003,004,008
C544
10uF
C631
1uF
NM
C542
0.1uF
R619
33k
R609
22k
14
C630
1uF
C633
22pF
R721
220k
R620
10k
for Out
R599
47k
R589
1.5k
IC538 (3/3)
NJM4558V-TE2
R542
0
for Cancel
R713
100k
C570
0.1uF
IC545 (2/3)
74VHC4053MTCX
IC543 (2/3)
NJM4556AM-A-TE2
5
+
7
- 2
IC538 (1/3)
NJM4558V-TE2
RTS/CC IO LEVEL
IN RTS:2Vpp/CC:400mVpp
OUT(@200ohm Load)
RTS:10mApp/CC:2mApp
IC538 (2/3)
NJM4558V-TE2
IN+OUT
R
ENG
ENG
(**: Inverted)
R532
100
CN101
(62/135)
GND
R544
10
PROD-IN
(RTS/CC)
C535
0.1uF
b11
C579
470pF
C566
0.1uF
R554
100
C534
10uF
PROD-IN(Y)-in
C559
0.1uF
C561
470pF
C532
1uF
CN101
a11 (61/135)
C592
1000pF
IC540 (3/3) V+
NJM4558V-TE2 V-
PROD-IN(X)-in
GND
L
AD PROD
DA PROD
C585
1000pF
C556
10uF
-5V-A
R595
47k
D530
DA221-TL
CH1
R579
100k
R567
10k
C569
470pF
IC536 (1/3)
NJM2732RB1(TE2)
IC536(3/3)
NJM2732RB1(TE2)
+1.65V-2
6.3V
R536
15k
C536
470pF
8
1
7
VCC
COMMON CH0
R534
15k
- 2
C557
0.1uF
1
V+
GND
C530
10uF
IC531
TC7W53FK(TE85R)
+5V-A
C540
1000pF
(15kHz)
TP531
R530
10
(203.5mVpp)
(Inverted)
+3.3V-A2
L531
22uH
Q535
2SC4617TL-QR
005
-12V
+12V
ENG AD
R541
100k
+1.65V-2
5
A
2
INH
GND
4
D531
DA221-TL
C546
0.1uF
C553
10uF
CH1
R585
10k
C572
470pF
R556
100
ENG-IN
(4W)
- 6
7
R582
100k
5
IC540 (2/3)
NJM4558V-TE2
VEE
3
R586
10k
CN101
a10 (55/135)
ENG-IN(X)-in
R597
47k
C583
1000pF
R598
47k
C584
1000pF
005
CN101
(56/135)
IC539 (2/3)
NJM4558V-TE2
IN+OUT
R575
10k
R558
10k
R555
100
- 2
1
IC539 (1/3)
NJM4558V-TE2
R613
10k
R574
10k
- 6
R578
10k
R588
10k
C573
0.1uF
C634
1uF
V+
V-
for Cancel
C637
22pF
C574
0.1uF
R622
33k
R610
22k
5
+
R714
100k
16
VDD
- 6
14
R594
4.7k
C635
1uF
RV531
10k
INH
VEE VSS
7 8
C590
0.1uF
R711
22k
12
13
11
6
R712
22k
R708
33k
R727
220k
R626
47k
R616
22k
R642
47k
ENG-OUT
(RTS/CC)
R658
10k
47k
2
1
10
IC544 (1/3)
NJM4556AM-A-TE2
2 -
R637
10k
5
3
9
R638
10k
1
IN+OUT
C602
10uF
R645
10k
R725
47k
R668
10k
R646
10k
R667
10
1608
OUT
R689 R691
4.7k 10k
V+
V-
R680
100k
IC544(3/3)
NJM4556AM-A-TE2
GND
Q545
2SC4617TL-QR
RTS/CC IO
R672
10k
R674
100k
ENG-RTS/CC
ENG SEL
RTS(CC)
C608
100uF
50V
R671
10
1608
C629
10pF
NM
IC546 (3/3)
74VHC4053MTCX
IC546 (1/3)
74VHC4053MTCX
Q542
2SA1774TL-QR
R661
10k
15
C591
0.1uF
RV531:ENG RTS CANCEL
IC539 (3/3)
NJM4558V-TE2
R726
220k
R623
10k
for Out
R600
47k
R592
1.5k
R565
100
003,004
-12V
IC546 (2/3)
74VHC4053MTCX R724
IC544 (2/3)
NJM4556AM-A-TE2
ENG-IN
(RTS/CC)
OUT
AUDIO-MUTE-CONTROL
CN101
c10 (57/135)
C554
10uF
R706
10k
Q548
2SA1774TL-QR
1M
b10
ENG-IN(Y)-in
GND
C562
470pF
R705
10k
R703
22k
C621
100uF
16V
GND
Q547
2SA1774TL-QR R704
C587
1000pF
MB-GND
-5V-A
PROD/ENG-MUTE
R702
22k
R701
4.7k
C580
470pF
R573
10k
C560
0.1uF
R543
10
GND
Q546
2SA1774TL-QR
R697
47k
C538
470pF
IC537 (1/3)
NJM2732RB1(TE2)
6.3V
R537
15k
8
7
VCC
COMMON CH0
R581
100k
IC537 (3/3)
NJM2732RB1(TE2)
- 2
R535
15k
R568
10k
V+
GND
4
C531
10uF
C558
0.1uF
C549
1uF
IC532
TC7W53FK(TE85R)
(15kHz)
TP530
C541
1000pF
R545
10
R531
10
+5V-A
(203.5mVpp)
(Inverted)
+3.3V-A2
12V
(RTS/CC)
C611
22uF
R690
4.7k
R694
10k
4W
6
5
3
2
CL532
1.2
S531
4
CN101
(59/135)
ENG-OUT(X)-out
e10
ENG-OUT(Y)-out
CN101
d10 (58/135)
R696
22k
C612
22uF
12V
Q543
2SC4617TL-QR
009
Q536
2SA1774TL-QR
R552
47k
+12V
L532
22uH
R549
10k
C575
1000pF
GND
ENG-OUT
(192.5mVpp)
+1.65V-2
R562
1k
R561
100k
R566
15k
R570
15k
C568
10000pF
C578
470pF
C594
100pF
IC537 (2/3)
NJM2732RB1(TE2)
5
+
6 -
C582
1uF
R718
100
R728
220k
C564
0.1uF
3
R604
100
NM
Q550
2SC4213-AB-TE85L
R677
4.7k
R631
220 1608
R608
10k
C627 220pF
R615
22k
2 -
6.3V
R593
100k
R606
47k
ENG-OUT(4W)
R602
10k
ENG-OUT
(1.1Vpp)
R624
22k
IC542 (1/3)
NJM4580V(TE2)
+
R618
100
R698
47k
12V(4W)
C598
47uF 16V
IC542 (3/3)
NJM4580V(TE2)
AL-C
R634
220
1608
IC542 (2/3)
NJM4580V(TE2)
Q531
2SC4213-AB-TE85L
R662
10k
R643
10k
R717
10k
4W-X
Q539
2SC4617TL-QR
AL-C
R632
220
1608
R633
220 1608
6 -
R683
10k
C597
47uF 16V
4W-Y
8
009
V+
V-
R664
10k
ENG-STATUS-RTS/4W
R550
22k
R656
10k
Q533
2SC4213-AB-TE85L
C605
22uF
R678
4.7k
R684
10k
C616
0.1uF
GND
PROD/ENG-MUTE
005
R686 C615
22k 0.1uF
C606
22uF
Q537
2SC4617TL-QR
CL533
1.2
C619
22uF
C620
22uF
L533
22uH
-12V
SY-364 (5/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_5
9-62
A
9-62
HSCU-300
SY-364 (6/11)
SY-364 (6/11)
009
CMD-Y-TALLY
CMD-G-TALLY
CMD-R-TALLY
Y-TALLY-IN
+5V-T
G-TALLY-IN
R-TALLY-IN
TALLY
R-TALLY
e8
RED-Tally-(X)-in
D730
DAP222-TL
2
1
3
C730
0.022uF
16V
D733
DAN222-TL
1
3
2
2
3
5
6
TTL
S733
POWER
S730
1
CONTACT
C731
0.022uF
16V
CN101
(46/135)
d8
R739
1k
POWER
6
5
3
2
POWER
R733 R736
47k 15k
R730
1k
D736
UDZSNPTE-175.6B
RED-Tally-(Y)-in
R754
47k
R751
1k
R740
2.2k
R741
47k
R778
100
12
R779
100
IC730 (3/7)
IC730 (5/7)
PH730
TLP181(BL-TPR)
Q730
2SC4617TL-QR
13
IC730 (2/7)
IC730 (4/7)
3
R748
15k
IC730 (6/7)
IC730 (1/7)
C746
22uF
C739
22uF
11
R780
100
10
RED-TALLY-Panel-out
c5
CN102
(27/135)
GREEN-TALLY-Panel-out
b5
CN102
(26/135)
YELLOW-TALLY-Panel-out
a5
CN102
(25/135)
14
CONTACT
CN101
(47/135)
L730
22uH
TTL
POWER
C736
0.1uF
IC730 (7/7)
TC74VHCT04AFT(EKJ)
VCC
GND
C754
0.1uF
G-TALLY
TTL
POWER
CONTACT
CN101
(43/135)
a8
GREEN-Tally-(X)-in
D731
DAP222-TL
2
1
3
C732
0.022uF
16V
D734
DAN222-TL
1
3
2
2
3
5
6
TTL
S734
4
CN101
(44/135)
b8
6
5
3
2
D737
UDZSNPTE-175.6B
GREEN-Tally-(Y)-in
Q737
2SC4617TL-QR
R761
10k
POWER
R734 R737
47k 15k
R731
1k
JC730
0
R760
4.7k
R742
1k
POWER
POWER
S731
CONTACT
C733
0.022uF
16V
Q736
2SC4617TL-QR
R743
2.2k
R744
47k
R749
15k
R762
4.7k
R755
47k
R752
1k
Q738
2SC4617TL-QR
R763
10k
JC731
0
JC732
0
R764
4.7k
R765
10k
2
1
PH731
TLP181(BL-TPR)
Q731
2SC4617TL-QR
2
1
U-TALLY
POWER
TTL
POWER
+3V-T
Q733
2SC4617TL-QR
R745
1k
R757
10k (7-15V)
L733
10uH
D742
DAN222-TL
d6
YELLOW-Tally-(Y)-in
CONTACT
JC737
0
NM
C735
0.022uF
16V
R732
1k
POWER
R735 R738
47k 15k
D738
UDZSNPTE-175.6B
JC738
0
009
C750
10uF
35V
8
(1630Vpp)
C747
0.1uF
2 1
C743
22uF
R753
1k
C740
0.0047uF
Q734
2SC4617TL-QR
R747
47k
R750
15k
D739
UDZSNPTE-175.6B
D744
DAP222-TL
R758
10k
D743
DAN222-TL
Q732
2SC4617TL-QR
T730
a6
CN101
(31/135)
YELLOW-TALLY-Rear-out
(30mA)
a5
CN101
(25/135)
R772
4.7k
R775
10k
JC733
0
COM-TALLY-Rear-out
(30mA)
b5
CN101
(26/135)
JC734
0
c6
CN101
(33/135)
TALLY-GND
C744
22uF
C738
0.1uF
C748
0.1uF
C741
0.0047uF
AUX5
C751
10uF
35V
D740
UDZSNPTE-175.6B
5
7
(510Vpp)
3
2
R759
10k
D745
DAP222-TL
D747
DAN222-TL
C742
0.0047uF
D741
UDZSNPTE-175.6B
D748
DAN222-TL
D746
DAP222-TL
3 2
NM
T731 1
5
7
3
2
D752
DAP222-TL
R766
47
3
1
R768
33k
D749
DAP222-TL
R770
1k
C761
0.0033uF
R773
33k
R776
1k
C756
22uF
Q740
2SD596T1-DV345
C759
0.0033uF
Q741
2SD596T1-DV345
D753
DAP222-TL
R767
47
3
C758
0.0047uF
C755
22uF
NM
3 2
2 1
C752
10uF
C749 35VNM
0.1uF
C745
22uF
6.3V
NM
Q739
2SD596T1-DV345
C757
0.0047uF
Q735
2SC4617TL-QR
L732
22uH
C753
22uF
CN101
(34/135)
AUX4
D735
DAN222-TL
1
3
2
R746
2.2k
2 1
009
D732
DAP222-TL
2
1
3
C734
0.022uF
16V
NM
1
JC736
0
2
3
5
6
2 1
JC735
0
NM
(30mA)
(3.3V)
L731
22uH
NM
YELLOW-Tally-(X)-in
3 2
e6
TTL
S735 NM
6
4
5
3
1
2
3 2
CN101
(35/135)
POWER
S732
CN101
(32/135)
NM
PH732
TLP181(BL-TPR)
CONTACT
Q743
2SC4617TL-QR
D755
DAN222-TL
R756
47k
b6
D754
DAN222-TL
C737
0.1uF
RED-TALLY-Rear-out
(30mA)
R769
33k
Q742
2SD596T1-DV345
R771
1k
C762
0.0033uF
R774
33k
R777
1k
C760
0.0033uF
5
GND
SY-364 (6/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_6
9-63
HSCU-300
9-63
E
SY-364 (7/11)
C821
0.1uF
NM
R895
+3.3V
+3.3V
R821
10k
R818
R819
SDA-MAC
100
100
SCL-MAC
OFF:NORMAL
S801
(3/4)
ON:DEBUG
R822
10k
C832
0.1uF
R829
47
+3.3V
L802
10uH
C803 R803
0.1uF 1k
R830
47
27MHz-XTAL-CLK
008
+3.3V
IC833 (2/3)
NJM2732RB1(TE2)
+3.3V
C816
0.1uF
12
13
2
1
5
3
11
10
9
6
+3.3V L803
10uH
001 PNL-MASTER-BLACK-in
001
HD-PLL-VOLT
002
PNL-WHITE-R-in
R831
10k
+
C827
0.1uF
+3.3V L805
10k
5
+
C830
0.1uF
IC838(3/3)
10uH NJM2732RB1(TE2)
2 -
IC838 (2/3)
NJM2732RB1(TE2)
6 -
V+
GND
001
PNL-WHITE-B-in
001
PNL-BLACK-R-in
C822
0.1uF
001
R806
UNREG-VOLT-Sense
0V-18V max24V
XSHWE3
XSHWE2
12
13
2
1
5
3
11
10
9
6
c9
R809
100k
C810
0.01uF
R814
22k
001
CN101
(51/135)
100k
PNL-BLACK-B-in
001
CN101
(63/135) c11
CN101
(39/135) c7
ANA1(Temp-Level)-in
ANA2(TEMP-Level)-in
12
13
2
1
5
3
11
10
9
6
100
100
C812
0.01uF
XCS3
XCS2
C811
0.01uF
XCS0
TADP-NMI-OUT
009
C801
100pF
TADP-CLK
R826
AD_SEL_SY/PANEL
009
009
009
009
009
+3.3V
R802
10k
1Y
4
0Z
Z-COM
1Z
A
B
C
INH
GND:2 GND:1
8
7
C824
0.1uF
PNL-ASSIGN-VR-in
R811
R812
R853
10k
RE-A
PRTCT-OFF/ON
Char-CLK
RE-B
BUSY/READY
Char-TXD
CL803 1.2
Ver-Up-ON/OFF
H:RTC-CS
RTC-CLK
RTC-SIO
SCL-MAC
SDA-MAC
SDA1
XCPU-RST
CL802
1.2
CKPO
SCL1
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
+3.3V
L807
10uH
1k
8
6
4
2
8
6
4
2
+3.3V
R805
47k
R804
47k
8
6
4
2
RB848
2.2k
C897 C899 C963

7 1000pF1000pF1000pF
5
3
1
7
5
3
1
R807
R844
47k
1
2
3
4
5
6
7
8
C800
1000pF
RB853
2.2k
C896
1000pF
RB847
100
IC804
MB88102PFV-G-BND-ER
13
VCC
19
AVRH1
20
AVRH2
IC849
TC74VHC4053AFT(EK)
16
VCC
14
0X
X-COM
1X
15
0Y
Y-COM
1Y
4
0Z
Z-COM
1Z
A
B
C
INH
GND:2 GND:1
8
7
AD_SERIAL_DATA_IN
AD1_CS
AD_SERIAL_CLK
AD_CLK_256FS
AD1_START
R843
100
C898 C900 C964

1000pF1000pF 1000pF
7
5
3
1
AN1
AN2
AN3
AN4
AN5
AN6
AN7
AN8
C835
0.1uF
DO
R813
100
12
AD_SERIAL_DATA_OUT
100
+3.3V
1
2
IC828 (2/2)
TC7SZ08FU(TE85R)
PLD-ReConfig
008
PLD-Config-Done
008
R881
10k
R878 R882
10k 10k
DACK(MS)
+3.3V
R884
10k
DREQ(MS)
R883
10k
2
1
BUSY/READY 4
XCS4
XCS3
XCS2
XCS1
XCS0
WR/RD
IC826 (1/2)
TC7SH08FU(T5RSOYJF)
IC826(2/2)
TC7SH08FU(T5RSOYJF)
+3.3V
/BS
VCC
GND
C857
0.1uF
XRD
SHCKE
XSHWE0
XSHWE1
XSHWE2
XSHWE3
XSHCAS
XSHRAS
R877
100k
XWAIT
A24
A23
A22
A21
A20
VCC
GND IC828 (1/2)
TC7SZ08FU(TE85R)
+3.3V
009
R861
10k
001
Front-ENC(A)
IC841 (1/2)
R862
10k TC7SH14FU(T5RSOYJF)
R864
100k
2
4
001
9
TCLKX
10
CLK
100k
Front-ENC(B)
0.1uF
C841
0.1uF
VCC
GND
+3.3V
C842
0.1uF
C844
0.01uF
IC841 (2/2)
IC842(2/2)
TC7SH14FU(T5RSOYJF) TC7SH14FU(T5RSOYJF)
+3.3V
VCC
GND
+3.3V
+3.3V C848
IC842 (1/2)
R865 TC7SH14FU(T5RSOYJF)
15
CI
14
CSX
IC810
TC74LCX138FT(EKJ)
IC809
TC74LCX74FT(EKJ)
C843
0.01uF
C828
0.1uF
16 HSTX
AGND VSS
11
C831 17
0.1uF
9-64
A
RB800
10k
+3.3V
C809
0.01uF
XSHCAS
XSHRAS
+3.3V
IC848
16 TC74VHC4053AFT(EK)
VCC
14
0X
X-COM
1X
15
Y-COM
0Y
R810 100
ANA0(DPR-Level)-in
D13
ok
+3.3V
C823
0.1uF
D29
D28
D31
D30
XRD
WR/RD
XSHWE1
XSHWE0
R837
SD-PLL-VOLT
002
IC838 (1/3)
NJM2732RB1(TE2)
D9
D10
D11
D12
re
PC-TXD
PC-RXD
A17
A18
A19
D21
D20
D23
D22
D25
D24
D27
D26
C815
0.1uF
D7
D8
A16
V+
GND
IC847
16 TC74VHC4053AFT(EK)
VCC
14
0X
X-COM
1X
15
0Y
Y-COM
1Y
4
0Z
Z-COM
1Z
A
B
C
INH
GND:2 GND:1
8
7
UPDATE
CPU-CLK
XCS2
5
+
R824
22k 6
NM
A9
A10
A11
A12
A13
A14
A15
C818
0.1uF
IC833 (3/3)
NJM2732RB1(TE2)
RE-A
RE-B
1k
R816
D1
D2
D3
D4
D5
D6
IC844 (2/2)
TC7SH32FU(T5RSOYJF)
+3.3V
PNL-IRIS(DC1)-in
D0
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
VCC
GND
2
4
3
1
12
10
11
13
14
VCC
1D
1Q
1PR
1CK 1Q
1CLR
2D
2Q
2PR
2CK 2Q
2CLR
GND
7
1
2
3
A20
A21
A22
6
9
1
2
A23
R879
A24
6
10 4
5
IC844 (1/2)
TC7SH32FU(T5RSOYJF)
C856
0.1uF
16
VCC
A
Y0
B
Y1
Y2
C
Y3
G1
Y4
G2A Y5
G2B Y6
Y7
GND
8
15
14
13
12
11
10
9
7
CS(700R)
CS(CHU)
CS(PLD_SY)
CS(PLD_RET)
C847
0.1uF
001
SH-TDI
SH-TCK
SH-TMS
SH-XTRST
A8
R823 2
22k
NM
C817
0.1uF
D13
D12
D15
D14
D17
D16
D19
D18
R860
22
A0
SH-TDO
A1
A2
A3
A4
A5
A6
A7
47
47
47
47
XRD-2
IC833 (1/3)
NJM2732RB1(TE2)
R833
R834
R835
R836
IC808
HD6417616SFV
D31
1k
R815
16
17
18
19
20
C826
22uF
6.3V
H:RTC-CS
54MHz
IC807
6 CY23EP05SXC-1HT
R852 22
VDD
1
CLKOUT REF
CLK1
CLK2
CLK3
CLK4
GND
4
BT801
3 R846
100
8
9
11
R847
12
100k
13
14
15
8
3
2
5
7
+3.3V
XRD
Front-Inc-VR
4
CL801
1.2
2
54MHz
CPU-CLK
SR1-CLK
SR2-CLK
TADP-CLK
R859 22
C814
0pF
0V
2 -
RTC-SIO
RTC-CLK
13.5MHz
R880
10k
PB11/SRS2/CTS/STATS0
PVCC1
PB12/SRCK2/RTS/STATS1
PB13/TXD1
PB14/RXD1
PB15/SCK1
VSS18
VSS17
OPEN BGR
VCC18
VCC17
BRLS
DACK0
OPEN DACK1
DREQ0
DREQ1
OPEN BH
BUSHIZ
CS4
CS3
CS2
CS1
CS0
RD/WR
VCC16
(OPEN)
BS
VSS16
OPEN REFOUT
RD
CKE
OPEN CAS0
OPEN CAS1
OPEN CAS2
OPEN CAS3
DQMLL/WE0
DQMLU/WE1
DQMUL/WE2
DQMUU/WE3
CAS/OE
RAS
VCC15
WAIT
VSS15
VSS14
VSS13
A24
VCC14
VCC13
A23
A22
A21
A20
001
R825
1k
R841
R842
C829
0.1uF
6 -
R817
1k
7
6
47
R850
10k
R848
10k
100
100
C840
0.1uF
D25
D26
D27
D28
D29
D30
1
VDD
TIRQ DATA
CLK
AIRQ
CE0
FOUT
CE1
FCON
NC6
NC1
NC7
NC2
NC8
NC3
NC9
NC4
NC10
NC5
GND
10
13.5MHz
MS-CLK R832
+3.3V
D24
R840
10k
C839
470pF
MODE4
MODE3
C884 V+
0.1uF GND
IC839 (1/3)
TLC272CPWR-12
2
IC839 (2/3)
TLC272CPWR-12
IC805
RTC-4574JE
1
3
1
3
D801
DA221-TL
+5V
D5
D4
D7
D6
D9
D8
D11
D10
D802
RB706F-40
R839
10
C838
470pF
5
D20
D21
D22
D23
+5V
IC839 (3/3)
TLC272CPWR-12
R801
10
27MHz
CKPO
14
VCC
1D
1Q
1PR
1CK 1Q
1CLR
2D
2Q
2PR
2CK 2Q
2CLR
GND
7
D19
D1
D0
D3
D2
10
2
4
3
1
12
10
11
13
2
4
6
8
A1
A0
TADP-NMI-OUT
IRL3
IRL2
IRL1
IRL0
NMI
ASEMODE
GND
RES
PLLVSS
CAP2
CAP1
PLLVCC
MD4
CS0 BUS
WIDTH
MD3
=32bit
MD2
CLOCK
MD1
MODE
=MODE0
MD0
VCC1
EXTAL 13.5MHz
VSS1
XTAL XTAL OPEN
VCC2
CKIO 27MHz->54MHz
CKPREQ/CKM
CKPACK OPEN
VSS2
IVECF OPEN
TDO
TDI
TCK
TMS
TRST
VCC3
D0
VSS3
D1
D2
D3
D4
D5
D6
VCC4
D7
D8
VSS4
D9
D10
D11
D12
VCC5
D13
VSS5
1
3
5
7
XCS0
ASEMODE
XCS0
XCS1
5
C802
C808 22uF
0.1uF 6.3V
3216
VCC
GND
R838
X801
27MHz
IC845 (1/2)
4
TC7SZ04FU(TE85R)
VDD
2
4
1
3
CONT
OUT
GND
C806
10pF
2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
INTR(MS)
IC806 +3.3V
TC74LCX74FT(EKJ)
A24
IC845 (2/2)
TC7SZ04FU(TE85R)
R876
10k
8
3
VCC
5
A2 SDA
2
6
A1 SCL
1
7
A0
WP
VSS
4
IRQ(Torino&Daytona)
XINT-700P-RCP
XINT-700P-CHU
H-UDI-RST
R873
100
D14
D15
D16
D17
D18
VCC6
D19
VSS6
VSS7
D20
D21
D22
D23
VCC7
VCC8
D24
VSS8
D25
D26
D27
D28
D29
D30
VCC9
D31
VSS9
VSS10
A0
VCC10
A1
A2
A3
A4
A5
A6
A7
VCC11
A8
VSS11
A9
A10
A11
A12
A13
A14
A15
VCC12
A16
VSS12
A17
A18
A19
MAC Address
CN101
(120/135) c23
008
008
IIC ADDRESS:EEPROM
C807
1 0 1 0 L L L W/R 0.1uF
XCS4
XCS1
+3.3V
2
1
IC825 (1/2)
TC7SH08FU(T5RSOYJF)
C850 C852 C854 C975 C996 C998

0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
C849 C851 C853 C855 C995 C997 C999
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
PRTCT-OFF/ON
ON:Write Protect
OFF:MAC Write enable
IC801
CAT24C02WI-GT3
A23
A22
C837
0.1uF
R857
10k
H-UDI
007
009
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
S801
(1/4)
PROTECT
R849
10k
NM
CPU-PLD-Reserve
100k
TXER
ETXD3
ETXD2
ETXD1
ETXD0
TXEN
PVSS5
TXCLK
PVCC5
MDC
MDIO
ERXD3
ERXD2
ERXD1
ERXD0
PVCC4
RXCLK
PVSS4
CRS
COL
RXDV
RXER
PA0/CAMSEN
PA1/EXOUT
PA2/LNKSTA
CKPO/FTOB
PA4/FTOA
PVSS3
PA5/FTI
PVCC3
PA6/FTCI
PA7/WDTOVF
PA8/STXD0
PA9/STS0
PA10/STCK0
PA11/SRXD0
PA12/SRS0
PA13/SRCK0
PB0/TIOCD0/TCLKB/WOL
PVSS2
PB1/STXD1/TIOCC0/TCLKA
PVCC2
PB2/STS1/TIOCB0
PB3/STCK1/TIOCA0
PB4/SRXD1/TXD2
PB5/SRS1/RXD2
PB6/SRCK1/SCK2
PB7/STXD2/TIOCB2/TCLKD
PB8/STS2/TIOCA2
PB9/STCK2/TIOCB1/TCLKC
PB10/SRXD2/TIOCA1
PVSS1
IC835 (1/2)
TC7SH14FU(T5RSOYJF)
R808
100k
C804
0.1uF
C833
22uF
+3.3V
+3.3V
VCC
GND
L808 C834 C836

10uH 0.1uF 0.1uF
+3.3V
IC835 (2/2)
TC7SH14FU(T5RSOYJF)
A15
A14
A17
A16
A19
A18
A21
A20
+3.3V
Ver-Up-ON/OFF
PHY-LINK-ST
td(s)=0.69x6.5xC(uF)
ON:Version Up
OFF:NOP
VerUp
PHY-CRS
PHY-COL
PHY-RX-DV
PHY-RX-ER
PHY-SPD-ST
S801
(2/4)
C825
0.1uF
R875 100
PHY-XFDX-LED
R866
R869
100
10k
27MHz
PHY
008
R851
100
XINT-CPU-VD
009
PHY-RX-CLK
GND
3 C819
0.1uF
PANEL-EXIST/NONE
008
H :Config-Done
PLD-Config-Done-in
CN101
(132/135) c25
5
VCC
GND
R863
100
C820
0.1uF
CD
001,009
CN101
c24 (126/135)
PLD-ReConfig-out
PHY-MDC
PHY-MDIO
PHY-ERXD3
PHY-ERXD2
PHY-ERXD1
PHY-ERXD0
NC
PHY-TX-CLK
R943
100k
+3.3V
A7
A6
A9
A8
A11
A10
A13
A12
C805
0.1uF
2
1
PHY-TX-ER
PHY-ETXD3
PHY-ETXD2
PHY-ETXD1
PHY-ETXD0
PHY-TX-EN
VCC
GND
+3.3V
IC825 (2/2)
TC7SH08FU(T5RSOYJF)
IC843 (1/2)
TC7SH08FU(T5RSOYJF)
re
R820
10k
2
VDD
1
OUT
C813
0.1uF
D14
D15
D16
D17
D18
007,008,009,011
007,008,009,011
A3
A2
A5
A4
+3.3V
XCS3
XCS4
XCS2
ADDRESS
DATA
+3.3V
IC843 (2/2)
TC7SH08FU(T5RSOYJF)
IC802
R3112N281A-TR-FA
007,008,009,011
CONTROL
/BS
L801 +3.3V
10uH
Target-Vcc1
Target-Vcc1
/BS
Reserve
A3
A2
A5
A4
GND
GND
A7
A6
A9
A8
A11
A10
A13
A12
GND
GND
A15
A14
A17
A16
A19
A18
A21
A20
GND
GND
A23
A22
Reserve
A24
Reserve
Reserve
/CS4
/CS1
GND
GND
Reserve
/CS0
A1
A0
D1
D0
D3
D2
GND
GND
D5
D4
D7
D6
D9
D8
D11
D10
Target-Vcc2
Target-Vcc2
Target-Vcc2
Target-Vcc2
D13
D12
D15
D14
D17
D16
D19
D18
GND
GND
D21
D20
D23
D22
D25
D24
D27
D26
GND
GND
D29
D28
D31
D30
/RD
RD/WR
/WE1
/WE0
GND
GND
/WE3
/WE2
/CAS1
/CAS0
/CAS3
/CAS2
/CAS
/RAS
GND
GND
Reserve
Reserve
/CS3
/CS2
NMIIN OPEN
/ROMCS1
NMIOUT
/RSTOUT
GND
GND
CKIO
Reserve
/ROMCS3
Reserve
/ROMCS4
/ROMCS2
Target-Vcc3
Target-Vcc3
CN801
NM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
SY-364 (7/11)
9-64
HSCU-300
SY-364 (7/11)
SY-364 (7/11)
007,008,009,011
DATA
007,008,009,011
ADDRESS
26
28
11
12
47
15
XCS0(FLASH)
XRD
XSHWE1
45
43
41
39
36
34
32
30
44
42
40
38
35
33
31
29
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
CE
OE
WE
10
RESET NC1
13
BYTE
NC2
14
RY/BY NC3
VSS1 VSS2
27
46
2
4
6
8
2
4
6
8
RB811
100k
1 D3
3 D2
5 D1
7 D0
7
5
3
1
A23
A22
A21
A20
A19
A18
A17
A16
2
4
6
8
RB812
100k
1 A15
3 A14
5 A13
7 A12
2
4
6
8
RB813
100k
1 A11
3 A10
5 A9
7 A8
2
4
6
8
RB814
100k
1A7
3A6
5A5
7A4
2
4
6
8
RB815
100k
1A3
3A2
5A1
7A0
21
20
35
22
34
33
32
31
30
29
26
25
24
23
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
19
16
17
18
39
15
37
38
XCS3
WR/RD
XSHCAS
XSHRAS
XSHWE1
XSHWE0
SHCKE
SR2-CLK
BA1
BA0
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
CS
WE
CAS
RAS
DQMH
DQML
CKE
CLK
XSHCAS
XSHRAS
XRD
WR/RD
8
6
4
2
XSHWE3
XSHWE2
XSHWE1
XSHWE0
2
4
6
8
RB816
100k
7
5
3
1
C882
0.1uF
53
51
50
48
47
45
44
42
13
11
10
8
7
5
4
2
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
1
26
2
23
21
24
25
3
4
5
6
7
8
9
10
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
20
CE
22
OE
27
WE
XRD
XSHWE0
+3.3V
C880
0.1uF
36
NC1
40
NC2
XCS4
19
18
17
16
15
13
12
11
D7
D6
D5
D4
D3
D2
D1
D0
12
35
32
33
34
11
30
29
XRD
XSHWE1
XSHWE0
INTR(MS)
DACK(MS)
DREQ(MS)
RB818 +3.3V
1
3
5
7
100k
2
4
6
8
R905
R906
R907
SCKI
SCKO
1
3
R917
100
R918
47
17
L814
IC836(2/2) 2SA1797-T100-Q
10uH TC7SH08FU(T5RSOYJF)
POWER(MS)
THP801
R913
C887
22k
VCC
22uF
C888
6.3V
0.1uF GND
3216
R915
3.3k
39
IC836(1/2)
TC7SH08FU(T5RSOYJF)
2
1
R897
1k
R911
47k
R912
47k
C890
0.1uF
IC820
TC7SH04FU(T5RSOYJF)
IC821
TC7SH04FU(T5RSOYJF)
IC834 (2/2)
TC7SH14FU(T5RSOYJF)
Q802
2SC4617TL-QR
R904
100k
R914
10k
VCC
C883
0.1uF GND
1
3
C889
1uF
6.3V
R921
100k
2 SENSE(MS)
1 3
D807
DA221-TL
IC834 (1/2)
TC7SH14FU(T5RSOYJF)
GND
14
UPDATE
JIG-DET
MEMORYCN804STICK CN
1
2
3
4
5
6
7
8
9
10
R893
10
16 R827
100k
A20 1 A VCC Y0 15
14
A21 2 B
Y1
13
A22 3 C
Y2
12
Y3
11
A23 6 G1
Y4
10
4
G2A Y5
A24 5 G2B Y6 9
7
Y7
GND
+5V
VSS
BS
VCC
DIO
(Reserve)
INS
(Reserve)
SCLK
VCC
VSS
BS(MS)
POWER(MS)
DIO(MS)
SENSE(MS)
C892
0.1uF
CK(MS)
XCS2
R928
10
R930
0
NM
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
C894
0.1uF
D7
D6
D5
D4
D3
D2
D1
D0
2
3
4
5
6
7
8
9
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
1
3
5
7
1
3
5
7
RB819
47
2
4
6
8
2
4
6
8
ADDR(4)-out
ADDR(3)-out
ADDR(2)-out
ADDR(1)-out
ADDR(0)-out
WR-out
RD-out
b18
c18
b19
c19
d19
e20
e21
CN102
(89/135)
CN102
(90/135)
CN102
(95/135)
CN102
(96/135)
CN102
(97/135)
CN102
(104/135)
CN102
(110/135)
RB820
47
GND
10
+3.3V
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
IC823
TC74LCX245FT(EKJ)
20
VCC
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
1
3
5
7
1
3
5
7
RB821
47
2
4
6
8
2
4
6
8
BUS(7)-out
BUS(6)-out
BUS(5)-out
BUS(4)-out
BUS(3)-out
BUS(2)-out
BUS(1)-out
BUS(0)-out
a21
b21
c21
d21
SDA-in/out
SDA_in/out
a18
010
a20
b20
c20
d20
RB822
47
GND
10
R934
2.2k
R935
R936
+3.3V
47
47
R929
10k
IC824
NM TC74LCX245FT(EKJ) R932 47
SCL
010
+3.3V C895
+3.3V
0.1uF
R933
2.2k
20
18
2
VCC
R937
10
SCL1
B1
A1
SCL-out
a19
17
47
3
R942
d18
B2
A2
CS0-out
16
4
R938
10
CKPO
e18
B3
A3
CPU-CK-out
15
5
R939
47
e19
B4
A4
MST-RESET-out
XCPU-RST
14
6
B5
A5
CPU-RESET
13
7
XRD-2
R940
B6
A6
008,009,011
10
8
12
Char-CLK
A7
Chara-CK-out
B7
a22
9
11
47
R941
Char-TXD
A8
Chara-Data-out
B8
a23
CN102
(88/135)
CN102
(94/135)
CN102
(91/135)
CN102
(92/135)
CN102
(98/135)
CN102
(112/135)
CN102
(118/135)
GND
10
61 62
14 13 12 11
GND
RB817
100k
1
3
5
7
PC-TXD
PC-RXD
SH-TDO
+3.3V
L813
10uH
NM
SH-TMS
R901
22
SH-TDI
R902
22
H-UDI-RST R903
22
Q801
2SC4617TL-QR
1
2
3
4
5
6
7
8
9
10
11
12
13
14
IC840(1/2)
TC7SH04FU(T5RSOYJF)
4
R871
47k
PC-I/F
CN802
1
2
3
4
ZH-Straight
+5V
+5V
R870
10k
R867
220
+5V
TXD
RXD
GND
R872
2.2k
6 5
IC846 (1/2)
TC7SH08FU(T5RSOYJF)
2
1
IC846 (2/2)
IC840 (2/2)
TC7SH08FU(T5RSOYJF) TC7SH04FU(T5RSOYJF)
+3.3V
+3.3V
VCC
GND
NM
IC837 (1/2)
TC7SH14FU(T5RSOYJF)
TCK
GND
TRST
GND
TDO
GND
N.C.
N.C.
TMS
GND
TDI
GND
RESET
GND
22
22
22
R898
R899
R900
R868
10k
H-UDI
CN
CN803
R896
10k
SH-TCK
ASEMODE
SH-XTRST
R891
16
10k
VCC
7
XCS0(FLASH)
1B1 1A
+3.3V
1B2
1B3
R892
10k
1B4
9
XCS0(JIG)
2B1 2A
2B2
2B3
2B4
IC837 (2/2)
IC831 (2/2)
S0
TC7SH14FU(T5RSOYJF)
TC7SZ04FU(TE85R)
S1
IC830 (2/2)
IC832 (2/2)
+3.3V TC7SZ04FU(TE85R)
TC7SZ08FU(TE85R)
OE1
C861
+3.3VC862
+3.3VC863
+3.3VC864
0.1uF
0.1uF
0.1uF
0.1uF
OE2
GND
8
VCC
VCC
VCC
VCC
GND
GND
GND
GND
+3.3V
H-UDI
007
C846
0.1uF
VCC
GND
SY-364 (7/11)
C845
0.1uF
BOARD NO. 1-879-650-11

HDCU-300_SY-364_011_7
9-65
HSCU-300
+3.3V
SDA1
19
OE
1
DIR
CN102
(106/135)
CN102
(107/135)
CN102
(108/135)
CN102
(109/135)
CN102
(100/135)
CN102
(101/135)
CN102
(102/135)
CN102
(103/135)
+3.3V
6
5
4
3
10
11
12
13
14
2
1
15
+3.3V
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
XSHWE0
XRD
20
VCC
+5V
C858
0.1uF
IC832 (1/2)
TC7SZ08FU(TE85R)
OFF:NORMAL
S801
(4/4)
ON:DEBUG
0 NM
0 NM
MODE4
2
R889
0 NM
R886
100k
BS(MS)
Q804
+3.3V
R926
R927
A4
A3
A2
A1
A0
2
3
4
5
6
7
8
9
CONTROL
1
2
CK(MS)
R919
100
IC831 (1/2)
TC7SZ04FU(TE85R)
IC811
SN74CBT3253PWR-12
+3.3V
DIO(MS)
R923
100k
13
+5V
R885
10k
2
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
XCS0(JIG)
XRD-2
XSHWE1
XSHWE0
47k
R922
22k
R910
22k
16
HCKI
XRS
XCS
XRD/RDWRX
XWRH/XBE0
XWRL/XBE1
XINT
XDAK/XAS
XDRQ/XRDY
+3.3V
Q805
2SC4617TL-QR
R924
R908
100k
NM
15
BS
14
SDIR
SEL
Q803
2SC4617TL-QR
R909
47k
27
PO3
26
PO2
25
PO1
24
PO0
SDIO
100k
100k
100k
R920
1k
D808
SML-522MU8WT86PQ
MS-LED
2
4
43
VDD2
19
XCPU-RST
DACK(MS)
DREQ(MS)
INTR(MS)
IC816
TC74LCX138FT(EKJ)
D0
+3.3V
28
VCC
I/O7
I/O6
I/O5
I/O4
I/O3
I/O2
I/O1
I/O0
28
+3.3V
23
PI3
22
PI2
21
PI1
20
PI0
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
36
A3
37
A2
38
A1
MS-CLK
R916
2.2k
GND
A3
A2
A1
C886
0.1uF
C891
0.1uF
GND
14
40
41
44
45
46
47
48
1
2
3
4
5
7
8
9
10
VDD1
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
IC818
C868 C872 C876

0.1uF 0.1uF 0.1uF
10uH
RB806
100k
8
6
4
2
8
6
4
2
XRD
XSHWE1
IC815
C866 C870 C874 C878
MT48LC8M16A2P-75-Y15WTR 0.1uF
0.1uF 0.1uF 0.1uF
7
5
3
1
7
5
3
1
D16
36
NC1
40
NC2
+3.3VL809
RB805
100k
8
6
4
2 A24
RB807
100k
CS
WE
CAS
RAS
DQMH
DQML
CKE
CLK
GND
31
7 D11
5 D10
3 D9
1 D8
RB810
100k
1 D7
3 D6
5 D5
7 D4
19
16
17
18
39
15
37
38
XCS3
WR/RD
XSHCAS
XSHRAS
XSHWE3
XSHWE2
SHCKE
SR1-CLK
VDD1
VDD2
VDD3
VDDQ1
VDDQ2
VDDQ3
VDDQ4
1
14
27
3
9
43
49
D15
D14
D13
D12
20
CE
22
OE
27
WE
D15
D14
D13
D12
D11
D10
D9
D8
2 5 4
RB809
100k
7
5
3
1
D31
D30
D29
D28
D27
D26
D25
D24
D23
D22
D21
D20
D19
D18
D17
VSS1
VSS2
VSS3
VSSQ1
VSSQ2
VSSQ3
VSSQ4
8
6
4
2
RB808
100k
8
6
4
2
D19
D18
D17
D16
53
51
50
48
47
45
44
42
13
11
10
8
7
5
4
2
28
41
54
6
12
46
52
7
5
3
1
RB804
100k
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
IC822
TC74LCX245FT(EKJ)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
007,008,009,011
MODE3
XCS0
XCS1
JIG-DET
IC830 (1/2)
TC7SZ04FU(TE85R)
+3.3V
D23
D22
D21
D20
BA1
BA0
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
19
18
17
16
15
13
12
11
C860
0.1uF
37
VCC
A19
DQ15/A-1
A18
DQ14
A17
DQ13
A16
DQ12
A15
DQ11
A14
DQ10
A13
DQ9
A12
DQ8
A11
DQ7
A10
DQ6
A9
DQ5
A8
DQ4
A7
DQ3
A6
DQ2
A5
DQ1
A4
DQ0
A3
A2
A1
A0
7
5
3
1
RB803
100k
8
6
4
2
21
20
35
22
34
33
32
31
30
29
26
25
24
23
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
1
26
2
23
21
24
25
3
4
5
6
7
8
9
10
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
+3.3V
9
16
17
48
1
2
3
4
5
6
7
8
18
19
20
21
22
23
24
25
D27
D26
D25
D24
28
VCC
A14
I/O7
A13
I/O6
A12
I/O5
A11
I/O4
A10
I/O3
A9
I/O2
A8
I/O1
A7
I/O0
A6
A5
A4
A3
A2
A1
A0
L812
10uH
C885
22uF
6.3V
3216
6
VSS1
18
VSS2
31
VSS3
42
VSS4
IC813
S29AL016D70TFI020
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
RB802
100k
8
6
4
2
8
6
4
2
CE
OE
WE
10
RESET NC1
13
BYTE
NC2
14
RY/BY NC3
VSS1 VSS2
27
46
+3.3V
7
5
3
1
1
14
27
3
9
43
49
D31
D30
D29
D28
D27
D26
D25
D24
D23
D22
D21
D20
D19
D18
D17
D16
C879
22uF
6.3V
CN805
GND
GND
GND
GND
+3V
+3V
+3V
+3V
(A22)
(A21)
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
CS0(JIG)
RD
WRH
WRL
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
Auto Update
JIG DET
+5V
+5V
+5V
+5V
GND
GND
GND
GND
26
28
11
12
47
15
XCS0(FLASH)
XRD
XSHWE3
45
43
41
39
36
34
32
30
44
42
40
38
35
33
31
29
10uH
+3.3V
C881
0.1uF
9
16
17
48
1
2
3
4
5
6
7
8
18
19
20
21
22
23
24
25
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
37
VCC
A19
DQ15/A-1
A18
DQ14
A17
DQ13
A16
DQ12
A15
DQ11
A14
DQ10
A13
DQ9
A12
DQ8
A11
DQ7
A10
DQ6
A9
DQ5
A8
DQ4
A7
DQ3
DQ2
A6
DQ1
A5
DQ0
A4
A3
A2
A1
A0
+3.3VL810
C893
0.1uF
IC819
MB86189PFV-G-BND-ER-E1
IC817
L811
10uH
C865 C869 C873 C877

0.1uF 0.1uF 0.1uF 0.1uF
C867 C871 C875
0.1uF 0.1uF 0.1uF
VDD1
VDD2
VDD3
VDDQ1
VDDQ2
VDDQ3
VDDQ4
C859
0.1uF
+3.3V
IC814
D31
D30
D29
D28
VSS1
VSS2
VSS3
VSSQ1
VSSQ2
VSSQ3
VSSQ4
+3.3V
8
6
4
2
28
41
54
6
12
46
52
RB801
100k
7
5
3
1
IC812
S29AL016D70TFI020
+3.3V
9-65
M
SY-364 (8/11)
007,009,011
007,009,011
007,009,011
SY-364 (8/11)
ADDRESS
DATA
CONTROL
IC852
TC7SH08FU(T5RSOYJF)
C902 +3.3V
0.1uF
RCP-COM-RX(Y)-in
C914 C916 C918 C919 C920 C921

0.1uF 0.1uF 0.1uF 1000pF 0.1uF 1000pF
C910
0.1uF
R972
1k
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
C915
1000pF
VDD4
BCLKA
TCLKA
BRVDA
XRTSA
XCTSA
RVDA
XRVDA
VDD3
VSS6
NTVDA
TVDA
BTVDA
TIN
TEB
TOUT3
TOUT2
TOUT1
TOUT0
VDD2
27MHz-XTAL-CLK
C907
0.1uF
C905
0.1uF
C903
22uF
6.3V
3216
IC851
TC7SH08FU(T5RSOYJF)
C901 +3.3V
0.1uF
700P-TX-CCU-DATA-out
R955
10k
2
1
CN102
(116/135) e22
C904
0.1uF
700P-RX-CAM-DATA-in
PHY-RX-DV
R979
33
R981 R983
1.5k 4.7k
007
L820
10uH
CN102
(115/135) d22
R978
33
R957
1k
+3.3V
5
R952
100 4
L821
10uH
R951
1k R953
47k
VSS7
BREAKA
CABLEA
PACKETA
TDI
TMS
TCK
BTVDB
TVDB
NTVDB
VSS8
VDD5
XRVDB
RVDB
XCTSB
XRTSB
BRVDB
TCLKB
BCLKB
VSS9
IC853
CXD9093R
VSS5
CLK
VSS4
XWAIT
TEST
XRD
NC
XWR
VDD1
VSS3
D7
D6
D5
D4
VSS2
D3
D2
D1
D0
VSS1
R970
10k
R971
10
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
X802
4 25MHz
VDD
1
3
CONT
OUT
GND
2
C917
0.1uF
R973
22
R974
4.7k
007,008,009,011
007
009
009
XWAIT
XRD-2
CPU-RESET
PHY-XFDX-LED
PHY-COL-LED
PHY-ACT-LED
C913
XSHWE0
0.1uF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
OVDD1
DVDD1
REGDVDD
REF_CLK
XTALO
XTALI
XTALGND
OVDD2/NC
RESET#
PHYAD0/FDX_LED#
PHYAD1/COL_LED#
PHYAD2/ACT_LED#
PHYAD3/PAUSE
PHYAD4
TESTEN
LOW_PWR
D7
D6
D5
D4
RXD0
RXD1
OVDD3
DGND2
IC854
RXD2
BCM5221A4KPT
RXD3
MDC
MDIO
DGND1
FDX
ANEN/TRST#
F100/TCK
SPDLED#/ADV_PAUSE#/TMS
LNKLED#/MEDIA_CONV#/TDI
XMTLED#/INTR#/FDXLED#
RCVLED#/ACTLED#/MDIX_DIS/TDO
PHY
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
PHY-ERXD0
PHY-ERXD1
PHY-ERXD2
PHY-ERXD3
PHY-MDC
PHY-MDIO
PHY-SPD-ST
PHY-LINK-ST
PHY-XMT-LED
PHY-RCV-LED
D3
D2
D1
D0
C922 C923
0.1uF 0.01uF
R980
100
C924
10uF
470->1k
R984 C925
R988
100 1000pF
100
R982 R985
R987 R989
100 100
100 100
R986
100
R975
1k
R977
0
CMD-IC-RESET
009
CN101
(29/135)
Ether-COM-TX(X)-out
Ether-COM-TX(Y)-out
Ether-COM-RX(X)-in
Ether-COM-RX(Y)-in
e4
e3
e2
e1
CN101
(23/135)
CN101
(17/135)
CN101
(11/135)
CN101
(5/135)
AGND
Ether-GND
d2
CN101
(10/135)
CS(700R)
R969
10k
CS(CHU)
CPU-RESET
e5
A0
A1
A2
A3
R962
2.2k
R961
10
007,008,009,011
Ether +3.3V
C927
0.1uF
C911 R968
0.1uF 10k
CS(700R)
CS(CHU)
C909
0.1uF
C906
0.1uF
009
009
C926
1000pF
470->220 R976
220
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
VDD6
BREAKB
CABLEB
PACKETB
INTA
INTB
TRST
TDO
RESET
XRESET
VSS10
VDD7
XCSA
XCSB
VSS11
A0
A1
A2
A3
VDD8
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
CN102
b23
(119/135)
Pin and Cap Connect List

OVDD Cap REGDVDD Cap REGAVDD Cap
1,46-DGND 3-DGND
20-DGND
R956
1k
JTAG_EN
DGND4
CRS/CRS_DV
COL
TXD3
TXD2
TXD1
TXD0
TXEN
DVDD2
DGND3
TXC
TXER
RXER
RXC
RXDV
RCP-COM-RX(X)-in
R959R960
6.8k6.8k
PHY-TX-ER
PHY-RX-ER
PHY-RX-CLK
+3.3V
+5V
ENERGY_DET
MII_EN
SDREGAVDD
SD+
BIASVDD
RDAC
BIASGND
RDRD+
AVDD1
AVDD2
AGND1
TDTD+
AGND2
CN102
b22
(113/135)
PHY
007
PHY-TX-CLK
2
1
PHY-CRS
PHY-COL
PHY-ETXD3
PHY-ETXD2
PHY-ETXD1
PHY-ETXD0
PHY-TX-EN
5
R954
100 4
RCP-COM-TX-out
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
CN102
(114/135) c22
R958
10k
+3.3V
7
5
3
1
R963
10k
RB826
10k
IC856 (1/2)
TC7SH04FU(T5RSOYJF)
8
6
4
2
R964
1k
IC855 (1/2)
TC7SH04FU(T5RSOYJF)R965
2
1k
R966
1k
R967
1k
IC855 (2/2)
TC7SH04FU(T5RSOYJF)
GND
XINT-700P-RCP
007
H:CONNECT-CHU
009
H:CONNECT-R
009
IC856 (2/2)
TC7SH04FU(T5RSOYJF)
5
C908
0.1uF
VCC
GND
C912
0.1uF
VCC
GND
007
+3.3V
+3.3V
XINT-700P-CHU
GND
9-66
A
9-66
HSCU-300
SY-364 (8/11)
SY-364 (8/11)
+3.3V
R1002
10k
007
xRESET
POW-DET
config
ConfDONE
PLD-ReConfig
R1001
100
re
1
IC***
AT
AVP
EP1C12
+3.3V
IC858
R3112N281A-TR-FA
td[s] = 0.69 x C[uF]

C929
0.1uF
4
NC
CD
GND
3
IC861 (1/5)
TC74LCX08FT(EKJ)
R1003
47k
2
VDD
1
OUT
1
2
EPCS4
C933 C934 C938

0.1uF 0.1uF 0.1uF
5
NM
NM
2
IC***
DTX
EP1C12
+3.3V
R1006
10k
GND
EPR2
R1007
100
IC861 (4/5)
TC74LCX08FT(EKJ)
12
13
IC861 (2/5)
TC74LCX08FT(EKJ)
11
4
5
R1004
100
003,004,005
AD/DA-RST
IC861 (3/5)
TC74LCX08FT(EKJ)
R1005
100
+3.3V
+3.3V
ASDO
R1010
R1011
R1012
10k
10k
10k
R1013
10k
10k
10k
IC857
EPCS16SI8N
R1008
R1016
0
NM
R1017
47
106
77
291
76
300
4
CN806
VCC
DATAOUT
ASDI
CONF_DONE
nCONFIG
DCLK
MODE(H)
GND
nCE
nCS
IC862
IDT71V016SA15PHG-TL
C962
0.1uF
GND
A-MA15 18
A-MA14 19
A-MA13 20
A-MA12 21
A-MA11 24
A-MA10 25
A-MA9 26
A-MA8 27
A-MA7 42
A-MA6 43
A-MA5 44
1
A-MA4
2
A-MA3
3
A-MA2
4
A-MA1
5
A-MA0
CONF_DONE[K17]
nCEO[K2]
nCE[J7]
nCONFIG[J2]
nSTATUS[L12]
47
1
GND
IC860 (1/2)
TC7SZ125FU(TE85R) R1021
GND
GND
GND
C944 C946 C949

10uF 10uF 10uF
A-MD7
A-MD6
A-MD5
A-MD4
A-MD3
A-MD2
A-MD1
A-MD0
RB824
100
2
4
6
8
2
4
6
8
RB825
100 GND
011
GND
C952 L823
10uF 1uH
VCCIO4_4[P11]
VCCIO4_3[P8]
VCCIO4_2[V14]
VCCIO4_1[V5]
VCCIO3_4[H12]
VCCIO3_3[M12]
VCCIO3_2[E18]
VCCIO3_1[P18]
VCCIO2_4[E9]
VCCIO2_3[E12]
VCCIO2_2[A5]
VCCIO2_1[A14]
VCCIO1_4[M7]
VCCIO1_3[G7]
VCCIO1_2[P1]
VCCIO1_1[E1]
VCCA_PLL2[J12]
302
VCCA_PLL1[J5]
229
IC800 (6/6)
EP1C12F324C8N(300)
+1.5V
GND
C955 C956
C953 C954 10uF 10uF
0.1uF 0.1uF
GND
GND
GND
GND
C960 C961
C958 C959 10uF 10uF
0.1uF 0.1uF
GND
GND
GND
GND
1
3
16
18
20
33
35
37
50
52
54
67
69
84
99
114
309
310
311
312
314
315
316
317
318
320
322
324
10
301
264
44
C936 C940 C942

0.1uF 0.1uF 0.1uF
GND
1
3
5
7
1
3
5
7
GND
GND1[A1]
GND2[C1]
GND3[T1]
GND4[V1]
GND5[V3]
GND6[V16]
GND7[V18]
GND8[T18]
GND9[C18]
GND10[A18]
GND11[A16]
GND12[A3]
GND13[B2]
GND14[U2]
GND15[U17]
GND16[B17]
GND17[H8]
GND18[J8]
GND19[K8]
GND20[L8]
GND21[L10]
GND22[L11]
GND23[K11]
GND24[J11]
GND25[H11]
GND26[H9]
GND27[K9]
GND28[J10]
GNDA_PLL1[K1]
GNDA_PLL2[K12]
GNDG_PLL1[J6]
GNDG_PLL2[J18]
C935 C939 C941

0.1uF 0.1uF 0.1uF
GND
C943 C945 C948
10uF 10uF 10uF
CONFIG_CHAIN
323
321
319
313
68
53
51
36
34
19
17
2
C947
10uF
GND
38
37
36
35
32
31
30
29
16
15
14
13
10
9
8
7
R1024
100k
C951
0.1uF
VCCINT12[K10]
VCCINT11[J9]
VCCINT10[H10]
VCCINT9[L9]
VCCINT8[A2]
VCCINT7[A17]
VCCINT6[B18]
VCCINT5[U18]
VCCINT4[V17]
VCCINT3[V2]
VCCINT2[U1]
VCCINT1[B1]
L822
1uH
VCC
GND
240
237
31
22
303
299
48
39
257
254
65
56
294
289
14
5
+3.3V
C950
0.1uF
11
33
VDD1 VDD2
A15 I/O15
A14 I/O14
A13 I/O13
A12 I/O12
A11 I/O11
A10 I/O10
I/O9
A9
A8
I/O8
I/O7
A7
I/O6
A6
I/O5
A5
A4
I/O4
A3
I/O3
A2
I/O2
A1
I/O1
A0
I/O0
3
GND
1
GND
+3.3V C1170
0.1uF
+3.3V A-M-CE 6 CS
A-M-OE 41 OE
22
A-M-WE 17 WE
NC1
40
23
BHE
NC2
39
28
BLE
NC3
VSS1 VSS2
12
34
47
+3.3V
+3.3V
CONFIG_nCE_1-2
IC859 (2/2)
IC860 (2/2)
VCC
GND
C928 C930 C931 C932

0.1uF 0.1uF 0.1uF 0.1uF
GND
GND
AUDIO-DLY
IC859 (1/2)
TC7SZ125FU(TE85R)R1020
12 11
GND
009
VCC
GND
GND
CONFIG_CONF_DONE
CONFIG_nSTATUS
CONFIG_nCONFIG
EPR2
0.1uF
136
MSEL0[K3]
292
MSEL1[K7]
+3.3V
1
2
3
4
5
6
7
8
9
10
+3.3V C957
290
DATA0[H7]
11
DCLK[L1]
47
GND
angle-type
003
IC861 (5/5)
TC74LCX08FT(EKJ)
107
TDI[J17]
43
TCK[K18]
247
TMS[K14]
278
TDO[K13]
GND
5
2
ASDI DATA
6
DCLK
1
CS
IC800 (5/6)
EP1C12F324C8N(300)
R1014
GND
R1015
GND
AUDIO-MUTE
009
CONFIG_DATA0
CONFIG_DCLK
3
VCC1
7
VCC2
8
VCC3
R1009
10k
C937 0.1uF
GND
CPU-AUDIO-MUTE
14
PLD-Config-Done
009
9
10
R1023
100
009
ok
007
nCSO
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
SY-364 (8/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_8
9-67
HSCU-300
9-67
M
SY-364 (9/11)
SY-364 (9/11)
+3.3V
R1064R1067 RB838
47k 47k
47k
IC875
TC74LCX245FT(EKJ)
+3.3V
1
3
5
7
C974
0.1uF
R1062
47k
a18
b18
c18
b19
R1050
RCP-PWR-OK/NG-in
R1051
R1052
RB830 1
CAM-POWER-Status-in
1k
3
Cable-SHORT-Status-in
5
Cable-OPEN-Status-in
7
(PWR-UNIT DC/AC-in)
2
3
4
5
6
7
8
9
1k
1k
1k
2
4
6
8
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
C965
C967 C969 C971
0.01uF 0.01uF0.01uF0.01uF
C966
C968 C970
0.01uF 0.01uF 0.01uF
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
1
3
5
7
1
3
5
7
RB851
1k
008
2
4
6
8
2
4
6
8
FAN2-ALARM-OK/NG
FAN1-ALARM-OK/NG
CAM-PWR-STATUS-OFF/ON
H:CABLE-SHORT
H:CABLE-OPEN
PWR-UNIT-DC/AC
RCP-PWR-OK/NG
009
009
009
003,009
003,009
009
009
ADDRESS
006
R1089
47k
D837
DAP222-TL
2
1k
1
3
R1142
AUX5
002
008
002
002
+3.3V
RB841
47k
1
3
5
7
1
3
5
7
MIC-GAIN-CTRL(2)
a9
b9
d9
e9
3
2
1
D839
DAP222-TL
003
1
3
5
7
1
3
5
7
RB839
47k
1k
2
4
6
8
2
4
6
8
Q819
DTC114EE-TL
WFM-RECALL(RGB)
009
WFM-RECALL(8)
009
WFM-RECALL(7)
009
Q818
Q817
Q816
Q815
WFM-RECALL(6)
009
WFM-RECALL(5)
009
WFM-RECALL(4)
009
WFM-RECALL(3)
009
WFM-RECALL(2)
009
WFM-RECALL(1)
009
002
DTC114EE-TL DTC114EE-TL DTC114EE-TL DTC114EE-TL

DTC114EE-TL DTC114EE-TL DTC114EE-TL
R1054
100
R1066
4.7k
Q810
2SC4617TL-QR
ASDO
+3.3V
8
6
4
2
2
3
4
5
6
7
8
9
2
4
6
8
1k
1k
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
20
VCC
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
MENU-Enter-in
MENU-Clear-in
MENU-on-in
DISP-on-in
Front-ENC(ENT)-in
PANEL_3V_REG_ON/OFF-out
009
009
009
009
009
001
009
PNL-IIC-SCL-out
009
009
009
009
009
INCOM-G1-out
INCOM-G0-out
INCOM-PW-OFF/ON
INCOM-UNBAL/BAL
MENU-LED-out
PANEL-ID-in
001
R1056
100
RB8421
1k
3
5
7
R1059
1k
1k
C972
0.01uF
+3.3V
GND
10
001
PNL-IIC-SDA
009
PNL-IIC-SDA-out
R1119
10k
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
IC873 (1/2)
TC7SZ125FU(TE85R)
4
R1120
100
C976
0.1uF
20
VCC
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
GND
GND
009 PNL-IIC-SCL-out
007 AD_SERIAL_DATA_IN
XINT-CPU-VD
007
009
A6
RB850
1k
1
3
5
7
R1099
2
4
6
8
100
PANEL_3V_REG_ON/OFF
A5
A0
IO91/LVDS19n[F3]
IO92/LVDS15p[G3]
IO93/LVDS13n[H3]
IO94/LVDS10n[L3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
A-MA14
007
A-M-OE
004
004
003
009
007
A-M-WE
CPU-PLD-Reserve
PGM2-Level-0/-20dB
PGM1-Level-0/-20dB
AD-PGM1/2
AD/DA-256FS
AD1_START
XSHWE0
A2
A3
A4
IO137/VREF0B1[D4]
IO139/LVDS18p[F4]
IO141/LVDS12p[H4]
IO142/PLL1_OUTp[K4]
IO143/LVDS9n[L4]
IO144/LVDS7n[M4]
IO146[P4]
A-MA13
A-MA5
PGM2-Level-*/+4dB
PGM1-Level-*/+4dB
005
DA-PROD/ENG
DA-FP/PGM
005
AD-PROD/ENG
007 AD_SERIAL_CLK
A-MD7
A-MD1
IO180/LVDS18n[F5]
IO183/PLL1_OUTn[K5]
IO184/LVDS9p[L5]
IO186/LVDS4p[N5]
004
004
003
A1
A-MA3
A-MA1
A-MA15
A-MD6
A-MD2
A-MA4
A-MA2
A-MD5
A-MD4
A-MD3
IO209/LVDS16p[F6]
IO211/VREF1B1[H6]
IO212/ASDO[K6]
IO213/LVDS11n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO234/LVDS16n[F7]
009
AD/DA-64FS
009 INCOM-G1-out
009 PNL-IIC-SDA-out
R1082
21
23
24
25
26
27
28
29
30
32
CL852
1.2 85
86
87
88
89
90
91
92
93
94
95
96
100 97
98
143
144
145
146
147
148
149
150
151
152
153
154
192
193
194
195
196
197
198
199
200
201
202
235
236
238
239
241
242
270
271
272
273
295
296
297
298
IO8/LVDS102n[V4]
IO9/LVDS98p[V6]
IO11/LVDS93n[V8]
IO12/LVDS91n[V9]
IO13/LVDS88n[V10]
IO14/LVDS85n[V11]
IO15/LVDS84p[V12]
IO48/LVDS102p[U3]
IO49/LVDS100n[U4]
IO53/LVDS93p[U8]
IO54/LVDS91p[U9]
IO55/LVDS88p[U10]
IO57/LVDS84n[U12]
IO61/LVDS76p[U16]
IO100/LVDS100p[T4]
IO102/LVDS96p[T6]
IO104/LVDS92p[T8]
IO105/LVDS90n[T9]
IO106/LVDS87p[T10]
IO107/LVDS86n[T11]
IO109/LVDS81p[T13]
IO111/LVDS76n[T15]
IO148/VREF2B4[R5]
IO149/LVDS96n[R6]
IO151/LVDS92n[R8]
IO153/LVDS87n[R10]
IO154/LVDS86p[R11]
IO156/LVDS81n[R13]
IO189/LVDS97n[P7]
IO190/VREF1B4[P9]
IO191[P10]
IO192[P12]
IO193/VREF0B4[P13]
IO217/LVDS101n[N8]
IO218/LVDS89n[N9]
IO219/LVDS80p[N10]
IO220/LVDS77p[N11]
IO236/LVDS101p[M8]
IO237/LVDS89p[M9]
IO238/LVDS80n[M10]
IO239/LVDS77n[M11]
IC800
(2/6)
EP1C12F324C8N(300)
IC800
(1/6)
EP1C12F324C8N(300)
R1130
10k
R1063
100
RB8431
100
3
5
7
FRONT-INC-PRIV/ENG
FRONT-INC-PRIV/PROD
135
CLK0/LVDSCLK1p[J3]
186
CLK1/LVDSCLK1n[J4]
R1094
10k
+3.3V
+3.3V
2
3
4
5
6
7
8
9
2
4
6
8
R1053
IC876
TC74LCX245FT(EKJ)
R1070
10k
R1057
10k
C973
0.1uF
R1077
10k
+3.3V
R1079
10
PGM-ON/OFF
MIC-ON/OFF
2
4
6
8
R1061
100
PNL-IIC-SCL
PNL-IIC-SDA-in
INCOM-G1
INCOM-G0
INCOM-PW
INCOM-UNBAL
MENU-LED
PANEL-EXIST/NONE
001
009
001
001
001
001
001
001,007,009
+3.3V
GND
10
C986
0.1uF
+3.3V
IC874
TC74LCX245FT(EKJ)
+3.3V
VCC
IC873 (2/2) GND

TC7SZ125FU(TE85R)
3
RB837 R1068
10k
10k
7
5
3
1
261
262
263
265
266
267
268
269
288
293
009 INCOM-PW-OFF/ON
009 INCOM-UNBAL/BAL
009 AD/DA-LRCK
HD-SYNC-OE
002
74MHz-PLD-CLK
181
182
183
184
185
187
188
189
190
191
225
226
227
228
230
231
232
233
234
SD-BURST-GATE
SD-REF-GATE
008
002
RB8351
1k
3
5
7
R1058
R1076
open-drain
REAR-PREVIEW-OFF/ON 009
R1065
10k
001
MENU-Enter
001
MENU-Clear
001
MENU-on
001
DISP-on
001
Front-ENC(ENT)
009 PANEL_3V_REG_ON/OFF
129
130
131
132
open-drain 133
134
137
138
open-drain 139
140
141
142
SD-ANA-SYNC
002
002
+3.3V
001
001
001
001
IO0[D1]
IO2/LVDS17p[G1]
IO3/DQ0L7[H1]
IO4/nCSO[J1]
IO5/DQ1L0[M1]
IO6/LVDS6p[N1]
IO7/VREF2B1[R1]
1k 70 IO36/LVDS23n[C2]
1k 71
IO37/LVDS22n[D2]
72
73
IO39/LVDS19p[F2]
R1098
1k 74
IO40/LVDS17n[G2]
75
IO41/LVDS13p[H2]
78
IO42/LVDS10p[L2]
79
80
IO44/LVDS6n[N2]
open-drain 81
82
IO46/LVDS1p[R2]
83
IO47/LVDS0p[T2]
i_SD-TEMP-H
HD-TEMP-H
002
HD-TEMP-V
002
009 INCOM-G0-out
DISP-on-in
009
009 MENU-LED-out
009 Front-ENC(ENT)-in
004
DA-MIC1/2
Q812
Q811
DTC114EE-TL
4
6
100 7
8
9
12
13
15
1k
002
Q813
Pre-View(rear)-out
DA-STBY/*
AD-STBY/FP
HD-ANA-SYNC2
002
002
74M-PLL-REF
002
REF-SD/HD
002
1001/1000
002
1000/1001
009 PNL-IIC-SDA-in
009 MENU-on-in
009 MENU-Enter-in
009 MENU-Clear-in
004
Q814
CN101
(102/135) c20
HD-REF-IN-INT/EXT
i_SD-TEMP-V
nCSO
REF-SEL(SD/HD24p)
MST-SD-F(MAIN)
o_EXT-REF-SYNC
R1126
003
002 DAC-SCL-PLD-out
002 DAC-LD-PLD-out
002
74M-PLL-VAR
MST-HD-F(MAIN)
002
REF-SEL(SD/HD60i)
002
002
REF-HD/SD
002
27M-PLL-REF
005 PROD-STATUS-RTS/4W
005
ENG-RTS/CC
004
2
4
6
8
2
4
6
8
R1055
RB833 1
1k
3
5
7
RB834 1
1k
3
5
7
R1092
PWR-OK/NG
001
002 DAC-SDA-PLD-out
i_SD-TEMP-SYNC
002
002 SD-REF-IN-INT/EXT
002
SP-BB-FRAME
002
27M-PLL-VAR
005 ENG-STATUS-RTS/4W
PROD-RTS/CC
005
2
3
2
3
2
3
2
3
2
3
a7
b7
d7
e7
WFM-Recall(RGB)-out
WFM-Recall(8)-out
WFM-Recall(7)-out
WFM-Recall(6)-out
WFM-Recall(5)-out
WFM-Recall(4)-out
WFM-Recall(3)-out
WFM-Recall(2)-out
WFM-Recall(1)-out
Rear-Alarm-NG/OK-in
D828
DAP222-TL
RB836
47k
R1060
47k
d5
R1141
AUX4
009
009
009
009
009
009
009
009
CN101
(3/135) c1
002
TRUNK-I/F-232C/422A
R1083
CN101
(98/135) e19 (RCP-PWR-NG-Status-in)
R1093
CN101
AUX3
(45/135) c8
D820
DAP222-TL
CN101
(28/135)
CN101
(37/135)
CN101
(38/135)
CN101
(40/135)
CN101
(41/135)
CN101
(49/135)
CN101
(50/135)
CN101
(52/135)
CN101
(53/135)
D838
DAP222-TL
2
1
1k
3
R1081
10k
R1080
1k
D834
D836
DAP222-TL
DAP222-TL
D833
D835
DAP222-TL
DAP222-TL
D824
DAP222-TL
D821
D827
DAP222-TL
DAP222-TL
+5V
006
MIC1-CTRL-ON/OFF
MIC2-CTRL-ON/OFF
ASPECT-CTRL(1)
ASPECT-CTRL(0)
MIC-GAIN-CTRL(1)
MIC-GAIN-CTRL(0)
ASPECT-CTRL-ON/OFF
2
4
6
8
2
4
6
8
2
4
6
8
2
4
6
8
RB831 1
1k
3
5
7
RB832 1
1k
3
5
7
MIC1-CTL-on/off-in
MIC2-CTL-on/off-in
Aspect-CTL(1)-in
Aspect-CTL(0)-in
MIC-Gain-CTL(1)-in
MIC-Gain-CTL(0)-in
MIC-Gain-CTL(2)-in
c5
002
3
2
3
2
3
2
3
2
a16
b16
d16
e16
d18
e18
d20
e20
CN101
(27/135)
GND
10
CN101
(76/135)
CN101
(77/135)
CN101
(79/135)
CN101
(80/135)
CN101
(91/135)
CN101
(92/135)
CN101
(103/135)
CN101
(104/135)
R1090
47k
+3.3V
D822
D829
DAP222-TL
DAP222-TL D831
D825
2
DAP222-TL
1 DAP222-TL
3
2
1
3
2
1
3
2
1
3
2
1
3
2
1
3
2
1
3
2
1
3
D823
D830
DAP222-TL
DAP222-TL
D826
D832
DAP222-TL
DAP222-TL
RB849
100k
007,008,011
+3.3V
RB852
1k
RB840
47k
AUDIO-DLY
2
4
6
8
a6
b6
c6
20
VCC
1
3
5
7
CN102
(31/135)
CN102
(32/135)
CN102
(33/135)
CN101
(88/135)
CN101
(89/135)
CN101
(90/135)
CN101
(95/135)
007 AD_SERIAL_DATA_OUT
007,008,011
CONTROL
2
4
6
8
9-68
A
9-68
HSCU-300
SY-364 (9/11)
SY-364 (9/11)
+3.3V
TALLY
R1108
100k
NM
R1110
100k
NM
BOARD-ID1
BOARD-ID0
R1109
0
R1097
D0
D2
D5
008 H:CONNECT-R
009 DPR-TX12-PGM12-out
009
009
011
DPR-64FS-out
DPR-RX56-INC12-IN
MST-HD-F(RET)
155
156
157
158
159
160
161
163
164
165
166
167
A-MA8
A-MA9
A-MA11
008
D4
D7
CPU-AUDIO-MUTE
008 H:CONNECT-CHU
009 DPR-TX56-INC12-out
009 ETHERNET-LED-OFF/ON
009
009
DPR-LRCK-out
DPR-RX34-AES12-IN
203
204
205
206
207
208
210
211
212
213
214
A-MA6
A-MA7
XRD-2
PRTCT-OFF/ON
007 AD_SEL_SY/PANEL
008
009
009
CMD-IC-RESET
DPR-TX34-SPA12-out
DPR-RX12-MIC12-IN
243
244
245
246
248
249
250
251
252
A-MA0
A-MA12
007
009
009
009
009
AD1_CS
CABLE-SHORT-LED-OFF/ON
CAM-POWER-LED-OFF/ON
MAIN-Alarm-LED-OFF/ON
CABLE-OPEN-LED-OFF/ON
009 REAR-PREVIEW-OFF/ON
274
275
276
277
279
280
281
282
283
304
A-MD0
A-M-CE
002
R1075
100
IC870 (2/3)
TLC272CPWR-12
5
7
C1B
5
INH
11
R1
12
R2
9
VCOIN
10
DEMO
15
PC3O
GND
8
R1114
2.2k
C981
0.1uF
R1102
22k
R1100
1k
C979
0.1uF
C980
22uF
6.3V
G-TALLY-IN
IO112/LVDS75n[T16]
IO113/LVDS73p[R16]
IO114/VREF2B3[P16]
IO115/LVDS69n[N16]
IO116/DQ1R0[M16]
IO119/LVDS61n[H16]
IO120/LVDS58p[G16]
IO121/LVDS54n[F16]
IO123/LVDS52n[D16]
CMD-Y-TALLY
IO160/LVDS69p[N15]
IO162/LVDS64p[L15]
IO164/LVDS62p[H15]
IO165/LVDS58n[G15]
IO168/LVDS52p[D15]
100
RET-64FS
RET-PGM1/2
RET-PGM3/4
FAN1-ALARM-OK/NG
H:CABLE-SHORT
H:CABLE-OPEN
RCP-PWR-OK/NG
(reserve)
011 PLD-PLD-RESERVE
011 RET-LRCK
R1123
R1124
R1125
R1088
R1122
47 55
220 57
IO27/LVDS45p[A13]
220 58
IO28/LVDS42p[A12]
59
60
IO30/LVDS38p[A10]
61
IO31/LVDS35n[A9]
62
IO32/LVDS33n[A8]
1k 63
64
IO34/VREF2B2[A6]
66
47
009
009
009
009
009
MIC-GAIN-CTRL(2)
MIC-GAIN-CTRL(0)
FAN2-ALARM-OK/NG
CAM-PWR-STATUS-OFF/ON
PWR-UNIT-DC/AC
001,007,009
PANEL-EXIST/NONE
CN101
(reserve)
(108/135) c21
CN101
(96/135) c19
CN101
(97/135) d19
(reserve)
(reserve)
Y-TALLY-IN
009
009
009
009
009
009
009
ASPECT-CTRL-ON/OFF
002
HD-ANA-SYNC1
MIC-GAIN-CTRL(1)
ASPECT-CTRL(1)
WFM-RECALL(4)
WFM-RECALL(7)
WFM-RECALL(5)
CAM-POWER-ON/OFF
R-TALLY-IN
FRAME-GATE
009,011
009 ASPECT-CTRL(0)
009 WFM-RECALL(3)
009 WFM-RECALL(6)
009 WFM-RECALL(RGB)
008
PHY-ACT-LED
008
PHY-COL-LED
008
PHY-RCV-LED
IO197[L14]
IO198/VREF1B3[J14]
IO199/LVDS62n[H14]
IO200/LVDS59p[G14]
IO201/LVDS55p[F14]
IO202/VREF0B3[E14]
009
TRIAX/COAX(BNC)-OUT
009 MIC2-CTRL-ON/OFF
009 WFM-RECALL(2)
002 HD-PEDE-CLIP
SD-SYNC-CLIP
002
008
PHY-XMT-LED
009 MIC1-CTRL-ON/OFF
009 WFM-RECALL(1)
009 WFM-RECALL(8)
SD-PEDE-CLIP
002
IO221/LVDS70p[N12]
IO222/LVDS70n[N13]
IO223/LVDS65n[M13]
IO224/LVDS65p[L13]
IO225/LVDS63n[J13]
IO228/LVDS55n[F13]
IO229/LVDS57p[F12]
IO240/LVDS57n[G12]
R1087
1k
R1085
1k
R1086
1k
115
116
117
118
119
120
121
122
123
124
125
126
127
128
168
169
170
171
172
173
174
175
176
177
178
179
180
215
216
217
218
219
220
221
222
223
224
253
255
256
258
259
260
284
285
286
287
305
306
307
308
IO74/LVDS50p[B16]
IO77/LVDS45n[B13]
IO78/LVDS42n[B12]
IO79/LVDS40n[B11]
IO80/LVDS38n[B10]
IO81/LVDS35p[B9]
IO82/LVDS33p[B8]
IO84/LVDS28n[B6]
IO124/LVDS50n[C16]
IO126/VREF0B2[C14]
IO129/LVDS41n[C11]
IO130/LVDS39n[C10]
IO131/LVDS36p[C9]
IO132/LVDS34p[C8]
IO133/LVDS30p[C7]
IO134/LVDS28p[C6]
GND
+
R1105
10 2 R1106
R1103
22k
47k
2
3
4
5
6
7
8
9
7
5
3
1
7
5
3
1
RB856
100
19
OE
1
DIR
+3.3V
C989
0.1uF
IC879
TC74LCX245FT(EKJ)
8
6
4
2
8
6
4
2
RB858
100
7
5
3
1
7
5
3
1
RB859
100
AUDIO-TX12-PGM-out
AUDIO-TX34-RET-out
AUDIO-TX56-Incom-out
AUDIO-TX64FS-out
AUDIO-TX-LRCK-out
DPR-RX12-MIC12-IN
DPR-RX34-AES12-IN
DPR-RX56-INC12-IN
CN102
e24 (128/135)
CN102
d24 (127/135)
CN102
c24 (126/135)
CN102
b24 (125/135)
CN102
a24 (124/135)
009
009
009
MB-GND
MB-GND
CN102
b25
(131/135)
CN102
a25 (130/135)
GND
10
TP802
TP801
64FS
009
AD/DA-LRCK
009
AD/DA-64FS
R1131
100
R1132
100
2
3
4
5
6
7
8
9
20
VCC
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
GND
+3.3V
009
R1133
100
AD/DA-256FS
2
3
4
5
6
7
8
9
20
VCC
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
B1
B2
B3
B4
B5
B6
B7
B8
LRCK
18
17
16
15
14
13
12
11
AD/DA-LRCK1
AD/DA-LRCK2
AD/DA-LRCK3
AD/DA-LRCK4
AD/DA-64FS1
AD/DA-64FS2
AD/DA-64FS3
AD/DA-64FS4
003
003
004
005
DA-STBY/*,AD-STBY/FP
DA-FP/PGM,AD-PGM 1/2
DA-MIC 1/2
DA-PROD/ENG,AD-PROD/ENG
DA-MIC 1/2
003
003
004
005
DA-MIC 1/2
003
003
004
005
GND
10
IC880
TC74LCX245FT(EKJ)
TP803
C990
0.1uF
B1
B2
B3
B4
B5
B6
B7
B8
256Fs
18
17
16
15
14
13
12
11
AD/DA-256FS1
AD/DA-256FS2
AD/DA-256FS3
AD/DA-256FS4
AD_CLK_256FS
007
GND
10
GND
+3.3V
R1136
22k
Q820
2SC4617TL-QR
R1134
100
009
IO230/LVDS49p[F11]
IO231/LVDS46p[F10]
IO232/LVDS37p[F9]
IO233/LVDS25n[F8]
IO241/LVDS49n[G11]
IO242/LVDS46n[G10]
IO243/LVDS37n[G9]
IO244/LVDS25p[G8]
Q821
2SC4617TL-QR
R1140
100
R1137
100
b3
CN101
(14/135)
C991
100pF
CAM-POWER-ON/OFF
R1135
47k
C994
0.01uF
R1139
10k
IC881
TC74LCX245FT(EKJ)
+3.3V
C988
0.1uF
IC800
(4/6)
EP1C12F324C8N(300)
009
009
009
009
009
009
009,011
ETHERNET-LED-OFF/ON
CABLE-SHORT-LED-OFF/ON
CABLE-OPEN-LED-OFF/ON
CAM-POWER-LED-OFF/ON
MAIN-Alarm-LED-OFF/ON
TRIAX/COAX(BNC)-OUT
FRAME-GATE
2
3
4
5
6
7
8
9
A1
A2
A3
A4
A5
A6
A7
A8
19
OE
1
DIR
18
17
16
15
14
13
12
11
B1
B2
B3
B4
B5
B6
B7
B8
GND
IO203[E13]
IO204[E11]
IO205/VREF1B2[E10]
IO208/LVDS29n[E6]
IC800
(3/6)
EP1C12F324C8N(300)
A1
A2
A3
A4
A5
A6
A7
A8
C993
0.1uF
GND
L831
10uH
C982
C984
10uF 0.1uF
6.3V
X803
24.576MHz
4
C985
R1107
R1112 22pF
100
VDD
1
3 100
VC
OUT
GND
2
8
6
4
2
8
6
4
2
DPR-TX12-PGM12-out
DPR-TX34-SPA12-out
DPR-TX56-INC12-out
DPR-64FS-out
DPR-LRCK-out
AUDIO-RX12-MIC-in
AUDIO-RX34-AES-in
AUDIO-RX56-Incom-in
IO172/LVDS41p[D11]
IO173/LVDS39p[D10]
IO175/LVDS34n[D8]
IO176/LVDS30n[D7]
IO177/LVDS29p[D6]
R1118
2.2k
GND
003
100
009
009
009
009
009
CN102
(122/135) e23
CN102
(121/135) d23
CN102
(120/135) c23
IC870 (1/3)
R1104 TLC272CPWR-12
10
R1101
33k
IO62/LVDS75p[T17]
IO63/LVDS74n[R17]
IO64/DQ1R6[P17]
IO65/LVDS71p[N17]
IO67/LVDS66p[L17]
IO68/LVDS61p[H17]
IO70/LVDS56p[F17]
IO72/LVDS51p[D17]
IO73/LVDS51n[C17]
R1073
R1074
STBY-INCOM MUTE
TONE-DETECT
209
CLK2/LVDSCLK2p[J15]
162
CLK3/LVDSCLK2n[J16]
R1117
10
+5V
IO18/LVDS74p[R18]
IO19/LVDS71n[N18]
IO20/LVDS68n[M18]
IO21/LVDS66n[L18]
IO22/DQ0R7[H18]
IO24/LVDS56n[F18]
IO25/DQ0R0[D18]
1k
1k
20
VCC
20
VCC
B1
B2
B3
B4
B5
B6
B7
B8
18
17
16
15
14
13
12
11
R1138
8
RB857 6
100 4
2
R1084
R1143
100
7
5
3
1
1k
100
4
ETHERNET-LED-out
CABLE-SHORT-LED-out
CABLE-OPEN-LED-out
CAM-POWER-LED-out
MAIN-Alarm-LED-out
TRIAX/Co-AX(BNC)-out
Frame-Reset-Gate-out
a19
d5
e5
e6
d6
a3
d4
CN101
(94/135)
CN102
(28/135)
CN102
(29/135)
CN102
(35/135)
CN102
(34/135)
CN101
(13/135)
CN102
(22/135)
GND
10
IC871 (1/2)
TC7SZ04FU(TE85R)
R1115
1M
+3.3V
C983
0.1uF
SY-364 (9/11)
IC871 (2/2) VCC

TC7SZ04FU(TE85R) GND
BOARD NO. 1-879-650-11
6 -
16
3
VCC
CIN
1
4
PCPO
VCOUT
2
14
SIN
PC1O
13
6
C1A
PC2O
V+
GND
R1113
10
009
003,009
003,009
009
CN101
(114/135) c22
R1071
R1072
RB855
100
R1095
R1069 4.7k
100
C978
0.1uF
R1096
4.7k
27MHz-PLD-CLK
IC870(3/3)
TLC272CPWR-12
C977
10uF
6.3V
100 38
40
41
42
45
46
47
49
100
101
102
103
104
105
108
109
110
111
112
113
A-MA10
IC877
MC74HC4046ADTR2
TONE1-DETECT-in
TONE0-DETECT-in
CCU-ID1-in(Pull-Up)
CCU-ID0-in(Pull-Up)
011
011
011
CPU-RESET
D1
D3
D6
CS(PLD_SY)
d21
e21
d22
e22
R1111
0
007,008,011
CMD-G-TALLY
CMD-R-TALLY
8
6
4
2
CN101
(109/135)
CN101
(110/135)
CN101
(115/135)
CN101
(116/135)
+3.3V
DATA
L830
10uH
+3.3V
RB844
47k
007,008,011
+5V
IC883
TC74LCX245FT(EKJ)
7
5
3
1
006
HDCU-300_SY-364_011_9
9-69
HSCU-300
9-69
M
SY-364 (10/11)
+1.8V
FB904
C1020
1uF
NM
R1154 GND
100
NM
R1155
100
NM
SDI INPUT
CN101
(130/135) a25
CN101
(124/135) a24
CN101
(131/135)
CN101
(125/135)
CN101
(119/135)
CN101
(118/135)
b25
b24
b23
a23
FB902
HD/SD-SDI-RET1-in(Y)
HD/SD-SDI-RET1-in(X)
C1007
22uF
6.3V
Guard-GND
Guard-GND
Guard-GND
Guard-GND
R1248
100
NM
GND
R1247
100
NM
R1156
120
NM
GND
R1150
100
NM
R1151
100
NM
R1157
120
NM
GND GND
C1084 C1085
0.1uF 0.1uF
NM
NM
1
2
3
VCO_GND_1
4
GND C1008
5
4.7uF
6
0
R1162
7
GND
8
9
R1256 330 10
+1.8V
11
GND
12
FB914
C1086
GND 0.01uF 13
14
R1170 0 15
CL901
0.8
16
GND
C1025 0.01uF 17
18
RET1-SP00
GND
19
RET1-SP01
20
RET1-SP03
21
RET1-SP05
22
RET1-SP07
23
RET1-SP09
24
RET1-SP11
25
RET1-SP13
C1003 R1159
0.0022uF 0
+1.8V
+3.3V
FB903
C1024
1uF
GND
RET1-SP15
RET1-SP17
RET1-SP19
RET1-SP18
FB905
CL902 CL903 C1022
0.8 1uF
0.8
100
99
98
97
96
95
94
93
92
91
90
89
88 R1164 1k
87
86
85
84
83
82
81
80
79
78
77
76
GND
R1169
220
GND
LF[A1]
CP_CAP[B1]
BUFF_VDD[C1]
DDI1[D1]
DDI1[E1]
CD1[F1]
DDI2[G1]
DDI2[H1]
CD2[J1]
RSET[K1]
CD_VDD[K2]
SDO[K3]
SDO[K4]
CD_GND[K5]
JTAG/HOST[K6]
F[K7]
IO_VDD1[K8]
DOUT0[K9]
DOUT1[K10]
DOUT3[J10]
DOUT5[H10]
DOUT7[G10]
DOUT9[F10]
DOUT11[E10]
DOUT13[D10]
+3.3V
+1.8V
CL904
0.8
GND
C1009
0.01uF
GND
VCO_VCC_1 C1027 0.01uF
R1168
GNDGND
0
C1026
X900
GND
R1259
C1014
1uF
+3.3V
1483.5-1485.0MHz
10
0.01uF GND +3.3V
R1257
4.7k
C1006
VCO_VCC_1
7
GND
R1165 0.01uF
FB906
VCC
0
NM
5 CONT
1
C1015
OUT
G1 G2 G3 G4
1uF
R1166
1k
2 4 6 8
NM
R1258
RET1 PCLK
4.7k
C1018
1uF
NM
R1261
C1087 0
0.01uF
GND
NM
R1178
100
NM
R1182
100
NM
NM
R1180 GND
100
NM
GND
CL907
0.8
75
74 RET1 ERR
RET1-ERROR
73 CL900
1.2
72 R1174 0
71 R1171 0 NM +3.3V
70
69
R1172 GND
1k
68
67 VCO_VCC_1
R1161
66
3.6k
NM
65
C1004
0.1uF
64
63
R1249
62 GND
6.8k
61
R1175
0
60
59
GND
58 GND
57
56
55
54
53
52
51
SDI INPUT
CN101
(112/135) a22
CN101
(106/135) a21
CN101
(113/135)
CN101
(107/135)
CN101
(101/135)
CN101
(100/135)
b22
b21
b20
a20
R1183
100
NM
FB909
HD/SD-SDI-RET2-in(Y)
HD/SD-SDI-RET2-in(X)
C1035
22uF
6.3V
Guard-GND
Guard-GND
Guard-GND
Guard-GND
R1176
100
NM
GND
R1158
33k
VCO_GND_1
R1251
100
NM
R1252
100
NM
R1179
120
NM
R1181
120
NM
GND GND
C1029 C1079
0.1uF 0.1uF
NM
NM
RET1-SP16
RET1-SP14
RET1-SP12
RET1-SP10
RET1-SP08
RET1-SP06
RET1-SP04
RET1-SP02
GND
R1177
100
NM
1
2
3
VCO_GND_2
4
GND C1036
5
4.7uF
6
0
R1188
7
GND
8
9
R1191 330 10
+1.8V
11
GND
12
FB915
C1089
GND 0.01uF 13
14
R1196 0 15
CL909
0.8
16
GND
C1053 0.01uF 17
18
RET2-SP00
GND
19
RET2-SP01
20
RET2-SP03
21
RET2-SP05
22
RET2-SP07
23
RET2-SP09
24
RET2-SP11
25
RET2-SP13
C1031 R1185
0.0022uF 0
+1.8V
+3.3V
FB910
C1052
1uF
GND
+3.3V
RET1-PCLK
C1049
0.01uF
C1047
0.01uF GND
LF[A1]
CP_CAP[B1]
BUFF_VDD[C1]
DDI1[D1]
DDI1[E1]
CD1[F1]
DDI2[G1]
DDI2[H1]
CD2[J1]
RSET[K1]
CD_VDD[K2]
SDO[K3]
SDO[K4]
CD_GND[K5]
JTAG/HOST[K6]
F[K7]
IO_VDD1[K8]
DOUT0[K9]
DOUT1[K10]
DOUT3[J10]
DOUT5[H10]
DOUT7[G10]
DOUT9[F10]
DOUT11[E10]
DOUT13[D10]
RET2-SP15
RET2-SP17
RET2-SP19
RET2-SP18
GND
CL906
0.8
GND
R1193
47k
R1195
220
GND
011
011
RET2-LOCKED
+3.3V
FB912
CL910 CL911 C1050
0.8 1uF
0.8
CL912
0.8
C1051
0.01uF
R1186
NM
0 GND
GND
H[H8]
DATA_ERROR[H7]
SDOUT_TDO[H6]
SCLK_TCK[H5]
CS_TMS[H4]
NC14[H3]
NC13[G3]
NC12[F3]
NC11[E3]
NC10[D3]
PDBUFF_GND[C3]
CP_GND[B3]
LB_CONT[B4]
NC9[B5]
NC8[B6]
FW_EN/DIS[B7]
IO_GND2[B8]
DOUT16[B9]
DOUT14[C9]
DOUT12[D9]
DOUT10[E9]
DOUT8[F9]
DOUT6[G9]
DOUT4[H9]
DOUT2[J9]
IC902
GS-1559-CBE2
C1037
0.01uF
GND
VCO_VCC_2 C1055 0.01uF
GNDGND
R1194
0
C1054
X901
R1264
GND
C1042
1uF
+3.3V
1483.5-1485.0MHz
10
0.01uF GND +3.3V
R1262
4.7k
C1034
VCO_VCC_2
7
GND
R1267 0.01uF
FB913
VCC
0
NM
5 CONT
1
C1043
OUT
G1 G2 G3 G4
1uF
R1192
1k
2 4 6 8
NM
R1263
RET2 PCLK
4.7k
C1046
1uF
NM
VCO_GND_1
C1013
470pF
NM
FB907
NM
C1030
0.1uF
C1028
0.1uF
H[H8]
DATA_ERROR[H7]
SDOUT_TDO[H6]
SCLK_TCK[H5]
CS_TMS[H4]
NC14[H3]
NC13[G3]
NC12[F3]
NC11[E3]
NC10[D3]
PDBUFF_GND[C3]
CP_GND[B3]
LB_CONT[B4]
NC9[B5]
NC8[B6]
FW_EN/DIS[B7]
IO_GND2[B8]
DOUT16[B9]
DOUT14[C9]
DOUT12[D9]
DOUT10[E9]
DOUT8[F9]
DOUT6[G9]
DOUT4[H9]
DOUT2[J9]
IC901
GS-1559-CBE2
GND
+3.3V
R1189
1k
FB911
C1048
1uF
C1023
0.01uF
R1160
NM
0 GND
DOUT15[C10]
DOUT17[B10]
DOUT19[A10]
DOUT18[A9]
IO_VDD2[A8]
PCLK[A7]
NC1[A6]
VCO[A5]
VCO[A4]
VCO_GND[A3]
VCO_VCC[A2]
CP_VDD[B2]
PD_VDD[C2]
NC2[D2]
TERM1[E2]
NC3[F2]
NC4[G2]
TERM2[H2]
NC5[J2]
NC6[J3]
NC7[J4]
SDO_EN/DIS[J5]
SDIN_TDI[J6]
V[J7]
IO_GND1[J8]
NM
R1153
100
NM
R1152
100
NM
GND
0.01uF
SDI2_RESET
26
27
28
29
30
31
TP901 32
R1260 10
33
C1005 C1017 0.01uF 34
0.01uF NM
35
C1016 36
C1010 0.01uF 37
FB901
4.7uF
C1011 0.01uF 38
C1012 0.01uF 39
40
41
42
43
44
45
46
47
R1173 1k 48
49
50
FB900
NM
C1002
0.1uF
GND
R1167
47k
C1021
0.01uF
C1019
011
SDI-RET2
RET2-SD/HD
RET2-20/10
RET2-M/S
RET1-LOCKED
+3.3V
CORE_VDD2[E6]
CORE_VDD1[F6]
CORE_GND2[F5]
CORE_GND1[E5]
DVB_ASI[D5]
LOCKED[D6]
NC20[D7]
NC19[E7]
NC18[F7]
NC17[G7]
RESET_TRST[G6]
SMPTE_BYPASS[G5]
IOPROC_EN/DIS[G4]
20BIT/10BIT[F4]
SD/HD[E4]
IP_SEL[D4]
NC16[C4]
NC15[C5]
MASTER/SLAVE[C6]
RC_BYP[C7]
YANC[C8]
CANC[D8]
IO_VDD3[E8]
IO_GND3[F8]
FIFO_LD[G8]
GND
+3.3V
C1000
0.1uF
R1163
1k
SDI2_CTRL
87
86
85
84
83
82
81
80
79
78
77
76
+3.3V
011
100
99
98
97
96
95
94
93
92
91
90
89
88 R1190 1k
SDI1_RESET
011
CORE_VDD2[E6]
CORE_VDD1[F6]
CORE_GND2[F5]
CORE_GND1[E5]
DVB_ASI[D5]
LOCKED[D6]
NC20[D7]
NC19[E7]
NC18[F7]
NC17[G7]
RESET_TRST[G6]
SMPTE_BYPASS[G5]
IOPROC_EN/DIS[G4]
20BIT/10BIT[F4]
SD/HD[E4]
IP_SEL[D4]
NC16[C4]
NC15[C5]
MASTER/SLAVE[C6]
RC_BYP[C7]
YANC[C8]
CANC[D8]
IO_VDD3[E8]
IO_GND3[F8]
FIFO_LD[G8]
011
SDI-RET1
RET1-SD/HD
RET1-20/10
RET1-M/S
DOUT15[C10]
DOUT17[B10]
DOUT19[A10]
DOUT18[A9]
IO_VDD2[A8]
PCLK[A7]
NC1[A6]
VCO[A5]
VCO[A4]
VCO_GND[A3]
VCO_VCC[A2]
CP_VDD[B2]
PD_VDD[C2]
NC2[D2]
TERM1[E2]
NC3[F2]
NC4[G2]
TERM2[H2]
NC5[J2]
NC6[J3]
NC7[J4]
SDO_EN/DIS[J5]
SDIN_TDI[J6]
V[J7]
IO_GND1[J8]
SDI1_CTRL
CL913
0.8
75
74 RET2 ERR
RET2-ERROR
73 CL905
1.2
72 R1200 0
71 R1197 0 NM +3.3V
70
69
R1198 GND
1k
68
67 VCO_VCC_2
R1187
66
3.6k
NM
65
C1032
0.1uF
64
63
R1250
62 GND
6.8k
61
R1201
0
60
59
GND
58 GND
57
56
55
54
53
52
51
R1184
33k
VCO_GND_2
RET2-SP16
RET2-SP14
RET2-SP12
RET2-SP10
RET2-SP08
RET2-SP06
RET2-SP04
RET2-SP02
26
27
28
29
30
31
TP902 32
R1265 10
33
C1033 C1045 0.01uF 34
0.01uF NM
35
C1044 36
C1038 0.01uF
FB908
37
4.7uF
C1039 0.01uF38
C1040 0.01uF39
40
41
42
43
44
45
46
47
R1199 1k 48
49
50
011
SY-364 (10/11)
R1266
C1088 0
0.01uF
GND
GND
CL908
0.8
+3.3V
RET2-PCLK
011
VCO_GND_2
C1041
470pF NM
9-70
A
9-70
HSCU-300
SY-364 (10/11)
SY-364 (10/11)
VBS_RET
011
1
VBS_NONE/EXIST
+5V
L904
10uH
C1056
0.1uF
R1202
330
1 4
+5V
R1212
100
C1001
0.01uF
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
C1067
0.1uF
A.G
C1060
1uF
C1058
22pF
NM
R1203
0
C1057
0.1uF
R1213
33k
IC904
TC7W53FK(TE85R)
1
IC905(1/2)
TC7SET08FU(T5RSOJF)
GND
VBS-RET1/RET2
R1255
3.3k
C1062
0.1uF
-5V
VCC
GND
2
1
R1253
47
8
7
VCC
COMMON CH0
5
A
2
INH
GND
4
CH1
C1063
0.1uF
6
R1209
4.7k
VEE
3
Q909
XN6435-TX
R1207
100 2
Return2-VBS(X)-in
C1082
0.1uF
R1204
330
R1205
0
CN101
(121/135) d23
R1210
10k
C1064
0.1uF
3 6
5
R1211
10k
ADGND1
ADVDD1
VIN1
VIN2
VIN3
VIN4
VIN5
VIN6
AVDD1
AGND1
REFP1
CM1
REFN1
REFP2
CM2
REFN2
AVDD2
AGND2
LPFOUT1
LPFOUT2
AVDD3
AGND3
ADVDD2
ADGND2
ADGND3
L908
10uH
C1065
47uF
6.3V
C1083
0.01uF
A.G
Return2-VBS(G)-in
011
011
C1068
0.1uF
+3.3V
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
1 4
R1214
33k
R1217
0
R1220
R1221
R1219
47k
SCL
007
SDA_in/out
011
VSB_CLKO
IC903
ML86V7666TBZ03A
CLKSEL
CLKX2
DGND4
DVDD11
CLKX2O
CLKXO
ODD/EVEN
HSYNC_L
VSYNC_L
VVALID
HVALID
DGND3
DVDD10
Y9
Y8
Y7
Y6
Y5
Y4
Y3
Y2
Y1/B0
Y0/B1
DGND2
DVDD9
GND
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
R1241
10
C1074
0.1uF
R1242 22
VBS_CLKI
R1243 22
NM
VBS-F
R1244
100
R1245
100
VBS-V
R1246 100
C1075
0.1uF
VBS-H
VBS-D9
VBS-D8
VBS-D7
VBS-D6
VBS-D5
VBS-D4
VBS-D3
VBS-D2
VBS-D1
VBS-D0
C1076
0.1uF
C1073
0.1uF
C1071
0.1uF
R1218
0
SLEEP
VBS_RESET
007
C1077
10uF
PGND
PLLLPF
PLLVREF
PVDD
DGND6
DVDD12
INS0
INS1
INS2
GAINS0
GAINS1
GAINS2
MODE0
MODE1
MODE2
MODE3
DGND5
M0
M1
M2
STATUS1
STATUS2
CSYNC/SCALR
VHVAL/SCALW
PLLSEL
3 6
R1236
10k
GND
L905
10uH
IC905 (2/2)
TC7SET08FU(T5RSOJF)
CN101
(122/135) e23
C1066
47uF
6.3V
3 6
R1206
100 2
R1234
10k
C1070
0.1uF
R1240
R1215
5 100
Return1-VBS(G)-in
C1081
10uF
6.3V
011
C1069
10uF
L909
10uH
MODE[3,2]=[0,1]:10bit
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
Return1-VBS(X)-in
C1080
10uF
6.3V
C1078
0.1uF
1 4
R1254
100
Q908
XN6435-TX
VBS INPUT
CN101
(128/135) e24
Q910
XN6534-TX
L911
10uH
C1072
0.1uF
DVDD7
SCAN
TEST0
TEST1
TEST2
SLEEP
RESET_L
SCL
SDA
DVDD8
DGND1
C9
C8
C7
C6
C5
C4
C3
C2
C1/B7
C0/B6
B5
B4
B3
B2
R1208
4.7k
CN101
(127/135) d24
L910
10uH
+3.3V
+3.3V
R1239
100
+3.3V
GND
R1225
10
10
10
R1223
10
+3.3V
R1227
10k
R1228
10k
SY-364 (10/11)
BOARD NO. 1-879-650-11
HDCU-300_SY-364_011_10
9-71
HSCU-300
9-71
M
SY-364 (11/11)
011
011
010
SDI-RET1
010
SDI-RET2
010
SDI2_CTRL
010
RB900 220
RET1-SP09
1
2
RET1-SP08
3
4
RET1-SP07
5
6
RET1-SP06
7
8
RET1-SP05
1
2
RET1-SP04 RB901 3
4
220
RET1-SP03
5
6
RET1-SP02
7
8
RET1-SP01 R1300
220
RET1-SP00
R1301
220
RET1-SP19 RB9021
RET1-SP18 220 3
RET1-SP17
5
RET1-SP16
7
RET1-SP15 RB903 1
220
RET1-SP14
3
RET1-SP13
5
RET1-SP12
7
RET1-SP11 R1302
RET1-SP10
R1303
RET1-ERROR
R1305
RET1-LOCKED R1306
VIDEO-TRUNK-BUS
HD-RET-BUS
SDI1_CTRL
SY-364 (11/11)
RET2-SP09
RET2-SP08
RET2-SP07
RET2-SP06
RET2-SP05
RET2-SP04
RET2-SP03
RET2-SP02
RET2-SP01
RET2-SP00
RET1_SP09
RET1_SP08
RET1_SP07
RET1_SP06
RET1_SP05
RET1_SP04
RET1_SP03
RET1_SP02
RET1_SP01
RET1_SP00
7
5
3
1
7
RB905 5
220 3
1
R1310
R1311
R1313
RET2-ERROR
RET2-SP19
1
RET2-SP18
RB906 3
220 5
RET2-SP17
RET2-SP16
7
RET2-SP15
1
RET2-SP14
RB907 3
220
RET2-SP13
5
RET2-SP12
7
RET2-SP11
1
RET2-SP10
RB908 3
220
RET2-LOCKED
5
7
2
4
6
8
2
4
6
8
220
RET1_SP19
RET1_SP18
RET1_SP17
RET1_SP16
RET1_SP15
RET1_SP14
RET1_SP13
RET1_SP12
RET1_SP11
220
RET1_SP10
220
RET1_ERR
220 RET1_LOCKED
RB904
220
8
6
4
2
8
6
4
2
220
RET2_SP09
RET2_SP08
RET2_SP07
RET2_SP06
RET2_SP05
RET2_SP04
RET2_SP03
RET2_SP02
RET2_SP01
220
RET2_SP00
220
RET2_ERR
2
RET2_SP19
4
RET2_SP18
6
RET2_SP17
8
RET2_SP16
2
RET2_SP15
4
RET2_SP14
6
RET2_SP13
8
RET2_SP12
2
RET2_SP11
4
RET2_SP10
6 RET2_LOCKED
8
010
VBS_RET
RET1_LOCKED
RET1-M/S
RET1_SP15
RET1_SP13
70
71
72
73
74
75
78
79
80
81
82
83
TRUNK-C3
CL924
1.2
TRUNK-C9
CL921
1.2
RET1_SP14
RET1_SP12
RET2_SP18
1
RET2-M/S
RET2-SD/HD 3
RET2-20/10 5
7
010
RB909
220
129
130
131
132
133
134
137
138
139
140
141
142
TRUNK-C2
TRUNK-C6
TRUNK-Y2
TRUNK-Y4
HD-RET-C7
2
4
6
8
SDI1_RESET
RET2_SP17
RET2_SP19
181
TRUNK-C5
182
TRUNK-Y3
183
TRUNK-Y5
184
HD-RET-C6
185
TRUNK-Y9
R1350
100 187
188
189
190
191
007,008,009
CPU-RESET
225
226
227
TRUNK-Y7
228
HD-RET-C4
230
220
R1340
231
232
220 233
R1308
234
TRUNK-Y6
009
FRAME-GATE
RET1-SD/HD
RET1_SP19
261
262
263
265
266
267
220 268
R1309
269
288
HD-RET-C8
293
TRUNK-CLK
HD-RET-C9
TRUNK-Y8
HD-RET-C5
R1330 0 NM
RET1-20/10
RET1_SP16
002
010
27MHz-RET-PLD-CLK
RET2-PCLK
R1342
R1312
10
10
IO0[D1]
IO2/LVDS17p[G1]
IO3/DQ0L7[H1]
IO4/nCSO[J1]
IO5/DQ1L0[M1]
IO6/LVDS6p[N1]
IO7/VREF2B1[R1]
SDRAM-DATA
RET1_SP11
RET1_SP09
RET1_SP07
RET1_SP05
RET1_SP03
VBS_D9
IO209/LVDS16p[F6]
IO211/VREF1B1[H6]
IO212/ASDO[K6]
IO213/LVDS11n[L6]
IO214/LVDS5p[M6]
IO215/LVDS4n[N6]
IO216/LVDS5n[N7]
IO234/LVDS16n[F7]
135
CLK0/LVDSCLK1p[J3]
186
CLK1/LVDSCLK1n[J4]
R1352
2.2k
RET-PGM3/4
RET-PGM1/2
VBS_D8
VBS_D7
VBS_D3
VBS_D1
192
193
194
195
196
197
198
199
200
201
202
RET2_SP13
RET2_SP15
RET2_SP10
RET2_SP09
RET2_SP07
RET2_SP05
RET2_ERR
RET1_SP18
RET1_SP17
RET2_SP16
VBS_N/E
VBS_D6
010
SDI2_RESET
RET2_SP02
VBS_V
VBS_F
RET2_SP03
RET2_SP01
RET2_SP00
010
VSB_CLKO
011
SDRAM-DATA
235
236
238
239
241
242
270
271
272
273
295
296
297
298
IO8/LVDS102n[V4]
IO9/LVDS98p[V6]
IO11/LVDS93n[V8]
IO12/LVDS91n[V9]
IO13/LVDS88n[V10]
IO14/LVDS85n[V11]
IO15/LVDS84p[V12]
IO48/LVDS102p[U3]
IO49/LVDS100n[U4]
IO53/LVDS93p[U8]
IO54/LVDS91p[U9]
IO55/LVDS88p[U10]
IO57/LVDS84n[U12]
IO61/LVDS76p[U16]
IO100/LVDS100p[T4]
IO102/LVDS96p[T6]
IO104/LVDS92p[T8]
IO105/LVDS90n[T9]
IO106/LVDS87p[T10]
IO107/LVDS86n[T11]
IO109/LVDS81p[T13]
IO111/LVDS76n[T15]
IO148/VREF2B4[R5]
IO149/LVDS96n[R6]
IO151/LVDS92n[R8]
IO153/LVDS87n[R10]
IO154/LVDS86p[R11]
IO156/LVDS81n[R13]
IO189/LVDS97n[P7]
IO190/VREF1B4[P9]
IO191[P10]
IO192[P12]
IO193/VREF0B4[P13]
IO217/LVDS101n[N8]
IO218/LVDS89n[N9]
IO219/LVDS80p[N10]
IO220/LVDS77p[N11]
IO236/LVDS101p[M8]
IO237/LVDS89p[M9]
IO238/LVDS80n[M10]
IO239/LVDS77n[M11]
38
40
41
42
45
46
47
49
MD7
MD9
MD11
MD13
MD15
MD24
MD26
MD28
009
R1339
MST-HD-F(RET)
100
101
102
103
104
105
108
109
110
111
112
113
220
MD6
MD46
MD8
MD10
MD12
MD25
MD27
R1324
010 VBS-RET1/RET2
R1318
R1341
009 RET-LRCK
009 PLD-PLD-RESERVE
009
220
220
MD45
MD43
MD41
MD39
MD37
MD35
R1317
RET-64FS
011
100
MD29
MD54
220
MD47
MD44
MD42
MD40
MD38
SDRAM-CKE
SLEEP
VBS_RESET
203
204
205
206
207
208
210
CASX 211
212
MA8
213
MA12
214
MA4
IO160/LVDS69p[N15]
IO162/LVDS64p[L15]
IO164/LVDS62p[H15]
IO165/LVDS58n[G15]
IO168/LVDS52p[D15]
MD14
MA7
MA5
VBS_H
CS(PLD_RET)
VBS_CLK
MD36
MD34
MD33
007,008,009,011
ADDRESS
A3
MD32
010
002
RET1-PCLK
74MHz-RET-PLD-CLK
R1304
R1343
IO62/LVDS75p[T17]
IO63/LVDS74n[R17]
IO64/DQ1R6[P17]
IO65/LVDS71p[N17]
IO67/LVDS66p[L17]
IO68/LVDS61p[H17]
IO70/LVDS56p[F17]
IO72/LVDS51p[D17]
IO73/LVDS51n[C17]
IO112/LVDS75n[T16]
IO113/LVDS73p[R16]
IO114/VREF2B3[P16]
IO115/LVDS69n[N16]
IO116/DQ1R0[M16]
IO119/LVDS61n[H16]
IO120/LVDS58p[G16]
IO121/LVDS54n[F16]
IO123/LVDS52n[D16]
007,008,009,011
CONTROL
IO18/LVDS74p[R18]
IO19/LVDS71n[N18]
IO20/LVDS68n[M18]
IO21/LVDS66n[L18]
IO22/DQ0R7[H18]
IO24/LVDS56n[F18]
IO25/DQ0R0[D18]
155
156
157
158
159
160
161
163
164
MA9
CSX 165
166
MA6
167
MA10
VBS_D2
VBS_D0
010
010
243
244
245
246
248
DQM 249
RASX 250
251
252
274
275
276
WEX 277
279
280
281
282
MA11
283
304
IO197[L14]
IO198/VREF1B3[J14]
IO199/LVDS62n[H14]
IO200/LVDS59p[G14]
IO201/LVDS55p[F14]
IO202/VREF0B3[E14]
IO221/LVDS70p[N12]
IO222/LVDS70n[N13]
IO223/LVDS65n[M13]
IO224/LVDS65p[L13]
IO225/LVDS63n[J13]
IO228/LVDS55n[F13]
IO229/LVDS57p[F12]
IO240/LVDS57n[G12]
209
CLK2/LVDSCLK2p[J15]
162
CLK3/LVDSCLK2n[J16]
10
10
R1349
2.2k
IC900
(3/6)
EP1C12F324C8N(300)
IC900
(2/6)
EP1C12F324C8N(300)
GND
9-72
VBS_D5
VBS_D4
R1320
R1319
RET1_SP01
RET1_ERR
009
009
85
86
87
88
89
90
91
92
93
MD1 94
MD3 95
MD4 96
97
98
143
144
145
146
147
148
149
150
151
152
47 153
47 154
RET2_SP14
RET2_LOCKED
RET2_SP11
RET2_SP08
RET2_SP06
RET2_SP04
IO180/LVDS18n[F5]
IO183/PLL1_OUTn[K5]
IO184/LVDS9p[L5]
IO186/LVDS4p[N5]
IC900
(1/6)
EP1C12F324C8N(300)
RET2_SP12
IO91/LVDS19n[F3]
IO92/LVDS15p[G3]
IO93/LVDS13n[H3]
IO94/LVDS10n[L3]
IO98/LVDS1n[R3]
IO99/LVDS0n[T3]
IO137/VREF0B1[D4]
IO139/LVDS18p[F4]
IO141/LVDS12p[H4]
IO142/PLL1_OUTp[K4]
IO143/LVDS9n[L4]
IO144/LVDS7n[M4]
IO146[P4]
21
23
24
25
26
27
28
MD0 29
MD2 30
MD5 32
RET1_SP10
RET1_SP08
RET1_SP06
RET1_SP04
RET1_SP02
RET1_SP00
IO36/LVDS23n[C2]
IO37/LVDS22n[D2]
IO39/LVDS19p[F2]
IO40/LVDS17n[G2]
IO41/LVDS13p[H2]
IO42/LVDS10p[L2]
IO44/LVDS6n[N2]
IO46/LVDS1p[R2]
IO47/LVDS0p[T2]
SDRAM-ADDRESS
RB910 220
1
2 VBS_D9
3
4 VBS_D8
5
6 VBS_D7
7
8 VBS_D6
1
2 VBS_D5
4 VBS_D4
RB911 3
220
5
6 VBS_D3
7
8 VBS_D2
VBS-D1
R1314
220 VBS_D1
VBS-D0
220 VBS_D0
R1315
RB912
220
VBS-V
1
2
VBS_V
VBS-F
3
4
VBS_F
VBS-H
5
6
VBS_H
VBS_NONE/EXIST7
8 VBS_N/E
VBS_CLKI R1316
22 VBS_CLK
2
4
6
7
8
9
R1329
0
NM
R1307 220 12
13
15
SDRAM-CTRL
011
VBS-D9
VBS-D8
VBS-D7
VBS-D6
VBS-D5
VBS-D4
VBS-D3
VBS-D2
011
CL923
1.2
CL922
1.2
HD-RET-CLK
011
GND
9-72
HSCU-300
ADJ
GND
2
C1168
10uF
DATA
CL925
1.2
R1365
15k
R1366
10k
C1169
10uF
ADDRESS
011
SDRAM-DATA
011
VIDEO-TRUNK-BUS
007,008,009,011
GND
10
C1103
220pF
19
18
17
16
15
14
13
12
1
3
5
7
1
3
5
7
RB920
47
2
4
6
8
2
4
6
8
HD-RET-C2-out
HD-RET-C3-out
HD-RET-C4-out
HD-RET-C5-out
HD-RET-C6-out
HD-RET-C7-out
HD-RET-C8-out
HD-RET-C9-out
RB919
47
d9
c9
b9
a9
d10
c10
b10
a10
CN102
(52/135)
CN102
(51/135)
CN102
(50/135)
CN102
(49/135)
CN102
(58/135)
CN102
(57/135)
CN102
(56/135)
CN102
(55/135)
VIDEO-TRUNK-BUS
HD-RET-Y2
HD-RET-Y3
HD-RET-Y4
HD-RET-Y5
HD-RET-Y6
HD-RET-Y7
HD-RET-Y8
HD-RET-Y9
HD-RET-BUS
115
116
117
118
119
120
121
122
123
124
125
126
127
128
MD53
MD30
MD52
MD63
MD61
MD59
MD57
MD17
MD19
MD21
MD23
HD-RET-H
HD-RET-Y8
HD-RET-Y9
MA3
MA1
MA2
MD51
MD49
A1
XSHWE0
D3
D1
XRD-2
HD-RET-Y6
HD-RET-Y7
TRUNK-C4
MA0
MD50
MD48
A2
D7
D2
D0
HD-RET-Y5
TRUNK-C8
TRUNK-C7
A4
A0
D6
HD-RET-Y4
HD-RET-Y2
HD-RET-Y3
MD55
D5
TRUNK-F
HD-RET-C3
D4
TRUNK-H
HD-RET-C2
011
168
169
170
171
172
173
174
175
176
177
178
179
180
215
216
217
218
219
220
221
222
223
224
253
255
256
258
259
260
284
285
286
287
305
306
307
308
RB915
220
R1326 10
19
18
17
16
15
14
13
12
1
3
5
7
1
3
5
7
RB922
47
2
4
6
8
2
4
6
8
HD-RET-Y2-out
HD-RET-Y3-out
HD-RET-Y4-out
HD-RET-Y5-out
HD-RET-Y6-out
HD-RET-Y7-out
HD-RET-Y8-out
HD-RET-Y9-out
RB921
47
d7
c7
b7
a7
d8
c8
b8
a8
CN102
(40/135)
CN102
(39/135)
CN102
(38/135)
CN102
(37/135)
CN102
(46/135)
CN102
(45/135)
CN102
(44/135)
CN102
(43/135)
DQM
59
DQM3
28
DQM2
71
DQM1
16
DQM0
CASX
RASX
CSX
WEX
18
CAS
19
RAS
20
CS
17
WE
GND
IO74/LVDS50p[B16]
IO77/LVDS45n[B13]
IO78/LVDS42n[B12]
IO79/LVDS40n[B11]
IO80/LVDS38n[B10]
IO81/LVDS35p[B9]
IO82/LVDS33p[B8]
IO84/LVDS28n[B6]
C1107 IC912
0.1uF TC74LCX574FT(EKJ)
220 2
220 3
4
5
6
7
8
9
R1327
10
11
1
R1359
R1321
0
NM
HD-RET-CLK
74MHz-RET-CLK
002
IO124/LVDS50n[C16]
IO126/VREF0B2[C14]
IO129/LVDS41n[C11]
IO130/LVDS39n[C10]
IO131/LVDS36p[C9]
IO132/LVDS34p[C8]
IO133/LVDS30p[C7]
IO134/LVDS28p[C6]
R1322
10
GND
+3.3V
TRUNK-C2
TRUNK-C3
TRUNK-C4
TRUNK-C5
TRUNK-C6
TRUNK-C7
TRUNK-C8
TRUNK-C9
1
3
5
7
1
3
5
7
RB926
220
002
IC915
TC74LCX574FT(EKJ) 20
2
4
6
8
2
4
6
8
RB925
220 R1334
2.2k
R1335
10
2
3
4
5
6
7
8
9
11
1
C1112
220pF
VCC
D0
Q0
D1
Q1
D2
Q2
D3
Q3
D4
Q4
D5
Q5
D6
Q6
Q7
D7
CK
OE
GND
10
20
VCC
D0
Q0
D1
Q1
D2
Q2
Q3
D3
D4
Q4
D5
Q5
D6
Q6
Q7
D7
CK
OE
GND
10
19
18
17
16
15
14
13
12
R136047
19
18
17
16
15
14
13
12
HD-RET-H-out
HD-RET-F-out
R1361
47
RB932
47
1
3
5
7
1
3
5
7
2
4
6
8
2
4
6
8
74MHz-RET-CLK-output
Prompt-C2-out
Prompt-C3-out
Prompt-C4-out
Prompt-C5-out
Prompt-C6-out
Prompt-C7-out
Prompt-C8-out
Prompt-C9-out
RB931
47
e9
e10
CN102
(53/135)
CN102
(59/135)
R1328
10
HD-RET-CLK-out
Guard-GND
e8
e7
CN102
(47/135)
CN102
(41/135)
CN102 GND
d16 (79/135)
CN102
c16 (78/135)
CN102
b16 (77/135)
CN102
a16 (76/135)
CN102
d17 (85/135)
CN102
c17 (84/135)
CN102
b17 (83/135)
CN102
a17 (82/135)
IO203[E13]
IO204[E11]
IO205/VREF1B2[E10]
IO208/LVDS29n[E6]
1
3
5
7
1
3
5
7
RB928
220
RB927
220
IO230/LVDS49p[F11]
IO231/LVDS46p[F10]
IO232/LVDS37p[F9]
IO233/LVDS25n[F8]
IO241/LVDS49n[G11]
IO242/LVDS46n[G10]
IO243/LVDS37n[G9]
IO244/LVDS25p[G8]
19
18
17
16
15
14
13
12
1
3
5
7
1
3
5
7
RB934
47
2
4
6
8
2
4
6
8
Prompt-Y2-out
Prompt-Y3-out
Prompt-Y4-out
Prompt-Y5-out
Prompt-Y6-out
Prompt-Y7-out
Prompt-Y8-out
Prompt-Y9-out
RB933
47
MA12
MA11
MA10
MA9
MA8
MA7
MA6
MA5
MA4
MA3
MA2
MA1
MA0
CN102
d11 (64/135)
CN102
c11 (63/135)
CN102
b11 (62/135)
CN102
a11 (61/135)
CN102
d15 (73/135)
CN102
c15 (72/135)
CN102
b15 (71/135)
CN102
a15 (70/135)
GND
+3.3V
C1115
0.1uF IC917
TC74LCX574FT(EKJ)
TRUNK-F
TRUNK-H
R1331
R1362
220
220
R1337
10
+3.3V
2
3
4
5
6
7
8
9
11
1
L922
10uH
C1108
10uF
C1109
0.1uF
VCC
GND
TRUNK-CLK R1332
10
FB923
IC918 (2/2)
TC7SZ00FU(TE85R)
VCC C1111
1uF
GND
R1333
2.2k
19
18
17
16
15
14
13
12
R136347
47
R1364
Prompt-F-out
Prompt-H-out
e17
e16
CN102
(86/135)
CN102
(80/135)
R1356
10
SDRAM-CLK
SDRAM-CKE
011
011
IC918 (1/2)
TC7SZ00FU(TE85R)
IC919 (1/2)
TC7SZ00FU(TE85R)
4
2
1
4
R1338
10
R1357
3.3k
GND
GND
2
1
56
54
53
51
50
48
47
45
42
40
39
37
36
34
33
31
85
83
82
80
79
77
76
74
13
11
10
8
7
5
4
2
MD63
MD62
MD61
MD60
MD59
MD58
MD57
MD56
MD55
MD54
MD53
MD52
MD51
MD50
MD49
MD48
MD47
MD46
MD45
MD44
MD43
MD42
MD41
MD40
MD39
MD38
MD37
MD36
MD35
MD34
MD33
MD32
C1121 C1123
0.1uF 0.01uF
GND
+1.5V
IC900 (6/6)
EP1C12F324C8N(300)
FB926
FB924
C1124 C1126
0.1uF
47uF
6.3V
C1142
47uF
6.3V
C1128
0.1uF
C1129
0.1uF
GND
C1130
0.1uF
C1131
0.1uF
+3.3V
FB925
C1132
0.1uF
C1143
47uF
6.3V
FB927
C1125 C1127
47uF
0.1uF
6.3V
GND
C1134
0.1uF
C1135
0.1uF
C1136
0.1uF
C1137
0.1uF
C1138
0.1uF
C1139
0.1uF
C1140
0.1uF
C1141
0.1uF
IC921
W9864G2GH-6-W-ER10
C1133
0.1uF
GND
44
229
VCCA_PLL1[J5] GNDG_PLL2[J18]
264
302
VCCA_PLL2[J12] GNDG_PLL1[J6]
301
GNDA_PLL2[K12]
10
2
GNDA_PLL1[K1]
VCCINT1[B1]
324
17
GND28[J10]
VCCINT2[U1]
322
19
GND27[K9]
VCCINT3[V2]
320
34
GND26[H9]
VCCINT4[V17]
318
36
GND25[H11]
VCCINT5[U18]
317
51
GND24[J11]
VCCINT6[B18]
316
53
GND23[K11]
VCCINT7[A17]
315
68
GND22[L11]
VCCINT8[A2]
314
313
GND21[L10]
VCCINT9[L9]
312
319
GND20[L8]
VCCINT10[H10]
311
321
GND19[K8]
VCCINT11[J9]
310
323
GND18[J8]
VCCINT12[K10]
309
GND17[H8]
114
5
GND16[B17]
VCCIO1_1[E1]
99
14
GND15[U17]
VCCIO1_2[P1]
84
289
GND14[U2]
VCCIO1_3[G7]
69
294
GND13[B2]
VCCIO1_4[M7]
67
56
GND12[A3]
VCCIO2_1[A14]
54
65
GND11[A16]
VCCIO2_2[A5]
52
254
GND10[A18]
VCCIO2_3[E12]
50
257
GND9[C18]
VCCIO2_4[E9]
37
39
GND8[T18]
VCCIO3_1[P18]
35
48
GND7[V18]
VCCIO3_2[E18]
33
299
GND6[V16]
VCCIO3_3[M12]
20
303
GND5[V3]
VCCIO3_4[H12]
18
22
GND4[V1]
VCCIO4_1[V5]
16
31
GND3[T1]
VCCIO4_2[V14]
3
237
GND2[C1]
VCCIO4_3[P8]
1
240
GND1[A1]
VCCIO4_4[P11]
GND
GND
3
GND
GND
23
22
24
66
65
64
63
62
61
60
27
26
25
BA1
BA0
A10/AP
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
DQM
59
DQM3
28
DQM2
71
DQM1
16
DQM0
CASX
RASX
CSX
WEX
18
CAS
19
RAS
20
CS
17
WE
DQ31
DQ30
DQ29
DQ28
DQ27
DQ26
DQ25
DQ24
DQ23
DQ22
DQ21
DQ20
DQ19
DQ18
DQ17
DQ16
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
68
CLK
67
CKE
14
21
30
57
69
70
73
NC1
NC2
NC3
NC4
NC5
NC6
NC7
56
54
53
51
50
48
47
45
42
40
39
37
36
34
33
31
85
83
82
80
79
77
76
74
13
11
10
8
7
5
4
2
MD31
MD30
MD29
MD28
MD27
MD26
MD25
MD24
MD23
MD22
MD21
MD20
MD19
MD18
MD17
MD16
MD15
MD14
MD13
MD12
MD11
MD10
MD9
MD8
MD7
MD6
MD5
MD4
MD3
MD2
MD1
MD0
+3.3V
R1344
10k
IC900 (5/6)
EP1C12F324C8N(300)
107
TDI[J17]
R1345
10k 43
TCK[K18]
10k 247
R1346
TMS[K14]
GND
278
R1354
TDO[K13]
NM 0
R1355
290
DATA0[H7]
47 11
DCLK[L1]
R1353 0 NM
+3.3V
008
106
77
291
76
300
CONF_DONE[K17]
nCEO[K2]
nCE[J7]
nCONFIG[J2]
nSTATUS[L12]
136
MSEL0[K3]
292
MSEL1[K7]
GND
CONFIG_CHAIN
Prompt-CLK-out
Guard-GND
e15
e11
CN102
(74/135)
CN102
(65/135)
GND
SY-364 (11/11)
FB922
C1110
1uF
20
VCC
Q0
D0
D1
Q1
Q2
D2
D3
Q3
Q4
D4
D5
Q5
Q6
D6
Q7
D7
CK
OE
GND
10
C1119
C1117 1uF
10uF
L921
10uH
DQ31
DQ30
DQ29
DQ28
DQ27
DQ26
DQ25
DQ24
DQ23
DQ22
DQ21
DQ20
DQ19
DQ18
DQ17
DQ16
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
FB929
GND
20
VCC
D0
Q0
Q1
D1
D2
Q2
D3
Q3
D4
Q4
Q5
D5
D6
Q6
Q7
D7
CK
OE
GND
10
C1120 C1122
0.1uF 0.01uF
GND
+1.5V
C1145
C1151
C1157
C1163
0.1uF
0.1uF
0.1uF
0.1uF
C1153
C1159
C1165
+3.3V C1147
0.1uF
0.1uF
0.1uF
0.1uF
C1149
C1155
C1161
C1167
0.1uF
0.1uF
0.1uF
0.1uF
+3.3V
2
3
4
5
6
7
8
9
11
R1336 10 1
2
4
6
8
2
4
6
8
NC1
NC2
NC3
NC4
NC5
NC6
NC7
GND
C1114 IC916
TRUNK-Y2
TRUNK-Y3
TRUNK-Y4
TRUNK-Y5
TRUNK-Y6
TRUNK-Y7
TRUNK-Y8
TRUNK-Y9
IC920
W9864G2GH-6-W-ER10
68
CLK
67
CKE
14
21
30
57
69
70
73
GND
C1113
0.1uF
IO172/LVDS41p[D11]
IO173/LVDS39p[D10]
IO175/LVDS34n[D8]
IO176/LVDS30n[D7]
IO177/LVDS29p[D6]
IC919 (2/2)
TC7SZ00FU(TE85R)
R1358
HD-RET-H
HD-RET-F
IC900
(4/6)
EP1C12F324C8N(300)
SDRAM-CLK
220
2
3
4
5
6
7
8
9
11
1
C1118
C1116 1uF
10uF
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
HD-RET-F
IO27/LVDS45p[A13]
IO28/LVDS42p[A12]
IO30/LVDS38p[A10]
IO31/LVDS35n[A9]
IO32/LVDS33n[A8]
IO34/VREF2B2[A6]
RB916
2
4
6
8
2
4
6
8
BA1
BA0
A10/AP
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
+1.5V
L920
10uH
44
58
72
86
6
12
32
38
46
52
78
84
55
57
58
59
60
61
62
63
64
66
MD31
MD62
MD60
MD58
MD56
MD16
MD18
MD20
MD22
1
3
5
7
1
3
5
7
20
VCC
D0
Q0
D1
Q1
D2
Q2
D3
Q3
D4
Q4
D5
Q5
D6
Q6
Q7
D7
CK
OE
GND
10
23
22
24
66
65
64
63
62
61
60
27
26
25
MA12
MA11
MA10
MA9
MA8
MA7
MA6
MA5
MA4
MA3
MA2
MA1
MA0
C1106 IC911
011
SDRAM-DATA
C1144
C1150
C1156
C1162
0.1uF
0.1uF
0.1uF
0.1uF
C1152
C1158
C1164
+3.3V C1146
0.1uF
0.1uF
0.1uF
0.1uF
C1148
C1154
C1160
C1166
0.1uF
0.1uF
0.1uF
0.1uF
FB928
GND
GND
CONTROL
011
20
VCC
Q0
D0
Q1
D1
Q2
D2
Q3
D3
Q4
D4
Q5
D5
D6
Q6
Q7
D7
CK
OE
GND
10
011
VSS1
VSS2
VSS3
VSS4
VSSQ1
VSSQ2
VSSQ3
VSSQ4
VSSQ5
VSSQ6
VSSQ7
VSSQ8
SDRAM-ADDRESS
R1325
R1323
2.2k
2
3
4
5
6
7
8
9
11
1
SDRAM-CTRL
44
58
72
86
6
12
32
38
46
52
78
84
011
2
4
6
8
2
4
6
8
SDRAM-ADDRESS
011
1
15
29
43
3
9
35
41
49
55
75
81
007,008,009
007,008,009,011
4
VDD
5
CE VOUT
1
RB914 3
220 5
7
1
RB913 3
220 5
7
HD-RET-C2
HD-RET-C3
HD-RET-C4
HD-RET-C5
HD-RET-C6
HD-RET-C7
HD-RET-C8
HD-RET-C9
2.5V
011
CONFIG_nCE_1-2
CONFIG_nCONFIG
CONFIG_CONF_DONE
CONFIG_nSTATUS
CONFIG_DATA0
CONFIG_DCLK
IC922
R1173H001D-T1-F
C1105
IC910
TC74LCX574FT(EKJ) 0.1uF
1
15
29
43
3
9
35
41
49
55
75
81
+3.3V
HD-RET-BUS
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
011
SY-364 (11/11)
VDD1
VDD2
VDD3
VDD4
VDDQ1
VDDQ2
VDDQ3
VDDQ4
VDDQ5
VDDQ6
VDDQ7
VDDQ8
SY-364 (11/11)
GND
BOARD NO. 1-879-650-11

HDCU-300_SY-364_011_11
9-73
HSCU-300
9-73
M
VIF-39
VIF-39
+5.5V
L1
10uH
C1
47uF
25V
C2
0.1uF
GND
V+
IC1 (2/2)
AD8014ARTZ-REEL7 V2
IC1 (1/2)
AD8014ARTZ-REEL7
CN1
REF in
4 -
1
2
3
GND
4
5
6
R5
330
7 8 GND
EXT-MIC1(G)-in
EXT-MIC1(Y)-in
EXT-MIC1(X)-in
EXT-MIC2(G)-in
EXT-MIC2(Y)-in
EXT-MIC2(X)-in
MIC1-(Y)-out
MIC1-(X)-out
b1
a2
MIC2-(Y)-out
MIC2-(X)-out
b2
CN4
6
5
4
3
2
1
A-side
E1
MIC1,2
GND
GND
1.290V
EXT-Ref(X)-out
e25
CN911
(5/135)
CN911
(110/135)
CN911
(116/135)
CN911
(122/135)
CN911
(127/135)
CN911
(128/135)
CN911
(134/135)
GND
-1.290V
R4
1k
GND
R2
10k
a1
C4
47uF
25V
GND
-5.5V
3
+
CN911
(124/135)
CN911
(125/135)
C3
0.1uF
L2
10uH
R1
100
CN911
(130/135)
CN911
(131/135)
R3
1k
EXT-Ref(G)-out
d25
1.230Vpp
Ether +3.3V
Ether-COM-TR(X)-in
Ether-COM-TR(Y)-in
Ether-GND
Ether-COM-RC(X)-out
Ether-COM-RC(Y)-out
e5
e4
e3
d2
e2
e1
C65
10pF
C64
10pF
CN911
(4/135)
GND
C61
100uF
10V
C23
1uF
RET HD/SD IN 2
1
2
3
4 GND
5
6
GND
R13
0
C11
10uF
R11
910
NM
C13
1uF
R17
75
R15
910
NM
R19
75
R21
75
GND
GND
GND
2
SDI
3
SDI
8
MCLADJ
C14
1uF R25
22k
R23
75
R26
C19
10k
1uF
GND
R27
C17
22k
0.1uF
5
AGC
6
AGC
GND
SDO
SDO
CD
MUTE
BYPASS
NC(TM)
HD/SD-SDI-RET1(Y)-out
HD/SD-SDI-RET1(X)-out
C26
4.7uF
a25
a24
CN911
(1/135)
CN911
(7/135)
+5.5V
CN911
(49/135)
CN911
(13/135)
CN911
(14/135)
CN911
(8/135)
CN911
(2/135)
GND GND
a23
b23
b24
b25
L81
10uH
a17
C81
47uF
25V
FB12
GND
C15
1uF
R18
75
R16
910
NM
R20
75
R22
75
GND
GND
2
SDI
3
SDI
8
MCLADJ
C16
1uF R28
22k
R24
75
R29
C20
10k
1uF
GND
R30
C18
22k
0.1uF
5
AGC
6
AGC
CN911
(50/135)
C24
1uF
C82
47uF
L82 25V
10uH
GND
SDO
SDO
CD
MUTE
BYPASS
NC(TM)
C27
4.7uF
11
10
15
14
7
17
HD/SD-SDI-RET2(Y)-out
HD/SD-SDI-RET2(X)-out
C28
4.7uF
CN911
(31/135)
CN911
(32/135)
CN911
(26/135)
CN911
(20/135)
GND GND
a20
b20
b21
b22
a22
a21
CN911
(19/135)
CN911
(25/135)
CN911
(129/135)
CN911
(117/135)
CN911
(105/135)
CN911
(93/135)
CN911
(81/135)
CN911
(69/135)
CN911
(67/135)
CN911
(60/135)
CN911
(48/135)
CN911
(36/135)
CN911
(24/135)
CN911
(12/135)
Guard-GND
Guard-GND
Guard-GND
Guard-GND
GND
L41
10uH
C41
47uF
25V
IC41
AD8014ARTZ-REEL7
VBS 1
VBS 2
R43
100
JC41
0
NM
R41
75
JC42
0
R44
47k
GND
4 -
C42
5 1uF GND
1
Return1-VBS(X)-out
Return1-VBS(G)-out
R46
2 1k
d24
e24
CN911
(10/135)
CN911
(11/135)
GND
1.994Vpp
GND
C44
47uF
25V
R42
75
GND
R49
330
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
MB-GND
C43 1uF
R45
1k
GND
L42
10uH
-5.5V
R48
47k
R50
1k
4 -
R82
1k
R86
22k
R90
47k
Rear-Alarm-NG/OK-in
-0.9V
c1
R88
100
CN911
(132/135)
R83
10k
C87
R87
47k 0.1uF
10V
R89
47k
GND
-5.5V
-5.5V
CN911
(135/135)
f1
SHIELD
CN911
(123/135)
f3
SHIELD
CN911
(111/135)
f5
SHIELD
CN911
(99/135)
f7
SHIELD
CN911
(87/135)
f9
SHIELD
CN911
(75/135)
f11
SHIELD
CN911
(68/135)
f13
SHIELD
CN911
(66/135)
f15
SHIELD
CN911
(54/135)
f17
SHIELD
CN911
(42/135)
f19
SHIELD
CN911
(30/135)
f21
SHIELD
CN911
(18/135)
f23
SHIELD
CN911
(6/135)
f25
SHIELD
GND
IC42
AD8014ARTZ-REEL7
R47
100
R85
22k
Q81
2SC4617TL-QR
CL82
1.2
144
132
120
108
96
84
72
60
48
36
24
12
f2
f4
f6
f8
f10
f12
f14
f16
f18
f20
f22
f24
CN911
(126/135) c2
CN911
(120/135) c3
CN911
(114/135) c4
CN911
(78/135) c10
CN911
(63/135) c15
CN911
(57/135) c16
+5.5V
1
2
3
4 GND
5
6
GND
R81
22k
C84
1uF
-5.5V
GND
CN3
Rear -5.5V
b17
GND
R84
22k
GND
1
VEE_A1
4
VEE_A2
9
VEE_D1
12
VEE_D2
R12
910
NM
L12
4.7nH
C83
1uF
+3.3V
C86
22uF
4
5
GND 3 CE VDD
VOUT
ADJ
GND
2
GND
16
VCC_A
13
VCC_D
GND
C12
10uF
IC6
R1173H001D-T1-F
+5.5V
C85
22uF
Guard-GND
Guard-GND
Guard-GND
Guard-GND
+3.3V
R14
0
CL81
1.2
Rear +5.5V
GND
C22 1uF
+3.3V
+5.5V
C25
4.7uF
11
10
15
14
7
17
GND
IC3
GS1574ACNE3
F-GND
GND
1
VEE_A1
4
VEE_A2
9
VEE_D1
12
VEE_D2
CN2
RET HD/SD IN 1
R62
0
NM
GND
FB11
16
VCC_A
13
VCC_D
GND
1
2
3
4
5
6
7
8
R61
0
NM
C21 1uF
L11
4.7nH
CN5
TXD+
TXDTXD_CT
NC
NC
RXD_CT
RXD+
RXDFG19 10 FG2
C63
1000pF
C62
1000pF
+3.3V
IC2
GS1574ACNE3
Ethernet
Connector
CN911
(118/135)
CN911
(112/135)
CN911
(106/135)
CN911
(100/135)
CN911
(94/135)
CN911
(88/135)
CN911
(82/135)
CN911
(76/135)
CN911
(70/135)
CN911
(61/135)
CN911
(55/135)
CN911
(43/135)
CN911
(37/135)
CN911
(119/135)
CN911
(113/135)
CN911
(107/135)
CN911
(101/135)
CN911
(95/135)
CN911
(89/135)
CN911
(83/135)
CN911
(77/135)
CN911
(71/135)
CN911
(62/135)
CN911
(56/135)
CN911
(44/135)
CN911
(38/135)
C45
1uF
5
GND
R52
330
Return2-VBS(X)-in
Return2-VBS(G)-in
R51
2 1k
e23
d23
CN911
(17/135)
CN911
(16/135)
a3
a4
a5
a6
a7
a8
a9
a10
a11
a15
a16
a18
a19
b3
b4
b5
b6
b7
b8
b9
b10
b11
b15
b16
b18
b19
TRIAX/Co-AX(BNC)-out
Front-PIX(X)-in
YELLOW-TALLY-Rear-out
WFM-Recall(8GB)-out
GREEN-Tally-(X)-in
WFM-Recall(4Q)-out
ENG-IN(X)-in
PROD-OUT(X)-in
PGM1-IN(X)-in
MIC1-CTL-on/off-in
CAM-POWER-Status-in
CAM-POWER-SW-in
Front-PIX(G)-in
COM-TALLY-Rear-out
RED-TALLY-Rear-out
WFM-Recall(7RG)-out
GREEN-Tally-(Y)-in
WFM-Recall(3B)-out
ENG-IN(Y)-in
PROD-OUT(Y)-in
PGM1-IN(Y)-in
MIC2-CTL-on/off-in
Cable-SHORT-Status-in
POW-UNIT DC/AC-in
CN911
(108/135)
CN911
(102/135)
CN911
(96/135)
CN911
(90/135)
CN911
(84/135)
CN911
(72/135)
CN911
(51/135)
CN911
(45/135)
CN911
(39/135)
CN911
(33/135)
CN911
(27/135)
CN911
(21/135)
CN911
(15/135)
CN911
(9/135)
CN911
(3/135)
CN911
(133/135)
CN911
(121/135)
CN911
(115/135)
CN911
(109/135)
CN911
(103/135)
CN911
(97/135)
CN911
(91/135)
CN911
(85/135)
CN911
(79/135)
CN911
(73/135)
CN911
(64/135)
CN911
(58/135)
CN911
(52/135)
CN911
(46/135)
CN911
(40/135)
CN911
(34/135)
CN911
(28/135)
CN911
(22/135)
c5
c6
c7
c8
c9
c11
c17
c18
c19
c20
c21
c22
c23
c24
c25
d1
d3
d4
d5
d6
d7
d8
d9
d10
d11
d15
d16
d17
d18
d19
d20
d21
d22
(reserve)
TALLY-GND
ANA2(TEMP-Level)-in
AUX3
ANA0(DPR-Level)-in
ANA1(Temp-Level)-in
(NC)
Cable-OPEN-Status-in
(reserve)
Pre-View(rear)-out
(reserve)
(reserve)
IRQ(Torino&Daytona)
PLD-ReConfig-out
PLD-Config-Done-in
CN911
(104/135)
CN911
(98/135)
CN911
(92/135)
CN911
(86/135)
CN911
(80/135)
CN911
(74/135)
CN911
(65/135)
CN911
(59/135)
CN911
(53/135)
CN911
(47/135)
CN911
(41/135)
CN911
(35/135)
CN911
(29/135)
CN911
(23/135)
e6
e7
e8
e9
e10
e11
e15
e16
e17
e18
e19
e20
e21
e22
YELLOW-Tally-(X)-in
WFM-Recall(5E)-out
RED-Tally-(X)-in
WFM-Recall(1R)-out
ENG-OUT(X)-out
PROD-OUT(X)-out
PGM2-IN(X)-in
Aspect-CTL(0)-in
HD/SD-SYNC(G)-out
MIC-Gain-CTL(0)-in
RCP-PWR-NG-Status-in
MIC-Gain-CTL(2)-in
TONE0-DETECT-in
CCU-ID0-in(Pull-Up)
WFM-Recall(9add)-out
YELLOW-Tally-(Y)-in
WFM-Recall(6RB)-out
RED-Tally-(Y)-in
WFM-Recall(2G)-out
ENG-OUT(Y)-out
PROD-OUT(Y)-out
PGM2-IN(Y)-in
Aspect-CTL(1)-in
HD/SD-SYNC(X)-out
MIC-Gain-CTL(1)-in
(reserve)
TONE1-DETECT-in
CCU-ID1-in(Pull-Up)
C46
1uF
VIF-39
GND
BOARD NO. 1-879-658-11

HDCU-300_VIF-39_011_1
9-74
A
9-74
HSCU-300
Frame Wiring
FERRITE
CORE
AC INLET
HARNESS
PS
3P
CN1
CN2
CN3
CN4
RED
BLUE
CAMERA(TRIAX)
HARNESS TRIAX-CCU(K,T)
HARNESS TRIAX-CCU(F)
3P
POWER
FERRITE
CORE
CN2002
FERRITE
CORE
CN1
COAXIAL
CABLE
HARNESS
F-GND
PS-739
TRIAX(J)ASSEMBLY
TRIAX(UC)ASSEMBLY
TRIAX(CE)ASSEMBLY
FL-349
FERRITE
CORE
5P
N
G
L
HARNESS
AC IN
Frame Wiring
FAN
CN1004
CN5006
CN3(15P)
WF REMOTE
CN2(15P)
CN5
HARNESS
UNREG
8P
EPR2
8P
CN2
CN6
HARNESS
RCP
3P
CN5001
10P
TRUNK
CN5007
10P
HARNESS
INCOM
CN4(9P)
3P
CT-257
CN2
8P
CN1008 CN1010 CN1009 CN1011

10P
16P
10P
10P
CN5004 CN5002 CN5003 CN5005
CN-3081B
3P
CN9
MIC REMOTE
8P
CN1
CN1(25P)
INTERCOM/TALLY/PGM
AU-321
COAXIAL CABLE
CN7
15P
CN1
FLEXIBLE
FLAT CABLE
15P
CN3
CN8
2P
CN-3082
30P
HARNESS
RCP-POWER
CN5
CN921
CN3
HARNESS
MIC
110P
CN1
MIC1
6P
INTERCOM
HARNESS
CONTROL
10P
CN-3083
CN10
MIC2
SY-364
VIF-39
CN101
CN1
110P
30P
FLEXIBLE
FLAT CABLE
CN102
6P
CN4
CN5
CN911
CN3
110P
CN4
CN2
110P
CN2
HARNESS
RCP-POWER
10P
CN806
CN805
60P
NC
CN802
4P
NC
4P
CN5
WF MODE
CN4
CN-3080B
REMOTE
CN11
CN10
CN9
CN8
CN7
CN6
CN2
CN1
CN12
33P
DPR-300
DY-23
(MAIN)
CN100
120P
CN701
CN101
120P
CN1800
DY-23
(RET)
CN101
120P
CN900
SDI-97B
CN101
COAXIAL
CABLE
CN3901
CN1
110P
CN102
10P
CN702
EPR2
Pb/B/B-Y
COMPONENT
OUTPUT
Y/G/Y
Pr/R/R-Y
SYNC
WF
PIX
2
1
PROMPTER INPUT
2
1
VBS OUTPUT
FLEXIBLE
FLAT
CABLE
ENC-112
3
RETURN INPUT
REFERENCE
INPUT
HARNESS
WF-REMOTE
2P
CN3
MB-1124
EPR2
SDI 2/4
SDI 1/3
CN804
10P
MEMORY
STICK
SLOT
VBS 2/4
VBS 1/3
CN1
30P
NC
CN3
33P
CN10
CN3
CN921
110P
CN2
CN2
CN1
110P
4
3
SDI OUTPUT
2
1
Frame Wiring
9-75
HSCU-300
9-75
E
Section 10
Board Layouts
Index
Board name
Page
A.
AU-321
10-2
C.
CN-3080B
10-3
CN-3081B
10-4
CN-3082
10-5
CN-3083
10-5
D.
E.
CT-257
DPR-300
10-6
DY-23
10-11
ENC-112
10-11
F.
FL-349
10-12
M.
MB-1124
10-12
P.
PS-739
S.
SDI-97B
10-13
SY-364
10-14
VIF-39
10-18
V.
*: The board layout of this board is not described in this manual.
HSCU-300
10-1
10-1
R85
C3
C13
C31
R48
C41
R58
C45
R38
R63
C21R62
R79
C47
R61
C48 R60
D18
R36
D20
RB1 RB2
FB2
R28
C22
R29 R74
R75
R76
R26
C19
R24
C17
C18
R25
R41
C55
R2 Q2
CN1
C12
Q8
EN1
FB3
L1
C14
R70 Q19
C54R69 C53
R68
C10
CN2
R53
R16
R17
C46
C44
Q11
C23
R5 Q3
IC1
D14
C8
R52
Q6
C9
Q1
C1
C6
CN3
C49
Q9
R4
D4
Q16
Q17 Q14
C34 C33
R59
C42
C20
R27
R6
C2
C36
Q15
C43
R34
R35
R81
R73
R78
R71
R40 Q13
R42
R39
R82
C26
Q12
R37
R33
C4
C25
C30
R77
R64
R15 Q7
C24
C35
C11
C29
C38
C37
C28
C32
C40
C39
D10
R12
R18
C27
C7
C56
D5
C16
R80
R83
R7 R10
Q4
C5
R3
FB1
R44
R46
R56
C51
S1
R65
S2
S4
S3
R54
R13
R14
IC3
R45
R47
R57
R55
RV1
R11 Q5
R1
R67 R72
R66 Q18
C15
C52
R9 R8
D11 D1 D6
D12 D2 D7
D13 D3 D8
AU-321
R86
R84
AU-321
AU-321 -A SIDE-
AU-321 -B SIDESUFFIX: -11
SUFFIX: -11
--------------------AU-321 (1-879-647-11)
--------------------*:B SIDE
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C35
C36
C37
C38
C39
C40
C41
C42
C43
C44
C45
C46
C47
C48
C49
C51
C52
C53
C54
C55
C56
A1
B2
A1
B2
A1
A2
B1
B1
A1
B2
D2
D2
D1
C2
D1
D1
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
D1
C1
C1
D1
C1
C1
D2
D2
C1
C2
B1
C1
B1
C1
D2
D2
D2
B1
D2
B1
D2
D2
D2
C1
C1
D2
C2
C2
C2
CN1
CN2
D2
C2
CN3
D2
D1
D2
D3
D4
D5
D6
D7
D8
D10
D11
D12
D13
D14
D18
D20
A1
A1
A1
A2
A2
A1
A1
A1
A1
A1
A1
A1
A1
C1
C2
EN1
C2
FB1
FB2
FB3
D1
D2
D2
IC1
IC3
C2
D1
L1
D2
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
Q9
Q11
Q12
Q13
Q14
Q15
Q16
Q17
Q18
Q19
A1
B2
B2
A1
B1
A1
B2
C2
C2
C2
C2
C2
D2
D2
D2
D2
C1
D2
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
A1
B2
A1
B2
B2
B2
A1
A1
A1
A1
B1
R12
R13
R14
R15
R16
R17
R18
R24
R25
R26
R27
R28
R29
R33
R34
R35
R36
R37
R38
R39
R40
R41
R42
R44
R45
R46
R47
R48
R52
R53
R54
R55
R56
R57
R58
R59
R60
R61
R62
R63
R64
R65
R66
R67
R68
R69
R70
R71
R72
R73
R74
R75
R76
R77
R78
R79
R80
R81
R82
B1
A1
A1
B1
B1
B1
B1
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C1
C1
C1
C1
D2
C1
C2
B1
B1
C1
C1
D2
D2
D2
D2
C2
C2
B1
C1
C1
C1
D2
D2
D2
D2
C1
D2
C2
C2
C2
D2
D2
D2
D1
D2
C2
R83
R84
R85
R86
D1
D1
D1
D1
RB1
RB2
D2
D2
RV1
B1
S1
S2
S3
S4
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C35
C36
C37
C38
C39
C40
C41
C42
C43
C44
C45
C1
C1
B1
C1
A1
B2
A1
B2
A1
A2
B1
B1
A1
B2
D2
D2
D1
C2
D1
D1
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
D1
C1
C1
D1
C1
C1
D2
D2
C1
C2
B1
C1
B1
C1
D2
D2
D2
B1
D2
C46
C47
C48
C49
C51
C52
C53
C54
C55
C56
B1
D2
D2
D2
C1
C1
D2
C2
C2
C2
CN1
CN2
CN3
D2
C2
D2
D1
D2
D3
D4
D5
D6
D7
D8
D10
D11
D12
D13
D14
D18
D20
A1
A1
A1
A2
A2
A1
A1
A1
A1
A1
A1
A1
A1
C1
C2
EN1
C2
FB1
FB2
FB3
D1
D2
D2
IC1
IC3
C2
D1
L1
D2
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
Q9
Q11
Q12
Q13
Q14
Q15
Q16
Q17
Q18
A1
B2
B2
A1
B1
A1
B2
C2
C2
C2
C2
C2
D2
D2
D2
D2
C1
Q19
D2
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R24
R25
R26
R27
R28
R29
R33
R34
R35
R36
R37
R38
R39
R40
R41
R42
R44
R45
R46
R47
R48
R52
R53
R54
R55
R56
R57
R58
R59
R60
R61
R62
R63
R64
R65
R66
R67
R68
R69
A1
B2
A1
B2
B2
B2
A1
A1
A1
A1
B1
B1
A1
A1
B1
B1
B1
B1
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C2
C1
C1
C1
C1
D2
C1
C2
B1
B1
C1
C1
D2
D2
D2
D2
C2
C2
B1
C1
C1
C1
D2
D2
R70
R71
R72
R73
R74
R75
R76
R77
R78
R79
R80
R81
R82
R83
R84
R85
R86
D2
D2
C1
D2
C2
C2
C2
D2
D2
D2
D1
D2
C2
D1
D1
D1
D1
RB1
RB2
D2
D2
RV1
B1
S1
S2
S3
S4
C1
C1
B1
C1
10-2
10-2
HSCU-300
CN-3080B
R11
R10
R3
CN7
RY1
R6
CN8
SL1
CN6
CN2
D1
C1
FL4
FL5
Q3
R13
L1
FL1
FL2
CN1
JC1
R1
CN12
R5 R2
CN-3080B
R8
R4
R7
Q1
R9
R12
Q2
FL3
CN11
FB1
C3
C2
CN10
CN9
CN3
CN4
CN5
LP1
CN-3080B -A SIDE-
CN-3080B -B SIDE-
SUFFIX: -11
SUFFIX: -11
----------------------CN-3080B (1-879-651-11)
----------------------*:B SIDE
HSCU-300
C1
C2
C3
B1
B2
B2
CN1
CN2
CN3
CN4
CN5
CN6
CN7
CN8
CN9
CN10
CN11
CN12
A1
A1
B2
C2
B2
B1
B1
C1
A2
B2
B2
C1
D1
B1
FB1
B2
FL1
FL2
FL3
FL4
FL5
B2
C2
C2
C2
C2
JC1
A1
L1
B1
LP1
B2
Q1
Q2
Q3
B2
B2
B1
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
A1
A1
A1
B2
A1
A1
B2
B2
B2
B1
B1
B2
B2
RY1
B1
SL1
* A1
10-3
10-3
CN-3081B
----------------------CN-3081B (1-879-652-11)
----------------------*:B SIDE
R121
C124
C123
R202
R201
L103
C115
C112
JC22
JC21
C101
C102
C103
C104
CN8
IC1
C61
C111
C121R117
C120
C118
C117
C116
C114
C62
L61
FL63
FL61
CN4
IC2
R71
R66
R67
R72
R70
R69
R73
C64
C63
JC41
C41
R106
R114
R113
R111
R110
R109
R108
R112
R103
CN6
R101
C105FB101
C110
C113
CN3
C12
C4
C9
C1
C109
C7
C5
L3
L1
C6
L2
CN2
C8
L4
CN1
F1
D1
C2
A2
THP102
E1
G1
G1
G1
H1
D1
B2
A2
B2
B2
THP21
THP61
THP101
THP102
C122
R119R120
L1
L2
L3
L4
L61
L101
L102
L103
L104
CN921
D1
D1
D1
A2
A2
CN9
CN5
JC21
JC22
JC41
RB101
RB102
THP21
FB103
D1
D1
C2
THP61
RB101RB102
CN10
IC1
IC2
IC101
D101
C1
C1
C1
C1
C108
FL61
FL62
FL63
FL64
C107R105R102 R104
G1
G1
G1
G1
C2
C2
A2
A2
L104
FB104
CN7
FL62
FB1
FB2
FB3
FB4
FB101
FB102
FB103
FB104
C106
FB102
FL64
H2
L102
L101
R68
E1
THP101
R63 R61
R65R64 R62
B2
D1
D1
D1
D1
D1
D1
D1
D1
D1
D1
D1
D1
D1
C2
C2
C2
C2
C2
A1
E2
A1
A1
A1
A1
E2
A1
A1
E2
E2
A1
E2
E2
E2
E2
E2
E2
IC101
C48
C44
C43
C47
C46
C42
C49
C45
D101
R61
R62
R63
R64
R65
R66
R67
R68
R69
R70
R71
R72
R73
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
R201
R202
R107
H1
F1
E1
C1
A1
A2
A2
B1
A1
A1
D2
E2
E2
C119
CN1
CN2
CN3
CN4
CN5
CN6
CN7
CN8
CN9
CN10
CN921
Q101
Q102
R115Q101
R116
C21
A1
A1
A1
E2
A1
A1
E2
E2
E2
C26
C31
C22
C24
C29
C27
C33
C25
C32
C30
C23
C34
C28
C116
C117
C118
C119
C120
C121
C122
C123
C124
FB1
FB3
FB2
FB4
G1
H1
H1
G1
G1
G1
G1
H1
G1
H1
H1
G1
H1
H1
H1
E1
F1
F1
F1
F1
F1
F1
F1
F1
F1
F1
F1
F1
F1
D1
E1
E1
E1
E1
E1
E1
E1
E1
D1
D1
D1
D1
B1
C1
C1
C1
C2
C2
C2
C2
A2
A2
A1
B2
A2
A1
B2
R118Q102
C2
C14
C3
C10
C13
C11
C15
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C21
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C41
C42
C43
C44
C45
C46
C47
C48
C49
C61
C62
C63
C64
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
C113
C114
C115
CN-3081B
CN-3081B -A SIDESUFFIX: -11
CN-3081B -B SIDESUFFIX: -11
10-4
10-4
HSCU-300
CN-3082, CN-3083
C3
CN3
A1
A1
A1
A1
A1
A1
C2
CN1
CN3
A1
A1
C5
FB1
FB2
FB3
FB4
FB5
FB6
FB7
FB8
FB9
FB10
FB11
FB12
FB13
FB14
A1
A1
A1
A1
A1
A1
A1
A1
A1
A1
A1
A1
A1
A1
FB2
C1
C2
C3
C4
C5
C6
FB1
FB3
CN1
C1
FB9
FB10
FB7
FB8
FB13
FB14
FB11
FB12
FB6
FB5
C6
---------------------CN-3082 (1-879-653-11)
---------------------*:B SIDE
CN-3082, CN-3083
FB4
C4
CN-3082 -A SIDE-
CN-3082 -B SIDE-
SUFFIX: -11
SUFFIX: -11
CN1
FB4 C3
CN1
CN2
A1
A1
FB1
FB2
FB3
FB4
A1
A1
A1
A1
CN-3083 -A SIDE-
L1
A1
SUFFIX: -11
L1
CN2
A1
A1
A1
C1 C2
C1
C2
C3
FB3
FB2
HSCU-300
FB1
---------------------CN-3083 (1-879-654-11)
---------------------*:B SIDE
CN-3083 -B SIDESUFFIX: -11
10-5
10-5
R767R758
R776
C711 C728
RB702
R724
R714
R723
RB701
C634
R2687
RB808
RB807RB801RB802
R1128
R1127
R1196
R1126
R1132
R1131
R1115
R1129
C635
C630
C640
C636 C638
RB1102
RB1103 RB1101RB1115
FB1106
R1172
SL1102
R1187
R1186
R1181
R1180
R295
R293
R297
R299
R288
R287
FB1101
R1228
D201
L204
C243
FL201
FB1110
C1250
R1211
Q211
R1160
SL1101
CL409
IC1101
C626
C4004
C1646
Q210
R1948
R1945
R1658
FB1109
C1631
C3860
IC3906
FL202
E203
R240
R239
C1256
C1257
E202
R271
IC208
R270
T203
R251
R252
R256
C1242
IC203 C220
C218
FL3901
FL3801
IC204
E204
C3845
C3846
R3812
R3813
C3745
C3746
R3711
R3712
IC800
CL604
C629
C625
CN1800
CL1711
CL1701
R3831
R3837
R3832
R3838
R3833
C3874
C3823
CL3811
CL3810
C3723
CL3708
CL3709
FL3701
FL3902
RB3801
RB3701
C3770
C3986
CL3901
C3954
C3955 C3932
R3920
R3921
C3760
R3822
RB3901
C3969
R3721
R3930
C722
RB708RB709RB710RB711RB713RB712
L408
IC411 R495
C4031
R497
D404
R494
C4030
RB1806RB1805RB1804
CL1800
C1707
R1776
R3730
R3731
R3732
R3939
R3940
R3941
C3461
CL411
RB909RB908RB907RB906
R1828
RB1813RB1812RB1811
R1814
C459
C1703
R1774
RB2034
C387
R360
RB2152RB2151
C2117
C2119
C4009
C471
R1708 RB1707 RB1706 RB1708
TP2003
RB2031RB2028
S2001
CL1710
CL1709
CN900
C2124
RB2148
RB2147
RB2136
RB2133
RB2134
C2130
C1545
CL3908
CL3909
R3402
R1905
R1593
C1570 R1586
C1565
C1566
R1582
RB3401
IC3403
R3412
R3413
C3425
CL3408
CL3409
C3650
C3651
R3618
R3619
C3545
C3546
R3512
R3513
C454
R2101
C2004
RB3601
C3669
R3422
C3628
CL3608
CL3609
CL3508
CL3509
RB2026RB2025RB2024
R2021
R2023
R3641
R3642
R3643
RB3501
C3560
R3632
Q2804
CL2802
R3431
R3440
R3432
R3441
R3433
R2618
R2681
R2617
C3523
CL242
C2817
R2839
R2827
C2818
R2832
R2824
C2815
R2838
R2826
C2816
R2830
R1636
R1530
D1506
C1532
R1545
R1536C1526 C1530
C1543
IC1510
C1589
C1500
RV1501
C1502
IC1501R1504
R1505
R1930
TP1505
C2725
FB2704
C2733
R2707
C2773
C2774
R2758
R2737
C2724
FB2703
C2735
R2757
CL2701 R2709
R2753
C2775
C2776
R2823
CL304
R1634 D1602
C1531
C2222
C2231
C2227
C2246
CL2201
CL2207
CL2208
CL2202
R2256
TP2201 TP2200 R2201
C2403
C2625
R2649
C2622
R2643R2051
R2054
R2050
R2053
R2049
R2052
RB2018RB2017
RB2016
C2005
L2604
R2606
R2605
R2604
R2603
R2602
C2609
C2603
C383
C374 C385
D306 C386
R342
IC308
FB2806
R2821
R2818
R2847
R2815
R2819
R2814
R2843
TP2801
CL2001
CL2002
CL2003
CL2004
C2651
R2608
R2607
IC2302IC2304
FB2601
FB2602
C2352
C2610
C2611
X2301
C2322
R2316
R2304
R2357
R2370
X2302
R2303
C2312R2339
C2332R2377
C422
C2813
R2837
R2825
C2814
R2828
L2801
C393
R2806
R2804
R2802
R2803
R2805
R2808
RB2414RB2412RB2410RB2420RB2417
R2406
R2414
R2668
R2674
L2607
L2606
IC2301
CL2303
R2323
R2336
R509
FB501
IC501
R513
R512
C505
TP502
RB2415RB2413RB2411 RB2421RB2419RB2416
RB2422RB2418
L2402
R484
R4013
FB426
FB425
FB423
FB424
R2645
R26
R24
R21
C21
RB2401
RB2403
RB2402
RB2512
RB2504
RB2506
RB2507
IC706
IC708
R23
R22
RB506RB505
R740
R541
R558
R562
R2409
RV1502
IC902
C2342
R2375
C2351
R3531
R3537
R3532
R3538
R3533
IC1503
C1569
C405
C2734
R2708
R2822
R2820
R2816
C3681
R1560
R1939
C404
CL402
C4060
R2845
R2421
R2422
R2420
R2423 R2848
R2425
R2424 R2817
R2844
R3510
CL3512
CL3504 IC3505
IC1502
R540
R2518
R2519
CL2801
FB2807
CL247
C1544
IC3606
C498
CL401
C4059
L2803
C3569
CL3612
CL3604 IC3605
IC3405
C4058
C4041
R2762
R3522
C3550
LV1502
E14
R3625
R2846
R1529
CL3912
CL3904 IC3905
R3616
R3652
C2805
IC1609
C1615
CL3412
C3655
THP281
R1635
CL3404
CL3505
LV1503
C3905
C3910
CL3405
CL3605
C3541
C3532
C3533
L3509 C3503
Q403
R411R450
C421
C2366
C365
C359
C360
Q309
C361
R331
R332
C362
R333
R3927
C3646
C3637
C3638
L3609 C3605
R3470
C3446
L3507
CL3506
L3508
R1566
R3905
R3906
D3905
C3442
C3432
C3433
L3409 C3403
R472
C416
C2350
C2349
C364
C3959
CL3606
L3608
IC1511
D3904
C389
CL3406
CL3507
L3607 R3554
R3555
R1934
R258
R1209
CL303
CL3712
CL3704 IC3705
L3907
CL3607
L3407 R3654
R3655
C375
C2346
R2359
R2367
R2355
R2348
R343R341
IC2802
R340
C2866
R3521
R3520
CL307
R1932
R279L214
C3903
C3904
R3904
R3929
R3928
CL3407
R3631
R3630
R2314
CL3516FB3507
R3534CL3514
CL3515
C1501
R1503
R1502
R1501
C214
R3964
R3644
R3421
R3420
C2354
C1508
C273
T202
C3950
C3941
C3942
L3908 C3912
CL3416
R3434CL3414
CL3415
R2616
R1527
C275
R254
R253
C274
C276 IC207
D308
CL3906
L3906
CL3905
R3764
C3750
CL3808
CL3809
C392C391
R2615
C2365
L2802
C3741
C3732
C3733
L3708 C3703
CL3705
CL3812
CL3804 IC3805
CL3907
L3707 R3959
R3960
L3706
R3864CL3801
C3850
CL309
IC2602
R527
R526
R525
R520
R514
C512
C2330
C2329
R330
R327 IC306
C357
IC305 R352
R328
CL3805
IC310
R3942
R3720
R3719
R2038
R2037
R2039
R2036
CL2306
R2620
R2622
C530
C506
FB502 R511
R510
CL305
Q307
C352
R323
E201
C3841
C3832
C3833
L3808 C3803
E5
FB2319
CL2305
C2326
R2325 CL2301
R2333
R2321
R324
R1509
C346
CN3901
CL3707
L3807 R3759
R3760
C2022
C2302
R2614
R2624
R2628
R2629
R365R363
R362
R3733
L3806
IC1617
RB2029
C2301
R2630
IC2000
CL502
E1501
L304
C381
R1940
R3821
R3820
C2003
E7
R2741R2766
R1946
R1220
R1943
R1944
C1643 C1647
R1222 C1255 C1645
R1210 C1252
CL3807
R3859
R3860
RB2011RB2012
R4026
Q415
C345
C1612
R1668
R1630
C1628
R1677
RB2111
RB2112 RB2010RB2007RB2020RB2019RB2015
RB2008RB2009RB2021RB2013RB2014
RB2115RB2116
C2115
C434
CL404
C2306
R524
RB902RB903
R2734
R2735
R2798
R2797
C2726
FB324
FB325
CL308
CL306
R335R336
C322
C1710C1715
R2651
IC21
R2725
C2731
C1640
R1700
R1693
C1636
R1690
R1627
R1632
Q1601
C223C224
C279C280
L404
IC1700
CL3803
R3834CL3814
CL3815
IC2101
C435
C2645IC2609
R2671
R573IC523
TP2703
R1680
R1628
C2631
R482
C2636
R2669
R2655
R2648
C2109
RB2104
RB2101
CL244
R2677
R538
TP2702 R2722
C2730
C265
Q212
C451
R439
R1809
R1808
R1654
R1691
R1695
Q1603
C266C267
R249
R250
C268
C270
C271
R1804
R1803
R1802
L405
C2402
RB716RB717
R2728
C2732
R475
R476
R477
TP1100
CL203
R255R1208
C1241R257
R284
R260
C282R262C1244
C278
C289
C288
C277
C281R261R259
C1243
R281
C215
T204
C217
C272
R222
R223
R3907
C3902
R3902
R3901
R3903
C3911
R3801
R1207R225
R227C1238
IC3907
L307
THP303
THP307
C3009
C3008
FB305
FB306
FB332
C3002
C621
R635
R636Q602R639
R673
R1801
D2201
R2260
R2203
IC2400
R559C522
C518
THP301
C470
R452
R1811
C2245
IC2001
R2520
R576
R575R574
R413
IC406
R907
R906
R905
C627
C628
R669
R670
D203
IC202
R292
C1224
R290
C1214
C1211
C1212
C1210
R275
R276
IC206 C1213
C1215
C1216
R920
R2510
TP2701
R1151
R1152 IC1103
C1227
R286
R1205
R1218
R656
R1637
RB1116RB1117RB1118FB1103
R298
R1200
C1226
C1225
R294
R296
C326
T201
R226C1237R220
R1206R224R221C216
C3805
R3804
R3849
R229
C226R231C1240
C222
C233
R3805
R3806
R3858
C3815
C219
FB22
FB21
R1173
R1184
R1185
R1182
R1183
R1175
CL1112
R291
C1223RV201
R289 IC217 R1219
C245C248
R242
C232
C221
C225R230C1239
R228
R337
R334
R1164
R1165 IC1104
R1166
R1161
R1178
R1179
R1176
R1177
R1163
C269
RB1119
R1195
R1154
R1663
R1659
C3849
R3817
R3818
C3848
IC3801
R3909
C3908
R3908
C3909
C3906
R3701
L303
CL601
CL602
CL603
RB1105 RB1107 RB1109 RB1111

RB1114RB1113
RB1106 RB1108 RB1110 RB1112
C1190
C1189
C1180
C1181
R1192
RB1120RB1121
C485
C2407
C2502
R401
D405
R4003
Q409 Q408
TP602
R666
R668 R667
R665
R664
C1017
C1018
C1015
C1016
R1145
R1143
R1144
E4
R1223
FB333
C4026
CL703
TP601
R1142
C1151
C1152 L1104
R1101
R1116
R1121R1119
R1122
R1124
R1123
R1118
R1120
C576
R1117
R1112
R1125
R1102
R1227
R1226
C306
R2684
R2685
R2682
R913
CL2203
CL2205
RB2201
RB2202
C4046
CL246
CL245RB2407RB2408RB2409 RB2404
RB2405
RB2406
RB2001
RB2002
RB2003
RB2004
RB2005
RB2006
L2501 C2501
CN102
C724
L2601
C2618
CN702
R4020
R2686
C4006
C1644
IC1616
R1947
CN101
C710
L2201
Q2803
IC505
CL900
Q701
CL704
R921
R904
R903
RB703RB704
IC700
RV2601
C2620
R2683
C3868
C3822
C3818
R3839
C3817
R3819
C3816
C3814
C3813
C3812 C3806
C3810
C3809
C3804
R3802
R3803
C305
Q410
D406
RV2602
C2617
L2602
R1133
C1634
IC1615
R1692
R1694
C1638
C203
C1633
R203
C1613
X201
R202
IC1607
R1629
CL201CL202
R1631 L213
R1221C1251
C1610
C1254
R1942
C1253 R1225 Q213
R1941
R1229
C1642CL3813
R1224
R3814
C3835
C3834
C3882
RB803
R1130
R1134
IC1618 Q1605
R1633
C3847
C3747
R3718
R3705
R3758
C3715
C3713
C3712 C3706
C3710
C3709
C3704
R3702
R3703
R3910
FL1502
C317
C398
R778
L2202
Q2802
R2809
R2202
RB504 RB503
R2261
CN701
SL4
R743
R744
R745
R746
L612
IC410
R471
R3816
C3840
C3829
L3804
L3803
C3828
C3749
R3716
R3717
C3748
IC3701
C3705
R3704
R3749
R3863
R3862
IC3802
C3825
C3831
C3830
R3713
C3735
C3734
C3782
C3844
L611
C623
C624
L609 CL1801
FB3806
R3763
R3762
SWF5
C3725
C3731
C3730
C3956
CL3710
CL3711
C3722
C3718
R3739
C3717
R3736
C3716
C3714
R3848
R3847
R3846
C3744
IC3702
C3729
L3704
L3703
C3728
C3922
C3921 C3915
C3919
C3918
C3913
R3911
R3912
R3914
R3958
C3924
CL1703
C3855
CL3806
R3715
C3740
SWF4
R3924
C3949
C3934
C3940
C3939
IC3901
R3836
R3823
C3853
C3852
C3859 C3873
R3748
R3747
R3746
R3955
R3946
C3958
R3925
R3926
C3957
R3835
IC3804
C3854
RB804
RB805RB806
CL606
R661
CL605R659R660
R658
R657
L610
C4005
R2639
RB812RB811
R662
R663
L608
C304
C1637
C3884
C3755
CL3701C3768
C3977
FB3807
IC3704
R3735
R3722
C3753
C3752
C3759 C3769
C3962
C3961
C3968 C3985
R3922
C3944
C3943
C3982
CL1704
CL1705 FB3808
CL1706
FB3809
FB3706
FB3707
FB3708
R3734
C3784
C3754
R3963
R3962
C714
R706
R702
R760
R708
C715
R496
R493
RB1800RB1801RB1802RB1803
RB1807RB1808RB1809RB1810
R1777
FB3709
FB3906
R3830
CL3706
C3953
R716
R488
C4024
C637
R478
R474
R4010
R4009
R4007
TP262
C639
R637
R638
C622
L607
CL708
CL709
D701
R769
C717C723
C4029
C4028
CL706CL707
C633
C632
IC602
R3829
R3943
R3944
R3931
R747
R748
R749
R750
L407
C4036
C631
CL405
R1810
RB1721 RB1719 RB1720
R3729
IC3904
C3931
C3927
R3961
C3926
R3947
C3925
C3923
R4001
R499
R4002
R4004
RB1724
RB1717
RB730 RB719 RB718
RB721 RB720
RB905
C476
C456
C458
C457
R4014
R467
R468
R469
R772
R773
RB904
RB2132
RB2135
C2126
C473
C475
C474
C455
C395
C394
FB330
FB329
CL407
L704
CL408
CL701
CL702
R774
R775
R751
R752
IC709
FB708
R753
R754
R755
C736
C733
CL406
R1806
R1807
R1830
R1818
R1820
RB1718
C3914
R3913
R3945
C3606
C3608
R3604
R3602
C3607
R3601
R3606 C3604R3603
C3603 R3607
R3605
R1903
R1904
D1508
C1557
RB911
THP412
C472
L2101
R3404
C3405
R3451
C3470
R3401
R3608
R1567
RV1503
TP1502
R3419
R3406
R3453
C3415
CL3910
CL3911
FL3401
R3611
C3610
R3651
IC3401
C3413
C3412 C3406
R3443
C3410
C3409
C3404
R3403
FL3601
C1695
D1509
R1931 R1933
R1581
R1584
R1585
C1582
R1583
IC2104
C2132
RB2150RB2149
C3422
C3418
R3473
C3417
R3437
C3416
C3414
FB429
FB428
FB430
FB431
C1709
IC3902
C3938
L3904
L3903
C3937
C3652
C3618
C3617 C3611
C3615
C3614
C3609
R3610 R3609
R3612
R3653
C3620
CL3411
THP408
CL410
C4023 IC408
R487
R1827
R1816
R1770
C3964
SWF6
C3654
R3623
R3624
C3653 CL3410
IC3601
R3414
C3436
C3435
C3434
C3478
RB724 RB723
RB814RB813
R3728
R3956
R3416
C3441
C3424
C3469
FB434
FB433
FB435
FB436
R3938
R3457
R3456
R917
R908
TP1800
R1732
C3984
C3455
C3454
IC3402
C3431
C3430
C3423
C3429
L3404
C3428
L3403
C3627
C3623
C3622
C3621
C3619
R3501
R1508
FB331
TP1501
C1541
R1528
FL1501
TP1503
R1911
FB3907
C3460
R3620
C3640
C3639
C3678
SWF1
C3630
C3636
C3635
CL3610
CL3611
FL3501
R3504
C3505
R3551
C3570
FB3406
IC3404
C3479
R3622
C3645
IC3602
C3634
L3604
L3603
C3633
C3547
C3513
C3512 C3506
R3543
C3510
C3509
C3504
R3503 R3502
R3505
R3506
R3553
C3515
FB3407
FB3408
R3657
R3656
R926
R927
R929
R930
R1730
C3963
RB722
C4051
RB2146RB2145
CL2005
CL2006
R3671
R3670
SWF3
R3516
C3540
CL3510
CL3511
C3549
R3517
R3518
C3548
CL1707
CL1708
C2030
C2017
FB3409
FB3606
C3663
C3662
C3668 C3680
C3649
C1708
R3436 R3937
R3423
C3456
RB728 RB727 RB726RB725
C2122
L2103
C2103
C2101
R361
R3435
C3450
C3447C3449C3445
R3471
CL3601R3650
C3629
IC3501
C1583
C2105
C2107
FB3608
IC3604
R3557
R3556
R3514
C3535
C3534
C3578
C3525
C3531
C3530
C3529
L3504
L3503
C3528
C3522
C3518
R3539
C3517
C3516
C3514
C3453
R3646
R3633
C3664
R3672
C4049
C2128
L2204
R3645
R1534
IC1504
LV1501
FB3609
R3571
R3570
SWF2
C1525
C1524
R1535
IC1505
D304
C366
D1507
R3430
C3679
C3554
C3553
C3559 C3568
IC2804
C2870
C2864 C2873
R1542C1528
R1539
C1527
R1540
R1538
R1544R1541
R1537
R1510
C3544
IC3502
R1638
R1547
C4013
IC3504
R338
R339
R3572
CL3501R3550
C3524
R322
L305
C3661
R3536
R3523
C490
L2003
R3429
R3535
C3555
C488
R364
R3640
C3579
C3552
IC2402
R2033
R3639
CL243
C1529R1592
R1543
C363
C2614
C2615
RB2612
R3529
C373
CL2008
CL2007
CL2010
CL2009
RB2610RB2611
R2812
FB2402
C1616
R353 C358
R329
L306
L308
CL302
C310R304
C311C312
R302
R305
R303
C338
R315
R325
C349R321
R317R316
THP304
C335
C336
C318
C316
C368
IC307
Q306
C341
R308
C319
C3007
FB335
C369
CL301
C2874
RB2806RB2805RB2804
IC2806
C2820
C2811
RB2709RB2708RB2707
IC2705
R326
C3001
FB334
C2006C2010 R2024
TP2004 TP2002 TP2001
R2374
R2013
R2043
R2040
R2044
R2046
R2041
L2004
R2623
R2621
FB3607
FB3506
L2301
C2861
RB2809RB2808RB2807
R2841
C2871
C2804
R2810RB2803RB2802RB2801
IC2807
C2808
R2831
R2835
L2718
C2779R2717
R2719
R2718
L2706
C2809
R2833
R2836
TP2802
FB2706
IC2709
R2713
R2727
R2731
E271
C2717
R2726
C2821
C2812
R2714
R2745
TP2803
IC2703
RB2703RB2702RB2701
R2711
R2721
R2729
R2720
R2842
C2020
R2619
IC2310
C2364
RB2312
L2710
R2746
C2715
C2819
C2810
IC2706
R2739
R2738
R2795
IC2805
R2716
C2807
R2829
R2834
IC2704
RB2706RB2705RB2704
R2712
R2724
R2730
R2723
R2840
C2605
C2604
R2631
R3530
C2716
C2202
C2602
R2611
R2612
C2353
RB2117RB2118
C2113
RB2103
RB2102
RB2105
R2007
R2031 C2012C2021
R2011
R2032
RB2615
R2372
C423
L2610
RB2310RB2309RB2308RB2307RB2306
CL2302
IC2309
R2373
IC2311
RB2113
RB2114
C2111
C2252
C2650
R2613
C2369
C2370
R2358 R2376
L402
RB2616 RB2617
CL2304
R2381
R2646
R2647
C2628
R2650
IC2605
RB2609
RB2608
RB2607 RB2606
RB2605
C2608
C2363
C417
RB2618RB2619
R2308
C2368C2367
R2305
R2315
R2364
R2366
R2365
R2354
C2337
R4016
R470 IC417
C4042
R4015
R473
C328
C367
R412
FB421
FB420
L301
C425
R2309
RB2427
R2673
C2646
C2647
L2611
R2344
C2632
R2653
C2627
C2643 C2624
C2623C2626 R2652
L2609
R2345
R2654
L2605
C2630C2629
IC2610
RB2301
R2306 RB2305RB2304RB2303RB2302
RB2311
IC2308
C511
R2343
R2324 R2338
R563
R560
R529
R528
R2330
R2332
R2331
R2320
C509
R550
TP501
L2603
C2641
C2642
IC2608 R2670
R2672
C2644
C2640
C2633
C2639 L2612 C2634
IC2606
R2255
L2205
R2210
RB2205 R2204
R2259
L406
L401
R2208
L2403
TP261
C2635
R2665
C2638
C2637
L403
C442
R425
L2608
R485
R483
R480
R479
R481
C436
C437
C438
C439
D407
C2405C2410
R2439
C2421
R2437
C2417
RB2501RB2502RB2503
R2407
R902
C2221
THP406
FB902
C904
CL241
CL901
RB910
IC2501
R2503
CL2204
RB2204RB2203
R742
S2801
R2885
R2410
R2405
R2404
R2429
R25
C22
IC22
CL403
L2203
C2241
RB2510RB2509RB2508
R537
R539
C510
R2807
IC2801
R2250
R2251
IC2205
C2253
C520
C521
SL3
R572 C541
R2505
R2504
FB702C738
IC513
IC514
RB2513RB2511
FB703
C732
R739
R2801
C2801
C2802
Q2801
IC524
C540
C528
IC519
C2503
C2803
R738
DPR-300
R757
R756
DPR-300
DPR-300 -A SIDESUFFIX: -11

10-6
10-6
HSCU-300
DPR-300
C2512
C2513
R542
R543
R544
RB714RB715
C4011
R546
R561
R548
R547
R532
CL501
R556
R521R518
R519
R402
C4056
FB405
R408
C413
C412
THP401
R403
C4057
C418
R2346
R2347
FB2310
FB2316
C1725
C535
R523
R2312
R2313
FB2301
FB2307
C2357
C2362
FB2311
C2339
C515
C730
C441
C501
IC2305
FB422
C2316
C2361
FB2302
C2648
C2319
C2373
C2374
IC2613
RB900RB901
FB900
R421
R418
IC2401
R2217
R2222
C2649
C4014
C2001
R2018
C4010 L2002
IC2614
R2042
C2019
C2011
R2017
R2020
R2016
R2014
R2022
R2047
C2002
C2746
C2760
C2761
R2703
IC2701
R2705
C2758
C2759
C2745
R2750
C2747
R2751
L2703
E272
C2771
FB2702
R2704
IC2702
R2706
FB2804 C2839
IC2711
C2823
C2829C2826
C2838
THP302
C301
C302
C303
C308
C307
R367
Q305 R366C325
C397
R306
C3005
C321
IC311 R371
IC301
R377C382
R373
C309
R351
R350
C320
C339
FB321
C3006
R318
C348
IC304
C1515
R1519 D1504
R1518
R1521
D1503
C337
R1620
C2762
C2763
R2760
R2765
R2777
R2784
FB2803
FB2805 C2837
C2822
C2828C2825
C2824
C2830C2827
R2430
C1533
R3647
R1616
FB2801
L2816
R2878
R1924
THP306
C3641
L3605
C3643
L3406 L3405
C3439
C3536
C1542
C1523
C1625
C1623
R1643
C1624
R1644
C3491
C3490
C3489C3452
C3983
C3945
R3524
R3525
C3563
C3562
R3634
R3635
C3672
C3671
R3424
R3425
C3464
C3463
C3472
R3932
R3933
C3972
C3971
R3723
R3724
C3763
C3762
R2502
R2501
R2436
R2415
R2227
R2236
C2237
C2205
C2009
C2016
C2023
C2024
C2419
C2401
C2226
C2216
C2209
C2206
C2204
C2244
C2263
C2262
C2415
R459
R2212
C2220
IC2204
C2260
R2206
C2238R2258
IC405 R457
C478
R447
R432
RB1715 RB1713
C1806
FB1801
C1804
C619
C617
C606
FB437
FB439
FB438
FB440
FB441
FB444
FB443
FB446
FB445
R426
R414
R463
R436
R435
IC414
C4053
C2120
C2118
C1713
RB1711R1729
C1719 C1718
R1743
C614
C609
C616
C2106
R901C910
C2123
RB2140
RB2139
C4032
C4033
IC407 R4018
C493
RB2144RB2143
Q405
RB2131
RB2128
RB2129
C2129
R486
THP409
C4016
R491C4025
R492 D403
C4022
R703C719
C802
RB810 RB809
FB442
IC409
R770
FB503
R729
R710
C721
C726
C729
C712
FB911
L3905
C3947
R3661
R3660
C3690
R3659
C3689
L1507
C807
C3948
C3929
R3917C3960
C3988
IC1601
C3928
C3726 C3727
C3739
C3720
R3738C3751
C3788
IC1603
C3901
C3916
R2637
R2636
R2633
R701
C605
C2112
R1588
C3878
R3865
C3736
L3506 L3505
C3538
C1692
C1693
R1922
R1599
R1923
IC1512 C1590
R1597
C1592C1591 R1596
R1906
R737
R705
R725
R726
R733
R648
R3967
R3966
R3965
C3419
C3402
C3407
R1571
R1574 L1504
C1556 R1577 C1559C1548 C1547
C1549 R1562
R736
R2004
R1919
R1591
R1572
C1558C1561
R777
C2400
R1917
L702
C705
R2002
C1580
R1914
C1650
R1938C1577
R1640
R3561
R3560
C3590
R3559
C3589
R1929
R1642
C3935 C3936
R1657
R1656
R1655
R1639
C1617 C1619
R1641
C1620 C1622
R3767
R3766
R3765
C3437
C3602
C3612
L703
C706
C2233
IC1606
FB3803
C3856
FB3804
L3705
C3738
C2427
C330
IC1604 R3673 C3624
FB3703
C3756
FB3704
R3824
R3825
C3863
C3862
C3658
R1559
C1505R1507
C1578
IC1515C1507
R1555R1557
R1556
R1552
R1551
C1509
IC1507
D1501
R1549
C1539 C1536
R310
C376
R344
C3519
C1600
C1540
C1503
L1501
C3625
C3866
C3440
C3420R3409
R3439
R1624
R1626
C1607
C1608
C1606
R375
R1511
R1516
R1515
R1514
C1514
R1512
R1513
C3426 C3427
C1537
C1588
C1587
C399
C378
C332
D307 R348R370 D303 R314R369
Q310 C379R347 Q308 C333R313
C3656
C3677
C1574
C1573
D302
C1522
C1513
C1520
R1522
R1526
C1521
C1535
C3644
C3551
C3577
C3502
C3507
C1609
C353
Q304
C3631 C3632
E2
C1601
C2713
R3472
R1603
C3520
C351
C3539
FB3903
C3965
FB3904
C3766
C3836
C3526 C3527
L2814
R2866
R2871
R2856
C3975
IC2603
IC2615
IC711
R1140
C1112
C1107
R1138
R1139
R1104L1106
R1696
R1949
C1639
R1697
R1698
R1685 C1635
R1686 R1689
R1665
R3867
R3866
R2427
FB2403
IC1605
C340
FB3403
C3457
FB3404
IC1613
C1563
R1587
R1580
R1579
C315
R309
FB311
FB312
FB313
FB314
FB315
FB316
FB317
FB318
FB3603
C3665
FB3604
R1648
R1647
R1650
FB3503
C3556
FB3504
L1505
FB310
FB309
FB308
FB307
R307
C1546 C1599
R1563
L1506 R1564
Q1504
Q1503
C1551
R1901
R1573
R1565
R1575
C1554
Q1505 C1553 C1597
L1508
C3004 D301
C3010
FB301
FB302
FB303
FB304
R301
R378
R376
D305
R374
IC312
R359
R349
IC309
C377
R372
C3003
C331
Q301
Q302 C314
C313
C380
R346R345
C323
C324
C334
C372
C371
C370
C347
C342
FB323
FB322
C344
C343
C1651
R1937
FB319
FB320
R312R311
IC303
Q1501
C1510
C1511
C1512
C350
R320
R319
THP305
C3467
R1611
R1613
C1603
C1604
C2753
C2723
FB2705 C2738
THP308
C3675
C3826 C3827
C3719
IC1602
C3702
C3707
C3819
IC1109
R1153
C1179
C3871
R3844
R3843
C3870
C3869
R3842
L1603
L201
C1614
R209
C202
C208
R1646
Q202
R218
R1645
R1679
C1611
R206
R1666
C207
C211
R1673 C1627
R1674 R1676
R201
C1178
C1177
C1176
FB1105
C1249C256 C255
C3839
C3820
R3841C3851
C3888
R1607
C2770
R2715
X1101
FB1102
C1602
R2733
C2720
C2729
L2715
C2714
R2880
C1163
RB1716 RB1712
L3805
C3838
R2736
R2768
R2779
R1775
R1113
R1114
R1111
C1157
C1626
C2709
C3566
C2865
C2862
RB522RB523
FB1111
C2867
L2815
R2869
R2872
R2860
C1807
R1737
R1738
R1735
R1736
R1707
C1125
R1671
R1683
R1699
C1641R1667
R1678
R1687
C1632
R2881
C2718
C2727
L2716
C2710
R1733
R1734
C1711
C1724
RB1714
C1802
Q201
C210
R212 R211
R1204
R219 C213 R216
R283 C212 Q205
Q214
R2782
C2860
C2806
C1704
R1705
R1751
R1752
C2612
C1706
L1701
C1714
R2045
C601
R601
R602 Q601
R672 R605
R1826
R1800
C1808
C2015
R1740
R1739
R1745
R1746
C2601
FB427
RB1722
C2027
C444
THP404
R614
C607
C608
R632
R633
E8
R1741
R1742
R2627
C2029
FB432
IC1102
FB2001
R431
C615
R652
R653
R631
R634R671
R630
R629
C702
R715
R704R759
C1187
C1185
C1186 R1169
FB1108
R1157
R210
R208
R2764
L2813
R2863
R2870
R2853
R2879
C354
C355
C1516
R1520
C1517
C1519
C1518
IC201
C1220
C1218 IC212
IC210 R285
R280 IC213
L211
C241
C240
R245
C235
R235
R278
C237
C1202 C1201
IC205
R273
C3802
C3807
E1
C228
C227
IC216 C234
C390
C1260
C1259
C1258
C291
R266
L207
C388
D3601
C327
R354
C2007
R618
R619
R620
L602
R2035
R621
R625
C4037
R498
R4006
C703
R719
R779
L603
C2102
C2104
RB2125RB2126
C2108
L605
L1103
C2606
R2659
R2657
R2610C2652R2680R2658
C2653
R2656
C461
THP405
Q412
C725
R801
C2114
RB2108
RB2107
RB2110
C716
C4020
C806
L2104
RB2121
RB2122
C2110
RB2602
C2201
C909
C1101
C1121 C1102 C1109C1120 C1113
C1133 C1145 C1139 C1132
C1126 C1144 C1131
IC2312
C2242
C4019
R916
IC412
C708
R732
C709
R765
C2248
R2102
R446
RB2603
R2362
R2363
R2361
C2338
C2345
R2351
C2234
C903
C4012
RB705
C707
Q414
C252
C2711
R2785
R2767
R2770
C2750R2769
R2755
R2756
R2771
L2712 C2751
R2778
IC2710R2788
C2764
C2765
C244
C229
R234
R233R232 C251
R1214
C2719
C2772
C2728
L2717
C2712
C2736
R2749
R2743
C2743
R2787
C2744
R2754 L2709
C2752
R1215
R237
IC2611
C2251
C2333
C2721
L2701
C2705
C2708
R238
C231
Q401
R2748
R2744
C2739
R2789
C2740
R2740 L2707
C2754
L2704
R2701
C2778
Q303
C356
R1525
R1524
C396
R356R358
R357R355
C329
IC302
C2347
R2311
C2372
R2378
R2369
R2379
C2336
C2335
FB414
FB413
FB412
FB411
C4038
R2248
R2247
R2246
R2238
R2310
R2356
C2313
FB415
FB416
FB417
FB418
R2245
R2244
R2243
R2237
C2223
C4052
FB906
FB1104
C415
C2318
R564
R2783R2732
R2763
R2796 C2748R2772
R2773
R2759
R2761
R2774
L2713 C2749
R2780
IC2707R2793
C2703
C2706
C2701
C236
FB507
R2328
R2329
R2327
R2241
R2240
R2239
R2242
C2210
C2203
C491
THP407
R762
C740
R2340
R2341
C2325
R2317
R2219
R2229
R2218
R2232
R2235
R2214
R2228
R2213
R2231
R2234
R2224
R2230
R2223
R2233
C2211
C494
C4054
IC416 IC415
C801
FB803
R802
C811
C809
C2375
FB2309
C2213
C4048
C4047
R4025
IC502
C519
C1160
C1161
R1135
IC504
RB2425
C2424
C440
IC520
C504
C2327
C2737
C2766
C2767
R2702
C299
IC402
L2405
C2236
C2219
R2001
C486
C487
R771
C2616
THP403
C2309
C508 C534
FB506
R2417
R2416
R2434
R2003
R2254
R465
R464
C735
FB802
THP411 R415
R417
R416 R424
C428
R2301R2302 R502
R503
C2722
L2702
C2755
R2887
R2850
R2855
C2842
C2843
L2805
C2834
C2833
L2808
R2799 R2742
R2747
C2741
R2775R2791 C2742
R2776
R2710 L2708
C2756
L2705
C2704
C2707
C2702
C2836
C2835
L2809
C2849
C2848
C2854
C2855
R1936
R1935
R1548 D1505
R1531 R1523
R1533
R1532
R1517
Q1502
L1502
C1594
C1593
IC1508R1921
R1920
R1598
FB2701
R2888
R2851
R2858
C2844
C2845
L2806
R1554
R1550
C1538
R1553
C1534
L1503
C1504
C1506
D1502
R1506
R1927
R1926
R1558
R1928
R1546
IC1513
C1694 IC1509
C1596
C1575 R1918
C1576C1586
C1584
R1589
R1925
L1509 C1585
R1915
C1579
R1912
R1913
C1581
R1916
IC1506
C285
R265
C294
R264R263 C298
R1216
C407
R1621
L3501
C1552
R1576
R1568
R1595
R1594
R1590
C1572
C1571
R1570
R1569 C1560
R1578
R1910
R1909
C1555
C1550 R1908
R1561
C1564
C1562
R1907
C2851
C2850
FB1107
R727
R721
L2401
R4012
R4023
IC701
C2511
C2506
R454
R453
R455R462
C1136 C1149
C1141
C1129 C1137
C1116 C1105 C1111 C1123 C1117
FB410
FB409
FB408
FB407
THP402
R2781
C2769
C2768
IC2708R2794
C2757
R2752
L2714
R2886
R2849
R2852
C2840
C2841
R1170
C1183
Q402
C4001
C420
C419
D402
C2331
L1601
L3502
C3501
C1567
C1568
IC1514
R1902
C1598
C3686
C3684
C3660
C3685
C3683
C3659
C1595
FB2401
R3552
R3507
R3508
R1619
L3602
L3601
L3401
L3402
R1604
L3902
L3611 C3688
L3606 C3687
D3602
C2856
C2857
D2801
IC209
C531
R567
C424
C411
R405
IC401
FB406
FB401
FB402
FB403
FB404
C4061
D401
C2411
R2438
C2356
C2315
C403
C402
C401
R407 C409
C499 C410
R406
R404
R409
C414
C408
R2402
C2414
C900
IC704
C536
C533
C537
FB326
C2360FB2317
C2847
C2846
IC2803
R2889
C2869
L3510
R1615
C3601
L2804
C2852
C2853C2859FB2802
R2877
C3557
D3501
L208
R535
R1778
L1703
R1754
IC1701
R1753
L501
FB419
R2428
C2505
C2508
R566R565 R554
R553
R549
R552
C532
R522
RB501RB502
C2340
FB2313
C2344
R2352
R2353C2341 C2343
C384
C3564
C3561
R3573
C3511
C3508
C1605
R1617
C292
RB508RB512RB519
IC418
RB2426
C737
FB704
C2304
FB2312
R2360
C2348
C2777
L3901
R1217
R268
RB507RB509
C2519
C2518
R741
R768
C527
C529
C526
R722
R728
FB2303
C2311
L2811
R2864
R2865
R2857IC2809R2882
R2874
R3509
R3541
C3521
R3574R1618
R3519
R3540
R3613
R3614
C3616
C3613
R1623
C3401
FB3502
R3615
R3649
C3626
R3648R1614
R3626
R3627
R1625
R3957
R3915
R3916
R1612
L3701
L3702
L3802
L3801
C286
R267
C287
R269
C513FB504
C514
RB520
C516
IC900
RB510RB511
FB505 IC503
C2328
L2812
R2867
R2868
R2859IC2810R2883
R2875
Q2805
R2412
C2423
FB2404
C3543
C3582
R3515
C3537
L3610
C3411
C3408
C3648
C3682
R3621
C3642
C3444
R3452
R3407
R3408
L3909
R1608
R247
R1602
C3907
C2863
R2813
C3421R3438 R1622
R3410
R3953
C3930
R3948R1601
R3918
C3565
C3558
D3603
C3952
R1610
C3701
RB513RB514
R555
C2359FB2308
L2810
R2811
C2858 R2861
R2862
IC2811
R2854IC2808R2884
D2802
R2873
C2868
L2817
C2832
FB2808R2876
C2831
C2872 C2875
L2807
C3567
C3666
FB3602
C3673
C3670
C3451
C3482
R3415
C3438
C3920
C3917
C3471 R3418 C3448
R3454
R3455
R3417
D3902
R3757
R3706
R3707
R3857
R3807
R3808
C3711
C3708
IC508
C517
IC509IC506R534
R531R530 R533
C2303
R2382
R2349
FB2314
R2601
IC507
IC510
IC518IC517IC515
C2310
C2320
FB2304
C2324
R2318
R2319C2321 C2323
IC2601
R2025
C2358
R2368
C2613
C3674
C3667
L3408
C3974
C3967
L3709
L3809
C296
C3811
C3808
R3708
C3721
R3737R1609
R3709
R2326
R2380
R2371
C2334
R2626
R2625
R2350
R2030
FB2305
R2027
RB2614
RB2604
RB2613
R2019
FB2306
C2371
RB2601
IC2612
IC2005
R2012
R2048
L2001
R2609
R2679R2678
C2607
C503
IC2303
C2355
R2322
R2028
R2675
C2018
C2013
C2028
C3676
C3466
C3459
C3976
C3987
R3923
C3946
D3701
D3801
R3809
C3821
R3840R1605
R3810
R2335
R2342
R2337
R720
L2302
C507
RB515RB516
RB517RB518
C406
D3401
C3743
C3787
R3714
C3737
C433
C2307
C2314
R2307
IC2307IC2306
R2644
R2034
IC2003
C2025
R2006
IC511
RB521
THP282
R3459
R3460
R3461
R1652
R1653
R1651
C3843
C432
C431
R2252
C2308
C502
R501
IC2202
C2305
R1750
R1749
RB1702
C3458
FB3402
C3465
C3462
C3765
C3758
C427
RB2428
C2258
Q411
C2317 R2334
C2014
RB2027 RB2032 RB2033 RB2030
R1747
R1748
C429
R423
C4007
R420
C430
R422
R419
IC2201
C2247
R2008
R2009
R2010
RB2022
IC707
R2418
R2419
C2257
R2216
R2215
R2221
R2220
R2005
R2015
C3978
R1662
C2516
C2517
R2411
R2433
IC2203
R2226
R2225
R2029
R1771
R1772
C2420RB2423RB2424
C2416
C2409
C2214
C2235
C2259
L2502 C4015
C2509
C2504
E9
RB2109
RB2106
C3966
FB3902
C3973
C3970
R1660
R1661
C3801
L202
C2240
FB701R900
C2507
C2510
R2435
IC2102
C448
R428
R433
C449
R437
C446 L2102
C445
C447
C3778
C3779
IC1614
R1606
C290
C283
C284
R2249
C2239
RB2119RB2120
IC2002
C1716
C2422 C2418
C2406
C2426
R2408 R2413
RB1701
IC1612
C3757C1621
FB3702
C3764
C3761
C1629
IC1611
C3857C1618
R1669
R1670
R1649
L1602
C230
R274
C297
Q207 Q206
R241
C2225
C2232
RB2123RB2124
C2116
C464
R444
R448
C463
R441
C466
C462
C465
R434 R438 R429

R430
R427
C1721
RB1723C1720C1723
C1712
C1717
RB1710
C3864
C3861
C3865
C3858
C1630
C247
C254
R1235 R236
R1234
R1233 L212
C239
C2228
RB2127
RB2130
C2125
C2243
C246
C238
C2207
C2208
C2249
C2250
C2217
C2212
R2403
C2413
C2408
R2257
C2218
R2209
R2253
R2211
C2224
C2515
C2514
C2412
R2401
C2425
C477 C480
C2215
C2261
Q413R449 R442 R440

R445
R443
C443
C1701
C1702
L1702
C1722
C1705
C3767
FB3802
Q1602
R1675
R1672
IC3806
C3872
C3867
C3887
R3815
C3837
R248
C242
R243
C253
C1236
C1235
C1209 L210
L209
C1234
C1208C1233
Q209 Q208
R272
RB1709
Q1604
R1681
R1682
C295
C293
R2205
C3468
R1212
C258C259C260
C257
R246
C2229
C2008
RB1704 RB1703 RB1705
R1688
R1684
R217
R215
R214
C1247
C1246
C1232
C264 L206
L205
C1231
C263 C1245
IC211
C1228
C250
C249
C261
R244
C1204C1205C1206
C1203
R1213 C1200
R3845
R3850
C262
C1222
L203
R1230
R1231
R1232
C1805
C1159
C1156
C1164
IC1108
C205C206
R204C204
Q204
R205
R213 C1248
R207
Q215
C201
Q203 C209
C1221
C1229R1201
D202 IC215
C1217
R277
C1219
R1203
C1207
FB1800
R1824
R1825
R1110
C1158
R282
R1202
IC1801
R1141
R1156
R1155
C1174
C1175
C1173
R1158
R1159
C1230
FB1808
R2207
L2207
C1153
C1170
R1171
IC403
C452
C1165
C1162
R1136
R1137
C1172
R1168
R1167
C1184
R1823
C1801 R1822
R1106
R1103
L1101
L1102
C1124
L1105
C1171
C1188
C1800
IC1800
R1829
R1819
C4008
C1104 C1115
C1122 C1110 C1103
C1114
C1148
C1135 C1128C1147C1140 C1127 C1134C1146
C460
C450
C453
FB1812
L601
C1150
C1106
C1118
IC404
C468
C1809
C1143 C1138
C1119 C1108
C489
C2230
C2121
C469
FB1805
FB1804
C2404
C2127
C467
R627
R628
L606
C603
C604 R604
R763
R764
R761R766
C701
R603
C602
C484
C2131
RB2142RB2141
C739
C618
C483
IC2103
IC903
R655
R654
C620
C479
C907
R933
R934
IC601
L604
IC710
C1142 C1130
C4045
C4050
C482
R461
R458
R456
FB907
FB908
R460
C481
C4044
RB2138
RB2137
R935C901
IC901
R928
R932
C902 R931
C804
R2638
R2642 R2688
R2641
R2640
C523
C426
C4055
FB901
C613
Q404
FB801
C812
C4021
R803
R2691
R2676
R2690
R2689C2621
C803
C612
C610
R626
R624
R623
R622
C611
C905
FB903
C4017
C4034
C4035
THP410
C4018
R707
C808
C805
C810
R410
R489R490
C727
R713
R712
R711
R2632
C2619
R2635
R2634
C718
IC703 IC702
C720
C713
R4005
R735
R734
C4027
R709
RB706RB707
Q407
R4008
IC705
Q406
C908
C906
R4021
C4039
C492 C4003
R4024
FB447
C495
C4002
C741
C497
R466
R4011 C496
C4043
R4022
R4019
R4017
IC713
C734
RB729
C731
L701
C704
IC2604
FB707
FB705
FB706
R504
R505
DPR-300
HB001
DPR-300 -B SIDESUFFIX: -11

HSCU-300
10-7
10-7
DPR-300
DPR-300
---------------------DPR-300 (1-879-649-11)
---------------------*:B SIDE
C21
C22
C201
C202
C203
C204
C205
C206
C207
C208
C209
C210
C211
C212
C213
C214
C215
C216
C217
C218
C219
C220
C221
C222
C223
C224
C225
C226
C227
C228
C229
C230
C231
C232
C233
C234
C235
C236
C237
C238
C239
C240
C241
C242
C243
C244
C245
C246
C247
C248
C249
C250
C251
C252
C253
C254
C255
C256
C257
C258
C259
C260
C261
C262
C263
C264
C265
C266
C267
C268
C269
C270
C271
C272
C273
C274
C275
C276
C277
C278
C279
C280
C281
C282
C283
C284
C285
C286
C287
C288
C289
C290
C291
C292
C293
C294
C295
C296
G2
G2
* B5
* B4
B4
* B4
* B4
* B4
* B4
* B4
* B5
* B5
* B4
* B4
* B4
B6
A6
B6
A6
A6
A6
A6
A6
A6
A6
A6
B5
A5
* A6
* A6
* A5
* B5
* A5
A5
A5
* A6
* A6
* A5
* A5
* A5
* A5
* A5
* A5
* A5
A5
* A5
A5
* A5
* A5
A5
* A5
* A5
* B5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
A5
A5
A5
A5
A5
A5
A5
A6
A6
A6
A6
A6
A6
A6
A6
A6
A6
A6
* A6
* A6
* A6
* A6
* A6
A6
A6
* A6
* A6
* A5
* A6
* A6
* A6
* A6
C297
C298
C299
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
C344
C345
C346
C347
C348
C349
C350
C351
C352
C353
C354
C355
C356
C357
C358
C359
C360
C361
C362
C363
C364
C365
C366
C367
C368
C369
C370
C371
C372
C373
C374
C375
C376
C377
C378
C379
C380
C381
C382
C383
C384
C385
C386
C387
C388
C389
C390
C391
C392
C393
C394
C395
* A6
* A6
* A5
* G6
* G6
* G6
B4
G6
G6
* G6
* G6
* G6
G6
G6
G6
* G6
* G6
* G6
G6
G6
G6
G6
* G6
* G6
G6
* G6
* G6
* G6
A5
* A6
G3
* A6
* F6
* F6
* F6
* F6
* F6
G6
G6
* F6
G6
* G6
* F6
F6
* F6
* F6
* F6
F6
F6
* G6
* F6
F6
* F6
* F6
F6
* F6
* F6
* F6
* F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
G3
G6
G6
* G6
* G6
* G6
F4
E4
G3
* F6
* G6
* G6
* F6
* F6
F6
* G6
E4
* E4
E4
E4
D4
* A6
B6
* A6
D4
D4
D4
D4
D4
C396
C397
C398
C399
C401
C402
C403
C404
C405
C406
C407
C408
C409
C410
C411
C412
C413
C414
C415
C416
C417
C418
C419
C420
C421
C422
C423
C424
C425
C426
C427
C428
C429
C430
C431
C432
C433
C434
C435
C436
C437
C438
C439
C440
C441
C442
C443
C444
C445
C446
C447
C448
C449
C450
C451
C452
C453
C454
C455
C456
C457
C458
C459
C460
C461
C462
C463
C464
C465
C466
C467
C468
C469
C470
C471
C472
C473
C474
C475
C476
C477
C478
C479
C480
C481
C482
C483
C484
C485
C486
C487
C488
C489
C490
C491
C492
C493
C494
* A6
* G6
G6
* G6
* G3
* G3
* G3
G4
G4
* G4
* G4
* G3
* G3
* G3
* G3
* G4
* G4
* G3
* G4
G3
G3
* G3
* G4
* G4
F3
F4
F4
* G3
G3
* D1
* F2
* F2
* F2
* F2
* F2
* F2
* F2
F2
F2
F2
F2
F2
F2
* F2
* F2
F2
* C3
* C3
* C3
* D3
* D3
* D3
* D3
* C3
C3
* C3
* C3
D3
D3
C3
C3
C3
C3
* C3
* C3
* C3
* D3
* C2
* D3
* D3
* C2
* C3
* C3
C3
D3
D3
C3
C3
C3
C3
* D1
* D1
* D1
* D1
* C1
* D1
* D1
* D2
C2
* C2
* C2
C2
* D2
C2
* C2
* C1
* C1
* B1
C495
C496
C497
C498
C499
C501
C502
C503
C504
C505
C506
C507
C508
C509
C510
C511
C512
C513
C514
C515
C516
C517
C518
C519
C520
C521
C522
C523
C526
C527
C528
C529
C530
C531
C532
C533
C534
C535
C536
C537
C540
C541
C576
C601
C602
C603
C604
C605
C606
C607
C608
C609
C610
C611
C612
C613
C614
C615
C616
C617
C618
C619
C620
C621
C622
C623
C624
C625
C626
C627
C628
C629
C630
C631
C632
C633
C634
C635
C636
C637
C638
C639
C640
C701
C702
C703
C704
C705
C706
C707
C708
C709
C710
C711
C712
C713
C714
C715
* B1
* B1
* B1
G3
* G3
* F2
* F2
* F2
* F2
F3
F3
* F2
* G3
G3
G2
G3
F3
* G1
* G1
* G2
* G2
* G2
G1
* A1
G1
G1
G1
* G1
* G2
* G2
G1
* G2
F3
* G2
* F3
* G3
* G3
* G3
* F3
* G3
G1
G2
B4
* B3
* B3
* B3
* B3
* B3
* B3
* A3
* A3
* B3
* B2
* B2
* B2
* B2
* B3
* B3
* B3
* B3
* B3
* B3
* B3
B3
B3
B3
B3
B3
B3
B3
B3
B3
B3
B2
B2
B2
B3
B3
B3
B3
B3
B3
B3
* A3
* A2
* A2
* A2
* A2
* A2
* A2
* A2
* B2
A2
A2
* A2
* A2
A2
A2
C716
C717
C718
C719
C720
C721
C722
C723
C724
C725
C726
C727
C728
C729
C730
C731
C732
C733
C734
C735
C736
C737
C738
C739
C740
C741
C801
C802
C803
C804
C805
C806
C807
C808
C809
C810
C811
C812
C900
C901
C902
C903
C904
C905
C906
C907
C908
C909
C910
C1015
C1016
C1017
C1018
C1101
C1102
C1103
C1104
C1105
C1106
C1107
C1108
C1109
C1110
C1111
C1112
C1113
C1114
C1115
C1116
C1117
C1118
C1119
C1120
C1121
C1122
C1123
C1124
C1125
C1126
C1127
C1128
C1129
C1130
C1131
C1132
C1133
C1134
C1135
C1136
C1137
C1138
C1139
C1140
C1141
C1142
C1143
C1144
C1145
* A2
B2
* A2
* A2
* A2
* A2
B2
B2
A2
* A2
* A2
* A2
A2
* A2
* F2
* A2
G1
A1
* B1
* B1
B1
* F2
G1
* A3
* A3
* A1
* A2
* A2
* A3
* A2
* A2
* A3
* A2
* A2
* A2
* A2
* A3
* A3
* F2
* C2
* C2
* C2
G2
* C2
* C2
* C2
* C2
* C2
* C2
A4
A4
A4
A4
* A3
* A4
* A4
* A4
* A4
* A3
* A3
* A3
* A4
* A4
* A4
* A3
* A3
* A4
* A4
* A4
* A3
* A3
* A3
* A3
* A4
* A4
* A3
* A4
* B3
* A3
* A4
* A4
* A3
* A3
* A3
* A3
* A4
* A4
* A4
* A4
* A3
* A3
* A4
* A4
* A4
* A3
* A3
* A3
* A4
C1146
C1147
C1148
C1149
C1150
C1151
C1152
C1153
C1156
C1157
C1158
C1159
C1160
C1161
C1162
C1163
C1164
C1165
C1170
C1171
C1172
C1173
C1174
C1175
C1176
C1177
C1178
C1179
C1180
C1181
C1183
C1184
C1185
C1186
C1187
C1188
C1189
C1190
C1200
C1201
C1202
C1203
C1204
C1205
C1206
C1207
C1208
C1209
C1210
C1211
C1212
C1213
C1214
C1215
C1216
C1217
C1218
C1219
C1220
C1221
C1222
C1223
C1224
C1225
C1226
C1227
C1228
C1229
C1230
C1231
C1232
C1233
C1234
C1235
C1236
C1237
C1238
C1239
C1240
C1241
C1242
C1243
C1244
C1245
C1246
C1247
C1248
C1249
C1250
C1251
C1252
C1253
C1254
C1255
C1256
C1257
C1258
C1259
* A4
* A4
* A4
* A4
* A3
B4
B4
* B4
* B4
* B4
* B4
* B4
* A4
* A4
* A4
* B4
* B4
* B4
* A4
* A4
* A4
* A4
* A4
* A4
* A4
* A4
* A4
* A4
A4
A4
* A4
* A4
* A4
* A4
* A4
* A4
A4
A4
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
A5
A5
A5
A5
A5
A5
A5
* A5
* A5
* A5
* A5
* A5
* A5
A5
A5
A5
A5
A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
* A5
B6
A6
B5
A5
A6
A6
A6
A6
* A5
* A5
* B4
* B4
* A5
B5
B5
B5
B5
B5
B5
B6
B6
* A6
* A6
C1260
C1500
C1501
C1502
C1503
C1504
C1505
C1506
C1507
C1508
C1509
C1510
C1511
C1512
C1513
C1514
C1515
C1516
C1517
C1518
C1519
C1520
C1521
C1522
C1523
C1524
C1525
C1526
C1527
C1528
C1529
C1530
C1531
C1532
C1533
C1534
C1535
C1536
C1537
C1538
C1539
C1540
C1541
C1542
C1543
C1544
C1545
C1546
C1547
C1548
C1549
C1550
C1551
C1552
C1553
C1554
C1555
C1556
C1557
C1558
C1559
C1560
C1561
C1562
C1563
C1564
C1565
C1566
C1567
C1568
C1569
C1570
C1571
C1572
C1573
C1574
C1575
C1576
C1577
C1578
C1579
C1580
C1581
C1582
C1583
C1584
C1585
C1586
C1587
C1588
C1589
C1590
C1591
C1592
C1593
C1594
C1595
C1596
* A6
E6
F6
F6
* F6
* E6
* F6
* F6
* F6
F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* E6
E6
* E6
E6
E6
D6
* D6
* D6
* D6
* D6
* D6
* D6
* D6
* D6
* D6
* D6
* E6
E6
* E6
* D6
* E6
* D6
* E6
* E6
* E6
E6
E6
* E6
* E6
E6
E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* F6
* E6
* E6
* E6
E6
E6
* E6
* E6
* E6
* E6
* E6
E6
* E6
* E6
* E6
* E6
* E6
* D6
* E6
C1597
C1598
C1599
C1600
C1601
C1602
C1603
C1604
C1605
C1606
C1607
C1608
C1609
C1610
C1611
C1612
C1613
C1614
C1615
C1616
C1617
C1618
C1619
C1620
C1621
C1622
C1623
C1624
C1625
C1626
C1627
C1628
C1629
C1630
C1631
C1632
C1633
C1634
C1635
C1636
C1637
C1638
C1639
C1640
C1641
C1642
C1643
C1644
C1645
C1646
C1647
C1650
C1651
C1692
C1693
C1694
C1695
C1701
C1702
C1703
C1704
C1705
C1706
C1707
C1708
C1709
C1710
C1711
C1712
C1713
C1714
C1715
C1716
C1717
C1718
C1719
C1720
C1721
C1722
C1723
C1724
C1725
C1800
C1801
C1802
C1804
C1805
C1806
C1807
C1808
C1809
C2001
C2002
C2003
C2004
C2005
C2006
C2007
10-8
* D6
* D6
* D6
* E6
* D6
* C6
* C6
* C6
* E5
* E5
* D5
* D5
* F6
B5
* B4
B5
B4
* B5
F6
F6
* C5
* C5
* C5
* C5
* C5
* C5
* D4
* D5
* D5
* B5
* B4
B4
* B4
* B5
B4
* B5
B4
B4
* B4
B4
B4
B4
* B4
B4
* B5
B5
B5
B5
B5
B5
B5
* E6
* F6
* E6
* E6
* E6
E6
* C3
* C3
C3
* C3
* C3
* D4
C3
C3
C4
C4
* C3
* C3
* C3
* C3
C4
* C3
* C4
* C3
* C3
* C3
* C3
* C3
* C3
* C3
* G3
* B3
* C3
* C3
* C3
* C3
* C3
* C3
* B3
* C3
* E3
* E4
D3
D3
E3
E3
* E3
C2008
C2009
C2010
C2011
C2012
C2013
C2014
C2015
C2016
C2017
C2018
C2019
C2020
C2021
C2022
C2023
C2024
C2025
C2027
C2028
C2029
C2030
C2101
C2102
C2103
C2104
C2105
C2106
C2107
C2108
C2109
C2110
C2111
C2112
C2113
C2114
C2115
C2116
C2117
C2118
C2119
C2120
C2121
C2122
C2123
C2124
C2125
C2126
C2127
C2128
C2129
C2130
C2131
C2132
C2201
C2202
C2203
C2204
C2205
C2206
C2207
C2208
C2209
C2210
C2211
C2212
C2213
C2214
C2215
C2216
C2217
C2218
C2219
C2220
C2221
C2222
C2223
C2224
C2225
C2226
C2227
C2228
C2229
C2230
C2231
C2232
C2233
C2234
C2235
C2236
C2237
C2238
C2239
C2240
C2241
C2242
C2243
C2244
* D3
* D3
E3
* D3
E3
* D3
* D3
* D3
* D3
D4
* E3
* E3
E3
E3
D3
* D3
* D3
* E3
* E3
* D3
* D3
D3
D3
* D3
D3
* D3
D2
* D3
D2
* D3
D2
* D3
D2
* D3
D3
* D2
D3
* D2
C2
* C2
C2
* C2
* D2
C2
* D2
C2
* D2
C2
* D2
C2
* C2
D2
* C2
D2
* D2
E2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* E2
* D2
* D2
* D2
* D2
* D2
* D1
E1
D1
* D2
* D2
* D2
* D2
E2
* D2
* D1
* D1
E1
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
* D2
D1
* D2
* D2
* D2
C2245
C2246
C2247
C2248
C2249
C2250
C2251
C2252
C2253
C2257
C2258
C2259
C2260
C2261
C2262
C2263
C2301
C2302
C2303
C2304
C2305
C2306
C2307
C2308
C2309
C2310
C2311
C2312
C2313
C2314
C2315
C2316
C2317
C2318
C2319
C2320
C2321
C2322
C2323
C2324
C2325
C2326
C2327
C2328
C2329
C2330
C2331
C2332
C2333
C2334
C2335
C2336
C2337
C2338
C2339
C2340
C2341
C2342
C2343
C2344
C2345
C2346
C2347
C2348
C2349
C2350
C2351
C2352
C2353
C2354
C2355
C2356
C2357
C2358
C2359
C2360
C2361
C2362
C2363
C2364
C2365
C2366
C2367
C2368
C2369
C2370
C2371
C2372
C2373
C2374
C2375
C2400
C2401
C2402
C2403
C2404
C2405
C2406
10-8
E2
E2
* D2
* E2
* D2
* D2
* D2
E2
E1
* E2
* E2
* E2
* D2
* D2
* D2
* D2
F3
F3
* F2
* F2
* F3
F3
* F3
* F3
* F3
* F3
* F3
F3
* F3
* F3
* F3
* F3
* F3
* F3
* F3
* F3
* F3
F3
* F3
* F3
* F3
F3
* F3
* F3
F3
F3
* F4
F4
* F4
* F3
* F3
* F3
F3
* F4
* F4
* F4
* F4
F4
* F4
* F4
* F4
F3
* F4
* F4
F4
F4
F4
E4
F4
F4
* F3
* F3
* F3
* F3
* F3
* F4
* F3
* F4
F3
F4
F3
F4
F3
F3
F3
F3
* F3
* F3
* F3
* F3
* F3
* E2
* E2
F2
E2
* E1
E2
* E2
C2407
C2408
C2409
C2410
C2411
C2412
C2413
C2414
C2415
C2416
C2417
C2418
C2419
C2420
C2421
C2422
C2423
C2424
C2425
C2426
C2427
C2501
C2502
C2503
C2504
C2505
C2506
C2507
C2508
C2509
C2510
C2511
C2512
C2513
C2514
C2515
C2516
C2517
C2518
C2519
C2601
C2602
C2603
C2604
C2605
C2606
C2607
C2608
C2609
C2610
C2611
C2612
C2613
C2614
C2615
C2616
C2617
C2618
C2619
C2620
C2621
C2622
C2623
C2624
C2625
C2626
C2627
C2628
C2629
C2630
C2631
C2632
C2633
C2634
C2635
C2636
C2637
C2638
C2639
C2640
C2641
C2642
C2643
C2644
C2645
C2646
C2647
C2648
C2649
C2650
C2651
C2652
C2653
C2701
C2702
C2703
C2704
C2705
E1
* E2
* E2
E2
* E2
* E1
* E1
* E1
* E1
* E2
E2
* E2
* E2
* F1
E2
* E2
* F5
* F2
* E1
* E2
* F5
G1
F1
F1
* F2
* F2
* F2
* F2
* F2
* F2
* F2
* F2
* F1
* F1
* F1
* F1
* F1
* F1
* F1
* F1
* E4
E3
F3
E3
E3
* E3
* E3
E3
E3
E4
E4
* E4
* E4
E4
E4
* A2
A2
A2
* A2
A3
* A3
E3
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
F2
F2
E2
E2
E2
E2
E2
E2
E2
E3
E3
* F3
* E3
E3
E3
* E3
* E3
* F5
* F4
* F5
* F4
* F5
C2706
C2707
C2708
C2709
C2710
C2711
C2712
C2713
C2714
C2715
C2716
C2717
C2718
C2719
C2720
C2721
C2722
C2723
C2724
C2725
C2726
C2727
C2728
C2729
C2730
C2731
C2732
C2733
C2734
C2735
C2736
C2737
C2738
C2739
C2740
C2741
C2742
C2743
C2744
C2745
C2746
C2747
C2748
C2749
C2750
C2751
C2752
C2753
C2754
C2755
C2756
C2757
C2758
C2759
C2760
C2761
C2762
C2763
C2764
C2765
C2766
C2767
C2768
C2769
C2770
C2771
C2772
C2773
C2774
C2775
C2776
C2777
C2778
C2779
C2801
C2802
C2803
C2804
C2805
C2806
C2807
C2808
C2809
C2810
C2811
C2812
C2813
C2814
C2815
C2816
C2817
C2818
C2819
C2820
C2821
C2822
C2823
C2824
* F5
* F4
* F5
* G5
* F5
* G4
* F4
* G5
* F5
G5
G4
G5
* G5
* G4
* G5
* G5
* G4
* G5
G5
G4
G5
* G5
* G4
* G5
G5
G4
G5
F5
F4
F5
* G5
* G4
* G5
* G5
* G5
* G4
* G4
* G5
* G5
* G5
* G4
* G5
* G4
* G4
* G5
* G5
* G5
* G5
* G5
* G5
* G4
* G4
* G5
* G5
* G5
* G5
* G4
* G4
* G5
* G5
* G4
* G4
* G4
* G4
* F5
* F4
* F4
F4
F4
F5
F5
* F5
* F5
F5
E1
E1
E1
F4
F4
* F4
F4
F5
F4
F4
F5
F5
F4
F4
F5
F5
F5
F5
F4
F5
F5
* F4
* F5
* F5
C2825
C2826
C2827
C2828
C2829
C2830
C2831
C2832
C2833
C2834
C2835
C2836
C2837
C2838
C2839
C2840
C2841
C2842
C2843
C2844
C2845
C2846
C2847
C2848
C2849
C2850
C2851
C2852
C2853
C2854
C2855
C2856
C2857
C2858
C2859
C2860
C2861
C2862
C2863
C2864
C2865
C2866
C2867
C2868
C2869
C2870
C2871
C2872
C2873
C2874
C2875
C3001
C3002
C3003
C3004
C3005
C3006
C3007
C3008
C3009
C3010
C3401
C3402
C3403
C3404
C3405
C3406
C3407
C3408
C3409
C3410
C3411
C3412
C3413
C3414
C3415
C3416
C3417
C3418
C3419
C3420
C3421
C3422
C3423
C3424
C3425
C3426
C3427
C3428
C3429
C3430
C3431
C3432
C3433
C3434
C3435
C3436
C3437
* F4
* F5
* F5
* F4
* F5
* F5
* F4
* F4
* F5
* F5
* F5
* F5
* F4
* F5
* F5
* F4
* F4
* F5
* F5
* F5
* F5
* F4
* F4
* F5
* F5
* F4
* F4
* F4
* F4
* F5
* F5
* F5
* F5
* F4
* F4
* F4
F4
* F5
* F4
F4
* F4
F4
* F4
* F4
* F4
F5
F4
* F4
F5
F5
* F4
F6
G6
* G6
* G6
* G6
* G6
G6
G6
G6
* G6
* D6
* D6
D5
D5
D6
D6
* D6
* D5
D5
D5
* D5
D5
D5
D5
D5
D5
D5
D5
* D5
* D5
* D5
D5
D5
D5
D5
* D5
* D5
D5
D5
D5
D5
D5
D5
D5
D5
D5
* D5
C3438
C3439
C3440
C3441
C3442
C3444
C3445
C3446
C3447
C3448
C3449
C3450
C3451
C3452
C3453
C3454
C3455
C3456
C3457
C3458
C3459
C3460
C3461
C3462
C3463
C3464
C3465
C3466
C3467
C3468
C3469
C3470
C3471
C3472
C3478
C3479
C3482
C3489
C3490
C3491
C3501
C3502
C3503
C3504
C3505
C3506
C3507
C3508
C3509
C3510
C3511
C3512
C3513
C3514
C3515
C3516
C3517
C3518
C3519
C3520
C3521
C3522
C3523
C3524
C3525
C3526
C3527
C3528
C3529
C3530
C3531
C3532
C3533
C3534
C3535
C3536
C3537
C3538
C3539
C3540
C3541
C3543
C3544
C3545
C3546
C3547
C3548
C3549
C3550
C3551
C3552
C3553
C3554
C3555
C3556
C3557
C3558
C3559
* D5
* D5
* D5
D5
D5
* D5
D5
D5
D5
* D5
D5
D5
* D5
* D5
D4
D4
D4
D4
* D4
* D4
* D4
D4
D4
* D4
* D4
* D4
* D4
* D4
* D4
* D4
D5
D6
* D4
* D4
D5
D4
* D5
* D5
* D5
* D5
* E6
* E6
E5
E5
E6
E6
* E6
* E5
E5
E5
* E5
E5
E5
E5
E5
E5
E5
E5
* E5
* E5
* E5
E5
E5
E5
E5
* E5
* E5
E5
E5
E5
E5
E5
E5
E5
E5
* E5
* E5
* E5
* E5
E5
E5
* E5
E5
E5
E5
E5
E5
E5
E5
* E5
E4
E4
E4
E4
* E4
* E4
* E4
E4
C3560
C3561
C3562
C3563
C3564
C3565
C3566
C3567
C3568
C3569
C3570
C3577
C3578
C3579
C3582
C3589
C3590
C3601
C3602
C3603
C3604
C3605
C3606
C3607
C3608
C3609
C3610
C3611
C3612
C3613
C3614
C3615
C3616
C3617
C3618
C3619
C3620
C3621
C3622
C3623
C3624
C3625
C3626
C3627
C3628
C3629
C3630
C3631
C3632
C3633
C3634
C3635
C3636
C3637
C3638
C3639
C3640
C3641
C3642
C3643
C3644
C3645
C3646
C3648
C3649
C3650
C3651
C3652
C3653
C3654
C3655
C3656
C3658
C3659
C3660
C3661
C3662
C3663
C3664
C3665
C3666
C3667
C3668
C3669
C3670
C3671
C3672
C3673
C3674
C3675
C3676
C3677
C3678
C3679
C3680
C3681
C3682
C3683
E4
* E4
* E4
* E4
* E4
* E4
* E4
* E4
E4
E4
E6
* E5
E5
E4
* E5
* E5
* E5
* D6
* E6
D6
D6
E5
D6
D6
D6
E5
E6
E6
* E6
* E5
E5
E5
* E5
E5
D5
E5
D5
E5
E5
E5
* E5
* E5
* E5
E5
E5
E5
E5
* E5
* E5
E5
E5
E5
E5
D5
D5
D5
D5
* E5
* D5
* D5
* D5
D5
D5
* E5
E5
E5
E5
D5
D5
D5
D5
* E5
* E4
* D6
* D6
E4
E4
E4
E4
* E4
* E4
* E4
E4
D4
* E4
* E4
* E4
* E4
* E4
* E4
* E4
* E5
D5
E4
E4
E4
* D5
* D6
C3684
C3685
C3686
C3687
C3688
C3689
C3690
C3701
C3702
C3703
C3704
C3705
C3706
C3707
C3708
C3709
C3710
C3711
C3712
C3713
C3714
C3715
C3716
C3717
C3718
C3719
C3720
C3721
C3722
C3723
C3725
C3726
C3727
C3728
C3729
C3730
C3731
C3732
C3733
C3734
C3735
C3736
C3737
C3738
C3739
C3740
C3741
C3743
C3744
C3745
C3746
C3747
C3748
C3749
C3750
C3751
C3752
C3753
C3754
C3755
C3756
C3757
C3758
C3759
C3760
C3761
C3762
C3763
C3764
C3765
C3766
C3767
C3768
C3769
C3770
C3778
C3779
C3782
C3784
C3787
C3788
C3801
C3802
C3803
C3804
C3805
C3806
C3807
C3808
C3809
C3810
C3811
C3812
C3813
C3814
C3815
C3816
C3817
* D6
* D6
* D6
* D6
* D6
* E5
* E5
* C6
* C6
C5
C6
C6
C6
* C6
* C6
C6
C6
* C6
C6
C6
C6
C6
C6
C5
C5
* C5
* C5
* C5
C5
C5
C5
* C5
* C5
C5
C5
C5
C5
C5
C5
C5
C5
* C5
* C5
* C5
* C5
C5
C5
* C5
C5
C5
C5
C5
C5
C5
C5
* C5
C5
C5
C4
C4
* C4
* C4
* C4
C5
C4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
C5
C5
C5
* C5
* C5
C5
C4
* C5
* C5
* C6
* C6
C5
C6
C6
C6
* C6
* C6
C6
C6
* C6
C6
B6
C6
B6
C6
C5
C3818
C3819
C3820
C3821
C3822
C3823
C3825
C3826
C3827
C3828
C3829
C3830
C3831
C3832
C3833
C3834
C3835
C3836
C3837
C3838
C3839
C3840
C3841
C3843
C3844
C3845
C3846
C3847
C3848
C3849
C3850
C3851
C3852
C3853
C3854
C3855
C3856
C3857
C3858
C3859
C3860
C3861
C3862
C3863
C3864
C3865
C3866
C3867
C3868
C3869
C3870
C3871
C3872
C3873
C3874
C3878
C3882
C3884
C3887
C3888
C3901
C3902
C3903
C3904
C3905
C3906
C3907
C3908
C3909
C3910
C3911
C3912
C3913
C3914
C3915
C3916
C3917
C3918
C3919
C3920
C3921
C3922
C3923
C3924
C3925
C3926
C3927
C3928
C3929
C3930
C3931
C3932
C3934
C3935
C3936
C3937
C3938
C3939
C5
* C5
* C5
* C5
C5
C5
C5
* C5
* C5
C5
C5
C5
C5
B5
B5
B5
B5
* C5
* B5
* B5
* B5
B5
B5
* C5
C5
C5
C5
B5
B5
B5
B5
* C5
C5
C5
C4
C4
* C4
* C4
* C4
C5
B4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
C5
* B5
* B5
* B5
* B5
C5
C5
* C5
B5
C4
* B5
* C5
* D6
B6
B6
B6
C6
C6
* C6
B6
C6
C6
C6
D5
D6
D6
D6
* D6
* D6
D6
D6
* D6
D6
C6
D6
C6
D6
D5
D5
* D5
* D5
* D5
D5
D5
D5
* D5
* D5
D5
D5
D5
HSCU-300
DPR-300
C3940
C3941
C3942
C3943
C3944
C3945
C3946
C3947
C3948
C3949
C3950
C3952
C3953
C3954
C3955
C3956
C3957
C3958
C3959
C3960
C3961
C3962
C3963
C3964
C3965
C3966
C3967
C3968
C3969
C3970
C3971
C3972
C3973
C3974
C3975
C3976
C3977
C3978
C3982
C3983
C3984
C3985
C3986
C3987
C3988
C4001
C4002
C4003
C4004
C4005
C4006
C4007
C4008
C4009
C4010
C4011
C4012
C4013
C4014
C4015
C4016
C4017
C4018
C4019
C4020
C4021
C4022
C4023
C4024
C4025
C4026
C4027
C4028
C4029
C4030
C4031
C4032
C4033
C4034
C4035
C4036
C4037
C4038
C4039
C4041
C4042
C4043
C4044
C4045
C4046
C4047
C4048
C4049
C4050
C4051
C4052
C4053
C4054
D5
C5
C5
C5
C5
* D5
* C5
* C5
* C5
C5
C5
* D5
D5
D5
D5
C5
C5
C5
C5
* D5
D5
D5
D4
D4
* D4
* D4
* D4
D5
C4
* D4
* D4
* D4
* D4
* D4
* D4
* D4
D5
* D5
C5
* D5
D4
D5
D5
* C5
* D5
* G3
* C1
* C1
B3
B3
B3
* F2
* B3
D2
* E4
* G2
* A2
E3
* E3
* G1
* B2
* B2
* B2
* B2
* B2
* B2
* B2
B2
B2
* B2
B2
* B2
B2
B2
B2
B2
* B2
* B2
* B2
* B2
B2
* A2
* G4
* C1
F4
G3
* C1
* C1
* C2
C2
* C2
* C2
C2
* C2
C2
* C2
* C1
* C2
HSCU-300
C4055
C4056
C4057
C4058
C4059
C4060
C4061
* C2
* G3
* G3
F4
G4
G4
* G4
CL201
B4
CL202
B4
CL203
A5
CL241
F2
CL242
F5
CL243
F5
CL244
E2
CL245
E1
CL246
E1
CL247
F5
CL301
G6
CL302
G6
CL303
A6
CL304
F6
CL305
F6
CL306
G6
CL307
E4
CL308
F6
CL309
C4
CL401
G4
CL402
F4
CL403
C1
CL404
F2
CL405
B3
CL406
B3
CL407
C1
CL408
B1
CL409
B3
CL410
B2
CL411
B2
CL501 * G2
CL502
G2
CL601
A2
CL602
A2
CL603
B2
CL604
B2
CL605
B2
CL606
B2
CL701
A1
CL702
B1
CL703
B2
CL704
A2
CL706
A2
CL707
A2
CL708
A2
CL709
A2
CL900
B2
CL901
B1
CL1112 A4
CL1701 C4
CL1703 B4
CL1704 C4
CL1705 C4
CL1706 C4
CL1707 D3
CL1708 D3
CL1709 D4
CL1710 D4
CL1711 C4
CL1800 B3
CL1801 B3
CL2001 E3
CL2002 E3
CL2003 E3
CL2004 E3
CL2005 D4
CL2006 D4
CL2007 E4
CL2008 E4
CL2009 E4
CL2010 E4
CL2201 E2
CL2202 E2
CL2203 E1
CL2204 E1
CL2205 E1
CL2207 E2
CL2208 E2
CL2301 F3
CL2302 F4
CL2303 F3
CL2304 F3
CL2305 F3
CL2306 F3
CL2701 F5
CL2801 F5
CL2802 F4
CL3404 D5
CL3405 D5
CL3406 D4
CL3407
CL3408
CL3409
CL3410
CL3411
CL3412
CL3414
CL3415
CL3416
CL3501
CL3504
CL3505
CL3506
CL3507
CL3508
CL3509
CL3510
CL3511
CL3512
CL3514
CL3515
CL3516
CL3601
CL3604
CL3605
CL3606
CL3607
CL3608
CL3609
CL3610
CL3611
CL3612
CL3701
CL3704
CL3705
CL3706
CL3707
CL3708
CL3709
CL3710
CL3711
CL3712
CL3801
CL3803
CL3804
CL3805
CL3806
CL3807
CL3808
CL3809
CL3810
CL3811
CL3812
CL3813
CL3814
CL3815
CL3901
CL3904
CL3905
CL3906
CL3907
CL3908
CL3909
CL3910
CL3911
CL3912
D4
D5
D5
D5
D5
D5
D4
D4
D4
E5
E5
E5
E4
E4
E5
E5
E5
E5
E5
E4
E4
E4
E5
D5
D5
E4
D4
E5
E5
E5
E5
D5
C5
C6
C5
C5
C4
C6
C5
C5
C6
C6
C5
C4
B6
B5
C5
B4
C6
C5
C5
C6
B6
B5
C4
C4
D5
C6
C5
D5
C4
D6
D5
D5
D6
C6
CN101
CN102
CN701
CN702
CN900
CN1800
CN3901
G5
G3
B1
A3
C2
C3
B5
D201
D202
D203
D301
D302
D303
D304
D305
D306
D307
D308
D401
D402
D403
D404
D405
D406
D407
D701
D1501
D1502
D1503
D1504
A5
* A5
B4
* G6
* G6
* F6
F6
* G6
E4
* G6
D4
* G4
* G4
* B2
B2
B2
A2
G3
A2
* F6
* F6
* F6
* F6
D1505
D1506
D1507
D1508
D1509
D1602
D2201
D2801
D2802
D3401
D3501
D3601
D3602
D3603
D3701
D3801
D3902
D3904
D3905
* F6
F6
F6
D6
E6
F6
E2
* F5
* F4
* D5
* E5
* D6
* D6
* D5
* C5
* B5
* C5
B6
B6
E1
E2
E4
E5
E7
E8
E9
E14
E201
E202
E203
E204
E271
E272
E1501
* A6
* C5
B4
D4
F2
* C3
* E3
C6
B5
A6
A5
B5
G5
* G4
F6
FB21
FB22
FB301
FB302
FB303
FB304
FB305
FB306
FB307
FB308
FB309
FB310
FB311
FB312
FB313
FB314
FB315
FB316
FB317
FB318
FB319
FB320
FB321
FB322
FB323
FB324
FB325
FB326
FB329
FB330
FB331
FB332
FB333
FB334
FB335
FB401
FB402
FB403
FB404
FB405
FB406
FB407
FB408
FB409
FB410
FB411
FB412
FB413
FB414
FB415
FB416
FB417
FB418
FB419
FB420
FB421
FB422
FB423
FB424
FB425
FB426
FB427
G6
G6
* G6
* G6
* G6
* G6
G6
G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* F6
* F6
G6
G6
* G3
G6
G6
G6
G6
G6
G6
G6
* G4
* G4
* G4
* G4
* G4
* G3
* G4
* G4
* G4
* G4
* G3
* G4
* G4
* G4
* G3
* G3
* G3
* G3
* G3
G3
G3
* F2
F2
F2
F2
F2
* C3
FB428
FB429
FB430
FB431
FB432
FB433
FB434
FB435
FB436
FB437
FB438
FB439
FB440
FB441
FB442
FB443
FB444
FB445
FB446
FB447
FB501
FB502
FB503
FB504
FB505
FB506
FB507
FB701
FB702
FB703
FB704
FB705
FB706
FB707
FB708
FB801
FB802
FB803
FB900
FB901
FB902
FB903
FB906
FB907
FB908
FB911
FB1101
FB1102
FB1103
FB1104
FB1105
FB1106
FB1107
FB1108
FB1109
FB1110
FB1111
FB1800
FB1801
FB1804
FB1805
FB1808
FB1812
FB2001
FB2301
FB2302
FB2303
FB2304
FB2305
FB2306
FB2307
FB2308
FB2309
FB2310
FB2311
FB2312
FB2313
FB2314
FB2316
FB2317
FB2319
FB2401
FB2402
FB2403
FB2404
FB2601
FB2602
FB2701
FB2702
FB2703
FB2704
FB2705
FB2706
FB2801
FB2802
FB2803
FB2804
FB2805
C3
C3
C3
C3
* C3
C3
C3
C3
C3
* D2
* C2
* C2
* C2
* D2
* C2
* C2
* C2
* C2
* C2
* C1
F3
F3
* A1
* G1
* G2
* G3
* G3
* F2
G1
G1
* F2
* B1
* B1
* B1
A1
* A2
* A2
* A2
* F2
* C2
G2
* C2
* C2
* C2
* C2
* C2
B4
* B4
A4
* A4
* A4
A4
* A4
* A4
A5
A5
* B4
* C3
* B3
* C3
* C3
* C3
* C3
* E3
* F3
* F3
* F3
* F3
* F3
* F3
* F3
* F3
* F2
* F4
* F3
* F3
* F4
* F4
* F4
* F4
F3
* F5
F5
* F5
* F5
F3
F3
* F4
* F4
G5
G4
* G5
F5
* F4
* F4
* F4
* F5
* F4
FB2806
FB2807
FB2808
FB3402
FB3403
FB3404
FB3406
FB3407
FB3408
FB3409
FB3502
FB3503
FB3504
FB3506
FB3507
FB3602
FB3603
FB3604
FB3606
FB3607
FB3608
FB3609
FB3702
FB3703
FB3704
FB3706
FB3707
FB3708
FB3709
FB3802
FB3803
FB3804
FB3806
FB3807
FB3808
FB3809
FB3902
FB3903
FB3904
FB3906
FB3907
F4
F5
* F4
* D4
* D4
* D4
D4
D4
D4
D4
* E4
* E4
* E4
E4
E4
* E4
* E4
* E4
D4
E4
E4
E4
* C4
* C4
* C4
C4
C4
C4
C4
* C4
* C4
* C4
B4
C4
C4
C4
* D4
* D4
* D4
C4
D4
FL201
FL202
FL1501
FL1502
FL3401
FL3501
FL3601
FL3701
FL3801
FL3901
FL3902
B5
A5
F6
D6
D6
E6
E6
C6
C6
B5
D6
IC21
IC22
IC201
IC202
IC203
IC204
IC205
IC206
IC207
IC208
IC209
IC210
IC211
IC212
IC213
IC215
IC216
IC217
IC301
IC302
IC303
IC304
IC305
IC306
IC307
IC308
IC309
IC310
IC311
IC312
IC401
IC402
IC403
IC404
IC405
IC406
IC407
IC408
IC409
IC410
IC411
IC412
IC414
IC415
G2
G2
* A5
A5
A6
A5
* A6
A5
A6
A6
* A5
* A5
* A5
* A5
* A5
* A5
* B6
A5
* G6
* A6
* F6
* F6
F6
F6
G6
F4
* F6
D4
* G6
* G6
* G3
* F2
* C3
* C3
* D1
G3
* C1
B2
* B1
B3
B2
* B2
* C1
* C1
IC416
IC417
IC418
IC501
IC502
IC503
IC504
IC505
IC506
IC507
IC508
IC509
IC510
IC511
IC513
IC514
IC515
IC517
IC518
IC519
IC520
IC523
IC524
IC601
IC602
IC700
IC701
IC702
IC703
IC704
IC705
IC706
IC707
IC708
IC709
IC710
IC711
IC713
IC800
IC900
IC901
IC902
IC903
IC1101
IC1102
IC1103
IC1104
IC1108
IC1109
IC1501
IC1502
IC1503
IC1504
IC1505
IC1506
IC1507
IC1508
IC1509
IC1510
IC1511
IC1512
IC1513
IC1514
IC1515
IC1601
IC1602
IC1603
IC1604
IC1605
IC1606
IC1607
IC1609
IC1611
IC1612
IC1613
IC1614
IC1615
IC1616
IC1617
IC1618
IC1700
IC1701
IC1800
IC1801
IC2000
IC2001
IC2002
IC2003
IC2005
IC2101
IC2102
IC2103
IC2104
IC2201
IC2202
IC2203
IC2204
IC2205
* C1
G3
* D1
G3
* A1
* G2
* G3
G2
* G2
* G2
* G2
* G2
* G2
* G1
G1
G1
* G2
* G2
* G2
G1
* F2
G1
G1
* B2
B3
A2
* A3
* A2
* A2
* F2
* A2
G1
* F1
G1
A1
* A3
* A3
* B1
A2
* F2
* C2
G2
* C2
A3
* B4
A4
A4
* B4
* A4
F6
E6
E6
F6
F6
* F6
* F6
* E6
* E6
E6
E6
* E6
* E6
* D6
* F6
* D5
* C5
* C5
* E5
* E5
* D5
B4
F6
* C5
* C5
* D4
* B5
B4
B5
B5
B4
C3
* G3
* C3
* C3
D3
D2
* D3
* E3
* E3
D3
* D3
* C2
C2
* E2
* E2
* E2
* D2
D1
IC2301
IC2302
IC2303
IC2304
IC2305
IC2306
IC2307
IC2308
IC2309
IC2310
IC2311
IC2312
IC2400
IC2401
IC2402
IC2501
IC2601
IC2602
IC2603
IC2604
IC2605
IC2606
IC2608
IC2609
IC2610
IC2611
IC2612
IC2613
IC2614
IC2615
IC2701
IC2702
IC2703
IC2704
IC2705
IC2706
IC2707
IC2708
IC2709
IC2710
IC2711
IC2801
IC2802
IC2803
IC2804
IC2805
IC2806
IC2807
IC2808
IC2809
IC2810
IC2811
IC3401
IC3402
IC3403
IC3404
IC3405
IC3501
IC3502
IC3504
IC3505
IC3601
IC3602
IC3604
IC3605
IC3606
IC3701
IC3702
IC3704
IC3705
IC3801
IC3802
IC3804
IC3805
IC3806
IC3901
IC3902
IC3904
IC3905
IC3906
IC3907
F3
F3
* F3
F3
* F2
* F3
* F3
F3
F3
F4
F3
* F3
E2
* E2
F5
F1
* E3
E3
* A2
* A2
E2
E2
E2
F2
E2
* E3
* E3
* E3
* E3
* A2
* F5
* F4
F5
F4
F5
G4
* G5
* G4
G5
* G5
* F5
E1
F4
* F4
F4
F4
F5
F5
* F4
* F5
* F5
* F4
D5
D5
D5
D4
D5
E5
E5
E4
E5
E5
E5
E4
E5
D6
C5
C5
C4
C6
C5
C5
C4
C6
* B5
D5
D5
D4
D6
C6
B6
L201
L202
L203
L204
L205
L206
L207
L208
L209
L210
L211
L212
L213
L214
L301
L303
* B5
* A6
* A5
A5
* A5
* A5
* A6
* A5
* A5
* A5
* A5
* A5
B4
B6
G3
G6
10-9
L304
L305
L306
L307
L308
L401
L402
L403
L404
L405
L406
L407
L408
L501
L601
L602
L603
L604
L605
L606
L607
L608
L609
L610
L611
L612
L701
L702
L703
L704
L1101
L1102
L1103
L1104
L1105
L1106
L1501
L1502
L1503
L1504
L1505
L1506
L1507
L1508
L1509
L1601
L1602
L1603
L1701
L1702
L1703
L2001
L2002
L2003
L2004
L2101
L2102
L2103
L2104
L2201
L2202
L2203
L2204
L2205
L2207
L2301
L2302
L2401
L2402
L2403
L2405
L2501
L2502
L2601
L2602
L2603
L2604
L2605
L2606
L2607
L2608
L2609
L2610
L2611
L2612
L2701
L2702
L2703
L2704
L2705
L2706
L2707
L2708
L2709
L2710
L2712
L2713
L2714
DPR-300
F6
F6
F6
F6
F6
C1
G4
F2
C3
C3
C1
B2
B2
* G3
* B3
* B3
* A3
* A3
* B2
* B3
B3
B3
B3
B3
B3
B3
* A2
* A2
* A2
B1
* A4
* A4
* B3
B4
* A4
* B4
* F6
* F6
* E6
* D6
* E6
* D6
* E6
* E6
* E6
* F6
* B5
* B5
* C3
* C3
* G3
* E3
* E4
D3
D3
D3
* D3
D2
* D2
D1
D1
D1
E3
E2
* D2
F4
* F2
* E2
F2
E2
* E2
G1
* F1
A2
A2
E2
E2
E2
F2
E2
E2
E3
E3
E3
E2
* F5
* F4
* F5
* G5
* G4
G5
* G5
* G4
* G5
F4
* F5
* F5
* F4
L2715
L2716
L2717
L2718
L2801
L2802
L2803
L2804
L2805
L2806
L2807
L2808
L2809
L2810
L2811
L2812
L2813
L2814
L2815
L2816
L2817
L3401
L3402
L3403
L3404
L3405
L3406
L3407
L3408
L3409
L3501
L3502
L3503
L3504
L3505
L3506
L3507
L3508
L3509
L3510
L3601
L3602
L3603
L3604
L3605
L3606
L3607
L3608
L3609
L3610
L3611
L3701
L3702
L3703
L3704
L3705
L3706
L3707
L3708
L3709
L3801
L3802
L3803
L3804
L3805
L3806
L3807
L3808
L3809
L3901
L3902
L3903
L3904
L3905
L3906
L3907
L3908
L3909
LV1501
LV1502
LV1503
Q201
Q202
Q203
Q204
Q205
Q206
Q207
Q208
Q209
Q210
Q211
Q212
Q213
Q214
Q215
* F5
* F5
* F4
F5
F4
F5
F5
* F4
* F5
* F5
* F4
* F5
* F5
* F4
* F5
* F4
* F4
* F5
* F5
* F4
* F4
* D6
* D6
D5
D5
* D5
* D5
D4
* D4
D5
* E6
* E6
E5
E5
* E5
* E5
E4
E4
E5
* E5
* D6
* E6
E5
E5
* D5
* D6
E4
E4
D5
* E5
* D6
* C6
* C6
C5
C5
* C5
C5
C4
C5
* C5
* C6
* C6
C5
C5
* B5
C5
C4
B5
* C5
* D6
* C6
D5
D5
* C5
D5
D4
C5
* D5
F6
E6
E6
* B4
* B4
* B5
* B4
* B4
* A5
* A5
* A6
* A6
B5
B5
B5
B5
* B4
* B4
10-9
Q301
Q302
Q303
Q304
Q305
Q306
Q307
Q308
Q309
Q310
Q401
Q402
Q403
Q404
Q405
Q406
Q407
Q408
Q409
Q410
Q411
Q412
Q413
Q414
Q415
Q601
Q602
Q701
Q1501
Q1502
Q1503
Q1504
Q1505
Q1601
Q1602
Q1603
Q1604
Q1605
Q2801
Q2802
Q2803
Q2804
Q2805
* G6
* G6
* F6
* F6
* G6
F6
F6
* F6
F6
* G6
* G4
* G3
G3
* B2
* B2
* A2
* A2
B2
B2
A2
* F2
* D3
* D2
* B2
F2
* B3
B3
A2
* F6
* F6
* D6
* D6
* D6
B4
* B4
B4
* B4
B4
E1
E1
E1
F4
* F5
R21
R22
R23
R24
R25
R26
R201
R202
R203
R204
R205
R206
R207
R208
R209
R210
R211
R212
R213
R214
R215
R216
R217
R218
R219
R220
R221
R222
R223
R224
R225
R226
R227
R228
R229
R230
R231
R232
R233
R234
R235
R236
R237
R238
R239
R240
R241
R242
R243
R244
R245
R246
R247
R248
G2
G2
G2
G2
G2
G2
* B4
B4
B4
* B4
* B4
* B4
* B4
* B5
* B5
* B5
* B4
* B5
* B4
* B4
* B4
* B4
* B4
* B4
* B5
B6
B6
A6
A6
B6
A6
B6
A6
B5
A5
B5
A5
* B5
* B5
* A5
* A5
* A5
* A5
* A5
A5
A5
* A5
A5
* A5
* A5
* A5
* A5
* A6
* A5
R249
R250
R251
R252
R253
R254
R255
R256
R257
R258
R259
R260
R261
R262
R263
R264
R265
R266
R267
R268
R269
R270
R271
R272
R273
R274
R275
R276
R277
R278
R279
R280
R281
R282
R283
R284
R285
R286
R287
R288
R289
R290
R291
R292
R293
R294
R295
R296
R297
R298
R299
R301
R302
R303
R304
R305
R306
R307
R308
R309
R310
R311
R312
R313
R314
R315
R316
R317
R318
R319
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
R330
R331
R332
R333
R334
R335
R336
R337
R338
R339
R340
R341
R342
R343
R344
R345
R346
R347
A5
A5
A6
A6
A6
A6
A6
A6
A6
A6
A6
A6
A6
A6
* A6
* A6
* A6
* A6
* A6
* A6
* A6
A6
A6
* A6
* A6
* A5
A5
A5
* A5
* A5
A6
* A5
A6
* A5
* B5
A6
* A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
A5
* G6
G6
G6
G6
G6
* G6
* G6
G6
* G6
* F6
* F6
* F6
* F6
* F6
F6
F6
F6
* F6
* F6
* F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
G6
G6
G6
G6
E4
F4
F4
F4
F4
F4
* G6
* F6
* F6
* F6
R348
R349
R350
R351
R352
R353
R354
R355
R356
R357
R358
R359
R360
R361
R362
R363
R364
R365
R366
R367
R369
R370
R371
R372
R373
R374
R375
R376
R377
R378
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R411
R412
R413
R414
R415
R416
R417
R418
R419
R420
R421
R422
R423
R424
R425
R426
R427
R428
R429
R430
R431
R432
R433
R434
R435
R436
R437
R438
R439
R440
R441
R442
R443
R444
R445
R446
R447
R448
R449
R450
R452
R453
R454
R455
R456
R457
R458
R459
R460
R461
R462
R463
R464
R465
R466
R467
R468
R469
* F6
* G6
* G6
* G6
F6
F6
* B6
* A6
* A6
* A6
* A6
* G6
D4
D4
D4
D4
D4
D4
* G6
* G6
* F6
* F6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
* G6
G3
* G3
* G3
* G3
* G3
* G3
* G3
* G4
* G3
* B2
G3
G3
G3
* C1
* F2
* F2
* F2
* F2
* F2
* F2
* F2
* F2
* F2
* F2
F2
* C1
* D3
* D3
* D3
* D3
* D3
* D3
* D3
* D3
* C1
* C1
* D3
* D3
C3
* D3
* D3
* D3
* D3
* D2
* D3
* D3
* D3
* D2
* D2
G3
C3
* D1
* D1
* D1
* C1
* D1
* D1
* D1
* C1
* D1
* D1
* C1
* C1
* C1
* B1
G3
G3
G3
R470
R471
R472
R473
R474
R475
R476
R477
R478
R479
R480
R481
R482
R483
R484
R485
R486
R487
R488
R489
R490
R491
R492
R493
R494
R495
R496
R497
R498
R499
R501
R502
R503
R504
R505
R509
R510
R511
R512
R513
R514
R518
R519
R520
R521
R522
R523
R524
R525
R526
R527
R528
R529
R530
R531
R532
R533
R534
R535
R537
R538
R539
R540
R541
R542
R543
R544
R546
R547
R548
R549
R550
R552
R553
R554
R555
R556
R558
R559
R560
R561
R562
R563
R564
R565
R566
R567
R572
R573
R574
R575
R576
R601
R602
R603
R604
R605
R614
G3
B3
G3
G3
B3
B3
B3
B3
B3
F2
F2
F2
F2
F2
F2
F2
* B2
B2
B2
* B2
* B2
* B2
* B2
B2
B2
B2
B2
B2
* A2
B2
* F2
* F2
* F2
* A1
* A1
F3
F3
F3
F3
F3
G3
* G3
* G3
G3
* G3
* F3
* F3
G2
G3
G3
G3
F3
F3
* G2
* G2
* G2
* G2
* G2
* G2
G1
G1
G1
G1
G1
* G1
* G1
* G1
* G2
* G2
* G2
* G3
G3
* G3
* G3
* G3
* G3
* G2
G1
G1
F3
* G2
G1
F3
* F3
* G2
* G2
* G2
G2
G1
G1
G1
G1
* B3
* B3
* B3
* B3
* B3
* A2
R618
R619
R620
R621
R622
R623
R624
R625
R626
R627
R628
R629
R630
R631
R632
R633
R634
R635
R636
R637
R638
R639
R648
R652
R653
R654
R655
R656
R657
R658
R659
R660
R661
R662
R663
R664
R665
R666
R667
R668
R669
R670
R671
R672
R673
R701
R702
R703
R704
R705
R706
R707
R708
R709
R710
R711
R712
R713
R714
R715
R716
R719
R720
R721
R722
R723
R724
R725
R726
R727
R728
R729
R732
R733
R734
R735
R736
R737
R738
R739
R740
R741
R742
R743
R744
R745
R746
R747
R748
R749
R750
R751
R752
R753
R754
R755
R756
R757
* A2
* A2
* A2
* B2
* B2
* B2
* B2
* B2
* B2
* B2
* B3
* B2
* B3
* B3
* B3
* B3
* B3
B3
B3
B3
B3
B3
* B3
* B3
* B3
* B3
* B3
B2
B2
B2
B2
B2
B2
A3
A3
B3
B3
B3
B3
A3
B3
B3
* B3
* B3
B3
* A3
A2
* A2
* A2
* A2
A2
* A2
A2
* A2
* A2
* A2
* A2
* A2
A2
* A2
A2
* A2
* F2
* F2
* F2
A2
A2
* A2
* A2
* F2
* F2
* A2
* A2
* A2
* A2
* A2
* A2
* A2
G1
G1
G1
* F1
G2
A1
A1
A1
A1
A1
B1
B1
B1
B1
B1
A1
A1
B1
A1
A1
R758
R759
R760
R761
R762
R763
R764
R765
R766
R767
R768
R769
R770
R771
R772
R773
R774
R775
R776
R777
R778
R779
R801
R802
R803
R900
R901
R902
R903
R904
R905
R906
R907
R908
R913
R916
R917
R920
R921
R926
R927
R928
R929
R930
R931
R932
R933
R934
R935
R1101
R1102
R1103
R1104
R1106
R1110
R1111
R1112
R1113
R1114
R1115
R1116
R1117
R1118
R1119
R1120
R1121
R1122
R1123
R1124
R1125
R1126
R1127
R1128
R1129
R1130
R1131
R1132
R1133
R1134
R1135
R1136
R1137
R1138
R1139
R1140
R1141
R1142
R1143
R1144
R1145
R1151
R1152
R1153
R1154
R1155
R1156
R1157
R1158
A1
* A2
A2
* A3
* A3
* A3
* A3
* A3
* A3
A1
* F1
A2
* A1
* B1
B1
B1
B1
B1
A2
* A2
A1
* A2
* A2
* A2
* A2
* F2
* C2
G2
C1
C1
C2
C2
C2
C2
C2
* C2
C2
C2
C1
C2
C2
* C2
C2
C2
* C2
* C2
* C2
* C2
* C2
B4
B4
* A3
* B4
* A3
* B4
* B4
B4
* B4
* B3
B3
B4
B4
B4
B4
B4
B4
B4
B4
B4
B4
A3
A3
A3
A3
B3
B3
B3
B3
B3
* A4
* A4
* A4
* A4
* A4
* B4
* A4
A4
A4
A4
A4
A4
A4
* A4
A4
* A4
* A4
* A4
* A4
R1159
R1160
R1161
R1163
R1164
R1165
R1166
R1167
R1168
R1169
R1170
R1171
R1172
R1173
R1175
R1176
R1177
R1178
R1179
R1180
R1181
R1182
R1183
R1184
R1185
R1186
R1187
R1192
R1195
R1196
R1200
R1201
R1202
R1203
R1204
R1205
R1206
R1207
R1208
R1209
R1210
R1211
R1212
R1213
R1214
R1215
R1216
R1217
R1218
R1219
R1220
R1221
R1222
R1223
R1224
R1225
R1226
R1227
R1228
R1229
R1230
R1231
R1232
R1233
R1234
R1235
R1501
R1502
R1503
R1504
R1505
R1506
R1507
R1508
R1509
R1510
R1511
R1512
R1513
R1514
R1515
R1516
R1517
R1518
R1519
R1520
R1521
R1522
R1523
R1524
R1525
R1526
R1527
R1528
R1529
R1530
R1531
R1532
* A4
A4
A4
A4
A4
A4
A4
* A4
* A4
* A4
* A4
* A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A4
A3
A5
* A5
* A5
* A5
* B5
A5
B6
A6
A6
A6
B5
B5
* B5
* A5
* B5
* A5
* A6
* A6
A5
A5
B5
B5
B5
B5
B5
B5
B5
B5
B5
B5
* A6
* A6
* A6
* A5
* A5
* A5
F6
F6
F6
F6
F6
* F6
* F6
F6
F6
F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
F6
F6
F6
F6
* F6
* F6
DPR-300
R1533
R1534
R1535
R1536
R1537
R1538
R1539
R1540
R1541
R1542
R1543
R1544
R1545
R1546
R1547
R1548
R1549
R1550
R1551
R1552
R1553
R1554
R1555
R1556
R1557
R1558
R1559
R1560
R1561
R1562
R1563
R1564
R1565
R1566
R1567
R1568
R1569
R1570
R1571
R1572
R1573
R1574
R1575
R1576
R1577
R1578
R1579
R1580
R1581
R1582
R1583
R1584
R1585
R1586
R1587
R1588
R1589
R1590
R1591
R1592
R1593
R1594
R1595
R1596
R1597
R1598
R1599
R1601
R1602
R1603
R1604
R1605
R1606
R1607
R1608
R1609
R1610
R1611
R1612
R1613
R1614
R1615
R1616
R1617
R1618
R1619
R1620
R1621
R1622
R1623
R1624
R1625
R1626
R1627
R1628
R1629
R1630
R1631
R1632
R1633
R1634
R1635
R1636
* F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
* E6
F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* F6
* E6
D6
* D6
* D6
* D6
* D6
* D6
E6
E6
* E6
* E6
* E6
* E6
* D6
* D6
* D6
* D6
* D6
* D6
* E6
* E6
* E6
E6
E6
E6
E6
E6
E6
* E6
* E6
* E6
* E6
* E6
F6
E6
* E6
* E6
* E6
* E6
* E6
* E6
* D5
* D6
* D6
* D6
* C5
* C6
* C6
* C6
* C5
* C6
* C6
* C6
* C6
* E5
* E5
* E5
* E5
* E5
* E5
* E5
* E5
* D5
* D5
* D5
* D5
* D5
B5
B4
B4
B4
B4
B4
B4
F6
F6
F6
R1637
R1638
R1639
R1640
R1641
R1642
R1643
R1644
R1645
R1646
R1647
R1648
R1649
R1650
R1651
R1652
R1653
R1654
R1655
R1656
R1657
R1658
R1659
R1660
R1661
R1662
R1663
R1665
R1666
R1667
R1668
R1669
R1670
R1671
R1672
R1673
R1674
R1675
R1676
R1677
R1678
R1679
R1680
R1681
R1682
R1683
R1684
R1685
R1686
R1687
R1688
R1689
R1690
R1691
R1692
R1693
R1694
R1695
R1696
R1697
R1698
R1699
R1700
R1705
R1707
R1708
R1729
R1730
R1732
R1733
R1734
R1735
R1736
R1737
R1738
R1739
R1740
R1741
R1742
R1743
R1745
R1746
R1747
R1748
R1749
R1750
R1751
R1752
R1753
R1754
R1770
R1771
R1772
R1774
R1775
R1776
R1777
R1778
R1800
R1801
R1802
R1803
R1804
B4
F5
* C5
* C5
* C5
* C5
* D4
* D4
* B4
* B4
* B5
* B5
* B5
* B5
* B5
* B5
* B5
B4
* B5
* B5
* B5
B5
B5
* B5
* B5
* B5
B5
* B4
* B4
* B4
B4
* B4
* B4
* B4
* B4
* B4
* B4
* B4
* B4
B4
* B4
* B4
B4
* B4
* B4
* B4
* B4
* B4
* B4
* B4
* B4
* B4
B4
B4
B4
B4
B4
B4
* B4
* B4
* B4
* B4
B4
* C3
* C4
D4
* D3
D3
D3
* C3
* C3
* C3
* C3
* C4
* C4
* C4
* C4
* C4
* C4
* C3
* C4
* C4
* D4
* D4
* D4
* D4
* C4
* C4
* G3
* G3
C3
* D3
* D3
C3
* C4
C4
C4
* G3
* B3
B3
B3
B3
B3
R1806
R1807
R1808
R1809
R1810
R1811
R1814
R1816
R1818
R1819
R1820
R1822
R1823
R1824
R1825
R1826
R1827
R1828
R1829
R1830
R1901
R1902
R1903
R1904
R1905
R1906
R1907
R1908
R1909
R1910
R1911
R1912
R1913
R1914
R1915
R1916
R1917
R1918
R1919
R1920
R1921
R1922
R1923
R1924
R1925
R1926
R1927
R1928
R1929
R1930
R1931
R1932
R1933
R1934
R1935
R1936
R1937
R1938
R1939
R1940
R1941
R1942
R1943
R1944
R1945
R1946
R1947
R1948
R1949
R2001
R2002
R2003
R2004
R2005
R2006
R2007
R2008
R2009
R2010
R2011
R2012
R2013
R2014
R2015
R2016
R2017
R2018
R2019
R2020
R2021
R2022
R2023
R2024
R2025
R2027
R2028
R2029
R2030
R2031
R2032
R2033
R2034
R2035
B3
B3
C4
C4
B3
C3
C3
C3
C3
* C3
C3
* C3
* C3
* C3
* C3
* B3
C3
C3
* B3
C3
* D6
* D6
D6
D6
D6
* D6
* E6
* D6
* D6
* E6
E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
E6
E6
E6
E6
E6
* E6
* E6
* F6
* E6
E6
B5
B5
B5
B5
B5
B5
B5
B5
B5
* B4
* D2
* D2
* D2
* D2
* D3
* D3
E3
* D3
* D3
* D3
E3
* E3
D3
* D4
* D3
* D4
* D4
* E3
* E3
* D4
D4
* D4
D4
D4
* D4
* E3
* E3
* E3
* E3
E3
E3
D4
* E3
* E3
R2036
R2037
R2038
R2039
R2040
R2041
R2042
R2043
R2044
R2045
R2046
R2047
R2048
R2049
R2050
R2051
R2052
R2053
R2054
R2101
R2102
R2201
R2202
R2203
R2204
R2205
R2206
R2207
R2208
R2209
R2210
R2211
R2212
R2213
R2214
R2215
R2216
R2217
R2218
R2219
R2220
R2221
R2222
R2223
R2224
R2225
R2226
R2227
R2228
R2229
R2230
R2231
R2232
R2233
R2234
R2235
R2236
R2237
R2238
R2239
R2240
R2241
R2242
R2243
R2244
R2245
R2246
R2247
R2248
R2249
R2250
R2251
R2252
R2253
R2254
R2255
R2256
R2257
R2258
R2259
R2260
R2261
R2301
R2302
R2303
R2304
R2305
R2306
R2307
R2308
R2309
R2310
R2311
R2312
R2313
R2314
R2315
R2316
R2317
R2318
R2319
R2320
R2321
D4
D4
D4
D4
D3
D3
* E3
D3
D3
* D3
D3
* D4
* E3
E3
E3
E3
E3
E3
E3
D3
* C2
E2
D1
E2
E2
* D2
* D2
* D2
E2
* D2
E2
* D2
* D2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* E2
* D2
D1
D1
* E2
* D2
* D1
D1
E2
* D2
* D2
E2
E2
D1
* F2
* F2
F3
F3
F3
F3
* F3
F3
F3
* F3
* F3
* F3
* F3
F3
F3
F3
* F3
* F3
* F3
F3
F3
R2322
R2323
R2324
R2325
R2326
R2327
R2328
R2329
R2330
R2331
R2332
R2333
R2334
R2335
R2336
R2337
R2338
R2339
R2340
R2341
R2342
R2343
R2344
R2345
R2346
R2347
R2348
R2349
R2350
R2351
R2352
R2353
R2354
R2355
R2356
R2357
R2358
R2359
R2360
R2361
R2362
R2363
R2364
R2365
R2366
R2367
R2368
R2369
R2370
R2371
R2372
R2373
R2374
R2375
R2376
R2377
R2378
R2379
R2380
R2381
R2382
R2401
R2402
R2403
R2404
R2405
R2406
R2407
R2408
R2409
R2410
R2411
R2412
R2413
R2414
R2415
R2416
R2417
R2418
R2419
R2420
R2421
R2422
R2423
R2424
R2425
R2427
R2428
R2429
R2430
R2433
R2434
R2435
R2436
R2437
R2438
R2439
R2501
R2502
R2503
R2504
R2505
R2510
* F3
F3
F3
F3
* F3
* F3
* F3
* F3
F3
F3
F3
F3
* F3
* F3
F3
* F3
F3
F3
* F3
* F3
* F3
F3
F3
F3
* F4
* F4
F4
* F3
* F3
* F4
* F4
* F4
F3
F3
* F3
F3
F3
F3
* F3
* F3
* F4
* F3
F3
F3
F3
F3
* F4
* F3
F3
* F3
F4
F4
F4
F4
F4
F4
* F3
* F3
* F3
F3
* F3
* E1
* E1
* E1
E1
E1
E2
E2
* E2
E1
E1
* F2
* F5
* E2
E2
* E2
* E2
* E2
* E2
* E2
F5
F5
F5
F5
F5
F5
* F5
* E1
F2
* F5
* E2
* E2
* E2
* E2
E2
* E2
E2
* F2
* F2
G2
G1
G1
G1
R2518
R2519
R2520
R2601
R2602
R2603
R2604
R2605
R2606
R2607
R2608
R2609
R2610
R2611
R2612
R2613
R2614
R2615
R2616
R2617
R2618
R2619
R2620
R2621
R2622
R2623
R2624
R2625
R2626
R2627
R2628
R2629
R2630
R2631
R2632
R2633
R2634
R2635
R2636
R2637
R2638
R2639
R2640
R2641
R2642
R2643
R2644
R2645
R2646
R2647
R2648
R2649
R2650
R2651
R2652
R2653
R2654
R2655
R2656
R2657
R2658
R2659
R2665
R2668
R2669
R2670
R2671
R2672
R2673
R2674
R2675
R2676
R2677
R2678
R2679
R2680
R2681
R2682
R2683
R2684
R2685
R2686
R2687
R2688
R2689
R2690
R2691
R2701
R2702
R2703
R2704
R2705
R2706
R2707
R2708
R2709
R2710
R2711
R2712
R2713
R2714
R2715
R2716
F1
F1
F1
* E4
E3
E3
E3
E3
E3
E3
E3
* E3
* E3
F3
F3
F3
F3
F3
F4
E4
E4
E4
E3
E3
E3
E3
E3
* E3
* E3
* E3
E3
E3
E3
E3
* A2
* A2
* A2
* A2
* A2
* A2
* A2
A2
* A3
* A3
* A3
E3
* E3
F2
E2
E2
E2
E2
E2
E2
E2
E2
E2
E2
* E3
* E3
* E3
* E3
F2
E2
E2
E2
F2
F2
E2
E2
* E3
* A3
E2
* E3
* E3
* E3
E4
A2
A2
A2
A2
A2
A2
* A2
* A2
* A2
* A3
* F5
* F4
* F5
* F4
* F5
* F4
F5
F4
F5
* G4
G5
G4
G5
G5
* F5
G4
R2717
R2718
R2719
R2720
R2721
R2722
R2723
R2724
R2725
R2726
R2727
R2728
R2729
R2730
R2731
R2732
R2733
R2734
R2735
R2736
R2737
R2738
R2739
R2740
R2741
R2742
R2743
R2744
R2745
R2746
R2747
R2748
R2749
R2750
R2751
R2752
R2753
R2754
R2755
R2756
R2757
R2758
R2759
R2760
R2761
R2762
R2763
R2764
R2765
R2766
R2767
R2768
R2769
R2770
R2771
R2772
R2773
R2774
R2775
R2776
R2777
R2778
R2779
R2780
R2781
R2782
R2783
R2784
R2785
R2787
R2788
R2789
R2791
R2793
R2794
R2795
R2796
R2797
R2798
R2799
R2801
R2802
R2803
R2804
R2805
R2806
R2807
R2808
R2809
R2810
R2811
R2812
R2813
R2814
R2815
R2816
R2817
R2818
R2819
R2820
R2821
R2822
R2823
F5
G5
F5
G5
G5
G5
G4
G4
G4
G5
G5
G5
G5
G4
G5
* G4
* F5
G5
G5
* G5
G4
G4
G4
* G5
F5
* G4
* G5
* G5
G5
F4
* G4
* G5
* G5
* G5
* G5
* G4
F5
* G5
* G5
* G5
F5
G4
* G4
* G4
* G4
F4
* F4
* G4
* G4
F5
* F5
* G5
* G5
* G5
* G5
* G4
* G4
* G4
* G4
* G4
* G4
* G5
* G5
* G5
* G4
* G5
* G4
* G4
* G5
* G5
* G5
* G5
* G4
* G5
* G4
G4
* F4
G5
G5
* G4
E1
E1
E1
E1
E1
E1
E1
E1
E1
F4
* F4
F4
* F4
F4
F4
F5
F5
F4
F4
F5
F4
F4
F5
R2824
R2825
R2826
R2827
R2828
R2829
R2830
R2831
R2832
R2833
R2834
R2835
R2836
R2837
R2838
R2839
R2840
R2841
R2842
R2843
R2844
R2845
R2846
R2847
R2848
R2849
R2850
R2851
R2852
R2853
R2854
R2855
R2856
R2857
R2858
R2859
R2860
R2861
R2862
R2863
R2864
R2865
R2866
R2867
R2868
R2869
R2870
R2871
R2872
R2873
R2874
R2875
R2876
R2877
R2878
R2879
R2880
R2881
R2882
R2883
R2884
R2885
R2886
R2887
R2888
R2889
R3401
R3402
R3403
R3404
R3406
R3407
R3408
R3409
R3410
R3412
R3413
R3414
R3415
R3416
R3417
R3418
R3419
R3420
R3421
R3422
R3423
R3424
R3425
R3429
R3430
R3431
R3432
R3433
R3434
R3435
R3436
R3437
R3438
R3439
R3440
R3441
R3443
10-10
F5
F4
F5
F5
F4
F4
F5
F5
F5
F4
F4
F5
F4
F4
F5
F5
F4
F5
F5
F4
F5
F5
F5
F4
F5
* F4
* F5
* F5
* F4
* F4
* F4
* F5
* F5
* F5
* F5
* F4
* F4
* F4
* F4
* F4
* F5
* F5
* F5
* F4
* F4
* F5
* F4
* F5
* F5
* F4
* F5
* F5
* F4
* F4
* F4
* F4
* F5
* F5
* F5
* F5
* F4
E1
* F4
* F5
* F5
* F4
D6
D6
D5
D6
D5
* D5
* D5
* D5
* D5
D5
D5
D5
* D5
D5
* D4
* D4
D5
D4
D4
D4
D4
* D4
* D4
D4
D4
D4
D4
D4
D4
D4
D4
D5
* D5
* D5
D4
D4
D6
DPR-300
R3451
R3452
R3453
R3454
R3455
R3456
R3457
R3459
R3460
R3461
R3470
R3471
R3472
R3473
R3501
R3502
R3503
R3504
R3505
R3506
R3507
R3508
R3509
R3510
R3512
R3513
R3514
R3515
R3516
R3517
R3518
R3519
R3520
R3521
R3522
R3523
R3524
R3525
R3529
R3530
R3531
R3532
R3533
R3534
R3535
R3536
R3537
R3538
R3539
R3540
R3541
R3543
R3550
R3551
R3552
R3553
R3554
R3555
R3556
R3557
R3559
R3560
R3561
R3570
R3571
R3572
R3573
R3574
R3601
R3602
R3603
R3604
R3605
R3606
R3607
R3608
R3609
R3610
R3611
R3612
R3613
R3614
R3615
R3616
R3618
R3619
R3620
R3621
R3622
R3623
R3624
R3625
R3626
R3627
R3630
R3631
R3632
R3633
R3634
R3635
R3639
R3640
R3641
D6
* D5
D5
* D4
* D4
D5
D5
* D5
* D5
* D5
D5
D5
* D5
D5
E6
E6
E5
E6
E5
E5
* E5
* E5
* E5
E5
E5
E5
E5
* E5
E5
E5
E5
* E5
E4
E4
E4
E4
* E4
* E4
E4
E4
E4
E4
E4
E4
E4
E4
E4
E4
E5
* E5
* E5
E6
E5
E6
* E5
E5
E4
E4
E5
E5
* E5
* E5
* E5
E5
E5
E5
* E5
* E5
D6
D6
D6
D6
D6
D6
D6
E6
E6
E5
E6
D5
* E5
* E5
* E5
E5
E5
E5
D5
* D5
D5
D5
D5
D5
* E5
* E5
E4
E4
E4
D4
* D4
* D4
E4
E4
E4
R3642
R3643
R3644
R3645
R3646
R3647
R3648
R3649
R3650
R3651
R3652
R3653
R3654
R3655
R3656
R3657
R3659
R3660
R3661
R3670
R3671
R3672
R3673
R3701
R3702
R3703
R3704
R3705
R3706
R3707
R3708
R3709
R3711
R3712
R3713
R3714
R3715
R3716
R3717
R3718
R3719
R3720
R3721
R3722
R3723
R3724
R3728
R3729
R3730
R3731
R3732
R3733
R3734
R3735
R3736
R3737
R3738
R3739
R3746
R3747
R3748
R3749
R3757
R3758
R3759
R3760
R3762
R3763
R3764
R3765
R3766
R3767
R3801
R3802
R3803
R3804
R3805
R3806
R3807
R3808
R3809
R3810
R3812
R3813
R3814
R3815
R3816
R3817
R3818
R3819
R3820
R3821
R3822
R3823
R3824
R3825
R3829
R3830
R3831
R3832
R3833
R3834
R3835
10-10
E4
E4
E4
D4
D4
* E5
* E5
* E5
E5
E6
E5
D5
D4
D4
D5
D5
* E5
* E5
* E5
E5
E5
E5
* E5
C6
C6
C6
C6
C6
* C5
* C5
* C5
* C5
C5
C5
C5
* C5
C5
C5
C5
C6
C4
C4
C4
C4
* C4
* C4
C4
C4
C4
C4
C4
C4
C4
C4
C5
* C5
* C5
C5
C5
C5
C5
C6
* C5
C6
C4
C4
C5
C5
C5
* C5
* C5
* C5
C6
C6
C6
C6
B6
B6
* C5
* C5
* C5
* C5
C5
C5
B5
* B5
B5
B5
B5
C5
C4
C4
C4
B4
* B4
* B4
C4
C4
C4
C4
C4
C4
B4
R3836
R3837
R3838
R3839
R3840
R3841
R3842
R3843
R3844
R3845
R3846
R3847
R3848
R3849
R3850
R3857
R3858
R3859
R3860
R3862
R3863
R3864
R3865
R3866
R3867
R3901
R3902
R3903
R3904
R3905
R3906
R3907
R3908
R3909
R3910
R3911
R3912
R3913
R3914
R3915
R3916
R3917
R3918
R3920
R3921
R3922
R3923
R3924
R3925
R3926
R3927
R3928
R3929
R3930
R3931
R3932
R3933
R3937
R3938
R3939
R3940
R3941
R3942
R3943
R3944
R3945
R3946
R3947
R3948
R3953
R3955
R3956
R3957
R3958
R3959
R3960
R3961
R3962
R3963
R3964
R3965
R3966
R3967
R4001
R4002
R4003
R4004
R4005
R4006
R4007
R4008
R4009
R4010
R4011
R4012
R4013
R4014
R4015
R4016
R4017
R4018
R4019
R4020
B4
C4
C4
C5
* C5
* C5
* B5
* B5
* B5
* B5
C5
C5
C5
C6
* B5
* C5
B6
B4
B4
B5
B5
C5
* C5
* C5
* C5
B6
B6
B6
B6
B6
B6
C6
B6
B6
D6
D6
D6
D6
C6
* D5
* D5
* D5
* D5
D5
D5
C5
* C5
C5
C5
C5
C6
D4
D4
D4
C4
* C4
* C4
D4
D4
D4
D4
D4
D4
C4
C4
D6
D5
D5
* D5
* D5
D5
D5
* D5
C6
C4
C4
D5
C5
C5
D5
* D5
* D5
* D5
B2
B2
B2
B2
* A2
* A2
A2
* A2
A2
A2
* B1
* C1
F2
G3
G3
G3
* C1
* C1
* C1
G3
R4021
R4022
R4023
R4024
R4025
R4026
* C1
* C1
* C1
* C1
* C1
F2
RB501
RB502
RB503
RB504
RB505
RB506
RB507
RB508
RB509
RB510
RB511
RB512
RB513
RB514
RB515
RB516
RB517
RB518
RB519
RB520
RB521
RB522
RB523
RB701
RB702
RB703
RB704
RB705
RB706
RB707
RB708
RB709
RB710
RB711
RB712
RB713
RB714
RB715
RB716
RB717
RB718
RB719
RB720
RB721
RB722
RB723
RB724
RB725
RB726
RB727
RB728
RB729
RB730
RB801
RB802
RB803
RB804
RB805
RB806
RB807
RB808
RB809
RB810
RB811
RB812
RB813
RB814
RB900
RB901
RB902
RB903
RB904
RB905
RB906
RB907
RB908
RB909
RB910
RB911
RB912
RB913
RB914
RB915
RB1101
RB1102
RB1103
RB1105
RB1106
RB1107
RB1108
RB1109
RB1110
RB1111
RB1112
RB1113
RB1114
* F3
* F3
G2
G2
G2
G2
* G2
* G2
* G2
* G2
* G2
* G2
* G2
* G2
* G1
* G1
* G1
* G1
* G2
* G2
* G1
* B3
* B3
A2
A2
A2
B2
* A2
* B2
* B2
B2
B2
B2
B2
B2
B2
* F2
* F1
G2
G2
A1
A1
B1
B1
B1
A1
A1
B1
B1
B1
B1
* A2
B1
A3
A2
A2
A2
A2
A2
A3
A3
* A3
* A3
A2
A2
A2
A2
* F2
* F2
G2
G2
C1
C1
C2
C2
C2
C2
C1
C1
C2
C2
C2
C2
B3
B3
B3
A3
A3
A3
A3
A3
A3
A3
A3
A3
A3
RB1115
RB1116
RB1117
RB1118
RB1119
RB1120
RB1121
RB1701
RB1702
RB1703
RB1704
RB1705
RB1706
RB1707
RB1708
RB1709
RB1710
RB1711
RB1712
RB1713
RB1714
RB1715
RB1716
RB1717
RB1718
RB1719
RB1720
RB1721
RB1722
RB1723
RB1724
RB1800
RB1801
RB1802
RB1803
RB1804
RB1805
RB1806
RB1807
RB1808
RB1809
RB1810
RB1811
RB1812
RB1813
RB2001
RB2002
RB2003
RB2004
RB2005
RB2006
RB2007
RB2008
RB2009
RB2010
RB2011
RB2012
RB2013
RB2014
RB2015
RB2016
RB2017
RB2018
RB2019
RB2020
RB2021
RB2022
RB2024
RB2025
RB2026
RB2027
RB2028
RB2029
RB2030
RB2031
RB2032
RB2033
RB2034
RB2101
RB2102
RB2103
RB2104
RB2105
RB2106
RB2107
RB2108
RB2109
RB2110
RB2111
RB2112
RB2113
RB2114
RB2115
RB2116
RB2117
RB2118
RB2119
RB2120
RB2121
RB2122
RB2123
RB2124
RB2125
B3
A4
A4
A4
A4
A4
A4
* C4
* C4
* C4
* C4
* C4
D3
D4
D3
* C3
* C4
* D3
* C4
* D4
* C4
* D4
* C4
C4
C4
C4
C4
C4
* C3
* C3
C4
B3
B3
B3
B4
B3
B3
B3
C3
C3
C3
C4
C3
C3
C3
D1
D1
D1
D1
E1
E1
D3
D3
E3
D3
D3
D3
E3
E3
E3
E3
E3
E3
E3
E3
E3
* D3
D3
D3
D3
* D3
D3
D4
* D4
D3
* D3
* D3
D3
D2
D3
D3
D2
D3
* D3
* D2
* D2
* D3
* D2
D3
D3
D2
D2
D3
D3
D2
D2
* D2
* D2
* D3
* D3
* D2
* D2
* D3
RB2126
RB2127
RB2128
RB2129
RB2130
RB2131
RB2132
RB2133
RB2134
RB2135
RB2136
RB2137
RB2138
RB2139
RB2140
RB2141
RB2142
RB2143
RB2144
RB2145
RB2146
RB2147
RB2148
RB2149
RB2150
RB2151
RB2152
RB2201
RB2202
RB2203
RB2204
RB2205
RB2301
RB2302
RB2303
RB2304
RB2305
RB2306
RB2307
RB2308
RB2309
RB2310
RB2311
RB2312
RB2401
RB2402
RB2403
RB2404
RB2405
RB2406
RB2407
RB2408
RB2409
RB2410
RB2411
RB2412
RB2413
RB2414
RB2415
RB2416
RB2417
RB2418
RB2419
RB2420
RB2421
RB2422
RB2423
RB2424
RB2425
RB2426
RB2427
RB2428
RB2501
RB2502
RB2503
RB2504
RB2506
RB2507
RB2508
RB2509
RB2510
RB2511
RB2512
RB2513
RB2601
RB2602
RB2603
RB2604
RB2605
RB2606
RB2607
RB2608
RB2609
RB2610
RB2611
RB2612
RB2613
RB2614
RB2615
RB2616
RB2617
RB2618
RB2619
* D3
* D2
* C2
* C2
* D2
* C2
C2
D2
D2
C2
D2
* C2
* C2
* D2
* D2
* C2
* C2
* D2
* D2
D2
D2
C2
C2
D2
D2
C2
C2
D1
D1
D2
D2
E2
F3
F3
F3
F3
F3
F4
F4
F3
F3
F3
F3
F4
F1
F1
F1
E1
E1
E1
E1
E1
E1
E2
E2
E2
E2
E2
E2
E1
E1
F1
E1
E1
E2
F2
* F1
* F2
* E2
* E1
E2
* E2
F2
F2
F2
F2
F2
F2
G2
G1
G1
F1
F1
F1
* E3
* E3
* E3
* E3
E3
E3
E3
E3
E3
E4
E4
E4
* E4
* E3
E3
E3
E3
E3
E3
RB2701
RB2702
RB2703
RB2704
RB2705
RB2706
RB2707
RB2708
RB2709
RB2801
RB2802
RB2803
RB2804
RB2805
RB2806
RB2807
RB2808
RB2809
RB3401
RB3501
RB3601
RB3701
RB3801
RB3901
F5
F5
F5
F4
F4
F4
F5
F5
F5
F4
F4
F4
F5
F5
F5
F5
F5
F5
D4
E4
D4
C4
B4
C4
RV201
RV1501
RV1502
RV1503
RV2601
RV2602
A5
F6
E6
E6
A2
A2
S2001
S2801
D3
E1
SL3
SL4
SL1101
SL1102
G1
A1
A4
A4
SWF1
SWF2
SWF3
SWF4
SWF5
SWF6
D5
E5
E5
C5
C5
D5
T201
T202
T203
T204
A6
A6
A6
A6
THP281
THP282
THP301
THP302
THP303
THP304
THP305
THP306
THP307
THP308
THP401
THP402
THP403
THP404
THP405
THP406
THP407
THP408
THP409
THP410
THP411
THP412
F4
* F4
G3
* G6
G6
G6
* F6
* F6
G6
* F6
* G3
* G4
* F2
* C3
* C3
D2
* B2
B2
* B2
* B2
* F2
C2
TP261
TP262
TP501
TP502
TP601
TP602
TP1100
TP1501
TP1502
TP1503
TP1505
TP1800
TP2001
TP2002
TP2003
TP2004
TP2200
TP2201
TP2701
TP2702
TP2703
TP2801
TP2802
TP2803
E2
A3
G3
G3
B2
B2
B4
F6
E6
E6
F6
B2
E4
E4
D3
E4
E2
E2
G5
G5
G4
F4
F5
F5
X201
X1101
X2301
X2302
F4
B4
* B4
F3
HSCU-300
L301
L302
L303
* B2
* B2
* A2
CL119
CL108
CL116CL117
CL118
C106 C109
C139
RB101
C111 C130
CL101
C166
C136
C125
C122
C123
CL111
CL110
CL109
CL115
CL105
CL104
RB108
C100
C103
C158
CL106CL102
RB103RB102
R104
C165
CN100
R105
R107
FB403
FB404
C414C415
C411C412C413
R309
R310 C347
C107
RB220
RB412
RB414
RB410
C311
C301
C302
R111R113
R110
R108
D103
C115 R205
R408
R409
R421
R415
R210
R209
CN103
CN102
RB413
C319C320C321C322C327
C307
RB211RB210
RB217 RB215 RB213
RB209 RB216 RB214 RB212
C114
IC100
C105
C340
C337
C306
R303
R302
C346
L303
C304C305
R115
RB122RB121CL112RB126RB125
RB407RB408
R417
R406
R207
R206
RB419RB418
IC102
C342
C345
C314 C332C334
C330C331
C315
C335
RB404
R416
R307
R306
R305
R119
C326C325C324C323
R208
A2
B1
* A2
B1
A1
B2
C170
C126
R420
D102
R107
IC101
IC201
IC301
IC401
IC402
IC403
C146
C132 C144
C418
RB402
RB406 RB401
* B2
* A2
A2
A2
* A1
* A1
* A1
* A1
* B2
CL100
R118
R120
RB403
RB405
FB101
FB301
FB304
FB305
FB401
FB402
FB403
FB404
FB405
A2
A2
A2
* A2
A2
* A2
A2
A2
B1
B1
B1
B1
B1
B1
B1
B1
B1
* A1
A1
* A1
* A1
A1
B1
* B1
* B1
* B1
B1
* A1
* B1
A1
R109
RB114RB113CL113RB118RB117
C107
RB109 RB110
C128
C148
IC101
* B1
* A2
RB201
RB202
RB203
RB204
RB205
RB206
RB207
RB208
RB209
RB210
RB211
RB212
RB213
RB214
RB215
RB216
RB217
RB218
RB219
RB220
RB221
RB222
RB301
RB401
RB402
RB403
RB404
RB405
RB406
RB407
R108
C151
C150
C149
C402
C403
D102
D103
B1
B1
A1
B1
A1
A1
B1
A1
* A1
B1
CL103
FB401
FB402
RB107
C104
RB106
A2
* A2
A2
* B1
* B1
R412
R413
R414
R415
R416
R417
R418
R419
R420
R421
CL114
CL101
CL102
CN101
CN102
CN103
A2
B2
B2
B2
* B1
* A2
A2
* A2
* A2
* A2
* A2
A2
A2
B1
B1
B1
* A1
A1
A1
* A2
* A2
* A2
* A2
B2
B2
B2
* A2
* A2
* A2
* A2
B2
B2
B2
B2
B2
A1
* A1
B1
B1
B1
A1
R106
ENC-112 -A SIDE-
ENC-112 -B SIDE-
SUFFIX: -11
SUFFIX: -11
---------------------ENC-112 (1-879-595-11)
---------------------*:B SIDE
R101
R102
R104
R105
R107
R108
R109
R110
R111
R112
R113
R114
R115
R205
R206
R207
R208
R209
R210
R301
R302
R303
R304
R305
R306
R307
R308
R309
R310
R311
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R411
R103C127
C171
FB100
FB101
SUFFIX: -11
* B1
* B1
* B2
* B2
* B2
* B1
* B2
* B1
* B1
* B2
* B2
* B1
C140 C102
R117
C156
SUFFIX: -11
CL201
CL202
CL301
CL302
CL303
CL304
CL305
CL306
CL307
CL308
CL309
CL310
R101
R112
C159
C155
C154
C162
C131
C129
C143
C142
C163
RB120RB119
C138
RB124RB123
C118
R100
C161
DY-23 -B SIDE-
* B1
* B1
* B1
* B1
* B1
* B1
* B1
* A2
* B1
* B1
* B1
* B1
* B1
* B1
* B2
* B1
* A2
* A2
* A1
* A1
* A1
* A1
* B1
* B1
* B1
* B1
* B1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* B2
* B2
R102
C167
C145C119
C115CL107
C124 C114
C120 C121
C117
C116
C105
C110 C113
C112 C108
C135 C141
C104 C101
C133 C147
C134 C137
R116
C153
DY-23 -A SIDE-
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
C344
C345
C346
C347
C401
C402
C403
C404
C405
C406
C407
C408
C409
C410
C411
C412
C413
C414
C415
C416
C417
C418
C419
C420
C160
C152
C164
C157
CL102
C420
R112
R114
RB203 RB205 RB207RB208
HSCU-300
D109
D108
D107
D106
D105
D104
D103
D102
D101
D100
RB204RB206
RB112RB111
R301
FB301C113
A2
A2
A2
A1
A1
A2
* A2
* A2
* A2
* B2
* A2
B1
B1
* A2
* A2
* B2
* B2
* B2
* A2
* B2
A2
* A2
* A2
* B1
* B1
* B1
* B1
* B1
* B1
* B1
* A1
* A1
* A1
* A1
* B1
* B1
* B1
* B1
* A1
* B1
* B1
R111
R121
IC301
-------------------DY-23 (1-879-648-11)
-------------------*:B SIDE
C101
C102
C103
C104
C105
C106
C107
C108
C109
C112
C113
C114
C115
C301
C302
C303
C304
C305
C306
C307
C308
C309
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
R114
R113
R110
C416
R311
R308
L301
C419 FB405
IC403
R304
C303
L302
R405
R404
R401
R402
R403
RB420RB421
RB417
R109
R104
R102
R101
C101
C102
C103
IC101
X301
CL309
CL301
CL302
CL308
CL305FB101
C410
C169
C168
RB116RB115
C417
R407
C309
C108
C109
R105
C112
CL303
C344
C308
RB218RB221
C341
C313
C343C318C317C316
C329
C312
C339C333
C328
C336
CN101
CL101
FB102
C405
RB409
R115
CL307
CL310
CL304
CL202
C338
CL306
CL201
RB301
RB415RB416
IC201
C404
C407C409
RB219
RB411
IC402
R419
R414
R411
C106 FB304
FB305
RB202 RB201
R413
R418
R410
R412
RB222
C401
C406
C408
IC401
DY-23, ENC-112
RB105
DY-23, ENC-112
RB408
RB409
RB410
RB411
RB412
RB413
RB414
RB415
RB416
RB417
RB418
RB419
RB420
RB421
A1
A1
* A1
A1
* A1
* A1
* A1
A1
A1
A2
B2
B2
* B2
* B2
X301
* A2
C100
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
C113
C114
C115
C116
C117
C118
C119
C120
C121
C122
C123
C124
C125
C126
C127
C128
C129
C130
C131
C132
C133
C134
C135
C136
C137
C138
C139
C140
10-11
10-11
* A1
* A1
* A1
* A1
* A1
* B2
* A1
* B1
* B2
* A1
* B1
* B1
* B1
* B2
* A2
* A2
* A2
* A2
* A2
* A2
* A2
* A2
* B2
* B2
* A2
* B2
* B2
* B2
A2
* B2
* B1
* B2
* B2
* A1
* A1
* A2
* B2
* B1
* B2
* A2
* A2
C141
C142
C143
C144
C145
C146
C147
C148
C149
C150
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
C169
C170
C171
* A2
* A2
* B2
* B1
* A2
* B1
* B1
A2
A1
A1
* A1
* A1
* A1
* B1
* B1
* B1
* A1
* A1
* B1
* A1
* B1
* B1
* A1
* A1
* B1
* B1
* A2
* A2
* A2
* B2
* B2
CL100
CL101
CL102
CL103
CL104
CL105
CL106
CL107
CL108
* B1
* B1
* B2
* A1
* B2
* B2
* B2
* A2
* A2
CL109
CL110
CL111
CL112
CL113
CL114
CL115
CL116
CL117
CL118
CL119
CN100
* A2
* A2
* B2
B1
A1
* B2
* B2
* B2
* B2
* A2
* A2
B2
D100
D101
D102
D103
D104
D105
D106
D107
D108
D109
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
* A1
FB100
FB101
FB102
* B2
* B2
A2
IC100
IC101
IC102
B2
A1
B1
R100
R101
R102
R103
R104
R105
R106
R107
B1
* B1
* A1
* B2
B2
A2
* B2
A2
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
* B2
* B2
A2
A2
* B2
A2
A2
B2
* A1
* B1
B2
B2
A2
B2
RB101
RB102
RB103
RB105
RB106
RB107
RB108
RB109
RB110
RB111
RB112
RB113
RB114
RB115
RB116
RB117
RB118
RB119
RB120
RB121
RB122
RB123
RB124
RB125
RB126
* B2
B2
B2
A1
A1
A1
* A2
A2
A2
A1
A1
A1
A1
A1
A1
A1
A1
B1
B1
B1
B1
B1
B1
B1
B1
FL-349, MB-1124
CN3
L3
C11
CN2
TP2
L21
FB11
L22
C21
C22
C3
CN1
CN2
CN3
CN4
CN5
FB4
---------------------MB-1124 (1-879-656-11)
---------------------*:B SIDE
L4
C4
B2
A1
A3
C5
TP1
TP2
TP3
C13
A1
A1
A2
A2
A3
A1
A2
A3
B1
B1
FB5
L1
L2
L3
L4
L5
L11
L13
L14
L21
L22
TP3
A1
A1
A2
A3
A1
A2
A3
FB14
FB2
FB3
FB4
FB5
FB11
FB13
FB14
FB13
B1
B1
A3
A3
L13
CN1
CN2
CN3
CN4
L14
L5
FB3
A1
A2
A2
A2
A2
B1
B1
TP1
C3
C4
C5
C11
C13
C21
C22
CN4
--------------------FL-349 (1-879-655-11)
--------------------*:B SIDE
FL-349, MB-1124
L11
L1
FB2
L2
CN1
FL-349 -A SIDE-
FL-349 -B SIDE-
SUFFIX: -11
SUFFIX: -11
CN1
CN2
CN3
CN4
B1
D1
B1
D1
* B2
MB-1124 -A SIDESUFFIX: -11
CN5
MB-1124 -B SIDESUFFIX: -11
10-12
10-12
HSCU-300
SDI-97B
SDI-97B
--------------------SDI-97B (1-879-657-11)
--------------------*:B SIDE
CN921
CL4
R12 R11 R10
R24R23C21
L151
C345
R371
CN10
CL361
IC341
R332
C310
IC302
CL321
C325
C322
L11
CL151
C1
R244
CL201
R204
R247
R224
R207
R241
R201
R261
C263R262
R221
R227
C262
R265
R266R267
R503
C523 C524
C503 C504
R523
R345
R364R341
R362
L301
R303
R302
R301
R323
R322
R352 L343
L152
R2
CL3
FL341
R501
R502
R509
IC501
R329
C323C324
R521
R522
R529
IC521
C224 CL261
R321
C347
C349
IC342
FL321
C204 CL221R233
C221
R223R225
CL362
IC321
C346C342
C348
R325
R112
R106
R213
C201
R203R205
R506
R320
C309
IC301
C304
C244
CL501
R313
C308R315
R307
CL241R253
C241
R243R245
R526
R312
C307R314
C10
R1
C361
CL521
FL301
CL2
R254C245
R252
R250
IC241
R110
R105
CL1
FL241
IC3
CL30
E1
R21
R26
R246
R214C205
R212
R210
IC201
IC221
R206
R226
R268
C264
C525
R234C225
R232
R230
FL201
FB1
SL1
C16
R25
FL221
IC261
R264
R263
R528
CN2
CN3
SDI-97B -A SIDE-
* A2
* B2
C156
R32 IC11
R33
R31
R29
Q2
R104
C104
R103
C15
C13
R162
R161
R163
R164
R167
R166
R5
R9
Q1
C155
R155
C150
C12
C14
C4
C154
D28
R152
C28
L2
C27
D1
C6
R3
C5
C242 R249
C202 R209
C222 R229
L261
C153
IC121
R151
R153
R159R158
R160R165
L522
L502
C2
THP1
C157
R30
R28
R242
C3
L242
R156
R154
C151
R248
R6
IC2
C8 C11
R202
L202
R8
IC1
R208
L1
R222
L222
L241
THP2
R228
L201
C243
C261
L221
C203
L521
C223
L501
R4
D2 C7
C23
C24
E2
C102
C9
R7
C106
L321
PH141
R108
IC102
IC141
R115
C113R127
FB103
R107
C112R130
R118 C110
L322
C107
R124
R132
IC101
R133
R125
R157
R169
R168
C101
C111R128
R117
C152
FB104
C108
R116
C114R129
C109
R126
R134
R131
R123
C105
SUFFIX: -11
L262
C103
* A2
* A1
B1
* B9
* B7
* B9
* B7
B1
B1
* B3
* B3
* B4
* B4
* B3
* B3
* B4
* A4
A7
A7
* B6
* B6
B5
B5
R524
C505
L1
L2
L11
L101
L102
L103
L104
L151
L152
L201
L202
L221
L222
L241
L242
L261
L262
L301
L302
L321
L322
L341
L343
R504
* B2
* A1
A1
* A1
* B9
* B7
* A1
* B1
B3
B4
B3
A4
B7
B7
B6
B5
A5
B5
B4
R508
IC1
IC2
IC3
IC11
IC101
IC102
IC121
IC141
IC201
IC221
IC241
IC261
IC301
IC302
IC321
IC341
IC342
IC501
IC521
CN1
C521
R525R527
C17
R354R355
R356
R353R348
A3
A4
A3
B8
B7
B6
R111R114
R328
C501
R505R507
R349
FL201
FL221
FL241
FL301
FL321
FL341
R330R331
R333
L341
A1
* B8
* B7
* B9
* B7
THP1
THP2
R363
R344
R361
FB1
FB101
FB102
FB103
FB104
A1
R316
R109R113
C341
C321
A5
* B6
SL1
R365R366
R367
R369
C326
E1
E2
B1
B1
* B2
* B2
* B1
* B1
* B2
* B2
* B1
A2
A2
A2
A2
A2
A2
A2
A2
A2
A2
* A1
* A1
* A1
* A1
* A1
* A1
* B9
* B7
B8
B7
* B9
* B7
B8
B8
B7
B7
B8
B7
* B9
* B7
* B8
* B7
* B9
* B7
* B9
* B7
* C9
* C9
* C7
* C7
* C9
* C9
* C7
* C7
* C9
* C8
* C7
* C7
* A1
* A1
* A1
* B1
* A1
* B1
* B1
* A1
* A1
* A1
* B1
* B1
* B1
* B1
* A1
* B1
* B1
* B1
* B1
A3
* A3
B3
B3
R318 R334
C306
C303
FB102
* A2
* B2
* A1
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
R31
R32
R33
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
R122
R123
R124
R125
R126
R127
R128
R129
R130
R131
R132
R133
R134
R151
R152
R153
R154
R155
R156
R157
R158
R159
R160
R161
R162
R163
R164
R165
R166
R167
R168
R169
R201
R202
R203
R204
* A2
* B2
A2
A5
A5
B5
B5
B5
B5
B5
A5
A5
A5
A5
B5
B4
B4
B5
B5
A4
A4
A4
A4
B4
R120
L102
L104
R122
D1
D2
D28
Q1
Q2
Q3
R367
R369
R371
R501
R502
R503
R504
R505
R506
R507
R508
R509
R521
R522
R523
R524
R525
R526
R527
R528
R529
R327R324R326
C9
C7
C6
B1
A3
* B1
B3
B3
B3
* B3
* B3
B3
B3
B3
B3
A4
* A4
B4
B3
B4
B4
B4
* B4
* B4
B4
B4
B4
B4
A3
* A3
B2
B2
B3
B3
B3
* B3
* B3
B3
B3
B3
B3
A4
A4
A4
A4
B4
B4
B4
B4
A7
A8
A8
B8
B8
B7
B7
B7
B7
B8
B8
B7
B7
B7
B7
B8
B8
B8
A6
A6
A6
B6
B6
B6
B6
B6
B6
B6
B6
B8
B7
B7
A5
A5
A5
B5
B5
B5
B5
B5
B5
B5
A5
B5
A5
A5
A5
A5
L302
CN1
CN2
CN3
CN10
CN921
PH141
R205
R206
R207
R208
R209
R210
R212
R213
R214
R221
R222
R223
R224
R225
R226
R227
R228
R229
R230
R232
R233
R234
R241
R242
R243
R244
R245
R246
R247
R248
R249
R250
R252
R253
R254
R261
R262
R263
R264
R265
R266
R267
R268
R301
R302
R303
R304
R305
R306
R307
R308
R309
R310
R311
R312
R313
R314
R315
R316
R318
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
R330
R331
R332
R333
R334
R341
R344
R345
R348
R349
R352
R353
R354
R355
R356
R361
R362
R363
R364
R365
R366
R310R304
A2
A2
B2
A2
A1
B1
B3
B3
B2
B4
B6
B5
A5
A5
A4
* B5
* B5
* B4
* B4
C305
C302R308R306 C301
CL1
CL2
CL3
CL4
CL30
CL151
CL201
CL221
CL241
CL261
CL321
CL361
CL362
CL501
CL521
L501
L502
L521
L522
R311R305
B5
A4
B4
B4
B4
R309
HSCU-300
C505
C521
C523
C524
C525
FB101
B2
* A2
* B2
* A2
* B2
* A2
* B2
* B1
* B2
B1
* B1
* A2
* B2
* A2
* B2
A1
A1
A2
* A1
* B1
* A1
* A1
* A1
* B8
* B7
* B9
* B7
* B8
* B7
* B8
* B7
* B9
* B7
* C9
* C7
* C9
* C7
* A1
* B1
* B1
* B1
* A1
* A1
* B1
* B1
B3
* B3
* B3
B3
B3
B4
* B4
* B4
B4
B4
B3
* B3
* B3
B3
B3
* B4
B4
A4
B4
B7
B7
B7
B7
B7
B7
B7
B7
B8
B8
B6
B6
B6
B6
B6
B6
B5
B5
B5
B5
B5
B5
B5
A5
A5
B5
B5
R119
L101
L103
R121
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C21
C23
C24
C27
C28
C29
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
C113
C114
C150
C151
C152
C153
C154
C155
C156
C157
C201
C202
C203
C204
C205
C221
C222
C223
C224
C225
C241
C242
C243
C244
C245
C261
C262
C263
C264
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C321
C322
C323
C324
C325
C326
C341
C342
C345
C346
C347
C348
C349
C361
C501
C503
C504
Q3
R27
R22
C29
SDI-97B -B SIDESUFFIX: -11
10-13
10-13
JC733
Q743JC734
R772
JC730JC731JC732
R761R763R765
R760
R778 R762
R780
R779 R764
CL533
CL531
C1601
THP962
C1599
R143
T731
R618
R605
R723
C755
PH732
S735
S732
C82
R89
C167C178
R615
PH731
S734
S731
R87
T730
C756
C915
C917
PH730
S733
S730
R172
R171
R602
R728
R608
C57
C56
R160
R227
R84
R90
R80
R86
C304
R1137
C1590
C87
C86
C12
C28
C72
L6
Q403
R444 R430
R445
R432
R433
R446
R447
R434
R435
L12
C1555
C1589
L1507
C1563
R98R100
C73
D2
C128
R161
C117 C115R178
R174R176
L24
C170R85
C99
C94
IC11 IC14
R603
R601
L22
R152R159
R979
R978
IC854
R753
R756
IC8
C914 R974
R752
R755
R91
R93
R138
C89
IC31
C598
R607
C593
C59
C78
R126
C93
R107
CL402
CL404
R514
CL403
CL405
R515
IC542
R614
E1500
R604
IC408
IC409
R470
R471
C597
R621
C626
R662
CL530
C168
C927
R680
RB833 RB834
L1505
R120R119
R31
R28
C100
C2
IC42
R658
R724
R332
THP955
L1513
C1603 THP969
THP960 C1564
L1503
C1591
IC18 IC20
R173
R170
IC25 IC13
C77
R139
R137
IC15
R1
R50
R46
R622
R638
R725
R619
R657
R368
R358
C350
C356
R353
R720
Q9
R187
C404
C591
C589
C1571
THP958
L1510
C1598
Q10
C1580
R231
R236
R191 C158
C141
C16
C31
C442
L32
L1506
L1512
C48
L5
R206
R200
R207
R201
C18
R63
C583C584
R597R598
C440
THP968
C585C586
R595R596
C1608
THP956
L1504
C1570
L1508
C1597
R209
C312
R203
R218
C366
C367
C313
R321
C315
CL301
IC303
C369
C371
R385
C370
C343
C536
C577C576
R569R563
IC531 IC536
IC406
R421
C578C575
R570R566
IC532 IC537
C538
R391
R204
R77
C157
R240
C5
C49
R70
R13 R10
R17 C9
R23
R21
R22
C6
RB1
Q308
R333R334
C330
C368
IC300
C314
C325
C327
C323 RB300
C537
C547
C548
IC849
IC848
IC847
C823
C816
C533
C824
R307
C403
TP801
C550 RB530
R811R810
C811C809
THP965
C1605
C165
C107
R448
R449
IC10
X802
C124
R751
R59
IC35
C95
Q1506
Q820 Q821
C61
R123
C176
IC1
IC3
CL1507
C177 C171
R754
R79
CL532 S531
S530
C407
C98
IC49
C91
C408
C175
R679
C76
E1503
FB3
CL1508
R145
L21
C412
C458
C459
R422
R413 R419
R414 R420
R336
R646
R410
R616R610
CL304
IC308
CL305
CN1
R985 R989
R984 R988
L300
R661
R659
C166
C450C449 C452C451
R493R492 R495R494
IC36
C140
C129 C123
R147
C90
R186
R473
R183
R184R181
IC22
IC405
R590
R636
R428
R1066
TP6
CL303
R383
R208
R210
R436C439 R437C441
C565
R581R585
R582R586
R549R550
R552
C566
R548
R551
R472
R217R225
R815
TP802
D839
R1131
R1132
R1133
RB837
IC875
RB830
CL1502
R1198
R1195
R1053
C972
R1070
R1059
IC873
C986
D1501
RB844
C1539
C1541
C1550
C1558
THP964
R1516
R1530
C1501
IC902
R1252
R1181
C1029 R1177
R1182
R1178
C1031
R1185
R1192
R1194 R1262
R900
R898
R899
R801
RB852RB851
R903
R902
R901
R1213
R1214R1208
R1108
C808
R803
L802
R1169
C978
C1066
C1065
R1209
R1110 R1069
R1014
R1010
R1005
R1097
D1511
R1607
R1609
C1625
C1627
C1631
CL1513
CN102
CL1503
D1509
IC807
C833
C1518
R1507
C1503
R1517
R1546
R1547
C977
C1071 C1073
C1070
IC901
R1157
R1151
C1084 R1150
R1153
R1152
R1159
C1003
R1166
R1168 R1257
C836
C984
C982 L831
X803
C1613
R1613
FB1512
FB1513
TP901
C1536
THP953
C1611
R885
R892
R818
R819
C807
C853
C850
R918
R919
C837
IC1502
IC861
R1364
R1363
RB934RB933
R1302
R1303
R1361
R1360
RB932RB931
R1314
R1315
R1316
CL925
Q810
Q1505
CL300
CL401
C417
TP530
R531
C568
TP531
R530
C567
C818
R824
C830
CL400
C302
R315R316
C301
C564
C563
C151
R33
CL1511
C357C362
R351R357D300
C346
C827
R831
R532
C1526
C1508
R1523
CL1514
R237 R242
R243
R219
R220
R221
IC1510 IC1511
R361C336
R302
C36
R359
TP1
R355
C328
R304
R1511
C1504
R1204 R1202
Q908
IC5
C324
IC400
C322
C1088
C1037
R1525
Q909
R64
Q314Q313Q305
RB400
C990
R1130
IC880
IC879
R371
R373
C364C363
RB853 RB848
C989
RB843
C973
R1096
R1196
CL1504
Q910
L823
R1172
R1170
CL900
C1067
CL1501
R1239
R1633
R1632
R1082
C806
X801
C947
R1057RB842
C995
R1634
R1635
R1568
R859
R830
R1612
C855
C1041
R1548 R1606
C1614
C1549
L830
IC830
IC831
C902
R880
R878
R881
R882
IC819
L814
R1334
R1337
R1336
R1335
R1323
R1327
R1326
R1325
R1300
R1301
R1305
RB902
C1139
C1525
C1515
FB1501
C1013
C854 CL802
C1058
IC871
C985
R1112
C829
IC811
R1362
R1331
R1359
R1358
R941
R940
R939
R938
R937
R933
IC883
C895
C894
R930 C893
C1125
R1138
R1143
R1084
C1147C1149C1151
C1163R1357
R1356
C885
THP801
IC814
IC812
L812
IC853
C1153C1155 C1159
C1165C1167
R1344
IC900
R1343
RB922RB921
RB920RB919
R954
IC852
C869
IC917
IC916
IC915
IC912
IC911
IC910
R971
C1087
C1009
C997C996 C840
C867
CL905
CN803
R843C831
IC876
R895
R833
R834
L810
C851
IC801
CL803
R876
R875
R917
C543
C812
R812
C339 C354
R337
R340R342
C341C338
SORI01
C817 R837
R823
C355
R617
IC541
R352
IC307
C333
C340C337
R339R341 R356
C349
R366
C332
R660
C596
R719
R635
C607
C621
C595
C815
IC857
R1002
R1001R1007 C957
THP963
CN2
R609R611R673
C1606
R637
C463
C462
L805
C592
IC545
R816
R1120
R533
R1056
R1119
RV530
RB835
IC838
C557
R554
R547
L803
R580R584
R579R583
IC874
L813
R1077
R1068
R1063
R559
R560
IC833
CN101
C873
C910
C905
C886
RB928RB927
RB926RB925
RB916RB915
RB914RB913
RB821RB822
RB819RB820
R969
R968
C911
C974
C880
RV531
IC804
R1061
R1076
R1058
C530
R908
R893
R827
L801
R802
C962
C879
R1023
R1006
R1004
L811
R896
L807
R813
C828
C558
R555
R644 IC543
R640
R721
R620 R625
R674
IC540
IC546
R561
R562
C579R567
C559 R572C569C588
C594
C532
R606
C400
R504
R505
R491
R490
R624
C627
R573C572
C580R568
C434
R451
C531
C890
C832
R839
R832
R835
C801
IC862
IC816
R807
R844
CN804
IC800
C881
IC817
C1170
R905
R906
R907
R836
C539
C608
IC40
R645 IC544
R726
R623 R626
C453
C587 C590
C454
IC530
IC410
C999 C834
R913R921
CN806
IC808
Q804
S801
R869
R866
R923
R915
C877
C887
R873
SORI02
RB847
C416
C998
L808
R1099
R877
RB806RB805RB807
C975
IC845
C560
C413
R852
C552
C428
R511
R479R485
R478R484
IC401 IC402
R416C410
Q404
C414 R431
C426
R474
R475
R468C445 R469C446
R502
R503
R489
R488
R510
R477
R476
C444C448 C443C447
R481R487
R480R486
R409
IC411
C316
R429
C422
C421
C424
C423
R439
R438
C418R426
R424
C420
R425
C419R427
R125
C329
IC309
C411
C401
C402
R838
C802
C803
C300
IC302
C425
C433
R450
IC407 C427
C415
C46
C44
L822
TP803
R412 R418
R411 R417
R423
R415C409
C58
C43
R384
R124
R406
C365
R379R380
R374
R370
CL852
IC306
RB850
R338C351C359
R363
C373C374
R1017
C39
C37
C1600
L1511
L14
C361
C54
R1012
R1126
R1098
R1088
R1087
R1074
R1073
R1072
R1071
R1085
R1086
R1083
R1093 D838D837
R1092
R1080
R1081
R1090
R1089
IC806
R1122
R1123
R1124
R1125
R829
R961
R963
C814
C903
C937
C892
C859
C1076
C849
C1062 C1063
C1064
C1068
R822
C952
C983
R1117
R1115
R1109
R1111
C139
R108
IC301
R1095
R1142
R1141
D4
IC37
IC32
R212
C81
C754
IC730
C79
RV1
C68
C70
C88
IC38
C308
C310
R1075
R821
C858 C862
C863
R1215
R350
C345
R343
L16
C26
L15
L4
C15
IC39
C907
IC877
C303
C360
C17
C1
C306
IC9
R322
C326
R320C307
C331
C51
R88
Q738Q737Q736
R121
R148 C106
R136
R140
R118
C172
R328
IC33
IC305
C71
C335
R335
C334
C906
C852
C1534
R891
IC903
C904
C1074 C1075
R960
R957
R956
R959
CL908
R1193 CL909
CL913
CL912
E1501
C97
R149
C52
IC7
IC2
R96
R92
IC34
R360
C352C348
R362
R364R319
IC304
C92
C103
C104
C105
R32
R44
R61
R346
R347
R345C347 R331
C29
C32
X1
IC16
CL302
R300
R306
IC12
C30
R29
C23
TP4
R95
R94
R2
IC48 IC27
R745
C745
C752
D754D755
10-14
R65
C47
Q303
C135 L31
L9
R122
C173
R742
C744
C751
TP5
R130
R1207
R1205
C134 L30
R57
R74
IC6 IC4
R75 C53 R73
C75
C67
R106
IC19
C108
C109
C169
C174
C66
R739
L29
IC17
R157
R158
R146
C55
C358
X2
R1206
R1203
X3
C1083
R1211
R1254
R1210
C1001
C34
R958
R962
CL906 CL907
CL904
R1167 CL901
C1060R1212
R1255
R194R211
D9
C80
C1072
IC43 IC21
IC23
IC51 IC50
R193
IC41
C1043
C1045
R214
C159
R215
C160
Q6
C63
R101
R102
R103
R97
IC44
L17
C132
C120C114
R216
C163
R188
R185
C131
C130
R1246
R1245
R1244
R1243
R1242
R1241
L10
CL910
CL911
R1201
TP902 R1265
R190
R180 R192
R182
R189
C133
C60
C62
L18
R228
IC47
C148
IC46
C146
C164
CL1510
L11
IC26
C156
TP7
R34
R245 R246
X901
IC28
C8
R1263C1042
R1267
C1034
R1199
R1266
R1200
R1188
R1191
R1197
R1180
R1183
C1079 R1251
R1179
R1176
R12
C1046 C1033
CL902
CL903
C913
R1162
R1256
R1171
C1145
FB929
FB909
C1015
C1017
R1175
R1260
R1624
X900
R1636
R1173
R1261
R1174
C1509
C1506
C1505
C1018 C1005
C1157
RB900RB901 RB912RB910RB911
C909
C871
C865
R929
C1124
IC824
IC823
IC822
IC881
R1309
R1308
R1304
R1307
R1306
R1352
R1321
CL921
CL922
CL923
CL924
R1349
IC921
C1530
FB902
C1126
C1161
C1532
R1258C1014
R1165
C1006
R1513
IC1514
C1035
C1568
THP959
C743
C750
R983
10-14
IC1503
R1154
R1155
C1085 R1248
R1247
R1156
C1569
C1588
R972
C920
C921
R1329
C1142
RB903
C1007
C14
R11
CL1509
L1509
C1581
C1573
THP961
C1594
C1617
C1616
C1615
IC1505
IC1506
CL1505
R1608
C1511
THP957
C1552
C1559
L1500
R1508
C145
C1574
R1140
R986 R980
R987 R982
R775
IC24
C1553
C1560
C1637
R1631
Q1512
R1534
C1513
R1518
R1504
R1627
R1623
C1636 IC1501
R1540
R1541
C1520
THP950
R1616
R1617
C1620
Q1513
Q1509
R1615
C1618
R1610
R1605
R1628
C1638 IC1513
L1502
R239
R238
C152
CL1506
R1602
IC1504
L1516
C1537
IC29
C155
C153
C1510
R1322
R1342
FB924
FB926
C1533
C1105
CL1500
R1510
R1509
C1623
R1065
C1531
C1106
FB1500
C1107
Q813Q811Q817Q815
R1136
R1055
JC736
R1134
JC735
JC738 C994 R1135
JC737 R1139 C991
Q814Q812Q818Q816Q819
L821
R981 C916
C1538
RB840
C1602
R973
C918
C919
C1103
THP954
RB841
R1054
C1624
E1502
C1113
THP952
L1501
C988
C1114
THP951
R928
C1115
C1514 C1524
RB857
L820
R942
RB859RB858
C1143
CN802
C993
C1112
R1050
R1051
R1052
R932
CN805
RB856RB855
C891
SY-364
SY-364
CL801
BT801
C875
D808
CN801
C976
C822
THP966
C1604
SY-364 -A SIDESUFFIX: -11

HSCU-300
R663
R685
R682
R676
L532
Q533
R664
R633
R634
C605
Q536
R675
R681
C613
C617
R641
C604 Q535
R698
R404
C616
C620
R401
L23
C739
R132
R142
R144
C102
R60
R67R66
R68
R71
R732
C735
D735
D732
C749
R311Q304Q306Q307
R717
Q550
Q531
D5
R702
R78
R150
C748
R731
C733
C747
R730
C762
C760 C761
C759
R777
R776
Q742 Q741
Q740 Q739
C758 R767
C757 R766
C924
C923
C922
R716
Q407
R72 C45
C84
R643
D734
D731
R975R976
R768
L301
C353
R705
C731
R16
Q309
R393
R387R349
C342C344
R41
R49
R55
R111
R127
R114
R666
R668
R134
R665
C609
D7
R1580
C1587
R1576
C1582
R104
R105
C611
C1575
C633
R707
C570 R576R571
R612R577
Q544
Q540
Q545
Q542
R642
R166
L20
R154
IC45
C110
C69
C74
C119
C1556
C1579D1506
R1567
C1583
R1582
RB836 RB839
D820D824D821D828D827
C1561
C430
C573 R578R574
R613R575
R168R167
C121
C637
D531
R556
C574
D530
R553
C571
C432
R213
R199
R205
C142
R196R195R197
R45
C1593
R1564
C1576
C1592
R1579R1577
C1565
C1557
R1562
R1560
C1566
R323
R354
D833
C305
C372
FB4
FB5
IC1509
D834
THP967
R47
R39
R542
R324
C309
C311
R330
C535
C534
Q312
R814
C810
R809
C35
R53
Q3
C22
R1594R1597
R1621
C1634
R1588
R1573
R1591
C1639
R230
D835
D836
IC1515
R1638
C964
C800
C900
C963
C899
C898
C897
C896
L2
C4
L7
R3
RB838
C943
C936
RB824 RB825
C1053
C932
C946
C942
R1024
R1016
R1114
C941
C1054
C1051
C1519
D1502
FB1502
R1013
R1011
R1015
IC905
C1056
C1567
C1572
C1551
C1554
C839
C838
C1025
L904
R1217
R1218
R1107
R1106
R1105
C980 R1101
R1104
C813
C825
C1026
C1023
C856
FB1549
FB1548
FB1518
FB1519
FB1516
FB1517
R1533
C1516R1528
C1632
C1633
C1535
C1544
C1547
FB1515
FB1514
C1619
D1512
FB1530
R1328
C821
C820 C805
C819
C883
R897
R904
RB800
R886
R1532
R884
R883
R862
C844 C843
IC842 IC841
C864
C951
C1146
R1366 C1169
R1312
R1313
R1311
R1310
R943
R1008
R916
R909
IC858
R1003C929
IC834
C889
R372
R692
R687
IC821
C870
L531
Q539
Q408 R403
R497
R483
R496
R482
R769
L731
R771 D753
C746
R99
R632
R631
R247
R179
C435
R112
R76
R462
C437
C64
R317
R703
R463
R461
L27
R735
Q732
R747 C738
R746 R750
R734
Q731
R744 C737
R743 R749
R733
Q730
R741 C736
R740 R748
D733
D730
R42
C19
R20
R19 R5
IC859
IC813
R967
IC815
R964
R965
C1130
C1127
R1338
C1111
FB923
C1109
C1108
C1110FB922
R966
R953
C874
R389
C1595
R688
R693
R695
C631
C630
R465
R690
R694
R696
IC538
IC539
C27
C455
C635
C634
R464
IC403
IC404
R18
R691
R689
R226
R165
R162
R14
R15
C13
C85
R129R128
R1575
RB301
R667
R110
D1503
L34
C949 C960
C940 C958
R557
C561
C551
R540C545
R534 R591 C555
C581 R546
L33
R1585
C1052
R558
C562
C549
R541C546
R535 R593 C553
C582 R545
RB831
Q315
Q316R301
R303
R308
FB1528
FB1529
R977
RB832
D1504
Q4
R36
R52
C154
R1558
L3
IC30
C21
R1186
C405R408
C406
L40
C1640
C1048
R1189
R1190
C1028
C40
L1
R234R235
C150
R1639
C1641
R1542
Q1501
R62
R8
C1044
R1184
R1250
R1637
R1625
C1152
R1345
D801
C1135
FB927
FB925
C1136
C1158
C1160
C845
R870
R867
R847
R840
R920
C954
C955
C953
C956
C1078
IC904
R1103
Q1510
C1000
FB1543
FB1542
FB1541
FB1540
FB1547
FB1546
FB1545
FB1544
R1094 C935 C959

C945 C961
R1062
R1064
R1067
C971
C970
C969
C968
C967
C966
C965
IC837 R889
R860 RB810RB811RB809RB808
C1020
R1163
R1164
R1586
R1570
C1069
R1160
IC810
R1240
C1016
R1249
R1158
C835
R853
IC826
R863
IC843
IC825
R820
R1220
R1219R1221
R1223
R1225
L911
R1234
R1236
R1549
R1551
R1618
Q1511
R1502
R1503
Q1500
FB1504
FB1506
FB1508
FB1510
R1543
R1529
C1024
FB1532
FB1534
FB1536
FB1538
C1635
FB1523
FB1522
FB1521
FB1520
FB1527
FB1526
FB1525
FB1524
C1507 C1517
C1502
C950
C868
IC851
IC856IC855
C1138
IC835
R808
R1545
D832D830D826D823D831D829D825D822
L732
R770 D752
10-15
IC1508
R1553
R1538
D741
C742
D749 D746
R774
C1542
R1574
C1628
R759
C734
Q735 D748 D747
C1546
D740
C741
D745
L733
IC1507
R1552
R1559
R1561
R1563
R758
C732
Q734 D743
R1554
D739
C740
D744
C1562
R1556
R757
C730
Q733 D742
L36
R1640
D1508
C1540
R1584
IC1512
C1586
R1557
L730
D738
R738
R1581Q1507C1610
R1601
R1604
L35
L37
IC1500
R1555
D737
R737
C149
C147
D736
R736
C1577
R1565
R1566
D1505C1578
Q1503
C1584
R1578
C1585
R141
L19
C111
C112
FB1
R1583
C1596
R1590
R1592
C122
Q1504
R1572
L38
R224
R223
R222
C1543
C1089
FB915
FB1505
FB1507
FB1509
FB1511
C1630
E1505
C1626
R1600
FB1533
FB1535
FB1537
FB1539
C1629
C1030
R1539
FB1531
C3
C1523
IC922 C1168
R936
IC832
R1526
C1529
C1527
R1550
FB1503
C1040 C1036
D1507
R175
R1340
R1350
L809
RB905RB904RB908RB907RB906RB909
R1365
C1548
C1521
C1522
L26
R169
C118
R131 C96
R135 Q8
C113
C116
R177
C11 C10 C7
R9
R1589
R1595
R1593
R1598R1622
Q1508
R1599
C143
C144
R25
R24
D1513
C1528
C1621
C1622
C1057
C1118
C1120
C1122
R1353
R1355
R1332
R1333
R1527
C1012 C1008
R4
C24
R37
C1141
R1330
R1531
R1524
C1039
L8
C161
C162
R116
R117
C101
R133
Q532
10-15
C1002
R1614
R1611
C1086
FB914
C1133
C1132
C1137
C1011
R1346
R58
C25
L28
C126
D6
FB907
C138
IC918 IC919
C826
C872
C866
RB826
R1324
C1140C1131
R1187
C1032
FB908
C1038
FB910
C127
FB2
C125
R115
D1
R164 R163
D8
R151
R156
R155
C1047
C1049
C1129
C1117
L921
C1123
C1121
C1119
FB903
FB900
R198
R202D10
Q7
R1161
C1004
FB901
C1010
L39
C136
C137
R327
R51
R329 C319
R325C317
L13
C41 C38
R56
R344
C1019
C1021
C1134
FB911
C42
R1320
R1319
R1317
R1318
R1341
R1339
FB904
FB912
R1264
C1055
FB913 C1050
R109
R153
R69
C83
L25
C179
D3
C65
R1259
C1027
FB906 C1022FB905
R1253
L905 C1081 C1082
C20
R83 R81
R82
Q5
C50
R7
R6
L910
C1150C1148 C1144
IC870
R1227
R1228
C1156C1154
C1077
C1080
R513
C456
R27
R35
R26
Q2 R30 Q1
R48
R43
IC920
FB928
C981
L908
C321
C1164C1166
C979
R1102R1100
L909
E1504
R970
R40
R54
C33
Q405
R318
R400
R402Q400Q401Q402
L533
Q406
R955
C912
R386
C436
R460
C948
C928
Q311
R407
R1079
C438
C931
C939
R1009
R512
C908
C901
R952
R849
R1118 R1113
R677
R683
C615
C619
R405
C861
R701
R851
C1162
C876
R1354
R850
IC846
D802
C878
C1128
R825
R951
C841
R864
R868
RB818
C804
RB849
R458
R455
R453R459R467
C431
R443R442
R686
R684
R678
C606 Q537
R456
R454
C602
R671
R452R457R466
C429
C629
R441R440
R727
R708
R697
R706
Q549
R655
R712
R711
R672
R656
Q543
Q530
L530
C614
C618
R629
R630
C612
C930
C944
C541
R718 R537
C842
R865
C857
R879
IC809 C847
IC844
R857
R600
R704Q548Q547Q546
R628
R627
R714
R326
C318
C320
R543
C554
IC802
C540
R715 R536
R588R592
R722
R670
C603
C601
R700
Q538
R709 R639R699
R710
R669
R594
Q541
Q317
R348
R388R392
R310
Q534
C628
R565
R599
C610
R587R589
Q318
R390
R817
IC840 Q801
R871
R872
IC828
R861
C848
R539
C544
C542
R538
R544
C556
C860
IC820
RB817RB816
R805
R804
R564
R713
C882
IC818
R806
R826
C846
C884
IC839
C933
C934
C938
R926
R927
C1116
L920
IC805
C888
D807
R314
R312
R1020
R381
R382
R369
HSCU-300
R1021
IC860
R924
R910 R922
Q803 Q805
Q310
Q802
R912
R911
R914 IC836
R841 R848
R842
R846
L922
SY-364
SY-364
R935
R934
R1506
R1505
R1515
R1514
R1520
R1519
R1522
C1512
R1630
R1060
C753
R773
C926
C925
SY-364 -B SIDE-
SUFFIX: -11
SY-364
SY-364
--------------------SY-364 (1-879-650-11)
--------------------*:B SIDE
BT801
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21
C22
C23
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C35
C36
C37
C38
C39
C40
C41
C42
C43
C44
C45
C46
C47
C48
C49
C50
C51
C52
C53
C54
C55
C56
C57
C58
C59
C60
C61
C62
C63
C64
C65
C66
C67
C68
C69
C70
C71
C72
C73
C74
C75
C76
C77
C78
C79
C80
C81
C82
C83
C84
C85
C86
C87
C88
C89
B9
F2
F3
* H4
* H4
H4
H4
* H4
H4
H4
* H4
* H4
F2
* F2
H4
F3
F3
F3
F3
* F2
* F2
* H4
* H4
G2
* H4
* H4
F2
* F3
F2
F2
F3
F3
F2
* E2
G4
* G4
G4
E2
* G4
E2
* G4
* G4
* G4
E1
E1
* E1
E1
G4
G3
G4
* F1
F2
F2
G4
F1
G4
F2
F2
E2
F2
H2
H2
H2
H2
* F2
* F1
H2
G2
F1
* F3
F1
F3
G2
G2
* F3
G2
F3
F3
F1
F1
G2
F1
F1
* F1
* F1
* G2
G2
G2
F1
F1
C90
C91
C92
C93
C94
C95
C96
C97
C98
C99
C100
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C111
C112
C113
C114
C115
C116
C117
C118
C119
C120
C121
C122
C123
C124
C125
C126
C127
C128
C129
C130
C131
C132
C133
C134
C135
C136
C137
C138
C139
C140
C141
C142
C143
C144
C145
C146
C147
C148
C149
C150
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
C169
C170
C171
C172
C173
C174
C175
C176
C177
C178
C179
C300
F3
G2
G1
F1
F1
H3
* H3
F3
H3
G1
H3
* G1
* G1
G1
G1
G1
F3
G2
G3
G3
* G3
* G2
* G2
* H3
G3
G2
* H3
G2
* H3
* H3
H3
* H3
* H3
H3
G2
* G3
* G3
* G3
G2
H3
H3
H3
G3
G3
G3
G3
* G4
* G4
* G3
E3
E3
G3
* G3
* H3
* H3
J4
H4
* J4
H4
* J4
* J4
K4
J4
J4
* H4
J4
H4
K4
G3
G4
G4
* H4
* H4
G4
G4
G2
F3
G1
G2
G3
F1
F2
F2
G2
G2
F2
F2
F2
F1
* F2
E4
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C311
C312
C313
C314
C315
C316
C317
C318
C319
C320
C321
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
C344
C345
C346
C347
C348
C349
C350
C351
C352
C353
C354
C355
C356
C357
C358
C359
C360
C361
C362
C363
C364
C365
C366
C367
C368
C369
C370
C371
C372
C373
C374
C400
C401
C402
C403
C404
C405
C406
C407
C408
C409
C410
C411
C412
C413
C414
C415
C416
E4
E4
F4
A2
* E4
F4
F4
F4
* D4
F4
* D4
F4
F4
D4
F4
D4
* F4
* D4
* F4
* D4
* F4
D4
D4
F4
D4
F4
D4
F4
D4
F4
F4
B3
B2
F4
F4
E4
B2
B3
B3
B2
B3
* B2
E4
* B3
E4
F4
F4
F4
B2
B3
E4
F4
* B2
B3
A2
A3
F4
F4
E4
E4
E4
F4
E5
E5
E5
F4
F4
E4
E4
E4
E4
* E4
E4
E4
D1
D4
D4
D4
D3
* D4
* D4
E2
D3
E2
D2
D4
E3
D2
D2
D2
D4
C417
C418
C419
C420
C421
C422
C423
C424
C425
C426
C427
C428
C429
C430
C431
C432
C433
C434
C435
C436
C437
C438
C439
C440
C441
C442
C443
C444
C445
C446
C447
C448
C449
C450
C451
C452
C453
C454
C455
C456
C458
C459
C462
C463
C530
C531
C532
C533
C534
C535
C536
C537
C538
C539
C540
C541
C542
C543
C544
C545
C546
C547
C548
C549
C550
C551
C552
C553
C554
C555
C556
C557
C558
C559
C560
C561
C562
C563
C564
C565
C566
C567
C568
C569
C570
C571
C572
C573
C574
C575
C576
D4
D4
D4
D4
D4
D4
D4
D4
D2
D2
D2
D2
* D3
* D3
* D3
* D3
D2
D2
* D2
* D2
* D2
* D2
D3
D3
D3
D3
D3
D3
D1
D1
D3
D3
D3
D3
D3
D3
D3
D3
* D4
* D4
E2
E2
D2
D2
C4
C4
C4
C4
* C4
* C4
C4
C4
C4
C4
* C4
* C4
* C4
C4
* C4
* C4
* C4
C4
C4
* C4
C4
* C4
C4
* C4
* C4
* B4
* B4
B4
C4
C4
C4
* B4
* C4
B4
C4
C3
C3
B4
C4
C3
* B3
* B4
C3
* C3
* C4
C4
B4
C577
C578
C579
C580
C581
C582
C583
C584
C585
C586
C587
C588
C589
C590
C591
C592
C593
C594
C595
C596
C597
C598
C601
C602
C603
C604
C605
C606
C607
C608
C609
C610
C611
C612
C613
C614
C615
C616
C617
C618
C619
C620
C621
C626
C627
C628
C629
C630
C631
C633
C634
C635
C637
C730
C731
C732
C733
C734
C735
C736
C737
C738
C739
C740
C741
C742
C743
C744
C745
C746
C747
C748
C749
C750
C751
C752
C753
C754
C755
C756
C757
C758
C759
C760
C761
C762
C800
C801
C802
C803
C804
B4
C4
C3
C3
* C4
* C4
C3
C3
B3
B3
C3
C3
B3
C3
C3
B3
B1
C1
C2
C1
C2
C1
* C3
* C3
* B2
* B1
* C1
* C1
B2
C2
* C3
* B3
* C3
* C3
* B1
* B1
* C1
* D1
* B1
* B1
* C1
* D1
C2
B2
C1
* C3
* C3
* B3
* B3
* B3
* C3
* C3
* C3
* J2
* H2
* J2
* H2
* J1
* H1
* H2
* H2
* H1
* H1
* J2
* J2
* J1
J2
J2
J1
* J1
* J2
* J2
* J1
J2
J2
J1
* K2
J1
K1
K2
* J2
* J1
* J2
* J1
* J2
* J1
* C4
A6
C6
D6
* E8
C805
C806
C807
C808
C809
C810
C811
C812
C813
C814
C815
C816
C817
C818
C819
C820
C821
C822
C823
C824
C825
C826
C827
C828
C829
C830
C831
C832
C833
C834
C835
C836
C837
C838
C839
C840
C841
C842
C843
C844
C845
C846
C847
C848
C849
C850
C851
C852
C853
C854
C855
C856
C857
C858
C859
C860
C861
C862
C863
C864
C865
C866
C867
C868
C869
C870
C871
C872
C873
C874
C875
C876
C877
C878
C879
C880
C881
C882
C883
C884
C885
C886
C887
C888
C889
C890
C891
C892
C893
C894
C895
* D7
D6
E7
D6
A4
* B4
A4
A4
* D7
C9
B4
B4
B4
B4
* D7
* D7
* D7
B4
B4
A4
* D7
* B9
B4
C5
C6
B4
C5
D6
C6
C6
* D7
C7
C7
* D7
* D7
D6
* D8
* D7
* D8
* D7
* E9
* E9
* D7
* D7
D8
C8
C8
D8
D7
D7
D7
* D7
* E8
E7
C8
* D8
* E7
E7
E7
* E8
E9
* D9
E8
* D8
E8
* D8
E9
* D9
E9
* D9
D8
* E8
D9
* E9
B6
C5
B6
* C6
* B8
* B9
B8
B8
B8
* B8
* B8
B8
D9
D9
K9
K9
K9
C896
C897
C898
C899
C900
C901
C902
C903
C904
C905
C906
C907
C908
C909
C910
C911
C912
C913
C914
C915
C916
C917
C918
C919
C920
C921
C922
C923
C924
C925
C926
C927
C928
C929
C930
C931
C932
C933
C934
C935
C936
C937
C938
C939
C940
C941
C942
C943
C944
C945
C946
C947
C948
C949
C950
C951
C952
C953
C954
C955
C956
C957
C958
C959
C960
C961
C962
C963
C964
C965
C966
C967
C968
C969
C970
C971
C972
C973
C974
C975
C976
C977
C978
C979
C980
C981
C982
C983
C984
C985
C986
* C4
* C4
* C4
* C4
* C4
* E8
F8
E9
E8
E8
E9
F8
* F8
F9
F8
F9
* F8
F8
K2
K2
K1
K2
K2
K2
L2
L1
* K1
* K1
* K1
* L1
* L1
L2
* E6
* A8
* E6
* E6
* E5
* A8
* A8
* E5
* D5
A8
* A8
* E6
* E5
* E6
* E6
* D5
* D6
* E5
* E5
E5
* E6
* E5
* A8
* A8
E6
* E6
* E6
* E6
* E6
A8
* E5
* E5
* E5
* E5
D5
* C4
* C4
* L5
* L5
* L5
* L5
* L5
* L5
* L5
B5
B5
L5
C7
B5
E7
E6
* E6
* E6
* E7
E6
E6
E7
E6
A5
C988
C989
C990
C991
C993
C994
C995
C996
C997
C998
C999
C1000
C1001
C1002
C1003
C1004
C1005
C1006
C1007
C1008
C1009
C1010
C1011
C1012
C1013
C1014
C1015
C1016
C1017
C1018
C1019
C1020
C1021
C1022
C1023
C1024
C1025
C1026
C1027
C1028
C1029
C1030
C1031
C1032
C1033
C1034
C1035
C1036
C1037
C1038
C1039
C1040
C1041
C1042
C1043
C1044
C1045
C1046
C1047
C1048
C1049
C1050
C1051
C1052
C1053
C1054
C1055
C1056
C1057
C1058
C1060
C1062
C1063
C1064
C1065
C1066
C1067
C1068
C1069
C1070
C1071
C1072
C1073
C1074
C1075
C1076
C1077
C1078
C1079
C1080
C1081
10-16
J9
C4
D4
K2
L9
K2
D7
D6
D6
D6
C6
* H7
G6
* H7
H7
* G7
G7
H7
H7
* H7
H7
* H7
* G7
* G7
H7
G7
G7
* G7
G7
G7
* G7
* G7
* G7
* G7
* G7
* G6
* G6
* G7
* G7
* H6
H6
* H6
H6
* G6
G6
H6
H6
* H6
H6
* H6
* G6
* G6
H6
G6
G6
* G6
G6
G6
* G6
* G5
* G6
* G6
* G6
* G5
* G5
* G6
* G6
* G6
* F6
F6
F6
F6
F6
F6
F6
F6
F6
F6
* G7
G7
F7
G7
F7
F7
F7
F7
* F7
* F6
H6
* F6
* F6
C1082
C1083
C1084
C1085
C1086
C1087
C1088
C1089
C1103
C1105
C1106
C1107
C1108
C1109
C1110
C1111
C1112
C1113
C1114
C1115
C1116
C1117
C1118
C1119
C1120
C1121
C1122
C1123
C1124
C1125
C1126
C1127
C1128
C1129
C1130
C1131
C1132
C1133
C1134
C1135
C1136
C1137
C1138
C1139
C1140
C1141
C1142
C1143
C1144
C1145
C1146
C1147
C1148
C1149
C1150
C1151
C1152
C1153
C1154
C1155
C1156
C1157
C1158
C1159
C1160
C1161
C1162
C1163
C1164
C1165
C1166
C1167
C1168
C1169
C1170
C1501
C1502
C1503
C1504
C1505
C1506
C1507
C1508
C1509
C1510
C1511
C1512
C1513
C1514
C1515
C1516
* F6
F6
H7
H7
* G6
H7
H5
* G5
K8
J8
J8
K8
* J8
* J8
* J8
* J8
L8
K8
K8
L8
* H9
* H9
* H9
* H9
* H9
* H9
* H9
* H9
H9
J9
H8
* G8
* G9
* H9
* G8
* H8
* H8
* H8
* H9
* H9
* G9
* H8
* H8
H8
* H9
* H9
G8
G9
* G8
G8
* G8
G8
* G8
G8
* G8
G8
* G9
G9
* G9
G9
* G9
G9
* G9
G9
* G9
G8
* G9
G8
* G8
G9
* G8
G9
* K8
* K8
D6
H6
* K8
J7
H6
H6
H6
* K7
J7
H6
J7
H7
* K7
H6
K8
J7
* J7
C1517
C1518
C1519
C1520
C1521
C1522
C1523
C1524
C1525
C1526
C1527
C1528
C1529
C1530
C1531
C1532
C1533
C1534
C1535
C1536
C1537
C1538
C1539
C1540
C1541
C1542
C1543
C1544
C1546
C1547
C1548
C1549
C1550
C1551
C1552
C1553
C1554
C1555
C1556
C1557
C1558
C1559
C1560
C1561
C1562
C1563
C1564
C1565
C1566
C1567
C1568
C1569
C1570
C1571
C1572
C1573
C1574
C1575
C1576
C1577
C1578
C1579
C1580
C1581
C1582
C1583
C1584
C1585
C1586
C1587
C1588
C1589
C1590
C1591
C1592
C1593
C1594
C1595
C1596
C1597
C1598
C1599
C1600
C1601
C1602
C1603
C1604
C1605
C1606
C1608
C1610
10-16
* K7
H7
* J6
J6
* J6
* J6
* J7
K8
K7
K7
* K7
* H7
* K7
H7
J7
H7
J7
H7
* K7
J7
J5
K5
J6
* J5
K6
* K5
* J6
* K7
* K6
* K7
* H7
H7
K6
* K6
K3
K4
* K6
J2
* J3
* J4
K6
K3
K4
* K3
* K4
J2
J3
* J4
* J3
* K6
J2
J3
J4
J3
* L6
J3
J3
* J3
* J4
* J3
* H2
* H3
J4
J3
* J2
* J3
* J4
* J4
* J3
* J2
J2
J2
H2
H3
* H4
* H3
J2
* H2
* H3
H4
H3
H1
H1
H1
L3
L3
A1
A2
A3
A3
* J4
C1611
C1613
C1614
C1615
C1616
C1617
C1618
C1619
C1620
C1621
C1622
C1623
C1624
C1625
C1626
C1627
C1628
C1629
C1630
C1631
C1632
C1633
C1634
C1635
C1636
C1637
C1638
C1639
C1640
C1641
J8
J7
J7
J6
J7
J7
J7
* J7
J7
* J6
* J6
K6
K6
K7
* K6
K7
* K6
* K7
* K7
K7
* K7
* K7
* J4
* H6
J6
H6
J7
* J4
* K4
* K4
CL300
CL301
CL302
CL303
CL304
CL305
CL400
CL401
CL402
CL403
CL404
CL405
CL530
CL531
CL532
CL533
CL801
CL802
CL803
CL852
CL900
CL901
CL902
CL903
CL904
CL905
CL906
CL907
CL908
CL909
CL910
CL911
CL912
CL913
CL921
CL922
CL923
CL924
CL925
CL1500
CL1501
CL1502
CL1503
CL1504
CL1505
CL1506
CL1507
CL1508
CL1509
CL1510
CL1511
CL1513
CL1514
F4
E4
F4
G4
A2
A3
D4
D4
D1
D1
E1
D1
B2
B1
C2
C1
C9
D7
D7
D5
G6
G6
G7
G7
G6
G5
G6
G6
G5
G5
G6
G6
G5
G5
H9
H9
H9
H9
K8
K7
J7
K5
H7
K6
K3
K2
H2
H3
J4
J3
J4
K7
K4
CN1
CN2
CN101
CN102
CN801
CN802
A2
A3
L3
L7
B6
E9
CN803
CN804
CN805
CN806
B5
B7
D9
A8
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D300
D530
D531
D730
D731
D732
D733
D734
D735
D736
D737
D738
D739
D740
D741
D742
D743
D744
D745
D746
D747
D748
D749
D752
D753
D754
D755
D801
D802
D807
D808
D820
D821
D822
D823
D824
D825
D826
D827
D828
D829
D830
D831
D832
D833
D834
D835
D836
D837
D838
D839
D1501
D1502
D1503
D1504
D1505
D1506
D1507
D1508
D1509
D1511
D1512
D1513
* F2
F2
* F2
F2
* F2
* G3
* H3
* G2
G3
* G3
F4
* C4
* C4
* J2
* J2
* J1
* J2
* J1
* J1
* H2
* H2
* H1
* J2
* J2
* J1
* J2
* J2
* J2
* J2
* J1
* J1
* J1
* J1
* J2
* J1
J1
J1
* B9
* B9
* B8
A6
* K2
* K3
* K4
* K4
* K2
* K4
* K4
* K3
* K3
* K4
* K4
* K4
* K4
* K4
* K4
* K4
* K4
E5
E5
E5
J6
* J6
* K3
* K3
* H3
* H3
* J4
* J3
H7
J6
* J7
* H6
E1500
E1501
E1502
E1503
E1504
E1505
A1
F5
K5
E3
* D2
* H6
FB1
FB2
FB3
FB4
FB5
* G2
* G2
H3
* G4
* G4
FB900
FB901
FB902
FB903
FB904
FB905
FB906
FB907
FB908
FB909
FB910
FB911
FB912
FB913
FB914
FB915
FB922
FB923
FB924
FB925
FB926
FB927
FB928
FB929
FB1500
FB1501
FB1502
FB1503
FB1504
FB1505
FB1506
FB1507
FB1508
FB1509
FB1510
FB1511
FB1512
FB1513
FB1514
FB1515
FB1516
FB1517
FB1518
FB1519
FB1520
FB1521
FB1522
FB1523
FB1524
FB1525
FB1526
FB1527
FB1528
FB1529
FB1530
FB1531
FB1532
FB1533
FB1534
FB1535
FB1536
FB1537
FB1538
FB1539
FB1540
FB1541
FB1542
FB1543
FB1544
FB1545
FB1546
FB1547
FB1548
FB1549
IC1
IC2
IC3
IC4
IC5
IC6
IC7
IC8
IC9
IC10
IC11
IC12
IC13
IC14
IC15
IC16
* H7
* H7
H7
* G6
* G6
* G7
* G7
* H5
* H6
H6
* G5
* G5
* G6
* G6
* G6
* G5
* J8
* J8
G8
* G9
G8
* G9
* G8
G8
K7
J7
* J6
* J6
* J5
* J6
* J5
* J6
* J5
* J6
* J5
* J6
K7
K7
* J7
* J7
* J7
* J7
* H7
* H7
* K6
* K6
* K6
* K6
* K6
* K6
* K6
* K6
* K6
* K6
* J6
* J7
* J6
* J7
* J6
* J7
* J6
* J7
* J6
* J7
* K7
* K7
* K7
* K7
* K7
* K7
* K7
* K7
* K6
* K6
G2
F3
E2
F3
G4
F4
F1
F1
F2
G2
F1
G2
F3
F1
F3
G2
IC17
IC18
IC19
IC20
IC21
IC22
IC23
IC24
IC25
IC26
IC27
IC28
IC29
IC30
IC31
IC32
IC33
IC34
IC35
IC36
IC37
IC38
IC39
IC40
IC41
IC42
IC43
IC44
IC45
IC46
IC47
IC48
IC49
IC50
IC51
IC300
IC301
IC302
IC303
IC304
IC305
IC306
IC307
IC308
IC309
IC400
IC401
IC402
IC403
IC404
IC405
IC406
IC407
IC408
IC409
IC410
IC411
IC530
IC531
IC532
IC536
IC537
IC538
IC539
IC540
IC541
IC542
IC543
IC544
IC545
IC546
IC730
IC800
IC801
IC802
IC804
IC805
IC806
IC807
IC808
IC809
IC810
IC811
IC812
IC813
IC814
IC815
IC816
IC817
IC818
IC819
G3
H3
G2
H3
G4
E3
G4
J4
F3
H4
G2
H4
J4
* G4
F1
F2
F2
G1
G2
H3
F2
F2
F2
E2
H3
G3
G4
G3
* G3
H4
H4
G2
F3
G4
G4
E4
F4
D4
E4
F4
F4
E4
B2
B2
E4
D4
D2
D2
* D3
* D3
D3
D4
D2
D2
D2
D3
D3
C4
C4
C4
C4
C4
* B3
* C3
C3
B1
C1
C3
C3
C3
C3
J1
E6
E8
* D7
C5
* B9
D6
C6
D7
* D7
* D7
E8
C8
* C8
E8
* E8
B5
C6
* C6
B8
IC820
IC821
IC822
IC823
IC824
IC825
IC826
IC828
IC830
IC831
IC832
IC833
IC834
IC835
IC836
IC837
IC838
IC839
IC840
IC841
IC842
IC843
IC844
IC845
IC846
IC847
IC848
IC849
IC851
IC852
IC853
IC854
IC855
IC856
IC857
IC858
IC859
IC860
IC861
IC862
IC870
IC871
IC873
IC874
IC875
IC876
IC877
IC879
IC880
IC881
IC883
IC900
IC901
IC902
IC903
IC904
IC905
IC910
IC911
IC912
IC915
IC916
IC917
IC918
IC919
IC920
IC921
IC922
IC1500
IC1501
IC1502
IC1503
IC1504
IC1505
IC1506
IC1507
IC1508
IC1509
IC1510
IC1511
IC1512
IC1513
IC1514
IC1515
JC730
JC731
JC732
JC733
JC734
JC735
* B8
* B8
K9
K9
L9
* D7
* D8
* D7
E7
E7
* E7
B4
* B8
* E8
* B8
* E7
B4
* B9
* E9
* D8
* D7
* D7
* D7
D6
* E9
B4
B4
A4
* E8
F8
F8
K1
* F8
* F8
A8
* A8
* A8
* A8
A8
D6
* E7
E6
B5
B5
L5
B5
E6
D5
D5
J9
L9
H9
G7
G6
F7
* F6
* F6
J8
J8
K8
K8
L8
L8
* J8
* J8
* G8
G8
* K8
* J3
J6
K7
H7
J7
H7
H7
* K3
* K4
* J4
H4
J4
* J4
J7
H6
* K4
J1
J1
J1
J1
J1
L2
JC736
JC737
JC738
L2
L2
L2
L1
L2
L3
L4
L5
L6
L7
L8
L9
L10
L11
L12
L13
L14
L15
L16
L17
L18
L19
L20
L21
L22
L23
L24
L25
L26
L27
L28
L29
L30
L31
L32
L33
L34
L35
L36
L37
L38
L39
L40
L300
L301
L530
L531
L532
L533
L730
L731
L732
L733
L801
L802
L803
L805
L807
L808
L809
L810
L811
L812
L813
L814
L820
L821
L822
L823
L830
L831
L904
L905
L908
L909
L910
L911
L920
L921
L922
L1500
L1501
L1502
L1503
L1504
L1505
L1506
L1507
L1508
L1509
* H4
* H4
* H5
F3
F3
F2
* H4
* H4
G3
H4
G4
E2
* G4
E1
F2
F2
H2
H2
* G2
* F3
F3
F1
* G1
G1
* G3
* H3
* G2
* G3
G2
G3
G3
E3
* G4
* H3
* J4
* J4
* J4
* H4
* G4
* H4
B3
* B2
* B1
* B1
* C1
* D1
* H1
* K1
* K2
* J2
B6
C6
B4
B4
C5
C6
* E8
E8
C6
B8
B6
B8
E9
K2
E5
E6
E7
E7
* G6
* F6
* F6
* F6
* F7
* F7
* H9
* H9
* J8
J7
K7
J6
J3
J4
K3
K3
J2
H4
H4
L1510
L1511
L1512
L1513
L1516
H3
H1
K3
K3
J7
PH730
PH731
PH732
H2
H2
H1
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
Q9
Q10
Q303
Q304
Q305
Q306
Q307
Q308
Q309
Q310
Q311
Q312
Q313
Q314
Q315
Q316
Q317
Q318
Q400
Q401
Q402
Q403
Q404
Q405
Q406
Q407
Q408
Q530
Q531
Q532
Q533
Q534
Q535
Q536
Q537
Q538
Q539
Q540
Q541
Q542
Q543
Q544
Q545
Q546
Q547
Q548
Q549
Q550
Q730
Q731
Q732
Q733
Q734
Q735
Q736
Q737
Q738
Q739
Q740
Q741
Q742
Q743
Q801
Q802
Q803
Q804
Q805
Q810
Q811
Q812
Q813
Q814
Q815
* F3
* F3
* H4
* G4
* F2
H2
* F3
* H2
H3
H3
F4
* A2
F5
* A2
* A2
F4
* A2
* A3
* E4
* E4
F5
F5
* A2
* A2
* B2
* B3
* D1
* D1
* D1
E2
D2
* E1
* D1
* D1
* D1
* C1
* C2
* C1
* C1
* B2
* B1
* C1
* C1
* B1
* C1
* C3
* B3
* C3
* C3
* C3
* C3
* C2
* C2
* C2
* B1
* C2
* H2
* H2
* H1
* J2
* J2
* J1
J1
J1
J1
* J2
* J2
* J1
* J1
J1
* E9
* B8
* A6
B8
* A6
L4
K3
K3
K3
K3
K3
HSCU-300
SY-364
Q816
Q817
Q818
Q819
Q820
Q821
Q908
Q909
Q910
Q1500
Q1501
Q1503
Q1504
Q1505
Q1506
Q1507
Q1508
Q1509
Q1510
Q1511
Q1512
Q1513
K3
K3
K3
K2
K2
K2
G6
F6
G6
* J6
* J6
* H2
* H3
J4
J3
* J4
* H4
J6
* J6
* J7
H6
J6
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
R31
R32
R33
R34
R35
R36
R37
R39
R40
R41
R42
R43
R44
R45
R46
R47
R48
R49
R50
R51
R52
R53
R54
R55
R56
R57
R58
R59
R60
R61
R62
R63
R64
R65
R66
R67
R68
R69
F3
F3
* H5
* H5
* F2
* F2
* F2
* H4
* H4
H4
H4
H4
H4
* F2
* F2
* F2
H4
* F3
* F2
* F2
H4
H4
H4
* F3
* F3
* F3
* F3
G2
G2
* F3
G2
F2
H4
H4
* F3
* F4
* H4
* H4
* F2
* F2
* F2
* F2
F2
* F3
F3
* G4
* F3
* E2
F3
* G4
* F4
* G4
* E2
* E2
* G4
F3
* G4
E2
* E1
F2
* G4
F3
G5
G5
* F1
* F1
* F1
* F1
HSCU-300
R70
R71
R72
R73
R74
R75
R76
R77
R78
R79
R80
R81
R82
R83
R84
R85
R86
R87
R88
R89
R90
R91
R92
R93
R94
R95
R96
R97
R98
R99
R100
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R114
R115
R116
R117
R118
R119
R120
R121
R122
R123
R124
R125
R126
R127
R128
R129
R130
R131
R132
R133
R134
R135
R136
R137
R138
R139
R140
R141
R142
R143
R144
R145
R146
R147
R148
R149
R150
R151
R152
R153
R154
R155
R156
R157
R158
R159
R160
R161
G4
* F1
* F1
G3
F4
G4
* F1
G4
* F2
E2
E2
* F2
* F2
* F2
F2
F1
E2
F1
F1
G1
F2
F2
F1
F2
F3
F3
F1
H2
H2
* F2
H2
H2
H2
H2
* F3
* F3
H2
F1
F1
* F2
* F3
* G2
* F2
* G2
* G2
* G2
* G2
F3
G3
G2
F1
G2
G2
F3
F3
F1
* G2
* G2
* G2
G2
* H3
* G1
* G1
* G2
* G2
F3
F3
G1
F3
F3
* H2
* G1
G1
* G1
G3
G3
F3
F3
F3
* G2
* G2
G1
* G2
* G3
* G3
* G3
G3
G3
G1
G2
G2
R162
R163
R164
R165
R166
R167
R168
R169
R170
R171
R172
R173
R174
R175
R176
R177
R178
R179
R180
R181
R182
R183
R184
R185
R186
R187
R188
R189
R190
R191
R192
R193
R194
R195
R196
R197
R198
R199
R200
R201
R202
R203
R204
R205
R206
R207
R208
R209
R210
R211
R212
R213
R214
R215
R216
R217
R218
R219
R220
R221
R222
R223
R224
R225
R226
R227
R228
R230
R231
R234
R235
R236
R237
R238
R239
R240
R242
R243
R245
R246
R247
R300
R301
R302
R303
R304
R306
R307
R308
R310
R311
* G3
* G3
* G3
* G3
* G3
* H3
* H3
* H3
G3
G2
G2
G3
G1
* H3
G1
* G3
G2
* G2
H3
H3
H3
H3
H3
H3
H3
G3
H3
H3
H3
G3
H3
G4
G4
* G4
* G3
* G4
* G4
* E3
F4
E4
* G4
G4
G4
* F3
F4
E4
G4
G4
G4
G4
E4
* E3
G4
G4
G4
G4
G4
J4
J4
J4
* J4
* J4
* J4
H4
* F3
F2
H4
* J4
H4
* J4
* J4
H4
J4
J4
J4
J4
K4
K4
H4
H4
* G2
F4
* A2
E4
* A2
E4
F4
F4
* A2
* A2
* A2
R312
R314
R315
R316
R317
R318
R319
R320
R321
R322
R323
R324
R325
R326
R327
R328
R329
R330
R331
R332
R333
R334
R335
R336
R337
R338
R339
R340
R341
R342
R343
R344
R345
R346
R347
R348
R349
R350
R351
R352
R353
R354
R355
R356
R357
R358
R359
R360
R361
R362
R363
R364
R366
R368
R369
R370
R371
R372
R373
R374
R379
R380
R381
R382
R383
R384
R385
R386
R387
R388
R389
R390
R391
R392
R393
R400
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R411
R412
R413
R414
R415
* A2
* A2
E4
E4
* A2
* E4
F4
F4
F4
F4
* E4
* D4
* E4
* D4
* F4
F4
* E4
* D4
F4
B3
F4
F4
F4
B2
B3
E4
B2
B3
B2
B3
E4
* F4
F4
F4
F4
* B2
* B3
E4
F4
B2
B3
* E4
F4
B2
F4
B3
F4
F4
E4
F4
E4
F4
B2
B3
* A2
E4
E4
* A2
E4
E4
E4
E4
* A2
* A3
F4
E4
E4
* E4
* B2
* B3
* B2
* B3
F4
* B2
* B3
* D1
* D1
* D2
* D1
* D1
* D1
E4
* D4
* D4
D3
D3
E2
E2
D2
D2
E3
R416
R417
R418
R419
R420
R421
R422
R423
R424
R425
R426
R427
R428
R429
R430
R431
R432
R433
R434
R435
R436
R437
R438
R439
R440
R441
R442
R443
R444
R445
R446
R447
R448
R449
R450
R451
R452
R453
R454
R455
R456
R457
R458
R459
R460
R461
R462
R463
R464
R465
R466
R467
R468
R469
R470
R471
R472
R473
R474
R475
R476
R477
R478
R479
R480
R481
R482
R483
R484
R485
R486
R487
R488
R489
R490
R491
R492
R493
R494
R495
R496
R497
R502
R503
R504
R505
R510
R511
R512
R513
R514
D2
E2
E2
D2
D2
D4
D2
E2
D4
D4
D4
D4
D4
D4
D2
D2
D2
D2
D2
D2
D3
D3
D3
D3
* D3
* D3
* D3
* D3
D2
D2
D2
D2
E2
D2
D2
D2
* D3
* D3
* D3
* D3
* D3
* D3
* D3
* D3
* D2
* D2
* D2
* D2
* D3
* D3
* D3
* D3
E1
D1
E2
D2
D3
D3
D2
D2
D3
D3
D3
D3
D3
D3
* E1
* D1
D3
D3
D3
D3
E1
E1
D1
D1
D3
D3
D3
D3
* E1
* D1
D1
D1
D1
D1
D1
D1
* D4
* D4
E1
R515
R530
R531
R532
R533
R534
R535
R536
R537
R538
R539
R540
R541
R542
R543
R544
R545
R546
R547
R548
R549
R550
R551
R552
R553
R554
R555
R556
R557
R558
R559
R560
R561
R562
R563
R564
R565
R566
R567
R568
R569
R570
R571
R572
R573
R574
R575
R576
R577
R578
R579
R580
R581
R582
R583
R584
R585
R586
R587
R588
R589
R590
R591
R592
R593
R594
R595
R596
R597
R598
R599
R600
R601
R602
R603
R604
R605
R606
R607
R608
R609
R610
R611
R612
R613
R614
R615
R616
R617
R618
R619
D1
C4
C4
C4
C4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
* C4
* B4
* C4
* B4
B3
C3
C3
C3
B4
C4
* C3
B4
C4
* C3
* B4
* C4
B4
B4
C4
C4
B4
* B4
* C4
C4
C3
C3
B4
C4
* B3
C3
C3
* C3
* C3
* B3
* B3
* C3
C3
C3
C3
C3
C3
C3
C3
C3
* B3
* C3
* B3
B3
* C4
* C3
* C4
* C3
B3
B3
C3
C3
* B3
* C3
B1
C2
B1
C1
B1
C2
B1
C2
C3
C3
C3
* B3
* C3
B1
C1
C3
B2
C1
C3
R620
R621
R622
R623
R624
R625
R626
R627
R628
R629
R630
R631
R632
R633
R634
R635
R636
R637
R638
R639
R640
R641
R642
R643
R644
R645
R646
R655
R656
R657
R658
R659
R660
R661
R662
R663
R664
R665
R666
R667
R668
R669
R670
R671
R672
R673
R674
R675
R676
R677
R678
R679
R680
R681
R682
R683
R684
R685
R686
R687
R688
R689
R690
R691
R692
R693
R694
R695
R696
R697
R698
R699
R700
R701
R702
R703
R704
R705
R706
R707
R708
R709
R710
R711
R712
R713
R714
R715
R716
R717
R718
C3
B1
C3
C3
C1
C3
C3
* C2
* C2
* C1
* C1
* C2
* C1
* C1
* C1
B3
C3
C3
C3
* C3
C3
* C1
* C3
* C2
C3
C3
C3
* C1
* C1
B3
C3
B3
C2
C3
C2
* B1
* C1
* B3
* B3
* C3
* C3
* B3
* B3
* C3
* C3
B3
C3
* B1
* B1
* D1
* C1
B2
C2
* B1
* B1
* C1
* C1
* B1
* D1
* C3
* B3
* C3
* C3
* C3
* C3
* B3
* C3
* B3
* C3
* C3
* D1
* C3
* B1
* C2
* C2
* C2
* C2
* C2
* C2
* C3
* C3
* C3
* C3
* C3
* C3
* B3
* C3
* C4
* B1
* C2
* C4
R719
R720
R721
R722
R723
R724
R725
R726
R727
R728
R730
R731
R732
R733
R734
R735
R736
R737
R738
R739
R740
R741
R742
R743
R744
R745
R746
R747
R748
R749
R750
R751
R752
R753
R754
R755
R756
R757
R758
R759
R760
R761
R762
R763
R764
R765
R766
R767
R768
R769
R770
R771
R772
R773
R774
R775
R776
R777
R778
R779
R780
R801
R802
R803
R804
R805
R806
R807
R808
R809
R810
R811
R812
R813
R814
R815
R816
R817
R818
R819
R820
R821
R822
R823
R824
R825
R826
R827
R829
R830
R831
B3
C3
C3
* C3
B1
C3
C3
C3
* C3
C2
* J2
* J1
* J1
* H2
* H1
* H1
* H2
* H2
* H1
J2
* H2
* H2
J2
* H2
* H2
J1
* H1
* H1
* H2
* H2
* H1
H2
H2
H1
H2
H2
H1
* J2
* J2
* J1
J1
J1
J1
J1
J1
J1
* J2
* J1
* J2
* J1
* J2
* J1
J1
* J2
* J1
J1
* J2
* J1
J1
J1
J1
A6
A6
D6
* C5
* C5
* B4
C5
* E8
* B4
A4
A4
A4
C5
* B4
B4
B4
* B9
E7
E7
* D7
E7
E7
B4
B4
* B9
* B4
C5
D6
D6
B4
10-17
R832
R833
R834
R835
R836
R837
R838
R839
R840
R841
R842
R843
R844
R846
R847
R848
R849
R850
R851
R852
R853
R857
R859
R860
R861
R862
R863
R864
R865
R866
R867
R868
R869
R870
R871
R872
R873
R875
R876
R877
R878
R879
R880
R881
R882
R883
R884
R885
R886
R889
R891
R892
R893
R895
R896
R897
R898
R899
R900
R901
R902
R903
R904
R905
R906
R907
R908
R909
R910
R911
R912
R913
R914
R915
R916
R917
R918
R919
R920
R921
R922
R923
R924
R926
R927
R928
R929
R930
R932
R933
R934
SY-364
D6
D6
D6
C6
C6
B4
D6
D6
* B9
* B9
* B9
C5
C5
* B9
* B9
* B9
* E7
* B9
* D8
D6
* D8
* D7
D6
* D7
* D8
* D7
* D7
* D8
* D7
D7
* E9
* E9
D7
* E9
* E9
* E9
D8
D8
D8
C8
D8
* D7
D8
D8
D8
* E8
* D8
E7
* E7
* E7
E8
E7
C5
C8
A6
* B8
A6
A6
A6
B6
B6
B6
* B8
B8
B8
B8
B8
* A6
* A6
* B8
* B8
B8
* B8
B8
* A6
B8
B8
B8
* A6
B8
* A6
B8
* A6
* C9
* C9
K9
K9
K9
K9
K9
* L8
R935
R936
R937
R938
R939
R940
R941
R942
R943
R951
R952
R953
R954
R955
R956
R957
R958
R959
R960
R961
R962
R963
R964
R965
R966
R967
R968
R969
R970
R971
R972
R973
R974
R975
R976
R977
R978
R979
R980
R981
R982
R983
R984
R985
R986
R987
R988
R989
R1001
R1002
R1003
R1004
R1005
R1006
R1007
R1008
R1009
R1010
R1011
R1012
R1013
R1014
R1015
R1016
R1017
R1020
R1021
R1023
R1024
R1050
R1051
R1052
R1053
R1054
R1055
R1056
R1057
R1058
R1059
R1060
R1061
R1062
R1063
R1064
R1065
R1066
R1067
R1068
R1069
R1070
R1071
* L8
* L8
K9
L9
L9
L9
L9
L9
* A8
* E8
* E8
* E8
F8
* E8
F8
F8
F8
F8
F8
F9
F9
F9
* F8
* E8
* E9
* E8
F9
F9
* F8
F8
K2
K2
K2
* K1
* K1
* K1
K1
K1
L1
K1
L1
K1
L1
L1
L1
L1
L1
L1
A8
A8
* A8
A8
E6
A8
A8
* A8
* E5
E6
* E6
E5
* E6
E6
* E6
* E6
E5
* A8
* A8
A8
* D6
L5
L5
L5
B5
L4
L2
B5
B5
B5
B5
* K2
B5
* L5
B5
* L5
L4
L4
* L5
B5
E6
B5
E5
10-17
R1072
R1073
R1074
R1075
R1076
R1077
R1079
R1080
R1081
R1082
R1083
R1084
R1085
R1086
R1087
R1088
R1089
R1090
R1092
R1093
R1094
R1095
R1096
R1097
R1098
R1099
R1100
R1101
R1102
R1103
R1104
R1105
R1106
R1107
R1108
R1109
R1110
R1111
R1112
R1113
R1114
R1115
R1117
R1118
R1119
R1120
R1122
R1123
R1124
R1125
R1126
R1130
R1131
R1132
R1133
R1134
R1135
R1136
R1137
R1138
R1139
R1140
R1141
R1142
R1143
R1150
R1151
R1152
R1153
R1154
R1155
R1156
R1157
R1158
R1159
R1160
R1161
R1162
R1163
R1164
R1165
R1166
R1167
R1168
R1169
R1170
R1171
R1172
R1173
R1174
R1175
E5
E5
E5
E6
B5
B5
* E5
E5
E5
D6
E5
J9
E5
E5
E5
E5
E5
E5
E5
E5
* E5
E6
E6
E6
E5
D6
* E6
* E6
* E6
* E6
* E6
* E6
* E6
* E7
E6
E6
E6
E6
E6
* E6
* E6
E6
E6
* E6
B5
B5
E6
E6
E6
E6
E5
B4
D5
D5
D5
K2
K2
K2
K2
J9
K2
K2
E5
E5
J9
H7
H7
H7
H7
H7
H7
H7
H7
* G7
H7
* G7
* G7
H7
* G6
* G7
H7
H7
G6
G7
G6
G6
H6
H6
G6
H6
G7
R1176
R1177
R1178
R1179
R1180
R1181
R1182
R1183
R1184
R1185
R1186
R1187
R1188
R1189
R1190
R1191
R1192
R1193
R1194
R1195
R1196
R1197
R1198
R1199
R1200
R1201
R1202
R1203
R1204
R1205
R1206
R1207
R1208
R1209
R1210
R1211
R1212
R1213
R1214
R1215
R1217
R1218
R1219
R1220
R1221
R1223
R1225
R1227
R1228
R1234
R1236
R1239
R1240
R1241
R1242
R1243
R1244
R1245
R1246
R1247
R1248
R1249
R1250
R1251
R1252
R1253
R1254
R1255
R1256
R1257
R1258
R1259
R1260
R1261
R1262
R1263
R1264
R1265
R1266
R1267
R1300
R1301
R1302
R1303
R1304
R1305
R1306
R1307
R1308
R1309
R1310
H6
H6
H6
H6
H6
H6
H6
H6
* G6
H6
* G6
* G6
H6
* G5
* G6
H5
H6
G5
G6
G5
G5
H5
H5
G5
H5
G6
G6
G6
F6
F6
G6
F6
F6
F6
G6
F6
F6
G6
F6
F6
* F7
* F7
* F7
* F7
* F7
* F7
* F7
* F7
* F7
* F7
* F7
G7
* F7
F7
F7
F7
F7
F7
F7
H7
H7
* G7
* G6
H6
H6
* F6
G6
G6
H6
G7
G7
* G7
G7
G6
G6
G6
* G6
G6
G5
H6
H8
H8
H8
H8
H8
H8
H8
H8
H8
H8
* H8
R1311
R1312
R1313
R1314
R1315
R1316
R1317
R1318
R1319
R1320
R1321
R1322
R1323
R1324
R1325
R1326
R1327
R1328
R1329
R1330
R1331
R1332
R1333
R1334
R1335
R1336
R1337
R1338
R1339
R1340
R1341
R1342
R1343
R1344
R1345
R1346
R1349
R1350
R1352
R1353
R1354
R1355
R1356
R1357
R1358
R1359
R1360
R1361
R1362
R1363
R1364
R1365
R1366
R1502
R1503
R1504
R1505
R1506
R1507
R1508
R1509
R1510
R1511
R1513
R1514
R1515
R1516
R1517
R1518
R1519
R1520
R1522
R1523
R1524
R1525
R1526
R1527
R1528
R1529
R1530
R1531
R1532
R1533
R1534
R1538
R1539
R1540
R1541
R1542
R1543
R1545
* H8
* H8
* H8
H8
G8
H8
* H8
* H8
* H8
* H8
H9
H9
K8
* G9
J8
J8
K8
* L6
H8
* H9
L8
* H8
* J8
L8
K8
L8
L8
* H8
* G8
* H8
* H8
H9
G9
G9
* G9
* H8
G9
* H9
H9
* H9
* H9
* H8
G8
G8
K8
K8
K8
K8
L8
L8
L8
* K8
* J8
* J6
* H6
J6
* K7
* K8
H7
H7
J7
J7
H6
H6
* K7
* K7
H6
J7
H6
* K7
* K7
* K7
J7
* H6
H6
* K8
* J7
* J7
* J7
H6
* H6
* K7
* J7
H6
* K7
* J7
J6
J6
* J6
* J7
* K7
R1546
R1547
R1548
R1549
R1550
R1551
R1552
R1553
R1554
R1555
R1556
R1557
R1558
R1559
R1560
R1561
R1562
R1563
R1564
R1565
R1566
R1567
R1568
R1570
R1572
R1573
R1574
R1575
R1576
R1577
R1578
R1579
R1580
R1581
R1582
R1583
R1584
R1585
R1586
R1588
R1589
R1590
R1591
R1592
R1593
R1594
R1595
R1597
R1598
R1599
R1600
R1601
R1602
R1604
R1605
R1606
R1607
R1608
R1609
R1610
R1611
R1612
R1613
R1614
R1615
R1616
R1617
R1618
R1621
R1622
R1623
R1624
R1625
R1627
R1628
R1630
R1631
R1632
R1633
R1634
R1635
R1636
R1637
R1638
R1639
R1640
J7
J7
H7
* H7
* H7
* H7
* K3
* K4
* J3
* J3
* J3
* J4
* J4
* J3
* J4
* J3
* J3
* J3
* J4
* J3
* H2
* J3
H6
* J6
* J4
* J4
* J2
* J2
* J2
* J4
* J4
* J4
* H2
* J4
* J3
* J3
* J4
* J4
* J6
* J4
* J4
* J4
* J4
* J4
* H4
* H4
* H4
* H4
* H4
* H4
* H4
* J4
J7
* J4
J6
J7
J6
J7
J6
J6
* J7
J7
J7
* J7
J7
J7
J7
* J7
* J4
* H4
J6
H6
* H6
J6
J7
* K7
H6
H6
H6
H6
H6
H6
* H6
* K4
* K4
* K4
RB1
RB300
RB301
RB400
G4
D4
* E4
D4
RB530
RB800
RB801
RB802
RB803
RB804
RB805
RB806
RB807
RB808
RB809
RB810
RB811
RB812
RB813
RB814
RB815
RB816
RB817
RB818
RB819
RB820
RB821
RB822
RB824
RB825
RB826
RB830
RB831
RB832
RB833
RB834
RB835
RB836
RB837
RB838
RB839
RB840
RB841
RB842
RB843
RB844
RB847
RB848
RB849
RB850
RB851
RB852
RB853
RB855
RB856
RB857
RB858
RB859
RB900
RB901
RB902
RB903
RB904
RB905
RB906
RB907
RB908
RB909
RB910
RB911
RB912
RB913
RB914
RB915
RB916
RB919
RB920
RB921
RB922
RB925
RB926
RB927
RB928
RB931
RB932
RB933
RB934
C4
* D8
C7
C7
C7
C7
C8
C8
C8
* C7
* C7
* D7
* C7
C8
C7
C7
C7
* D8
* D8
* B8
K9
K9
K9
K9
* D6
* D6
* F9
L5
* L3
* L4
L3
L3
B5
* K3
B5
* L5
* K3
K4
K4
B5
B5
F5
C5
C4
* D5
D5
E6
E6
C4
L9
L9
J9
L9
L9
H8
H8
H8
H8
* H8
* H8
* H8
* H8
* H8
* H8
H8
H8
H8
J8
J8
J8
J8
J8
J8
J8
J8
K8
K8
L8
L8
K8
K8
L8
L8
RV1
RV530
RV531
F1
A5
A5
S530
S531
S730
B2
C2
J2
S731
S732
S733
S734
S735
S801
J2
J1
H2
H2
H1
A8
SORI01
SORI02
A5
L5
T730
T731
J2
J1
THP801 B8
THP950 H7
THP951 K7
THP952 K7
THP953 J7
THP954 K6
THP955 K3
THP956 K4
THP957 J4
THP958 J3
THP959 J2
THP960 J3
THP961 K2
THP962 H1
THP963 A3
THP964 K6
THP965 A2
THP966 A3
THP967 * K4
THP968 L4
THP969 L3
TP1
TP4
TP5
TP6
TP7
TP530
TP531
TP801
TP802
TP803
TP901
TP902
H4
G1
G1
H4
H3
C4
C4
D4
C5
D5
G7
G6
X1
X2
X3
X801
X802
X803
X900
X901
G1
G3
G3
D6
K2
E6
G7
G6
B2
VIF-39
VIF-39
--------------------VIF-39 (1-879-658-11)
--------------------*:B SIDE
CN911
R86
R90
B7
B8
B7
B8
B7
B7
B7
B7
B7
B7
B7
C6
C5
C6
C6
C6
B6
C5
C5
B6
C5
B5
B5
B4
C5
B1
B1
A1
A2
A2
A2
A2
A2
A2
A2
R88
R87
R85
R84
R89
Q81
R20
R21
R22
R23
R24
R25
R26
R27
R28
R29
R30
R41
R42
R43
R44
R45
R46
R47
R48
R49
R50
R51
R52
R61
R62
R81
R82
R83
R84
R85
R86
R87
R88
R89
R90
C87
B7
B7
IC1
IC2
IC3
IC6
IC41
IC42
C9
B7
B7
B1
C6
C5
JC41
JC42
C6
C5
VIF-39 -B SIDE-
L1
L2
L11
L12
L41
L42
L81
L82
B8
B8
C7
C7
B6
B6
A2
B2
SUFFIX: -11
Q81
A2
R1
R2
R3
R4
R5
R11
R12
R13
R14
R15
R16
R17
R18
R19
C9
C9
C8
B9
B9
C7
C7
C7
C7
C7
C7
C7
C7
B7
JC42
L41
R82
R62
R42
R47
R48 IC42
R43
R44 IC41
C43
R26R27
R29R30
R49
C46
R20
R18
R52
JC41
C45
R50
C65
R51
C42
R45
C64 C63R61
R12
R19
R17
E1
R11
L2
CL82
C44
L12 C12
L11 C11
R5
C2
IC1
IC6 CL81
C86
C82
C62
C61
L42
FB12
R28
C18 C20
C28
C15
C16
C27
C24 C22
FB11
R25
C17 C19
C26
C13
C14
C25
C23 C21
C4
R2
R1
CN4
C41
L1
L81
FB11
FB12
C84
B5
L82
E1
R41
R81
C9
C7
C6
B1
C4
A3
R16R14
R83
CN1
CN2
CN3
CN4
CN5
CN911
R15R13
R46
C85
B1
B2
R3
IC3
R22
R24
C81
CL81
CL82
R4
C3
IC2
R21
R23
C83
B8
B8
C9
B8
C7
C7
B7
B7
B7
B7
B7
B7
B7
B7
B8
B7
B8
B7
B7
B7
B7
B7
B6
B6
C6
B6
B5
C5
B4
B4
B4
B4
B4
A2
B2
A2
B2
A1
B1
A2
C1
C1
C2
C3
C4
C11
C12
C13
C14
C15
C16
C17
C18
C19
C20
C21
C22
C23
C24
C25
C26
C27
C28
C41
C42
C43
C44
C45
C46
C61
C62
C63
C64
C65
C81
C82
C83
C84
C85
C86
C87
CN5
CN1
CN2
CN3
VIF-39 -A SIDESUFFIX: -11
10-18
10-18
HSCU-300
SAFETY CHECK-OUT
After correcting the original service problem,
perform the following safety checks before
releasing the set to the customer :
Check the metal trim, metallized knobs,
screws, and all other exposed metal parts for AC
leakage. Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part
to earth ground and from all exposed metal
parts to any exposed metal part having a return
to chassis, must not exceed 3.5 mA. Leakage
current can be measured by any one of three
methods.
1. A commercial leakage tester, such as the
Simpson 229 or RCA WT-540A. Follow the
manufacturers instructions to use these
instruments.
2. A battery-operated AC milliammeter. The
Data Precision 245 digital multimeter is
suitable for this job.
3. Measuring the voltage drop across a resistor
by means of a VOM or battery-operated AC
voltmeter. The limit indication is 5.25 V, so
analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa
SH-63Trd are examples of a passive VOM
that is suitable. Nearly all battery operated
digital multimeters that have a 20 V AC
range are suitable. (See Fig. A)
To Exposed Metal
Parts on Set
0.15 F
1.5 kZ
AC
voltmeter
(5.25V)
Earth Ground
Fig A. Using an AC voltmeter to check AC leakage.
HSCU-300
HSCU-300 (UC)
HSCU-300 (J)
HSCU-300 (CE) J, E
9-968-615-01
Sony Corporation
Printed in Japan
2009. 4 08
2009

SM HSCU-300 E1 9968615010-00e PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

SM HSCU-300 E1 9968615010-00e PDF

Uploaded by

Copyright:

Available Formats

HD CAMERA CONTROL UNIT

For safety, do not connect the connector for peripheral

Fara fr explosion vid felaktigt placerat batteri.

Eksplosjonsfare hvis feil type batteri settes i.

For kundene i Norge

Attention-when the product is installed in Rack:

Purpose of this manual ............................................................ 3 (E)

Related manuals ...................................................................... 3 (E)

3-2. Audio System ............................................................3-2 (E)

3-3. System Settings .........................................................3-7 (E)

1-1. Connectors and Cables ..............................................1-1 (E)

Location of Printed Circuit Boards ...........................1-6 (E)

Outside Dimensions ..................................................1-6 (E)

Description of Onboard LED Indicators ...................1-7 (E)

Switch Settings .........................................................1-9 (E)

Potentiometer Functions......................................... 1-11 (E)

Mounting the Unit in a 19-Inch Rack......................1-12 (E)

System Connection....................................................3-1 (E)

3-4. Video Signal System .................................................3-8 (E)

Connecting/Disconnecting the Flexible Card Wire...2-2 (E)

2-3. Upgrading the Software Programs ............................2-3 (E)

Writing and Rewriting the PLD Internal Data ..........2-5 (E)

Periodic Replacement Parts.......................................2-6 (E)

2-6. Notes on Replacement of Circuit Board ...................2-6 (E)

Circuit Protective Devices.........................................2-7 (E)

2-8. How to Extend Boards ..............................................2-8 (E)

Circuit Description ..................................................2-14 (E)

2-10. Notes on Repair Parts ..............................................2-19 (E)

4-1. Preparations ...............................................................4-1 (E)

VE OPERATION Menu ............................................4-2 (E)

MAINTENANCE Menu .........................................4-12 (E)

5. Replacement of Main Parts

Removing/Installing the Front assembly...................5-1 (E)

Replacing the DC Fan ...............................................5-1 (E)

Removing/Installing the Rear Panel Assembly .........5-2 (E)

Replacing the TRIAX connector assembly ...............5-3 (E)

5-5. Replacing Boards ......................................................5-4 (E)

FL-349 Board.................................................5-10 (E)

6-2. Audio System Adjustment.........................................6-3 (E)

6-3. Video/Reference Signal System Adjustment.............6-5 (E)

MB-1124 ....................................................................... 9-51

6-4. SD Signal System Adjustment ..................................6-6 (E)

VIF-39 ........................................................................... 9-74

6-5. HD Signal System Adjustment..................................6-9 (E)

Tone Detection Frequency Adjustment..........6-13 (E)

FL-349 ........................................................................... 9-50

10. Board Layouts

Notes on Repair Parts ...................................................... 7-1

MB-1124 ..................................................................... 10-12

Exploded Views............................................................... 7-2

SDI-97B ...................................................................... 10-13

Electrical Parts List ......................................................... 7-6

SY-364 ......................................................................... 10-14

Supplied Accessories ..................................................... 7-79

VIF-39 ......................................................................... 10-18

Optional Fixtures ........................................................... 7-79

Input Signals (BNC)

Analog composite signals: 1.0 V p-p, 75 Z

Analog composite signals: 1.0 V p-p, 75 Z

Output Signals (BNC)

HD SDI: SMPTE 292M, 0.8 V p-p, 75 Z, 1.485 Gbps/1.4835 Gbps

HD: BTA-S001A, tri-level sync, 0.6 V p-p, 75 Z

0.714 V p-p, 75 Z (NTSC)