You are on page 1of 7

An introduction to collecting 20 mm cannon cartridges

Anthony G Williams

This article first appeared in The Cartridge Researcher, the monthly bulletin of the European Cartridge
Research Association, in January and February 2007
The 20 mm automatic cannon first saw service during World War 1 but achieved its peak of success in
World War 2, mainly as an aircraft and short-range anti-aircraft weapon, but also in some light armoured
vehicles and small naval craft. Since the 1950s the popularity of this calibre has declined, as it has been
replaced in most of its roles either by larger-calibre cannon or by guided missiles. However, 20 mm cannon
continue to equip US fighter planes, remain popular for the short-range defence of warships and have
found new roles in arming helicopters.
A wide range of different cartridges was developed for 20 mm cannon, varying greatly in size and power.
Only one saw service in WW1, but by WW2 some seventeen different rounds were in use; no less than five
of them in Japan and four in Germany.
Many of these disappeared soon after WW2, and today only four cartridges from that period remain in
production. However, another four were introduced in the 1950s and these also remain in service today.
This basic guide is concerned only with identifying, and providing some brief historical notes about, those
cartridges which have seen service in the armed forces of at least one country. All of them have been
made in different loadings in some cases, in a very wide variety of them so there is plenty of scope for
collectors. There are also some experimental rounds to search for, but these are much less common.
When collecting cannon ammunition it is of course necessary to ensure that you comply with the laws of
your country. Projectiles containing explosives are banned in almost all circumstances, and there may also
be restrictions concerning those with incendiary or tracer elements. The great majority of rounds which
become available to collectors have inert projectiles and most also have the propellant removed, but it is
advisable to check this. Projectiles are usually very firmly crimped into the cases, so rather than risk
damaging the case necks it is common practice to drill a hole in the side of the case to remove the
propellant. However, this process carries some risk and safety precautions are required, so do not attempt
it unless you know what you are doing.

20x70RB
An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
1 of 7 21/02/2013 22:36
This is the "granddad" of all 20 mm cannon cartridges, being used in the German Becker, developed during
WW1. About 360 guns had been delivered by the end of the war, with about a third of them fitted to aircraft
and the rest issued to troops for anti-aircraft and anti-tank purposes. As well as the solid AP shot shown,
an HE shell with a very prominent plunger-type nose fuze may be found.
A very similar cartridge is often confused with the Becker; this is for the German Ehrhardt, which entered
production by the end of WW1 but did not make it into service. It has a slightly wider case (see item
494-17).

20x72RB
After WW1 the development of the Becker was continued, first by SEMAG of Switzerland and, at the end of
the 1920s, by Oerlikon. The cartridge case was slightly enlarged and used in Oerlikon's Type F, or FF,
which saw service in various air forces during the 1930s. The gun was most famous for its adoption by the
Japanese Navy air force under the designation 20mm Type 99-1. Among other planes, this equipped the
initial marks of the Mitsubishi A6M "Zero" fighter.
20x80RB
The German Luftwaffe decided in the late 1930s to adopt a light cannon to equip its fighters and selected
the Oerlikon FF, which they made under licence as the MG-FF. However, they made some changes to the
gun and ammunition, including lengthening the cartridge case. During 1940 they introduced the
"Minengeschoss" (mine shell), which was made by drawing the projectile body in the same way as a
cartridge case rather than drilling a cavity for explosives. This enabled very thin projectile walls to be made,
doubling their HE/I capacity while also reducing their weight. The recoil characteristics were different,
causing the gun to be modified and subsequently given the designation "MG-FFM"

20x82
The Lufwaffe only adopted the MG-FF as an interim measure while a more effective gun was being
developed. This emerged in late 1940 as the Mauser MG 151 in 15x96 calibre. However, the advantages
of the high-capacity M-geschoss shell were soon realised, so the cartridge case was necked out and
shortened to take the same shells as the MG-FFM. The gun designation was changed to MG 151/20, and
this remained the Luftwaffe's standard aircraft cannon from 1941 to the end of WW2. It was also used by
France (latterly as a helicopter gun) until at least the 1970s. It was unusual in being offered with two
different priming systems: electric (for synchronised guns) and percussion. The yellow with green band
colouring on the projectile shown (and that of the 20x80RB) indicate an HE shell with a self-destruct fuze,
as typically used for home defence.

20x94
This cartridge was developed during WW2 for the Japanese Army air force's Ho-5 cannon, also known as
the 20mm Type 2. The gun was based on a slightly enlarged Browning M2. As designed, it offered an
impressive combination of high performance and light weight, but the lack of high-quality steels for
gun-making meant that the ammunition had to be significantly downloaded to reduce the stress on the gun
mechanism. Despite this, the Ho-5 was the Army's standard aircraft cannon at the end of WW2.

20x99R
This cartridge was developed in the late 1930s for the Soviet ShVAK aircraft cannon. In fact, the gun was
first produced in 12.7x107R calibre, using a rimmed case which was quite different from the later (and still
current) 12.7x108. However, that saw very little use, the cartridge soon being necked out to 20 mm calibre.

The gun had a good rate of fire, but the performance of the cartridge was not impressive, as the light shells
held little HE.As well as being extensively used in Soviet aircraft during WW2, the gun was also fitted to
some light tanks. At the end of the war, the Berezin B-20 appeared, a lighter gun chambered for the same
An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
2 of 7 21/02/2013 22:36
cartridge. The cartridge has survived to this day because it is used in sub-calibre training devices.

20x101RB
When SEMAG took over the development of the Becker, they also introduced a more powerful version
using a longer-cased 20x100RB cartridge. Oerlikon continued its developed as the Type L (later the FFL).
This saw very limited use, except for its adoption by the Japanese Navy air force as the Type 99-2, with a
fractionally longer cartridge case. This supplemented the smaller Type 99-1, replacing it in service in later
marks of the A6M Zero, and was the Navy's standard aircraft cannon at the end of WW2.

20x105B
This cartridge was developed in the interwar years by Solothurn, a Swiss company closely associated with
Rheinmetall (Germany being banned from developing certain armaments by the Treaty of Versailles). As it
is the smaller of the two 20 mm rounds developed by Solothurn it is commonly known as the "Short
Solothurn". It was developed in conjunction with the Lb 204 aircraft cannon, which saw little if any use, but
saw service in various armies in the Solothurn S18-100 series anti-tank rifles. It is therefore generally found
loaded with AP projectiles, of which there are various types. Rather bizarrely, one variant (the S18-350)
was used as an aircraft gun by the Dutch air force, despite offering only semi-automatic fire. 20x105
This Rheinmetall-Borsig development was the successor to the 20x105B, the change apparently being
made to improve the reliability of ammunition feeding. It was used in the MG 204 aircraft gun of the late
1930s, which saw only very limited service in some Luftwaffe seaplanes.

20x110RB
After Oerlikon took over the development of the SEMAG guns in the late 1920s, they developed an even
larger version of the gun around this cartridge. It was known as the Oerlikon Type S (or FFS in its aircraft
version) and is probably the mostly widely used 20mm cannon ever made. As an aircraft gun it saw only
limited use with the French air force in the 1930s, but it was adopted by the RN and USN and became their
standard light AA gun in WW2. It lasted in RN service certainly until the late 1980s if not later, and remains
in use around the world to this day.

20x110
This cartridge was developed in France in the mid-1930s for use in the Hispano-Suiza HS 404 aircraft gun.
It is similar to the 20x110RB described above, except that the rim is the same diameter as the body and the
shoulder is sharper. The gun was adopted by the RAF as the 20mm Hispano, remaining in service until
replaced by the 30mm Aden in the mid-1950s, and was also used by US aircraft in and after WW2. The
last version of the USAF's gun, the M24, had electric rather than percussion priming. This gun and the
postwar HS 804 have been widely used as aircraft and AA guns, and the ammunition remains in
production. The cartridge was also used in the postwar Bofors m/45 and m/49 aircraft guns. The third
photo shows a postwar Swiss API round.

An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
3 of 7 21/02/2013 22:36

20x113
This rivals the 20x105 as being one of the least-used cannon rounds. It was developed in Finland in the
mid-1930s by Aimo Lahti for his L-34 "boat gun"; a light automatic cannon fitted to about a dozen patrol
boats. Various experimental versions were developed, and belted cases may also be found.

20x120
This cartridge was developed in Denmark in the 1920s for the Madsen automatic cannon, offered in
various mountings for aircraft, AA and anti-tank use, although only successful in the AA role. It was never
the primary armament of any major army, but was widely used in WW2 and remained in service for
decades afterwards. The ammunition for the gun was made in several countries, mostly notably in the UK
by Kynoch, as was usually the case for Madsen ammunition as they had no ammunition production
facilities of their own.

20x125
This Japanese Army cartridge was first used in the Type 97 anti-tank rifle introduced in the late 1930s, but
during WW2 the mechanism of this semi-automatic gun was adapted to create an automatic aircraft
cannon. This saw limited use in two versions; the Ho-1 for flexible mountings and the Ho-3 for fixed use.
The guns were too slow-firing to be considered successful and were replaced by the Ho-5, which was
lighter and had twice the rate of fire.

20x138B
This was the second of the 20mm cannon cartridges developed by Solothurn in the 1930s, and is known
as the "Long Solothurn" round. It proved far more successful than the 20x105B, being primarily used in the
highly successful FlaK 30 and 38 AA guns which were extensively used by German forces in WW2 (and
remained in service in some nations for decades after the war). It was also used in the KwK 30 and 38 light
AFV guns, and in the Solothurn S18-1000 series anti-tank rifles.
As well as being used in these German and Swiss weapons, it was used in the Finnish Lahti L39 anti-tank
rifle and L40 AA gun, and in the Italian Breda M35 and Scotti cannon. A very wide range of ammunition
was developed for this gun, including M-geschoss shells and Pzgr 40 tungsten-cored AP.

An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
4 of 7 21/02/2013 22:36
20x139 FMK
This was developed in Switzerland in the late 1930s for the FMK aircraft gun (which saw limited use) and
the Flab Kan 38 AA gun, which remained in use for some time after the war. This cartridge is very similar to
the postwar 20x139 cartridge for the Hispano-Suiza Hs 820, but the rim is thinner and the cases of brass.
The example shown here is a drill round.

20x142
This was the ammunition used for the Japanese Army's Type 98, their standard light AA gun from the late
1930s to the end of WW2. This powerful round was also credited with some anti-tank capability and so
came with AP as well as HE projectiles. There was an earlier Type 94 AA gun which used even larger
(20x158) ammunition, but this saw very little use before being replaced by the Type 98.

20x145R
This was a Bofors development for their m/40 AA and anti-tank gun. It was in effect a scaled-down version
of their famous 40 mm, but did not achieve anywhere near the same success and the cartridges are now
uncommon. This case is fitted with a non-standard dummy projectile.


20x102
This American cartridge is probably the most widely used 20mm round in service today, due to the fact that
it is chambered in the M61 (Vulcan) "gatling" rotary cannon fitted to US fighters, the naval Phalanx close-in
weapon system, and some AA vehicles. It is also chambered in the US M39 revolver cannon (as fitted to
many 1950s USAF fighters, and still used in the F-5), the current French GIAT 20M621, and the Czech
ZPL-20, a version of the Russian 23mm GSh-23 twin-barrel aircraft gun rechambered for the NATO round.
The history of this cartridge goes back to WW2 when a very powerful .60 inch anti-tank rifle was
developed. This never saw service but the 15.2x114 ammunition was used in various experimental aircraft
guns developed during WW2, notably the T17 which was a modified Mauser MG 151. After the war the .60
cartridge remained the USAAF's preferred basis for new aircraft guns, and the first versions of what
became the M39 and the M61 were chambered for it. However, the advantages of explosive shells were
finally accepted by the USAF and the case was necked out to 20mm and slightly shortened to keep the
overall length the same. Many different loadings in several countries have been developed for this round,
including APDS (for the Phalanx). The original USAF ammunition was the M50 series; this was largely
An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
5 of 7 21/02/2013 22:36
replaced by the more streamlined, multi-purpose PGU-28/B from the late 1980s, but the older rounds have
been reinstated because of concerns over premature explosions in the barrel. All versions of the 20x102
use electric priming.
20x110 USN
The USN did not initially share the USAAF/USAF's interest in new revolver and rotary guns. Instead, they
improved the performance of the Hispano by speeding up its rate of fire and rechambering it for a powerful
new round, the 20x110 USN. This was developed by taking the base dimensions of the 20x102, but
stretching the case length to the maximum which the Hispano could handle. It hardly seemed worth the
effort as the performance is only marginally better than the 20x102. Like its smaller brother, it uses electric
priming. The modified Hispano was designated the Mk 12 and was the USN's standard aircraft cannon
from the mid 1950s until the 1970s when it was finally replaced by the M61. As well as the Mk 12, the new
round was chambered in a remarkable gun, the Mk 11. This is a twin-barrel eight-chamber revolver with a
mixture of recoil and gas operation and with partly smoothbored barrels. It was used only in the Mk 4
gunpod. This round remains in production but is steadily going out of use as the planes which carry the
guns are retired, and it is likely to become obsolete soon.
20x128
This is one of the two European 20mm rounds to have been introduced since WW2. It was developed by
Oerlikon in the 1950s for their KAA cannon, intended as a successor to the famous 20mm Type S. The
cartridge is far more powerful, and the gun fires twice as fast. It has not matched the level of success of the
older Oerlikon, although it has achieved numerous sales, primarily as a naval AA gun. It was rapidly
adopted by the RN, after the Falklands War revealed the inadequacy of close-in defence guns, in the
GAM-B01 mounting. The cartridge has also been adopted, in electric rather than percussion-primed form,
for the unusual Spanish Meroka volley gun, used as a naval close-in weapon system.
20x139
This is the other postwar European 20mm round, and a close rival for the 20x128. It was originally
introduced by Hispano-Suiza in the 1950s for their HS 820 cannon, which they saw as the natural
successor to the HS 804. Hispano-Suiza was taken over by Oerlikon in about 1970, after which the HS 820
was renamed the Oerlikon KAD. The cartridge has been more successful than the 20x128, mainly because
of its use in the popular Rheinmetall Rh 202 cannon. It is also chambered in the GIAT F2 / 20M693, which
is made in South Africa as the Vektor G1-2. These guns have seen various uses, as naval and land-based
AA, light AFV armament and in helicopters.
20x83.5
This little cartridge is in fact a slightly modified version of the 20x82, and is interchangeable with it. It is
made in South Africa, where the Mauser MG 151/20 cannon is still in production as the Vektor GA-1. The
light weight, small size and low recoil of this gun make it popular for fitting to light vehicles and small
helicopters. The cartridge is also chambered in the Mechem NTW-20 anti-materiel rifle.

METRIC
CALIBRE
RIM
DIAM.
MM
BODY
DIAM.
MM
PROJ.
TYPE/
WEIGHT GM
M.VEL.
M/SEC
MUZZLE
ENERGY
JOULES
NAME /
WEAPONS CHAMBERED IN
20x70RB 20.2 21.9 AP/130 490 15,600 Becker aircraft, early Oerlikon F
20x72RB 19.0 21.9
HE/128 550-600 19-23,000 Oerlikon FF, Japanese Navy Type 99-1,
Oerlikon SSG (550 m/s)
20x80RB

19.0 22.0
HE/134
HEI/115
HE/92
600
585
700
24,100
19,700
22,500
MG-FF aircraft
MG-FFM aircraft
M-Geschoss
20x82 25.2 25.2
HE/115
HE(M)/92
HE/111
710
800
720
29,000
29,400
28,800
Mauser MG 151/20 (electric or percussion);
HE(M) = M-Geschoss
- Vektor GA-1, Mechem NTW-20 rifle (SA)
An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
6 of 7 21/02/2013 22:36
20x94 24.9 25.0
HEI/79
APT/120
730
700
21,000
29,400
IJA 20mm Type 1 (Ho-5) aircraft (these are
final loadings; earlier ones were c. 820 m/s,
33,300 j)
20x99R 25.2 21.8
HE/97 860 35,900 ShVAK, B-20 aircraft (+ subcalibre training),
Helenius rifle
20x101RB 19.0 21.9
HE/127
HE/128
675
750
28,900
36,000
Oerlikon L (675 m/s)/FFL (100mm case
length); IJN Type 99-2
20x102 29.5 29.1
HE/101
APDS/100
1,030
1,100
53,600
60,500
M39, M61 (Vulcan), M197, GIAT M 621,
Ford Tigerclaws, (APDS is M149 Phalanx
round). Electric primed.
20x105B 25.0 25.0
AP/140 730 37,300 Solothurn (Short): S18-100 ATR & S18-350
aircraft, Lb 204
20x105 25 26.2 HE/134 750 37,700 MG 204 aircraft
20x110RB 21.9 24.9
HE/122 830 42,000 Oerlikon FFS + S series, Polsten AA,
SSG-36 ATR (750 m/s)
20x110

24.8 24.8
HE/130
"
HE/102
880
850
945
50,300
46,900
45,500
HS404/804; AN/M2+M3 (US), m/45+49 (S),
M1955 (YU), G 360 (IS), RT20 rifle
(Croatia).
850 m/s = UK Mark V (short barrel)
945 m/s = US M24 (electric primed),
20x110 USN 29.5 29.3
110 1010 56,100 Mark 11 + Mark 12 aircraft.
(Mk 100 series ammunition - electric)
20x113 28.0 28.0
136 800 43,500 20mm Lahti L34 naval (exp. belted version
also)
20x120 28.9 29.0
AP/154
HE/126-112
780
840-890
46,800
44,400
20mm Madsen AA/AT/aircraft
20x125 28.5 28.7
AP/162
HEI/127
790
820
50,500
42,700
IJA 20mm Type 97 AT rifle
IJA 20mm Ho-1, Ho-3 aircraft
20x128 32.0 32.3
HE/120
APCR/102
1,050
1,300
66,100
86,200
Oerlikon KAA, KAB (+ 50m/s for KAB).
APCR (electric) = Meroka CIWS
20x138B 27.0 27.0
HE/119
AP/147
AP/101
HE/134
900
795
975
950
47,000
46,500
48,000
60,500
Solothurn (Long): Flak 30+38 AA, KwK
30+38 AFV, MG C/30 L air, Breda M 35,
Scotti + Lahti L40 AA, S18-1000/1100 and
Lahti ATRs. 134g load = MG C/30 L
20x139 FMK 28.5 28.5
HE/131
AP/147
1,010
930
66,800
63,800
WW2 FMK aircraft and WW2+postwar
Flab Kan 38 AA. (Rim 2.6mm thick)
20x139

28.5 28.5
HE/120
APDS/108
1,100
1,250
72,600
84,400
HS 820/Oerlikon KAD (US M139),
Rheinmetall Rh 202, GIAT M 693, Mauser
MK20, HS 827 exp.
(Rim 3.5mm thick)
20x142 33.4 33.5 HET/132 950 59,600 IJA 20mm Type 98 AA
20x145R 29.5 25.4
AP/145 815 48,200 20mm Bofors m/40 AA/AT (+ subcalibre
training)

HOME
An introduction to collecting 20 mm cannon cartridges The 20 mm au... http://www.quarry.nildram.co.uk/an_introduction_to_collecting_20.htm
7 of 7 21/02/2013 22:36

You might also like