You are on page 1of 5

Electrical Projects List Contact No.

: 07620572223
07620572224

1
Email: info@eewtech.in Visit: www.eewtech.in

23,Besides Vishwas Highschool , Shrikrushna Nagar Square, New Nandanvan, Nagpur-440009

All Topic Based On Students Innovative Ideas
EWKC13
High-efficiency power converters for domestic induction heating applications

EE001GG
Remote Monitoring Of Power Frequency Electrical Signals Employing GSM Network

EEC01
Auto Selection Of Any Available Phase, In 3 Phase Supply System
EEC02
Automatic Star Delta Starter Using Relays And Adjustable Electronic Timer For Induction
Motor
EEC03
Electronic Soft Start Of 3 Phase Induction Motor
EEC04 Four Quadrant Dc Motor Control Without Microcontroller
EEC05
High Voltage Dc Up to 3kv From Ac By Using Diode And Capacitors In Ladder Network
EEC06
Induction Motor Protection System
EEC07
Over Voltage Or Under Voltage Tripping Mechanism
EEC08
Phase Sequence Checker For Three Phase Supply

EEC09
PVG Based Smart Energy Modeling For Agricultural
Sector

EEC10
Three Phase Fault Analysis With Auto Reset On Temporary Fault And Permanent Trip
Otherwise
EEC11
Time Delay Based Relay Operated Load
EEC12
Using TV Remote As A Cordless Mouse For The Computer Using PIC Mc
EEC13
Voice Enabled Speed Control Of Single Phase Induction Motor

EWKS8 Wind power integration and operation in an AC/DC hybrid transmission system of
Shandong province

EWKS2 Temperature Control of Thermoelectric Cooler Based on Adaptive NN-PID

EWKS13 Development of model system for cost-effective Pico-hydro turbine

EWKS11
Foot step power generation system for rural energy application to run AC and DC loads

EWYT26 Application of super capacitor energy storage in micro grid system

EWYT27 Optimization of battery energy storage system with super-capacitor for renewable energy
Electrical Projects List Contact No. : 07620572223
07620572224

2
Email: info@eewtech.in Visit: www.eewtech.in

23,Besides Vishwas Highschool , Shrikrushna Nagar Square, New Nandanvan, Nagpur-440009

applications

EWKS2
Medicine Refrigeration for rural and flood affected areas Fast chilling solar based
refrigerator with dual mode battery charging for preserving medicines

EWYT28 A management strategy for solar panel battery super capacitor hybrid energy system
in solar car

EWYT29 A stand alone super capacitor charging system using a feed forward boost converter

EWYT30 Analysis and Design of a Bidirectional Isolated DC-DC Converter for Fuel Cell and Super-
Capacitor Hybrid System

EWK406
Design of an Intelligent SMS based Remote electricity Metering and billing System. A
Scheme for the Application of Smart Message Language in a Wireless Meter Reading
System

EARM21
Real-time atomization of agricultural environment for social modernization of Indian
agricultural system

EWK801 AC motor speed control using power TRIAC with display unit

EWK802 Three Phase Load safety implementation with phase fault detector

EWK803 TRIAC based Sound Scanner for Audio Controlled Lamps

EWK804
Servo controlled voltage stabilizer with higher and lower cut off

EWK808
Automatic Power factor corrector using capacitive load banks

EWKR16
RF Based farmer friendly Agricultural Robot with motorized shovel control System with
automatic seed dispensing system

EWKR17
Automatic Intelligent Industrial Object sorter with conveyor belt arrangement for color
distinguishing and object count applications

EWYT35
Wireless Mobile Charger based on induction effect principle with antitheft protection
system (Wireless power transformation)

EWYT38
Auto speed control of solar car at specified locations like school zones / hospitals /
residential areas

EWKR18
Pole climbing Robot for surveillance application with voice and image recording in SD
card / Memory card

Electrical Projects List Contact No. : 07620572223
07620572224

3
Email: info@eewtech.in Visit: www.eewtech.in

23,Besides Vishwas Highschool , Shrikrushna Nagar Square, New Nandanvan, Nagpur-440009

EWYT42
Intelligent helmet cop with alcohol detection to disable the engine ignition on detection of
Alcoholic breath of the driver with audio alert system
EWKC7
Implementation of model Radar target direction identifier with remote station alert system

EWKC8
Music transmission and reception with high S/N ratio using fiber optic communication

EWKS8
Aerodynamic wind mill with reverse charge protection for rural power generation
applications with battery voltage analyzers using AT89S52 MCU.

EWKS10
Solar based E-Uniform for soldiers who work at extreme high temperature or extreme low
temperature(same uniform can be used to warm up or cool down body temp)

EWKS13
Microhydel power generation system from building roof rain water flow to power AC / DC
loads with battery reverse charge protection.

EWK203
Petrochemical Level Indicator and Controller for Automation of cotton purification process
in spinning mills using 89S52 MCU

EWK204
Super sensitive Industrial Security System with Auto dialer and 60dB loud siren

EWK222
EEPROM Based Prepaid energy meter with auto cut off on no balance

EWK234
Design and implementation of maximum power tracking system by automatic control of
solar panel direction according to the sun direction (Model Sunflower)

EWK229
Automatic Active Phase selector for single phase load from three phase supply

EWK804
Servo controlled voltage stabilizer with higher and lower cut off

EWK808
Automatic Power factor corrector using capacitive load banks

EWKC14
Advanced user controlled roof top antenna signal tracking system using AT89S52 MCU
and 10RPM geared DC motor

EWKS3
Solar based air compressor pump for car bike tire inflate

EWKS4
Solar based high efficient vacuum cleaner capable of capturing even 40 microns small
dust

EWKS5
Implementation of Solar inverter for home / garden / street light applications

EWKS6
Real Time Clock based solar LED street light automation using Dallas RTC and I2C
protocol
Electrical Projects List Contact No. : 07620572223
07620572224

4
Email: info@eewtech.in Visit: www.eewtech.in

23,Besides Vishwas Highschool , Shrikrushna Nagar Square, New Nandanvan, Nagpur-440009

EWKS9
Next generation alternative energy storage application with super capacitors / ultra
capacitors with voltage analyzers using AT89S52 MCU.
EWKS12
Hand cranked dynamo based energy generation system for emergency headlamp
applications for mining workers and engineers who work under ground and dark
conditions

EWKS14
Farmer friendly Solar based electric fence for rural agriculture with battery voltage
analyzer using AT89S52 MCU

EWK306
Wireless Electrical Apparatus Control System with Speed Control of AC motor in a plant
using RF communication

EWK307
Wireless DC Motor speed and direction Control using RF communication

EWK309
Wireless stepper motor control using RF communication

EWK312
Wireless DC Motor Speed and Direction Control using IR (PWM and H-Bridge)

EWK313
Wireless Electrical Apparatus Control System using IR communication



MATLAB Simulations/Control System/Power electronics

EMAT1
A novel three-phase to five-phase transformation using a special transformer connection

EMAT2
Super capacitors and battery power management for hybrid vehicle applications using multi
boost and full bridge converters

EMAT3
Direct torque control for doubly fed induction machine-based wind turbines under voltage
dips and without crowbar protection

EMAT4
Implementation and control of an hybrid multilevel converter with floating dc-links for
current waveform improvement

EMAT5
A facts device: distributed power-flow controller (DPFC)

EMAT6
Ripple current reduction of a fuel cell for a single-phase isolated converter using a dc active
filter with a center tap

Electrical Projects List Contact No. : 07620572223
07620572224

5
Email: info@eewtech.in Visit: www.eewtech.in

23,Besides Vishwas Highschool , Shrikrushna Nagar Square, New Nandanvan, Nagpur-440009

EMAT7 Enhancement of power quality in distribution system using D-STATCOM
EMAT8
Power-management strategies for a grid-connected PV-FC hybrid system

EMAT9
Wind farm to weak-grid connection using UPQC custom power device

EMAT10
Single-phase to three-phase drive system using two parallel single-phase rectifiers

EMAT11
Enhancement of micro turbine-generator Output voltage quality through application of
matrix converter interface

EMAT12
A fuzzy rule-based approach for islanding detection in distributed generation

EMAT13
A new 84-pulse VSC configuration using multi-level dc voltage reinjection for especial
applications

EMAT14
Design of a hybrid PID plus fuzzy controller for speed control of induction motors

EMAT15
An inrush mitigation technique of load transformers for the series voltage sag compensator

EMAT16
A 28 pulse ac-dc converter based SMPS for telecom power supply

EMAT17
Novel direct torque control based on space vector modulation with adaptive stator flux
observer for induction motor

EMAT18
A voltage controlled adjustable speed PMBLDCM Drive using a single-stage PFC half-
bridge converter

EMAT19
A High efficiency AC/DC Converter With Quasi Active Power Factor Correction

EMAT20
An integrated Four Port DC/DC Converter for Renewable Energy Application

You might also like