Professional Documents
Culture Documents
CNFE6+2USPOE
10/100TX Drop/Insert/Repeat
6TX/2FX Ethernet Switch with PoE
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 1
CNFE6+2USPOE
CNFE6+2USPOE
Up layer switch with
1Gbps enabled
Fiber
Insert
48VDC in
...
...
...
...
Ethernet
... 5
Fiber
10/100TX
2
3
4
5
6
7
8
PoE
PC
Ethernet
48VDC in
10/100TX
...
...
...
PoE
2
3
4
5
6
7
8
CNFE6+2USPOE
Fiber
... 6
Insert
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 2
CNFE6+2USPOE
FIGURE 2 CNFE6+2USPOE
OPTICAL
FIBER
RJ-45
RJ-45
RJ-45
BLACK
BLACK WITH WHITE STRIPE
RJ-45
FIGURE 3 CNFE6+2USPOE
FRONT PANEL
REAR PANEL
EFFECT
PORT
Uplink
DIAGNOSTIC
ON
ON
ON
OFF
OFF
ON
OFF
OFF
NOTE: Remove
Electrical Connector for
Rack Mount Units
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 3
CNFE6+2USPOE
LINK (PORT 3 8)
POE (PORT 3 8)
POWER
SOLID
Link Up
Link Up
Power Suppled to PD
Power Applied
BLINKING
Data Activity
Data Activity
POE Negotiating
OFF
No Data Link
No Data Link
No Power Supplied
CNGE2FE24MODMS
P1
CNFE6+2USPOE
P1
CNFE6+2USPOE
P2
P1
CNFE6+2USPOE
PC Connections
on Ports 38
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 4
CNFE6+2USPOE
CNGE2FE24MODMS
P1
P1
CNFE6+2USPOE
P2
P1
Camera
Connections
Providing PoE
on Ports 38
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 5
Figure A
Dimensions are for a standard ComNet two slot module
2. Tighten the two thumb screws on the card until the front panel of the
card is seated against the front of the rack.
WARNING: Unit is to be used with a Listed Class 2 or LPS power supply.
IMPORTANT SAFEGUARDS:
A) Elevated Operating Ambient - If installed in a closed or multi-unit rack
assembly, the operating ambient temperature of the rack environment may
be greater than room ambient. Therefore, consideration should be given to
installing the equipment in an environment compatible with the maximum
ambient temperature (Tma) specified by the manufacturer.
B) Reduced Air Flow - Installation of the equipment in a rack should be such
that the amount of air flow required for safe operation of the equipment is not
compromised.
INS_CNFE6+2USPOE_REV
07/08/11
PAGE 6