R.H.Sapat College of Enfineering Studies, Management & Research- Nashik05
Subject- Basic Civil & Environmental Engineering Time - 30 minutes Unit Test Number - 1 Total Marks - 30 Name of Student: Roll No.: 1. The bed profile of river, nala or lake is studied in__________surveying a. City Surveying b. Hydrological Surveying C c. Hydrographic Surveying d. Topographic Surveying 2. A (G+25) storied building is to be constructed. Which type of the structure will you allow? a. Load Bearing b. Composite C c. Frame d. Compound 3. Optimal use of various resources for proper planning of various activities is ensured in a. Construction Engineering b. Surveying D c. Town Planning d. Project Management 4. __________ has lower design specifications than Major District Roads a. National highways b. State Highways D c. Major District Roads d. Other District Roads 5. Distribution of water stored in the dam is done by constructing a. Water tank b. Spillway C c. Canal d. Road 6. The geometric design specifications and design speed for__________is same. a. National highways & Village Roads b. State Highways & Village Roads D c. State Highways & Major District Roads d. National Highways & State Highways 7. In_________behaviour of fluids is studied at the motion with considering pressure forces. a. Fluid Dynamics b. Fluid Kinematics A c. Fluid Kinetics d. Fluid Statics 8. What is the width of narrow gauge? a. 0.500m b. 1.000m D c. 1.676m d. 0.765m 9. Initial cost of rigid pavement is__________is that of flexible pavement. a. More than b. Less than A c. Same as d. None of these 10. Stability analysis of the soil is studied in a. Foundation Engineering b. Engineering Geology C c. Geotechnical Engineering d. Water Source Engineering 11. Presence of water table__________ultimate bearing capacity. a. Increases b. Decreases B c. Sometimes(a), Sometimes(b) d. Can't Say 12. Valuation of property is required for a. Finding out probable cost of construction b. Finding out actual cost of project C c. Buying or Selling property d. Preparing tender documents 13. Zoning and land reservations are studied in a. Earthquake Engineering b. Town Planning B c. Surveying d. Environmental Engineering 14. Scrap value is about__________of its total coat of construction. a. 10% b. 20% A c. 30% d. 40%
15. Remote sensing is a modern technique of__________
a. Surveying b. Landscaping A c. Irrigation d. Town planning 16. The feeling of hand when immersed in cement should be a. Cool b. Warm A c. Hot d. Very Hot 17. The standard size of brick is________cm. a. 9 x 9 x 20 b. 9 x 9 x 9 D c. 19 x 19 x 19 d. 19 x 9 x 9 18. Low Heat Cement is used in construction of a. Dam b. Pipes A c. Residential Building d. Brick Masonary 19. P.C.C. is weak in_________ a. Tension b. Compression A c. Bending d. Torsion 20. Compressive strength of M30 concrete is_________ a. 10 N/mm2 b. 20 N/mm2 C c. 30 N/mm2 d. 40 N/mm2 21. Safe bearing capacity of soil = 200 kN/m2, Factor of safety = 1.5, then what is the value of ultimate bearing capacity? a. 300 kN/m2 b. 450 kN/m2 A c. 133.33 kN/m2 d. 150 kN/m2 22. Commonly available grades of steel in civil engineering are a. Fe250, Fe415, Fe500 b. Fe250, Fe415, Fe550 A c. Fe250, Fe450, Fe500 d. Fe250, Fe415, Fe515 23. The rock formed by cooling the molten lava is known as a. Sedimentary rocks b. Igneous rocks B c. Metamorphic rocks d. None of these 24. The process of removing sharp corners of stone if requires is known as a. Chiseling b. Polishing C c. Dressing d. Curing 25. A small depression is provided on the top of brick is known as a. Mouse b. Frog B c. Stretcher d. Header 26. The correct use of building material is leads to a. Strength b. Efficiency D c. Economy d. All of above 27. In which type of concrete, compressive stresses are induced before subjecting it to the loading a. Reinforced cement concrete b. Plain cement concrete C c. Pre stressed concrete d. Lime concrete 28. What is the value of bearing capacity for black cotton soil as per I.S.1904-1961 a. 250 kN/m2 b. 200 kN/m2 C c. 150 kN/m2 d. 100 kN/m2 29. For sloping roofs with slope greater than 10 degree, a minimum live load of_________is considered a. 1.5 kN/m1 b. 2 kN/m2 D c. 3.5 kN/m2 d. 4 kN/m2 30. Withdrawl of moisture from soil will result in a. Twisting of soil b. Tensile stresses of soil C c. Settlement of soil d. All of above