Professional Documents
Culture Documents
Kelas : EK 2C
Making 2 Instruction
AN ADMINISTRATOR and then APPLY & OK. Now click on UPDATE and
when update is complete click on CLOSE.
Now again cut the folder named as LABCENTER ELECTRONICSwhich you
pasted in PROGRAM FILES and again paste it toPROGRAM FILES
X86 in C-drive only.
So the only change is just cut copy paste and rest is same as for 32bit Operating System.
NOW run your PROTEUS shortcut icon and enjoy your simulator for
various pcb design & simulation design purposes.
1.
2.
3.
4.
5.
Now Your Copper Clad Board Is Ready For Toner Transfer (Toner Onto The
Board) .
Step 3: Toner Transfer (Transfer Of Toner Onto The Board)
For The Toner Transfer:
1. Heat The iron to its Maximum Setting.
2. Cut The Design And Place It Upside-Down On The Board And Make Sure
That It Is Completely on the Board.
3. Slowly Move And Press the Iron On The Board with Pressure For 20-25
Minutes.
Step 4: Washing The Board And Completely Removing the Paper
After Heating, Wash The Board With Water Till the Paper Completely Gets
Removed, Now Only Black Lines Are Left on the Board. DO NOT REMOVE
THOSE LINES. After That IF There Are Any Non Transferred Lines Then Grab A
Permanent marker And Draw The Lines.
Step 5: The Etching Method
For The Etching Method :1. Boil Approx. 500 ml Of Water In A Utensil For 15-20 Minutes. The Hotter
The Water is, The Less Time The Etching Method Will Take.
2. Pour Ferric Chloride In The Small Container.
3. Now, Pour The Boiling Water In Ferric Chloride. (The Hotter The Water
is, The Less Time The Etching Method Will Take) (Do Not Completely Fill
the Container)
4. Also Pour the Boiling Water In The Big Container (Again, Do Not
Completely Fill It)
5. Now Put The Small Container In The Big Container, After Doing That Put
The Board In The Small Container
6. Keep Checking That The Copper Is Removed Or Not.
Hold The Board With Tweezers(Not With Hands Like I Am Doing, As It Is
A Chemical).
2.a
2.b.
3.
4.
5.
5.a.
1.
2.
3.
4.
5.
6.
8.
7.
9.