You are on page 1of 1

9.0) Grounding Stud: A 0.625 in (16 mm) stud shall be welded to the external container.

Stud shall
not extend beyond corner posts.
10.0) Wall Studs: The container shall be provided with 2 in x 2 in x 0.125 in (40 mm x 40 mm x
3mm) Carbon steel angle welded on end every 48 in (406 mm) on center (1 in x 1.5 in x 3 in
[26mm x 38mm x 77mm], 16 Gauge Channel to be used if Nudo Panel is installed).
11.0) Wall and ceiling lining: Fiberglass reinforced plastic panels; Sequentia, Inc. #1200
Structoglass Standard, textured one side, 0.125 (3mm) thick. One continuous sheet (no
seams) and/or 4x8 Nudo Panel acceptable to be affixed on each wall and on the ceiling.
Finish/Color: 1130 white. Finish/Color shall be uniform on all panels. All seams at ceiling and
floor to be sealed at all corner edges and around all penetrations using Devcon Plastic Welder
Methacrylate adhesive. Color: White. Part Number: DA291. Use (13mm) thick exterior
plywood panels (minimum CDX grade) as underlayment for the plastic panels on the walls
and ceiling. Foam insulation to be inserted between the interior corrugation cavities before
installation of plywood and plastic panels.
12.0) Floor Finishing: 3003-H22 Continuous Aluminum Diamond Plate, 1/8 (3mm) thick, bright
reflective finish to be applied to the floor and extended up 3.75 (95mm) on all walls. Plate to
be bolted to container floor and seams to be continuously welded. Plate to show no signs of
bowing or buckling after application. All bolt heads, plate edges at door openings, access box
penetrations and where the plate meets the sidewalls to be sealed with Devcon Epoxy Plus 25
epoxy adhesive. Color: White. Rhino or Linex spray on lining acceptable as a substitute.
13.0) Floor Drains: Four floor drains to be installed per Drawing 1308903 (Reference note 4.). Floor
drain to be Oatey 72000 series PVC adjustable general purpose drain with 5 (125mm)
Stainless Steel grate and 3 (75mm) pipe connection. Floors drains and drain grates to be
recessed into the wood and aluminum floor and sealed with Devcon Epoxy Plus 25 epoxy
adhesive. Color: White.
14.0) Electrical Sleeves: (4) circular penetrations on the sides and end of the container. Weld in
316SS threaded couplings and supply brass threaded plugs on the exterior side.
15.0) Exterior Paint and Preparation: The painting vendor shall thoroughly blast clean all exterior
surfaces. The painting vendor shall comply with the requirements of SSPC-SP 10 Near-White
Metal Blast Cleaning to remove all visible oil, grease, dirt, dust, mill scale, rust, paint, oxides,
corrosion products and other foreign matter. A primer coat of 4-5 mils to be applied by the
paint vendor no less than 8 hours after blast cleaning. Paint vendor to apply a finish coat of 5-7
mils Use PSC PS-SI-02-1 color code and Polysiloxane paint for seawater compatibility.
Color: bright white semi gloss.
16.0) Interior Paint: Same as item 15.0, but white (if wood).

1309531-Rev B

You might also like