Professional Documents
Culture Documents
1.
In a parallel resonant circuit, the circuit current at resonance is maximum.
A.
True
B.
False
Answer: Option B
Explanation:
In parallel resonance current is minimum.
View Answer Workspace Report Discuss in Forum
2.
The rms value of wave in figure is
A.
about 95 V
B.
about 80 V
C.
about 50 V
D.
about 25 V
Answer: Option B
Explanation:
A.
has to be increased
B.
has to be decreased
C.
D.
Answer: Option A
Explanation:
For overdamping R is more.
View Answer Workspace Report Discuss in Forum
4.
Henry is equivalent to
A.
Volts/Ampere
B.
Weber/Volt
C.
Weber/Ampere
D.
Weber/Ampere2
Answer: Option C
Explanation:
A.
B.
C.
D.
Answer: Option A
Explanation:
If degrees of numerator and denominator were unequal, a pole or zero can be
removed. Such a function cannot be a minimum function. Therefore degrees of
numerator and denominator must be equal.
6.
When a current source I is suddenly connected across a two terminal relaxed RC circuit at
time t = 0, the voltage across the current source is shown in figure. The RC circuit is
A.
B.
C.
D.
a pure capacitor
Answer: Option C
Explanation:
Initially capacitor behaves as short-circuit and finally as open circuit.
View Answer Workspace Report Discuss in Forum
7.
The driving-point impedance Z(s) of a network has a pole-zero locations as shown in the figure.
If Z(0) = 3, then Z (s) is
A.
B.
C.
D.
Answer & Explanation
Answer: Option B
Explanation:
and Z(0) =
=3
k = 2.
and i(t) is a unit step, then V(t) in the steady state is given by
A.
4/9
B.
4/3
C.
D.
Answer: Option A
Explanation:
= 4/9.
View Answer Workspace Report Discuss in Forum
9.
For a transmission line open circuit and short circuit impedances are 20 and 5 . Then
characteristic impedance is
A.
100
B.
50
C.
25
D.
10
Answer: Option D
Explanation:
Z0 = Zoc Zsc .
View Answer Workspace Report Discuss in Forum
10.
The terms RMS and average values apply only to sine waves.
A.
True
B.
Answer: Option B
Explanation:
These terms are applicable to all waveshapes.
11.
The drift velocity of electrons is
A.
B.
C.
D.
Answer: Option A
Explanation:
Drift velocity of electrons is very small.
False
A.
B.
C.
D.
Answer: Option A
Explanation:
Since peak values are equal, their rms values are equal irrespective of phase difference.
View Answer Workspace Report Discuss in Forum
13.
A.
1/6 F and 4
B.
C.
D.
1/2 F and 1
Answer: Option A
Explanation:
No answer description available for this question. Let us discuss.
View Answer Workspace Report Discuss in Forum
14.
In an R-C series circuit excited by a voltage E, the charge across capacitor at t = 0+ is
A.
B.
CE
C.
CE (1 - e-t/RC)
D.
Answer: Option A
Explanation:
Voltage across a capacitor cannot change instantaneously.
View Answer Workspace Report Discuss in Forum
15.
Two networks are cascaded through an ideal buffer. If td1 and td2 are delay times of network, the
overall delay time is
A.
td1 + td2
B.
t2d1 + t2d2
C.
td1 + td2
D.
Answer & Explanation
Answer: Option C
Explanation:
In cascaded networks delay times are added.
16.
A series RC circuit has R = 5 and C = 10 F. The current in the circuit is 5 sin 20000t. The
applied voltage is
A.
B.
C.
D.
Answer: Option B
Explanation:
Z = R2 + XC2 = 50
V = 550 sin(20000 t - 45)
V = 252 sin(20000 t - 45)
View Answer Workspace Report Discuss in Forum
17.
A capacitor stores 0.15C at 5 V. Its capacitance is
A.
0.75 F
B.
0.75 F
C.
0.03 F
D.
0.03 F
Answer: Option C
Explanation:
Q = CV or 0.15 = C(5) or C = 0.03 F.
View Answer Workspace Report Discuss in Forum
18.
A 0.5 F capacitor is connected across a 10 V battery. After a long time, the circuit current and
voltage across capacitor will be
A.
0.5 A and 0 V
B.
0 A and 10 V
C.
20 A and 5 V
D.
0.05 A and 5 V
Answer: Option B
Explanation:
When the capacitor is fully charged, i = 0 and voltage across capacitor is equal to battery voltage.
View Answer Workspace Report Discuss in Forum
19.
For node 1 in figure, KCL equation is
A.
B.
C.
D.
Answer: Option C
Explanation:
A.
4A
B.
2.5 A
C.
3.1 A
D.
Answer: Option A
Explanation:
A.
2 x 1010
B.
0.5 x 1010
C.
1010
D.
4 x 1010
Answer: Option B
Explanation:
Insulation resistance of cable is inversely proportional to length.
View Answer Workspace Report Discuss in Forum
22.
, i(t) =
A.
3e-4t - e-5t
B.
3e-4t - 2e-3t
C.
2e-4t - 5e-2t
D.
3e-4t - e-t
Answer: Option B
Explanation:
A.
B.
13 A
C.
18
D.
12 A
Answer: Option D
Explanation:
A2 = 132 - 25
12 A.
2.
3.
A.
1, 2 and 3
B.
2 and 3
C.
1 and 3
D.
1 and 2
Answer: Option D
Explanation:
Bott Duffins realisation does not use transformer.
View Answer Workspace Report Discuss in Forum
25.
The synthesis of minimum function was suggested by
A.
O'Brune
B.
R. Richards
C.
D.
Answer: Option A
Explanation:
The procedure is called Brune's synthesis.
26.
C = (2) (energy)/V2
A.
True
Answer: Option A
B.
False
Explanation:
2 wattmeter
2.
one wattmeter
3.
3 wattmeter
1 and 2
B.
1 and 3
C.
2 and 3
D.
3 alone
Answer: Option B
Explanation:
A minimum of 2 wattmeters is required to measure 3 phase power. Of course power can be
measured by putting one wattmeter in each phase.
View Answer Workspace Report Discuss in Forum
28.
Which of the following is correct for a driving point functions?
A.
B.
C.
The real parts of all poles and zeros must be negative or zero
D.
Answer: Option C
Explanation:
It is a necessary condition for response to be stable.
View Answer Workspace Report Discuss in Forum
29.
An infinite ladder is constructed with 1 and 2 resistors shown below.
A.
8.18 A
B.
0A
C.
9A
D.
can't determined
Answer: Option C
Explanation:
R = 1 + (2 || R)
R=2
.
View Answer Workspace Report Discuss in Forum
30.
In the circuit of figure the voltage across capacitor at t = is
A.
0V
B.
20 V
C.
very large
D.
7.5 V
Answer: Option D
Explanation:
A.
0.25
B.
0.5
C.
0.1
D.
Answer: Option A
Explanation:
Mutual inductance wm = k L1L2
m = k. 2. 8j2 = 4k. j
Z = 20 - j10 + j2 + j6 + 2.4kj - 2j + 8kj = 0 at resonance
-2 = -8k
k = 1/4
0.25 .
A.
B.
C.
D.
all 3
Answer: Option D
Explanation:
Degree of node is the no.of branch incident to it.
View Answer Workspace Report Discuss in Forum
33.
In an RC series circuit R = 100 and XC = 10 . In this circuit
A.
B.
C.
D.
Answer: Option B
Explanation:
A.
more than 12
B.
less than 3
C.
D.
Answer: Option C
Explanation:
Z = R2 + XC2. When f is made four times, XC becomes one-fourth but R remains the same.
View Answer Workspace Report Discuss in Forum
35.
A current is flowing through a conductor with non-uniform area of cross-section. Then
A.
B.
C.
current will be different but current density will be same at all the crosssections
D.
current will be the same but current density will be different at different
cross-sections.
Answer: Option D
Explanation:
Current density = current/area of cross-section. Same current throughout the
conductor.
Since, area of cross-section is non-uniform, current density will be different at different
cross-sections.
36.
A series RL circuit has
will be
A.
B.
C.
D.
Answer & Explanation
Answer: Option B
Explanation:
R = 4 , L = 1 H, = 4 rad/sec, XL = 4
A.
2.67 kWh
B.
3 kWh
C.
2.5 kWh
D.
3.5 kWh
Answer: Option A
Explanation:
A.
B.
1 rad/sec
C.
4 rad/sec
D.
16 rad/sec
Answer: Option B
Explanation:
are equal.
A.
length of cable
B.
diameter of cable
C.
D.
Answer: Option B
Explanation:
A.
2 and 0
B.
1 and 0
C.
0 and -1
D.
1 and -1
Answer: Option B
Explanation:
Power factor is maximum and equal to 1 for purely resistive load. Power factor is minimum and
equal to zero for purely reactive load.
41.
The time constant of the circuit in figure shown.
A.
RC
B.
C.
D.
Answer & Explanation
Answer: Option B
Explanation:
Time constant
Req.C
.
View Answer Workspace Report Discuss in Forum
42.
In the circuit shown in given figure, the values of i(0 +) and I(), will be respectively
A.
B.
1.5 A and 3 A
C.
3 A and zero
D.
3 A and 1.5 A
Answer: Option C
Explanation:
A.
500
B.
50
C.
20
D.
Answer: Option A
Explanation:
A.
B.
C.
D.
indeterminate
Answer: Option B
Explanation:
Impedance matrices will be added.
View Answer Workspace Report Discuss in Forum
45.
As compared to the number of network elements in Brune synthesis, the number of network
elements Bott-and Duffin in realization is
A.
more
B.
less
C.
equal
D.
Answer: Option A
Explanation:
To avoid mutually coupled inductors, more elements are needed.
46.
A sinusoidal voltage has peak to peak value of 100 V. The rms value is
A.
50 V
B.
70.7 V
C.
35.35 V
D.
141.41 V
Answer: Option C
Explanation:
= 35.35 V.
A.
230 V
B.
0.5 x 230 V
C.
2 x 230V
D.
230/2V
Answer: Option C
Explanation:
Peak voltage rating = 2 (rms voltage rating).
View Answer Workspace Report Discuss in Forum
48.
The current wave shape shown in figure (1) is applied to a circuit element. The voltage across the
element is shown in figure (2). The element is
A.
B.
C.
D.
Semiconductor
Answer: Option C
Explanation:
When a current pulse is applied to a capacitor the voltage rises linearly and becomes constant at
the end of pulse.
View Answer Workspace Report Discuss in Forum
49.
In figure, the current supplied by battery immediately after switching on the circuit is
A.
1A
B.
4A
C.
10 A
D.
Answer: Option A
Explanation:
At t = 0, inductance behaves as open circuit.
View Answer Workspace Report Discuss in Forum
50.
RMS value of i(t) = 10[1 + sin (- t)] is
A.
10
B.
10/2
C.
l50
D.
102
Answer: Option C
Explanation: