You are on page 1of 112

http://service-electronic.blogspot.com/2012/05/tv-flyback-transformer-datasheetlist.

html
http://aanservice.blogspot.com/2013/06/data-pin-out-flyback.html
http://www.newportelec.com/flybacks.html
http://www.eserviceinfo.com/equipment_type/TV_2.html

TV flyback transformer datasheet list


Label: flyback datasheet, Flyback pin, flyback serial number
A flyback transformer (FBT), also called a line output transformer (LOPT), is a special
type of electrical transformer. It was initially designed to generate high current
sawtooth signals at a relatively high frequency. In modern applications it is used
extensively in switched-mode power supplies for both low (3V) and high voltage
(over 10 kV) supplies.
flyback transformer

Unlike conventional transformers, a flyback transformer is not fed with a signal of


the same waveshape as the intended output current.

In particular, very high voltages are easily obtained using relatively few turns of
winding which, once rectified, can provide the very high accelerating voltage for a
CRT. Many more recent applications of such a transformer dispense with the need to
produce high currents and just use the device as a relatively efficient means of
producing a wide range of lower voltages using a transformer much smaller than a
conventional mains transformer would be.[citation needed]

The flyback transformer is used in the operation of CRT-display devices such as


television sets and CRT computer monitors. The voltage and frequency can each
range over a wide scale depending on the device.

Unlike a power (or 'mains') transformer which uses an alternating current of 50 or


60 Hertz, a flyback transformer typically operates with switched currents at much
higher frequencies in the range of 15 kHz to 50 kHz.

These are many TV flyback transformer datasheet list :


1. Samsung TV
Flyback Number : FSV 14A001
FSV 20A001
FCK 14A033
FCV 20A001
PIN

: 16,5V_NC_H_46V_185V_GROUND_NC_ABL_B+125V_COL

154-064P (Goldstar)
154-177B
FCK 14B047 (Akari)
COL_185V_B+_GROUND_16V_24V_40V_ABL_H_AFC

154-064G (Goldstar)
154-177E
COL_180V_92V_125VBOOST_24V_12V_GROUND_ABL_H_AFC

FCM 14A025 (Samsung, Blaupunkt)


FCM 1411L01
16,5V_AFC_H_24V_180V_GROUND_B+90V_ABL_125VBOOST_COL

DCF 1577 (Daewoo, Mitsuba)


DCF 2077
FSA 16012M
COL_B+_AFC_125VBOOST_16,5V_ABL_24V_GROUND_180V_H

FTK 14B011 (Aiwa)


COL_B+_25V_GROUND_180V_H_ABL_GROUND_AFC_15V

FCK 1411E10A (Etron)


190V_COL_NC_B+_NC_24V_ABL_GROUND_15V_H

JF 0208-0208C (Solitron)
COL_B+_GROUND_185V_H_ABL_GROUND_15V_AFC_24V

JF 0208-0210B (Sansui)
JF 0501-0501
COL_B+_180V_14V_24V_H_GROUND_ABL_AFC_NC

FCM 14B014N (Polytron, Digitec)


FCM 20B061N
JF 0601-19577
COL_B+_GROUND_200V_NC_H_NC_ABL+12v_-12v

JF 0501-1206 (Sansui)

COL_B+_180V_16V_25V_H_GROUND_ABL_AFC_NC

L40B17100 (Sanyo)
COL_B+_NC_180V_AFC_GROUND_ABL_NC_H_GROUND

L40B09000 (Sanyo)
COL_B+_NC_AFC_GROUND_H_ABL_16V_NC_180V

L40B05500 (Sanyo)
COL_B+_NC_AFC_GROUND_H_GROUND_NC_NC_ABL

L40B09001 (Sanyo)
COL_B+_NC_AFC_GROUND_H_ABL_NC_NC_180V

6174Z-6040C (LG)
BSC 23-N0107
COL_185V_B+_GROUND_-14V_+14V_GROUND_ABL_H_AFC

BSC 24-08B (Tv China)


BSC 24-01N362
BSC 25-4803
BSC 25-N1616
BSC 25-0106
COL_B+_NC_AFC_GROUND_H_ABL_NC

BSC 25-T1010A (Tv China)

BSC 24-01N4014K
BSC 25-09N21A
BSC 25-09N20E
TEP_COL_TEP_B+_TEP_TEP_GROUND_H_ABL_180V

BSC 60HZ (Changhong)


COL_B+_190V_GROUND_11V_16V_45V_ABL_H_AFC

BSC 24-2231HC (Panda)


COL_B+_46V_16V_GROUND_AFC_ABL_H_180V_NC

BSC 65A (Changhong)


COL_B+_190V_GROUND_NC_NC_14,5V_ABL_H_AFC

TFB 4067BD (Toshiba)


TFB 4125CH
TFB 4122HY/ES/CS/DY
BSC 23-N0102
COL_B+_185V_GROUND_NC_24V_12V_ABL_H_AFC

FCK 14A028 (Fuji Electric)


NC_B+_14V_24V_H_GROUND_ABL_180V_B+_COL

154-189C (Fuji Electric)


154-277C
FCM 20B027

COL_B+_180V_14V_22V_H_GROUND_ABL_AFC_NC

FUY 20C009 (Akari)


COL_180V_B+_GROUND_NC_24V_NC_ABL_H_AFC

FCK 14A006 (Digitec, Polytron, OK)


FCM 2015HE
FCM 14A032
KFS 60844A
NC_NC_GROUND_185V_15V_H_24V_ABL_B+_COL_

154-138K (Etron)
154-182H
190V_NC_COL_AFC_B+_43V_ABL_GROUND_12V_H

CF 0801 (Fujitec)
COL_B+180V_15V_24V_H_GROUND_ABL_NC_NC

CF 0854 (Fuji Electric, Siera)


CF 0582
COL_B+_GROUND_AFC_185V_H_25V_15V_GROUND_ABL

FSA 28027M (Fuji Electric)


COL_NC_NC_123V_12V_ABL_25V_GROUND_185V_H

BSC 24-01N4009A (Tv China)

COL_NC_B+_GROUND_NC_TEP_NC_ABL_H_AFC

BSC 22-2314H (Fujitec)


COL_B+_180V_15V_24V_AFC_GROUND_ABL_NC_NC

BSC 22-01N40J (Tv China)


COL_180V_115V_GROUND_22V_16V_ABL_H_NC_NC

F 0193 PEN1-SA (Sharp)


F 0194 PEN1-SA
COL_B+_GROUND_42V_12V_AFC_185V_GROUND_H_ABL
(cat: teg 12v pada FBT F0194= 16V)

154 - 132A
154 - 132C
C _ 40v _ 16,5 _ Heater _ Gnd _ B+ _ 180v _ Gnd _ Abl _40v

154 189H
154 277C
FCM 20B027
C _ B+ _ 180v _ 16v _ 24v _ Heater _ Gnd _ Abl _ Afc _ Nc

8-598-858--00
8-598-811
C _ B+135v _ 200v _ Heater _ Gnd _ -16,5(vertkl) _ Gnd(vertkl) _ +16,5(vertkl) _ Nc _
Abl

BSC 22-01-06
BSC 25-48
BSC 25-4803
BSC 24-01N362
C _ B+ _ Nc _ afc _ gnd _ Heater _abl _ nc

BSC 24-01N4014K
BSC 25-T1010A
BSC 25-09N21A
BSC 25-05N2110A
BSC 25-09N20E
Tep _ C _ Tep _ B+ _ Tep _ Tep _ gnd _ Heater _ abl _ 180v

BSC 65A
C _ B+ _ 190v _ Gnd _ Nc _ Nc _ 14,5v _ Abl _ Heater _ Afc

DCF 2217J
C _ B+ _ afc _ boost-up _ 16,5 _ 24 _ abl _ gnd _ 200v _ heater

F 0101KM-SA
F 0141 PE-M
C _ B+ _ Gnd _ 24v _ 16v _ Afc _ 180v _ Gnd _ Heater _ Abl

FCK 14A006
FCM 2015HE
FCM 14A032

C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

FCK 1411 L 01
FCM 14A025
C _ Boost-up _ Abl _ B+ _ Gnd _ 180v _ 24V _ Heater _ Afc _ 16,5v

FCG 2045 BL
Afc - 16,5v _ Heater _ Boost-up _ B+83v _ Gnd _ Nc _ C _ Abl _ 175v _ 24v

FCM-20B061N (polytron)
C_B+_gnd_185_nc_Ht_Nc_abl_+12_-12

FSA 16012M
DCF 2077A
DCF 1577
FSA 16012M
C - B+ - Afc _ Boost-up _ 16,5 _ Abl _ 25v _ Gnd _ 185v _Heater

FUY-20C009 (akari)
C_180_B+_gnd_nc_24_nc_abl_Ht_afc

FSV - 20A001
FCK - 14A033
FSV - 14A001
C _ B+125v _ Abl _ Nc _ Gnd _ 185 _ 46 _ Heater _ Nc _ 16,5

FTK-14A004P (samsung)
C_B+125v_ABL_ Nc_ Gnd_ 180v_24v_Ht_afc_16,5

JF 0501-1206
C _ B+ _ 180v _ 16v _ 25v _ Heater _ Gnd _ Abl _ Afc _ Nc

JF0601-19577 (polytron)
C_B+_gnd_200v_nc_Ht_nc_abl_+12_-12

MC - FBC-015
LCE CF0854
C _ B+ _ Gnd _ Afc _ 185 _ Heater _ 25 _ 15 _ Gnd _ Abl

TFB 4125 DY (tosiba)


TFB 4125 HY
C _ B+ _ 180 _ Gnd _ Nc _ 26v _ 12v _ Abl _ Heater _ Afc

K 148 TC
C - 180v _ B+ - Gnd _ Afc _ 16v _ Abl _ Heater _ Nc _ Nc
154-064P Goldstar
154-177B
FCK-14B047

C _ 180v _ B+ _ Gnd _ 16v _ 24v _ 40v _ Abl _ Heater _ Afc

F 0101KM-SA
F 0141 PE-M
C _ B+ _ Gnd _ 24v _ 16v _ Afc _ 180v _ Gnd _ Heater _ Abl

K 148 TC
C - 180v _ B+ - Gnd _ Afc _ 16v _ Abl _ Heater _ Nc _ Nc

FCG 2045 BL
Afc - 16,5v _ Heater _ Boost-up _ B+83v _ Gnd _ Nc _ C _ Abl _ 175v _ 24v

FSA 16012M
DCF 2077A
DCF 1577
FSA 16012M
C - B+ - Afc _ Boost-up _ 16,5 _ Abl _ 25v _ Gnd _ 185v _Heater

JF 0501-1206 sansui
C _ B+ _ 180v _ 16v _ 25v _ Heater _ Gnd _ Abl _ Afc _ Nc

JF0601-19577 (polytron)
C_B+_gnd_200v_nc_Ht_nc_abl_+12_-12

FCM-20B061N (polytron)
c_B+_gnd_185_nc_Ht_Nc_abl_+12_-12

FUY-20C009 (akari)
C_180_B+_gnd_nc_24_nc_abl_Ht_afc

BSC 65A changhong


C _ B+ _ 190v _ Gnd _ Nc _ Nc _ 14,5v _ Abl _ Heater _ Afc

154 - 132A intel


154 - 132C
C _ 40v _ 16,5 _ Heater _ Gnd _ B+ _ 180v _ Gnd _ Abl _40v

FCK 1411 L 01
FCM 14A025
C _ Boost-up _ Abl _ B+ _ Gnd _ 180v _ 24V _ Heater _ Afc _ 16,5v

154 189H
154 277C
FCM 20B027
C _ B+ _ 180v _ 16v _ 24v _ Heater _ Gnd _ Abl _ Afc _ Nc

MC - FBC-015
LCE CF0854
C _ B+ _ Gnd _ Afc _ 185 _ Heater _ 25 _ 15 _ Gnd _ Abl

FSV - 20A001 samsung


FCK - 14A033
FSV - 14A001
C _ B+125v _ Abl _ Nc _ Gnd _ 185 _ 46 _ Heater _ Nc _ 16,5

FTK-14A004P (samsung)
C_B+125v_ABL_ Nc_ Gnd_ 180v_24v_Ht_afc_16,5

8-598-858--00 sony KV-PG21P70


8-598-811
C _ B+135v _ 200v _ Heater _ Gnd _ -16,5(vertkl) _ Gnd(vertkl) _ +16,5(vertkl) _ Nc _
Abl

8-598-960-00 sony KV-G21P1


C_b+115V_200V_ht_ gnd_-13v_gnd_+15v_nc_abl

TFB 4125 DY (thosiba)


TFB 4125 HY
C _ B+ _ 180 _ Gnd _ Nc _ 26v _ 12v _ Abl _ Heater _ Afc

BSC 22-01-06
BSC 25-48
BSC 25-4803
BSC 24-01N362
C _ B+ _ Nc _ afc _ gnd _ Heater _abl _ nc

BSC 24-01N4014K tv china


BSC 25-T1010A
BSC 25-09N21A
BSC 25-05N2110A
BSC 25-09N20E
Tep _ C _ Tep _ B+ _ Tep _ Tep _ gnd _ Heater _ abl _ 180v

BSC25-2678S konka K2169TC


C_200v_B+_ gnd_afc_16v_abl_ht_nc_nc

JY0301-0206 tv china 29
C_B+_nc_afc_gnd_HT_abl_tep_tep_tep

DCF 2217J
C _ B+ _ afc _ boost-up _ 16,5 _ 24 _ abl _ gnd _ 200v _ heater

DATA PIN-OUT FLYBACK

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321

BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL
154-064P (goldstar14")
154-177B (goldstar21")
FCK-14B047 (akari14")
c _ 180v _ b+ _ gnd _ 16v _ 24v _ 40v _ abl _ htr _ afc.

6174Z-8005C (LG 20")

c - 180 - b+ - gnd - nc - 24 - gnd - abl - ht -afc.

154-064G (goldstar14")
154-177E (goldstar20")
c - 180v - b+(92v) - boost up - 24v - 12v - gnd - abl - htr - afc.

154 - 132A (intel)


154 - 132C
6174V - 600H (LG 21")
6174Z - 6040C (LG 21")
BSC 23 - N0107 (LG 14")
c _ 40v _ 16,5 _ htr _ gnd _ b+ _ 180v _ gnd _ abl _ 40v

154 189 C
154 189 H
154 277 C
BSC 22-2314 H
CF 0801-3701
FCM 20B027
c _ b+ _ 180v _ 16v _ 24v _ htr _ gnd _ abl _ afc _ nc.

6174V-6002U (LG 21")


BSC 26-N2121(N) (LG 21")
c - 180v - b+ - gnd - 12v - 26v - nc - abl - ht - afc

BSC 65 A (changhong)

c _ b+ _ 190v _ gnd _ nc _ nc _ 14,5v _ abl _ htr _ afc.

BSC 22-01N401
BSC 22-01N402
BSC 22-01-06
BSC 22-0201
BSC 22-2314B
BSC 23-4404A
BSC 23-14H
BSC 24-14L
BSC 24-01N36
BSC 24-01N362
BSC 24-01N362B
BSC 24-08A
BSC 24-09G
BSC 25-48
BSC 25-4803
BSC 25-4803F
BSC 25-4803T
BSC 25-N0803A
BSC 25-Z601A
c _ b+ _ nc _ afc _ gnd _ htr _ abl _ nc.

BSC 25-2678S (konka K2169TC)


c _ 200v _ b+ _ gnd _ afc _ 16v _ abl _ ht _ nc _ nc

BSC 24-01N4014K (china)


BSC 25-01N4010GA (14")
BSC 25-05N2110A
BSC 25-0909
BSC 25-09N20E
BSC 25-09N21A
BSC 25-1003A
BSC 25-1194D024 (14")
BSC 25-2108A
BSC 25-4813P (cina multy)
BSC 25-N1003A-4-R (21")
BSC 25-T1010A
BSC 25-Z603F (21")
BSC 26-0221 (29")
Tep _ c _ tep _ b+ _ tep _ tep _ gnd _ htr _ abl _ 180v.

DCF 2217 J
c _ b+ _ afc _ boost-up _ 16,5 _ 24 _ abl _ gnd _ 200v _ htr.

F 0101 KM-SA (sharp 14R20 14")


F 0102 KM-SA (sharp 20R20B, 20R200, 51R200)
F 0141 PE-M
F 0147
c _ b+ _ gnd _ 24V _ 16V _ afc _ 180V _ gnd _ ht _ abl

F 0122 PE-M (sharp 20Q250)

c _ b+ _ 24V _ 16V _ nc _ afc _ gnd _ ht _ 180V _ abl

F 0193 PEN1-SA (sharp 14U15)


c _ b+(115) _ gnd _ 40V _ 12V _ afc _ 180V _ gnd _ ht _ abl

F 0194 PEN1-SA (sharp 20R200MKII, 51U200, 20W200)


F 2037 PE-B (sharp 20AG2-S)
c _ b+ _ gnd _ 40V _ 16V _ afc _ 180V _ gnd _ ht _ abl

F 094
FA 061 WJ-SA (sharp 51X200)
c _ b+(130V) _ gnd _ 24V _ 12V _ afc _ 185V _ gnd _ ht _ abl

FA 113 WJ-B (sharp 51DXF250E)


c _ b+ _ gnd _ 24V _ nc _ afc _ 180V _ gnd _ ht _ abl

FA 122 WJ-B
c _ b+(130V) _ gnd _ 24V _ nc _ afc _ 180V _ gnd _ ht _ abl

FA 011 WJ-B (sharp)


c _ b+ _ gnd _ 24V _ 16V _ afc _ 180V _ nc _ ht _ abl

FA 060 WJ-SA (sharp 14S20MKII)


c _ b+ _ gnd _ nc _ 12V _ afc(-12V) _ 180V _ gnd _ ht _ abl

FCG 2045 BL

afc - 16,5v _ htr _ boost-up _ B+83v _ gnd _ nc _ c _ abl _ 175v _ 24v

FCK 1411 L 01
FCM 14A025
c _ boost-up _ abl _ b+ _ gnd _ 180v _ 24V _ htr _ afc _ 16,5v.

FCK 14A006 (14")


FCM 2015HE (21")
FCM 14A032 (21")
FTK 21R002 (21")
KFS 60844A (21")
nc _ nc _ gnd _ 180 _ 15v _ ht _ 24 _ abl _ b+ _ c

FCM 14B014N (polytron 14")


FCM 20B061N (polytron 21")
c _ b+ _ gnd _ 185 _ nc _ htr _ nc _ abl _ +12 _ -12.

FUH29VH02 (polytron29)
c _ b+ _ gnd _ 185v _ nc(16v) _ htr _ nc _ abl(bcl) _ 12v _ 12v

FSV 20A001 (samsung)


FCK 14A033
FSV 14A001
c _ b+125v _ abl _ nc _ gnd _ 185 _ 46 _ htr _ nc _ 16,5

FTK-14A004P (samsung)

c _ b+125v _ abl _ nc _ gnd _ 180v _ 24v _ htr _ afc _ 16,5.

FUY-20C009 (akari)
c _ 180 _ b+ _ gnd _ nc _ 24 _ nc _ abl _ htr _ afc.

FCG 2045 BL
afc _ 16,5v _ htr _ boost-up _ b+83v _ gnd _ nc _ c _ abl _ 175v _ 24v.
HTF2904
c _ b+ _ 24v _ 16v _ gnd _ htr _ grnd _ afc _ nc _ 180v

FSA 16012M
DCF 2077A
DCF 1577
FSA 16012M
c _ b+ _ afc _ boost-up _ 16,5 _ abl _ 25v _ gnd _ 185v _ htr.

JF 0501-1206
c _ b+ _ 180v _ 16v _ 25v _ htr _ gnd _ abl _ afc _ nc.

JF 0601-19577 (polytron 21'' MX5203R)


c _ b+ _ gnd _ 200v _ nc _ htr _ nc _ abl _ +12 _ -12.

JY 0301-0206 (china 29")


c _ b+ _ nc _ afc _ gnd _ Htr _ abl _ tep _ tep _ tep

K 148 TC

c _ 180v _ b+ _ gnd _ afc _ 16v _ abl _ htr _ nc _ nc.

MC FBC-015
LCE CF0854
c _ b+ _ gnd _ afc _ 185 _ htr _ 25 _ 15 _ gnd _ abl.

8-598-858--00 (sony KV-PG21P70)


8-598-811
c _ b+135v _ 200v _ htr _ gnd _ -16,5(vertkl) _ Gnd(vertkl) _ +16,5(vertkl) _ nc _ abl

BSC25-Z305A (Goldstar)
BSC25-Z3201
FCM20B058
154-064
154-177B
c _ 180v _ B+ _ gnd _ 16v _ 24v _ 40v _ ABL _ H/T _ AFC

FCG 2045BL
BSC 24-0406D
c _ 180v _ B+ _ gnd _ 24v _16v _ ABL _ H/T _ NC _ NC
190v _ NC _ HOUT _ AFC _ B+ _ 43v _ ABL _ gnd _ 12v _ H/T

BSC 22-2314H
154-189C
JF 0501-1206
HOUT _ B+ _ 180v _ 16v _ 26v _ H/T _ gnd _ ABL _ AFC _ NC

BSC 24-01N4004U
HOUT _ B+ _ +13V _ -13v _ gnd _ H/T _ AFC _ ABL _ NC _ NC

6174Z-8040C
HOUT _ 185v _ B+ _ gnd _ -14v _ +14v _ gnd _ ABL _ H/T _AFC

MC-FBC-015
LCE CF 0854
HOUT _ B+ _ gnd _AFC _ 185V _ H/T _ 25V _ 15V _ gnd _ ABL

BSC25-4813
BSC 25-N0301CY
BSC 25-1003A
BSC 25-Z603F
BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1
BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T

BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S

C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
BSC 22-2314H
154-189C
JF 0501-1206
HOUT _ B+ _ 180v _ 16v _ 26v _ H/T _ gnd _ ABL _ AFC _ NC
BSC 24-01N4004U
HOUT _ B+ _ +13V _ -13v _ gnd _ H/T _ AFC _ ABL _ NC _ NC

6174Z-8040C
HOUT _ 185v _ B+ _ gnd _ -14v _ +14v _ gnd _ ABL _ H/T _AFC

MC-FBC-015
LCE CF 0854
HOUT _ B+ _ gnd _AFC _ 185V _ H/T _ 25V _ 15V _ gnd _ ABL

BSC25-4813
BSC 25-N0301CY
BSC 25-1003A
BSC 25-Z603F
BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1
BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V

L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE

FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
BSC 24-01N4004U
HOUT _ B+ _ +13V _ -13v _ gnd _ H/T _ AFC _ ABL _ NC _ NC
6174Z-8040C
HOUT _ 185v _ B+ _ gnd _ -14v _ +14v _ gnd _ ABL _ H/T _AFC

MC-FBC-015
LCE CF 0854
HOUT _ B+ _ gnd _AFC _ 185V _ H/T _ 25V _ 15V _ gnd _ ABL

BSC25-4813
BSC 25-N0301CY
BSC 25-1003A
BSC 25-Z603F
BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1
BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79

BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
6174Z-8040C
HOUT _ 185v _ B+ _ gnd _ -14v _ +14v _ gnd _ ABL _ H/T _AFC

MC-FBC-015
LCE CF 0854
HOUT _ B+ _ gnd _AFC _ 185V _ H/T _ 25V _ 15V _ gnd _ ABL

BSC25-4813
BSC 25-N0301CY
BSC 25-1003A
BSC 25-Z603F
BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1

BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094

FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003

BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
MC-FBC-015
LCE CF 0854
HOUT _ B+ _ gnd _AFC _ 185V _ H/T _ 25V _ 15V _ gnd _ ABL
BSC25-4813
BSC 25-N0301CY
BSC 25-1003A
BSC 25-Z603F

BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1
BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :

F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D

BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
BSC25-4813
BSC 25-N0301CY
BSC 25-1003A

BSC 25-Z603F
BSC 25-09N20ER
BSC 25-N0312A
BSC 25-T1010A
BSC 24-N40G1
BSC24-01N4001M
TP _ HOUT _ TP _ B+ _ TP _ TP _ gnd _ H/T _ ABL _ 180V

BSC 25-4803T
BSC 25-4804TC
BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP

SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
BSC 25-4803T
BSC 25-4804TC

BSC 25-03F69F
BSC 25N1616T
BSC 25-03P79
BSC 25-N0449
BSC 24-01N36
BSC 23-N0124R
BSC 22-01016H
BSC 25-0236
BSC 25-03P79
BSC 25-N0803A
BSC 22-N65T
BSC 25-0251
BSC 25-3604V
L 40B10602
C _ B+ _ NC _ AFC _ gnd _ H/T _ ABL _ TP
SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA

Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL

FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

(Samsung)
SHARP :
F0101KM-SA
F0141PE-M
F0102KM-SA
F094
FA061WJ-SA
FA060WJ-SA
FA135
F0147
BSC-250216F
FA093WJ-SA
Hout _ B+ _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H/T _ ABL
FO193PEN1-SA

Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL

KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
FO193PEN1-SA
Hout _ B+ _ Grnd _ 45v _ 16v _afc _ 180v _ Grnd _ h/t _ ABL
KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC

FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634

BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
KONKA :
BSC 25-0106
BSC 25-2678S
JF 0501-19188
C _ 180v _ B+ _ GND _ AFC _ 16v _ ABL _ H/T _ NC _ NC
FCM 2015HE

FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl

BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
FCM 2015HE
FCM 14A032
C _ B+ _ Abl _ 24v _ Heater _ 16v _ 180v _ Gnd _ Nc _ Abl
BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC

TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B+ _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC
TCL :
BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T

TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
TCL :

BSC 25=0252S
C _ B+ _ NC _ NC _ NC _ AFC _ GRND _ ABL _ 200V _ H/T
TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T

POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
TCL :
JF0501-1619
BSC25-0299D,
185V _H+_AFC_B+_16V_24V_ABL_GND_NC_H/T
POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL

(Samsung)
POLYTRON :
JF0501-19577
H_B+_GRND_+VID_+VID_H/T_NC_BCL_12VOL_HSINC-12VOL
(Samsung)
(Samsung)

FSV 14A001
FSV 20A001
FCK 14A033
FCV 20A001
16,5V_NC_H_46V_185V_GROUND_NC_ABL_B+125V_COL
154-064P (Goldstar)
154-177B
FCK 14B047 (Akari)
COL_185V_B+_GROUND_16V_24V_40V_ABL_H_AFC
154-064G (Goldstar)
154-177E
COL_180V_92V_125VBOOST_24V_12V_GROUND_ABL_H_AFC
FCM 14A025 (Samsung, Blaupunkt)
FCM 1411L01
16,5V_AFC_H_24V_180V_GROUND_B+90V_ABL_125VBOOST_COL
DCF 1577 (Daewoo, Mitsuba)
DCF 2077
FSA 16012M
COL_B+_AFC_125VBOOST_16,5V_ABL_24V_GROUND_180V_H

FTK 14B011 (Aiwa)


COL_B+_25V_GROUND_180V_H_ABL_GROUND_AFC_15V
FCK 1411E10A (Etron)
190V_COL_NC_B+_NC_24V_ABL_GROUND_15V_H
JF 0208-0208C (Solitron)
COL_B+_GROUND_185V_H_ABL_GROUND_15V_AFC_24V

JF 0208-0210B (Sansui)
JF 0501-0501
COL_B+_180V_14V_24V_H_GROUND_ABL_AFC_NC
FCM 14B014N (Polytron, Digitec)
FCM 20B061N
JF 0601-19577
COL_B+_GROUND_200V_NC_H_NC_ABL+12v_-12v
JF 0501-1206 (Sansui)
COL_B+_180V_16V_25V_H_GROUND_ABL_AFC_NC
L40B17100 (Sanyo)
COL_B+_NC_180V_AFC_GROUND_ABL_NC_H_GROUND
L40B09000 (Sanyo)
COL_B+_NC_AFC_GROUND_H_ABL_16V_NC_180V
L40B05500 (Sanyo)
COL_B+_NC_AFC_GROUND_H_GROUND_NC_NC_ABL
L40B09001 (Sanyo)
COL_B+_NC_AFC_GROUND_H_ABL_NC_NC_180V
6174Z-6040C (LG)
BSC 23-N0107
COL_185V_B+_GROUND_-14V_+14V_GROUND_ABL_H_AFC
BSC 24-08B (Tv China)
BSC 24-01N362
BSC 25-4803
BSC 25-N1616
BSC 25-0106
COL_B+_NC_AFC_GROUND_H_ABL_NC

BSC 25-T1010A (Tv China)


BSC 24-01N4014K
BSC 25-09N21A
BSC 25-09N20E
TEP_COL_TEP_B+_TEP_TEP_GROUND_H_ABL_180V
BSC 60HZ (Changhong)
COL_B+_190V_GROUND_11V_16V_45V_ABL_H_AFC
BSC 24-2231HC (Panda)
COL_B+_46V_16V_GROUND_AFC_ABL_H_180V_NC
BSC 65A (Changhong)
COL_B+_190V_GROUND_NC_NC_14,5V_ABL_H_AFC
TFB 4067BD (Toshiba)
TFB 4125CH
TFB 4122HY/ES/CS/DY
BSC 23-N0102
COL_B+_185V_GROUND_NC_24V_12V_ABL_H_AFC
FCK 14A028 (Fuji Electric)
NC_B+_14V_24V_H_GROUND_ABL_180V_B+_COL
154-189C (Fuji Electric)
154-277C
FCM 20B027
COL_B+_180V_14V_22V_H_GROUND_ABL_AFC_NC
FUY 20C009 (Akari)
COL_180V_B+_GROUND_NC_24V_NC_ABL_H_AFC
FCK 14A006 (Digitec, Polytron, OK)
FCM 2015HE

FCM 14A032
KFS 60844A
NC_NC_GROUND_185V_15V_H_24V_ABL_B+_COL_
154-138K (Etron)
154-182H
190V_NC_COL_AFC_B+_43V_ABL_GROUND_12V_H
CF 0801 (Fujitec)
COL_B+180V_15V_24V_H_GROUND_ABL_NC_NC
CF 0854 (Fuji Electric, Siera)
CF 0582
COL_B+_GROUND_AFC_185V_H_25V_15V_GROUND_ABL
FSA 28027M (Fuji Electric)
COL_NC_NC_123V_12V_ABL_25V_GROUND_185V_H
BSC 24-01N4009A (Tv China)
COL_NC_B+_GROUND_NC_TEP_NC_ABL_H_AFC
BSC 22-2314H (Fujitec)
COL_B+_180V_15V_24V_AFC_GROUND_ABL_NC_NC
BSC 22-01N40J (Tv China)
COL_180V_115V_GROUND_22V_16V_ABL_H_NC_NC
F 0193 PEN1-SA (Sharp)
COL_B+_GROUND_42V_12V_AFC_185V_GROUND_H_ABL
F 0194 PEN1-SA
COL_B+_GROUND_42V_16V_AFC_185V_GROUND_H_ABL
F 0042PE-M (Sharp)
15V_COL_24V_B+_ABL_AFC_GROUND_NC_180V_H
F 0063PE-M (Sharp)

F 0067PE-M
COL_B+_24V_12V_NC_AFC_GROUND_H_185V_ABL
F 0102KM-SA (Sharp)
COL_B+_GROUND_24V_14V_AFC_180V_GROUND_H_ABL
FA 060WJ-SA (Sharp)
COL_B+_GROUND_NC_12V_(AFC/-12V)_185V_GROUND_H_ABL
FA 061WJ-SA (Sharp)
COL_(B+130V)_GROUND_24V_12V_AFC_185V_GROUND_H_ABL
FA 113WJ-B (Sharp)
COL_B+_GROUND_24V_NC_AFC_180V_GROUND_H_ABL
FA 122WJ-B
COL_(B+130V)_GROUND_24V_NC_AFC_180V_GROUND_H_ABL
FTK 14A004P (Samsung)
16,5V_AFC_H_24V_180V_GROUND_NC_ABL_(B+125V)_COL
154-279C (Siera, Fuji Electric)
COL_(B+135V)_200V_GROUND_GROUND_25V_16V_ABL_H_NC
BSC 25-N0363 (LG 21FU6RL/Pearl Black)
COL_180V_B+_GROUND_INNER_26V_NC_ABL_H_AFC
8-598-858-00 (Sony)
8-598-11
COL_B+_200V_H_GROUND_-16,5V_GROUND_+16,5V_NC_ABL
QQH0132-001 (JVC AV-1438)
COL_B+_40V_NC_25V_GROUND_H_ABL_180V_GROUND
JF 0501-19539 (Polytron MX5262RF/Zepelin)
COL_B+_GROUND_185V_NC_H_25V_ABL_12V_Hpulse
BSC 25-1194D030 (SANKEN)

FSV 20A099
16,5V_24V_H_46V_180V_GROUND_NC_ABL_B+125V_COL
FTK 14A004F(S) (SAMSUNG)
16,5V_24V_H_-16,5V_185V_GROUND_NC_ABL_B+125V_COL
8-597-041-20 (SONY KV-LS21M61)
COL_B+_200V_H_GROUND_-13V_GROUND_+13V_NC_ABL
FUH 29VH04 (POLYTRON PS30UV25BM) U-SLIM
COL_B+(135)_GROUND_185V_NC_H_BCL_+12V_-12V
JF0501-32611 (SANYO CG21SF1T) FLAT 21
COL_B+(125)_NC_185V_AFC_ABL_ABL_NC_H_GROUND
154-138K

Thursday, June 13, 2013 -

0 comments

How it Works Philips IC Horizontal oscillator (TDA series)


Horizontal oscillator circuit seems to be almost the same, but from time to time actually experienced
a slight development in the way it works.Therefore, here we spoke to understand the development of
horizontal oscillator circuit Philips and understand the characteristics of each.Thus will be helpful in

the analysis while doing trobelshuting. TDA2579 TDA 2579 is ic Horizontal / Vertical oscillator
earliest introduced by Philips. The next generation ic Horizontal / Vertical ic is sometimes called
"Jungle". Here the horizontal and vertical oscillator circuit still separate stand alone as an
oscillator horizontal frequency is determined by the parallel resonant circuit RC (resistor and
capacitor).In the example image below is a component of the pin-14. Frequency can diadjust with a
variable resistor (VR) Horizontal oscillator will start working if the pin-16 gets supply Vcc voltage of
12v. Pin-11 H Out is an open collector, therefore, require a resistor connected to Vcc. Capacitors
for resonant circuit type of paper (the paper) was chosen because it has a good tolerance (1%) and
stable values are not easily changed by a change in temperature. It is very important that the
horizontal frequency is stable. Changes in the value of the capacitor can cause image collapse, even if
the value changes too ekstem may sometimes lead Tr Horizontal damaged. Series TDA836x
Communication with Mikrokontrol still uses an analog system (system voltage) Horizontal
Horizontal oscillator adopt Count-down system.Line oscillator generates a frequency of 2 x
horizontal frequency. Then this frequency is divided by a divider circuit in order to obtain the
horizontal frequency. Due to the characteristics of each component is likely little changed - it is so
stable oscillator in the calibration with a frequency of X-tal color. Horizontal oscillator will start
working if the pin-36 H.Vcc (start) got the Vcc supply voltage of 8V Although rarely used - Pin-39
PH2 input filter can also be used as input X-ray protector.Where the horizontal will die if the voltage
on the high PH2 close to the voltage Vcc. If PH2 receive high voltage, will cause the pin-37 H OUT
voltage rises H Tr base >>> >>> ride driver and collector Tr Hor driver when measured zero voltage
(but if there is voltage removable tr) >>> and the horizontal part is not H OUT does not work
because meng output as a signal. TDA8366 and series TDA837x this IC technology has been
adopted 12Cbus (data communication via the data SDA / SCL) How it works just like its
predecessor oscillator Line TDA356x. Tetapai Horizontal oscillator will only work if: (a) Pin35 H
Vcc've got a supply voltage 8V and (b) Pulse clock SDA / SCL already baktip work (meaning
Mikrokontrol already working) Have two pieces of input X-ray protector that can cause horizontal
the oscillator does not work, namely Pin-48 EHT input. Normal voltage is around 3v. If this pin
voltage is more than 4v will cause pin H OUT does not emit a signal. Pin-39 PH2 filter. Normal
voltage is around 3v. If the pin is received over voltage of 5v will cause the pin H OUT does not emit a
signal. EHT protector can be activated / in non-aktipkan through adjustment service menu PRD
and XPR (0 = non active, 1 = active) Therefore if the horizontal not work it needs to be checked are:
Voltage suply H Vcc Resistor pull-ups on a pin-H Out (possibly breaking) Check whether
Mikrokontrol own work (check power on-off with remote) Check the lines SDA / SCL to ic more
(there may be short). check the voltage on the X-ray protector input pin-EHT and pin-PH2, which
may be the voltage is high (more than 5v)Series TDA884x / 885x How the horizontal section is
almost the same as the TDA8366 How to check if horizontal section oscillator does not work is like
TDA8366 characteristic if horizontal oscillator does not work on this ic - the voltage on pin-40 H
OUT voltage will rise to more than 6V >>> cause Tr basis Hor drive high voltage so that the collector
>>> -emitornya like dishortkan >>> collector voltage when measured zero (but if tr base in Horopen drive voltage at the collector there).This sometimes causes engineers deceived, mistaken ic
damaged. H vcc start is the door 37 H Out is pin-40 EHT input is pin-50 Series UOC TDA935x /
6x / 8x and TDA955x / 6x / 8x PS / N2 How it works remains like its predecessor H Vcc start is
pin-39 H OUT is pin-33 EHT input is pin-36 How to check if the oscillator does not work - the
same as TDA8366 TDA955x / 6x / 8x produced in two different versions namely SDIP and QFP (ic
paste) To ic types of QFP: H Vcc is pin-9 H OUT is pin-30 EHT input is pin-34 PH2 filter is
pin-11 sometimes encountered horizontal die-life If EHT PH2 protector protector and active - can
cause death horizontal section. When horizontal die - will cause the voltage on pin-EHT or PH2
back down. This leads to protectionism inactive and horizontal working again. But once again
horizontal work - EHT voltage or PH2 will go up again and horizontal back dead protectionism

Thursday, April 11, 2013 -

0 comments

KNOW COMPONENTS SMD (SURFACE MOUNTED DEVICE)


SMD are electronic components that the assembly is placed directly on the solder side (hereinafter we use
the term "Solder Side") of the PCB. This means that SMD components directly in contact with the copper
surface of the PCB. In contrast to conventional electronic components which have a specialty as a wire or
metal legs, then SMD has two or more sides / parts surface in the form of a special metal that functions
like a conventional component foot. The form was much smaller compared with conventional
components. Because of its small that, then labeling to inform SMD type, type, and its value, use a special
system and standardization, which generally only use letters and digits. Therefore to be able to know the
data for a complete SMD components, we often need a document component datasheets.Without these
documents then we will be hard to determine the polarity and foot function components SMD with
certainty. The advantages of SMD compared with conventional components include: The surface area of
PCB is required to place an electronic circuit to be much smaller than if we make a PCB using components
conventional electronics must provide holes for the legs of the component (Trough-hole
component). Because SMD assembled by placing it directly on the solder side PCB, then both sides of the
PCB can be used in making electronic circuits so that the needs of the active surface area of PCB is
reduced by 50%. The assembly can be done more simply without having to cut foot component
first assembly process will automatically be easier performed and lower costs Due to its small size, the
density of packing materials and the final circuit components becomes higher. Highly resistant to shocks
and mechanical stresses. Do not require drilling and other machining processes. Can use copper surfaces
(PCB) which is thinner cheap or cost-effective for mass production. The lack of SMD or the limits to its
use, among others: It is very difficult to make the IC with the number of legs very much (raster 0.5 to 1.27
mm, max. 148 feet) where the distance between the foot placement is what is the main
problem. Electronic circuit layout design becomes very complex.Distance leg component has a certain size
(not flexible), dimensions and distance between legs or between the components being dependent on the
technology used by the plant. High density packaging materials, cause problems at high temperature.The
heat dissipation of components due to the power used components will be directly channeled through
PCB copper surface. High heat on the surface of the PCB affect any existing components. Not all SMD
components dapart clearly marked, and even many who are not marked at all. The process of repair of
electronic equipment that is constructed using SMD components, it becomes more complicated to
do Resistors Resistors SMD is available in a box shape (rectangular form) or in the form of MELF or
cylinder (cylinder form). Polular form factor, better known commonly used are 1206 and 0805, where the
value is between 1 sd prisoner 1M.

MARKING RESISTOR SMD


For resistors with a tolerance of 5% to 2% available in standard value according to the requirements of
IEC E24 and marked with the following code:

A = The first digit value resistor


B = second digit value resistor
C = Number Zero Sample readings SMD Resistor 5% and 2%

For SMD Resistors with a tolerance of 1% is available in the standard value according to the provisions of
E24 (E96) and is characterized by 3 or 4 digit code, such as a table beside.

A = The first digit value resistor


B = second digit value resistor
C = The third digit value resistor
D = Total Zero table above examples reading Resistor SMD 1%. Meanwhile, the resistance value resistor
MELF marked with 4 or 5 ring color standards such as the resistor conventional. Trimpot SMDTrimpot
SMD is available in 2 forms / functions different mechanical 3 feet and 4 feet. The fourth leg is a foot that
just serves as a mechanical amplifier when these components are installed. Power wasted by SMD trimpot
is 0.2W. Part slides can be rotated 360 , but the only active rotation angle of 270 . Values range from
100 resistance is up to 1M. Capacitors SMD Ceramic Multilayer Chip Capacitor , available in a very
wide range of values, starting from 0:47 till 1F pF. These values are written in seven form factors. Shape
is determined by the value of the capacitor.The most widely known form is 0805 and 1206. Unfortunately
this component is not marked by any good digital value and a color code. But this fact does not become a
problem for the industry, which components are installed / assembled on an automated roller. However
this is very dangerous for a technician to make repairs because they can not read the value of the
capacitor. Tantalum Capacitors SMDCapacitors SMD Tantalium provided in a form factor that is
diverse, and some of them do not even accompanied by a description (printed) value. Polarity + is marked
with a white line or the letter "M" in white. Form factor depends on the value of capacitance and voltage
limit works. Here is the form factor of a standard capacitor Tantalium SMD: 3.2 x 1.8 mm 3.5 x 2.8
mm 6.0 x 3.2 mm 7.3 x 4.3 mm , while value is encoded with a system digit and character number and
letters Encoding with a digit: Position the first digit indicates the first digit of the value of capacitance
Position the second digit indicates the second number of the capacitance value the position of the third
digit indicates the number of zeros in units of pico farads pF

Example; Description of the printed code "224" means 220 000 pF = 220 nF = 0:22 mF : Encoding of
character numbers and letters Example 1: 1.0mF, 16 V ...... CA *0.22mF, 35 V ... .. VJ * 2.2mF, 6.3 V ......
JJ *

C = 16V
A = 1pF
6 = X105
Then CA6 = 1pF x 105,16V = 1mF, 16V

Example 2:
A6 ...... 1.0 x 106 pF = 1.0 mF
J5 ....... 2.2 x 105 pF = mF 0:22
J6 ....... 2.2 x 106 pF = 2.2 mF A = 1.0 pF 6 = 106 So A6 = 1.0 x 106 pF = 1.0 mF, 35V

Wednesday, April 10, 2013 -

0 comments

CALCULATION OF POWER TRANSFORMER AND AMPLIFIER

How to calculate the power that produced a tranformer to the amplifier amplifier (with a record of
calculated transformer transformer pure / kw1), the following formula:

P = V. I
Where,
P = power (VA / Watt)
V = Voltage / Voltage (Volt)
I = Current (Amperes)
as an example; what is the power that is generated from an X 30V 10A transformer?
before included in the formula on a 30V voltage transformer is VAC (voltage Ac) then it should be
changed before the VDC because in general electronic devices using a DC voltage.
Vdc = Vac x 1,414 (1,414 is the standard unit)
Vdc = 30Vac X 1414
Vdc = 42.420
then
P = V. I
P = 42,420VDC X 10A
P = 424.2 VA / WattTrafo 10A x 30Vac (42,4Vdc) is capable of producing approximately 424.2 VA / Watt

Power Power Amplifier can be calculated from the final transistors, eg a mono amplifier uses two pairs of
transistors Sanken then generated power 400Watt where each pair Sanken transistors capable of
producing around 200Watt and transistors Jengkol Malaysia 100watt.
power amplifier can actually produce power if power 400Watt power supply adequate power at least the
same or more. and in the manufacture of power amplifier, which need to be considered first is knowing
the power load will be supplied in this case is the power of speaker, having known it will be easy to
determine the power amplifier, as well as the power supply of power the ampplifier must meet at least the
same or more power speakers.

conclusion:

Power Power supply should be able to handle the power amplifier and the power amplifier should be able
to handle the power Speaker.

Wednesday, March 13, 2013 -

6 comments

DATA-OUT PIN FLYBACK

2015HE FCM
FCM 14A032
C B + _ _ _ Abl 24v 16v _ _ _ Heater 180v Nc _ _ _ Gnd Abl
BSC24-014001D
BSC25-N0321
BSC25-N1534
BSC25-N1634
BSC25-Z1003
BSC25-Z2705
BSC25-Z2706
BSC25-N0313
H1 _ H _ H2 _ B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC
TCL:
BSC 25 = 0252S
C _ B + _ NC _ NC _ NC _ AFC _ grnd _ ABL _ 200V _ H / T
TCL:
JF0501-1619
BSC25-0299D,
185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H / T
Polytron:
JF0501-19577
H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC-12VOL
154-064P (goldstar14 ")
154-177B
FCK-14B047
c 180v _

(goldstar21
_

16v

gnd

24v

40v

htr

")
(akari14")
_ abl afc.

6174Z-8005C
c
180
-

154-064G
154-177E
c - 180v

nc

24

(92v)

boost

up

24v

20
gnd

154
6174V
6174Z
BSC
c 16.5

abl

12v

gnd

ht

abl

132A

600H
-

23
_ _

40v

gnd

(intel)

(LG

6040C
N0107
_ b _ _

htr

14
_ _

154
189
277
22-2314

24v

16v

180v

gnd

htr

(LG
26-N2121
b
+
gnd

65
gnd 190v

132C
")
21")
")
40v abl

21

(LG
(LG
_ 180v gnd

afc

189
H
C
H
0801-3701
20B027
_ nc abl.

")
21")
afc

21
(N)
26v

12v

nc

nc

A
_

")
-afc.

")
(goldstar20")
- htr - afc.

6174V-6002U
BSC
c
180v
-

BSC
c +

(LG
-

gnd

(goldstar14

154

C
154
154
BSC
CF
FCM
c +

nc

14,5v

(LG
abl

htr

ht

(Changhong)
_ abl afc.

22-01N401
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
24-09G
BSC
BSC
BSC
BSC
BSC
BSC
c
+

BSC
c +

BSC
22-01N402
22-01-06
22-0201
22-2314B
23-4404A
23-14H
24-14L
24-01N36
24-01N362
24-01N362B
24-08A
BSC
25-48

BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
BSC
Tep tep

nc

25-2678S
200V gnd

afc

afc

gnd

htr

(concha
16v abl

24-01N4014K
25-01N4010GA

25-4803
25-4803F
25-4803T
25-N0803A
25-Z601A
_
nc
abl.

ht

(14

25-1194D024
25-

4813P
25-N1003A-4-R

(china
(21

25-Z603F
_

26-0221
_ _ +

tep

tep

(29
gnd htr

K2169TC)
nc nc

(china)
")
25-05N2110A
25-0909
25-09N20E
25-09N21A
25-1003A
(14")
25-2108A
Multy)
")
25-T1010A
(21")
")
_ 180v abl.

DCF
c b

F
F
F
F
c

afc

0101
0102

PE
c +

PEN1
F
c +

F
FA
c _

FA
c +

FA
c _

0122
_ _ 16V

gnd

(115)

(130V)

24V

gnd

2217
_ 24

24V

F-M
afc _ _

16V

gnd

nc

F-SA
40V 12V

abl

200V

(sharp
14R20
14
(sharp
20R20B,
20R200,
0141

(sharp
PE-B
40V gnd _

2037
_ 16V

113
_ _

16.5

24V

F-SA

061
(130V) gnd

0193
gnd _

0194
b

KM-SA
KM-SA

PEN1
c _ b

boost-up

WJ-B
afc _

180V

gnd

(sharp
gnd 180V

nc

180V

(sharp
_ gnd afc

20Q250)
_ ht abl

185V

122
_ _ 24V

(sharp
_ gnd afc

(sharp
nc 180V

180V

afc

ht

J
htr.

")
51R200)
PE-M
0147
ht _ abl

20R200MKII,
51U200,
(sharp
_ _ gnd 180V afc _ _

WJ-SA
24V 12V

afc

gnd

20W200)
20AG2-S)
_ ht abl

094
51X200)
_ ht abl

ht

14U15)
ht abl

51DXF250E)
_ gnd abl

WJ-B
gnd abl

WJ
c +

WJ
c +

16V

060
_ gnd

FA
24V

nc

gnd

FA-SA
_ afc 12V

011-B
nc 180V

(12V)

(sharp
180V _

afc

(sharp)
ht abl

14S20MKII)
_ gnd abl

ht

FCG
2045
BL
afc - 16,5v htr _ _ _ boost-up B + 83v gnd _ _ _ nc c abl _ _ _ 24v 175v

FCK
FCM
c boost-up

FCK
FCM
FCM
FTK
KFS
nc
_

FCM
FCM
c +

1411
_

abl

gnd

L
b

180v

24V

14A006

afc

01
14A025
htr 16,5v.

")
(21")
")
(21")
")
_
c

(14
2015HE

14A032

(21
21R002

nc

FUH29VH02
c + b _ _

gnd

60844A
180
_

14B014N
20B061N
_ gnd htr 185

gnd

185v

nc

15V

ht

(21
24
_

abl

(Polytron
_

(16v)

htr

nc

14
(Polytron
nc abl _

nc

abl

(bcl)

12

")
21")
-12.

(polytron29)
_ _ 12v 12v

FSV
FCK
FSV
c b

20A001

125v

FTK-14A004P
c b + 125v

FUY-20C009
c
_ 180 _

nc

nc

abl

gnd

abl

gnd

gnd

24

185

htr

24v

nc

46

180v

nc

abl

nc

(samsung)
14A033
14A001
_ 16.5 htr

(samsung)
16.5 afc.

(akari)
htr afc.

FCG
2045
BL
afc htr _ _ _ 16,5v boost-up _ b + 83v gnd _ _ _ nc c abl _ _ _ 24v 175v. HTF2904c + b _ _ _ 16v 24v
gnd
_
_
_
htr
grnd
afc
_
_
_
nc
180v

16012M
DCF
DCF
FSA
c + b

JF
c +

JF
c +

JY
c +

afc-up

25v

0601-19577
_ _ gnd

boost

16v

200V

0301-0206
_ nc gnd

of

16.5

180v

(Polytron
htr _ _

afc

abl

25v

gnd

185v

htr

afc

21
_

nc

(china
_ _ HTR

nc

abl

abl

''
_

tep

FSA
2077A
1577
16012M
gnd htr.

0501-1206
_ nc abl.

MX5203R)
+ 12 -12.

29
_

tep

")
tep

K
c

180v

FBC
LCE
c +

gnd

gnd

htr

148
_ _

16v

afc

8-598-858--00

185

afc

25

abl

htr

15

(Sony

nc

TC
nc.

MC-015
CF0854
gnd abl.

KV-PG21P70)

8-598-811
c + b _ _ htr 200V 135v _ _ _ gnd -16.5 (vertkl) _ Gnd (vertkl) _ +16.5 (vertkl ) _ _ nc abl

BSC25-Z305A
BSC25-Z3201
FCM20B058
154-064
154-177B
c 180v _ _

(Goldstar)

16v

FCG
BSC
c 180v _ _ _ B + 24v
190v Hout _ _ _ NC AFC

gnd

ABL

40v

24v

AFC

2045BL
24-0406D
gnd _16v _ _ _ ABL H / T _ _ NC NC
B + _ _ _ ABL 43v 12v _ _ _ gnd H / T

BSC
22-2314H
154-189C
JF
0501-1206
Hout B + _ _ _ 180v 16v 26v _ _ H / T _ gnd AFC _ _ _ ABL NC BSC 24-01N4004U Hout _ B _ + _ +
13V gnd -13v _ _ H / T _ AFC _ ABL _ NC _ NC6174Z-8040C Hout _ 185v _ B + _ gnd _ -14v _ + 14v _
gnd _ ABL _ H / T _AFCMC-FBC-015 LCE CF 0854 Hout _ B + _ gnd _AFC _ 185V _ H / T _ 25V 15V
_ _ _ gnd ABL BSC25-4813 BSC 25-N0301CY BSC 25-1003A BSC 25-Z603FBSC 2509N20ER BSC 25-N0312A BSC 25-T1010A BSC 24-N40G1 BSC24-01N4001M TP Hout _ _ _ _
B + TP TP TP _ _ _ gnd H / T _ _ ABL 180V BSC 25-4803T BSC 25-4804TC BSC 25-03F69F BSC

25N1616T BSC
25-03P79 BSC
25-N0449 BSC
24-01N36 BSC
23-N0124R BSC
2201016H BSC 25-0236BSC 25-03P79 BSC 25-N0803A BSC 22-N65T BSC 25-0251 BSC 253604VL 40B10602 C _ + _ B _ gnd AFC NC _ _ H / T _ _ ABL TP SHARP: F0101KM-SA F0141PE
-M F0102KM-SA F094 FA061WJ-SA FA060WJ-SA FA135F0147 BSC-250216F FA093WJ-SA
Hout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H / T _ ABL FO193PEN1-SA Hout _ B + _ grnd
_ _ 45v 16v 180v _afc _ _ _ grnd h / t _ ABL KONKA: BSC 25-0106 BSC 25-2678S JF 050119188 C 180v _ _ _ GND B + 16v _ _ _ AFC ABL _ H / T _ _ NC NC FCM 2015HEFCM 14A032 C B +
_ _ _ Abl 24v 16v _ _ _ Heater 180v Nc _ _ _ Gnd Abl BSC24-014001D BSC25-N0321 BSC25N1534 BSC25-N1634 BSC25-Z1003 BSC25-Z2705 BSC25-Z2706 BSC25-N0313 H1 _ H _ H2 _
B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC TCL: BSC 25 = 0252S C _ B + _ NC _ NC _ NC _ AFC
_ grnd _ ABL _ 200V _ H / T TCL: JF0501-1619 BSC25 -0299D, 185V _H + _AFC_B +
_16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H /
T_NC_BCL_12VOL_HSINC-12VOL (Samsung) BSC 22-2314H 154-189C JF 0501-1206 Hout _
180v B + _ _ _ 16v 26v _ H / T _ gnd AFC _ _ _ ABL NC BSC 24-01N4004U Hout _ B _ + _ + 13V gnd
-13v _ _ H / T _ AFC ABL _ _ _ NC NC 6174Z-8040C Hout 185v _ _ B _ + _ gnd _ _ + 14v -14v gnd
ABL _ _ H / T _AFC MC-FBC-015 LCE CF 0854 Hout _ gnd _AFC B + _ _ _ 185V H / T _ 25V 15V _
_ _ gnd ABL BSC25-4813 BSC 25-N0301CY BSC 25-1003A BSC 25-Z603F BSC 2509N20ER BSC 25-N0312A BSC 25-T1010ABSC 24-N40G1 BSC24-01N4001M TP Hout _ _ _ B
+ _ TP TP TP _ _ _ gnd H / T _ _ ABL 180V BSC 25- 4803T BSC 25-4804TC BSC 25-03F69F BSC
25N1616T BSC 25-03P79 BSC 25-N0449 BSC 24-01N36 BSC 23-N0124RBSC 22-01016H BSC
25-0236 BSC 25-03P79 BSC 25-N0803A BSC 22-N65T BSC 25- 0251 BSC 25-3604V L
40B10602 C _ + _ B _ gnd AFC NC _ _ H / T _ _ ABL TP SHARP: F0101KM-SA F0141PEM F0102KM-SA F094FA061WJ-SA FA060WJ-SA FA135 F0147 BSC-250216F FA093WJSAHout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H / T _ ABL FO193PEN1-SA Hout _ B + _
grnd _ 45v _ 16v _afc _ 180v _ grnd _ h / t _ ABL KONKA: BSC 25-0106 BSC 25-2678S JF 050119188 C 180v _ _ _ GND B + 16v _ _ _ AFC ABL _ H / T _ _ NC NC FCM 2015HE FCM 14A032 C _
B + Abl _ _ _ Heater _ 16v 24v 180v _ _ _ Gnd Nc _ Abl BSC24-014001D BSC25-N0321 BSC25N1534BSC25-N1634 BSC25-Z1003 BSC25-Z2705 BSC25-Z2706 BSC25-N0313 H1 H2 _ H _ _ _
110v B + H3 _ _ _ GND H4 HT _ _ _ ABL AFC TCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ _
ABL grnd AFC _ _ _ 200V H / T TCL:JF0501-1619 BSC25-0299D, 185V _H + _AFC_B +
_16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B + _GRND_ + VID_ + VID_H /
T_NC_BCL_12VOL_HSINC-12VOL (Samsung) BSC 24-01N4004U Hout _ B _ + _ + 13V gnd -13v _
_ H / T _ AFC ABL _ _ _ NC NC6174Z-8040C Hout 185v _ _ B _ + _ gnd -14v + 14v gnd _ _ _ _ ABL H
/ T _AFCMC-FBC-015 LCE CF 0854 Hout _ gnd _AFC B + _ _ _ 185V H / T _ 25V 15V _ _ _ gnd
ABL BSC25-4813 BSC 25-N0301CY BSC 25- 1003A BSC 25-Z603FBSC 25-09N20ER BSC 25N0312A BSC 25-T1010A BSC 24-N40G1 BSC24-01N4001M TP Hout _ _ _ B + _ TP TP TP _ _ _
gnd H / T _ _ ABL 180V BSC 25-4803T BSC 25-4804TC BSC 25-03F69F BSC 25N1616T BSC 2503P79 BSC 25-N0449 BSC 24-01N36 BSC 23-N0124R BSC 22-01016H BSC 25-0236BSC 2503P79 BSC 25-N0803A BSC 22-N65T BSC 25-0251 BSC 25-3604VL 40B10602 C _ + _ B _ gnd
AFC NC _ _ H / T _ _ ABL TP SHARP: F0101KM-SA F0141PE-M F0102KM-SA F094 FA061WJSA FA060WJ-SA FA135F0147 BSC-250216F FA093WJ-SA Hout _ B + _ Ground _ 24v _ 16v _
afc _ 180v _ Gnd _ H / T _ ABL FO193PEN1-SA Hout _ B + _ grnd _ 45v _ 16v _afc _ 180v _ grnd _
h / t _ ABL KONKA: BSC 25-0106 BSC 25 -2678S JF 0501-19188 C 180v _ _ _ GND B + 16v _ _ _

AFC ABL _ H / T _ _ NC NC FCM 2015HEFCM 14A032 C B + _ _ _ Abl 24v 16v _ _ _ Heater 180v Nc
_
_
_
Gnd
Abl BSC24-014001D BSC25-N0321 BSC25-N1534 BSC25-N1634 BSC25Z1003 BSC25-Z2705 BSC25-Z2706 BSC25-N0313 H1 H2 _ H _ _ _ 110v B + H3 _ _ _ GND H4 HT
_ _ _ ABL AFC TCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ _ ABL grnd AFC _ _ _ 200V H /
T TCL: JF0501-1619 BSC25-0299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /
T Polytron: JF0501-19577 H_B + _GRND_ + VID_ + VID_H / T_NC_BCL_12VOL_HSINC12VOL (Samsung) 6174Z-8040C Hout 185v _ _ _ gnd B + _ _ + 14v -14v gnd _ _ _ ABL H / T _AFC

MC-FBC-015
LCE
CF
0854
Hout _ gnd _AFC B + _ _ _ 185V H / T _ 25V 15V _ _ _ gnd ABL BSC25-4813BSC 25-N0301CY BSC
25-1003A BSC 25-Z603F BSC 25-09N20ER BSC 25- N0312A BSC 25-T1010A BSC 24N40G1 BSC24-01N4001M TP Hout _ _ _ B + _ TP TP TP _ _ _ gnd H / T _ _ ABL 180V BSC 254803T BSC 25-4804TCBSC 25-03F69F BSC 25N1616T BSC 25- 03P79 BSC 25-N0449 BSC
24-01N36 BSC 23-N0124R BSC 22-01016H BSC 25-0236 BSC 25-03P79 BSC 25-N0803A BSC
22-N65T BSC 25-0251 BSC 25-3604V L 40B10602 C B + _ _ _ NC AFC _ gnd _ H / T _ ABL _
TP SHARP: F0101KM-SA F0141PE-MF0102KM-SA F094 FA061WJ-SA FA060WJ-SA FA135
F0147 BSC-250216F FA093WJ-SA Hout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H / T _
ABL FO193PEN1-SA Hout grnd _ B + _ _ _ 45v 16v 180v _afc _ _ _ grnd h / t _ ABL KONKA: BSC
25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _ _ B + GND AFC _ _ _ ABL 16v _ H / T _ _ NC
NC FCM 2015HE FCM 14A032 C B + _ _ _ Abl 24v 16v _ _ _ Heater 180v Nc _ _ _ Gnd Abl BSC24014001D BSC25-N0321 BSC25-N1534 BSC25-N1634 BSC25-Z1003 BSC25-Z2705 BSC25Z2706 BSC25-N0313 H1 _ H _ H2 _ B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _ AFC TCL: BSC 25 =
0252S C _ B + _ NC _ NC _ NC _ AFC ABL grnd _ _ _ _ 200V H / T TCL: JF0501-1619 BSC250299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B VID_
+ + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC-12VOL (Samsung) MC-FBC- 015 LCE CF
0854 Hout _ gnd _AFC B + _ _ _ 185V H / T _ 25V 15V _ _ _ gnd ABL BSC25-4813 BSC 25-

N0301CY BSC 25-1003A BSC 25-Z603F BSC 25-09N20ER BSC 25-N0312A BSC 25T1010A BSC 24-N40G1 BSC24-01N4001M TP Hout _ _ _ B + _ TP TP TP _ _ _ gnd H / T _ _ ABL
180V BSC 25-4803T BSC 25-4804TC BSC 25-03F69F BSC 25N1616T BSC 25-03P79 BSC 25N0449 BSC 24-01N36 BSC 23-N0124R BSC 22-01016H BSC 25-0236BSC 25-03P79 BSC 25N0803A BSC 22-N65T BSC 25-0251 BSC 25-3604VL 40B10602 C _ + _ B _ gnd AFC NC _ _ H /
T _ ABL _ TP SHARP: F0101KM-SA F0141PE-M F0102KM-SA F094 FA061WJ-SA FA060WJSA FA135F0147 BSC-250216F FA093WJ-SA Hout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd
_ H / T _ ABL FO193PEN1-SA Hout grnd _ B + _ _ _ 45v 16v 180v _afc _ _ _ grnd h / t _
ABL KONKA: BSC 25-0106 BSC 25-2678S JF 0501-19188 C 180v _ B _ + _ GND AFC _ _ 16v ABL
_ _ H / T _ _ NC NC FCM 2015HEFCM 14A032 C B + _ _ _ Abl 24v 16v _ _ _ Heater 180v Nc _ _ _
Gnd
Abl BSC24-014001D BSC25-N0321 BSC25-N1534 BSC25-N1634 BSC25-Z1003 BSC25
-Z2705 BSC25-Z2706 BSC25-N0313 H1 _ H _ H2 _ B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _
AFC TCL: BSC 25 = 0252S C _ B + _ NC _ NC _ NC _ AFC _ grnd _ ABL 200V _ _ H /
T TCL: JF0501-1619 BSC25-0299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /
T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC12VOL (Samsung) BSC25-4813 BSC 25-N0301CY BSC 25-1003A BSC 25-Z603F BSC 2509N20ER BSC 25-N0312A BSC 25-T1010A BSC 24-N40G1 BSC24-01N4001M TP Hout _ _ _ B
+
_
TP
TP
TP
_
_
_
gnd
H
/
T
_
_
ABL
180V

25-4803T
BSC
BSC
25-4804TC
BSC
25-03F69F
BSC
25N1616T
BSC
25-03P79
BSC
25-N0449
BSC
24-01N36
BSC
23-N0124R
BSC
22-01016H
BSC
25-0236
BSC
25-03P79
BSC
25-N0803A
BSC
22-N65T
25-0251
BSC
BSC
25-3604V
L
40B10602
C _ + _ B _ gnd AFC NC _ _ H / T _ _ ABL TP SHARP: F0101KM-SA F0141PE-M F0102KMSA F094 FA061WJ-SA FA060WJ-SA FA135 F0147 BSC-250216F FA093WJ-SA Hout _ B + _
Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H / T _ ABL FO193PEN1-SA Hout _ B + _ grnd _ 45v _ 16v
_afc _ 180v _ grnd _ h / t _ ABL KONKA: BSC 25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _
_ GND B + 16v _ _ _ AFC ABL _ H / T _ _ NC NC FCM 2015HE FCM 14A032 C _ B + Abl _ _ _
Heater _ 16v 24v 180v _ _ Gnd _ _ Nc Abl BSC24-014001D BSC25-N0321 BSC25-N1534 BSC25N1634 BSC25-Z1003 BSC25-Z2705 BSC25-Z2706 BSC25-N0313 H1 H2 _ H _ _ _ 110v B + H3 _

_ _ GND H4 HT _ _ _ ABL AFC TCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ _ ABL grnd AFC _ _


_
200V
H
/
T TCL: JF0501-1619 BSC25-0299D, 185V
_H
+
_AFC_B
+
_16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B VID_ _GRND_ + + + VID_H /
T_NC_BCL_12VOL_HSINC-12VOL (Samsung) BSC
25-4803TBSC
25-4804TC BSC
2503F69F BSC 25N1616T BSC 25-03P79 BSC 25-N0449 BSC 24-01N36 BSC 23-N0124R BSC
22-01016H BSC 25- 0236 BSC 25-03P79 BSC 25-N0803A BSC 22-N65T BSC 25-0251 BSC 253604V L 40B10602 C _ + _ B _ gnd AFC NC _ _ H / T _ _ ABL TP SHARP: F0101KMSAF0141PE-M F0102KMSA F094 FA061WJ-SA FA060WJ-SA FA135 F0147BSC250216F FA093WJ-SA Hout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _ Gnd _ H / T _
ABL FO193PEN1-SA Hout _ B + _ grnd _ 45v _ 16v _afc grnd 180v _ _ _ h / t _ ABL KONKA: BSC
25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _ _ GND B + 16v _ _ _ AFC ABL _ H / T _ _ NC
NC (Samsung) SHARP:F0101KM-SA F0141PE-M F0102KM-SA F094 FA061WJ-SA FA060W
J-SAFA135 F0147 BSC-250216F FA093WJ-SA Hout _ B + _ Ground _ 24v _ 16v _ afc _ 180v _
Gnd _ H / T _ ABL FO193PEN1-SA Hout _ grnd B + _ _ _ 45v 16v 180v _afc _ _ _ grnd h / t _
ABL KONKA: BSC 25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _ _ GND B + 16v _ _ _ AFC
ABL _ H / T _ _ NC NC FCM 2015HE FCM 14A032 C B + _ _ _ Abl 24v 16v _ _ _ Heater 180v Nc _ _
_ Gnd AblBSC24-014001D BSC25-N0321 BSC25-N1534 BSC25-N1634 BSC25-Z1003BSC25Z2705 BSC25-Z2706 BSC25-N0313 H1 _ H _ H2 _ B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _
AFC TCL: BSC 25 = 0252S C _ B + _ NC _ NC _ NC _ AFC _ grnd _ ABL _ 200V _ H /
T TCL: JF0501-1619 BSC25-0299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /
T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC12VOL (Samsung) FO193PEN1-SA Hout grnd _ B + _ _ _ 45v 16v 180v _afc _ _ grnd _ h / t _
ABLKONKA: BSC 25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _ _ GND B + 16v _ _ _ AFC
ABL _ H / T _ _ NC NC FCM 2015HE FCM 14A032 C _ + _ B abl Heater _ _ _ 24v 16v 180v _ _ _
Gnd
Nc
_
abl BSC24-014001D BSC25-N0321BSC25-N1534 BSC25-N1634 BSC25Z1003 BSC25-Z2705 BSC25-Z2706BSC25-N0313 H1 H2 _ H _ _ B _ + _ 110v H3 GND H4 _ _ _ _
AFC HT _ ABLTCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ _ ABL grnd AFC _ _ _ 200V H /
T TCL: JF0501-1619 BSC25-0299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /
T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC12VOL (Samsung) KONKA:BSC 25-0106 BSC 25-2678S JF 0501-19188 C 180v _ _ _ GND B +
16v _ _ _ AFC ABL _ H / T _ _ NC NC FCM 2015HE FCM 14A032 C B + _ _ _ Abl 24v 16v _ _ _
Heater 180v Nc _ _ _ Gnd Abl BSC24-014001D BSC25-N0321 BSC25-N1534 BSC25N1634 BSC25-Z1003 BSC25-Z2705 BSC25 -Z2706 BSC25-N0313 H1 _ H _ H2 _ B + _ 110v _ H3
_ H4 _ GND _ HT _ ABL _ AFC TCL: BSC 25 = 0252S C _ B + _ NC _ NC _ NC _ AFC _ grnd _ ABL _
200V
_
H
/
T TCL:JF0501-1619 BSC25-0299D, 185V
_H
+
_AFC_B
+
_16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H /
T_NC_BCL_12VOL_HSINC-12VOL (Samsung) FCM 2015HE FCM 14A032 C B + _ _ _ Abl 24v
Heater _ _ _ Gnd 16v 180v _ _ _ Nc AblBSC24-014001D BSC25-N0321 BSC25-N1534 BSC25N1634 BSC25-Z1003BSC25-Z2705 BSC25-Z2706 BSC25-N0313 H1 H2 _ H _ _ _ 110v B + H3 _
_ _ H4 GND HT _ _ _ ABL AFC TCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ _ ABL grnd AFC _ _
_
200V
H
/
T TCL: JF0501-1619 BSC25-0299D, 185V
_H
+
_AFC_B
+
_16V_24V_ABL_GND_NC_H / T Polytron _ H _ H2 _ B + _ 110v _ H3 _ H4 _ GND _ HT _ ABL _
AFC TCL: BSC 25 = 0252S C _ B + _ NC _ NC _ NC _ AFC _ grnd _ ABL _ 200V _ H /

T TCL: JF0501 -1619 BSC25-0299D,185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /


T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC12VOL(Samsung) TCL: BSC 25 = 0252S C B + _ _ _ NC NC NC _ _ AFC ABL grnd _ _ _ _ 200V H /
T TCL: JF0501-1619 BSC25-0299D, 185V _H + _AFC_B + _16V_24V_ABL_GND_NC_H /
T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H / T_NC_BCL_12VOL_HSINC12VOL (Samsung) TCL:JF05011619 BSC25-0299D, 185V
_H
+
_AFC_B
+
_16V_24V_ABL_GND_NC_H / T Polytron: JF0501-19577 H_B VID_ + + + _GRND_ VID_H /
T_NC_BCL_12VOL_HSINC-12VOL (Samsung) Polytron:JF0501-19577 H_B VID_ + + + _GRND_
VID_H
/
T_NC_BCL_12VOL_HSINC-12VOL (Samsung
) (Samsung) FSV
14A001 FSV
20A001 FCK
14A033FCV
20A001 16,5V_NC_H_46V_185V_GROUND_NC_ABL_B
+
125V_COL 154-064P
(Goldstar) 154-177B FCK
14B047
(Akari) COL_185V_B
+
_GROUND_16V_24V_40V_ABL_H_AFC 154-064G
(Goldstar) 154177ECOL_180V_92V_125VBOOST_24V_12V_GROUND_ABL_H_AFC FCM 14A025 (Samsung,
Blaupunkt
) FCM
1411L0116,5V_AFC_H_24V_180V_GROUND_B
+
90V_ABL_125VBOOST_COL DCF 1577 (Daewoo, Mitsuba) DCF 2077 FSA 16012M COL_B +
_AFC_125VBOOST_16,5V_ABL_24V_GROUND_180V_H FTK
14B011
(Aiwa)COL_B
+
_25V_GROUND_180V_H_ABL_GROUND_AFC_15V FCK 1411E10A (Etron) 190V_COL_NC_B +
_NC_24V_ABL_GROUND_15V_H JF
0208-0208C
(SOLITRON) COL_B
+
_GROUND_185V_H_ABL_GROUND_15V_AFC_24V JF
0208-0210B
(Sansui) JF
05010501 COL_B
+
_180V_14V_24V_H_GROUND_ABL_AFC_NC FCM
14B014N
(Polytron,
Digitec) FCM 20B061N JF 0601-19577 COL_B + _GROUND_200V_NC_H_NC_ABL + 12v_12v JF 0501-1206 (Sansui) COL_B + _180V_16V_25V_H_GROUND_ABL_AFC_NC L40B17100
(Sanyo) COL_B + _NC_180V_AFC_GROUND_ABL_NC_H_GROUND L40B09000 (Sanyo)COL_B
+
_NC_AFC_GROUND_H_ABL_16V_NC_180V L40B05500
(Sanyo)COL_B
+
_NC_AFC_GROUND_H_GROUND_NC_NC_ABL L40B09001
(Sanyo) COL_B
+
_NC_AFC_GROUND_H_ABL_NC_NC_180V 6174Z-6040C (LG) BSC 23-N0107 COL_185V_B +
_GROUND_-14V_ + 14V_GROUND_ABL_H_AFC BSC 24-08B (Tv China) BSC 24- 01N362 BSC
25-4803 BSC 25-N1616 BSC 25-0106 COL_B + _NC_AFC_GROUND_H_ABL_NC BSC 25T1010A (Tv China) BSC 24-01N4014K BSC 25-09N21A BSC 25-09N20E TEP_COL_TEP_B +
_TEP_TEP_GROUND_H_ABL_180V BSC
60Hz
(Changhong) COL_B
+
_190V_GROUND_11V_16V_45V_ABL_H_AFC BSC
242231HC
(Panda)COL_B
+
_46V_16V_GROUND_AFC_ABL_H_180V_NC BSC
65A
(Changhong) COL_B
+
_190V_GROUND_NC_NC_14,5V_ABL_H_AFC TFB
4067BD
(Toshiba) TFB
4125CH TFB
4122HY
/
ES
/
CS
/
DY BSC
23-N0102 COL_B
+
_185V_GROUND_NC_24V_12V_ABL_H_AFC FCK
14A028
(Fuji
Electric) NC_B
+
_14V_24V_H_GROUND_ABL_180V_B
+
_COL 154-189C
(Fuji
Electric) 154-277C FCM
20B027 COL_B
+
_180V_14V_22V_H_GROUND_ABL_AFC_NC FUY
20C009
(Akari)COL_180V_B + _GROUND_NC_24V_NC_ABL_H_AFC FCK 14A006 (Digitec, Polytron,
OK) FCM 2015HE FCM 14A032 KFS 60844ANC_NC_GROUND_185V_15V_H_24V_ABL_B +
_COL_ 154-138K (Etron) 154-182H 190V_NC_COL_AFC_B + _43V_ABL_GROUND_12V_H CF
0801 (FUJITEC) COL_B + 180V_15V_24V_H_GROUND_ABL_NC_NC CF 0854 (Fuji Electric,
Siera) CF 0582 COL_B + _GROUND_AFC_185V_H_25V_15V_GROUND_ABL FSA 28027M (Fuji
Electric) COL_NC_NC_123V_12V_ABL_25V_GROUND_185V_H BSC
24-01N4009A
(Tv

China) COL_NC_B + _GROUND_NC_TEP_NC_ABL_H_AFCBSC 22-2314H (FUJITEC) COL_B +


_180V_15V_24V_AFC_GROUND_ABL_NC_NC BSC
22-01N40J
(Tv
China)COL_180V_115V_GROUND_22V_16V_ABL_H_NC_NC F 0193 PEN1-SA (Sharp) COL_B +
_GROUND_42V_12V_AFC_185V_GROUND_H_ABL F-SA
0194
PEN1 COL_B
+
_GROUND_42V_16V_AFC_185V_GROUND_H_ABL F 0042PE-M (Sharp) 15V_COL_24V_B +
_ABL_AFC_GROUND_NC_180V_H F
0063PE-M
(Sharp) F
0067PEM COL_B
+
_24V_12V_NC_AFC_GROUND_H_185V_ABL F
0102KM-SA
(Sharp) COL_B
+
_GROUND_24V_14V_AFC_180V_GROUND_H_ABL FA-SA
060WJ
(Sharp) COL_B
+
_GROUND_NC_12V_ (AFC / -12V) _185V_GROUND_H_ABLFA-SA 061WJ (Sharp) COL_ (B +
130V) _GROUND_24V_12V_AFC_185V_GROUND_H_ABL FA 113WJ-B ( Sharp)COL_B +
_GROUND_24V_NC_AFC_180V_GROUND_H_ABL FA-B
122WJCOL_
(B
+
130V)
_GROUND_24V_NC_AFC_180V_GROUND_H_ABL FTK
14A004P
(Samsung) 16,5V_AFC_H_24V_180V_GROUND_NC_ABL_ (B + 125V) _COL 154-279C (Siera,
Fuji Electric) COL_ (B + 135V) _200V_GROUND_GROUND_25V_16V_ABL_H_NC BSC 25-N0363
(LG 21FU6RL / Pearl Black) COL_180V_B + _GROUND_INNER_26V_NC_ABL_H_AFC 8-598858-00
(Sony) 8-598-11COL_B
+
_200V_H_GROUND_-16,5V_GROUND_
+
16,5V_NC_ABL QQH0132-001
(JVC
AV-1438) COL_B
+
_40V_NC_25V_GROUND_H_ABL_180V_GROUND JF 0501 -19 539 (Polytron MX5262RF /
Zepelin) COL_B
+
_GROUND_185V_NC_H_25V_ABL_12V_Hpulse BSC
25-1194D030
(SANKEN) FSV 20A099 16,5V_24V_H_46V_180V_GROUND_NC_ABL_B + 125V_COL FTK
14A004F (S) (SAMSUNG)16,5V_24V_H_-16,5V_185V_GROUND_NC_ABL_B + 125V_COL 8-597041-20
(
SONY
KV-LS21M61) COL_B
+
_200V_H_GROUND_-13V_GROUND_
+
13V_NC_ABL Fuh
29VH04
(Polytron
PS30UV25BM)
U-SLIM COL_B
+
(135)
_GROUND_185V_NC_H_BCL_ + -12V 12V_ JF0501-32611 (SANYO CG21SF1T) FLAT 21 COL_B +
(125)
_NC_185V_AFC_ABL_ABL_NC_H_GROUND

154-138K

Tuesday, March 5, 2013 -

0 comments

SERVICE MODE TV SHARP


Chassis BCTVA
66AS06H, DV5932H, DV5935H, DV5937H and DV6635H
1. Connect a test pattern to the antenna terminal
2. Tune to this signal
3. Connect a jumper wire between terminals 2 (GND) and 6 (Service) of the service slot on the Video Unit
4. SOFTWARE SERVICE will Appear on the screen
5. Remove the jumper wire Use the channel up and down buttons to move between the options Use the
volume control buttons to change the Data Use the standby button on the remote control to store the data
is Turn the receiver off at the mains to exit the service mode 4BS Chassis -C DV5940H, DV6640H and
66AS05H 1.Connect a test pattern to the antenna terminal 2. Tune to this signal 3. Connect a jumper wire
between terminals 2 (GND) and 6 (Service) of the service slot on the Text Unit 4. SOFTWARE SERVICE
will Appear on the screen 5. Remove the jumper wire

Use the channel up and down buttons to move between the options
Use the volume control buttons to change the Data
Use the standby button on the remote control to store the data is
Turn the set off at the mains to exit the service mode. CA1 Chassis 37DM23H, 37DT25H, 37ET35H,
37EM33H and 51DT25H 1. Connect a test pattern to the antenna terminal 2. Tune to this signal 3. Turn
the receiver off using the mains button 4. Press the volume down and channel up buttons on the front of
the receiver at the same time 5. Keeping Reviews These buttons pressed, turn the mains on 6.When the
set starts up it will be in service mode 7. Release the two buttons Use the channel up and down buttons to
move between the options Use the volume control buttons to change the Data The Data is stored
automatically at switch off To exit the service mode, press the standby button on the remote control CA10
Chassis51DS02H , 51DS03H, 51DS05H, 59DS03H, 59DS05H, 59ES03H, 59ES05H, 59ESD7H,
66DS03H, 66DS05H, 66ES05H and 66ESD7H 1. Connect a test pattern to the antenna terminal 2. Tune

to this signal 3. Turn the receiver off using the mains button 4. Press the volume down and channel up
buttons on the front of the receiver at the same time 5. Keeping Reviews These buttons pressed, turn the
mains on 6. When the set starts up it will be in service mode 7. Release the two buttons Use the channel
up and down buttons to move between the options Use the volume control buttons to change the Data Use
the standby button on the remote control to store the data is Turn the set off at the mains to exit the
service mode. CS Chassis51CS03H, 51CS05H, 59CS03H, 59CS05H, 59CSD8H, 66CS03H, 66CS05H and
66CSD8H 1. Connect a test pattern to the antenna terminal 2. Tune to this signal 3.Turn the receiver off
using the mains button 4. Press the volume down and channel up buttons on the front of the receiver at
the same time 5. Keeping Reviews These buttons pressed, turn the mains on 6. When the set starts up it
will be in service mode 7. Release the two buttons Use the channel up and down buttons to move between
the options Use the volume control buttons to change the Data Use the standby button on the remote
control to store the data is Turn the set off at the mains to exit the service mode. CW100
Chassis 66DW18H and 76DW18H 1. Connect a test pattern to the antenna terminal 2. Tune to this
signal 3. Turn the receiver off using the mains button 4. Press the volume down and channel up buttons
on the front of the receiver at the same time 5. Keeping Reviews These buttons pressed, turn the mains
on 6. When the set starts up it will be in service mode 7. Release the two buttons Use the channel up and
down buttons to move between the options Use the volume control buttons to change the Data Use the
standby button on the remote control to store the data is Turn the set off at the mains to exit the service
mode.D3000 Chassis DV51083H, DV5903H, DV59083H, DV6603H and DV66083H1. Connect a test
pattern to the antenna terminal 2. Tune to this signal 3. Turn the receiver on 4. Press the service switch
(S1401) located on the Video PWB Use the channel up and down buttons to move between the options Use
the volume control buttons to change the Data Use the standby button on the remote control to store the
Data Press the service switch again to exit the service mode 4BS-B ChassisDV5165H and
DV5180H 1. Connect a test pattern to the antenna terminal 2. Tune to this signal 3. Turn the receiver off
using the mains button 4. Press the volume down and channel up buttons on the front of the receiver at
the same time 5.Keeping Reviews These buttons pressed, turn the mains on 6. When the set starts up it
will be in service mode and SERVICE SOFTWARE will Appear on the screen 7.Release the two
buttons Use the channel up and down buttons to move between the options Use the volume control
buttons to change the Data Use the standby button on the remote control to store the data is Turn the set
off at the mains to exit the service mode. DECO-4 and DECO-5 Chassis DV5105H (DECO-4),
DV5107H, DV5132H and DV5135H (DECO-5) 1. Connect a test pattern to the antenna terminal 2. Tune to
this signal 3. Turn the receiver on 4. Connect a jumper wire between terminals momentarily 2 (GND) and
6 (Service) of the connector of CN1 on the video unit. Note that the wire is used just like a passing contact
switch 5.'SHARP Software Service Ver' will Appear on the screen Use the channel up and down buttons to
move between the options Use the volume control buttons to change the Data Use the standby button on
the remote control to store the data isTurn the receiver off at the mains to exit the service mode 4BSA
ChassisDV3760H, DV3770H and DV5161H 1. Connect a test pattern to the antenna terminal 2. Tune to
this signal 3. Connect a jumper wire between terminals 3 (GND) and 6 (service) of connector TB on the
Main PWB 4. Press the MODE button on the remote control 5. 'SERV' will Appear on the
screen six. Remove the jumper wire To select an adjustment use the channel up and down buttons To
change the Data press the Data buttons The changes are stored automatically Turn the set off at the mains
to exit the service mode. 5BSA Chassis 37AM12H, 37AM23H, 37AT25H and 51AT15H 1. Connect a test
pattern to the antenna terminal 2. Tune to this signal 3. Turn the receiver off using the mains

button 4. Press the volume down and channel up buttons on the front of the receiver at the same
time 5. Keeping Reviews These buttons pressed, turn the mains on 6. When the set starts up it will be in
service mode - 'SERV' Appears on the screen 7. Release the two buttons Use the channel up and down
buttons to move between the options Use the volume control buttons to change the Data The Data is
stored automatically switch off at S3B Chassis DV3750H, DV3751H, DV5131H and DV5150H 1. Connect
a test pattern to the antenna terminal 2. Tune to this signal 3. Connect a jumper wire between terminals 2
and 6 of the service slot on the video PWB 4. Press the MODE button on the remote control 5. 'SERV' will
Appear on the screen six. Remove the jumper wirUse the channel up and down buttons to move between
the options Use the volume control buttons to change the Data Use the standby button on the remote
control to store the data is Turn the set off at the mains to exit the service mode.

Saturday, March 2, 2013 -

0 comments

TYPES OF DAMAGES TV
TV COMMERCIAL DAMAGE
Damage to the TV is not necessarily caused by a faulty TV components. Sometimes damaged by soldering
tin is not good so the legs component is not connected perfectly to the PCB. Symptoms and causes damage
to TV assortment. The symptoms may be totally dead, no sound or image produced ugly. TV damage can
be caused by components that are already with age or the relationship between the components is less
than perfect.
Here are a few references in identifying damage to the TV, but this was not to be the benchmark in
handling damage your TV, please develop in order to be an experience for you. 1. NO PICTURE AND
SOUND Some of the damage that could lead to air TV can not work at all. In general, this kind of damage
occurs in the power supply (Power Supply) or horizontal deflection circuit. A. TV total dead and
indicator lights off. Cause: Most likely damage to the power supply circuit.Action: Check the grid,
regulator circuit input to output. In general, the power supply has a TV output voltage of 115 V, 24 V and 5
V, depending on the brand TV- her.Replace damaged components and fix the circuit path is less than
perfect. B.Audible squeal vibration switching transformer. Cause: Usually the output voltage
short because no component is damaged. Action: Remove the burden of the regulator by disconnecting
the output transistor base horizontally or one leg horizontal transformer and measure the output
voltage. If the output indicates voltage regulator in accordance with the instructions contained in the PCB,
check the entire distribution channel output voltage of the regulator and a whole series of
horizontal. C. Indicator light turns on but the picture and sound does not appear. Cause:
Possible damage to the horizontal or regulator circuit. The voltage generated by the regulator usually

hampered because the diode voltage divider is broken. Not all brands of TVs have this diode. Diodes are
used usually has a serial number and R2KY R2M. Action: on some TV usually there are 2 color indicator
light. When the TV is turned on red indicator, every few seconds to turn green or die and TV shows can be
enjoyed. If the indicator remains unchanged but the color or just a flash means there is a
protection. Check the output voltage of the regulator to the load. If the voltage does not normally mean
regulator circuit is interrupted or no component is damaged and needs to be replaced. D. No Raster But
Sounds Good. Cause: video amplifier circuit, high voltage divider or CRT damaged. Action: Check the
high voltage connected to CRT. Normal ? If normal, check the high voltage cathode CRT. If the measured
voltage is not there, check the high voltage circuit. Check the high voltage to the cathode of the
CRT. Normal? If normal, check the video amplifier circuit. If all normal, check the CRT circuit. The
damage that often occurs is dropping so the CRT filament does not emit light. Cause: CRT anode voltage
is too low as a result of damage to the high voltage circuit, the horizontal deflection circuit or power
supply circuit. CRT cathode voltage all be great because of interference on the video amplifier. Action:
Check the voltage regulator output.Normal? If normal, check the CRT cathode voltage. If not normal,
check the output voltage of the regulator. CRT cathode voltage checks. Normal? If normal, check the CRT
anode voltage. If not normal, check the high voltage circuit. 2) RASTER THE LINES
HORIZONTAL Cause: Sources of interference depends on the oscillator used TV. Action: Check the
circuit vertical deflection Check all electrode IC or a transistor with multitester. A) Synchronization
Horizontal Ugly Strip black can not be missing from raster though synchronization has been set. Cause:
this kind of damage is rare on TV new output. If the damage happens, it is usually caused by a component
that is worn age. Action: Check the horizontal oscillator circuit. Chances are there Elko is dry. Usually
indicated by the back of Elko that looks dull or broken. B) Some Pictures Displaced
Horizontal video signal that is produced is mixed with the input signal synchronization in the circuit
AFC.Action: Check Elko dry or diode leak in the range of synchronization, a series of video buffer and
AGC . 3) Sync vERTICAL UGLY Cause: the damage lies in the integrator or the vertical oscillator
circuit. This kind of damage is usually common in old TV output. Action: Check the vertical oscillator
circuit. Maybe regulator vertical TV long output is worn, while in the new TV damage caused by ceramic
capacitors leak. 4) synchronization HORIZONTAL AND VERTICAL UGLYCause: Most of the
damage occurred on the divider synchronization signal and the amplifier circuit synchronization signal, or
sometimes occur in the circuit AGC and noise removal circuit (noise canceler). action: Check the vertical
and horizontal synchronization. Weak? If yes, check the signal separator circuit sinkrosasi. If the
synchronization signal separator circuit normal, check the synchronization signal amplifier. If the normal
synchronization signal amplifier section, check the AGC circuit and circuit noise eraser. 5. DISABLED
(Distortion) RASTER PATTERN a) Figure Narrow Cause: The output voltage thus lower
horizontal sawtooth current circuit on the horizontal deflection coils (yoke) getting weaker.Action: Check
the output voltage of the power supply. If the output voltage is low, check its components. Check the
horizontal deflection circuit, especially a transistor in it. Check the condition of the yoke, if damaged or
frayed should be replaced b) Widening Horizontal Cause: This kind of damage caused by Vr
damaged.Action: Check components. If the power supply voltage is normal, check the anode voltage CRT
CRT if the anode voltage is too low, check the circuit change the value of VR, if there is no change in the
VR dressing. Check the output voltage of the power supply. If the output voltage is greater high-voltage
amplifier. C) Shortening Image Height Cause: The amplitude of the sawtooth wave in the vertical
deflection coil is too small so that the vertical deflection circuit output is not enough. Action: Check V

SIZE and V LIN. In digital TV, the setting can be done by remote control set on the Adjustment menu. If
there is no change in R and Tr check the vertical deflection circuit. Red arrow is R and Tr in the vertical
deflection circuit is broken. D) Depreciation The Top Or Bottom Cause: Caused by the value Vr is
not appropriate or electrolytic capacitors dry. Action: Set VR, if no significant change VR damaged. Check
Elko are still good or it is dry. E) Figure Vertical AftCause: The current sawtooth at deflection coils
vertical too low. Action: Set VR, if nothing changes may Elko was already dry. F) Figure Ugly 1) Noise
Snow On Fig. Cause: the intensity of the field at a low-frequency signal reception. TV antenna system is
damaged high-frequency amplifier circuit is damaged. Action: Turn the antenna direction to obtain a good
image. Fix path antenna cables Check solder on the block tuner and AGC. 2) Contrast Picture Low Cause:
Damage is located between the circuit mixer until a video amplifier. Solution: Check there is a resistor
whose value has enlarged or short. 3) Appears Dashes Cause: Usually disruption of radio
transmitters. measures: Keep away from the TV antenna and frequency sources of interference. 4) Noise
White spots Cause: disruption of the spark plug for motorcycles, cars or high voltage power distribution
wires. measures: Keep away from the TV antenna and high voltage power cables. Use coaxial cable for
antenna TV 5) Horizontal Black Cause: Usually caused by a device that uses a small motor.Action: Keep
the TV from the noise source. 6) are Shadow Of Other Channel Cause: There was a cross-modulation by
the channels that have the emittance large .action: Adjust the height of antenna TV Set the value Vr at
AGC circuit 7) interference color TV picture looks blue, red, yellow, cyan or green Cause: Usually the
damage occurs due to disturbances in the circuit RGB or CRT. action: Check the circuit matrix RGB, there
is usually a resistor value that expand or soldering has been ugly. If no component is damaged adjust RGB
VR If you still do not get results, check CRT 8) Disorders Sound No Sound / Sound Weak Cause: There
was damage to the audio circuit and speaker. Actions: Touch input audio amplifier circuit with his
fingers. If there was a hiss in the speakers, check the audio IF. If not, check the audio amplifier circuit or
check speaker.

Friday, February 8, 2013 -

0 comments

GENERAL PART OF TV
List Transistor Transistor power
supply C4932 C4237 C5144 C5460 D1655 D1887D1886 D1885 D1884 D1883 D1882 D1710 D1656 D5703
D2498 List IC Power Supply STR-W6753 STR-W6754 STR-W6756 STR-S6706 STR-F6653 STRF6654STR-G6653 STR-50213 TEA 2261 List IC
Vertical LA7838 LA7837 KA2131 AN5521LA7830 IX0640 LA7840 AN5510 AN5512 AN5515 LA78040 TA
8445 UPC1378HList IC Signal Processor (IF) TDA 8360 TDA 8361 TDA 8362 AN 5601 AN 5436 KA
2134 AN 5440 List of IC Sound TDA 2003 TA 82480K AN 5265 List of IC
eeprom24c08 24C04 24C02 24C01 24C16 24C32

You might also like