You are on page 1of 558
saoj2Npuoriwas sdijiyd 9661 INDOTWLVI ASIINOD Semiconductors CONCISE CATALOGUE 1996 5 PHILIPS QUALITY ASSURED ur quality system focuses on the continuing high quality of our components and the best possible service for our customers. We have atthree-sided quality strategy: we apply a system of total quality control and assurance; we operate customer-oriented dynamic improvement programmes; and we promote a partnering relationship with our customers and suppliers. PRODUCT SAFETY In striving for state-of-the-art perfection, we continuously improve ‘components and processes with respect to environmental demands. Our components offer no hazard to the environment in normal use when operated or stored within the limits specified in the data sheet. ‘Some components unavoidably contain substances that, ifexposedby accident or misuse, are potentially hazardous to health. Users of these ‘components are informed of the danger by waming notices in the data sheets supporting the components. Where necessary the warning notices also indicate safety precautions to be taken and disposal instructions to be followed. Obviously users of these components, in ‘general the set-making industry, assume responsibilty towards the ‘consumer with respect to safety matters and environmental demands. All used or obsolete components should be disposed of according to the regulations applying at the disposal location. Depending on the location, electronic components are considered to be ‘chemical’, ‘special’ or sometimes ‘industrial waste. Disposal as domestic waste is, usually not permitted. Philips Semiconductors Concise Catalogue 1996 Philips Semiconductors and Philips Electronics North America Corporation reserve the right to make changes, without notice, in the products, including circuits, standard cells, andlor software, described or contained herein in order to improve design and/or performance. Philips Semiconductors assumes no sponsibility oF liability for the use of any of these products, conveys no icense or ttle under any patent, copyright, or mask work right to these products, and makes no representations or warranties that these products are free from patent, copyright, or mask work infringement, unless otherwise specified. Applications that are described herein for any of these products are {orillustrative purposes only. Philips Semiconductors makes no representation ‘or warranty that such applications willbe sultable forthe specified use without further testing or modification. LIFE SUPPORT APPLICATIONS. Philips Semiconductors and Philips Electronics North America Corporation Products are not designed for use in life support appliances, devices, or systems where malfunction of a Philips Semiconductors and North American Philips Corporation Product can reasonably be expected to result in a personal injury. Pilips Semiconductors and Philips Electronics North America Corporation custumers using or selling Philips Semiconductors. and Philips Electronics North America Corporation Products for use in such applications {do 50 at thelr own risk and agree to fully indemnify Philips Semiconductors ‘and Philips Electronics North America Corporation for any damages resulting from such improper use or sale. Philips Semiconductors and Philips Electronics North America Corporation Tegisters eligible circuits under the Semiconductor Chip Protection Act ‘© Copyright Philips Electronics North America Corporation 1996 All rights reserved PHILIPS SEMICONDUCTORS. CONCISE CATALOGUE 1996 Table of contents 1. General information Preface . Data handbook system . 2. Index Integrated circuits 1.25 Discrete semiconductors 2-61 Circulators and isolators 2-102 High-power kiystrons. 2-103 Semiconductor sensors . ol 3. Integrated circuits (contents) 133 Produc information . 37 Packing quantities Se Competitive cross-reference guide : Liles Package outlines Lill getat 4. Discrete semiconductors (contents) : ‘Small-signal transistors & diodes & medium-power rectifiers Power semiconductors . RF & microwave semiconductors & modules. Marking codes for small devices . Competitive cross-reference guide Packing quantities . Package outlines . ulators and Isolators (contents) Product information . 17 Package outlines 6. High-power klystrons (contents) Product information......... 7. Semiconductor sensors (contents) . Product information Package outlines PHILIPS SEMICONDUCTORS CONCISE CATALOGUE 1996 PHILIPS SEMICONDUCTORS CONCISE CATALOGUE 1996 General information General Information - PHILIPS SEMICONDUCTORS: General information CONCISE CATALOGUE 1996 PHILIPS SEMICONDUCTORS CONCISE CATALOGUE 1996 General information CONTENTS Data handbook system... PHILIPS SEMICONDUCTORS General information CONCISE CATALOGUE 1996 PREFACE The standard type range This Concise Catalogue will provide you with a compact, handy reference to the Philips Semiconductors standard range of integrated circuits and discrete semiconductors, offered for sale through our extensive and worldwide network of National Sales Organizations. We recommend that you consult with your local Philips Semiconductors sales organization for information regarding full data, price and availabilty of these products. The Philips Data Handbook System For complete specifications of the components listed in this catalogue, please refer to the relevant ‘volume of the Philips data handbook, which is indicated in the alphanumerical index of this catalogue. ‘A complete list of the Philips integrated circuit and discrete semiconductor handbooks appears on next page of this catalogue. ‘The Philips data handbook system comprises more than 65 books, classified into six series: Integrated Circuits Discrete Semiconductors Display Components Passive Components Professional Components Magnetic Products Data handbooks contain all pertinent data available at the time of publication and each is revised and reissued regularly. Loose data sheets are sent to subscribers to keep them up-to-date on additions and alterations made during the lifetime of a data handbook. Catalogues are available for selected product ranges (some catalogues are also available on floppy disks). More information from Philips Semiconductors? For more information about Philips Semiconductors data handbooks, catalogues and subscriptions, contact your local Philips Semiconductors sales organization listed on the back cover of this catalogue. Product specialists are at your service and enquiries are answered promptly. v4 PHILIPS SEMICONDUCTORS: CONCISE CATALOGUE 1996 General information DATA HANDBOOK SYSTEM In the alphanumeric index (Section 2), reference is made to Philips Semiconductors’ data sheets or data handbooks. These data handbooks contain all pertinent data available at the time of publication and each is revised and reissued regularly. Loose data sheets are sent to subscribers to keep them up-to-date on additions or alterations made dirng the Wetie o'a data handbook a Catalogues are available for selected product ranges; some catalogues are also on floppy disks. For more information about Philips Semiconductors handbooks, catalogues and subscriptions contact, your nearest Philips Semiconductors national organization listed on the back cover of this catalogue. For this catalogue, the following data handbooks are of interest: Integrated Circuits handbook series Discrete Semiconductors handbook series book tile book tite {Cot Semiconductors for Radio and Audlo Systems SCO1_ Diodes 1002 Semiconductors for Television and Video Sc02 Power Diodes Systems C03 Thytistors and Tiiacs 1003 Semiconductors for Telecom Systems C04 Smal-signal Transistors 1Co4 CMOS HE40008 Logie Family SCO5 Low-frequency Power Transistors and Modules 1C06 High-speed CMOS Logic Family ues IC11 Goneral-purposertinear Ics $006 NN Pome testes"? Ic12 °C Peripherals SCO7 Smal-signal Field-etfect Transistors 1C13. Programmable Logic Devices (PLO) SCOBa_RF Power Transistors for HF and VHF C14 B048-based 8-bit Microcontrolers SCosb RF Power Transistors for UHF ICIS FAST TTL Logie Series C09 RF Power Modules 1C16 CMOS Integrated Circuits for Clocks and $010 Surface Mounted Semiconductors Watches S013. PowerMOS Transistors 1617 Wireless Communications Inejucing TOPEE Ts nt IGE SC14_ RF Wideband Transistors SC15 Microwave Transistors SC16 Wideband Hybrid IC Modules SC17_ Semiconductor Sensors IC18 Semiconductors for In-Car Electronics (planned) 119 ICs for Data Communications 120 80CS1-based B-bit Microcontrollers 122 Desktop Video 123 QUBIC Advanced BICMOS Interface Logic QUBIC Advanced Prtenonl Components handbook sre (stn) 1C24 Low Voltage CMOS & BICMOS Logic exe ikeds Elsecok doesiock halecechaoates PCO1 High-power Kiystons and Accessories (eXtended Architecture) PCO6_Gircuators and Isolators ay PHILIPS SEMICONDUCTORS General information CONCISE CATALOGUE 1996 Philips Semiconductors Concise Catalogue 1996 CONCISE CATALOGUE 1995 Alphanumeric index Index = DATA SHEET AVAILABILITY (see column “Handbook") Gx, SCxx or PCxx: see Data Handbook DS-00x: see loose-leaf Data Sheet sales: contact your local Philips Sales Organization for a copy of the most recent Data Sheet 2A Philips Semiconductors Concise Catalogue 1996 CONCISE CATALOGUE 1995 Alphanumeric index 22 Philips Semiconductors CONCISE CATALOGUE 1995 CONTENTS: Integrated Circuits occ tala Paledabahdat cee BS Discrete Semiconductors . Circulators and Isolators High-power Kiystrons ‘Semiconductor Sensors . Philips Semiconductors Concise Catalogue 1996 CONCISE CATALOGUE 1995 a Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype rand age number description SMD book a INTEGRATED CIRCUITS 10149 1024: ECL bipolar PROM (256x8) CIPI ‘sales es 101490 1024-bit ECL bipolar PROM (256e8) = CDIP16. sales es s0HZOEVE4 ECL 10KH PAL-ype device opip24 PLoces rors 6 TAABTOO (Quad 2-nput NAND gate Dipt4 8014, SSOP14 TssOPt4 sales 7 7AABTOR (Quad 2-nput NOR gate bipia 8014, SSOP14 TSSOP14 ‘alos 7AABTOA Hox ievertor pips 8014, SSOP14 TssoP14 sales 7AABTOS. (Quad 2-nput AND gato pipta 8014, SS0P14 TSSOP14 sales TansTio “Tiiple 3input NANO gato Dita 8014, SSOP14 TssoPt4 sales ‘7 TAABT125 (Quad butt biPia 8014, ssoP14 TSsOPI4 e23 87 ‘74aBT128 (Quad but opis 8014, SSOP14 TssoPi4 1025 °7 T4ABTI61543 16-bit latched transceWver ‘SSOPS6, TSSOPS6 S023 58 T4ABT162240 16-bit invortodbutler SSOP48, TSSOP48 sales 57 74NBT162244 16-bit butforfine diver SSOP48, TSSOP48_ sales 57 TAABTI62245 16-bit vansceiver sales 58 T4asTi6240 162i invorterbutr SS0P48, TSSOP48 sales 57 74ABTI6240-1 16-0 uterine driver SSOP48, TSSOP48 sales 87 74aBTi6241 16-8 butler SSOP48, TSSOP49 sales 57 TARBTIE244A 16-bit bufferfine diver SSOP48, TSSOP43_DS-C23 57 TAABTI6244-1 16-0 uterine diver SSOP48, TSSOP43_DSC23 87 T4ABT162458 16-bit ranscolver SSOP48, TSSOP4S sales 5a TAABTI62I5A-1 16-bit bus transceiver SSOP48, TSSOP48_ S023 5a 74ABTI62543 16-bit latched tranecalver, dual enable SSOPS6, TSSOPSS. sales 58 ‘74ABT16273 16-bit D-type fip-op with reset SSOP43, TSSOP48 05.1023 57 TARBTI6273A 16-bit Dp fip-fop with reset SSOP48, TSSOP48_ sales 57 74ABT163738 ——_16-btransparant latch ‘SSOP48, TSSOP48 05-1023 7 T4ABTIOS7AB_ 16+ D-type fip-lop ‘SSOP48, TSSOP48 05-1023 7 74ABT165000 18-bit bus transcoWver ‘SSOP56, TSSOPS6 DS:1C23 58 TAABTIGSOIA 18-5 bus transceWver 'SSOP56, TSSOPS6._DS-CZ3 58 ‘TARBT 16543 16bit latched transceiver, dual enable 'S80P56, TSSOPS8 _DS-1C23 58 74ABTI6646 16-5 bus ransceivedtogistr ‘SSOP56, TSSOPS6 DS-1023 58 ‘TaABT 6652 16 transceiverregister 'SSOP56, TSSOPS.DS-ICZ3 58 T4ABTI6S21A 20-8 us interace register SSOPS6, TSSOPSS _DS-IC23 7 74ABT16823A 18-bit bus interface regi ‘SSOP56, TSSOPS6__DS-1023 7 TARBTIG825A 16-bit bus interface rogisor ‘SSOP56, TSSOPS6 sales 87 T4ABTI6827A 20-bit ule ine aver ‘SSOPS6, TSSOPS6 sales 7 74ABTI6841A —__20-Dt bus interiae latch ‘SSOPS6, TSSOPS8_ 5-023 57 ‘74nBT16090 ‘sB-bit latch transcelver, 8 party 'SSOPS6, TSSOPS6 sales 58 TARBT16952A 16-bit registered transceiver FPse sales 58 74nsT20 Duel 4-input NAND gate Dipti 8014, SS0P14 ssoPt4 sales 87 TAnBT2240 (Cota averting butter iPz0 ‘8020, $80P20 TSSOP20 sales 87 ‘aasto2as (Cota butferine driver iPz0 8020, SS0P20 TSSOP20 sales 7 TanBT2205, (Octal wansceiver with erection pin iP20 ‘8020, Ss0P20 TSsoP20 sales cy 25 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index type package hand page ‘umber description through-hole SMO book o aasTo40 tal ivoring butler ipa0 8020, ss0r20 Tssore0 wos 7 TAABT240 See 74ABT2240 o1p20 S020, ss0r20 ss0P20, vc23 57 ansross tal bute diver o1pe0 020, ss0F20 rssoP20 1020 7 ranora4e ctl buterine ver oreo $020, $S0F20 ssor%0 12a sr Tansraset Soo 74nT2244 oreo 18020, SS0P20 ssore0 120 7 ransra4s Octal transceiver wih drecion pin ———IP20 S020, ss0P20 ssoPe0 128 se TanBTess| Seo 4a T2245 irz0 5020, ss0°20 ‘Tesoro waa s THABTZT&A ——_ Oca ype Hoop oreo 3020, S0P20 score sales 7 TANBT2052. Octal rior tanscever pee So2e, ss0re6 ssoP24 123 38 T4ABT2I69 Octal egitered vansotver wires S024, ss0P2« yssores 1020 8 anorse Cad 2sinput OR gate bit $014, SS0P14 ssoPt4 sales 57 TAABTITGA Octal Dtype transparent itch ireo $020, ssoP20 {score 7 TAABTITAA Od! DAype ipton pos-edge ing: 0120 S020, ss0r20 ssoP20 sales sr ransror7 (ctl yp fipsop wih enabio o1re0 $020, ssore0 Tss0P20 co 7 aasra7e4 Programmable DRAM controler ‘rPioo sales ° TANBTSO7A ——-Sym_ al ype fipopock ver IPI $014, SsoPt4 sso sales se TAABTS4 ‘octal yp fp op, invring o1re0 S020, 80°20 yssore0 120 7 TanBTS40 (ctl bt, inverting o1re0 S020, ssor20 ssoP20 eas sr TaasrsAt (ctl bterine ver o1P20 020, ss0F20 ‘ssor20 1o2s = T4NGTS#3A Oca acd tanscevr, dual enable IPR S024, ssore4 Tesore4 sales 38 ransTsAs (ctl atcod taneceive, dal nadie —_DIP24 Soze, ssorz4 ‘scores 120 se T4NBTSTSA Catal DAype transparent teh o1re0 S020, ssor20 res0P20, sales 7 THABTETIA —_ Octal ype tp fop o1re0 020, 80°20 ss0r20 sales 7 ansre20 ‘uta vansceiver wih dal enable o1re0 13020, SS0FZ0 TssoPe0 123 se ransro23 Catal vansetver wth dul enable o1rz0 5020, 80°20 ssoP20 128 se ransre40 ct! ranscetver wth econ pn vireo 3080, S0P20 ssor20 120 8 TAASTEAGA Octal bus ranszaverogistar irae 5024, Ss0P26 ssoPes sales 36 ansroes otal bus ranscavaregiter oirea S024, ssoree yssoree wea 38 26 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype hand page umber description sMo book = TaaaTest ‘Osta rarscalvertgiter oiPes 024, ssoP26 TssoP26 sales Ey TAABTESZA Osa bus ransoawvertegster ores 3024, 5026 Tesoro sales Ey 74ABT657 (Octal wanscever, patty gon/checker —_vIP24 024, SS0P24 TssoP24 12a 50 raaBT74 Dual D-ype Mp-top ova S014, SS0P14 TssoPt4 sales s ranere21 10-8 D:ype tp-top iP24 5024, SS0P24 Tss0P24 123 sr ransTe23 8. D-ype fip-op, reset and enable OIP24 5024, SSOP24 TssoP24 tz 87 ransTea7 10-8 butfrtine diver ira 024, SS0P24 Tss0P24 tz s TaAsTESS (tte transceiver arty genicheck ——vIP24 5024, SSOP24 TssoP24 123 52 TaneTeAt 10-bit interac tach ire 024, SSoP24 Tss0Pe4 12a °7 TAABTOAS it bus norfaco lath, set and eset DIP24 8024, SS0P24 TssoPes tox s 7anToAS ‘S-Lbus iteace latch, set and reset —_OIP24 3024, SS0Pz4 TssoP26 tc23 sr 7anoTa59 -t ranse, 9 par. checkergen oires 3024, S024 Tss0P24 tc2a 50 anerTe61 ‘0-0 bus transceiver oiPe4 S024, SS0P24 TssoP24 120 se 7AABTO69 ‘9-8 bus vanscever ores 5024, SSOP24 Tss0Pz6 1c2a 58 74aaT899 It dual atch vB par. genohk ——OIP28 $028, PLoc2s cz 58 74ALSOOA (Quad 2ingut NAND gate, ors sou sales e Taa.so2 (Quad 2input NOR gate ois soi sales 62 74ALS048 Hox inverter os sou sales 3 74a.s08 (tad 2rput AND gato Dip sor ales e2 T4ALS100A Dual JK postive-edge tog. psp IPS sie sales 2 T4ALSi0A “Tiple input NAND gato Dis sou sales 82 TARLSS124 Dual JK negatve-edge tgs fip-top IPTG 5016 sales e2 TAALSHIA Tiple input AND gato oii sow sales e2 74ALS138, ne to B'ine decodedéemuitplxer DIPS 5010 sales et HaALsi90 Dual 2tne to sne decoderdemix ——_IPTS sore sales 8 24ALSi51 Bene to tne mitplexer DiPie S019 sales 63 74ALS189 Dual ine one mulplxer Opie 5016 sales 6 HaALsis7 Quad 2input data soloctorimitipiexer ——DIPIS 5016 sales 6 7AALS158 Quad 2input data selectormatpiexer ——DIPIS 5016 sales 6 7AaLsie1e Synchronous bt binary courtr DPI sos sales 60 74ALS698 Synetronous «bt binary counter Die S016 sales 60 TAALSi64 © seranparalo-ou ht 69, Dis S014 sales 64 7anisi7a Hox D-type pop wih reset DiPse soe sales 6 TAALS175 usd D-type edge wiggeed pop DIP S016 sales 6 74ALS191 Upfaown Binary counter ois S016 tales 6 7aalsis3 ‘Schr presetble 4 binary counter DIPS sore ses 8 T4ALS20 Dial input NAND gate ois S014 sales e TAALS2408 ‘Octal inverter butler oipe0 $020 aes 0 74ALS240K-1 Octal ivrtr butler oreo 020 ses 60 TAALS2UIA Octal biter oip20 S020 sles 0 TARLS261A-1 Octal bulfor oiPe0 8020 sales 60 TANLS2440 Octal butor oip20 S020 sles 0 27 Ni Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number description through-hole SMD book os TAALS244A-1 Octal butler 1Pe0 soz 60 T4ALS245A (Octal bus transceiver 1P20 3020 es TAALS245A-1 Octal bus transceiver o1P20 8020 oe TAAts25i Bin to tn multiplexer DiPI6 8016 63 7AALS253 Dual na to tine mutiplxor DiPt6 S016 ca 74A.8257 ‘Quad 2-nput data slectormuttpixer IPTC S016 6 74nL8258 (Quad 2.input data sloctrmutipixer PIC 8016 6 74nLse7 “ipl input NOR gate opie 5014 62 74At5273 ‘Ocal D-ype tip-top with reset iP20 18020 6 TAALSSOA ‘input NAND gato Dit S016 @ 74at832 ‘ud 2p OR gato opis soi 2 74AL8373 (Octal transparent atch iP20 020 6 74ALS574 Octal D-type tp-op oiP20 8020 a 74AL8877 (Octal D-type tiptop with clock enable DIP20 020 61 TARLSOBA (Quad 2-nput NAND butfor bipta sors 62 TAALS543 (cal registered vanscaiver s0IP24 S026 64 T4ALSS43-4 (Octal registred tanscoiver soip2s S024 64 TAAL S508 (Octal registred tanscaiver soip24 S024 64 TAALS5A41 (Octal registred transceiver soipes 8024 6s TARLSSESA ‘Octal transparent atch iP20 8020 6 T4ALSBSAA ‘Octal D-type tip-top DiP20 ‘3020 6 74ALS5738 Octal ansparent atch iP20 8020 63 TAALSS74A (tal D-type fi op 120 020 6 74ALS8208 Cctal bus transceiver iP20 3020 6 T4ALSE2OA1 Octal bus transceiver 120 020 6 TAALSSA5A Octal transceWver 1p20 8020 6 T4ALSEASA1 Octal transceiver oiP20 020 6 TAALS848 (Octal bus transceiver and register soipzs S024 65 74nt36464 (Octal bus tanscoiver and register soipe4 8024 65 74AL8648 ‘Octal bus transcoWer and reisor s0iP24 ‘8024 65 TAALSO48-4 ‘Octal bus transceiver and register soipes 8028 65 74A.se51 ‘Octal transceiver and register sips 8028 65, 74ALSE5I-1 (cal ansooiver and register Sipe 8026 6 74ALS652 (cal ranscoWver ard regstar sbiP2s 5024 65 74ALS652-1 (cal transceiver and register spiP2s $028 65 TAALSTAA Dual O-ypo odgo-tigoredfip-too DiPts sor 6 7AALS86 (Quad 2-Iput EXCLUSIVE-OR gate Dips 5014 2 T4ALVC164245 —_Y6- dua-supplytansaing tance 'SS0P48, TSSOPA8 20 T4ALVCHI62244 16-bit 30 bulfertine criver SSOP48, TSSOPA8 2 T4ALVCHI62245 16-bit 30.0 bus trans with dt. pin SSOP48, TSSOPA8 30 T4RLVCH16240 16 bufferine ver 8048, TSSOPA8 27 T4ALVCHIE241 16 bufferine dfvor SSOP48, TSSOP48 2 TAALVCHI6244 16-bit butfertine diver SSOP48, TSSOP48 2 TAALVCH6245 16-58 bus transceiver with dr. pin SSOP48, TSSOPA 90 TAALVCHIG373—_ 16-bit D-ypo transperant latch 'SSOP46, TSSOPA8, 28 TAALVCHIBS7A 16+ ea tiggorod D-type flip-top 'SSOP48, TSSOPA8 28 TAALVCHI6470 164i registered transceiver 'SSOPS6, TSSOPS6 30 TARLVCHYE500 18-bit nivesal bus transceiver SSOPS6, TSSOPS6 30 T4ALVCHI6501 18-bit uiverel bus anscelver SSSOPS6, TSSOPES 30 TAALVCHIES40 16-5 butertine diver TssoPd8 2 TARLVCHIGS41 16> bufertine diver TSSOP 48 28 TAALVCHI6543 164i Diype registred transceiver ‘SS0PS56, TSSOPSS 20 74ALVCH19600 18-bit universal bus transceiver 'SSOPS6, TSSOPSS 20 TANLVCHI6501 18+ universal bus transceiver ‘SSOP56, TSSOP56. 1024 30 7AALVCH16623 16-bit ranscever with dual enable SSOPAS, TSSOPHB 1024 20 TARLYCHTO646 162 bus ransceWvorogistor SSOPS6,TSSOPSS IC24 30 28 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype. package hand page umber description through-hole__SMD_ book a T4ALVCHt68S2 16-bit ransc register wih dual enable ‘SSOP56,TSSOPS6 1024 20 ‘T4ALVCHT6952 16-bit ragstered transceiver ‘SSOPS6, TSSOPSE 1626 20 74H1C00 (Quad 2-input NAND gate opt4 8014, SS0P14, TSSOP14 108 8 ‘aHco2 (Quad 2input NOR gate oipa 8014, SS0P14, TssoP14 1008 48 ‘7aHicoa (Qued 2-nput NAND gate pipia 8014, S80P14, TSSOP1s 108 8 ‘aH1Co4 Hox inverter opr 8014, SS0P14, TssoP14 1008 40 eo ‘7aH1C08 ‘Quad 2-nput AND gate ops 8014, 880P14, TssoP14 Ios a 7aHc10 “Tiiple 2nput NAND gate ops 8014, SS0P14, TssoPt4 1008 ry vaHc107 Dual JK tip-top with reset ppt 8014, SS0P14, TSSOP14 1606, a 7aH1C109 ‘Dual J tip-top with set and reset pipe 8016, SSOP16, TSSOP16 1006 a anon “iple 3.input AND gate pipt4 S014, SSoP14, ‘TSSOPtS 1006 a raHcr12 Dual JK tip-top with set and reset opie 8016, SS0Pt6, TssoP1s 1006 a 7aHo123 Dual retriggerable monovi with reset IPG 8016, SSoPt6, TSSOP16 108 49 Taos ‘Quad butfertine diver opis 8014, SS0P14, TssoP14 108 6 aHC126 (Quad butfertine dvor pipa 8014, ssoP14, TSsOP14 1008 6 7aHo1s2 ‘Quad 2-input NAND Schmit tigger oips4 8014, SS0P14, TSSOP1s cos 48, 49 74H0153 ‘13:input NAND gate pips 8016, SsoP16, TssoP16 1008 8 vaHie1s7 ‘34088 line decoder/dernutiploxer pps 8016, SSOP 16, ‘TSSOP16 Ico a 7aHC138 340.8 line decoder/demutiplexer DiPie 8016, SSOP 16, ‘TSSOP16 108 a 7aH0139 Dual 204 line decoderldemutiplexer —DIPI6 8016, ssoPt6, TSSOP16 tos a aHots Hx inverting Schmit tigger ppt 8014, ss0P14, TSSOPt4 1006 «0 7aHo17 ‘104104 Ine priority encoder DiPte 8016, SSOP 16, TssoPt6 1006 a 7aHC151 B.rput multpexer opts 5016, SS0P16, ‘TSSOPI6 ‘cos 43 aera ual ¢nput mutiplexer DiPte 8016, SSOP16, TSSOP16 106 cy 7aHC154 “440-6 line docoderidemutiplexer Dipz4,s0IP2¢ S024, SSOP24, TssoP24 1006 a raH187 (Quad 2-nput multiplexer oie 8016, SSOPI6, TSSOPI6 106 48 raHe153 ‘Quad 2.nput mutiplexer opis 8016, SSoPt6, TssoP16 106 ry 7aH160 Preset. synchr. BCD decade counter IPG 1008 48 7ancre1 Preset. synchr.4-bit binary countor pips 8016, Ss0P16, ‘TSSOP16 108 48 28 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index package hand page number description through-hole SMD_ book as ranctee Prose sync, BCD decade counter PIS 5016, ssorie, Tssorte 1006 ” ranctes Prose sy. ary couner PIS Bore, SsoPte, Tssorte 1008 « ances bit sevabivperabeout shines, «PA Sore, sso, Sssorie 1008 * ranotes Gi sort paratout shir opis Sore, Ss0P6, Tssorte 1008 ates bt sorativperatctout sities. «PIG 018, SSOP, JscoPie 1606 ~ rants ed o-ype ip-top pis Sore, ss0P16, Tssorte 1e08 ” ranot74 Hox 0:ypefpsop wh raat pris Sore, ss0Ps6, Tssorte 1008 a nanos ‘ad D-ype fon wi set pie Bore, SSOP16 ‘Tseorte 608 « ranotes «bt artetc ge unit vires, soIp24 S024, SSOP, scores 1008 * vance Looked cry generator opis Sore, Ss0Pt6, ssorte 1608 “6 aHct90 Prose syn BCD decade uptown counter DIPIS 5016, SSOPT6, Fssorte 1008 “ ranotot Preset. syn. 4 nay upiown cnt. DIPIG Sore, 8S0P%6, TesoPte 1606 “6 rancree Preset, yn BCD decade uptown counter DIPIS Bore, SS0Pt6, ‘ssorte 1008 * ravers Preset sy 4 bay uptown oI Sore, SsoPte ‘ssoPe v.08 * ances ‘ide, utversl shit oir pie Sore, sorte, ‘ssoPte 1608 ° rancts ‘i para acces regtr pis 5016, sS0Pt6, TssoPte 1608 anc20 ual input HAND gate piers Bore, SS0Pt4, Tssorte 1008 “ rane Dual put AND gate ors Sore, ss0P14 Teor 1606 a ranceat Dus ont. manovb wih eset PIG Sore, Ss0Pt6, TssoPte. e068 ra rancest 109 tne decodeéemsleer ois Sor ssoPs6, score eos ” raneas8 08 tne decoseréomipexer opis Sore, sS0P16, Tssorts coe ” aHc240 ot uterine ver o1re0 3020, SS0°20, ‘ssorco 1608 * rancest Ct butetin ver vireo 5020, 80°20, ‘esorz0 1608 « vance ued bs ranscaver piers Sone, S80Pt4, Tssore i606 0 rane cud bs ranssver pews Bore, sso Tesorie 1606 so vances Octal buortine iver o1P20 5020, SS020, {Ssor20 1008 “6 ances Cot bus tanscoier P20 3020, SS0P20, ‘ss0P20 1608 %0 acest input matic ois 5016, 80°16, yscoPie 1608 « 20 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number oscription througtviole SMD book = 7aHco59 Dual input mutiplexer oPi8 8016, ss0P16, TssoPi6 108 4 7aHo257 (Quad 2nput multiplexer Dre 5016, SSoPt6, TssoP'e ico 48 raHc250 (Quad 2snput mulpecer ps6 016, ssoPt, TssoP'6 106 4 ranc2se ‘it accresable atch pre 5016, SSOPtE, TssoPi6 tos « rasicar Tiple input NOR gate iPr 0%4, SSOP, TssoPt4 1008 rancor (octal D-ypetpsop with reset D1P20 020, SS0P20, Tss0P20 108 740200 Sit edafeven party generatovchecker IPA 5016, SSOP14, TssoPi4 108 rancaea {bi binary fll adder win fast cary PIB 5016, SSOPI6, TssoPi6 1co8 4 raHcos7 Digtal phase ockedoop titer oi 8016, SSOPt6, Tss0P16 te08 «0 anc299 2. universal ait register Dire 18020, sS0Pz0, Tss0P20 too, 49 zatica0 input NANO gate opis 014, SSOP14, Tssorts ico 4” rans {Quad 2input OR gate pips S0%4, SS0P14, TssoPis 108 48 raHcase input mudogitor wth aches o1P20 020, SS0P20, Tss0P20 108 49,49 raNcase ‘input mutplxedrogister o1P20 13020, SS0P20, TssoP20 1008 48,49 aHC008 Hex butting driver ore 5016, sS0Pt6, TssoPi6 tos 46 7480908 Hoxbutertine ver ois S016, ssoPt6, TssoPI6 ioe 46 7aHC367 Hex butane ever oie S016, ssoPre, TssoPi6 108 “6 rates Hox bute drive ore 8016, S50P16, Tss0Pi8 108 “6 ranosrs ‘Octal D-ype transparent atch o1P20 5020, SS0P20, Tssor20 ‘08 "7 racers Octal Daypefipop o1P20 3020, sS0P20, Ts50P20 106 a rancor cal Dypefip-op wth data enab. P20 8020, ss0P20, Tss0P20 tos a 7aH0300 ual decade ripple counter ois 016, SSOP, Tssor'6 toe 4 7aH389 Dual i tna Apple counter pips S014, ssoPt4, TssoPi4 tos 46 astcao02 ua input NOR gate ops S014, SsOPt4, Tss0Pt4 108 “ 7aHHo40102 82it synchronous BCD down counter IPIB 5016, SsoPre, Tss0P16 108 “6 7aHicao103 ‘it synchvonous binary down counter IPI 8016, ss0Pt6, Tss0P16 108 46 TaHCAo104 “+1 bit. universal sit register ore 8016, ssoPt6, Tsso'6, eos 4 7aHCA0105 401 16 word FIFO register oie 8016, sSoPt, TssoP16 cos 4 Philips Semiconductors. Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype package hand page number description throughhole__SMD book 2 aHc4o1s Dual 4-bt ser vpar-out shit re. pips 8016, SSOPI6, TSSOP1B 1006 49 raHcao16 ‘Quad bilateral switches pips S014, SSOP14, TssoPt4 tc06 «0 ‘7anc4o17 Johnon dee. counter with 10 decoded op DIPI6 8016, SSOP 16, TssoP16 008 8 raHca0z0 ‘4-stage binary pple counter orri6 8016, $8016, TSSOP16 106 6 7aHca024 7-stage binary Hipp counter ors 8014, SS0P14, TSSOP14 1006 6 7aHc4o4o 12-stage binary pple counter opis 18016, SSOP16, TSSOPI6 too 46 ‘7AHCA0K6A Phase-ocked loop with VCO pipt6 8016, SSOP16, ‘TSSOP16 1008 49 7aHc4049 Hox inventing HIGH-o-LOW level shiterDIPI6 016, 85016, ‘TSsOPt6 c08 «s 74104050 Hox HIGH-t-LOW level shiter pis 8016, SSOP 16, ‘TssOP16 1008 8 ‘aHc40s1 ‘channel analog mudemux Dis 8016, SSOP 16, TSsOP16 te06 «8 7AHC4052 Dual 4-channel analog muxidemux pis 8016, SSOP 16, ‘TSSOP16 06 “8 7aHiC4053 ‘eiple 2-channel analog muxidemux DiPt6 18016, SSOP16, TSSOP16 106 “3 7aH104059 Programmable divide-by-n counter Dip24, sDIp24 $024, SSOP24, TSSOP24 1006 6 74H1¢4060 ‘4-stage binary pple counter with ose. DIPY6 8016, SSOP 16, ‘TssOP16 cos 48 7aHC406s ‘Quad bilateral switches Dipi4 8014, SS0P14, TssoP14 Ico 49 ‘7aHc4067 ‘16:channel analog muxddemux Dip24, soIP24 S024, SSOP24, ‘TssoP24 1006 48 aHo4o7s ‘Triple input OR gate pips 8014, SSOP14, TssoPt4 e068 a 7aHCA004 8-stago shit-ane:-store bus register pris 18016, SS0P16, ‘TSSOP16 06 cy rancaa [BCD to decimal decoder (1-01-10) pipie 8016, SSOP 16, TssoP16 cos a7 7aHo42s Duel retiggerable monovb with reset IPI 8016, SSOP 16, TSSOP1S tc08 « 7aHcas16 ‘Quad blatoral swtches. oPi6 8016, SSOP 16, TSsOP16 1008 «9 7aHCA361 ‘-channel analog muxidemux with latch DIPZ0 ‘8020, SS0P20, ‘TSS0P20 106 cy 7aHo4s52 Dual 4channel an. maddemux wit atch DIP20 ‘8020, SS0P20, ‘TSS0P20 1006 “a aHc4369 “Triple 2channel an, muxddemux w. latch DIP2O 8020, SS0P20, ‘Tss0P20 to06 4 7aHCASI0 BOD upldown counter pipis 8016, SS0P16, TSSOP1S te06 48 7aHoAstt BCD to 7-segmentlatchidecoderidrver IPI 8016, SSOP 16, TSsoP16 106 a 7aHoast4 410-16 ine decodeddemuttploxer Dip24, sDIP24 $024, SSOP24, ‘TssoP24 1006 a 7aHC4515 440-16 tne decodertdemutiploxer Dipz4, spIP2¢ S024, SSOP24, ‘TSSOP24 08 a 22 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page umber description through-hole__SMD book 3 7AHCA516 Binary upidown counter piPis 8016, Ss0P16, TSsOPI6 1008 46 7aHeAst6 ual synchronous BOD counter pips 8016, SsoPt6, TSSOP16 ‘c06 46 74114520 Dual synchronous 4-bit binary counter IPG 8016, SSOP 16, ‘TSSOP16 1006 46 7aHcas38 Dual retiggerable precision monovib IPG 8016, SSoP16, TSSOP16 106, 4 TaHC4543, BCD-t0-7 segm. latchidec ir for LCDs IPG ‘8016, SSOP 16, ‘TSSOPIB 106 7aHios33 (Octal D-type transparent latch iP20 18020, S020, T5SOP20 10s TaHCS34 (Octal ype fip-op b1pz0 ‘8020, S50P20, ‘TssoP20 106 7aHes40 (Octal uterine dever iPz0 ‘8020, SS0P20, TssoP20 1006 6 7aHCs41 Octal butetine diver oip20 8020, 88020, T3S0P20 ‘cos 46 7aNCS555 Programmable delay imer with osclatorDIPI6 8016, SSOP 16, TSSOP16 1008, 49 7aH0563 (Octal D-ype transparent latch iPz0 ‘8020, SS0P20, ‘TssoP20 06 a 7aHCS64 Octal D-type tip-top iP20 ‘8020, SS0P20, TssoP20 1006 a 7AHes73 (Octal ype transparent latch iPz0 ‘8020, S30P20, ‘TssoP20 1008 a7 raHos74 Octal Daype tip-top oiP20 8020, $8020, TssoP20 1008 ar 7aHos8 Dual AND-OR gate pips 014, Ss0P14, TssoPi4 so08 a7 7aHCs63 4b ull aor wit fast cary pits 8016, SS0P16, TSSOP16 1006 48 ‘aHoso4 ‘It chit register wih output reg pire. 8016, SSOP, ‘TSSOPI6 108 49 74HC595 B-bitser-inser. or par-ut sh 9, Dit 8016, SSOPI6, TSsOP16 1006 49 7aHs97 {It shift register with Input latches oipt6 016, ssoPt6, TSSOPI6 1008 49 74H83234 Programmable ripple counter wih oso. soa 1008 6 7aHics40 cal bus transceiver oiP20 ‘8020, $8020, TSSOP20 1008 50 7aHCs4s (Octal bus transceiver P20 8020, $8020, ‘TssoP20 008 50 7aHCese (Octal bus transceiverregster Dip24, SoiP2¢ $024, SSOP24, ‘TssoP24 106 50 raHo648 (Octal bus transcelverrgis Diz, soip2¢ S024, SSOP24, TSSOP26 108 50 aH852 (Octal registered bus transceiver biz ‘S024, SS0P24, ‘TssoP24 108 50 ‘aH1o570 4x4 rogister fle oiPt6 8016, SsoPt6, TSSOP16 108 49 7aHC888 ‘Sit magnitude comparator iPz0 ‘8020, S$0P20, TSSOP20 1008 46 TaHcrO14 Hex inverting Schmit tigger ois 8014, $8014, TSSOP14 1008 28 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number description through-hole SMD book 3 74HC7090 8-0 x 64-word FIFO register o1Pe8 028, SS0P28, Tss0P28 108 49 74HC7O46A PLL with lock detector pts 016, SSoPI6, ‘TSSOPI6 to08 «0 raH07080 {16-5 everdods party genchecker o1P20 8020, sS0P20, Tss0P20 1006 48 rancrise ‘Quad ac. prcision Schmit tigger biPts $014, SSOP, ‘TSsoPi4 106 « 7ancT248 (octal bus Schmit tigger transceWver P20 8020, ss0P20, ‘Tss0P20 tos 49,50 7aHo7266 (Quad 24nput EXCLUSIVE-NOR gate IPI 8014, SSOPI4, ‘TssoPi4 106 4 rano7s Duel JK fip-op with reset oir 8014, SSOPt4, ‘TssoPi4 1006 a ravers Dual DAype tpsop with set and reset DIP14 8014, SSOPI4, ‘TssoPta 1006 a 7407408, 4b 6¢-word FIFO register oiPis 016, SSOPI6, TSSOP 16 1006 4 7aHoT404 52x 64word FIFO rogisor oiPt8 8020, $S0P20, ‘Tss0P20 1008 4 7aHC7S (Quad bistable transparent latch DiPi6. 8016, SSOPI6, Tss0Pi6 tco6 4 raHc7s40 (Octal Schmit tigger butertine diver IP20 18020, SS0P20, ‘Tss0P20 108 46,49 7aHCTS41 (Octal Schmit tigger butlertine diver IP20 ‘8020, SSOP20, TSs0P20 1008 46,49 7aNCTSS7 {it shit register with input latches ‘8016, SSOPI6, ‘TSSOPI6 1008 49 raHCr731 ‘Quad 64-bit state shit egistor 8016, S50P16, TSSOPI6 1008 49 74HC8S ‘4b magnitude comparator opis 8016, SSoPI6, TSSOPt6 108 4 74H086 (Quad 2nput EXCLUSIVE-OR gate iris 8016, SSOP, Tss0P14 1608 a TaHCs014 Nino-wide Schmit tg. bulfine diver DIP20 ‘8020, SS0P20, Tss0P20 1006 46,49 7aHoo01s Nine-vide Schmit tig. buLtine diver DIP20 8020, SS0P20, Ts80P20 1008 46,49 ratooit4 Nine-wide Schmit tigger butor 120 8020, SS0P20, 88020 1606 46,49 ranoatts Nine-wide Schmit tigger butler 1P20 8020, Ss0Pz0, Ts50P20 ios 48,49 7aHC98 “+i binary ripe counter iPr 8014, SSOPI4, ‘TssoPt4 1006 46 ranoToe ‘Quad 2-nput NOR gate pipts 8014, SSOP14 ssoP4 108 4 TaHCTOs ‘Quad 2nput NAND gate opts S014, SSOPI4, ‘TSSOPts 1008 “ TaHCTO4 Hox ivoror opts 016, SSOPIA, Tss0Pi4 tos raHcTo8 (Quad 2nput AND gate DiPts 014, SSOP, ‘Tss0P14 108 a raneri0 Tiple 3nput NAND gate pits 8014, SSOP14, ‘TssoPt4 1008 4 ranerio7 Dual tip-top with reset pipts 8014, SSOPIA, ‘TSSOPI4 108 a 14 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype hand page umber description throughenolg "SMD book es raneri09 Dual JK tpop win set andreset IPTG sor, ssoPis, Tssorte 1608 a ranerit Te sinpt AND gate oi Sore ss0P14, TssoPt 1006 a ranorin2 Dual JK fpop win set and set PIB Sore, ss0r16, TssoPie, 1608 a aneries Dual rotiggerale monovb wih reset IPI6 Sore, sorts, Tssorte 1006 ” ranories Cad tine aver pis Sore, ssoPt4, FssoPt« v008 “ ranories vad uterine aver opis Sore, sso, TSsoPt« 1008 “6 renorise Cad 2snput NAND Schmit gger PA Sore ssoPr4, Tssort oy 140 ranorias {input NAND gate pis Sore, ssorte, score 1005 ” ranoris7 2:08 fn decoseréomutipoxer pris S018, sso, Tssorte 1608 ” nanerise 2:08 ne decoserdomutplner pee Sore, ssorie, Tssorte eos ° rancriso Dual 240-4 tne dacodedemutpoxer—OPI6 Sore, ss0P6, {ssorte 1008 a ranor14 Hoxinvring Sebi ger pine Sore, sorts, corte 1608 ° ranorar {004 tne pty encoder pris S018, Ss0rt6, secre 1008 ” anorist not mutiplexer ote Sore, ss0Pt6, Tssorte 1608 “ ranoriss Dual put mtipexee pets Sore, ssorte, Jecorte 1006 ° mancris4 ‘0-0 ne decodeomuilerer «P24, SUIP24 «Sar as0Pa4, scores 1008 ” ranovisr Ca aint meteor ors Sore, Ss0F6, Tsoorte 1608 “ ranerisa (a 2nput miter ore Sore, ssorte, Jsoorte 108 ® ranori60 Preaet. syn. BCD decade counter ——PI6 Sore, ssorre, Yssorte 1608 « anerie1 Prose sync. 42 Bary counter IPAS Sore, ssorte, Tseorts 1c08 « ranori6e Prose. mtv. BCD decade counter IPI Sore, ssorte, ssorte 1008 “ ranoTies Prose. syn, binary enuner PI Sore, ssorte, TssoPt 1608 ‘ ranoTi68 bi sovainparaietotshitrog. PI Sore, ssorts, TssoPt soos 0 ranoTi6s 2. sof nvparaout hit eg oie Sore, ssorte, qssorte e068 ° rancri8s 8 saa nparaout shit eg oe S016, ssoPt6, Tesorte 008 “0 ranori7s und D-yp0 top ote Sore, ssoPte, Tssorte 1008 ” ranori7e Hex Oy sop wih sot ote Bore, SSoPt6, TSsoPte 1608 ° ranoTi7s Ca 9p pop wih reset pets Sore, SsoPt6, TssoPt6 1008 e 25, Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number description through-hole__ SMD book 3 TAHCTIO1 4-08 arithmetic logic unit ipa, spiP2¢ $024, SSOP24, ‘Ts80P24 008 6 raHCTIE2 Look-ahead carry generator pips 8016, $S0P16, TSSOP16 e06 8 TAHCTI90 Prose. syn, BCD decede upldown counter DIP 8016, SSOP 16, TssoP16 1008 48 TAHCTION Preset. yn. 4bitbinary upidown cnt. IPI 18016, SSOP16, ‘TSSOPI6 006 6 rancTi92 Proset. yn. BOD decade upidown counter DIP 8016, SSOP16, TssoP16 1006 8 TAHCTIe3, Prasat. syn 4-bitbinary upidown ent. DIP 8016, SSOP 16, TSSOP16 tc06 48 TAHCTI94 44-bit bir, universal shit register pipt6 8016, SSOP16, TSSOP16 106 9 TAHCTI9S 4-bt parallel acess shit registor o1p16 8016, SS0P16, TSSOP16 1006 “9 7aHCT20 ‘Dual 4input NAND gate Dips 5014, SSOP14, ‘TssOPt4 1006 43 vancres Dual 4-nput AND gate pip 8014, SSOP14, TssOPt4 1c08 a ranoT221 Dual non-etig. monovib with reset ovis 8016, SS0P16, TSSOP16 1006 9 TaHCT297 3:08 line decoder/demutploxer pris 8016, SSOP 16, TssoP16 to06 a TaHCT238 340-8 tine decoder/demutploxer Dipi6 8016, SSOPI6, TSSOP16 106 a ancr240 (Octal butertine ariver ip20 020, SS0P20, ‘TssoP20 106 46 7aHoT241 ‘Octal butertine driver piP20 18020, 85020, TssoP20 cos 46 TaHCT2«2 (Quad bus transceiver pis 8014, SS0P14, TSSOP14 1006 50 TaHcT248 (Quad bus transceiver pips 8014, SSOPT4, TSSOPt4 1006 50 7AHCT244 (Octal butertine criver iP20 3020, $8020, TssoP20 1006 6 7aHOT2AS (Octal bus transceiver iro ‘8020, SS0P20, TSSOP20 1006 50 7aHCT251 input multiplexer pit $016, SSOP TE, TSSOPI6 408 vancT2s ual nut mutipexer pips 8016, SSOP 16, TSSOPI6 tc06 8 raHoT257 (Quad 2-nput multiplexer opts 8016, SSOPt6, TssoP16 1006 4 TaHCT258 (Quad 2-nput multilexor pipi6 8016, SSOPI6, TSSOPI6 106, “a 7aHcT259 ‘bit addrossable latch pis 8016, SSOP 16, ‘TssoPt6 108 8 reHeT27 “Teple S.input NOR gato oipta 8014, S50P14, TssoP14 106 cy rancr273 (Octal D-type tip-top with reset 1P20 8029, 85020, ‘TssoP20 1006, a 74HCT280 9-8 oddleven party generatorchecker —_DIPT4 8014, S80P14, TssoP14 1008 6 7aHCT263 “bit binary full adder wit fast carry Dit 8016, SSOPt6, TSSOP16 tos 6 216 Philips Semiconductors INTEGRATED CIRCUITS Concise Catalogue 1996 Alphanumeric index ‘ype Package ‘rand page number description throughhole__SMD ‘book 3 vaHcre97 Digital phase-lockedoopfitor oPt6 8016, SSOP 16, TSsoPI6 co 49 TaHCT299 ‘bit universal shit rogiser ipo 8020, SSOPz0, TSSOP20 1006 ry 7AHOTSO input NAND gate pip 8014, SSOP14, TSsoP14 1006 cy aHcTs2 ‘Quad 2-input OR gate Dipts 8014, SS0P14, TSSOP14 108 48 TAHCTS54 ‘input muiregistr with ltchos piP20 's020, ssoPz0, TSSOP20 1c06 43,49 7AHCTIS6 ‘input mutiplexertagister oip20 8020, 8S0P20, ‘T3s0P20 1006 48,49 7AHOTSES Hox button ceiver Dips 15016, SSOP 16, ‘TSSOPI6 106 46 7AHCTI66 Hox butfertine driver opis 8016, SSOP16, TSSOP16 106 46 vaHeT367 Hex butfertine diver DiPt6 8016, $8016, TSSOPI6 loos 46 7eHCT368 Hox butfertine diver pis 8016, ssoP16, ‘TSSOP16 1008 4 vaHeTa7a (Octal D-type transparent latch piP20 8020, 8S0P20, ‘TssoP20 106, a aHcTs74 (Cota D-type tip-top ip20 ‘8020, SS0P20, T5s0P20 108 a7 vencra77 (Octal D-type fipsop with data enable P20 ‘8020, $80P20, TssoP20 1008 a 74HCT300 Dual decade ripe counter ovis 8016, SsoP16, TSSOPI6 1008 46 TANTS Dual 4-bit binary ripple counter opis 8014, SS0P14, TssoP14 c06 46 7aHCT4002 Dual input NOR gate Dips 8014, SSoPt4, TSSOPts 1006 48 TaHoTa0102 ‘8 synchronous BCD down counter IPG 8016, SSoP16, TSSOP16 106 46 ‘4HCT¢O108 -R synctronous binary down counter OIPI6 8016, ssoPt6, TSSOPI6 1008 6 7eHICTA0104 4+-it bid. universal shit register ovis 8016, SS0P16, TSsoPI6 tos 4 74HOTAO105 401. 16 word FIFO register pire 8016, 8S0P16, TSsoP16 1008 «0 TaHCTaO1S Duel 4-itser-nvpar.-out shit reg. Dipte 8016, SSoP16, TSSOP16 106 9 TAHCTAONS (Quad bilateral switches pip 8014, ss0P14, TSSOP14 1008 9 7eHCTAO17 Johnson dec. counter wih 10 decoded op DPI 8016, 85016, TSSOP16 1008 “6 7aHeTac20 14-stage binary pple counter pris 8016, 85016, TSSOP16 coe, 6 ‘TaHcTa028 7-stage binary pple countor pip 8014, SS0P14, TssoP14 1606, “6 ‘TaHCT4O40 ‘2sstage binary ripple counter Dipis 8016, SS0P16, ‘TSSOPt6 1006 6 74HCTAO46A, Phase-tocked loop with VCO DiPte 8016, SSoP16, TSSOP16 108 49 7aHCT¢051 @-channel analog muxidemux DiPt6 8016, SS0P 16, TSSOP16 (008 4 Ba Philips Semiconductors Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype package hand page number description throughhole__SMD_ book a ‘ancraos2 ual 4-channel analog munddemux DiPis 8016, SS0P16, TSSOPt6 1006 a 7AHCTA059 ‘Tine 2-channol analog muxdemux opis 016, SSOP 16, TssoP16 1006 cy ‘TaHCT40s@ Programmable divde-by-n counter piP2s, spiP24 S024, SSOP24, ‘Tss0P24 1008, 6 TAHCTA060 14-stage binary pple counter with ose. DIP16 8016, SSOPte, TSSOPI6 too 8 TAHCTAO8S (Quad bilateral switches Dita 8014, SS0P14, TSSOPt4 1006 4 7AHCT«O87 ‘6-channel analog muxidemux Dip24,sDIe2¢ S024, SSOP24, TSsOP24 1006 “a TaHCT«O7S ‘Triple S-nput OR gato pips 8014, SS0P14, ‘TssoPt4 1c06 «8 TaHCTAO94 ‘stage shit-and-store bus register Dips 8016, SS0P16, TSSOP1S 108 49 7ancTa2 BCD to decimal decoder (1-010) piers 8016, SSOP 16, TSSOP16 tos a TAHCTA23 Dual retiggerable monovi with reset IPI 18016, SSOP 16, TSSOP16 108 4 TAHOTASI6 (Quad bilateral switches DiPis 8016, SSOP16, ‘TssOP16 008, 49 7aHCTEa51 ‘#-channel analog muxidemux with latch DIP20 8029, $5020, TssOP20 008 4 raHCTaas2 Dual 4-chan. an. muxidemux with tach DIP20 18020, SS0P20, TssoP20 006 8 7aHCT4S53 ‘iin 2-chan, an, munddemux wih latch DIP20 8020, $8020, TSsoP20 1008 48 7aHCTAS10 ‘BCD upléown counter opis $016, SSOP 16, TSsOP16 106 6 7aHOTASt1 2CD to 7-sogmentlatchidecoderarver—DIPIO 8016, SSOP 16, ‘TssOP16 1008, a vancTasta 40-16 tne decoderldemuttplexer Dipz4, soir24 S024, SSOP24, TssoP26 006 a TAHCTASIS 410-16 tne decoderidomultiploxer pipe, spip24 $024, SSOP24, TssoP24 too a 7AHOTASI6| Binary up/down counter pris 8016, SSOP 16, TSSOP16 106 “6 7eHeT#518 Dual synchronous BCD counter oPi6 S016, SSOPI6, TSSOP16 1006 6 ‘7aH1OT4520 Dual synchronous 4bit binary counter DIP 8016, SSOP 16, ‘TSSOP16 1008 48 aHCTas38 Dual retriggerable precision monovib IPI 8016, $5016, TSSOPI6 1006 ry TAHCTASS [8CD-to-7 segm.latchidecJirforL CDs IPI ‘8016, SS0P16, TSSOP16 106 av 7AHOTSS3 (Octal D4ype transparent latch ipz0 020, 8S0P20, ‘TssoP20 cos av TaHCTS94 (Octal D-type tip-top p1P20 8020, $5020, TssoP20 1008 a TAHCTS¢0 Octal butfertine diver 1P20 8020, 880P20, ‘TssoP20 108 8 7aHCTSA1 (Octal butertine driver o1P20 8020, $5020, TssoP20 1008 6 TAHCTSSSS Programmable delay mer wih oscla‘or DIY 8016, $8016, TSSOPI6 106 0 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number description through-hole_SMD_ book Es 7AHCTS6S (Octal D-type transparent latch ip20 ‘S020, S80P20, ‘TssoP20 106 a TAHCTS64 (ata D-ype tip-top DiP20 ‘8020, $$0P20, TSs0P20 tos a 7aHCTS7a (Octal D-type transparent latch oipz0 ‘8020, S50P20, ‘TssoP20 1008 a 7AHoTs74 Octal D-ype fip-iop D1P20 ‘8020, SS0P20, TSSOP20 106 a 74HCTSE3 “+f addor with fast carry opis 8016, SSOP 16, TSSOP16 108 TAHCTSO4 ‘St shit register with output rep. pipi6 8016, SsoPt6, TSSOP16 1008 TAHCTS9S ‘8 server. oF par-out sh. reg pipi6 8016, 8s0P 16, ‘TSSOP16 606, 7aHCTsO7 ‘-bitshit register with input latches pits 8016, SSOP16, ‘TSSOP1S 1c06 0 74HOTES2GA Programmable ripple counter wih osc. $08 1606 46 7AHCTSA0 (Octal bus transceiver iPz0 ‘8020, SS0P20, TSSOP20 106 50 TAHCTEAS (Octal bus transceiver ip20 8020, 8S0P20, ‘TssoP20 106 50 7aHCTEA (Octal bus transcelverlegistor Dip24, S0IP24 8024, SSOP24, TSSOP24 108 50 aHcTe48 ctl bus transceiverrogistor biP2s, SpIP24 S024, SSOP24, TssoP24 108 50 TaHCTeS2 (Cota rgistrod bus transceiver pipea 8024, SS0P24, ‘TSSOP26 108 50 ‘aHcTe70 4x 4 rogister fle DiPi6 8016, SSOP 16, TSSOP16 1008 0 vaHcTeae ‘-bit magnitude comparator iP20 8020, $8020, ‘TssoP20 1006 6 7aHoTT030 S-bitx 64-word FIFO register pipze 028, SsoP28, ‘TsSOP28 1006 0 ‘7aHOT7O4BA PLL wath lock detector pipe 016, SSOP16, TSSOP16 1006 ry 74AHCTTOHO 16-bit evenvodd party generatorcheckor DIP20 8020, 8S0P20, ‘TssoP20 006 46 aHeTT132 ‘Quad ad). precision Schmit tigger opt S014, SsoPt4, TSSOPI4 1008 49 TaHCTT245 (Octal bus Schmit tigger transceiver IPO ‘8020, SS0P20, TsS0P20 1008 49, 50 rancT73, Dual JK fip-op with reset pips 8014, ssoP14, TSsoP14 1008 a TaHCTTS Dual D-type fip-lop with set and rset DIPS 8014, sso 14, TSSOPt6 1008 a TAHITI 408 ‘4-bt x 64-word FIFO register DiPr6 8016, SS0P16, TSSOP16 1008 «o 7AHCTTAO4 S:bItx 64-word FIFO register Dipis 8020, 8S0P20, TssoP20 008 « 7AHOTTS ‘Quad bistable transparent latch opis 8016, SsoPi6, TSSOP16 1006 2 7AHCTTS40 (Octal Schmit tigger buterine driver IPO ‘8020, S80P20, TSSOP20 1006 46,49 7AHCT 541 (Octal Schmit tigger buterine dive IPO ‘8020, S80P20, TSS0P20 1006 46,49 29) Philips Semiconductors Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype package hand page number description through-hole_ SMD book x vanoT7s97 8-5 shit ogistr with input latches IPS 5016, ssoPt6, TssoPi6 1008 « ranorT731 Quad 6408 sta sit rogiter oii 8016, SSOPt6, Tss0P16 108 “ rancres 4+ magnitude comparator DIP 5016, SSOPt6, TssoPi6 108 «6 7aNcTe9 (Quad 2input EXCLUSIVE-OR gato IPI S014, SSOP14, TssoPi4 106 a TaHcToO%4 Nineswide Schmit tig. butting diver ——_DIP20, 020, ss0P20, Tss0P20 ico 46,49 TaHCTIONS Nine-wige Schmit ti. bute diver DIP20 8020, 8S0P20, Tss0P20 1006 49,49 TAHCTOOHEA PLL wih bandgap controled VCO oiPi6 $016, SSOP16, Tss0Pi6 ps.cos *° rancrotte Nine-wide Schmit tigger butler oir2o 18020, SSOP20, Tss0P20 108 46,49 raHoTOLS Nino-wide Schmit ager butler DiP20 8020, SS0P20, ‘T8820 1008, 45,40 7aHoT99 4b binary ripple counter pt S014, SsOPt4 TssOPt4 1008 «6 ras. 39240 (octal butloctine ver 5024, ss0P24 TssoPe4 io2s a rantsse4t (xa butletine aver 5024, SS0P24 TssoPe4 124 a antsse4 (xa uterine diver 8024, SSOP24 Tss0P24 vot ” TAH 3248, Octal bus transceiver 5024, Ss0P24 ‘Tss0P24 voz 20 ayt.93973 Ccta Daype transparent latch 8024, SSOP24 Tss0P26 1024 8 ratt.ss574 cal Dype fp top 024, ssOP24 TssoP24 124 28 7a41.39508, ‘Octal D-ype transparent latch 5024, SSOP24 TssoP24 to2a 8 7AHL39534 Octal Daypefipsop 5024, SSOP26 Ts50P24 vo28 28 7441-33620 Cctal bus transceiver 3024, S50P24 Tss0P26 voz 0 7ae.3628, (cal bus transceiver 5024, SSOP24 TssoP24 1024 20 744.39640 tal bus transceiver 8024, SSOP24 TssoP24 124 20 7a.39648 ‘Octal bus ransooivergiser 8028, ss0P28 Tss0P28 woot so 7aHL33648 (ctl bus tanscoiverteistor 8026, ssoP28 Tss0P28 to28 0 ran 39651 (octal ranseivertegistor 5028, SSOP28 Tss0P28 124 20 rati.s96s2 ‘Octal ranscalverrogster $028, SSOP28 Tss0P28 to2a 30 raH39052 Cctal egistored transceiver 18028, SSOP28 7850P28 voz 90 74439053, (cal registred wansceiver 8028, SS0P28 Tss0F28 to2s 30 7Atvoo ‘Quad 2npat NAND gate ipa S014, S50P14 TssoPt4 to2 2 220 Philips Semiconductors Goncise Catalogue 1996, INTEGRATED CIRCUITS Alphanumeric index package Tend page nor description throughnle SMD beak eS avon Cad np NOR gato ors s014, ssoPt4 resort ve2e 2 raves Cound 2npt NAND gate ore Sora, s60r14 TSsoPta ve an aves Hoxie oss Sota esors4 {sorte veze 2 rawvoo nd 2g AND gata opr Sota scorn Tssorte voz a” rawvio Tle sip NAND gate overs Sore, soot Tesora soze rawvior Dn JK op wit sat pew Sota ssorra Tssorte vezs awvie8 Duel JK tpfop win set andreset PIB S0%0,ssorr6 Tssorte, reas Fy raw “Tipe input AND gate ops fore, sso Tesora wea 2 raivies Dua eapebie monovb wit rest IPB fot8, ssorte rssoPte reas 2 rawies a butane ve ors Sore ss0r14 rssort4 reat ” raw cad bute avr pew Sore ss0rt4 TssoPt4 voze a awvise (und ings NAND Sct gger——_IPY4 Sore, ssorr4 qssoPt4 teat 2 raise $e ne dace ose S0%6,ss0r16 score wea 20 awvi00 Dus 240-4 ne decodecdemuipleer —_OIPI6 Sore, ss0rt6 TSsort6 vo2s 2 rawie Hoxinvrng Set ger ots Sowa esorr4 Tesora reas 2 vauviss i int mins oie Sore, ss0rt6 Tesorte wea 2 vauvisa ‘e-10 ne cacodeddutpicer P24 S020, ss0°24 {esores veae Fa awisr aa pit mitprer oie fore, ssorte ‘score veas 2 rauvies Pras. sree 4 bay counter PIB So%8,ss0P16 {score sale Py navies Pra. sete 4-3 bray cour PIG S018, ssoPte score ssi 23 rawiee i srahinpamtooutshitieg, §———vPt4 S014 s80°r4 TseoPt4 vez 20 vies Ot parities ore ote, ssorre TssoPt6 wees 2» vauvsra Hex Diy Mop with eset ors S0%0,ss0Pt6 Tssorte teat 2 rawvis nd ype tp tn set oss Sore, s80°16 {ssorte sales a raion Pres. sree 4 brary uidown ens, IPB S016, ss0Pt6 ‘eeorte, sie 0 rauviea Pres sy. ary uptown nr, IPA6 Sore, ssori6 ‘score sai Fy 7awvoo Dual pit NANO gto opis Sore,o50°14 Tssorts ve2s an rawaso ct tute iver ore S020, ss0r20 T3s0r0 vez 2 22 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype Package ‘hand age umber description through-hole__ SMD. book 3 raves (octal butertineeriver iP20 8020, sS0P20 ‘T3S0P20 124 a raves Octal uterine diver 120 8020, S50P20 Tss0P20 124 a ravens (ca bus transceiver ip20 8020, SS0P20 Tss0P20 020 0 rawvest input mutiplxer Dips $016, SSOPIS Ts50P16 \o24 2 raves ‘Quad 2nput mutiplexer iPr 8016, SSOP16 Tss0Pi6 woz 2 rawves9 8-bit addressable latch opts 8016, SSOPI6 ‘TSs0Pi6 to24 2 raver “Tiplo input NOR gate pips S014, SSOPI4 TssoPi4 voz a raver ‘Octal D-type tip-top with reset iP20 8020, SS0P20 TssoP20 to24 28 rave (Quad 2nput OF gate opts 8014, SSOP14 TSSOPi4 1024 a 7aLva6s Hox butterin crver opie S016, SSOP16 ‘TSSOP 16 woz 28 rawvse7 Hox butforineciver oir. 8016, SSOPI6 Tss0Pi6 tz 8 rawva68 Hox inverter DiPts 8016, SSOP16 TS50P16 sales 8 vawvars ‘Octal Dsypo transparent atch iP20 ‘8020, $50P20 Tss0P20 124 28 raysr4 ‘Octal D'ype pop 120 8020, S50P20 ‘Tssor20 to24 Ey 7awvs77 Coca D-type tipslop with data enable D1P20, 8020, SS0P20 Tss0P20 024 28 ratva0a Dual 4. binary Apple countor ois 8016, SSOP14 ‘TSSOP t4 024 6 rauvaoe0 “4-stago binary pple counter opts S016, SSOPI6 TssoPi6 sales 8 7aLvA0H0 {12.stage binary pple counter piPis 8016, SSOPIE TS80P16, sales 8 TaLVa0st ‘channel analog mutiplexeddemix IPI 016, SSOPI6 ‘TSSOPI6 128 2 raLvans2 Dual ¢-channel analog mutiplexerdorux DIPI6 S016, SSOPI6 ‘TSSOP (ozs 2 7aLV4053 Tiple 2-channel analog muxddemux OPIS 8016, SSOPI6 Tss0P16 wae 2 raLvo60 ‘4-stago binary pple countr wih ose. DIPI®. 8016, SSOP16 Tss0Pi6 24 8 aLvaoes (ued bilateral swiches pits 8014, SSOPt4 ‘Tss0Pi4 124 29 7aL40s7 ‘6-channel analog mulplexertdemitipl, —DIP24 024, S50P24 Tss0P24 sales 29 7aLvaon4 6-stage shit and-store bus register oiPr6 $016, SSOP16 Ts50P16 124 29 Tava (Quad batral swichos pipe 5016, SSOP16 TsSOPI6 2s 2 7awvaro9 ‘NM batary management cut iPr 8016, SSOPIE TSSOPI6, v2 30, 82 7aLvses (Octal butrtine diver 120 8020, S50P20 Tss0P20 tz 28 222 ips Semiconductors ‘Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype Package hand page umber description through-hole_SMD book cs 7aLvsra (Octal D-type transparent latch piPz0 ‘8020, S80P20 TssoP20 loz 2a raLsra (Octal D-type fipsop iP20 ‘8020, S80P20 TssoP20 loz 28 7aLvs9s S-bserin/seroutor parcutsh.reg. IPI 8016, SS0P16 TssoPI6 028 29 maura Dual D:ype fip-‘lop with set and reset DIP 8014, 850P14 ‘TSSOPt 1028 28 raves (Quad 2-nput EXCLUSIVE-OR gate opis 8014, ssoP14 TSSOP14 o2a auvooo (Quad 2-nput NAND gate 8014, SsOP14 TssoP14 o24 rauvoo2 (Quad 2-nput NOR gate 8014, SSOP14 TSSOPt4 o2a 7aLvoos Hex inverter S014, SSOP14 TSSOP1s oe ar aLveos ‘Quad 2.input AND gate 8014, SSOPI4 TSSOPI4 oz ar 7aLvero “iple 9nput NAND gate 8014, SsoP14 TSSOP14 sales ar vauveto9 Dual JK tip-top with set and reset 8016, SSOPI6 TSSOPIG loz 28 vauvert ‘eple 3nput AND gate 8014, SSOP14 TsSOP14 sales ar rauver2s (Quad butertine diver 8014, SS0P14 TssoPt4 o24 ar vaLvor26 Quad butler 8014, SSOP14 ‘TssoPt6 sales 27 vawvers8 810-8 line deooderldemutiplexer 8016, SSOP16 ‘TSSOP16 cas 28 vawvors9 Dual 2-0-4 line decoderidemutiplexer ‘S016, SSOPI6 TssoPt6 o24 28 vauvera Hex inverter Schmit tigger 8014, SSOP14 ‘TSSOPI sales 29 aLverss Dual 410-1 mutiplexer 8016, SSOP16 TssOP16 sales 2 vaLveis7 Quad 2 input mutiplexer 8016, SSOP16 TSSOP16 o24 29 7aLverss ‘Quad 2-0-1 data selectormutiploxer 8016, SSOP16 TSSOP16 sales 29 TALVC162244 16-bit 30.0 butfertine diver ‘SSOP&8, TSSOP4B sales ar raLvere240 16itbutertine aver ‘SSOP%8, TSSOP4B sales 27 raLvere2as 160i butter ‘SSOP#8, TSSOPAB sales a7 raLvere24s ‘s6:bit bus transceiver with dr. pin ‘SSOP48, TSSOPAB sales 20 yatveres73 {16-bit D-type transparant latch SSOP48, TSSOP4B sales 28 yaLveres74 ‘16.it edge triggered D-type fp-op SSOP48, TSSOPB sales 8 7aLVCI91 ‘Asynchronous pres. 4-bit upidown counter 5016, 85016 TSSOP16 sales 28 vatver9a ‘Synchronous pres. 4-bit upidown counter 8016, 8S0P16 TssoPI6 sales 8 7aLvez0 Dual 4-nput NAND gate 8014, SSOP14 TSsoPi4 sales 27 rauven244 (Octa ator with series resistor 8020, ssoPz0 T3S0P20 sales 2 yaLve2so (ctl buttertine driver 8020, SS0P20 TSSOP20 loz a 228 Philips Semiconductors ‘Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand) page number description throughhole__SMD ‘book = raLveass (Cota buterine diver ‘8020, SS0P20 ‘TSSOP20 to24 ar aLvezss (Cota buterine driver 18020, SS0P20 TSSOP20 lo2a ar TaLveess, (Cota bus transcelver ‘8020, SS0P20 ‘TssoP20 lo2a 30 raLvees7 ‘Quad 2.nput mutiplexer 8016, SSOP16 TsSOP16 024 cy 7aLve2s8 ‘Quad 240-1 data selector multiplexer 5016, SSOP16 TssoPi6 sales 2 7aLvo2s9 ‘Octal adressabe latch 8016, SSOPI6 ‘TssoP16 sales 29 vawve2s9 ‘Synch, prs, 8 bid. binary counter 024, ssoP24 ‘TssoP24 sales 28 vauvea7 ‘Tepe input NOR gate 8014, SS0P14 TssoPi4 sales 2 rauvo273 (Octal D-ype tip-top 8020, 8S0P20 ‘TssoP20 sales 28 7auvoz9se sit transceiver S024, SSOP24 TssoP24 to28 20 vaLveso input NAND gate 8014, SSOPI4 TSSOP14 sales ar vaLves2 (Quad 2.nput OR gate 8014, SsoP14 TSSOPt4 ozs a vya.vesrs (Octal ype transparent latch 18020, SS0P20 TssoP20 to24 28 vaLvesr4 Cota D-type fipop ‘8020, S80P20 ‘TssoP20 024 Ey raLves77 ‘Cota D-type fp-op with enable 18020, SSOP20 ‘TSSOP20 sales 2 rauvoss (Quad 2-nput NAND butter 8014, SSOP14 TSsOP14 o2e a 7auvo4o ‘Dual 4nput NAND butler 8014, Ss0P14 TssoPt4 sales ar rauveaz4s bi 9-5V love shiter transceiver S024, SSOP24 TSSOP24 loz 30 vyaLvest ‘Dual 2-wide 2nput AND-ORINV gate 014, SS0P14 TssoPt4 sales a aLvesso (Octal butler ‘8020, Ss0P20 ‘TSSOP20 ‘alos 28 7ALVCS41 (Octal butler ‘8020, Ss0P20 ‘TssoP20 sales 23 vauvess (ata registered transceiver 024, SsoP24 TSsoP24 cae 0 raLvossa (Octal registered transceiver ‘8024, SSOP24 TSsoP24 to28 30 va.vesrs (Octal D-type transparent latch ‘$020, SS0P20 ‘TssoP20 voz Ey vaLvesrs (Cota D-type tip-top ‘8020, SS0P20 TssoPe0 o24 2 ‘aLvesra ‘e-ibidrectonal binary countor 8020, SS0P20 ‘TSSOP20 sales 28 atvos20 (Octal transceiver 8020, SS0P20 TssoP20 sales 30 yaLvos23 (ota bus transceiver 8020, SS0P20 ‘TssoP20 024 0 224 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanume: ‘ype package hand age ‘umber description throughhole___SMD ook 3s raLvesso ta tanscoWver 8024, ss0P26 Tssor24 sales 30 7aLvCS46 (octal bus transceivortagster 5024, SSOP24 ‘TssoP24 128 20 auveese (Octal registered bus ransoeWver 8024, SSOP24 ‘Tss0P24 oz 30 ravers Dual DAype fp-op wih stand reset S014, SSOPI4 TssoP14 to24 2 rawvesa 10-bit bus interface register 8024, SS0P24 Tss0P24 loz rauvee2 ‘-bit bus interface register 8024, SS0P24 Tss0P24 124 ravens, (cal bus intrtace register 8024, SSOP24 ‘Tss0P24 sales rauvese7 10-5 buttor ine dever 8024, SS0P26 TssoP24 voz 2 vaLvosst 10 bus itortace latch $024, SSOP24 Tss0P24 128 2 7aLvo86 (Quad 2Anput EXCLUSIVE-OR gate 8014, SOPs Tss0Pi4 1024 2 7aLvoude Hox invertor (unbuttored) $014, SSOPI4 TSsOPt4 sales a rauvroo ‘Quad 2nput NAN gate S014, ssoPia TSSOP ‘alos Ea ravroa ‘Quad 2 input NOR gato S014, SSOP14 TssOP14 a rauvToa Hoxievortor 5014, SSOPI4 ‘TssoPi4 salos ar auto ‘Quad 2nput AND gate S014, SSOPI4 ‘TSs0Pi4 sales ar ratio “Tipe input NAND gate 014, SSOP14 Tss0Pt4 sales ar vauvtias, ‘Quad butortine aver S014, SS0P14 Tss0Pi4 tc24 2 vauvTi26 ‘Quad buterine crivar 014, SSOP14 TssoPt4 sales a TALVTI62240A 164 90. buifetine crivers SOPH, TSSOPA8_IC2 2 TaLVTi6z2448 1630. bulledine vers S80P48, TSSOP48 1025 7 TaLvTie22458 16 90-2 bus ans. wth pin S8OP48, TSSOP48 1026 30 TALVTI62408 16-bit uterine devers, SSOPH8, TSSOP49.DS.1C24 2 7ALVT162443——_4:bbuteine cvers SSOPH8, TSSOPA3_ 05:26 Eo 7ALVT162458 16-bit bus transceiver with dt. pin SSOP48, TSSOP48 _DS4C25 20 TALVTIGZT3A ——_46-b# D-type lo-op SSOPH9, TSSOP48_ 1024 2 TALVTIGS73A 16-bit D-ype treneparant atch SSOP48, TSSOP4®_DSC24 28 TALVTIGS7AA 16-00 tiggored D-ypo flo top ‘S8OP48, TSSOP4B_DS-C24 28 7ALVTI6500A —_—_—18-unvorsal bus tanscetver ‘SSOP56, TSSOPSS 0S:C24 30 TALVTI8S01A 18-bit universal bus transceiver 'SSOP56, TSSOPS6. DS.IC24 30 TALVTIES41A ——_16-I Duflrtine diver ‘SSOP48, TSSOP4B 1024 28 TALVTHBS43A 16-bit registred transceiver 'SSOP56, TSSOPSS. DS-IC24 30 TALVTIG46A 162 BUS ransooWer 'SSOP56, TSSOPSS. 5.1024 30 7ALVTICSS2A ——_16- wanscelvortegitors ‘S8OPS6, TSSOPS5 _DS-C24 30 TALYTICRZIA 20-5 bus infriace rgiter 'SSOP56, TSSOPS6. sales 29 TALYTI6623A 18-bit bus interface register ‘SSOP56, TSSOPSS. sales 29 7ALVTI6827A 20-bit uffertine diver ‘SSOPS6, TSSOPS6. sales 2 7ALVTI6B41A 20-8 bus interface latch 'SSOP56, TSSOP55. sales 29 TaLvTie899 16-bit latched tanscalver 'SSOP56, TSSOPSS. sales 30 225 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package rand) page number description through-hole__SMD book o TALVT16952A 16-0 rogistored transceiver ‘SSOP56, TSSOPS6 sales 20 vauvre0 Dual 4nput NAND gato S014, SSOP14 ‘TssoP14 sales ar rauvr224s Octal bus transceiver 8020, ss0P20 ‘TssoP20 sales 0 7aLvT240, ctl butfertine diver 8020, SS0P20 ‘TssoP20 o24 a TALVT24AA ctl butfertine diver 8020, S80P20 ‘TSS0P20 eas a TaLvT2as, (Octal bus transceiver wih dretion pin 8020, S80P20 ‘TssoP20 oa 30 TaLvT24s4 (Octal bus transceiver 8020, SS0P20 TssoP20 sales 30 TALVT2543 (Octat registered transceiver 024, SSOP24 ‘TssoP24 sales 0 rarer (Octal D-type fipsop ‘8020, S80P20 Tss0P20 loz 2a 7auvre952 (Cota registred transceiver ‘8024, SSOP24 ‘TssoP2s 024 30 avs ‘Quad 2.input OR gate 014, SsoP14 TSSOPt4 sales a 7ALVTSTS (Octal D-ype tip-top 8020, 8S0P20 ‘TssoP20 sales 28 rauvrar4 Octal D-ype tip-top 8020, S80P20 TssoP20 sales 28 7ALVT94 (ota D-type latch 8020, SS0P20 ‘TsS0P20 sales 28 ALTA, (Octal registered transceiver 8024, SSoP24 TssoP24 028 20 TAL TSA (Octal registered transceiver 8024, SSOP24 TssoP24 sales 20 TAL TSAd (Octal registered transceiver 8024, SSOP24 TssoP24 sales 20 7ALVTSTS ‘Cota D-type transparent latch ‘5020, SSOP20 ‘Tss0P20 oa 2 aLvrsrs Octal D-type tip-top 8020, SS0P20 Tssor20 o2a Ey 7auvTe20 (ota bus transosiver 8020, SSOP20 ‘Tss0P20 sales 30 yauvTe23 (Octal bus transceiver 8020, S80P20 TSSOP20 sales 0 7aLTe4O (Octal bus transceiver 8020, S80P20 TssoP20 sales 0 TaLvress. (Octal bus transceiverragistor 8024, SSOP24 ‘TssoP24 oz 30 7ALVTESY otal ransceiverogistr ‘S024, SS0P24 ‘TSsOP24 ‘alos 30 7aLvTese ctl registered bus transceiver ‘S024, SSOP24 ‘TssoP24 o24 30 vaue7a ual D-ype tip-top 8014, SSOP14 TSsOP1s sales 28 yauvre2t 10-bit Dye fiptlop 8024, SSOP24 TSSOP24 sales 2 7aLvTI2I-t 10-bit D-type fip-lop ‘8024, SSOP24 TsSOP24 ‘ales 2 226 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index pe package hand page number description through-hole SMD book 3s rawvte2s ‘8. D-ype p-op with resavenable 8024, s50P26 TssoP24 sales 20 vauvtea7 10> bufrtine dver 8024, SSOP24 Tss0P24 sales 2 vacvrast 10-5 bus interface latch 8024, SSOP24 ‘TSSOP24 sales 29 7awvT943 i bus interface latch wih sotraset 8024, SSOP24 ‘TSsOP26 sales 2 7atvuo4 Hox invrter(unbutfored) pts S014, SS0PI4 ‘TSsOPts 124 a ABT22VI0AS BICMOS low noi, highlve PLO Pucces slo Cy ABT22VIOA7 BICMOS low-noga,high-ve PLO. Pucca salos 68 ABT22VI07 BIGMOS low-n0s0,hgh-ivo PLD iP26 PLcc28, soz Ics 6 ADCOEOS-1C Bb CMOS ADC. iP20 020 cit 7 ‘AOC0803-1LC 8 BRCMOS ADC iP20 8020 vit ws ‘ADCOBOH-IC BB CMOS ADC iP20 ‘8020 en 78 ‘ADCOe04-1LC —BBRCMOS ADC biP20 8020 rit 7 ‘apc0s20 abit CMOS ADC biP20 8020 ort 7 AM26.S31 (Quad high-speed diferent ine ver IPI 8016 icra 85 AN26.832 (Quad high-speed df. ine receivers IPB 8016 ic19 85 ‘AM26L833 (Quad high-speed dit. ine recelvers IPTG 8016 re19 85 aneor2 12-5 mutipying DAG 0120 8020 ict 7 ‘Aueso1 Quad voiags comparator Dis Sov on me ‘auz002 Quad low-power operatonal ampliier —OIPY4 sow fon 7 ‘au2003 Low-power dual votage comparator DIP 808 ron 7% ‘Au2904 Dual low-power operational ampiiier DIP 808 on 7 CaFt80 64-bit TTL bipolar RAM (16x4). sore. sles 69 CaFet9A 4-1 TTL bipolar RAM (16x4) sore sales 9 cay2010 GSM 4 W power ampiior LoFPA ‘cr 7 ‘eay2030 DECT 0.6 W power ampitier ‘SSOPIOM \ci7 a aces: ‘Bt high sped mutipying DAC copie roit 7 ACOA ‘i high-I state shit register cori 108 a HEC#0158 Duel 4bit state shit reistr copie 104 a7 HEcaote8 Quadruple ilatoral swichos corps to 3 HEC4o1745 Hex D:ype flip-top corPis 04 38 27 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package number description throughhole__SMD Hec4o1758 ‘Quadruple D-¥ype tip-top corre HECA017B. ‘stage Johnson counter cos HEOso1048 “bit bi. universal shit rogister corps HECaotos8 “bit universal sit register corps HECAO198 ‘Quadruple 2-input multiplexer corte HEC«0208 “Visstage binary counter corre HEC«0238 “Triple 3nput NAND gate opie HEC«0248 7-stage binary counter copia HEC«O258 “Tile input NOR gate corps HEC«0278 Dual JK tip-top corre HEC«0308 (Quadruple EXCLUSIVE-OR gato cores HEC40358 4-08 universal shift ogisor cores HECa0408 ‘2-stage binary counter corps HEca0428 {Quadruple D-aton corris HEC40478 “Monostable/astable multivbrator coors HEC40498, Hex inverting butters corre HEC#0508 Hex non-inverting butters corre HEC40515, ‘-channel analog multplexerdemutipl. _CDIPI6 HECao6sB ‘Quadruple bilateral swches corre HEC406aB ‘input NAND gate copia HEOA069U8 Hox inverter copia HEO&0708 ‘Quadruplo EXCLUSIVE-OR gate copia HECAO7I1B ‘Quadruple 2-nput OR gate corria HEC«07a8 “Triple input AND gate corria HEC«0818 Quadruple 2nput AND gate corps HEC«0938 CQuacruple 2nput NAND Schmit tigger CDIPY4 HEC«0948 B-stago shitand:store bus register corre HECas058 bi, -bit per word stale RAW RAM DIP HEC45108 BOD upiéown counter coiPi6 HECASN1a [BCD to 7-segment latchidecoderidrverCDIPI6 HECAs120 input multiplexer wih G-state ouput CDIPI6 HEC4s19B, ‘Quadruple 2input muttploxor corre HECAs208, Dual binary counter come HEOA5288 Dual monostable multvibrator cops HEOA5308 Dual 4-nput multiplexer corPis HECs5415 Programmable timer coiris HEC45565 Dual 1-014 dacoderidemuliplexer copie HEC«SS7B +10-64 bt variable length shit regis corre HEC«Se56 44-bit magnitude comparator corse HECA7SOV_ Frequency synthesizer coiPee HECATSIV Universal divider corres HEF 40008 Duel 3-nput NOR gate and inverter Dipi4, copa SO14 HEF001B, ‘Quadruple 2-input NOR gate DIPi4, COPA O14 HEF¢001UB, ‘Quadruple 2-input NOR gate DIPI4.coPi4 Sor HEF«0026 Dual 4nput NOR gato DiPI4, cops SO14 HEF¢0066, ‘18.stago static shit register DIPI4, copia SO14 HEF¢007UB, Dual complomentary pair and inverter IPA, CDIPI4 S014 HEF«0008, ‘4 binary ful addor DIPi6, coIPIs S018 HEF«00078 ‘state hox nowvinverting butter DPte,coris S016 EF 490068 '3-stato hex inverting butfor DiPi6, coPIs S016 HEF«o1068 Hex inverting Schmit trigger DIPi4,cori4 —-So14 HEFAONB ‘Quadruple 2-nput NAND gate Dipi4,coIPi4 O14 HEF«011UB, ‘Quadruple 2-nput NAND gate DIPi4,coIpia O14 HEF«0128 Dual 4nput NAND gate DiPi4, cos So14 HEF«O136, ual D-type tip-top DIPI4,coIP4 S014 HEF«O14B 8: state shift register DIPI6, coIPIG S016 228 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand) age number description throughhole SMD book a HEF«0158 Dual 4bit state shit register DiPie, coip1s S016 to08 HEF«01608 ‘bt synchronous decade counter DIPI6, CoIPIB—SO18 008 HEF«01618 4-bit synchronous binary counter DIPI6, coIPIG S016 coe HEF401628 ‘4-bit synchronous decade counter DIPi6, CoIPIG§—SO16 cos HEF«01698 ‘4 synchronous binary counter DIPI6, COIPIG —So16 co HEF«0168 ‘Quadruple bilateral switchs DIPI4, cOIPIs—So14 04 HEF«01748 Hex D-type flip-top DIPI6, coIPIs S016 toa HEF¢01755 Quadruple D-¥ype fp-top DIP, cops So16 cos HEF«017B, S-stago Johnson counter DIPI6, coIPIs—so16 04 HEF«0188 Presettable dvide-by-n counter DIPI6, COIs S016 G04 HEF«01928 “4-bi upidow decade counter DIPi6, cops S016 io HEF «01098 ‘i upidown binary counter DiPt6, coPIs S016 co HEF¢01948 4-bit bid. universal shit register Dipt6, coPIs—-SO16 104 HEF¢01958 ‘bit universal shit gist DiPt6, coPIG —-SOT6 1604 HEF«O108 Quadruple 2input multiplexer DiPt6, corIs S016 to04 HEF¢0208, ‘4:stage binary counter DiPt6, coPIs —-SO18 104 HEF¢021B 8. static shit register DIPI6, coIPIB S018 104 HEF«0225 4-stage divide-by Johnson counter «IPG, CDIPIG_——«SOT6 ico4 HEF¢0258 “Triple input NAND gate IPs, CDIPt—So14 Ico HEF¢02408 cial butters with 3-state outputs P29, CDIP20 $020 ‘co8 HEF¢02448 Octal butters with 3-state outputs iP29, cDIP20. $020, cos HEF«02458 Octal bus ransceWver, 3-sate outputs D1P20, CDIP20. «S020 Goa HEF¢024B, 7siage binary counter DiPi4, cops Sona ‘Goa HEF«0255, Triple 3-nput NOR gate DiPt4, colts S014 G04 HEF«0278 ual UK tip-top DIPIe, CoIPi6 —So16 cos HEF«0208 1-20-10 decoder DIPIs, cOPIs —_So16 C04 HEF«0208 ‘Synchronous upidown counter DIPt6, coPIs O16 co HEF«0308 ‘Quadruple EXCLUSIVE-OR gat DiPt4, colts So14 coa HEFs0g18 64-stage static shit register DiPts, cOPIs S016 Ico HEF¢035B ‘bit universal shit registr DiPt6,corPIs—sot6 04 HEF¢03735 (Octal tansparant latch wit 3-state Dip29, coIP20 $020 04 HEF¢03748 Octal D-ype tip-top iP29, cDIP20 $020 1604 HEF¢0408 ‘2-stage binary counter DIPI6, COP S016, I04 HEF«0S1B, ‘Quadruple truelcomplement buffer DIPI4, Cops S14 Ico HEF«0428 ‘Quadruple D-atch DiPis, coPIs S016 co HEF«0408 ‘Quadruple FAS latch with Stato ouputs DIPI6, COIPIG—«SON6 co HEF «0446 ‘Quadruple FVS latch with stato ouputs IPI, CDIPI6 «O16 Ico4 HEF«o4e Phase-tocked loop DiPte,corPis —sot6 oo HEF«047, “Monostable/asable muitivrator DiPt4, cots So14 104 HEF¢0408 Hox inverting butlers Dipts, coPI6 —_So16 oa HEF«0508 Hox non-inverting butters DiPte, coris —so16 oo HEF¢0518 ‘8.channel analog muxidemux Dive, coIPIs—-SO16 104 HEF¢0828 Dual 4channel analog murddemux DiPte, cOPIs —-SO16 Ios HEF¢0536 “riple 2channel analog muxidemux DiPt6, coPIs S016 Ios HEF¢0506 Programmable divde-by-n countor iP2s, CDiP24 —So24 to04 HEF¢0608, ‘4:stage rpple-cary binary counter DIPI6, COIs —-SO16 Ico HEF«0868, Quadruple biatoral switches DIPi4, COPA Sota Io HEF¢067B, 16-channel analog muxiderux Dip2s, colP28 S024 ico HEF¢0608, input NAND gate DIPI4, coIPts Sona cos 38 HEF¢059UB, Hex invertor DIPI4, Cops so14 coa 36 HEF«0708, (Quadruple EXCLUSIVE-OR gate DIPI4, cops sor cos 38 HEFAO7IB, Quadruple 2nput OR gate DIPi4, copia Sora ‘cos 38 HEF«O726, Dual input OR gate DIPI4,coIP4 S014 co 36 HEF«O7SB, Tiple S-input AND gate Dipi4,coPi4 sora coa 36 HEF¢O75B, “Tiiple input OF gate DIPi4, coIPi4 §—So14 oy 36 HEF076B, ‘Quad D-ype register, state ouputs DIPIG, CDIPIG._—«SO16 604 a7 229 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page number description through-hole _ SMD book 3 EF«0778 ‘Quadruple EXCLUSIVE-NOR gat DIPt4,cDIp14. S014 toa 36 HEF4078B ‘input NOR gate DIPt4, coIpI4 S014 coe 36 HEF4031B ‘Quadruple 2input AND gate DIPts, coipi4 S014 coe 36 HEF40826 Dual 4-input AND gate DiPts, coIPi4 S014 coe 38 HEF¢085B, Dual 2-wide 2-input AND-OR-nvert gate DIPY4, CDIP!4. S14 1008 38 HEF«088B “wide 2.nput ANO-OR-inver gate Dipi4, corre So14 i604 36 HEF4090B, ‘Quadruple 2input NAND Schmit tigger DIPI4, CDIPt4—SON4 too a7 HEF¢004B, ‘stage shit-and-store bus register DIPI6, coPIG S016 104 ar HEF«1048, ‘Quadruple lowto-igh voltage translator DIPI6, CDIPIG «O16 Io 38 HEFAS028 Strobed hex inverterbutler DIPi6, DIP S016 cos 35 HEF«5058 t-bi, bt per word static RAW RAM OIP14, CDIPIA Icoa 37 HEF¢5086, ual bit atom Dip24, coiP2e —SO2 cos 37 HEF«5108, BOD upldown counter DIPI6, COIPIG S016 cos 35 HEFASNB [BCD to 7-segmentltchdecoderfdrver —OIPI6, CDIPIG—«SON6 cos 357 HEF«5125 input mutiplexer wih state ouput «IPG, CDIPIG «SONG cos 37 HEFAS148 1-01-16 decoderidemuliplexer Dip2s, cDip24 = S024 o08 35 HEFS5158 1-01-16 decoderidemutiplexer Dipea, coir24 S024 coe 35, HEFs5168 Binary upidown counter DIPt6, cOIPIG S016 ico 35 HEFSS178 Dual 64-bit static shit register DIPt6, cDIPIG S016 Io ar HEFAS1@8 Dual BCD counter DiPi6, cots S016 toa 35 HEF«S198, ‘Quadruple 2-input multiplexer Dipie, coPis S016 oa a7 HEF45208, Duel binary counter DiPi6, coIPI6 S016 oa 35 HEFAS21B, 2a stage frequency divider DiPi6, coPi6 —So16 co 35 HEF¢S228 Programmable 4-bt BCD down counter DIP'6, CDIPIS.—-SOt6 too 35 HEF«s268 Programmable 4b binary down counter DIPT6, CDIPI6.—-SO16 cos 35 HEF«5Q7B BOD rate multpior DiPI6, coIPI6 S016 oo 38 HEF«5288 Duel monostabla mutvibrator DIPI6, CoP O16 G08 a7 HEF¢5S1B +12nput party chockerigenerator DIPI6,ColPie —So16 G04 35, HEF¢5S28 input pity encoder DIPI6, CoIPts S016 Ico4 38 HEFE5s45 Realtime §-docade counter Dipes, coipee © S028 coe 35 HEF«5308 Dual precision manostable muivibratorDIPI6,CDIPIG-SO16 Io a7 HEF&S305 ‘Dual input multiplexer DiPi6, coIPIs S016 104 a7 HEF&S418 Programmable timer Dipta, copra Sot 104 38 HEFS5438 [BCD to 7-segmentlatchidecoderdrver IPTG, CDIPIG «O16 104 3637 HEFS5SSB Duel 1-04 decodeddemutiplexer DiPie, coIPis S016 04 35 HEFAS5SB Dual 1-0-4 decodexidemutiplexer DiPi6,coIPIs —So16 Ico8 35 HEF«SS7B 1-40-64 bt variable length shit reg DIPI6,coIPIs S016 te08 37 HEF¢5655, 4-0 magnitude comparator DIPI6, COP S018 104 38 HEF«7208 256i, tit per word RAM DiPt6, coIPIs S016 to 37 HEF«720v 256i, 1-it per word RAM. DiPt6, coPIs S016 104 37 HEF«72¢B -bit addressable latch DiPte,corPis O16 004 37 HEFA731B ‘Quacruplo 64-i static shit register Dipt4, cOIPs4 oa 37 HEF«7aIV ‘Quadruple 640i static shit register Dipt4, comps 104 37 HEF«7378 ‘Quadruple static decade counter DiPta, coipsa cos 35 HEFAT7V ‘Quadruple state decade countor Dipta, cops 104 35 HEFA7SoV IECIEEE bus intrtaco ipso roy 38 HEFA750V Frequency synthesizer pipe: co 38 HEFA7SIV Universal divider Dip2e,colP28 $028 ‘cos 35, HEFA75OV [AC motor control circuit iP2e, coiP28 Ios 38 HEF«7535 Universal timar module OIPt8, CDIPIB. to04 38 HEFs75aV Universal timer module DiPta, coIPia ‘sales 38 HEFA7SAV {B-elament bar graph LOD aver Dipzs,coir28 S028 roo 38 HEFs755V “Transceiver for serial data comm, ize, coiP28 S028 104 38 HEFA7O4B, ‘stage shit-and-store register LED dr. DIPI6 S016 oa a7 HEF«8048, ‘aestage shitand-sore reg, LED driver D1P2O 020 co 7 HEF«9s66, Dual precision monostable mutivbrator —DIPY6 oo 37 230 Philips Semiconductors INTEGRATED CIRCUITS Goncise Catalogue 1996, Alphanumeric index ‘ype package ‘hand page umber description throughhole__SMD ‘book a HEFTO6OUB Hex inverter: open drain opi so14 38 loM7ss5¢ General purpose CMOS timer IPB $08 7 IoM7s5st General purpose CMOS timor Dips sos 9 LF198 Sample-and-told ampiier cDiPs: 79 F298 ‘Sampleand-hold ampliter copa 7 F396 ‘Sampleand-hold ampiitor IPS, CIPS sora 7 oat Votage comparator ope 7% umize (Quad low-power operational amplifier IPI, CDIP14 7 Lwra9 Quad vottage comparator opp 72 Lutgea Quad votage comparator Dita Lise Dual low-power operational amplifier CIP Lwts3 Low-power dual votago comparator CDIP@ Lwtosa Low-power dual votage comparator DIPS tet Voltage comparator ope so8 wero Dual votage comparator corps 7 Meas ‘Quad low-power operational ampiier _DIP4, CDIP14 ” ese ‘Quad vottage comparator opi sou 8 Lweson ‘Quad vottage comparator DiPia 7a wes Dual low-power operational ampiifer DIPS 808 7 Lwee01 ‘Quad vottage comparator Dipia 8014 8 Lwzoce ‘Quad low-power operational amptier —IP4 8014 7 Lveoc3, Low-power dual votage comparator Dips 08 cd Lwza04 Dual low-power operational amplier DIP 808 7 wes Low-power dual vtage comparator Dips, CDIPS 808 8 Lesa Low-power dual voltage comparator ips’ 78 uit Voltage comparator Die $08 78 wate Voltage comparator Dips. so8 8 Lst9 Dual votage comparator pips 8014 7 aes ‘Quad tow-power operational amplifier DIPI4, CDIPI4 S14 7 NN ‘Quad low-power operational ampiier —DIP4 S014 7 Lwsse ‘Quad votage comparator piers 8014 78 aoa ‘Quad votage comparator Dip 78 vase Dual low-power operational amplifier DIP 808 7 Lassen Dual low-power operational amplifier DIP 808 7 a3 Low-power dual votage comparator Dips, coIps 808 8 L393 Low-power dual vtage comparator DIPS, COIPS 8 Lvrievet-o 3 Vok BICMOS versatile GAL-ype PLD DIP20 PLoc20, soz ‘80°20, TSSOP20 68 Lvrieves 3 Volt BICMOS versatia GAL-ype PLD _DIPz0 PLcG20, $020 ‘SS0P20, TSSOP20 sales 6 ivrieve7 3 Volt BICMOS versatile GAL-ype PLO DIPz0 PLCCz0, S024 ‘S80P20, TSSOP20 sales 66 Lvrevio7 3 Volt BICMOS versal PAL pipes PLcces, S028 sales 66 Lvrzavi0-8, 3 Volt BICMOS versatle PAL Dipet PLcc2e, $024 sales 66 Lvrzavi0.D '3 Volt BICMOS versal PAL pipes PLccee, $024 sales 66, Lvr3082 PLoces’ sales 7 axe421 Dipzs 028 lou 78 Maxeaat Dipza. 8028 roa a Maxie B.D NMOS miorocontoler Diz8: 8028 tou 78 Mez052 Dual otal registred transceiver ‘aFP52 Ic23 88 MB2240 16: invoring butfortine diver ‘aP52 cas 37 MB2241 16-bit butertine driver aFPs2 cas 7 Mazza 16-bit butterine driver caFP52 eas 87 Mex24s ual ootal transceiver arPs2 cas 58 MB2373 ‘ual octal transparent latch carps 1o23 57 Ma2374 ual octal D-type tip-top aFP52 1023 57 231 Philips Semiconductors Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ype package hand page number description through-hole__SMD book 3 Mees77 Dual octal D-type fip-op with enable FPse 02s 7 Ma2set Dual octal buterine divers aFPs2 o23 7 Bess Dual octal latched transceiver FPs2 ces 58 B2623 Dual octal transceWver wih dual enable FPs2 023 58 Mazes Duel octal bus transceiversiregistors FPs2 ces 5 B2es2 Dual octal ranscewversirogisirs FPs2 ces 58 M262 Dual 10-t D-ypatipsop FPs2 12 58 e2e23 Dual o-bit D-type fip-lop FPs2 i238 58 MBe8e7 Dual 10-bit butfertine diver FPs2 ica, 7 M2644 Dual 10-it bus intorace latch cFPs2 Iza 53 M2661 Dual 10-5 bus transceiver aFPs2 12 58 Motaoe-s ‘bit mutiptying DAC pips 8016 ret 78 Mc14s4os EIA-292.0, CCITT V.28 devortoceiver IPI so16L eo 85 Mctas8 Dual gen. purpose operational ampli IPB 08, rent 7 Mo1496 Balanced modulatoldemodulator DiPt4, cDiLts 17 7 Mcts08-8 ‘ba mutpiying DAC core len % Morse ‘Dual gen. purpose operational amplifier IPB lon 7 Mcts%6 Balanced modulatorldemedulator DiPt4, corps ic17 37 Mo3302 {Quad vottage comparator DIPi4,coIP4 O14 ten % Mca361 Low-power FM IF system DiPis sore. 1009, 17 88 Mo3a10 10-1 high-speed multiplying DAC opiPis lent % Mosa10c 10-bit high-speed multipiying DAC cores lent 8 N74F00 (Quad 2-input NAND gate DPI 8014 los e N74Fo2 ‘Quad 2.nput NOR gate Dipia S014 tors 62 N74FO8 Hox inverter Dipia 8014 ris, 6 N74FO6 Hox inverter buttercriver DiPia S014 ros, 60 N74Fo7 Hox butfertine dever opis 014 eis, 60 N74F08 ‘Quad 2-nput AND gate pips 8014 11s e N74F10 “Triple input NAND gate pies S014 115 62 N74F100 Dual UK posiive-edge tiggored fiptio IPI 8016 ess, 62 Nvarit “Triple Sinput AND gate Dipia S014 6 Nrari12 Dual JK negative-edge tiga. fip-op IPI S016 e NraFH13 Dual JK postive-edge tiggared ip-lo —-IPI4 S014 e NFN4 Dual JK nogative-edge tigg. fipsiop ——IPI4 S014 2 NrAF 1240, (atl butfar Dip20 8020 60 N7AF1241 (Oct butter Dip20 8020 6 NraF1243 Quad tansoaiver opis so14 6s NrAF i248 (Sct but Dip20 020 cy NTF 1245, (Octal bus transceiver 1P20 020 65 NaF I25 ‘Quad butter ppd 8014 60 N74F126 ‘Quad butter Dia S014 0 N74F132 ‘Quad 2.nput NAND Schmit tigger pips 014 62, 64 N7aF133 ‘1ainput NAND gate oiPis 8016 62 NraFi98 Stine to Brine decoderdemuiplexer IPI 8016 et N74F139 Dual 2tine to din decodertdemux DiPi6 8016 6 Nraeta Hox Inverter Schmit tigger Dipta sors 64 N7AF 149 Biine to 3-ine pioty encoder Dips. 8016 6 N7AFIS1A ine to ne muliplexer pris $016 a N7AF153 Dual ne tone multiplexer opis 8018 3 N7aF54 ‘ine to 16lne decoderidomutiplexer —SDIP24 S024 6 N7aF157 ‘Quad 2input data seloctorimuliplexer —DIPI6 S016 63 N7AE157A ‘Quad 2input data selctorimuliplexer—DIPIG 8016 63 NraFi5@ (Quad 2-nput data seleciovmutiplexer IPI. S016 iors, 6 N74F1584 (Quad 2-nput data selectovmuttplexer IPG S016 os 63 N7AF1604 Dual octal ath pipes 8028 ers 63 N7AF161A ‘Synchronous 4 binary counter DiPis 5016 ers 6 282 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ype package hand) page number description through-hole SMD book a N7AFI6SA ‘Synchronous 4-bit binary counter DiPt6 8016 tors N7aF164 it soratinparalo-out shit 9, Dita 8014 ters NTF 166 {it sor/par-in/sria-out shit 69. Dipt6 8016 115, N7AF169 ‘Synchr. 4-bt binary upléown counter IPI 8016 ics, N7aFt7a {Quad D-type fip-fop Dips 8016 rors, NIAFt74 Hex D-type flip-top with reset overs S016 irs, N7aF175 ‘Quad D-type edge-tiggered fip-op DIPI6 8016 los N74F 1762 4 Mbit memory address controler DiPao PLocas 115, N74F76 1 Mbit itetigent DRAM controtor DiPas PLocas res, N7AF704 1 Mbit DRAM dual ported controler IPAS PLocas (15, N7AF784-4 1 Mbit DRAM dual ported controler IPB Picea ris, N7E1785, 1 Mbit ORAM dual ported controler PAB PLocas less, NTAF765-4 1 Mbit DRAM dual ported controler IPB PLocas ors N74F1766 Burstamode DRAM contler Dips PLocas iors N7aF1779 8. bidirectional Binary counter DiPI8 sore ors N7AF 1004 Hex 2-input NAND diver ip20 020 ors N74F 1005, Hex 2-input NOR ever ip20 8020 os N74F 1808 Hex 2-nput NAND driver ip20 020 cs Nraeiat it arthmetic logic unt SDIP24 S024 es N74F182 Look-ahead carry generator Dipie 8016 ors N74F1832 hex 2input OR diver ip20 8020 os N74F1898 ‘4bit TTL bipolar RAM (164) Dipis 8016, S016. ICS 63, 69 N74F191 et bit binary upltown counter IPI 8016, es, et N74F193 et ¢-bit binary upldown counter IPB 8016 115, et N7AF198 ‘4b bidirectional universal hit eg, DiPi6 8016 11s eo N74F195 ‘4b parallel access shit register DiPie S016 ics, os N74F198 ‘bit bidirectional universal shit reg. spiPz4 S024 ics, 64 N74F199 ‘bit parallel access shit ragistor sDIP24 S024 11s 64 N74F20 Dual 4-input NAND gate Dipta som 1s e N7AF210R ‘64-bit TTL bipolar RAM (16x4) DiPi6. $016, Ste, ICIS 63, 69 N74F2240 (Octal inv. buffer with 202 torm. networ —DIP20 ‘8020 ies, 60 N74F2261 ‘Octal butler with 30 term. network P20 8020 1s 60 N74F2244 (Octal bufar with 30 © term. network DIP20 8020, $80P20 ICIS cy N74F2045, (Octal bus transceiver ip20 8020 sales 65 N74F228 1636 asynchronous FIFO iP20 8020 115 64 N74F2573, (Octa transparent latch ipz0 5020 ‘sales 6 N74F240 (Octal invertor butter ipz0 8020, 8S0P20 ICs 60 N74F2408 (ctl inverter butter iPz0 8020, S80P20IC15 60 N74F261 (ata butler ipzo ‘5020 11s 60 N7AF2A1A (Octal butter i209 S020 115 60 NraFoa2 ‘Quad bus inverting transceiver Dipta S014 115, 04 N74F243 ‘Quad bus vansceiver Dip 8014 115, 64 N7AF 268 (etal butfer iPz0 S020, S80P20 IC15 60 N7aFoAan (Octal butter i290 020 11s. 60 N7AF 2448, (otal butlers DiPz0 8020 15, 60 N74F245 ‘Octal bus transceiver DiPzo 8020, $80P20 IC15 64 N74F2518 ‘sine to tne mutiplexer DiPt6 8016 115 6 N74F253 Dual 41ne 0 t-tne multiplexer DiPi6 8016 ris 6s N74F256 Dual 4-bit addressable latch DiPt6 80168 ris. 6 N74F257A ‘Quad 2ne to tine data selectormux IPI 8016 115 63 N7AF258A ‘Quad Zine to tine data selectorimux IPI 8016 ers, 6s N74F259 ‘bit addressable latch DiPt6 8016 rors, 6 N74F260 Dual S-input NOR gato pita S014 115, 62 N74F269 it binary counter SDIP24 S024 ress, et N7aF27 “Triple 3.nput NOR gato Dips S014 ra 62 NraF273 Octal D-ype tip-top with reset iP20 8020 ress, et 233 Philips Semiconductors Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype package hand) page ‘umber description throughrhole__SMD book 3 N74F2794, Octal ype tip-top iPz0 020 ers et 1N74F200A .it oddleven party goneratorcheckor IPA 8014 lors 60 N74F2808 S-bit oddlaven party generatorchecker IPI so14 lors 60 N74F283 ‘4b full adder wit fast carry DiPi6 8016 tors 60 N74F2052 tit transceiver soipe4 8024, PLOO28 ICIS 65 N74F2053, e-bitwansceiver SoIP24 S024, PLOG28 ICIS 6s N74F200 (Quad 2-nput multiplexer with storage IPI 8016 leis 04 N74F209 (Octal shitistorage register iPz0 8020 ics, 04 N74F20 ‘input NAND gate Dip S014 1s, e N74Fso240 (Octal 20 2 tine ctivr with enable S0IP24,cDIr2¢ S024 15 er N74Fs0246 (Octal 30.9 wransm.tnafbackpiane driver SDIP24,GDIP24 S024 1s, et N74F2097 ‘Quad 2.np. NAND, 30 9 transm. in dr. DIPI6 S016. 1s or N74F9098 ‘Quad 2.np. NAND, 20 0 transm. ine de. IPIB sore ers, 6 N74F9040 ‘Qual 41np, NAND, 90.2 wansm. line dr. DIPIB sore 1s, et N7aF92. ‘Quad 2.nput OR gate Dip 8014 15 e N7aFs22 (Octal shitvstorage register ip20 3020 15 ot N7aF323 (Octal sitvtorage register ip20 ‘8020 115 64 N7AF50 “4bR shit register Dipis sote eis, wo N74F353 Dual 4-nput mutipexer DiPis so16 os 63 N74F 65 Hex buttovcriver pris S016 15 60 N74F966 Hex inverter butter pies 8016 os 60 N74F367 Hex butrcrver DiPis 8016 os 60 N74F968 Hex Inverter butler Dies S016 ios 6 Nr4rs7 (Quad 2-input NAND buffer pips 8014 ows 62 N7eS73 Octal transparent latch DiP20 8020, $80P20 ICIS 6 N7arar4 Octat D-ype tip-top iro 8020, SS0P20 ICIS 6 N7aF377 Octal D-ype tip-top with cock enable D120 8020 crs 6 NU4ES77A Octal D-ype tip-top with enable iP20 8020 ters 6 N7aFa7e Hox D:¥ype flp-op with clock enable IIS 8016 cis 6 N7AF979 {Quad D-type fipop with enable Dipi6. 8016 15, et N7AFS7OA ‘Quad paral register wih enable DiPI6 so16 015 et N74FS8, ‘Quad 2 input NAND butter Dipia sot 1015, e N7AF381 4-bI anthmatic logic und Dip20 020 ies 60 N74Fa82 ‘bt artis logio unit 020 ies 60 N74F385 ‘Quad serial addersubtractor 020 tors 6 N74F3803, (Quad FutureBus backplane transceiver Pucca iors 6 N74F203 Dual 4-bit binary ripple counter S014 os et N7AF305, 4b cascadable shit register 8016 ers 4 N7AF308 (Quad 2-por register tue 8020 11s o NTAF309 ‘Quad 2-por reqistr tue 8016 eas o N7AF«O Dual 4-input NAND but S014 ies, 2 N74F410 ‘94-bit TL bipolar RAM (164) 11563, 64,60 N7AFASS ‘Octal butler with party gon. chock ‘so24 ess, 0 N7AF456 ‘Octal buter with party gen. checker 8024 ies 60 N7AF50100 ‘Synchronizing dual JK ipo 8016 os 62 N74F50728 ‘Cascaded synohr. dual D-ype fip-op S014 tos 62 N74F50729 ‘Synchronizing dual Dype fiptop 8014 os 6 N74FsO74 ‘Synchronizing dual Dype tip-top 8014 ors 2 N7aFSi ‘Dual 2-wide 24nput AND-ORVinv. gate S014 11s, 2 N7aF521 ‘B-bit identity comparator 8020 ross. 0 N74FS24 bit register comparator ‘8020 115 60 N74F5300 Fiber-optic LED driver sos oss, et N74Fs302 Fiber-optic dual LED/clock divor Sov ess, et N74F533 Invrting octal D-type latch 020 ors 83 N7AFS34 ‘Cota type fip-lop 020 es et N74F597 1-10 decoder 8020 los et Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page umber description through-hole SMO book Es N74Fs38 1-068 decoder ipz0 s020 N74F539 Dual 1-08 decoder ipz0 S020 N74F540 Octal butfertine diver Dipz0 8020 N74F541 ctl non-inverting butfrtine ceiver ip20 8020 N7AFS49 Octal registered transceiver soiP24 8024 N7aF544 Octal registered transoeiver s0IP24 S024 N74F545 ‘Octal bus transceiver iPz0 $020 N74Fss2 Octal reg. vansceiver with status fags DIZ 028 N74F564 (OctatD-ype tip-top iPzo 8020 N74F569 “4-bi binary upldown synch. counter D120 S020 N74F573 (Ota transparent latch Dipz0 020 N7aF574 Octal D-Yype tip-top DiP20 020 N74F579 ‘bt binary upidown counter, common WO DIPZ0 020 N74FS595 8-it shit regstor with output latches IPTG 8016 N74F597 8. shit register with input latches Dipte 8016 N74F508 8. shift registr with input latches ipz0 8020 N74F604 Dual bit register ize: 028 N74F620 Octal bus transceiver iP20 8020 N74F621 Ocal bus transcoWver i209 8020 N74F623 Octal bus transceiver DiPz0 8020 N7AF64 4-2-8-2input AND-OR-nvert gate oIPt4 8014 N74Fo40 (Octal bus transceiver biPz0 8020 NraFeat (Octal bus transceiver pip20 020 N7aF642 (Octal bus transceiver Dip20 8020 N74Fo06 (Octal bus transceiver and register SDIp24 8024 N74F6464 (Octal bus transceiver and register sDIP24 ‘8024 N74F647 Octal bus transceiver and register sbiP2 S024 N7aF648 cal bus transceiver and register soIP24 S024 N7aF64BA (Octal bus transcewver and regster sDIPad S024 N74F649 (Ocal bus transceiver and register soIP24 S024 N7aF6s1 Octal wansceiverregister SDIP24 S024 N7AF653A Ocal ranscoWverregister soIpe4 024 Nrarese Octal vansceWverragister solPe4 S024 N7AFS52A (Octal tanscewvertogister spipa4 S024 NraFess (Octal transceivertogister corres N7AF6S5A (Octal inv, butler wih panty gen/check —SDIP24 soz N7AFSSEA (Oct butler with party gen. checker SDIP24 024 N74F657 (Octal bus transe. with party gen/check —SDIP24 soz N74F670 “4x4 rogitor fe piPi6 S016 Nraror4 16-bit ser/par-in seal out shit 10g spIP24 soz N7aF676 16-bit ser/par-in.setal out shit 16g sDIP2 S024 N7AFTI1A uintuple 2-input muliploxer ip20 ‘8020 NTAETI 4 Quint 2input mux with 30.2 termination DIPZO S020 N74F7124 ‘Quintuple 3-nput mutiplexer spiP24 8024 NrAFTi24 Quint input mux with 30.2 termination SDIP24 ‘S024 N74F7234 (Quad 3-input mutplexer D124 ‘so2t N7aFT2341 (Quad 3-input mux wih 30.9 termination SDIP24 S024 N74E725A (Quad 4-input muttplexer soiP24 S024 NTAFT254 (Quad 4-input max with 30.9 termination SDIP24 S024 N7aF739 (Quad data multiplexer Dipz0 8020 NraFT4 Dual Diype edge-tiggored flip-flop Dip S014 N74F756 Octal inverter butter iPz0 S020 N7aF757 Octal but i209 020 74760 ‘Cota butar o1P20 020 N74F764-1 DRAM dual ported controler DiPo PLocas N74F765-1 DRAM dual ported controler wio latch _DIPAO PLocas 235, Philips Semiconductors Alphanumeric index Concise Catalogue 1996 INTEGRATED CIRCUITS ‘ype package and page ‘number description through-hole_ SMD book x NTAETTS (Octal ba. ached bus transceiver Dire Puoces tors 65 NUETI “Tipte bi. latched bus transceiver ———_—DIP20 PLoc20 rons 65 NIAFT79 ‘8. bidirectional binary countor Dirt Soi lens et NTAF7@6 ‘input asynchronous bus abitr DiPie S016 ions 64 N74F@04 Hox input NAND ceiver ir20 8020 rons st N74F805 Hex 2snput NOR driver 1P20 3020 iors et N74F007 ‘Ocal shiticount registered transceiver IP2B 026, PLEC28 Cts. 85 Nz4Fe08 Hox 2ingut AND aver ir20 18020 res o N74F@2t “0: bus intrace register soipe4 5024 iors os N7aFe22 40-5 bus intrtace rogstae soip26 S024 ies 6 N74F823 i bus intrace regstor soipz6 soz rors, ot N7AF628 9-0 bus itrace register soip26 8024 rons 6 N74F825 2. bus iteace register soiree 8024 rors, os N74F@26 825i bus inarface rogsar sires 5024 1015 64 N7are27 “0-5 butor ine ceiver soiree 024, 8S0P24 C15 60 N7AF 828 1-5 bute ine diver soiPe4 S024 ros, 60 N7AFe32 Hox 2sinput OR aver iP20 5020 1015, i N74F095 ksh register suIr26 5024 e158 64 N74F@t “0. bus interface latch soipes 5024 1018 63 N7Aro«2 100 bus inetoce fateh soiree 8028 1015 63 N74F9« 9-4 bus interface azn sire 50% iors, 63 N74Fo44 bi bus interface atch soir 024 ions 6 N7aro48 Bit bus interface atch sors 8026 iors, 6 N7aro@6 bit bus interface latch soir24 3024 1015 6 N74F85 {401 magatude comparator oiPi6 sore iors 60 7A 66 Quad 2-input EXCLUSIVEOR gate IPS Sov iors 8 N7aFa61 10> bus transceiver soiree 8028 rors, 65 N74FB62 10-5 bus transceiver SDIp26 024 iets 65 N74F063 S-itbus wanscelver SOIp26 3024 rons 6s NAF B64 bus transceiver soles 024 rors, 65 7478960 (Octal ached br. FutureBus vansc. IPB PLoczs ros 65 NTAF8961 cial laced bi. FuureBus warsc. ——DIP28 PLocas ros 65 N74F8962 ‘bt latched bide. Futures vanse. Fes, PLogss 015, 6 N74F 8963 ‘latches bide. FutureBus Wanse OFPas, PLOCAA 1015 5 N74F 096s Futurobus address data transceiver PLocas 1015, 65 N7AF 8966 Futuebus adress data vanscever PLooss 1015 85 NezHsa21 £32766: bpolar PROM (409638) Dip24,cpip2s —PLCC28 sales 3 NazHSa2iA 532766-bit bipolar PROM (409638) Dip24,coIp2s—PLOC28 sales 68 NeoHS3218 32768: bipolar PROM (409638) DiP2s,coP2s —PLOO2 sales 68 Neo.stas 2048-t bipolar PROM (25638) 1P20 3020, PLCcz0 sales os Ne2st2a 255: bipolar PROM (3238) opi S016, PLOG2D sales 68 251204 256: bipolar PROM (32) ois S016, PLCC20 Sales 3 Ne25126 {024-bt dipolar PROM (25644) DPI S016, PLOG20 sales 6 N25 1258 1024-5 bipolar PROM (25634) DIP. S016, PLOC20 sales 68 Ne2st29 1024: bipolar PROM (2564) Dis S016, PLCC20 sales, 6 Ne251204 1024-bt bipolar PROM (256e4) DiPi6 8016, PLCC20 sales 6 Ne25190 2048. bipolar PROM (5124) DiPi6 S016, PLOC2D sales 63 Ne251308 2048.bt bipolar PROM (51244) DiPis 5016, PLCCZD sales 8 Na2si3t 2048-0 bipolar PROM (51244) Dis S016, PLOC2D sales 6 NSD5I31A 2048 bipolar PROM (51244) ors 5016, PLOC20 sales 68 Nexsi35, 2048+ bipolar PROM (25618) iP20 $020, PLCCZ0 sales 6 a2s137 4006: bipolar PROM (102834) DiPte 3020, PLOC20 sales 68 Nez5t37A 4006: bipolar PROM (102634) oie 18020, PLCC20 sales 6 1a2s1378 4006: bipolar PROM (102834) oie 18020, PLCC20——salos 6 ezstet 4006 8 bipolar PROM (51218) Oir2s, soIp2¢ LOC sales 6 Ne2BA1A 4006: bipolar PROM (51218) Dip24,s0IP24 PLCs sales oe 238) Prilips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index type package hand page number description throughrhole SMD book es Neos147 4006 bipolar PROM (5128) o1pa0 so20,picc20 sale rs Neosta7a 4006: bipolar PROM (5128) Diao S020, PLCG20 sales @ Neosia78 4006: polar PROM (51238) ireo 8020, PLCC20 sales 6 Nester ft02.h par PROM (10268) Dies, soiree —PLcoas Seles 8 NaostaiA ‘182: bipolar PROM (1026) oiee Pleces ed 8 Neastere 192: par PROM (10248) bires, soiree Pecos sales « Na2st9sa ‘182: bipolar PROM (204644) oipte S018, FLCcz0 alas ° Neostase ‘182-b iplar PROM (20464) opie S018, PLCc highspeed 3 V AD converter Lorre tco2 103 Aer" 25 Miz pe 8 vdeo OAC rps W602, 22 403 ToAErT2 39/85 NH2 tiple 6 vdeo DAC oFPse toe, 22 03 TDASTTEA Tipe BM video OVA converter oFPes 1602, 22 103 27, Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index type package hand page umber description througrrtols SMO book ES rossr76 10-500 MSPS DIA convener picces too 109 ToABrT6A {orb 100 Msps 1A converter ricezs Deco paseo ‘Toe logan anger Seorcom rer 7 ToABres bt AD wih contol sin orrea Sates 104 Tossre0 ft, 40 Maps ND conener s50P20 Deco ot Tone Dual 8b 40 Maps AD converter torres Dsice —ot oaseze Unwereal PRLNTSO progam. medator 5006, SS0P24 Sl tor Toastat igen ee multarard dover icoe too Toasts Aigeont os mulsaard decor sates too Toastes Aiport tee multstarard dacoer icoe too Toaoteoe Progenmabledoecton conoler tone tos TDA Programmatie deflect controler toe tos TOASTCOR tstndar coger, ye, processor sales tee Tonotera Sve-cnroled decodersye processor tales tos Toaotee Mtitanaré decoder, oye. processor sales too TDAst70 "UV pre mprovement prem soe icoe tes Tosi” YUV pete improvement restr Dsiooe oa Taste Linanoe tansent proveren 1 Dsicce 0 rproe'0 fo Ft pressor for VS 8 ao corres reo tor Tonset2 is store auo processor arres ‘alee tor Tost iS stereo aud procesor ores tooe ior TDAGTISA Wis VC ne ip povesor Grreonec koe ior Toaoves WHS vdeo (7) processor sorrse Sales ior oxsec0 TV ampttarandPLLdonoddatr ——-DIP20 soz toe tor Toaceoe Mutst amp and PLLdereasatr ——Dlp2d S000 tooe tot ToAse0s Mutis amp and PLLderecuor —‘DIP2D 5020 tooe tot “xseoe Vir PLL comer piezo teoe ie Tones Murtstndara E-PUL and FPL domod. SOIPS2 Dsice fot Toaseos Sige sandard 05S: and FM cemed. DIP20 soz teva tot Toate Muitandare V-PLL sore Dsice tot ToAcet2 Mult VIF-PLL with AWFM PLL demo. 8008 teva tot pases She standard VIPUL 5008 Deco fot Toasete Multan VPS PLL S008 Dsicoe fot Toasets MtistrdardMAC VIF-PLL sorse Deicce ot Toaoez0 Mulistandard TF sound demodtor toe tot proezt Doal amet TY FAEPLLcound domo DP too tot TDAeco ‘Wanrooune rest Dre sors rove tor ToAset0 1 strata seul processor Dire. 5020 rove tot Toasets TWVtm stool sound processor ——_—DIP2D 5000 too tot Tose? Vand Vi srefaal sound processor SDIP2t Soet Dsice ot Tonseso Vand VIR streofduel sound posessor SblPa Soe Dscaz ot Toacess [2Cbus cnmoted BSC slwSAP dee, SDIPS2 Piccee tones fe Tonseeo Unnersal nt ado processor sore teoe tee Toots TF itor, FM detector and audio amph__DIPTE sows ‘ios oe Torre Lowponer teeny sybase’ COPSY) S028 toto, 17 " Torsros bt highspeed ND converter Soze rove 104 rorerre San DIA convertors pies sore. rove tos Tenoees Doty BC pce wih preanpiewich Dien S028 toot ° Tees Dis Deby Bre Youcion cra SUIP24 Sozt foot % TeA0876 Dia head pre-amp sore. sels Tener? Dal prepiiree equalize Soze roo rf Tena Dus! Doby Bre redcton stout ——-SDIPS2 Some toot oe TeArOW7 {opt cerbar oom dopey ever PIB sales 0 Teatooo Swiched mode power soppy conor SIL9 toe. 11 & Teatont Eatery biol toe 08 ten & TEAI000 Speech arson creat pis (603 % 258 Philips Semiconductors Concise Catalogue 1996 INTEGRATED CIRCUITS Alphanumeric index ‘ype package hand page umber description. through-hole__SMD_ book ES TEAIO61 ‘Speech transmission cut ope 10s 20 TeAt0s2 ‘Speech transmission cicut Dipie sore 1603, 90 TEATOS2A, Speech transmission cuit pipie 8016 1603 90 TEAT063 Interface for long tines P20 020 sales 90 TEAt064A Speech transmission circuit P20 8020 103 90 TEAI064B ‘Speech transmission circuit P20 020 103 90 TEAI065 Speech transmission circuit pipes S024 103 90 ‘TEAI066 Speech transmission circuit 8020 103 90 TEAI087 Speech transmission circuit pips 8020 103 90 TEAIOS7A ‘Speech transmission circuit DiPta 8020 sales 90 TEAt068 Speech transmission circuit DiPta 8020 03 90. TeAtoat Supply circuit for telophone cots ips 508) 10s 90 TEAw8s Call progress monitor ips cos — TEA1083A, Call progress monitor DiPi6 S016. 100s 20 TEAt085 Lstening-in circuit bipe 5024 co 80 TEAT0B5A LUstening-in circuit ipea S024 ‘cos 80 TEA088 'SMPS battery charger contol cuit SO16L ion 82 TEA1093 Hands-ree tolephone sat circuit bipz ‘5028 sicos 90 TEA1094 Hands-reetolophone set circuit lg ‘8028 cos) 90 TEAI095 Voice switched speakerphone IC soz sales 90 TEA1096 ing interface and lstening-n cut Dipzs soz tos 90 TEAI0O6A, [Ung intertace and lsteing-in cut pipes 8028 103, 90 TEAT1O0 Control leu for battery chargers DiPie O16. ton 82 TEANIO1 CCorirl circuit for battery chargers Dipis sore on 82 TEA1I2 Meriter and contol IC for NIMHINCS IPI 8020 sales a2 TEANI2 Une interface for parallel operation lay 5016 sales 90 TEAIIIZR Une intertace for parallel operation Dipi6. 8016 sales 90 TEAIIIS ‘Une intertace for parallel operation pips 8018 sales 90 TEANOI lectonic power plug contol IC 020 sales a ‘TEASSOO Coded locking ert for security systoms —_IP16. Sore. kent 93 TEASSO1 Coded locking ct for security systems IP14. ont 93 TTEASSS1 Single-chip AM radio 8016 tor 94 ‘TEASS70 RFF circuit for AWEM radio pips tor 94 TEASSB1 PLL storeo decoder piPis S016. tot 95 ‘TEASS®2 BBTSC PLL stereo decoder iP20 coz 102 ‘TEASS91 AMUFM rao receiver circu iPz0 cot 94 TEASSOIA |AMUFM radio receiver circuit SDIP4 ‘cot 94 TEAss9« |AMUFM rad receiver ccut, ‘soiPa2 cot 9 TEASTIO. |AMVEM aco recaiver circuit, sDIP24 8024 cot 9 TEAST |AMUFM stereo radio creut SDIPs2 ose tco1 94 TEASTI2 [AM/FM stereo DTS radio cieut sDIPa2 022 Ico1 9 TEASTST Solf tuned AMM aco reoaiver ‘arpa Ico1 94 TEASTSS Seif tuned AM/FM radio receiver aFPaa sales 34 TEAS7E2 ‘Sef tuned AM/FM rac receiver FPa4 Dsicor 4 TEAGIOO FAME system for microcomputer turing D120 toot 94 TEAGION ‘Astenna diversity out opie 8020 vot 95 ‘TEAGz00 ‘AM upconversion radio receiver DiPz0 tor 9 ‘TEAG300 Car radio pre-amp and source selector DIPZB 028 ‘ot 95 ‘TEAS320 ‘Sound fader contol circuit SDIPS2 032 scot 95 TEASI21 ‘Sound fad contol circuit ‘SDIPS2 8022 ‘cot 95 TEAS322 ‘Sound fader control circut vso40 sales 95 ‘TEASS25 ‘Sound tader contol circuit vvso40 sales 98 TEAG2I0 ‘Sound fader contol circuit 8020 cot 95, TEAB60 Five-band equalizer SDIPs2 sox cot 98 TEAG810 Front-end and PLL synth. for car radios soso tco1 9 TeAse11 AMUFM RF and PLL synthesizer circuit vvso10 ico 94 250 Philips Semiconductors Concise Catalogue 1996 Alphanumeric index INTEGRATED CIRCUITS ype package hand page number description throughrhole SMD book = Tenssat ICE car ado vsose icot o Tensa2e AMF I, storo decoder and NC cet vs056 ssles o TEAB850 Pre, channe selectivity PACS creat FFAs, de icon ot TSA5055 25 Giz Udrectonal fog. aynbesizer sore Icoa 106 Tsasstt 1.3 GHz bldrectnalsytesier ore ico2 400 TSASSIIAT ——_1.3.GHe bdrectonal synestzor so20 tcoe 100 Tsassii 113 GH bidrectonal synthesizer S016 tco2 100 Teassi2 113 GHz bideoctnalsyesizer ore ssorzom tco2 400 TSASSI2AT ——_1.8.GH Udrectonal synhesizr S020 ico2 400 Teasstar 1.3 He bidrectnalsyosier 5016 icoe 100 Teasste 1.3 He bidectonalsyesier ores S016 Icoa 100 TSASSI4AT 13 GHz Didectana syihesizer $020 ico2 400 Tsassi6 113 GHebldoctonalsynesizer sors tcoz 400 Tsassi8 1.3 GHebidroctonalsythestar 50°20 tales 100 TSA5520 13 GHe PLL requency smibeszer 5016, SsoPteM fone 400 TSAS52 413 Giz PLL frequency syrtesizar 8016, SS0PieM 1602 {00 A552 414 Gtz BC bus contd sytesizor S80F20,8018 1602 400 TsA5526 113 GHz PUL requency eynteszer S016, SS0FtEM 1602 100 TSAss26A 113 Gis un tumcontoed TV synth S016, SS0F16 1602 400 Tsasszr 13 GHe PUL toquoncy smteszor ssoF eM Icoe 100 TsAss27A 1.3 GHe un. bus-contoted TV sysh S016, ss0P16 1602 400 Tasos Fado tuning PLL reqiency syteszar —DIPI6 Soi6. icor 34 TsA6060 Fadi turing PLLrequney syteszar —OIPI6 so%6t toot a Usazos0 Low-power gta UHF paging recover 5026 160 % Usacoer image reject 1800 Mz vanso. or OECT LorPse ici 3 usazor2 Image reject on-and or GS SsOP20M 1603, 17 rs uaazore Image rejecting one for GSM 'SSOP20M osicrr 88 UAAZO7ZA Image reject rert-on for DECT 'SSOP20M psicr7 88 usa20778 image reject ror-on for DCSIPCN SSOP20M osicr7 8 Usazoeo ‘Advanced pager caver 5028, OFPS2, FC 1603 89 Usanoee ‘Advanced pager receiver rorrs2 1609, 17 20 Uaaszot UMFAVHE ferote contol aciver S016 sles 100 Uaioe Higholt DMOS intro and roger ORB 8028 Deco 2 UBAI7004 Hight OMOS interptor and foger IPB S028 Dsicas %0 ucaeae Currertmdo PNM contol oe soe tent 2 UMaro00t Data processor for eal rato soz 1603, 17 rs ‘waiooz proc aFrae sales °° uMatoos Dual low-power roquency syrteszar 'ss0P20 160s, 17 a UNAtors Low-power yrbeszer fr mob racos 5016 1603, 17 e7 UMaiois Dual 1.1 GH requnoy snester ssorzom Dsic09 87 umator7 Lowvotage 1.2 GHz freq syhestzr ssorzo ici er OMatoro Lowevltage dual 1.2 GHz fog yh ss0rz ic er UMator9 Lowevtage ro. synth foe ao Ss0P20M ior 7 UMAtOr9A 117 GH ag, synosza for GSWOCS 'SSOP20M ici? e7 untatozo Lowevattage cel 24 GH fog yh 'SSOP20M ic &7 UMAt020A 417 Giz da fog. synth, fr GSWIDCS ss0r20M tc? 7 tuwasoas ovevallage fog sth for dot ss0r20 dsics7 e7 UF 000 Data processor for collar ado S028 tcoa = area Precision vote rguistor cerita ten e war230 Precision votage restr Die sow ton ee nares Deental veo ampiir bute ren 7 war930 Diferental veo ampier biti ier 7 nares Generel pupces operational ampifer LB rei n arene General pupose operational amifer LB sos ren 7 nararc Duel operatona amp ote ici 7 260 Philips Semiconductors Concise Catalogue 1996 DISCRETE SEMICONDUCTORS Alphanumeric index ype hand page umber description book 4 DISCRETE SEMICONDUCTORS. 1N4001G Mains rectifier soot 60 41N40011D Mains rectifier scot 60 1N40026 Mains rectiior Scot 60 1Ng00210 Mains rectifier Scot 60 41N4003G Mains rectifier scot 60 1400310 Mains rectifier Scot 60 1N4004G Mains rectifier Scot 60 ‘1N400410 Mains rectifier scot 60 1N4005G Mains rectifier scot 60 ‘1N4O05ID Mains rectifier scot 60 1Na006a Mains rectifier Scot 60 $N40061D Mains rectifier scot 60 41N40076 Mains rectifier scot 60 1N40071D Mains rectifier scot 60 1Na148 High-speed diode Scot 50, 51 1N4150 Untra-high-speed diode scot 50, 51 ANA151 Ultra-high-speed diode ‘scot 51 14153, Uta-high-speed diode sco1 51 1N4a46 High-speed diode scoi 51 1N4a48 High-speed dod scot 5 1N4531 High-speed diode ‘scot 50, 51 1N4592 High-speed diode ‘scot 51 1N4728A, Voltage regulator diode scot 57 1N47494, Voltage regulator diode scot 87 1N5059 Controlled avalanche rectfior scot 62 1N5060 Controlled avalanche rectifier scot 2 4N5064 Controlled avalanche rectifier scot 2 4N5062, Controlled avalanche rectifier ‘soot 62 1N52258, Voltage regulator diode Scot 87 1N5267B, Voltage regulator diode scot 87 1NS817 Schottky barrier diode Scot 69 1NS818, Schottky barrier diode Soot 69 1N5819 Schottky barrier diode scot 69 4NB2t Voltage reference diode scot 59 ANB2IA Voltage reference diode scot 59 1Na23 Voltage reference diode scot 59 1NB23A Voltage reference diode scot 59 1NB25, Voltage reference diode scot 59 1N825A, Voltage reference diod soot 59 1N827 Voltage reference diode scot 59 1NB27A Voltage reference diode scot 59 1NB29 Voltage reference diode scot 59 1N829A Voltage reterence diode soot 59 1NO14 High-speed diode scot 80, 51 ANO16 High-speed diode scot 5 1PS181 High-speed double diod S001 50, 52 1PSi84 High-speed double diode scot 50, 52 4PS193, High-speed diode scot 50, 52 1P8226 High-speed double diode Scot 50, 52 1PS300 High-speed double diode scot 50, 52 4P8301 High-speed double diode ‘scot 50, 52 1psa02 High-speed double diode ‘sco1 50, 52 anizit Silicon planar transistor scoa 5,923 2N1893 Silicon transistor sco4 5,9, 23 26 Philips Semiconductors Concise Catalogue 1996 DISCRETE SEMICONDUCTORS, Alphanumet ‘ype wand age number description book 4 2N2102/PH Slicon planar transistor sales 8 2N2219 Silicon planar epitaxial transistor sco4 9, 21,23, 2NZD19A Slicon planar epitaxial transistor C04 9, 21, 23, 2Neo22 Slicon planar epitaxial transistor 8008 21,23, 2N22204 Silicon planar epitaxial transistor 8004 21, 23 2N2297 Siicon planar epitaxial transistor 8Co4 21, 23 2N2829 Thyristor sales 34 2N2969 Silicon planar epitaxial transistor sco4 21,23 2N2405/PH sales 9 2nza83, 8008 5,8 2N2de4 Silicon planar transistor sCo4 5,8 2N2894NPH icon Switching transistor sales 24 2N2905 icon planar epitaxial transistor C04 11,21, 26 2N29050 Siicon planar epitaxial transistor sco4 41,21, 24 2N2806 Slicon planar epitaxial transistor cos 21,25 2N29068 Silcon planar epitaxial transistor C04 21,25 2N2907 ‘Siicon planar epitaxial transistor SCo4 21,25 2N29078 Silicon pianar epitaxial transistor cos 21,25 2N3019 Silicon planar epitaxial transistor SCo4 21, 23 2N3553 Silicon epitaxial planar overtay transistor sales ‘100 2N3700/PH Sllicon planar transistor sales 8 2N3866 Silicon planar epitaxial overay transistor SCOBa 100, 101, 104 2N3904 C04 21, 23 2N3906 C04 21, 25 2NG963/PH Siicon planar transistor sales "1 2Na964/PH Slicon planar transistor sales "1 2N4029/PH Silicon planar transistor sales 4 Naot icon planar epitaxial transistor sco4 6,11, 25 2Na033 icon planar epitaxial transistor S008 6, 11,25 2NAOSS/PH Silicon planar transistor salos 4 2N4036 PNP power transistor sco4 25 2N4037/PH Siicon planar transistor sales " 2Naoa1 N-channel FET sco7 38, 98 2N4092 N-channel FET sco7 38, 38 2Na093 N-channel FET sco7 38, 39 2nat24 Silicon planar epitaxial transistor C04 921,23, 2N4126 Silicon planar epitaxial transistor 8004 12,21, 25 2Naz20 N-channel junction FET sco7 35, 36, 2N42200 N-channel junction FET sco7 35, 38 2Nezet N-channel junction FET sco7 35, 36, 2Naz2tA N-channel junction FET sco7 35, 36, 2Naze2 N-channel junction FET sco7 35, 98 2N42200 N-channel junction FET sco7 35, 36 2Nag91 N-channel FET 8co7 38, 29, 2Na392 N-channel FET sco7 38, 39 2N4383, N-channol FET 007 38, 39 2Nadot Slicon planar epitaxial transistor sco4 9,21, 23 2Naa02 Slicon planar epitaxial transistor sC04 21,25 2Naa03 Slicon planar epitaxial transistor 8Co4 21, 25 2Naa16 N-channol fel- effect transistor ‘sco7 35, 38 2NAG16A N-channel field-effect transistor 8co7 35, 36 2NaA27 Silicon planar epitaxial overay transistor ‘SCO8a 99, 101 2N4856 N-channel FET sco7 38, 39 2N4857 Nechannel FET sco7 38, 39, 2N4858 N-channel FET 8c07 38, 39 2N4859 Nechannel FET sco7 38, 39 262 Philips Semiconductors Concise Catalogue 1996 DISCRETE SEMICONDUCTORS Alphanumeric index ee ca ‘ype hand page umber description book a 2N4860 N-channel FET sco7 38, 39 2NG861 Nechannel FET sco7 38, 39 2N487OPH Programmable unijunction transistor sales 33 2N5064 Thytistor 8003 a2 2N5087 Silicon planar epitaxial transistor SCo4 17, 18 2N5088 Slicon planar epitaxial transistor C04 47,18 2N5116 P-channel junction FET sco7 38, 40 2N5400 Silicon PNP high-voltage transistor SCo4 25, 28, 29 2N5401 Slicon PNP high-voltage transistor 8004 25, 28, 29 2NS415 Slicon PNP high-voltage transistor 8604 25, 28, 29 2N5416 Siicon PNP high-voltage transistor ‘sCo4 25, 28, 29 2N5480 P-channel junction FET. 8¢o7 38, 40 2N5461 P-channel junction FET S007 38, 40 2N5462 P-channel junction FET sco? 38, 40 2N5484 N-channel field-effect transistor sco7 35, 98 2N5485 sco7 35, 38 2N5486 sco? 35, 36 2N5550 Ssco4 23, 28, 29 2N5S51 Slicon NPN high-voltage transistor sco4 23, 28, 29 2N5680 Slicon planar epitaxial transistor sales 12 2N6O27/PH Programmable unijuncton transistor sales 33 2N6028PH Programmable unjunction transistor sales 33 2N6427 NPN silicon planar darington transistor sales 5,9 2N7000 ‘N-channel enhancement mode vertical D-MOS transistor ‘S007 42,43 2N7002 N-channel vertical D-MOS transistor sco? 42, 48 2NB81/PH Thytstor sales 34 2PAI0I5 Silicon small-signal transistor 804 612 2PALOISL Slicon snal-signal transistor S004 8 2PAISIB PNP general purpose transistor SC04 6,16 2PATSS Siicon small-signal transistor Sco4 2 2pBt2te General purpose low-frequency transistor sales 5,14 2PBIZ19A General purpose low-frequency transistor sales 5,14 2PB709 PNP general purpose transistor sco4 616 2PB709A PNP general purpose transistor sco4 6,16 2PB710 PNP general purpose transistor sco4 6.16 2PB710A PNP ganeral purpose transistor scos 6,16 2PC1815 Slicon small-signal transistor sco4 59 2PCIBIBL Siicon small-signal transistor 'sC04 18 2PC4081 NPN general purpose transistor S004 5,14 2PCO45 Siicon small-signal transistor sc04 5.9 2P0601 NPN general purpose transistor ‘sc04 5,14 2PDEO1A NPN general purpose transistor scos 514 2PD602 [NPN general purpose transistor scos 514 2PD602A [NPN general purpose transistor sco4 5,14 BA220 High-speed diode scot 51,56 Baz High-speed diode scot 51 BASIG Low-voltage stabistor scot 56 BASIS Low-voltage stabistor scot 56 BASIC High-speed diode ‘scot 51 BASI High-speed diode scot 50,51 BASIB High-speed diode sco1 50, 51 BAAZ3A ‘AM band-switching diode sco1 49, 88 BAGZSAL ‘AM band-switching diode Scot 49, 86 BAAS UHF mixer diode SCO1 49, 54, 55, 86 Bassa Band-switching diode scot 49, 86 BABS Band-switching diode Scot 49, 86 28) Philips Semiconductors Concise Catalogue 1996 DISCRETE SEMICONDUCTORS Alphanumeric index iype wand page number description book Badsa Band switching diode scot 49, 86 BASE2 Band-switching diode scot 49, 86 BAGs2 Band-switching diode scot 49, 86 BABES Band-switching diode 8¢o1 49, 86 BA792 Band-switching diode scot BAL74 High-speed diode scot BAL7aW High-speed diode scot BAL99 High-speed diode sco1 BALOOW High-speed diode SCO1 BASHIS Low-leakage diode sco1 BASIS: High-speed diode scot BASIC High-speed diode sco1 BASIEW High-speed diode Scot BASI7 Low-voltage stabistor 8001 BASI9 High-speed diode C01 BAS20 High-speed diode scot BAS21 High-speed diode scot BAS216 High-speed switching diode scot BAS2B High-speed double diode scot BAS29 High-speed (double) diode sco1 BASS High-speed (double) diode scot BASS. High-speed diode Scot BASS5 High-speed (double) diode scot BAS4O Schottky bartier (double) diode scot BASASA Low-leakage diode scot BASASAL Low-leakage diode scot BASES High-speed diode scot BASS6 High-speed double diode scot BASGI6 High-speed diode S001 BAS678 High-speed diode scot BAS70 Schottky barter (double) diode 8601 BAS7OW, Schottky barter (double) diode Scot BAS70-01 Schottky barter (double) diode Scot BAS70.07 Schottky barrier (double) diode Scot BASB1 Schottky barter diode C01 Basse Schottky barrier diode C01 BASES Schottky barter diode Cot BASBS Schottky barter diode 8601 BASEE Schottky barter diode C01 BATI7 Schottky barier diode scot 54, 55 BATI Band-switching diode Scot 49, 86 BAT254 Schottky barrier diode Scot 54, 55 BATS4 Schottky barer (double) diode C01 54, 55 BATSaW ‘Schottky barrier (double) diode Scot 54, 55 BATSE Schottky barter dlode C01 54, 55 BAT?4 Schottky barter diode Scot 54, 55 BATaI Schottky barter diode C01 54, 55 BATS? Schotky barrier diode scot 54, 55 BATES Schottky barter diode 801 54,55 BATSS Schottky barter diode C01 34, 55 BATES Schottky bartior diode scot 54, 55 BATS Schottky barter diode scot 54, 55, BAVI0 High-speed diode SCo1 50, 51 BAV100 ‘General purpose diode Scot 52 BAVi01 General purpose diode SCo1 50, 52 Bavio General purpose diode scot 50, 52 264

You might also like