Professional Documents
Culture Documents
in
(All Mining Solutions)
DISCUSSION FORUM
CALL/WHATSAPP- 8804777500
EMAIL- INFO@MINEPORTAL.IN
IMPORTANT QUESTIONS
FOR
COAL INDIA
MANAGEMENT TRAINEE
PROBATION CLOSURE EXAM
-
COURTESY MANOJ KUMAR SINGH, MANAGER(IE), INDUSTRIAL ENGINEERING DEPARTMENT
www.MINEPORTAL.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
(SECTION-I : Coal Mining Technology, Mining Equipments, Organisational Profile of CIL, Physical
& Financial Performance of CIL and Coal & Coal Products)
Q1. Which of the following equipments are chain mounted?
(a) Side Discharge Loader (SDL) (b) Load Haul Dump (LHD) (c) Both (d) None
Q2. Which of the following is a Mass Production technology for UG?
(a) SDL (b) LHD (c) PSLW (d) All
Q3. Which of the following equipments can be tyre mounted?
(a) Pay Loader (b) Grader (c) Dozer (d) All
Q4. Which of the following company has deployed the largest size Shovel-Dumper combination
(42cum + 240T) in CIL?
(a) SECL (b) MCL (c) CCL (d) NCL
Q5. Which OCP has deployed largest capacity shovel Dumper combination in CIL?
(a) Gevra (b) Dipika (c) Jagannath (d) Piparwar
Q6. What is the largest size of Rope Shovels in CIL?
(a) 10cum (b) 20cum (c) 30cum (d) 42cum
Q7. What is the largest size of Dumper in CIL?
(a) 170T (b) 240T (c) 360T (d) 400T
Q8. What is the largest size of Rope Shovel in the World?
(a) 63cum (b) 50cum (c) 42cum (d) 35cum
Q9. What is the boom length of the largest Dragline in the World?
(a) 133 m (b) 150 m (c) 100 m (d) 50 m
Q10. What is the largest size of hydraulic Shovels in CIL?
(a) 18cum (b)12cum (c) 11.5cum (d) 9.5cum
Q11. What is the largest capacity of hydraulic Shovels in the World?
(a) +25cum (b) +30cum (c) +40cum (d) +50cum
Q12. What is the largest size of Drills in CIL ?
(a) 381mm (b) 311mm (c) 250mm (d) 160mm
Q13. What is the largest size of Dozer in CIL?
(a) 450hp (b) 770 hp (c) 850hp (d) 410hp
Q14. What is the full-form of LHD?
(a) Load Haul Dump (b) Load Haul Dumper
(c) Low Haul Dumper (d) Low Haul Dump
Q15. Which of the following is a mass production technology for U.G.?
(a) Longwall (b) SDL (c) LHD (d) Bord & Pillar
Q16. Which of the following is an intermittent mining technology?
(a) LHD & SDL (b) Longwall (c) Bord & Pillar (d) None
Q17. What is the bucket capacity of the largest size of Dragline in CIL?
(a) 24cum (b) 30 cum (c) 33 cum (d) 35 cum
Q18. What is the bucket capacity of the largest capacity of Dragline in the world ?
(a) 100cum (b) 55cum (c) 120cum (d) 129cum
Q19. Where could you find High Wall Mining in CIL?
(a) WCL (b)SECL (c)MCL (d) NCL
Q20. Shortwall mining is used in which company?
(a) SECL (b)MCL (c) WCL (d)NCL
Q21. In which OCP, In-pit crushing & conveying is used?
(a) Gevra (b) Dipika (c) Piparwar (c) Jagannath
Q22 What is the total number of Coal washeries in CIL ?
(a) 17 (b) 16 (c) 15 (d) 14
Q23. Which Subsidiary of CIL has Surface Miners equipments?
1
(a) Low ash & moisture (b) High Sulphur (c) Both (d) None
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q49. High Wall Mining can be classified as
(a) OC Mining Technology (b) UG Mining Technology
(c) Hybrid Mining Technology (d) Other Mining Technology
Q50. Surface Miner in CIL is used for ..
(a) Coal (b) OB (c) Both (d) None
Q51. Coal Handling Plants (CHP) are used for ?
(a) Coal Transportation (b) Coal Loading (c) Coal Crushing (d) All
Q52. The Largest Dragline in CIL (33cum) has been ordered by which Company?
(a) NCL (b) SECL (c) MCL (d) WCL
Q53. What is the ideal standard dumper for 20cum shovel?
(a) 170T (b) 100T (c) 120T (d) 150T
Q54. What is the total coal washing capacity of CIL as on 1st.April 2011?
(a) 39.4MT (b) 20.4MT (c) 30.4MT (d) 50.4MT
Q55. What is the Net Profit (PAT) of CIL during 2010-11?
(a) Rs.10,867 Cr. (b) Rs.8,067 Cr. (c) Rs.9,867 Cr. (d) Rs.11,867 Cr.
Q56. Under New Coal Distribution Policy (NCDP), Coal is sold by CIL through
(a) Fuel Supply Agreement (FSA) (b) Memorandum of Understanding (MoU)
(c) E-Auction (d) All of the above
Q57. Which of the following equipments are used in Longwall Mining ?
(a) Shearer (b) Road Header (c) Stage Loader-crusher (d) All of the above
Q58. Which of the following equipments are used with Continuous Miner ?
(a) Shuttle Cars (b) Twin/quad Bolter (c) Feeder Breaker (d) All of the above
Q59. Which of the following equipments are used for mine development for PSLW ?
(a) Continuous Miner only (b) Road Header only (c) Either (d) None
Q60. What are the benefits of Longwall Mining ?
(a) Higher Productivity (b) Higher Recovery of coal
(c) Safety & Reliability (d) All of the above
Q61. Shuttle Cars in UG is used for transportation of
(a) Coal (b) Manpower (c) Machine (d) All of the above
Q62. By which UG mining method, 75% coal recovery can be achieved ?
(a) Bord & Pillar (b) Continuous Miner (c) Longwall (d) None of the above
Q63. Which of the following is the most common cause of accidents in UG mines ?
(a) Roof & side fall (b) Explosion (c) Fire (d) Water inundation
Q64. What is the key driver for change in mining technology ?
(a) Improving Productivity (b) Quality Improvement
(c) Environmental Issues (d) All of the above
Q.65 Bucket Wheel Excavators in India are used for mining of..
(a) Coal (b) Lignite (c) Both (d) All of the above
Q66. What is the share of coal in primary energy consumption of India ?
(a) 52.40% (b) 62.40% (c) 72.40% (d) 82.40%
Q67. What will be gap between Demand & coal Production during 2011-12 ?
(a) 93.33MT (b) 75.33MT (c) 83.33MT (d) 65.33MT
Q68. How many coalfields in India are not currently under production ?
(a) 4 (b) 3 (c) 2 (d) 1
Q69. What will be demand of coal during 2011-12 ?
(a) 713.33MT (b) 680.33MT (c) 550.34MT (d) 100.34MT
Q70. What is the share of UG in total coal production of CIL ?
(a) 11% (b) 10% (c) 12% (d) 13%
Q71. What is the share of coking coal in total coal production of CIL ?
3
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
(SECTION-II : Common Coal Cadre, CDA Rules, Leave Rules, NCWA-VIII, HRA etc)
Q1. How many days of Special Leave is permissible as per CIL leave rules ?
(a) 2 months (b) 4 months (c) 6 months (d) 1 month
Q2. How many days of Casual Leave can be taken at a time ?
(a) 5 days (b) 7 days (c) 4 days (d) 8 days
Q3. How may days of Maternity Leave is admissible to the female executives ?
(a) 30 days (b) 60 days (c) 90 days (d) 180 days
Q4. How may days of Earned Leave is encashable at the time of retirement ?
(a) 240 days (b) 280 days (c) 300 days (d) None of the above
Q5. Special Disability Leave is granted for following reasons.
(a) Disease arising out of employment (b) General disease (c) Injury while on duty (d) a & c
Q6. How may days of special casual leave is granted for attending Seminar/conference by Union
representative ?
(a) 5 days (b) 8 days (c) 10 days (d) None
Q7. How may days of Transit Leave is granted in case of change of station from one place to another ?
(a) 8 days (b) 9 days (c) 6 days (d) None
Q8. Minimum year of service required for eligibility of Study Leave.
(a) 10 years (b) 5 years (c) 8 years (d) 2 years
Q9. Nurses are give allowances at the rate of..
(a) Rs.400/-pm (b) Rs.200/-pm (c) Rs.300/-pm (d) Rs.500/-pm
Q10. The following Discipline is a sensitive discipline as per transfer policy of CIL
(a) Security (b) Sales & Marketing (c) Both of the above (d) None of the above
Q11. As per transfer policy, the executive belonging to sensitive posts is to be transferred on
completion of..
(a) 2 years (b) 4 years (c) 3 years (d) 5 years
Q12. The period of salary revision in case of Executives is.
(a) 5 years (b) 10 years (c) 8 years (d) 4
Q13. The non-practicing allowance is given at .. of basic to Executives of Medical discipline.
(a) 20% (b) 17.5% (c) 30% (d) 10%
Q14. The anniversary date of increment in case of Executives is..
(a) Anniversary date of last promotion (b) 1st.September
st
(c) 1 .April (d) 1st.July
Q15. The normal period of completion of cadre in a particular grade is
(a) 5 years (b) 3 years (c) 7 years (d) 2 years
Q16. The EER of an Executive can be assessed by Reporting officer if the Executive has worked under
him for
(a) 3 months (b) 6 months (c) 4 months (d) 8 months
Q17. The notice period in case of resignation of an Executive is..
(a) 2 months (b) 1 month (c) 3 months (d) 4 months
Q18. If the date of birth of an Executive is 1st.January 1952,When will he superannuate ?
(a) 31st.Dec 2011 (b) 1st.Jan 2012 (c) 31st.Jan 2012 (d) 1st.Dec 2011
Q19. Which of the following clause of CDA Rule relates to outside influence?
(a) Clause 5.5 (b) Clause 5.7 (c) Clause 21 (d) Clause 10
Q20. The rate of subsistence allowance payable to an Executive for first 6 months is. of
basic.
(a) 75% (b) 25% (c) 50% (d) 100%
Q21. Which of the following is a minor penalty ?
(a) Withholding Increment (b) Lowering stage of pay (c) Suspension (d) Demotion
Q22. An Executive can file Appeal before the Appellate Authority within of receipt of order
5 Page
of penalty.
(a) 30 days (b) 15 days (c) 45 days (d) 7 days
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q23. In case of Non-executive the total leave encashable at the time of retirement is.
(a) 100 days (b) 120 days (c) 150 days (d) 140 days
Q24. Under the Life Cover Scheme, what amount is paid to the dependent of the deceased ?
(a) Rs.30,000/- (b) Rs.50,000/- (c) Rs.60,000/- (d) Rs.40,000/-
Q25. What is the eligibility criteria for payment of gratuity ?
(a) 5 years (b) 15 years (c) 10 years (d) 20 years
Q26. For how many workers canteen is to maintained under the Mines Act ?
(a) 500 (b) 300 (c) 250 (d) 350
Q27. What is the maximum limit of EL that can be encashed by an Executive in a calendar year ?
(a) 30 days (b) 90 days (c) 60 days (d) 45 days
Q28. What was the minimum wage per day of Daily Rated Employee under NCWA-VIII ?
(a) Rs.359.46 (b) Rs.369.47 (c) Rs.345.34 (d) 379.46
Q29. The Management Trainees are entitled for which of the following leaves ?
(a) EL, HPL & CL (b) CL & Sick Leave (c) EL & CL (d) CL
Q30. How much HRA is given to a Non-Executive under NCWA-VIII ?
(a) Rs.75/-pm (b) Rs.90/-pm (c) Rs.100/-pm (d) Rs.150/-pm
Q31. What is the rate of Transport Subsidy ?
(a) Rs.8.50/day (b) Rs.7.50/day (c) Rs.9.50/day (d) Rs.10.50/day
Q32. Under Reservation Policy, what is the reservation for OBC ?
(a) 27% (b) 22.50% (c) 15% (d) 7.50%
Q33. How many days of quarantine leave is granted?
(a) 28days (b) 20days (c) 14days (d) 7days
Q34. How many days of special leave can be granted to an Executive in his entire service period ?
(a) 2months (b) 4months (c) 6months (d) 8months
Q35. As per the Gratuity Act, the declaration of nominee is given in..form ?
(a) Form K (b) Form I (c) Form F (d) Form D
Q36. Fallback Wages are applicable to
(a) Daily Rated (b) Monthly Rated (c) Piece Rated (d) Contractual Workers
Q37. Under which circumstances, Ex-gratia is given ?
(a) Death due to illness (b) Accidental Death on Duty
(c) Normal death (d) All of the above
Q38. What is the maximum ceiling for payment of Gratuity ?
(a) Rs.10 lakh (b) Rs.5 lakh (c) Rs.3.5 lakh (d) Rs.7.5 lakh
Q39. What is PRP ?
(a) Performance Related Pay (b) Profit Related Perks
(c) Productivity Related Pay (d) Performance Related Payment
Q40. Which of the following are placed in E-1 Grade ?
(a) Management Trainees (b) Subordinate Engineers (c) Officers (d) All
Q41. From which date gratuity has been revised to Rs.10 lakhs ?
(a) 1st Jan.2007 (b) 1st July 2007 (c) 1st Jan.2009 (d) 1st July 2006
Q42. Recruitment in CIL is done by which of the following methods ?
(a) Campus selection (b) All India Written Test (c) Departmental Selection (d) All
Q43. What is EER ?
(a) Executive Evaluation Report (b) Executive Enquiry Report
(c) Enquiry Evaluation Report (d) Executive Establishment Report
Q44. Merit-cum-Seniority is a criteria used for in CIL
(a) Pay Fixation (b) Transfer (c) Promotion (d) All of the above
Q45. In case of death, the family of deceased Executive can retain companys quarter for.
6
Q46. An Executive working in Ranch (Y class City) will get HRA at the rate of of basic ?
(a) 10% (b) 25% (c) 30% (d) 20%
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q47. What does PBT stand for ?
(a) Production By Tax (b) Production Before Tax (c) Profit Before Tax (d) Profit By Tax
Q48. In Mining discipline, how much appointment is done through direct recruitment from outside ?
(a) 60% (b) 50% (c) 40% (d) 25%
Q49. What is the rate of payment of monetary compensation in case of Executives ?
(a) Rs.4,500/-pm (b) Rs.6,000/-pm (c) Rs.9,000/-pm (d) Rs.12,000/-pm
nd
Q50. If the date of birth of an Executive is 2 .August 1952, when will he superannuate ?
(a) 31st.August 2012 (b) 2nd.August 2012
st
(c) 1 .August 2012 (d) 31st.July 2012
Q51. Which of the following is considered for calculation of Gratuity ?
(a) Basic, DA, CFA (b) Basic, DA, NPA (c) Basic, DA (d) Basic
Q52. Which of the following is a Major Penalty ?
(a) Demotion (b) Suspension (c) Removal (d) All of the above
Q53. Who will be chargesheet issuing authority for General Manager(Excavation) for minor penalty?
(a) Chairman(CIL) (b) CMD (c) CVO (d) GM(P/EE)
Q54. The period for revision of pay for Executives is
(a) 5 yrs. (b) 10 yrs. (c) 6 yrs. (d) 4 yrs.
Q55.In case the delay in completing enquiry is due to the Executive concerned, his subsistence
allowance will be of basic?
(a) 25% (b) 50% (c) 75% (d) 100%
Q56. If an Executive avails CL, then his total absence from HQ should not exceed
(a) 8 days (b) 6 days (c) 10 days (d) 12 days
Q57. An Executive can apply for VRS if he has completed of service ?
(a) 10 years (b) 20 years (c) 15 years (d) 25 years
Q58. What is a PPO ?
(a) Pension Payment Order (b) Performance Pay Order
(c) Perks Pay Order (d) Production Purchase Order
Q59. Under CMPS 1998, Disablement Pension is payable at the rate of of last 10 months average
emoluments.
(a) 20% (b) 25% (c) 50% (d) 75%
Q60. The corpus of CMPS 1998 is.
(a) 2% of notional basic & DA (b) one additional increment
(c) 1.16% of CMPF & Govt. share (d) All
Q61. Name the statutory form for keeping details of employees under the Mines Act
(a) Form D (b) Form A (c) Form B (d) Form C
Q62.SLW is a term related to..
(a) Grant of promotion (b) Grant of one increment before retirement
(c) Transfer Grant of Employee (d) Grant of Stagnation Increment
Q63.What is the maximum number of HPL that can be encashed at the time of retirement?
(a) 180 days (b) 240 days (c) 300 days (d) 360 days
Q64. Which of the following is the beginning of Disciplinary Proceedings ?
(a) Receipt of Complaint (b) Start of Investigation
(c) Suspension (d) Contemplation of disciplinary action
Q65. An Executive can be dismissed from service by.
(a) CMD (b) Director(Personnel)/CIL (c) Chairman/CIL (d) CGM(Personnel)/CIL
Q66. What was the minimum guaranteed benefits under NCWA-VIII ?
(a) 24% (b) 20% (c) 30% (d) 35%
Q67. Which NCWA Agreement was of 4yrs & 6 months duration ?
(a) NCWA-VI (b) NCWA-I (c) NCWA-IV (d) NCWA-V
7
(a) Dy.GM (b) Chief Manager (c) Chief Medical Officer (d) All of the above
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q69. Executive Director (Medical) comes under which grade ?
(a) E-9 (b) E-8 (c) E-10 (d) E-7
Q70. Which is the highest grade in pay scales of Executives ?
(a) E-9 (b) E-8 (c) E-10 (d) E-7
...
A N S W E R
01(c), 02.(d), 03(d), 04(c), 05(d), 06(c), 07(c), 08(b), 09(b), 10(d), 11(c), 12(b), 13(b), 14(c), 15(b), 16(c),
17(c), 18(a), 19(c), 20(c), 21(a), 22(c), 23(d), 24(c), 25(a), 26(c), 27(c), 28(a), 29(b), 30(d), 31(b), 32(a),
33(b), 34(c), 35(c), 36(c), 37(b), 38(a), 39(a), 40(d), 41(a), 42d), 43(a), 44(c), 45(c), 46(d), 47(c), 48(a),
49(c), 50(a), 51(b), 52(d), 53(b), 54(b), 55(a), 56(c), 57(b), 58(a), 59(b), 60(d), 61(c), 62(b), 63(c), 64(d),
65(c), 66(a), 67(c), 68(d), 69(b), 70(a)
....
(SECTION-III : Coal Industry in India A retrospect, Nationalisation of Coal Mines)
Q14.What was coal production at the beginning of Ist 5 Year Plan (1951-56) ?
Page
Ans. 33 Mt.
Q15.What was coal production at the end of 2nd. 5 year Plan (1956-61) & 3rd. 5 year Plan (1961-66) ?
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Ans.Total : 55.6 MT, NCDC 8.05 MT (1956-56) and Total : 67.72 MT, NCDC : 9.6 MT (1961-66).
Q16.What role did NCDC play in Indian Coal Industry ?
Ans.NCDC Played pioneering role in Indian Coal Industry by way of introduction of
a.Large Scale Mechanisation b. Use of Modern Scientific Technique.
c. Conservation of Coal d. Foreign Collaboration with Poland & USSR.
e. Opening new Mines in MP, Orissan & Maharasthra
Q17.When was Coal Industry nationalised and why ?
Ans During IVth 5 Yr. Plan (1969-74) Coal Industry was nationalised in 2 phases :-
a.) Management of Coking Coal Mines was taken over by Govt. of India on 17th Oct. 1971 &nationalisation
was effective from 5th January, 1972. Bharat Coking Coal Limited was formed by virtue of Coking Coal
Mines (Emergency provisions at 1971 and Coking Coal Mines (Nationalisation) Act 1972. This Act gives
eligibility of Coal Mining in India.
.
(SECTION-IV : Categorisation of Coal, UHV, GCV,Grades of Coal etc.)
(a) It has long flame on burning (b) It has bright flame on burning (c) It gives more heat
(b) (d) It has more volatile matter
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q12.The permissible limit of ash in washed coal as per MoEF guidelines is
(a) Less than or equal to 34% (b) Less than 38% (c) Less than 40% (d) Less than 45%
Q13.The ash content(%age) is .................... in higher quality coal.
(a) more (b) less (c) constant (d) variable
Q14.What is the unit in which heat value of coal is expressed ?
(a) K,Cal/Kg (b) Cal/Kg (c) Kcal/te (d) Cal/te
Q15.What is a Bomb Calorimeter?
(a) An instrument to detect a bomb
(b) An instrument to measure heat value
(c) A musical instrument
(d) A gas instrument
...
A N S W E R
01(a), 02.(c), 03(c), 04(b), 05(b), 06(a), 07(c), 08(a), 09(a), 10(c), 11(d), 12(a), 13(b), 14(a), 15(b).
..
(SECTION-V : Mining Technology OC & UG, Mining Methods, Mining Machinery-OC & UG)
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q14. In which state small deposits of Anthracite coal is found?
(a) J&K (b) Tamil Nadu (c) Assam (d) Gujarat
Q15. Which of the indigenous firm manufacture SDL & LHD in India?
(a) Joy Mining Machinery Co (b) Atlas Copeo
(c) Eimco Elecon (d) Tractors India Ltd
Q16. Road Header is used to drive ..
(a) Single heading (b) Double heading (c) Triple heading (d) Multiple heading
Q17. A building where explosives & detonators are stored is called
(a) Sheller (b) Magazine (c) Store (d) House
Q18. Which is best quality coking coal ?
(a) Steel grade I (b) Steel grade II (c) Washery grade I (d) Washery grade IV
Q19. Which is the best quality Non-cocking coal ?
(a) G (b) D (c) C (d) A
Q.20 What is true about Universal Drilling Machine (UDM) ?
(a) It is crawler mounted (b) It can drill in any direction
(c) It can drill blast holes (d) All of the above
Q21. UDM can drill in which of the following direction?
(a) Horizontal (b) Vertical (c) Inclined (d) All directions
Q22. Which is a mine transport system
(a) Rope Haulage (b) Locomotive Haulage (c) Shuttle Car (d) All of above
Q23. What is EMP ?
(a) Environment Management Plan (b) Environment Management Project
(c) Environment Management Programme (d) Environment Mine Plan
Q24. Coke can not be made from ...
(a) Lignite (b) Anthracite Coal (c) Sub-bituminous Coal (d) All
Q25. What are the products of a coal washing ?
(a) Washed Coal (b) Middling (c) Rejects (d) All
Q26. Which of the following is not correct for Anthracite coal?
(a) Small deposits in India is found in J&K (b) It is best quality coal
(c) Best coke can be made from this coal (d) All of the above
Q27. What is correct about Bituminous coal?
(a) Coke can be made from this coal (b) It can be used as domestic fuel
(c) It can be used in thermal power plant (d) All of the above
Q28. Ultimate Analysis of coal gives percentage of present in coal.
(a) Carbon (b) Hydrogen (c) Sulphur (d) All of the above
Q29. Proximate Analysis of coal gives percentage (by weight of) present in coal.
(a) Ash (b) Volatile Matter (c) Fixed Carbon (d) All of the above
Q30. Name the type of coke manufactured by heating coking coal at 650 degree Celsius temperature
in absence of oxygen ?
(a) Soft Coke (b) LTC Coke/CIL Coke (c) Both (d) Hard Coke
Q31. Which of the following gases are common in Under Ground Mines ?
(a) Oxygen (b) Hydrogen (c) Carbon Dioxide (d) All of the above
Q32. What is the common name for Methane in Under Ground Coal Mines ?
(a) Firedamp (b) Stinkdamp (c) Blackdamp (d) Whitedamp
Q33.In which mine was fully mechanized Longwall Face with Powered Support was first introduced
in India ?
(a) Moonidih (BCCL) (b) Dhemo Main Colliery (ECL)
(c) Pathakhera No.2 (WCL) (d) Ramagundam GDK (SCCL)
Q34. Hard Coke is made by heating coking coal at .. Celsius temperature in absence of
11
oxygen ?
Page
(a) 500 degree C (b) 100 degree C (c) 650 degree C (d) 1,000 1,100 degreeC
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q35. Shortwall Mining is a variant of
(a) Bord & Pillar (b) Longwall (c) Both of the above (d) None of the above
ANSWER
1(c), 2(a), 3(a), 4(c), 5(b), 6(c), 7(a), 8(c), 9(c), 10(d), 11(d), 12(c), 13(c), 14(a), 15(c), 16(a), 17(b), 18(a),
19(d), 20(d), 21(d), 22(d), 23(a), 24(d), 25(d), 26(c), 27(d), 28(d), 29(d), 30(c), 31(d), 32(a), 33(a), 34(d),
35(c).
..
(SECTION-VI : Basic Computer Skills, MS Office, Uses of Internet, E-Mail, Fax etc.)
(a) Transmission rate (b) Modem speed (c) Data Speed (d) Data rate
Page
(a) Password (b) Virus software (c) Anti virus software (d) User software
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q62. The replacement for MS DOS from Microsoft Corporation is. .
(a) XENIX OS (b) LINUX (c) UNIX OS (d) MS WINDOWS
Q63. System commands are commands by which..
(a)Computers communicate
(b)Programmers communicate with OS of the computer
(c)The Operators enter date
(d)Programmers create alternative solutions.
Q64. A language used directly by the computer is....
(a) English language (b) High level language (c) Machine language (d) Low level language
Q65. A 8 bit unit is called a
(a) Data set (b) Byte (c) KB (d) MB
Q66. A Memory chip that is programmed at the time of its manufacture is known as
(a) RAM Chip (b) Microprocessor chip (c) Dynamic RAM chip (d) ROM Chip
Q67. Which one of the following is an Optical Storage disk ?
(a) Floppy disk (b) Hard disk (c) CD-ROM (d) None of the above
Q68. The cheapest & fastest mode of sending written communication to any part of the world
is
(a) Telex (b) E-mail (c) Fax (d) None of the above
Q69. WWW stands for
(a) World Wild Web (b) World Write Web (c) Word Wide Web (d) World Wide Web
Q70. E-mail stands for
(a) Economic Mail (b) Electronic Mail (c) Electrical Mail (d) None
Q71. The device which allows a computer to transmit and receive information over the telephone line
is ..
(a) Modem (b) Trans-receiver (c) Transmitter (d) Wireless
Q72. The Internet connection can be established with ...
(a)Computer system only
(b)Computer system + Modem
(c)Computer System + Modem + Telephone line
(d)Computer System + Modem+Telephone line + Software for Internet access
Q73. Which one of the following is correct E-mail address?
(a) abc@ntw.org (b)@abc,ntw.org. (c) ntw.org.abc (d)abc.ntw.org@
Q74. A system that lets computers all over the world talk to each other is called
(a) Internet (b) LAN (c) TAN (d) WAN
Q75. Modem stands for ..
(a) Modulation device (b) Moderator device
(c) Modulation-Demodulation device (d) Demodulation device
Q76. Local Area Networks are communication systems that are used to link
(a) terminals, computes & other devices located within a compact area
(b) terminals, computers and other devices located across many cities
(c) Both of the above (d) None of the above
Q77. A interconnection of computer systems and/or peripheral devices at dispersed locations that
exchange data is called..
(a) Data communication (b) Data storing (c) Telephone exchange (d) Network
Q78. A general term to describe the transmission of messages by the use of computer system &
telecommunications facilities is known as
(a) Mail transfer (b) Electronic Mail Transfer (c) Message Transmission (d) Message Delivery
Q79. A device responsible for allowing a communication between a group of Personal Computers to
each other is called
15
(a) USB Device (b) Data Card (c) Network Interface Card (d) Device Card
Page
Q80. A modem card that plugs into a slot inside the computer is called..
(a) Internal modem (b) External modem (c) USB Modem (d) None of the above
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q81. Multimedia is .
(a) An integration of voice & text
(b) An integration of voice, text and graphics
(c)An integration of voice, text, graphics & animation
(d) an integration of graphics and text
Q82. DTP stands for ...
(a) Disk Top Publishing (b) Desk Top Printing (c) Desk Top Publisher (d) Desk Top Printer
Q.83. Advice used to produce humanly readable computer output is called as
(a) Hard Disk (b) Printer (c) Floppy Disk (d) computer paper
Q84. A scanner is.
(a) An optical device
(b) An optical device which works like a photocopier
(c) An optical device used for cutting & pasting images
(d) An optical device used to digitize images and store it on a disk
Q85. A device which provides a good surge suppresser and adds features such as battery backup and
power conditioning is called..
(a) SMPS (b) Inverter (c) Rectifier (d) UPS
Q86. The facts and figures that are currently being used for decision making is called
(a) Data (b) Information (c) MIS (d) Figures
Q87. PPM stands for .
(a) Page Policy Matter (b) Page per Minute (c) Page Paper Minute (d) None
Q88. A file with extension .doc represents a ..
(a) Spreadsheet file (b) Graphic file (c) Document file (d) Power Point file
Q89. All executable files in DOS should have as file extension.
(a) .bat (b) .exe (c) .com (d) .sys
Q90. What does http written with website address stand for ?
(a) hyper text transfer protocol (b) high text transmission protocol
(c) hyper text transfer pact (d) high text transmission programme
...
A N S W E R
01(b), 02(a), 03(d), 04(d), 05(c), 06(c), 07(a), 08(c), 09(c), 10(b), 11(c), 12(a), 13(d), 14(a), 15(c), 16(c),
17(b), 18(a), 19(c), 20(a), 21(b), 22(d), 23(a), 24(a), 25(a), 26(c), 27(b), 28(b), 29(d), 30(b), 31(d), 32(c),
33(a), 34(a), 35(d), 36(b), 37(a), 38(d), 39(c), 40(a), 41(b), 42(b), 43(b), 44(a), 45(b), 46(b), 47(a), 48(b),
49(a), 50(b), 51(d), 52(a), 53(c), 54(b), 55(a), 56(c), 57(b), 58(a), 59(d), 60(c), 61(a), 62(d), 63(b), 64(c),
65(b), 66(d), 67(c), 68(b), 69(d), 70(b), 71(a), 72(d), 73(a), 74(a), 75(c), 76(a), 77(d), 78(b), 79(c), 80(a),
81(c), 82(c), 83(b), 84(d), 85(d), 86(a), 87(b), 88(c), 89(b), 90(a).
....
(SECTION-VII : PERSONNEL/HR : Working Conditions, Human Relations & Trade Unions)
Q1. According to the revised and amended Indian Factories Act, the hours of work including overtime
shall not exceed more than .. hours per week
(a) 48 (b) 56 (c) 60 (d) 72
Q2. The Indian Factories Act prescribes that a woman worker can work in a factory between.
(a) 6 A.M. and 6 P.M. (b) 7 A.M. and 6 P.M. (c) 6 A.M. and 7 P.M. (d) 7 A.M. and 7P.M.
Q3. The Indian Factories Act prohibits a child worker to work for more than hours per day
(a) 6 (b) 6 (c) 5 (d) 4
Q4. The Factories Act is normally applicable to any establishment wherein .. or more workers
are employed and wherein a manufacturing process is carried on with the aid of power.
(a) 10 (b) 15 (c) 20 (d) 25
16
Q5. According to the Factories Act, factories employing or more workers have to appoint
2 Page
Q19. The Industrial Employment [Standing Orders] Act is applicable to industrial establishments
where in or more workers are employed.
(a) 25 (b) 50 (c) 100 (d) 150
Q20. Ordinarily, the limit prescribed for deduction from wages of a person under the Payment of
Wages Act, in a wage period is . Percent of wages.
(a) 20 (b) 40 (c) 50 (d) 60
Q21. Which one of the following is not among the main provisions of the Payment of Wages Act ?
(a) Fixation of wage periods
(b) Deductions which can be made from wages
(c) Dependents benefits
(d) Time of payment of wages
17
Q22. According to the Payment of Wages Act, a discharged worker must be paid before the expiry of
Page
Q38. Which one of the following statements relating to the Employees Deposit Linked Insurance
Scheme is wrong ?
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
(a) The employee has to make a contribution to this scheme.
(b) The scheme is applicable in the event of death of the employee
(c) The scheme came into force on 1st August 1976
(d) The scheme provides for payment of an additional amount.
Q39. What is the minimum number of members required to form a trade union ?
(a) 2 (b) 5 (c) 7 (d) 11
Q40. The Trade Union Act 1926 requires that at least of the total number of office
bearers of a Registered Trade Union must be persons actually engaged in the Industry to which
the union belongs.
(a) one third (b) one fourth (c) half (d) full
....
AN S W E R
01(c), 02(c), 03(d), 04(a), 05(b), 06(c), 07(a), 08(b), 09(c), 10(d), 11(c), 12(d), 13(a), 14(a), 15(a), 16(d),
17(c), 18(d), 19(c), 20(c), 21(c), 22(b), 23(a), 24(b), 25(c), 26(c), 27(a), 28(c), 29(d), 30(c), 31(d), 32(b),
33(b), 34(d), 35(c), 36(c), 37(b), 38(a), 39(c), 40(c).
....
(SECTION-VIII : Right to Information Act 2005)
Q1. Under RTI, information who be can sought from.
(a) Private authority (b) Public authority (c) Both (a) and (b) (d) none of the above
Q2. Under RTI, who can get information?
(a) Indian citizens (b) Foreigners
(c) Both (a) and(b) (d) none of the above
Q3. Information includes
(a) records, documents, menus (b) e-mails, logbooks (c) samples, models (d) all of the above
Q4. Right to Information includes ..
(a) documents, records etc. (b) inspection of work (c) taking samples of materials (d) all of the above
Q5. Information can be sought in which of the following form?
(a) print outs/photo copies (b) diskettes and floppies (c) video cassettes (d) all the above
Q6. RTI Act gives right to information to
(a) corporations (b) associations (c) companies (d) individuals
Q7. Which section of RTI deals with exemption from disclosure of information?
(a) Section 8(1) (b) Section 10(1) (c) Section 11(1) (d) Section 12(1)
Q8. Information exempted from disclosure ceases to be exempted after lapse of years.
(a) 10 years (b) 15 years (c) 20 years (d) 25 years
Q9. For seeking information under RTI, a fee of Rs. .. is required to be deposited.
(a) Rs. 15 (b) Rs. 10 (c) Rs. 5 (d) Rs. 20
Q10. RTI fee can be deposited in the form of ..
(a) Cash (b) Postal Order (c) Demand Draft (d) All of the above
Q11. How much charge is applicable for getting print out/photocopy of documents (A-4 size) ?
(a) Rs.1/- per page (b) Rs.1.50/- per page (c) Rs.2.0/- per page (d) Rs.2.50/ per page
Q12. Which of the following statement about RTI is incorrect?
(a) No reason is required for getting information. (b) No prescribed format for getting information.
(c) No justification is required. (d) None of the above.
Q13. RTI fee of Rs. 10 is exempted for
(a) SC/ST (b) BPL (c) Poor (d) All of the above
Q14. Under RTI CPIO has to provide information within . days of receipt of application.
(a) 10 days (b) 20 days (c) 30 days (d) 25 days
Q15. In case of life or liberty of a person, information shall be provided within .. of the
19
receipt of request.
(a) 24 hours (b) 48 hours (c) 36 hours (d) 72 hours
Page
Q16. If a person is not satisfied with the order of Appellate authority, he can seek second appeal
with
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
(a) CPIO (b) Appellate authority (c) CIC (d) none of the above
Q17. How much penalty can be imposed on CPIO by CIC for delay in supply of information?
(a)Rs.100/- per day (b) Rs.200/- per day (c) Rs.250/- per day (d) Rs.300/- per day
Q18. What is the maximum amount of penalty that can be imposed on CPI0?
(a)Rs.20,000 (b) Rs.25,000 (c) Rs.30,000 (d) Rs.50,000
Q19. A person not satisfied with CIC order can appeal in
(a)Supreme Court (b) High Court (c) Lower Court (d) None of the above
Q20. Office of Central Vigilance Commission is located at ..
(a)Kolkata (b) New Delhi (c) Chennai (d) Mumbai
Q21. When was the RTI Act enacted?
(a) June 2005 (b) June 2004 (c) June 2006 (d) June 2003
Q22. The RTI Act is applicable to whole of India except the state of
(a) Sikkim (b) Jammu & Kashmir (c) Goa (d) Andaman & Nicobar islands
Q23. What is CPIO?
(a) Central Public Indian Officer (b) Central Private Indian Officer
(c) Central Public Information Officer (d) Central Public India Office
Q24. Who appoints Chief Information Commissioner?
(a) President (b) Prime Minister (c) Supreme Court (d) Parliament
25. What does CIC mean?
(a) Central Information Commission (b) Chief Information Commissioner
(c) Both (a) and (b) (d) None of the above
Q26. Appeal to Appellate Authority can be made within days from the date of receipt of
reply from CPIO?
(a) 15 days (b) 20 days (c) 45 days (d) 30 days
Q27. A second appeal can be made within . days of receipt of order from
Appellate Authority?
(a) 90 days (b) 45 days (c) 30 days (d) 60 days
Q28. The decision of CIC can be challenged in .
(a) Supreme Court (b) High Court (c) International Court of Justice (d) None of the above
Q29. On which organizations RTI Act is not applicable?
(a) Intelligence (b) Security (c) Both (a) and (b) (d) None of the above
Q30. The list of Intelligence and Security organization exempted from RTI Act 2005 is given in
schedule of the Act.
(a) First (b) Second (c) Third (d) Fourth
....
ANSWER
01(b), 02(a), 03(d), 04(d), 05(d), 06(d), 07(a), 08(c), 09(b), 10(d), 11(c), 12(d), 13(b), 14(c), 15(b), 16(c),
17(c), 18(b), 19(d), 20(b), 21(a), 22(b), 23(c), 24(a), 25(c), 26(d), 27(a), 28(d), 29(c), 30(b).
....
(SEXCTION-IX : Revision Questions)
(a)Raw & washed coal (b) soft & hard coke (c) coal gas (d) all of the above
Page
....
AN S W E R
01(d), 02(d), 03(c), 04(d), 05(d), 06(a), 07(c), 08(d), 09(b), 10(c), 11(a), 12(b), 13(a), 14(c), 15(b), 16(a),
17(a), 18(d), 19(a), 20(b), 21(c), 22(a), 23(a), 24(c), 25(d), 26(b), 27(a), 28(b), 29(b), 30(a), 31(d), 32(a),
33(c), 34(c), 35(b), 36(a), 37(b), 38(d), 39(c), 40(c), 41(a), 42(b), 43(c).
....
(SECTION-X : Reference Material Useful for CIL Interview & CIL Deptt Exams)
Q-57. How many Non-Coking Coal Washeries are operational in CIL as on 31-03-2010 ?
(A) 6 (B) 5 (C) 7 (D) 8
Page
Q-83. The major restructuring of CIL is proposed during which Five Year Plan ?
(A) 11th.Plan (B) 12th.Plan (C) 13th.Plan (D) 14th.Plan
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q-84. Which project in NCL has produced highest coal in 2010-11 ?
(A) Jayant (B) Dudhichua (C) Nigahi (D) Amlohri
Q-85. Which Co. has highest ranking among the Indian Co. in Fortune 500 Global List 2010 ?
(A) RIL (B) HPCL (C) ONGC (D) IOC
Q-86. Non-Coking Coal is commonly known as. ?
(A) Steam Coal (B) Thermal Coal (C) Both (D) None
Q-87. What does OHSAS stand for ?
(A) Occupational Health & Safety Assurance System (B) Occupational Health & Safety System
(C) Occupational Health & Safety Assessment System (D) Occupational Health & Safety Assessment Series
Q-88. What is ISO 14001 ?
(A) QMS (B) EMS (C) OH&S (D) SA
Q-89. After proposed expansion, which will be the largest coal mine of CIL ?
(A) Dipika (B) Gevra (C) Talabira (D) Rajmahal
Q-90. What is IBS ?
(A) Integrated Business Solution (B) Information Business System
(C) Indian Business System (D) International Business System
Q-91. What is PRP ?
(A) Productivity Related Pay (B) Production Related Pay
(C) Pay Related Payment (D) Performance Related Pay
Q-92. What will be coal demand during 2011-12 ?
(A) 713mt (B) 712mt (C) 711mt (D) 710mt
Q-93. What is the expected coal import of India during 2011-12 ?
(A) 83mt (B) 82mt (C) 81mt (D) 80mt
Q-94. What is the expected coal production of India during 2011-12 ?
(A) 630mt (B) 650mt (C) 700mt (D) 680mt
Q-95. Dankuni Coal Complex has been placed under the administrative control of ..
(A) SECL (B) ECL (C) CIL (D) NEC
Q-96. What is the remarkable characteristics of Tertiary Coal ?
(A) High Moisture (B) High Ash (C) High Sulphur (D) All
Q-97. What is special about Imported Non-Coking Coal ?
(A) High Calorific Value (B) Low Ash (C) Both (D) None
Q-98. Which is the only coalfield in India which is spread in 2 states & 2 subsidiary Co. of CIL ?
(A) Central India Coalfields (B) Rajmahal (C) Singrauli (D) Raniganj
Q-99. What is the thickness of Jhingurdah Seam of NCL ?
(A) 130-138m (B) 20m (C) 12m (D) 8m
Q-100. How many coal seams are found in moher basin of Singrauli coalfields ?
(A) 1 (B) 2 (C) 3 (D) 4
Q-101. In which state of India Tertiary coal is found?
(A) Meghalaya (B) Mizoram (C) Nagaland (D) All
Q-102. In which Indian state both Gondwana & Tertiary coal are found?
(A) Meghalaya (B) Assam (C) Nagaland (D) All
Q-103. When did Coal India get Mini-Ratna status?
(A) 2007 (B) 2006 (C) 2005 (D) 2004
Q-104. When did Coal India get Nav-Ratna status?
(A) 2007 (B) 2008 (C) 2006 (D) 2005
Q-105. What was the total coal production of World in 2009 ?
(A) 4,000 mt (B) 5,000 mt (C) 5,990 mt (D) 5,500 mt
Q-106. Which is the largest coal importer country in the world?
(A) Japan (B) Indonesia (C) China (D) India
26
Page
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q-108. How many coal washeries are presently operational in CIL?
(A) 16 (B)17 (C) 15 (D) 14
Q-109. What is the contribution of Open Cast in Coal Production of India?
(A) 88% (B) 80% (C) 85 % (D) 75%
Q-110. Name the only company in the world which has applied for 4 certifications (ISO-9001, ISO-
14001, OHSAS-18001 & SA-8000) under IMS?
(A) Rio-Tinto (B) SCCL (C) CIL (D) NCL
Q-111. What is the coal production target of CIL for 2011-12?
(A) 435 mt (B) 460 mt (C) 452 mt (D) 520 mt
Q-112. Which country in the world has highest reserves of Coal and Lignite?
(A) USA (B) China (C) India (D) Australia
Q-113. What is the total coal & lignite reserve in the world by the end of 2008?
(A) 800 bt (B) 984 bt (C) 850 bt (D) 900 bt
Q-114. In how many states of India coal reserves is found?
(A) 11 (B) 10 (C) 8 (D) 14
Q-115. The estimated coal reserve of India is enough to last for over_____ yrs?
(A) 200 yrs (B) 208 yrs (C) 150 yrs (D) 100 yrs
Q-116. What is the market share of CIL in Indian coal production?
(A) 82% (B) 80% (C) 75% (D) 70%
Q-117. How many CPSUs were operational as on 31st.March 2009?
(A) 252 (B) 235 (C) 246 (D) 310
Q-118. Name the foreign subsidiary of CIL.
(A) Coal Videsh Ltd (B) Coal India Africana Limitada (C) CIL Videsh Ltd (D) CIL Mozambique Ltd
Q-119. When did CIL get SCOPE Excellence Award?
(A) 2006 (B) 2007 (C) 2008 (D) 2009
Q-120. What is the contribution of UG mines in CIL coal production?
(A) 10% (B) 9% (C) 8% (D) 7%
Q-121. What is the contribution of OC mines in CIL coal production?
(A) 88% (B) 89% (C) 90% (D) 91%
Q-122. How much coal is supplied to Power Utilities by CIL?
(A) 65% (B) 72% (C) 70% (D) 75%
Q-123. What were the Gross Sales of CIL during 2009-10?
(A) Rs.50,000 Cr. (B) Rs.52,000 Cr. (C) Rs.51,000 Cr. (D) Rs.53,000 Cr.
Q-124. How much coal was E-marketed by CIL during 2009-10?
(A) 43 mt (B) 41 mt (C) 42 mt (D) 44 mt
Q-125. Which subsidiary of CIL has gained highest in terms of %age through E-marketing of coal
during 2009-10?
(A) SECL (B) NCL (C) CCL (D) MCL
Q-126. How much Profit (before tax & dividend) did CIL post in 2009-10?
(A) Rs.8,000 Cr. (B) Rs.10,000 Cr. (C) Rs.11,000 Cr. (D) Rs.12,400 Cr.
Q-127. What is the Profit after tax of CIL in 2009-10?
(A) Rs.9,000 Cr. (B) Rs.10,000 Cr. (C) Rs.8,300 Cr. (D) Rs.8,000 Cr.
Q-128. What is the paid up equity of CIL?
(A) Rs.6,300 Cr. (B) Rs.6,000 Cr. (C) Rs.6,200 Cr. (D) Rs.6,400 Cr.
Q-129. CIL has paid the highest ever dividend of Rs.________ during 2009-10?
(A) Rs.2,000 Cr. (B) Rs.2,200 Cr. (C) Rs.2,100 Cr. (D) Rs.2,300 Cr.
Q-130. Which country has highest Reserve to Production(R/P) ratio for Coal?
(A) Australia (B) China (C) India (D) USA
27
Q-157. How much electricity was generated by coal/lignite in India during 2009-10 ?
Page
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q-158. What is the present share of UG production in India ?
(A) 12% (B) 5% (C) 10% (D) 20%
Q-159. How many CPSUs are in Fortune 500 global companies list 2010 ?
(A) 1 (B) 2 (C) 3 (D) 4
Q-160. In India LIGNITE reserves are found in_______________ states ?
(A) GUJARAT (B) TAMIL NADU (C) RAJASTHAN (D) All of the Above
Q-161. Which mining company has not been awarded Mini-Ratna status ?
(A) CMPDIL (B) CCL (C) NLC (D) SCCL
Q-162. Name the International Standard issued by ISO for Quality Management System (QMS) ?
(A) ISO 9000 (B) ISO 9001 (C) ISO 9002 (D) ISO 9003
Q-163. Which is the oldest Coalfield in India ?
(A) JHARIA (B) RANIGANJ (C) BOKARO (D) RAJMAHAL
Q-164. Which subsidiary of CIL has posted the highest Profit during 2009-10 ?
(A) SECL (B) MCL (C) NCL (D) WCL
Q-165. In India, the share in production of coal through which mining system is declining ?
(A) OPENCAST (B) UNDERGROUND (C) OC & UG (D) NONE
Q-166. The Captive Mining of Coal was first allowed in India in________ .
(A) 2000 (B) 1976 (C) 2002 (D) 1990
Q-167. Which company in private sector produces highest coal in India ?
(A) Tata Steel (TISCO) (B) BECML (C) JSPL (D) MIL
Q-168. The Coking Coal Reserves in India is____% of total geological reserves ?
(A) 10% (B) 18% (C) 5% (D) 25%
Q-169. Which major coalfield in India has highest coal reserves ?
(A) TALCHER (B) RANIGANJ (C) JHARIA (D) IB-VALLEY
Q-170. Which grades of coal is abundantly found in India ?
(A) A & B (B) C (C) D (D) E, F & G
Q-171. Which company is the largest corporate employer in India ?
(A) COAL INDIA (B) RELIANCE (C) TATA (D) BIRLA
Q-172. How much disinvestment of CIL was done in October 2010 through IPO ?
(A) 20% (B) 15% (C) 5% (D) 10%
Q-173. Which is directly under the administrative control of CIL ?
(A) NEC (B) SCCL (C) NLC (D) DCC
Q-174. All Coal Washeries of CIL are placed under the control of _____ ?
(A) Director(F) (B) Director(Mrkt) (C) Director(Tech) (D) Director(Pers)
Q-175. Who looks after the work of COAL VIDESH at CIL ?
(A) Director(F) (B) Director(Mrkt) (C) Director(Tech) (D) Director(Pers)
Q-176. Which is the largest coal producing company in the world ?
(A) BHP-Billiton (B) Coal India (C) Rio-Tinto (D) Arcelor-Mittal
Q-177. The Exploration of Coal is being done by___________.
(A) CMPDIL (B) MECL (C) GSI (D) All of the above
Q-178. The Proven Coal reserves of India as on 01.04.2010 is_________.
(A) 110 bt (B) 100 bt (C) 96 bt (D) 90 bt
Q-179. The IB Valley coalfield is situated in which subsidiary of CIL ?
(A) SECL (B) WCL (C) MCL (D) NEC
Q-180. Which subsidiary of CIL has posted loss in 2009-10?
(A) BCCL (B) ECL (C) Both (D) None
Q-181. How much electricity in the world is generated by coal?
(A) 40% (B) 41% (C) 42% (D) 43%
29
Q-182. Which country in the world produces 93% of electricity from coal?
(A) Poland (B) China (C) Australia (D) South Africa
Page
Q-183. Which subsidiary of CIL has E-marketed highest coal during 2009-10?
(A) MCL (B) SECL (C) CCL (D) WCL
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in
www.MINEPORTAL.in Call/Whatsapp-8804777500 www.fb.com/mineportal.in
QUESTION BANK
Q-184. How much coal was imported by India during 2009-10?
(A) 30 mt (B) 40 mt (C) 68 mt (D) 50 mt
Q-185. Which Subsidiary Company of CIL has the highest Manpower?
(A) ECL (B) BCCL (C) SECL (D) CCL
Q-186. Which Subsidiary of CIL has the highest number of Executives?
(A) ECL (B) BCCL (C) SECL (D) CCL
Q-187. When do we celebrate Coal India Foundation Day?
(A) 1st October (B) 1st November (C) 1st December (D) 1st October
Q-188. Coal India Limited has been awarded which status ?
(A) Mini-Ratna (B) Nav Ratna (C) Maha-Ratna (D) All
Q-189. How much Non-Coking Coal reserves are present in India ?
(A) 82% (B) 90% (C) 95% (D) 85%
Q-190. Which of the following PSUs has got Maha-Ratna status in 2010?
(A) SAIL & CIL (B) IOC & ONGC (C) NTPC (D) All
Q-191. When did CMPDIL get Mini-Ratna Cat-II status ?
(A) 2007 (B) 2009 (C) 2008 (D) 2010
Q-192. How much coal was exported by India in 2008-09 ?
(A) 2 mt (B) 1 mt (C) 3 mt (D) 0 mt
Q-193. How much lignite was produced in India during 2009-10 ?
(A) 34 mt (B) 33 mt (C) 32 mt (D) 35 mt
Q-194. Which subsidiary of CIL has achieved zero accident during Jan-Mar 2010 ?
(A) ECL (B) BCCL (C) MCL (D) NCL
Q-195. Which state in India has highest reserve of Tertiary coal ?
(A) Assam (B) Arunachal Pradesh (C) Nagaland (D) Meghalaya
Q-196. Which state in India has largest reserve of Gondwana coal ?
(A) West Bengal (B) Chhattisgarh (C) Jharkhand (D) Orissa
Q-197. CIL operates in how many state of India ?
(A) 7 (B) 8 (C) 6 (D) 5
Q-198. How much financial power is granted to Mini-Ratna Category-II companies ?
(A) Rs.1,000 Cr. (B) Rs.400 Cr. (C) Rs.500 Cr. (D) Rs.300 Cr.
Q-199. What is the overall OMS of CIL in 2009-10 ?
(A) 4.08 (B) 5.08 (C) 6.08 (D) 7.08
Q-200. When did CIL get Maha-ratna status ?
(A) 2008 (B) 2009 (C) 2010 (D) 2011
....,
ANSWERS
1(A), 02(B), 03(B), 04(B), 05(D), 06(A), 07(C), 08(D), 09(B), 10(A), 11(B), 12(A), 13(B), 14(A), 15(D), 16(A),
17(B), 18(A), 19(B), 20(A), 21(C), 22(A), 23(D), 24(B), 25(A), 26(B), 27(A), 28(D), 29(A), 30(A), 31(D), 32(A),
33(C), 34(C), 35(A), 36(A), 37(C), 38(D), 39(C), 40(A), 41(D), 42(A), 43(C), 44(D), 45(D), 46(A), 47(B), 48(C),
49(D), 50(B), 51(D), 52(B), 53(D), 54(A), 55(C), 56(C), 57(B), 58(D), 59(A), 60(B), 61(C), 62(D), 63(B), 64(C),
65(B), 66(A), 67(A), 68(C), 69(C), 70(A), 71(C), 72(B), 73(A), 74(C), 75(A), 76(C), 77(D), 78(D), 79(D), 80(B),
81(A), 82(A), 83(B), 84(A), 85(D), 86(C), 87(C), 88(B), 89(B), 90(A), 91(D), 92(A), 93(A), 94(A), 95(A), 96(C),
97(C), 98(D), 99(A), 100(D), 101(D), 102(B), 103(A), 104(B), 105(C), 106(A), 107(A), 108(B), 109(A), 110(D),
111(C), 112(A), 113(B), 114(D), 115(B), 116(A), 117(C), 118(B), 119(D), 120(A), 121(C), 122(B), 123(B), 124(A),
125(B), 126(D), 127(C), 128(A), 129(B), 130(D), 131(A), 132(B), 133(A), 134(B), 135(C), 136(A), 137(C), 138(A),
139(D), 140(A), 141(C), 142(D), 143(A), 144(C), 145(D), 146(A), 147(D), 148(D), 149(A), 150(B), 151(D), 152(C),
153(D), 154(C), 155(A), 156(A), 157(D), 158(A), 159(D), 160(D), 161(D), 162(B), 163(B), 164(C), 165(B), 166(B),
167(A), 168(B), 169(A), 170(D), 171(A), 172(D), 173(A), 174(B), 175(C), 176(B), 177(D), 178(A), 179(C), 180(D),
181(B), 182(D), 183(A), 184(C), 185(A), 186(C), 187(B), 188(D), 189(A), 190(D), 191(B), 192(A), 193(A), 194(C),
195(D), 196(C), 197(B), 198(D), 199(A), 200(D).
30
...
Page
By: Manoj Kumar Singh, Manager(IE), Industrial Engineering Department, Northern Coalfields
Limited, Singrauli(MP)-486 889, Mobile No.-9993875526, E-mail : mks_ie@nclhq.nic.in