You are on page 1of 57

TopPage

SJPT56RHS

SERVICE MANUAL
No. S3120SE55CRNFT

Refrigerator-freezer
MODELS SJ-PT56R-HS
SJ-T52R-S
SJ-PT56R SJ-T56R
SJ-T56R-S
Refrigerant; HFC-134a DESTINATION F
Refer to "HFC-134a COOLING UNIT" Service Manual for handling this refrigerant.

CONTENTS

CHAPTER 1. SPECIFICATION CHAPTER 7. SELF-DIAGNOSIS MODE


(Only for SJ-PT56R)
CHAPTER 2. DESIGNATION OF VARIOUS PARTS
[1] EXTERNAL DESCRIPTION........................... 2-1 CHAPTER 8. MODE FOR DISPLAY
[2] CONSTRUCTIONS........................................ 2-3 (Only for SJ-PT56R)

CHAPTER 3. DIMENSIONS CHAPTER 9. ASSEMBLING PROCEDURES OF


[1] OUTER DIMENSIONS AND CLEARANCE ........ 3-1 MAIN PARTS AND CAUTIONS
[2] INNER DIMENSIONS .................................... 3-2 [1] FAN LOUVER AND
E.V COVER ASSEMBLY ...............................9-1
CHAPTER 4. LIST OF ELECTRICAL PARTS [2] R CONTOROL COVER ASSEMBLY
[1] SJ-PT56R....................................................... 4-1 (SJ-PT56R)...................................................9-3
[2] SJ-T52R/T56R ............................................... 4-1 [3] R CONTOROL COVER ASSEMBLY
(SJ-T52R/T56R) ...........................................9-5
CHAPTER 5. WIRING DIAGRAM [4] R SHOWER DUCT ASSEMBLY....................9-7
[1] WIRING DIAGRAM ........................................ 5-1 [5] DEFROST HEATER ASSEMBLY ..................9-8
[2] ELECTRIC ACCESSORIES LAYOUT ........... 5-2
[3] CIRCUIT DIAGRAM....................................... 5-4 CHAPTER 10. COOLING UNIT
[1] COOLING UNIT...........................................10-1
CHAPTER 6. FAILURE DIAGNOSIS [2] LOCATION ..................................................10-2
[1] OUTLINE OF CONTROL ............................... 6-1
[2] WHEN THE DEFROSTING FAILURE IS Parts Guide
DOUBTFUL(Only for SJ-PT56R) ................... 6-1
[3] RE-SETTING OF MICROCOMPUTER AT
POWER FAILURE.......................................... 6-1
[4] DIAGNOSIS METHOD OF FAILURE
AROUND PWB .............................................. 6-2
[5] CONVERSION TABLE BETWEEN TEM-
PERATURE AND RESISTANCE VALUE........ 6-3

This document has been published to be used for


after sales service only.
The contents are subject to change without notice.
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 1. SPECIFICATION
SJPT56RHS
Service Manual

Items SJ-T52R SJ-PT56R SJ-T56R


Type 2-Door
Outer dimensions Height 1670mm(65.7") 1770mm(69.7")
Width 800mm(31.5") 800mm(31.5")
Depth 720mm(28.3") 720mm(28.3")
Rated storage volume Total 514liter(18.1cu.ft) 555liter(19.6cu.ft)
(Rated volume) Freezer 139liter(4.8cu.ft) 139liter(4.9cu.ft)
Refrigerator 375liter(13.3cu.ft) 416liter(14.7cu.ft)
Defrosting System Heater system
Start Automatic
Finish Automatic
Temperature control Automatic (Adjustable)
No-frost freezer Yes
Interior lamp Freezer — 1 (LED) —
Refrigerator 1 1 (LED) 1
Evaporating pan 1 (unremovable)
Freezer Compartment F-shelf 1
F-shelf S — 1 —
Ice cube maker Twin ice cube maker
Ice storage box 1
F door pocket ass'y 1
RF door pocket 1
Refrigerator Compartment Fresh case 1
Fresh door 1
R glass shelf ass'y 2 1 2
R glass shelf SF ass'y — 1 —
R glass shelf SB ass'y — 1 —
V glass shelf ass'y 1
Vegetable case 2
Egg tray 1 2 1
R door pocket 1
R door cover — 1 —
RF door pocket 1
Utility pocket 2
Utility pocket L — 1
Bottle pocket 1
Tube stand 1 2 1
Deodorizing unit (Honeycomb type) 1 2 1
Door opening side — Changeable*1 —
*1 To modify the door, REFRIGERATOR HINGE KITS (SJ-L55CRD) will be required.
All modification work should be carried out by a competent person.

RATING
Items SJ-T52R SJ-PT56R SJ-T56R
Rated voltage (V~) 110
Rated frequency (Hz) 60
Climate class ST
Rated input (W) 100
Rated input of heating systems (W) 146
Defrosting input (W) 146
Refrigerant (Charging quantity) [Non-flammable] HFC-134a(110g) HFC-134a(110g) HFC-134a(110g)
Insulation blowing gas [Flammable] Cyclo pentane (HC)
Net Weight (kg) 77 82 79

PLUG TYPE
Plug cord 2 pin
Plug type A-1
Destination mark F
COLOR
Items -HS/S
Outside color Silver
Inside color White

1–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 2. DESIGNATION OF VARIOUSService
SJPT56RHS
PARTSManual
[1] EXTERNAL DESCRIPTION
The names in parenthesis “[ ]” are the denominations used in the REPLACEMENT PARTS LIST.

1. SJ-PT56R

1 1. Freezer LED light [LED lamp]


15
2. Freezer shelf [F-shelf]
2
3 3. Movable shelf [F-shelf s]
16
4. Ice cube maker
4
5 17 5. Ice cube box [Ice storage box]
6. Control panel
6
7 7. Fresh case & door
18
8 8. Refrigerator LED light [LED Lamp]
19
9 20 9. Refrigerator shelf [R glass shelf ass'y]
10 10. Hybrid cooling panel (Aluminum panel)
11 11. Half shelf (1 pair)
12 21 [R galss shelf sf ass'y,
13 R glass shelf sb ass'y]
22 12. Fruit and vegetable shelf
[V glass shelf ass'y]
23
13. Fruit and vegetable crisper
17 [Vegetable case]
14
15 14. Adjustable feet & cover [Adjustable leg]
15. Magnetic door seal [Door packing]
16. Flexible pocket [F door pocket ass'y]
17. Door pocket [RF door pocket]
18. Refrigerator pocket & cover
19. Utility pocket
20. Egg holder [Egg tray]
21. Utility pocket (large)
22. Bottle pocket
23. Tube stand

2–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
2. SJ-T52R,T56R

13
1. Freezer shelf [F-shelf]
1 2. Ice cube maker
14 3. Ice cube box [Ice storage box]
2 4. Fresh case & door
3 15
5. Refrigerator light [Lamp]
4 6. Freezer temp.conrol knob
5 7. Refrigerator temp.control knob
6 16
8. Refrigerator shelf [R glass shelf ass'y]
7 17
9. Hybrid cooling panel (Aluminum panel)
8 18
10. Fruit and vegetable shelf
9 [V glass shelf ass'y]
10 19
11 11. Fruit and vegetable crisper
[Vegetable case]
20
12. Adjustable feet & cover [Adjustable leg]
21 13. Magnetic door seal [Door packing]
14. Flexible pocket [F door pocket ass'y]
15
12 15. Door pocket [RF door pocket]
13
16. Refrigerator pocket
17. Utility pocket
18. Egg holder [Egg tray]
19. Utility pocket (large)
(Only for SJ-T56R)
20. Bottle pocket
21. Tube stand

2–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[2] CONSTRUCTIONS

Mark : Cold air flow

LED lamp PWB L ass'y F-thermistor


(Only for SJ-PT56R) F fan motor

DEF-thermistor
Freezer Evaporator
compartment Fuse ass'y
Deodorizer (Only for SJ-PT56R)
LED PWB ass'y Defrost heater
(Only for SJ-PT56R)
Ionizer-K
Damper ass'y
R LED lamp PWB L ass'y
(for SJ-PT56R)
Lamp (for SJ-T52R/T56R)
R-thermistor
Refrigerator temp. control knob
Freezer temp. control knob
(Only for SJ-T52R/T56R) Refrigerator
compartment
Aluminum panel

Deodorizer

Evaporating pan
Compressor
Starting relay
Overload relay(Protector)
Foot cover
Adjustable leg ass'y Main PWB ass'y
Caster

2–3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 3. DIMENSIONS
SJPT56RHS
Service Manual

[1] OUTER DIMENSIONS AND CLEARANCE


1. SJ-PT56R

This model is Free standing type.


(Not built-in type.)

728
800 720 800
499

540
10
44

1440

1500
1770
7

135
1150
60

1400

2. SJ-T52R

This model is Free standing type.


(Not built-in type.)

725
800 720 800
524

540
10

1440

1500
1670

135
1076
60

1400

3–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
3. SJ-T56R

This model is Free standing type.


(Not built-in type.)

725
800 720 800
524

540

10

1440

1500
1770
135
1176
60

1400

[2] INNER DIMENSIONS


The dimensions between shelves can be changed by setting the shelves on the other rails.

1. SJ-PT56R

195
660 85 320
640
74
74

250
65

128

326 660 85
208
82

82
74

135 268
74
63

648 665 122 265


122
10
45

45
89

653 120
165

345
53

53

328
142

120
203
83
83

53

653 330 328


625

150 150
257

210
17
17

635 660
132
356
360

265
265

265

660 98
72

275 275 235


74

50
330

3–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
2. SJ-T52R

195
660 85 320
640

74
74
30 47
250
660 85

208
82

82
74
135 268

74
648
665 122 265

122
10
45

45
89
653 120

165
345

53

53
328 328

53
246

528
208
653
345

17
17

155
635 660
132
356

244
265

265

265
98
275 275 74 660

72
235

50
330

3. SJ-T56R

195
660 85 320
640
74
74

‫ڎ‬
30 47

250
660 85
208
82

82
74

135 268
74

648 665 122 265


122
110
45

45
89

653 120
165

345
53

53

328
142

120
203
83
83

53

653 330 328


625

345
257

210
117
117

635 660
132
356
360

265
265

265

660 98
72

275 275 235


74

‫ڎ‬

50
330

3–3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 4. LIST OF ELECTRICAL PARTS
SJPT56RHS
Service Manual

[1] SJ-PT56R
ITEMS TYPE NAME RATING SPECIFICATIONS
R Thermistor — DC 5V R0 = 6.4 k, B(0) = 3811
F Thermistor — DC 5V R0 = 6.4 k, B(0) = 3811
Defrost Thermistor — DC 5V R0 = 15 k, B(0) = 3811
Thermo. fuse 12Y 250V 2A Working temp. : 76 C
Defrost heater — 110-120V 77.7 160W at 115V
Fan motor FBA12J15VXD DC 15V —
F Door switch D3D-211 250V 0.5A/125V 1A 3 Terminals lever type
R Door switch D3D-211 250V 0.5A/125V 1A 3 Terminals lever type
F Lamp (LED) DPWB-A135CBKZ DC 14.5V 75mA, white LED Lamp
R Lamp (LED) DPWB-A150CBKZ DC 14.5V 125mA, white LED Lamp
LED Operation FPWB-A499CBKZ DC 14.5V Blue LED
Compressor EGX60HLC 115-127V/60Hz Cooling capacity : 179W (50Hz)
Main coil : 5.10 
Aux. coil : 5.70  Common

(at 25 C)

Aux. coil Main coil

PTC Relay PTH7M4R7MD3 50/60 Hz 4.7 0.94 (at 25 C)


Overload Relay(Protector) 4TM319NFBYY-53 — Open/ Close : 120/ 61 C
Capacitor RC-EZA198CBZZ — 250V, 12F
Main PWB FPWB-A511CBKZ 100-127V Control by MPU
Ionizer-K(Plasmacluster unit) FTRN-A014CBKZ DC 12V —

[2] SJ-T52R/T56R
ITEMS TYPE NAME RATING SPECIFICATIONS
R Thermistor — DC 5V R0 = 6.4 k, B(0) = 3811
F Thermistor — DC 5V R0 = 6.4 k, B(0) = 3811
Defrost Thermistor — DC 5V R0 = 15 k, B(0) = 3811
Thermo. fuse 12Y 250V 2A Working temp. : 76 C
Defrost heater — 110-120V 77.7 160W at 115V
Fan motor FBA12J15VXD DC 15V —
F Door switch D3D-211 250V 0.5A/125V 1A 3 Terminals lever type
R Door switch D3D-211 250V 0.5A/125V 1A 3 Terminals lever type
R Lamp — 120V 15W #187 Straight Terminal, Pitch 6
Compressor EGX60HLC 115-127V/60Hz Cooling capacity : 179W (50Hz)
Main coil : 5.10 
Aux. coil : 5.70  Common

(at 25 C)

Aux. coil Main coil

PTC Relay PTH7M4R7MD3 50/60 Hz 4.7 0.94 (at 25 C)


Overload Relay(Protector) 4TM319NFBYY-53 — Open/ Close : 120/ 61 C
Capacitor RC-EZA198CBZZ — 250V, 12F
Main PWB FPWB-A513CBKZ 100-127V Control by MPU
VR PWB FPWB-A554CBKZ DC 5V —

4–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 5. WIRING DIAGRAM
SJPT56RHS
Service Manual

[1] WIRING DIAGRAM


Be sure to replace the electrical parts with specified ones for maintaining the safety and performance of the set.

1. SJ-PT56R

2. SJ-T52R/T56R

(BR) MAIN PWB


(GY)

AC/DC

PROTECTOR

(SOURCE CORD)
(SB)

(GR)

(GY)
(SB)
(BR)

(BR)
(BK)
(GR)

(BL)
(SB)

(BK)
(BR)

(BK)

(BL)

(Y)

(R-THERMISTOR) (W)
(P)
(W)

(O)
(O)
(V)

(DEF-THERMISTOR)(P)
(R)
(R)
(P)

(F-THERMISTOR)

L
FM
(W) CONTROL
PWB
FUSE DEF-HEATER LAMP R-DOOR F-DOOR FAN MOTOR ELECTRICAL DAMPER
SWITCH SWITCH

COMPRESSOR
STARTING RELAY (G/Y)

(BL)

BK : BLACK
BR : BROWN
R : RED
O : ORANGE
Y : YELLOW
GR : GREEN
BL : BLUE
V : VIOLET
GY : GRAY
W : WHITE
P : PINK
SB : SKY-BLUE
G/Y : GREEN/YELLOW STRIPE

5–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[2] ELECTRIC ACCESSORIES LAYOUT
1. SJ-PT56R

BK : BLACK
BR : BROWN
R : RED
O : ORANGE
Y : YELLOW
GR : GREEN
BL : BLUE
V : VIOLET
GY : GRAY
W : WHITE
P : PINK
SB : SKY-BLUE
G/Y : GREEN/YELLOW STRIPE

5–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
2. SJ-T52R/T56R

BK : BLACK
BR : BROWN
R : RED
O : ORANGE
Y : YELLOW
GR : GREEN
BL : BLUE
V : VIOLET
GY : GRAY
W : WHITE
P : PINK
SB : SKY-BLUE
G/Y : GREEN/YELLOW STRIPE

5–3
Downloaded from www.Manualslib.com manuals search engine
TH1
Rating AC220-240V 50/60Hz S8R2K10D315J
C4 C2
TNR10V471K
AC160-288V VRS1
4700pF 0.1u/275V TSL1112RA-100M3R7-PF
50/60Hz B3P(5-2,4)-VH(LF)(SN) 0.1u/275V ZD3 TRNS1 D4
1SR139-600 TP6 6 (L3) VM14.5V
STO3D-200 D2S6M
Toroidal Core(ESD-R-38 10Turns) 1 TP1 F1 R1 C1 AX 1/4W 5 10
910k(1/2W) R34 R5 IC4
VM14.5V
CN1A 2.5A/250V C5 Film 4 11 TP8 DC5V
TP2 Film 4700pF D16 D18
5 (AX) 3 1 BP5225 5

1
C7 Jumper 13kF D3 TP10
L1 Vi n Vout +
CN1C SA1 TP44 150u/450V D1NL20U 9
SS21V-050360(36mH) IC2 C10 ZD1 + + C13 (C28) GG + (C79)
RA-272M-C6-F R2 + 2 8 DC5V

3
4
2 HZ11C1 R3 100uF/25V
Tab1 1TP42098-21 220pF/50V C14

1SR139-600
(AX) C6 F/B Q5
5 EER28/5.95mH 100uF/10V C15 KRA101S
VRS2 4700pF AX 1/4W

C74
C12
TP45 D Jumper
TNR10V511K 910k(1/2W) /250VAC R6 0.1u/25V
1u/50V
CN8

0.1u 25V
4 16kF 3216
TP3 C9 D2 TP18

GND Z/C
Vcc TXD 1

1000uF/25V
100uF/25V
C8 R18
B2P4-VH-BL (LF)(SN) D1NL20U +C11 (C75) (C73) 2
150pF/2kV MR1712
1 TP7 2200p/50V 100uF/25V 10000pF 10000pF TP9 1k TP20 3
D17 D19

3
DC5V R17
(CN3) 1SR139-600 2.7k
F2 1SR139-600
For Israelonly C77 C76 B03B-XASK-1-A(LF)(SN)
1. Main PWB (SJ-PT56R)

4 250V4A 10000pF 10000pF R21


RY1 DC12V 2.7k
D10 250V R20
[3] CIRCUIT DIAGRAM

1SS133 RXD
3 AX 1/4W 0.1u 0.1u 1k R22
CN1B TP11 R8 (C17) (C27)
FTR-H2AL PC1 Q6 1k
Comp 1.8k
KRC101S
Q3 PC123Y52 R11

1
4
C16 8.66kF AX 1/4W C31
RY2 DTD123ES 0.01u
DC12V
1 4 D12 1000p/50V R9 AX 1/4W
1k
1SS133 R7
(CN4) 1 TP12 2 3 20kF C18 R4

3
2
DC5V
J3 FTR-F3(3A) AX 1/4W 0.1u/50V Jumper
3 Jumper DEF_H CN9A 1
Q2 R29 TP25

Downloaded from www.Manualslib.com manuals search engine


B2P3-VH CN9B 2 R-TH
KRC101S R-TH
4.7k
J3 R14
Jumper 1.8kF AX 1/4W (C36) R30
10 IC3 0.01u 6.34kF C37
TA76431S VM14.5V /50V 0.1uF/25V
CN5F TP27
8 70mA/12V
CN5E
R31 R32 Q7 CN9C 3
KTC3205 TP19 I_detect
7 470 470 CN9D 4
CN5D B8B-XASK-1-A(LF)(SN)
TP4 (RY3) DC12V
5 1 4 (D15) Plasmacluster
CN5C 1SS133 C38
2 3 0.1uF/25V
B6P(10-2,4,6,9)-VH(LF)(SN) PLASMA Q8
KRA101S
FTR-F3(3A)
R_Lamp ZD2
(Q19) HZ12B2
KRC101S Q9
DC5V KRC101S
JMP1 Panasonic
Jumper
R12 VM14.5V IC6
D7 D6 D5
R Door SW input 4.7k 1N4005SG 1N4005SG 1N4005SG DC12V LB1948M
B6P(10-2,4,6,9)-VH(LF)(SN) TP21
R16 R15 (1/10W) 1 10 TP28 CN9E 5
3 D8 43k 43k TP14 TP15 R19 VCC OUT1
R DOORSW 3TP38 + R33 2 9 TP29 CN9F 6
R Door SW DUMP_B2 IN1 OUT2
CN5B 3 8 TP30 CN9G 7

1
4
1N4005SG C42 10k DUMP_B1 IN2 OUT3
1 (1/2W) (1/2W) 4.7k (1/10W) 100uF/25V 4 7 TP31 CN9H 8
(AX) (AX) DUMP_A2 IN3 OUT4
2 1TP39 + 5 6
D13 DC5V DUMP_A1 IN4 GND
3 CN5A C25

5–4
1SS133 TP26 (JMP2)
10uF/50V PC2 DC5V
F DOORSW ENFORCEDEF
1 PC123Y52 OPEN
R26

2
3
B8B-XASK-1-A(LF)(SN)
B2P2-VH(LF)(SN) CN2 R82 VM14.5V
2 (JMP3)
1 DC5V 10k
4.7k TP13
2 (1/10W)
(R81) OPEN
10k
B4B-PH-KL
(R90) (CN12) Q14
DC5V 1 KTA1273-Y TP36
DC5V 10kF
2 R47
DC5V C50 D1
R24 R91 TP43 3 RAM DataCheck 4.7k 1N4005SG
R48 0.1uF/25V
F Door SW input 4.7k (C24) + C23 10kF 4
R10 R14
(1/10W) 750(1/2W)
D9 43k 43k TP23 TP24 R25 F_FAN_ON
100u/25V 0.1u Q15 AX
F Door SW (RD) R89

1
4
1N4005SG IC1 KRC101S DC5V DC5V
(1/2W) 4.7k (1/10W) 10k Q16 (Q17) DC5V Q18
(1/2W) DC5V DC5V DC5V
(AX) (AX) DC5V 20 9 KRA101S KRA101S KRA101S
+ VREF RXD1 TP46 CN11
7 2 1
C26 D14 AVC C TXD1 TP47 Vcc
8 2
10uF/50V 1SS133 PC3 C22 +C21 MODE Mode E8 Emulator Connector
3 F_FAN_H
R23
PC123Y52 (R88) (R87) RESET Reset

2
3
32 TP48 4
10k 10k 100u/25V 0.1u P00 R-TH TP49 Vss
(RD) 5 31 F_FAN_M
AVSS P01 F-TH B4B-PH-KL
4.7k TP22 30 F_FAN_L
F Roomlamp B04B-XASK-1-A(LF)(SN) CN7 Q10 VM14.5V (1/10W)
P02 DEF-TH DC5V AX 1/4W
TP16 2SB1237 CF1 29 CN10A 1 HALL
1 P03 D11 R50 (R60) (R51) (R61) R52 (R62)
LED 1 6 28 CN10B 2 GND F-FM
2 XIN P04 DUMP_B2 1SS133T R45 3.16kF 3.16kF 6.19kF 6.19kF 10kF 10kF
2 27 R44 CN10C 3 COIL
3 TP17 R28 P05 DUMP_B1 1k 4.7k TP34
3 26 TP37 R53 AX 1/4W AX 1/4W
4 4.7k P06 DUMP_A2 I_mes R46 I_detect F Fanmotor
LED R86 TP35 + + 1W 10kF I_detect
R27 CSTLS8M00G56-A0 0.51
1M 22 C78 (C48) C49 (AX)
R Roomlamp F RoomLamp(LED) P10 I_mes 1uF/50V 0.1u 100uF/10V
21 B7B-XASK-1-A(LF)(SN)
1k P11 PLASMA R55
F_Lamp 19 DC5V 1W DC5V
Q11 VM14.5V Q1 P12 F Door SW (AX) 0.51
TP42 2SB1237
4 18 CN10D 4 F-TH
KRC101S XOUT P13 R Door SW
15 R56 4.7k TP40 CN10E 5
P16 R_Lamp GTH1 F-TH
25 10 R36
CN10F 6 DEF-TH
R37 DUMP_A1 AN0 P17 F_Lamp TP33 C16X-41-3S
4.7k TP32 R57 4.7k TP41 CN10G 7
4.7k DEF-TH
12
R38 P31 F_FAN_M R35 R58
R RoomLamp(LED) 23 (C54) (C55) R59 C56 C57
P33 F_FAN_L (C32) 10kF 0.01u 0.01u
DC5V 24 16.9kF 16.9kF 0.1uF/25V 0.1uF/25V
1k P34 F_FAN_ON 0.1u/25V /50V /50V
R_Lamp 1
Q4 P35 ENFORCEDEF
11
KRC101S P36 F_FAN_H

4
5 R83 14
P53 DEF_H
10k 13
P54 Comp
RESET
DC5V +5V 17

N.C.
N.C.

R93 TXD0 TXD


GND

2 1 3 16
VDD VOUT RESET RXD0 RXD
C64 + C20 1k
C65 +C66 C67 C68 C69 C70 C19
IC9 R5F21266SNF
P
3

BD4842G Main Control Board Circuit Diagram


100u/25V100u/25V 0.1u 0.1u 0.1u 0.1u 0.1u
0.1u 0.01u
1.Ratingof reslstors without appointment are 1/10W, error 5%(J).
2.Ratingof capacitors without appointm ent are 0.01u/50V
,0.1u/50V.
3.Partswith parentheses are not in use,but canbeinserted.
SJPT56RHS
(D320)1N4005SG
Rating AC 220-240V 50/60Hz Film
Film C304
C302
IC302
AC160-288V VRS301 C301 4700pF TH301
TNR10V471K 0.1u/275V 0.1u/275V S8R2K10D315J STR-A6251M R306 TSL1112RA-100M3R7-PF
50/60Hz TP306 C308 TRANS301 D304 (L303)
B3P(5-2,4)-VH(LF)(SN) 1N4005SG 220k 5 RL2Z 14.5V DC5V
F301 R301 0.01u/400V
SJPT56RHS

1 TP301 1W 4 10 1 3
I O

8
7
5
CN301A 910k(1/2W) C305 3 9 TP10
2.5A/250V D316 D318 D302 TP8 G +
5 TP302 (AX) 4700pF EG01C 2 (C328)
L301 C314
CN301C SA301 TP344 7 1u/ 50V 2 C315

D
D
R302 SS26V-070510(51mH) + 100uF/10V
RA-272M-C6-F + D303 1 6 3216
Tab301 1TP42098-21 910k(1/2W) R304 0.1u/25V

1N4005SG
C306 C307
(AX) C313
VRS302 4700pF +C311

C312
TP345 82u/450V C309 D1NL20U 10
TNR10V511K /250VAC 22uF/50V
47pF/2kV 0.1u 25V

S/OCP
FM/SS
GND VCC
FB/CC/OLP
B2P(4-2,3)VH(LF)(SN) TP303 (Heat sink)

560uF/25V
(470uF/25V)
1 (C375) (C373) OSH-1025-SP2
10000pF 10000pF

1
2
3
4
(CN303)
D317 D319
For Israelonly F302 1N4005SG
250V4A 1N4005SG TP9
4 RY301 TP307 C377 C376
TP309
FTR-H2AL012T-SN R305
DC12V 10000pF 10000pF
D310 1/2W 1.0
1SS133 1/2W 1.2 250V
3 C310
2 0.01u/50V
CN301B TP311 AX 1/4W R308 (C317) (C327)
Comp Compressor PC301
2. Main PWB (SJ-T52R/T56R)

TP3121 RY302 4 1.8k


Q303 PC123Y52 R311
0.1u 0.1u

1
4
DTD123ES C316 8.66kF
2 3 DC12V
D312 1/4W
4700p/50V R309AX 1/4W
FTR-F3 1SS133 1k
C318 R307

3
2
B5P(8-2,5,7)-VH(LF)(SN) DEF_H Defrost heater 0.1u/50V Jumper
1 Q302

Downloaded from www.Manualslib.com manuals search engine


KRC101S
CN305A
R314
CN306A 1 IC303 1.8kF
1/4W
2 TP304 (RY303) TA76431S
DC12V B10-XASK-1-A(LF)(SN)
CN306B 1 4 (D314) DC5V
1SS133
2 3 CN309A 1
6 R329 TP325 R-TH
CN309B 2
CN305D FTR-F3
R roomlamp(Bulb) R-TH
R_Lamp 4.7k
B5P(7-4,6)-VH(LF)(SN) (Q321)
(C336) R330
KRC101S 0.01u 6.34kF Panasoni
c
DC5V C337
JMP301 /50V 0.1uF/25V
Jumper
R312
R316 R315 4.7k
43k (1/10W) R313
NC D308 43k TP314 TP315
R DOORSW 8
D3D-211 Door SW
CN305E

1
4
TP317 1N4005SG DC5V
B5P(8-2,5,7)-VH(LF)(SN) (1/2W) (1/2W) 4.7k (1/10W) 14.5V IC306
COM D309 TP326 (JMP303) D307 D306 D305 TP316 B10-XASK-1-A(LF)(SN)
NO B5P(7-4,6)-VH(LF)(SN) 7 (AX) (AX) + DC5V LB1948M PH
ENFORCE_DEF 1N4005SG 1N4005SG 1N4005SG DC12V
NC CN306E 1N4005SG C325 D313 OPEN 1 10 TP328 CN309C 3 2 3 4 5
TP318 VCC OUT1
D3D-211 10uF/50V 1SS133 PC302 R382 + R391 2 9 TP329 CN309D 4
F DOORSW 10k
DUMP_B2 IN1 OUT2
Door SW input R326 PC123Y52 10k C342 3 8 TP330 CN309E 5

2
3
COM
DUMP_B1 IN2 OUT3
(R381) 100uF/25V 4 7 TP331 CN309F 6
NO DUMP_A2 IN3 OUT4
CN305B 3 TP313 4.7k 5 6
4.7k (CN312) DUMP_A1 IN4 GND DC5V
CN305C 4 AX (1/4W) 1 (C330)
DC5V

5–5
B5P(8-2,5,7)-VH(LF)(SN) TP319 2 0.1uF/25V
DC5V TP343 3 RAM DataCheck CN309G 7
CN306C
3 (C324) +C323 4 R340 4.7k TP339 CN309H 8
F_VR
R342 4.7k TP338 CN309I 9
Door SW B4B-PH-KS R_VR
(RY304) 100u/10V 0.1u CN309J 10
DC12V (RD) R389
CN306D 5 (JMP302) 1 4 (D315) C335 C332 R343 R341
IC301 10k
OPEN 1SS133 DC5V DC5V DC5V 0.1uF/25V 0.1uF/25V 220k 220k RK09K1130(10k)
B5P(7-4,6)-VH(LF)(SN) 2 3 DC5V 20 9
VREF RXD1 TP346 CN311
7 2 1
TP305 FTR-F3
F roomlamp(Bulb) AVC C TXD1 TP347 Vcc
F_Lamp 8 2
(Q322) C322 +C321 MODE Mode E8 Emulator Connector
3 Q316 DC5V
KRC101S R388 R387 RESET Reset
32 TP348 4 KRA101S
10k 10k 100u/10V 0.1u P00 R-TH Vss 3.16kF
(RD) 5 31 TP349 R350
AVSS P01 F-TH B4B-PH-KS
30
P02 DEF-TH DC5V
(CF301) 29 F_FAN_H 3.16kF
P03 G_Th (R360)
1 6 28
XIN P04 DUMP_B2 R319
2 27 GTH301
P05 DUMP_B1 TP333 4.7k TP332 C16X-41-3S (Q317) DC5V
3 26
P06 DUMP_A2 G_Th KRA101S 14.5V
(R386) R320 6.19kF
CSTLS8M00G56-A0 1M 22 10kF (R351)
P10 DC5V (C380) (C381)
21 0.01u 0.1u D301 TP336
P11 F_Lamp F_FAN_M 6.19kF 1N4005SG
19 (R361) CN310A 1 Vcc 1
P12 F_VR (R394)
4 18 10k
CN310B 2 GND 2 F-FM
XOUT P13 R_VR 14.5V TP337
15 Q318 DC5V CN310C 3 Vs 3
P16 R_Lamp
25 10 R395 KRA101S R353
DUMP_A1 AN0 P17 Buzzer 10k
10kF F Fanmotor
(BZ301) R352 10kF
12 (R318)
P31 F_FAN_M 2.7k
PKM22EP
23 F_FAN_L 10kF
P33 F_FAN_L 1/4W (R362)
DC5V 24 DC5V
P34
1 TP334 CN310D 4 F-TH
P35 ENFORCE_DEF
11 R356 4.7k TP340 CN310E 5
P36 F_FAN_H Buzzer F-TH
(Q319) CN310F 6 DEF-TH

4
5
R383 14 KRC101S R357 4.7k TP341 CN310G 7
P53 DEF_H DEF-TH
10k 13
P54 Comp R358 R359
(C354) (C355) C356 C357 B7B-XASK-1-A(LF)(SN)
RESET 0.01u 0.01u
DC5V 17 16.9kF 16.9kF 0.1uF/25V 0.1uF/25V

N.C.
N.C.
R393 TXD0 /50V /50V

GND
2 1 3 16
VDD VOUT RESET RXD0
C320 1k
C319
IC309 R5F21266SNF
P DC5V

3
2 R5F21265SNF
P
BD4842G
0.1u 0.01u
C364 + C365 +C366 C367 C368 C369 C370

100u/25V100u/25V 0.1u 0.1u 0.1u 0.1u 0.1u

Main Control Board Circuit Diagram


1.Ratingof reslstors without appointment are 1/10W, error 5%(J).
2.Ratingof capacitors without appointm ent are 0.01u/50V
,0.1u/50V.
3.Partswith parentheses are not in use,but canbeinserted.
VL VL VL
R155 R156 R157
TP101 (D101)
4.7k 4.7k 4.7k
1N4005E
VL +5V
CN101 R151
1 3 1 TP102 VL VL
VL Vin Vout Q151
2 1k
TXD,RXD +C102 C101 C115 +C103
3 d1 Q101 Q102 Q103

GND
GND LED102 LED103 2SB1237 2SB1237 2SB1237
S03B-PASK-2 (RD) 47u/25V 0.1u/50V 0.1u 47u/10V (BL) (BL)
IC102
(RD) KRC101S
(2125) KIA78S05P (1608)

2
R152
TP103 Q152
TP104 1k
d2
R168 R169
820 820

12
9
8

1/2W 1/2W KRC101S


R153 L ED101
Q163 TP125 Q164 Q153 L TC-561ACB
+5V

Di g.1
Di g.2
Di g.3

1k
+5V LED102 LED103 d3 a
(C112)
+C111 f b
KRC105S KRC105S KRC101S g
100u/25V 0.1u
R178
(RD) e c
IC101 10k
+5V +5V +5V d . D.P. . .
+5V 20 9
3. LED PWB (Only for SJ-PT56R)

VREF RXD1 (CN102)


7 2 1
a
b
c
d
e
f
g
D.P1

AVCC TXD1 TP120


8 TP121 2
(C109) +C107 MODE Flash writing
3

Downloaded from www.Manualslib.com manuals search engine


(R194) (R195) RESET TP122
7
4
2
1
5
3

32 4
11
10

10k 10k 100u/25V 0.1u P00 DP TP123


5 31 R160 820
(RD) AVSS P01 g B4B-PH-KL Q155
30
P02 f 1/2W
CF101 29 a
P03 e
1 6 28
XIN P04 d
2 27
P05 c KRC105S
3 26
P06 b
R108
CSTLS8M00G56-A0 1M 22 R161 820
+5V P10 d1 Q156
21
P11 d2 1/2W
19 b
GTH101 P12 d3
4 18
C16X-41-3S XOUT P13 A_D
TP116 15
R131 P16 VL KRC105S
TP115 25 10
A_D a AN0 P17 BZ
4.7k
12 R162 820
P31 SW2 Q157
R130 (C140) C141 23 R150 BZ101
P33 L ED102 1/2W
10kF 24 2.7k PKM13EPY c
P34 LED103
0.1u 0.01u 1
P35 1/4W 4kHz
11
P36 SW1 KRC105S

P53 SW4
13 R163 820
P54 SW3 Q158

5–6
Q150
BZ 1/2W
+5V 17 KRC101S d
TXD0 TXD0
3 16
RESET RXD0 RXD0
KRC105S
R5F21266SNFP

4
5
R101 R103
10k 1k R164 820
Q159
+5V +5V +5V +5V 1/2W
+5V e

N.C.
N.C.

GND
2 1
VDD VOUT RESET
C110
C105 KRC105S
IC103
(C170) (C172)

3
BD4842G R170 R172
0.1u 0.01u 2.7k 2.7k R165 820
0.01u 0.01u Q160
1/2W
R174 TP105 R176 TP107 f
SW1 SW3

2
2

4.7k 4.7k
KRC105S
+5V SW101 SW103
SW1 SKQNADD010
SW3 SKQNADD010
R166 820
Q161
C108
1/2W

1
1

g
R142
0.1u
2.2k
KRC105S
R147 TP111 +5V +5V +5V +5V
TP110
TP109 RXD0 R167 820
R145 1k Q162
1/2W
1k Q141 DP
C132
KRC101S (C171) (C173)
R171 R173
0.01u 2.7k 2.7k KRC105S
0.01u 0..01u
R175 TP106 R177 TP108
SW2 SW4
2
2

+5V 4.7k 4.7k


(R146) SW102 SW104
Q142 TP112 SW2 SKQNADD010 SW4 SKQNADD010
1k KRA101S
R143 TP114 R144
1
1

1k C131 1k
R141
0.01u
2..2kk
SJPT56RHS
SJPT56RHS
CHAPTER 6. FAILURE DIAGNOSIS
SJPT56RHS
Service Manual

[1] OUTLINE OF CONTROL


1. ON/OFF Control of Compressor
• ON/OFF of the compressor will be controlled depend on the temperature detected by
the R-thermistor and F-thermistor. (Normal cooling control)
• In case the surrounding temperature is high at the power supply input, the compressor will be ON at once and the normal cooling control will start
after several hours.
• During 5 minutes after the compressor stops, it will not start regardless of the detected temperature by R-thermistor and F-thermistor.

2. Defrosting
Microcomputer calculates the appropriate timing of defrosting and defrosting is made automatically. Therefore no manual operation by user is
required. The cycle of defrosting varies depend on the usage condition of the refrigerator. (Maximum time 50 hours, minimum time 40 minutes)

3. Thermistor
Thermistors are installed in 4 places; in the refrigerator and freezer compartment, and on the Main PWB and close to Evaporator. (R-thermistor, F-
thermistor, Outside temp-thermistor, Def-thermistor)
R-thermistor and F-thermistor reads the temperature in the refrigerator and freezer compartment respectively and controls ON/OFF of the compres-
sor and OPEN/CLOSE of the electrical damper.
Def-thermistor detects the temperature around the evaporator and shows the progress of defrosting.
Outside temp-thermistor reads the surrounding temperature of refrigerator. It changes the operation mode when the outside temperature is high.

[2] WHEN THE DEFROSTING FAILURE IS DOUBTFUL(Only for SJ-PT56R)


Execute the Self-Diagnosis Mode. (Refer to the Chapter “SELF-DIAGNOSIS MODE”)
• In case the diagnosis result is “ 03” (Def-thermistor system defect), follow up the flowchart of 03. (In case of any abnormity in the Def-ther-
mistor, defrosting will not be made for safety reasons.)
• In case the diagnosis result is “ 07” (Defrost defect), follow up the flowchart of 07.
(This diagnosis result will be displayed when defrosting is made for 120 minutes, the maximum time length. In this case, the defect of PWB itself
and also the breakage of heater and heater circuit (melt down of current fuse and temperature fuse) are considerable.)

[3] RE-SETTING OF MICROCOMPUTER AT POWER FAILURE


• At the power failure for over 0.2 second, the control of the microcomputer will be reset.
(Microcomputer might continue to operate for approximately 10 seconds maximum at power failure depending on the load at the operation. When
you need the difinite power off condition ,approximately 30 seconds is necessary.)
• When the power is re-supplied, the normal cooling will be resumed.
• The temperature set by user is not maintained if a power failure occurred.(Only for SJ-PT56R)
(Defrosting also is not maintained.)
• When the self diagnosis is made, each mode and setting are resumed to the initial condition.(Only for SJ-PT56R)

6–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[4] DIAGNOSIS METHOD OF FAILURE AROUND PWB
In case of any abnormality of refrigerator, check by the following procedure;
1. Disconnect power supply and check the following point.
• Is there any failure portion in inserting connectors?
2. Detach the PWB and check the appearance.
• Is there any burning or abnormal damage?
3. Check the conditions of the fuse and the varistor. (Fuse and varistor are located at the position in the figure.)
• Under the condition of power supply plug connected;
In case of no cooling and no indoor lamp lighting, there might be a possibility of fuse (F1) melt down.
In case of cooling but no indoor lamp lighting, there might be a possibility of fuse (F2) melt down.(Only for SJ-T52R, T56R)
(However, these indications do not conclude the cause of the defect.)
When the fuse F1 is melt down, PWB does not operate at all.
When the fuse F2 is melt down, indoor lamp bulb and defrosting heater are not electrified. (It will be diagnosed as “Defrosting failure” by the
self diagnosis.)
• Melting in the fuse cannot be checked visually (as the safer one than transparent glass tube is used). Be sure to detach the connector “CN1/
CN301” before measuring the resistance between the both ends of the fuse by the tester.
• Next, measure the resistance value between the both leads of the varistor.
1) SJ-PT56R

Varistor 1 Varistor 2

Fuse 1

Fuse 2

2) SJ-T52R / T56R

Varistor 1 Varistor 2

Fuse 1

Fuse 2

6–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

Varistor
Normal (over approx.1.8M) Damage
Flow of excessive current is considerable for some rea- There is a possibility of excessive voltage applied from out-
sons. side with the factor such as thunder etc. When repeated with a
Melting
Check for any portion to cause short circuits especially on factor other than thunder, there might be the apparatus near
the primary circuit. by generating noises.
Fuse
Fuse and varistor are normal. -
Possibility to be caused by excessive current or voltage
Conduction
near the power supply is low. Proceed to the other check
item.

4. Check whether the temperature (resistance value) shown by R-thermistor is correct or not. (Refer to the table below.)
• Detach the connector “CN9/CN309” on the PWB and measure the resistance value between 1 and 2 pins.
5. Check whether the temperature (resistance value) shown by Def-thermistor is correct or not. (Refer to the table below.)
• Detach the connector “CN10/CN310” on the PWB and measure the resistance value between 6 and 7 pins.
6. Check whether the temperature (resistance value) shown by F-thermistor is correct or not. (Refer to the table below.)
• Detach the connector “CN10/CN310” on the PWB and measure the resistance value between 4 and 5 pins.

[5] CONVERSION TABLE BETWEEN TEMPERATURE AND RESISTANCE VALUE


1. R-thermistor, F-thermistor

Temperature Resistance Value Temperature Resistance Value Temperature Resistance Value


(C) (K) (C) (K) (C) (K)
-25 26.1 -9 10.3 7 4.52
-24 24.54 -8 9.75 8 4.3
-23 23.08 -7 9.24 9 4.1
-22 21.72 -6 8.76 10 3.91
-21 20.46 -5 8.3 11 3.73
-20 19.27 -4 7.87 12 3.56
-19 18.16 -3 7.47 13 3.4
-18 17.13 -2 7.09 14 3.24
-17 16.16 -1 6.74 15 3.1
-16 15.25 0 6.4 20 2.47
-15 14.4 1 6.08 25 1.99
-14 13.6 2 5.78 30 1.61
-13 12.85 3 5.5 35 1.31
-12 12.15 4 5.23 40 1.08
-11 11.49 5 4.98
-10 10.88 6 4.74

2. Def-thermistor

Temperature Resistance Value Temperature Resistance Value Temperature Resistance Value


(C) (K) (C) (K) (C) (K)
-25 61.17 -9 24.13 7 10.58
-24 57.51 -8 22.85 8 10.09
-23 54.1 -7 21.65 9 9.61
-22 50.92 -6 20.52 10 9.16
-21 47.94 -5 19.46 11 8.74
-20 45.17 -4 18.46 12 8.34
-19 42.57 -3 17.51 13 7.96
-18 40.14 -2 16.63 14 7.6
-17 37.86 -1 15.79 15 7.26
-16 35.74 0 15 20 5.79
-15 33.74 1 14.26 25 4.66
-14 31.87 2 13.55 30 3.77
-13 30.12 3 12.89 35 3.08
-12 28.48 4 12.26 40 2.52
-11 26.94 5 11.67
-10 25.49 6 11.11

6–3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 7. SELF-DIAGNOSIS MODE (Only
SJPT56RHS
for SJ-PT56R)
Service Manual
1. Entering method of the mode

1) Press the [Select] button on the control panel over 5 seconds at the opening condition of
the freezer and refrigerating room doors. F
R R
2) With a beep sound of buzzer, the self-diagnosis mode is entered. When the self-diagnosis
mode is not entered by the above operation, defect of Door SW system can be considered.
Select button

2. When the self-diagnosis mode is entered, the following movements will be made. Forced release operation is not prepared for the self-diagnosis
mode. It returns to the normal movement after a lapse of 2 minutes.
• When the self-diagnosis mode is entered, beep sound for reminding of closing the door must not be sounded for 20 minutes.
• Defect and various conditions are displayed by [ON/OFF of buzzer].
• Defect and various conditions are displayed on the control panel. In case of plural defects and various conditions, these are displayed one after
another by button operation and all contents are notified.

3. Display of self-diagnosis
• Display example of control panel (at the defect of F-thermistor system)

F
R R

Result of diagnosis Move to the previous display


Move to the next display

• Buzzer notice example; (at defrost defect, 2 times of 0.5 second ON)

0.5 second 0.5 second 0.5 second 0.5 second


ON
Buzzer
Repeating
OFF

3 seconds stop 0.5 second stop 3 seconds stop 0.5 second stop

7–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

No. Status Buzzer LED Content Correspon-


Display dance
method
- No defects None - - - -
1 F-thermistor system defect 01 [1]
2 R-thermistor system defect 02 [2]
Defect of each thermistor, short circuit/wire breakage
3 DEF-thermistor system defect 03 of thermistor wiring and defect of main PWB [3]
Outside temperature-thermistor sys-
4 04 [4]
tem defect
Wire breakage of fuse, defrost heater, defect of main
PWB
5 Defrost defect 07 [5]
(120-minute defrosting has been occurred continu-
ously 2 times within the past 48 hours.)
Defect of wiring / main PWB
6 Fan motor system defect 08 (When fan motor is ON, over current or no current is [6]
detected.)
Defect of wiring / main PWB
Ionizer (Plasmacluster) system
7 11 (When Plasmacluster is ON, over current or no current [7]
defect
is detected.)
Short circuit/wire breakage of wiring and defect of LED
8 LED Display communication defect 12 or main PWB (Communication with LED PWB has [8]
been abnormal over 3 times within the past 48 hours.)
9 F-thermistor system defect history 61 [1]
10 R-thermistor system defect history 62 [2]
Defect of thermistor system has been occurred over 1
11 DEF-thermistor system defect history 63 minute continuously within the past 48 hours. [3]
Outside temperature-thermistor
12 64 [4]
system defect history
Defect of fan motor has been occurred over 3 times
13 F fan motor system defect history 66 [6]
continuously within the past 48 hours.
Defect of Ionizer (Plasmacluster) electrifying has been
Ionizer (Plasmacluster) electrifying
14 72 occurred over 3 times continuously within the past 48 [7]
defect history
hours.
Temperature of F-thermistor has been reached over
15 F-room high temperature history 76 -10C continuously for 6 hours or more within the past [1]
48 hours. (except right after the installation)
Temperature of R-thermistor has been reached over
16 R-room high temperature history 77 +10C continuously for 6 hours or more within the past [2]
48 hours. (except right after the installation)

• Buzzer: =0.5 sec ON/0.5 sec OFF, =2 sec ON/0.5 sec OFF

7–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
Correspondence method

[1] 01 / 61 / 76 [2] 02 / 62 / 77

(F-thermistor system diagnosis) (R-thermistor system diagnosis)

Power OFF Power OFF

10 9

2.47

NO NO
NG? NG?

YES YES

Remove 6P connector from E.V. Remove 6P connector from R


cover Assy and measure the louver Assy and measure the
thermistor resistance between thermistor resistance between
3 and 4 . 5 and 6 .

NO NO
NG? NG?

YES YES

Replace F-thermistor. Replace R-thermistor.

Replace main PWB. Replace main PWB.

7–3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

[3] 03 / 63 [5] 07

(Defrosting diagnosis)
(DEF-thermistor system diagnosis)

Turn power OFF. After approx. 30 sec.,


open door and re-energize.
(Buzzer beeps continuously)
Power OFF

Forced defrosting (Measurement is impossible when


DEF-thermistor is set at 10°C or higher because
defrosting ends immediately)
10

After approx. 15 sec., the voltage


5.8 measured across 8 and 10 of CN5
YES
on the main PWB is equal to supplied
voltage? (e.g. 240 V)

NO NO
NG?

YES Replace main PWB.

Remove 6P connector from E.V.


cover Assy and measure the Disconnect CN5 from the main PWB. Measure the
thermistor resistance between resistance between 8 and 10 of CN on the wiring.
5 and 6 .

approx. 280 NO
NO (defrost heater 170~190W)
NG?
YES
Between 6P connector 2 and NO
YES 4P connector 1 ( white line) on
Check cause of defrosting failure E.V. cover Assy is carrying current?
· Check door packing
Replace DEF-thermistor. · Check mounting seal of E.V. cover Assy YES
Replace fuse Assy.

Resistance of 4P connector between NO (Open)


Replace main PWB. 1 and 2 on E.V. cover K is normal? (331 )

YES
Check defrost heater wiring for loose
Replace defrost heater.
connection or disconnection.

[4] 04 / 64

(Outside temperature - thermistor system diagnosis)

Replace Main-PWB.

Outside
temperature thermistor
is installed on
Main-PWB ass'y.

7–4
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

[6] 08 / 66 [7] 11

(Fan motor system diagnosis) (Ionizer system diagnosis)

Under compressor operating,


close the door switch and of CN9 on the main PWB
are positively engaged? NO

YES
Fan motor NO
rotates?

YES 1 and 2 of 2P connector on R


NO
louver Assy are positively engaged?
Check cause of defrosting
failure
· Dislocation of fan YES
· Check door packing
· Installation of E.V. cover Assy Insert connector.
· Defective seal
Replace Plasmacluster.

Fan locked ?

YES

Check position of fan.

Replace Fan motor or main PWB. [8] 12

(LED system diagnosis)

CN8 on the main PWB is positively


engaged? NO

YES

3P connector on LED control panel


is positively engaged?
NO

YES

Insert connector.

Replace LED-PWB Ass'y.

7–5
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 8. MODE FOR DISPLAY (Only for
SJPT56RHS
SJ-PT56R)
Service Manual

F
R R

button

1. Entering method of the mode

Within 2 minutes after main power input, press the [ ] button over 3 seconds at the opening condition of the refrigerating room door.

2. Release of the mode

Press the [ ] button over 3 seconds at the opening condition of the refrigerating room door.
(Even without the above operation, release can be made by main power OFF.)

3. Movement in the mode


1) Compressor, fan motor, heater and Plasmacluster are stopped.
2) Damper is always made [CLOSE] condition.
3) Indoor lamp is lit when door is open.
4) LED display
• Temperature will be displayed in turn automatically.
5) Door alarm is operated only for freezer room door.

8–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 9. ASSEMBLING PROCEDURES
SJPT56RHS
OF MAIN
Service ManualPARTS AND CAUTIONS
CAUTION: DISCONNECT THE UNIT FROM THE POWER SUPPLY BEFORE ANY REPAIRING.

[1] FAN LOUVER AND E.V COVER ASSEMBLY


1. How to remove the Fan louver
1) Take out 2 screws with screw driver.
2) Pull the Fan louver toward yourself to take off.

Fan louver

Screw

Screw

Figure A-1

2. E.V cover assembly


2) Insert terminal F-Thermistor and Def-thermistor in the housing.
1) Stick E.V cover sealer d to F fan motor. (Figure A-2) (Figure A-3)

OVER LAP
EV cover sealer d YLP-06V-B (VO)
F-THERMISTOR
DEF-THERMISTOR
F fan motor FUSE ASS’Y
F-THERMISTOR

DEF-THERMISTOR

Figure A-2 Figure A-3


3) Stick E.V cover sealer a and c to E.V cover. (Figure A-4)

E.V cover sealer a E.V cover sealer a

E.V cover sealer a

E.V cover

E.V cover sealer c

ABOUT THE SAME

Figure A-4

9–1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
4) Set Fan motor, F-thermistor, Def-thermistor, Fuse ass'y in the EV cover and stick Al tape. (Figure A-5)

F-thermistor
F fan motor Def-thermistor

Fuse ass’y

STICK AL TAPE

SEC. AA

AL TAPE (T40 *W30*52L)

Figure A-5
5) Set the Deodorizer to the Fan louver.(Only for SJ-PT56R)

Fan louver Deodorizer

Figure A-6

9–2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[2] R CONTOROL COVER ASSEMBLY (SJ-PT56R)
1) Stick Ra sealer c and Ra sealer d to R air guider b. Ra sealer d R air guider b

2) Insert Deodorizer to R air guider b.(Figure A-7)


R air guider b

Deodorizer
Ra sealer C

Figure A-7

3) Insert R air guider b to R air guider a. 8) Insert 7) ass'y 5) ass'y.


4) Fix 2) ass'y with paper tape (Figure A-8) 9) Fix 8) ass'y with paper tape.
5) Stick Ra-sealer a ,i,h,f,g U-sealer insu.b, and discharge sealer to 3) 10)Stick A-sealer rc-d to Damper ass'y.(Figure A-10)
ass'y. 11)Insert Damper harness to Damper ass'y.
6) Connect Plasma holder and connector of R-PLharness.
12)Insert 11) ass'y to 9) ass'y.
(Figure A-9)
13)Stick A-sealer damper to 12) ass'y.
7) Insert 6) ass'y to Plasma holder. 14)Fix 13) ass'y with paper tape.

Paper Tape
㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕

U-sealer insu.b Paper Tape


㧔㨃㧟㧜˜㧝㧜㧜㨙㨙㧕
Paper Tape
Ra sealer h 㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕
Ra sealer f Paper Tape
Ra sealer A 㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕

Ra sealer I Damper Ass'y

R air guider a Paper Tape


Paper Tape Paper Tape A sealer damper 㧔㨃㧟㧜˜㧞㧝㧜㨙㨙㧕
㧔㨃㧟㧜˜㧝㧤㧜㨙㨙㧕 㧔㨃㧟㧜˜㧞㧜㧜㨙㨙㧕 Paper Tape Plasma holder
Paper Tape 㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕 Ionizer-k Damper Ass'y
㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕 A
B Ra sealer a

Discharge sealer R-PL


Harness

Ra sealer h Ra sealer g

A SEC.AA
B
Paper Tape Ra sealer f R air guider a SEC.BB
Ra sealer f 㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕 Paper Tape
㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕 Paper Tape
㧔㨃㧟㧜˜㧝㧡㧜㨙㨙㧕

R air guider a

Back side
U-sealer insu.b R air guider a Ra sealer l
R air guider b

Ra sealer a Ra sealer h

Ra sealer f

Figure A-8

9–3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

Connect IONIZER-K and connectorof R-PL harness Stick A-sealer rc-d to Damper ass'y
Insert Damper Harness to Damper ass'y

A-sealer RC-d
Plasma holder Plasma holder R-PLharness
Damper ass'y

Connect should be inserted surely.

R-PLharness
Plasma holder
Damper Harness
A-sealer RC-d

Figure A-9 Figure A-10

15)Fix R LED PWB L ass'y to R-c box cover with tapping screw.
16)Insert the R-pl harness to 15) ass'y, and fix it to R-c box cover with paper tape.
17)Fix R-thermistor to R-c box cover,and stick R-thermistor sealer.
18)Stick Mask label to 17) ass'y.
19)Insert 14) ass'y to 18) ass'y.
20)Fix Lamp cover to 19) ass'y.

R-C BOX-E

Figure A-11

Tapping screw R Air guider a


Paper tape R-C Box Cover R Led Lamp Pwb L Ass'y R-Thermistor R Air guider b
R-Thermistor R-PL Harness (30 x 60 mm)
Sealer

R Led Lamp Pwb L Ass'y

R-Thermistor Mask Label R-C Box Cover

Figure A-12

9–4
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[3] R CONTOROL COVER ASSEMBLY (SJ-T52R/T56R)
1) Stick Ra sealer c and Ra sealer d to R air guider b. Ra sealer d R air guider b
2) Insert Deodorizer to R air guider b. (Figure A-13)
R air guider b

Deodorizer
Ra sealer c

Figure A-13

3) Insert R air guider b to R air guider a. 7) Stick A-sealer rc-d to Damper ass'y. (Figure A-15)
4) Insert R air guider c to 3)ass'y. 8) Insert Damper harness to Damper ass'y.(Figure A-15)
5) Fix 4) ass'y with paper tape. (Figure A-14) 9) Insert 8) ass'y to 6) ass'y.
6) Stick Ra-sealer a,i,h,f,g,U-sealer insu.b ,and Discharge sealer to 10)Stick A-sealer damper to 9) ass'y.
4)ass'y.

Paper Tape
(W30x150mm)

Paper Tape
Paper Tape (W30x100mm)
Ra sealer f
(W30x150mm)
U-sealer insu.b Paper Tape
Ra sealer a (W30x150mm)

Ra sealer I

Paper Tape
Ra sealer I R air guider c (W30x210mm)
Dapmer Harnes
R air guider a Paper Tape A sealer damper
Paper Tape (W30x180mm) Paper Tape Dapmer Ass'y
(W30x150mm) (W30x150mm)

Discharge sealer

Ra sealer h Ra sealer g

Ra sealer a
Paper Tape Paper Tape
Ra sealer f (W30x150mm) Ra sealer a (W30x150mm)

Back side
U-sealer insu.b Ra sealer l
R air guider b R air guider a

Ra sealer a Ra sealer h

Ra sealer f

Figure A-14

Stick A-sealer rc-d to Damper ass'y


A-sealer rc-d Insert Damper harness to Damper ass'y

Damper ass'y
A-sealer rc-d

Damper harness

Figure A-15

9–5
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
11)Fix 10) ass'y with paper tape. 19)Insert Lamp harness to 18)ass'y.
12)Fix VR PWB ass'y to R-C box cover. 20)Fix 19)ass'y to R-C box cover..
13)Insert Control knob to 12) ass'y. 21)Fix R-thermistor to R-C box cover.
14)Fix 13) ass'y with Waterproof tape. 22)Stick R-thermistor sealer to R-C box cover.
15)Fix 14) ass'y with PWB sheet 55DR. 23)Stick Warning label to R-C box AL sheet.
16)Fix Lamp ass'y to R lamp holder. 24)Fix 24) ass'y with paper tape.
17)Fix 16)ass'y to Tapping screw. 25)Insert 11) ass'y to 25) ass'y.
18)Insert R-C box AL sheet to R-C box cover
After putting in two notches hole bent it 90

Insert of pin
PL process
PWB sheet 55DR
VR PWB ass’y Note
Pins should be insert surely,
and check by pulling it.

R-thermistor

Control knob
Control knob

B
PWB sheet 55DR

VR PWB ass’y

Rc box AL sheet
Control knob

R lamp holder R Lamp Holder R sir guider a


Paper Tape
Tapping screw Rc box cover Lamp Ass'y
R Thermistor sealer
(30x60mm) R sir guider b
Lamp harness Rc box AL sheet R-thermistor

C
A

Paper Tape Rc box AL sheet


(30x30mm)
PWB Sheet Control label Contorol Knob warning label
Paper Tape VR PWB 55DR
(30x30mm) Ass'y Lamp Ass'y
R Lamp Holder
R Thermistor sealer Rc box cover

Figure A-16

9–6
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[4] R SHOWER DUCT ASSEMBLY
1. Fix R-shower ins. a to R shower duct.

R shower duct

R-shower ins.a

Figure A-17
2. Stick A-sealer R-shower-d to “1” ass'y. (Figure A-18)
3. Fix Al panel to “2” ass'y. (Figure A-19)

R-shower ins.a

R-shower duct

A-sealer
R-shower-d R-shower ins.a

Al panel

A-sealer
R-shower-d

* One of the A-sealer R-shower-d is divided into 6 pieces


and the other is not divided.

Figure A-18 Figure A-19

9–7
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[5] DEFROST HEATER ASSEMBLY 2. Replacement of Def. heater ass’y.
1. Take off the Drain support al from the food liner.
1. Taking-out Evaporator
1. Take-out Fan louver.
Drain support al
2. Take-out E.V cover ass’y.

E vaporator

Figure A-23
F ood liner convex part
2. Raise the protrusion part of Drain support al.
Then remove Heater cover.
Figure A-20
3. As shown in Figure A-20, pull the upper part of Evaporator toward
you, pull it diagonally so that the pipe of Evaporator does not con- Protrusion part
tact the convex part of food liner.

Food liner convex part

Evaporator Drain support al

Pipe

Heater cover

Protrusion part of Drain support al (2 pcs.)

Figure A-21
4. Pull the Evaporator for remove as shown in Figure-21. Def. heater ass'y
NOTE: When pulling Evaporator and bending the pipes,pay attention
so as not to break and deform the pipes. Still, take care not to
hurt yourself by fin of Evaporator. Heater cover

Figure A-24
3. Open Def.heater fixed part of Drain support al to the right and left,
then remove Def.heater ass’y.

Fixed parts

Evaporator

Figure A-22

Drain support al

Def. heater ass'y

Figure A-25

9–8
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
4. Replace Def. heater ass’y with new one.

Heater cover

Def. heater ass'y

Drain support al

Figure A-26
5. Bend the end of Drain support 90.

Drain support al

Figure A-27
6. Aseemble Defrost heater to Drain support al.
7. Assemble Heater cover to Drain support al. Bend top edge to outside.
8. Stick the Vinyl tape on the Lead wire of Defrost heater ass'y.

Drain support al

Figure A-28

3. Installing of Evaporator
1. Install Evaporator as shown in the Figure A-20 in the reverse order of Figure A-21
2. Correct the defromed fin.
NOTE: 1. When installing Evaporator, take care not to deform significantly and break the pipes.
2. Take care not to damage the lead wires and hurt yourself by the fin of Evaporator.
3. You shouldn’t touch Defrost heater with your bare hand. (You should wear pure gloves.)
4. You should wipe that with alcohol. When you touch Defrost heater with your bare hand.

9–9
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
CHAPTER 10. COOLING UNIT
SJPT56RHS
Service Manual

[1] COOLING UNIT

Mark: Refrigerant flow


Mark: Brazing portion(copper to copper)
Mark: Brazing portion(steel to copper)

Hot pipe R Hot pipe Hot pipe L


(Side condenser) (DP-condenser) (Side condenser)

Back condenser

Evaporator

Suction pipe

Discharge P connector
Eva pan pipe ass’y

S.P connector
Charge pipe
Compressor
Charge pipe

Capillary tube
Dryer
Dryer
Connector

10 – 1
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[2] LOCATION
1. Location 1

Dryer
Capillary tube Dryer connector

Hot pipe

Back condenser
Charge pipe
Evaporator

Charge pipe L

Suction pipe S.P Discharge


connector Eva pan pipe ass’y
P connector
Compressor

Mark shows pinch points

Mark shows welding points (copper to copper)

Mark shows welding points (steel to copper)

2. Location 2

Discharge P. connector
Eva pan pipe ass'y to Eva pan pipe ass'y Pinch Point
to Back condenser (inlet)

Dryer connector
to Dryer
Charge pipe
to Dryer

Hot pipe (outlet)


to Dryer connector
Pinch point

Dryer
to Capillary tube

S.P connector
to Suction pipe
Charge pipe
Back condenser S.P. connector Compressor’s discharge pipe to compressor’s
to Hot pipe to compressor’s to Discharge P. connector process tube
suction pipe

10 – 2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

10 – 3
Downloaded from www.Manualslib.com manuals search engine
PartsGuide
SJPT56RHS

PARTS GUIDE
Refrigerator-freezer
MODELS
SJ-PT56R-HS
SJ-T52R-S
SJ-T56R-S

SJ-PT56R SJ-T56R

CONTENTS

[1] SJ-PT56R-HS CYCLE PARTS [6] SJ-T52R/T56R-HS CYCLE PARTS

[2] SJ-PT56R-HS MECHANIAL PARTS [7] SJ-T52R/T56R-HS MECHANIAL


PARTS
[3] SJ-PT56R-HS DOOR PARTS
[8] SJ-T52R/T56R-HS DOOR PARTS
[4] SJ-PT56R-HS ATTACHMENT
PARTS [9] SJ-T52R/T56R-HS ATTACHMENT
PARTS
[5] SJ-PT56R-HS OTHER PARTS
[10] SJ-T52R/T56R-HS OTHER PARTS
[]
 INDEX

This document has been published to be used


for after sales service only.
The contents are subject to change without notice.
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[1] SJ-PT56R-HS CYCLE PARTS

6-32

6-31 6-16

6-14

2-70

6-11
6-19
6-12
6-18
6-5 4-17
6-1
6-18 1-11 2-87
2-78
6-3
6-2
6-29

1-12

1-9
2-71 6-9

1-31 4-11
1-22 4-10

4-1 4-2 2-81

1-32 2-83 4-15


1-52 1-35
2-80

2-82

1-36 2-77 1-61

6-4

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[1] SJ-PT56R-HS CYCLE PARTS


1-9 QACC-A160CBZZ AP Source cord
1-11 RHOG-A251CBZZ AZ Protector
1-12 RSTT-A219CBZZ AZ Ptc relay
1-22 FCNW-B019CBKZ AT Relay cord s ass'y
1-31 RC-EZA198CBZZ AZ Capacitor
1-32 QCNW-B021CBZZ AC Reray wire rc
1-35 QCNW-B295CBZZ AM Emi earth 2pin cr
1-36 QCNW-B283CBZZ AG Pwb earth wire
1-52 FPWB-A511CBKZ AY Main pwb ass'y
1-61 RCILFA011CBZZ AV Emi core esd-r-38
2-70 USRA-A313CBFA AP Drain pan
2-71 LHLD-A797CBFZ AE Ev.pan holder
2-77 LHLD-A359CBFA AE T-box holder
2-78 LPLTMA399CBP0 AD Dryer support
2-80 PBOX-A164CBFA AM Terminal box
2-81 PCOV-A396CBPZ AF Terminal cover
2-82 PCOVMA005CBYZ AF Terminal box cover
2-83 PSHEPA084CBZZ AG Terminal sheet
2-87 LBND-A018CBE0 AP Fastening band a
4-1 LBND-A023CBE0 AC L-band c
4-2 LBND-A019CBE0 AB Nylon band
4-10 QTAN-A013CBE0 AH Solderless term. A
4-11 QTAN-A012CBE0 AH Solderless term. B
4-15 LX-BZA090CBZZ AC Special screw

2
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK

[1] SJ-PT56R-HS CYCLE PARTS


4-17 LX-WZA035CBZZ AB Washer
6-1 PCMPLA371CBZZ CB Compressor
6-2 PSPAGA080CBZZ AK Rubber grommet
6-3 PSPAFA047CBEZ AE Sleeve
6-4 FFRM-A152CBKZ AH Base frame ass'y
6-5 FDRY-A006CBK0 AX Dryer ass'y
6-9 PCOVPA271CBEZ AH Terminal cover
6-11 PPIPCA624CBZZ AM S.p connector
6-12 PPIPCA625CBZZ AL Discharge connector
6-14 PGUM-A004CBF0 AH Absorbent rubber a
6-16 PGUM-A003CBF0 AH Absorbent rubber b
6-18 PPIPCA252CBE0 AD Charge pipe
6-19 PPIPCA551CBZZ AF Drier connector
6-29 LHLD-A465CBE0 AG Cord clip
6-31 FPIPCA307CBKZ AN Eva pan pipe s ass'y
6-32 LANG-A058CBPZ AC Absorbent rubber clm

3
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[2] SJ-PT56R-HS MECHANIAL PARTS

2-61

1-3
1-1

2-64
1-6

1-17
2-11
2-63
2-13

2-68 2-109 2-12


2-60
2-37
1-51

2-110 6-8

1-50
2-53 2-51
2-50
2-2 2-18 2-66
1-21
2-67

2-15

2-41 1-53 2-40


2-42
2-43 2-46

2-442-45 2-47 2-16

2-26 1-10

2-106
2-1
2-29
2-102
2-108
2-103
2-25 2-14
2-107 2-105 1-45
1-57
2-21 2-24

2-104 1-4

2-36 2-101
1-55

1-60
2-23
2-49
1-2
2-52

2-48 2-20
2-35

2-7 2-7-2
2-34 2-8
2-7-1

2-33 2-38

2-8-2
2-31 2-7-1

2-39

4
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[2] SJ-PT56R-HS MECHANIAL PARTS


1-1 RH-HXA104CBZZ AZ F-thermistor
1-2 RH-HXA103CBZZ AZ R-thermistor
1-3 RH-HXA105CBZZ AZ Def-thermistor
1-4 DTHM-A043CBKZ AX Damper ass'y
1-6 RMOTRA096CBZZ BE F fan motor
1-10 QSW-PA097CBZA AG Door switch
1-17 FFS-TA127CBKZ Fuse ass'y
1-21 FHETBA224CBZZ AP Def. Heater ass'y
1-45 FTRN-A014CBKZ AZ Ionaizer-k
1-50 LHLD-A801CBFA AE F-lamp holder
1-51 DPWB-A135CBKZ AY Led lamp pwb l ass'y
1-53 FPWB-A499CBKZ BG Led pwb ass'y
1-55 QCNW-B371CBZZ AL R-pl harness(51/55)
1-57 QCNW-B258CBZZ AP Damper harness
1-60 DPWB-A150CBKZ AY Rled lamp pwb l assy
2-1 GCOVPA237CBRA AU Control panel
2-2 GCOVPA279CBFA AF C-hinge slit cover
2-7 FLEGPA077CBKZ AQ Leg holder l ass'y
2-7-1 FAJS-A013CBK0 AE Adjustable leg ass'y
2-7-2 LHLD-A533CBPZ AL Leg holder l
2-8 FLEGPA078CBKZ AQ Leg holder r ass'y
2-8-2 LHLD-A534CBPZ AP Leg holder r
2-11 GCOV-A310CBFA AE Upper hinge cover
2-12 GCOV-A192CBFH AE Top cover
2-13 DHNG-A602CBMZ AG Upper hinge r ass'y
2-14 DHNG-A636CBMZ AG Bottom hinge r ass'y
2-15 DHNG-A686CBMZ AG Center hinge rt assy
2-16 DHNG-A687CBMZ AF Center hinge rb assy
2-18 LHLD-A825CBPZ AE C-box angler
2-20 GCOVPA277CBFA AR R-c box cover
2-21 LHLD-A714CBFZ AR Plasma holder
2-23 PGID-A206CBFZ AH R air guider a
2-24 PGID-A207CBFZ AH R air guider b
2-25 PSEL-C669CBZZ AD A-sealer rc-d
2-26 PSEL-E092CBZZ AE Ra sealer a
2-29 PSEL-C958CBZZ AH A-sealer damper
2-31 LPLTMA847CBPZ AH Al panel
2-33 MLOV-A064CBFA AR R shower duct
2-34 PGID-A210CBFZ AG R-shower ins.a
2-35 PSEL-E097CBZZ AE A-sealer r-shower-d
2-36 PFIL-A047CBEZ AC Deodorizer
2-37 PFIL-A050CBEZ AM Deodorizer
2-38 GCOVPA234CBFA AE Leg cover l
2-39 GCOVPA235CBFA AE Leg cover r
2-40 LSTPPA161CBFA AE Case stopper
2-41 JBTN-A045CBRA AF Button fr
2-42 JBTN-A046CBRA AF Button dw
2-43 JBTN-A047CBRA AF Button up
2-44 JBTN-A048CBRA AF Button dc
2-45 JBTN-A049CBRA AF Button pl
2-46 LHLD-A802CBFA AE Led pwb holder
2-47 GDAI-A084CBTA AU Control box base
2-48 TLAB-B605CBRA AE Mask label
2-49 PSEL-D085CBZZ AD R thermistor sealer
2-50 HGRL-A269CBFA AU Fan louver
2-51 PCOV-A391CBRB AK F lamp cover
2-52 PCOV-A392CBRB AK R lamp cover
2-53 GCOVAA056CBFA AE Screw cover
2-60 GCOV-A311CBFZ AS E.v cover
2-61 PSEL-C959CBZZ AE E.v cover sealer a
2-63 PSEL-C961CBZZ AH E.v cover sealer c
2-64 PSEL-C601CBZZ AE Ev-cov.sealer c
2-66 PSHEMA341CBPZ AG Heater cover
2-67 LPLTMA819CBPZ AF Drain support
2-68 GCOVPA239CBFB AT Ev terminal cover
2-101 PSEL-E104CBZZ AE Ra sealer c
2-102 PSEL-E052CBZZ AE Ra sealer d
2-103 PSEL-E053CBZZ AE Discharge sealer
2-104 PSEL-E095CBZZ AF Ra sealer f
2-105 PSEL-E103CBZZ AE Ra sealer g
2-106 PSEL-E107CBZZ AF Ra sealer h
2-107 PSEL-E108CBZZ AF Ra sealer i
2-108 PSEL-C948CBZZ AE U-sealer insu b
2-109 PFPFPC008CBFZ AE E.v cover insu.a
2-110 PSEL-E193CBZZ AF Fan louver sealer a
6-8 PEVA-A225CBZZ Evaporator

5
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[3] SJ-PT56R-HS DOOR PARTS
3-4
3-2
3-8
3-10 3-31 3-1
3-22

3-6

3-3

3-10 3-21 3-30


3-22

3-7
3-9
3-31
3-1-1
3-5
3-4 3-1-2

3-8
3-10 3-31
3-22 3-20

3-6

3-11-3

3-11
3-13

3-10
3-22

3-7
3-9
3-31
3-12
3-5
3-11-1
3-11-4

3-11-2

6
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[3] SJ-PT56R-HS DOOR PARTS


3-1 FDORFB986CBKZ BR F-door ass'y
3-1-1 LSTPMA028CBMZ AE F-door stopper r
3-1-2 LSTPPA158CBFA AE Fd-stopper spring r
3-2 FPACGA519CBKZ AY F-door packing
3-3 JHNDPA285CBPZ AQ F door handle
3-4 HDECQA544CBTA AF Hd cover t
3-5 HDECQA545CBTA AF Hd cover b
3-6 LPLTPA478CBTA AH Hd base t
3-7 LPLTPA479CBTA AH Hd base b
3-8 LPLTPA480CBPZ AF Hd support t
3-9 LPLTPA481CBPZ AF Hd support b
3-10 LX-BZA112CBZZ AD Handle screw 5x20
3-11 FDORRB891CBKZ BS R-door ass'y
3-11-1 LSTP-A064CBMZ AE R-door stopper r
3-11-2 LSTPPA159CBFA AE Rd-stopper spring r
3-11-3 NBRGPA022CBFA AC Nylon bearing 3s
3-11-4 LPLTMA846CBMZ AF Rd-support
3-12 FPACGA520CBKZ AZ R-door packing
3-13 JHNDPA286CBPZ AQ R door handle
3-20 PCAP-A055CBFF AE Bearing cap
3-21 HBDGDB043CBJA AP Badge
3-22 GCOVAA052CBTA AE Screw cover
3-30 PPACGA268CBZA AL F-sub. Packing
3-31 PCUS-A014CBZZ AD Hd-support cushion

7
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[4] SJ-PT56R-HS ATTACHMENT PARTS

5-12

5-1 5-13

5-14 5-11

5-3

5-16

5-4 5-15

5-6
5-17

5-7
5-8

5-19

5-18
5-5
5-7

5-20

5-9

5-22

5-10

5-3
5-21

8
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[4] SJ-PT56R-HS ATTACHMENT PARTS


5-1 FPOK-A277CBKZ AS F-door pocket ass'y
5-3 UPOKPA308CBFB AN Rf door pocket
5-4 GDORPA086CBRB AM R door pocket cover
5-5 UPOKPA340CBFB AK Utility pocket
5-6 UPOKPA310CBFB AP R door pocket
5-7 UTNA-A282CBFC AF Egg tray
5-8 UPOKPA314CBFB AM Utility pocket l
5-9 UPOKPA312CBFB AT Bottle pocket
5-10 UPOKPA251CBFE AG Tube stand
5-11 UTNA-A450CBFB AR F shelf s
5-12 UTNA-A449CBFB BA F shelf
5-13 FSRA-A273CBYZ AR Ice cube maker
5-14 UYOK-A579CBFB AN Ice storage box
5-15 GDORPA085CBFB AN Fresh door
5-16 UYOK-A577CBFB AY Fresh case
5-17 FTNA-A512CBKZ AY R glass shelf ass'y
5-18 FTNA-A465CBKZ AY R glass shelf sf asy
5-19 FTNA-A466CBKZ AY R glass shelf sb asy
5-20 FTNA-A510CBKZ AY V glass shelf ass'y
5-21 UYOK-A578CBFB AY Vegetable case
5-22 LSTYPA047CBFA AN Partition v
[5] SJ-PT56R-HS OTHER PARTS
1-32 QCNW-B021CBZZ AC Reray wire rc
90-1 TINS-B160CBRZ AS Operation manual
90-3 SPAKCA611CBZZ BD Packing case 55cr-f-2
90-6 CPADBA108CBKZ BA Bottom pad ass'y
90-7 CPADBA109CBKZ AP Top pad ass'y
90-19 TINS-A366CBR0 AC Srv.station list
90-20 FGAN-A070CBR0 AD Warranty card scot

9
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[6] SJ-T52R/T56R-HS CYCLE PARTS
6-32

6-31 6-16

6-14

2-70

6-11
6-19
6-12
6-18
6-5 4-17
6-1
6-18 1-11 2-87
2-78
6-3
6-2
6-29

1-12

1-9
6-9
2-71
4-11
1-22 4-10
1-31

4-1 2-81
2-83
1-32 2-80 1-52

2-82

1-36 2-77
4-15
1-39

6-4

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[6] SJ-T52R/T56R-HS CYCLE PARTS


1-9 QACC-A160CBZZ AP Source cord
1-11 RHOG-A251CBZZ AZ Protector
1-12 RSTT-A219CBZZ AZ Ptc relay
1-22 FCNW-B019CBKZ AT Relay cord s ass'y
1-31 RC-EZA198CBZZ AZ Capacitor
1-32 QCNW-B021CBZZ AC Reray wire rc
1-36 QCNW-B283CBZZ AG Pwb earth wire
1-39 QCNW-A887CBE0 AG Earth wire
1-52 FPWB-A513CBKZ BK Main pwb ass'y
2-70 USRA-A313CBFA AP Drain pan
2-71 LHLD-A797CBFZ AE Ev.pan holder
2-77 LHLD-A359CBFA AE T-box holder
2-78 LPLTMA399CBP0 AD Dryer support
2-80 PBOX-A164CBFA AM Terminal box
2-81 PCOV-A396CBPZ AF Terminal cover
2-82 PCOVMA005CBYZ AF Terminal box cover
2-83 PSHEPA084CBZZ AG Terminal sheet
2-87 LBND-A018CBE0 AP Fastening band a
4-1 LBND-A023CBE0 AC L-band c
4-10 QTAN-A013CBE0 AH Solderless term. A
4-11 QTAN-A012CBE0 AH Solderless term. B
4-15 LX-BZA090CBZZ AC Special screw
4-17 LX-WZA035CBZZ AB Washer
6-1 PCMPLA371CBZZ CB Compressor

10
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
NO. PARTS CODE PRICE NEW PART DESCRIPTION
RANK MARK RANK

[6] SJ-T52R/T56R-HS CYCLE PARTS


6-2 PSPAGA080CBZZ AK Rubber grommet
6-3 PSPAFA047CBEZ AE Sleeve
6-4 FFRM-A153CBKZ AK Base frame ass'y
6-5 FDRY-A006CBK0 AX Dryer ass'y
6-9 PCOVPA271CBEZ AH Terminal cover
6-11 PPIPCA624CBZZ AM S.p connector
6-12 PPIPCA625CBZZ AL Discharge connector
6-14 PGUM-A004CBF0 AH Absorbent rubber a
6-16 PGUM-A003CBF0 AH Absorbent rubber b
6-18 PPIPCA252CBE0 AD Charge pipe
6-19 PPIPCA551CBZZ AF Drier connector
6-29 LHLD-A465CBE0 AG Cord clip
6-31 FPIPCA307CBKZ AN Eva pan pipe s ass'y
6-32 LANG-A058CBPZ AC Absorbent rubber clm

11
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[7] SJ-T52R/T56R-HS MECHANIAL PARTS

2-61

1-3
1-1

2-64
1-6

1-17
2-63 2-11

2-13

2-68 2-109
2-60

2-110 6-8

2-53 2-51
2-50
2-66
1-21
2-54
2-67
2-55

2-15

2-40
2-26 2-55
2-106
1-10
2-29
2-102
2-108
2-103
2-105 2-25
2-107
1-57
2-24
1-7 2-14
2-22
2-104 1-4
1-55
2-30
2-36 2-101

2-89
2-23
1-54
2-19 2-49
2-52 90-2
1-58
1-2

2-88 2-20

2-35
90-31

2-7 2-7-2
2-34 2-8
2-7-1

2-33 2-38

2-8-2
2-31 2-7-1

2-39

12
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[7] SJ-T52R/T56R-HS MECHANIAL PARTS


1-1 RH-HXA104CBZZ AZ F-thermistor
1-2 RH-HXA103CBZZ AZ R-thermistor
1-3 RH-HXA105CBZZ AZ Def-thermistor
1-4 DTHM-A043CBKZ AX Damper ass'y
1-6 RMOTRA096CBZZ BE F fan motor
1-7 FLMP-A005CBZZ AL Lamp ass'y
1-10 QSW-PA097CBZA AG Door switch
1-17 FFS-TA127CBKZ Fuse ass'y
1-21 FHETBA224CBZZ AP Def. Heater ass'y
1-54 FPWB-A554CBKZ AY Vr pwb ass'y
1-55 QCNW-B270CBZZ AH Lamp harness
1-57 QCNW-B258CBZZ AP Damper harness
1-58 QCNW-B304CBZZ AK Control harness
2-7 FLEGPA077CBKZ AQ Leg holder l ass'y
2-7-1 FAJS-A013CBK0 AE Adjustable leg ass'y
2-7-2 LHLD-A533CBPZ AL Leg holder l
2-8 FLEGPA078CBKZ AQ Leg holder r ass'y
2-8-2 LHLD-A534CBPZ AP Leg holder r
2-11 GCOV-A310CBFE AE Upper hinge cover
2-13 DHNG-A602CBMZ AG Upper hinge r ass'y
2-14 DHNG-A636CBMZ AG Bottom hinge r ass'y
2-15 DHNG-A611CBMZ AG Center hinge r ass'y
2-19 LPLTMA840CBPZ AE R-cbox al sheet
2-20 GCOVPA277CBFA AR R-c box cover
2-22 LHLD-A803CBFZ AG R lamp holder
2-23 PGID-A206CBFZ AH R air guider a
2-24 PGID-A207CBFZ AH R air guider b
2-25 PSEL-C669CBZZ AD A-sealer rc-d
2-26 PSEL-E092CBZZ AE Ra sealer a
2-29 PSEL-C958CBZZ AH A-sealer damper
2-30 PGID-A177CBFZ AG R air guider c
2-31 LPLTMA847CBPZ AH Al panel [T56R]
2-31 LPLTMA848CBPZ AH Al panel [T52R]
2-33 MLOV-A064CBFA AR R shower duct [T56R]
2-33 MLOV-A065CBFA AR R shower duct [T52R]
2-34 PGID-A210CBFZ AG R-shower ins.a [T56R]
2-34 PGID-A211CBFZ AG R-shower ins.a [T52R]
2-35 PSEL-E097CBZZ AE A-sealer r-shower-d [T56R]
2-35 PSEL-E099CBZZ AE A-sealer r-shower-d [T52R]
2-36 PFIL-A047CBEZ AC Deodorizer
2-38 GCOVPA234CBFA AE Leg cover l
2-39 GCOVPA235CBFA AE Leg cover r
2-40 LSTPPA161CBFA AE Case stopper
2-49 PSEL-D085CBZZ AD R thermistor sealer
2-50 HGRL-A269CBFA AU Fan louver
2-51 PCOV-A395CBRA AH F lamp cover
2-52 PCOV-A390CBFB AE R lamp cover
2-53 GCOVAA056CBFA AE Screw cover
2-54 PCAP-A077CBFA AA Screw cover
2-55 PCAP-A006CBFW AB Screw cover
2-60 GCOV-A311CBFZ AS E.v cover
2-61 PSEL-C959CBZZ AE E.v cover sealer a
2-63 PSEL-C961CBZZ AH E.v cover sealer c
2-64 PSEL-C601CBZZ AE Ev-cov.sealer c
2-66 PSHEMA341CBPZ AG Heater cover
2-67 LPLTMA819CBPZ AF Drain support
2-68 GCOVPA239CBFB AT Ev terminal cover
2-88 JKNB-A085CBFA AF Control knob
2-89 LPLTPA490CBZZ AE Pwb sheet 55dr
2-101 PSEL-E104CBZZ AE Ra sealer c
2-102 PSEL-E052CBZZ AE Ra sealer d
2-103 PSEL-E053CBZZ AE Discharge sealer
2-104 PSEL-E095CBZZ AF Ra sealer f
2-105 PSEL-E103CBZZ AE Ra sealer g
2-106 PSEL-E107CBZZ AF Ra sealer h
2-107 PSEL-E108CBZZ AF Ra sealer i
2-108 PSEL-C948CBZZ AE U-sealer insu b
2-109 PFPFPC008CBFZ AE E.v cover insu.a
2-110 PSEL-E193CBZZ AF Fan louver sealer a
6-8 PEVA-A225CBZZ Evaporator
90-2 TLAB-A874CBRZ AC Warning label
90-31 HPNLCA085CBRA Control label

13
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[8] SJ-T52R/T56R-HS DOOR PARTS
3-2

3-1

3-21 3-30

3-6
3-4

3-1-1

3-1-2

3-11

3-16
3-14

3-12
3-11-1
3-11-4

3-11-2

14
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[8] SJ-T52R/T56R-HS DOOR PARTS


3-1 FDORFC081CBKZ BR F-door ass'y
3-1-1 LSTPMA028CBMZ AE F-door stopper r
3-1-2 LSTPPA158CBFA AE Fd-stopper spring r
3-2 FPACGA519CBKZ AY F-door packing
3-4 HDECQA550CBTA AL Hd cover f
3-6 LPLTPA491CBFA AP Handle base f
3-11 FDORRC105CBKZ BT R-door ass'y [T56R]
3-11 FDORRC107CBKZ BT R-door ass'y [T52R]
3-11-1 LSTP-A064CBMZ AE R-door stopper r
3-11-2 LSTPPA159CBFA AE Rd-stopper spring r
3-11-4 LPLTMA846CBMZ AF Rd-support
3-12 FPACGA520CBKZ AZ R-door packing [T56R]
3-12 FPACGA521CBKZ AZ R-door packing [T52R]
3-14 HDECQA551CBTA AM Hd cover r
3-16 LPLTPA492CBFA AP Handle base r
3-21 HBDGDB043CBJA AP Badge
3-30 PPACGA268CBZA AL F-sub. Packing

15
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
[9] SJ-T52R/T56R-HS ATTACHMENT PARTS

5-12

5-1

5-14
5-13

5-3

5-16

5-15

5-6
5-17

5-8
5-17

5-5
5-7

5-20

5-9

5-22

5-10

5-3
5-21

16
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS

NO. PARTS CODE PRICE NEW PART DESCRIPTION


RANK MARK RANK

[9] SJ-T52R/T56R-HS ATTACHMENT PARTS


5-1 FPOK-A277CBKZ AS F-door pocket ass'y
5-3 UPOKPA308CBFB AN Rf door pocket
5-5 UPOKPA340CBFB AK Utility pocket
5-6 UPOKPA310CBFB AP R door pocket
5-7 UTNA-A282CBFC AF Egg tray
5-8 UPOKPA314CBFB AM Utility pocket l [T56R]
5-9 UPOKPA312CBFB AT Bottle pocket
5-10 UPOKPA251CBFE AG Tube stand
5-12 UTNA-A449CBFB BA F shelf
5-13 FSRA-A275CBYZ AR Ice cube maker
5-14 UYOK-A579CBFB AN Ice storage box
5-15 GDORPA085CBFB AN Fresh door
5-16 UYOK-A577CBFB AY Fresh case
5-17 FTNA-A506CBKZ BD R glass shelf ass'y
5-20 FTNA-A505CBKZ BE V glass shelf ass'y
5-21 UYOK-A578CBFB AY Vegetable case
5-22 LSTYPA047CBFA AN Partition v
[10] SJ-T52R/T56R-HS OTHER PARTS
90-1 TINS-B161CBRZ AS Operation manual
90-3 SPAKCA611CBZZ BD Packing case 55cr-f-2 [T56R]
90-3 SPAKCA613CBZZ BD Packing case 51dr-f-2 [T52R]
90-6 CPADBA108CBKZ BA Bottom pad ass'y
90-7 CPADBA109CBKZ AP Top pad ass'y
90-19 TINS-A366CBR0 AC Srv.station list
90-20 FGAN-A070CBR0 AD Warranty card scot

17
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
INDEX
PRICE NEW PART PRICE NEW PART
PARTS CODE No. PARTS CODE No.
RANK MARK RANK RANK MARK RANK

[ C ] " 7-2-68 AT
CPADBA108CBKZ 5-90-6 BA GCOVPA277CBFA 2-2-20 AR
" 10-90-6 BA " 7-2-20 AR
CPADBA109CBKZ 5-90-7 AP GCOVPA279CBFA 2-2-2 AF
" 10-90-7 AP GDAI-A084CBTA 2-2-47 AU
[ D ] GDORPA085CBFB 4-5-15 AN
DHNG-A602CBMZ 2-2-13 AG " 9-5-15 AN
" 7-2-13 AG GDORPA086CBRB 4-5-4 AM
DHNG-A611CBMZ 7-2-15 AG [ H ]
DHNG-A636CBMZ 2-2-14 AG HBDGDB043CBJA 3-3-21 AP
" 7-2-14 AG " 8-3-21 AP
DHNG-A686CBMZ 2-2-15 AG HDECQA544CBTA 3-3-4 AF
DHNG-A687CBMZ 2-2-16 AF HDECQA545CBTA 3-3-5 AF
DPWB-A135CBKZ 2-1-51 AY HDECQA550CBTA 8-3-4 AL
DPWB-A150CBKZ 2-1-60 AY HDECQA551CBTA 8-3-14 AM
DTHM-A043CBKZ 2-1-4 AX HGRL-A269CBFA 2-2-50 AU
" 7-1-4 AX " 7-2-50 AU
[ F ] HPNLCA085CBRA 7-90-31
FAJS-A013CBK0 2-2-7-1 AE [ J ]
" 7-2-7-1 AE JBTN-A045CBRA 2-2-41 AF
FCNW-B019CBKZ 1-1-22 AT JBTN-A046CBRA 2-2-42 AF
" 6-1-22 AT JBTN-A047CBRA 2-2-43 AF
FDORFB986CBKZ 3-3-1 BR JBTN-A048CBRA 2-2-44 AF
FDORFC081CBKZ 8-3-1 BR JBTN-A049CBRA 2-2-45 AF
FDORRB891CBKZ 3-3-11 BS JHNDPA285CBPZ 3-3-3 AQ
FDORRC105CBKZ 8-3-11 BT JHNDPA286CBPZ 3-3-13 AQ
FDORRC107CBKZ 8-3-11 BT JKNB-A085CBFA 7-2-88 AF
FDRY-A006CBK0 1-6-5 AX [ L ]
" 6-6-5 AX LANG-A058CBPZ 1-6-32 AC
FFRM-A152CBKZ 1-6-4 AH " 6-6-32 AC
FFRM-A153CBKZ 6-6-4 AK LBND-A018CBE0 1-2-87 AP
FFS-TA127CBKZ 2-1-17 " 6-2-87 AP
" 7-1-17 LBND-A019CBE0 1-4-2 AB
FGAN-A070CBR0 5-90-20 AD LBND-A023CBE0 1-4-1 AC
" 10-90-20 AD " 6-4-1 AC
FHETBA224CBZZ 2-1-21 AP LHLD-A359CBFA 1-2-77 AE
" 7-1-21 AP " 6-2-77 AE
FLEGPA077CBKZ 2-2-7 AQ LHLD-A465CBE0 1-6-29 AG
" 7-2-7 AQ " 6-6-29 AG
FLEGPA078CBKZ 2-2-8 AQ LHLD-A533CBPZ 2-2-7-2 AL
" 7-2-8 AQ " 7-2-7-2 AL
FLMP-A005CBZZ 7-1-7 AL LHLD-A534CBPZ 2-2-8-2 AP
FPACGA519CBKZ 3-3-2 AY " 7-2-8-2 AP
" 8-3-2 AY LHLD-A714CBFZ 2-2-21 AR
FPACGA520CBKZ 3-3-12 AZ LHLD-A797CBFZ 1-2-71 AE
" 8-3-12 AZ " 6-2-71 AE
FPACGA521CBKZ 8-3-12 AZ LHLD-A801CBFA 2-1-50 AE
FPIPCA307CBKZ 1-6-31 AN LHLD-A802CBFA 2-2-46 AE
" 6-6-31 AN LHLD-A803CBFZ 7-2-22 AG
FPOK-A277CBKZ 4-5-1 AS LHLD-A825CBPZ 2-2-18 AE
" 9-5-1 AS LPLTMA399CBP0 1-2-78 AD
FPWB-A499CBKZ 2-1-53 BG " 6-2-78 AD
FPWB-A511CBKZ 1-1-52 AY LPLTMA819CBPZ 2-2-67 AF
FPWB-A513CBKZ 6-1-52 BK " 7-2-67 AF
FPWB-A554CBKZ 7-1-54 AY LPLTMA840CBPZ 7-2-19 AE
FSRA-A273CBYZ 4-5-13 AR LPLTMA846CBMZ 3-3-11-4 AF
FSRA-A275CBYZ 9-5-13 AR " 8-3-11-4 AF
FTNA-A465CBKZ 4-5-18 AY LPLTMA847CBPZ 2-2-31 AH
FTNA-A466CBKZ 4-5-19 AY " 7-2-31 AH
FTNA-A505CBKZ 9-5-20 BE LPLTMA848CBPZ 7-2-31 AH
FTNA-A506CBKZ 9-5-17 BD LPLTPA478CBTA 3-3-6 AH
FTNA-A510CBKZ 4-5-20 AY LPLTPA479CBTA 3-3-7 AH
FTNA-A512CBKZ 4-5-17 AY LPLTPA480CBPZ 3-3-8 AF
FTRN-A014CBKZ 2-1-45 AZ LPLTPA481CBPZ 3-3-9 AF
[ G ] LPLTPA490CBZZ 7-2-89 AE
GCOV-A192CBFH 2-2-12 AE LPLTPA491CBFA 8-3-6 AP
GCOV-A310CBFA 2-2-11 AE LPLTPA492CBFA 8-3-16 AP
GCOV-A310CBFE 7-2-11 AE LSTP-A064CBMZ 3-3-11-1 AE
GCOV-A311CBFZ 2-2-60 AS " 8-3-11-1 AE
" 7-2-60 AS LSTPMA028CBMZ 3-3-1-1 AE
GCOVAA052CBTA 3-3-22 AE " 8-3-1-1 AE
GCOVAA056CBFA 2-2-53 AE LSTPPA158CBFA 3-3-1-2 AE
" 7-2-53 AE " 8-3-1-2 AE
GCOVPA234CBFA 2-2-38 AE LSTPPA159CBFA 3-3-11-2 AE
" 7-2-38 AE " 8-3-11-2 AE
GCOVPA235CBFA 2-2-39 AE LSTPPA161CBFA 2-2-40 AE
" 7-2-39 AE " 7-2-40 AE
GCOVPA237CBRA 2-2-1 AU LSTYPA047CBFA 4-5-22 AN
GCOVPA239CBFB 2-2-68 AT " 9-5-22 AN

18
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
PRICE NEW PART PRICE NEW PART
PARTS CODE No. PARTS CODE No.
RANK MARK RANK RANK MARK RANK
LX-BZA090CBZZ 1-4-15 AC " 7-2-35 AE
" 6-4-15 AC PSEL-E099CBZZ 7-2-35 AE
LX-BZA112CBZZ 3-3-10 AD PSEL-E103CBZZ 2-2-105 AE
LX-WZA035CBZZ 1-4-17 AB " 7-2-105 AE
" 6-4-17 AB PSEL-E104CBZZ 2-2-101 AE
[ M ] " 7-2-101 AE
MLOV-A064CBFA 2-2-33 AR PSEL-E107CBZZ 2-2-106 AF
" 7-2-33 AR " 7-2-106 AF
MLOV-A065CBFA 7-2-33 AR PSEL-E108CBZZ 2-2-107 AF
[ N ] " 7-2-107 AF
NBRGPA022CBFA 3-3-11-3 AC PSEL-E193CBZZ 2-2-110 AF
[ P ] " 7-2-110 AF
PBOX-A164CBFA 1-2-80 AM PSHEMA341CBPZ 2-2-66 AG
" 6-2-80 AM " 7-2-66 AG
PCAP-A006CBFW 7-2-55 AB PSHEPA084CBZZ 1-2-83 AG
PCAP-A055CBFF 3-3-20 AE " 6-2-83 AG
PCAP-A077CBFA 7-2-54 AA PSPAFA047CBEZ 1-6-3 AE
PCMPLA371CBZZ 1-6-1 CB " 6-6-3 AE
" 6-6-1 CB PSPAGA080CBZZ 1-6-2 AK
PCOV-A390CBFB 7-2-52 AE " 6-6-2 AK
PCOV-A391CBRB 2-2-51 AK [ Q ]
PCOV-A392CBRB 2-2-52 AK QACC-A160CBZZ 1-1-9 AP
PCOV-A395CBRA 7-2-51 AH " 6-1-9 AP
PCOV-A396CBPZ 1-2-81 AF QCNW-A887CBE0 6-1-39 AG
" 6-2-81 AF QCNW-B021CBZZ 1-1-32 AC
PCOVMA005CBYZ 1-2-82 AF " 5-1-32 AC
" 6-2-82 AF " 6-1-32 AC
PCOVPA271CBEZ 1-6-9 AH QCNW-B258CBZZ 2-1-57 AP
" 6-6-9 AH " 7-1-57 AP
PCUS-A014CBZZ 3-3-31 AD QCNW-B270CBZZ 7-1-55 AH
PEVA-A225CBZZ 2-6-8 QCNW-B283CBZZ 1-1-36 AG
" 7-6-8 " 6-1-36 AG
PFIL-A047CBEZ 2-2-36 AC QCNW-B295CBZZ 1-1-35 AM
" 7-2-36 AC QCNW-B304CBZZ 7-1-58 AK
PFIL-A050CBEZ 2-2-37 AM QCNW-B371CBZZ 2-1-55 AL
PFPFPC008CBFZ 2-2-109 AE QSW-PA097CBZA 2-1-10 AG
" 7-2-109 AE " 7-1-10 AG
PGID-A177CBFZ 7-2-30 AG QTAN-A012CBE0 1-4-11 AH
PGID-A206CBFZ 2-2-23 AH " 6-4-11 AH
" 7-2-23 AH QTAN-A013CBE0 1-4-10 AH
PGID-A207CBFZ 2-2-24 AH " 6-4-10 AH
" 7-2-24 AH [ R ]
PGID-A210CBFZ 2-2-34 AG RC-EZA198CBZZ 1-1-31 AZ
" 7-2-34 AG " 6-1-31 AZ
PGID-A211CBFZ 7-2-34 AG RCILFA011CBZZ 1-1-61 AV
PGUM-A003CBF0 1-6-16 AH RH-HXA103CBZZ 2-1-2 AZ
" 6-6-16 AH " 7-1-2 AZ
PGUM-A004CBF0 1-6-14 AH RH-HXA104CBZZ 2-1-1 AZ
" 6-6-14 AH " 7-1-1 AZ
PPACGA268CBZA 3-3-30 AL RH-HXA105CBZZ 2-1-3 AZ
" 8-3-30 AL " 7-1-3 AZ
PPIPCA252CBE0 1-6-18 AD RHOG-A251CBZZ 1-1-11 AZ
" 6-6-18 AD " 6-1-11 AZ
PPIPCA551CBZZ 1-6-19 AF RMOTRA096CBZZ 2-1-6 BE
" 6-6-19 AF " 7-1-6 BE
PPIPCA624CBZZ 1-6-11 AM RSTT-A219CBZZ 1-1-12 AZ
" 6-6-11 AM " 6-1-12 AZ
PPIPCA625CBZZ 1-6-12 AL [ S ]
" 6-6-12 AL SPAKCA611CBZZ 5-90-3 BD
PSEL-C601CBZZ 2-2-64 AE " 10-90-3 BD
" 7-2-64 AE SPAKCA613CBZZ 10-90-3 BD
PSEL-C669CBZZ 2-2-25 AD [ T ]
" 7-2-25 AD TINS-A366CBR0 5-90-19 AC
PSEL-C948CBZZ 2-2-108 AE " 10-90-19 AC
" 7-2-108 AE TINS-B160CBRZ 5-90-1 AS
PSEL-C958CBZZ 2-2-29 AH TINS-B161CBRZ 10-90-1 AS
" 7-2-29 AH TLAB-A874CBRZ 7-90-2 AC
PSEL-C959CBZZ 2-2-61 AE TLAB-B605CBRA 2-2-48 AE
" 7-2-61 AE [ U ]
PSEL-C961CBZZ 2-2-63 AH UPOKPA251CBFE 4-5-10 AG
" 7-2-63 AH " 9-5-10 AG
PSEL-D085CBZZ 2-2-49 AD UPOKPA308CBFB 4-5-3 AN
" 7-2-49 AD " 9-5-3 AN
PSEL-E052CBZZ 2-2-102 AE UPOKPA310CBFB 4-5-6 AP
" 7-2-102 AE " 9-5-6 AP
PSEL-E053CBZZ 2-2-103 AE UPOKPA312CBFB 4-5-9 AT
" 7-2-103 AE " 9-5-9 AT
PSEL-E092CBZZ 2-2-26 AE UPOKPA314CBFB 4-5-8 AM
" 7-2-26 AE " 9-5-8 AM
PSEL-E095CBZZ 2-2-104 AF UPOKPA340CBFB 4-5-5 AK
" 7-2-104 AF " 9-5-5 AK
PSEL-E097CBZZ 2-2-35 AE USRA-A313CBFA 1-2-70 AP

19
Downloaded from www.Manualslib.com manuals search engine
SJPT56RHS
PRICE NEW PART
PARTS CODE No. RANK MARK RANK
" 6-2-70 AP
UTNA-A282CBFC 4-5-7 AF
" 9-5-7 AF
UTNA-A449CBFB 4-5-12 BA
" 9-5-12 BA
UTNA-A450CBFB 4-5-11 AR
UYOK-A577CBFB 4-5-16 AY
" 9-5-16 AY
UYOK-A578CBFB 4-5-21 AY
" 9-5-21 AY
UYOK-A579CBFB 4-5-14 AN
" 9-5-14 AN

20
Downloaded from www.Manualslib.com manuals search engine
COPYRIGHT © 2011 BY SHARP CORPORATION

ALL RIGHTS RESERVED.


COPYRIGHT © XXXX BYSHARP CORPORATION
No part of this ALLpublication may be reproduced, stored
RIGHTS RESERVED.
in retrieval systems, or transmitted in any form or by
any means, electronic, mechanical, photocopying, re-
cording, or other
No part wise, without
of this publication prior written permission
may be reproduced,
stored in a retrieval system, or transmitted in
of the any
publisher.
form or by any means, electronic, mechanical,
photocopying, recording, or otherwise, without
prior written permission of the publisher.

SHARP CORPORATION
55CRNF/51DRZF/55DRZF

Downloaded from www.Manualslib.com manuals search engine

You might also like