You are on page 1of 30

SHACKLES

The Crosby Group, Inc.

Angle loads must be applied in the plane of the bow. Never Exceed 120° included
angle.
Use Bolt Type and Screw Pin
Shackles ONLY.
Shackles symmetrically loaded
with two legs slings having a max-
imum included angle of 120° can
be utilized to full Working Load
Limit.

* In-Line load is applied perpendicular to pin.


† DO NOT SIDE LOAD ROUND PIN SHACKLES

10

10-1
SHACKLES
The Crosby Group, Inc.
Forged Shackles
SCREW PIN ROUND PIN

209

G-209 S-209 G-213 S-213 213

Screw pin anchor shackles meet the Round pin anchor shackles meet the
performance requirements of Federal performance requirements of Federal
Specification RR-C-271D Type IVA, Specification RR-C-271D Type IVA,
Grade A, Class 2, except for those pro Grade A, Class 1, except for those provi-
visions required of the contractor. sions required of the contractor.
•  Working Load Limit permanently shown on every shackle.
•  Forged — Quenched and Tempered, with alloy pins.
•  Shackles can be furnished proof tested with certificates to designated standards, such as ABS, DNV,  Lloyds, or
other certification. Charges for proof testing and certification available when requested at the time of order.
•  Hot Dip galvanized or Self Colored.


† Furnished in screw pin only.
* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit. Minimum Ultimate Strength is 6 times the Working Load Limit. For  Working
10 Load Limit reduction due to side loading applications, see beginning of chapter.

† Furnished in screw pin only.


* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit. Minimum Ultimate Strength is 6 times the Working
Load Limit. For Working Load Limit reduction due to side loading applications, see beginning of chapter.

10-2
SHACKLES
The Crosby Group, Inc.
Alloy Screw Pin Anchor Shackle
G-209-A

G-209-A
Screw pin anchor shackles meet the performance requirements
of Federal Specification RR-C-271D Type IVA, Grade B, Class 2,
except for those provisions required of the contractor.
•  Working Load Limit permanently shown on every shackle.
•  Forged Alloy Steel — Quenched and Tempered, with alloy pins.
•  Shackles can be furnished proof tested with certificates to designated standards, such as ABS, DNV, Lloyds, or
other certification. Charges for proof testing and certification available when requested at time of order.
•  Hot Dip galvanized.

* Note:  Maximum Proof Load is 2.5 times the Working Load Limit.  Minimum Ultimate Strength
is 5 times the Working Load Limit.  For Working Load Limit reduction due to side loading appli-
cations, see beginning of chapter.

10

* Note: Maximum Proof Load is 2.5 times the Working Load Limit.  Minimum Ultimate Strength is 5 times the Working Load Limit.  For Working Load Limit reduction
due to side loading applications, see beginning of chapter.

10-3
SHACKLES
The Crosby Group, Inc.
Forged Chain Shackles
SCREW PIN ROUND PIN

210

215

G-210 S-210 G-215 S-215


Screw pin chain shackles meet the Round pin chain shackles meet the
performance requirements of Federal performance requirements of Federal
Specification RR-C-271D, Type IVB, Specification RR-C-271D Type IVB, Grade
Grade A, Class 2, except for those pro- A, Class 1, except for those provisions
visions required of the contractor. required of the contractor.
•  Working Load Limit permanently shown on every shackle.
•  Forged — Quenched and Tempered, with alloy pins.
•  Shackles can be furnished proof tested with certificates to designated standards, such as ABS, DNV,  Lloyds, or
other certification. Charges for proof testing and certification available when requested at the time of order.
•  Hot Dip galvanized or Self Colored.
•  Fatigue rated.

10
† Furnished in Screw Pin Only.
* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit. Minimum Ultimate Load is 6 times the Working Load Limit. For Working Load Limit
reduction due to side loading applications,  see beginning of chapter.

† Furnished in Screw Pin Only.


* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit. Minimum Ultimate Load is 6 times the
Working Load Limit.For Working Load Limit reduction due to side loading applications, see beginning of chapter.

10-4
SHACKLES
The Crosby Group, Inc.
Bolt Type Shackles
BOLT TYPE ANCHOR SHACKLE BOLT TYPE CHAIN SHACKLE
2130

G-2130 S-2130 G-2150 S-2150


Bolt Type Anchor shackles with thin Bolt Type Chain shackles. Thin hex
head bolt — nut with cotter pin. Meets head bolt — nut with cotter pin. Meets
the performance requirements of the performance requirements of
Federal Specification RR-C-271D Type Federal Specification RR-C271D Type
IVA, Grade A, Class 3, except for those IVB, Grade A, Class 3, except for those
provisions required of the contractor. provisions required of the contractors.
2150

• Working Load Limit permanently shown on every shackle.


• Forged — Quenched and Tempered, with alloy pins.
• Shackles 55 tons and smaller can be furnished proof tested with certificates to designated standards, such as
ABS, DNV, Lloyds, or other certification.
• Shackles 85 tons and larger can be provided as follows.
• Non Destructive Tested
• Serialized Pin and Bow
• Material Certification (Chemical)
• Certification must be requested at time of order.
• Hot Dip galvanized or Self-Colored.
• Fatigue rated.

10

10-5
SHACKLES
The Crosby Group, Inc.
Bolt Type Shackles

* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit.  Minimum Ultimate Load is 6 times the Working Load Limit. For Working Load Limit reduction due to
side loading applications, see beginning of chapter.
† Individually Proof  Tested with certification and furnished with Round Head Bolts and welded handle.
‡ Furnished in anchor style only.

Nominal Working Stock No. Weight Dimensions (in.) Tolerance +/-


Size Load Each
(in.) Limit (t)* G-2150 S-2150 (lbs.) A B D F G K M P R G A
               
               
               
               
               
               
               
               
               
               

10 



 
 
  
  


















               
               
               
               
 ‚              

* NOTE: Maximum Proof Load is 2.2 times the Working Load Limit.  Minimum Ultimate Load is 6 times the Working Load Limit. For Working Load Limit reduction due
to side load applications, see beginning of chapter.
† Individually Proof  Tested with certification and furnished with Round Head Bolts and welded handle.
‡ Furnished in Anchor style only.

10-6
SHACKLES
The Crosby Group, Inc.
Alloy Bolt Type Anchor Shackle
contractor.
•  Working Load Limit is permanently shown on every
shackle.
•  Alloy bows,  Alloy bolts.
•  Quenched and Tempered.
•  All sizes are individually proof tested to 2.2 times the
Working Load Limit.
•  Shackles 110 tons and larger are provided as fol-
lows.
•  Non Destructive Tested
•  Serialized Pin and Bow
•  Material Certification (Chemical)
G-2140 and S-2140 •  Certification must be requested at time of order.
G-2140 meets the performance requirements of •  Forged Alloy Steel 30 thru 175 tons. Cast Alloy Steel
Federal Specification RR-C-271D, Type IVA, Grade 200 thru 600 tons.
B, Class 3, except for those provisions required of the •  Pins are galvanized and painted red.
NOTICE:  All 2140 shackles 110 tons and larger are magnetic particle inspected. Certification available on request.

* Note: Maximum Proof Load is 2.2 times the Working Load Limit. Minimum Ultimate Load is 4 times the
Working Load Limit on 200 thru 600 Tons. For sizes 30 thru 175 Tons,  Minimum Ultimate Load is 6 times the
Working Load Limit.
** Cast Alloy Steel.
† Furnished with Round Head Bolts with welded handle.
†† Maximum Proof Load is 1000 Tons and furnished with Round Head Bolts with welded handle.

10

* Note: Maximum Proof Load is 2.2 times the Working Load Limit.  Minimum Ultimate Load is 4 times the Working Load Limit on 200 thru
600 Tons. For sizes 30 thru 175 Tons,  Minimum Ultimate Load is 6 times the Working Load Limit.
** Cast Alloy Steel.
† Furnished with Round Head Bolts with welded handle.
†† Maximum Proof Load is 1000 Tons and furnished with Round Head Bolts with welded handle.

10-7
SHACKLES
Crosby® Alloy Shackles
“WIDE BODY” SLING SAVER SHACKLES INCREASE SLING LIFE
•  Greatly improves wearability of wire rope slings.
•  Can be used to connect HIGH STRENGTH Synthetic
Web Slings, HIGH STRENGTH Synthetic Round
Slings or Wire Rope Slings.
•  Increase in shackle bow radius provides minimum
58% gain in sling bearing surface and eliminates
need for a thimble.
•  Increases usable sling strength minimum of 15%.
•  Pin is non-rotating, with weld on handle for easier
use.
•  All ratings are in metric tons, embossed on side of
bow.
•  Forged alloy steel from 75 through 300 metric tons.
400 through •  Cast alloy steel from 400 through 1000 metric tons.
1000 metric tons
•  Sizes 400 tons and larger are tested to 1.33 times
Working Load Limit.
•  Sizes 300 tons and smaller are proof tested to 2
times the Working Load Limit.
CONVENTIONAL •  All 2160 shackles are individually proof tested,
SHACKLE Crosby certification available at time of order.
Shackles requiring ABS, DNV, Lloyds and other
certifications are available upon special request and
must be specified at time of order.
“WIDE BODY” •  Shackles are produced in accordance with certified
SHACKLE lifting appliance requirements.
75 through 300   • Non Destructive Testing
metric tons   • Serialization / Identification
   •  Material Testing (Physical / Chemical / Charpy)
G-2160   • Proof Testing
•  All sizes Quenched and Tempered for maximum
Patented strength.
•  Bows and pins are furnished Dimetcoted. All pins
are Dimetcoted then painted red.
NOTICE: All shackles are magnetic particle inspected. •  Type Approval and certification in accordance with
DNV Specification 2.7-1 Offshore Containers and
DNV rules for Lifting Appliances–Loose Gear.
Working Dimensions
Load Crosby (in.)
Limit* CERTEX G-2160 Weight B D
(metric Cat. Ref. Stock Each A +/- C +/- E G H J K P R
tons) No. No. (lbs.) .25 .02
10 ‚ ³             
‚ ³             
‚ ³             
‚ &;             
‚ &;             
‚ &;             
‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             
‚‚ &;             

* Ultimate Load is 5 times the Working Load Limit.


† Forged Alloy Steel.  Proof Load is 2 times the Working Load Limit.
†† Cast Alloy Steel.  Proof Load is 1.33 times the Working Load Limit.

10-8
HOIST RING
The Crosby Group, Inc.
Warnings and Application Instructions
WRONG WRONG External Inspection Points RIGHT

180° Pivot

Figure 1 Figure 2

Hoist Ring Application Assembly Safety


•  Use swivel hoist ring only with ferrous metal (steel, 360°
iron) or soft metal (i.e., aluminum) loads (work piece).
Do not leave threaded end of hoist ring in aluminum
loads for long time periods due to corrosion.
Figure 3 Figure 4
•  After determining the loads on each hoist ring, select
the proper size hoist ring using the Working Load
Limit ratings in Table 1 for UNC threads and Table 2 Hoist Ring Inspection/Maintenance
for Metric threads. •  Always inspect hoist ring before use.
•  Drill and tap the work piece to the correct size to a •  Regularly inspect hoist ring parts. (Fig. 3)
minimum depth of one-half the threaded shank diame-
ter plus the threaded shank length. See rated load limit •  Never use hoist ring that show signs of corrosion,
and bolt torque requirements imprinted on top of the wear or damage.
swivel trunnion. (See Table 1 and/or Table 2) •  Never use hoist ring if bail is bent or elongated.
•  Install hoist ring to recommended torque with a torque •  Always be sure threads on shank and receiving holes
wrench making sure the bushing flange meets the load are clean, not damaged, and fit properly.
(work piece) surface. •  Always check with torque wrench before using an
•  Never use spacers between bushing flange and mount- already installed hoist ring.
ing surface. •  Always make sure there are no spacers (washers)
•  Always select proper load rated lifting device for use used between bushing flange and the mounting sur-
with Swivel Hoist Ring. face. Remove any spacers (washers) and retorque
•  Attach lifting device ensuring free fit to hoist ring bail before use.
(lifting ring). (Fig. 1) •  Always ensure free movement of bail. The bail
•  Apply partial load and check proper rotation and align- should pivot 180° and swivel 360°. (Fig. 4)
ment. There should be no interference between load •  Always be sure total work piece surface is in contact
(work piece) and hoist ring bail. (Fig. 2) with hoist ring bushing mating surface. Drilled and
•  Special Note: When a Hoist Ring is installed with a tapped hole must be 90° to load (work piece) sur-
retention nut, the nut must have full thread engage- face.
ment and must meet one of the following standards to
develop the Working Load Limit (WLL).
1.  ASTM A-563 (A) Grade D Hex Thick
(B) Grade DH Standard Hex
10
2.  SAE Grade 8 — Standard Hex

WARNING
•  Loads may slip or fall if proper Hoist Ring assem-
bly and lifting procedures are not used.
•  A falling load may cause serious injury or death.
•  Use only genuine Crosby parts as replacements.
•  Read, understand and follow all instructions, dia-
grams and chart information before using swivel
hoist ring assembly.

10-9
HOIST RING
The Crosby Group, Inc.
Warnings and Application Instructions
Wrong

Do not reeve slings from After slings have been prop- Buckling may occur if the
one bail to another. This will erly attached to the hoist load is not stiff enough
alter the load and angle of ring, apply force slowly. to resist the compressive
loading on the hoist ring. Watch the load and be pre- forces which result from
pared to stop applying force the angular loading.
if the load starts buckling.

•  When using lifting slings of two or more legs, make


OPERATING SAFETY sure the forces in the legs are calculated using the
•  Never exceed the capacity of the swivel hoist ring, angle from the vertical to the leg and select the proper
see Table 1 for UNC threads and Table 2 for Metric size swivel hoist ring to allow for the angular forces.
threads. (Note: Sling angles will de-rate sling members (chain,
rope, or webbing) but will not de-rate swivel hoist ring
capacity.)

WARNING
•  Loads may slip or fall if proper Hoist Ring assem-
bly and lifting procedures are not used.
•  A falling load may cause serious injury or death.
•  Use only genuine Crosby parts as replacements.
•  Read, understand and follow all instructions, dia-
grams and chart information before using swivel
hoist ring assembly.

Dependability In Lifting-
Everywhere, Every Time.

10

You’re in a tough lifting situ- CERTEX, the lifting experts, for


ation. Valuable equipment and the experience and resources to
the lives of your workers are make your most complex lifting
on the line. You have to meet challenge like just another day
deadlines, observe regulations at the office.
and stay within a budget. The CERTEX puts its world-
slightest overlooked detail can wide network into the hands of
put employees and valuable local companies who know your
equipment in harm’s way. Are needs and are close at hand to
you sure you have every detail serve you.
covered?
When you’re taking on
the weight of the world, turn to Lifting Products and Services

10-10
HOIST RING
The Crosby Group, Inc.
Warnings and Application Instructions

* Ultimate load is 5 times the Working Load Limit. Individually proof


tested to 2 1/2 times the Working Load Limit.
** The tightening torque values shown are based upon threads being clean, dry and free
of lubrication.
† Long bolts are designed to be used with soft metal (i.e., aluminum) work piece.
While the long bolts may also be used with ferrous metal (i.e., steel & iron) work
pieces, short bolts are designed for ferrous work pieces only.
†† Bolt specification is a Grade 8 Alloy socket head cap screw to ASTM A 574. All
threads are UNC – 3A.

10

* Designed to be used with ferrous work piece only.


** The tightening torque values shown are based upon threads being clean, dry and free of lubrication.
† Individually proof tested to 2 1/2 times the Working Load Limit based on the 4:1 design factor.
†† Bolt specification is a Grade 12.9 Alloy socket head cap screw to DIN 912.
All threads are metric (ASME/ANSI B18.3.1m).

WARNING
•  Loads may slip or fall if proper Hoist Ring assem-
bly and lifting procedures are not used.
•  A falling load may cause serious injury or death.
•  Use only genuine Crosby parts as replacements.
•  Read, understand and follow all instructions, dia-
grams and chart information before using swivel
hoist ring assembly.

10-11
HOIST RING
The Crosby Group, Inc.
UNC Threads
Top washer has the following features:
•  The Working Load Limit and
Recommended Torque value are per-
manently stamped into each washer.
•  Washer is color coded for easy identi-
fication
Red - UNC thread

BOLT SIZE IDENTIFICATION


The size of the bolt will be stated as in the following example. Illustration
shows meaning of each dimension given.

# of Threads
per Inch
5/16” - 18 x 1.50”

Bolt Diameter

Length of Bolt
(from under head)

10

* Ultimate load is 5 times the Working Load Limit.


Long bolts are designed to be used with soft metal (i.e., aluminum) work piece. While the long bolts may also be used with ferrous metal (i.e., steel & iron) work piece,
short bolts are designed for ferrous work pieces only.
†† Bolt specification is a Grade 8 Alloy socket head cap screw to ASTM A 574. All threads listed are UNC - 3A.

SEE APPLICATION AND


WARNING INFORMATION

10-12
EYE BOLTS
The Crosby Group, Inc.
Warnings and Application Instructions

Regular Nut Shoulder Nut Machinery Nut


Eye Bolt Eye Bolt Eye Bolt
G-291 G-277 S-279

IMPORTANT SAFETY INFORMATION —


READ & FOLLOW
Inspection/Maintenance Safety:
•  Always inspect eye bolt before use.
•  Never use eye bolt that shows signs of wear or dam-
age.
•  Never use eye bolt if eye or shank is bent or elongat-
ed.
•  Always be sure threads on shank and receiving holes
are clean.
•  Never machine, grind, or cut eye bolt.
Assembly Safety:
•  Never exceed load limits specified in Table I.
•  Never use regular nut eye bolts for angular lifts.
•  Always use shoulder nut eye bolts (or machinery eye
bolts) for angular lifts.
•  For angular lifts, adjust working load as follows:

IN - LINE
Shoulder Nut Eye Bolt — Installation for Angular
Loading
•  The threaded shank must protrude through the load
•  Never undercut eye bolt to seat shoulder against the sufficiently to allow full engagement of the nut.
load. •  If the eye bolt protrudes so far through the load that
•  Always countersink receiving hole or use washers to
seat shoulder.
the nut cannot be tightened securely against the load,
use properly sized washer to take up the excess space 10
BETWEEN THE NUT AND THE LOAD.
•  Always screw eye bolt down completely for proper
seating. •  Place washers or spacers between nut and load so that
when the nut is tightened securely, the shoulder is
•  Always tighten nuts securely against the load. secured flush against the load surface.
•  Thickness of spacers must exceed this distance
between the bottom of the load and the last thread of
the eye bolt.

WARNING
•  Loads may slip or fall if proper eye bolt assembly and lifting
procedures are not used.
•  A falling load can serious injury or kill.
•  Read and understand both sides of these instructions, and
follow all eye bolt safety information presented here.
•  Read, understand and follow all information in diagrams and
charts below before using eye bolt assemblies.

10-13
EYE BOLTS
The Crosby Group, Inc.
Warnings and Application Instructions
Regular Nut & Shoulder Nut Eye Bolt – Installation for In-line Loading
RIGHT RIGHT
RIGHT WRONG
Tighten
Hex Nut
Securely
Against
Load
Tap Depth:
2.5 x 2x
Diameter Diameter
(Minimum)

More than one eye bolt diam- One eye bolt diameter of
eter of threads, only (1) nut threads or less, use two (2) One eye bolt diameter or less
required. nuts.
Tighten hex nut securely Tighten hex nut securely
against load against load

Operating Safety
•  Always stand clear of load.
•  Always lift load with steady, even pull – do not jerk.
•  Always apply load to eye bolt in the plane of the eye – not at an angle.
•  Never exceed the capacity of the eye bolt–see Table 1.
•  When using lifting slings of two or more legs, make sure the loads in the legs are calculated using the angle from
the vertical to the leg and properly size the shoulder nut or machinery eye bolt for the angular load.

WRONG
Do not reeve slings from After slings have been Buckling may occur
one eye bolt to another. properly attached to the if the load is not stiff
This will alter the load Resultant Load eye blots, apply force enough to resist the
and angle of loading on slowly. Watch the load compressive forces
the eye bolt. carefully and be prepared which result from
to stop applying force if the angular loading.
the load starts buckling.

10

WARNING
•  Loads may slip or fall if proper eye bolt assembly and lifting
procedures are not used.
•  A falling load can serious injury or kill.
•  Read and understand both sides of these instructions, and
follow all eye bolt safety information presented here.
•  Read, understand and follow all information in diagrams
and charts below before using eye bolt assemblies.

10-14
EYE BOLTS
The Crosby Group, Inc.
Warnings and Application Instructions
Machinery Eye Bolt — Installation for In - line & Angular Loading
These eye bolts are primarily intended to be installed into
tapped holes.
1.  After the loads on the eye bolts have been calculated,
select the proper size eye bolt for the job.
For angular lifts, adjust working load as follows:

2.  Drill and tap the load to the correct sizes to a mini-
mum depth of one-half the eye bolt size beyond the
shank length of the machinery eye bolt.
3.  Thread the eye bolt into the load until the shoulder is
flush and securely tIghtened against the load.
4.  If the plane of the machinery eye bolt is not aligned
with the sling line, estimate the amount of unthread-
ing rotation necessary to align the plane of the eye
properly.
5.  Remove the machinery eye bolt from the load and
add shims (washers) of proper thickness to adjust the
angle of the plane of the eye to match the sling line. Shim added to change eye alignment 90°
Use Table II to estimate the required shim thickness Minimum tap depth is basic shank length plus one-half the nom-
for the amount of unthreading rotation required. inal eye bolt diameter.

The New Standard In 10


Lifting Products and Services.
In the field of lifting, CERTEX means by world-wide experience and expertise to
certainty. From simple, straight forward solve any lifting problem.
hardware and custom-made assemblies, Wherever people are at work building,
to complete lifting management programs, producing and moving the world’s goods,
the name CERTEX represents quality, CERTEX means certainty.
safety, service and expertise. CERTEX
companies are your trusted local source
for lifting products and services, backed

10-15
EYE BOLTS
The Crosby Group, Inc.
Shoulder Type Machinery Eye Bolts
•  Forged Steel — Quenched & Tempered.
•  Recommended for straight line pull.
•  Fatigue tested to 1 1/2 times the Working
Load Limit for 20,000 cycles.

S-279

* Ultimate Load is 5 times the Working Load Limit.

10

SEE APPLICATION AND


WARNING INFORMATION

10-16
EYE BOLTS
The Crosby Group, Inc.
Shoulder Nut Eye Bolts


G-277
• Forged Steel.
• Hot Dip galvanized.
• Furnished with standard Hot Dip galvanized, heavy hex nuts.
• Fatigue tested to 1 1/2 times the Working Load Limit for 20,000 cycles.

* Ultimate Load is 5 times the Working Load Limit.

10

SEE APPLICATION AND


WARNING INFORMATION

10-17
EYE BOLTS
The Crosby Group, Inc.
Regular Nut Eye Bolts

G-291

• Recommended for straight line pull.


• All Bolts Hot Dip galvanized after threading.
• Furnished with standard Hot Dip galvanized hex nuts.
• Forged Steel — Quenched and Tempered.
• Fatigue tested to 1 1/2 times the Working Load Limit for 20,000 cycles.

10

*Ultimate Load is 5 times the Working Load Limit.

SEE APPLICATION AND


WARNING INFORMATION

10-18
EYE BOLTS
The Crosby Group, Inc.
Shoulder Nut Ring Bolts
• Forged Steel — Quenched and Tempered.
• Diameter of ring stock is same as shank diameter.
• Hot Dip galvanized.

G-257

* Ultimate load is 5 times the Working Load Limit.

Pad Eyes

•  Forged Steel — Quenched and Tempered.


•  Forged from 1035 Carbon Steel.
•  Excellent welding qualities.
•  Widely used on farm machinery, trucks, steel hulled
marine vessels and material handling equipment.
•  Reference American Welding Society specifications for
proper welding procedures.

S-264

10

* Meets the requirements of Military Specification MS-51930A

10-19
EYE BOLTS
The Crosby Group, Inc.
Eye Nuts


G-400

• Forged Steel — Quenched and Tempered.


• Threaded.
• Hot Dip galvanized.
• Tapped with standard UNC class 2 thread.

* Ultimate Load is 5 times the Working Load Limit. Rating based on standard tap size.

10

10-20
LIFTING POINTS
RUD
STARPOINT – VRS-F SWIVEL EYE BOLT

Type CERTEX RUD WLL


UNC Cat. Ref. No. No. lbs. M A B C D E L
956)81&          
956)81&          
956)81&          
956)81&          
956)81&          
956)81&          
0HWULF6L]HV PP

Type CERTEX RUD WLL


metric Cat. Ref. No. No. t M A B C D E L
956)0          
956)0          
956)0          
956)0          
956)0          
956)0          
956)0          
956)0          
956)0          
1RPLQDO:// %R[TXDQWLWLHV

The StarPoint® is the perfect solution


to elimintate the unsafe and rigid style
eye bolt.
•  Safety factor 4:1 in any direction.

• 
Marked working load limits (WLL) are rated
at 90˚ from thread.

• 
Clear indication of working load limit in met-
ric tons and lbs. for side loading applications.

• 
Forged material (1.6541) alloy quenched
and tempered.

• 
The Distinct Florescent pink powder-coating
changes its color when temperatures exceed
200˚C. If the StarPoint® reaches temperatures
10
of 400˚C, the color changes to a deep black
with small bubbles, indication that it has been
over-heated.

• Body and bolt, 100% electromagnetic alloy


crack tested in accordance with specification
EN 1677.

• The StarPoint® is supplied with an annealed


star-profile-key. Simply engage the Hexagon
socket bolt with the star-profile-key and use
your fingers to respectively tighten or untight-
en the arrangement. Disengage the key.

• The StarPoint® is rotatable!

10-21
LIFTING POINTS
RUD
PowerPoint Star
The first generation of lifting points • 
Tested design factor 4:1 in • Can be turned in a 90˚ position from the
with a double ball bearing which any direction bolt center line
enables jerk - free turning, swiveling
and tilting. PP-S is designed with a • 
Cr Ni Mo Steel, Quenched • Not suitable for permanent swiveling under
universal connection for every lifting and tempered full load
appliance (hook and ring assemblies, •  Double Ball bearing for smooth • Body and bolt, 100% electromagnetic alloy
round slings, loops endless slings etc.) tilting and turning crack tested in accordance with specifica-
• Optimized design prevents the lift- •  tion EN 1677
Maximum WLL with the smallest
ing points as well as the load from thread diameter •  Surface: pink powder coated
being damaged
NOTE: RUD Lifting Points are also available in metric sizes
PowerPoint-Star

CERTEX RUD WLL


Type Cat. Ref. No. No. lbs. M A C T
336²W²81&       
336²W²81&       
336²W²81&       
336²W²81&       
336²W²81&       
336²W²81&       
336²W²81&       
1RPLQDO://
PowerPoint-B
CERTEX RUD WLL
Type Cat. Ref. No. No. lbs. M A C T
33%²W²81&       
33%²W²81&       
33%²W²81&       
33%²W²81&       
33%²W²81&       
33%²W²81&       
33%²W²81&       
PowerPoint-VIP 1RPLQDO://
9,3FKDLQ
CERTEX RUD WLL FRQQHFWLRQ
Type Cat. Ref. No. No. lbs. M A F G
339,3²W²81&       
339,3²W²81&       
339,3²W²81&       
339,3²W²81&       
339,3²W²81&       
339,3²W²81&       
339,3²W²81&       
1RPLQDO://
10 Load Ring bolted
VLBG
VLBG-Adjustable in pull direction, turns 360˚
CERTEX RUD WLL
Type Cat. Ref. No. No. lbs. M H C T
9/%*=²W²81&       
9/%*=²W²81&       
9/%*=²W²81&       
9/%*=²W²81&       
9/%*=²W²81&       
9/%*=²W²81&       
1RPLQDO://

Why are RUD-Lifting Points “PINK”?


The special fluorescent pink powder coating permanently
changes color at increased temperatures. If chain reaches tem-
peratures of 400˚C, the color changes to a deep black with small
bubbles, indicating that the chain has been over-heated; the
chain should not be used at this high temperature.
The special fluorescent pink powder coating permanently high-
lights the maximum temperature at which the VIP lifting point
has been used.

10-22
LIFTING POINTS
RUD
Load Ring - VLBS - for welding

RUD RUD
No. No.
CERTEX captive without WLL Weld Weight
Type Cat. Ref. No. complete spring lbs. A B C D E ØF G H I T lbs.
9/%6               +9 
9/%6               +9 
9/%6               +9 
9/%6               +9 
9/%6  ²             +9 

• The new VLBS forged out of high tensile CrNiMo - steel •  Important: By the special weld design (continuous HV),
with an innovative design offers many advantages. the requirements of DIN 18800 are fulfilled, i.e., a closed
weld avoids corrosion and thus suitable for outdoor use.
- Up to 50% higher WLL.
• Distinctive features for type LBS-U: A protected spring
- The two protective supporting lugs (inside the load ring) maintains the load ring in every required position. The parts
are patented and they improve the connection with the are assembled in such a way that they remain captive.
attachment in addition to the protected clamping spring.
• The spring reduces vibration induced noise.
- The support effect is exceptional, especially if the ring
is side loaded or the lifting point is welded on an uneven
10
work piece.
- The special fluorescent pink powder coating perma-
nently highlights the maximum temperature at which the
VIP chain has been used.
• Easy and quick to weld assemble.
• Compact and shapely design.
• High dynamic and static strength.
• Forged suspension ring acc. to EN 1677, grade 80, electro-
magnetic crack detected, pink powder coated; meets the
requirements of the appropriate safety authorities.
• The welding block has been forged of material 1.0570 (St
52-3) and clearly stamped with the permissible WLL. The
patented distance lugs assist in achieving the correct root
weld.

10-23
LIFTING POINTS
RUD
Load Ring - VRBS - for welding

RUD
No. Weld
CERTEX captive WLL Weight
Type Cat. Ref. No. complete lbs. A B C D E F O Q X T +9D lbs.
95%6              +9 
95%6              +9 
95%6              +9 
95%6              +9 
95%6              +9 
95%6            ²  +9 

• Distribution of the load force due to the 2 point fix-


ing, hence an optimized force introduction to the ATTENTION: Refer to the RUD user welding instructions!
work piece.

10 • Forged, suspension ring acc. to EN 1677-1, electro-


magnetic crack detected, pink power coated.
Suspension ring can also be ordered single. For
instance VRL 4. This lifting point fulfills the require-
ments of the appropriate safety authorities (German
Employer’s insurance Association). Stamped .
• Lays flat when not in use.
• Low profile.
• Rounded well shaped design.
• High dynamic and static strength.
• The welding blocks are forged out of the ideal weld-
able steel ST52-3N (S355J2+N) and the nominal
WLL is embossed.
• Patented distance lugs assist in achieving the correct
root weld (approx. 3 mm).
• The weld arrangement (continuous HV weld) fulfills
the requirements of DIN 18800 i.e. the closed weld
avoids corrosion and is thus suitable for outdoor use.

10-24
PIPE HANDLING
The Caldwell Group
Model PC — “Tea Cup” Pipe Carrier
FEATURES:
• An efficient way to handle concrete water and sewer
pipes.
• The Caldwell “Tea Cup” Pipe Carrier will save you
time and money.
• Three sizes available, to handle from 3/4” to 1-1/2”
cable, and lift up to 15 tons.
• Designed and manufactured to ASME B30.20 and B30.9.

SPECIFICATIONS — Model PC

SPECIFICATIONS — Model LS
Tea Cup Lifting Sling Option — LS

Operation 10

1. Drop pipe carrier 2. Align and insert 3.  Lift pipe.


lifting sling through “tea cup” pipe car-
hole in pipe. rier into lifting sling.

10-25
BEAMS

Beam Configurations

Four Point Lift Beams

Glass Pack Beams. Custom lifting beam handles packs of glass Three Point Lift Beam.
panes with slings.

10

High Capacity Sling Beams Adjustable Center Bail for Off-Center Loads

Beams and Spreaders can be made to meet your requirements exactly. A few examples of special configurations
are shown here. Details will vary depending on capacity.

10-26
SPECIALTY BEAMS
The Caldwell Group
Model 16 — Adjustable Spreader/Lifting Beam
FEATURES:
•  Use as 2, 3 or 4 point lifting or spreader beam.
•  Converts to spreader beam with addition of top rigging.
•  Has adjustable lifting points.
•  Can handle both wide and unbalanced loads
•  Low headroom capability.
•  Shackles included.
•  Designed and manufactured to ASME B30.20.

OPTIONS:
•  Pair of swivel hooks — Code S
•  Chain top rigging — Code C
• Cross beams (one or two) specify spread(s)
Consult Factory

SPECIFICATIONS

Operation
10

2 Point Lift 3 Point Lift 4 Point Lift

10-27
C-HOOKS

Ordering Instructions
Define Coil Sizes
Determine your maximum coil width (dimension “K”).
Your C-Hook’s nominal center of gravity, “E”, should
equal half of “K”. This allows your widest coil to be
centered under the lifting bail for a level lift.
If you are handling multiple coils or coiled rod or wire,
please provide the maximum load width and request a
quote on a “full length lower arm”.
Determine your minimum coil width. The listed models
show a range of coil widths which can be handled one at
a time by the same lifter. (Larger ranges can be furnished.)
“L” is the narrowest coil that can be lifted without the
lifter’s lower arm protruding past the edge of the coil.
Coils narrower than “L” may be handled if centered under
the bail.
Coil Load Details
1.  Max. Width _____ Min. Width _____________
2.  Max. Outside Diameter ___________________
Radial Thickness 3.  Min. Inside Diameter _____________________
4.  Max. Weight ___________________________
Determine maximum radial thick- Will more than one coil be handled at once? ____
ness to be handled. Most users
select a vertical clearance, “V”, that
is 3” to 5” greater than the maxi-
mum radial thickness.
Max. OD of coil 2 Min. ID of coil
Radial Thickness — }}}} 2

Hook Dimensions
1. ______”
2. ______”
3. ______”
4. ______”
5. ______”
6. ______”
7. ______”
8. ______”
Capacity __________Tons.

10
Coil Lifter Dimensions
A.  Lift Arm Length . . . . . . . _______”
B.  Max. Arm Depth . . . . . . _______”
C.  Max. Arm Width . . . . . . _______”
U.  Upper Arm Length . . . . _______”
V.  Vertical Clearance . . . . _______”
Other Features . . .

10-28
COIL LIFTERS
The Caldwell Group
Model 82-RC — Close Stacking “C” Hook
PRODUCT FEATURES:
• Recessed Counterweight allows for close stacking of coils which
maximizes floor space.
• Handles a wide range of coil widths.
• Designed for heavy duty application.
• High tensile alloy steel plate reduces physical size and weight.
• Counter balanced to hang level.
• Inside radius on hooks avoid coil edge contact.
• Curved coil saddle is standard.
• Guide handle for ease of coil positioning.
• Available with optional padding for additional coil protection.
• Designed and manufactured to ASME B30.20.

CAUTION: Center of
gravitymustbecentered
undercranehooktopre-
venttiltingofthelifterand
load.

Note:  “E” dimension is always one-half of maximum coil width.


SPECIFICATIONS

10

Counter weight extends beyond arm one-half of the counter weight width, in capacities 25 Ton and Greater.
Other sizes available, consult factory.

10-29
LIFTING SOLUTIONS
The Caldwell Group
Barrier Lifter
Product Features and Benefits:
• New, compact & rugged design holds up to the work environment where barriers are used.
• Handles concrete barriers from 6” - 12” nominal width at the top of the barrier.
• Stainless steel Auto-Latch.
• Auto-Latch mounting insures proper alignment.
• Locating assembly orientates tong on barrier without operator intervention and will pivot when grab is set on the ground.
• Gripping pads pivot to conform with the load.
• Replaceable polyurethane pads protect barrier.
• Alloy steel dog-point pads bite into painted barrier surfaces (typical in coastal areas).
• Centering guide cut out on grab shoe helps to properly center tong over barrier for a level lift.
• Extended handles on each side keep operator away from load and can be adjusted as needed.
• Lifting eye allows for easy hook attachment, self-centers rigging, and will accommodate a fork.

10

Model # Polyurethane Pads Steel “Dog Rated Weight


Point” Pads Capacity (lbs.)
(lbs.)
BLG-4.1/4 X 8500 550
BLG-7.1/4 X 14500 600
BLG-4.1/4-DP X 8500 550
BLG-7.1/4-DP X 14500 600

10-30

You might also like