You are on page 1of 97

PROPAGATION CONSTANT ()

= (Z/Y)
= (R + j L)(G + j C)
= +j

Where:
= attenuation coefficient
= Phase shift coefficient
VELOCITY FACTOR
The ratio of the transmission speed in the
transmission line and the transmission
speed in free space

V = Vf(c) V = c/k Vf= 1/k


Where: NOTE:
v = velocity in a Velocity factors in transmission
medium line vary from approximately 0.8
to 0.6.
c = velocity of light in The velocity factor of coax is
free space typically in the 0.6 to 0.7 range.
k = dielectric constant Open-wire and twin lead have a
velocity near 0.8
of the medium
TRANSMISSION LINE LENGTH

Physical length
Ex: s = 10 km
Length in terms of (1 = s)
Ex: s = 0.25 = 360 /
Electrical length
Ex: l = 120 ;
TRANSMISSION LINE LOSSES
RADIATION LOSSES
Transmission line acts as an antenna if the
separation of the conductors in appreciable fraction
of a wavelength
Increased with frequency

CONDUCTOR HEATING OR I2R


LOSSES
Proportional to current and inversely proportional to
characteristic impedance
Increase of frequency because of skin effect
TRANSMISSION LINE LOSSES

DIELECTRIC HEATING
Proportional to the voltage across the dielectric and
inversely proportional to the characteristic
impedance for an power transmitted.

Increase with frequency for solid dielectric lines


because of gradually worsening properties with
increasing frequency.
WHEN SIGNAL REACHES
THE LOAD
The entire signal
is absorbed by
the load

ZL = Zo
matched line

non-resonant
(Resistive)
Flat Line
WHEN SIGNAL REACHES
THE LOAD
A portion of the
signal is absorbed
by the load and
some is returned
to the source.

ZL Zo
ZL = R jX
WHEN SIGNAL REACHES
THE LOAD

The entire signal is


reflected back to
the source.
ZL = 0 (short);
Zo = (open);
ZL = jX
(pure reactance)
REFLECTION COEFFICIENT
Vector quantity that represents the ratio
of the reflected voltage to the incident
voltage.

= V R / V I = IR / II
0 1
= (ZL ZO) / (ZL+ZO)
= (Vmax Vmin) / (Vmax + Vmin)
REFLECTION COEFFICIENT
At matched line; ZL = Zo
= 0; most desirable

At short circuited line; ZL = 0


= -1

At open circuited line; ZL = infinity


=1
REFLECTION COEFFICIENT

The reciprocal of the reflection


coefficient is called the return loss (RL)

RL = 1 /
RLdB = 20 log(1 / )
STANDING WAVE RATIO

The ratio of the voltage (or current) at a point


of maximum amplitude to a point of minimum
amplitude.

A measure of the mismatch between the load


and the line.
STANDING WAVE RATIO

SWR = Vmax / Vmin


SWR = (1+ ) / (1- )
SWR 1

When the line is terminated in a purely


resistive load:
SWR = ZO / ZL ; ZO>>ZL
SWR = ZL / ZO ; ZL>>ZO
STANDING WAVE RATIO

Note: the higher the SWR, the greater is


the mismatch between the line and the
load

At matched line, ZL = ZO
SWR = 1 ; most desirable
STANDING WAVE RATIO

/
2
/
4
At short circuited
line,
ZL = 0
SWR =
STANDING WAVE RATIO
a. Quarter wavelength
Minimum current
Maximum voltage
Maximum impedance

b. Half wavelength
Maximum current
Minimum Voltage
Minimum Impedance
STANDING WAVE RATIO

/
2
/

At open circuited
4

line,
ZL =
SWR =
STANDING WAVE RATIO
a. Quarter wavelength
Maximum current
Minimum voltage
Minimum impedance

b. Half wavelength
Minimum current
Maximum Voltage
Maximum Impedance
STANDING WAVE RATIO

If a load is connected to a transmission


line and matching is required, a /4
transformer may be used if ZL is purely
resistive.

ZOT = ZOZL
TRANSMISSION LINE SECTIONS
AND THEIR LC EQUIVALENTS
TRANSMISSION EQUIVALENT
LINE CIRCUIT

/
4
TRANSMISSION LINE
COMPONENTS
DOUBLE STUB

Adjustable stub
which could cope
with frequency or
load impedance
changes and still
give adequate
matching
TRANSMISSION LINE
COMPONENTS
Choke, sleeve, bazooka
BALUN A circuit element used to connect
a balanced line to an unbalanced
line or antenna
TRANSMISSION LINE
COMPONENTS
DIRECTIONAL COUPLER

Used to measure
the power being
delivered to a load
or an antenna
through a
transmission line.
TRANSMISSION LINE
COMPONENTS

REFLECTOMETER

A device used to
measure standing
wave.
TRANSMISSION LINE
COMPONENTS
SLOTTED LINE
A piece of coaxial
line with a narrow
longitudinal slot in
the outer conductor
which permits
convenient and
accurate
measurement of
standing waves.
TRANSMISSION LINE
COMPONENTS
SMITH CHART
A Polar impedance
diagram, which consists
of two sets of circles, or
arcs of circles, which are
so arranged that various
important quantities
connected with
mismatched transmission
lines may b plotted an
evaluated fairly easily.
QUESTIONS

1. A system of conductors used to convey


electric power or signal between two or
more points

A. Channels
B. Optical cables
C. Transmission lines
D. Waveguides
QUESTIONS

2. These conductors are uniformly spaced by


insulators. They have low losses at low and
medium frequencies and are economical to
construct and maintained

A. Coaxial cables
B. Open-wire transmission lines
C. Optical cables
D. Waveguides
QUESTIONS

3. To prevent radiation losses and interference


from external sources, the inner conductor
of this transmission line is completely
enclosed with a metal sheath or braid

A. Coaxial cables
B. Open-wire transmission line
C. Optical cables
D. Waveguides
QUESTIONS

4. The term balance line means that

A.Both conductors carry currents that flow


in opposite directors
B.Conductors present equal capacitance to
ground
C.One conductor is connected to ground
D.A and B above
QUESTIONS

5. The characteristic impedance of a


transmission line is determined by:

A. Its operating frequency


B. Its length
C. Its physical size and arrangement
D. The signal applied at the input terminal
QUESTIONS
6. The distributed parameters of the
transmission line are: the series
resistance; the series inductance; the
shunt capacitance and the shunt
conductance. What parameter was
determined due to dielectric losses?

A. Series resistance
B. Series inductance
C. Shunt capacitance
D. Shunt conductance
QUESTIONS

7. Shunt capacitance was determined due to:

A. Conductors were closed to each other


B. The length and diameter of the conductors
C. Dielectric losses
D. Flux linkage
QUESTIONS

8. Series resistance was determined due to:

A.Conductors were closed to each other


B.The length and diameter of the conductors
C.Dielectric losses
D.Flux linkages
QUESTIONS
9. At radio frequencies, a line is considered
lossless because:

A. Characteristic impedance is determined


by its physical structure
B. Inductive reactance is much more than
the resistance
C. Capacitive reactance is much larger then
the shunt conductance
D. B and C above
QUESTIONS

10. Determine the characteristic impedance of


a transmission line which has a capacitance
of 30pF/m and an inductance of 75nH/m

A.5
B.50
C.500
D.5 K
QUESTIONS
11. The Zo of an open-wire balance line is
determined from its physical structure.
[ Zo = 276 log (2S/d) where S is the center-
to-center distance of the conductors and d
is the diameter of the conductor ]. At what
condition is the Zo minimum?

A. S=d
B. S = 2d
C. d = 2S
D. S >> d
QUESTIONS

12. If a change in the dielectric material


decreases the capacitance, the
characteristic impedance is:

A. Kept constant
B. Decreased
C. Increased
D. Halved
QUESTIONS

13. All power applied at the input of the line


will be absorbed by the load if:

A. ZO > ZL
B. ZO < ZL
C. ZL = ZO
D. ZO = ZL
QUESTIONS

14. When ZL ZO, the power sent down the


line toward the load is called the

A. The incident power


B. The reflected power
C. The power dissipation
D. The carrier power
QUESTIONS

15. When mismatch is great, this power


actually cause damage to the transmitter
or the line itself.

A. The incident power


B. The reflected power
C. The power dissipation
D. The carrier power
QUESTIONS

16. A resultant wave due to the combination


of incident and reflected wave

A. Electromagnetic wave
B. Sine wave
C. Standing wave
D. Current
QUESTIONS

17. If the load impedance matches the


characteristic impedance of the line, there
are _____ standing waves

A. More
B. Less
C. No
D. Ten (10)
QUESTIONS

18. A measure of the mismatch between line


and load impedance is called as

A. Reflection coefficient
B. Standing wave ratio
C. Loss
D. Standing waves
QUESTIONS

19. At matched condition, SWR is equal to

A. Zero
B. One
C. 100
D. Infinite
QUESTIONS

20. The ratio of the reflected voltage to the


incident voltage on the transmission line is
termed as

A. Reflection coefficient
B. Standing wave ratio
C. Loss
D. Standing waves
QUESTIONS

21. A shorted or opened line will have a


reflection coefficient of

A. Zero
B. One
C. 100
D. Infinite
QUESTIONS

22. The minimum voltage along a


transmission line is 260V, while the
maximum voltage is 390V. The SWR is

A. 0.67
B. 1.0
C. 1.2
D. 1.5
QUESTIONS

23. At UHF and microwave frequencies,


transmission lines are commonly used as

A. Antenna
B. Coupler
C. Resonant circuit
D. Transformer
QUESTIONS

24. The time required for a wave to propagate


on a transmission line will depend on the
value of its

A.Series resistance and shunt conductance


B.Series inductance and shunt capacitance
C.Series resistance and series inductance
D.Shunt conductance and shunt capacitance
QUESTIONS

25. The current (and voltage) distribution


along a matched line vary _____ with
distance

A. Linearly
B. Inversely
C. Exponentially
D. Logarithmically
QUESTIONS

26. a measure of how the voltage or current


decreases with distance along the line

A. Propagation constant
B. Attenuation constant
C. Phase constant
D. SWR
QUESTIONS

27. The value remains constant for any length


of wire

A. Characteristic impedance
B. Inductance
C. Capacitance
D. Propagation constant
QUESTIONS

28. A measure of the difference in phase


between the input and output current or
voltage

A. Attenuation constant
B. Reflection constant
C. Phase constant
D. Characteristic impedance
QUESTIONS

29. To match a 300 transmission line to a


100 load, the impedance of the quarter-
wave transformer is

A. 1.732 K
B. 20
C. 200
D. 173.21
QUESTIONS

30. An attenuation of 1 Neper is equal to _____


dB

A. 8.686 x 10-3
B. 8.686
C. 4.343
D. 0.115
QUESTIONS

31. Characteristic impedance and load


impedance must be matched in order to
transfer

A. Maximum power to the load


B. Maximum current to the load
C. Maximum voltage to the load
D. Maximum standing waves
QUESTIONS

32. The ratio of reflected voltage to the forward


or incident voltage is termed as

A. Reflection coefficient
B. SWR
C. VSWR
D. Propagation constant
QUESTIONS
33. A more common method of expressing the
degree of mismatch between Zo and ZL is
return loss. [Return Loss = 20 log (1/
reflection coefficient)]. Echoes may result if
return loss is

A. Too high
B. Too low
C. Zero
D. Infinite
QUESTIONS

34. The points along the line where the


incident and reflected voltages are in phase
are points of

A. Maximum voltage and maximum current


B. Minimum voltage and minimum current
C. Maximum voltage and minimum current
D. Minimum voltage and maximum current
QUESTIONS

35. When incident and reflected voltages are


out of phase, the voltages are

A. Added
B. Neutralized
C. Multiplied
D. Divided
QUESTIONS

36. If the distance of separation between


centers of two parallel wires is increased,
the characteristic impedance will

A. Increased
B. Decreased
C. Be the same
D. Doubled
QUESTIONS
37. Which statement is true?

A. Increasing the length of the wire will


increase the SWR
B. Decreasing the length of the wire will
increase the SWR
C. Increasing the length of the wire will
decrease the SWR
D. Changing the length of the wire will
have no effect on the SWR
QUESTIONS

38. The characteristic impedance of balance


wire varies from

A. 150 to 600
B. 40 to 150
C. 75 to 400
D. 75 to 600
QUESTIONS

39. The characteristic impedance of coaxial


cable varies from

A. 150 to 600
B. 40 to 150
C. 75 to 400
D. 75 to 600
QUESTIONS
40. Often inserted in telephone lines at
spacing as close as 1 (1.6km), to
counteract the capacitance of the line and
thus make the line impedance more closely
equivalent to a pure resistance

A. Amplifiers
B. Transformer
C. Equalizer
D. Loading coils
QUESTIONS

41. When the receiving end of the wire is an


open circuit, it is a point of

A. Maximum current and zero voltage


B. Maximum voltage and zero current
C. Zero current and zero voltage
D. Maximum voltage and maximum current
QUESTIONS

42. If a wire is terminated on a short circuit,


the end of the wire is a point of

A.Maximum current and zero voltage


B.Maximum voltage and zero current
C.Zero current and zero voltage
D.Maximum voltage and maximum current
QUESTIONS

43. The principal method of reducing noise


and crosstalk to low value on open-wire
lines

A. Filter method
B. Scrambling
C. Feedback
D. Transposing
QUESTIONS

44. Used for VHF antennas

A. RG-214/U
B. RG-59/U
C. RG-11/U
D. RG-58/U
QUESTIONS

45. Which transmission line has the highest


attenuation?

A. RG-214/U
B. RG-59/U
C. RG-11/U
D. Twin lead
QUESTIONS

46. Which transmission line has the lowest


attenuation?

A. RG-214/U
B. RG-59/U
C. RG-11/U
D. Twin lead
QUESTIONS

47. A widely used transmission line, in which


two stranded wires are separated by a flat
continuous plastic insulators

A. RG-214/U
B. RG-59/U
C. RG-11/U
D. Twin lead
QUESTIONS

48. Used for TV antennas; cable TV; and HF


antennas

A. RG-214/U
B. RG-59/U
C. RG-11/U
D. RG-58/U
QUESTIONS

49. An open-wire line has an attenuation of


2.4 dB per 100 ft. The attenuation for 275
ft is

A. 2.4 dB
B. 3.3 dB
C. 4.8 dB
D. 6.6 dB
QUESTIONS

50. The ratio of velocity of propagation in the


transmission line and the velocity of
propagation in free space

A. Wavelength constant
B. Propagation constant
C. Velocity factor
D. Velocity of light
QUESTIONS
51. This transmission line is used in
microwave circuit. It consists of a narrow,
flat conductor sandwiched between
dielectric boards whose outside surfaces
are coated with conductor

A. Stripline
B. Microstrip
C. Waveguide
D. Coax
QUESTIONS
52. Is a narrow, flat conductor on a single
dielectric board whose opposite face is
metallized, much like an ordinary printed-
circuit board. It is also used in microwave
circuits

A. Stripline
B. Microstrip
C. Waveguide
D. Coax
QUESTIONS

53. Can be placed at either end of a


transmission line to convert between 72-
unbalanced line to a 300- balance line

A. Stub
B. Resonant circuit
C. Balun
D. Coupler
QUESTIONS

54. Power loss due to increased effective


resistance of a conductor at microwave
frequencies due to skin effect.

A. Conduction loss
B. Radiation loss
C. Dielectric loss
D. Corona
QUESTIONS

55. When does a transmission line terminated


in a short look like a short to the source?

A. At quarter-wavelength
B. At half-wavelength
C. At less than /5
D. At less than /4
QUESTIONS

56. How many cycles of a 1 MHz wave can a


6=mile transmission line accommodate?

A. 60 cycles
B. 6 cycles
C. 16.67 cycles
D. 32.26 cycles
QUESTIONS

57. A transmission line has a capacitance of


25 pF / ft. and an inductance of 0.15 h /
ft. Determine the characteristic impedance
of the line.

A. 77.5
B. 50
C. 75
D. 100
QUESTIONS
58. For a transmission line giving a maximum
rms voltage reading of 50 V at one point
and a minimum rms voltage reading 25 V
at another point. What is the VSWR of the
line?

A. 2
B. 4
C. 1
D. 5
QUESTIONS

59. Two 2-mm-diameter wires held 6cm apart


center-to-center has a characteristic
impedance of______.

A. 500
B. 250
C. 491
D. 75
QUESTIONS

60. Does minimum or maximum VSWR


indicate best matching of antenna to
transmission line?

A. Minimum
B. Maximum
C. Either a or b
D. Neither a or b
QUESTIONS

61. If two towers of a 1100-kHz array are


separated by 120, What is the tower
separation in feet?

A. 321
B. 48
C. 298
D. 412
QUESTIONS

62. What is the reflection coefficient of an


open-circuited transmission line?

A. 1
B. -1
C. 0
D. Infinity
QUESTIONS

63. The reflection coefficient on a


transmission line is 1/3, what is the SWR?

A. 0
B. 3
C. 2
D. 4
QUESTIONS

64. Indicate the false statement. The SWR on


a transmission line is infinity: the line is
terminated in a/an

A. Short circuit
B. Open circuit
C. Pure reactance
D. Complex impedance
QUESTIONS

65. Coaxial lines are used on those systems


operating_______.

A. Below 2 GHz
B. At 300 MHz
C. Above 10 kHz
D. Above 10 Ghz
QUESTIONS

66. What is the SWR along a transmission line


having a characteristic impedance of 75
and a load impedance of 300 ?

A. 0.25
B. 4
C. 2
D. 0.5
QUESTIONS

67. Who developed the Smith Chart?

A. Philip H. Smith
B. James N. Smith
C. Philip S. Chart
D. Gunn Chart
QUESTIONS

68. An electronic equipment used to measure


standing wave ratio.

A. Reflectometer
B. Wavemeter
C. Altimeter
D. Multimeter
QUESTIONS

69. What is the phase shift corresponding to


/ 4 in standing wave pattern?

A. 0
B. 40
C. 90
D. 180
QUESTIONS

70. For a parallel resonant circuit, a / 4 stub


must be_____ at the ends.

A. Open
B. Shorted
C. Loaded
D. complex
PHIL LOMBOY,
KAPUSO MO
NGAYONG PASKO.

You might also like