You are on page 1of 1

RRC Measurements Measurement Cheat Sheet (FDD) (FDD)

Intra-Frequency Frequency Measurements Measurement


Event
Event 1A Event 1B Event 1C Event 1D Event 1E Event 1F Event 1J J

Description
A Primary CPICH enters the reporting range A primary CPICH leaves the reporting range A non-active active primary CPICH becomes better than an active primary CPICH Change of best cell A Primary CPICH becomes better than an absolute threshold A Primary CPICH becomes worse than tha an absolute threshold A non-active active E-DCH E DCH but active DCH primary CPICH becomes better than an active E-DCH DCH primary CPICH

Traffic Volume Measurements


Event
Event 4A

Description
Transport Channel Traffic Volume becomes larger than an absolute threshold Transport Channel Traffic Volume becomes smaller than an absolute threshold

Event 4B 4

Quality Measurements
Event
Event 5A

Description
A predefined number of bad CRCs is exceeded

UE Internal Measurements
Event
Event 6A Event 6B Event 6C Event 6D Event 6E Event 6F

Description
The UE Tx power becomes larger than an absolute threshold The UE Tx power becomes less than an absolute threshold The UE Tx power power reaches its minimum value The UE Tx power reaches its maximum value The UE RSSI reaches the UE's dynamic receiver range The UE Rx-Tx Rx Tx time difference for a RL included in the active set becomes larger than an absolute threshold

Inter-Frequency Frequency Measurements Measurement


Event
Event 2A A Event 2B B

Description
Change of best frequency frequenc The estimated quality of the currently used frequency is below a certain threshold and the estimated quality of a non-used used frequency is above a certain threshold The estimated quality quality of a non-used non used frequency is above a certain threshold The estimated quality of the currently used frequency is below a certain threshold The estimated stimated quality of a non-used non used frequency is below a certain threshold The estimated quality of the currently used frequency is above a certain threshold

Event 2C C Event 2D D

Event 2E E Event 2F F

UE Positioning ositioning Measurements easurements


Event
Event 7A Event 7B Event 7C

Description
The UE position changes more than an absolute threshold SFN SFN measurement changes more SFN-SFN than an absolute threshold GPS time and SFN time have drifted apart more than an absolute threshold

Inter-RAT RAT Measurements


Event
Event 3A A

Description
The estimated quality of the currently used UTRAN frequency is below a certain threshold and the estimated quality of the other system system is above a certain threshold The estimated quality of other system is below a certain threshold The estimated quality of other system is above a certain threshold Change of best cell in other system

Important Parameters
Parameter
Ec/No

Description
Energy per chip (Ec) divided by the noise and interference inter ence power spectral density (No). ( Measure of the absolute received primary CPICH signal. Received power measured within the relevant channel bandwidth measured relevant on a GSM BCC CCH carrier

Event 3B B Event 3C C Event 3D D

RSCP GSM RSSI

You might also like