Professional Documents
Culture Documents
Corbel Design fcu Cover, C fy fyv column width reaction,V av bend, r = = = = 40 25 460 250 0.7 675 75 4 64 N/mm2 mm N/mm2 N/mm2 m 700 kN mm mm hcs R hcs L Self Weight hcs & top Service DL beam sect1 sect2 DL LL LL thus, W beam , L = = = = = = = = = = = = = 6 6 4.5 2.9 5.772 2.688 52.86 3 18 102.8 9 m m kN/m2 kN/m2 kN/m kN/m kN/m kN/m2 kN/m kN/m m
700
16 mm 12 mm
b) bearing width length, lb = Max/ bearing = stress = width of bearing, w = = c) length of corbel. Lc Lc = = says d) depth of corbel
Lc= 250
l2 1/2w
av assume depth of corbel, h h1 = = 450 mm 351 mm > h/2 b1 b2 w= 70 h1 = ok not ok d = ok not ok 417 mm > av 110.2 mm 139.8 mm 225 225 450
e) check shear stress v = = ok not ok 2) Corbel reinforcement a) Main tie steel Check if Fs > V/2 v/fcu = = = 0.36 (1-2av /d) 0.231 0.058 < 0.231 V/ bd 2 2.31 N/mm
< =
but
v/fcu
Total tension b) Check steel stress v fcu v/fcu av/d from chart z/d fs
0.9 (z/d)(av/d)(1-z/d) (av/d)2 + (z/d)2 0.058 0.180 0.72 700 (z/d-0.55) / (1- z/d) 425 N/mm2
2 794.1 mm
= = = = =
Hence As As min
= = =
3 nos. of T 20 ok not ok
943 mm2
c) check bearing stress within bend Fs' = (Fs + T) x nos. of bar 49.76 kN As req As prov
ab r aasumer
= = = = ok not ok
2d vc / av 2 8.85 N/mm vc =
> 5.06
0.8fcu
5.06
use calculated vc' use 0.8fcu since v < vc ; no shear links required but provide 25% 0f main bar for confinemnet 236 mm2 16 = 402.3 mm2 ok not ok
Link 2
=
nos. of T
- to check shear stress formula, v=v/bd, b equal width of column or depth of corbel
Projek ILAJ : Loading Data 1. Dead load Slab self weight conc 205 H Core Slab Topping 75 mm = = =
3 24 kN/m
SDL M&E = Ceiling = Screed = Blockwall = 0.25 0.25 1.2 1.2 kN/m2 kN/m2 kN/m2 kN/m2
2 2.9 kN/m