Professional Documents
Culture Documents
1. Make sure you have enough downtime for physical machine as this process will reboot machine.
2. Make sure if .Net FRM 2.0 and above is installed or else when XenConvert tool is run then it will
thrown following message
4. Select Next
5. Provide the location for XC install
1. Lunch the XC client from physical or virtual machine . This will detect the host machine and as a
target select “XenServer” so that it will import directly to the XenServer.
2. Here you can select the volume which you are targeting to P2V and also reduce the free space
on the selected disk. What it mean is if you want to reduce the HD size you can specify less
space. Also I would suggest incase if the other drive size is bigger then use NT backup and NT
restore which will be shown in Backup and restore section.
3. Here type pool master IP address. Under “workspace” you should have sufficient space to store
VHD file which get created from XC. It is always advisable to store locally if you have space but
incase space is not there then we have to store on CIFS.
4. This will the machine name with which it will get imported.
5. Make sure you check this option to generate log for further troubleshooting
6. After this stage it start converting the physical disk
7. Once the drive is converted then it start importing the OVF file. This process takes longer time
since it connects to the XenServer to import the VHD file. This will sit at three level which shown
below and give it ample time to finish.
8. If everything is fine then you will get below message
9. If the import option keeps failing then we have other way to import it.
NOTE : Only if you have tested above method and failed couple of time.
1. Before you power on the VM make sure your it is disconnected from n/w as your production might
be up.
2. Login to the VM using local credential and uninstall hidden driver
a. Set the path as shown below
3. Now before you reboot make sure all theH/W related software is uninstalled
4. Now after every unwanted s/w is uninstalled then reboot the VM and continue with Xen Tool install.
4. Once it start importing the OVF file and process is successful then you will get following
message. Not that there is a time when there will be no update on log file as shown
below
Backup:
1. Perform the backup of drive which was not part of P2V and run ntbackup from start
-> run -> ntbackup
below
drive
5. Select the volume which needs to be imported. One thing should be remembered is
the stop all the services other than windows
service.
6. This backup needs space to store the backup file . So select the space where there
are enough space.
7. Click on finish to start the backup.
1. Before you start performing restore, target drive should have been created on VM . To create
a new store select storage tab of VM and then select “Add”. Type the “Name” and then specify
the size. Make sure you select the appropriate size. Based on storage which have free space
create a new disk
drive
2. Once the drive is create login to VM with local admin and password. Make sure that there is no
network connectivity to VM if the PROD physical or virtual machine is powered on. Once logged
in run diskmgmt.msc from start - > run and then select the drive which has to be formatted.
Once formatted we are ready with the restore. We should mount or map the shared store
where the backup .bkf file is stored. We have to run ntbackup wizard again select restore
3. Browse and select the .Bkf file and then select the entire
drive
4. Click on advance
5. While choosing location select alternate location as we are going to store on different drive
6. Select next and leave the option as it is
7. This is very important option or else application will not work .This must be selected.
8. Sit tight and let this restore finish. Once the restore is finished then reverse back the status of all
the services which has been set to manual to Automatic. Once rebooted I bet the application
will be up and running