Professional Documents
Culture Documents
3Which two commands ensure that any password that permits access to the privileged
EXEC mode is not shown in plain text when the configuration files are displayed?
(Choose two.)
Router(config)# enable secret cisco
Router(config)# enable cisco
Router(config)# encryption-password all
Router(config)# enable login encrypted
Router(config)# enable password encryption
Router(config)# service password-encryption
4A new network is to be configured on a router. Which of the following tasks must be completed to
configure this interface and implement dynamic IP routing for the new network? (Choose three.)
Select the routing protocol to be configured.
Assign an IP address and subnet mask to the interface
Update the ip host configuration information with the device name and new interface IP
address.
Configure the routing protocol with the new network IP address.
Configure the routing protocol with the new interface IP address and subnet mask. Configure the
routing protocol in use on all other enterprise routers with the new network information.
5 How does TCP ensure the reliable transfer of data?
if data segments are not received from the source, the destination requests that the
segments be resent.
If an acknowledgment of the transmitted segments is not received from the destination in
a predetermined amount of the time, the source resends the data.
TCP uses the SYN-ACK portion of the three-way handshake to ensure that all data
has been received.
The TCP Protocol Interpreter process verifies the transmitted data at source and
destination.
6 A network administrator is asked to design a system to allow simultaneous access to the Internet for
250 users. The ISP for this network can only supply five public IPs. What can be used to accomplish
this task?
routable translation
dynamic translation
static translation
port address translation
to indicate the correct router interface that should be used to forward a segment
to identify which switch ports should receive or forward the segment
to determine which Layer 3 protocol should be used to encapsulate the data
to enable a receiving host to forward the data to the appropriate application
to allow the receiving host to assemble the packet in the proper order
DNS server
WINS server
IP address
NetBIOS
subnet mask
default gateway
13A Catalyst 2960 switch has been taken out of storage to be used as a temporary
replacement for another switch that needs to be repaired. About a minute after the switch
has started, the SYST LED on the front of the switch transitions from blinking green to
amber. What is the meaning of the amber SYST LED?
The switch has no configuration file in NVRAM.
The switch has failed POST and must be sent for service.
The switch is functioning properly.
The switch is in half-duplex mode.
17Refer to the exhibit. The network shown is connected using services from the same
ISP. How will the Fohi router dynamically learn routes to the192.168.16.16/28,
192.168.16.32/28, and 192.168.16.64/28subne tworks?
with BGP
with a static route
with a directly connected route
with an interior routing protocol
18Refer to the exhibit. Which type of UTP cable should be used to connect Host A to
Switch1?
rollover
console
crossover
straight-through
19When customers use credit cards to make purchases at a small business, a modem is heard dialing
a telephone number to transfer the transaction data to the central office. What type of WAN serial
connection is in use?
leased line
packet switched
circuit switched
point-to-point
20 A user reports being unable to access the Internet. The help desk technician employs a bottom-up
approach to troubleshooting. The technician first has the user check the patch cable connection from
the PC to the wall, and then has the user verify that the NIC has a green link light. What will the
technician have the user do next?
Enter an IP address into the WWW browser address bar to see if DNS is at fault.
Use traceroute to identify the device along the path to the ISP that may be at fault.
Verify the IP address, subnet, and gateway settings using ipconfig on the PC.
Connect to the user home router to check firewall settings for blocked TCP ports.
21 A ping192.1.1.20 command is issued on workstation A to determine if workstation B
can be reached. What events will occur if this command is successful? (Choose two.)
The router will block the ping request message.
The router will reply to the echo request with a proxy ping response.
Workstation A will send a UDP ping request message to workstation B.
Workstation B will send a UDP ping reply message to workstation A.
Workstation A will send an ICMP echo request message to workstation B.
Workstation B will send an ICMP echo reply message to workstation A.
The Internet server will send data to port 8547 on the client.
24What is one purpose of the TCP three-way handshake?
sending echo requests from the source to the destination host to establish the presence of
the destination
determining the IP address of the destination host in preparation for data transfer
requesting the destination to transfer a binary file to the source
synchronizing sequence numbers between source and destination in preparation for
data transfer
25Which type of address is1 9 2 . 1 6 8 . 1 7 . 111 /2 8?
host address
network address
broadcast address
multicast address
26A customer reports connectivity problems to an ISP technician. Upon questioning the
customer, the technician discovers that all network applications are functioning except for
FTP. What should the technician suspect is the problem?
misconfigured firewall
bad port on switch or hub
misconfigured IP addressing on the customer's workstation
wrong DNS server configured on the customer's workstation
wrong default gateway configured on the customer's workstation
27The show ip route command was executed on one of the routers shown in the graphic
and the following output was displayed:
C192.168.4.0/24 is directly connected, Serial0/0
R192.168.5.0/24 [120/1] via192.168.4.2, 00:00:19, Serial0/0
R192.168.1.0/24 [120/2] via192.168.3.1, 00:00:20, Serial0/1
R192.168.2.0/24 [120/2] via192.168.3.1, 00:00:20, Serial0/1
C192.168.3.0/24 is directly connected, Serial0/1
From which router was this command executed?
ABCD
28Refer to the exhibit. Which two sets of commands are required to configure passwords
for all management ports on a Catalyst 2960 switch? (Choose two.)
31Which subnet masks could be used when subnetting a Class B IP address? (Choose
two.)
255.255.255.240
255.255.192.0
255.255.0.0
255.192.0.0
240.0.0.0
255.0.0.0
32 Refer to the exhibit. The network administrator has configured the RTA and RTB
interfaces. In order to allow hosts that are attached to RTA to reach the server that is
attached to RTB, a static route from RTA to the server LAN and a default route from RTB
back to RTA need to be configured. Which two commands will the administrator use to
accomplish these tasks on the two routers? (Choose two.)
RTA(config)# ip route 10.16.10.5 255.255.255.252 10.16.10.6
RTA(config)# ip route 0.0.0.0 0.0.0.0 10.16.10.6
RTA(config)# ip route 10.16.10.96 255.255.255.252 10.16.10.6
RTB(config)# ip route 10.16.10.6 255.255.255.248 10.16.10.6
RTB(config)# ip route 0.0.0.0 0.0.0.0 S0/0/1
RTB(config)# ip route 0.0.0.0 0.0.0.0 10.16.10.6
33How do port filtering and access lists help provide network security?
They prevent specified types of traffic from reaching specified network
destinations.
They alert network administrators to various type of denial of service attacks as they
occur.
They prevent viruses, worms, and Trojans from infecting host computers and servers.
They enable encryption and authentication of confidential data communications.
34 Refer to the exhibit. The network administrator of the building in the graphic needs to
choose the type of cable best suited to add ServerB to the network. Which cable type is
the best choice?
STP
UTP
coaxial
fiber optic
35What is used by a routing protocol to determine the best path to include in the routing
table?
Convergence time
Default distance
Metric
Type of router
36Refer to the exhibit. Which IP addresses could be assigned to the hosts in the diagram?
(Choose two.)
192.168.65.31
192.168.65.32
192.168.65.35
192.168.65.60
192.168.65.63
192.168.65.64
37Given the network192.168.25.0 shown in the graphic, which subnet mask would
accommodate the number of hosts in each subnet?
255.255.0.0
255.255.224.0
255.255.255.0
255.255.255.224
255.255.255.240
255.255.255.248
38 Which two protocols allow network devices to report their status and events to a
centralized network management device? (Choose two.)
Syslog
Telnet
HTTP
HTTPS
SNMP
not make it back to the ISP router. What will fix this problem?
The ISP must be configured to forward packets from the192.168.1.0 network.
The ip route command needs to be edited so that the next hop address is10.1.1.5.
The ip route command needs to be edited so that the192.168.1.1 address is the next hop
address.
The ip route command should be removed from the RTB router configuration.
42 A network technician is using a network management station to gather data about the performance
of devices and links within the ISP. Which application layer protocol makes this possible?
SNMP
FTP
DHCP
SMTP
43What are two purposes of DNS? (Choose two.)
to dynamically assign IP addressing information to network hosts
to simplify the administration of host and default gateway addressing on client computers
to assign TCP port numbers to hosts as part of the data transfer process
to resolve human-readable domain names to numeric IP addresses
to replace the static HOSTS file with a more practical dynamic system
44A hacker attempts to reach confidential information that is stored on a server inside the
corporate network. A network security solution inspects the entire packet, determines that
it is a threat, and blocks the packet from entering the inside network. Which security
measure protected the network?
an IDS
an IPS
a host-based firewall
Anti-X software
45 How many host addresses may be assigned on each subnetwork when using the
130.68.0.0 network address with a subnet mask of 255.255.248.0?
30
256
2046
2048
4094
4096
46In an IPv4 environment, what information is used by the router to forward data packets
from one interface of a router to another?
destination network address
source network address
source MAC address
well known port destination address
47 A small tire retailer requires a low-cost WAN connection to its headquarters in order to
manage its inventory and process customer sales in real time. Which WAN connection
type is best suited to its needs?
Sonet
T3
dialup
DSL
leased line
48The command copy tftp running-config has been entered on the router. What will this
command do?
copy the configuration in RAM to a server
copy the configuration file from a server to RAM
copy the configuration file in NVRAM to RAM
copy the configuration file in NVRAM to a server
copy the configuration file from a server to NVRAM
49Refer to the exhibit. The network administrator needs to configure the Fa0/0 interface of RTB so
that hosts from RTA can connect to the server that is attached to RTB. Which two commands will the
administrator use to accomplish this task? (Choose two.)
RTB# ip address 192.168.102.98 255.255.255.248
RTB(config-if)# ip address 192.168.102.99 255.255.255.252
RTB(config)# ip address 192.168.102.97 255.255.255.252
RTB(config)# no shutdown
RTB(config-if)# no shutdown
RTB(config-if)# ip address 192.168.102.97 255.255.255.252
50Refer to the exhibit. A NOC technician at an ISP enters the command shown. What are
two reasons to use this command? (Choose two.)
to map the path to192.168.1.7
to test reachability to192.168.1.7
to locate connectivity problems along the route to192.168.1.7
to identify the ISPs that interconnect the NOC with the remote host with the address
192.168.1.7
to measure the time that packets take to reach192.168.1.7 and return to the technician's
workstation