URC22B
NEW
UNIVERSAL
REMOTE CONTROL
OPERATE:
TV'VCR'SATELLITE'CD
AUX FOR CABLE/OTHERS
INSTRUCTION
BOOKLET
WORK WITH MOST MAJOR BRANDS
EASY SET UP INSTRUCTIONS INSIDE
WORK WITH DIGITAL SATELLITE RECEIVER
RIGHT RESERVED TO IMPROVE
SPECIFICATIONS WITHOUT NOTIFYDescription
Tends:
i
4 nevi Ta oe
ver 104 | a. 370:750751 |
nes
AUNT AUX? | COVLDROMDVVCD =| 18
J AMPYHIFT
ae a [CRSA
First find your TV modelior other appliances}code; then you
press ‘button »*SET
(ele Nuh aboeh tate ha fn
the indicator keeps on. Input digits and the indicator will
Nail an eo Tate’
OOManual Code Search
Ifyou do not know your appliance’s brand or can not find its
eode,you may find its code manually;first press and hold
“SET button, and then press selected equipment button.The
indicator will keeps light on; now press again"SET" buttan, the
indicator will flash. Point your control toward TV and press
“POWER” button, andone code will be send eachtime you
press until TV is tured off. Immediately: press selected
equipment button, other wise the next cade may be locked. Use
the same method to set other appliances,
Auto Code Search
1 poven the deeyu vant conta Is BV
Must be inserted witha tape,
1. ress.and hold (SET] keyin the meantime, press and hold
the[POWER] key formore than 3 seconds and then
release themthe auto search begin The remote control enters
pst kale pgs ce
power signal every
4. See if the Sete Te
anly Keyleccept sop the auto
(Note-you have tobe very patientsince it may take a long time
tosearch the code. Press any button immediately to save the
code when TV is tumed off; otherwise the saved code may be
‘the next one.)
Test ifthe other keys work good enough.!f most keys work not
paeenien ‘go te step B-D using Auto Search again to
‘The user can press the “Set’ key in the searching mode to
changethecade searching direction.
Code Check
‘You may find outa code loclced by you in the Following ways so
that you can directly input number for the next time.
First press TV" button to switch the control to "TV" state:
T: press and hold “SET, and then ptess "1", now watch the
indicator: it flash once to indicate the first numbers 1, no flash
to indicate the first number is 0.
again press and hold “SET, and thenpress"2". watch the
indicator and count the times ft flashes, flashing 5 times to
indicate the second number is5, no flash to indicate the second
number is'0,
again peessand hold." SET; and thenypress "2", wathe. the
indicator and count the times it lashes,ie, Rashing@ times to
indicate the thind number is 6, no flash to indicate the second
numiber is 0. F
2
Fractional Differential Equations: An Introduction to Fractional Derivatives, Fractional Differential Equations, to Methods of Their Solution and Some of Their Applications