Professional Documents
Culture Documents
2.
I dissected my original model so that each panel and piece of rope became a single object.
Next I calculated how many degrees I would need to rotate each piece. 360 / 24 = 15
3.
4.
Then attached them all back together to form a single object again.
5.
Then used the merge vertex tool to join the pieces together smoothly.
6. I duplicated the object and attached it to the first piece. I then combined the two pieces to make it one single piece.
7.
10.
8. Once it was in position I continued to make it into a single object, and connect all of the new vertices.
9.
Now I have my circular conveyor belt. Next I created a NURBS circle and sized it to fit inside.
11. Here I connected the mesh to the circle using the wire tool.
12.
14. 13.
15.
I quite like that it curled the cardboard a bit reminds me of card thats been left outside in the damp. Adds a bit more character to the object. 16.