Professional Documents
Culture Documents
Chapter 5 Exam
Started: Nov 2 at 10:54pm
Quiz Instructions
Question 1 1 pts
Refer to the exhibit. Based on the debug ip dhcp server packet output, which
statement is true?
The client sends the BOOTREPLY broadcast message to inquire for a new IP address.
The client sends a DHCPREQUEST that contains IP address 10.1.10.21 to the DHCP
server.
The client sends a DHCPDISCOVER that contains IP address 10.1.10.21 to the DHCP
server.
The client accepts the offer from the DHCP server for the 10.1.10.21 IP address.
Question 2 1 pts
Which three statements about a routed port are true? (Choose three.)
A routed switch port is created by configuring a Layer 2 port with the no switchport
interface configuration command and assigning an IP address.
A routed switch port is created by entering VLAN interface configuration mode and
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 1/13
3/11/2020 Quiz: Chapter 5 Exam
assigning an IP address.
A routed switch port provides an interface that may provide a Layer 3 connection to a next-
hop router.
A routed switch port is a virtual Layer 3 interface that can be configured for any VLAN that
exists on a Layer 3 switch.
A routed switch port is a physical device that is associated with several VLANs.
Question 3 1 pts
How is the Layer 2 functionality restored to a port configured for Layer 3 operation?
switchport
no switchport
Question 4 1 pts
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 2/13
3/11/2020 Quiz: Chapter 5 Exam
Refer to the exhibit and the partial configuration taken on routers RTA and RTB. All users
can ping their gateways, but users on VLAN 5 and VLAN 10 cannot communicate with
the users on VLAN 20. What should be done to solve the problem?
RTA interface Fa0/1 and RTB Fa0/1 should be configured with three subinterfaces, each
with ISL encapsulation.
RTA interface Fa0/1 and RTB Fa0/1 should be configured with three subinterfaces, each
with 802.1Q encapsulation.
Question 5 1 pts
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 3/13
3/11/2020 Quiz: Chapter 5 Exam
36298.jpg
Refer to the exhibit. The router has been properly configured for the trunking interface.
Which statement is true about the routing table on the router?
Because the switch is not configured properly to trunk VLAN 1 and VLAN 2, the routing
table of the router will not show routes to either VLAN .
Because the switch port fa0/1 is in access mode, the routing table of the router will not
show any routes.
It will show a next hop address of the switch for both VLANs.
Question 6 1 pts
Which message will be sent back to the client by the DHCP server to confirm that the IP
address has been allocated to the client?
DHCPDISCOVER broadcast
DHCPREQUEST unicast
DHCPOFFER broadcast
DHCPREQUEST broadcast
DHCPOFFER unicast
DHCPDISCOVER unicast
DHCPACK unicast
Question 7 1 pts
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 4/13
3/11/2020 Quiz: Chapter 5 Exam
Which two statements are true about routed ports on a multilayer switch? (Choose two.)
To create a routed port requires removal of Layer 2 port functionality with the no
switchport interface configuration command.
A routed port behaves like a regular router interface and supports VLAN subinterfaces.
The interface vlan global configuration command is used to create a routed port.
Question 8 1 pts
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 5/13
3/11/2020 Quiz: Chapter 5 Exam
Question 9 1 pts
What is an advantage to using a trunk link to connect a switch to an external router that is
providing inter-VLAN routing?
lowers latency
Question 10 1 pts
A client computer is set up for DHCP and needs an IP configuration. During the DHCP
client configuration process, which response will enable the client to begin using the
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 6/13
3/11/2020 Quiz: Chapter 5 Exam
DHCPREQUEST
DHCPACK
DHCPOFFER
DHCPDISCOVER
Question 11 1 pts
i178115n1v1.jpg
Question 12 1 pts
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 7/13
3/11/2020 Quiz: Chapter 5 Exam
Refer to the exhibit and the partial configuration taken on router RTA. Users on VLAN 5
cannot communicate with the users on VLAN 10. What should be done to fix the
problem?
The Fa0/0 interface should be configured with a primary IP address of 10.10.5.1/24 and a
secondary IP address of 10.10.10.1/24.
Two static routes should be configured on the router, each pointing to each subnet.
Question 13 1 pts
Which statement describes what occurs when a DHCP request is forwarded through a
router that has been configured with the ip helper-address command?
The router replaces the broadcast destination IP address of the DHCP request with the
unicast IP address that is specified with the ip helper-address command.
The router replaces the source IP address of the DHCP request with the IP address that is
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 8/13
3/11/2020 Quiz: Chapter 5 Exam
The router replaces the source MAC address included in the DHCP request with its own
MAC address.
The router replaces the unicast destination IP address of the DHCP request with the
unicast IP address that is specified with the ip helper-address command.
Question 14 1 pts
Refer to the exhibit. Which statement is true regarding the diagram and show ip route
command output?
Because their packets are being trunked, hosts on VLAN 10 do not need a default gateway.
The default gateway for hosts on VLAN 10 should be the Fa0/0 IP address of the router.
The default gateway for hosts on VLAN 10 should be the Fa0/0.1 IP address of the router.
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 9/13
3/11/2020 Quiz: Chapter 5 Exam
The default gateway for hosts on VLAN 10 should be the Fa0/0.2 IP address of the router.
Because no routing protocol has been configured, the router will not forward packets
between workstations.
Question 15 1 pts
Which two statements are true about switched virtual interfaces (SVI) on a multilayer
switch? (Choose two.)
An SVI behaves like a regular router interface but does not support VLAN subinterfaces.
To create an SVI requires removal of Layer 2 port functionality with the no switchport
interface configuration command.
Question 16 1 pts
A DHCPREQUEST message has been sent from the client to the DHCP server. What
information is included in the message?
denial message to reject the first offer from the DHCP server
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 10/13
3/11/2020 Quiz: Chapter 5 Exam
Question 17 1 pts
A client sends a request for an IP address to a DHCP server. Which DHCP message to
the client will provide the configuration parameters that include an IP address, a domain
name, and a lease for the IP address?
DHCPREQUEST
DHCPOFFER
DHCPACK
DHCPDISCOVER
Question 18 1 pts
Refer to the exhibit. What additional configuration is required for host A to receive IP
configuration from the DHCP server?
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 11/13
3/11/2020 Quiz: Chapter 5 Exam
Question 19 1 pts
Refer to the exhibit. Which configuration should be applied on router R1 in order for host
1 to receive its IP configuration from the DHCP server?
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 12/13
3/11/2020 Quiz: Chapter 5 Exam
Question 20 1 pts
Refer to the exhibit. Host A is unable to obtain an IP address from the DHCP server.
Which procedure would solve this problem?
https://1314297.netacad.com/courses/1089891/quizzes/9514461/take 13/13