Objective UNIT-IV
4.4 Objective
4.4.1 Choose the Correct Answer
1. Which of the Following devices are controlled using PWM signal (C)
A) LED B) DC Motors C) Both A and B D) None of the Above
2. Which following is ADC Sensor (A)
A) MCP3008 B) LM293 C) 2N 3904 D) MCP4725
3. Which of the Following is Motion Detection Sensor (B)
A) LDR B) PIR C) DHT11 D) MCP3008
4.Which of the Following are Temperature Sensors (D)
A) RTD B) Thermistor C) DHT11 D) All the Above
5. Which of the following Raspberry Pi version doesn’t have inbuilt Bluetooth (A)
A) Raspberry Pi 2 B) Raspberry Pi 3 C) Raspberry Pi 4 D) Raspberry Pi 5
6. Which following is DAC Sensor (B)
A) MCP3008 B) MCP4725 C) 2N 3904 D) LM293
7. Which of the following devices control High power Devices. (C)
A) MOSFET Transistor B) Relay C) Both A and B D) None of the Above
8. Motors are Classified as (D)
A) DC Motor B) Servo Motor C) Stepper Motor D) All the Above
9. PWM signal Width can be varied through (A)
A) Duty Cycle B) Pitch C) Current D) Power
10. Servomotors will rotate in (D)
A) 00 B) 900 C) 1800 D) All the Above
4.4.2 Fill in the Blanks
1. LDR stands for Light Dependent Resistor.
2. DHT stands for Digital Humidity and Temperature.
3. MCP3008 is interface through SPI to Raspberry Pi.
4. MCP4725 is interface through I2C to Raspberry Pi.
5. An Embedded Sensor is a network of embedded computers placed in the physical world.
6. LED stands for Light Emitting Diode.
7. The position of the servo motor is set by the length of a pulse.
8. An H-Bridge is required to drive a bipolar stepper motor.
9. Relays act as Switch.
10. Buzzer will act as Output Device.
MRITS/II-II/CSE-IoT/Sensors and Devices 35