Professional Documents
Culture Documents
Defective harness between laser scanner unit and engine board. Check procedures/corrective measures Follow the flow chart below.
Code 4000
Contents Laser scanner unit (Polygon motor) error POLRDY* does not go low within 20 seconds after POLON* goes low (When starting) or within 16 seconds after REGPAP signal goes high (during printing).
NOTE: When If not solved this flow chart, try to replace below items. Harness (S03012) scanner unit and engine board (KP1081) Engine board (KP-1081) and scanner unit (replace at the same time)
NOTE: Pins of YC7 connector are crowded and tiny. When if measuring signal, contact measurement probe with pins of YC7 connector accurately.
Remove and check harness between engine board (KP-1081) and laser scanner unit. No Yes Turn power switch on.
Does pin #31 (POLON*) of YC7 on engine board (KP-1081) goes high and then low?
No
OK?
Yes Print status page. Replace harness between engine board (KP-1081) and laser scanner unit. No
Does pin #30 (POLRDY*) of YC7 on engine board goes low, after pin #31 (POLON*) of YC7 goes low? Yes Replace engine board (KP-1081). See page 1-620.
No
Does pin #29 (POLCLK) of YC7 on engine board (KP-1081) output square-wave*1 signal? Yes
1-5-6