Professional Documents
Culture Documents
TECHNICAL SERVICES DEPT. copper alloys (Note) 8470 457.38 aluminium alloys (Note) 2700 145.80
insert dimensions for the required product shape in orange boxes, then read off the weight in the red boxes at right. Material: Note - Densities shown in green boxes are typical. Add specific density under "others" for different materials.
sheet / plate flat bar coil round bar / wire square bar
density: Thickness (mm) 6 Thickness (mm) Diameter (mm) 19 A/F (mm) A/F (mm) Width (mm) 1500 Width (mm) Length (m) 6 kg: kg/m: Length (m) 24 Length (m) Length (m) kg: A/F (mm) Length (m) kg: Thickness (mm) Leg 1 (mm) 125 ID (mm) WT (mm) Side 2 (mm) WT (mm) Leg 2 (mm) 50 Length (m) 1 Length (m) 1 Length (m) Length (m) kg: kg: kg: 3.2 OD (mm) OD (mm) 150 Side 1 (mm) kg: kg:
53.39
54.07
57.97
18.48
34.22
hex bar oct bar angle bar hollow bar round tube / pipe square / rect tube / pipe
4.29
4.34
4.66
1.48
2.75
0.00 43.01
0.00 43.56
0.00
0.00
0.00 27.57
100 50 3.2 6 kg: Note: All results are approximate. Refer to second sheet for calculation fomulas. www.atlasmetals.com.au